2005 Ford Expedition 4-DR.

COOPER TIRES 265/70/17 DISCOVERER M+S. BELT SEPARATION AND TIRE DEFORMITY ON 3 OF 4 TIRES IN THE LAST 1000 MILES. 2 FAILED WITHIN THE LAST 200 MILES. IN MOTION, HIGHWAY. . SEVERE VIBRATION OCCURRED. (THINK PAINT MIXER) LOW USE 80% TREAD REMAINS. MAX USE OF 3K MILES PER YEAR BUT NOT ALL YEARS. PURCHASED IN 2013. DOT RM1Y C6J 2412 COOPER CUSTOMER SERVICE CLAIMS I DIDN'T USE THEM ENOUGH. *TR

MY TRUCK LOST ALL FORWARD GEARS EXCEPT FOR REVERSE OUT OF THE BLUE THE OTHER MORNING WHEN ATTEMPTING TO LEAVE HOME. VALVE BODY, SERVOS, SOLENOIDS, HAVE BEEN REPLACED AND STILL HAS NOT CORRECTED THE ISSUE. THE VEHICAL HAS LESS THEN 155000 MILES

ENGINE MAKES RATTLING NOISE AND MISSING BADLY

MY CAR AT TIMES WILL GIVE A HARD START. TURNING, BUT NOT FULLY TURNING OVER OR GIVES OFF A SOUND THAT I CAN ONLY DESCRIBE AS AN ELEPHANT TRUMPETING. WHEN IT DOES START AT TIMES IT WILL SHUT COMPLETELY OFF JUST AS FAST. IT HESITATES TO PICK UP ADEQUATE SPEED AND WILL STUMBLE OR JERK, AND WHEN PUT IN REVERSE IT WILL COMPLETELY STALL OUT. I'VE HAD A NEW BATTERY INSTALLED, AND THE SPARK PLUGS AND BOOTS HAVE BEEN CHANGED, BUT TO NO AVAIL.

THE CAR TURNS OFF. I NEED TO PUT THE CAR IN PARK WAIT A FEW MINUTES THEN TURN THE CAR BACK ON AND IT WORKS. THE BAD THING IS IT CAN HAPPEN AT ANY TIME.

I WAS DRIVING AND ALL OF A SUDDEN STEERING WHEEL LOCKED AND MY CAR LITERALLY SHUT OFF WHILE I WAS DRIVING.. I COASTED TO THE SIDE AND I TURNED OFF CAR.. TRIED TO TURN IT BACK ON AND IT KEPT CRANKING AND I KEPT DOING IT LIKE 5 TIMES UNTIL IT STARTED BACK UP. SURE IT IS A 2005, BUT IT HAS BEEN GIVING ME PROBLEMS SINCE I GOT IT, NOW IT IS WORSE. I DON'T BELIEVE IT IS WEAR AND TEAR I ACTUALLY REPLACED THE WHOLE ENGINE 4 YEARS AFTER I BOUGHT MY CAR WHICH IS RIDICULOUS TO BEGIN WITH. IF MY CAR BURNS UP WHILE I AM DRIVING I WILL REALLY MAKE A STINK..

CRANK NO START, AFTER REPLACED NEW FUEL PUMP, FILTER AND OTHER PARTS WOULD NOT START AND NOT GETTING FUEL. WAS IN MOTION AND DIED AFTER MAKING A RIGHT TURN AFTER FILLING FUEL TANK.

MY GEAR SHIFT BROKE WHICH BROKE THE STEERING COLUMN AND I FEEL LIKE THIS IS DEFAULTED SYSTEM SO DO FORD BECAUSE DID CONTINUE THIS STEERING COLUMN SO I HAD TO REPLACE IT WITH ONE FROM JUNK YARD SO HOW IS THAT SAFE FOR ME AS A CONSUMER WELL I FILING THIS JUST IN CASE IT BREAK AGAIN AND MY LIFE IS IN DANGER MY CAR CAME OUTTA OF PARK LIKE TO TANNED ME OVER SO I'M SPEAKING UP BECAUSE THIS PUT MY LIFE IN DANGER

ALUMINUM BODY PANELS ARE CORRODING UNDERNEATH THE PAINT, CAUSING BUBBLING, FLAKING, AND CHIPPING OF THE PAINT. THIS IS NOT CAUSED NATURALLY, THIS IS A FAILURE ON THE PART OF FORD AND THEIR QUALITY CONTROL. THE ALUMINUM UNDERNEATH WAS CONTAMINATED FROM THE FACTORY WITH IRON CAUSING CORROSION. WHILE KNOWING ABOUT THIS PROBLEM, THEY FAILED TO ISSUE A RECALL.

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE FUEL CAP AND THE TIRE SENSOR WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER (CAPITAL FORD OF CHARLOTTE LOCATED AT 5411 N TRYON ST, CHARLOTTE, NC 28213) WHERE IT WAS DIAGNOSED THAT THE TIRE SENSOR, THE FUEL CAP AND THE WINDSHIELD WIPER BLADE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT STATED THAT THE FUEL CAP WARNING LIGHT, FAILURE OCCURRED EVEN AFTER REPLACING THE PART. THE MANUFACTURER WAS NOT CONTACTED AND WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 94,368.

THE PAINT IS PEELING ON THE EXTERIOR AND INTERIOR IN LARGE PATCHES FOR NO OBVIOUS REASONS INCLUDING RUST OR ENVIRONMENTAL FACTORS LIKE BEING CLOSE TO SALT WATER. THE PEELING PAINT IS PRIMARILY ON THE BACK HATCH BUT ALSO SOME PAINT BUBBLING IS OCCURRING ON A FEW OTHER SMALL SPOTS ON THE VEHICLE. THERE IS ALSO EVIDENCE OF SIGNIFICANT LEAKS OF WATER INTO THE BODY BUT NO OBVIOUS POINTS OF ENTRY.

FUEL PUMP DRIVER MODULE FAILED DUE TO DESIGN FLAW WHICH CAUSED GALVANIC CORROSION. ALUMINUM BODY OF COMPONENT ACTS AS THE SACRIFICIAL ANODE FOR THE FRAME WHICH IS STEEL. THIS CAUSED MY VEHICLE TO STALL AT 65MPH AND LOSE POWER AND THUS CAUSED THE LOSS OF POWER STEERING AND HYDRAULIC BRAKE BOOSTER WHILE TRAVELING A HIGH RATE OF SPEED. THIS COULD BE ESPECIALLY DANGEROUS ON HIGHWAYS, CONGESTED AREAS, OR AREAS WITH PEDESTRIANS SUCH AS SCHOOLS. I HAVE ALSO NOTIFIED FORD OF THIS PROBLEM.

VEHICLE VIBRATES BADLY ESPECIALLY AT HIGHWAY SPEEDS. VIBRATION IS SO BAD, THE VEHICLE ROCKS SIDE-TO-SIDE WHILE DRIVING. DRIVING AT HIGHWAY TURNPIKE SPEED OF 75MPH, VEHICLE ENGINE BEGAN TO SURGE AND THEN COMPLETELY SHUT DOWN. OIL PRESSURE GAUGE INDICATED LOW OIL PRESSURE AND VEHICLE WOULD NOT START. VEHICLE STILL HAD ELECTRICAL FUNCTION BUT ENGINE NO LONGER WOULD TURN OVER. CHECKED ENGINE OIL LEVEL AND HAD ENGINE OIL. CALLED HIGHWAY PATROL AND HAD TO HAVE THE VEHICLE TOWED. *TR

TWICE I'VE BEEN DRIVING AND ALL OF A SUDDEN I LOST POWER AND "ELECTRONIC THROTTLE CONTROL" MESSAGE CAME ON. ACCELERATOR WOULD NOT WORK, COASTED TO THE SIDE OF THE ROAD-- 2ND TIME IN HEAVY TRAFFIC!! BOTH TIMES I TURNED OFF ENGINE AND RESTARTED OK, BUT I'M SCARED TO DEATH TO DRIVE WITH MY CHILDREN IN THE CAR. DRIVING STRAIGHT ON CITY STREET BOTH TIMES. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING 30 MPH, THE VEHICLE VIBRATED ABNORMALLY AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000. THE VIN WAS NOT AVAILABLE.

THIS CAR JUST NUMEROUS OF PROBLEM..... WHO EVER BUILT THIS CAR DID NOT HAVE A GOOD JOB OF DOING IT

MY SUV WAS PARKED IN PARKING LOT OF A STORE. SMOKE STARTED COMING OUT FROM MY VEHICLE. THEN IT STARTED TO CATCH ON FIRE. FIRE FIGHTERS SAID THE FIRE STARTED FROM THE FUEL INJECTORS.

TAKATA RECALL. MY FORD EXPEDITION 2005, HAS BEEN MESSING UP FOR A WHILE NOW. WE'VE TAKEN IT TO THE MECHANIC WAY TOO MANY TIMES. IT STARTS SHAKING SOMETIMES WHEN WE STEP ON THE GAS AFTER WE STOP AT A STOP LIGHT OR STOP SIGN, AND GOING UP A HILL IT FEEL A LIKE IT HESITATES AND FEELS AS IF IT'S PULLING BACK. YESTERDAY WAS WHAT STARTED TO CONCERN ME THOUGH. MY VEHICLE JUST SHUT OFF ON ME COMPLETELY WHILE I WAS ON THE HIGHWAY. MY FORD FOCUS 2012 HAS BEEN DOING THE SAME THING AND IT TURNS OUT IT HAD A RECALL ISSUE, SO I WAS WONDERING IF THAT'S THE CASE WITH MY EXPEDITION.

SAME AS EVERYONE ELSE DRIVING NORMALLY AND TRUCK COMPLETELY SHUTS OFF 4 DIFFERENT TIMES ALL DIFFERENTLY I CHANGED THE FUEL PUMP DRIVER MODULE HAD FUEL TANK DROPPED AND CHANGED FUEL FILTER AND PUMP I'M NOT GOING TO LIE I LOVE MY BABY SHE'S BEEN GOOD TO ME BESIDES THIS I HAVE 250,000 PLUS MILES ON HER AND COUNTING AND NEVER FACED PROBS TILL NOW I'VE RECENTLY THIS YEAR (TECHNICALLY) REBUILT HER MOTOR AND THAT'S IT . ALSO PASSANGER OVER HEAD LIGHTSTART HAVE BEEN ACTING FUNNY SOME WORK SOME DON'T AND AC IN THE 3RD ROW SOMETIMES GOES OUT OR MAKES A CLICKING NOISE AND HEATER DON'T WORK AT ALL ON THE 2ND OR 3RD ROW I AM A SINGLE FEMALE WITH 3 YOUNG KIDS ID LOVE TO KEEP MY BABY RUNNING SO PLEASE HELP AND I'VE HAD ONE OTHER PROB ONE TIME ON HIGH WAY I HAD A FENDER BENDER I REPEATEDLY STOPPED OVER N OVER ON BREAKS AND NEVER MANAGED TO STOP UNTIL I SLAMMED INTO OTHER DRIVER IN FRONTHE OF ME ME AND MY KIDS WERE TERRIFIED AND NEVER THANK GOD HAPPENED AGAIN BUT YEP SO PLEASE FOR THE LOVE OF PEOPLE'S SAFETY RECALL FIX AND APOLOGIZE FOR THE WRONG HARMFUL DOING LIKE BIG BOYS AND PAY UP OR YOU'LL EITHER LOSE PRECIOUS INNOCENT LIVES OF FORD CUSTOMERS OR JUST LOSE CUSTOMERS IN GENERAL HAVE A HEART FIX YALLS WRONG AND LETS MOVE ON WITH THIS FORD BUILT TUFF HECK OF A BEAUTIFUL SUV AND LETS LIVE LIFE SAFE TY SORRY FOR THE CAPS NOT YELLING JUST NEEDING TO STAND OUT IS ALL TEXAS IS WHERE I'M AT YALL BE SAFE ;)

I HAVE AN 05 EXPEDITION EDDIE BAUER EDITION AND THE TRUCK WAS SHUDDERING AND VIBRATING WHILE ON INCLINE OR DRIVING. IT ALSO WOULD HESITATE UPON ACCELERATION. THE NEXT DAY THE TRUCK WILL ONLY ROLL IN REVERSE IT WILL NOT DRIVE FORWARD AND THE "CHECK ELECTRONIC THROTTLE CONTROL" MESSAGE CONTINUES TO POP UP. DROVE IT AND ALL OF A SUDDEN IT WOULDN'T SHIFT, AND ALL GAUGES WENT FLAT, TRUCK WAS STILL REVVING BUT GAUGES WERE AT ZERO AND THE TRUCK WOULDN'T MOVE. I WAS GOING 60 MPH. AND IT JUST STOPPED MOVING COMPLETELY. CANNOT DRIVE THE TRUCK.

MY ENGINE SAID FAIL SAFE MODE. MY SPARK PLUGS GOT STUCK IN ENGINE COSTING ME 1000 TO FIX.

WAS DRIVING AND EXPERIENCED COMPLETE BRAKE FAILURE, NO WARNING, WENT TO STOP AND HAD NO BRAKES WHAT SO EVER! THE BRAKE LINE GOING TO THE PASSENGER SIDE FRONT CALIPER HAD COMPLETELY RUSTED AWAY UNDER THE MIDDLE OF THE VEHICLE BETWEEN THE PASSENGER SIDE FRONT TIRE AND THE ABS DISTRIBUTION BOX. I WAS ALWAYS TOLD THAT THE BRAKE SYSTEMS WERE DESIGNED WITH A TANDEM MASTER CYLINDER SO THAT IF AN EVENT LIKE THIS HAPPENED YOU WOULD STILL HAVE 2 WHEELS THAT HAD BRAKES. THIS OBVIOUSLY IS NOT THE CASE AS THERE WAS A COMPLETE LOSS OF ALL 4 BRAKES. LUCKILY I WAS ONLY DOING 25 MPH AND THERE WAS NO TRAFFIC WHERE I WAS WHEN THIS HAPPENED, IT TOOK A WAYS TO GET THE VEHICLE STOPPED BY APPLYING THE PARKING BRAKE. I DON'T WANT TO EVEN THINK WHAT WOULD HAPPEN IF I WAS ON THE FREEWAY DOING 70 MPH AND HAD TO STOP IN AN EMERGENCY AND THIS HAPPENED, I WOULD PROBABLY BE DEAD AND POSSIBLY SOMEONE ELSE ALSO. THIS NEEDS TO BE ADDRESSED ASAP. PEOPLES LIVES ARE AT SERIOUS RISK HERE. I CANNOT UNDERSTAND WHY THESE BRAKE LINES WOULD NOT BE MADE OUT OF 318 STAINLESS STEEL, THEY WOULD NEVER CORRODE AND THIS WOULD POSSIBLY SAVE LIVES. I AM TOTALLY CONVINCED THAT PEOPLE HAVE DIED FROM THIS HAPPENING. THIS IS NOTHING NEW WITH FORDS! MY MECHANIC TOLD ME THAT HE SEES FORD VEHICLES ALL THE TIME WITH RUSTED OUT BRAKE LINES AND PEOPLE THAT HAVE EXPERIENCED COMPLETE BRAKE FAILURE DUE TO THIS.

MY 2005 EXPEDITION IS MAINTAINED NORMALLY AND SPARK PLUGS CHANGED AND THE ENGINE WILL EITHER CUT OFF OR SLOW DOWN TO ABOUT 30 MILES AN HOUR WHILE I AM ON THE HIGHWAY WITH A ERROR MESSAGE FAIL SAVE MODE. MOST TIMES WHEN I SHUT OFF THE ENGINE AND RESTART IT TURNS OVER BUT DOESN'T STAY ON. TOTALLY UNSAFE FOR ME AND MY FAMILY. PLEASE RESEARCH AND RECALL WHAT THE ISSUE IS! THIS ISSUE HAS STARTED ABOUT 4 YEARS AFTER WE PURCHASED THE VEHICLE AND HAS BEEN HAPPENING MAYBE ONE TO TWO TIMES A MONTH SINCE.

FOR MANY TIME THAT MY EXPEDITION HAS STALLED BECAUSE OF THE THROTTLE BODY FAILING. THE ENGINE GOES INTO SAFE MODE AND STALLS AND STOPS, THI IS VERY DANGER SITUATION

TRANSMISSION BAD ,PAINT COME OUT SOME AREAS, REPLACE ALL THE SPARK PLUGS

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT THE AIR CONDITIONING UNIT FAILED AND EMITTED HOT AIR FROM THE VENTS WHEN ACTIVATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC SEVERAL TIMES WHERE THE BLENDER DOOR ACTUATOR, COMPRESSOR, AND CONTROL PANEL WERE REPLACED; HOWEVER, THE FAILURE RECURRED. THE MECHANIC STATED THAT THE FAILURE COULD NOT BE REMEDIED. THE MANUFACTURER STATED THAT THERE WERE NO RECALLS FOR THE VEHICLE. THE CONTACT WAS ALSO ADVISED THAT THE FAILURE COULD HAVE BEEN ATTRIBUTED TO THE CONTROL HEAD THAT WAS LOCATED BEHIND THE CONTROL PANEL. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 118,000.

I HAVE A 2005 FORD EXPEDITION AND HAVE MAINTAINED MY VEHICLE MAINTENANCE AND ONLY HAVE 124,000 MILES ON THIS VEHICLE. IT CONTINUES TO SHUT OFF THE ENGINE AND CODE FAIL SAFE MODE ON CODE APPEAR AND WHEN I'M DRIVING ON THE HIGHWAY IT IS DANGEROUS. AFTER READING SO MANY COMPLAINTS THIS IS UNSAFE. ALSO, THE COMPUTER ISSUES WITH LOCKING DOORS, FAILURE OF THE TRANSMISSION (WHICH I HAD TO REPLACE) SUCH A DISAPPOINTMENT OF A VEHICLE. FORD SHOULD RECALL ENGINE AND COMPUTER ISSUES. I PURCHASED THIS VEHICLE BRAND NEW $50,000 + AND HAVE NOT BE ABLE TO DEPEND ON THE STABILITY SINCE I'VE HAD IT.

MY FORD EXPEDITION, WHILE DRIVING AT 40 MILES AN HOUR LOST POWER. THIS IS THE 3RD TIME IN 2 YEARS IT HAS HAPPENED. ON THE INFO CENTER IT STATED ENGINE FAIL SAFE MODE. THE THREE TIMES IT HAS HAPPENED HAS BEEN ON BACK ROADS.I CONSIDER THIS A VERY UNSAFE CONDITION . MY DEALER LOOKED AT IT THE FIRST TWO TIMES AND SAID THERE WERE NO CODES, THAT I WOULD NEED TO BRING IT IN SOONER. BUT THERE ARE NO LASTING RESULTS, AND IT STARTS RIGHT BACK UP.

MY 15 YEAR OLD SON AND MY LIFE WERE PLACED IN SERIOUS DANGER, BY THE GROSS NEGLIGENCE AND DECEPTIVE BUSINESS PRACTICES PROMOTED BY THE FORD MOTOR COMPANY, REGARDING SCAN CODE P2106. SINCE AS EARLY AS FEBRUARY 26, 2013 FORD MOTOR COMPANY WAS MADE AWARE OF A DANGEROUS DEFECT CONCERNING THE MECHANICAL AND ELECTRICAL COMPONENTS OF THEIR MANUFACTURED PRODUCT RELEASED TO THE CONSUMER PUBLIC FOR PROFIT. THE VEHICLES ARE FORD TRUCKS, MANUFACTURED FROM 2003 - 2008, WITH THE V8 5.4 L ENGINE. PUBLIC RECORD REVEALS CASE NO. 12-7222, JASON SCHMIDT, (PLAINTIFF) VS. FORD MOTOR COMPANY, (DEFENDANT) FILED IN THE UNITED STATES DISTRICT COURT FOR THE EASTERN DISTRICT OF PENNSYLVANIA, THAT FORD MOTOR COMPANY IS WELL AWARE OF THIS ISSUE. I BELIEVE THAT FORD MOTOR COMPANY HAS MADE NO ATTEMPTS TO INFORM FORD DEALERSHIP OWNERS, THE FORD DEALERSHIP MANAGERS OR FORD SERVICE REPAIR SHOP MANAGERS AT THE FORD DEALERSHIPS AND CONSUMERS WHO HAD ALREADY PURCHASED THEIR MANUFACTURED PRODUCT OF THE ISSUE. THIS ISSUE IS VERY DANGEROUS, I WAS TRAVELING 70 MPH, WITH MY SON IN THE TRUCK. FORD MOTOR COMPANY HAS GONE ON RECORD, VIA TELEPHONE CONVERSATION, EXPLAINING TO ME THAT; "FORD MOTOR COMPANY HAS NO CONTROL OVER HOW INDIVIDUAL DEALERSHIPS FUNCTION OR OPERATE THEIR ESTABLISHMENT PLACES OF BUSINESS, SORRY. BUT I CAN TAKE A COMPLAINT AND BE SURE THAT THE DEALERSHIP RECEIVES IT AND PROVIDE YOU WITH A COMPLAINT NUMBER". FLAMMER FORD, SPRING HILL, FL REPLACED A PART AND NEGLECTED TO TEST DRIVE THE TRUCK, RELEASED THE VEHICLE TO ME AND THE PART REPLACED WAS NOT WHAT WAS WRONG WITH THE TRUCK. I HAD MY TRUCK TOWED TO AUTONATION FORD IN BROOKSVILLE, FL FOR THE SAME ISSUE (P2106 CODE), THEY DID THE SAME THING, WITHOUT REPLACING A THING. ONLY THIS TIME, WHILE DRIVING ON A HIGHWAY, MY TRUCK AND THE LOST ALL POWER. MY TRUCK IS BACK AT AUTONATION FORD IN NEED OF A NEW TRANSMISSION.

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION EQUIPPED WITH MICHELIN LTX M/S TIRES, SIZE: P265/70/R17 (NA). THE CONTACT STATED THAT ALL FOUR TIRES EXHIBITED CRACKS AND SEVERE OUTER TIRE TREAD SEPARATION. THE DEFECTIVE TIRES WERE NOT REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE TIRE AND VEHICLE FAILURE MILEAGE WAS 20,000.

WHILE MOVING IN TRAFFIC THE VEHICLE ENGINE CUT-OFF ON ITS OWN. MESSAGE CAME UP ON DASH DISPLAY, SOMETHING ABOUT "ELECT THROTTLE CONTROL". WAS MOVING VERY SLOWLY ON AN INTERSTATE HIGHWAY BAD TRAFFIC, WITH HEATERS (FRONT AND BACK) AND THE RADIO ON. I WAS ABLE TO COAST OFF TO THE SIDE OF THE HIGHWAY. TURNED OFF RADIO, HEATERS, THEN WAS ABLE TO RESTART THE VEHICLE. BATTERY CONDITION WAS FINE (REPLACED 2 YEARS AGO), NO OTHER WARNING. VEHICLE IS WELL-MAINTAINED, NEVER DRIVEN HARD OR USED FOR TOWING. TODAY I AM TAKING IT TO A FORD DEALER FOR EVALUATION.....UPDATED 08/25/15 *BF

SINCE PURCHASING THE EXPEDITION IN DECEMBER 2014, I'VE HAD SEVERAL INCIDENTS OF "CHECK ENGINE THROTTLE" WARNINGS AND THE ENGINE SHUT DOWN, SUDDENLY. THIS SEEMS TO ALSO HAVE A SECONDARY ISSUE OF THE TRUCK HESITATING/SPUTTERING AROUND 40-50MPH. THE VEHICLE HAS SHUT DOWN ON ME IN CITY TRAFFIC QUITE A FEW TIMES AND ONCE ON AN EXIT RAMP OF THE HIGHWAY. THIS IS A VERY DANGEROUS SITUATION TO EXPERIENCE. THE DEALER MENTIONED POSSIBLE SPARK PLUG ISSUES. WHEN THE "CHECK ENGINE" ICON FINALLY CAME ON, I HAD IT READ BY THE DEALER AND AN INDEPENDENT MECHANIC. THE CODE IS A P2104. THE DEALER NEVER GOT BACK TO ME ON A REMEDY FOR THIS. THE MECHANIC SAYS THE ELECTRONIC THROTTLE CONTROL MUST BE REPLACED AND COULD BE THE CAUSE OF BOTH ISSUES. BOTH HAVE BEEN REPORTED TO THE DEALER BEFORE THEIR WARRANTY EXPIRED. I'M FINDING THE REPAIR COULD COST ABOUT $700. AN ISSUE OF THE ENGINE SHUTTING OFF, REGARDLESS OF SPEED, WHILE DRIVING IS VERY DANGEROUS. THE TRUCK MUST BE PLACED IN PARK, TURNED OFF, THE RE-STARTED BEFORE CONTINUING MY DRIVE. THE SCARIEST WAS UPON AN EXIT RAMP OF THE HIGHWAY AT APPROXIMATELY 30MPH. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE THROTTLE BODY SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 121,800.

THIS IS THE 4TH TIME IN 5 WEEKS THAT MY CAR HAS SHUT DOWN WHILE DRIVING AND IT SAYS "ENGINE FAIL SAFE MODE". IT HAS BEEN IN THE SHOP AFTER THE FIRST 3 INCIDENTS AND DIFFERENT THINGS HAVE BEEN DONE TO IT. I JUST GOT IT OUT OF THE SHOP AND IT HAPPENED THE 4TH TIME. SO IT'S GOING BACK TO SHOP. I HAVE BEEN FORTUNATE, AND HAVE NOT BEEN IN A ACCIDENT AS A RESULT OF IT SHUTTING DOWN. LOOKING ONLINE IT'S AMAZING HOW MANY PEOPLE HAVE EXPERIENCED THIS SAME ISSUE. WHY HAS FORD OR NHTSA NOT DONE SOMETHING ABOUT THIS? WILL IT TAKE SOMEONE GETTING KILLED BEFORE THEY TAKE ACTION? *TR

RED LIGHT UP AHEAD. DRIVER SLOWING DOWN GIVING PLENTY OF SPACE. ENGINE STARTED REVVING AND VEHICLE STARTED SPEEDING UP. DRIVER PUSHED BRAKE AS HARD AS SHE COULD. VEHICLE WAS ALMOST STOPPED BEFORE ACCELERATION BUT ACCELERATED TO ABOUT 10 MPH AT THE TIME OF IMPACT. 2005 FORD EXPEDITION STRUCK REAR OF CAR WHICH WAS STOPPED AT THE RED LIGHT. DRIVER TOOK VEHICLE TO MECHANIC AT GAS STATION TO CHECK FOR MECHANICAL PROBLEM- NO DEFECT FOUND. *TR

THE DASH MESSAGE CENTER LIGHTS HAVE PROGRESSIVELY BEEN GETTING DIMMER TO THE POINT THE MILEAGE INFORMATION, DIRECTION OF TRAVEL AND TEMP ARE UNREADABLE IN DAYLIGHT HOURS. HOWEVER, AT NIGHT, WHEN THE AUTO LIGHTS TURN ON, THE MESSAGE CENTER IS QUITE CLEAR. *TR

WHILE DRIVING ALONG AT 55 MPH ENGINE SHUT DOWN. NO POWER BRAKES, STEERING, ETC. INDICATOR MESSAGE ON DASHBOARD SAID "CHECK ELECTRONIC IGNITION". REPAIR COST $ 724.19. *TR

WHILE DRIVING THE VEHICLE WENT INTO A HEAVY VIBRATION FROM THE MOTOR AND THE SMELL OF RAW FUEL WAS PRESENT. AFTER TURNING OFF THE VEHICLE IT WOULD NOT START. THE VEHICLE WAS TOWED TO THE FORD DEALER AND THE DEALER STATED THAT A FUEL INJECTOR BECAME STUCK OPEN. THE INJECTOR FILLED THE CYLINDER WITH FUEL AND CAUSED THE ENGINE TO BLOW UP (SEVERE DAMAGE). IT WAS FOUND THAT THIS OCCURRED ON FORD EXPEDITIONS NUMEROUS TIMES AND FORD EXTENDED THE WARRANTY TO 11 YEARS, 120,000 MILES AND MY SCARY EXPERIENCE OCCURRED AT 129,000. I PREVIOUSLY REPLACED THE MOTOR AT MY OWN EXPENSE 2 YEARS PRIOR AND FORD DID NOT REPLACE THE INJECTORS OR NOTIFY ME OF AN INJECTOR ISSUE. FORD IS STATING THAT THEY WILL NOT HONOR THE WARRANTY AND THE ENGINE DAMAGE WAS CAUSED BY THE INJECTOR THAT WAS NOT REPLACED. IT WAS FOUND THAT FORD WAS AWARE OF THE INJECTOR ISSUE SINCE 2007. I'M NOT SURE THESE ISSUE ARE GETTING REPORTED. *TR

VEHICLE CHECK ENGINE LIGHT STAYS ON. VEHICLE TURNS OFF WHEN SITTING IDLE. BROUGHT VEHICLE TO DEALERSHIP AND THEY SAID THEY FIXED IT, BUT AFTER LEAVING THE DEALERSHIP AND PAYING A LARGE BILL THE CHECK ENGINE LIGHT CAME BACK ON AND STILL CUTS OFF WHEN JUST SITTING IDLE IN "DRIVE". SCARED THAT THIS CAN CAUSE AN ACCIDENT IF SOMEONE BEHINDS ME DOESN'T REALIZE THAT MY VEHICLE CUTS OFF. *TR

I HAVE HAD AN ENGINE CHECK LIGHT AND NO ONE CAN FIND THE PROBLEM. SOME MECHANICS TELL ME ITS ONE THING AND THE OTHERS SOMETHING ELSE. TOOK TO A.V FORD AND QUICKLANE IN NORTH HOLLYWOOD. MY TRUCK STAYED SEVERAL DAYS AT SHOP AND STILL CANT FIND PROBLEM. MECHANIC EVEN CALLED DETROIT PLANT TO GET ADVISE. STILL NOT RESOLVED. PAID TOO MUCH JUST TRYING TO FIGURE THE PROBLEM. HAS THERE BEEN ANY ISSUES BROUGHT TO YOU ABOUT ENGINE LIGHT ON FOR FORD TRUCKS. I HAVE DOCUMENTS OF VISITS TO MECHANICS IF YOU GUYS NEED THEM. *TR

WHILE MOVING IN TRAFFIC THE VEHICLE ENGINE CUT-OFF ON ITS OWN. MESSAGE CAME UP ON DASH DISPLAY, SOMETHING ABOUT "ELECT THROTTLE CONTROL". WAS MOVING VERY SLOWLY ON AN INTERSTATE HIGHWAY BAD TRAFFIC, WITH HEATERS (FRONT AND BACK) AND THE RADIO ON. I WAS ABLE TO COAST OFF TO THE SIDE OF THE HIGHWAY. TURNED OFF RADIO, HEATERS, THEN WAS ABLE TO RESTART THE VEHICLE. BATTERY CONDITION WAS FINE (REPLACED 2 YEARS AGO), NO OTHER WARNING. VEHICLE IS WELL-MAINTAINED, NEVER DRIVEN HARD OR USED FOR TOWING. TODAY I AM TAKING IT TO A FORD DEALER FOR EVALUATION. *TR

FOR THE 3RD TIME IN THE PAST YEAR I AM DRIVING DOWN THE ROAD AT ABOUT 40 MPH - ENGINE LIGHTS COMES ON, MESSAGE "CHECK ELECTRONIC THROTTLE CONTROL" COMES ON - I HAVE NO POWER, I COAST TO THE SIDE LANE TURN ON HAZARD LIGHTS, TURN KEY TO OFF POSITION. RESTART THE CAR (TAKES A COUPLE OF TRIES) AND CONTINUE - THIS IS EXTREMELY DANGEROUS AND SHOULD BE ADDRESSED BY FORD ( I HAVE REPORTED THIS ISSUE) LOOKING ON LINE AND ON ONE SITE HTTP://WWW.CARCOMPLAINTS.COM/FORD/EXPEDITION/2005/ENGINE/VEHICLE_SPEED_CONTROL.SHTML THERE ARE 52 COMPLAINTS WITH THE SAME ISSUE. THERE ARE MANY OTHER SITES REPORTING THE SAME EXACT PROBLEM. I AM TAKING MY VEHICLE TO THE DEALER TOMORROW - WHAT ELSE SHOULD I BE DOING TO RESOLVE THIS ISSUE. - IT'S APPARENT THAT MANY OTHER PEOPLE ARE HAVING THIS SAME EXACT ISSUE- DOES IT TAKE SOMEONE DYING TO GET THE CAR MANUFACTURERS TO LISTEN TO THEIR CUSTOMERS? *TR

WE WERE SITTING IN TRAFFIC AND WERE REAR-ENDED AT MILEAGE SPEED AND CRASHED INTO THE VEHICLE IN FRONT OF US. THE AIR BAGS DID NOT OPEN. *TR

WHILE DRIVING ON THE HIGHWAY THE CAR COMPLETELY SHUT DOWN. ALL LIGHTS ON DASH LIT UP, RADIO WENT OFF. SECONDS LATER THE CAR RESTATED ITSELF AND THE RADIO WENT BACK ON. THIS HAPPENED TWICE ON 10/20/2014 AND ONCE ABOUT TWO WEEKS BEFORE THAT.. NO WARNING LIGHTS COME ON, NO BUMPS THE ROAD WAS SMOOTH, NO RAIN PUDDLES. IT JUST DIES AND RESTARTS ITSELF EACH TIME. FOR ABOUT 6 MONTHS NOW THE CAR DIES COMPLETELY WHEN I AM BACKING UP EVERY NOW AND THEN NOT EACH TIME. WE HAD 5 PEOPLE IN THE CAR AND GOT VERY SCARED. I HAVE HAD LOTS OF WORK DONE TO THE CAR AND HAVE RECEIPTS. MECHANIC SAID IT SOUNDS LIKE RAN ELECTRICS PROBLEM THAT COULD BE ONE OF A HUNDRED THINGS. PLEASE HELP WITH A SOLUTION. *TR

PAINT ON TAILGATE IS PEELING AND BUBBLING. *TR

PAINT IS CRACKING. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH, THE VEHICLE STALLED WITHOUT WARNING. ADDITIONALLY AFTER RESTARTING THE VEHICLE, THE ELECTRONIC THROTTLE CONTROL WARNING LIGHT ILLUMINATED. THE FAILURE OCCURRED ON TWO OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 103,000.

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT THE DRIVER CRASHED INTO ANOTHER VEHICLE THAT WAS PARKED. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC AND THE CONTACT WAS INFORMED THAT THE FRONT RADIATOR HAD BECOME ROTTEN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 72,000.

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION EQUIPPED WITH MIRADA, TIRE LINE: CROSS TOUR SLX, TIRE SIZE: 265/70R17, AND DOT NUMBER: CC70-V2L3011 TIRES. THE CONTACT STATED THAT THE PASSENGER SIDE REAR AND DRIVER SIDE REAR TIRES BOTH EXPERIENCED SEVERE SIDE WALL CRACKING AND SEPARATION. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12T014000 (TIRES). THE FAILURE TIRE AND VEHICLE MILEAGE WAS 68,550.

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING ON AN INCLINE, THE VEHICLE STALLED AND THE ELECTRONIC THROTTLE CONTROL INDICATOR ILLUMINATED. THE ENGINE RESUMED NORMAL OPERATION AFTER THE VEHICLE WAS RESTARTED. THE FAILURE OCCURRED SEVERAL TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 68,000.

