2004 Mazda MPV

2004 MAZDA MPV. CONSUMER WRITES ASKING TO BE REMOVED FROM RECALL LIST BECAUSE THEY NO LONGER OWN THE VEHICLE.

FRONT CROSS MEMBER CORROSION; FRAME DAMAGED; CAR DANGEROUSLY UNSTABLE. WHEEL ALIGNMENT COST ME $72.64 AND FRAME REPAIR COST $693.36. THE VEHICLE IN THE SHOP FOR 4 DAYS. MENTAL ANGUISH. MAZDA DEALER DECLINED REPAIRS. MAZDA CUSTOMER SERVICE DECLINED TO PAY. NOW THEY ARE ADMITTING THAT PROBLEM ON MAZDA 6 VEHICLES. IT'S AN OLD PROBLEM PROBABLY RELATED TO METALLURGY OR IMPROPER PAINT PROTECTION.

SUSPENSION SUBFRAME RUSTED AND CRACKED.

TL* THE CONTACT OWNS A 2004 MAZDA MPV. WHILE THE CONTACT'S WIFE WAS DRIVING 15 MPH, SHE STRUCK ANOTHER VEHICLE ON THE DRIVER'S SIDE DOOR. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AN UNKNOWN LOCATION. THE VEHICLE WAS NOT TAKEN TO A DEALER TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT TO SEND DOCUMENTATION FROM THE DEALER. THE FAILURE MILEAGE WAS APPROXIMATELY 166,000.

I WENT INTO THE DEALERSHIP TO GET MY SAFETY RECALLS DONE AT THE MAZDA DEALERSHIP ON TORRANCE BUT THEY SAID I NEEDED TO FILL OUT A FORM AND TO WAIT FOR THEM TO RECEIVE THE AUTO PARTS. IT HAS BEEN MORE THAN 6 MONTHS SINCE I WENT, I HAVE NOT HEARD FROM THE AT ALL.

TL* TAKATA RECALL. THE CONTACT OWNS A 2004 MAZDA MPV. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V354000 (AIR BAGS) WAS RECEIVED IN MAY OF 2016. AFTER CONTACTING THE MANUFACTURER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED FOR THE RECALL REMEDY WERE STILL NOT AVAILABLE AND NO ESTIMATED TIME FOR RECEIVING THE PARTS COULD BE PROVIDED. THE LOCAL DEALER WAS NOT NOTIFIED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

AIR BAG INFLATOR REPLACEMENT FIRST NOTICE REC.8/1/16,CALLED BOMARITO(LOCAL DEALER)-NO PARTS-WOULD CALL CALLED AGAIN1/2/17-SAME RESPONSE SECOND NOTICE REC.4/17/17-CALLED AGAIN SAME RESPONSE.

TAKATA RECALL: I RECEIVED MAZDA OFFER TO REPLACE DEFECTIVE PART AND ACCOMMODATE FOR TRANSPORTATION WHILE THE CAR IS BEING REPAIR. THE ONLY REQUIREMENT TO HAVE THIS ACCOMMODATIONS IS TO MAKE AN APPOINTMENT FOR THEM TO DELIVER SUCH OFFER TO FIX THE INCONVENIENCES THAT THIS BRINGS. I CALLED TO MAKE THE ARRANGEMENTS BUT NOW MAZDA REFUSES TO GIVE ANOTHER TRANSPORTATION WHILE FIXING THE CAR, EVEN THOUGH THIS IS INCLUDED IN THEIR WRITTEN OFFER.

TL* TAKATA RECALL. THE CONTACT OWNS A 2004 MAZDA MPV. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V354000 (AIR BAGS) HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS UNAVAILABLE.

THERE IS NO WAY TO ADJUSTMENT THE ALIGNMENT OF THE REAR WHEELS ON THIS YEAR MAZDA MPV, THUS THE TIRES WARE OUT EARLY BECAUSE THEY ARE NOT IN ALIGNMENT. TIRE FAILURE OCCURRED WHILE DRIVING ON HIGHWAY MAZDA DEALER SAYS NO ADJUSTMENT CAN BE DONE AS MAZDA DID NOT PROVIDE A WAY TO CORRECT THIS ALIGNMENT PROBLEM SO EARLY TIRE FAILURE CAN RESULT. MAZDA DEALER WORK SHEET FOR ALIGNMENT STATES THAT THE REAR WHEELS ARE OUT OF FACTORY SPECIFICATION AND IF NOT CORRECTED CAN LEAD TO EXCESSIVE TIRE WEAR, HANDLING AND SAFETY ISSUES. MAZDA BY THERE OWN ADMISSION DID NOT PROVIDED ANY WAY TO CORRECT THIS SAFETY ISSUE. I'M DRIVING A VEHICLE WITH TIRE SAFETY ISSUES DUE TO LACK OF ABILITY TO ALIGN THE REAR WHEELS TO MAZDAS OWN SPECIFICATIONS. *TR

TL* TAKATA RECALL. THE CONTACT OWNS A 2004 MAZDA MPV. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V354000 (AIR BAGS); HOWEVER, THE PART TO DO THE REPAIR WAS NOT AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* TAKATA RECALL. THE CONTACT OWNS A 2004 MAZDA MPV. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V354000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

TL* TAKATA RECALL. THE CONTACT OWNS A 2004 MAZDA MPV. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V354000 (AIR BAGS) HOWEVER THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS UNAVAILABLE.

ACCELERATOR (GAS PEDAL) STOCK OPEN WHEN PEDAL PRESSED FOR ACCELERATION ONTO INTERSTATE HIGHWAY. VEHICLE ACCELERATED TO VERY HIGH SPEED. PRESSING BRAKE SLOWED VEHICLE TO 55 MPH. SHIFTED TO NEUTRAL, HEARD A LOW POP AND ACCELERATOR MECHANISM DISENGAGED.

TL* THE CONTACT OWNS A 2004 MAZDA MPV. THE VEHICLE WAS REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V773000 (AIR BAGS); HOWEVER, THE AIR BAG LIGHT CONTINUOUSLY ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

TL*THE CONTACT OWNS A 2004 MAZDA MPV. THE CONTACT STATED THAT THE DRIVER SIDE AIR BAG WAS FAULTY. THE CONTACT MENTIONED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V773000 (AIR BAGS). HOWEVER, THE RECALL ONLY INCLUDED THE PASSENGER SIDE AIR BAG. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, WHO ADVISED THE CONTACT THAT THE DRIVERS SIDE AIRBAG WAS DISCONTINUED AND THE PART NEEDED TO DO THE REPAIR WAS UNAVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 51,000.

WHY DOES RECALL ONLY COVER THE PASSENGERS SIDE AIR BAG INFLATOR? WHAT COMPANY MANUFACTURED THE DRIVERS SIDE AIR BAG INFLATOR? I WOULD LIKE THE DRIVERS SIDE REPLACED ALSO. I WAS TOLD BY SERVICE DEPARTMENT THAT MAZDA WILL NOT COVER REPLACEMENT OF DRIVERS SIDE AIR BAG INFLATOR. I ASKED PARTS DEPARTMENT IF I COULD PURCHASE DRIVERS SIDE INFLATOR. THEY SAID THAT THE PART WAS DISCONTINUED. I DON'T FEEL SAFE DRIVING MY VEHICLE. WHAT IS THE SOLUTION TO THIS PROBLEM? *TR

TL* THE CONTACT OWNS A 2004 MAZDA MPV. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS THE VEHICLE WOULD INTERMITTENTLY STALL WITHOUT WARNING. IMMEDIATELY AFTER THE FAILURE OCCURRED ALL OF THE WARNING INDICATOR LIGHTS ILLUMINATED ON THE CONTACTS INSTRUMENT PANEL. BOTH THE MANUFACTURER AND DEALER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000. THE VIN WAS NOT AVAILABLE. RK

VEHICLE WAS LURCHING, NO WARNING LIGHT WAS ON. IT TOOK A WHILE TO FIGURE OUT THE REAR COIL WAS BAD. WE SPENT $1200 GETTING A TUNE UP AND THAT DIDN'T FIX THE PROBLEM TOOK A WHILE TO FIGURE IT OUT. ALSO, THE TRANSMISSION FAILED ON THIS VEHICLE COMPLETELY AT 55 THOUSAND MILES. WE HAD TAKEN IT IN 3 TIMES BEFORE IT FAILED AND THEY SAID NOTHING WAS WRONG WITH IT. *TR

