2004 Pontiac Aztek 4-DR.

I HAVE BEEN SMELLING GAS FROM MY CAR FOR YEARS BUT JUST NEVER HAD THE MONEY TO GET IT LOOKED AT. I EVEN CALLED ABOUT RECALLS CONCERNING THE FUEL SYSTEM THAT I FOUND OUT ABOUT THROUGH RESEARCH IN 2015 BUT WAS TOLD THEY HAD BEEN CLOSED SO I WOULD BE CHARGED FOR THE REPAIRS EVEN IF IT WAS PREVIOUSLY COVERED UNDER RECALL. I NO LONGER FILL MY TANK WITH GAS BECAUSE THERE IS A LEAK. I JUST GOT MY CAR BACK FROM THE DEALERSHIP, THEY STATE THAT I NEED A NEW FUEL TANK, AND FUEL LEVER SENSOR AND SENDER. ALSO, HAVE OIL LEAKS IN 2 PLACES, THEY TELL ME I NEED UPPER & LOWER INTAKE GASKETS. AS WELL AS VALVE COVER GASKETS & OIL PUMP DRIVE O-RING REPLACED AND OIL PAN GASKET REPLACED. ALSO, NEEDS WATER PUMP AND DRIVE BELT REPLACED.I ALSO FOR THE PAST 3 OR SO YEARS HAVE TO KEEP A PEN OR PENCIL IN MY CAR TO INSERT UNDER THE STEERING WHEEL TO RELEASE MY KEY .

FUEL TANK IS LEAKING; THERE IS A HISTORY OF A RECALL THAT HAS NEVER BEEN REPAIRED ON THIS VEHICLE. IT IS A SAFETY ISSUE.

TL* THE CONTACT OWNS A 2004 PONTIAC AZTEC. THE CONTACT STATED THAT WHILE DRIVING 20 MPH CRASHED INTO A GMC ENVOY AND FLIPPED OVER LANDING ON THE ROOF. THE CONTACT STATED THAT THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO WARNING LIGHTS ILLUMINATED PRIOR TO THE FAILURE. A POLICE REPORT WAS FILED. THE SEAT BELT FAILED TO UNLOCK AS THE CONTACT WAS CUT FROM THE VEHICLE. THE CONTACT STRUCK THE STEERING WHEEL, WAS UNCONSCIOUS, AND SUSTAINED INJURIES TO THE EYE WHICH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO AN INDEPENDENT LOT. THE OCCUPANT OF THE GMC HAD NO REPORTED INJURIES. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED BUT NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 171,000. *DT CONSUMER STATED SHE HAS LOST HER EYE SIGHT DUE TO AIRBAG FAILURE.*JB*DT*JB

TL* THE CONTACT OWNS A 2004 PONTIAC AZTEK. WHILE DRIVING 35 MPH, THE CONTACT ATTEMPTED TO STOP THE VEHICLE AND THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD. THE VEHICLE FINALLY STOPPED BEFORE REACHING AN INTERSECTION. THE CONTACT NOTICED THAT BRAKE FLUID WAS LEAKING AND THE BRAKE HOSES WERE FRACTURED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO DIAGNOSED THAT THE BRAKE SYSTEM WAS FRACTURED. THE BRAKES AND HOSES WERE REPAIRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE DEALER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 95,000.. *BF CONSUMER STATED POWERSTEERING HIGH PRESSURE RUPTURED DUE TO RUST. THE DAY THE BRAKE LINES WERE GETTING REPAIRED CONSUMER WAS TOLD FUEL LINE FROM THE PUMP TO THE INJECTORS WAS ALSO RUSTED AND WOULD LEAK ANYTIME. *JB

MY CAR TURN OFF ON MY CHILDREN AND I ON THE HIGHWAY THANK GOD WE WAS ABLE TO COAST ON THE SIDE OF THE ROAD. MY MECHANIC SAID THAT MY IGNITION CONTROL MODULE WENT OUT OUTTA NO WHERE NOT ONLY THAT CRANKSHAFT SENSOR AND FUEL LINE EXHAUSTED SYSTEM SOMETHING WRONG ENGINE LIGHT STILL ON. WITH THAT BEING SAID I'M GREAT MY CHILDREN WAS NOT HURT DOING THIS ORDEAL. I LEARNED THAT THESE CARS HAVE FEW COMPLAINTS. BUT DO HAVE SOME ISSUES WITH ELECTRICAL SYSTEM AND VACUUM HOW'S EXHAUSTED. JUST GOT THE CAR I MARCH AND FOUND OUT BOUT THIS RECALL I'M SO DISAPPOINTED SCARED TO DRIVE THIS CAR RIGHT NOW.

"TAKATA RECALL" ON MY CAR THE ELECTRONIC IS NOT WORKING AND HASN'T BEEN FOR A LONG TIME, THE LIGHTS KEEP COMING ON AND WON'T GO BACK OFF. AND THE GAS TANK IS NOT WORKING RIGHT, I CAN'T GET GAS INTO MY TANK , IT DOES GO IN BUT I HAVE TO KEEP TRYING BECAUSE IT POPS OUT AND DON'T LET ME PUT GAS IN IT.

I WAS DRIVING DOWN THE HIGHWAY FOR 45 MINUTES AND WHEN GOT HOME NOTICE THERE WAS GAS COMING FROM MY PONTIAC AZTEC. DID SOME RESEARCH AND NOTICE THERE'S A RECALL. CALL BUICK AND THEY TOLD ME MY VIN IS NOT COVER UNDER THE RECALL. REALLY?