ACCELERATED ENGINE TO PASS, ENGINE COUGHED AND HEAVED. THE RPM CLIMBED BUT VEHICLE ACTED LIKE IT WAS DYING. CAR EVENTUALLY DIED. TURNED CAR OFF RE- STARTED IT. CHK ENGINE LIGHT CAME ON. ENGINE RAN ROUGH WANTED TO RAMP UP IN RPMS BUT STILL ACTED LIKE IT WAS GOING TO DIE. (THIS IS NOT THE FIRST TIME, IT IS VERY INTERMITTENT) THE LAST TIME IT SEEMED SERIOUS AND CONTINUOUS THEY CHANGED THE TRANSMISSION. THE PROBLEM DID NOT LEAVE. I READ NUMEROUS POST ON THE WEB SITE AS THE PROBLEM CONTINUES TO COME BACK. NEVER SHOWING CODES. JUST RUNS LIKE CRAP. NUMEROUS IDENTICAL PROBLEMS ON THE INTERNET. BOUGHT A NEW MAF. NO HELP. REPLACED COIL PACKS NO HELP. CHECKED AND CLEANED VCT SOLENOIDS. NO HELP. REPLACED CAMSHAFT POSITION SENSOR. NO HELP. NO CHK ENG LIGHTS. WILL NOT EXCEED 3500 RPM. *TR

I WAS DRIVING MY 2005 FORD EXPEDITION WEST ON EISENHOWER BLVD AT ABOUT 25 MPH. I PROCEEDED THROUGH THE INTERSECTION OF EISENHOWER AND CLEVELAND AVE WHEN A PICK-UP TRUCK RAN A RED LIGHT AND COLLIDED WITH THE RIGHT FRONT OF MY VEHICLE. MY VEHICLE SUSTAINED EXTENSIVE DAMAGE TO THE FRONT BUMPER, RIGHT FRONT FENDER AND FRONT PASSENGER DOOR, COMPLETELY DISLODGING THE RIGHT FRONT WHEEL AND BUCKLING THE FRAME OF THE VEHICLE. I SUSTAINED INJURIES, INCLUDING A BRUISED STERNUM AND BRUISED LUNGS. NEITHER FRONT AIRBAG DEPLOYED, WHICH WOULD HAVE MITIGATED MY INJURIES!

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE BRAKES WERE ENGAGED BUT FAILED TO STOP THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 183,797.

I WAS DRIVING MY 2005 FORD EXPEDITION AT 25MPH AND CAME TO A STOP LIGHT. I STOPPED. I TRIED TO ACCELERATE BUT I COULDN'T. MY RPM WHERE MOVING BUT CAR WOULD NOT. THEN THE CHECK ELECTRIC THROTTLE CONTROL MESSAGE POPPED ON. CAR FINALLY STARTED TO ACCELERATE BUT DIED OUT. IT THEN RESTARTED AND DROVE NORMALLY FOR 4 BLOCKS, BEFORE NOT ACCELERATING AT ALL. HAD TO BE TOWED TO FORD DEALER. THIS NEEDS TO BE RECALLED. *TR

ELECTRONIC THROTTLE CONTROL HELP, I HAVE A 2005 EXPEDITION,. THE THING HAS JUST STARTED SHUTTING DOWN ON ME WHILE DRIVING. FOR NO APPARENT REASON, WHILE DRIVING ALONG, IT STOPS RUNNING, AND AFTER SHUTTING IT OFF, PLACING IT IN PARK, IT WILL START BACK UP. IT WAS SO SCARY , THANKS GOD I DIDN'T HAD ANY ACCIDENT ,THIS IS A BIG ISSUE FROM FORD *JS

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE SPUTTERED WHEN THE ACCELERATOR PEDAL WAS APPLIED AND THEN STALLED WITH THE ILLUMINATION OF THE ENGINE FAIL SAFE LIGHT. THE VEHICLE WAS ABLE TO BE RESTARTED AFTER SEVERAL ATTEMPTS AND WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE ELECTRONIC THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, HOWEVER THE VEHICLE STILL SPUTTERED INTERMITTENTLY. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 155,000.

DRIVING UP A SMALL INCLINE AND THE VEHICLE LOST POWER. I HAD ELECTRICAL POWER JUST NO FUEL GETTING TO THE ENGINE. I WAS ABLE TO PULL OFF TO THE SIDE OF THE ROAD. THE FUEL TANK WAS JUST BELOW A 1/4 TANK. ADD A GALLON OF GAS AND TRIED TO RESTART THE CAR. IT WOULD NOT RESTART. CALLED FOR THE TOW TRUCK TO TAKE TO THE GARAGE. THE GARAGE HAD TO DROP THE FUEL TANK AND TOLD ME THE FUEL PUMP CONTROL MODULE WAS BAD. THEY HANDED ME THE MODULE UPON PICKING UP MY VEHICLE AND I CAN TELL YOU WHY THE MODULE WENT BAD. IT HAS A HOLE IN IT FROM CORROSION. I HAVE SAID MODULE IF ANYONE FROM FORD OR NHTSA WOULD LIKE TO EXAMINE THE MODULE. *TR

THE REPORTED MODEL WAS CRUISING AT 65 MILES AN HOUR ALONG NORTH BOUND I-795 @ NC RTE 42, WILSON, NC (STATE POLICE RESPONDED TO THIS DISABLED VEHICLE CALL) VEHICLE ACTED LIKE IT RAN OUT OF GAS. ELECTRICAL PROVEOUT INDICATORS WERE NORMAL. IGNITION SYSTEM WAS FUNCTIONAL, AS WERE ALL OTHER FACETS OF THE ELECTRICAL SYSTEM SEEMED FINE DURING THE ENGINE POWER FAILURE, HOWEVER , LOSS OF STEERING POWER AND BRAKING POWER WAS EVIDENT AND PROMINENT. AFTER SAFELY COASTING OFF ONTO THE SHOULDER JUST PAST THE SAID INTERSECTION THE VEHICLE WOULD NOT START AND WAS TOWED TO A REPAIR FACILITY. A FINAL DIAGNOSIS WAS PERFORMED AND WAS DETERMINED OF A RELAY CONTACT FAILURE. THIS RELAY IS AN INTEGRAL PART OF THE MAIN POWER DISTRIBUTION PANEL / FUSE BLOCK RIGHT OF THE PASSENGER FOOT WELL. MAKING THIS PART INTEGRAL TO THE POWER BLOCK MAKES IT EXTREMELY EXPENSIVE TO REPAIR AND MAKES THE VEHICLE UNSAFE AS FAR AS A REASONABLE REPAIR TO A CRITICAL SYSTEM AND PLACES OTHER SYSTEMS AT RISK BY THE NATURE OF REPLACING THE ENTIRE POWER BLOCK TO REPAIR THE PROBLEM.. IE: THE FUEL PUMP. WHEN THIS RELAY CONTACT FAILS, POWER IS LOST TO THE FUEL PUMP DRIVER MODULE LOCATED UNDER THE DRIVER'S REAR WHEEL WELL. THIS MODULE SUPPLY POWER TO THE FUEL PUMP MOTOR IN THE FUEL TANK. THE FUEL PUMP CONTROL MODULE ITSELF SHOULD BE SCRUTINIZED HENCE IT'S LOCATION MAKES IT VULNERABLE TO WEATHER AND QUICK CORROSION. *TR

WHILE SETTING AT A STOP LIGHT A WARNING MESSAGE CAME ON ABOUT CHECKING ELECTRONIC THROTTLE CONTROL. WHEN I RELEASE THE BRAKE TO ACCELERATE WHEN THE LIGHT TURNED GREEN I COASTED INTO THE INTERSECTION ONLY TO FIND THAT THE ACCELERATOR PEDDLE HAD NO RESPONSE. FORTUNATELY THE ENGINE IDLE WAS ENOUGH TO GET ME THROUGH THE INTERSECTION BEFORE THE LIGHT TURNED RED. I THEN COASTED TO THE NEAREST PARKING LOT AND SHUT THE ENGINE OFF. RESTARTED THE VEHICLE WITH NO CHANGE IN ACCELERATOR PEDDLE RESPONSE. AFTER DOING RESEARCH AND SEEING NUMEROUS PROBLEMS WITH THIS SAME ISSUE I SEE I WAS FORTUNATE TO HAVE NOT BEEN DRIVING AT HIGHWAY SPEEDS WHEN THIS ISSUE HAPPEN. FORD NEEDS TO RECALL AND FIX THIS ISSUE BEFORE SOMEONE GETS KILLED WHEN THEIR VEHICLE JUST QUITS WORKING. *TR

I HAVE TALKED TO A FEW OTHER OWNERS OF FORD EXPEDITIONS (LATER MODELS 2004-2008) AND THERE IS A DEFINITE ISSUE WITH RUST AND OTHER COMPONENTS RUSTING OUT. IT SEEMS TO BE A SERIOUS ISSUE WITH RUST ESP WHEN THE BRAKE LINES ARE BASICALLY ALL RUSTED OUT IN THE FRONT OF THE VEHICLE. ALSO THE CROSS MEMBER FRAME UNDERNEATH HAS A LOT MORE THAN ACCEPTABLE AMOUNT OF RUST, NEVER SEEN THIS MUCH EVEN WITH A TRUCK I HAVE NOW A 1997 DODGE WITH 190,000 MILES DOESN'T EVEN COME CLOSE TO THE RUST I SEE WITH THE FORD. RUST BUBBLES ON THE REAR LIFT GATE HANDLE AREA AND JUST ABOUT ALL AROUND THE WINDOW AREAS AND THE HOOD. MIND YOU THAT THE TIME WE'VE HAD THE VEHICLE ONLY MAYBE A HANDFUL OF TIMES IT WAS OUT IN SNOW OR EVEN RAINY WEATHER - LOW MILES FOR THE YEAR 67,000/8 YEARS+. THE LINES AND RUST REPAIR WILL COST MONEY $$ TO FIX I BELIEVE THAT FORD KNOWS THERE'S AN ISSUE AND STIFFS THE CONSUMER KNOWING THAT THE MATERIALS RUST OUT CAUSING A VERY UNSAFE VEHICLE TO DRIVE. ANYBODY FOR A CLASS ACTION LAWSUIT HERE? *TR

I HAVE A 2005 FORD EXPEDITION WITH ADJUSTABLE HEIGHT OF THE BRAKE PEDDLE. THE ADJUSTMENT DOES NOT WORK AND THE HEIGHT OF THE BRAKE PEDDLE IS AT A HEIGHT THAT WHEN THE BRAKE IS DEPRESSED IT IS ALSO POSSIBLE THAT THE ACCELERATOR IS ALSO DEPRESSED CAUSING UNEXPECTED ACCELERATION. I HAVE CONTACTED MY LOCAL DEALER AND WWW.FORD.COM ABOUT THIS SAFETY ISSUE AND BOTH HAVE TOLD ME THAT THERE IS NO RECALL AND THAT THEY WILL NOT FIX OR ASSIST ME ON THIS. I BELIEVE THAT THE SUDDEN ACCELERATION IS A SERIOUS SAFETY CONCERN AND SHOULD BE ADDRESSED BY NHTSA. *TR

AFTER STOPPING AT A TRAFFIC SIGNAL, THE ENGINE BEGAN TO ACCELERATE WITHOUT THE PEDAL BEING PUSHED. THE FOOT BRAKE WAS APPLIED WITH INCREASING FORCE TO STOP THE VEHICLE FROM GOING INTO THE INTERSECTION. THIS SLOWED THE FORWARD MOVEMENT OF THE VEHICLE DOWN, BUT DIDN'T STOP IT UNTIL THE IGNITION WAS TURNED OFF. THE VEHICLE WAS RESTARTED WITHIN TWO MINUTES AND OPERATED NORMALLY. THIS IS ONE OF THOSE VERY DANGEROUS PROBLEMS THAT CAN CAUSE ACCIDENTS AND GET PEOPLE KILLED. THIS ELECTRONIC THROTTLE CONTROL/BODY NEEDS TO BE RE-ENGINEERED AND A RECALL ISSUED FOR THIS PRODUCT. TOO MANY ISSUES WITH THIS NOT TO IGNORE IT. *TR

VEHICLE DIED UNEXPECTEDLY WHILE TRAVELING DOWN HIGHWAY AT A HIGH RATE OF SPEED. THERE ARE HUNDREDS OF COMPLAINTS JUST LIKE THIS ON HERE. IF A RECALL ISN'T IN ORDER PEOPLE WILL DIE AND THE LAWSUITS WILL BEGIN. IT'S OBVIOUSLY A MAJOR MECHANICAL PROBLEM. FORD AND THE NHTSA SHOULD BE LIABLE. THIS IS SERIOUS AND READING THROUGH ALL OF THESE COMPLAINTS IT DOESN'T SEEM LIKE THE NHTSA IS DOING THEIR JOB. *TR

WHILE DRIVING HOME DOWN A SLIGHT DECLINE, I HEARD A BEEP AND THE MESSAGE ON THE DASH READ (CHECK ELECTRONIC THROTTLE CONTROL) WHICH I THEN MENTALLY ADDED TO MY LIST OF THINGS TO DO. NOT UNTIL A NEEDED TO START ACCELERATING AGAIN DID I REALIZE THAT MY THROTTLE WAS COMPLETELY INOPERABLE. LUCKILY, A WORD USED FREQUENTLY BY OTHER OWNERS TO DESCRIBE THIS SAME ISSUE, I WAS ABLE TO COAST TO A STOP WHILE OTHER VEHICLES WENT AROUND ME. TURNING OFF THE VEHICLE AND RESTARTING IT SEEMED TO "RESET" THE THROTTLE CONTROL. I DO NOT TRUST THAT IT WILL BE SAFE TO USE, PARTICULARLY WITH THE WINTER DRIVING CONDITIONS THAT I ENCOUNTER. I HAVE AN APPOINTMENT SCHEDULED FOR MONDAY. WITH ALL THE COMPLAINTS I HAVE SEEN REGARDING THIS SAME ISSUE, I AM SHOCKED THAT MORE ACTION (RECALL) HAS NOT BEEN TAKEN. DOES A CRASH, FIRE, INJURY, OR FATALITY NEED TO OCCUR BEFORE THIS CAN BE TAKEN SERIOUSLY? I AM BAFFLED THAT A WARNING MESSAGE CANNOT BE DISPLAYED IN ADVANCE OF COMPLETE THROTTLE FAILURE CONSIDERING THE POTENTIAL CATASTROPHIC OUTCOMES. THIS VEHICLE WAS INSPECTED/SERVICED NOVEMBER 2013. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE WRENCH ICON ILLUMINATED AFTER THE FAILURE OCCURRED. THE CONTACT COASTED ONTO THE SHOULDER AND WAS ABLE TO RESTART THE ENGINE. THE VEHICLE WAS LATER TAKEN TO THE DEALER, WHO PERFORMED A DIAGNOSTIC AND LOCATED THE FAILURE AT THE THROTTLE. THE THROTTLE WAS REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 117,000.

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE TRAVELING 60 MPH, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE DRIVER FUEL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 108,000.

I WAS DRIVING MY 2005 FORD EXPEDITION EDDIE BAUER EDITION WHEN I STARTED TO MAKE A TURN. SUDDENLY THE VEHICLE STOPPED MOVING AND AN INDICATOR LIGHT STATING "ENGINE FAIL SAFE MODE" CAME ON. DURING THE TURN, A VEHICLE WAS COMING TOWARD ME AND I BARELY HAD ENOUGH TIME TO GET MY VEHICLE OUT OF THE LANE BEFORE I GOT HIT. I HAD TO STOP MY VEHICLE, PUT IT IN PARK (WHILE SITTING ON THE ROADWAY), SHUT IT OFF, AND RESTART IT BEFORE I COULD MOVE AGAIN. IT RAN FINE FOR A COUPLE OF DAYS AND THEN IT HAPPENED TO ME AGAIN WHILE DRIVING. THIS IS A VERY DANGEROUS SITUATION THAT SHOULD BE LOOKED INTO AND AFTER CHECKING THE INTERNET IT SEEMS THERE ARE LOTS OF PEOPLE WITH THE SAME EXPERIENCES. I TOOK MY VEHICLE TO THE SHOP AND THEY TOLD ME IT WAS THE THROTTLE BODY. AFTER SPENDING $409.00 (BECAUSE OF COURSE IT WAS NOT COVERED BY MY WARRANTY) TO REPAIR IT HOPEFULLY THE PROBLEM MAY BE FIXED. I FIGURED SPENDING THE MONEY WAS BETTER THAN THE OPTION OF POSSIBLY GETTING IN A SERIOUS ACCIDENT AND BEING KILLED IF THE PROBLEM WAS NOT FIXED. SOMEBODY NEEDS TO LOOK INTO THIS PROBLEM WITH THE VEHICLE AND MAKE FORD RESPONSIBLE FOR COSTS SINCE IT IS OBVIOUSLY A DEFECT IN THE VEHICLE. *TR

WHILE DRIVING 55MPH ON INTERSTATE 95 IN PHILADELPHIA, PA WITH MY WIFE AND 2 CHILDREN THE VEHICLE STOPPED RUNNING AND I WAS DANGEROUSLY STALLED IN THE MIDDLE OF INTERSTATE 95. THE CHECK ENGINE LIGHT CAME ON AND CHECK ELECTRONIC THROTTLE MESSAGE CAME ON. THIS IS A FAMILY VEHICLE AND MY WIFE AND I REFUSE TO DRIVE IT NOW IN FEAR OF THIS INCIDENT OCCURRING AGAIN RESULTING IN DEATH OR SERIOUS INJURY. BASED UPON MY RESEARCH, IT APPEARS TO BE A WELL KNOWN PROBLEM THAT OCCURRED TO THOUSANDS OF FORD EXPEDITION OWNERS. I WOULD APPRECIATE THE PROBLEM BEING ADDRESSED EXPEDITIOUSLY BEFORE PEOPLE ARE KILLED AND/OR INJURED. *TR

DRIVING ON HIGHWAY AT ABOUT 60 MPH CHANGING LANES AND A ODB MESSAGE APPEARS "CHECK ELECTRONIC THROTTLE CONTROL" AND THE CAR JUST SHUTS DOWN. IT WAS A LIFE THREATENING MOMENT FOR MY FAMILY AND I AS A TRUCK THAT WAS ON COMING FROM BEHIND WITH SPEED HAD TO SLAM ON THE BRAKES IN ORDER NOT TO COLLIDE WITH ME SINCE I HAD NO POWER TO ACCELERATE. I WAS ONLY FORTUNATE THAT THE TRUCK HAD A CLEAR LANE TO CHANGE INTO ABRUPTLY. THE ELECTRONIC THROTTLE MESSAGE AFTER FURTHER RESEARCH IS A WIDE SPREAD KNOW ISSUE AMONG FORD CARS AND I AM LIVID AND VERY ANGRY THAT THE NHTSA HAS NOT ISSUED A RECALL ON THIS KNOW ISSUE AS IT IS PUBLIC KNOWLEDGE ONLINE. THIS NEEDS TO BE ADDRESSED IMMEDIATELY TO AVOID ANY POTENTIAL FUTURE TRAGEDIES. I HOPE FORD DOES NOT WANT BLOOD ON THERE HANDS! *TR

I HAVE SIX KIDS AND WHEN YOUR DRIVING AND YOUR CAR SHUTS OFF GOING 50-60 MILES AN HOURS AND GIVES YOU A MESSAGE FAIL SAFE MESSAGE, THAT'S PRETTY SCARY. I FIXED THE THROTTLE BODY SENSOR ONCE AND NOW HAVE ISSUES WITH THE SAME ISSUE. I HAVE LOOKED INTO THIS AND SURPRISED THAT THERE ARE NOT RECALLS. THIS IS ONE EXPENSIVE FIX. *TR

MY MOTHER HAD MY CAR WHEN THIS OCCURRED AND THE INCIDENT AND SUBSEQUENT RESEARCH SHOWING A DANGEROUS PATTERN AND NO RECALL OF THIS ISSUE HAS ME VERY CONCERNED. WHILE AT A RED LIGHT, THE ENGINE FAILSAFE MESSAGE FLASHED ACROSS THE DASH WITH THE ENGINE LIGHT ON WHILE MAKING LOUD ALERT BEEPS. THE ENGINE WAS STILL RUNNING BUT THE CAR WOULD NOT GO. MY MOTHER PUT IT IN PARK AND SHUT THE ENGINE OFF. SHE WAS ABLE TO RESTART THE CAR AND DRIVE WITH NO ISSUES. MY CONCERN DOING RESEARCH ON THIS ISSUE IS THAT THIS CAN OCCUR WHILE IN MOTION. IF THIS HAD HAPPENED A MINUTE EARLIER OR LATER, IT COULD HAVE RESULTED IN VERY SERIOUS ACCIDENTS DURING HIGH SPEEDS OR LEFT TURNS. I AM NOW ALMOST FEARFUL FOR MYSELF AND OTHERS TO DRIVE THIS CAR. *TR

I WAS DRIVING WITH 4 KIDS IN THE CAR, WHEN ALL THE SUDDEN MY CAR TURNED OFF, ALL THE LIGHTS CAME ON THE DASH. LUCKILY I WAS ABLE TO MOVE OVER TO A PARKING LOT. I TURNED THE CAR OFF, TURNED BACK ON, NOTHING. TRIED AGAIN AND IT WORKED. I WAS ABLE TO DRIVE 50 MILES HOME AND AS I WAS TURNING IN MY DRIVEWAY IT HAPPENED AGAIN. *TR

DRIVING ON I-75 AT 78 MPH MY CAR JUST SHUT OFF. I HAD NO POWER AND NEARLY WAS INVOLVED IN A 18 WHEELER HITTING ME. THE "CHECK ELECTRONIC THROTTLE CONTROL" WARNING LIGHT CAME ON BUT AFTER THE ENGINE QUIT. ONCE I CALMED DOWN THE CAR STARTED RIGHT BACK UP. I JUST HAD MY SECOND ISSUE WITH THE SAME WARNING LIGHT AND ENGINE POWER SHUTTING OFF. I HAD TO COAST THROUGH A VERY BUSY INTERSECTION. THEN THE CAR STARTED RIGHT BACK UP. THIS IS A VERY SERIOUS PROBLEM ON MORE THAN A FEW EXPEDITIONS AND SOMEONE IS GOING TO GET KILLED IF THE ISSUES ARE NOT RESOLVED. FORD MOTOR COMPANY REFUSES TO HELP.... *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THAT THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 149,000. *TR

REAR DRIVER SIDE PASSENGER WINDOW WENT DOWN BY ITSELF AND THERE IS NO WAY TO SEND IT UP. IS STUCK OPEN. I AM REPORTING BECAUSE I FOUND MORE THAN 20 FORUMS ONLINE WITH HUNDREDS OF REPORTED COMPLAINTS ON THE SAME ISSUE AND I DON'T SEE THE NECESSARY RECALL ON THIS ITEM. *TR

VEHICLE STOPPED RUNNING WHILE MAKING LEFT TURN AT INTERSECTION, VEHICLE STOPPED RUNNING WHILE AT STOP LIGHT, VEHICLE STOPPED RUNNING WHILE ON INTERSTATE HWY AT HIGHWAY SPEEDS. ALL THIS HAS HAPPENED MORE THAN 20 TIMES. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE CAUGHT ON FIRE. THE FIRE STARTED FROM UNDER THE REAR SEAT OF THE VEHICLE. THE VEHICLE WAS DESTROYED IN THE FIRE. A POLICE REPORT WAS FILED. THE CONTACT STATED THAT HIS MECHANIC BELIEVED THAT A FAILED CATALYTIC CONVERTER COULD HAVE POTENTIALLY CAUSED THE FIRE. THE FAILURE AND THE CURRENT MILEAGE WAS 98,300. *TR

I WAS DRIVING ON THE FREEWAY AT 60MPH AND THE ENGINE SHUT DOWN AND SHOWED "CHECK ELECTRIC THROTTLE CONTROL". I WAS NOT ABLE TO PULL TO THE SIDE. THE TRUCK WORKED FINE AFTER I RESTARTED IT. THIS HAS HAPPENED 5 TIMES. WE WERE LUCKY THAT NOBODY HIT US ON THE FREEWAY. THROTTLE BODY NEEDS TO BE REPLACED. 3 DIFFERENT MECHANICS AND 1 ELECTRICIAN SAID THIS A DEFECT AND THEY SEE IT ALL THE TIME WITH THIS ENGINE. *TR

WAS DRIVING WHEN CHECK ELECTRONIC CONTROL SENSOR CAME ON AND WITH OUT WARNING VEHICLE DIED IN MIDDLE OF ROAD. *TR

WHILE TRAVELING AT 60 MPH, RIGHT REAR TIRE FAILED TO HOLD TOGETHER. A "THUMPING" SOUND WAS HEAD JUST PRIOR TO THE TIRE EXPLODING. DIVER MAINTAINED CONTROL AFTER HITTING THE RETAINING WALL ALONG THE FREEWAY. VEHILE IMPACTED RATAINING WALL ONCE, THEN SPUN AND INPACTED IT AGAIN TOTALING THE VEHICLE AFTER AIRBAGS DEPLOYED. UPON THE ON SCENE INSPECTION, IT HAS BEEN DETERMINED THAT THE TIRE SEPARATED AND LOST ALL TREAD. NO DEATHS HAPPENED AS A RESULT OF THE DRIVER NOT PANICING AND MAINTAINING WHAT CONTROL SHE WAS ABLE TO. TIRE WAS A CONTINENTAL CONTITRAC SUV. *TR

TL* THE CONTACT OWNS A 2007 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS ADVISED THAT THE FUEL PUMP HAD FAILED. THE CONTACT WAS INFORMED BY THE DEALER THAT THE REPAIR WOULD TAKE THREE MONTHS BECAUSE THE FUEL PUMP WAS ON BACK ORDER AND THERE WAS NO AFTER MARKET FUEL PUMP THAT WOULD WORK ON THE 2005 MODEL YEAR. THE FAILURE AND THE CURRENT MILEAGES WERE 74,000 *TR

I WAS DRIVING DOWN THE HIGHWAY GOING 65 & MY TRUCK COMPLETELY SHUT DOWN WAS ALMOST HIT BY A SEMI. A WRENCH SIGN CAME ON, I PUT IT IN PARK & SHUT IT OFF & STARTED IT BACK UP. THIS HAPPENS ALL THE TIME. I BELIEVE SOMETHING SHOULD BE DONE BEFORE SOMEONE GETS KILLED,FROM WHAT IM READING ITS HAPPENS TO ALOT OF OWNERS. SO PLEASE FOR OUR SAFETY DO SOMETHING DON'T WAIT TILL ITS TO LATE. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE VEHICLE STALLED AND THE ENGINE FAIL SAFE MODE WARNING MESSAGE ILLUMINATED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 125,000. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE WINDOW FELL DOWN AND WOULD NOT CLOSE. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER OR MECHANIC. THE FAILURE AND CURRENT MILEAGES WERE 100,000. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE ENGINE SHOOK. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE VARIABLE CAM TIMING PHASER HAD FAILED AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 130,000.

GETTING ON FREEWAY AN AUDIBLE BIP AND A WARNING CAME ON SCREEN INDICATING TO CHECK ELECTRIC THROTTLE AND A FEW SECONDS LATER THE ENGINE DIED. EXTREMELY DANGEROUS. HAD KIDS IN CAR. THIS SHOULD BE A MATTER FOR RECALL. *TR

FAILURE OF CAM SHAFT AND VALVE, LIFTER PARTS ASSOCIATED WITH THE RIGHT SIDE OF THIS 5.4L ENGINE. MOST LIKELY DUE TO VARIABLE CAM TIMING UNITS. 5.4 L ENGINE IN 2005 EXPEDITION, FIRST PLACED IN SERVICE IN DECEMBER 2004. RIGHT SIDE OF ENGINE BEGAN MAKING A TICKING NOISE WITHIN 30,000 MILES. DEALER SERVICE STATED TICKING NOISE IS NORMAL, NO ISSUES. NOISE CONTINUED. NOISE RECENTLY BECAME WORSE. RIGHT SIDE OF ENGINE. MILEAGE FOR VEHICLE IS AT 142,000 MILES. INDEPENDENT MECHANIC STATES HYDRAULIC LIFTER ISSUE, CAM SHAFT IS BAD. $1,200+ REPAIR. DOING RESEARCH ON VARIOUS CAR SITES REVEALS MANY ISSUES SIMILAR TO THIS WITH THE 5.4L FORD ENGINE. ISSUES STATED DEALT WITH: DEFECTIVE CYLINDER HEADS, FAILING CAM PHASERS, CAMSHAFT BEARINGS FAILING, FAILED CAM SOLENOIDS, THRUST BEARING FAILURE, VARIABLE CAM TIMING (VCT) FAILURE AND CAM SHAFT FAILURE DUE TO OTHER PARTS. THIS DEFECT SEEMS TO BE COVERED IN A TB PUT OUT BY FORD (TSB 05-15-8), BUT DID NOT INVOLVE A RECALL. THIS ISSUE HAS AFFECTED 100'S IF NOT 10,000'S OF EXPEDITION OWNERS. INITIATE AN INVESTIGATION AND I BELIEVE THAT YOU WILL AGREE FORD SHOULD ISSUE A RECALL TO REPAIR OR REPLACE. *TR

WE HAVE HAD THREE INCIDENTS OF UNEXPECTED ACCELERATION ON OUR FORD EXPEDITION. ONCE WITH MY DAUGHTER AND THREE GRANDCHILDREN AND TWICE WITH MYSELF. I HAVE CONTACTED FORD AND THEY SAY THERE IS NO KNOWN VEHICLE PROBLEM AND ONLY OFFERED TO HAVE IT TOWED TO A FORD DEALER AND I WILL BE RESPONSIBLE FOR THE COST OF THE REPAIR. IF FORD IS CORRECT AND THERE IS NO KNOWN PROBLEM, THEN WHY WOULD FORD BE WILLING TO PAY THE COST OF TOWING THE VEHICLE TO A DEALERSHIP? I SPOKE WITH FORD CUSTOMER SERVICE ON MARCH 5TH AND TODAY APRIL 1ST. [XXX] A FORD CUSTOMER SERVICE MANAGER STATED THE ABOVE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE ENGINE JUST STALLED AND THE MESSAGE "ENGINE FAIL SAFE MODE" APPEARED. LUCKILY WE WERE RIGHT AT A PARKING LOT THAT WE ROLLED INTO WITH MY HUSBAND STEERING. WE HAD JUST PULLED OFF THE INTERSTATE TRAVELING 65 MPH. IT COULD HAVE RESULTED IN INJURIES AND/OR DEATH. FORD SHOULD FIX THIS PROBLEM. *TR

WHILE DRIVING AT 40 MPH ENGINE STOPPED WORKING MAKING BRAKES AND STEERING FAIL. LIMPED OFF BUSY ROAD LUCKILY! ENGINE LIGHT SHOWED ELECTRONIC THROTTLE FAILURE. NOW CHECK ENGINE LIGHT IS ON. GOING TO DEALERS FOR REPAIR TODAY-SINCE THIS IS AN OBVIOUS PROBLEM FOR FORD WHY HAVEN'T THEY ADDRESSED IT! COULD BE DEADLY IF FAILS IN HEAVY TRAFFIC CONDITIONS. *TR

ENGINE SHUTS OFF WHILE DRIVING. *TR

WHILE I WAS DRIVING DONE THE INTERSTATE, MY FORD EXPEDITION LOST ALL POWER AND COMPLETELY STALLED. LUCKILY, I WAS ABLE TO GET IT OFF THE ROAD TO THE SHOULDER WITHOUT ANY INCIDENT. THIS IS THE THIRD TIME IT HAS HAPPENED TO ME. PREVIOUSLY, I HAD MY FUEL PUMP SENSOR CHANGED BECAUSE MY CHECK ENGINE LIGHT CAME ON AND THAT IS WHAT IT INDICATED; HOWEVER, THE PROBLEM STILL EXITS AND MY MECHANICS ARE BAFFLED. VERY DANGEROUS! *TR

DRIVING IN CITY TRAFFIC, AT APPROXIMATELY 35 MPH. THE ELECTRONIC THROTTLE CONTROL LIGHT CAME ON AND ENGINE DIED. WE WERE ABLE TO COAST TO GAS STATION. THE VEHICLE STARTED RIGHT UP AND EVERYTHINGS WORKED FINE. THE NEXT DAY TOOK VEHICLE TO FORD DEALERSHIP. AFTER TROUBLESHOOTING, THEY WERE NOT REALLY SURE OF WHAT WAS THE PROBLEM. BUT THEY SUGGESTED CHANGING THE THROTTLE BODY. WE DECIDED TO TAKE VEHICLE HOME. VEHICLE WORKED FINE UNTIL YESTERDAY, THE PROBLEM OCCURRED AGAIN. THIS IS AN UNSAFE CONDITION. THERE IS A LARGE ABOUT OF E-MAIL TRAFFIC ABOUT THIS SAME PROBLEM, AND FORD HAS NOT ISSUED A RECALL. *TR

ENGINE FAILSAFE MODE CAME ON IN THE MIDDLE OF DRIVING AND THE TRUCK JUST SHUT OFF IN THE MIDDLE OF THE ROAD. I HAD TO TURN IT OFF AND RESTART IT...IT HAPPENED THREE TIMES IN ONE TRIP. *TR

THE SPARK PLUG BROKE IN THE ENGINE COSTING A LOT OF MONEY TO REPAIR. NOW ANOTHER ONE IS STUCK AND I CANT AFFORD TO GET IT FIXED. THIS COULD POSSIBLY CAUSE FIRE AND CREATE A SAFETY HAZARD. THERE ARE NUMEROUS COMPLAINTS OUT THERE AND THIS REALLY NEEDS TO BE A RECALL SITUATION. *TR

WAS DRIVING AROUND 40 MILES PER HR AND ENGINE JUST QUIT. NO POWER STEERING. WARNING LIGHT CAME ON REGARDING THROTTLE. LUCKILY WE WERE NOT ON THE INTERSTATE AND COULD PULL OVER. MY SON WILL BE TURNING 16 IN A FEW MONTHS AND HE WAS GOING TO BE DRIVING THIS. NOW WE ARE WORRIED. THERE ARE SO MANY COMPLAINTS ON LINE. FORD NEEDS TO RECALL THIS. SOMEONE WILL END UP BEING HURT OVER THIS. I HAVE SEEN THAT REPLACING THROTTLE DOES NOT FIX IT. WE TURNED CAR OFF AND RESTARTED IT AND IT WORKED FINE. YOU DO NOT KNOW WHEN THIS WILL HAPPEN. *TR