I WAS ON I-75 WHEN I ACCELERATED HARD WHILE TRYING TO MERGE INTO A GAP IN HEAVY, MERGING TRAFFIC. WHEN I TOOK MY FOOT OFF THE ACCELERATOR MY VAN CONTINUED TO ACCELERATE AS THE ENGINE CONTINUED TO REV AT A HIGH RPM. I STABBED AT THE ACCELERATOR WITH MY FOOT TO SEE IF I COULD UNSTICK IT, BUT IT ONLY CAUSED THE ENGINE TO REV EVEN HIGHER - TO FULL-THROTTLE. I JABBED AT IT MULTIPLE TIMES TO NO AVAIL. I TRIED TO LIFT THE GAS PEDAL WITH MY FOOT BY JAMMING IT UNDERNEATH THE PEDAL AND PULLING IT UP, BUT IT FLOATED FREELY AND CONTINUED TO FALL BACK TO ITS FULL-THROTTLE POSITION. ALTHOUGH I WAS CONFIDENT THAT THE FLOOR MAT WAS NOT THE CAUSE OF THE PROBLEM I PULLED IT AWAY FROM THE PEDALS AND, AS EXPECTED, THERE WAS NO EFFECT. I WAS ABLE TO KEEP CONTROL OF MY VAN BY APPLYING EXTREMELY HEAVY PRESSURE TO THE BRAKE WHILE SHIFTING BETWEEN NEUTRAL AND DRIVE. DURING THAT TIME I WAS STILL JABBING AND LIFTING THE ACCELERATOR WITH MY RIGHT FOOT TRYING TO 'UNSTICK' THE GAS PEDAL. I WAS ENTERING AND CROSSING AND OVERPASS THAT WAS UNDERGOING CONSTRUCTION. CONCRETE BARRIERS LINED BOTH SIDES OF THE HIGHWAY AND BRIDGE WHERE THE EMERGENCY LANES WOULD HAVE OTHERWISE BEEN LOCATED. I HAD TO MAINTAIN SOME SPEED, FOR FEAR OF BEING REAR-ENDED, WHILE SEARCHING FOR THE FIRST OPPORTUNITY TO PULL OVER. MY VEHICLE WAS TOWED TO THE NEAREST MAZDA DEALERSHIP WHERE THE MECHANIC WAS ABLE TO QUICKLY ASCERTAIN THAT THE SCREWING MECHANISM FROM AN UNSECURED AIR HOSE CLAMP HAD SNAGGED THE THROTTLE ARM - THE CLAMP ATTACHES THE HOSE TO THE ENGINE. AS I PUSHED HARDER ON THE GAS PEDAL IT FURTHER EXACERBATED THE PROBLEM BY LOCKING THE ARM IN A MORE WIDE-OPEN THROTTLE POSITION. THE CLAMP HAD BEEN LEFT UNSECURED FROM PREVIOUS WORK DONE AT A MAZDA DEALERSHIP. ACCORDING TO THE MECHANIC, THIS COULD HAVE ALSO OCCURRED IF THE CLAMP HAD BEEN SECURED, BUT NOT POSITIONED OUT OF THE WAY OF THE ARM. *TR

THE ENGINE COILS HAVE FAILED 4 TIMES SINCE WE HAVE OWNED THE VEHICLE. LAST NIGHT WHILE TRAVELING ON THE INTERSTATE IN THE RAIN, KEY WORDS, IN THE RAIN IT STARTED AGAIN. I AM SURE AT LEAST ONE IF NOT TWO COILS WENT THIS TIME. JUST HAD A COIL AND ALL THE BOOTS THAT ARE SUPPOSE TO PROTECT THE COILS AND KEEP THE MOISTURE OUT REPLACED IN FEBRUARY, 2012. IT ALWAYS HAPPENS WHEN IT RAINS. MAZDA IS WELL AWARE OF THE SITUATION AND HAS DONE NOTHING TO FIX THIS ISSUE EXCEPT TO STOP USING THIS SYSTEM AND START MAKING THEIR CARS DIFFERENTLY. BUT WHAT ABOUT THE PEOPLE WHO OWN THE OLDER MODELS? THIS IS A DANGEROUS SITUATION AS I WAS ON THE HIGHWAY, AT NIGHT, AND IT WAS POURING DOWN RAIN AND THE VAN STARTS SLOWING DOWN AND SPUTTERING ALONG, WITH TRAFFIC TRAVELING BEHIND ME. THIS SHOULD BE A RECALL ISSUE AS IT IS A KNOWN PROBLEM AND IT IS BECAUSE OF A MANUFACTURING DEFECT NOT ANYTHING THAT OWNERS CAN AVOID. *TR

MY RADIATOR FAN CONSTANTLY RUNS INTERMITTENTLY BUT WITH INCREASING LENGTHS OF TIME, REGARDLESS OF THE WEATHER (HOT, COLD.) THE ENGINE DOES NOT OVERHEAT. BUT THE LIGHTS DIM AT NIGHT WHEN THE FAN KICKS IN AND CREATES A LOUD HUMMING SOUND THAT IS BECOMING MORE IRRITATING. I READ ON THE WEB THAT MANY EARLIER MODELS OF THE MAZDA HAD A RECALL FOR THE FAN CONTROL MODULE UP TO 2003. MY VEHICLE IS NOT IN THE RECALL, BUT I NOTICED A LOT OF PEOPLE ON THE WEB HAVE MODELS AFTER THE RECALL PERIOD AND WE ALL HAVE THE SAME PROBLEM AS THE RECALLED MODULES. (SP-60 I THINK IS THE RECALL NOTICE.) I'M NOT SURE I AM CONTACTING THE RIGHT OFFICE, BUT HOW DO YOU GET THIS ON THE RECALL PROGRAM OR DETERMINE THAT THE FAULTY MODULES AREN'T CREATING THE SAME PROBLEM FOR MODELS MADE AFTER THE RECALLED VERSIONS? CAN YOU HELP? *KB

IGNITION COILS RETAIN MOISTURE AND CAUSE CYLINDERS TO MISFIRE. THIS CAUSES VEHICLES TO STALL OR LOSE POWER -- USUALLY WHEN RAINING. IN OUR CASE, THIS HAS HAPPENED REPEATEDLY ON THE INTERSTATE DURING RAIN. WE EARLY CAUSED AN ACCIDENTS BY OUR INABILITY TO GET OUT OF TRAFFIC WITH OUR SUDDENLY-SLOWED VEHICLE. REPLACEMENT OF A SINGLE COILS COST US OVER $200. THERE ARE SIX IGNITION COILS (OVER $1000). MANY INTERNET FORUMS INDICATE THAT THIS PROBLEM IS SYSTEMIC IN THIS MAKE/MODEL. WE UNDERSTAND THAT THE MANUFACTURER REDESIGNED THE COIL FOR SUBSEQUENT MODELS. THEY OBVIOUSLY RECOGNIZED THE FLAW.

2004 MAZDA MINI VAN THE IGNITION COILS ARE CONTINUALLY HAVING TO BE REPLACED-I AM ON THE 4TH TIME HAVING ONE OF THEM REPLACED OVER THE PASS 4 YEARS. *TR

2004 MAZDA MPV. CONSUMER STATES THAT WHILE DRIVING SPEEDS OF 70 MPH THE VEHICLE JUST LOST ALL ACCELERATION DROPPING TO BELOW 5 MPH. SHE ALSO STATES THAT THE VEHICLE JUST SHUT OFF. *KB THE MECHANICS WERE UNABLE TO FIND A PROBLEM. *JB

ENGINE COIL ISSUE. ROUGH IDLE, CHECK ENGINE LIGHT. *TR

WITH OUR MAZDA 2004 MPV, WE HAVE HAD FOUR SEPARATE INCIDENTS IN 2 1/4 YEARS FROM MAR 2008 THROUGH JUNE 2010 WHERE THE CHECK ENGINE LIGHT HAS COME ON TO INDICATE AN ENGINE PROBLEM. IN EACH INCIDENT, THE VEHICLE RUNS VERY ROUGH AND VERY SLOW. EACH INCIDENT RESULTED IN US TAKING THE VEHICLE TO THE MAZDA DEALERSHIP WHERE SOME OR ALL OF THE IGNITION COILS WERE REPLACED. FOR SOME OF THE INCIDENTS, THE VEHICLE WAS OUT OF WARRANTY BUT IN EACH INCIDENT ALL OR SOME OF THE COSTS WERE COVERED BY MAZDA. IN 2 OF THE INCIDENTS, WE WERE OUT OF TOWN AND IT WAS DARK. IN ANOTHER INCIDENT, WE WERE LEAVING TOWN, AND THE OTHER, WE WERE IN TOWN. NOW, WE WILL NOT TAKE THE VEHICLE OUT OF TOWN FOR FEAR OF COMPLETELY BREAKING DOWN AT NIGHT OR IN UNSAFE CONDITIONS. ON THE INTERNET, I FIND VERY MANY SIMILAR INCIDENTS FOR THE MAZDA MPV. *TR

TL* THE CONTACT OWNS A 2004 MAZDA MPV. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE INDEPENDENTLY DECELERATED. THE CONTACT APPLIED PRESSURE TO THE ACCELERATOR PEDAL BUT THE VEHICLE WOULD NOT RESPOND BEFORE STALLING. THE EMERGENCY FLASHERS WERE ENGAGED BUT TO NO AVAIL. AFTER TEN MINUTES, THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS NEITHER DIAGNOSED FOR THE FAILURE NOR REPAIRED. THE FAILURE MILEAGE WAS 42,000 AND THE CURRENT MILEAGE WAS 42,400.