LIGHTING GOES OUT AT NIGHT WHICH IS VERY DANGEROUS

I HAVE NOT DRIVEN MY VEHICLE FOR 2 MONTHS BECAUSE MY MECHANIC TOLD ME MY VALVE COVER GASKETS WERE LEAKING ON TO MY EXHAUST MANIFOLD AND THAT IT WHY IT WAS SMOKING WHEN WE STOPPED. I TALKED TO MY LOCAL GM DEALER AND THEY SAID IT IS NOT PART OF THE RECALL SO THEY COULD NOT HELP, SO I HAVE THREE CHOICES LET IT SIT IN MY DRIVEWAY, PAY SEVERAL HUNDRED DOLLARS TO GET IT FIXED OR DRIVE IT TILL IT STARTS ON FIRE. IT HAS THE 3800 MOTOR LIKE ALL THE OTHER CARS IN THE RECALL. I CAN GET A LETTER FROM MY MECHANIC IF NEEDED.

KEY STUCK IN IGNITION ONCE CAR TURNED OFF. THIS HAS HAPPENED INTERMITTENTLY SINCE FIRST OCCURRED IN 2010. THE ONLY WAY TO REMOVE KEY IS TO OVERRIDE PARK SHIFT INDICATOR, WHICH WOULD ALLOW KEY TO BE REMOVED WHILE VEHICLE IN MOTION, THEREBY DISABLING POWER STEERING AND BRAKING. THERE IS NO FIX THAT DOES NOT INVOLVE OVERRIDING PARK SHIFT INDICATOR PER DEALER.

KEY STUCK IN IGNITION ONCE CAR TURNED OFF. THIS HAS HAPPENED INTERMITTENTLY SINCE FIRST OCCURRED IN 2010. THE ONLY WAY TO REMOVE KEY IS TO OVERRIDE PARK SHIFT INDICATOR, WHICH WOULD ALLOW KEY TO BE REMOVED WHILE VEHICLE IN MOTION, THEREBY DISABLING POWER STEERING AND BRAKING. THERE IS NO FIX THAT DOES NOT INVOLVE OVERRIDING PARK SHIFT INDICATOR PER DEALER.

TL* THE CONTACT OWNS A 2004 PONTIAC AZTEK. WHILE REFUELING THE VEHICLE, THE CONTACT WAS NOTIFIED THAT FUEL WAS SPILLING ONTO THE GROUND. THE CONTACT NOTICED THAT THE WELD OF THE FUEL LINE WAS FRACTURED. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V349000 (FUEL SYSTEM, GASOLINE) AND NHTSA CAMPAIGN NUMBER: 03V454000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 104,000. UPDATED 09/14/15*LJ

I HAVE BEEN HAVIBG ISSUES WITH MY CALL STALLING AND FUEL LEAKAGE FPR AWHILE NOW AND WHILE CHECKING THE WEBSITE FOR RECALLS I NOTICED THERE WERE 4 RECALLS ON MY CAR. WHEN CALLED TO TRY AND HAVE THE RECALLS FIXED, I WAS TOLD THAT MY CARS VIN WASN'T ON THE LIST FOR ANY RECALLS. BUT THE ISSUES DESCRIBED IN THE RECALL IS THE EXACT ISSUE I HAVE BEEN EXPERIENCING FIR THE LAST YEAR OR SO. WHY NOT LET ME BRING THE CAR IN TO BE CHECKED AND IF THE ISSUE MY CAR IS HAVING IS THE PARTS ON THE RECALL LIST, JUST REPLACE THEM. BUT NO NOT GM, THEY REFUSED TO EVEN LOOK AT THE CAR. SO DISAPPOINTED IN GM, ESPECIALLY SINCE I JUST BOUGHT ANOTHER GM VEHICLE. LOOKING IN TO REPLACING IT NOW.

DRIVING CAR ON ROAD AND CAR QUIT RUNNING, ELECTRICAL STARTED FLASHING. PULLED OVER AND IGNITION SWITCH WOULD ONLY GO TO ACC. MODE, IT WOULD NOT TURN TO OFF POSITION. I HAD CAR TOWED TO MY HOUSE. THE IGNITION WILL ONLY GO TO ACC. MODE WILL NOT TURN TO OFF POSITION WHERE KEY CAN BE REMOVED..UNHOOKED BATTERY TERMINAL AND CAR IS STILL PARKED. *TR

TL* THE CONTACT OWNS A 2004 PONTIAC AZTEK. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE ACCELERATED INDEPENDENTLY AND THE CHECK ENGINE, FUEL TANK, AND FUEL PRESSURE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 158,000.

SEEMS LIKE THE VAN HAS BEEN LEAKING FUEL FOR SOMETIME NOW AS AN ODOR OF GAS COULD BE SMELLED WHEN DRIVING BUT NEVER REALIZED IT UNTIL THE VAN WAS PARKED ON THE CARPORT AND SAW A PUDDLE OF FUEL ON THE GROUND. *TR

TL* THE CONTACT OWNS A 2004 PONTIAC AZTEK. WHILE DRIVING 15 MPH, THE ENGINE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE, BUT THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE DEALER WAS UNABLE TO DIAGNOSE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS UNKNOWN.

