2004 Ford Econoline

I WAS DRIVING MY RV DOWN THE FREEWAY WHEN THE INSIDE DUAL BLEW OUT ON THE PASSENGER SIDE OF THE VEHICLE. BEFORE THE TIRE BLEW OUT I NOTICED A VIBRATION ON THE PASSENGER SIDE OF THE RV. A FEW MOMENTS LATER THE TIRE BLEW OUT AND THE TREAD CAME OFF COMPLETELY LEAVING ONLY THE SIDE WALLS. I DO NOT REMEMBER RUNNING OVER ANY OBJECTS IN THE FREEWAY AND HAD NOT HIT ANY POT HOLES. THIS TIRE WAS THREE YEARS OLD WITH LESS THAN 5,000 MILES ON IT. I HAD CHECKED AND VERIFIED THE TIRE PRESSURE BEFORE LEAVING AND ENSURED THAT I HAD INFLATED THE TIRES TO THE RECOMMENDED TIRE PRESSURE PER THE VEHICLES OWNER MANUAL 80 PSI. THESE TIRES WERE THE DEFINITY DAKOTA LT225/75/16 TIRE. THE TIRE WAS REPLACED BY PEP BOYS AS I HAD PURCHASED THE HAZARD WARRANTY.

TL* THE CONTACT OWNS A 2004 FORD E-450. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V782000 (EQUIPMENT). THE MANUFACTURER WAS CONTACTED AT 1-855-262-3540 APPROXIMATELY TWO MONTHS AGO. THE CONTACT LEFT A VOICEMAIL FOR A CALL BACK, BUT DID NOT RECEIVE A RESPONSE. THE CONTACT FELT THAT A REASONABLE AMOUNT OF TIME HAD PASSED FOR THE RECALL REMEDY. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE VIN WAS NOT AVAILABLE.

THE AIR BAGS DEPLOYED ONCE IGNTION WAS TURNED OVER. NO ACCIDENT JUST DEPLOYED FOR NO REASON.

AT 68,450 MILES, SEVERAL ISSUES OCCURRED: 1) OIL PRESSURE SWITCH BLEW OUT OF THE HOUSING, 2) OIL WAS VISIBLE IN COOLANT, 3) OIL WAS LEAKING FROM ENGINE, 4) IDLE VACILLATED UP AND DOWN W/O ANY ACTION ON PART OF THE USER. TOOK VAN TO DEALER, WHO CLAIMED TO HAVE REPAIRED THESE ITEMS. INSPECTION OF THE "REPAIRED VEHICLE" REVEALED OIL STILL DRIPPING OFF ENGINE ONTO GROUND. WAS TOLD THAT THIS WAS "NORMAL" AND WOULD DISAPPEAR. HOWEVER, THIS DID NOT HAPPEN. ENGINE HAS CONTINUED TO LEAK AND OIL CONTINUES TO MIX WITH COOLANT FLUID, EVEN AFTER FLUSHING SYSTEM TWICE SINCE REPAIR. DESPITE NUMEROUS CALLS TO DEALER, PROBLEM HAS NOT BEEN FIXED. ENGINE HAS LESS THAN 13K ADDITIONAL MILES ON IT SINCE "REPAIR" AND OIL IS STILL LEAKING. LEAK CONTINUES TO GET WORSE WITH TIME. I BELIEVE THIS IS A MANUFACTURER'S DEFECT AND SINCE THE ENGINE HAS FAR LESS THAN 100K MILES ON IT, SHOULD BE REPAIRED AS A WARRANTY ITEM. MIXING OF OIL AND COOLANT IS A SAFETY HAZARD AND NEEDS TO BE PROGRAMMATICALLY ADDRESSED BY FORD.

VIBERATION IN REAR AND CLUNKING NOISR IN REAR WHEN STOPPING AT LIGHT THEN TAKING OF WHILE MAKING A RIGHT TURN

ALL GAUGES STOP WORKING WHEN IT RAINS BUT STARTS AND RUNS OK. POWER WINDOWS DO NOT WORK WHEN IT RAINS BUT STARTS AND RUNS OK.

2004 FORD 4.6L ENGINE: #2 SPARK PLUG EJECTED FROM CYLINDER HEAD. ~$700 TO REPAIR!!!

TL* THE CONTACT OWNS A 2004 FORD E-350. WHILE DRIVING APPROXIMATELY 25 MPH, THE FRONT AIR BAGS DEPLOYED WITHOUT WARNING. THE CONTACT SUSTAINED BURNS ON BOTH FOREARMS, BUT DID NOT RECEIVE MEDICAL ATTENTION. THERE WAS NO POLICE REPORT FILED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 177,000. THE VIN WAS UNAVAILABLE.

THERE ARE TONS OF DRIVERS ON PUBLIC ROADS USING OFF ROAD LED LIGHT BARS AND USING AMPLIFIED HID HEADLIGHTS. THEY ARE SO BRIGHT I HAVE TO BLOCK THE LIGHT WITH MY HANDS WHEN THEY DRIVE BY. I KNOW THIS IS ILLEGAL. IT IS TERRIBLY UNSAFE. WHY ARE THERE NOT LAWS BEING ENFORCED TO PREVENT THEIR USE ON THE STREET?

AT THE POINT I REACH 40 MPH TRUCK SHIFTS TO NEUTRAL, HAVE TO PULL OVER SAFELY AND TAKE TRUCK OUT OF OVERDRIVE TO GET HOME. VERY DANGEROUS WHEN TRAVELING AT THAT RATE OF SPEED. DID SOME OF MY OWN INVESTIGATING AND FOUND MANY WEBSITE HAVE ANGRY PEOPLE WHO ALSO OWN SAME VEHICLES WITH VERY LOW MILEAGE. I SAW THE RANGE OF MILES BETWEEN 44,000 MILES TO 150,000 MILES. PLEASE REFER TO WWW.CARCOMPLAINTS.COM JUST TO START WITH, THERE ARE MANY OTHER WEBSITES FOR THIS MODEL YOU CAN SEE. PLEASE HELP. *TR

TL* THE CONTACT OWNS A 2004 FORD E-450. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE VEHICLE STALLED. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. IN ADDITION, THE VEHICLE FAILED TO START INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER MULTIPLE TIMES. THE TECHNICIAN DIAGNOSED THAT THE POWER CONTROL MODULE, STARTER AND THE HOP OIL PRESSURE PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 119,000.

TL* THE CONTACT OWNS A 2004 FORD E-350. WHILE DRIVING 70 MPH, THE VEHICLE STALLED AND WAS TOWED TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE FUEL INJECTOR, FUEL TANK, FUEL PUMP, AND THE ENGINE NEEDED TO BE REPLACED. THE TECHNICIAN ALSO STATED THAT THE SILVER COATING IN THE FUEL TANK WAS FROM ONE OF THE DAMAGED PARTS. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 52,000. UPDATED 04/07/15*LJ UPDATED 11/3/15*JS

AVI FOODSYSTEMS VEHICLE # [XXX] IS A DANGER ON THE ROAD IT IS NOT FEDERALLY INSPECTED AND YOU CAN SEE THE TRUCK IS A HAZARD. I FEEL BAD FOR THE DRIVER EVERYTIME I SEE HER COME TO OUR ACCOUNT. SHE IS RISKING HER LIFE DRIVING THAT VEHICLE. THIS TRUCK HAS OHIO PLATES AND IS IN ERIE,PA I WANTED TO INFORM D.O.T. ANONYMOUSLY. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

BFG COMMERCIAL T/A TIRE (215/85 R16) BLEW OUT AND HAD TOTAL TREAD SEPARATION CAUSING SOME VEHICLE DAMAGE. TIRE WAS UNDER 5 YEARS OLD PER DOT DATE CODE, UNDER 15K MILES, HAD GOOD TREAD, NO INDICATION OF DAMAGE. NO KNOWN IMPACT WITH ANY ROAD DEBRIS, BLOW OUT OCCURRED WHILE TRAVELING UNDER 55 MPH. VERY LITTLE WARNING, JUST SLIGHT FEELING OF MISBALANCE BEFORE TIRE EXPLODED. TIRES HAD BEEN CHECKED FOR PROPER INFLATION 2-3 DAYS BEFORE. TIRES WERE VISUALLY INSPECTED DURING TRAVEL - NO SIGNS OF OVER/UNDER INFLATION. *TR

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THAT THE LOWER BALL JOINTS WERE CAUSING PREMATURE WEARING OF THE TIRES. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE FRONT END SPRINGS WERE COMPLETELY FRACTURED. THE DEALER AND MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE MANUFACTURER STATED THAT THERE WERE NO ACTIVE RECALLS REGARDING THE FAILURE AND DECLINED TO PROVIDE A REMEDY TO RESOLVE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 93,000. UPDATED 05/05/14*JB

TL* THE CONTACT OWNS A 2004 FORD F-150. THE CONTACT STATED THE FRONT PASSENGER'S SIDE WINDOW INDEPENDENTLY OPENED. THE FAILURE RECURRED SEVERAL MONTHS LATER ON THE REAR PASSENGER WINDOW. THE VEHICLE WAS TAKEN TO THE DEALER, WHO STATED THAT BOTH WINDOW REGULATOR ASSEMBLIES WOULD NEED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURE WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

TL* THE CONTACT OWNS A 2004 FORD E-450. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKES SUDDENLY ENGAGED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THAT THE ALUMINUM PUCKS IN THE BRAKING SYSTEM EXPANDED WHEN HEATED, CAUSING THE BRAKES TO ENGAGE. THE MECHANIC RECOMMENDED REPLACING THE ALUMINUM PUCKS WITH STEEL ONES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 30,000. UPDATED 3/28/14*CN

TL* THE CONTACT OWNS A 2004 FORD E-350. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, HE NOTICED SMOKE COMING FROM THE EXHAUST PIPE. THE VEHICLE WAS TAKEN TO THE DEALER AND TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. BOTH TECHNICIANS ADVISED THE CONTACT THAT THE EGR COOLER AND THE HEAD GASKET WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 83,000.

TL* THE CONTACT OWNS A 2004 FORD E-150. THE CONTACT STATED THAT A PRIVATE MECHANIC ATTEMPTED TO REMOVE THE SPARK PLUGS BUT THEY WERE FUSED TO THE ENGINE. THE VEHICLE WAS EVENTUALLY REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 118,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2004 FORD E450 SD. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, THE BRAKES WOULD SEIZE INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE BOTH THE FRONT AND REAR BRAKES WERE REPLACED. THE MASTER CYLINDER WAS ALSO INCLUDED IN THE REPAIR. THE FAILURE RECURRED NUMEROUS TIMES. THERE HAD BEEN OTHER REPAIRS THAT INVOLVED THE REPLACEMENT OF THE BRAKES. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 26,000.