AT APPROX. 50,000 MILES MY 2004 MAZDA MPV'S 'CHECK ENGINE LIGHT' WENT ON. WHEN I BROUGHT THE CAR IN FOR SERVICE I WAS TOLD AN IGNITION COIL HAD TO BE REPLACED. AT APPROX. 60,000 MILES, THE SAME THING HAPPENED ... THE CAR'S CHECK ENGINE LIGHT ' CAME ON AND, AGAIN, AN IGNITION COIL HAD TO BE REPLACED. I HAVE SINCE LEARNED FROM WEB POSTINGS THAT THIS IGNITION COIL PROBLEM MAY BE A FAIRLY COMMON REPAIR ON 2004 MAZDA MINI-VANS AND I'M WONDERING IF THIS IS A DESIGN DEFECT THAT SHOULD BE ADDRESSED THROUGH A RECALL AND REPAIR BY MAZDA. WERE I ON A HIGHWAY WHEN THE LIGHT CAME ON ... THE CAR LOST ACCELERATION CAPACITY AND BECAME VERY DIFFICULT TO DRIVE ... I COULD HAVE BEEN IN A SERIOUS ACCIDENT. I AM NOW CONCERNED THAT THIS IGNITION COIL PROBLEM MAY CONTINUE TO RE-OCCUR IN THE FUTURE. *TR

2004 MAZDA MPV: I HAVE HAD TO REPLACE ALL 6 IGNITION COILS IN MY VAN - THE VAN WOULD SHAKE AND SEEM TO BE STALLING AND THE ENGINE LIGHT WOULD COME ON. THIS STARTED IN JULY 2007 AND CONTINUED SO FAR THROUGH JAN 2010 (WHEN 4 COILS AND ALL MY SPARK PLUGS NEEDED TO BE REPLACED AT ONCE !). I HAVE ALSO HAD THE CAR IN DURING OCT 2008 BECAUSE THE FAN WOULD CONTINUE RUNNING FOR SEVERAL MINUTES AFTER THE VAN WAS SHUT OFF. MY DEALER TOLD ME THIS IS A "FORD" ISSUE. WHEN WILL MAZDA BE REQUIRED TO PAY FOR ALL THESE EXPENSIVE REPAIRS?? *TR

MY 2004 MAZDA MPV SUFFERED THE SAME PROBLEM AS MANY OTHER CONSUMERS. ON TWO DIFFERENT OCCASIONS I HAD TO REPLACE ALL OF THE COILS AND PLUGS ON MY VEHICLE. THE FIRST INSTANCE WAS JUST AFTER THE WARRANTY EXPIRED AND INVOLVED ONE OF THE REAR COILS BUT THE SAID I SHOULD REPLACE ALL THREE REAR COILS. THE SECOND INCIDENT OCCURRED TWO MONTHS LATER TO THE FRONT COIL AND I REPLACED ALL OF THOSE - TOTAL COST $900. I COMPLAINED TO MAZDA BUT THEY WOULDN'T DO ANYTHING FOR ME. THIS SHOULD BE RECALLED AND OWNERS COMPENSATED. *TR

WE HAVE 2004 MAZDA MPV WHICH WE BOUGHT NEW. WHILE IT WAS STILL UNDER WARRANTY, WE HAD TO HAVE COILS REPLACED. WE THOUGHT IT WAS ODD THAT WE WOULD BE HAVING TO REPLACE COILS ON SUCH A NEW VEHICLE. AFTER INVESTIGATION, WE FOUND THAT THIS IS A COMMON OCCURRENCE WITH THE YEAR MPV WE HAVE. APPARENTLY THERE IS A DESIGN FLAW WHICH ALLOWS MOISTURE TO GET TO THE COILS, CAUSING THEM TO SHORT OUT. WE MENTIONED THIS TO FITZGERALD MAZDA IN ANNAPOLIS, MD WHERE WE WERE HAVING IT SERVICED. THEY ADMITTED THIS WAS A PROBLEM BUT BASICALLY THOUGHT WE SHOULD BE HAPPY THAT IT WAS STILL UNDER WARRANTY..EVEN THOUGH IT WAS PROBABLY GOING TO BE AN ONGOING PROBLEM LONG AFTER THE WARRANTY RAN OUT. SINCE THE WARRANTY RAN OUT, WE HAVE HAD TO HAVE COILS REPLACED 2 MORE TIMES AT OUR OWN EXPENSE AND ARE WAITING TO HAVE YET ANOTHER COIL REPLACED AS I AM WRITING THIS COMPLAINT. EACH TIME WE HAVE TO HAVE A COILED REPLACED, IT IS VERY COSTLY DUE TO THE FACT THAT THE DESIGN OF THE VEHICLE MAKES THEM VERY DIFFICULT TO GET TO. ONCE WE HAD TO HAVE IT DONE WHILE WE WERE TRAVELING ON VACATION IN FLORIDA..THIS WAS DONE AT THE MAZDA DEALERSHIP IN GAINESVILLE, FLORIDA. THEN ANOTHER TIME WE HAD A COIL REPLACED BY A MECHANIC IN OWINGS, MARYLAND. THAT MECHANIC DID EXTENSIVE RESEARCH FOR US AND CAME TO THE SAME CONCLUSION..THIS IS A PROBLEM WITH MOISTURE GETTING TO THE COILS AND WILL HAPPEN AGAIN AND AGAIN THROUGHOUT THE LIFE OF THE VEHICLE. WE ARE NOW DELAYING ANOTHER VACATION..PAYING OUT OF POCKET TO HAVE YET ANOTHER COIL REPLACED. WE WANT MAZDA TO STAND MY THEIR PRODUCT. THERE SHOULD BE A RECALL AND THEY SHOULD BE REQUIRED TO CORRECT THE PROBLEM AT THEIR EXPENSE. WE HAVE SPENT CLOSE TO $2,000.00 NOW. THE WORST PART IS, IT IS ONLY A MATTER OF TIME BEFORE ANOTHER COIL GOES OUT. PLEASE HELP! *TR

TL*THE CONTACT OWNS A 2004 MAZDA MPV. WHILE DRIVING AT SPEEDS OF 30 MPH, THE VEHICLE BEGAN HESITATING AS IF IT WERE ATTEMPTING TO STALL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY REPLACED THE ELECTRICAL COIL TO THE CYLINDER. THE REPAIRS WERE PERFORMED UNDER FACTORY WARRANTY. THE FAILURE RECURRED WITHIN A YEAR AND THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC PLACED INSULATING MATERIALS AROUND THE COIL TO PREVENT MOISTURE FROM ENTERING THE COIL. THE MECHANIC ADVISED WHEN MOISTURE WOULD ENTER THE ELECTRICAL COILS; IT WOULD CAUSE A SHORTAGE CONTRIBUTING TO THE FAILURE. IN ADDITION, WHEN THE ENGINE WAS SHUT OFF, THE COOLING FAN WOULD CONTINUE OPERATING. THE FAILURE PERSISTED. THERE WERE NO RECALLS FOR THE FAILURE. THE FAILURE MILEAGE WAS 23,000 AND THE CURRENT MILEAGE WAS 100,000.

CAR IS RUNNING FINE, AND THEN ENGINE STOPS. AFTER SETTING FOR A MINUTE OR SO, ENGINE WILL START AGAIN AND RUN FINE FOR DAYS ...THEN THE ABOVE RECURS. REPLACED IDLE CONTROL VALVE...NO MORE TROUBLE. *TR

2004 MAZDA MPV ENGINE COMPLETELY AND SUDDENLY DIES WHEN DRIVING - USUALLY WHEN PRESSING THE ACCELERATOR PEDAL AS THE ENGINE IS DECELERATING. DROVE CAR TO SHOULDER, PLACED IN NEUTRAL TO RESTART. APPEARS TO BE THE IDLE CONTROL VALVE (MADZA FORUM SITES REPORT NUMEROUS SIMILAR EVENTS). *TR

LIKE MANY OTHER MAZDA MPV OWNERS, I'VE EXPERIENCED PROBLEMS WITH THE VEHICLE'S IGNITION COILS. IN AUGUST 2008, THE VEHICLE WAS RIDING VERY ROUGH AND HESITATING ON THE HIGHWAY. THE DIAGNOSTICS FOR THE CHECK ENGINE LIGHT SHOWED THAT ONE OF THE IGNITION COILS HAD MISFIRED. I HAD THE COIL REPLACED AND, AT THE RECOMMENDATION OF THE DEALERSHIP, REPLACED THE SPARK PLUGS. AT THAT TIME, MY VEHICLE WITH APPROXIMATELY 35,000 MILES ON IT, WAS OUT OF WARRANTY. I PAID $476 FOR THE REPAIR BUT WAS ULTIMATELY REIMBURSED BY MAZDA ON A CUSTOMER GOODWILL BASIS. ONE YEAR LATER, IN AUGUST 2009, THE VEHICLE AGAIN BEGAN RIDING ROUGH AND HESITATING. WHEN THE CHECK ENGINE LIGHT CAME ON, I BROUGHT THE VEHICLE TO THE DEALERSHIP. BASED ON THE EARLIER EXPERIENCE, I SUSPECTED AN IGNITION COIL AS THE CULPRIT. MY SUSPICIONS WERE REALIZED. THE DEALERSHIP FOUND THAT CYLINDER #5 HAD MISFIRED AND THAT SEVERAL OTHER COILS WERE WEAK. THE DEALER INDICATED THAT THE OTHER COILS WERE LIKELY TO GO AND RECOMMENDED THAT ALL OF THEM BE REPLACED. I HAD THE WORK DONE AT A COST OF $960. THE VEHICLE AT THIS POINT HAD ONLY 46,000 MILES ON IT. BOTH REPAIRING DEALERSHIPS MENTIONED THAT THIS IS A COMMON PROBLEM WITH MPVS. FROM MY RESEARCH, I CAN SEE THAT IS A SIGNIFICANT PROBLEM FOR 2002-2006 MPV'S. ENTIRE MESSAGE BOARDS ARE DEDICATED TO THIS MAZDA MPV IGNITION COIL DEFECT. MOST BELIEVE THAT THERE'S A DESIGN FLAW THAT PREVENTS THE COILS FROM DISPERSING MOISTURE PROPERLY, WHICH OVER TIME LEADS THE CYLINDERS TO MISFIRE. IT SEEMS TO ME THAT MAZDA SHOULD HAVE VOLUNTARILY RECALLED THE VEHICLE DUE TO THIS ISSUE. HAVING PREVIOUSLY MADE A CUSTOMER ACCOMMODATION ON THE EARLIER REPAIR, MAZDA HAS REFUSED TO REIMBURSE ME FOR THE COSTS OF THIS LATEST REPAIR. IT'S UNFORTUNATE THAT MAZDA HAS CHOSEN TO DEAL WITH THE PROBLEM ON A CUSTOMER-BY-CUSTOMER BASIS, RATHER THAN HAVING VOLUNTARILY RECALLED THE VEHICLE IN ORDER TO ADDRESS THIS VERY COMMON PROBLEM. *TR