WHILE TRAVELING DOWN THE FREEWAY AT 70 MPH, THE VEHICLE DIED. IT WOULD NOT RESTART. AFTER 1 HOUR VEHICLE THE VEHICLE STARTED AND THEN DIED WITHIN SECONDS. THE FUEL FILTER AND FUEL PUMP WERE REPLACED BECAUSE ALL INDICATIONS LEAD TO BELIEVE THAT THE FUEL PUMP WAS BAD. AFTER REPLACEMENT OF THE FUEL PUMP, VEHICLE WOULD NOT START. LOOKING ON THE INTERNET FOR POSSIBLE SOLUTIONS FROM OTHERS, I FOUND ONE PERSON WITH THE SAME PROBLEM AND FOLLOWED THEIR ADVISE ON HOW TO FIX IT. I FOUND THE "DRIVERS MODULE" ON THE BACK TOPSIDE OF THE FRAME. WHEN THE MODULE WAS REMOVED, IT WAS FOUND TO HAVE TWO LARGE SECTIONS OF CORROSION ABOUT 1/4 INCH THICK. WHEN THE CHUNKS WERE KNOCKED OFF, UNDER THEM WERE TWO HOLES THROUGH THE SIDE OF THE MODULE AND THE CIRCUIT WAS BURNT, THE PLUG WAS ALSO STARTING TO CORRODE. THE PLACEMENT FOR THE MODULE IS A TERRIBLE SPOT. IT IS ALUMINUM ATTACHED TO A STEEL FRAME, WITH NOTHING SEPARATING THEM. WHEN THE NEW MODULE ARRIVED, IT NOW HAS A RUBBER GASKET TO KEEP THEM SEPARATE. THIS LOOKS LIKE A DESIGN FLAW ON FORD'S PART AND A RECALL SHOULD BE ORDERED. FORD SHOULD FURTHER REFUND THE COST OF THE FUEL PUMP BECAUSE ALL INDICATIONS SHOW THAT THE FUEL PUMP IS BAD, WHEN IN TRUTH IT IS THE MODULE AND NOT THE FUEL PUMP. *TR

FIRST TIME IT OCCURRED I WAS TRAVELING TO WORK THE CAR STALLED WHILE DRIVING APPROX. 20 MPH AND THERE WAS NO CONTROL OF THE CAR - WAS ABLE TO MOVE TO SIDE OF ROAD AND RESTART. FAULT ON THE CONSOLE WAS "ELECTRONIC THROTTLE". HAS HAPPEN APPROX 4 MORE TIMES AT VARIOUS SPEEDS AND CONDITIONS WITH THREE DIFFERENT DRIVERS. NO PROBLEM EVER FOUND BY DEALER. HAS HAPPENED AT HIGH SPEED ON THE FREEWAY COMPLETE LOSS OF STEERING AND POWER OCCURS MORE CONCERNING IT CAN HAPPEN AT ANY TIME WITHOUT WARNING. I FIND THIS TO BE EXTREMELY DANGEROUS AND A DEATH TRAP WAITING TO HAPPEN. THE LAST TIME IT OCCURRED WHEN BY TEENAGE DAUGHTER WAS DRIVING SHE WAS SCARED TO DEATH REFUSING TO DRIVE IT HOME. THIS REMINDED ME OF TOYOTA PRIUS SO I TOOK IT UPON MYSELF TO REPORT MY INCIDENTS. LOOKING AT THE INTERNET I NOW FIND IT OCCURS FREQUENTLY AND IT IS NOT AN ISOLATED CASE. *TR

MY 2005 EXPEDITION WAS TRAVELING AT A SPEED OF 40MPH WHEN IT STOPPED ACCELERATING AND DIED IN TRAFFIC WHILE I WAS TAKING MY KIDS TO SCHOOL. I COULDN'T TURN THE STIRRING WHEEL TO GET OFF OF THE ROAD. THIS IS A VERY DANGEROUS PROBLEM AND IT HAS HAPPENED TO ME ABOUT THREE OR FOUR TIMES. ONCE IT HAPPENED WHEN I WAS PULLING OUT INTO TRAFFIC ON A HILL THANK GOD NO ONE ELSE WAS COMING. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE VEHICLE STALLED AND THE ENGINE FAIL SAFE MODE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AS IT RESUMED NORMAL FUNCTION. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 25,000. UPDATED 11/13/12 *CN UPDATED 11/27/2012 *JS

I WAS DRIVING, WHEN I TRIED TO FURTHER ACCELERATE, THE CAR DID NOT RESPOND AND A WARNING " CHECK ELECTRONIC THROTTLE CONTROL". I PULLED OVER AND WAS ABLE TO RESTART THE CAR AND CONTINUE TO DRIVE AS NORMAL. THE INTERNET INDICATES THIS IS A COMMON PROBLEM IN 2005 EXPEDITIONS. THIS IS OBVIOUS A HIGHLY DANGEROUS SITUATION TO NOT BE ABLE TO ACCELERATE WHILE ALREADY DRIVING. *TR

I HAVE A 2005 EXPEDITION AND HAVE HAD A ELECTRONIC THROTTLE CONTROL FAILURE ON IT TWICE IN THE LAST 10 MONTHS. BOTH CASES HAPPENED WHILE TURNING THROUGH A MAJOR INTERSECTION, THE ENGINE CONTINUED TO RUN, BUT THERE WAS NO CONNECTION BETWEEN THE GAS PEDAL AND THE THROTTLE (STEPPING ON THE GAS HAD NO EFFECT). LUCKILY I WAS ABLE TO COAST THROUGH THE INTERSECTION AND ONTO THE SHOULDER WITHOUT GETTING HIT. THE FIRST OCCURRENCE WAS IN DEC 2011, AND IT JUST HAPPENED AGAIN THIS MORNING (1 OCT 2012), LUCKILY I WAS DRIVING AND SAFELY MANEUVERED OUT OF HARM'S WAY. IF IT HAD BEEN MY WIFE AND CHILDREN IN THE VEHICLE, OR IF IT HAD HAPPENED ON THE HIGHWAY, IT IS HIGHLY LIKELY THAT THE OUTCOME WOULD HAVE BEEN MUCH WORSE. THERE ARE MANY REPORTS OF THIS SAME FAILURE ON THE INTERNET. I WILL NOT LET MY WIFE AND CHILDREN RIDE IN THE VEHICLE TRIED TO HAVE FIXED AT THE DEALER IN DEC 2011 AND THEY HAD NO IDEA HOW TO FIX IT, JUST WANTED TO START REPLACING PARTS. CALLED THE DEALER AGAIN TODAY AND THEY HAD NO OTHER ANSWER. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE CONTACT LOST POWER STEERING. THE CONTACT ATTEMPTED TO BRAKE HOWEVER, THE BRAKES FAILED. THE CHECK BODY THROTTLE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHO INSPECTED THE VEHICLE AND STATED THAT THE THROTTLE BODY NEEDED REPLACEMENT. THE VEHICLE WAS REPAIRED BY REPLACING THROTTLE BODY. THE MANUFACTURER WAS MADE NOT AWARE OF THE FAILURE. THE FAILURE AND THE CURRENT MILEAGE WAS 63,000.

I WAS DRIVING DOWN THE CENTER LANE ON RT 41 IN PORT CHARLOTTE, WITH AN APPROXIMATE SPEED OF 45 MPH, WHEN THE ENGINE JUST SHUT DOWN. THIS IS NOT THE FIRST TIME IT HAPPENED TO ME, AND IT'S VERY DANGEROUS. I HAD TO MANEUVER CAREFULLY TO PULL OVER TO THE SIDE OF THE ROAD, WITH CARS BEEPING, AND SWERVING AROUND ME. I TRIED TO RESTART THE VEHICLE, BUT KEPT GETTING AN "ENGINE FAIL SAFE MODE" MESSAGE. I SAT FOR A WHILE ON THE SIDE OF THE ROAD FOR ABOUT 5 MINUTES, AND WHEN I TRIED RESTARTING THE TRUCK, IT MIRACULOUSLY STARTED. ON MONDAY, SEPTEMBER 17, 2012, I WENT OUT TO START MY VEHICLE SO I COULD BRING IT IN TO MY MECHANIC, AND IT WOULDN'T START. I HAD TO HAVE IT TOWED TO HIS SHOP. HE INFORMED ME THAT HE HAS SEEN THIS PROBLEM MANY TIMES WITH THIS VEHICLE. HE ALSO TOLD ME THAT PEOPLE WERE ON THE HIGHWAY WHEN THE VEHICLE SHUT DOWN ON THEM, AND HAS CAUSED ACCIDENTS. HE RESET THE CODE FOR THE THROTTLE BODY, AND THE TRUCK RAN FINE. AFTER DOING AN INTERNET SEARCH ON THIS PROBLEM, I SEE THAT THERE ARE MULTIPLE COMPLAINTS ABOUT THIS DANGEROUS PROBLEM. I ALSO CONTACTED FORD TO SEE IF THERE WAS A RECALL FOR THIS PROBLEM, AND THEY SAID THERE WASN'T. I AM AFRAID TO DRIVE THE TRUCK NOW, FOR FEAR THAT IT IS GOING TO SHUT DOWN IN A BUSY INTERSECTION. HOPEFULLY FORD WILL STEP UP TO THE PLATE AND DO A RECALL FOR THIS PROBLEM. *TR

DRIVING THE VEHICLE AND I ATTEMPTED TO STOP AND THE BRAKE PEDAL WENT TO THE FLOOR, EVEN AFTER PUMPING THE BRAKES. SOON AFTERWARD THE LOW FLUID LIGHT WENT ON. I HAD THE VEHICLE TAKEN TO MY LICENSED MECHANIC WHO DIAGNOSED THE PROBLEM AS A RUSTED THROUGH BRAKE LINE. SEVERAL OTHER LOCATIONS WERE HEAVILY RUSTED AND LEAKING AS WELL. I WAS VERY FORTUNATE NOT TO HIT ANYONE, ESPECIALLY SINCE I HAD 5 CHILDREN IN THE VEHICLE WITH ME AT THE TIME OF THE INCIDENT. I HAVE BEEN THE ONLY THE OWNER AND ORDERED THE VEHICLE NEW FROM FORD. THIS VEHICLE IS LIGHTLY USED AND NOT GARAGED. *TR

THE AIR CONDITIONING UNIT IS LEAKING EXCESSIVE AMOUNTS OF WATER UNDER THE CARPET AND THE WATER IS POOLING UNDER THE RUG AND FLOWING INTO THE CHANNEL WHERE THE WIRING HARNESS IS LOCATED. THIS WIRING HARNESS DOES NOT LOOK TO BE PROTECTED FROM WATER AND IT IS A MATER OF TIME BEFORE THE INSULATION ON THIS WIRE BREAKS DOWN AND SHORTS OUT TO THE FRAME. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT THE ENGINE STALLED WITHOUT WARNING WHILE DRIVING AT ANY SPEED. THE ENGINE FAILURE MODE LIGHT ILLUMINATED AFTER THE FAILURE OCCURRED. THE FAILURE WAS EXPERIENCED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC, WHO REPLACED THE FUEL FILTERS AND THE INJECTOR BUT THE FAILURE WAS NOT CORRECTED. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER, WHERE A DIAGNOSTIC TEST WAS PERFORMED AND LOCATED THE FAILURE AT THE THROTTLE BODY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 18,005 AND THE CURRENT MILEAGE WAS 119,000.

A CLUNK/THUMP NOISE FROM THE REAR WHEN THE TRANSMISSION IS ENGAGED OR SHIFTED, DURING A CHANGE IN VEHICLE DIRECTION OR ON ACCELERATION. HAVE HAD MY TRANS REPLACED ONCE UNDER WARRANTY AND NOW ITS DOING THE SAME THING AGAIN. *TR

WARNING LIGHT SAID ELECTRONIC THROTTLE CONTROL, THIS IS THE THIRD TIME I HAVE ALMOST HAD A MAJOR ACCIDENT AND FORD TELLS ME TO CALL THEM WHEN I HAVE AN ACCIDENT OR THE CODE SHOWS BACK UP. THEY ADMIT THAT THEY ARE AWARE OF THIS ISSUE BUT IT MUST FAIL COMPLETELY BEFORE IT CAN BE REPLACED UNDER WARRANTY OR RECALL. ALSO THE TRUCK CUTS OUT AT 60MPH AND JERKS UNTIL YOU SPEED UP. THEY ADVISED THEY ARE ALSO AWARE OF THIS PROBLEM AND COME BACK WHEN IT BREAKS DOWN. *TR

WHILE DRIVING ON ROAD IN TRAFFIC, THE ENGINE WAS BUCKING AND TURNING OFF, CAUSING TRAFFIC TO SWERVE AROUND ME UNTIL I COULD GET OFF THE ROAD. WARNING LIGHT SAID ELECTRONIC THROTTLE CONTROL. TOOK TO DEALER FOR INSPECTION. *TR

IN TRYING TO AVOID DEBRIS THE SUV FLIP AND SLIDING DOWN THE HWY I HIT A TRACTOR TRAILER REAR TIRE,THE AIR BAGS DID NOT DEPLOY. *TT

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE SUDDENLY STALLED. THE ENGINE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AND A WARNING NOTIFICATION APPEARED, INDICATING THERE WAS A CHARGING SYSTEM FAILURE. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSTIC TESTING AND THE TECHNICIAN STATED THE COMPUTER HAD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

ENGINE STOPS RUNNING AT DIFFERENT SPEEDS. SYSTEM DISPLAYS A CHECK ELECTRONIC THROTTLE CONTROL ERROR. THIS IS VERY DANGEROUS. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 55 MPH, THE ENGINE STALLED WITH THE ILLUMINATION OF THE WARNING INDICATOR. THE ENGINE RESTARTED AFTER WAITING A FEW MOMENTS AND RESUMED AS NORMAL. THE FAILURE RECURRED THREE TIMES WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS BUT THEY WERE UNABLE TO DETECT A FAILURE CODE. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

I WAS DRIVING ON FOUR LANE HIGHWAY IN RIGHT LANE AT 40MPH. I NOTICED THE CAR STARTING TO SLOW DOWN AND WHEN I PRESSED THE GAS PEDAL IT DID NOT REACT AND THE CAR CONTINUED TO SLOW DOWN. I LOOKED AT MY GAUGES ON THE DASH AND THERE WERE NO WARNING LIGHTS AND ALL GAUGES READ NORMALLY. I THOUGHT I COULD SMELL SMOKE, AND THE CAR CONTINUED TO SLOW DOWN, AND I KNEW I NEEDED TO GET OFF THE ROAD AS TRAFFIC WAS HEAVY. AS I PULLED OFF THE ROAD INTO THE PARKING LOT FOR THE STRIP MALL, THE CAR STALLED, LIGHTS CAME ON THE DASH TO INDICATE THE CAR STALLED AND I WAS ABLE TO STOP THE CAR, PUT IT IN PARK AND TURN THE CAR OFF. I COULD SMELL SMOKE AND I COULD SEE SMOKE GOING OUT THE CAR WINDOWS FROM INSIDE THE CAR AS I HAD THE WINDOWS OPEN A COUPLE OF INCHES. THERE WAS NO SMOKE COMING FROM UNDER THE HOOD. I DEBATED WHETHER TO CALL AAA OR 911. AS THE SMOKE INCREASED I CALLED 911. I THEN WENT TO THE CAR TO GET MY PURSE. WHEN I OPENED THE PASSENGER FRONT DOOR THE CAR WAS FILLED WITH SMOKE AND I THOUGHT I COULD SEE FIRE IN THE MIDDLE ROW OF SEAT ON THE FLOOR. I OPENED THE BACK DOOR ON THE PASSENGER SIDE AND SAW FLAMES SHOOTING UP FROM THE FLOOR 6 INCHES HIGH IN THE CENTER OF THE FLOOR. I TRIED TO PUT OUT THE FIRE WITH A SNOW SCRAPER WITH THE BRUSH END, BUT I WAS NOT SUCCESSFUL. I ASKED THE DRY CLEANING LADY IF SHE HAD A FIRE EXTINGUISHER. IT TOOK 30 SECONDS TO GET THE EXTINGUISHER AND ON MY WAY BACK TO THE CAR, I COULD SEE FLAMES UNDER THE CAR AND WHEN I OPENED THE BACK PASSENGER DOOR THE FIRE HAD SPREAD TO THE BACK SEAT. I WAS FEARFUL FOR HOW FAST THE FIRE SPREAD AND THE SMOKE PREVENTED ME FROM REACHING THE FIRE WITH THE EXTINGUISHER. THE FIRE DEPARTMENT THEN ARRIVED AND IT TOOK THEM 15-20 MINUTES TO PUT OUT THE FIRE AS THE FLAMES WERE SHOOTING AT LEAST 20 FEET INTO THE AIR. THE CAR WAS COMPLETELY ENGULFED IN FLAMES. I HAVE PICTURES I TOOK WITH MY PHONE. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE VEHICLE WOULD ENGAGE INTO SAFE MODE ERRONEOUSLY AND STALL. THE CONTACT HAD TO SHUT OFF AND RESTART THE VEHICLE IN ORDER TO HAVE THE VEHICLE FUNCTION PROPERLY. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER FOR A DIAGNOSTIC TEST OR REPAIRS. THE CONTACT CALLED THE MANUFACTURER AND FILED A COMPLAINT. THE FAILURE MILEAGE WAS 101,000.

I WAS DRIVING THE VEHICLE AND IT IMMEDIATELY LOST ACCELERATION. AN ALARM ON DASH IDENTIFIED THE PROBLEMS AS ELECTRONIC THROTTLE CONTROL FAILURE. THIS WAS VERY DANGEROUS AND I WAS LUCKY NO ONE WAS FOLLOWING ME CLOSE. MY WIFE IS NOW SCARED TO DRIVE THE VEHICLE AND I DON'T KNOW WHAT TO DO. THERE ARE MANY COMPLAINTS ON THE WEB ABOUT THIS ISSUE WHICH I WOULD HAVE THOUGHT A RECALL WOULD BE INITIATED BY FORD. I SEARCHED AND FOUND OUT THAT THERE WAS NO RECALL ON THIS ISSUE. I CALLED FORD MOTOR COMPANY AND THEY INFORMED ME THAT I WAS THE FIRST ONE TO COMPLAIN ABOUT THIS ISSUE. I FIND THAT VERY HARD TO BELIEVE WITH EVERYTHING I HAVE READ ON THE WEBSITE. ANYONE ONE WHO READS THIS THAT HAS HAD THE PROBLEM SHOULD CALL FORD MOTOR COMPANY AND COMPLAIN. JUST GO TO FORD.COM AND CLICK ON SUPPORT TO GET THE PHONE NUMBER. *TR

I HAVE A 2005 FORD EXPEDITION WITH 84K MILES AND I WAS GOING 30 MPH WHEN I LOST THE GAS PEDAL(POWER) TO MY VEHICLE. WARNING LIGHT CAME ON AND THEN I PULLED TO SIDE OF ROAD. LUCKY I WAS NOT HIT FROM BEHIND DUE TO LOSING POWER TO THE ENGINE. TURNED VEHICLE OFF FOR A FEW MINUTES AND THEN TURNED BACK ON. NO WARNING LIGHT AND TRUCK RAN FINE. TOOK IT TO LOCAL FORD DEALER WHO FOR $98 TELLS ME I NEED TO SPEND ANOTHER $600 TO REPLACE THROTTLE BODY. AFTER A LONG DISCUSSION WITH SERVICE MANAGER I DECIDED TO DECLINE THE REPAIR UNTIL I CONTACT FORD AND NATIONAL HIGHWAY SAFETY BOARD. *KB

VEHICLE HAS BEEN STALLING FOR ALMOST A YEAR. VEHICLE SHUT OFF ON BUSY HIGHWAY AND TOWED TO NEARBY REPAIR SHOP. MECHANIC FOUND FUEL PUMP CONTROL MODULE COMPLETELY CORRODED FROM BEHIND AND CIRCUIT BOARD EXPOSED TO MOISTURE. THE FPCM FRIED AND SHORTED OUT ONE LEG OF THE FUEL PUMP. BOTH PIECES HAD TO BE REPLACED. NEW FPCM INSTALLED WAS OBVIOUSLY REDESIGNED SO MODULE WOULD NOT SUFFER THIS FLAW AGAIN. I AM FINDING AN ALARMING AMOUNT OF COMPLAINTS ON THE INTERNET OF FORD EXPEDITION OWNER EXPERIENCING THE EXACT SAME PROBLEMS UNDER MORE DANGEROUS CONDITIONS. *KB

VEHICLE STOPED RUNNING ON FLAT LEVEL READ AT 65 MILES PER HOUR.VEHICLE WOULD NOT RESTART. VEHICLE HAD BEEN STALLING PRIOR. MECHANIC CANT PINPOINT PROBLEM BUT FEELS FUEL PUMP, FUEL PUMP MODULE, FUES BOX MALFUNCTION ARE THE CAUSE. TO MANY STORIES OF THIS PROBLEM SURFACING. MY FAMILY IN DANGER WITH VEHICLE STOPPED ON MAJOR HIGHWAY, CAUSED BY A WELL KNOWN PROBLEM FORD IS AWARE OF. *TT

I WAS DRIVING MY CAR WHEN ALL OF A SUDDEN THE ACCELERATOR IS NOT RESPONDING AND SO I NEED TO COAST THE CAR TO THE CURVE. I CALLED THE DEALER AND SO MY CAR WAS STILL UNDER MY EXTENDED WARRANTY AND SO I TOOK THE CAR IN AND I WAS TOLD THAT THEY REPLACED THE PART THIS WAS IN MARCH 2009, IT IS NOW JANUARY 21, 2012 AND I HAD THE SAME PROBLEM. THE MESSAGE BOARD READS, CHECK ELECTRONIC THROTTLE SYSTEM. *TR

2005 FORD EXPEDITION HAS EXPERIENCED APPROXIMATELY 5 EPISODES WHERE IT HAS STALLED WITH NO NOTICE OR PRIOR INDICATION OF A PROBLEM. THE PROBLEM STARTED AROUND 50K MILES AND HAPPENED MOST RECENTLY AS ABOUT 120K MILES. ON AT LEAST 2 OCCASIONS THE CENTER DASH INDICATED ENGINE FAILSAFE MODE. EACH TIME, THE TRUCK COULD BE IMMEDIATELY RESTARTED AND WOULD OPERATE NORMALLY. THE ONLY COMMON CIRCUMSTANCE IS THAT THE TRUCK WAS COASTING TO A LOWER SPEED AT THE TIME OF THE FAILURE. NO CODES ARE RECORDED, SO NO TROUBLESHOOTING CAN BE PERFORMED. REPLACED THE THROTTLE POSITION SENSOR, BUT FAILURE HAS OCCURRED TWICE SINCE. THE NEXT STEP IS TO REPLACE THE THROTTLE BODY ASSEMBLY. *TR

TRAVELING IN A PARKING LOT CAR DIED AND SAID CHECK ELECTRIC THROTTLE CONTROL. WONT RUN OR CRANK. LEFT STUCK IN A PARKING LOT HAD TO GET TOWED HOME. *TR

AT 45 MPH I LOST THROTTLE CONTROL AND WARNING LIGHT CAME ON INDICATING "ELECTRONIC THROTTLE CONTROL". I DRIFTED TO THE SIDE OF THE ROAD, PUT IN PARK AND TURNED OFF ENGINE. I RESTARTED AND EVERYTHING WAS FINE AND WARNING LIGHT WAS GONE. HAS BEEN FINE FOR THE PAST COUPLE OF WEEKS. READING EVERYBODY'S CONCERNS ON THIS ISSUE MAKES ME WONDER IF THERE REALLY IS A FIX FOR THIS. I CERTAINLY DON'T TRUST THE DEALERS......WHAT'S UP FORD??? *TR

TRAVELING ALONG CONGESTED CITY STREET DURING MORNING RUSH AND VEHICLE LOOSES ALL POWER. INSTRUMENT CLUSTER LIGHTS ARE ALL ON. MESSAGE SAY "CHECK ELECTRONIC THROTTLE" I WAS ABLE TO TURN THE VEHICLE OFF AND BACK ON TWICE BEFORE THE ERROR CLEARED. I HAVE AN APPOINTMENT AT THE DEALERSHIP IN THE MORNING. BUT THESE OTHER REPORTS DON'T GIVE ME MUCH HOPE. AND I JUST PAID OFF THE NOTE LAST WEEK. *TR

MY 2005 FORD EXPEDITION WITH JUST 62,000 MILES ON IT HAS CHIPPING AND BUBBLING PAINT ON THE REAR LIFT GATE AND THE HOOD. TALKED TO MY LOCAL FORD DEALER AND THEY SAID THAT THEIR WAS AN ISSUE WITH THE ALUMINUM PRIOR TO PAINTING THESE TWO PARTS AT THE FACTORY. FORD IS NOT STANDING BEHIND THIS DEFECT. *TR

WHILE DRIVING AT 60MPH ON US 85 N THE ENGINE LIGHT CAME ON WITH A MESSAGE "CHECK ELECTRONIC THROTTLE CONTROL" THE SPEED BEGAN TO DROP AND I COULD NOT ACCELERATE. I BEGAN TO MERGE TO THE RIGHT TO THE EMERGENCY LANE. I TURNED OFF THE ENGINE AND STARTED AGAIN. THEN I DROVE THE VEHICLE HOME. IT WAS A VERY SCARY EXPERIENCE I COULD HAVE BEEN IN AN ACCIDENT. IT WAS VERY DANGEROUS. THIS SHOULD BE A RECALL PROBLEM. *KB

2005 EXPEDITION RANDOMLY STALLS AT VARIOUS SPEEDS USUALLY AROUND 45 - 50 MILES PER HOUR. YOU HAVE TO TRY TO GET TO THE SIDE OF THE ROAD, STOP AND GIVE THE CAR A COUPLE OF MINUTES AND CRANK IT AGAIN. I HAVE TAKEN TO FORD DEALERSHIP AND I NEED A THROTTLE POSITION SENSOR. IT WILL BE $700 TO FIX. THE PERSON THAT OWNED THE VEHICLE BEFORE ME HAD ALREADY REPLACED THIS SAME PART. MY CONCERN IS I SPEND THE $700 AND STILL HAVE THE SAME PROBLEM. THIS IS A SERIOUS SAFETY ISSUE, I STAY IN CONSTANT FEAR THAT IT IS GOING TO STALL AT ANY MINUTE. I CAN'T BELIEVE FORD HAS NOT RECALLED THIS. THIS IS MY SECOND FORD BUT WILL BE MY LAST. *TT

2005 FORD EXPEDITION EDDIE BAUER, 90,000 MILES. (VEHICLE MANUFACTURED IN 2004.) WHILE BEING DRIVEN AT HIGHWAY SPEED THROTTLE STUCK IN FULLY DEPRESSED POSITION AFTER BEING ENGAGED FOR A ROUTINE PASS OF ANOTHER VEHICLE. VEHICLE WAS NOTED TO ACCELERATE. ACCELERATOR PEDAL COULD NOT BE RETURNED TO NON-DEPRESSED STATE WHEN FORCE APPLIED. BRAKES APPLIED FORCEFULLY, VEHICLE WAS UNABLE TO BE SLOWED OR BROUGHT TO A STOP. STRONG SMELL OF "BURNING" BRAKE PADS WAS NOTED. ATTEMPTED TO SHIFT VEHICLE INTO AUTOMATIC TRANSMISSION POSITION OF NEUTRAL. NO CHANGE IN ENGINE SPEED NOTED. TRANSMISSION THEN SHIFTED INTO REVERSE. VEHICLE WHEELS LOCKED UP AND VEHICLE SKIDDED APPROXIMATELY 100 - 150 FEET BEFORE COMING TO A STOP. ANTILOCK SYSTEM AND OTHER SYSTEMS DID NOT ACTIVATE. AFTER COMING TO A STOP, THROTTLE PEDAL WAS INSPECTED. NO INTERIOR INTERFERENCE FROM FLOOR MATS OR OTHER MATERIALS NOTED. OPERATOR IS 100% CERTAIN AS A RESULT OF "REAL-TIME" VISUAL CONFIRMATION, THAT ACCELERATOR AND BRAKE PEDALS WERE NOT MISTAKENLY ENGAGED OR DUALLY ENGAGED. CRUISE CONTROL WAS NOT ENGAGED. VEHICLE HAS BEEN SERVICED AND MAINTAINED REGULARLY AND WITH PRECISION AND DETAIL. VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC IMMEDIATELY POST THE INCIDENT. THROTTLE BODY FOUND TO BE FOULED AND DIRTY. INDEPENDENT MECHANIC IS REASONABLY CERTAIN THAT DIRTY THROTTLE BODY IS MOST LIKELY CAUSE OF THIS EVENT. INDEPENDENT MECHANIC HAS PERSONAL KNOWLEDGE AND EXPERIENCE OF SIMILAR THROTTLE BODY FAILURES PRODUCING SIMILAR EVENTS AS HAS BEEN DESCRIBED ABOVE. THIS VEHICLE HAS HAD OTHER PREMATURE FAILURES, INCLUDING (1) NEED FOR TRANSMISSION AND TRANSFER CASE TO BE REBUILT AT 28,000 MILES; (2) FAILURE OF POWER DRIVER'S SEAT TO MOVE ON ITS TRACK AT 25,000 MILES; (3) PREMATURE CAM PHASER FAILURE AND REBUILD AT APPROXIMATELY 35,000 MILES. *TR

OUR VEHICLE IS A 2005 FORD EXPEDITION LIMITED. ON TWO OCCASIONS THIS VEHICLE HAS UNEXPEDTEDLY LOST ALL POWER WITH THE MESSAGE "CHECK ELECTRONIC THROTTLE" APPEARING. ON ONE OCCASSION WE WERE MAKING A LEFT TURN ON A BUSY ROAD. WHEN THE VEHICLE LOST POWER WE WERE STUCK IN THE MIDDLE OF THE ROAD WITH ONCOMING TRAFFIC HAVING TO STOP SUDDENLY TO KEEP FROM HITTING US BROADSIDE. TURNING OFF THE IGNITION AND RESTARTING THE CAR MADE THE PROBLEM GO AWAY. LAST WEEK MY WIFE AND SON WERE IN THE VEHICLE COMING TO A STOP AT AN INTERSECTION. WHEN APPLYING THE BRAKE THE VEHICLE SUDDENLY ACCELERATED. MY WIFE HAD TO BREAK HARD AND NARROWLY MISSED HITTING THE CAR IN FRONT OF HER. THE VEHICLE WAS BROUGHT TO THE DEALERSHIP WHERE I WAS INFORMED THAT THEY WILL NEED TO REPLACE THE THROTTLE BODY. AFTER RESAEARCHING THIS ISSUE ON THE INTERNET IT APPEARS THAT BOTH THESE PROBLEMS ARE COMMON WITH THE 2005 EXPEDITION. IF THIS VEHICLE HAS NOT SERIOUSLY INJURED OR KILLED SOMEONE YET IT IS AMAZING AND JUST A MATTER OF TIME BEFORE IT HAPPENS. I DO NOT UNDERSTAND WHY THIS PROBLEM IS BEING IGNORED BY FORD! *TT

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE STALLED AND RESTARTED INDEPENDENTLY WITHIN MINUTES. THE OVERDRIVE WARNING INDICATOR WAS ILLUMINATED AND THE ENGINE BEGAN TO EXHIBIT ABNORMALLY LOUD NOISES. IN ADDITION, THE VEHICLE WOULD NOT SHIFT GEARS. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE TRANSMISSION WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS OUT OF WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 63,000.

MY WIFE AND 3 CHILDREN WERE DRIVING MY 2005 FORD EXPEDITION DOWN HWY 29 IN LAKE COUNTY, CA. WHEN THE 2 FRONT AIRBAGS SUDDENLY DEPLOYED. THERE WAS NO ACCIDENT OR IMPACT. LUCKILY MY WIFE WAS ABLE TO RETAIN CONTROL OF THE VEHICLE BUT HAS INJURIES HER CHEST AND NECK. THE CODES FROM THE VEHICLE DO NOT INDICATE ANY ERROR OR MALFUNCTION. IT WOULD MAKE SENSE THAT THIS INCIDENT IS RELATED TO THE F-150 RECALL ISSUE. *TR

WE WIFE HAS A 2005 FORD EXPEDITION, IT IS USED MAINLY FOR HER TO HAUL OUR KIDS TO PRACTICE AND SCHOOL BACK AND FORTH. THE TRUCK IS CONSTANTLY DYING WHILE DRIVING IT. THE DISPLAY SHOWS CHECK ELECTRONIC THROTTLE CONTROL". THIS MORNING SHE WAS TAKING THE KIDS TO SCHOOL WHEN IT DIED WHILE GOING THROUGH AN INTERSECTION. I HAVE TALKED TO SEVERAL DIFFERENT DEALERS WHO SAY THEY NEVER HEARD OF THIS PROBLEM, BUT CAN CHECK IT OUT FOR $$$$$$ YET I CAN SEARCH THE INTERNET AND FIND THE SAME PROBLEM HAPPENING TO THESE EXPEDITIONS. MY QUESTIONS IS WHY ISN'T FORD BEING RESPONSIBLE AND GETTING THESE RECALLED AND REPAIRED BEFORE SOMEONE IS KILLED IN THESE VEHICLES. CAN YOU IMAGINE DRIVING WITH YOUR LOVED ONES AND LOOSING FULL CONTROL OF YOUR VEHICLE AT ANYTIME.WE HAVE EXPERIENCED THE SHUTDOWN AT ALL SPEEDS. IT IS GETTING WORSE. WHERE IS THE RECALL FORD?? BEFORE SOMEONE IS KILLED.........UPDATE CHANGED OUT THE TPS QUESS WHAT DIDN'T FIX IT STILL DOING IT..WHAT NOW FORD?? *TR

WHILE TRAVELING 60-65 MPH, IN THE FAST LINE OF A FOUR LANE INTERSTATE, MY 2005 FORD EXPEDITION SUFFERED ENGINE FAILURE. I WAS ABLE TO SAFELY GET MY CAR OFF THE INTERSTATE WITHOUT HARMING MYSELF OR MY CHILDREN. THE MECHANIC INFORMED US A ROCKER PIN HAD BROKEN AND CAUSED DAMAGE TO A PISTON RESULTING IN THE NEED FOR A NEW ENGINE. I AM REPORTING THE INCIDENT TO YOU BECAUSE WHEN WE PICKED UP OUR CAR AT THE SERVICE DEPARTMENT, HAVING HAD THE ENGINE REPLACED, WE WERE TOLD THAT THERE WERE TWO OTHER FORDS (1EXPEDITION AND 1F150) THAT CAME IN AFTER OURS WITH THE SAME ISSUE. *TR

2005 FORD EXPEDITION HAS BEEN STALLING WITH NO WARNING WITH THE CHECK THROTTLE CONTROL LIGHT ON. WILL RESTART AFTER TURNING OFF. I HAVE REPLACED THE THROTTLE SENSOR TWICE AND HAS NOT HELPED. THIS PROBLEM IS VERY COMMON FOR THE 2005 EXPEDITION. FORD DEALER WILL NOT HELP,BUT OFFERS A $700. FIX THAT I UNDERSTAND DOES NOT ALWAYS HELP. *TR

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THE FUEL PUMP DRIVER MODULE FAILED. THE CONTACT STATED WHILE DRIVING 65 MPH THE VEHICLE STALLED WITHOUT WARNING. THE FUEL PUMP DRIVER MODULE WAS LOCATED IN THE REAR OF THE VEHICLE NEAR THE FUEL TANK. THE FAILURE DESTROYED THE FUEL PUMP AND BLEW THE 15 AMP FUSE THAT ALLOWS THE FUEL PUMP TO FUNCTION. THE DEALER INFORMED THE CONTACT THAT THE PART WAS CURRENTLY ON BACK ORDER. THE FAILURE AND CURRENT MILEAGES WERE 103,000.