ABS SYSTEM LIGHTS WENT ON AND ABS SYSTEM EXHIBITS CRUNCHING, GRINDING, NOISY AND ABNORMAL PULSING OPERATION. JUNE 2012 MESSAGE INDICATES RF HUB NEEDS REPLACEMENT. DONE. ABS SYSTEM ACTS UP AGAIN IN UNDER 30 DAYS SAME SYMPTOMS. REAR BRAKES/DRUM REPLACED 6/2013, ABS PROBLEMS STILL PRESENT. FRONT BRAKES REPLACED 8/2013, ABS PROBLEMS STILL PRESENT. 8/2013 TAKEN TO GM DEALER SERVICE FOR ANALYSIS. SPEED SENSOR REPLACED, ABS PROBLEM STILL PRESENT. DEALER ADVISES THAT LF HUB NEEDS REPLACING AND ABS HARNESSES ON BOTH SIDES. 8/2014 LF HUB REPLACED AND ERROR MESSAGE NOW READS THAT RF HUB IS BAD AGAIN. TAKING BACK TO GM DEALER THIS WEEK TO TRY AND FIND THE DEFINITIVE SOLUTION. CONTINUED ONE BY ONE REPAIRS THAT DO NOT FIX THE PROBLEM HAVE BEEN A CONSTANT STREAM. NOTE: RR HUB WAS ALSO REPLACED IN 2011. *TR

THE GAUGES MESSED UP FIRST NONE OF THE GAUGES WORK SOMETIMES THE SPEED ODOMETER WILL MOVE BUT DOES NOT WORK . THE CAR ALSO WHEN ACCELRATING THE GAS IT WONT GO THE WAY IT SHOULD IT TAKES ALONG TIME TO BUILD UP SPEED. I HAVE SPENT A LOT OF MONEY ON THIS CAR TRYING TO GET IT TO RUN PROPER I HAVE REPLACED THE TRANSMISSION AND I HAVE HAD IT IN THE SHOP AT G.M.C TO HAVE THE ISSUE WITH THE FUEL SYSTEM ISSUE THEY REPLACED A PART BUT IT DID NOT RESOLVE THE PROBLEM THEY HAD NO IDEA WHAT THE PROBLEM WAS AND THIS WAS TEAGUE CHEVROLET-BUICK INC MABANK, TX, 75147. AS OF MAY 2, 2014 THE CAR WANT STAY RUNNING THIS HAS SOMETHING TO DO WITH THE FUEL SYSTEM I JUST FOUND OUT ABOUT THE RECALL I WAS NEVER NOTIFIED ABOUT THIS I ONLY FOUND OUT CAUSE I WAS SERCHING ON WHAT COULD BE WRONG WITH MY AZTEK AND I FOUND THE RECALL THIS AXTEK IS A REAL LEMON. *TR

THE AIR BAGS DEPLOYED BURNING DRIVERS CLOTHES ON THE LEFT WRIST. THE DRIVERS RIGHT KNEECAP WAS FRACTURED BY HITTING THE DASH WHEN THE VEHICLE STRUCK A POWER POLE. *TR

TL* THE CONTACT OWNS A 2004 PONTIAC AZTEC. THE CONTACT STATED THAT WHEN THE BRAKE WAS ENGAGED WHILE DRIVING AT LOW SPEEDS, THE BRAKE GRABBED AND EXHIBITED A GRINDING NOISE. IN ADDITION, THE ANTI-LOCK BRAKING SYSTEM WARNING LIGHT ILLUMINATED. THE FAILURE WAS EXPERIENCED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO REPLACED THE FRONT BRAKE PADS AND CALIPERS HOWEVER, THE FAILURE WAS NOT CORRECTED. THE VEHICLE CONTINUED TO EXHIBIT THE SAME FAILURES. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 38,000 AND THE CURRENT MILEAGE WAS 49,000.

I WAS PULLING OUT OF A GAS STATION INTO TRAFFIC,AS I ENTERED TRAFFIC ALL POWER SHUT DOWN FORCING ME TO COAST TO THE SHOULDER OF THE HIGHWAY. *TR

MY 2004 PONTIAC AZTEC RALLY EDITION HAS A LEAK IN THE FUEL TANK. THE DEALERSHIP IS TELLING ME THAT IT IS NOT ON RECALL. I SEE RECALLS ON THE SYSTEM. NEED TO KNOW WHY MY MODEL HAS NOT BEEN RECALL. *TT

TL* THE CONTACT OWNS A 2004 PONTIAC AZTEC. THE CONTACT STATED THAT THE VEHICLE WOULD PROVIDE INACCURATE READINGS FOR VARIOUS COMPONENTS ON THE INSTRUMENT PANEL. THE DEALER AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 120,070 AND THE CURRENT MILEAGE WAS 121,000.

TL* THE CONTACT OWNS A 2004 PONTIAC AZTEK. THE CONTACT STATED THAT WHILE DEPRESSING THE BRAKE PEDAL, THE ALL WHEEL DRIVE WARNING LIGHT AND THE ANTILOCK BRAKE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT ALSO STATED THAT SHE FELT THE METAL WITHIN THE BRAKE PEDAL RUBBING TOGETHER WHILE APPLYING THE BRAKES. A LOCAL MECHANIC REPLACED THE BRAKES, BUT THE FAILURE RECURRED. THE MECHANIC THEN DETERMINED THAT THE ELECTRONIC CONTROL MODULE WAS DEFECTIVE. THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS OF THE FAILURE. THE FAILURE MILEAGE WAS 57,000 AND THE CURRENT MILEAGE WAS 61,444. UPDATED 04/11/12*LJ UPDATED 04/17/12