TODAY WAS DRIVING NORMALLY ON THE SIDE ROAD NOT TOWING & IN OVERDRIVE WHEN AROUND 40MPH THE OVERDRIVE DISENGAGED & STARTS REVVING LIKE IT'S IN NEUTRAL. I PULL OVER & PUT IT INTO PARK & THEN BACK INTO OVERDRIVE & START DRIVING ONCE AGAIN & SAME THING HAPPENED THREE TIMES. LUCKILY THERE WAS A SERVICE SHOP CLOSE. I TOOK THE TRUCK IN & THEY SAID TAKE IT TO A TRANSMISSION SHOP. HE ALSO SAID IT WAS FINE TO TAKE IT OUT OF OVERDRIVE & THAT WOULDN'T CAUSE IT TO DO THAT. SO, I TOOK IT OUT OF OVERDRIVE & IT DIDN'T MISS A BEAT. AFTER READING THE REVIEWS IT SEEMS TO BE AN ISSUE WITH THE OVERDRIVE SERVO RETAINING CLIP BREAKING. THIS IS BY FAR A MAJOR PROBLEM FORD NEEDS TO LOOK INTO THAT COULD POTENTIALLY PUT LIVES AT RISK. IF IT'S A BAD PART WHY NOT FIX THE PROBLEM IF THERE ARE HUNDREDS OF REPORTS ON THIS SAME EXACT ISSUE? I'VE BEEN A FORD OWNER ALL MY LIFE & AM TRULY SADDENED THAT THIS COULD POSSIBLY BE MY LAST FORD I EVER BUY AGAIN. I'M HOLDING FORD ACCOUNTABLE ON THIS & EVERYONE ELSE THAT HAS THE SAME ISSUE SHOULD DO THE SAME. IT'S A $2.50 PART, THAT'S ALL. & WHEN YOU BRING IT INTO FORD OR ANY OTHER TRANSMISSION SHOP THEY WANT TO DO A WHOLE REBUILD WHICH WILL COST THOUSANDS. WE GO BY THE SAYING BUILT IN AMERICA FOR A REASON & THAT'S NOT USING CRAP PARTS. BUILD IT RIGHT THE FIRST TIME & HAVE NO PROBLEMS. IF YOU START THROWING PARTS & BUBBLE GUMMING IT TO DEATH, THIS IS WHAT HAPPENS. FIX IT FORD! THERE ARE ENOUGH COMPLAINTS ON THIS ALREADY. *TR

SIDEWALL SEPARATED COMPLETELY ON ONE TIRE AND THE TREAD IS SEPARATING FROM THE BODY IF ANOTHER TIRE. BOTH TIRES ARE THE SAME MAKE AND MODEL. DEAN MUD TERRAIN SXT M+S LT245/75-R16 DOT ON TIRE WITH SIDEWALL SEPARATION UP11-DNW-0108 DOT ON TIRE WITH TREAD LUG SEPARATION UP11-DNW-0108 FAILURES OCCURRED AT THE SAME TIME ON A 2004 FORD E350 ECONOLINE. DURING FREEWAY OPERATION, OPERATOR FELT A RUMBLE AND SLOWED AND PULLED OVER TO THEN NOTICE THE SIDEWALL HAD SEPARATED. HE THEN ALSO NOTICED THE REAR. CHANGED TIRES TO A DIFFERENT BRAND AND CONTACTED COOPER THE PARENT COMPANY OF DEAN TO SEE IF THERE WAS A RECALL. NO RECALL WAS STATED UNDER THEIR COMPANY. FOUR OF THE TIRES ON THE VAN ARE UNDER WARRANTY AND THEY DIRECTED ME TO CONTACT A LOCAL DISTRIBUTOR TO CHANGE THEM. STILL HAVE THE TIRES AND HAVE YET TO CHANGE THEM OUT. *TR

TL* THE CONTACT OWNS A 2004 FORD E250. THE CONTACT STATED THAT THE GLUE THAT HELD THE EMERGENCY BRAKE PAD SEPARATED FROM THE PEDAL. THE CONTACT STATED HE TRIED TO USE THE EMERGENCY BRAKE BUT IT WAS INOPERABLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO INSPECTED THE FAILURE BUT DID NOT REPAIR THE FAILURE. THE MANUFACTURER WAS NOTIFIED WHO STATED THERE WAS NO RECALL AND IF THERE WAS A RECALL IN THE FUTURE HE WOULD RECEIVE A REIMBURSEMENT. THE FAILURE MILEAGE WAS 175,339.

THE TIRE DEVELOPED A "SLOW LEAK" AT 16,500 MILES SINCE INSTALLATION. THE TIRE DEALER REMOVED THE TIRE AND FOUND THE TIRE TO HAVE A 2-3 INCH SLICE IN THE OUTER SKIN OF THE SIDEWALL WHICH RAN PARALLEL TO AND CLOSEST TO THE RIM (AS OPPOSED TO THE TREAD). IT WAS VERY APPARENT THERE WAS TOTAL SEPERATION OF THE OUTER SIDEWALL FROM THE INNER RIBBING YET THERE WAS ONLY A SLOW LEAK OF PSI. *TR

TL* THE CONTACT OWNS A 2004 FORD E350. EQUIPPED WITH BF GOODRICH T/A A/S TIRES, SIZE: LT245/75R16. THE CONTACT STATED THAT RECALL NOTICE FOR NHTSA CAMPAIGN ID NUMBER 12T019000 (TIRES: TREAD/BELT) WAS RECEIVED JULY OF TWO THOUSAND TWELVE. THE CONTACT BELIEVED THAT THE WAIT FOR THE REPAIRS HAD EXCEEDED A REASONABLE AMOUNT OF TIME. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE DOT NUMBER AND VIN WERE NOT AVAILABLE.

TL* THE CONTACT OWNS A 2004 FORD E-350. THE CONTACT STATED THAT THE VEHICLE WOULD STALL WITHOUT WARNING. THE VEHICLE WOULD STUTTER AND THEN STALL. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE FUEL INJECTION CONTROL PRESSURE SENSOR FAILED. THE CONTACT REFERENCED NHTSA RECALL CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM: WIRING) BUT WAS ADVISED THAT THE VEHICLE WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 93,000.

DVD PLAYER WILL NOT EJECT CD'S. *TR

TL* THE CONTACT OWNS A 2004 FORD E-350. THE CONTACT STATED THAT THE VEHICLE WOULD LOSE POWER WHEN ACCELERATING AND THEN STALL. THE CONTACT WOULD HAVE TO WAIT THIRTY MINUTES BEFORE THE VEHICLE WAS ABLE TO BE RESTARTED. THE CONTACT STATED THE FAILURE WOULD OCCUR WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES, BUT THERE WAS NO SOLUTION TO THE PROBLEM. THE CONTACT DID RESEARCH AND FEELS THE PROBLEM IS CAUSED BY THE FUEL TANK DELAMINATING. THE FAILURE MILEAGE WAS 50,800 AND THE CURRENT MILEAGE WAS 120,000.

I AM THE ORIGINAL OWNER OF A 2004 FORD E 350 DIESEL,IT HAS BEEN IN THE SHOP MANY OF TIMES FOR THE SAME PROBLEM TRUCK STOPS RUNNING IN MIDDLE OF INTERSECTIONS, HIGHWAYS ETC DOES NOT START AND NEEDS TO BE TOWED.FORD DEALERSHIP HAS NO IDEA WHAT IS WRONG WITH TRUCK, I GET TRUCK BACK SAME THING HAPPENS. REPEATEDLY. NOW THAT THE TRUCK IS OUT OF WARRANTY SAME THING HAPPENS RESULT: DELAMINATING FUEL TANK, LITTLE SLIVERS OF PAINT CLOGGING FUEL LINES, PUMPS AND INJECTORS. *TR

DURING THE WINTER MONTHS OUR 2004, FORD, E150, VAN HAS HAD OCCASIONAL YET COMPLETE BRAKE FAILURE SEVERAL TIMES. TYPICALLY, IT HAS HAPPENED WHEN IT WAS VERY COLD -10F AND TYPICALLY SLOWER SPEEDS 10-15MPH BUT TODAY IT WAS 30 F AND SPEEDS WERE 45-50 MPH AS WE WERE COMING DOWN A MOUNTAIN PASS IN COLORADO. WE ALMOST REAR ENDED A SEMI AND ALMOST TOOK ANOTHER CAR HEAD ON BUT THEY HAD MOVED INTO THE FAR LANE. BEFORE REACHING THE BRAKE FAILURE RUN OFF WE WERE ABLE TO DOWN SHIFT AND EVENTUALLY THE BRAKES CAME BACK TO COMPLETE WORKING ORDER. THE VAN HAS BEEN BROUGHT IN SEVERAL TIMES TO FORD DEALERSHIP AND EACH TIME SAME ANSWER, WE CAN'T REPRODUCE THE PROBLEM SO THEY HAVEN'T DONE ANYTHING. *TR

PROBLEM: HESITATION ON ACCELERATION, ROUGH IDLES, LOSS OF POWER UPON ACCELERATION. INJECTOR FOUND CLOGGED ON 12-2006. REPLACED TURBO ASSEMBLY AND COLD AIR BOOT ON 12/20/2006. FILED WRITTEN COMPLAINT TO FORD IN APRIL 2006 FOR RECURRING ENGINE ISSUES. FORD NEVER ANSWERED. ON 1/30/09 TRUCK NOT RUNNING AND FORD REPLACED THE TRANSMISSION. ASKED FORD SERVICE TO CHECK ROUGH RUNNING AND ENGINE POWER LOSS BUT COMPUTER SHOWED NO CODES. TOOK TRUCK INTO FORD ON 1/21/20011 FOR BRAKES AND VEHICLE NOT RUNNING PROPERLY EVEN AFTER WARM UP. DIAGNOSIS FROM FORD --- FOUND RUST IN THE FUEL FILTER, WAS TOLD FUEL TANK NEEDED REPLACED AS WELL AS INJECTORS AND INJECTOR PUMP AND FUEL LINES. COST TO REPLACE $5000 OR MORE. WARRANTY RAN OUT NOVEMBER 2010. FORD IS NOW REQUIRING VEHICLE OWNERS TO REPLACE THEIR FUEL TANKS AND ANY ANCILLARY PARTS AT THEIR OWN COST. FORD HAD TO OF KNOWN THAT THERE WAS A PROBLEM WITH THE FUEL TANKS DELAMINATING AFTER 2004. AS A SMALL BUSINESS OWNER IN THIS ECONOMY HAVING TO SPEND EXTRA MONEY ON A PROBLEM THAT COULD AND SHOULD HAVE BEEN TAKEN CARE OF UNDER WARRANTY IS EGREGIOUS. MY VEHICLE CURRENTLY HAS 113,000 MILES AND TO ALREADY HAVE TO REPLACE A TRANSMISSION AND NOW THE FUEL TANK IS INDICATIVE OF A DEFECTIVE VEHICLE. FORD IS NEGLIGENT IN NOT ACKNOWLEDGING A POTENTIALLY DANGEROUS TO LIFE SAFETY PROBLEM.