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED WHILE DRIVING 70 MPH THE VEHICLE SUDDENLY SHUT OFF. THE VEHICLE WAS IN LIMP MODE WHEN THE FAILURE OCCURRED. HE DROVE ONTO THE EMERGENCY LANE AND SHUT THE VEHICLE OFF AND THEN RESTARTED IT. THE VEHICLE WORKED FINE AFTER IT WAS RESTARTED. THE CONTACT CALLED THE MANUFACTURER REGARDING THE ENGINE AND THE MANUFACTURER ADVISED HER TO TAKE THE VEHICLE TO A DEALER FOR DIAGNOSTIC TESTING. THE CONTACT DID NOT TAKE THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING BECAUSE OF THE COST. THE CONTACT STATED THAT THIS WAS A MAJOR SAFETY ISSUE. THE FAILURE MILEAGE WAS 51,000. THE CONSUMER STATED THE THROTTLE CONTROL UNIT MAY BE A SAFETY PROBLEM, CAUSING SUDDEN LOSS OF ENGINE POWER TO THE VEHICLE. THE LIMP HOME MODE IS AT IDLE SPEED. HOWEVER, WITH THE ENGINE SHUT DOWN, THE VEHICLE STILL HAS POWER BRAKE AND STEERING. THE ENGINE SHUT DOWN CAN OCCUR AT ANYTIME AT ANY SPEED. UPDATED 08/18/11

ME HUSBAND AND I OWN A 2005 FORD EXPEDITION XLT (V8 5.4L). THE TRUCK HAS CUT OFF ON US SEVERAL TIMES IN THE LAST TO WEEKS, WITHOUT WARNING! IT HAS EVEN CUT OFF ON US ON THE HIGHWAY. WE WERE TRAVELING 55MPH. WE HAVE FOUR SMALL CHILDREN THAT TRAVEL WITH US CONSTANTLY. I CONSIDER THIS TO BE A LIFE THREATENING DEFECT. MY HUSBAND TOOK THE TRUCK TO A MECHANIC, THINKING OH WE JUST NEED A TUNE UP. TWO OF THE SPARK PLUGS BROKE OFF INTO THE MOTOR HEAD. WE ENDED UP SPENDING $800 BUCKS TO HAVE IT REPAIRED AND $150 BUCKS ON A VAN RENTAL. IN MY OPINION FORD SHOULD HANDLE THIS SITUATION AS SOON AS POSSIBLE. IT IS A LIFE THREATENING DEFECT. WE ARE THANKFUL THAT WE MADE IT OFF OF THE HIGHWAY SAFELY THAT DAY. BUT WHAT IF ANOTHER FAMILY HAS THE SAME PROBLEM....AND THEY ARE NOT SO LUCKY? I GUESS FORD WILL THEN ISSUE A RECALL AND EXTEND THEIR MOST SINCERE APOLOGIES. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING AT VARIOUS SPEEDS, THE CONTACT HEARD A BEEPING NOISE AND THEN NOTICED THAT THE CHECK ELECTRONIC THROTTLE WARNING LIGHT WAS ILLUMINATED AS THE VEHICLE LOST POWER. THE FAILURE RECURRED ON FOUR SEPARATE OCCASIONS. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC WHO ADVISED THE CONTACT THAT THE ELECTRONIC CONTROL MODULE HAD FAILED. HE REMOVED THE BATTERY TERMINAL, RESET THE COMPUTER, CLEARED ALL CODES, REPLACED THE THROTTLE POSITION CENSOR, AND CLEANED THE THROTTLE BODY. THE DEALER WAS NOTIFIED OF THE PREVIOUS FAILURES AND DID NOT OFFER ANY ASSISTANCE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CURRENT MILEAGE WAS 110,000 AND THE FAILURE MILEAGE WAS 70,000. THE VIN WAS UNAVAILABLE. UPDATED 04/25/11 *BF THE CONSUMER STATED THE PROBLEM HAPPENED FOR A SECOND TIME. UPDATED 06/20/11

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT WAS DRIVING APPROXIMATELY 10 MPH WHEN THE ENGINE STALLED WITHOUT PRIOR WARNING. THE ENGINE FAILED TO RESTART AND THE VEHICLE WAS TOWED AN AUTHORIZED DEALER WHERE THE FUEL PUMP DRIVER MODULE WAS REPLACED. THE FAILURE MILEAGE WAS 66,859. UPDATED 05/05/11*LJ THE CONSUMER STATED WHEN THE ENGINE FAILED, HE LOST POWER STEERING. HE WAS ON STEEP HILL AND WAS ABLE TO STOP BY PLACING THE TRUCK INTO PARK AND APPLYING THE EMERGENCY BRAKE. UPDATED 07/01/11

MY 2005 FORD EXPEDITION HAS BEEN EXPERIENCING INTERMITTENT PROBLEMS AND THE ONLY MESSAGE YOU RECEIVE IS "CHECK ELECTRONIC FUEL THROTTLE." TRAVELING AT ANY SPEED THE CAR LOSES POWER IN THE SENSE LIKE IT HAS BEEN SHIFTED INTO NEUTRAL. WHEN THIS OCCURS YOU CAN STEP ON THE GAS PEDAL BUT ITS LIKE IT ISN'T ACKNOWLEDGED. YOU SHUT THE CAR OFF WAIT A FEW MINUTES AND RESTART IT AND EVERYTHING IS FINE. YOU MAY GO DAYS OR IT MAY BE WEEKS BEFORE IT HAPPENS AGAIN. IT IS A VERY SCARY SITUATION WHEN THIS HAPPENS. I HAVE BEEN SO LUCKY NOT TO HAVE BEEN INVOLVED IN AN ACCIDENT DUE TO THIS PROBLEM.

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED WHILE DRIVING 35 MPH, THE ELECTRONIC THROTTLE CONTROL WARNING LIGHT WAS ILLUMINATED AND THE VEHICLE IMMEDIATELY STALLED. THE CONTACT STATED THAT THE FAILURE WOULD RECUR WHEN DRIVING ANY SPEED. THE VEHICLE WOULD RESTART IMMEDIATELY AND DRIVE AS NORMAL. THE DEALER WAS CONTACTED AND STATED THAT THE THROTTLE BODY WOULD POSSIBLY NEED REPLACING AT A COST OF $600. THERE WERE NO RECALLS OR WARRANTIES FOR THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 73,000 AND THE CURRENT MILEAGE WAS 98,000.

CARS SHUTS OFF WHILE DRIVING! I HAVE EXPERIENCE THIS FOUR TIMES AT VARIOUS SPEEDS. THE CAR SHUTS OFF AND THE CHECK ELECTRONIC THROTTLE CONTROL LIGHT COMES ON. TWICE HAVE BEEN ON THE FREEWAY AT 65 MILES PER HOUR WITHOUT WARNING. BOTH TIMES I WAS ABLE TO START ENGINE BY PUTTING IT IN NEUTRAL WHILE DRIVING. ALTHOUGH I WOULD NOT RECOMMEND PERFORMING THIS TECHNIQUE AS YOU MAY ACCIDENTALLY PUT THE CAR INTO REVERSE AND AT THAT SPEED IT COULD BE RISKY. HOWEVER, I HAD NO CHOICE BECAUSE OF THE LANE I WAS IN. AS MOST HAVE MENTIONED, THIS IS SERIOUS PROBLEM ESPECIALLY WHEN DRIVING WITH FAMILY IN VEHICLE. MY WIFE WILL NOT DRIVE THE CAR BECAUSE SHE'S AFRAID...I DON'T BLAME HER. FORD SELLS ITSELF AS A FAMILY ORIENTED COMPANY SO LETS PROTECT OUR FAMILIES AND FIX THE PROBLEM. THESE COMPLAINTS DATE AS FAR BACK AS 2005. ARE THEY WAITING UNTIL SOME OF THEIR CUSTOMERS START GETTING IN SERIOUS ACCIDENTS? THIS IS A LIFE THREATENING PROBLEM AND NEEDS TO BE ADDRESSED! IF THEY DO NOT WANT TO PERFORM A RECALL THEN THEY SHOULD AT LEAST TELL US HOW TO FIX IT SINCE THEIR DEALERS ARE NOT. *TR

WHILE DRIVING MY 2005 FORD EXPEDITION UNDER NORMAL DRIVING CONDITION AT APPROXIMATELY 35 MILES PER HOUR, THE "CHECK ELECTRONIC THROTTLE CONTROL" INDICATOR APPEARED ON THE DASH CONSOLE AND THE ENGINE SHUT OFF. I PUT THE VEHICLE IN NEUTRAL GEAR AND COASTED TO A STOP ON A SIDE ROAD. THE VEHICLE RESTARTED WITH NO ISSUE AND I WAS ABLE TO CONTINUE ON MY TRIP. THIS HAS HAPPENED ENUMERABLE TIMES WITH THIS VEHICLE. MY WIFE, SON AND I ALL KNOW THE DRILL. WHY HASN'T FORD PUT A SERVICE BULLETIN OUT ON THIS ISSUE? *TR

DRIVING AT 45 MPH VEHICLE JUST TURNS OFF AND HAS NO POWER. HARD TO STEER AND BRAKE. DASH SAYS "CHECK ELECTRONIC THROTTLE CONTROL". AFTER PULLING OVER VEHICLE WILL RESTART. THIS HAS HAPPENED THREE TIMES NOW AND DEALER SAYS THERE IS NOTHING WRONG. *TR

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION EDDIE BAUER EDITION(NA). WHILE DRIVING 10-20 MPH, THE ELECTRONIC THROTTLE CONTROL LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE STALLED AND THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD. AFTER A FEW MINUTES, THE VEHICLE WAS RESTARTED AND FUNCTIONED PROPERLY. THE LIGHT ON THE INSTRUMENT PANEL TURNED OFF AS WELL. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE THROTTLE SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE OCCURRED AGAIN. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 92,000 AND THE CURRENT MILEAGE WAS 94,000.

I OWN A 2005 FORD EXPEDITION. THIS YEAR MODEL EXPEDITION HAS A KNOWN THROTTLE CONTROL ISSUE THAT CAUSES THE VEHICLE'S ENGINE TO DEFAULT TO "FAILSAFE MODE," WHICH IS A REDUCED POWER MODE. THIS IS A VERY SIGNIFICANT SAFETY ISSUE BECAUSE "FAILSAFE MODE" CAN BE ACTIVATED ANYWHERE AT ANY TIME WITHOUT WARNING. IMAGINE THE IMPLICATIONS OF SUDDENLY LOSING MOST OF YOUR ENGINE'S POWER AT INTERSTATE OR HIGHWAY SPEEDS. NOW, IMAGINE THE SAME SCENARIO WITH YOUR FAMILY ON BOARD AND A BOAT IN TOW, A VERY COMMON USE FOR THIS TYPE OF VEHICLE. THE INTERNET IS FULL OF FAILED THROTTLE BODY COMPLAINTS, YET FORD HAS DONE NOTHING TO ADDRESS THIS POTENTIALLY LIFE THREATENING DEFECT. THIS IS MUCH MORE THAN A NUISANCE ISSUE THAT THREATENS ONLY THE OWNERS' POCKETBOOKS. THIS IS A MAJOR SAFETY HAZARD AND FORD NEEDS TO DO SOMETHING ABOUT IT. THEIR NEGLIGENCE IS SHAMEFUL. *TR

I WAS DRIVING UP THE HIGHWAY WITH MY TWO KIDS IN MY CAR. I WAS TRAVELING ABOUT 40 MPH. ALL OF A SUDDEN I HEAR THE BEEP ON MY SYSTEM AND IT STATED THAT I NEEDED TO " CHECK ELECTRONIC THROTTLE CONTROL". I LAID OFF THE GAS AND WENT THRU A LIGHT WHEN I ATTEMPTED TO HIT THE GAS AGAIN I REALIZED I HAD NO POWER AT ALL AND I WAS COASTING. I GOT IN THE TURNING LANE AND HAD TO PULL IN FRONT OF A CAR JUST SO I WOULD NOT BE STUCK IN THE MIDDLE OF THE ROAD WHERE MY KIDS AND I WOULD HAVE BEEN IN AN ACCIDENT. I WAITED ABOUT 10 MINUTES AND THE VEHICLE FIRED UP. I WAS IN TEARS TRYING TO MAKE IT TO MY OFFICE BECAUSE I FELT LIKE IT MIGHT HAPPEN AGAIN. THE WHOLE MILE IT TOOK FOR ME TO GET THERE THE TRUCK FELT LIKE IT WAS GOING TO SHUT OFF AGAIN. IT FELT LIKE THE TRUCK DID NOT HAVE GAS AND WAS RIDING ON FUMES. IT WAS SHAKING AND MOVING SLOWING. I WILL NOT DRIVE IT LIKE THIS AND WILL PROBABLY TRADE IT IN NOW. I CANNOT DRIVE A VEHICLE THAT I DO NOT FEEL IS RELIABLE FOR ME AND MY KIDS. THIS IS THE FIRST TIME THAT THIS HAS HAPPENED AND THE TRUCK HAS 83K MILES ON IT. I ALSO HAD PROBLEMS WITH THE CATALYTIC CONVERTER AT 46K MILES. MY MECHANIC SAID THAT THE THROTTLE BODY COULD HAVE FAILED AS A RESULT OF THE CATALYTIC CONVERTER NOT WORKING PROPERLY. I MIGHT TRY TO FIX THE PROBLEM DEPENDING ON COSTS ASSOCIATED WITH IT OR MIGHT GET ANOTHER VEHICLE. *TR

I WAS TRAVELING W/B ON I-96 NEAR THE OKEMOS EXIT WHEN MY 2005 FORD EXPEDITION'S ENGINE SUDDENLY SHUT OFF. A WARNING STATING, "CHECK ELECTRONIC THROTTLE CONTROL" CAME ON. I EXITED THE EXPRESS WAY. THE ENGINE STILL RAN IN IDLE, BUT WOULD NOT RUN ANY FASTER THAN THAT. I PULLED INTO A PARKING LOT AND SHUT OFF THE ENGINE. I RESTARTED THE VEHICLE AND IT BEGAN RUNNING NORMALLY AGAIN. APPROXIMATELY FIVE MINUTES LATER, WHILE I WAS EXITING A PARKING LOT, THE SAME THING HAPPENED AGAIN. THIS TIME THE ENGINE WOULD NOT RUN AT ALL AND THE POWER STEERING STOPPED WORKING. I RESTARTED THE VEHICLE AGAIN AND IT RAN FINE. HOWEVER, THE CHECK ENGINE LIGHT IS NOW ILLUMINATED. I HAVE RESEARCHED ONLINE AND HAVE OBSERVED THAT THIS IS A PROBLEM FOR MANY PEOPLE. THERE ARE FORUMS OF COMPLAINTS ABOUT THIS EXACT SAME PROBLEM FOUND ON COUNTLESS WEBSITES. FURTHERMORE, THIS IS A VERY DANGEROUS PROBLEM. IF I WOULD HAVE BEEN TRAVELING THROUGH AN INTERSECTION WHEN THIS OCCURRED I COULD HAVE BEEN HIT. THIS EXPEDITION HAS HAD MANY ELECTRICAL PROBLEMS INCLUDING: TURN SIGNAL FAILURE, FUEL PUMP MODULE FAILURE, LIGHTS AND SIGNALS RANDOMLY NOT WORKING, WIPERS RANDOMLY NOT WORKING, ETC. I HAVE SPENT A LOT OF MONEY REPAIRING THESE ISSUES. I AM FED UP WITH THEM AND I AM CONTACTING YOU TODAY BECAUSE THE ELECTRICAL ISSUES IN THIS CAR ARE FINALLY BECOMING UNSAFE. I HAVE ALSO CONTACTED FORD AND AM WAITING FOR A RESPONSE. MY VEHICLE ONLY HAS APPROXIMATELY 92,000 MILES ON IT AND IS STILL UNDER AN EXTENDED POWERTRAIN WARRANTY. *TR

THIS IS THE FIFTH INCIDENT REGARDING THIS VEHICLE. IN EACH CASE, THE CAR WAS TRAVELING AT A NORMAL RATE OF SPEED UNDER ORDINARY TRAFFIC CONDITIONS. WITHOUT WARNING, THE CAR EITHER LOST POWER AND SHUT OFF SUDDENLY OR LOST THE ABILITY TO ACCELERATE AND SLOWED TO A STOP. IN EACH CASE THE DASHBOARD MESSAGE CENTER WARNING "CHECK ELECTRONIC THROTTLE CONTROL" (OR SOMETHING SIMILAR) APPEARED. IN EACH CASE THE DRIVER TURNED THE IGNITION SWITCH TO THE OFF POSITION, WAITED SEVERAL MINUTES, AND THEN STARTED THE CAR. THE WARNING MESSAGE NO LONGER APPEARED AND THE CAR RAN FINE WITHOUT ANY FURTHER IMMEDIATE INCIDENT. IN THIS PARTICULAR CASE (INCIDENT #5), THE CAR WAS TRAVELING AT APPROXIMATELY 25 MPH SOUTH ON 14TH ST NW IN WASHINGTON, DC, WHEN THE CAR LOST THE ABILITY TO ACCELERATE, AND THE "CHECK ELECTRONIC THROTTLE CONTROL" WARNING APPEARED IN THE DASHBOARD MESSAGE CENTER. DUE TO TRAFFIC AND STREET PARKING CONDITIONS, THE DRIVER WAS UNABLE TO MOVE THE CAR OUT OF THE ACTIVE TRAFFIC LANE, THEREBY TEMPORARILY BLOCKING TRAFFIC. THE DRIVER TURNED OFF THE IGNITION, WAITED APPROXIMATELY 3 MINUTES, AND THEN STARTED THE CAR. THE DASHBOARD WARNING LIGHT WAS NO LONGER ILLUMINATED, AND THE CAR WAS ABLE TO ACCELERATE NORMALLY. INCIDENTS SIMILAR TO THIS HAVE BEEN REPORTED ON VARIOUS WEBSITES. *TR

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 50 MPH THE VEHICLE STALLED. AFTER APPROXIMATELY THREE MINUTES THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND CONTINUE DRIVING. THE CONTACT ALSO STATED THAT THE FAILURE OCCURRED INTERMITTENTLY IN THE PAST WHILE DRIVING AT ANY SPEED. THE FAILURE AND CURRENT MILEAGES WERE 80,000. UPDATED 02/11/11 *BF THE TPS SENSOR WAS REPLACED. HOWEVER, THE PROBLEM RETURNED. UPDATED 03/11/11

WHILE TRAVELING 50 MPH ON BUSY STREET CAR POWER FAILED, SHUTTING OFF COMPLETELY INCLUDING LOSS OF POWER STEERING. ENGINE FAILURE LIGHT CAME ON. RESTARTED AFTER THAT AND DROVE FINE. SINCE THEN IT HAS OCCURRED 3 TIMES OVER LAST MONTH. LAST WEEK OCCURRED AT WHEN I WAS ATTEMPTING TO TURN WITH A TURN SIGNAL BUT SHUT OFF BEFORE I COULD MAKE THE TURN. THIS IS A LIFE THREATENING PROBLEM AND NEEDS TO BE RECALLED. THOUGHT IT HAD TO DO WITH LOW GAS TANK BUT HAD PLENTY OF GAS LAST WEEK. *TR

DRIVING ON FREEWAY IN MY 2005 FORD EXPEDITION, WHEN I LOST POWER AND BRAKES AND THE CHECK ENGINE LIGHT CAME ON. COASTED TO THE SIDE OF FREEWAY. VERY DANGEROUS INCIDENT. *TR

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 40 MPH THE VEHICLE MADE A BEEPING NOISE AND A WARNING LIGHT WAS DISPLAYED ON THE DASHBOARD INDICATING TO CHECK THE ELECTRONIC THROTTLE CONTROL. HE LOST ALL CONTROL OF THE VEHICLE WHEN THE ACCELERATOR PEDAL WAS ENGAGED. HE COASTED THE VEHICLE ONTO THE SIDE OF THE ROAD, TURNED THE VEHICLE OFF AND BACK ON. THE VEHICLE BEGAN TO FUNCTION NORMALLY. HE CALLED AN AUTHORIZED DEALER WHO ORDERED THE PARTS BASED ON HIS DESCRIPTION OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED WHEN THE COMPLAINT WAS FILED. THE FAILURE AND CURRENT MILEAGES WERE 85,000.

THIS IS THE FOURTH INCIDENT REGARDING THIS VEHICLE. IN EACH CASE, THE CAR WAS TRAVELING AT A NORMAL RATE OF SPEED UNDER ORDINARY TRAFFIC CONDITIONS. WITHOUT WARNING, THE CAR EITHER LOST POWER AND SHUT OFF SUDDENLY OR LOST THE ABILITY TO ACCELERATE AND SLOWED TO A STOP. IN EACH CASE THE DASHBOARD MESSAGE CENTER WARNING "CHECK ELECTRONIC THROTTLE CONTROL" (OR SOMETHING SIMILAR) APPEARED. IN EACH CASE THE DRIVER TURNED THE IGNITION SWITCH TO THE OFF POSITION, WAITED SEVERAL MINUTES, AND THEN STARTED THE CAR. THE WARNING MESSAGE NO LONGER APPEARED AND THE CAR RAN FINE WITHOUT ANY FURTHER IMMEDIATE INCIDENT. IN THIS PARTICULAR CASE (INCIDENT #4), THE CAR WAS TRAVELING AT APPROXIMATELY 10 MPH AND WAS TURNING RIGHT INTO A SUPERMARKET PARKING LOT IN CHEVY CHASE, MARYLAND. AS THE CAR PULLED INTO THE PARKING LOT, THE CAR LOST THE ABILITY TO ACCELERATE, THE "CHECK ELECTRONIC THROTTLE CONTROL" WARNING APPEARED IN THE DASHBOARD MESSAGE CENTER. THANKFULLY, THE CAR HAD ENOUGH MOMENTUM TO SAFELY PULL INTO A PARKING SPACE WITHOUT FURTHER INCIDENT. THE DRIVER TURNED OFF THE IGNITION, WAITED APPROXIMATELY 5 MINUTES, AND THEN STARTED THE CAR. THE DASHBOARD WARNING LIGHT WAS NO LONGER ILLUMINATED, AND THE CAR WAS ABLE TO ACCELERATE NORMALLY. *TR

STOPPED AT A TRAFFIC LIGHT INTERSECTION TO MAKE A RIGHT TURN. WHILE I WAS MAKING THE RIGHT TURN ABOUT 5 MPH, THE 2005 FORD EXPEDITION STALLED AND ALL THE LIGHTS WENT ON. I WAITED FOR ABOUT 10 SECONDS TO TURN ON THE CAR. THE CAR STARTED. I STOPPED 5 MINUTES LATER TO STOP THE ENGINE TO SEE IF EVERYTHING WAS OK. IT TOOK TWO TRIES TO START THE ENGINE. I TOOK IT TO A FORD DEALER THE NEXT DAY TO GET IT INSPECTED. THEY CLAIM IT WAS THE "THROTTLE POSITION SENSOR". I GOT THAT REPLACED FOR ~$340.00. *TR

WHILE DRIVING ON US 95 NORTH THE VEHICLE ALL OF THE SUDDEN STALLED. THIS HAS HAPPENED TWICE BEFORE WHILE DRIVING AT SPEEDS OF 60 AND GREATER ON BUSY INTERSTATES. THE ENGINE JUST STOPS AND THE CAR MUST COAST TO THE SIDE OF THE ROAD AND SIT FOR A FEW MINUTES AND THEN IT WILL START AGAIN AND RUN FINE FOR AT LEAST A WEEK OR TWO. RECENTLY THIS HAS BEEN HAPPENING EVERY COUPLE OF MONTHS. THE FIRST INCIDENT WAS IN JAN OF 2010 ON A TRIP FROM MISSOURI TO VIRGINIA. NOW THAT WE LIVE IN VIRGINIA, NEAR DC THIS IS SOMETHING THAT WE FIND VERY DANGEROUS ESPECIALLY WITH FOUR CHILDREN IN THE CAR.

2005 FORD EXPEDITION LIMITED ~83.5K MILES VEHICLE HAD BEEN DRIVEN ABOUT A HALF HOUR AND THE ENGINE STOPPED WITHOUT WARNING, UNABLE TO ACCELERATE, BRAKE OR STEER. COASTED TO SIDE OF ROAD, SHUT VEHICLE OFF, RESTARTED. TOOK TO DEALERSHIP, UNABLE TO REGISTER CODE HOWEVER I PROVIDED THEM WITH COMMENTS FROM ONLINE SITES POINTING TO THROTTLE CONTROL BODY FAILURE CAUSING ENGINE TO GO INTO FAILSAFE MODE. DEALERSHIP'S FIRST INCLINATION WITHOUT ANY CODES IS TO REPLACE A FUEL SENSOR. DEALERSHIP REFUSED TO ADDRESS THROTTLE CONTROL BODY DESPITE MY SUGGESTION ALONG WITH OTHER VEHICLE OWNER'S INCIDENT REPORTS FROM ONLINE SITES. 8 DAYS LATER WHILE MY HUSBAND WAS DRIVING MYSELF AND FIVE CHILDREN, AFTER ABOUT A HALF HOUR OF DRIVING, HE FOUND HE WAS UNABLE TO ACCELERATE, LOOKED AT THE MESSAGE CENTER AND IT SAID CHECK ELECTRONIC THROTTLE CONTROL AT WHICH TIME HE PUT THE VEHICLE IN NEUTRAL AND WAS ABLE TO RESTART. DEALERSHIPS ARE NOT ADDRESSING THIS ISSUE BECAUSE THE ONBOARD COMPUTER OR SENSORS ARE NOT STORING THESE CODES, THE PROBLEM IS SO FAR INTERMITTENT. THIS PARTICULAR DEALERSHIP DESPITE MY RESEARCH WOULD NOT ADDRESS THE ISSUE. IT ALSO APPEARS FORD IS NOT ACKNOWLEDGING THIS EITHER. SO FAR, I HAVE FOUND ONE INSTANCE ONLINE WHERE THE OWNER OF A 2006 EXPEDITION WAS REIMBURSED FROM FORD FOR THE REPLACEMENT OF THEIR ELECTRONIC THROTTLE CONTROL BODY THEREBY ACKNOWLEDGING SOME SEMBLANCE OF RESPONSIBILITY. THIS NEWER THROTTLE CONTROL BODY IS DIFFERENT THAN THE ORIGINAL, IMPROVED. WHY IS THERE NOT A RECALL OR EVEN A TSB? HOW MANY REPORTS OF THERE OUT THERE, HOW MANY ACCIDENTS, INJURIES, POSSIBLY DEATHS MIGHT BE ATTRIBUTED TO THIS FAILURE? AFTER CONTACTING FORD, WE WILL HAVE THE THROTTLE CONTROL BODY REPLACED. ALSO, IT APPEARS, PEOPLE ARE BEING SUGGESTED TO REPLACE THE SENSOR FIRST ONLY TO HAVE THE PROBLEM OCCUR AGAIN - IT'S NOT THE SENSOR, IT'S THE ACTUAL PART. *TR

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION EDDIE BAUER. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT STATED THAT THE VEHICLE STALLED, WHEN THE ELECTRONIC THROTTLE CONTROL WARNING LIGHT ILLUMINATED CAUSING THE VEHICLE TO LOOSE POWER. THE DEALER WAS NOTIFIED AND INFORMED THE CONTACT THAT THERE WERE NO RECALLS AND OFFERED NO FURTHER ASSISTANCE. THE MANUFACTURER WAS INFORMED AND ADVISED THE CONTACT THAT THEY WERE NOT AWARE OF THE PROBLEM AND TO FILE A COMPLAINT WITH NHTSA. THE MANUFACTURER ALSO STATED THAT THEY WOULD DOCUMENT THE COMPLAINT AS WELL. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 58,000. UPDATED 07/18/11

I OWN A 2005 FORD EXPEDITION AND HAVE EXPERIENCED LOSING ALL THROTTLE CONTROL ON THE FREEWAY. I WAS LUCKY ENOUGH TO MAKE IT SAFELY TO THE SIDE OF THE ROAD. I WAS SCARED . THERE WERE 5 PEOPLE IN THE VEHICLE INCLUDING TWO YOUNG CHILDREN. VERY DANGEROUS! THIS HAPPENS WITHOUT WARNING. AFTER ABOUT 5 MINUTES, THE VEHICLE STARTED UP AGAIN WITHOUT ANY PROBLEMS. TODAY I HAVE A DIFFERENT PROBLEM. O/D LED FLASHES ON DASH AND VEHICLE WILL NOT ACCELERATE PROPERLY. I HAD IT TOWED TO THE NEAREST MECHANIC. THEY SUSPECT A TRANSMISSION FAULT. I WISH I NEVER DECIDED ON GETTING THIS SUV. I SHOULD NOT BE SCARED TO DRIVE MY CAR. FORD NEEDS TO FIX THIS PROBLEM ASAP!!!!! *TR

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH, THE VEHICLE SUDDENLY STOPPED ACCELERATING WITH NO WARNING. THE CONTACT HAD TO TURN THE IGNITION OFF AND ON TO ALLEVIATE THE PROBLEM. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP BUT THE FAILURE COULD NOT BE DIAGNOSED. THE FAILURE OCCURRED THREE TIMES. THE FAILURE MILEAGE WAS APPROXIMATELY 56,000.

DRIVING AT 50MPH IN 2005 FORD EXPEDITION LMTD. WHEN LOST ALL THROTTLE CONTROL AND HAD TO TRY AND GET TO THE SIDE OF THE ROAD SAFELY. "CHECK THROTTLE CONTROL" WARNING CAME ON DURING INCIDENT. THIS WAS THE FIRST TIME AT 108,500 MILES. IT SEEMS THIS IS HAPPENING A LOT ON THIS VEHICLE MODEL. NOT A VERY SAFE DEFECT FROM FORD. FORD NEEDS TO THINK OF THEIR CONSUMER SAFETY AND RECALL AND CORRECT THIS ISSUE. MEANWHILE MY NEXT CAR THAT WAS GOING TO BE A FORD WILL BE SOMETHING DIFFERENT. *TR

THIS IS INCIDENT 3 OF 3 WITH RESPECT TO THIS VEHICLE. IN EACH CASE, THE CAR WAS TRAVELING AT A NORMAL RATE OF SPEED UNDER ORDINARY TRAFFIC CONDITIONS. WITHOUT WARNING, THE CAR EITHER LOST POWER AND SHUT OFF SUDDENLY OR LOST THE ABILITY TO ACCELERATE AND SLOWED TO A STOP. IN EACH CASE DASHBOARD MESSAGE CENTER WARNING "CHECK ELECTRONIC THROTTLE CONTROL" (OR SOMETHING SIMILAR) APPEARED. IN EACH CASE THE DRIVER TURNED THE IGNITION SWITCH TO THE OFF POSITION, WAITED SEVERAL MINUTES, AND THEN STARTED THE CAR. THE WARNING MESSAGE NO LONGER APPEARED AND THE CAR RAN FINE WITHOUT FURTHER IMMEDIATE INCIDENT. IN THIS PARTICULAR CASE (INCIDENT #3), THE CAR WAS TRAVELING AT APPROXIMATELY 25 MPH ON A TWO-LANE (ONE LANE IN EACH DIRECTION) DC CITY STREET. THE CAR LOST POWER COMPLETELY, AND THE DRIVER WAS NOT ABLE TO MOVE THE CAR OUT OF THE LANE OF TRAFFIC, THEREBY BLOCKING THE HEAVY LINE OF TRAFFIC BEHIND HER. AFTER SEVERAL MINUTES, THE DRIVER WAS ABLE TO RESTART THE VEHICLE. *TR

THIS IS INCIDENT #1 OF 3 WITH RESPECT TO THIS VEHICLE. IN EACH CASE, THE CAR WAS TRAVELING AT A NORMAL RATE OF SPEED UNDER ORDINARY TRAFFIC CONDITIONS. WITHOUT WARNING, THE CAR EITHER LOST POWER AND SHUT OFF SUDDENLY OR LOST THE ABILITY TO ACCELERATE AND SLOWED TO A STOP. IN EACH CASE DASHBOARD MESSAGE CENTER WARNING "CHECK ELECTRONIC THROTTLE CONTROL" (OR SOMETHING SIMILAR) APPEARED. IN EACH CASE THE DRIVER TURNED THE IGNITION SWITCH TO THE OFF POSITION, WAITED SEVERAL MINUTES, AND THEN STARTED THE CAR. THE WARNING MESSAGE NO LONGER APPEARED AND THE CAR RAN FINE WITHOUT FURTHER IMMEDIATE INCIDENT. IN THIS PARTICULAR CASE (INCIDENT #1), THE CAR WAS TRAVELING AT APPROXIMATELY 35 - 40 MPH ON A THREE-LANE (IN EACH DIRECTION) STATE HIGHWAY. THE DRIVER WAS ABLE TO MOVE THE CAR FROM THE MIDDLE LANE TO THE RIGHT LANE BEFORE LOSING ALL POWER TO ACCELERATE. THIS ROAD HAS NO SHOULDER, SO THE CAR BLOCKED TRAFFIC IN THE RIGHT LANE UNTIL IT WAS RESTARTED. WHEN THE CAR WAS NEXT TAKEN TO THE DEALER FOR SERVICE, THE DEALER DID NOT REPORT AN ON-BOARD DIAGNOSTIC CODE THAT WOULD ACCOUNT FOR THIS INCIDENT. *TR

THIS IS INCIDENT #2 OF 3 WITH RESPECT TO THIS VEHICLE. IN EACH CASE, THE CAR WAS TRAVELING AT A NORMAL RATE OF SPEED UNDER ORDINARY TRAFFIC CONDITIONS. WITHOUT WARNING, THE CAR EITHER LOST POWER AND SHUT OFF SUDDENLY OR LOST THE ABILITY TO ACCELERATE AND SLOWED TO A STOP. IN EACH CASE DASHBOARD MESSAGE CENTER WARNING "CHECK ELECTRONIC THROTTLE CONTROL" (OR SOMETHING SIMILAR) APPEARED. IN EACH CASE THE DRIVER TURNED THE IGNITION SWITCH TO THE OFF POSITION, WAITED SEVERAL MINUTES, AND THEN STARTED THE CAR. THE WARNING MESSAGE NO LONGER APPEARED AND THE CAR RAN FINE WITHOUT FURTHER IMMEDIATE INCIDENT. IN THIS PARTICULAR CASE (INCIDENT #2), THE CAR WAS TRAVELING AT APPROXIMATELY 60 MPH ON A FOUR-LANE (IN EACH DIRECTION) INTERSTATE HIGHWAY (THE INNER LOOP OF THE CAPITAL BELTWAY IN MONTGOMERY COUNTY, MD). THE DRIVER WAS ABLE TO MOVE THE CAR FROM THE SECOND LANE FROM THE RIGHT TO THE SHOULDER BEFORE LOSING ALL POWER TO ACCELERATE, ALTHOUGH AT RAPIDLY DECELERATING SPEED, THIS MANEUVER WAS EXTREMELY DANGEROUS. WHEN THE CAR WAS NEXT TAKEN TO THE DEALER FOR SERVICE, THE DEALER DID NOT REPORT AN ON-BOARD DIAGNOSTIC CODE THAT WOULD ACCOUNT FOR THIS INCIDENT. *TR

I FILED A COMPLAINT IN OCT (10355191) REQUESTING INFO ON VEHICLE SHUT DOWN. IT HAPPENED AGAIN THIS WEEK WHILE MY WIFE WAS DRIVING TO WORK. *TR

DRIVING APROX. 45 MPH LOSS CONTROL OF THROTTLE 2ND. TIME THIS HAS HAPPENED. *TR

2005 FORD EXPEDITION. WHILE DRIVING ON THE HWY THE "CHECK ELECTRONIC THROTTLE CONTROL" LIGHT CAME ON AND SHUT DOWN MY CAR.. I HAD NO ACCELERATOR PEDAL CONTROL. THIS OCCURS ON AVERAGE ONCE A MONTH. WHEN THIS HAPPENS ,YOU HAVE NO POWER. YOU HAVE TO COAST TO THE SIDE OF THE ROAD AND CALL FOR HELP. *TR