TL* THE CONTACT OWNS A 2004 PONTIAC AZTEK. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, SHE CRASHED HEAD ON INTO ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE DRIVER RECEIVED INJURIES TO THE HEAD AND WAS LATER TRANSPORTED TO THE HOSPITAL. THE POLICE WERE CONTACTED AND A REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE CONTACT'S HOME AND PENDING AN INVESTIGATION. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 104,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2004 PONTIAC AZTEK. THE CONTACT WAS DRIVING 45 MPH AND WAS INVOLVED IN A CRASH WHERE THE AIRBAGS FAILED TO DEPLOY. THE CONTACT WAS REPORTED INJURED. A POLICE REPORT WAS NOT AVAILABLE. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT CONTACTED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 117,000. KMJ

2004 PONTIAC AZTEK RALLY - THIS PROBLEM STARTED IN APRIL 2010 - YOU GET INTO THE CAR, TURN IT ON AND START DRIVING DOWN THE ROAD. THE SPEED OF THE CAR INCREASES SLOWLY UNTIL YOU HAVE TO PUT ON THE BRAKE TO STAY WITHIN THE POSTED SPEED LIMITS. THIS HAPPENS ALMOST DAILY NOW. A CHEVROLET DEALER, FIRST TRIED A NEW BATTERY & GAVE IT BACK TO US. WITHIN 2 MILES OF THE DEALERSHIP IT STARTED AGAIN. WE TOOK IT BACK - THEY HOOKED IT UP TO A COMPUTER - FOUND NOTHING - SO THEN THEY REPLACED THE CAR'S COMPUTER SYSTEM - WE LEFT THE DEALERSHIP AND IT STARTED AGAIN - WE TOOK IT BACK AND THEY SAID THEY WOULD HAVE TO CONTACT GMAC AND MAKE SOME INQUIRIES. NO ONE KNOW WHAT IS WRONG WITH IT BUT IT IS NOT SAFE TO DRIVE THE WAY IT IS. *TR

AFTER NOTICING A STRONG GASOLINE SMELL WHILE DRIVING VEHICLE, IT WAS DISCOVERED THAT THE FUEL PRESSURE REGULATOR WAS DRIPPING FUEL ONTO THE ENGINE. THE FUEL WAS COMING FROM THE CASE SEAM AND NOT THE FUEL LINE OR CONNECTION TO THE FUEL RAIL. *TR

I HAVE HAD TO REPLACE BOTH FRONT WHEEL BEARINGS ON MY 04 AZTEK 1 MONTH AGO AND NOW THE REAR BEARINGS ARE NEEDING TO BE REPLACED. VEHICLE HAS 69,000 MILES. *TR

I NOTICE THE SMELL OF GAS ON MY DRIVE WAY, AFTER A FEW DAYS I NOTICE IT WAS COMING FROM THE VEHICLE. I NOTICED IT WOULD ONLY DO IT WHEN I PARKED FORWARD (SO THE CARS FRONT END WAS INCLINED) I THOUGHT IT WAS COMING FROM THE CLAMP, I TIGHTEN THE CLAMED. DID NOT WORK. TOOK IT TO A MECHANIC AND SAID IT WAS THE SEAL AROUND THE TANK BUT THERE IS NO WAY TO FIX IT WITH A PATCH. WE NOTICED THIS ABOUT A FEW DAYS AGO AND ARE WAITING TO SEE IF A RECALL LETTER WE RECEIVED WAS THE ONE FOR THE GAS TANK. CROSS OUR FINGERS! *TR

TL*THE CONTACT OWNS A 2004 PONTIAC AZTEC. THE CONTACT STATED THAT THE ENGINE WOULD CONSTANTLY OVERHEAT. THE DEALER STATED THAT THERE WAS NOTHING WRONG WITH THE VEHICLE AND JUST THE GAUGE WAS DEFECTIVE. LATER, THE VEHICLE OVERHEATED TO THE POINT THAT THERE WERE BELL-LIKE SOUNDS COMING FROM THE ENGINE. THE DEALER INSPECTED THE VEHICLE AGAIN AND STATED THAT THE ENGINE HEAD GASKET HAD BLOWN AND NEEDED TO BE REPLACED AT THE ESTIMATED COST OF $3,000. IN ADDITION, THE MANUFACTURER STATED THAT THE ENGINE NEEDED TO BE REPLACED AT THE ESTIMATED COST OF $7,000. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS LESS THAN 100,000 AND CURRENT MILEAGE WAS 116,000.

BOTH FRONT WHEEL BEARINGS HAD BE REPLACED AT 62000. I AM NOW HAVING TO REPLACE THE PASSENGER SIDE AGAIN 7 1/2 MONTHS LATER. THE DEALER TOLD ME THERE WAS A SELECT FEW SERIAL NUMBERS ON THE WHEEL BEARINGS THAT THEY WERE BEING REPLACED UNDER A SAFETY ALERT BUT MINE WAS NOT ONE OF THEM.. SO EVEN THOUGH I WAS HAVING THE SAME PROBLEM I AM HAVING TO PAY FOR MINE TWICE. *JB

REPLACED LEFT FRONT WHEEL BEARING ON 3/20/07 AND THEN HAD TO REPLACE RIGHT FRONT WHEEL BEARING 4/25/07 46,000 MILE ON CAR. *TR

TL*THE CONTACT OWNS A 2004 PONTIAC AZTEK. WHILE DRIVING 45 MPH, THE CONTACT SMELLED GAS. HE PULLED THE VEHICLE OVER AND DISCOVERED A FUEL VALVE LEAK. THE DEALER WOULD NOT PERFORM THE REPAIR UNDER RECALL NUMBER 07V349000 (FUEL SYSTEM, GASOLINE:STORAGE). THE COST FOR THE REPAIR WAS $804. THE CONTACT ALSO STATED THAT THE IGNITION WAS MALFUNCTIONING AND THE VEHICLE WOULD START AFTER THE THIRD ATTEMPT. THE DEALER ALSO REFUSED TO REPLACE THE PART UNDER RECALL NUMBER 05V157000 (ELECTRICAL SYSTEM:IGNITION). THE CURRENT AND FAILURE MILEAGES WERE 42,901.