FUEL TANK DELAMINATION IN MY 2004 FORD E-350 HAS CAUSE A NEED FOR AN EXPENSIVE TOTAL FUEL SYSTEM REPLACEMENT. OBVIOUSLY IT IS A HUGE PROBLEM AS THERE ARE MANY COMPLAINTS ONLINE OF THE EXACT SAME PROBLEM ALL OVER THE COUNTRY. FORD SAYS ITS THE BIO DIESEL THAT IS CAUSING THE PROBLEM, BUT ITS FUNNY HOW DODGE AND CHEVY AREN'T HAVING ANY PROBLEMS... *TR

TL*THE CONTACT OWNS A 2004 FORD E350 SD. THE FUEL TANK DETERIORATED AND THE PARTICLES THAT COMES OFF OF THE TANK CLOGGED THE FUEL INJECTORS. THE FAILURE PREVENTED FUEL FROM GETTING INTO THE ENGINE WHICH MADE THE VEHICLE DRIVE 15 MPH TO INCLUDE A ROUGH START. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY STATED THAT IT WOULD COST OF $4500 TO SEAL THE FUEL TANK. THE REPAIRS WERE NOT COVERED UNDER WARRANTY OR RECALL. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 113,000.

2004 FORD DIESEL OVERHEATS AND STALLS. *TR

TL*THE CONTACT OWNS A 2004 FORD E-150. WHILE DRIVING 20 MPH THE CONTACT NOTICED THAT THE REAR PASSENGER DOOR HAD SUDDENLY OPENED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE DOOR HINGES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 130000.

MY 2004 F-150 HAS A WINDOW REGULATOR GO OUT FOR THE SECOND TIME THIS IS A REAL ISSUE IT IS A HAZARD TO MY CHILDREN AND A REAL BIG COST TO ME BEING 300 DOLLAR BOTH TIMES I HAD TO REPLACE IT NEED TO BE RECALLED WHAT A BIG DISAPPOINTMENT CAN YOU HELP ME IN THIS MATTER THANK YOU. *TR

TL* THE CONTACT OWNS 2004 FORD E 250. THE CONTACT STATED IN ORDER TO REMOVE HIS KEYS FROM THE IGNITION; HE WOULD HAVE TO PRESS AND HOLD HIS FOOT ON THE BRAKE PEDAL AND HOLD THE GEAR SHIFT SELECTOR IN THE PARK POSITION WHILE APPLYING SLIGHT FORCE. THE CONTACT FOUND (NHTSA CAMPAIGN ID NUMBER: 08V051000: VEHICLE SPEED CONTROL: CRUISE CONTROL) WHICH HE BELIEVED WAS DIRECTLY RELATED TO THE FAILURE. THE CONTACT ALSO STATED THE DRIVERS SIDE SEAT IS DEFECTIVE.THE DEALER ADVISED THE CONTACT THAT HE WOULD HAVE TO COVER THE REPAIR EXPENSE FOR ALL THREE FAILURES. THERE WERE NO REPAIRS MADE TO THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 9,400 AND THE APPROXIMATE CURRENT MILEAGE WAS 24,000.

VEHICLE CUTS OUT DURING DRIVING . *TR

TL*THE CONTACT OWNS A 2004 FORD E350 ECONOLINE WITH 79800 MILES. THE CONTACT NOTICE THAT THE WARNING LIGHT ON HIS INSTRUMENT PANEL CAME ON STATING THAT THERE WAS WATER IN THE FUEL. THE VEHICLE WAS THEN TAKEN TO THE DEALER WHO STATED THAT THE LINING IN THE FUEL TANK HAD DELAMINATED. THE CONTACT WAS TOLD THAT HIS FUEL SYSTEM NEEDED TO BE REPLACED.

DRIVING DOWN INTERSTATE IN 2004 FORD F150 XLT WITH APPROX. 70K MILES AND INADVERTENTLY LOWERED REAR WINDOW. WHEN I WENT TO CLOSE THE WINDOW, I HEARD A LOUD CRACK AND REALIZED THAT THE WINDOW WAS NOT GOING BACK UP. AFTER PULLING OFF ONTO THE SHOULDER TO INSPECT WHAT HAD OCCURRED, I SAW THAT MY REAR WINDOW HAD DROPPED INTO THE DOOR. LUCKILY IT WAS NOT RAINING THAT DAY OR I WOULD HAVE HAD A BACK SEAT FULL OF WATER. I TOOK IT TO A LOCAL MECHANIC WHO SAID THAT FORD'S POWER WINDOW BRACKET REGULATOR, WHICH WAS CRACKED, IS ONE PIECE AND REQUIRED REPLACEMENT BY TAKING APART THE DOOR. $275 WAS SPENT TO FIX THE REAR WINDOW. I HAVE SEEN NUMEROUS COMPLAINTS REGARDING FORD'S WINDOWS. RIGHT NOW I CONSIDER MYSELF LUCKY THAT IT HAS ONLY HAPPEN TO ONE WINDOW, BUT I WON'T BE SURPRISED IF IT HAPPENS AGAIN SOON TO ANOTHER WINDOW SINCE IT APPEARS OTHERS HAVE HAD TWO OR THREE WINDOWS WITH THIS PROBLEM. IT APPEARS TO BE A MAJOR DEFECT THAT SHOULD BE RECALLED. *TR

VAN STOPPED RUNNING IN FREEWAY 2004 FORD E-350 DIESEL PROBLEM WITH TANK DELAMANATION 4 VANS SAME THING ALL CAME TO A STOP IN THE ROADWAY. *TR

5 SPEED AUTOMATIC TRANSMISSION OCCASIONALLY JUMPS OUT OF DRIVE DURING NORMAL OPERATION OF VEHICLE, ENGINE REVS FOR A SECOND OR TWO, THEN TRANSMISSION SLAMS BACK INTO DRIVE. *TR

VEHICLE LOST POWER 4 DIFFERENT TIMES. FUEL PUMP EXCESS NOISE, FUEL PUMP CLOGGED. DEALER CONTACTED FORD MOTOR CORP WHO BLAMED CONDITION ON DIESEL FUEL. FUEL PUMP WAS REPLACED AS WELL AS FUEL FILTERS AND FUEL TANK. WE ARE OUT $3000.00 FOR THE REPAIRS.

I HAVE A FORD E-350 SUPER DUTY VAN THAT HAS HAD DRIVABLE PROBLEMS SINCE IT WAS NEW. AFTER MANY TRIPS TO DEALERSHIPS I WAS TOLD THAT THERE WAS NO FIX AT THIS TIME AND FORD SHOULD COME OUT WITH A FIX IN THE FUTURE. THE ENGINE DIES WHEN HOT AT TIMES CAUSING HARD BRAKING AND LOSS OF STEERING. AT 100699 MILES, JUST 699 MILES OUT OF WARRANTY THE ENGINE QUITE RUNNING WHEN HOT. IF IT SITS FOR 6 OR MORE HOURS IT WILL RESTART AND RUN FOR ONLY 20 MINUTES. FORD TOLD ME IT WAS NO LONGER UNDER WARRANTY AND WOULD PROVIDE NO ASSISTANCE. *TR

FUEL TANK LINER IS SEPARATING CAUSING CORROSION AND RUST IN THE FUEL TANK. FORD REFUSES TO WARRANTY THE PROBLEM. THEY ARE BLAMING IT ON THE DIESEL FUEL, WHICH IS INACCURATE. I HAVE ONE CONFIRMATION FROM A CUSTOMER THAT THEY FINALLY COVERED HIS REPAIR, HOWEVER, HE HAD TO LODGE COMPLAINTS WITH BOTH THE NHTSA AND THE BBB. SO I AM OFFICIALLY LODGING A COMPLAINT AGAINST FORD MOTOR COMPANY, STEVEN'S FORD (THE DEALER), AND THE WARRANTY COMPANY. THE SAFETY ASPECT OF THIS IS THE TRUCK STALLS WHILE DRIVING AND DOES NOT RESTART. THE TRUCK ALSO EXPERIENCED A LOSS OF POWER WHEN GOING UPHILL. BOTH OF WHICH CAN CAUSE A DANGEROUS SITUATION WHEN IN HEAVY TRAFFIC. THIS IS A CHRONIC PROBLEM THAT FORD IS AWARE OF AND IS DENYING RESPONSIBILITY. I PERSONALLY KNOW OF AT LEAST 5 PEOPLE WHO HAVE HAD SIMILAR PROBLEMS WITH THEIR E350 VANS DUE TO CORROSION IN THE FUEL TANK. THIS IS NOT AN ISOLATED INCIDENT AND SHOULD BE COVERED UNDER THE WARRANTY. (PLEASE NOTE THERE IS LESS THAN 36,000 MILES ON THIS, BUT FORD IS NOT TAKING RESPONSIBILITY, NEITHER IS THE WARRANTY COMPANY FROM WHICH AN EXTENDED WARRANTY WAS PURCHASED) . FORD IS TRYING TO BLAME THE REASON ON USE OF MORE THAN 5% MIXTURE OF BIODIESEL AND IS SAYING THAT THE REASON THEY ARE NOT COVERING THE PROBLEM IS THAT THERE IS RUST IN THE FUEL TANK. THE RUST IS A REACTION FROM THE FUEL IN A POORLY DESIGNED FUEL TANK. IF IT WERE A DIESEL FUEL PROBLEM THIS WOULD OCCUR IN DIFFERENT MAKES OF TRUCKS, NOT JUST FORD. THERE IS A HUGE PROBLEM, THAT IS NOT ONLY A SAFETY, BUT AN ENVIRONMENTAL ONE AS WELL. *TR

I OWN 4 DIESEL POWERED FORD E350 VANS. IN 2008 I HAVE HAD A FUEL TANK REPLACED IN A 2000 AND 2004 VAN. I DECIDED TO HAVE MY 2007 CHECKED AND FOUND THAT THE FUEL FILTERS WERE CLOGGED. I HAVE SPENT OVER $7000.00 SO FAR. ALTHOUGH FORD DID NOT REPLACE THE TANK IN MY 2007 I AM STARTING TO WONDER WHEN I WILL HAVE TO HAVE THIS DONE. I HAVE ONE OTHER 2000 THAT JUST STARTED HAVING PROBLEMS. I DON'T NEED TO SPEND ANOTHER $7000.00. I ASKED FOR ABOUT DELAMINATION BUT THEY SAID ITS THE FUEL I'M USING. I SAW THE FUEL FILTERS THAT CAME OUT OF THE VEHICLES AND IT WAS A GRAY/ SILVER MATERIAL. *TR

FORD E450 FRONT BLOWER MOTOR SWITCH FAILURE ON TRANSIT BUSES USED FOR PUBLIC TRANSPORTATION. *NJ THE CONSUMER STATED THE PROBLEM IS NOT ISOLATED TO ONE VEHICLE AND IS BEING FOUND ROUTINELY IN ALL THE VEHICLES OF THIS TYPE IN HIS FLEET AS THE SWITCHES ROUTINELY OVERHEAT. ONE OF THE VEHICLES CAUGHT FIRE AS A RESULT OF THE FAULTY SWITCH. *JB

TL*THE CONTACT OWNS A 2004 FORD E-450. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SPONTANEOUSLY STALLED. THE VEHICLE USUALLY RESTARTS ITSELF AFTER THE FAILURE OCCURS. THE VEHICLE WAS TAKEN TO THE DEALER ON FIVE OCCASIONS AND ALL THE FUEL INJECTORS WERE REPLACED. A MECHANIC STATED THAT THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS WAS THE CAUSE OF THE FAILURE. THE DEALER STATED THAT THE VIN WAS EXCLUDED FROM NHTSA CAMPAIGN ID NUMBER 05V270000 (ELECTRICAL SYSTEM:WIRING); THEREFORE, THEY WOULD NOT ASSUME ANY FINANCIAL RESPONSIBILITY FOR THE REPAIRS. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 120,000 AND CURRENT MILEAGE WAS 337,000.