2004 MAZDA MPV ENGINE FAILURE DUE TO ENGINE COILS, ONE WENT OUT IN MAY DRIVING IN THE RAIN ON THE HIGHWAY AND ANOTHER WENT OUT TWO MONTHS LATER ALSO IN THE RAIN ON THE HIGHWAY. DEALER SAID IT IS COMMON. WELL THEN THERE NEEDS TO BE A RECALL. THE VEHICLE ONLY HAS ABOUT 50K MILES ON IT. *TR

TOTAL TRANSMISSION FAILURE. *TR

MAZDA MPV 2004 VEHICLE'S ENGINE HESITATED WHEN DRIVING IN RAIN AT ANY SPEED. THIS BEGAN HAPPENING BEFORE MILEAGE AND DATE LISTED BELOW. THIS IS A SAFETY HAZARD WHEN PARTICULARLY WHEN IT OCCURRED WHILE DRIVING ON THE WASHINGTON METRO BELTWAY. AN ASSISTANT SERVICE MANAGER AT, ROSENTHAL MAZDA ARLINGTON, 750 N. GLEBE ROAD, ARLINGTON, VA. ( 703/527-3000) ADVISED THAT THIS PROBLEM WAS KNOWN TO MAZDA FOR THE PAST FIVE YEARS AND REQUIRED AIR INDUCTION SERVICE EVERY 12,000-15,000 MILES. WE NEVER WERE WARNED OF THIS PROBLEM OR THE NEED FOR THE SPECIFIC PREVENTABLE MAINTENANCE BY EITHER THE COMPANY OR ROSENTHAL MAZDA. THE REPAIR COST $2000 AND COULD HAVE BEEN AVOIDED IF MAZDA HAD ADVISED OWNERS OF THE NEED FOR PREVENTABLE MAINTENANCE (AIR INTAKE MANIFOLD). I REPEAT THAT THIS IS A SAFETY ISSUE, CAUSING THE DRIVER TO BE DISTRACTED AND THE CAR TO ACCELERATE POORLY, PARTICULARLY WHEN THE ENGINE IS HESITATING WHILE DRIVING AT HIGH SPEEDS IN CONGESTED TRAFFIC. PLEASE CONTACT MAZDA AND INVESTIGATE AND REQUIRE THEM TO SEND WARNINGS AND REIMBURSE THOSE WHO SUFFERED MONETARY DAMAGE AS A RESULT OF THEIR LACK OF WARNING. *TR

THE ENGINE LIGHT TURNED ON THREE TIMES SINCE I BOUGHT THIS CAR. ALSO WHEN I SEARCHED INTERNET I FOUND A LOT OF USERS REPORTED SIMILAR ISSUE. *TR

2004 MAZDA MPV WITH 63K MILES. HAS BROKEN DOWN 5 TIMES WITH SAME PROBLEM AFFECTING ONE OF TWO DIFFERENT COILS. ENGINE LIGHT COMES ON. VAN HESITATES/SHAKES. NO LOSS OF LIFE, BUT PLENTY OF LOST WAGES ETC AND MAZDA REP NOT COOPERATIVE. $400 AND AVERAGE 3 DAYS IN SHOP EACH TIME TO REPAIR. MECHANIC GUESSED PROBLEM BEFORE I EVEN TOLD HIM. STATES THAT THEY SEE THIS ALL THE TIME WITH THE MPV'S. *TR

REAR LIFTGATE DOOR GAS STRUT MOUNTING STUD SNAPPED OFF, THERE IS A RECALL IN CANADA FOR THIS ISSUE FOR MODEL YEARS 2000-2004. WHEN I CONTACTED MAZDA ABOUT THIS ISSUE, THEY WOULD NOT HONOR THE CANADIAN RECALL EVEN THOUGH THE ISSUE IS EXACTLY AS DESCRIBED AND IS FROM 2005 HTTP://WWW.MPVCLUB.COM/RECALLS.PHP?ID=19&PRINT=1 *TR

FRONT WINDSHIELD WIPER ARMS BROKE OFF DURING USE ON HIGHWAY AND HEAVY RAINS. UPON LATER INSPECTION, THE CAST METAL PART OF BOTH ARMS WERE CRACKED NEAR THE HINGE POINT. THE DRIVERS SIDE ARM BROKE OFF AND WAS CAUGHT IN THE PASSENGER SIDE WIPER BLADE FOR A FEW SECONDS CAUSING IT TO SMACK AGAINST THE WINDSHIELD AND CRACKING IT. MAZDA REFUSED TO OFFER ANY ASSISTANCE IN DETERMINING IF THE PARTS WERE DEFECTIVE OR IN OBTAINING REPLACEMENT PARTS. REPLACEMENTS WERE PURCHASED FROM THE ORIGINAL DEALER. *TR

TL*THE CONTACT OWNS A 2004 MAZDA MPV. WHENEVER THE AIR CONDITIONER IS ACTIVATED, THE FAN THAT BLOWS THE AIR IS VERY LOUD AND CONTINUES TO RUN 3-5 MINUTES AFTER THE VEHICLE IS TURNED OFF. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY STATED THAT THE FAN MODULE NEEDED TO BE REPLACED. THE CONTACT DID NOT NOTICE ANY DIFFERENCES PRIOR TO THE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 79,600.

MAZDA 2004 MPV WITH JUST UNDER 68,000 MILES HAS 3 FUEL INJECTORS(CEL) REPLACED BY LOCAL MECHANIC- 2 WEEKS LATER JERKY MISFIRES WITH CEL REQUIRED #5 COIL REPLACED BY DEALERSHIP, LESS THAN A MONTH LATER #4 COIL REPLACED BY LOCAL MECHANIC IN TOWN WE WERE VACATIONING IN-NO CEL, NOW SAME JERKY MISFIRES STARTING AGAIN A MONTH AFTER LAST REPLACEMENT. RECENT FORUM ENTRIES SEEM TO INDICATE A GROWING PROBLEM OF THIS TYPE FOR 2004 MPV. EXCEPT FOR TOWING CHARGES, EXPENSIVE REPAIRS, AND INCONVENIENCE- NO INJURIES. *TR

2004 MAZDA MPV WITH TRANSMISSION PROBLEMS. CONSUMER STATES THAT THE VEHICLE HAS A TRANSMISSION SHIFT SHOCK PROBLEM AND THE WARRANTY IS GETTING READY TO EXPIRE. WHEN ACCELERATING VEHICLE AND PASSENGER GET JOLTED FORWARD. *KB THE CONSUMER STATED THE LAST TIME THE PROBLEM HAPPENED, THE TRANSMISSION LIGHT ILLUMINATED.*JB

THE MINI VAN CAUGHT ON FIRE. *TR

BOUGHT THE 2004 MAZDA MPV ES IN 2005. CURRENTLY IT HAS ABOUT 64,000 KM (40K MILES). PROBLEM: RECENTLY 4 IGNITION COILS MALFUNCTIONED ..HAD 3 REPLACED RIGHT AFTER WARRANTY HAD EXPIRED. APPARENTLY, THIS IS NOT AN UNCOMMON PROBLEM FOR THIS 2004 MODEL. WATCH OUT! *TR

TL*THE CONTACT OWNS A 2004 MAZDA MPV. EVERY TIME IT RAINS, THE ENGINE MISSES AND THE CHECK ENGINE LIGHT ILLUMINATES. THE CONTACT TOOK THE VEHICLE TO THE MECHANIC AND WAS INFORMED THAT MOISTURE ENTERS THE ENGINE AND FOULS THE CYLINDER WHEN IT RAINS. THE FAILURE CAUSES THE VEHICLE TO RUN ROUGHLY AND TRAVEL ONLY AT LOW SPEEDS. THE VEHICLE HAS NOT BEEN TAKEN TO THE MAZDA DEALER, BUT THE MANUFACTURER STATED THAT THERE WAS NO RECALL. THE CURRENT AND FAILURE MILEAGES WERE 80,000.