2005 FORD EXPEDITION, TRANSMISSION PROBLEM .WHILE TRAVELING ON A HIGHWAY, THE O/D OFF LIGHT CAME ON. THEN LATER ON , THE CHECK ELECTRONIC THROTTLE POSITION . THE VEHICLE WENT INTO A LIMP HOME MODE. UNSAFE'WHEN I DID INVESTIGATE ,I NOTICED MY VEHICLE WAS LEAKING TRANSMISSION FLUID. THE SPOT WHERE IT WAS LEAKING FROM WAS NEAR THE RADIATOR, THE TRANSMISSION LINES TO AND FROM THE RADIATOR AND THE EXTERNAL TRANS COOLER AND TRANSMISSION WERE CORRODED. MY REPAIR SHOP TRIED TO OBTAIN AFTERMARKET ONLY TO FIND THEY HAD TO BE SPECIAL ORDERED FROM FORD. WHILE DOING THAT ,FORD INFORMED HIM, THEY HAD SOME 15 KITS COMING IN, HOWEVER THEY WERE ALL ACCOUNTED FOR AND THE NEXT SET WOULD BE IN ANOTHER MONTH. APPARENTLY THERE IS SOMETHING FAULTY. AND DEFINITELY UNSAFE.. *TR

MY 2005 FORD EXPEDITION SUDDENLY STALLED AS I WAS SLOWING DOWN TO ENTER AN INTERSECTION. THE DASH DISPLAYED CHECK ELECTRONIC THROTTLE CONTROL OR ENGINE FAIL SAFE MODE AND THEN I LOST ALL POWER. I QUICKLY STARTED THE TRUCK BACK UP AND WAS ABLE TO DRIVE BACK HOME, BUT HAD ACCELERATION ISSUES ALONG THE WAY AND THE SERVICE ENGINE LIGHT STAYED ON. FORD SERVICE DEPARTMENT DETERMINED IT WAS THE THROTTLE POSITION SENOR. NO SIGNS PRIOR TO THIS EVENT THAT SOMETHING WAS WRONG WITH THE CAR. APPARENTLY THIS TP SENSOR MALFUNCTION CAUSED ME TO HAVE MY THROTTLE BODY AND FUEL INJECTORS SERVICED TOO. MANY COMPLAINTS ABOUT THE TP SENSOR ON THE INTERNET. THIS ISSUE SEEMS TO BE A HUGE SAFETY ISSUE ESPECIALLY WHEN YOU CONSIDER MOST OF US PURCHASE AN EXPEDITION FOR HAULING AROUND OUR CHILDREN. I HAD MY TWO YEAR OLD IN THE CAR WITH ME WHEN MY TRUCK LOST ALL POWER IN THE MIDDLE OF AN INTERSECTION. *TR

I WAS DRIVING 55MPH ON HIGHWAY, WHEN ALL OF A SUDDEN THERE WAS NO POWER TO GAS PEDAL. THE CHECK ELECTRONIC THROTTLE CONTROL LIGHT FLASHED, I PULLED OVER THREE LANES TO SIDE OF ROAD. I SAT THERE TRYING TO START VEHICLE CONTINUOUSLY, FINALLY AFTER 10 MINUTES IT STARTED. *TR

OUR 2005 FORD EXPEDITION HAS SHUT OFF WITHOUT WARNING TWICE NOW. THE FIRST TIME THIS HAPPENED WE WERE DRIVING BACK FROM MISSOURI TO VIRGINIA AFTER THE HOLIDAYS IN JANUARY OF THIS YEAR. WE WERE ON THE INTERSTATE DRIVING ABOUT 70 MPH WHEN THE CAR JUST STOPPED AND THE CHECK ENGINE LIGHT CAME ON. WE CALLED FORD AND THEY SAID TO LET IT SIT FOR 30 MINUTES AND THEN TRY TO START THE CAR AGAIN. WE DID AND IT WORKED. THE TECHNICIAN EXPLAINED THAT IT MAY HAVE BEEN THE COLD WEATHER. JUST YESTERDAY 12 SEPT 2010 MY WIFE WAS DRIVING HOME FROM WORK WHEN THE CAR SHUT OFF ON ITS OWN AGAIN AND THE CHECK ENGINE LIGHT ILLUMINATED. SHE WAITED A FEW MINUTES AND THE CAR STARTED AGAIN. THE COLD HAD NOTHING TO DO WITH IT YESTERDAY. BOTH TIMES WE WERE FORCED TO COAST TO THE SIDE OF THE ROAD IN HEAVY TRAFFIC. LIVING IN THE DC AREA AND USING INTERSTATE 95 ON A SUNDAY AFTERNOON IS ALWAYS A CHALLENGE. HAVING YOUR VEHICLE JUST STOP RUNNING IS INSANE. I AM UNABLE TO FIND ANYTHING ABOUT A RECALL, BUT IN A SEARCH OF THE WEB I FOUND NUMEROUS OWNERS HAVING A SIMILAR ISSUE. WHAT IS FORD DOING ABOUT THIS? *TR

2005 FORD EXPEDITION - ELECTRONIC THROTTLE PROBLEM. THIS HAS BEEN AN ON-GOING PROBLEM SINCE 2008, A VERY DANGEROUS PROBLEM. WILL THE NOTIFICATION WARNS YOU THE CAR DIES IN MID-TRAFFIC CAUSING YOU TO COAST AND THEN THE ENGINE DIES. I HAVE HAD THIS FIXED IN 2008 AND IN 2009 AND 2010 IS HAVING THE SAME ISSUE - SOMEONE WILL END UP WITH A DEATH DUE TO THIS PROBLEM. PLEASE INVESTIGATE. *TR

PAINT IS BUBBLING AND PEELING OFF HOOD AND TAILGATE OF 2005 FORD EXPEDITION EDDIE BAUER EDITION. *TR

1.2005 FORD EXPEDITION AUGUST 8,2010: AROUND 12:45PM I STARTED MY CAR UP TO RUN TO MCDONALD'S TWO MINUTES AWAY FROM MY WORK. AS I PULLED OUT OF MCDONALD'S THE CAR STARTED TO SLOW DOWN AND WOULD NOT ACCELERATE. I THOUGHT IT WAS MY GAS SO I PULLED INTO EXXON DOWN THE STREET TO FILL UP ON GAS. I PUT $15 OF GAS INTO THE TANK. WHEN I STARTED TO CAR UP IT IMMEDIATELY STARTED SHAKING VIGOROUSLY AND A STRONG SMELL OF GAS AND CLOUDY FUMES CAME FROM MY EXHAUST PIPE. I HAD TO GO BACK TO WORK SO I DROVE THE TWO MILES WHILE TO CAR STRONGLY SHOOK AND THE EXHAUST PIPE WAS PRODUCING A CLOUD OF SMOKE THAT SMELLED HEAVILY OF GAS. I GOT TO WORK AND CALLED MY HUSBAND. I TURNED OFF THE CAR AND CHECKED MY OIL. I ATTEMPTED TO TURN ON MY CAR AGAIN AND WAS NOT ABLE TO GET MY CAR TO START AGAIN THAT DAY. AT 7PM I ATTEMPTED TO TURN MY CAR ON AGAIN AND IT JUST MADE A LOUD SCREECHY SOUND AND WOULD NOT TURN ON. 2.BECAUSE CAR WOULD NOT START WE CALLED HARRY'S TOWING TO BE TOWED TO A AUTO SHOP NEAREST TO OUR HOME. OUR CAR NEVER BEFORE HAS HAD ANY PROBLEMS AT ALL. 3. WE ASKED THE MECHANIC TO LOOK AT THE CAR AND IDENTIFY THE PROBLEM. WHEN HE CALLED US BACK HE SAID THE FUEL INJECTOR WAS THE PROBLEM AND HE AT THAT TIME HAD REPLACED IT ALREADY AND ADVISED US TO TAKE THE CAR TO FORD DUE TO THE FACT THE HE SAID THE MOTOR WAS DEAD AS WELL. WE THEN HAD THE CAR TOWED TO FORD IN FRANKLIN KENTUCKY. THEY IDENTIFIED THE PROBLEM AS THE FUEL INJECTOR AND THAT THE MOTOR FAILURE WAS DUE TO FUEL INJECTOR PROBLEMS. THE HEADQUARTERS OF FORD SAID WE ARE NOW NOT COVERED UNDER THE EXTENDED WARRANTY DUE TO THE FACT THAT WE TOOK THE CAR TO SOMEONE BESIDES FORD. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING 35 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE BEGAN TO DRIVE ROUGH. THERE WAS ALSO A LARGE QUANTITY OF SMOKE COMING FROM THE TAIL PIPE. THE VEHICLE WAS TOWED TO A LOCAL REPAIR FACILITY WHERE THE CONTACT WAS INFORMED THAT THE FUEL INJECTOR FAILED. THE FUEL INJECTOR WAS REPLACED YET THE FAILURE RECURRED. THE DEALER ADVISED THERE WAS A PROBLEM WITH THE CATALYTIC CONVERTER AND RECOMMENDED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 81,800.

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. HE STATED THAT THE PAINT ON THE TRUNK AND HOOD OF THE VEHICLE WERE COVERED WITH RUST AND BEGAN PEELING. THE VEHICLE WAS TAKEN TO THE DEALER WHO TOOK PICTURES OF THE VEHICLE AND MAILED THEM TO THE FORD MANUFACTURER. THE MANUFACTURER STATED RESPONDED TO THE PHOTOS STATING THAT THEY WOULD NOT REPAIR THE VEHICLE BECAUSE HE WAS THE SECOND OWNER. THERE WERE NO RELATED RECALLS. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 39,000.

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. THE VEHICLE STALLED WHILE DRIVING AT ANY SPEED. WHEN THE VEHICLE STALLS THE STEERING WHEEL ALSO BECOMES VERY STIFF. DURING THE FAILURE A CHECK ENGINE THROTTLE LIGHT ILLUMINATES ON THE DASHBOARD. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER HE WAS INFORMED EITHER THE THROTTLE OR THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 112,866.

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE TRAVELING 45 MPH HE CONTACT NOTICED THAT THE CHECK ELECTRONIC THROTTLE CONTROL LIGHT HAD APPEARED ON THE INSTRUMENT PANEL , SECONDS LATER THE VEHICLE HAD SUDDENLY SHUT OFF. THE VEHICLE WAS RESTARTED AND TAKEN TO THE DEALERSHIP WHERE THE THROTTLE BODY WAS REPLACED. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WAS 65000.

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING 50-55 MPH THE VEHICLE STALLED IN THE MIDDLE OF THE ROAD AND THE CHECK ELECTRONIC THROTTLE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. SHE WAITED A FEW SECONDS AND TURNED THE VEHICLE BACK ON AND IT BEGAN TO FUNCTION NORMALLY. THE FAILURE OCCURRED TWICE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO WAS UNABLE TO DIAGNOSE OR DUPLICATE THE FAILURE. THE FAILURE MILEAGE WAS 31,500 AND THE CURRENT MILEAGE WAS 31,750.

DRIVING MY 2005 FORD EXPEDITION LIMITED IN THE MORNING. AFTER ABOUT 2 MILES THE CAR POWERED TO A CRAWL AND GAVE ENGINE FAIL SAFE MODE ALERT. PULLED TO SIDE. POWERED DOWN CAR AND THE RESTARTED WITHOUT INCIDENT. A WEEK LATER THE SAME THING HAPPENED AGAIN. THIS IS APPARENTLY A DEFECTIVE THROTTLE CONTROL UNIT. THIS DESCRIPTION IS ALL OVER THE INTERNET AND IS A KNOWN SAFETY PROBLEM AS PEOPLE ARE REPORTING THAT IT HAS HAPPENED TO THEM ON THE FREEWAY. CAR IS UNSAFE TO DRIVE AND EVEN THOUGH THE PROBLEM IS WELL KNOWN, FORD COMPANY IS TAKING NO RESPONSIBILITY. ALL NHTSA HAS TO DO IS GOOGLE "ENGINE FAIL SAFE MODE" AND SEE THE NUMBER OF PROBLEMS THAT COME UP WITH SAME ISSUE. THIS IS DEFINITELY A WELL KNOWN SAFETY PROBLEM BUT YET THERE IS NO RECALL. DEALER SAYS THROTTLE CONTROL UNIT HAS TO BE REPLACED AT A COST OF $514.61 + TAX. THIS PROBLEM MAY ALSO HAVE TAKEN OUT MY AIR CONDITIONING. IT WENT OUT AT THE SAME TIME AS THE SECOND FAILURE, BUT DEALER (VISTA FORD IN OXNARD) IS SAYING THERE IS NO RELATIONSHIP. OTHERS HAVE REPORTED A/C SHUTTING DOWN WHEN ENGINE FAIL SAFE FAILURE OCCURRED. *TR

2005 FORD EXPEDITION STOPPED RUNNING WHILE DRIVING AT 40 MPH IN HEAVY TRAFFIC. VEHICLE WOULD NOT RESTART. IT APPEARS TO BE A FUEL PUMP PROBLEM. ONLY 40,000 MILES ON THIS VEHICLE. NONE OF THE DASH BOARD LIGHT INDICATORS CAME ON. *TR

ORIGINAL FACTORY SPARK PLUG BACKED OUT FROM CYLINDER HEAD. CHECKED REMAINING 7 SPARK PLUGS. FOUR OF SEVEN LOOSE. MECHANIC RECOMMENDED USING HELI COIL KIT ON ALL SPARK PLUG THREADS. MECHANIC MENTIONED THAT THIS WAS A COMMON OCCURRENCE ON FORD 5.4 LITER ENGINES. IF THIS IS TRUE, IT APPEARS AS THOUGH A RECALL SHOULD BE REQUIRED FOR REPAIR OF CYLINDER HEADS. *TR

MY 2005 FORD EXPEDITION WILL SUDDENLY TURN OFF WHILE IN MOTION WITH NO WARNING. THERE IS NO PATTERN TO DETERMINE WHEN IT WILL TURN OFF. IN THE 6 MONTHS I HAVE OWNED THE VEHICLE, IT HAS TURNED OFF CLOSE TO A DOZEN TIMES, AT SPEEDS RANGING FROM 20 MILES AN HOUR TO FULL FREEWAY SPEED. THE ELECTRONIC THROTTLE CONTROL LIGHT TURNS ON. I HAVE TAKEN IT TO A REPUTABLE MECHANIC WHO WAS UNABLE TO REPLICATE THE PROBLEM AS THE CODE REPORTED THAT THE ERROR OCCURRED WHILE THE VEHICLE WAS TURNED OFF - WHICH IS TECHNICALLY IMPOSSIBLE. RESEARCH HAS SHOWN THIS IS A COMMON PROBLEM WITH THIS VEHICLE, AND IT IS OBVIOUSLY DANGEROUS FOR A VEHICLE TO TURN OFF WHILE IT IS IN MOTION. I WOULD HOPE THIS VEHICLE IS RECALLED BEFORE INFORMATION LEAKS THAT PEOPLE HAVE DIED AS A RESULT. *TR

MY 2005 FORD EXPEDITION WAS CUTTING OFF AND TICKING EVERYDAY, BUT NO LIGHTS WERE COMING ON TO TELL ME WHAT IT WAS, I TOOK MY VEHICLE TO PEP BOYS SHOP AND THEY DECLINE TO FIX IT DO TO SPARK PLUGS BREAKING IN THE ENGINE, SO I TOOK IT TO THE FORD DEALER WHERE I PURCHASED IT. IT TOOK THEM A WHOLE DAY TO FIGURE OUT WHAT WAS WRONG WITH IT, THEY SAID I NEEDED A TUNE UP WHICH WAS $279, AND HE TOLD ME THAT ALL OF SPARK PLUGS NEEDED TO BE REPLACED AND THAT THEY SOMETIMES BREAK OFF IN THE ENGINE AND IF THAT WHERE TO HAPPEN IT WOULD BE A ADDITIONAL $90 PER PLUG, THE COIL NEEDED TO REPLACED $95, AND THE ON OF THE CYLINDER NEED TO BE REPLACED UNKNOWN AMOUNT/FORGOT, THEN THEY CALL ME BACK AND TOLD ME THAT ALL OF THE SPARK PLUGS HAD BROKE. THE FORD DEALERSHIP REPAIRED MY TRUCK CAUSE THERE WHERE OTHER PROBLEMS AS WELL SO TOTAL $1000 IN REPAIRS FOR A PROBLEM THAT I NEVER NEW THIS TRUCK WAS HAVING. *TR

2005 FORD EXPEDITION "ELECTRONIC THROTTLE CONTROL" LIGHT WILL COME ON AND THE ENGINE WILL STALL. THIS WILL HAPPEN AT ANY TIME, ANY SPEED AND WITHOUT WARNING. UNFORTUNATELY SOMEONE WILL HAVE TO BE SEVERELY INJURED BEFORE FORD TAKES A LOOK AT THIS. *TR

2005 FORD EXPEDITION WITHOUT WARNING STALLED WHILE MAKING A RIGHT HAND TURN AT AN INTERSECTION. VEHICLE TAKEN TO DEALERSHIP AND INFORMED ELECTRONIC THROTTLE BODY NEEDED TO BE REPLACED. VEHICLE ONLY HAS 60,000 MILES. INFORMED BY DEALERSHIP REASONS FOR DEFECT UNKNOW. HOWEVER, WE WERE STILL RESPONSIBLE FOR ALL REPAIR COSTS. REVIEW OF INTERNET INDICATES SEVERAL FORD CUSTOMERS HAVE REPORTED SAME PROBLEM WITH EXACT YEAR AND MAKE OF VEHICLE. *TR

WHILE DRIVING MY FORD 2005 EXPEDITION THE CAR STOPS RESPONDING TO THE THROTTLE AND LOSSES ALL POWER. THE DASHBOARD WARNING SYSTEM DISPLAYS "CHECK ELECTRONIC THROTTLE CONTROL". AFTER SHUTTING THE ENGINE OFF AND WAITING SEVERAL MINUTES THE CAR CAN BE RESTARTED AND DRIVEN. WE HAVE INQUIRED ABOUT THIS ISSUE WITH NO SATISFACTION. *TR

MY 2005 FORD EXPEDITION SUDDENLY AND UNEXPECTEDLY SHUT OFF IN THE MIDDLE OF THE HIGHWAY. AN ERROR CODE OF "CHECK ELECTRONIC THROTTLE" DISPLAYS ON THE DASH AND A WARNING SIGNAL SOUNDS. ALL WHILE THE VEHICLE LOSES THE ABILITY TO ACCELERATE AND POWER STEERING. AFTER BRINGING THE VEHICLE TO A STOP, IT CRANKS RIGHT UP AS IF THERE WAS NEVER A PROBLEM. IT HAS NOW DONE THIS ABOUT 5 OR 6 TIMES. WE HAVE NEARLY BEEN HIT TWICE BY 18 WHEELERS AS A RESULT OF THIS. THIS IS AN EXTREMELY DANGEROUS PROBLEM. I HAVE RESEARCHED THE PROBLEM ONLINE IN HOPES OF FINDING OUT WHAT COULD BE CAUSING THE PROBLEM. TO MY HORROR, I FOUND HUNDREDS OF SIMILAR COMPLAINTS ALL LINKED TO THE 2005 FORD EXPEDITION ONLY. I HAVE NOT SEEN THIS TYPE OF COMPLAINT FOR ANY OTHER MODEL YEAR. I'M LEARY OF EVEN TAKING IT TO A DEALERSHIP FOR THE PROBLEM AT THIS POINT BECAUSE THE COMMENTS AROUND THE ISSUES HAVE BEEN THAT FORD HAS REPLACED THE "THROTTLE BODY" AND IN SOME CASES IT DIDN'T RESOLVE THE PROBLEM. TO ME IT SOUNDS LIKE A RECALL IS NEEDED TO ADDRESS THIS ISSUE. IT SHOULDN'T TAKE A SEVERE ACCIDENT OR DEATH TO REMEDY THIS SITUATION. IT SOUNDS LIKE FORD IS TRYING TO AVOID ISSUING A RECALL ON THIS FROM THE COMPLAINTS THAT I HAVE REVIEWED. IF THE 2005 FORD EXPEDITION IS THE ONLY MODEL YEAR AFFECTED, THEN THERE IS SOMETHING THAT WAS PROGRAMMED OR INSTALLED INCORRECTLY ON THE FORD EXPEDITIONS FROM THAT MODEL YEAR. AN INVESTIGATION NEEDS TO BE INITIATED BEFORE THE FATAL RESULTS THAT TOYOTA HAS HAD RECENTLY BECOME A PART OF FORDS FUTURE, AND ALL BECAUSE THEY WANT TO BE IN DENIAL OF A PROBLEM WHICH SHOULD INITIATE A RECALL TO FIX. *TR

I HAVE OWNED TWO FORD EXPEDITIONS, BOTH OF WHICH WERE WRECKED WHEN IT RAINED. MY CONCERN IS THAT THE VEHICLE BECOMES VERY LOOSE IN THE REAR WHEN IT RAINS AND THAT IS THE PROBLEM THAT HAS LEAD TO ME HAVING MY ACCIDENTS. *TR

2005 FORD EXPEDITION WITH 90,000 MILES ON IT, DRIVEN IN NORMAL VEHICLE STALLS WHILE DRIVING UNDER NORMAL CONDITIONS, AND THE "CHECK ELECTRONIC THROTTLE CONTROL" MESSAGE COMES ON INFOR SCREEN, THEN ENGINE LIGHT COMES ON. ALMOST RAN INTO DITCH ALONG SIDE OF ROAD LAST TIME WHEN ENGINE STALLED, AS POWER STEERING AND BRAKES SHUT DOWN AS WELL. *TR

I HAVE A 2005 FORD EXPEDITION LIMITED. MY COMPLAINT IS THE THROTTLE BODY FAILURE. WHEN DRIVING DOWN THE ROAD, THE ENGINE WILL SHUT DOWN AND YOU LOOSE ALL POWER TO THE VEHICLE. I HAVE HAD THIS HAPPEN AT SPEEDS OF 55+ MPH AS WELL AS SPEEDS OF APPROX LESS THAN 10 MPH, SUCH AS WHILE IN A PARKING LOT. THIS PROBLEM STARTED IN THE SUMMER OF 2009, AND HAS HAPPENED EVERY MONTH SINCE, SOMETIMES SEVERAL TIMES DURING THE MONTH. WE TOOK THE VEHICLE TO HAVE IT TESTED AND WERE TOLD IT WAS A TPS SENSOR. THAT HAS BEEN REPLACED ($75.00) BUT THE PROBLEM IS STILL HAPPENING. I HAVE DONE SOME RESEARCH ON THIS AND IT IS AN ONGOING PROBLEM WITH THE 2005 EXPEDITIONS. I PERSONALLY KNOW OF 2 OTHER PEOPLE THAT HAVE HAD THE SAME PROBLEM AND HAVE HAD TO HAVE THE ENTIRE THROTTLE BODY REPLACED, ONE OF WHICH HAS HAD IT REPLACED TWICE NOW. THIS IS A HUGE CONCERN SINCE YOU DO LOOSE ALL POWER AND HAVE TO TRY TO COAST TO THE SIDE OF THE ROAD, WHILE TRYING TO AVOID BEING HIT BY OTHER VEHICLES ON THE ROAD. MY CONCERN IS THAT WHEN THIS HAPPENS, THE RESULT WILL BE A ACCIDENT WHILE TRYING TO GET THE VEHICLE TO THE SIDE OF THE ROAD. THE REPAIR COST FOR JUST THE PARTS IS $600.00, BUT THIS DOES NOT INCLUDE THE LABOR. FORD NEEDS TO RECALL THIS PART BEFORE SOMEONE DOES DIE OR IS SERIOUSLY INJURED, AS IT IS A HUGE SAFETY CONCERN. FORD AND THEIR DEALERS ARE AWARE OF THE PROBLEM, YET THE ONLY RESOLUTION IS TO HAVE THE CONSUMER PAY FOR THE REPAIRS. I AM AFRAID TO DRIVE MY VEHICLE NOW BECAUSE OF THIS PROBLEM. I DO NOT HAVE THE OLD TPS SENSOR, BUT THE VEHICLE IS STILL DOING THIS AND DO STILL HAVE THE THROTTLE BODY THAT IS BAD ON THE VEHICLE FOR INSPECTION. WHEN THIS HAPPENS, THE INFORMATION CENTER IN THE DASH TELLS YOU TO "CHECK ELECTRONIC THROTTLE CABLE". *TR

INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) 2005 FORD EXPEDITION [XXX] ENGINE SHUTS DOWN WHILE TRAVELING 50 MPH, FAILSAFE MODE INDICATOR LIGHT COMES ON. THIS HAS HAPPENED TWICE IN THE LAST MONTH. IT IS A HUGE LIFE SAFETY ISSUE WHEN YOU THINK YOU HAVE CONTROL OF THE VEHICLE AND YOU ACTUALLY DO NOT. I HAVE 4 CHILDREN I PUT INTO THIS VEHICLE AND I FEAR OUR SAFETY. I HAVE BEEN TOLD TODAY BY FORD THAT THE THROTTLE BODY IS FAULTY AND NEEDS TO BE REPLACED. THIS IS A PART THAT SHOULD NEVER HAVE TO BE REPLACED! CLEANED MAYBE BUT NEVER REPLACED. I HAVE 61, 000 MILES ON THE VEHICLE AND THIS PART SHOULD NOT BE BAD. I WILL BE REPLACING IT THIS WEEK, BUT I FEEL THAT FORD DOES NOT WANT TO ADDRESS THIS MATTER AS I SPOKE TO THE SERVICE MANAGER,[XXX]AT AL PACKER FORD WEST 561-790-1100 AND ALSO FORD CORPORATE OFFICE AT 800-241-3673 AND ALL THEY SAID THEY WOULD DO IS DOCUMENT THE PROBLEM. HOW MANY PEOPLE WILL CRASH OR DIE BEFORE SAFETY IS TAKEN SERIOUSLY? WHY DO DEALERSHIPS NOT TAKE RESPONSIBILITY FOR FAULTY PARTS. THIS IS A VERY FRIGHTENING EXPERIENCE FOR BOTH MYSELF AND MY CHILDREN AND IT HAS BEEN DOCUMENTED AND VERBALLY EXPRESSED TO SEVERAL PEOPLE NOW. I WOULD LIKE TO SEE ACTION TAKEN BEFORE SOMEONE DIES. *TR

FORD EXPEDITION 2005 TRANSMISSION FAIL, SUV HAS BEEN DRIVEN IN NORMAL WAY, WITH GOOD MAINTENANCE. TOO NEW TO FAIL. MY WARRANTY EXPIRED AND I KNOW MANY OWNERS HAVE THE SAME PROBLEM. SUDDENLY O/D DASH LED BLINKING AND AFTER 10 MINUTES ONLY REVERSE GEAR WORKS WELL, NOW I NEED TO PAY 2500.00 DLLS FOR REPAIR ON VEHICLE NOT PAID OFF YET. *TR

3RD INCIDENT OF THIS ISSUE WITH THIS VEHICLE AND MULTIPLE COMPLAINTS ONLINE. VEHICLE RUNS FINE AND THE WRENCH LIGHT WILL COME ON WITH A MESSAGE "ELECTRONIC THROTTLE CONTROL" THE VEHICLE REMAINS ON BUT THROTTLE DOES NOT OPERATE. ONE OF THE INCIDENTS HAPPENED IN AN INTERSECTION AND UNDER SIMILAR CIRCUMSTANCES WOULD HAVE RESULTED IN A CRASH. IF THE VEHICLE IS TURNED OFF AND RESTARTED IT WORKS FINE UNTIL NEXT INCIDENT. THIS IS VERY DANGEROUS AND I AM VERY SURPRISED THAT THIS HAS NOT BEEN RECALLED WITH THE NUMEROUS COMPLAINTS OF THIS ISSUE DOCUMENTED ON THE INTERNET. *TR

2005 FORD EXPEDITION 78,000 MILES. IN THE LAST FEW MONTHS THE CAR AT TIMES HAS FELT AS THOUGH THERE IS LITTLE TO NO ACCELERATION, ALMOST LIKE THE CAR IS IN NEUTRAL. TODAY MY CAR STALLED AND I WAS ABLE TO DRIFT TO THE SIDE OF THE ROAD. THE "CHECK ELECTRONIC THROTTLE" LIGHT CAME ON. THE CAR IS AT THE DEALER NOW, WITH A $600+ REPAIR BILL. SEEMS THERE SHOULD BE A CHECK FOR SUCH SYSTEMS. WHAT WOULD HAVE HAPPENED HAD I BEEN ON A BUSIER STREET OR FREEWAY. *TR

DRIVING NORMALLY ON THE HIGHWAY, VEHICLE STALLS AT REGULAR SPEED, LOSS OF ALL POWER, COAST TO A STOP ON THE SHOULDER OF THE HIGHWAY. *TR

MY 2005 FORD EXPEDITION SUDDENLY LOST ALL POWER WHILE DRIVING IN ROSEVILLE, CA ON SATURDAY FEBRUARY 13TH 2010. MY FAMILY OF FOUR WAS IN THE CAR, AND LUCKILY, WE AVOIDED AN ACCIDENT. A "ENGINE FAIL SAFE MODE" LIGHT CAME ON, AND I HAD TO PULL ON THE SIDE OF THE ROAD. I RESTARTED MY VEHICLE WITH NO PROBLEMS. *TR

2005 FORD EXPEDITION. WHILE DRIVING ON THE HWY THE "CHECK ELECTRONIC THROTTLE CONTROL" LIGHT CAME ON AND PUT THE VEHICLE IN "LIMP MODE" I HAD NO ACCELERATOR PEDAL CONTROL. DECEMBER 22, 2008. TAKEN TO DEALER, NO PROBLEM FOUND. CODE WAS " P2104". SAME THING HAPPENED AGAIN DECEMBER 20, 2009. TAKEN TO DEALER NO PROBLEM OR CODE FOUND. WHEN THIS HAPPENS ,YOU HAVE NO POWER. YOU HAVE TO COAST TO THE SIDE OF THE ROAD AND CALL FOR HELP. *TR

UNTIL TODAY I HAVE BEEN A LOYAL FORD VEHICLE OWNER. MY WIFE WAS TAKING OUR THREE CHILDREN TO SCHOOL THIS MORNING AND AS SHE WAS MERGING ONTO THE HIGHWAY SHE WAS ALERTED TO AN UNFAMILIAR CODE AND ALARM IN THE VEHICLE. BEFORE SHE COULD LOOK AT THE DASHBOARD THE VEHICLE LOST ALL POWER AND WOULD NOT ACCELERATE IN THE ACCELERATION LANE, THE BRAKING AND STEERING BECAME MINIMAL AND SHE WAS LEFT WITH A LITTLE MORE THAN A DISABLED VEHICLE ON THE HIGHWAY. WITH HEAVY RUSH HOUR TRAFFIC RAPIDLY APPROACHING HER AND UNSURE WHETHER THEY COULD STOP SHE HAD TO FORCE THE VEHICLE TO THE EDGE OF THE GUARDRAIL. THE VEHICLE WHEN TURNED OFF AND RESTARTED APPEARED NORMAL. I THEN CHECKED PRIOR COMPLAINTS ON THIS WEB SITE AND OTHERS AND AM APPALLED OF THE LACK OF ACTION BY FORD MOTOR COMPANY AND OTHERS FOR NOT LOOKING INTO THIS ISSUE. THE LIVES OF THREE SMALL CHILDREN AND WHOEVER ELSE MAY HAVE BEEN INVOLVED IN THIS POTENTIAL COLLISION DESERVE TO HAVE FORD ACKNOWLEDGE THIS PROBLEM. I PURCHASED THE EXTENDED WARRANTY FROM FORD AND WHEN I TALKED ON THE PHONE WITH THEM THIS MORNING, THEY TOLD ME THAT THEY WOULD JUST "KEEP AN EYE ON IT". WHEN THEY LOOKED ON THE COMPUTER TO INFORM ME MY WARRANTY HAD EXPIRED 200 MILES AGO THEY CHANGED THEIR MIND AND TOLD ME TO BRING IT IN. PLEASE, PLEASE LOOK INTO THIS OBVIOUS DEFECT. I AM A POLICE OFFICER AND SEE TOO MANY FATALITIES DUE TO OTHER CONTRIBUTING FACTORS. I WOULD NOT WANT TO SEE ONE BECAUSE OF AN ORGANIZATION FAILING TO TAKE ACCOUNTABILITY.