TL*THE CONTACT OWNS A 2004 FORD E-350. WHILE DRIVING 30 MPH, THE VEHICLE STALLED TWICE WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED. THE VEHICLE WAS TAKEN TO A DEALER AND THEY STATED THAT THE INJECTORS CAUSED THE FAILURE. THE DEALER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 05V270000 (ELECTRICAL SYSTEM:WIRING). THE VEHICLE HAS BEEN REPAIRED MORE THAN 20 TIMES AND THEY ALWAYS REPLACE THE INJECTORS; HOWEVER, THE MECHANIC STATED THAT THE CONTROL MODULE WAS THE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000 AND CURRENT MILEAGE WAS 332,000.

APRIL 2005 WAS THE FIRST TIME THE TRUCK STARTED TO STALL WHILE DRIVING. SYOSSET FORD'S DIAGNOSIS WAS R&R CAM SHAFT POSITION SENSOR. THE SECOND INCIDENT MAY 2005. TRUCK STALLING INTERMITTENTLY AGAIN. SYOSSET FORD UNABLE TO DUPLICATE THE PROBLEM. JULY 2005 A RECALL NOTICE IS SENT FROM FORD STATING THE ICP SENSORS MAY HAVE BEEN IMPROPERLY MANUFACTURED CAUSING THE VEHICLE TO STALL. THIRD INCIDENT TRUCK IS STILL STALLING INTERMITTENTLY ON AUGUST 15, 2005 ICP CONNECTORS ARE REPLACED. SEPTEMBER 2005 A RECALL NOTICE IS SENT FROM FORD STATING THE EP SENSOR MAY HAVE CORROSION AT THE ELECTRODE SURFACE CAUSING THE VEHICLE TO HAVE A SUDDEN LOSS OF POWER. FOURTH INCIDENT. JANUARY 23, 2006 CHECK ENGINE LIGHT IS ON AND TRUCK IS STILL STALLING INTERMITTENTLY. EGR VALVE AND EP SENSOR ARE BOTH REPLACED. FIFTH INCIDENT AUGUST 28, 2006 TRUCK STILL STALLING AND OIL LEAKING FROM COOLANT TANK. REPLACED OIL COOLER AND THE EGR VALVE FOR THE SECOND TIME. TRUCK STILL STALLS INTERMITTENTLY. NOVEMBER 28, 2007 THE STARTER IS REPLACED. STALLING ISSUE IS BECOMING WORSE. THERE ARE TIMES THE TRUCK HAS TO BE RESTARTED 40 TO 50 TIMES A DAY. STARTER IS REPLACED AGAIN FEBRUARY 11, 2008. MARCH 2008 TRUCK WILL NOT START. FORD DIAGNOSIS NO ICP PRESSURE. REPLACED HIGH PRESSURE PUMP, LEAKY FITTING & IPR. TRUCK IS STILL STALLING. SEPTEMBER 16, 2008 FORD DIAGNOSIS FOUND ICP CONNECTORS & SENSORS WERE CORRODED. THIS WILL BE THE SECOND TIME IT HAS BEEN REPLACED. TRUCK STILL STALLS CONTINUOUSLY. FORD LOOKS AT THE TRUCK AGAIN IN SEPTEMBER OF 2008 AND HAS DISCOVERED THE DIESEL FUEL TANK IS CORRODED AND NEEDS TO BE REPLACED. I BELIEVE THAT THE FUEL TANK HAS ALWAYS BEEN THE PROBLEM. FORD WILL NOT COVER THE FUEL TANK UNDER THEIR WARRANTY. MEAN WHILE THE STARTER IS REPLACED AGAIN ON NOVEMBER 20, 2008. THIS E450 VEHICLE HARDLY RUNS ANYMORE. PLEASE VISIT FINISHING.COM LETTER#44219. THERE ARE MANY PEOPLE WITH FORD DIESEL TRUCKS THAT ARE HAVING THE SAME PROBLEM. I BELIEVE THIS IS RECALL ISSUE. *TR

REPEATED VEHICLE BRAKE FAILURE. *TR

UNKNOWN AS TO EVENTS LEADING UP TO THE FAILURE. THE FAILURE IS, VEHICLE STALLS OUT WITHOUT WARNING AND AT TIMES ENGINE SURGES WITH POWER AND LOSES POWER. VEHICLE IS A FORD E 450 WITH A 6.0 LT DIESEL , MGF BY INTERNATIONAL TRUCK MOTORS FOR FORD MOTOR CO. INCIDENT FIRST REPORTED OCT 28, 2006 AND IS ON GOING TO THIS DATE, GETTING PROGRESSIVELY WORSE, RENDING VEHICLE UNRELIABLE. VEHICLE IS AN AMBULANCE, MODULAR AFTERMARKET MFG IS PL CUSTOM, OWNED BY THE PITTSTON TOWNSHIP AMBULANCE ASSOCIATION. CONTACT INFO WITH FORD IS MONIQUE - 1.800.343.5338, THEN SELECT OPTIONS - 3, THEN 7, THEN 4. CASE ID # - 41-AGBDWM. *TR

I WAS A PASSENGER IN A 15 PASSENGER VAN COMING TO TRANSPORT ME FROM THE AIRPORT. IT WAS A WHITE FORD CLUB WAGON (YEAR UNKNOWN). WE WERE GOING AT 70 MILES PER HOUR ON CRUISE CONTROL. THE REAR TIRE BLEW OUT AND WE BEGAN TO SWERVE AND THEN STARTED TO DO 360 DEGREE TURNS AND THEN HIT A GUARDRAIL AND FLIPPED 1.5 TIMES. ONE PERSON WAS KILLED AND SEVERAL MORE WERE INJURED SEVERELY. THE FRONT PASSENGER HAD TO HAVE THE JAWS OF LIFE TO REMOVE HER FROM THE VEHICLE. *TR

GAS FILL LINE CLOSES AND CAN ONLY FILL AT A RIDICULOUSLY SLOW RATE OR NOT AT ALL WITH SOME OF THE FASTER GAS PUMPS. *TR

2004 E-350 FORD DIESEL VAN ..IN 06 FUEL TANK DELAMINATION FORD REPLACED TANK..08 FUEL TANK DELAMINATION AGAIN @ 14000 MI. COST TO ME 2200.00. DEALER SAID FORD WILL NOT ADMIT TO A TANK PROBLEM AND COULD NOT ASSURE ME THE DELAMINATION PROBLEM HAS BEEN CORRECTED TO DATE..I CAN'T AFFORD 2,200.00 EVERY 14000 MI. I USE ONLY HESS DIESEL FUEL. I KNOW I AM NOT ALONE WITH THIS PROBLEM, THE DEALERSHIP SAID THEY DO AT LEAST TWO A MONTH. THIS IS A DANGEROUS CONDITION..THE TRUCK LOSES POWER AND STALLS. *TR

I HAVE HAD THREE TIRE TREAD SEPARATIONS FOR TIRES I PURCHASED IN 2006 FOR MY RV. THE TIRES ARE COOPER SRM II, LT225/75R16. THE PREVIOUS TWO WERE REAR TIRES THAT WERE REPLACED. THE MOST RECENT ONE HAPPENED ON A FRONT TIRE WHILE TRAVELING AT HIGHWAY SPEEDS. *TR

2004 E-250 STANDARD-LENGTH VAN (CONVERSION) WITH 4-WHEEL ABS DISC BRAKES. THE RIGHT REAR AXLE-TO-CALIPER BRACKET BROKE (CRACKED) COMPLETELY THROUGH ONE EAR AND COULD'VE SHEARED THE REMAINING EAR PERMITTING THE CALIPER TO COMPLETELY BREAK FREE, POTENTIALLY SHEARING THE BRAKE LINE AND CAUSING THE RIGHT REAR WHEEL TO LOCK/SEIZE AT HIGHWAY SPEEDS WITH POTENTIALLY DISASTROUS RESULTS. FAILED PN (ORIGINAL) WAS PART NUMBER XC2Z2B292AA WAS SUPERSEDED BY PART NUMBER 5C2Z2B511CA. *TR

TL*THE CONTACT OWNS A 2004 FORD E150. THE VEHICLE SPEED CONTROL SWITCH WAS DISCONNECTED APPROXIMATELY 6-8 MONTHS AGO. THE CONTACT SPOKE WITH FORD A COUPLE OF WEEKS AGO AND WAS INFORMED THAT THE PART FOR THE REPAIR WOULD NOT BE AVAILABLE FOR ANOTHER FOUR MONTHS. THERE HAD BEEN NO FAILURE TO DATE. THE CURRENT MILEAGE WAS 106,000.

VEHICLE: 2005 CHINOOK GLACIER CLASS C R/V, 2004 FORD E450 CUTAWAY CHASSIS. APPLICABILITY: ALL MODEL YEARS OF CHINOOK GLACIER R/V AND POSSIBLY OTHER MODELS. HAZARD: FIRE/EXPLOSION. COMPONENT: FLEXIBLE PROPANE HOSE CONNECTING 2 DISTRIBUTION MANIFOLDS UNDER COACH IN VICINITY RIGHT REAR WHEEL WELL. HOSE IS ROUTED OUTBOARD AND FASTENED TO THE AXLE ARCH FRAME MEMBER BETWEEN THE FRAME AND THE RIGHT REAR SPRING. MINIMAL CLEARANCE BETWEEN SPRING AND HOSE ALLOWS SPRING AXLE MOUNTING HARDWARE TO ABRADE HOSE. THE HOSE ABRADED THROUGH AND BEGAN LEAKING. I NOTED PROPANE SMELL AND HEARD HISSING WHILE PREPARING FOR RECENT TRIP. THE LEAK WAS IN THE VICINITY OF THE EXHAUST PIPE, JUST FORWARD OF GAS GENERATOR AND IN VICINITY OF 55 GAL FUEL TANK. I BELIEVE THERE WAS LIKELIHOOD OF CATASTROPHIC EXPLOSION AND FIRE HAS THIS GONE UNNOTICED, PARTICULARLY IF PARKED AND GENERATOR RUNNING. CORRECTION REQUIRED REMOVAL OF RIGHT REAR DUALS TO ACCESS THE HOSE AND MOUNTING CLAMPS. HOSE REMOVED AND REPLACED WITH NEW HOSE AND FITTINGS MADE UP BY LOCAL PROPANE COMPANY SERVICE PERSONNEL. NEW HOSE WAS RE-ROUTED ABOVE FRAME MEMBER SO AS TO PREVENT ANY POSSIBILITY OF CONTACT WITH SPRING HARDWARE. I BELIEVE THAT MOVING TO INBOARD OF FRAME IS NOT IDEAL AS THAT IS WHERE THE ENGINE EXHAUST PIPE IS ROUTED. BETTER SOLUTION MAY BE TO REPLACE THE FLEXIBLE HOSE WITH METAL TUBING. I CAN SUPPLY PHOTOS OF DAMAGED HOSE AND ORIGINAL PLACEMENT AS WELL AS MY REPAIR AND RE-ROUTING. I BELIEVE THIS SHOULD BE A MANDATORY MANUFACTURER SAFETY RECALL, HOWEVER, MANUFACTURER IS OUT OF BUSINESS. I BELIEVE THERE IS A STRONG LIKELIHOOD OF PERSONAL INJURY OR DEATH AND MAJOR PROPERTY DAMAGE IF THIS IS NOT CORRECTED. *TR

