2005 Ford F-150 Supercab

When starting the truck the airbag light is illuminated and flashes.

AIRBAG LIGHT WITH CODE 34. BOTH BELT RETENTION HAVE BEEN REPLACED BUT HAS NOT FIXED IT.

This and many other trucks of this generation have major frame rot issues due to the box frame. The rest of my truck looks excellent but the frame is so bad its most likely not repairable. I am not the only one with this major safety issue. Its only a 16 year old truck. Thankfully I have not towed or put a large load in the bed or else it could split in half. I wash my car seasonally and pressure wash off rust every spring. Yet the frame has rotted so badly they could not put it on a lift to do the alignment. I love this truck and I'm a big fan of the f150 line as a whole. Ford should take responsibility as Toyota has and fix their customers frames from this generation. I love ford but its always interesting walking through a parking lot and seeing every 04-08 f150 with major frame rot. Without fail every single one has that issue. Seems to me like they didn't properly galvanize and protect the steel. I am now needing to do a bed off frame restoration since no shop will take it on. This truck that should be going for $5k with this insane used car market. (August 3rd 2020) yet it is max $200 in scrap. Bad / cheap engineering should not be the owners responsibility. Yet that is what it has come to. It was most likely an honest unforseen mistake on their part. Overengineering the rigidity but ignoring the long term effects. Short term strength for log term pain as is commonly said with these trucks. I'm sure in a few years time these will just start breaking in half over bumps on the freeway. I beg and encourage ford to fix this before people die. I doubt ford wants another pr fiasco like the pinto. Hopefully they will do a cost analysis and realize that a recall is a much better option. Seem like 250-500k a pop for settlements for the most popular truck of all time is much much more than 5k per affected vehicle. Not including the long term dip in sales. So unless they want the other brands to win the truck war they gotta fix it. Tldr: a recall is cheaper than death.

The contact owns a 2005 Ford F-150. The contact stated while driving approximately 30 mph and depressing the brake pedal, the brake pedal traveled to the floor. The driver immediately turned the steering to avoid hitting several kids that were crossing the street. During the failure, the brake warning light illuminated. The cause of the failure was not yet determined. The local dealer was notified of the failure. The contact was informed that the part to replace the ABS module was no longer produced by the manufacturer and was therefore unavailable for a repair. The manufacturer was not notified of the failure. The failure mileage was 174,000.

I BOUGHT USED CASH TRUCK, DROVE FINE FOR FIRST DAY, SECOND DAY WHILE TRUCK WAS IN MOTION AND PUT IN REVERSE IT DIES, TOOK A COUPLE TURNS TO STARTED UP AND IT STARTED CODING THE CAMSAFT SENSORS, GOT CODES CLEARED, AND IT DROVE OK FOR 30 MINUTES COATED AGAIN STARTED TO STALL AND STUTTER A BIT. I HEARD A LOT ABOUT FORDS IN THE CAMSHAFT SENSORS DOES THAT MEAN MY TRUCK IS DONE FOR. MY TRUCK HAS TO CAMSHAFT SENSORS. 5.4

FRAME RUSTING TERRIBLY AND FRAME CRACKING NEAR DRIVERS SIDE FORWARD LEAF SPRING MOUNT. TRUCK HAS ONLY 128,000 MILES. DO NOT HAUL OR TOW ANY WHERE NEAR THE TRUCKS CAPACITY. NORMAL DRIVING AND MINOR OFF ROAD USE.

PURCHASED VEHICLE FEB 2021 FROM PRIVATE OWNER. TOOK VEHICLE IN FOR SERVICING. SERVICE DEPARTMENT INFORMED ME THAT THE OIL CHANGE COULD NOT BE COMPLETED, BECAUSE THEY WERE AFRAID TO PLACE THE VEHICLE ON THE LIFT DUE TO THE FACT THAT IT MIGHT SPLIT DUE TO THE FRAME BEING RUSTED COMPLETELY THROUGH. FURTHER, I WAS TOLD THAT THE VEHICLE WAS UNSAFE TO DRIVE DUE TO THE EXTENSIVE CORROSION OF THE FRAME ON BOTH THE PASSENGER AND DRIVER SIDE. I WAS INFORMED THAT AT ANY TIME, IF I HIT A BUMP OR WAS HIT FROM BEHIND, THE VEHICLE WOULD FOLD IN HALF. COMPLAINT ID #: ODI 11413329

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT HE LEARNED THAT HIS VEHICLE WAS SEVERELY RUSTED ON THE PASSENGER'S AND DRIVER'S SIDE OF THE VEHICLE. THE VEHICLE WAS RUSTED FROM THE MIDDLE OF THE VEHICLE TO THE REAR OF THE VEHICLE. THE CONTACT HAD TAKEN THE VEHICLE TO A CERTIFIED MECHANIC AS WELL AS TWO BODY SHOPS WHO STATED THAT THE ENTIRE SUBFRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 76,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE SEAT BELT FAILED TO LOCK INTO IT'S BUCKLE. THE BUCKLE FAILS TO ACTIVATE THE LOCK AND RELEASE THE SEAT BELT. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH WHEN A VEHICLE SLIPPED ON ICE IN FRONT OF THEIR VEHICLE, IN ORDER TO AVOID CRASHING, THE CONTACT ENDED UP STEERING INTO A NEARBY DITCH CRASHING INTO TREES. THE SEAT BELT BUCKLE FAILED TO SECURE THE SEAT BELT CAUSING IT TO SWING AND HIT THE CONTACT. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS NOT TOWED. A POLICE REPORT WAS NOT FILED. THE CONTACT STATED THAT THE SEAT BELT CAUSED HIS TEETH TO BE FRACTURED AND MEDICAL ATTENTION WAS NEEDED. THE VEHICLE WAS TAKEN TO A CERTIFIED MECHANIC WHO HAD NOT DIAGNOSED ANYTHING REGARDING THE SEAT BELT AS OF YET. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,00.