SEVERAL TIMES WHILE DRIVING MY FORD 2005 EXPEDITION THE CAR STOPS RESPONDING TO THE THROTTLE AND LOSSES ALL POWER CAUSING AN UNSAFE CONDITION IN TRAFFIC. THE DASHBOARD WARNING SYSTEM DISPLAYS "CHECK ELECTRONIC THROTTLE CONTROL". AFTER SHUTTING THE ENGINE OFF AND WAITING SEVERAL MINUTES THE CAR CAN BE RESTARTED AND DRIVEN. WE HAVE INQUIRED ABOUT THIS ISSUE WITH NO SATISFACTION. *TR

I HAVE A 2005 EXPEDITION AND IT JUST CUT OFF! I WAS DRIVING ABOUT 40 MILES PER HOUR AND IT JUST CUT OFF WHILE I WAS PRESSING ON THE GAS. I HAD TO COAST OFF THE SIDE OF THE ROAD. I ALMOST GOT IN AN ACCIDENT! A WARNING ALERT SAID CHECK ELECTRONIC THROTTLE AND I COULD NOT MOVE IT AND JUST STOP AND DIED. I WAITED ABOUT 5 MINUTES AND TRIED TO START MY CAR AGAIN AND IT STARTED. THE ENGINE LIGHT WAS ON AND TOOK IT TO AUTOZONE AND THE DIAGNOSTIC SAYS THAT THE THROTTLE IS STUCK. THIS HAPPENED TO ME LAST YEAR AROUND ABOUT THE SAME TIME AND JUST WENT AWAY. THE YEAR BEFORE I BROUGHT THE CAR FROM THE DEALERSHIP AND IT DID THIS TO ME 3 DAYS AFTER I BOUGHT IT. I TOOK IT BACK TO GET IT REPAIRED AND THEY FIXED IT NO CHARGE. NOW THEY ARE TRYING TO CHARGE ME. IT COST 700 DOLLARS EVERYTIME THIS PART GOES OUT. WHY SHOULD I HAVE TO KEEP GETTING THIS REPAIRED? THERE SHOULD BE A RECALL ON THIS VEHICLE (ELECTRIC THROTTLE). THERE ARE PLENTY OF COMPLAINTS ABOUT THIS PART. PLEASE INVESTIGATE AND SEE FOR YOURSELVES. IF YOU DO RESEARCH ON HOW MAY TIME PEOPLE HAVE TO GO FOR REPEAT REPAIR, I AM SURE IT WOULD BE OFF THE CHARTS. IT HAS A POOR DESIGN. IT COULD POTENTIALLY GET SOME KILLED, IF NOT ALREADY. I WAS IN THE CAR WITH MY CHILDREN AND I WAS SCARED! *TR

WHILE TRAVELING AT APPROXIMATELY 60 MPH IN MORNING RUSH HOUR ON A MAJOR HIGHWAY A MESSAGE APPEARED ON THE DISPLAY BOARD STATING CHECK ELECTRONIC THROTTLE SENSOR VEHICLE THEN IMMEDIATELY DIED AND I WAS UNABLE TO ACCELERATE. I WAS ABLE TO COAST TO THE SHOULDER ATTEMPTING TO AVOID ANY COLLISIONS. ONCE I CAME TO A STOP I PLACED THE VEHICLE IN PARK AND TURNED THE IGNITION OFF. AFTER A FEW MINUTES I RESTARTED THE CAR WITHOUT ANY PROBLEMS. THE MESSAGE ON THE DISPLAY SCREEN WAS NO LONGER THERE BUT THE CHECK ENGINE WAS ON. FOR THE REMAINDER OF THE DAY I HAD NO FURTHER ISSUES. THE FOLLOWING DAY AFTER WORK IT HAPPENED AGAIN IN 5:00 TRAFFIC. ONCE RETURNING HOME I BEGAN TO DO SOME RESEARCH ON THIS ISSUE. TO MY SURPRISE I AM NOT THE ONLY ONE HAVING THIS ISSUE. THERE ARE 100'S OF POST ON LINE IN MULTIPLE PLACES INQUIRING ABOUT THIS ISSUE. MY CONCERN IS THE SAFETY OF MY FAMILY AND OTHERS THAT MAY BE ON THE HIGHWAY WHEN THIS ISSUE OCCURS. WHEN THIS OCCURS YOU ARE UNABLE TO ACCELERATE. THIS COULD CAUSE SEVERE ACCIDENTS AS WELL AS DEATHS IF THIS ISSUE IS NOT ADDRESSED. *TR

CAR WAS RUNNING FINE THEN BEEP AND WARNING SHOWS ON DASH SOMETHING ABOUT "ELECTRONIC THROTTLE CONTROL'. THE CAR IS STILL RUNNING BUT GAS PEDAL DOESN'T WORK. I WAS STUCK AT A STREET LIGHT STOPPED UNTIL I COULD TURN OFF AND RESTART THE CAR. THIS IS THE 2ND INCIDENT WITH THIS VEHICLE. IT HAPPENED THE FIRST TIME DRIVING OVER 50 MPH ON A HIGHWAY AND HAD TO COAST TO THE SIDE OF THE ROAD. THERE IS APPARENTLY NOTHING THAT CAN BE FOUND WRONG AND NO WAY TO TELL IF IT IS GOING TO HAPPENED AGAIN AND WHY IT HAPPENED. I HAVE NOT DONE ANYTHING TO REPAIR SINCE I CAN NOT FIND A REASON AS TO WHY IT HAPPENED TO HAVE IT REPAIRED. *TR

WHILE DRIVING ON TWO DIFFERENT OCCASIONS A MESSAGE HAS APPEARED ON MY INSTRUMENT PANEL SAYING, "CHECK ELECTRONIC THROTTLE CONTROL." WHEN THIS HAPPENS I IMMEDIATELY LOSE MY ACCELERATION. BOTH TIMES I WAS ON A HILL AND THANK GOODNESS I DID NOT LOSE BRAKING ABILITY AS DESCRIBED BY OTHERS. WHEN YOU ARE ON A HILL IN A VEHICLE OF THIS SIZE IT IS NEARLY IMPOSSIBLE TO MANEUVER TO A SAFE LOCATION. THE FIRST TIME THIS OCCURRED WAS NOVEMBER 27, 2009 AND AGAIN YESTERDAY, JANUARY 3, 2010. I AM ALMOST 6 MONTHS PREGNANT AND TRANSPORT 4 YOUNG CHILDREN TO AND FROM SCHOOL. AFTER RESEARCHING THIS PROBLEM ONLINE, I HAVE DISCOVERED THAT THIS IS A VERY COMMON PROBLEM ON THE 2005 FORD EXPEDITION. I AM VERY AFRAID THAT SOMEONE IS GOING TO BE SERIOUSLY INJURED OR KILLED BY THIS FAILURE. I HAVE READ MANY REPORTS ON HERE DATING BACK MORE THAN A YEAR AND I AM CURIOUS AS TO WHAT IT TAKES TO HAVE THIS RECALLED. HEAVEN FORBID SOMEONE LOSES THEIR LIFE. *TR

2005 FORD EXPEDITION EB FUEL PUMP BROKE AT 65000 MILES. AUTO BOUGHT BRAND NEW AND IN EXCELLENT CONDITION. FORD DEALER AND FORD REP CANNOT LOCATE THE REPLACEMENT PUMP.. SAID IT WILL BE LATE FEBRUARY IF I AM LUCKY. THIS IS MY MAIN MODE OF TRANSPORTATION!! *TR

1. THERE WERE NO EVENTS LEADING UP TO THE FAILURE. THERE IS NO WARNING THAT THIS IS GOING TO HAPPEN OR IS HAPPENING. UNDER NORMAL DRIVING CONDITIONS, MY 2005 FORD EXPEDITION SIMPLY LOST ALL POWER AND THE WORDS "ENGINE FAIL SAFE MODE" APPEARED. 2. THIS OCCURRED TWICE (OCT. 6, 2009 AND NOV. 16, 2009). I WAS ABLE TO PULL TO THE SIDE OF THE ROAD BOTH TIMES BUT DURING THE SECOND INCIDENT, I LOST THE POWER STEERING AS WELL AND STRUGGLED TO PULL OVER. THE CONSEQUENCES OF THIS "ENGINE FAIL SAFE MODE" IS THAT THE CAR STOPS WORKING. YOU BECOME A SITTING DUCK WHEREVER THE CAR HAS DECIDED TO GO INTO THIS MODE. YOU ARE UNABLE TO ACCELERATE -NOT FUN WHEN THIS HAPPENED ON THE FREEWAY THE FIRST TIME-AND IF YOU DO NOT LOSE YOUR POWER STEERING, YOU CAN PULL TO THE SIDE OF THE ROAD. 3. THE ELECTRONIC THROTTLE BODY WAS REPLACED FOR APPROXIMATELY $700. NOWHERE IN THE CAR MANUAL DOES IT LET YOU KNOW THAT THIS CODE COULD LEAD TO THIS REPAIR. I HAD A HARD TIME FIGURING OUT WHAT THE CODE MEANT USING THE OWNER MANUAL. THE MOST FRUSTRATING PART OF THIS FAILURE IS THAT IF THIS HAD OCCURRED WHEN I WAS TRAVELING AT 65 MPH ON THE FREEWAY, I PROBABLY WOULD NOT BE HERE TO ENTER THIS COMPLAINT. I WOULD LIKE TO PREVENT THIS FROM HAPPENING TO SOMEONE ELSE. *TR

TRANSMISSION ON 2005 EXPEDITION IS SLIPPING. WHEN THE VEHICLE IS PLACED INTO DRIVE AND THE FOOT THROTTLE IS DEPRESSED THE VEHICLE HESITATES TO MOVE FORWARD, BUT THEN JERKS FORWARD. OTHER TIMES IT SEEMS LIKE IT DOESN'T WANT TO UPSHIFT WHEN DRIVING ON THE FREEWAY. I MUST ALSO STATE THAT THE PAINT ON THE TIP OF THE HOOD AND ON THE TAILGATE ARE STARTING TO BUBBLE /BLISTER, THE VEHICLE IS ONLY 5 YEARS OLD AND THE PAINT IS CARED FOR THROUGH POLISHING AND WAXING TWICE A YEAR. *TR

I WAS DRIVING ON CENTRAL EXPRESSWAY THIS MORNING (12/4) AND MY 2005 FORD EXPEDITION GAVE ME AN "ELECTRONIC THROTTLE" ERROR MESSAGE AND SHUT DOWN. I WAS DRIVING ~50 MILES AN HOUR IN THE MIDDLE LANES. EXTREMELY UNSAFE AND SEE ON THE INTERNET THAT THERE HAVE BEEN SEVERAL 2005 EXPEDITIONS WHO HAVE EXPERIENCED THE SAME SITUATION. I THOUGHT THE PART WOULD HAVE BEEN RECALLED OR THAT FORD WOULD HAVE FIXED THIS PART AS I BOUGH THIS VEHICLE USED FROM THEIR DEALERSHIP. VERY DISAPPOINTING. *TR

I HAD JUST PICKED UP MY SON FROM HIS SCHOOL AND MADE A LEFT TURN AT THE STOP SIGN TO GO TO THE MAIN ROAD TO PICK MY DAUGHTER FROM HER SCHOOL WHEN THE BRAKES FAILED IN MY TRUCK. THE RED WAS AHEAD,CARS WERE LINED,KIDS WERE CROSSING THE ROAD,AND I HAD TO SOMETHING REALLY FAST. I DROVE IN TO A DRIVEWAY IN MY RIGHT WHICH WAS A PARKING FOR A HOSPITAL. I KEPT TRYING TO PUSH THE BRAKE PEDAL TO STOP THE CAR,BUT THE WOULDN'T STOP. IT WENT OVER THE CURB AND HIT A TREE. I CALLED THE POLICE, THEN MY INSURANCE,CAR WAS TOWED TO THE BODY SHOP. THE FORD STORE DID THE DIAGNOSTICS ON THE BRAKE AND TOLD MY INSURANCE COMPANY THAT THE BRAKE BOOSTER HAD FAILED.MY INSURANCE COMPANY GOT THE WORK STARTED FOR THE BODY DAMAGE. I CALLED THE FORD STORE SEVERAL TIMES ASKING FOR A COPY OF THE DIAGNOSTIC AND THE PERSON IN CHARGE WOULD NOT RETURN MY CALL OR GIVE ME A COPY.THREE WEEKS LATER WHEN BODY STARTED THEY SENT A REPORT TO THE BODY SHOP THAT THE CAUSE OF THE ACCIDENT, WAS UNDETERMINED SENT THIS REPORT AFTER HE SPOKE TO THE OFFICE OF THE GENERAL COUNSEL OF FORD. THE ACCIDENT OCCURRED AT 3:15 ON SEPT.17TH AND MY CAR WENT THROUGH A 60,000 MILE CHECK UP ON SEPT.16TH. AT THE FORD STORE. *TR

DRIVING 2005 FORD EXPEDITION PASSED THROUGH INTERSECTION DRIVING 45 MPH AND ALL OF A SUDDEN CAR LIGHT TURNED ON AND READ ELECTRONIC THROTTLE CONTROL FAILURE AND CAR IMMEDIATELY COULD NOT DRIVE OVER 5 MPH. I TURNED AND GOT OFF THE MAIN ROAD, SCARED THAT I WAS GOING TO GET HIT BY ANOTHER CAR. WAS ABLE TO TURN CAR BACK ON AFTER LEAVING THE CAR THEIR FOR A FEW HOURS, TOLD THAT I NEEDED TO REPLACE THE THROTTLE BODY AND I HAVE 53,000 AND NOT UNDER WARRENTLY. THIS IS A SAFETY CONCERN THIS COULD HAVE CAUSED A SERIOUS ACCIDENT! *TR

2005 FORD EXPEDITION 5.4 ENGINE, MISFIRING 3&5 CYLINDER. ROUGH IDLE. CAR HAS 127,000 MILES AND SINCE WE HAVE HAD IT I HAD ISSUES WITH IT IDLING IN PARK AND ALMOST AT TIMES WANTING TO STALL. ENGINE HAS ON MORE THAN 3 OCCASIONS WHILE DRIVING 60-70 MPH ON THE HIGHWAY BECOME UN RESPONSIVE WHILE DRIVING. ENGINE WOULD RUN BUT NO ACCELERATION WHEN THE GAS PEDAL WAS PUSHED; IT WAS LIKE THE CAR WAS RUNNING IN NEUTRAL. INDICATOR LIGHT CAME ON SHOWING "ENGINE FAILURE". PULLED OFF THE ROAD AND RESTARTED CAR AND THEN IT RAN FINE AGAIN. FORD SVC DEPT. COULD NOT REPLICATE THE SITUATION WHEN I TOOK IT TO THEM, SO IT WAS NEVER REPAIRED. (CLEARLY THERE IS A FAULTY PROBLEM) CURRENTLY CAR IS IN THE SHOP REPLACING ALL 8 SPARK PLUGS, COILS AND BOOTS. MECHANIC INDICATED A LOT OF CARBON BUILDUP IN THROTTLE BODY. (SEEMS TO ME POSSIBLY SOME OTHER FAULTY COMPONENT COULD BE WHY I'M HAVING TO SPEND $800 TO FULLY REPAIR MY CAR). *TR

2005 FORD EXPEDITION DISPLAYED "ELECTRONIC THROTTLE CONTROL FAILURE" MESSAGE AND ENGINE ABRUPTLY QUIT AT HIGH SPEED IN TRAFFIC ON A CURVED ROAD RESULTING IN A SIMULTANEOUS LOSS OF POWER STEERING AND POWER BRAKES. THIS APPEAR TO BE A COMMON PROBLEM FOR WHICH THERE HAS BEEN NO SAFETY RECALL. A FAILURE LIKE THIS WITH NO MECHANICAL BACKUP FOR ENGINE THROTTLE CONTROL IS A SERIOUS SAFETY ISSUE. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING 25 MPH THE CHECK ELECTRONIC THROTTLE CONTROL WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL, AND THEN THE VEHICLE STALLED. HE WAS ABLE TO SAFELY RESTART THE VEHICLE TO RESUME NORMAL VEHICLE OPERATION. THE DEALER WAS NOTIFIED, AND A TECHNICIAN STATED THAT THEY WERE AWARE OF THE FAILURE, BUT BECAUSE THEY WERE NO RECALLS THEY WOULD NOT PROVIDE ANY ASSISTANCE. THE VEHICLE WILL BE REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 45000.

2005 FORD EXPEDITION - ENGINE DEFAULTS TO "LIMP HOME" MODE WHILE IN TRAFFIC. HAS OCCURRED TWICE SO FAR BUT HAVE BEEN ABLE TO NEGOTIATE GETTING OFF THE ROAD. VEHICLE HAS RESTARTED AFTER SITTING FEW MINUTES. *TR

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. WHEN HE ATTEMPTED TO DRIVE THE FAIL SAFE MODE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL, AND THEN THE VEHICLE STALLED. THE THROTTLE ALSO DISENGAGED, WHICH CAUSED THE VEHICLE TO DRIVE IN NEUTRAL GEAR. HE USUALLY HAS TO RESTART THE VEHICLE TO RESUME NORMAL OPERATION. NO REPAIRS WERE MADE. THE FAILURE MILEAGE WAS 51,195. THE CURRENT MILEAGE WAS 61,000.

2005 EXPEDITION HAS SEVERE ENGINE TICKING PROBLEM (SOUNDS LIKE A DIESEL) ORIGINAL COMPLAINT WAS BEFORE WARRANTY EXPIRED TOLD BY DEALER THAT IT WAS THE "3 VALVE MOTOR NOISE". WHEN IT GOT WORSE AT AROUND 37K MILES (1K) OUT OF WARRANTY DEALER THEN TELLS ME THAT THERE HAS BEEN A TSB ISSUED (TSB 06-4-7 ORIGINAL VERSION WAS ACTUALLY ISSUED SHORTLY AFTER THE TRUCK WAS BUILT) IT IS THE CAM PHASERS AND VALVE LASH ADJUSTERS AND IT WILL BE $3000 TO REPAIR AND NOW NOT COVERED UNDER WARRANTY. I HAVE REPEATEDLY WORKED WITH THE DEALER AND FORD CUSTOMER CARE TO RESOLVE ISSUE THE LAST PERSON AT CUSTOMER CARE TOLD ME "ITS YOUR PROBLEM" JUST BEFORE HANGING UP ON ME. THIS AFTER A SIMILAR PULLING TEETH EPISODE TO GET THEM TO FIX THE KNOWN CORROSION PROBLEM THAT THEY HAD AND DENIED BEFORE I FOUND A TSB ABOUT THAT TOO, I NOW HAVE ANOTHER LARGE RUST SPOT ON MY BACK DOOR THAT THE WILL NOT FIX EITHER. ALL OF THIS AFTER I PAID $4000 TO GET RID OF THE LINCOLN LS THAT I OWNED THAT THEY COULD NOT KEEP RUNNING AFTER DUMPING THOUSANDS OF DOLLARS INTO A COP PROBLEM THAT WAS EVENTUALLY COVERED UNDER A CUSTOMER CARE PROGRAM. I SURE DID NOT GET ANY MONEY BACK ON THAT. SOMEONE HAS TO WAKE SOMEONE OVER AT FORD UP AND GET THEM TO FIX THIS GARBAGE THEY HAVE BEEN TURNING OUT.. *TR

WHILE TRAVELING AT AROUND 50-60 MPH, THE VEHICLE LOST POWER AND I PULLED OVER INTO A PARKING LOT. THE DASH EXHIBITED A SYMBOL IMPLYING THE "ELECTRONIC THROTTLE" WAS MALFUNCTIONING. THIS IS QUITE DANGEROUS BECAUSE IT OCCURS WHILE DRIVING DOWN THE STREET WITH NO PRIOR WARNING. DO NOT KNOW YET HOW MUCH REPAIR WILL BE AS IT OCCURRED TODAY. NOTICED ON WEBSITE COMMENTS SECTION THAT THIS HAPPENS FREQUENTLY WITH THE 2005 FORD EXPEDITION. WANT TO KNOW WHAT FORD IS DOING ABOUT THIS. *TR

I HAVE A 2005 FORD EXPEDITION THAT HAS PAINT BUBBLING IN DIFFERENT AREAS. I DID SOME RESEARCH ON-LINE AND FOUND THAT FORD ISSUED A TECHNICAL SERVICE BULLETIN 04-25-1 IN 2004 AND ANOTHER BULLETIN 06-25-1 IN 2006 THAT EXPLAINS THAT PRIOR TO PAINTING, IRON PARTICLES CONTAMINATED THE ALUMINUM PANEL WHICH CAUSES THE PAINT BUBBLES DOWN THE ROAD. IN MY RESEARCH ON-LINE, I FOUND THAT FORD IS NOT TAKING CARE OF THEIR CUSTOMERS, BUT SOME DEALERS ARE COVERING SOME OF THE REPAIRS UNDER A "GOODWILL POLICY". I CONTACTED A LAWYER THAT SPECIALIZES IN LEMON-LAW, AND HE SUGGESTED I FILE THIS COMPLAINT. HE SAYS IF ENOUGH PEOPLE COMPLAIN, IT MAY FORCE FORD TO TAKE ACTION AND TAKE CARE OF THEIR CUSTOMERS. I DID CONTACT MY DEALERSHIP, AND THEY SAY THEY NEVER HEARD OF THIS PROBLEM. I AM PAST MY 3 YEAR WARRANTY, SO THEY SAY IT IS NOT COVERED. *TR

2005 FORD EXPEDITION, PAINT CRACKING AND PEELING ON THE ROOF. OF COURSE I DID NOT NOTICE IT TILL 102,000 MILES. I DID TAKE IT TO THE DEALER AND THEY BASICALLY TOLD ME THAT FORD WOULD NOT HAVE FIXED IT 100% ANYWAY. THEY DO A ONE-THIRD (FORD), ONE-THIRD (DEALER), ONE-THIRD (CUSTOMER) PAYS. I FIND THIS VERY UNACCEPTABLE. YOU BUY A $60+++ VEHICLE AND THE PAINT HOLDS NO GUARANTEE. I GUESS I'M LUCKIER THAN THE OTHER GUY THOUGH, YOU REALLY DON'T NOTICE THE ROOF. THE DEALER SAID IT WOULD BE ABOUT A $1500 REPAINT. I PLAN ON CHIPPING IT OFF AS MUCH AS I CAN, SANDING IT AND THEN GETTING SOME BLACK PLASTISOL COATING. LUCKILY AGAIN MY EXPEDITION IS BLACK AND THE PROBLEM IS BETWEEN THE LUGGAGE RACK RUNNERS AND SUNROOF. *TR

I HAVE A 2005 FORD EXPEDITION XLT (100K MILES, V8, A-TRANS). THE DRIVERS SIDE WINDOW IS STUCK PERMANENTLY IN THE OPEN POSITION. I AM TOLD THE REGULATOR IS BROKEN AND MUST BE REPLACED. *TR

OWN A 2005 FORD EXPEDITION, IN THE PAST 6 MONTHS AT ABOUT A RATE OF ONCE/MONTH THE ENGINE WILL SHUT OFF LOSS OF POWER WITH DIFFICULTY STEERING, THE VEHICLE HAS INDICATED THAT THE ELECTRONIC THROTTLE CONTROL IS THE ISSUE. ONCE I'M ABLE TO COAST THE VEHICLE TO THE SIDE OF THE ROAD I SHUT OFF THE VEHICLE AND RESTART WITHIN A FEW MINUTES AND ABLE TO CONTINUE UNTIL THE NEXT INCIDENT WITH THIS PROBLEM. I HAVE RESEARCHED THROUGH THE INTERNET AND HAVE FOUND NUMEROUS COMPLAINTS IN REFERENCE TO THIS SAME ISSUE WITH SOME INVOLVING ACCIDENTS DUE TO THE INADVERTENT LOSS OF POWER. I HAVE CONTACTED THE FORD MOTOR COMPANY AND THEY WILL ONLY TELL ME THAT THEY WILL NOT DO ANYTHING TO COVER THIS. THIS IS A SERIOUS SAFETY ISSUE AND NEEDS TO BE ADDRESSED BEFORE SOMEONE IS KILLED IN A MOTOR VEHICLE ACCIDENT DUE TO THIS PROBLEM. *TR

THE PAINT IS BUBBLING AND PEELING ON THE HOOD AND REAR LIFT GATE. THIS PROBLEM STARTED AND KEEPS GETTING WORSE. THE PAINT HAS ALREADY CAME OFF IN A 1 INCH SECTION. I COULD SEND I A PIECE OF THE PAINT TO A LAB IF NEEDED. CAR WAS NEVER IN ACCIDENT OF RE-PAINTED. *TR

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING 55 MPH, THREE OUT OF THE FOUR TIRES FLATTENED AND CAUSED THE CONTACT TO CRASH INTO A CONCRETE WALL. A POLICE REPORT WAS FILED AND THE VEHICLE WAS TOWED FROM THE SCENE. THERE WERE NO INJURIES. THE INSURANCE COMPANY IS INVESTIGATING THE CAUSE OF THE TIRE FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 64,000.

I HAVE A 2005 EXPEDITION EDDIE BAUER AND THE LIFT GATE WILL OPEN ON OCCASION. THE DEALER CANNOT FIND ANYTHING WRONG TO CAUSE THIS BUT IS AWARE OF OTHER COMPLAINTS. I BOUGHT THE VEHICLE BRAND NEW AND STARTED TO ENCOUNTER THIS PROBLEM AT 37,000 MILES WHEN THE WARRANTY RAN OUT. I AM AFRAID THIS WILL HAPPEN WHILE I AM TRANSPORTING MY DOGS TO A DOG SHOW AND THEIR CRATES WILL BE THROWN OUT OF THE REAR ONTO THE HIGHWAY. *TR

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT BOTH THE FRONT DRIVER'S AND PASSENGER SEATS WOULD NOT MOVE UP AND DOWN. IN ADDITION, THE FRONT PASSENGER WINDOW WAS THE FIRST TO SUDDENLY STOP WORKING. WITHIN SIX MONTHS, THE FRONT DRIVER'S SIDE WINDOW ALSO BEGAN TO FAIL. THE VEHICLE IS CURRENTLY AT THE DEALER, BUT THEY ARE NOT ASSUMING RESPONSIBILITY FOR THE REPAIRS. THE CONTACT BELIEVES THAT THIS IS A MANUFACTURER DEFECT. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 57,000 AND CURRENT MILEAGE WAS 63,000.

ELECTRIC THROTTLE CONTROL WENT OUT WHILE DRIVING AST 60 MPH ALSO IGNITION FUSE WENT OUT SO CAR WAS DEAD LEAVING ME STRANDED IN THE MIDDLE OF NO WHERE WITH 4 GIRLS IN THE CAR. THE ENGINE LITERALLY STOPPED WHILE I WAS DRIVING AT 60 MPH. COULD HAVE BEEN VERY DANGEROUS IF ON A CROWDED INTERSTATE. *TR

I RECENTLY TOOK MY 2005 FORD EXPEDITION FOR A TUNE-UP AT A LOCAL SHOP. THE OWNER OF THE SHOP TOLD ME THAT THE SPARK PLUG IN CYLINDER #4 BROKE AND IS STUCK IN THE ENGINE. THE SAFEST WAY TO REMEDY THE PROBLEM IS TO TAKE THE ENGINE HEAD OFF TO TAKE OUT THE BROKEN SPARK PLUG. I DID A RESEARCH ON THE INTERNET AND FOUND THAT FORD'S DESIGN OF THE SPARK PLUGS CAUSES THE THREAD TO SEPARATE FROM THE SPARK PLUG ITSELF LEADING TO THE BREAKING OF THE PLUGS. THERE ARE ALSO INSTANCES WHERE THE SPARK PLUG IS EJECTED FROM THE ENGINE. I TRIED TO FILE A COMPLAINT WITH FORD MOTOR COMPANY; HOWEVER, THEY REFUSED TO CALL IT A DEFECT IN THEIR SPARK PLUG DESIGNS. *TR

WAS DRIVING DOWN A 4 LANE HEAVY TRAFFIC ROAD IN FAIR WEATHER CONDITIONS AROUND 45 MPH WHEN VEHICLE MAINTENANCE LIGHT "CHECK ELECTRONIC THROTTLE CONTROL" CAME ON AND COMPLETELY SHUT OFF ANY DRIVING POWER TO MY VEHICLE. I WAS NOT EVEN ABLE TO ACCELERATE TO PULL OVER SAFELY. I WAS DRIVING WITH A 3 YEAR OLD AND I AM ALSO 6 MONTHS PREGNANT. WHEN THE CAR FINALLY STOPPED ITSELF, I SHUT THE ENGINE OFF, WAITED A MINUTE AND STARTED IT UP AGAIN. IT STARTED ROUGHLY, BUT THEN WAS FINE. CALLED FOX FORD DEALERSHIP IN GRAND RAPIDS, MI THAT I NORMALLY DEAL WITH AND THEY SAID THAT IT WOULD BE THE THROTTLE BODY WITH THROTTLE CONTROL SENSORS IN IT. MY TYPE OF WARRANTY (POWERTRAIN) DOES NOT COVER IT AND IT WILL RUN BETWEEN $500 - $700 TO FIX IT. CONTACTED FORD ITSELF. THERE IS NO RECALL ON THIS ITEM, ALTHOUGH I'VE NOTICED TONS OF COMPLAINTS ON THE INTERNET ABOUT IT. HTTP://WWW.FIXYA.COM/CARS/T1061679-ELECTRONIC_THROTTLE_CONTROL_LIGHT_CAME HAS AT LEAST 4 RIGHT THERE. THIS IS A VERY DANGEROUS PROBLEM. LUCKILY I WAS NOT DRIVING 70 MILES AN HOUR ON THE HIGHWAY WHEN THIS HAPPENED. THIS NEEDS TO BE RECALLED DUE TO SAFETY HAZARDS. I SEE IT CAUSING A MAJOR ACCIDENT IN THE FUTURE IF IT HASN'T ALREADY. THERE ARE TONS OF DO-IT-YOURSELF FIX-IT SITES WITH TONS OF PEOPLE REPORTING THIS SAME PROBLEM WITH THIS SAME YEAR VEHICLE. I DON'T SEE WHY IT HASN'T BEEN RECALLED YET. THIS IS DANGEROUS!! HOW CAN THEY EXPECT FAMILIES TO BE DRIVING SAFELY JUST TO BE SHUT OFF BY IT'S OWN VEHICLE THAT'S ONLY 4 YEARS OLD!! RIDICULOUS! *TR

WHILE DRIVING OUR 2005 FORD EXPEDITION THE "CHECK THROTTLE" LIGHT CAME ON. THE CAR IMMEDIATELY QUIT RUNNING AND FORTUNATELY I WAS ABLE TO COAST TO A STOP. WE CALLED OUR FORD DEALERSHIP AND WAS TOLD THEY THOUGHT A RECALL HAD BEEN ISSUED FOR THIS PROBLEM. WE TOOK THE CAR TO THE FORD DEALERSHIP AND WAS TOLD THEN THAT THEY COULD NOT FIND A RECALL FOR THIS PROBLEM. IT COSTS US $626.37. WE HAVE SINCE LEARNED THAT THERE HAVE BEEN NUMEROUS COMPLAINTS ABOUT THIS SAME PROBLEM ON 2005 FORD EXPEDITIONS. WAS TOLD WHEN WE CALLED FORD HEADQUARTERS THAT WE NEEDED TO FILE A COMPLAINT. *TR

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING BETWEEN 55-60 MPH, A TRACTOR TRAILER MERGED OVER AND CAUSED THE CONTACT TO CRASH INTO A TREE. NONE OF THE AIR BAGS DEPLOYED IN THE VEHICLE. THE CONTACT SUSTAINED FACIAL INJURIES AND THREE OTHER PASSENGERS SUSTAINED MINOR INJURIES. ONE OCCUPANT SUFFERED MAJOR INJURIES. THE VEHICLE WAS DESTROYED. THERE WAS ADDITIONAL PROPERTY DAMAGE TO THE HIGHWAY MEDIAN. A POLICE REPORT WAS FILED. ALL OF THE PASSENGERS WERE WEARING SEAT BELTS AT THE TIME OF THE CRASH. THERE WERE NO REPAIRS MADE TO THE AIR BAGS PRIOR TO THE CRASH. THE VEHICLE HAS NOT BEEN INSPECTED BY A DEALER. THE CONTACT'S INSURANCE COMPANY IS REVIEWING THE DAMAGE AND SENDING A RECONSTRUCTIONIST TO INVESTIGATE. THE CURRENT AND FAILURE MILEAGES WERE 85,000.

WHILE DRIVING WITH A SMALL CHILD IN THE CAR - LESS THAN 15MPH NEAR A RESIDENTIAL AREA - MY 2005 FORD EXPEDITION LTD SUDDENLY FLASHED AN ERROR MESSAGE "CHECK ELECTRONIC THROTTLE CONTROL" AND IMMEDIATELY LOST ACCELERATION, BRAKING AND STEERING. I WAS ABLE TO VEER THE VEHICLE TO THE SIDE OF THE ROAD WITHOUT CAUSING AN ACCIDENT. I USED THE EMERGENCY BRAKE TO STOP THE VEHICLE AT WHICH TIME I MANUALLY TURNED OFF THE IGNITION. WAITED A FEW MOMENTS, AND MANAGED TO GET THE VEHICLE STARTED AND RUNNING AGAIN. THERE WAS ABSOLUTELY NO WARNING AND THE VEHICLE GIVES YOU NO OPPORTUNITY TO GET THE VEHICLE PULLED OVER SAFELY BEFORE DISENGAGING. THIS APPEARS TO BE A VERY SERIOUS AND DANGEROUS SUDDEN MECHANICAL FAILURE. *TR

I WAS DRIVING MY CAR WHEN ELECTRONIC THROTTLE CONTROL LIGHT CAME ON AND MY CAR LOST POWER INSTANTLY AND STALLED. I HAVE 57,000 MILES ON MY CAR. I AM NOT COVERED UNDER WARRANTY BUT DUE TO THE NATURE OF THE PROBLEM, I FIGURED FORD WOULD HAVE RECALLED THIS FAULTY PART BECAUSE OF SAFETY CONCERNS. I TRAVEL DAILY WITH 3 CHILDREN AND THIS PROBLEM HAPPENED TO ME TWICE BEFORE I TOOK IT IN TO DEALERSHIP. THANKFULLY NO ONE WAS BEHIND ME BOTH TIMES. I HAD TO PAY OVER $500 TO HAVE THE PART REPLACED. I CALLED FORD TO EXPRESS MY CONCERN AND THEY BASICALLY DID NOTHING BUT TAKE MY INFORMATION AND THEN TURN THE CALL INTO A SALES EFFORT. THEY ADVISED ME THERE WERE GREAT PROMOTIONS AND REBATES ON NEW VEHICLES RIGHT NOW. LIKE I WOULD WANT TO BUY A FORD AGAIN WHEN THEY HAVE NO REGARD FOR CONSUMER SAFETY!!! *TR

2005 FORD EXPEDITION DRIVERS SIDE WINDOW REGULATOR BROKE AND WINDOW DROPPED INTO DOOR PANEL WITH A LOUD CRASHING SOUND WHILE DRIVING. I'M REPORTING THIS TO YOU BECAUSE OF SEVERAL OTHER REPORTS I FOUND ON-LINE REGARDING THE SAME ISSUE. THIS SEEMS TO BE A RECURRING SAFETY PROBLEM THAT NEEDS TO BE LOOKED INTO, AND POSSIBLY A RECALL ISSUE. *TR

2005 FORD EXPEDITION WITH ERROR MESSAGE OF 'CHECK ELECTRONIC THROTTLE CONTROL'. IT HAS HAPPENED 5 TIMES NOW. ENGINE, STEERING AND BRAKING STOP WORKING INSTANTLY. I HAVE TO SHUT TRUCK OFF TO RESTART. ALL TIMES IT HAS HAPPENED WHILE GOING 60-70 MILES AN HOUR ON HIGHWAY. FORD HAS CHARGED ME OVER $1200 TO THIS DAY FOR FIXES, BUT NOTHING HAS FIXED THE PROBLEM. THEY ALSO HAVE NO ANSWER AS TO WHY IT KEEPS RECURRING. WHEN THEY HOOK IT UP TO THE COMPUTER, THEY SAY THERE ARE NO ERROR CODES. *TR

WHILE DRIVING ON TWO SEPARATE OCCASIONS SUDDENLY THE CHECK ENGINE THROTTLE CONTROL LIGHT HAS COME ONE. UPON SAFELY PULLING OVER AND RESTARTING THE CAR THE LIGHT GOES OFF AND APPARENTLY THE THROTTLE RESETS. THE DANGER IS THAT WHEN THE LIGHT COMES ON THE CAR GOES INTO IDLE ONLY MODE. NO ACCELERATING, ETC. THERE IS NO WARNING THAT THIS IS GOING TO HAPPEN AND NO OTHER REMEDY. THE FIRST TIME I WAS IN A CARPOOL SETTING IDLING. THE SECOND TIME I HAD JUST GOTTEN OFF THE INTERSTATE AND WAS ABLE TO PULL INTO A SHOPPING CENTER. THIS IS A MAJOR SAFETY CONCERN IF IT HAPPENS ON THE INTERSTATE. I HAVE TAKEN THE CAR IN TO HAVE A DIAGNOSTIC EVALUATION AND THERE IS NO KNOWN CAUSE OF THE FAILURE. AFTER READING 100S OF SIMILAR COMPLAINTS ONLINE IT IS APPARENT THIS IS A PROBLEM FOR THE MAKE AND MODEL THAT NEEDS TO BE INVESTIGATED. *TR

2005 FORD EXPEDITION WILL DIE WHILE DRIVING AND A WRENCH LIGHT APPEARS ON THE DASH. THIS HAS HAPPENED MORE THAN 5 TIMES IN THE LAST MONTH. THE DEALER HAS STATED THAT THERE ARE THOUSANDS OF THESE OCCURRENCES WITH THE THROTTLE BODY NEEDING TO BE REPLACED AT AN $800 OWNERS EXPENSE. THE EXPEDITION IS NOT THE ONLY MODEL HAVING THIS PROBLEM. *TR