FORD E450 DOORS POP OPEN WHILE DRIVING. CONSUMER STATES THAT THE BODY IS TWISTED, THE DOORS POP OPEN WHILE DRIVING. THE MOTOR AND TRANSMISSION HAVE BEEN REPLACED. PLUS THIS VEHICLE HAS EXPERIENCED EVEN MORE SEVERE PROBLEMS. *KB THE CONSUMER STATED THE BOLTS SHEARED OFF THE BODY OF THE VEHICLE, THE ROOF LEAKED, THE VEHICLE WOULD JUST SHUT OFF WITH NO WARNING AND THE OVERHEAD OF THE CAB WAS COMING OFF OVER THE WINDSHIELD. *JB ODI NOTE: THIS IS A ROCKPORT BODY ON AN E450 FORD CHASSIS - GTB 5-2-08

TL*THE CONTACT OWNS A 2004 FORD E150. THE CONTACT STATED THAT THE BRAKES WERE INOPERABLE . THE DEALER WAS UNABLE TO DUPLICATE OR DIAGNOSE THE FAILURE AND AS OF SPRADLEY BARR FORD JANUARY 7, 2008, THE DEALER HAD NOT REPAIRED THE VEHICLE. THE CURRENT MILEAGE WAS 57,650 AND FAILURE MILEAGE WAS 18,000. UPDATED 02-14-08 *BF THE CONSUMER STATED ONCE THE VEHICLE IS DRIVEN FOR 15 MINS. AND THEN PARKED. THE CONSUMER STATED ONCE DRIVING AGAIN BRAKES BECOME NON EXISTENCE. UPDATED 02/14/08 *TR

FOR THE LAST 3 MONTHS, MY SEAT BELT WARNING BEEP HAS BEEN ON WHETHER I HAVE MY SEAT BELT ON OR OFF. THE DEALER SHIP WHERE I BOUGHT THIS VAN, WHICH IS BILL COLLINS FORD, HAS NOT BEEN ABLE TO HELP WITH THIS PROBLEM. ALSO MY DVD PLAYER STOPPED WORKING AND THE 3 ROW SEAT BELT STRAP HAS BROKE OFF. *TR

TL*THE CONTACT OWNS A 2004 FORD ECONOLINE E150. HE RECEIVED A SAFETY RECALL NOTIFICATION LETTER IN AUGUST 2007 ON THE FORD VEHICLE SPEED CONTROL. THE INFORMATION PROVIDED IN THE LETTER IS FRAUDULENT AND MISLEADING AND THE DEALER LEAD HIM TO BELIEVE THAT A REPAIR WAS GOING TO BE MADE DURING HIS APPOINTMENT. THE CONTACT WAS LATER INFORMED AFTER THE SWITCH WAS DISCONNECTED THAT THE PART WAS NOT AVAILABLE. HE HAS CALLED FORD EVERY MONTH SINCE RECEIVING THE NOTIFICATION IN AUGUST AND EVERY MONTH HE HAS BEEN TOLD THAT THE PARTS WOULD BE AVAILABLE THE FOLLOWING MONTH. HE HAS ALSO TRIED MORE THAN ONE FORD DEALERSHIP AND HE RECEIVED THE SAME RESPONSE. IF HE CANNOT HAVE HIS CAR REPAIRED THAT HE WOULD LIKE TO NEGOTIATE A REFUND. THERE ARE NO FAILURES AT THIS TIME. THE CURRENT MILEAGE WAS 48,000. UPDATED 01/17/08 *BF UPDATED 01/17/08 *TR

VEHICLE LOST POWER 3 DIFFERENT TIMES, ONCE ON INTERSTATE, TWICE IN HIGHWAY TRAFFIC, AND IN ONE CASE THE ENGINE DIED. TURNS OUT CAUSE WAS FAILURE OF TANK LINING CLOGGING UP THE FUEL SYSTEM. EACH OF THE 3 TIMES I REPLACE FUEL FILTERS BEFORE FINALLY CLEANING OUT THE TANK AND DETERMINING ACTUAL PROBLEM. FORD KNOWS THERE IS A PROBLEM WITH THE TANK LINING, AS SHOWN ON FORD TECHNICAL SERVICE BULLETINS 19728, BUT HAS DONE AND WILL DO NOTHING ABOUT THE PROBLEM EXCEPT TELL ME TO REPLACE MY TANK AT ALMOST $600 + LABOR. *TR

ENGINE WAS REPLACED 3 TIMES BY FORD DEALERSHIP, BUT PROBLEM NEVER FIXED , EVERY RE-BUILD ENGINE THAT WAS INSTALLED HAD DIFF. ISSUE , THEN THE LAST ONE JUST CAUGHT IN FIRE FROM LEAKING OIL AND ALSO FROM THE WAY THEY INSTALLED 11-01-07 DATE CAUGHT IN FIRE. *TR

AUTOMATIC TRANSMISSION WILL SLIP OUT OF GEAR WITHOUT WARNING DURING ON-ROAD OPERATION. *TR

(1) DRIVING VEHICLE. (2) INTERMITTENT POWER LOSS AND STALLING. AFTER STALLING CRANK/NO START (3) TOOK VEHICLE TO DEALER FOR REPAIR, UNABLE TO DUPLICATE PROBLEM NO REPAIRS MADE. REPEATED THIS PROCESS MANY TIMES WITH NO REPAIRS FIXING THE PROBLEM. *TR

BOLTS FALLING OFF OF BRAKES THAT HOLD CALIPER ON. I HAVE A TOTAL OF 12 2004 FORD E-150 AND 1 2004 FORD EXPEDITION. 3 OF MY E-250'S AND THE EXPEDITION HAS ALL HAD THIS HAPPEN TO THEM. WHAT HAPPENS IS THAT IT SOUNDS LIKE THE BRAKE PADS ARE WORN DOWN TO METAL ON METAL, WHEN BRAKES WERE CHECKED FOR THE PROBLEM, THE BOLT HAD COME LOOSE AND WAS CAUSING THE CALIPER TO RUB AGAINST THE RIM. *JB

TL*- THE CONTACT STATED THAT AT EACH TIME HE SPRAYED THE WASHER ON THE WINDOWS FROM THE 2005 FORD E350 WITH 100 FAILURE MILEAGE THE WASHER WENT ONTO THE ROOF OF THE VEHICLE. THE VEHICLE HAS BEEN TAKEN TO THE DEALER TWICE, AND THE DEALER REPLACED A TRIPLE PANEL TWICE, BUT THE PROBLEM STILL EXISTED. THE CURRENT MILEAGE WAS 17,000.*AK

TL*- THE CONTACT STATED THAT THE PASSENGER SIDE SEAT BELT LATCH ON THE 2004 FORD E350 WILL NOT STAY LATCHED. THE FAILURE MILEAGE WAS 60000. THE SEAT BELT LATCH WOULD POP OUT OF THE BUCKLE WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO THE DEALERSHIP, AND THEY INFORMED HIM HE SHOULD REPLACE THE SEAT BELT LATCH ASSEMBLY. THE VEHICLE CURRENTLY HAD 82000 MILES. *AK UPDATED 03/30/07. *JB

I WAS DRIVING DOWN INTERSTATE 91 IN MASS. DOING 65 MILES PER HOUR AND EVERYTHING WAS FINE UNTIL I FELT A SLIGHT VIBRATION AND WITH NO WARNING MY REAR RIGHT WHEEL JUST SNAPPED OFF. I WAS LUCKY TO BE ABLE TO STOP THE VEHICLE AND KEEP IT FROM ROLLING OVER OR CREATING A PILE UP OF TRAFFIC. WHEN I HAD GOTTEN OUT TO LOOK I FOUND THAT ALL 5 LUGS WERE SNAPPED OFF AND BROKEN. THERE HAS TO BE SOME SORT OF DEFECT WITH THESE BOLTS. MY FEAR IS THAT SOMEONE ELSE MAY GET KILLED. NOW I AM IN A PROCESS OF TRYING TO HAVE IT REPAIRED AND EVERYONE INCLUDING FORD IS PASSING THE BLAME ON SOMEONE ELSE. PLEASE HELP ME. *NM

TL* - THE CONTACT STATED THAT BETWEEN THE TURBO AND THE INNER COOLER, THERE WERE TWO STAINLESS STEEL LINES CONNECTED WITH A FLEXIBLE JOINT AND THE FLEXIBLE JOINT WAS COMING LOOSE. THE CONTACT STATED THAT WHEN IT CAME OFF HE LOST POWER . THE CONTACT STATED THAT VEHICLE PULLED A 5TH WHEEL TRAILER, AND THAT THIS HAS HAPPENED TWICE. THE CONTACT STATED THAT NEITHER THE WEATHER NOR THE ROAD CONDITIONS WERE A FACTOR. THE CONTACT ALSO STATED THAT HE WAS DRIVING 50 MPH. AK THE CONSUMER STATED THE PART WAS REPLACED UNDER WARRANTY/ UPDATED 06/08/07. *JB

DT*: THE CONTACT STATED WHILE DRIVING 25 MPH, THE ENGINE STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED AFTER 20 MINUTES, AND WAS TAKEN TO A SERVICE DEALER WHERE THE PROBLEM WAS UNABLE TO BE DETERMINED. THERE WAS A NHTSA RECALL # 05V270000, WHICH PERTAINS TO THE WIRING. THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

WE HAD A MAJOR PROBLEM WITH THE VEHICLE NOT STARTING WHEN IT WAS DISPATCHED TO A CALL. INTERNAL OIL COOLER DISENTIGRATED, AND LEAKED OIL INTO THE COOLING SYSTEM. THE CAM SENSORS, AND INJECTORS HAVE BEEN REPLACED SEVERAL TIMES. THE TRANSMISSION HAD TO BE REPAIRED SHORTLY AFTER PURCHASE, AND HAS HAD ALL OF THE INTERNAL GEARS REPLACED SINCE. ALL OF THE WIRING HARNESSES HAVE BEEN REPLACED.THIS PARTICULAR UNIT HAS SPENT MANY MONTHS THIS YEAR IN A SHOP BEING WORKED ON. *JB