COMPLETE FRAME UNDER TRUNK IS RUSTED TO WHERE THE FRAME IS GETTING READY TO BREAK IN HALF I HAVE LOOKED AT SEVERAL OTHER OF THE SAME MAKE AND MODEL AND THEY HAVE THE SAME SIMILAR PROBLEMS SO I'M NOT AS BAD AS OTHERS BUT 90% OF THEM ARE NOT SAFE TO DRIVE I LIVE IN THE AREA THERE'S NOT A LOT OF SALT NORE SAND IF THIS WAS A PROBLEM WITH JUST MY VEHICLE I WOULD UNDERSTAND BUT SINCE IT IS A PROBLEM WITH A LOT OF THESE TRUCKS SOMETHING NEEDS TO BE DONE BUY FORD MANUFACTURES.

SPARK PLUGS AND COIL PACK CONTINUE TO EJECT THEMSELVES FROM THE CYLINDER HEAD.(F150 BLOWN OUT SPARK PLUG). THIS CONTINUES TO BE A PROBLEM AND HAS OCCURRED WHILE THE CAR IS IN MOTION ON THE HWY., TRAVELING AT A SPEED OF ABOUT 30 MPH.

THE ENGINE TIMING SYSTEM FAILED CAUSING THE ENGINE TO STOP WITHOUT WARNING. THIS FAILURE OCCURRED ON A CITY STREET. A FELLOW WHO HELPED PUSH THE TRUCK TO THECURB MENTIONED THE TRITON ENGINE IS 'KNOWN FOR THIS PROBLEM'.

WENT TO HAVE TRUCK LINED UP AND WAS TOLD IT HAD RUSTED THE FRAME ALMOST INTO IN THE REAR. IN MORE THAN ONE PLACE.

ON DECEMBER 3, 2020 AT APPROXIMATELY 11:30 PM OUR 2005 F150 BURST INTO BLAMES FROM THE ENGINE AREA. THE VEHICLE HAD BEEN PARKED SINCE APPROXIMATELY 3:30 PM EARLIER THAT DAY IN OUR PERSONALLY DRIVE WAY. WITNESS STATED THAT THEY SAW THE FIRE START NEAR THE ENGINE AREA OF THE TRUCK.

FRAME OF TRUCK IS ROTTED AROUND LEAF SPRING AREAS AND UNDER CAB OF TRUCK AS WELL AS BED RAILS.

HAD VEHICLE TOWED TO A REPAIR GARAGE TO HAVE STARTER REPLACED.ACCORDING TO REPAIR TECH.WHILE LIFTING TRUCK A LOT OF CRACKING SOUND S INSPECTION OF FRAME REVILED EXCESSIVE RUSTING AND CRACKS .THEY CALLED AND TOLD ME TRUCK WAS UN SAFE TO USE.HAVE BILLS WITH STATEMENTS MADE BY REPAIR SHOP.

JUST PURCHASED VEHICLE AIR BAG LIGHT FLASHES AND TURNS ON WHEN DRIVING LOOKED INTO ISSUE. FOUND RECALL FOR AIRBAG THAT CAUSES THIS. RECALL 11S18B. CONTACTED FORD THEY SAID RECALL HAD NOT BEEN PERFORMED AND SET UP APPOINTMENT TO HAVE IT DONE. FORD COMPLETED RECALL. PICKED UP VEHICLE DROVE 1000 FEET AIRBAG LIGHT CAME BACK ON. TURNED AROUND AND INFORMED SERVICE DEPARTMENT. THEY TOLD ME THE RECALL HAS NOTHING TO SO WITH THE AIRBAG OR LIGHT AND THAT IF I PAY 100 THEY WILL DIAGNOSE VEHICLE. I INFORMED THEM THAT IT SHOWS RIGHT ON FOR THAT THE RECALL CAUSES LIGHT TO FLASH AND POSSIBLY AIRBAG TO DEPLOY. THEY TOLD ME IT DOES NOT AND I WAS WRONG AND SENT ME ON MY WAY

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS AT THE LOCAL DEALER MEL ERVIN FORD LOCATED AT 15455 OAKLEY RD, CHESANING, MI 48616, IT WAS DISCOVERED THAT THE SUB FRAME OF THE VEHICLE EXPERIENCED RUSTING AND CORROSION UNDER THE CABIN SECTION OF THE VEHICLE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 75,000.

WE PURCHASED FOUR NEW TIRES HANKOOK KONTROL P255/65 AND DROVE THE TRUCK LESS THAN A WEEK AND THE SIDE WALL BELT IN THE TIRE HAD A BLOWOUT NO ROUGH DRIVING, NO EXCESSIVE DRIVING JUST TO AND FROM WORK ON A CLEAN HIGHWAY WITH NO DEBRIS. THIS ALMOST CAUSED A WRECK ON THE HIGHWAY AND HE WAS ABLE TO STEER THE TRUCK INTO THE DITCH AS IT COULD HAVE BEEN A LOT WORSE ON A TWO LANE HIGH WAY THAT HAD A LOT OF TRAFFIC. THE VEHICLE WAS IN MOTION ON HWY 53 IN JOLIET, IL DRIVING STRAIGHT SOUTH AND THERE WAS A LARGE BANG NOISE AND THE TIRE WAS COMPLETELY FLAT WITH A BELT BLOWN ON THE INSIDE OF THE TIRE. WOULD LIKE TO SEE A RECALL BEFORE THIS KILLS SOMEONE. WAS TOLD BY BE DEALER THAT IT WOULD NOT BE WARRANTED AS THE TIRE WAS USED A FEW DAYS AND THEY ARE HARD TO DEAL WITH WHEN IT COMES TO A WARRANTY ISSUE

TRUCK FRAME RUSTED THROUGH TO THE POINT IT IS UNSAFE TO DRIVE AND WILL NOT PASS STATE INSPECTION. THE FRAME RUST IS EXCESSIVE AFTER TAKING GREAT CARE OF THE TRUCK.