LATELY WHILE DRIVING MY CAR WILL SUDDENLY JUMP FORWARD. IT SEEMS TO HAPPEN MORE SO WHEN GOING FROM 2ND TO 3RD GEAR. ALSO, THE ENGINE IS BECOMING MORE HOT, EVEN AFTER ONLY RUNNING FOR A FEW MINUTES AND A STRANGE SMELL IS EMITTING FROM THE ENGINE. I HAVE TAKEN IT TO THE DEALERSHIP HERE AND THEY HAVE SAID NOTHING ABOUT THE SITUATIONS. THEY CLAIM, I AM PUSHING TOO HARD ON THE GAS, WHICH I DON'T DO. THEY ALSO SAY TO MAKE SURE I HAVE ENOUGH COOLANT IN THE ENGINE WHICH I ALWAYS DO. I AM AFRAID THE ENGINE WILL CATCH FIRE OR SOMETHING WITH THE WAY IT IS RUNNING. UNFORTUNATELY, IT IS MY MAIN CAR TO GET AROUND WITH FOR THE CHILDREN. THE CAR IS ONLY 3 YEARS OLD. I AM TIRED OF TAKING IT TO THE DEALERSHIP AND NOT GETTING AN ANSWER. *TR

I OWN A 2004 MAZD MPV VAN. WHEN THE TRANSMISSION LEVER IS MOVED TO D FOR DRIVE, THE THE AIR CONDITIONIN (A/C ) ON/OFF SWICTH IS HIDDEN BEHIND THE LEVER NO MATTER HOW WHAT THE DRIVER SEAT SETTINGS MAY BE. I HAVE CONTACTED MAZDA, BUT THEY HAVE FAILED TO PROVIDE ANY REMEDY FOR THIS PROBLEM. I STRONGLY BELIEVE THAT THIS IS A DRIVING HAZARD AS I HAVE HAD A FEW CLOSE CALLS TRYING TO TURN THE A/C ON OR OFF WHILE DRIVING. *AK

WE WERE BROADSIDED BY A VEHICLE THAT RAN A RED LIGHT AT FULL SPEED. THE IMPACT WAS ON THE PASSENGER SIDE. THE CAR FLIPPED OVER AND SKIDDED ONTHE PASSENGER SIDE THEN FLIPPED BACK ONTO THE DRIVERS SIDE AND SKIDDED BEFORE ROLLING OVER AT LEAST ONCE. NOT ONE AIR BAG DEPLOYED. THANK GOD FOR THE SEAT BELTS. THEY SAVED OUR LIVES. INJURIES WERE CONCUSSIONS, SPRAINED NECK, INJURIES TO LOWER NECK, BACK AND SHOULDER OF PASSENGER. WE LANDED UPSIDE DOWN, RELEASED OUR SEAT BELTS AND CRAWLED TO SAFETY WITH THE HELP OF POLICE AND FIRE. OUR SPEED WAS ABOUT 25-30 MILES /HOUR. OUR CAR WAS TOTALLED. THE OTHER DRIVER WAS CITED IN THE ACCIDENT.

TL*THE CONTACT OWNS A 2004 MAZDA MPV. WHILE DRIVING 65 MPH ON THE INTERSTATE THE VEHICLE AUTOMATICALLY SHUT OFF ON FOUR OCCASIONS. THE CONTACT RESTARTED THE VEHICLE AFTER EACH FAILURE AND BROUGHT THE VEHICLE TO TWO DIFFERENT MAZDA DEALERS. NEITHER DEALER COULD DIAGNOSE THE CAUSE OF THE FAILURE. THE CONTACT STATED THAT THE FAILURE WAS RANDOM AND OCCURRED EVERY 1,000 MILES. THE CURRENT MILEAGE IS 60,700 AND FAILURE MILEAGE WAS 57,500.*AK

I PURCHASED A 2004 MPV ARCH 28, 2005. TO DATE, I HAVE HAD THIS VAN IN FOR WARRANTY SERVICE TO REPLACE IGNITION COILS THREE TIMES: 10/31/06 '' 31,770MI - #4 COIL REPLACED. TRANSMISSION RANGE SENSOR REPLACED ALSO 12/05/06 '' 33,229MI - #4 COIL REPLACED AGAIN 1/08/07 '' 34,708MI - #6 COIL REPLACED. TODAY AS I WAS DRIVING, THE SAME SYMPTOMS '' STEERING WHEEL VIBRATION, BUCKING, LURCHING '' OCCURRED AS BEFORE WHEN THE OTHER COILS FAILED. THE CEL CAME ON, I CHECKED FOR THE CODE AND I DISCOVERED THAT THE #5 COIL HAS FAILED. NOW THIS WILL BE THE FOURTH SERVICE FOR THE SAME PROBLEM. THERE HAS BEEN NO EFFORT ON THE PART OF COUNTRY MAZDA TO FIND THE SOURCE OF THE COIL FAILURE. REPLACING THE PARTS OBVIOUSLY IS NOT SOLVING THE PROBLEM. *AK

PROLONG OFF AND ON TICKING SOUND IN THE ENGINE , FINALLY THOUGHT IT WAS A BELT TOOK IT TO A SHOP TO HAVE BELTS CHANGED OR CHECKED , MECHANIC SAID IT IS NOT YOUR BELTS IT IS YOUR ENGINE, SO WE HAD TO HAVE IT TOWED AT OUR EXPENSE TO THE DEALER WE BOUGHT IT FROM TO HAVE ENGINE CHECKED OR REPLACED , AND NOW MAZDA WON'T WARRANTY IT !!! THE MECHANIC FROM WHERE WE BOUGHT IT FROM ,GOT KIND OF NASTY AND TOLD US TO GET OUR DAM CAR OUT OF HIS F-ING SHOP , WE WERE UPSET BECAUSE MAZDA WON'T REPLACE ENGINE , NOW I AM STUCK WITH A 15,000 DOLLAR CAR NO ENGINE !!!! JUST TURNED 51,000, AND I BELIEVE THAT IS NOT RIGHT EITHER , I LEFT THE LIGHTS ON BY ACCIDENT ONE DAY FOR 30 MINUTES MAX AND MY BATTERY DIED , WHEN WE BOUGHT NEW BATTERY I THINK MILEAGE JUMPED 10,000 , MILES BECAUSE A MONTH BEFORE WE TRIED TO TRADE CAR FOR A BIGGER VEHICLE( I HAVE 6 PEOPLE IN FAMILY- GROWING OUT OF THIS ONE )IN AND IT ONLY HAD 39,000 MILES ON IT ANOTHER DEALER CAN VERIFY IT BECAUSE WE GOING TO USE THE MAZDA FOR A TRADE IN, AFTER THE BATTERY WENT DEAD , ALL THE SUDDEN I HAD 51,000 MILES .... GO FIGURE THAT ONE OUT IN 30 DAYS ....*JB

ON MY MAZDA MPV IN TEMPERATURES BELOW 40 DEGREES THE TRANSMISSION SLIPS WHEN SHIFTING INTO 3RD GEAR. THIS CAUSES LOSS OF POWER AND A WHIPLASH ACTION WHEN THE TRANSMISSION RE-ENGAGES. IN HIGH TRAFFIC SITUATIONS THIS CAN BE VERY DANGEROUS. *NM

2004 MAZDA MPV - TRANSMISSION ISSUES AND ENGINE COIL FAILURES. TRANSMISSION HAS SHIFT SHOCK, WHERE THE VEHICLE SLAMS INTO THE NEXT GEAR AT 20 MPH. THE SHOCK SENDS THE VEHICLE DANGEROUSLY FORWARD. MAZDA HAD TWO SERVICE BULLETINS FOR THIS DEFECT WHICH INCLUDED REPLACING SENSORS AND SWITCHES. MAZDA ALSO SUPPLIED A DIAGRAM TO INSTRUCT DRIVERS TO "WIGGLE" THE GEAR SELECTOR BETWEEN GEARS. NONE OF THIS SOLVED THE PROBLEMS. ENGINE COILS WERE REPLACED THREE TIMES AT 24,000 MILES, 32,000 MILES, AND 35,000 MILES. THIS CAUSED THE VEHICLE TO STOP RUNNING CORRECTLY WHILE DRIVING. *NM

DT*: THE CONTACT STATED WHILE DEPRESSING THE ACCELERATOR PEDAL, THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, WHERE IT WAS DETERMINED THE BLADDER SEPARATED IN THE FUEL TANK AND WAS GETTING INTO THE FUEL PUMP. THE GAS TANK NEEDED TO BE REPLACED.