HEAD GASKET BLOWN ON 2004 PONTIAC AZTEK RALLY, 3.4L ENGINE, 39,880 MILES. I BOUGHT THIS CAR USED 3 MONTHS AGO WITH 37,000 MILES AT SOUTHTOWNE HYUNDAI IN RIVERDALE, GA - 770-471-1000. THEY TOLD ME THE CAR WAS MECHANICALLY SOUND AND HAD PASSED A 60-POINT INSPECTION. RECENTLY, UPON DRIVING UP A 5-MILE HILL, ABOUT MIDWAY THE CAR STARTED OVERHEATING. I LET IT COOL DOWN, TURNED OFF THE A/C, TURNED ON THE HEATER AND DROVE BACK APPROX. 5 MILES TO THE NEAREST SERVICE STATION. THE CAR DID NOT INDICATE ANY MORE OVERHEATING. TECH'S COULD NOT FIND A LEAK. THERE WAS NO MORE OVERHEATING UNTIL A COUPLE OF WEEKS LATER. ON MY WAY TO GET AN OIL CHANGE, IT HAPPENED AGAIN. TOOK IT TO PONTIAC SERVICE DEPARTMENT. THEY DIAGNOSED A BLOWN HEAD GASKET. I RESEARCHED THE INTERNET, THIS SEEMS TO BE A COMMON FAILURE FOR THIS PARTICULAR CAR. PONTIAC SAID IT WILL FIX FREE OF CHARGE IF I PAY $1,100 FOR MAINTENANCE SERVICE (REPLACING ALL FLUIDS - WHICH HAD BEEN DONE 3,000 MILES AGO AT THE SOUTHTOWNE HYUNDAI). LUCKY FOR ME, THE HEAD GASKET DID NOT BLOW ON A HIGHWAY OR HEAVY TRAFFIC BUT CLOSE TO THE DEALERSHIP. I AM NOW WAITING FOR REPAIRS THROUGH PONTIAC. *TR

2004 PONTIAC AZTEK, FUEL TANK FILLER NECK SEPARATION CAUSING FUEL TO LEAK AT A CONSTANT FLOW ONTO GROUND. NO ACCIDENT OR ABUSE WAS THE CAUSE. THIS VEHICLE HAS 27,357 ACTUAL MILEAGE. *TR

TL*THE CONTACT OWNS A 2004 PONTIAC AZTEK. WHILE DRIVING 45 MPH, THE ANTILOCK BRAKE SYSTEM FAILED. THE REAR END OF HER VEHICLE FISHTAILED WHEN SHE APPROACHED A WET SURFACE. SHE TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT HER ABS HAD FAILED THE LEFT FRONT HUB ASSEMBLY ALSO HAD TO BE REPLACED. THE CURRENT AND FAILURE MILEAGES WERE 44,304.

REPLACE LEFT FRONT WHEEL BEARING. *AK

RIGHT FRONT BEARINGS FAILED. *JB

I PURCHASED A 2004 PONTIAC AZTEK IN JUNE OF 2005 WITH 18K ON THE UNIT I DROVE MOSTLY HIGHWAY MILES FOR MY JOB IN ALL OF 05' AND THE BEGINNING OF 06' I HAD TO HAVE THE FRONT LEFT WHEEL BEARING REPLACED IN JUNE OF 06' AND THEN THE FRONT RIGHT SIDE NEEDS TO BE REPLACED IN JAN/ FEB. OF 07' THIS IS NOT ACCEPTABLE THE VEHICLE IS BARELY OUT OF WARRANTY AND IS FALLING APART / ALSO THE REAR HATCH IS FAILING THE HATCH WILL NOT OPEN PROPERLY WHEN THE BUTTON IS PUSHED OR YOU HAVE TO PULL UP ON THE HATCH WHEN YOU PUSH THE BUTTON / VERY FRUSTRATING. *NM