MY TRUCK IS RATTLING BAD AND ITS THE TIMING CHAIN FORD SHOULD HAVE RECALLED THIS BECAUSE IT IS A KNOWN PROBLEM. THE OIL SEALS ON THE TENSIONERS START LEAKING CAUSING THEM TO NOT KEEP THE CHAIN TIGHT LIKE IT SHOULD BE AND ALSO FAILS TO PUSH OIL AROUND TO THE RIGHT SIDE CAM WHICH CAUSES IT TO FAIL. THIS SHOULD BE RECALLED IT IS DANGEROUS AND COULD CAUSE INJURIES IF THE TRUCK STALLS OUT. ALSO THE SPARK PLUGS BLOW OUT OF THE HEADS CAUSING VERY HIGH REPAIR BILLS. THIS ALSO COULD CAUSE A ACCIDENT RESULTING IN DEATH. FORD HAS KNOWN ABOUT THIS PROBLEM BUT YET HAS DONE NOTHING TO MAKE IT RIGHT. FORD SHOULD STAND BEHIND THERE MISTAKE AND MAKE IT RIGHT FIX OR REPLACE THE ENGINE NO MATTER WHAT THE MILEAGE IS BECAUSE THEY KNEW ABOUT IT. MY TRUCK REPAIRS WILL COST OVER $7000 DOLLARS TO FIX BECAUSE FORD WOULD FIX THE PROBLEM THEY KNEW ABOUT. I CHANGE MY OIL EVERY 3000 MILES WITH VAL OIL AND LUCUS OIL STABILIZER BECAUSE OF THIS ISSUE IT SEEMS TO HELP THE RATTLE ALITTLE BUT ITS JUST GOING TO GET WORSE AND I CANT AFFORD $7000 TO REPLACE AN ENGINE. *TR

WHEN TRYING TO STOP THE VEHICLE IT SUDDENLY ACCELERATED FOR SOME UNKNOWN REASON. THIS HAS HAPPENED ON SEVERAL OCCASIONS AND ON ONE OF THOSE OCCASIONS WHEN PULLING INTO A PARKING SPOT IT RESULTED IN DAMAGE TO THE TRUCK. *TR

ENGINE TAPPING WHEN WARM ONLY AT IDLE DOESN'T DO IT WHILE COLD OR WHILE DRIVING I HAD A MECHANIC LOOK AT IT AND HE SAID IT'S DUE TO A DESIGN FLAW WITH FORD 5.7 ENGINES.

EXPERIENCE I GUESS THE THEY CALL IT THE DEATH WOBBLE. MAKES MY VEHICLE FEEL LIKE IT NOT ME A TING TO RUN RIGHT THE STEERING IS WEIRD AND CAN'T GET FORD TO CHECK IT OUT TO SEE WHAT'S GOING ON WITH IT THEY SAY JUST GET AN ALIGNMENT BUT THAT ISN'T HELPING

WHILE DRIVING 75 MPH ON INTERSTATE 40, VEHICLE WENT INTO FAIL SAFE MODE (HAPPENED A COUPLE OF TIMES). SUBSEQUENTLY, ENGINE BEGAN WITH A TICKING NOISE WITH EVER INCREASING RATTLING/SHAKING TO A POINT THAT THE ENGINE HAD TO BE TURNED OFF. THIS HAPPENED NUMEROUS TIMES WHILE STOPPING OR IDLING IN CITY TRAFFIC. LOCAL FORD DEALERSHIP REPLACED ALL COILS & PLUGS, THROTTLE BODY, FUEL FILTER, ETC. VEHICLE RAN FINE FOR SIX MONTHS, HOWEVER THE RATTLING, KNOCKING, SHAKING, SURGING, STALLING HAVE RETURNED TWO FOLD. VEHICLE IS NOW EXPERIENCING A MASSIVE OIL LEAK FROM THE ENGINE. HAD IT CHECKED BY AN INDEPENDENT MECHANIC WHO COULD NOT MAKE THE REPAIRS (BUT DID COMPLETE AN OIL CHANGE). FORD MOTOR COMPANY IS TOTALLY RESPONSIBLE FOR THESE ISSUES. THESE ISSUES ARE NOT JUST INCONVENIENT AND EXPENSIVE BUT MORTALLY DANGEROUS TO THE PASSENGERS OF THE VEHICLE AS WELL AS TO ANYONE IN CLOSE PROXIMITY. STEP UP FORD!

ME ENTER HOY QUE MI TRUCK TENA VARIOS RECALL Y NO HE RECIBIDO AVISO, GRACIAS POR SU ATENCION.

TL* THE CONTACT OWNS A 2005 FORD F-150. AFTER REPLACING THE TIRES ON THE VEHICLE, THE CONTACT HEARD A CRACKING NOISE WHEN THE VEHICLE WAS PLACED ON A LIFT. THE INDEPENDENT MECHANIC CONFIRMED THE FRAME WAS RUSTED THROUGH TO THE POINT THAT IT WAS UNSAFE TO PLACE ON THE LIFT. THE VEHICLE WAS TAKEN BACK TO FREDERICK MOTOR COMPANY (1 WAVERLEY DR, FREDERICK, MD 21702, (800) 734-9118). THE CONTACT WAS INFORMED THAT THEY COULD NOT ASSIST SINCE THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 57,000.*BF*JB

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE'S FRAME WAS CORRODED, WHICH CAUSED THE TRANSMISSION LINE TO BECOME DEFECTIVE. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE THE TRANSMISSION LINE WAS REPLACED. THE CONTACT WAS INFORMED BY THE MECHANIC THAT, DUE TO THE CORROSION, OTHER PARTS OF THE VEHICLE COULD BECOME DEFECTIVE. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 95,000.

THIS TRUCK IS VIRTUA;;Y RUST FREE ON BODY. THE FRAME HOWEVER IS RUSTED THROUGH NEAR THE GAS TANK. I HAVE SEEN OTHER PEOPLE WITH THIS ISSUE. MECHANIC HAD TO TAKE IT OFF LIFT, BECAUSE IT WAS SO WEAK. COULD JUST BREAK WHILE DRIVING.