THIS IS THE 5TH TIME THIS PARTICULAR MALFUNCTION HAS OCCURRED WITHIN A 4 MONTH PERIOD. WHILE CRUISING AT LOW SPEED (5-15 MPH) IN STOP AND GO TRAFFIC, THE ENGINE LIGHT ILLUMINATES AND THE VEHICLE SHUTS DOWN. WITH THE VEHICLE ENGINE OFF THERE ISN'T ANY POWER STEERING AND DRIVER MUST MANEUVER SAFELY TO THE SIDE OF THE ROAD AND COME TO A COMPLETE STOP, PLACE VEHICLE IN PARK AND RESTART THE ENGINE. THE ERROR MESSAGE IS ABOUT THE THROTTLE CONTROL AND THE VEHICLE IS ONLY 4 YEARS OLD WITH 64,000 MILES. THIS IS A SAFETY CONCERN ESPECIALLY AT HIGH RATES OF SPEED AND THE PART IS NOT COVERED BY THE VEHICLE WARRANTY. I WENT TO THE FORD DEALER WHERE WE PURCHASED VEHICLE AND WAS CHARGED $684.00 TO REPLACE THE ELECTRONIC THROTTLE CONTROL. THAT'S WHEN I LEARNED THAT THIS MALFUNCTION HAS RECENTLY BEEN OCCURRING ON SEVERAL 2005 FORD EXPEDITION VEHICLES IN THE LAST 6 MONTHS. APPARENTLY, THERE IS NO FORD RECALL FOR THIS PART AND IT IS A TRUE SAFETY CONCERN FOR ALL FORD EXPEDITION OWNERS. *TR

MY 05 FORD EXPEDITION WAS RECENTLY IN THE SHOP SEVERAL MONTHS BACK FOR ELECTRONIC THROTTLE ISSUES. TONIGHT THE CHECK ELECTRONIC THROTTLE LIGHT CAME ON AND CAUSED A TOTAL LOSS OF ACCELERATION. I PUT MY HAZARDS ON AND COASTED TO THE SIDE OF THE ROAD. AFTER TURNING OFF MY ENGINE AND RESTARTING MY VEHICLE RUNS LIKE NORMAL AGAIN. LUCKILY IT WAS VERY LATE AT NIGHT AND NO OTHER CARS WERE AROUND. THIS IS POTENTIALLY VERY DANGEROUS IF IT OCCURS IN FAST MOVING TRAFFIC. I HAVE RESEARCHED THIS ISSUE AND SEE COUNTLESS POSTS ON INTERNET FORUMS FROM 05 FORD EXPEDITION OWNERS DETAILING MY EXACT ISSUE AND TEMPORARY SOLUTION. WHEN IS THIS GOING TO BE OFFICIALLY ACKNOWLEDGED BY FORD AS A SERIOUS DEFECT AND RECALLED? *TR

WHILE DRIVING THE CAR ON THE HIGHWAY WITH CHILDREN IN THE VEHICLE, THE ENGINE LIGHT CAME ON, MESSAGE CAME ON ABOUT ELECTRONIC THROTTLE CONTROL , AND THE VEHICLE LOST ALL FUNCTIONS OF STEERING, BRAKING, AND ACCELERATING. THERE WERE NO WARNINGS BEFORE THIS HAPPENED. AFTER TAKING IT TO THE FORD DEALER TODAY, I SEE ON THE INTERNET THAT MANY MANY MANY FAMILIES ARE HAVING THIS SAME PROBLEM WITH 2005 FORD EXPEDITIONS. SEEING AS THE PROBLEM CREATES AN IMMEDIATE SAFETY CONCERN FOR NOT ONLY THE FAMILY IN THE 2005 FORD EXPEDITION, BUT ALL THE FAMILIES TRAVELING AROUND THE 2005 FORD EXPEDITION... I FEEL LIKE THE SAFETY BOARD SHOULD LOOK INTO THIS AS A POTENTIAL RECALL FOR 2005 FORD EXPEDITIONS. THANKFULLY MY FAMILY IS SAFE TODAY...BUT SOMEONE'S FAMILY MAY NOT BE SO LUCKY. *TR

2005 FORD EXPEDITION WAS STOPPED AT STOP SIGN. "CHECK ELECTRONIC THROTTLE CONTROL" MESSAGE WAS DISPLAYED ON MESSAGE CENTER, ALONG WITH AN ANNUNCIATING "DING". ENGINE CONTINUED TO RUN, BUT ACCELERATOR PEDAL WAS COMPLETELY DEAD. SHUT OFF IGNITION AND RESTARTED VEHICLE, AND ACCELERATOR CONTROL RETURNED TO NORMAL. THERE WAS ONE OCCURRENCE SO FAR. *TR

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING APPROXIMATELY 10 MPH ON NORMAL ROAD CONDITIONS, THERE WAS NO RESPONSE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. AN UNKNOWN WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL INTERMITTENTLY. ROADSIDE ASSISTANCE WAS CALLED TO THE SCENE AND THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR INSPECTION. THE TECHNICIAN STATED THAT THE TRANSMISSION FAILED. THE DEALER REPLACED THE AUTOMATIC TRANSMISSION. THE FAILURE MILEAGE WAS 59,991 AND CURRENT MILEAGE IS 62,000. UPDATED 05/06/09. *LJ UPATED 05/07/09.*JB

I WAS DRIVING 55MPH ON HIGHWAY, WHEN ALL OF A SUDDEN THERE WAS NO POWER TO GAS PEDAL. THE CHECK ELECTRONIC THROTTLE CONTROL LIGHT FLASHED, I PULLED OVER THREE LANES TO SIDE OF ROAD. I SAT THERE TRYING TO START VEHICLE CONTINUOUSLY, FINALLY AFTER 10 MINUTES IT STARTED. MY 9 MONTH OLD DAUGHTER AND I WAS ALMOST KILLED ON THE HIGHWAY DUE TO THIS PROBLEM. MY VEHICLE IS NOW RUNNING TERRIBLE. I CAME HOME TO SEE IF I COULD FIND ANYTHING ON THE INTERNET AND FOUND THAT THIS IS COMMON IN THE 2005 FORD EXPEDITION AND NOTHING IS BEING DONE. IS IT GOING TO TAKE SOMEONE GETTING KILLED FOR FORD TO RECALL THIS PROBLEM? IT OBVIOUSLY IS A MANUFACTURING PROBLEM AND THEY ARE DOING NOTHING ABOUT IT. I WILL BE CONTACTING FORD TOMORROW TO SEE ABOUT GETTING MY VEHICLE IN AND FIXING THIS. *TR

AS I WAS DRIVING TO MY OFFICE SHORTLY AFTER NOON TODAY, AN ALERT APPEARED "CHECK ELECTRONIC THROTTLE SYSTEM." MY EXPEDITION WOULD NOT ACCELERATE, I COASTED INTO A PARKING LOT AND TRIED TO ACCELERATE, BUT NOTHING HAPPENED. I TURNED OFF THE ENGINE AND RESTARTED MY VEHICLE - I COULD THEN ACCELERATE MY VEHICLE AND CONTINUED TO MY OFFICE. THIS IS WAS A VERY SCARY INCIDENT, THANKFULLY I WAS THE ONLY ONE IN MY VEHICLE TODAY; MY GRANDSON IS SOMETIMES WITH ME. I AM ALSO THANKFUL THAT I WAS IN THE RIGHT LANE, SO I WAS ABLE TO COAST INTO THE PARKING LOT. *TR

WHILE DRIVING MY 2005 FORD EXPEDITION (4 SEPARATE INCIDENTS) DOWN THE ROAD, A WARNING MESSAGE APPEARS ON THE MESSAGE CENTER TO "CHECK ELECTRONIC THROTTLE CONTROL". THE VEHICLE LOSES ALL ACCELERATION, ACCELERATOR DOES NOT WORK, I HAVE TO COAST TO THE SIDE OF THE ROAD, RESTART THE VEHICLE THEN IT RUNS FINE. VERY DANGEROUS, FORTUNATELY NO ONE HURT AND NO DAMAGE. BUT IF THIS WOULD HAPPEN ON AN INTERSTATE IN THE LEFT LANE IN HEAVY TRAFFIC...?? VERY SCARY SITUATION! ACCORDING TO MY MECHANIC AND A FORD DEALERSHIP, THEY CANNOT FIND A CAUSE AND NO FAULT CODES COME UP IN COMPUTER. SUGGEST POSSIBLE FIX OF REPLACING THE THROTTLE BODY FOR ABOUT $700-800, WITH NO RESPONSIBILITY FROM FORD. *TR

ON MY 2005 FORD EXPEDITION I HAVE GOTTEN AN ALERT OF "CHECK ELECTRONIC THROTTLE SYSTEM". ON TWO OCCASIONS WHEN THIS ALERT HAS SOUNDED, THE VEHICLE HAS DIED OUT IN THE MIDDLE OF TRAVEL AND I HAD TO GET TO THE SIDE OF THE ROADWAY TO RESTART. ON TWO OTHER OCCASIONS WHEN THIS ALERT HAS SOUNDED, THE VEHICLE DID NOT DIE BUT I WAS NOT ABLE TO ACCELERATE. I HAD TO STOP AND RESTART THE VEHICLE. THIS IS VERY DANGEROUS WHEN YOU ARE TRAVELING DOWN THE ROADWAY AND YOUR CAR EITHER DIES OUT OR LOSSES POWER. AFTER THE SECOND OCCURANCE I TOOK IT INTO THE DEALERSHIP AND WAS TOLD THAT THEY FOUND NOTHING WHEN HOOKED UP TO THE COMPUTER. THEY COULD DO NOTHING. THE VEHICLE RUNS FINE OTHER THAN THIS. THERE IS NO WARNING WHATSOEVER THAT THIS IS GOING TO OCCUR. *TR

CAR KEEPS DIES IN TRAFFIC ALMOST EVERYDAY AND THE ELECTRONIC THROTTLE CONTROL LIGHT KEEPS COMING ON . FORD WANTS $800 TO FIX. WITH THIS SAFETY ISSUE, I BELIEVE THERE SHOULD SOME SORT OF ACTION FORD SHOULD TAKE AND FIX THE PROBLEM SINCE IT IS ALWAYS HAPPENING TO THIS YEAR AND MODEL SO OFTEN. *TR

2005 FORD EXPEDITION - LOSES COMPLETE POWER UNEXPECTEDLY. HAPPENS OFF-AND-ON. DIFFICULT TO RE-CREATE PROBLEM TO MECHANIC. BLOGS FULL OF SIMILAR EXPERIENCES. VERY UNSAFE CONDITION WHILE ON AN EXPRESSWAY. RECEIVE ERROR MESSAGE - "CHECK THROTTLE CONTROL". COST $500 TO REPLACE THROTTLE BODY. SEEMS TO BE POPULAR PROBLEM IN THE 2005 EXPEDITION. *TR

2005 EXPEDITION EDDIE BAUER 4X4 - GOT A THROTTLE CONTROL ERROR MESSAGE, WAS TRAVELING AT ABOUT 55 MPH IN MORNING RUSH HOUR TRAFFIC ON A MAJOR HIGHWAY (DC/BALT) AND WAS LUCKY NOT TO GET SLAMMED INTO. VEHICLE ENGINE DIED, EVERYTHING ELSE WORKED. I SHUT IT ALL DOWN, TURNED THE KEY AND FIRED IT BACK UP AND IT IS RUNNING FINE AGAIN. IT DID THE SAME THING ABOUT 5 MONTHS AGO. FORD SHOWS NO RECALLS. MY VEHICLE HAS BEEN PUT ON A COMPUTER AND NO ERROR CODES CAME UP. THE COMPUTER IS REPORTING NOTHING. THIS IS VERY DANGEROUS AND OTHER PEOPLE ARE REPORTING THE SAME PROBLEM... HTTP://WWW.FIXYA.COM/CARS/T1061679-ELECTRONIC_THROTTLE_CONTROL_LIGHT_CAME#SAMEPROBLEMCONTINUED. *TR

2005 FORD EXPEDITION - NORMAL DRIVING, COMPLETE LOSS OF DRIVE POWER. COMES UP AS ELECTRONIC THROTTLE. YOU MUST PULL OFF ROAD, TURN VEHICLE OFF, THEN RESTART. THIS IS VERY WIDESPREAD, JUST DO A GOOGLE SEARCH FOR THROTTLE EXPEDITION. IT HAS RECURRED AT VARIOUS TIMES ALWAYS SEEMING TO RESET. FORD WANT $700 TO FIX. *TR

WHILE DRIVING, CHECK ENGINE THROTTLE CONTROL LIGHT COMES ON. THE CAR ESSENTIALLY SHUTS DOWN - LOSES ACCELERATION, POWER STEERING, ETC. THIS HAS HAPPENED THREE TIMES...DECEMBER 10, 2008, FEBRUARY 23, 2009, AND MARCH 2, 2009. THE CAR WILL START AGAIN IF YOU TURN IT OFF AND RE-START IT. THIS CAN BE EXTREMELY DANGEROUS IF IT HAPPENS AT A POINT WHERE IT'S HARD TO PULL OVER. AFTER READING MESSAGE BOARDS, IT SEEMS TO BE A FAIRLY COMMON PROBLEM IN 2005 EXPEDITIONS. *TR

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING 50 MPH, THE VEHICLE BEGAN TO FAIL AND THE CONTACT NOTICED THAT HER SPEED REDUCED TO 30 MPH. SHE WAS ABLE TO APPLY THE BRAKES AND SLOW THE VEHICLE DOWN. THE VEHICLE THEN SHUT OFF AND TOOK THREE ATTEMPTS TO RESTART. THE DEALER DETERMINED THAT THE THROTTLE BODY DISENGAGED AND THE VEHICLE WAS REPAIRED AT THE COST OF $700. THE CONTACT IS IN THE PROCESS OF NOTIFYING THE MANUFACTURER. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 68,000.

I HAVE A 2005 FORD EXPEDITION WITH 42K MILES AND I WAS GOING 30 MPH WHEN I LOST THE GAS PEDAL(POWER) TO MY VEHICLE. WARNING LIGHT CAME ON AND THEN I PULLED TO SIDE OF ROAD. LUCKY I WAS NOT HIT FROM BEHIND DUE TO LOSING POWER TO THE ENGINE. TURNED VEHICLE OFF FOR A FEW MINUTES AND THEN TURNED BACK ON. NO WARNING LIGHT AND TRUCK RAN FINE. TOOK IT TO LOCAL APPLE FORD DEALER WHO FOR $98 TELLS ME I NEED TO SPEND ANOTHER $600 TO REPLACE ELECTRONIC THROTTLE BODY. II HAVE NOTICED FROM VARIOUS INTERNET SITES THAT THIS IS A VERY COMMON PROBLEM WITH THIS VEHICLE AND THAT IT CAN HAPPEN AT ANY TIME. AFTER A LONG DISCUSSION WITH SERVICE MANAGER I DECIDED TO DECLINE THE REPAIR UNTIL I CONTACT FORD AND NATIONAL HIGHWAY SAFETY BOARD. SO FAR, THE TRUCK IS STILL RUNNING FINE, BUT I EXPECT IT IS GOING TO DO THE SAME THING AGAIN. THIS IS SOMETHING FORD AND/OR THE FEDERAL GOV.'T SHOULD RECALL BEFORE SOMEONE GETS KILLED. *TR

I WAS DRIVING ON THE FREEWAY AT 65MPH AND THE "CHECK ELECTRONIC THROTTLE CONTROL" LIGHT CAME ON AND THEN MY VEHICLE ENGINE SHUT OFF. I HAD TO PULL OVER WITH NO POWER AND LITTLE ABILITY TO TURN BEFORE VEHICLE WOULD RESTART. IT HAS DONE THIS NOW THREE TIMES. I HAVE RESEARCHED THE COST FOR REPAIRS BUT DUE TO THE HIGH EXPENSE ($500) I AM NOT ABLE AT THIS TIME TO FIX. *TR

ON 1/23 MY WIFE (5 MONTHS PREGNANT) WAS DRIVING ALONE WITH MY 2 YEAR OLD SON THROUGH THE CA DESERT ON HER WAY TO PHOENIX, AZ. IN OUR 2005 FORD EXPEDITION WITH ONLY 35K MILES ON IT. ABOUT 20 MILES FROM BLYTHE, CA THREE FUEL INJECTORS FAILED. LUCKILY SHE FOUND A FORD DEALERSHIP IN BLYTHE THAT WAS OPEN ON THAT FRIDAY AND ABLE TO REPLACE THEM. UPON ARRIVAL IN PHOENIX, ANOTHER DEALER DETERMINED THAT THE CATALYTIC CONVERTER WAS DESTROYED AS A RESULT. I WOULD LIKE FORD TO REPLACE THE REMAINING 5 FUEL INJECTORS BEFORE THEY FAIL. WHAT KIND OF FORD POLICY IS IT TO EXTEND THE WARRANTY TO 120K MILES ON A KNOWN DEFECT AND WAIT FOR DISASTER? IT IS INSANE TO NOT BE ABLE TO RELY ON OUR CAR FOR LONG DISTANCE TRAVEL AND ALWAYS WORRY ABOUT THIS INCIDENT REPEATING. THE COST OF REPLACING THE CATALYTIC CONVERTER AND RESULTING POLLUTION SHOULD ALSO BE A CONSIDERATION TO FORD? FYI: THE INJECTORS FROZE IN THE OPEN POSITION AND FLOODED THE ENGINE AND EXHAUST SYSTEM WITH FUEL I.E. FIRE! *TR

I WAS DRIVING ABOUT 70MPH WHEN THE MESSAGE CENTER TONE SOUNDED AND THE MESSAGE READ "CHECK THROTTLE CONTROL". THE ENGINE CONTINUED TO RUN, HOWEVER, THE ACCELERATOR BECAME INOPERABLE. IT SEEMS AS IF A LOT OF 05 EXPEDITION OWNERS ARE HAVING THE SAME PROBLEM. THIS IS JUST WAY TO DANGEROUS TO DRIVE WITH THIS ISSUE. I NEVER DRIVE IN THE MIDDLE LANE ON HIGHWAYS NOW FOR FEAR THAT THIS COULD HAPPEN AT ANY TIME. *TR

WHILE DRIVING THE VEHICLE WILL HAVE NOT HAVE ANY THROTTLE RESPONSE AND "CHECK ELECTRONIC THROTTLE COMPONENT" SHOWS ON DASH. AFTER PULLING TO THE SIDE OF THE ROAD, OR COASTING INTO SOMEONE'S DRIVE-WAY ON A CURVEY ROAD, TURN THE IGNITION OFF AND SIT FOR A FEW MINUTES AND RESTART ENGINE AND IS FINE. HAS OCCURRED 3 TIMES NOW, ALL 3 AT SPEEDS LESS THAN 45 MPH. TOOK THE VEHICLE TO FORD DEALERSHIP WHERE THEY CHARGED ME $75 TO TELL ME THE BATTERY NEEDED TO BE REPLACED BECAUSE THAT IS ALL THE CODES THAT THEY CAME UP WITH. THEN I WOULD HAVE TO RETURN THE VEHICLE TO HAVE IT CHECKED AGAIN. ON MY DESCRIPTION OF SERVICE CODES P-1867-2F, B-1317-2F, B1318-2F, B2477-60, B2486-20, B1318-20, U1900-20, P0121-FF, P2104-FF, P2112FF, B1318FF, WERE ALL FOUND. *TR

2005 FORD EXPEDITION EDDIE BAUER. DURING VEHICLE OPERATION THE ENGINE SUDDENLY DIES AND A "CHECK ELECTRONIC FUEL CONTROL" MESSAGE COMES UP ON THE DISPLAY. THIS IS EXTREMELY DANGEROUS AS IT OCCURS WHILE DRIVING ON THE HIGHWAY. AFTER THE VEHICLE IS PULLED OVER AND IGNITION IS TURNED OFF THE VEHICLE WILL RESTART. THIS HAS OCCURRED MULTIPLE TIMES IN MY VEHICLE. AFTER DOING NUMEROUS INTERNET SEARCHES THIS SEEMS TO BE A RECURRING PROBLEM IN MULTIPLE 2005 EXPEDITIONS. *TR

ELECTRONIC THROTTLE CONTROL LIGHT, I WAS DRIVING ABOUT 50MPH WHEN THE CAR SLOWED DOWN TO A STOP AND THE GAS PEDAL WOULD NOT WORK. THE CAR WAS RUNNING AND ROLLING, BUT I COULD NOT ACCELERATE. (SCARY) *TR

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. THE VEHICLE WAS PURCHASED BRAND NEW FROM THE DEALER AND UNDERWENT REGULARLY SCHEDULED MAINTENANCE AT THE SAME DEALER. AT 94,000 MILES, THE ENGINE FAILED. WHENEVER THE VEHICLE REACHED ABOVE 30 MPH, THE VEHICLE WOULD LUNGE FORWARD AND FAIL TO DRIVE SMOOTHLY. THE FAILURE OCCURRED ONLY ONCE AND THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE DEALER HAD TO TEAR APART THE ENGINE IN ORDER TO LOCATE THE FAILURE. AFTER INSPECTION, THE DEALER STATED THAT THE TIMING CHAIN TENSIONER NEEDED TO BE REPLACED. THE FAILURE WAS CORRECTED AFTER THE TIMING CHAIN WAS REPLACED. THE CONTACT STATED THAT THE ISSUE SHOULD NOT HAVE OCCURRED TO A VEHICLE WITH 90,000 MILES AND LESS THAN FOUR YEARS OLD. THE CONTACT PAID FOR ALL THE REPAIRS. THE FAILURE MILEAGE WAS 94,746 AND CURRENT MILEAGE WAS 94,900. UPDATED 02/05/09. *LJ UPDATED 02/10/09. *JB

WHEN I TURNED THE ENGINE ON AND PUT CAR ON REVERSE IT SPEED OUT OF CONTROL, IMMEDIATELY TRY TO PUSH ON BRAKES BUT IT DIDN'T STOP AND I CRASHED INTO A PALM TREE. *TR

"CHECK ELECTRONIC THROTTLE" MESSAGE APPEARED AND ACCELERATOR PEDAL BECAME UNRESPONSIVE IN TRAFFIC. PULLED OVER, RESTARTED ENGINE AND ISSUE CORRECTED ITSELF. *TR

"CHECK ELECTRONIC THROTTLE" MESSAGE APPEARED AND ACCELERATOR PEDAL BECAME INOPERATIVE. THIS IS THE SECOND TIME THIS HAS OCCURRED. SHIFTED VEHICLE INTO NEUTRAL, RESTARTED ENGINE WHILE ROLLING ALONG AND ERROR WAS CORRECTED. *TR

2005 FORD EXPEDITION CAR FIRE LOST NINE MONTHS OF PAYMENTS CARS SEATS WALLET EASY UP CANOPIES ETC. *TR

I WAS DRIVING 60MPH DOWN THE HIGHWAY AND THE DASH LIT UP WITH "CHECK ELECTRONIC FUEL CONTROL." I WAS ABLE TO GET THE VEHICLE TO THE SIDE OF THE ROAD AS THE ENGINE TURNED ITSELF OFF, NO POWER STEERING, AND LIMITED BRAKING ABILITY. AFTER A FEW MINUTES IT RESTARTED AND I WAS ABLE TO LIMP IT BACK HOME AND I PLAN ON TAKING INTO THE LOCAL FORD DEALERSHIP IN THE MORNING. *TR

I BOUGHT MY 2005 FORD EXPEDITION IN MARCH 2007 WITH 21K MILES ON IT. I HAVE HAD TO REPLACE 2 DIFFERENT INJECTORS IN 16 MONTHS BECAUSE THE VEHICLE WILL START CUTTING BACK AND ACTING LIKE IT WANTS TO CUT OFF WHEN IT STOPS AT A LIGHT . THE MOST RECENT REPLACEMENT CAME WHEN I DROVE IT 5 MILES FROM HOME AND IT JERKED CONTINUOUSLY THE ENTIRE INSIDE OF THE VEHICLE SMELLED LIKE GAS VERY STRONGLY AS WELL AS THE EXHAUST. THE TRUCK STAYS PARKED MOST OF THE TIME BECAUSE IM TOO SCARED TO DRIVE IT AND ITS A GAS HOG!!!!!! THE REPLACEMENT OF THE INJECTORS ARE NOT CHEAP!!!! THE INSIDE LIGHTS WILL COME ON AND GO OFF AT ANYTIME FOR NO REASON. I TAP THE BRAKES AND THEY COME ON, I ROLL THE WINDOW UP OR DOWN AND THEY COME ON. I HAVE ALSO HAD TO REPLACE THE BATTERY DUE TO THIS HAPPENING EVEN WHEN THE TRUCK HAS BEEN PARKED FOR HOURS. I HAVE REPLACED THE OXYGEN SENSOR AND A COLI PACK. ITS NEVER ENDING AND I FEEL LIKE I SHOULD NOT HAVE TO CONTINUE TO REPLACE THESE THINGS WHEN I AM OBVIOUSLY NOT THE ONLY ONE WITH THIS PROBLEM. FORD NEEDS TO STEP UP AND TAKE RESPONSIBILITY FOR THEIR CRAPPY PRODUCTS. I HAVE 5 MORE YEARS @ $515 PER MONTH TO PAY FOR THIS PIECE OF CRAP!!!!!!!!!!!! *TR

MY WIFE WAS DRIVING OUR 2005 FORD EXPEDITION WITH 50,000 MILES. SHE STATED THAT THE RADIO QUIT WORKING AND THEN THE VEHICLE QUIT RUNNING. AT THAT POINT THE HORN BEGAN TO BLOW CONTINUOUSLY UNTIL SMOKE STARTED TO COME OUT OF THE RIGHT SIDE OF THE DASH. AT THIS TIME SHE EXITED THE VEHICLE WITH OUR BOYS AND CALLED THE FIRE DEPT. BY THE TIME THEY ARRIVED THE VEHICLE WAS FULLY INVOLVED WITH FIRE. NEEDLESS TO SAY THE EXPEDITION IS TOTALED FROM THE FIRE. THE ENTIRE INTERIOR IS BURNT UP AND MELTED. I HAVE FOUND SIMILAR COMPLAINTS ON SEVERAL FORUMS. *TR

2005 FORD EXPEDITION 4 WHEEL DRIVE, VEHICLE FACTORY RIMS SPLITTING APART, OUTWARD SIDE OF RIM. RIMS ARE COMING APART ALMOST FULL CIRCUMFERENCE OF RIM INSIDE OF RIM. CANNOT BE SEEN FROM OUTSIDE. HAS HAPPENED TO SEVERAL VEHICLES. ALSO HAVE LOCAL REPORTS FROM LOCAL GOVERNMENT AGENCIES OF SAME PROBLEM. FEEL IT IS AND EXTREME SAFETY ISSUE. HAVE REPLACED RIMS WITH FACTORY RIMS. HAVE KEPT OLD RIMS TO VIEW. *TR

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT STATED THAT THE VEHICLE STALLS AND CONSTANTLY SHUTS OFF AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO THE DEALER ON EIGHT OCCASIONS FOR THE FAILURES. IN JANUARY OF 2008, THE DIAGNOSTIC INDICATED THAT THE THROTTLE BODY WAS THE CAUSE OF THE FAILURE AND IT WAS REPLACED. THE MOST RECENT FAILURE OCCURRED ON JUNE 1, 2008 WHILE DRIVING 60 MPH. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THE TRANSMISSION FAILED. THE DEALER REPLACED THE TRANSMISSION. THE CONTACT SPENT $2,400 TO REPAIR THE VEHICLE THAT WAS PURCHASED NEW IN 2005. THE FAILURE MILEAGE WAS 16,000 AND CURRENT MILEAGE WAS 39,000.

FORD EXPEDITION PAINT. I PURCHASED A NEW 2005 FORD EXPEDITION EDDIE BAUER EDITION IN 5/2005 FROM A CAR DEALER. THE 36000/3 YEAR WARRANTY HAS EXPIRED AND THE PAINT IS BLISTERING ON THE TAILGATE. I CALLED DEALER AND THEY SAID IT IS A MANUFACTURING DEFECT AND THEY WILL NOT PAY FOR IT BUT IT WILL DO NO GOOD TO FIX IT UNLESS THE ENTIRE TAILGATE IS REPLACED WITH STEEL. THERE IS A SERVICE BULLETIN OUT ON THIS ISSUE AND THEY ARE NOT STANDING BEHIND IT. *TR

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. WHEN THE CONTACT STARTS THE VEHICLE, THE RPM'S INCREASED TO OVER 5,000 WHILE IT WAS IN GEAR AND WITH THE BRAKE PEDAL DEPRESSED. WHEN THE VEHICLE WAS PLACED INTO NEUTRAL, THE FAILURE CEASED AND THE VEHICLE DROVE NORMALLY. THE FAILURE WAS INTERMITTENT AND THE CONTACT HAS NOT BEEN IN ANY CRASHES. THE VEHICLE HAS BEEN DIAGNOSED BY THE DEALER SEVERAL TIMES, BUT THE FAILURE CONTINUES. THE CURRENT MILEAGE WAS 33,000 AND FAILURE MILEAGE WAS 17,275.

SLOW SPEED, APPLIED BRAKES, NO RESPONSE. PEDAL WAS SOFT. *TR

OUR 2005 FORD EXPEDITION EDDIE BAUER WAS DRIVING EXTREMELY ROUGH, WAS DIFFICULT TO START, AND THERE WAS ALSO A STRONG SMELL OF FUEL IN THE CABIN. WE WERE ABLE TO MAKE IT TO THE NEAREST LOCAL FORD DEALERSHIP. THEY INSPECTED THE VEHICLE AND INFORMED US THAT TWO OF OUR FUEL INJECTORS HAD GONE BAD, WHICH HAD ALSO DAMAGED TWO SPARK PLUGS. APPARENTLY THEY FROZE OPEN AND ALLOWED TOO MUCH FUEL INTO THE SYSTEM. SINCE FORD IS AWARE OF THIS PROBLEM THEY HAVE EXTENDED THE WARRANTY TO VEHICLE OWNERS FOR THE DEFECTIVE FUEL INJECTORS TO 120,000 MILES. LATE LAST YEAR THEY SENT OUT A LETTER TO IMPACTED VEHICLE OWNERS. HOWEVER, THEY ONLY REPLACE THE FUEL INJECTORS AS THEY GO BAD. WE NOW HAVE TWO NEW AND IMPROVED FUEL INJECTORS IN OUR VEHICLE AND SIX OF THE FAULTY ONES. WE ARE CONCERNED WITH THE SAFETY OF US CONTINUING TO DRIVE THIS VEHICLE. THE ENGINE COULD STOP AT ANY MOMENT LEAVING US IN A DANGEROUS SITUATION IN TRAFFIC OR IN A REMOTE AREA, AND WITH THE FLOODING OF FUEL INTO THE SYSTEM THERE IS AN INCREASED RISK OF FIRE. THERE SHOULD BE A RECALL ON THESE FAULTY FUEL INJECTORS FOR THE SAFETY OF THE VEHICLE OWNERS. I'M DISAPPOINTED THAT FORD HAS CHOSEN TO NOT STAND BY THEIR PRODUCT AND LEAVE THEIR CUSTOMER IN A POTENTIALLY DANGEROUS SITUATION. OTHERWISE, WE HAVE BEEN PLEASED WITH THIS VEHICLE. I RECOMMEND THAT THE NHTSA INVESTIGATE THIS ISSUE. THERE ARE BLOGS ONLINE WHERE OTHERS HAVE EXPERIENCED SIMILAR UNSAFE SITUATIONS RELATING TO THESE FAULTY FUEL INJECTORS. MANY HAVE HAD TO GO BACK TO FORD MULTIPLE TIMES ALREADY, AS AN INJECTOR GOES BAD. THIS SITUATION COULD BE REMEDIED IF FORD WOULD RECALL AND REPLACE ALL OF THESE INJECTORS WHETHER THEY HAVE FAILED YET OR NOT. *TR

RECURRING ENGINE NOISE WHICH IS MORE NOTICEABLE DURING COLD WEATHER. UNDER LOAD THE ENGINE , PARTICULARLY AT 2000 RPM, SOUNDS LIKE THERE IS A MANIFOLD LEAK OR A VALVE TICKING. I HAVE BEEN TO MY DEALER TWICE(OUT OF BUSINESS) AND TWO OTHER DEALERS THREE TIMES WITH NO SATISFACTORY RESULTS. *TR

MOONROOF IS LEAKING CAUSING INTERIOR WATER DAMAGE. *TR

I WAS DRIVING MY 2005 FORD EXPEDITION, 85,000 MILE DRIVEN, WAS TRAVELING ON LEVEL GROUND IN TRAFFIC AT 45 MPH WHEN THE ENGINE SPEED WENT TO IDLE AND I COULD NOT ACCELERATE. THE ENGINE WAS STILL RUNNING AND BOTH POWER BRAKES AND POWER STEERING STILL FUNCTIONED. THE MESSAGE ON THE INFORMATION PANEL STATED SOMETHING TO THE EFFECT OF "ELECTRONIC THROTTLE DYSFUNCTION." FORTUNATELY, I WAS NOT IN HEAVY TRAFFIC AND IN THE RIGHT HAND LANE AND WAS ABLE TO COAST TO A STOP ON THE SIDE OF THE ROAD. THE IGNITION WAS TURNED OFF AND ALLOWED TO SET FOR A FEW MOMENTS. UPON RESTARTING EVERYTHING FUNCTIONED PROPERLY AND HAS CONTINUED TO DO SO SINCE. THIS COULD HAVE EASILY BEEN A FATAL PROBLEM IF THE TIMING HAD BEEN POOR. MY FORD DEALER SERVICE MANAGER STATED THIS IS THE 3RD. ONE LIKE THIS IN THE LAST TWO WEEKS. MY VEHICLE IS PRESENTLY BEING REPAIRED BY REPLACING PART OF ITS COMPUTER. UNFORTUNATELY, FORD DOES NOT SEE FIT TO ASSUME RESPONSIBILITY. *TR

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING ON A WET ROAD AT 45 MPH, THE BACK OF THE VEHICLE BEGAN TO SLIDE. THE CONTACT WAS HIT BY ANOTHER VEHICLE AND SPUN OUT OF CONTROL ACROSS FOUR LANES OF TRAFFIC. THE BACK END OF THE VEHICLE CRASHED INTO A CEMENT BARRACADE. A VEHICLE THAT WAS ENTERING THE HIGHWAY CRASHED INTO THE DRIVERS SIDE. THE AIR BAGS NEVER DEPLOYED. THE AMBULANCE AND POLICE ARRIVED AND TRANSPORTED THE CONTACT TO THE HOSPITAL. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED, THE CONTACT HAS BEEN UNSUCCESSFUL AT SPEAKING WITH THEM. THE CURRENT AND FAILURE MILEAGE WAS 75,000.