CAR STALLS AT LIGHTS DOES NOT RESPOND WHEN ACCELERATING HAVE GONE TO BACK UP AND NO RESPONSE THEN CAR WILL JUST TAKE OFF HAVE HAD 2 ACCIDENTS DUE TO NO ACCELERATION FOG AND BUGS IN TAILLIGHTS AIRBAG LIGHT ON/OFF FOR NO REASON CAR HAS BEEN TO DEALERSHIP FOR ALL RECALLS I AM TOLD I AM NOT DRIVING THE CAR FAST ENOUGH AND AM TOLD I NEED TO CHECK MY OIL WHEN I GET GAS. TOO MANY PROBLEMS TO LIST DEALER WILL FIX BUT CANNOT DUPLICATE SOME OF THE PROBLEMS I EXPERIENCE HAVE TRIED TO CONTACT MANUFACTURER ONLY TO BE PUT ON HOLD TO LISTEN TO ZOOM ZOOM MUSIC OVER AND OVER. *JB

2004 MAZDA MPV. ENGINE WENT OUT WITHOUT WARNING WHILE CRUISING AT 65 MPH ON THE HIGHWAY. CHECK ENGINE LIGHT ON. THE CAR HAD ONLY 3000 MILES ON IT AT THAT TIME. GOT TOWED BY MAZDA ROADSIDE ASSISTANCE TO THE CLOSEST DEALER, WHO HAD NO TIME TO WORK ON IT FOR MORE THAN A WEEK (!). THEREFORE THE CAR WAS TOWED AT MAZDA'S EXPENSE TO THE DEALERSHIP I HAD BOUGHT IT FROM. THERE THEY DID NOT FIND ANYTHING WRONG WITH IT AND THEREFORE CONCLUDED THAT THE ECU MUST BE FAULTY. A NEW ECU WAS INSTALLED AND THE PROBLEM HAS SO FAR NOT RECURRED. THE CAR NOW HAS ABOUT 14000 MILES ON IT. *JB

PERSISTENT TICKING SOUND FROM ENGINE, WHICH HAS BECOME LOUDER WITH PASSING OF TIME. TSB RE TICKING SOUND HAS BEEN PERFORMED BY SHOWCASE MAZDA, AND ON FOLLOW-UP VISIT THEY ADVISED SITUATION IS NORMAL, THE TICKING SOUND NOTWITHSTANDING. A RESPECTED INDEPENDENT AUTO REPAIR SERVICE, COMBS AUTOMOTIVE, ADVISED THE ENGINE ABSOLUTELY SHOULD NOT BE MAKING THE TICKING SOUND WITH ONLY 30K MILES ON IT. PLEASE NOTE THAT BELOW I SHOW INCIDENT DATE AS THIS MONTH, BUT IT HAS BECOME MORE PRONOUNCE OVER PAST FEW WEEKS. *JB

BUCKING AND LOSS OF POWER, NOISE COMING FROM AREA NEAR FUEL PUMP UNTIL PART FAILED COMPLETELY AND CAR WOULD NOT START, OR IT WAS TAKEN IN FOR REPAIR BEFORE COMPLETE FAILURE TO BE REPLACED. FOUR FUEL PUMPS HAVE BEEN REPLACED IN 10 MONTHS OF OWNERSHIP OF NEW CAR. *NM

OVER THE PAST 3 MONTHS, PASSENGER-SIDE POWER SLIDING DOOR ON A 2004 MPV, INTERMITTENTLY WOULD: 1) NOT CLOSE. DOOR WILL ATTEMPT TO CLOSE, BUT BOUNCES OPEN AT THE END. DOOR POWER HAS TO BE TURNED OFF AT THE DRIVERS CONTROL, SO THAT THE DOOR CAN BE MANUALLY CLOSED. 2) DOOR WOULD NOT OPEN. SEVERAL OCCASION, THE DOOR WOULD APPEAR TO BE STUCK AND CANNOT BE OPEN WITH ANY OF THE CONTROLS AND NOT MANUALLY EITHER. DOOR BUTTON WILL "BEEP" BUT DOOR WOULD NOT OPEN. DOOR USUALLY "RECOVERS" AFTER DRIVING THE VEHICLE FOR A SHORT TRIP. 3) DOOR WILL MAKE MOTOR WHINNING SOUND...LIKE IT'S TRYING TO OPEN WHILE VEHICLE IS IN MOTION, AND ONCE IT DID OPEN ON ITS OWN WHILE VEHICLE WAS TRAVELING AT LOW SPEED. REPORTED TO MAZDA OF ROSWELL DEALER, THEY COULD NOT REPRODUCE PROBLEM AND CANNOT OFFER MUCH HELP. *NM

2004 MAZDA MPV - NORTH PARK MAZDA IS SAN ANTONIO HAS BEEN UNABLE TO FIX A NOISE COMING FROM THE FRONT OF THE VEHICLE. I TOOK THE VAN IN 5 TIMES IN JULY. THEY WERE UNABLE TO DUPLICATE THE NOISE ON THE FIRST FEW ATTEMPTS. I FINALLY HAD TO TAKE THE SERVICE MANAGER FOR A RIDE IN IT. THEY THOUGHT THEY HAD FIXED IT THE LAST 2 TIMES I TOOK IT IN BUT APPARENTLY DID NOT ACTUALLY LOCATE THE PROBLEM. I

2004 MAZDA 3 PASSENGER SEAT BELT MALFUCTION. MY MAZDA 3 SEAT BELT LOCKING MECHANISM FAIL TO RELEASE.

DT: THE ENGINE JUST TURNED OFF. THE VEHICLE CUT OFF TWICE WHEN TRYING TO GO UP HILL AT 20 MPH. THIS HAPPENED ON JULY 20TH, 2005. THE EVOLUTION WAS ROUGHLY AT 10,000 FEET. THE VEHICLE IS CURRENTLY AT THE DEALER. *AK *SC

AFTER DRIVING 45 MPH ON BLUE RIDGE PARKWAY FOR AT LEAST 3 HOURS, I WAS EXITING ONTO A MAJOR HIGHWAY. WHEN I STEPPED ON THE GAS, I HAD A LOSS OF POWER THAT ALMOST CAUSED AN ACCIDENT. COULD NOT EASILY RECREATE THE PROBLEM, SO I DID NOT GO TO THE DEALER ABOUT IT. *NM

WATER GETS IN THE DOOR PANEL EVERY TIME IT RAINS OR WE WASH THE CAR. THREE DIFFERENT MAZDA DEALERS TRIED TO FIX THE PROBLEM FIVE TIMES, UNSUCCESSFULLY. I AM AFRAID TO DRIVE MY CHILDREN IN THE CAR. THE DOOR IS ELECTRIC AND IT COULD CAUSE A SERIOUS PROBLEM. ALSO MOLD COULD DEVELOP IN THERE. I HAVE CONTACTED THE MAZDA CORPORATION. THEY INSPECTED THE CAR. THE PROBLEM HAS BEEN IDENTIFIED BY MAZDA. THEY PROMISED TO RESOLVE THE PROBLEM, BUT ARE NOT DOING ANYTHING ABOUT IT. THEY IGNORE MY PHONE CALLS AND LETTERS. WHAT SHOULD I DO? THANKS. *JB

DT: THE CONSUMER STATED 2004 MAZDA RX 8 STALLED WHILE DRIVING AT SPEEDS OF 20-35 MPH. THERE WERE NO LIGHTS ON THE DASHBOARD BEFORE THIS HAPPENED. , BUT AFTERWARDS ALL THE LIGHTS CAME ON, AND THE VEHICLE DIED. THE CONSUMER REPORTED THIS TO THE DEALER ,AND THEY DID THE DIAGNOSTIC TEST, AND FOUND NOTHING BUT SUGGESTED THAT HE DO A TUNE UP ON THE CAR. THE CAR HAS HAD NO OTHER PROBLEMS AND HAS DRIVEN FINE BEFORE THIS INCIDENT. THE OWNER NOTICED BEFORE THIS HAPPENED THAT HE HAD DRIVEN ABOUT 100 MILES WHEN THE CAR STALLED. THIS WAS ON BOTH OCCASIONS. THE DEALER DID DO A COMPUTER UPDATE. *AK

SINCE FEBRUARY 2005 I HAVE HAD MY MAZDA RX8 SERVICED FOR ENGINE NOISES, DECELERATION PROBLEMS, STALLING PROBLEMS AND RESTART PROBLEMS. THE VEHICLE BEGINS TO IDLE ROUGH AND JUST STALLS OUT (TWICE IN THE MIDDLE OF BUSY INTERSECTIONS WITH ONCOMING TRAFFIC-LIFE THREATENING SITUATION) AND CANNOT BE RESTARTED. THE VEHICLE HAS TO BE TOWED IN TO THE DEALERSHIP FOR RESTART. THE PCM HAS BEEN REFLASHED SEVERAL TIMES, PLUGS HAVE BEEN CHANGED AND THE PROBLEM STILL PERSISTS. I AM AFRAID FOR MY LIFE AND WILL NOT LET ANYONE ELSE RIDE IN THE CAR WITH ME. THE SERVICE DEPARTMENT AT THE DEALERSHIP IS AWARE OF THE LIFE THREATENING SITUATION AND I WANT TO KNOW IF I HAVE ANY RECOURSE IN GETTING MAZDA TO BUY BACK A CAR I CANNOT DRIVE. MY LUCK WILL RUN OUT IN THIS VEHICLE AND NOT ONLY WILL I BE INJURED OR KILLED, BUT SO WILL OTHER DRIVERS (ONCOMING TRAFFIC OR TRAFFIC BEHIND ME). I HAVE CALLED MAZDA HEADQUARTERS TWICE ABOUT THIS RECURRING PROBLEM AND AM AWAITING A CALL BACK FROM THE SECOND PHONE CALL INTO MAZDA. APPARENTLY THEY DON'T FEEL IT IS AS BAD AS IT IS. *NM

DT: THIS MAZDA HAD A VIBRATION PROBLEM . RECENTLY, HAD A STALLING PROBLEM. THE DEALER TRIED TO GET CONSUMER TO TRADE I IN VEHICLE. AFTER STOPPING AT A STOP SIGN WOULD HAVE TO PUSH THE GAS PEDAL TO THE FLOOR TO GET IT TO MOVE. THE SERVICE MANAGER FOUND OUT THE WERE HAVING THE SAME PROBLEMS IN HIGH HEAT AREAS.. THIS STARTED HAPPENING ON JUNE 30, 2005.*AK

WHILE PULLING INTO MY DRIVEWAY, I WAS BRAKING TO PARK WHILE THE AUTOMATIC TRANSMISSION WAS STILL IN DRIVE. SUDDENLY, THE ENGINE STARTED TO REV ON ITS OWN, WHILE MY FOOT WAS ON THE BRAKE. THE TACHOMETER STARTED READING IN THE DANGER ZONE, AND THE ENGINE WAS REVVING OUT OF CONTROL. WHITE SMOKE STARTED TO COME OUT FROM UNDER THE HOOD. I WAS ABLE TO PUT THE CAR INTO PARK AND TURN OFF THE ENGINE. IT WAS QUITE A FRIGHTENING EXPERIENCE.