THE ENTIRE FRAME IS RUSTING OUT. EVERYWHERE I LOOK THERES RUST. ALL OF THE CROSS FRAME FROM FRONT TO BACK DOWN SIDES AND ACROSS BOTTOM OF BED AND WHERE FLOOR BOARDS ATTACH LIKE WAS EXPENSIVE TRUCK FORD HAS TO KNOW

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO HAVE FRONT AND REAR SHOCKS INSTALLED. THE MECHANIC INFORMED THE CONTACT THAT DUE TO THE SEVERE RUST DAMAGE TO THE SUBFRAME, IT WAS NOT RECOMMENDED TO HAVE THE SHOCKS REPLACED. THE CONTACT WAS INFORMED THAT THE VEHICLE WOULD NOT PASS STATE INSPECTION WITHIN THE NEXT FEW MONTHS. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 180,000. *LN*JB

THE BRAKE WARNING LITE REMAINS ON. I'M TOLD BY MY MECHANIC THAT IT IS DUE TO A BROKEN CONNECTION IN THE DASH BOARD CIRCUIT BOARD AND HE SAID IT IS A RELATIVELY COMMON FAULT. REPAIR REQUIRES REMOVING THE ENTIRE DASH BOARD AND REPLACEMENT OF THE CIRCUIT BOARD.

1. BRAKE DOT 3 IS RUNNING OUT AFTER SEVERAL MONTHS. WHEN I APPLY THE BRAKES, THE VEHICLE KEEPS GOING. IN ORDER TO KEEP THE VEHICLE RUNNING, I MUST PUSH DOWN THE BRAKE VERY HARD TO STOP THE VEHICLE. I HAVE TO CONSTANTLY REFILL THE OIL TANK. 2. WHEN DRIVING ON THE HIGHWAY AND THE SPEED REACHES AT AROUND 45-65 MPH, THE VEHICLE AUTOMATICALLY LOSES POWER AND HIT AT 3-5 MPH BEFORE STOPPING. AFTER I COMPLETELY TURN OFF AND RESET THE BATTERY, THE VEHICLE STARTS NORMAL AGAIN. THE VEHICLE HAPPENED FROM 2009 TO CURRENT TIME, BUT THE ODB SCAN DOES NOT DETECT ANY CODE OR ERRORS.

ON 9-14-19 I GOT INTO MY TRUCK TO DRIVE. WITHOUT REALIZING IT, MY SEAT BELT DID NOT RECOIL THE LAST TIME I GOT OUT OF MY TRUCK. WHEN I REACHED TO PUT THE SEAT BELT ON, WITHOUT KNOWING IT, THE SEAT BELT WRAPPED ITSELF AROUND THE SEAT RECLINING HANDLE. WHILE DRIVING I STOPPED AT A LIGHT AND THE BELT MUST OF TIGHTENED UP MORE AND PULLED THE RECLINING HANDLE WHICH PUT ME IN A LATERAL POSITION WHILE DRIVING. IF I HADN'T PULL MYSELF UP BY THE STEERING WHEEL AND SLAM ON MY BRAKES, I WOULD HAVE HIT THE VEHICLE IN FRONT OF ME! I AM AFRAID TO DRIVE MY TRUCK ANYMORE WITHOUT CHECKING ON THE SEAT BELT EVERY DAY.

TL* THE CONTACT OWNS A 2005 FORD F-150. UPON STARTING THE VEHICLE, IT IDLED AND THE CONTACT HEARD A RATTLING NOISE COMING FROM THE ENGINE. THE CONTACT ALSO STATED THAT THE VEHICLE HAD AN OIL LEAK AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC TO HAVE THE IGNITION COILS REPLACED; HOWEVER, THE FAILURES CONTINUED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 184,994.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO SEVERAL UNKNOWN DEALERS FOR TRANSMISSION REPAIRS. THE TRANSMISSION COLUMN SHIFT ASSEMBLY WAS REPLACED IN 2007. IN 2010, THE TRANSMISSION FLUID SPILLED AND THE GASKET, FILTERS, AND SPARK PLUGS WERE REPLACED; HOWEVER, THE REPAIR DID NOT CORRECT THE FAILURE. THE CONTACT STATED THAT THE VEHICLE DID NOT ACCELERATE OVER 40 MPH AND VIBRATED. THE CONTACT ALSO STATED THAT WHEN THE VEHICLE WAS DRIVEN UP HILL WITH THE ACCELERATOR PEDAL DEPRESSED, THE VEHICLE DECELERATED. IN ADDITION, THE CHECK ENGINE AND TRANSMISSION FAULT INDICATORS ILLUMINATED. THE MANUFACTURER PROVIDED THE CONTACT WITH CASE NUMBER: N24150780-F193G8. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 84,000.

EXTENSIVE MAIN FRAME RAIL RUST RENDING TRUCK UNSAFE TO DRIVE NOW. STARTED AROUND 2010.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 35 MPH, THE FRONT DRIVER'S SIDE WINDOW LOWERED WITHOUT WARNING. THE CONTACT ATTEMPTED TO ROLL THE WINDOW UP, BUT IT FAILED TO CLOSE. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS APPROXIMATELY 140,000.

BOUGHT TRUCK LEAST WEEK TOOK IN FOR A OIL CHANGE AND WAS TOLD THAT THE FRONT HALF SHAFT IS ROTTEN TO THE POINT IT'S PITTING. THE STEERING SHAFT IS RUSTED OUT AND THE MAJORITY OF THE FRAME IS RUSTED OUT NEAR WHERE ALL THE IMPORTANT PARTS OF THE VEHICLE ARE HELD IN PLACE. AS I DO RESEARCH ON THIS PROBLEM I'M FINDING IT IS A COMMON PROBLEM. THE TRUCK ONLY HAS 61000 MILES ON IT AND IT SHOULDN'T HAVE THIS MUCH WEAR ON THE BODY OF THE TRUCK. FORD REALLY NEEDS TO LOOK INTO A RECALL BECAUSE THERE ARE THOUSANDS OF TRUCKS WITH THIS SAME ISSUE. I HAVE NEVER OWNED A FORD AND NEVER WILL AGAIN. THE CAR IS BASICALLY WORTHLESS AND IT'S A MATTER OF TIME WHEN IT RUSTS ALL THE WAY THRU. STATIONARY ISSUE. I DON'T HAVE ANY PHOTOS AS OF RIGHT NOW. I WILL BE TAKING MORE THE OIL SHOP HAS PICTURES THAT HE SHOWED ME.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 55 MPH, THE REAR FRAME DETACHED AND WAS ROTTED OUT. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO TONY BETTEN AND SONS FORD (3839 PLAINFIELD AVE NE, GRAND RAPIDS, MI 49525, (616) 363-6841), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND REFERRED THE CONTACT TO THE LOCAL DEALER. THE FAILURE MILEAGE WAS 151,678.