I OWN (2) AZTEK'S, A 2002 AND A 2004. I RECEIVED A LETTER IN SEPT 06 STATING THAT THERE IS AN ISSUE WITH FRONT BEARINGS WEARING PREMATURELY ON 2002 AZTEK'S. THE LETTER STATED THAT THEY WILL REPLACE ANY DEFECTIVE BEARINGS WITHIN (5) YEARS OF DATE OF PURCHASE OR 60,000 MILES, WHICHEVER OCCURS FIRST. SINCE MY 2002 AZTEK IS LOCATED AT MY VACATION HOME, IT HAS ONLY 18,000 MILES ON IT AND HAS NOT EXHIBITED THE WORN BEARING SYMPTOMS. HOWEVER, MY 2004 AZTEK DID HAVE THE BEARING ISSUE AT 48,000 MILES. I CALLED PONTIAC AND THEY SAID THEY WOULDN'T COVER THE EXPENSE BECAUSE IT IS NOT WITHIN THE VIN RANGE. WHEN I TOOK IT TO THE DEALER FOR REPAIRS, THE DEALER TOLD ME THAT THEY EXPECTED THE RECALL TO BE EXPANDED TO LATER MODEL AZTEKS AND TO KEEP MY RECEIPT FOR REIMBURSEMENT AT A LATER DATE. I HAVE SINCE TRIED TO RECOUP MY MONEY TO NO AVAIL. BEWARE, REGARDLESS OF WHAT YEAR AZTEK YOU HAVE, YOU WILL MOST LIKELY EXPERIENCE THE PREMATURE BEARING WEAR BEFORE 50,000 MILES. MAKE SURE YOU ADDRESS THIS ISSUE AS SOON AS YOU EXPERIENCE THE SYMPTOMS, HUM GROWL OR GRINDING COMING FROM THE FRONT WHEELS. TALKING WITH PONTIAC CUSTOMER SERVICE PEOPLE IS A JOKE. THEY COULD CARE LESS ABOUT LOSING A CUSTOMER. NO WONDER THE AMERICAN AUTOMAKERS KEEP LOSING MARKET SHARE. *JB

ON APRIL 17, 2006, I BROUGHT MY 2004 AZTEK IN TO THE PONTIAC DEALER BECAUSE THERE WAS A LOUD GRINDING NOISE AND VIBRATION COMING FROM UNDER THE FRONT PASSENGER SIDE OF MY VEHICLE. I WAS TOLD THAT THE FRONT RIGHT WHEEL BEARING WAS FAILING, AND THAT IT HAD TO BE REPLACED. SINCE IT WAS JUST OUT OF WARRANTY, AT 63,031 MILES, I PAID FOR THIS REPAIR. THEN, ON SEPTEMBER 13, 2006, I HEARD THE SAME NOISE AND VIBRATION COMING FROM THE FRONT DRIVERS SIDE OF MY VEHICLE. I BROUGHT MY VEHICLE INTO THE DEALERSHIP AGAIN, AND PAID TO HAVE THE FRONT LEFT WHEEL BEARING REPLACED. THERE IS A RECALL NOTICE OUT ON THIS FAILURE, IF THE VEHICLE IS UNDER 60,000 MILES AND 5 YEARS OF SERVICE. I DID NOT SEE THIS RECALL NOTICE ON YOUR WEBSITE. I BELIEVE THESE FAILURES COULD HAVE POTENTIAL SEVERE CONSEQUENCES, AND GM SHOULD REIMBURSE ME FOR THE NECESSARY REPAIRS. *NM

THE BRAKE PADS AND ROTORS ON THE CONSUMER'S 2004 PONTIAC AZTEK WORE OUT AT 28632 MILES. *TS *NM ***NAR***

PASSENGER SIDE FRONT BRAKE CALIPER. BOTH CALIPERS AND SHOES HAD TO BE REPLACES AT 38,000 MILES. *NM

ON SEPTEMBER 16, 2006 I WENT TO THE DEALERSHIP WHERE I PURCHASED MY 2004 PONTIAC AZTEC TO HAVE AN OIL CHANGE DONE. WHILE I WAS THERE, THE MAINTENANCE MANAGER INFORMED ME THAT MY RIGHT WHEEL BEARING HUB ASSEMBLY WAS GOING TO NEED REPLACED VERY SOON. I WAS SHOCKED! LAST YEAR THE LEFT WHEEL BEARING HUB ASSEMBLY NEEDED REPLACED. I WAS VERY UPSET. I CANNOT BELIEVE THAT WITHIN 2 YEARS BOTH WHEEL BEARINGS ASSEMBLIES NEED REPLACED. I BEGAN TO LOOK ON THE INTERNET AND FOUND THERE WERE SEVERAL PEOPLE WHO HAD SIMILIAR PROBLEMS WITH THE PONTIAC AZTEC. THIS MUST BE ADDRESSED. MY WIFE SPOKE TO THE DEALERSHIP AND GENERAL MOTORS. NEITHER WERE WILLING TO ADDRESS THIS PROBLEM. *NM

THE WELD BETWEEN THE FUEL TANK INLET CHECK VALVE AND THE FUEL TANK HAS FAILED CAUSING A GAS LEAK. THERE WAS AN EARLIER RECALL ISSUED (NHTSA RECALL NO. 03V454/GM RECALL NO. 03055) THAT WAS LIMITED TO 79 VEHICLES. I OWN A 2004 MODEL THAT IS NOT ONE OF THE 79 VEHICLES AND I AM ENCOUNTERING THE EXACT SAME PROBLEM AS WHAT IS OUTLINED IN THE RECALL. I BELIEVE MORE VEHICLES ARE AFFECTED THAT WHAT IS NOTED BY GM. *JB

WHILE DRIVING CAR WILL COMPLETELY SHUT DOWN, LOSING STEERING AND BRAKES. THIS HAS HAPPENED TWICE IN THE LAST SIXTY DAYS. THE FIRST TIME THE DEALER COULDN'T FIND ANYTHING WRONG. THE SECOND TIME A DIFFERENT DEALER REPLACED A PART THAT THEY THOUGHT COULD BE CAUSING THIS PROBLEM, BUT APPARENTLY IT ISN'T. THE THIRD TIME I STOPPED TO GET GAS AND THE CAR WOULD NOT START. AFTER SEVERAL ATTEMPTS THE CAR FINALLY STARTED UP AND I DROVE IT A SHORT DISTANCE HOME. THE DEALER IS GOING TO CHECK IT OVER AGAIN AND HOPEFULLY FIND A SOLUTION TO THIS PROBLEM, BEFORE SOMEONE IS SERIOUSLY INJURED OR KILLED BECAUSE OF THE MALFUNCTION. *NM