DURING ACCELLERATION LOSES POWER, HESITATES, FEELS LIKE ITS GOING TO STALL AND SMOKE COMES OUT OF EXHAUST. DEALER HAS REPLACED FUEL PUMP, PROBLEM GOT BETTER FOR A SHORT PERIOD BUT HAS BEGUN TO REOCCUR. NO CHECK ENGINE LIGHT SO THEY SAY THERE IS NOTHING THEY CAN DO FOR ME. TWO FAILED REPAIR ATTEMPTS - COUNTING UP TO LEMON LAW!

2 OCCURANCES IN 3000 MILES OF ENGINE LOOSING POWER, THEN STARTS TO BUCK ABOVE 3500-4000 RPM. THIS FIRST HAPPENED ON THE FREEWAY AND IT WAS DIFFICULT STAYING OUT OF THE WAY OF TRAFFIC UNTIL I COULD EXIT. THE SECOND OCCURANCE WAS AFTER I HAD EXITED THE FREEWAY ONTO A 2 LANE. I THEN DROVE 30 MILES TO HOME. BOTH TIMES IT WAS OK THE NEXT MORNING. DEALER CANNOT REPLICATE THE PROBLEM. SEVERAL OWNERS OF THIS MODEL CAR (2004 MAZDASPEED MIATA )HAVE HAD THIS PROBLEM AS REPORTED ON WWW.MAZDA-SPEED.COM FORUM.

I JUST HAD MY TIRES CHECKED AT 10,000 MILES DURING AN OIL CHANGE AT MY DEALERSHIP. NO PROBLEM WAS FOUND. I NOW HAVE 11,000 MILES ON MY CAR AND TIRES. MY TIRES ARE MICHELIN RADIAL XSE P215/50 R17. I WAS ON MY WAY TO WORK AND WITHOUT WARNING MY DRIVERS SIDE BACK TIRES BLEW OUT. IT SEPARATED FROM THE TIRE AND THE CORDS WERE SHOWING. I AM CONVINCED THAT THIS IS THE FAULT OF THE MICHELIN TIRE BECAUSE OF THE TREAD WEAR AND THE MILES ON IT. I DID NOT HIT ANYTHING IN THE ROAD NOR WAS THE TIRE PUNCTURED. WHEN THE TIRE BLEW I WAS ON WEST BOUND ON I-70 TO DOWNTOWN INDIANAPOLIS AND WITHOUT WARNING I SPUN AROUND SEVERAL TIMES IN THE MIDDLE OF I-70 AND GOT INTO AN ACCIDENT AND HAD TO BE TAKEN TO THE HOSPITAL VIA AMBULANCE FOR NECK AND BACK INJURIES. MY MAZDA 6 RECIEVED 6,000 DOLLARS IN DAMAGE THAT I KNOW OF SO FAR NOT TO MENTION THE PERSON THAT I CRASHED INTO. MY INSURANCE WILL NOT PAY FOR THE TIRE BECAUSE THAT WAS THE REASON FOR THE ACCIDENT. I THINK MICHELIN SHOULD PAY FOR 4 NEW TIRES OF A DIFFERENT BRAND, MY HOSPITAL VISIT, MY DEDUCTABLE AND MY RENTAL CARE EXPENSE AND MY LOST WAGES. ALSO MY TIRE PRESURE WAS CHECKED BY MY DEALER AGAIN THE WEEK OF JUNE 27,2005. I'M VERY LUCKY THAT I DIDN'T GET HURT WORSE OR SOMEONE GETTING HURT. I STILL DON'T KNOW THE EXTENT OF MY INJURIES BECAUSE I'M STILL HAVING A LOT OF PAIN SINCE THE ACCIDENT HAPPENED ON JULY 4, 2005. IS IT ANY WONDER THAT THE F1 DRIVERS DIDN'T WANT TO RACE AND FACE AN ACCIDENT OR WORSE YET DEATH?

SIRR OR MISS, I LIVE IN HOLLAND AND I HAVE AN QUESTION ABOUT AN MAZDA 3 1.6V EXECUTIVE SEDAN(EUROPEAN MODEL). AFTER THE FIRST OIL CHANGE THE ENGINE BEGINS TO MAKE A LOUD NOISE. IN THE THIRD GEAR IT BEGINS ABOUT 70 KM/H. ALLSO IN THE FOURTH GEAR THE SAME PROBLEM THAT BEGINS ABOUT 100KM/H. THE ENGINE IS A BIT SHAKING IN NEUTRAL (FREE) GEAR. WHEN I DRIVE ABOUT 80KM/H IN THE FOURHT SHIFT (THAN NORMAL NOISE) AND LET THE FEET OF THE GASPEDAL THAN THE SAME LOUD NOISE I HEAR. I HAVE DRIVE IN TWO OTHER MAZDAS WITHE THE EXACT SAME ENGINE WITH NO TROUBLE AT ALL!! THE GARAGE(DEALERS) CAN,T FIND ANYTHING. AND I THINK THAT MABY DE MAZDA IMPORTEUR WONT HELP US ANY FEARTHER. I AM COMPLAIN NOW EVRYWHERE ON MORE AND MORE WEBSITES OF ALL COUNTRYS IN EUROPE ,WHAT IS BAD FOR THE MAZDA COMPANY. PLEASE HELP ME FOR AN SOLUTION OPHUIS

DT: WHILE ON THE HIGHWAY, THE CONSUMER LOST CONTROL OF THE STEERING WHEEL. IT FELT LIKE THE STEERING WHEEL AND TIRES WERE NOT IN LINE, CAUSING THE VEHICLE TO SWERVE. THE SERVICE DEPARTMENT STATED THAT WAS THE WAY THE VEHICLE WAS DESIGNED. . IF THE ROAD WAS NOT EVEN THE STEERING WHEEL WILL DO THE SAME THING. CONSUMER STATED ON THE HIGHWAY WHEN GOING AT HIGH SPEED, THIS HAPPENED MORE OFTEN AND ON WINDY DAYS. WHEN MAKING A TURN, THE STEERING WHEEL DID NOT COME ALL THE WAY BACK. *AK

ENGINE STALLS--ON HOT DAYS--YOU'RE ON EXPRESSWAY YOU CAN FEEL POWER LOSS---THEN WHEN YOU GET OFF EXPRESSWAY OR HIT TRAFFIC JAM --THE CAR STALLS...SOMETIMES YOU CAN GET IT TO START..AND IDLE IS BAD BUT MAIN GOAL IS TO GET OUT OF THE WAY.....SOMETIMES IF ON THE SIDE OF ROAD YOU CAN SIT FOR AWHILE AND THEN START IT UP LIKE NOTHING HAPPENED???

HAS NO POWER, HESITATES BADLY, BUCKS ABOVE 3-4 RPM, HAS CAUSED ME TO ALL MOST CRASH AND OR GET HIT 2-3 TIMES. RETURNED TO DEALER NO "CODE" FOUND WAS TOLD THERE IS NOTHING WRONG. 10-20 PEOPLE ARE HAVING THE SAME ISSUE AS I AM (SEE INFORMATION HERE HTTP://MAZDA-SPEED.COM/FORUM2/INDEX.PHP?TOPIC=86.0 )

DT: WHILE DRIVING ON THE INTERSTATE ABOUT 65 MPH, THE VEHICLE JUMPED ABOUT 4 FEET INTO THE AIR AND FLIPPED OVER ABOUT 4 TIMES ACCORDING TO EYE WITNESSES. THE SIDE CURTAIN AIR BAGS DID NOT DEPLOY IN FACT NO AIR BAGS DEPLOYED. IT WAS NOT RAINING AND AS FAR AS THE CONSUMER COULD REMEMBER SHE DID NOT HIT ANYTHING. THERE WAS NO BLOW OUT OF THE TIRES. *JB

DT: THE CONSUMER OWNS A 2004 MAZDA 6I. WHEN THE CONSUMER SLOWED DOWN IN FIRST GEAR TO COME TO A STOP THE RPM STARTED TO REV UP ABOUT 2000 OR 3000 RPMS AND THE ENGINE STARTED TO REV UP ALSO. WHEN THE CONSUMER WAS AT A COMPLETE STOP THE ENGINE CONTINUED TO REV. THIS HAS HAPPENED TWICE IN THE SAME DAY. THE CAR HAS NOT BEEN DRIVEN VERY MUCH SINCE. THE CONSUMER WILL BE TAKING THE VEHICLE TO A DEALER NEXT WEEK. THERE WAS NO MODIFICATIONS ON THE ENGINE EVERYTHING WAS ORIGINAL EQUIPMENT. *JB

PASSENGER SLIDING VAN DOOR;WHEN IT RAINS, ALLOWS WATER TO ENTER TRACK SPACE OF VEHICLE; OVER TIME MAY CAUSE RUST;ALREADY TOOK MPV IN ONCE, MAZDA DID NOT FIX CORRECTLY, MADE THE LEAK WORSE AND NOW THE WINDOW HAS PROBLEMS ROLLING UP AND DOWN; TAKING VEHICLE IN AGAIN TO MAZDA FOR A 2ND TIME???