TWO MECHANICS AND ONE AUTOBODY TECHNICIAN INSPECTED THE TRUCK AND REPORTED THAT THE CHASSIS IS HEAVILY CORRODED THROUGHOUT FOR THE VEHICLE'S AGE AND IS NOT SAFE FOR TOWING. ONE MECHANIC REPORTED THAT THE REAR END OF THE TRUCK WOULD REQUIRE OVER $1,000 OF WELDED STEEL REINFORCEMENTS TO MAKE TRUCK TOWE WORTHY. ALSO GAS TANK CAN FELL DUE TO THE TANK HOLDER STREEPS ARE ATTACHED TO THE CORROTED CHASSIS.

I HAVE PUT 3 TRANSMISSION IN AND ONLY LAST ABOUT 4-5 YRS THE WRENCH LIGHT COMES ON AND IT LOST POWER

MY 2005 FORD F150 HAS BEEN EXPERIENCING SUA, "SUDDEN UNINTENDED ACCELERATION" SINCE THE DAY I BOUGHT IT NEW OFF A FORD DEALER LOT. THIS IS NOT DRIVER ERROR OR FLOOR MATS LIKE FORD EXPLANS AS THE PROBLEM. SUA DOES EXSIST. COMPLAINTS PEAKED IN 2005 FORD TRUCKS! ONLY HAVE 16K MILES ON MY VEHICLE BUT HAVE HAD A NUMBER OF NEAR ACCIDENTS OVER THE YEARS. WOULD GLADLY PAY TO HAVE THE PROBLEM FIXED, BUT THE ANSWER I ALWAYS GET " WHAT PROBLEM, IT DOESN'T EXSIST" SUA HAPPENS WHEN TRYING TO BRAKE WITH TRUCK IN GEAR AND IN MOTION. HAS HAPPENED IN BOTH FORWARD AND REVERSE MODE. CAN NOT DRIVE ANY MORE WITHOUT KEEPING MY HAND ON THE GEAR SHIFT LEVER TO THROW INTO NEUTRAL WHEN THE PROBLEM OCCURS. WORST INCIDENT WAS WHEN I NEARLY REAR ENDED A STOPPED SCHOOL BUS.

CHASSIS IS ROTTED OUT AND CANNOT EVEN BE PUT ON A LIFT. TOOK MY TRUCK TO BE INSPECTED AND THE FOUND THE CHASSIS ROTTED AND ADVISED NOT TO PUT ON LIFT

TRANSMISSION CLUNKS. TRUCK STALLS IN TRAFFIC BECAUSE OF THROTTLE BODY PROBLEMS. IT HAS BEEN AN ON GOING PROBLEM OVER THE PAST SEVERAL YEARS.

I NOTICE NUMEROUS OF F 150 LIKE MINE PAINT ON HOOD AND CAB FADING. ALL THE REST OF THE BODY PAINT IS GREAT. THERE SHOULD BE A RECALL ON THESE ITEMS.FORD SHOULD LET CUSTOMERS BRING TRUCK IN FOR A TOUCH UP OR PAINT JOB.

I HAVE A 2005 F150 FX4 THAT I BOUGHT IN 2010. IN 2017 WITH THE TRUCK BEING 12 YEARS OLD. I HAD TO REMOVE THE VEHICLE FROM THE ROAD BECAUSE OF FRAME ROT! THIS WAS MY BABY AND TAKEN WELL CARE OF. BOTH SIDES IN FRONT OF THE REAR AXLE ARE ROTTED OUT TO THE POINT A JACK JUST GOES RIGHT THROUGH THEM. THE INSPECTION FAILED BECAUSE IF THEY WOULD HAVE LIFTED IT, IT WOULD HAVE FOLDED IN HALF. ALSO HAS A BROKEN FRONT LEFT COIL SPRING. I SHOULD HAVE A VEHICLE WORTH AROUND 8-10 GRAND THAT IS GOING TO SELL FOR SCRAP METAL PRICED. WHY ARE AMERICAN AUTO MAKER NOT HELD RESPONSIBLE FOR MAKING DEFECTIVE VEHICLES? MY PREVIOUS VEHICLE WAS AN 199O TOYOTA TACOMA THAT HAD A FRAME ROT RECALL AND MINE WAS SPOTLESS. FAST FORWARD, BOUGHT AN AMERICAN MADE VEHICLE THAT COST ME 15 GRAND AND GOT 6 AND A HALF YEARS OUT OF AND NO ONE HOLDING FORD RESPONSIBLE! SICKENING!

LETTER FROM THE OFFICE OF THE ATTORNEY GENERAL STATE OF ILLINOIS ON BEHALF OF CONSTITUENT REGARDING HIS 2005 FORD F150 FORD TRUCK AND A FAULTY ENGINE WHICH WAS NOT DISCLOSED BY THE COMPANY. *LD *TR