DT*: THE CONTACT STATED WHILE DRIVING AT NO PARTICULAR SPEED THE VEHICLE STALLED. THE LIGHTS ON THE RADIO INTERMITTENTLY ILLUMINATED PRIOR TO THE STALLING. THIS HAPPENED FIVE TIMES. THE VEHICLE WAS PUT IN PARK THEN RESTARTED AND OPERATED PROPERLY. THE DEALERSHIP INSTALLED A NEW CHIP IN AN EFFORT TO REMEDY THE PROBLEM, BUT THIS HAS NOT REPAIRED THE PROBLEM. THE DEALERSHIP SUGGESTED THE VEHICLE BE PULLED OVER AND TOWED IN, TO DETERMINE THE CODES ON THE COMPUTER.

DT: THE BRAKES WERE REPLACED 6 TIMES. THE BRAKES CONTINUOUSLY SQUEAL AND CRUNCH. THE DEALERSHIP CONTINUES TO REPLACE ITEMS ONE AT A TIME. THEY HAVE NOT STATED WHAT THE PROBLEM WAS. THE MANUFACTURER REQUESTED THAT THE CONSUMER RETURN TO THE DEALER. THE PROBLEM STARTED APPROXIMATELY APRIL 15, 2005. THE VEHICLE WAS PURCHASED NEW. *JB

DT: 2004 PONTIAC AZTEC HAS A RECALL FOR IGNITION SWITCH. HOWEVER, THIS VEHICLE WAS NOT INCLUDED IN THAT RECALLED DUE TO VIN. THE VEHICLE STALLED AS DESCRIBED IN THE RECALL, BUT PONTIAC WILL NOT RECOGNIZE THIS VEHICLE. IT HAPPENED SEVERAL TIMES, NO REPAIRS AS OF YET.*AK *JB

DT: THE CONSUMER STATES THAT JUST TWO DAYS OFF OF THE LOT SHE STARTED HAVING PROBLEMS WITH HER ABS BRAKING SYSTEM. A NEW HARDWARE KIT WAS INSTALLED AND IT STILL DID NOT HELP THE PROBLEM. THE ABS PROBLEM WAS THAT THE VEHICLE WAS REALLY SHAKY AND MADE SOME TYPE OF NOISE WHILE BRAKING. IT WOULD MAKE HER BRAKE PADS WEAR OUT REAL QUICK. THE VEHICLE HAS BEEN TAKEN TO THE DEALER SEVERAL TIMES. THE DEALER PUT NEW SPRINGS ON THE SUSPENSION. THE CONSUMER HAS HAD PROBLEMS WITH THE BRAKES, POWER STEERING, GAUGE IS BROKEN, RADIO LIGHTS. THE GEAR STICKS AND SHE HAS TO HOLD IT REALLY TIGHT AND PULL IT REALLY HARD TO MAKE IT GO INTO ANOTHER GEAR AND IT MAKES A BOOM SOUND. *TT

DRIVING AT A LOW SPEED IN A PARKING LOT BY MYSELF, MY VEHICLE SHUT OFF ON ME. THE BATTERY LIGHT FLASHED AND I LOST THE STEERING AND BRAKES. I HAD TO SLAM ON THE EMERGENCY BRAKE TO AVOID HITTING A PARKED VEHICLE. THIS INCIDENT WAS REPORTED TO GM AND WAS TAKEN TO WAYNE WOODRUMS PONTIAC DEALERSHIP IN MACOMB, IL. THEY FOUND NOTHING WRONG WITH IT, THERE WERE NO CODES. I HAVE HAD NUMEROUS PROBLEMS WITH THIS VEHICLE INCLUDING BRAKING ISSUES THAT CAN NOT BE FIXED, PCV VALVE FAILURE, AND CURRENTLY IT IS STRUGGLING WHILE DRIVING AND LOUD RATTLING, I AM CALLING WOODRUMS BACK TOMMORROW MORNING. I AM UNSURE OF THE DATE THIS HAPPENED, ALL OF MY PAPERWORK IS IN ANOTHER LOCATION. I DO KNOW IT WAS IN NOVEMBER OF 2004. *AK

INTERMITTENTLY THE 3.4L ENGINE WOULD STALLS WHILE DRIVING AT LOW SPEED OF 10 MPH OR LESS. VEHICLE WOULD RESTART. THE VEHICLE HAD BEEN TO THE DEALER ON ONE OCCASION, AND THEY WERE UNABLE TO DUPLICATE THE PROBLEM. CONSUMER WILL BE TAKING THE VEHICLE BACK IN FOR ANOTHER INSPECTION.*AK

WHILE DRIVING 50 MPH ON A DARK BACK ROAD, AND SWITCHING FROM HIGH BEAM TO LOW BEAM, THE HEADLIGHTS FAILED. *AK

THERE WAS A PROBLEM WITH DRIVING VISIBILITY BOTH DURING DAYLIGHT AND DARK OF NIGHT. THE SPOILER DESIGN/LOCATION PART OF THE BODY SEPARATED THE UPPER GLASS AND LOWER SOLID DOOR. BF *SC

CRUSIE CONTROL EITHER WORKING SOMETIMES OR NOT AT ALL. IGNITION STALLING OR NOT STARTING, SMELL OF GAS OR BURNT IN FUMES VEHICLE. PAINT CHIPPING AND MOLDING COMMING ALOOSE IN SOME AREAS.*AK