PARAMEDIC PLUS DBA SUNSTAR PARAMEDIC, IN PINELLAS COUNTY, FLORIDA, PURCHASED 54 AMBULANCES, FORD E-450, 6.0 LITER, IN AUGUST OF 2004. FOR THE PAST TWO YEARS OF USING THESE AMBULANCES IN ONE OF THE COUNTRIES BUSIEST EMS AGENCIES, WE'VE INCURRED A MULTITUDE OF ISSUES, WHICH HAVE HAMPERED OUR ABILITY TO PUT AMBULANCES ON THE STREET. THESE PROBLEMS INCLUDE, BUT ARE NOT LIMITED TO: EGR VALVES, EGR COOLERS, OIL COOLERS, INJECTORS, AC COMPRESSORS, RADIATORS, WIRING HARNESSES, SEVERAL ENGINES. EVERY AMBULANCE IN OUR FLEET HAS BEEN AFFECTED BY ONE OR MORE OF THE ABOVE PROBLEMS. IN SPEAKING WITH EMS AGENCY REPRESENTATIVES ACROSS THE UNITED STATES, I HAVE FOUND THAT THIS IS NOT AN ISOLATED PROBLEM. WE ARE SPENDING COUNTLESS HOURS OF LABOR AND COST OF REPAIRS OVER TWO YEARS WITH 54 OF THESE VEHICLES. WE HAVE MAINTAINED ALL RECORDS OF REPAIR AND CAN DEMONSTRATE THE IMPACT THIS HAS ON OUR EMERGENCY 911 SERVICE. PLEASE FEEL FREE TO CONTACT ME AT YOUR CONVENIENCE SO WE CAN DISCUSS MORE OF THIS IN DETAIL. *JB

2004 FORD E-450 AMBULANCE 5/31/06 CREW STATED THE ENGINE WAS SURGING, EGR VALVE REPLACED BY DEALERSHIP. 5/31/06 CREW STATED A/C QUIT BLOWING AND GRINDING NOISE HEARD LARGER FUSE INSTALLED BY DEALERSHIP. DEALERSHIP STATED ALL OTHER A/C TEST CHECKED OUT OK. DEALERSHIP ADDED BOOSTER REPLACED TO DIESEL FUEL ALSO REPLACED FILTER, DRAINED WATER SEPARATOR. 9/1/06 ENGINE OIL LEAKING, CREW ALSO HAD A/C CONCERNS AGAIN DEALERSHIP REPLACED GEO ROTOR OIL PUMP COVER GASKET AND SEAL WEAR SLEEVE AND REASSEMBLE POST ROAD. DEALERSHIP FOUND COMPRESSOR SHAFT BROKE REPLACED A/C COMPRESSOR AND CLUTCH ASSEMBLE ACCUMULATOR AND FRONT ORIFICE TUBE. DEALERSHIP ALSO REPLACED FUEL INJECTOR CONTROL MODULE HARNESS, AND EXHAUST PRESSURE SENSOR SECONDARY TO RECALL. 10/12/05 CREW COMPLAINS THAT ENGINE SOUND LIKE IT IS "SUCKING AIR" DEALERSHIP STATED NOTHING WRONG, LATER THAT WEEK CREW MEMBERS FOUND AIR LEAK AT TURBO BRACKET CONTACTED DEALERSHIP THEY ADVISED THAT NOTHING WAS WRONG AND THAT WAS THE WAY IT SHOULD SOUND. WE STILL HAVE THIS EXTREME SURGING SOUND IN THE CAB ON ACCELERATION, THE SOUND IS SO LOUD THAT WE CAN NOT HEAR THE COMMUNICATION RADIO. THIS TRUCK IS A 2004 AMBULANCE WITH ONLY 24,964 MILES ON IT AND IS HOUSED INSIDE A CLIMATE CONTROLLED STATION. WE ARE AGAIN MAKING AN APPOINTMENT TO HAVE TURBO CHECK BECAUSE OF AIR LEAK. *NM

VEHICLE WAS PURCHASED ON OR AROUND SEPTEMBER 2003. ON MAY OF 2005 WE BEGAN TO HAVE MULTIPLE PROBLEMS CONCERNING THIS VEHICLE. THE MOST SIGNIFICANT OF THESE PROBLEMS IS AIR CONDITIONING COMPRESSORS LOCKING UP AND BREAKING THE DRIVE BELT. THIS VEHICLE IS AN AMBULANCE SO A FAILURE COULD CONTRIBUTE TO THE DEATH OF A PATIENT. WE HAVE TRIED VARIOUS REPAIRS TO THIS VEHICLE AS IT HAS FALLEN OUT OF WARRANTY AT THIS TIME. FIRST WE REPLACED THE COMPRESSOR, ACCUMULATOR AND ORIFICE TUBE AND THE BELTS THEN FLUSHED THE SYSTEM. THE 2ND OCCURRENCE WE REPLACED THE COMPRESSOR, ACCUMULATOR AND ORIFICE TUBE THEN FLUSHED THE SYSTEM, THE 3RD OCCURRENCE WE REPLACED THE COMPRESSOR,CONDENSER, ACCUMULATOR AND ORIFICE TUBE THEN FLUSHED THE SYSTEM. AT THIS TIME WE TRIED PLACING EXTERNAL FANS TO HELP LOWER THE HEAD PRESSURES THEN REPLACED THE FAN CLUTCH WITH A SNOW PLOW FAN CLUTCH AS DIRECTED BY OUR FORD DEALER. THE 4TH INCIDENT WE REPLACED THE COMPRESSOR THEN EXTENDED THE EVACUATION PERIOD FOR FEAR OF A POSSIBLE OIL OVERCHARGE. THE 5TH OCCURANCE ON 10/25/2006 WE REPLACED THE COMPRESSOR,CONDENSER, ACCUMULATOR AND ORIFICE TUBE THEN FLUSHED THE SYSTEM. WE ARE NOW IN THE PROCESS OF TRYING A BETTER GRADE REFRIGERATION OIL IN PLACE OF THE USUAL PAG OIL. WE HAVE BEEN TRYING EVERYTHING WE CAN THINK OF TO COMBAT THIS PROBLEM WITH NO SUCCESS. *NM

THE CONSUMER'S TWO 2004 E350'S HAVE WEIGHT ISSUES. *TS ON 5/15/06 THE TRUCKS WERE TAKEN TO A REPAIR FACILITY AND THE CONSUMER WAS TOLD THAT THE GROSS VEHICLE WEIGH RATING ON THE SIDE DOOR OF THE VEHICLE IS 14,200 LBS. THE CONSUMER'S PAPER WORK READ 11,500 LBS. WHEN THE VEHICLE WAS WEIGHT EMPTY IT WEIGHED 9,988 LBS. THE REPAIR FACILITY INDICATED THAT THEY COULD NOT RELEASE THE VEHICLE'S TO THE CONSUMER UNTIL THEY RECEIVED AND ANSWER FROM DOT. 2004 FORD E350 22' GLAVAL UNIVERSAL 15 PASSENGER VEHICLE.

5-2-06. 2004 ECONOLINE REAR SEAT BELTS AND SEAT BELT EXTENDERS ARE POORLY DESIGNED. *TS THE RECEIVING END OF THE SEAT BELTS ARE ATTACHED TO THE END OF THE STRAP, THE OTHER END IS BOLTED TO THE FLOOR. WITH USE THE RECEIVING END TENDS TO FALL BACK THROUGH THE HOLE AND HAS TO BE REINSERTED OFTEN. THE MANUFACTURER PROVIDED SEAT BELT EXTENDERS FOR THE FRONT TWO BUCKETS SEAT, BUT NOT FOR THE REAR SEATS. *NM

CRUISE CONTROL INOPERATIVE. BRAKE STOP LIGHTS INOPERATIVE. DEALER FOUND BRAKE LIGHT SWITCH FAILED . PART # 1LIZ*9F924*AA KIT, BRAKE REPAIR. SWITCH WAS REPLACED AT CUSTOMER EXPENSE. *NM

OIL LEAKING FROM 2004 F-350 6.0L DIESEL ENGINE. EGR FAILURE CAUSING TRUCK TO SHUT OFF ON ROAD. *JB

I BOUGHT A FORD 2004 E450 WITH A6. 0 ENGINE AND HAVE HAD TRANSMISSION PROBLEMS TWICE, ALSO REPLACED 2 HEATER CORES. THE VEHICLE ALSO STALLS AT HIGH SPEEDS ON THE HIGHWAY . I HAVE HAD NO LUCK WITH FORD CUSTOMER SUPPORT TO SELL BACK VIA LEMON LAW. *NM

CONSUMER 2004 FORD E150 WHEEL CAME OFF. LUG NUTS BROKE. *TS *JB

2004 FORD WAGON E350 WITH FLOOR LOWERED BY VANTAGE MOBILITY INT. FOR HANDICAP PEOPLE. DURING STOP AND GO DRIVING LIKE TRAFFIC JAMS WHILE PULLING A TRAILER THE FLOOR BETWEEN FRONT SEATS GETS MORE THAN HOT ENOUGH TO BURN YOUR FOOT. SLIDING DOOR OPENER HAS BROKEN 6 TIMES LEAVING THE DOOR FREE TO SLIDE OPEN AND SHUT. I KEEP A BUNGY CORD TO TIE IT UP BUT INTERIOR LIGHTS COME ON AND OFF WHEN USING BUNGY CORD. THE ORIGINAL LATCH BY FORD WAS REMOVED TO INSTALL THE DOOR OPENER. SPLIT DRIVE SHAFT INSTALLED TO MAKE ROOM FOR UNDER VEHICLE LIFT BY BRAUN CORP HAS A LOW ROAR TO IT. BICYCLE TYPE CHAIN FOR THE SLIDING DOOR OPENER AT WHEELCHAIR LIFT DRAGS ACROSS PART OF DOOR JAMB.(NO PULLEY OR SPROCKET). PAID $48,000 FOR THIS NEW 2004 MODEL IN APRIL, 2005 I'M ASKING FOR MY MONEY BACK. PLEASE HELP US. *NM

WHEN DRIVING ON A HIGHWAY WITH THE VEHICLE SPEED CRUISE CONTROL ON, THE COMPONENT WILL SHUT OFF WITHOUT WARNING. I HAVE BROUGHT THE AUTO BACK TO THE DEALER TWICE WITH THIS COMPLAINT, BOTH TIMES I WAS TOLD THAT THE PROBLEM WAS FIXED. BOTH TIMES THE COMPONENT FAILED AGAIN WHILE IN USE. I WILL BE BRINGING THE AUTO IN TO THE DEALER AGAIN IN TWO DAYS FOR THE SAME REPAIR. I SEE THAT FORD MOTORS HAS BEEN AWARE OF THIS PROBLEM PUBLICLY SINCE OCT. 01, 2004. *NM