YES A DRUNK DRIVER RAN INTO ME AND I THINK THE OFFICER LET HIM JUST CALL HIS WIFE TO COME GET HIM CAUSE HE WAS TO DRUNK TO DRIVE AND IT WAS MAYBE INVOLVING HIM DOING ON REPAIRS TO THE OFFICERS CAR THE REASON HE GOT OFF SCOT FREE, I MAY COULD UNDERSTAND IT BUT HE LIKE BROAD SIDED ME AND SENT ME FLYING ACROSS THE SEAT AND I SAW HIM TAKE OFF AND SO I WAS REACHING AROUND THE STEERING WHEEL TO TRY AND MAKE A SHARPER TURN AND GIVE IT SOME MORE GAS EVIDENTLY IT DID NOT WORK CAUSE THIS WAS JUNE 2 OF 2018 AND MY SHOULDER IS STILL HURT,HE HAS INSURANCE I HAVE INSURANCE BUT AFTER THE EMERGENCY ROOM VISIT I HAVE NOT BEEN ABLE TO HIRE A LAWYER,I HAVE NOT EVEN BEEN ABLE TO GET A DOCTOR TO TELL ME WHAT'S WRONG WITH MY SHOULDER,I CAN'T GET INTO AN ORTHO GROUP CAUSE THEY SAY WE DON'T TAKE THIRD PARTY CHECKS ,I FINALLY GOT INTO THE REGIONAL ONE IN MEMPHIS AND MADE THE APPOINTMENT 4 MONTHS AGO,AND STILL HAVE A MONTH TO GO ,IT IS NOT FAIR,I HAVE CONTACTED THE ATTORNEY GENERAL OF MISSISSIPPI AND WASHINGTON,I HAVE SENT EMAILS TO THE SENATOR THE GOVERNOR AND THEY REFERRED BACK TO MY LOCAL REPRESENTATIVES WHICH I HAVEN'T HEARD BACK FROM THEM AND THAT WAS A COUPLE MONTHS AGO,I ONLY GET ABOUT 3 HOURS SLEEP AT A TIME AND HAVE BEEN LIVING OFF MY SAVINGS FOR THE LAST 8 MONTHS ,IT IS ALMOST GONE AND WHEN I DO GET IN I AM NOT SURE IF I WILL EVEN HAVE THE MONEY BY THEN TO PAY FOR THE GAS TO GET BACK AND FORTH DURING THE PROCEDURE OF GETTING MY SHOULDER FIXED,I THINK YOU NEED TO USE THE MONEY FROM BUZZED DRIVING IS DRUNK DRIVING AND USE IT TO HELP THE INNOCENT PEOPLE THAT HAVE BEEN INJURED IN A WRECK BY A DRUNK DRIVER ESPECIALLY IF THE OFFICERS DON'T I FORCE THE LAW, BECAUSE WHEN THERE IS NO LAW ENFORCEMENT THERE IS NO LAW IN MY EYES,MY NAME IS [XXX] AND I LIVE IN [XXX] AND I HAVE A LOT MORE TO ADD TO THIS STORY BUT EVIDENTLY DON'T HAVE ENOUGH SPACE,PLEASE HELP INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *CC *TR

MY 2005 F150 HAS AN ELECTRONIC SWITCH TO ENGAGE THE 4 WHEEL DRIVE. IT HAS STOPPED WORKING ALL TOGETHER. I'VE RESEARCHED THE PROBLEM AND HAVE DISCOVERED THAT THIS IS A COMMON PROBLEM FOR THIS MODEL FROM 2004 ON UP. I NEARLY CRASHED WHILE DRIVING AFTER A SNOW STORM DUE TO THE 4 WHEEL DRIVE BEING INACTIVE.

TL* THE CONTACT OWNS A 2005 FORD-F150. THE CONTACT STATED THAT THE FRAME WAS RUSTED TO THE POINT THAT IT COULD NOT BE REPAIRED. THE RUST COULD PREVENT THE VEHICLE FROM PASSING INSPECTION. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND DID NOT ASSIST. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 120,000.

REAR PASSENGER SIDE WINDOW REGULATOR BROKE FOR SECOND TIME ALLOWING WINDOW TO FALL AND SHATTER INSIDE DOOR WHILE DRIVING IN TRAFFIC ON INTERSTATE. VERY DANGEROUS, VERY EXPENSIVE.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE DRIVER'S SIDE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V107000 (AIR BAGS). AUFFENBERG FORD O'FALLON (115 REGENCY PARK, O'FALLON, IL 62269, (618) 632-0090) REPLACED THE CLOCK SPRING ASSEMBLY ON THE DRIVER'S SIDE AS WELL AS THE WIRING HARNESS ON MARCH 22, 2011, BUT THE REMEDY FAILED. ON MARCH 25, 2015, THE VEHICLE WAS TAKEN BACK TO THE DEALER WHO REPLACED THE SAME PARTS, BUT THE REMEDY FAILED AGAIN AND THE DRIVER'S SIDE AIR BAG INDICATOR FLASHED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THEY WERE ONLY REQUIRED TO PERFORM THE RECALL REPAIR ONE TIME. THE FAILURE MILEAGE WAS NOT AVAILABLE.

EXTENSIVE FRAME RUST COMPROMISING VEHICLE INTEGRITY. CRACKED FRAME.

FRAME ON F150 IS RUSTING THROUGH CAUSING FRAME TO BECOME VULNERABLE TO BREAKING. RUSTING AND CRACKING TAKING PLACE BETWEEN BACK OF CAB AND REAR WHEEL MOUNTS. FOUND DURING OIL CHANGE AT FORD DEALERSHIP AND BODY SHOP DID NOT EVEN WANT TO PROVIDE ESTIMATE TO FIX DUE TO COMPLEXITY OF FIX AND LEGAL IMPLICATIONS.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY SHUT OFF. THE VEHICLE WAS EXAMINED BY AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP DRIVE MODULE WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE LOCAL DEALER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 135,000.

I JUST PURCHASED A 2005 FORD F150,SO I CAME HERE TO SEE IF THERE IS ANY RECALLS AND THEIR IS. 11V107000 IS THE RECALL NUMBER.I WILL ALSO ADD A PICTURE. WHAT DO I DO TO HAVE THIS FIXED?

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE THE VEHICLE WAS STATIONARY AND WHILE DRIVING VARIOUS SPEEDS, IT SHOOK WHILE IDLING AT A RED LIGHT AND STALLED WITHOUT WARNING. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE WOULD NOT RESTART WHEN PROMPTED. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE HEAD GASKET WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. A DEALER AND THE MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 94,000. *TT