DRIVING ABOUT 5 MPH ENGINE SHUT DOWN. DEALER COULD NOT DUPLICATE PROBLEM. *AK

GAS LEAKING FROM THE AREA NEAR THE FUEL TANK WAS NOTICED WHEN THE CAR WAS PARKED IN A GARAGE. PREVIOUS TO THAT THE CAR WAS PARKED IN A APARTMENT PARKING LOT, SO THE GAS LEAK MAY HAVE EXISITED DAYS EARLIER. LUCKILY THERE WERE NO INJURIES OR FIRES BECAUSE OF THIS BEFORE IT WAS DETECTED. THE CAR WAS TOWED TO THE DEALERSHIP AND THEY REPLACED THE WHOLE FUEL TANK AND SEAL. GAS WAS APPARENTLY LEAKING FROM A SEAM IN THE FUEL TANK. THOUGH SOME 2004 AZTEKS WERE RECALLED FOR THIS PROBLEM, MINE WAS APPARENTLY NOT ON THE RECALL LIST.*AK

WHILE DRIVING 30 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE DRIVER TRIED TO RESTART THE VEHICLE AND WAS ABLE TO DO SO. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE MECHANIC WAS UNABLE TO DUPLICATE THE PROBLEM. PLEASE PROVIDE FURTHER DETAILS. *JB

WHEN ROLLING THE WINDOWS DOWN AIR WAS COMING IN AND CAUSING A TURBULENCE IN THE VEHICLE. ALSO, IT WAS TOO LOUD, IT SOUNDED LIKE THE VEHICLE WAS GOING TO EXPLODE.*AK

WHILE PROCEEDING DOWN A STEEP HILL IN NORTHEREN PA THE ABS FAILED AND THE PONTIAC AZTEK BEGAN TO FISHTAIL AS THOUGH ON ICE. IT HAD TWO FRONTAL IMPACTS AND THE AIRBAGS DID NOT DEPLOY.

VEHICLE STALLED WHILE DRIVING. DEALERSHIP REPLACED THE FUEL PRESSURE REGULATOR, BUT THE FAILURE RECURRED. *AK

WHILE PULLING INTO A PARKING AREA THE VEHICLE STALLED WITHOUT WARNING. AS A RESULT THE STEERING COLUMN AND BRAKES LOCKED UP. THE DEALER CLAIMED THAT A POWER STEERING PUMP WAS INSTALLED ON THE VEHICLE. THE POWER STEERING COLUMN IS STILL WHINING AND THE BRAKES ARE STILL GRINDING AND THE STARTER IS STILL HESITATING. *NM THE FRONT AND BACK BUMPERS SEPARATED FROM THE VEHICLE, THE STEERING WHEEL HAD A LOT OF PLAY, THE WINDSHIELD CONTAINED NUMEROUS CHIPS, THE WINDOWS SQUEALED WHEN OPENING AND CLOSING, THERE WAS A CONSTANT WHINING SOUND COMING FROM THE STEERING WHEEL, THE STEERING WHEEL AND THE BRAKES WOULD LOCK UP WHEN IN MOTION, AND THE VEHICLE WAS NEVER PROPERLY ALIGNED. WHEN THE VEHICLE WAS TAKEN IN FOR THE WHINING, BRAKES AND THE STARTER, THE CONSUMER WAS TOLD THAT NOTHING WAS WRONG WITH THE VEHICLE. THE CONSUMER WAS LATER TOLD THAT THE POWER STEERING PUMP HAD AN AIR BUBBLE. THE ENGINE WAS ALSO SLOW TO START AND WOULD CLICK AT TIMES. *SC *JB

WHILE MAKING A LEFT TURN, A WINDING NOISE WAS HEARD COMING FROM THE STEERING COLUMN. THE VEHICLE THEN STALLED. THE CONSUMER TRIED TO RESTART THE VEHICLE, BUT WAS UNABLE TO. THE DRIVER APPLIED THE BRAKES, BUT THE PEDAL WENT TO THE FLOOR AND A LOUD GRINDING NOISE WAS HEARD FROM THE FRONT. THE TRANSMISSION LOCKED UP. THE DRIVER WAS ABLE TO COAST THE VEHICLE TO THE SHOULDER. THE DRIVER TURNED OFF THE VEHICLE AND THEN RESTARTED IT. THE CONSUMER WAS ABLE TO DRIVE THE VEHICLE TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THAT A STEERING PUMP WAS NEEDED, BUT THE BRAKES AND TRANSMISSION PROBLEM COULD NOT BE DUPLICATED. THE CONSUMER INFORMED THE MECHANIC THIS PROBLEM HAS OCCURRED MORE THAN ONCE. THE DEALER AND THE MECHANIC WERE AWARE OF THE PROBLEM. *JB

WHILE DRIVING ON THE HIGHWAY ON VACATION MY AZTEC JUST SHUT OFF. I HAD IT TOWED THEY RESET THE COMPUTER AND SENT IT OUT THE DOOR. EIGHT HOURS LATER IT DID IT AGAIN. I HAD IT TOWED BACK AND THEY FOUND A BAD IGNITION RELAY!! THIS THING IS NOT EVEN FOUR MONTHS OLD. *AK

LOSING AIR. TWICE WITHIN TWO WEEKS EACH OF CHECKING THE AIR PRESSURE, THE PRESSURE WAS DOWN TO 20 PSI, THEN 15 PSI. *LA