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. THE CONTACT CANNOT INSERTED THE NOZZLE INTO THE FUEL TANK TO PLACE GAS IN THE VEHICLE ,BUT THE GAS BLEW BACK OUT AT HIM AND HE STATED THAT IT TOOK 25 MINUTES TO FILL UP THE VEHICLE. FORD STATED THAT THE REPAIR WOULD COST AT LEAST $500. THE DEALER WOULD HAVE TO REMOVE AND REINSTALL THE FUEL TANK. THE MANUFACTURER STATED THAT NOTHING COULD BE DONE AND ADVISED THE CONTACT TO CALL NHTSA AND FILE A COMPLAINT. THE CURRENT AND FAILURE MILEAGES WERE 60,000. UPDATED 04/02/08. *LJ THE CONSUMER WAS INFORMED THAT ENGINEERS HAD INSTALLED A HOSE ON THE FUEL SYSTEM THAT RELOCATED FUMES AWAY FROM THE FILL TUBE. THEIR EXPLANATION WAS THAT THE HOSE MAY HAVE BEEN FROZEN AND NOT ALLOWING THE TANK TO VENT. UPDATED

IT TAKES 20 MINUTES TO FILL UP MY GAS TANK. FORD PUT SOME TIME OF RESTRICTION OR REROUTED THE FUMES AT THE GAS CAP. I HAVE TO ACTUALLY HOLD THE NOZZLE BACK AND INCH FROM THE OPENING AND SHOOT THE GAS AT THE TANK. THIS IS A VERY DANGEROUS SITUATION AND I AM SURE MUCH MORE DANGEROUS THAN THE ORIGINAL PROBLEM THE ENGINEERS WERE TRYING TO CORRECT (DUE TO A LAWSUIT). NOW FORD IS SAYING THAT THEY WILL NEED TO PUT THE CAR ON AN ENGINE ANALYZER ($160) THEN LOWER THE GAS TANK ($500 TO $600) IN ORDER TO SEE IF THE FUME VAPOR HOSE MAY BE FROZEN OR SUPPOSEDLY THERE IS A REPLACEABLE FILTER THAT THEY LOCATED ABOVE THE FUEL TANK. MY RESPONSE WAS ..."NO ENGINEER WOULD LOCATE A REPLACEABLE FILTER ABOVE THE FUEL TANK"! THEN THE SERVICE MANAGER BLAMED THE PROBLEM ON EPA...AS HE IS AWARE OF OTHER EXPEDITIONS WITH THIS PROBLEM...I SAID " I RETIRED FROM EPA..THEY MAY HAVE REQUIRED YOU TO DO SOMETHING WITH THE EMISSIONS....BUT THEY NEVER INSTRUCTED YOUR ENGINEERS TO LOCATE A FILTER ABOVE THE FUEL TANK"!!! I HAVE SPOKE WITH TWO DIFFERENT FORD GARAGES AND FILL THAT THEY ARE GIVING ME A RUN AROUND...MAYBE BECAUSE I AM A WOMEN AND THEY THINK I WILL PAY CLOSE TO $1,000 TO JUST GET FUEL IN THE VEHICLE! *TR

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. WHILE DRIVING 5 MPH, THE VEHICLE SLID INTO A DITCH. THE REAR DRIVER'S SIDE LIGHTS AND BUMPER WERE DAMAGED. THE DEALER STATED THAT THE VEHICLE WAS SUPPOSED TO COME EQUIPPED WITH FOUR WHEEL DRIVE, BUT DID NOT. THE MANUFACTURER PAID TO INSTALL THE FOUR WHEEL DRIVE FEATURE IN DECEMBER OF 2006. ON DECEMBER 1, 2007, THE VEHICLE SLID OUT OF THE DRIVEWAY INTO THE MIDDLE OF THE STREET. IN JANUARY OF 2008, THE VEHICLE WAS TAKEN TO THE DEALER AND THEY REINSTALLED THE FOUR WHEEL DRIVE. THE CONTACT RETRIEVED THE VEHICLE ON JANUARY 10, 2008 AND THE FOUR WHEEL DRIVE FAILED AGAIN SEVEN DAYS LATER. THE CURRENT MILEAGE WAS 33,900 AND FAILURE MILEAGE WAS 12,000. UPDATED 3/4/08 *CN THE DEALER HAS SINCE FIXED THE 4-WHEEL DRIVE.

THE VEHICLE LOSES POWER WHILE YOU ARE DRIVING, THERE IS NO WARNING OF ANY TYPE. JUST ALL OF A SUDDEN YOUR TRUCK WON'T MOVE. THIS CAN CAUSE SOMEONE TO REAR END YOUR VEHICLE. *CN

2005 FORD EXPEDITION WITH PEDAL DESIGN DEFECT. CONSUMER STATES THAT WHILE PRESSING THE BRAKE PEDAL THE ACCELERATOR PEDAL ALSO CAN GET DEPRESSED. DEALER TOLD HIM THEY COULD DO NOTHING IT WAS THE WAY THE PEDALS WERE SET UP. *KB THE CONSUMER EXPERIENCED THE PROBLEM ON 4 DIFFERENT OCCASIONS. THE CONSUMER STATED THE PEDALS WERE TOO CLOSE TOGETHER. *JB

I HAVE A 2005 FORD EXPEDITION, EDDIE BAUER. MOST RECENTLY (2 WEEKS AGO), MY CHECK ELECTRONIC THROTTLE LIGHT CAME ON, I CALLED MY LOCAL DEALER AND PLANNED TO TAKE IT IN THE NEXT DAY. I WORK CLOSE TO HOME AND HAVE LIMITED DRIVING DISTANCE. ON THE WAY HOME, THE THROTTLE WENT COMPLETELY OUT AND THE VEHICLE CUT OFF ON THE SIDE OF THE ROAD AND WAS UNABLE TO BE RESTARTED AND HAD TO BE TOWED. MY LOCAL DEALER DID FIX IT IN A TIMELY MANNER. HOWEVER...THIS IS NOT THE FIRST PROBLEM. WE BOUGHT IT BRAND NEW AND WITHIN A MONTH THE FUEL INJECTOR WENT OUT WHEN I WAS COMING BACK HOME FROM OUT OF TOWN, MY DRIVERS SIDE SEAT ADJUSTMENT WENT OUT TWICE AND HAD TO BE REPLACED. I AM SHORT AND HAD TO DRIVE WITH MY SEAT ALL THE WAY BACK. 2 CAM PHASERS HAD TO BE REPLACED BACK IN THE SUMMER AND THEN MOST RECENTLY THIS. I HAVE 2 SMALL CHILDREN AND WOULD PREFER A DEPENDABLE VEHICLE. I FILED A FORMAL COMPLAINT WITH FORD AND HEARD FROM THEM TODAY OF WHICH I WAS TOLD THAT HAVING 49,000 MILES ON MY VEHICLE IT WAS NOT UNUSUAL FOR PARTS TO GO BAD. I LIVE ON A HARD SURFACE ROAD AND DRIVE TO WORK, NORMAL DAY TO DAY ACTIVITIES AND OF COURSE VACATION. THE ONLY THING THEY WOULD DO WAS UPGRADE MY WARRANTY TO COVER THE TRANSMISSION. IT ALREADY HAS THE EXTENDED WARRANTY. I AM DISAPPOINTED THEY WOULD NOT STAND BY THEIR PRODUCT. I HAVE OWNED 2 TOYOYTA'S IN THE PAST AND PLAN TO GO BACK TO A TOYOTA AND A FORD COULD NOT BE GIVEN TO ME AGAIN. *TR

OUR 2005 FORD EXPEDITION EDDIE BAUER EXHIBITS THE SAME SYMPTOMS AS WERE REPORTED TODAY REGARDING "CAMSHAFT POSITION SENSOR ON FORD 7 LTR ENGINES 1997-2003 - ENGINE SHUTS DOWN WHILE DRIVING FORWARD , AT VARIABLE SPEED: VERY SLOW TO HIGHWAY SPEEDS. WILL RESTART ON FIRST TRY AFTER COMING TO COMPLETE STOP. MESSAGE PANEL SHOWS "CHECK THROTTLE LINKAGE" OR SIMILAR. FIRST OCCURRED AROUND JULY 07 SECOND TIME TOOK TRUCK TO FORD DEALER AUG 11 - THEY WERE UNABLE TO REPRODUCE PROBLEM AFTER TESTING FOR SEVERAL HOURS (AT LEAST THAT'S WHAT THE CHARGE SAID). ONE MONTH LATER IT HAPPENED AGAIN, HAS NOW INCREASED INTERMITTENT TO ONCE EVERY 2-3 WEEKS. INCIDENT DATES START APPROX JULY 2007 THROUGH YESTERDAY 12/05. *TR

I WAS TRAVELING AT 60 MPH AND SUDDENLY I HEARD AN ALARM AND THE DASH INDICATED "CHECK ELECTRONIC THROTTLE CONTROL. AT THAT INSTANT THE VEHICLE STALLED. I WAS ABLE TO MANEUVER TO THE BURM. TRIED TO START BUT WOULD NOT RESPOND. FINALLY AFTER ABOUT TWO MINUTES I WAS ABLE TO START THE VEHICLE AND RETURN TO WORK. TOOK VEHICLE TO BASS FORD SHERFFIELD VILLAGE OHIO. THEY ARE INVESTIGATING. *TR

TURNED ON IGNITION, LARGE EXPLOSION , SMOKE CAME OUT FROM UNDER HOOD, SUBSEQUENT INVESTIGATION SHOWED BATTERY HAD EXPLODED- BLEW THE TOP COVER OF THE BATTERY OFF OF BASE AS WELL AS RIGHT FRONT SIDE. CRACKED THE CLEAR COAT ON HOOD DIRECTLY ABOVE THE BATTERY.*JB

THE SEAT DOES NOT FIT PROPERLY IN THE VEHICLE, YOU HAVE TO PROP IT UP ON THE BACK OF THE SEAT, SO THE BABY IS SITTING CORRECTLY, THEN IT WILL CONTINUE TO SLIDE DOWN THEN THE BABIES HEAD WILL FALL FORWARD. IT ALSO DOES NOT HAVE THE 5 POINT HARNESS. *JB

2005 FORD EXPEDITION WITH FACTORY DEFECTS CUSTOMER STATES THAT THE CAR SOMETIMES SHOCKS THE BODY WHILE GOING THROUGH THE CAR WASH**CC 08/14/07 ADD TO CUSTOMER SENT IN ADDITIONAL INFO**NAR**CC THE CONSUMER STATED PLEASE ASSIST IN RETRIEVING THE $29,000 PAID OUT FOR THE VEHICLE AS THEY HAVE LEARNED THE VEHICLE IS NOT A NEW VEHICLE BUT WAS USED AND WAS SERIOUSLY DAMAGED. THE CONSUMER STATED IF IT RAINS OR GOES THROUGH A CAR WASH THERE IS AN ELECTRICAL SHOCK AND RUNNING THE VIN NUMBER INDICATES THAT THIS INFACT IS A USED VEHICLE NOT A NEW VEHICLE AS STATED BY THE DEALER. THE CONSUMER STATED THE ROOF SHAKES BADLY. *TR

I OWN A 2005 FORD EXPEDITION. ON SEVERAL OCCASSIONS, WHEN I STOP THE CAR, THE GLASS (ONLY) ON THE REAR LIFTGATE POPS OPEN AUTOMATICALLY. IF THERE IS ANYTHING IN THE BACK OF THE VEHICLE (PERSON OR THING) IT COULD POSSIBLY FALL OUT OF THE BACK OF THE VEHICLE. I WAS WONDERING IF OTHERS HAD REPORTED THIS PROBLEM AND IF IT SHOULD BE LOOKED INTO FOR RECALL. LATEST INCIDENT WAS 07/03/07.

BRAKE PEDAL AND GAS PEDALS TOO CLOSE. MANY TIMES GAS PEDAL HAS BEEN DEPRESSED WHILE TRYING TO ONLY DEPRESS THE BRAKE PEDAL.*AK

TL*THE CONTACT OWNS A 2005 FORD EXPEDITION. APPROXIMATELY THREE DAYS AGO THE STEERING COLUMN AND FRONT PASSENGER WINDOW LOCKED WHILE DRIVING THE VEHICLE. THE CURRENT AND FAILURE MILEAGE WERE 46,890.*AK

WE ARE THE OWNERS OF A 2005 FORD EXPEDITION XLT. IN AUGUST 2006 I INCURRED A BRAKING PROBLEM WHILE DRIVING. I IMMEDIATELY TOOK THE VEHICLE TO THE FORD DEALER AND HAD IT CHECKED OUT. THEY REPLACED THE FRONT BRAKE CALIPERS AND MACHINED THE FRONT ROTORS. PROBLEM SEEMED TO HAVE BEEN RESOLVED. THEN LAST WEEK ON FEB. 14TH WHILE DRIVING AT APPROXIMATELY 20-25 MI/HOUR AS I BROKE THE VEHICLE GROANED AND THE BRAKE PEDAL WENT COMPLETELY SOFT. AFTER SEVERAL PUMPS I WAS ABLE TO GET THE BRAKES BACK. UPON DRIVING A LITTLE FURTHER IT DID IT AGAIN. THEN WE RESUMED USING THE VEHICLE UNTIL SUN. FEB. 18TH WHEN THE SAME THING OCCURRED WHILE MY HUSBAND WAS DRIVING AND BEGAN TO BRAKE AT THE APPROXIMATE SPEED OF 20 MI/HOUR. WE RETURNED OUR VEHICLE TO THE DEALER TO BE CHECKED OUT. THEY SAID THEY RAN A FULL BATTERY OF DIAGNOSTIC TESTING AND FOUND THE VEHICLE TO BE FREE OF PROBLEMS. WE FEEL VERY UNSAFE DRIVING A VEHICLE THAT LOSES ITS ABILITY TO BRAKE. WE REALIZE THIS IS AN INTERMITTENT PROBLEM BUT AS FAR AS FAIRWAY FORD IS CONCERNED WE NEED TO CONTINUE DRIVING UNTIL IT DOES IT OFTEN ENOUGH THAT THEY CAN PINPOINT THE PROBLEM. OUR PROBLEM IS THAT COULD MEAN A MAJOR ACCIDENT TO SAY THE LEAST. WE ARE INQUIRING AS TO WHETHER THIS PROBLEM HAS BEEN ENCOUNTERED BY OTHER INDIVIDUALS. WE ARE ALSO INTERESTED IN ANY PATHS THAT WE SHOULD TAKE IN AN EFFORT TO IDENTIFY IF THIS IS A SYSTEMIC ISSUE WITH THE VEHICLE OR AN ISOLATED INCIDENT. WE ARE LOOKING FOR SUPPORT IN GETTING THIS ISSUE RESOLVED AS WELL. ANY DIRECTION THAT YOU COULD PROVIDE WILL BE GREATLY APPRECIATED. *JB

NATIONAL HIGHWAY TRANSPORTATION SAFETY ADMINISTRATION CC: FORD MOTOR COMPANY ; FAIRWAY FORD, PLACENTIA, CA TO WHOM IT MAY CONCERN: WE ARE THE OWNERS OF A 2005 FORD EXPEDITION XLT. IN AUGUST 2006 I INCURRED A BRAKING PROBLEM WHILE DRIVING. I IMMEDIATELY TOOK THE VEHICLE TO THE FORD DEALER AND HAD IT CHECKED OUT. THEY REPLACED THE FRONT BRAKE CALIPERS AND MACHINED THE FRONT ROTORS. PROBLEM SEEMED TO HAVE BEEN RESOLVED. THEN LAST WEEK ON FEB. 14TH WHILE DRIVING AT APPROXIMATELY 20-25 MI/HOUR AS I BROKE THE VEHICLE GROANED, SHUDDERED AND THE BRAKE PEDAL WENT COMPLETELY SOFT. AFTER SEVERAL PUMPS I WAS ABLE TO GET THE BRAKES BACK. UPON DRIVING A LITTLE FURTHER IT DID IT AGAIN. THEN WE RESUMED USING THE VEHICLE UNTIL SUN. FEB. 18TH WHEN THE SAME THING OCCURRED WHILE MY HUSBAND WAS DRIVING AND BEGAN TO BRAKE AT THE APPROXIMATE SPEED OF 20 MI/HOUR. WE RETURNED OUR VEHICLE TO THE DEALER TO BE CHECKED OUT. THEY SAID THEY RAN A FULL BATTERY OF DIAGNOSTIC TESTING AND FOUND THE VEHICLE TO BE FREE OF PROBLEMS. WE FEEL VERY UNSAFE DRIVING A VEHICLE THAT LOSES ITS ABILITY TO BRAKE. WE REALIZE THIS IS AN INTERMITTENT PROBLEM BUT AS FAR AS FAIRWAY FORD IS CONCERNED WE NEED TO CONTINUE DRIVING UNTIL IT DOES IT OFTEN ENOUGH THAT THEY CAN PINPOINT THE PROBLEM. OUR PROBLEM IS THAT COULD MEAN A MAJOR ACCIDENT TO SAY THE LEAST. WE ARE INQUIRING AS TO WHETHER THIS PROBLEM HAS BEEN ENCOUNTERED BY OTHER INDIVIDUALS. WE ARE ALSO INTERESTED IN ANY PATHS THAT WE SHOULD TAKE IN AN EFFORT TO IDENTIFY IF THIS IS A SYSTEMIC ISSUE WITH THE VEHICLE OR AN ISOLATED INCIDENT. WE ARE LOOKING FOR SUPPORT IN GETTING THIS ISSUE RESOLVED AS WELL. ANY DIRECTION THAT YOU COULD PROVIDE WILL BE GREATLY APPRECIATED. *JB

TL* - WHILE DRIVING A 2005 FORD EXPEDITION AT APPROXIMATELY AT 5 MPH SHE NOTICED BLACK SMOKE COMING FROM THE INTERIOR OF THE VEHICLE. THE CONTACT STATED SHE HAD HER PHONE CHARGER PLUGGED INTO THE CIGARETTE LIGHT ADAPTER. THE CONTACT INITIALLY THOUGHT THE FIRE WAS COMING FROM UNDER THE HOOD, SHE THEN DISCOVERED THE FIRE WAS COMING FROM INSIDE THE CAR. THE PLASTIC AROUND THE PHONE CHARGER CAUGHT FIRE. THE CONTACT POURED BABY FORMULA ON THE FLAMES TO EXTINGUISH THE FIRE. THE FAILURE MILEAGE WAS 39,000. THE VEHICLE WAS TOWED TO A FORD DEALER. THE VEHICLE FAILURE HAD NOT BEEN DIAGNOSED AT THIS TIME. THE CONTACT HAS PICTURES.*AK

I OWN A 2005 FORD EXPEDITION (LIMITED) ON A NUMBER OF OCCASIONS MY VEHICLES MOTOR HAS REVIVED UP AND I HAD TO PUT MY FOOT ON THE BRAKE VERY HARD TO PREVENT CRASHING INTO VEHICLES IN FRONT OF ME... IT ALSO HAPPENED ONE TIME WHEN I WAS GOING ABOUT 50 MPH AND THE CAR FOR NOW APPARENT REASON ACCELERATED TO 60 VERY QUICKLY. I HAVE REPORTED THIS TO THE DEALER ON THREE SEPARATE OCCASIONS AND THEY ADVISE THAT THERE IS NOTHING WRONG WITH THE VEHICLE. (MARONEY FORD, DELRAY BEACH, FL) *JB

DT*: THE CONTACT STATED WHILE AT A STOP LIGHT, THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE BEGAN TO ACCELERATE AS IF CRUISE CONTROL WAS ENGAGED. THE CONTACT TRIED TO DEPRESS THE BRAKE PEDAL HARDER UNTIL IT GOES AWAY. THERE WAS NO WARNING SIGNAL PRIOR TO THE INCIDENT. THE PROBLEMS PERSISTED INTERMITTENTLY WHILE THE VEHICLE WAS IDLING. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER WHO COULD NOT DUPLICATE THE PROBLEM. THE SECOND TIME, THE SERVICE DEALER ADJUSTED THE CALIBRATION FOR A TEMPORARY REMEDY. AFTER A COUPLE OF MONTHS, THE PROBLEM PERSISTED AND THE VEHICLE WAS TAKEN BACK TO THE DEALER, WHO INSTALLED A FLIGHT RECORD BOX. THE CONTACT KEPT THE FLIGHT RECORD BOX FOR TWO WEEKS AND RETURNED TO THE SERVICE DEALER BUT THE READINGS COULD NOT BE DETERMINED. THE VEHICLE WAS TAKEN TO THE DEALER SIX SEPARATE TIMES FOR THE SAME PROBLEM. THE MANUFACTURER WAS NOTIFIED AND DID NOT OFFERED ANY RESOLUTION.

DT*: THE CONTACT STATED WHILE DRIVING 30 MPH ON A WET HIGHWAY, THE CONTACT'S SPOUSE BROADSIDED ANOTHER VEHICLE AND THE AIR BAGS DID NOT DEPLOY. THE SEAT BELT WAS IN USE AND WORKED PROPERLY. A POLICE REPORT WAS TAKEN. THERE WAS FRONT END DAMAGE DONE TO THE VEHICLE. THE ONLY LIGHT ILLUMINATED IN THE VEHICLE WAS A LIGHT INDICATING THE GAS CAP WAS LOOSE. THE DEALERSHIP WAS NOT ALERTED. THE DRIVER SUSTAINED SOFT TISSUE DAMAGE. UPDATED 10/25/06. *JB

I WAS APPROACHING AN INTERSECTION AT CRAIG AND I-15. THIS IS KNOWN TO HAVE A GREEN LIGHT, YET THE TRAFFIC WILL SUDDENLY STOP INSTEAD OF A STEADY FLOW. I WAS DRIVING MY FORD EXPEDITION THAT I PURCHASED LESS THAN 2 WEEKS BEFORE. SUDDENLY THE TRAFFIC STOPPED, I SLAMMED ON THE BRAKES TO AVOID HITTING THE VEHICLE IN FRONT OF ME. I NOTICED THAT MY VEHICLE DID NOT STOP. I ENDED UP HITTING THE VEHICLE IN FRONT OF ME. I GOT CITED FOR GOING TOO FAST FOR THE CONDITION OF THE TRAFFIC. AT THAT TIME I DID NOT NOTICE A PROBLEM WITH THE PEDALS, ACCELERATOR AND BRAKE HAVE A CONFLICT. SINCE THE VEHICLE WAS NEW TO ME, I DID NOT NOTICE THE PROBLEM UNTIL A MONTH LATER, ALTHOUGH I QUESTIONED HOW I COULD HAVE THIS COLLISION AFTER SLAMMING ON THE BRAKES AS I DID. AFTER THE VEHICLE GOT OUT OF THE SHOP, I WAS DRIVING IN A RESIDENTIAL AREA. I APPLIED THE BRAKE TO SLOW DOWN AND NOTICED THE ACCELERATION INCREASING. IT WAS THEN THAT I REALIZED THAT I WAS PRESSING THE ACCELERATOR AND BRAKE PEDAL AT THE SAME TIME. I AM 6'3" TALL WITH A 11 1/2 IN SHOE. MY FOOT IS LARGER THAN THE AVERAGE MAN, I BELIEVE THAT THE PEDALS ARE TOO CLOSE TOGETHER UNTIL YOU ARE AWARE OF THIS AND MAKE A CONSCIENCE EFFORT TO SWITCH FROM ONE PEDAL TO ANOTHER. *NM

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS PARKED ON A SLIGHT INCLINE IT JUMPED OUT OF PARK AND ROLLED DOWN A HILL HITTING A TREE. UPON INSPECTING THE VEHICLE AFTER THE CRASH, THE GEAR INDICATOR WAS IN THE REVERSE POSITION. THERE WAS A POLICE REPORT FILED AT THE SCENE. THE VEHICLE WAS EXTENSIVELY DAMAGED HOWEVER, NONE OF THE AIR BAGS DEPLOYED. THE DEALERSHIP AND THE INSURANCE COMPANY HAVE BEEN INFORMED.

DT*: THE CONTACT STATED THE DRIVER SIDE FRONT TIRE HAS SEVERE CUPPING AND CHOPPING. THE TIRES ON THE VEHICLE ARE ORIGINAL AND THE DRIVER SIDE FRONT IS THE ONLY TIRE WITH THIS DEFECT. THE TIRE PRESSURE IS 35PSI. WHILE DRIVING THE VEHICLE VIBRATED AND PULLED TO THE LEFT. THE VEHICLE WAS TAKEN IN FOR SERVICE APRIL 6TH, 2006 WHERE IT CURRENTLY REMAINS. THE DEALERSHIP STATED THIS WAS A NORMAL PROBLEM FOR THIS VEHICLE WITH THE RIGHT FRONT TIRE. THE TIRE MANUFACTURER IS CONTINENTAL HOWEVER THE MODEL AND TIRE LINE ARE NOT CURRENTLY AVAILABLE.

ENGINE GOES TO FULL THROTTLE AT START UP AND WHILE IN GEAR WITH MY FOOT ON THE BRAKE AT A STOP SIGN. PROBLEM HAS BEEN REPORTED AND DOCUMENTED WITH THE DEALER SERVICE DEPARTMENT BUT HAS NOT BEEN CORRECTED. FIRST INCIDENT WAS WITHIN THE FIRST WEEK AFTER PURCHASE IN JULY 2005. LAST INCIDENT WAS LAST WEEK, MARCH 2006. *NM

THIS 2005 EXPEDITION HAS ONLY 15K MILES THE TRANSMISSION WAS SLIPPING REALLY HARD I HAD TO DRIVE IT TO THE DEALER IN GEAR 2. ONCE I ARRIVED THEY TOLD ME IT WOULD TAKE TWO WEEKS FOR THEM JUST TO EVEN LOOK AT IT(ONLY ONE TRANS TECH) I CALLED AND FOUND A DEALER WHO COULD FIX IT FASTER. I TRIED TO CALL FORD CORP TO SEE IF THEY WOULD TOW MY SUV 30-40 MILES, BUT THEY TOLD ME THEY DON'T DO DEALER TO DEALER TOWS. I WILL NEVER BUY A FORD AGAIN, THANK YOU FOR HELPING A CUSTOMER IM ONLY 28 YEARS OLD AND THIS IS MY 5TH AND LAST FORD VEHICLE. *NM

GEORGE NEWCOMB LANDERS MCLARTY 2609 SOUTH WALTON BENTONVILLE, AR 72712 I PURCHASED A 2005 EXPEDITION FROM YOU A FEW WEEKS AGO. ON 11-23-05 I BROUGHT IT OVER TO HAVE SOME DEFECTS REPAIRED. DEFECTS THAT WERE TO BE FIXED. TRANSMISSION. WHEN STOPPED ON A HILL IF YOU REMOVE YOUR FOOT FROM THE BRAKE THE VEHICLE WILL ROLL OUT OF CONTROL. THIS HAPPENS IF YOU ARE STOPPED WITH THE VEHICLE IN REVERSE GOING DOWN A HILL OF IN DRIVE GOING UP A HILL. THE TRANSMISSION WILL SHIFT AT ODD TIMES AS YOU ARE DRIVING. REAR PASSENGER DOME LIGHT FLICKERS WHEN YOU TURN IN ON WITH THE SWITCH IN THE BACK. RIGHT TURN SIGNAL FLASHES VERY FAST. TIRES ARE VERY BAD OUT OF BALANCE. DRIVER DOOR DOES NOT LATCH UNLESS IT IS SHUT HARD. I TOLD JESSE THAT THEY HAD TO BE DONE BY 5:00 PM. AFTER KEEPING THE VEHICLE ALL DAY NOTHING WAS FIXED. DURING MY VISIT IN YOUR OFFICE ON 12-9-05 YOU ASSURED ME THAT THE TRANSMISSION WOULD BE REPLACED. YOU ALSO STATED THAT FORD WAS AWARE OF THE BAD TIRES AND WOULD REPLACE THEM NOW THAT I HAD COMPLAINED. IN ADDITION TO THE ABOVE THE FOLLOWING NEW DEFECTS HAVE BEEN FOUND. TURN SIGNALS WILL SOMETIMES NOT WORK AT ALL. WHEN MAKING A SHARP TURN THE REAR END WILL SLIP. YOU CAN FILL IT NOT HOLDING THE ROAD. OUTSIDE FUMES ARE SUCKED INTO THE VEHICLE. ANY SMELL OR EXHAUST FROM THIS OR OTHER VEHICLES IS PULLED INSIDE. THE LEATHER ON THE FRONT SEATS HAS TURNED BLACK. THE TRANSMISSION, REAR END PROBLEM AND TIRES ARE ALL MAJOR SAFETY PROBLEMS. THESE MUST BE FIXED. I FEEL THAT HAVING MY WIFE DRIVE A VEHICLE WITH THESE PROBLEMS IS PUTTING HER IN DANGER. THE TURN SIGNALS AND LIGHT PROBLEM ARE POSSIBLE FIRE HAZARDS. THE UNCONTROLLED AIR INTAKE IS A PROBLEM THAT COULD CAUSE PEOPLE INSIDE THE VEHICLE TO BE GASSED BY A PASSING VEHICLE. MY WIFE HAS VERY BAD ALLERGIES WHEN THESE SMELLS ARE PULLED INTO THE VEHICLE SHE HAS TROUBLE BREATHING. I HAVE NEVER OWNED ANYTHING MADE FROM LEATHER THAT HAS CHANGED COLORS. *NM

DT: THE CONTACT STATES WHEN HE PIVOTS THE FOOT TO THE LEFT TO PRESS THE BRAKE PEDAL THE FOOT WILL ALSO PRESS THE GAS PEDAL. HE FEELS THE GAS AND BRAKE PEDALS ARE TO CLOSE TOGETHER.*AK UPDATED 1/4/2006 - *NM

VEHICLE WAS BEING DRIVEN AT ABOUT 20 MPH WHEN IT SUDDENLY ACCELERATED AND ALMOST LOST OF CONTROL OF THE VEHICLE. PLOWED INTO THE BRAKES AND PULLED VEHICLE OVER TO SET IN PARK AND SHUT DOWN ENGINE. THIS IS THE SECOND INCIDENT IN THE LAST 3 MONTHS. THIS VEHICLE IS VERY DANGEROUS TO OCCUPANTS OF THE VEHICLE AND ANYONE/ANYTHING OUT ON THE ROADS. *JB

VEHICLE WAS BEING DRIVEN IN A PARKING LOT. WE STOPPED TO ALLOW A CAR TO PULL OUT OF THE PARKING SPACE. THE BRAKE WAS RELEASED TO ALLOW THE CAR TO SLOWLY ROLL INTO THE PARKING SPACE WHEN IT SUDDENLY ACCELERATED. MY WIFE PLOWED INTO THE BRAKES AS THE VEHICLE CAME CLOSE TO RUNNING OVER PEDESTRIANS WALKING BY. DEALER CHECKED AND FOUND NOTHING WRONG. THIS IS ONE OF TWO INCIDENTS IN A 3 MONTH PERIOD. THIS VEHICLE IS A MAJOR CATASTROPHE WAITING TO HAPPEN, PLEASE BEWARE OF THE DANGER. *JB

THE EXPEDITION THAT I HAVE MAKES AN ANNOYING NOISE AT VARYING SPEEDS. THIS HAS BEEN GOING ON FOR THE LAST 8 MONTHS. IT WAS TAKEN TO THE SHOP IN FEB FOR A NOISE WHICH ENDED UP BEING A PROBLEM WITH THE REAR END. *NM

DT: THE CONTACT'S HUSBAND RENTED A 2005 FORD EXPEDITION. THE CONTACT STATED WHILE HER HUSBAND WAS DRIVING THE VEHICLE BEGAN TO HYDROPLANE , CAUSING IT TO HIT A TREE. AS THE VEHICLE HYDROPLANED IT TURNED SIDEWAYS AWAY FROM THE SHOULDER AND HIT A TREE FROM THE SIDE. UPON IMPACT, THE AIR BAGS DID NOT DEPLOY. THE VEHICLE IS EQUIPPED WITH THE FRONT AND THE SIDE AIR BAGS. THE CONTACT DID NOT KNOW WHAT TYPES OF AIR BAGS ARE IN THIS VEHICLE. THE CONSUMER HAS CONTACTED THE RENTAL CAR AGENCY, BUT HAS NOT INFORMED THEM THAT THE AIR BAGS DID NOT DEPLOY IN THE VEHICLE. THE CONSUMER HAS NOT CONTACTED THE MANUFACTURER.*AK

THE TRANSMISSION WOULD STALL AND NOT GO FORWARD IN THE DRIVE GEAR. STALLED IN THE MIDDLE OF AN INTERSECTION WITH THE FAMILY IN THE EXPEDITION. HAD TO DRIVE HOME IN SECOND AND FIRST GEAR. VEHICLE IS 27 DAYS OLD WITH 952 MILES PURCHASED AT BILLINGLSEY FORD IN LAWTON, OK 73501. *JB

I WAS TRAVELING AT 50MPH IN MY 2005 FORD EXPEDITION (3,700 MILES) WHEN A CHEVY CAVALIER RAN A STOP SIGN. I IMPACTED THE VEHICLE WITHOUT HAVING AN OPPORTUNITY TO HIT MY BRAKES. I WAS THE SOLE PERSON IN THE VEHICLE. IMPACT DESTROYED THE FRONT END OF MY VEHIVLE, AND PUSHED THE PASSENGER SIDE OF THE CAVALIER TO THE DRIVERS SEAT. MY VEHICLE THEN EXITED THE ROAD THROUGH A STAND OF TREES, DOWN AN EMBANKMENT AND CAME TO REST ON THE FAR SIDE OF THE EMBANKMENT. FAILURE: PASSNGER AIRBAG DEPLOYED, BUT DRIVER'S AIRBAG DID NOT, RESULTING IN NECK INJURIES. MAJORITY OF DAMAGE WAS TO DRIVER'S SIDE OF FRONT END. FORD HAS EXPRESSED NO INTEREST AS TO THE CAUSE OF THE AIRBAG FAILURE.

DT: THE CAR WAS SITTING AND RUNNING FOR MORE THAN 10 MINUTES NEAR A BUILDING. THE CAR WAS IN PARK. THE OWNER WAS UNLOADING THE VEHICLE, AND THEN WALKED BACK INTO THE BUILDING. THE OWNER HEARD A BOOM, AND CAME OUTSIDE AND SAW THAT THE CAR HIT A FAN, AND ALMOST HIT THE BARN. THE CAR WAS IN REVERSE WHEN THE OWNER GOT BACK INTO THE CAR. THE OWNER PUT IT BACK IN PARK AND SHUT VEHICLE OFF. THE CAR WAS INSPECTED, AND WAS DETERMINED THAT THEY COULDN'T DUPLICATE THE INCIDENT. THE OWNER HAS NOT CALLED THE MANUFACTURER. THE VEHICLE HAD MINIMAL DAMAGE. THERE WAS PROPERTY DAMAGE TO THE FAN.THE OWNER NOTED THERE WAS NO ONE AROUND THE VEHICLE. *AK

DT HAS A GLARE PROBLEM WITH THE WINDSHIELD, ALMOST LIKING LOOKING IN A MIRROR BECAUSE DASHBOARD LIGHTS INTERFERE WITH THE VISIBILITY OF DRIVING DOWN THE ROAD. HAD A DARK TOWEL ON THE DASHBOARD TO HELP WITH THE GLARE. NOTICED THIS ALMOST IMMEDIATELY. BEEN TO THE DEALER, THEY HAD CONSUMER CALL FORD BECAUSE OTHER CUSTOMERS HAD THE SAME PROBLEM. *AK

(1) VEHICLE STARTED AND SHIFTED INTO DRIVE (2) IMMEDIATELY AFTER SHIFTING WITH FOOT ON BRAKE, EXPERIENCED FULL ENGINE THROTTLE CAUSING UNWANTED ACCELERATION FORWARD AND ALMOST CAUSING ACCIDENTS (3) VEHICLE TAKEN TO FORD DEALERSHIP FOR SERVICE AND PROBLEM REOCCURED 2 DAYS LATER