I OWN A 2005 FORD F-150 4X4 EXTENDED CAB WITH JUST OVER 60,000 MI. FOR ITS AGE, THE TRUCK IS IN PRETTY NICE SHAPE EXCEPT FOR THE FRAME, IT'S GONE, RUSTED! THERE IS A SECTION BETWEEN THE CAB & ENGINE BAY THAT YOU CAN PUT YOUR FINGERS THROUGH, NOT ONE BUT SEVERAL FINGERS, LET ALONE IN OTHER AREAS THOUGH OUT THE FRAME THAT ARE ALSO ROTTED THROUGH. IT'S A BOXED FRAME WITH NO INSIDE COATING MADE WITH WHAT I READ ELSEWHERE WAS CHEEP STEEL, WON'T MENTION WHERE FROM, BUT NOT US STEEL. YES I LIVE IN NE, AND IT HAS TASTED SALT FROM THE ROADS, BUT I ALSO KEPT IT CLEAN ALL WINTER LONG. I PAID A LOT FOR THIS TRUCK, BOUGHT IT NEW AND NOW FEEL THAT I HAVE BEEN CHEATED. I AM NOW ON MY THIRD NEW FORD TRUCK, A 2018, AND I'M AFRAID TO WALK BUY IT WITH A SALT SHAKER IN MY HAND. MY FIRST WAS A 1984 F-250 THAT I DROVE FOR 21 YEARS, PUT 100,000 MILES ON IT, SOLD IT IN 05, AND IS STILL ON THE ROAD TO THIS DAY ON IT'S THIRD OWNER. I KNOW WHERE IT LIVES. I'M READING ON LINE THAT THIS IS HAPPENING TO A LOT OF THESE TRUCKS, LET ALONE I BELIEVE FORD HAS ALREADY REPLACED FRAMES IN A MINI VAN FOR THIS SAME REASON. I ALSO HAVE A FEW PICTURES. THERE IS A PIC JUST SHOWING THE UNDERSIDE, WHICH FOR THE MOST PART IS IN GOOD SHAPE, A LITTLE SURFACE RUST, NO THROUGH ROT. NOW THE FRAME PICS, ANOTHER STORY. THESE TRUCKS ALSO HAVE AN ISSUE WITH THE EXHAUST MANIFOLD AS TO WHERE THE BOLTS HOLDING IT IN PLACE ROT OUT AND NOW YOU HAVE A NOISY EXHAUST LEAK TRUCK THAT HAS TO HAVE ITS MOTOR TAKEN OUT TO HAVE THAT REPAIRED, GOT THAT GOING ON ALSO. THANK YOU FOR YOUR TIME, FROM A NOT SO HAPPY FORD OWNER PS: WHEN I BOUGHT MY NEW TRUCK, NOV OF 2017, THEY EVALUATED MY 05 FOR A TRADE IN, WHICH I WASN'T GOING TO DO ANYWAY, THEY ONLY OFFERED ME $3000 ON WHAT I THOUGHT WAS A GOOD TRUCK, FOILED AGAIN!

MAIN FRAME ROT LEFT REAR RUSTING RIGHT FRONT STARTING

WHILE DRIVING, MY F150 WITHOUT WARNING, DIED 3 TIMES IN 1/2 MILE. LEAVING ME WITH NO POWER STEERING, POWER BRAKES. VERY DANGEROUS. NEARLY HAD A ACCIDENT. HAD 1/2 TANK OF GAS. NEW BATTERY. IT DID NOT GIVE A CODE. I DID GET IT STARTED EACH TIME AND WAS ABLE TO DRIVE IT HOME. NOW I AM AFRAID TO DRIVE IT.

PAINT ON THE ROOF AND BACK OF THE CAB IS FLAKING OFF.

TRUCK WILL NOT PASS INSPECTION DUE TO FRAME RUST ON BOTH SIDES OF THE TRUCK.

HAVE OWNED THIS TRUCK BOUGHT NEW, 2005. HAVE USED SPARINGLY ONLY 15K + MILES. OVER THE YEARS I HAVE EXPERIANCED A NUMBER OF OCCASIONS WHEN IT TRIED TO ACCELLERATE WHEN I WENT TO BRAKE. FIRST THOUGHT IT A QUIRK OR FLOOR MATS. RECENTLY NEARLY TRASHED A PARKED CAR WHILE BACKING ITO A PARKING SPACE. CONTINUED TO ACCELLERATE DISPITE STANDING ON BRAKE. THERE IS NO LONGER ANY DOUBT THAT THIS IS A PROBLEM WITH SUA, SUDDEN UNINTENDED ACCELLERATION, THAT FORD HAS NEVER ADMITTED. I HAVE MADE SURE I AM OFF THE GAS PEDAL AND THE FLOOR MAT HAS BEEN REMOVED. THIS HAPPENS WHEN THE VEHICLE IS MOVING AND WHEN TRYING TO BRAKE!

PREMATURE FRAME CORROSION AND RUST FAILURE, DURING RECENT ROUTINE MAINTENANCE, MY MECHANIC INFORMED ME THAT THE FRAME ON THE REAR HALF OF MY 2005 FORD F-150 HAD RUSTED UNDER THE BED AND REAR WHEEL WELLS TO THE POINT OF FAILURE WHERE THE FRAME WOULD NO LONGER SUPPORT THE WEIGHT OF THE VEHICLE ON HIS LIFT. RUST THRU HOLES AND LONGITUDINAL CRACKS HAD FORMED ON THE BOTTOM AND SIDE FRAME SURFACES AT THE STRESS POINT BEFORE THE REAR WHEEL BEND. THIS SEEMS EXTREMELY UNUSUAL BECAUSE THE TRUCK HAS BEEN GENERALLY BEEN GARAGE KEPT AND MAINTAINED IN GOOD MECHANICAL CONDITION. THE EXTERIOR BODY ONLY EXHIBITS LIGHT SPOTS OF SURFACE RUST ON THE VISIBLE BODY PANELS. PROVIDING NO HINTS OF THE DEGRADATION OCCURRING BELOW. MY MECHANIC HAS TOLD ME THAT CATASTROPHIC FAILURE OF THE FRAME STRUCTURE WAS IMMINENT AND THAT THE VEHICLE WAS NO LONGER SAFE TO DRIVE. WHICH IN ITSELF IS CONCERNING IN THAT I HAD BEEN TOTALLY UNAWARE OF THE VEHICLE'S DETERIORATING CONDITION. HAD I NOT TAKEN THE VEHICLE IN FOR MAINTENANCE I WOULD LIKELY CONTINUED DRIVING THE VEHICLE UNTIL ONE DAY BEING TOTALLY SURPRISED WHEN THE BACK HALF OF MY TRUCK SEPARATED FROM THE FRONT.

ENGINE KNOCKING NOISE

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING APPROXIMATELY 30 MPH, THE EXHAUST PIPE DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND IT WAS DISCOVERED THAT THE ENTIRE SUBFRAME OF THE VEHICLE WAS RUSTED AND CORRODED, INCLUDING THE DAMAGED EXHAUST PIPE. THE EXHAUST PIPE WAS REPAIRED, BUT THE SUBFRAME WAS NOT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT THE LOCAL DEALER WAS NOT. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 70,000.