CLUTCH SHUDDERS VIOLENTLY WHEN ATTEMPTING TO ENGAGE. IS VERY PRONOUNCED ON HILLS, INCLINES, AND WHEN ATTEMPTING TO ENGAGE CLUTCH IN AN EMERGENCY SITUATION, IE, NEED ACCELERATION TO PASS, MERGED INTO TRAFFIC ETC. AS A RESULT, THE CLUTCH WILL FAIL TO ENGAGE PROPERLY AND LEAVE THE DRIVER AND PASSENGERS IN VULNERABLE POSITION OF NOT BEING ABLE TO MOVE WHEN EXPECTING TO. IN ADDITION, THE CAR WILL ROLL BACK WHILE ON HILLS AND GET DANGEROUSLY CLOSE TO VEHICLES BEHIND IT SINCE THE CLUTCH EITHER ENGAGES RESISTANTLY OR NOT AT ALL. *AK

1.WHEN ADJUSTED DRIVER'S POWER SEAT CONTINUES TO MOVE FORWARD EVEN AFTER ADJUSTMENT SWITCH IS RELEASED, RESULTING IN A POTENTIALLY DANGEROUS UNINTENDED AND UNCONTROLLABLE DRIVING POSITION FOR THE DRIVER.*AK 2.WHILE IN THE 'NEUTRAL' POSITION, THE AUTOMATIC TRANSMISSION SHIFT LEVER IS TOO EASILY MOVED UINTENTIONALLY INTO THE REVERSE POSITION RESULTING IN THE VEHICLE ABRUPTLY AND DANGEROUSLY REVERSING ITS POSITION AND MOVING REARWARD UNINTENTIONALLY AND WITHOUT WARNING. THE GEAR SELECTOR 'GATE DESIGN' IS FAULTY.

ON DECEMBER 20, 2004, I TRIED TO CRANK MY NEW 2004 RX-8 TO GO TO WORK. IT WAS 19 DEGREES OUTSIDE. THE CAR WOULD NOT CRANK. IT HAD BEEN SITTING FOR 2 DAYS OVER THE WEEKEND. UNFORTUNATELY, I TOOK IT OUT OF GEAR AND DID NOT PLACE IT BACK IN. WHEN I GOT OUT OF THE CAR AND WENT INSIDE, IT ROLLED, HITTING A TREE CAUSING $3800 DOLLARS WORTH OF DAMAGE. THE TREE WAS HIT VERY HARD AND THE AIRBAG DID NOT DEPLOY. APPARENTLY, THIS CAR "SUPPOSEDLY" WAS RECALLED AND FIXED WHILE STILL OWED BY THE MAZDA DEALERSHIP ACCORDING TO THEIR RECORDS. HOWEVER, AFTER HAVING IT TOWED INTO THE SERVICE DEPARTMENT, IT HAD NOT BEEN FIXED. I WAS NEVER TOLD OF ANY OF THESE PROBLEMS OR RECALLS PRIOR TO THE PURCHASE OF THE CAR. *AK

A MONTH AFTER I PURCHASED MY 2004 MAZDA RX8, I WENT TO START THE VEHICLE ONE MORNING AND IT WOULDN'T START. HAD THE VEHICLE TOWED TO SERVICE AND THEY ADVISED THEY DIDN'T REALLY KNOW WHAT WAS WRONG WITH THE VEHICLE. SERVICE DID A BATTERY INSPECTION, CHARGING AND TESTING; A DIAGNOSIS ON THE SPARK PLUG SET AND DRIVE CYCLE; AND CLEANED THE PLUG THREADS. JUST THIS MONTH, I PULLED TO A STOP LIGHT AND THE VEHICLE STARTED SHAKING THEN DIED. HAD IT TOWED TO SERVICE. SERVICE SAID VEHICLE NEEDED NEW COMPUTER PROGRAM INSTALLED FROM MAZDA. HAVE HAD THIS VEHICLE FOR 1 YEAR.*AK

CONSUMER WAS DRIVING AND WHILE ADJUSTING THE RADIO VEHICLE WENT DOWN A 6 FOOT EMBANKMENT AND ROLLED OVER. UPON IMPACT, AIR BAGS FAILED TO DEPLOY. VEHICLE WAS TOTALLED. *AK *TC

I HAD A SINGLE CAR ACCIDENT IN MY 2004 MAZDA MPV VAN WITH FRONT END SUSTAINING DAMAGE WITH NO DEPLOYMENT OF FRONT OR SIDE AIRBAGS. I SUSTAINED SIGNIFICANT HEAD AND FACIAL TRAUMA. *JB

SINCE THE PURCHASE OF MY 2004 NEW MAZDA 3 , I HAVE NOTICED A STRONG ODOR OF ROTTEN EGG SMELL THAT IS COMING INTO THE VECHICLE. THIS BAD SMELL IS SICKENING. HOW CAN YOU HELP ? I HAVE CALLED SERVICE AND THEY ARE NOT SURE WHAT TO DO. *AK

SIDEWALL OF THE RIGHT FRONT TIRE SPLIT IN TWO PLACES AFTER THE CONSUMER RAN OVER A CURB AT 5 MPH, WHICH CAUSED AN IMMEDIATE BLOWOUT. *BF ONE MONTH LATER THE CONSUMER RUBBED THE LEFT FRONT TIRE AGAINST A CURB WHILE PULLING THROUGH A NARROW DRIVEWAY AND THE LEFT FRONT TIRE SIDEWALL CAME APART IN THE SAME WAY AS THE FIRST TIRE DID. THE CONSUMER TOOK THE VEHICLE BACK TO THE DEALER, HOWEVER THE DEALER STATED IT WAS A ROAD HAZARD AND IT WAS NOT COVERED UNDER WARRANTY, BUT AS A COURTESY THEY REPLACED THE TIRE. THE CONSUMER REQUESTED THAT THE 17 INCH WHEELS BE REPLACED WITH 16 INCH WHEELS. *JB

NHTSA RECALL 04V073000 SUBJECT: FMVSS 208 AIR BAGS. NO PARTS WERE AVAILABLE . *AK

(1) DRIVING ALONG IN TOWN, APROX 5 MPH 2) TIRE WENT FLAT, SEEMS AS IF SOMEONE STUCK A KNIFE THROUGH IT, BUT IT WAS FINE UPON LEAVING MY HOME (ONLY HAS 1,866 MILES)/ (3) NOT COVERED BY WARRENTY, HAVE TO PURCHASE NEW TIRE. *AK

DURING INSPECTION DEALERSHIP INFORMED THE CONSUMER THAT ALL FOUR TIRES HAD TREAD SEPARATION. THE PROBLEM WAS NOT RESOLVED. DUNLOP SP4000, 215/60R16. *AK *NM

WHILE DRIVING CONSUMER APPLIED THE BRAKES AND PEDAL WENT TO THE FLOOR. A LOUD KNOCKING NOISE WAS HEARD FROM THE FRONT. CONSUMER WAS ABLE TO SLOW DOWN, AND PULLED OVER. CONSUMER HAD VEHICLE TOWED TO THE DEALER, AND MECHANIC DETERMINED THAT TRANSMISSION BLEW OUT DUE TO A WORN SHAFT SOLENOID. *AK

2004 MAZDA MPV PURCHASED ON FEB. 28, 2004. ON MAR. 27, 2004, ENGINE FAILED WITHOUT WARNING LIGHTS. FORTUNATELY, CAR WAS IDLE WHEN ENGINE FAILED. ONLY HAD 1,100 MILES ON VEHICLE. MANUFACTURER HAS NOT BEEN COOPERATIVE IN DIAGNOSING THE PROBLEM. INITIAL ASSESSMENT BY THE DEALER TECH AT STAR MAZDA IN GLENDALE, CA WAS THAT CONNECTING ROD FAILED AND ENGINE SEIZED. DEALER STATED THAT MAZDA'S OWN TECH PEOPLE WOULD HAVE TO TAKE A LOOK AT THE ENGINE TO DIAGNOSE PROBLEM. IT HAS ALREADY BEEN A WEEK. REQUESTED VEHICLE TO BE TOWED TO 1000 OAKS MAZDA, WHERE I PURCHASED THE VEHICLE. MAZDA STILL NOT GIVEN APPROVAL FOR THAT TOWING. STILL WAITING *JB

2004 MAZDA MPV WITH ONLY 400 MILES ON IT IS STARTING TO DEVELOP A SULFUR SMELL COMING FROM TAIL PIPE AREA. THIS HAS BEEN A ISSUE IN THE PAST WITH THE MPV. IS THERE A FIX. I HAVE NOT CONTACTED DEALER AS OF YET. *JB