DT: THE CONTACT OWNS A 2004 FORD E 350 A CONVERSION VAN WHICH WILL NOT START. THE VAN HAS A POWER STROKE DIESEL ENGINE. THE VAN WAS TOWED TWELVE OR MORE TIMES TO MULTIPLE DEALERSHIPS TO LOCATE THE PROBLEM. THE CONTACT STATED THAT NO DEALER COULD FIGURE OUT WHAT THE PROBLEM WAS. A DIAGNOSTICS TEST WAS PERFORMED ON THE VEHICLE ABOUT FIFTEEN TIMES. THE CONTACT HAS TALKED TO FORD NUMEROUS TIMES. HE INVESTED $96,000 IN THE VEHICLE AND WOULD LIKE TO BE ABLE TO DRIVE IT. THIS I HAPPENED AT ALL TIMES OF THE DAY. THE CONTACT WAS LIVING OUT OF THE VEHICLE AND WAS HAVING THOUSANDS OF DOLLARS IN TOWING EXPENSES. ALSO, THERE WERE RENTAL CAR AND MEDICAL EXPENSES AS A RESULT OF THE FAILURE.*AK

ON JULY 25, 2005 AT @ 10:00AM [XXX] WAS OPERATING MY 2004 FORD EXPLORER XLT (4 DOOR) VIN NO.: [XXX]. SHE WAS INTENDING TO BACK OUT OF THE STONE DRIVEWAY OF HER RESIDENCE LOCATED AT [XXX].DUE TO IT BEING A STONE DRIVEWAY, IT IS HER PRACTICE TO INTIALLY PROCEED 1-2 FEET FORWARD, THEN PUT THE CAR IN REVERSE, SO AS TO NOT KICK UP ANY STONES. [XXX] PROCEEDED TO ENGAGE THE ACCELARATOR FOR THE PURPOSE OF TRAVELLING FORWARD 1-2 FEET. SHE THEN PUT HER FOOT ON THE BRAKE, WHILE PUTTING THE VEHICLE INTO REVERSE. ONCE SHE TOOK HER FOOT OFF OF THE BRAKE AND BEFORE SHE ENGAGED THE ACCELERATOR, THE EXPLORER SUDDENLY AND UNEXPECTEDLY SURGED BACKWARDS, OUT OF CONTROL. THE VEHICLE TRAVELLED OUT OF THE DRIVEWAY (@15-20 FT), THEN CONTINUED TO TRAVEL @75-100 FT. ACROSS THE STREET AND IMPACTED WITH A PARKED 4X4 TRUCK. DURING THIS TIME, [XXX] ATTEMPTED TO STOP THE VEHICLE BY PRESSING DOWN HARD ON THE BRAKE PEDAL. UNFORTUNATELY THIS DID NOT STOP THE VEHICLE IN MOTION. [XXX] THEN TRIED TO SHIFT THE CAR INTO NEUTRAL, WHICH DID NOT STOP THE VEHICLE, AS IT CONTINUED TO SURGE BACKWARDS, ACROSS THE STREET AND IMPACT WITH A PARKED 4X4 PICK-UP TRUCK. THIS IMPACT DID NOT SLOW DOWN THE EXPLORER, AS IT PROCEEDED TO FLIP THE PICK-UP TRUCK UPSIDE DOWN AND FINALLY CAME TO REST DIRECTLY ON TOP OF THE PICK-UP TRUCK WITH ALL FOUR WHEELS SPINNING AND THE ENGINE RACING. THE EXPLORER SUSTAINED @$6,000.00 IN PD AND IS BEING SERVICED BY SUPERIOR AUTO BODY/MANASQUAN, NJ. SUPERIOR AUTO BODY HAS CONTACTED FORD MOTOR COMPANY TO HAVE A SPECIALIST INVESTIGATE THE ACCELERATOR MALFUNCTION. THE EXPLORER MUST BE TAKEN TO FORD DEALERSHIP LOCATED AT 700 SHREWSBURY AVE., RED BANK, NJ. I AM AWAITING THE RESULTS OF THIS INVESTIGATION. UPDATED 07/19/2012 *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

PURCHASED A NEW 2004 FORD E 150 VAN. SIDE ENTRY DOORS DO NOT SHUT CORRECTLY. WHEN DRIVING, THE DOORS RATTLE, INDICATING THEY ARE NOT LATCHING CORRECTLY. I AM CONCERNED ABOUT THE SAFETY OF PASSENGERS AND THE POSSIBILITY OF THE DOORS COMING OPEN. CONTACTED FORD MOTOR COMPANY AND WAS TOLD THEY WERE AWARE OF THE PROBLEM AND THEY WOULD LET ME KNOW WHEN A FIX WAS AVAILABLE. THEY PLACED TAPE ON THE INSIDE OF THE DOOR JAMS TO FORCE THE DOORS TOGETHER. I HAVE SINCE CONTACTED AN ATTORNEY AND QUIT DRIVING THE VEHICLE FOR THE PAST YEAR AS I WAITED FOR THE FIX FROM FORD. AFTER 12 MONTHS THERE HAVE BEEN NO AUTHORIZED FIXES FROM FORD MOTOR COMPANY. I DID NOT KNOW I COULD SUBMIT THIS TO YOU UNTIL TODAY WHEN A NEWS CAST MADE ME AWARE OF YOUR WEB SITE.*JB

DT: CONTACT STATED ON 7-31-05 WAS TRAVELING NORTH ON I-81 70 MPH AND CARRYING 3000 LBS OF STEEL AND ENGINE SHUT OFF 2 MILES SOUTH OF EXIT #66. ENGINE SOUNDED LIKE A WASHING MACHINE AFTERWARDS. CONTACT WAS ABLE TO RESTART THE VEHICLE BRIEFLY IN ORDER FOR THE WRECKER TO LOAD IT. CONTACT RECEIVED RECALL 05S34 ON 07/29/2005. DEALER SAID THIS VEHICLE WAS NOT COVERED UNDER THE RECALL. THIS WAS THE FIRST PROBLEM CONTACT HAD WITH THE ENGINE. *AK

FORD E-450 6.0L ENGINE LOSES POWER, STALLS, WILL NOT RESTART. BAYSHORE FORD SERVICE (WILMINGTON DE) RESULTS IN IDENTIFIED PROBLEMS OF DEFECTIVE EXHAUST BACK PRESSURE SENSORS, THROTTLE BODIES AND UNDERHOOD WIRING HARNESS. THIS IS A SAFETY ISSUE AS VEHICLE STALLS IN TRAFFIC WITH PASSENGERS ON BOARD. THESE DEFECTS SHOULD BE ADDED TO NHTSA RECALL # ) 05V270000. *NM

I RENTED A FORD PASSENGER VAN, THAT U-HAUL CORP CONVERTED TO A CARGO VAN. WHILE INSIDE OF THE CARGO AREA, WIND BLEW THE DOOR SHUT. I COULD NOT OPEN THE DOOR BECAUSE OF THE CHILD SAFETY LOCKS. IN ORDER TO ESCAPE I WAS FORCED TO BREAK OUT A WINDOW. NO INSTRUCTIONS WERE GIVEN THAT THE CHILD SAFETY LOCKS WERE IN THE ON POSITION. THE WINDOWS WERE SECURED BY U-HAUL, AND THE DRIVERS AREA IS SCREENED OFF. NO EXIT WAS AVAILABLE. AMBIENT TEMP WAS 80 DEGREES F. ESTIMATED INSIDE TEMP WAS 100 DEGREES PLUS. U-HAUL HAS NOT RESPONDED, HOWEVER THEY DID CHARGE ME FOR THE DAMAGE TO THEIR VEHICKLE. THE POINT HERE IS NOT THE MONEY INVOLVED, BUT THE SAFETY ISSUE. THE INTERIOR IS NOT HIGH ENOUGH TO STAND UP IN, THE WINDOWS ARE TO HIGH TO LAY ON YOUR BACK AND KICK OUT, AND WITHOUT A TOOL OR OTHER MEANS TO BREAK OUT THE WINDOW, ANY PERSON TRAPED INSIDE THE CARGO AREA COULD NOT GET OUT.

CUSTOMER CAR FAILED ON 11-02-2004. THE ABS LIGHTS IN PANEL BOARD WERE ALWAYS ON. CUSTOMER TOOK CAR TO DEALER TO CHECK BRAKES. DEALER SAID IT WAS A SENSOR, AND THEY CHANGED IT. EVEN THOUGH SENSOR WAS CHANGED IT KEPT ON LIGHTING UP. TWO OR THREE MONTHS AGO CUSTOMER BRAKES DID NOT FUNCTION. TOOK IT TO THE DEALER AGAIN. DEALER REPLACE DTHE MASTER CYLINDER. ON FRIDAY JUNE 24, 2005 THE ABS LIGHT TURNED ON AGAIN. *AK

DT: 2004, FORD, ECONOLINE 150. THE BENCH SEAT WOULD TIP OVER WITH THE CONSUMERS DAUGHTER IN IT BECAUSE SHE COULD NOT FIT IN THE CAPTAINS CHAIR. WHILE SHE WAS SITTING ON THE BENCH SEAT, IT TIPPED OVER WITH HER IN IT, CAUSING HER TO FALL OUT OF THE SEAT. THIS HAPPENED TO HER THREE TIMES. EACH TIME THEY WOULD GO AROUND A CURVE AND SHE WOULD FALL OUT OF THE SEAT BECAUSE THE WIDTH OF THE SEAT WAS NOT BIG ENOUGH, AND THE BENCH WAS TOO HIGH. ALSO, HER FATHER-IN-LAW WHO WAS NOT HANDICAPPED TRIED TO GET OUT OF THE BENCH SEAT AND HE FELL TWICE. *AK *JB

FROM THE VERY FIRST DAY WE OWNED OUR BRAND NEW FORD E-350 DIESEL CUBE VAN WE HAVE HAD AN ONGOING DRIVABILTY PROBLEM. THE ENGINE CUTS OUT WHILE DRIVING ALMOST COMING TO A STALL AND SPITS BLACK OR BLUE SMOKE OUT OF THE TAIL PIPE. WE HAVE HAD THE VEHICLE TO THE DEALERSHIP FIVE TIMES TO DATE TO HAVE THIS PROBLEM FIXED. THE DEALERSHIP CANNOT FIND THE PROBLEM. WE HAVE TRIED TO TAKE THE TRUCK TO A DIFFERENT DEALER, BUT THEY SAY THEY CANNOT FIX IT BECAUSE ANOTHER DEALER HAS ALREADY WORKED ON THE TRUCK AND GOT PAID, SO WE HAVE TO TAKE IT BACK TO THEM. WE USE THIS TRUCK FOR BUSINESS AND HAVE HAD TO RENT A TRUCK SEVERAL TIMES TO TAKE THE TRUCK IN AND FIND THE NEXT DAY THAT IT IS STILL NOT FIXED. WE ARE OUT $400.05 THAT WE BELIEVE EITHER THE DEALERSHIP OR FORD SHOULD REIMBURSE US FOR. I CALLED THE FORD CUSTOMER SERVICE LINE AND WAS BASICALLY TOLD THAT RENTAL REIMBURSEMENTS ARE NOT COVERED IN THE WARRANTY. SHOULD WE BE RESPOSIBLE FOR HAVING TO PAY THESE FEES? WE BOUGHT A BRAND NEW TRUCK SO WE WOULD NOT HAVE THIS PROBLEM.IT IS ALSO NOT OUR FAULT THE DEALERSHIP CANNOT FIND THE PROBLEM. WE HAVE BEEN MORE THAN PATIENT AND FEEL WE SHOULD GET OUR TRUCK FIXED PROPERLY AND BE REIMBURSED FOR OUR LOSSES. WE SEE THERE HAS BEEN A RECALL ON OUR VEHICLE AND STILL HAVE NOT BEEN NOTIFIED. WHICH ONLY MEANS ONCE AGAIN WE HAVE TO PAY TO RENT A TRUCK WHILE OURS GOES IN FOR REPAIRS, WITH NO GUARENTEE THAT IT WILL GET FIXED THAT TIME EITHER.

WE PURCHASED OUR 2004 FORD EXPEDITION IN JULY, TOOK IT TO FLORIDA ON VACATION AND WHILE DRIVING ON THE INTERSTATE IT STARTED SHUDDERING. WHEN WE FINALLY GOT IT STOPPED (THE BRAKES JUST WOULDN'T WORK) WE CHECKED FOR A FLAT TIRE - NOTHING. THE NEXT OCCURANCE WAS THE FIRST WEEK OF SEPTEMBER, WE TOOK IT INOT THE DEALER, THEY FOUND A DIAGNOSTIC CODE AND DID SOMETHING TO IT. IT HAPPENED SEVERAL MORE TIMES. WE CONTINUED TO TAKE IT IN.. THEY SAID THEY COULDN'T FIND A DIAGNOSTIC CODE. ON MARCH 16TH, THE DAY BEFORE IT WAS SCHEDULED TO GO IN FOR THIS AGAIN, I DROVE OVER A ROUGH SPOT ON THE STREET, AND ONCE AGAIN, IT STARTED SHUDDERING. I IMMEDIATELY PUT THE BRAKES ON - I WAS STANDING ON THEM - TO NO AVAIL - A BLOCK AND A HALF AFTER IT STARTED SHUDDERING, AND EXCELLERATING, I HIT A TRUCK AND INJURED MY NECK. WHEN I CONTACTED FORD MOTOR COMPANY THE FIRST TIME, THEY BLEW ME OFF. THE SECOND TIME, THE GUY JUST ASKED WHY I CALLED AGAIN. I TOLD THEM SOME ONE WAS GOING TO GET KILLED, AND I WANTED THIS FIXED. AFTER TALKING TO SEVERAL FRIENDS, I FOUND OUT THAT SEVERAL OTHER PEOPLE HAVE EXPERIENCED THE SAME THING. THE SERVICE MANAGER AT THE DEALER ASKED FOR THE VIN NUMBERS OF THE OTHERS. I AM IN THE PROCESS OF GETTING THEM ALL FOR HIM. DUE TO THE LACK OF RESPONSE FROM FORD, I HAVE TURNED IT OVER TO AN ATTORNEY.

UNABLE TO TURN OFF PASSENGER SIDE AIR BAG. TAKEN TO DEALER ,WHO STATES THEY CANNOT REPAIR IT. *AK

THE TIRE WAS UNDER SIZED. *SC THE CONSUMER STATED THE REAR AXLE WAS OVER WEIGHT BY 400 POUNDS. THE CONSUMER WAS CONCERNED THAT THE RV EXCEEDS THE MANUFACTURERS SPECIFICATIONS. (MICHELIN LOAD RANGE E TIRES.) *JB

I HAVE 3 VEHICLES WITH 5.4 LITER EXHAUST MANIFOLD LEAK, SEVERAL BOLTS ARE CRAKED I HAVE 50,000 MI JUST SHORT OF WARR.MY MECHANIC WON'T TOUCH IT.*AK

SIRS, I RECENTLY PURCHASED A 2004 FORD F-150 SUPERCAB TRUCK. SINCE I HAVE HAD THIS VEHICLE IT HAS SHUT OFF SIXTEEN TIMES. ON ONE OCCASION I WAS IN THE MIDDLE OF AN INTERSECTION. I WAS LUCKY AND DID NOT HAVE AN ACCIDENT. PLEASE FILE THIS COMPLAINT, BECAUSE I HAVE LEARNED THIS IS A WIDE SPREAD PROBLEM. I HOPE IT IS CORRECTED BEFORE SOMEONE IS KILLED. THANK YOU, PAUL FERGUSON. *AK

WHILE DRIVING AT VARIOUS SPEEDS OR TURNING THE ENGINE STALLED. WHEN THIS OCCURRED THE VEHICLE COASTED TO A COMPLETE STOP. DEALERSHIP REPROGRAMMED THE COMPUTER TWICE, REPLACED THE SENSOR ON CRANK SHAFT, AND CHECKED THE WIRING IN THE ENGINE COMPARTMENT. BUT, PROBLEM RECURRED. VEHICLE IS CURRENTLY AT THE DEALERSHIP. THE CHASSIS IS CONNECTED TO A BIG FOOT MH30BB 2004 MOTOR HOME. *AK WHEN THE ENGINE SHOT DOWN IT CHIMED AND THE LIGHTS CAME ON INDICATING THAT WATER WAS IN THE FUEL. CHECK ENGINE LIGHT COMES ON THEN THE ENGINE DIED. *TC

THE VEHICLE WILL NOT START. THE VEHICLE WAS TOWED TO DEALER AND THEY CANNOT FIND DEFECTS. THE MANUFACTURE HAS STATED THAT THEY WILL HELP. THE CONSUMER STATED "THIS IS AN EMERGENCY VEHICLE, AND HAS BEEN OUT OF SERVICE FOR THIRTEEN DAYS". *NM

WHILE DRIVING 20 MPH CONSUMER HEARD A LOUD SQUEAKING NOISE AND VEHICLE VIBRATED UNCONTROLLABLY. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND DROVE IT TO THE DEALER FOR INSPECTION. MECHANIC DETERMINED THAT THE ROTORS AND BRAKE PADS NEEDED TO BE REPLACED ,AND REPLACED THEM. HOWEVER, THE PROBLEM RECURRED. THIS INFORMATION WAS PROVIDE BY MRS. WILLIAM'S FRIEND MR BRONEK DUTJIEWICZ.*AK

FORD HAS NOT NOTIFIED THEIR CUSTOMERS OF THE 04S22 SAFETY RECALL AS OF 10/6/04. ON DEALER'S NOTIFICATION , POSIIBILITY OF SHORT IN ABS MODULE COULD START FIRE IN UNATTENDED VEHICLE - WITH THE IGNITION OFF WAS STATED. AS WELL AS A WARNING NOT TO PARK ANY UNSOLD RECALLED VEHICLES INSIDE. *AK

FIRST APPLICATION OF BRAKES AFTER BACKING OUT OF MY DRIVE WAY RATTLING NOISE IN BRAKE LINES AT THE ABS CONTROL MANIFOLD, IT IS HYD. PRESS. BLEEDING OFF, BRAKE PEDAL STARTS TO GO DOWN, I HAVE EXP. WITH HYD. AND KNOW THAT, THE VIBRATION IN THE LINE WILL CAUSE FITTINGS TO FAIL AT THE VALVE UNDER THE (B) NUT,,#2 (LEDS) IN MIRROR ARE FALLING BACK IN TO THE BODY OF THE MIRROR ASSY, BARELY VISIBLE FROM DRIVER SEAT. *JB

WHILE DRIVING 25 MPH, THE VEHICLE STALLED. THE CONSUMER TRIED TO RESTART THE VEHICLE, BUT WAS UNABLE TO DO SO. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION. THE MECHANIC DETERMINED THAT THE FUEL PUMP NEEDED TO BE REPLACED. *AK THE MECHANIC STATED THE FAILURE OCCURRED DUE TO THE INCORRECT ROUTING OF THE FUEL PUMP ELECTRICAL HARNESS. *SC *JB

THE VEHICLE WAS DIFFICULT TO STEER. AT A CERTAIN SPEED THE STEERING WHEEL WOULD SHIMMY AND THERE WAS SOME PLAY IN THE STEERING WHEEL. FORD HAD THE DISTRICT MANAGER VIEW THE SITUATION. HOWEVER, IT WAS AGREED THAT PROBLEM COULD NOT BE RESOLVED. *AK *SC *JB

2004 FORD F350 THIS FORD TRUCK WANDERS, THERE IS PLAY IN THE STEERING WHEEL. TRUCK DOES NOT GO STRAIGHT DOWN THE ROAD. WANDERS BACK AND FORTH, HAVE TO KEEP MINDING THE WHEEL. CRUISE CONTROL DECREASES 10-12 MPH FOR NO REASON. BOTH OF THESE PROBLEMS ARE SERIOUS SAFETY DEFECTS. THERE IS A DRIVELINE VIBRATION THAT IS CONTINUING TO GET WORSE. FORD IS UNWILLING AND UNABLE TO REPAIR THESE PROBLEMS. *JB

MY 5.4 LITER HAS TERRIBLE THROTTLE RESPONSE AT LOW SPEEDS. THE MOTOR HAS A LONG LAG TIME, FROM THE TIME YOU PRESS THE GAS PEDAL UNTIL THE MOTOR REVS AND THE TRUCK TAKES OFF. I HAVE BEEN IN A COUPLE OF CLOSE CALLS OR NEAR MISSES DUE TO THIS. IF IN AN EMERGENCY OPERATION YOU NEED TO STEP ON THE GAS AND GET OUT OF THE WAY OF ANOTHER VEHICLE, IT HAS SLOW THROTTLE RESPONSE AND IS DANGEROUS. THE DEALER SEEMS TO HAVE NO REAL FIX. *LA

WHILE DRIVING AT ANY SPEED AND WHEN TURNING THE STEERING WHEEL COLUMN WILL NOT COME BACK TO THE ORIGINAL POSITION. DEALER EXAMINED THE VEHICLE, AND REPLACED THE STEERING GEAR BOX. SEVERAL DAYS LATER, CHECK ENGINE LIGHT CAME ON. AFTERWARDS, THE RADIO, INTERIOR LIGHTS, AND BACK UP LIGHTS STOPPED WORKING. DEALER FIXED THE PROBLEM, BUT THE ENGINE LIGHT COME ON AGAIN. *AK

THIS UNIT IS A SMALL MOTORHOME WITH SIX SEAT BELTS BESIDES THE PILOT/COPILOT SEATS. THE CURB SIDE BELTS ARE OK AS THEY ARE SIXTEEN INCHES LONGER THAN THE STREET SIDE. THE STREET SIDE ARE SO SHORT THAT A SMALL CHILD COULD HARDLY USE THEM. THE SEAT BELTS ARE USED IN CONJUNCTION WITH TWO COUCHES IN THE LIVING AREA. THIS WAS BROUGHT TO THE ATTENTION OF THE MANUFACTURER BUT WAS JUST SHRUGGED OFF AS INCONSEQUENTIAL. IT IS A SAFETY ISSUE AND THE MANUFACTURER SHOULD BE MADE TO RECTIFY IT. THERE ARE NUMEROUS UNITS BESIDE THE ONE I HAVE AND I SUSPECT THEY ARE ALL SIMILAR WHERE TWO COUCHES ARE IN THE LIVING AREA. *LA