FRAME ON MY 2005 F-150 IS ROTTED AND HAS BECOME A SAFETY CONCERN.

HAD WHAT APPEARED TO BE A SLOW LEAK IN REAR TIRE. TOOK IT TO LES SCHWAB TIRE AND THEY FOUND IT WAS A WELD THAT WAS FAILING IN THE ORIGINAL STOCK RIM. THE SPLIT WAS APPROXIMATELY 8 INCHES LONG. I THEN SPOKE TO A LOCAL FORD DEALER WHO DENIED EVER HEARING ANY KNOWLEDGE OF SUCH A THING AND SIMPLY SAID YOU CANNOT BELIEVE EVERYTHING YOU SEE ON THE INTERNET AFTER I HAD GOOGLED THE ISSUE. HE SAID FORD TAKES THESE THINGS VERY SERIOUSLY BUT THAT THIS WAS SOMETHING BRAND NEW. HE KEPT INSISTING A 13 YEAR OLD TRUCK WILL HAVE ISSUES AND THAT I SHOULD LOOK AT THEIR NEW ONES...EVEN THOUGH THE INTERNET HAD ALL AGES OF RIM ISSUES RELATED TO THE F SERIES PICKUPS

WILL NOT GO IN REVERSE

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE AT A STOP, THE VEHICLE SHOOK AND DID NOT ACCELERATE. IN ADDITION, THE TRANSMISSION WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO BILL KNIGHT FORD OF STILLWATER (4405 W 6TH AVE, STILLWATER, OK 74074, 405-372-7144) AND THE COMPUTER SYSTEM WAS UPDATED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.

VEHICLE STALLS AND OR SURGES AND HAS DEAD SPOTS. AFTER MANY ATTEMPTS TO SOLVE THE ISSUE IT STILL PERSISTS. LOOKING ON LINE IT IS A COMMON PROBLEM WITH THIS VEHICLE.2005 -2008 F 150 5.4. IT IS ESPECIALLY DANGEROUS WHEN TOWING A TRAILER MY WIFE HAS ALMOST GOT INTO ACCIDENTS A COUPLE OF TIMES WHILE TOWING A HORSE TRAILER AND IS NOW AFRAID TO DRIVE THE TRUCK. SPOKE TO FORD BUT NO REAL RESPONSE. I THINK THIS ISSUE NEEDS TO BE LOOKED AT FURTHER ESPECIALLY WHEN CONSIDERING PEOPLE DO TOW WITH THEIR TRUCKS AND IT AMPLIFIES THIS ISSUE. THANKS MARIO .

MY 2005 FORD F150 TRUCK HAS HAD SO MANY PROBLEMS & SOME REPLACE TWICE & IM OVER IT IM ABOUT TO HAVE A HEART ATTACK NOW IT SOUNDS LIKE MY ACULATOR AGAIN WITH THE SOUND OF METAL SCRAPING ON THE GROUND AND WHEN I SWITCH IT TO 44 THE SOUNDS STOPS .BUT IF ITS NOT IN 44 THE SOUND STAYS AND IT IS LOUD ! I HAVE SPENT SO MUCH GET MY TRUCK FIXED AND WHAT UPSETS ME IS I TAKE CARE OF MY TRUCK CHANGE OIL SPARK PLUGS EVERYTHING SINCE PURCHASED IN 2005 BRAND NEW AND IM OVER IT SOMETHING NEEDS TO DONE WITH ALL THESE PARTS DEFECTED AND IT WILL CONTINUE UNTIL SOMETHING IS DONE.

FORD HAD AN EXTENDED WARRANTY ON THEIR 2005 5.4L ENGINES IN THE F-150 TRUCKS. THE EXTENDED WARRANTY WAS FOR CUSTOMER SATISFACTION PROGRAM 07M08. THE EXTENDED WARRANTY COVERED FUEL INJECTOR FAILURES BUT FAILED TO COVER THE RESULT OF THOSE FAILURES. I LOST SEVERAL INJECTORS WHICH RESULTED IN "DAMAGE TO OTHER POWERTRAIN COMPONENTS." THOSE COMPONENT WERE THE CATALYTIC CONVERTERS. BOTH OF MY CATALYTIC CONVERTERS FAILED. THE VEHICLE WOULD HESITATE WHEN ACCELERATING AND FUEL CONSUMPTION INCREASED AS THE CATALYTIC CONVERTERS CONTINUED TO FAIL. EMISSION TESTING WAS NEVER PERFORMED OF THIS VEHICLE. I CAN BE ASSUMED THAT EMISSION TESTING WOULD HAVE FAILED WHILE THE VEHICLE WAS STILL UNDER THE 07M08 COVERAGE.

A WHEEL STUD, FORD P/N YL3Z 1107 AB, ON THE RIGHT FRONT WHEEL/HUB ASSEMBLY WOULD NOT TIGHTEN TO THE PRESCRIBED 150 FT-LBS TORQUE BECAUSE IT STRETCHED. THE WHEEL STUD STRETCHED 0.044" BEFORE I STOPPED TRYING TO TORQUE IT UP TO SPECIFICATION. THE WHEEL STUD AND NUT WERE REPLACED. THE VEHICLE WAS STATIONARY. THERE WAS NO ACCIDENT OR INCIDENT INVOLVED. I BELIEVE THAT EITHER FORD HAS OVERSTATED THE TIGHTENING TORQUE OR THERE IS A MATERIALS AND/OR HEAT TREATING DEFECT. THE WHEEL STUD APPEARS TO BE ZINC PLATED. THE WHEEL BOLT TORQUE OF 150 FT-LBS IS LISTED IN REFERENCE MATERIALS AS THE TIGHTENING TORQUE FOR PLAIN, UNLUBRICATED M14 CLASS 10.9 STEEL FASTENERS. THE TIGHTENING TORQUE FOR ZINC PLATED M14 FASTENERS IS ABOUT 20 FT-LB LESS.

EXHAUST MANIFOLDS ARE LEAKING AND CAUSING EXHUST FUMES TO ENTER THE VEHICLE. TRUCK HAS APROX 120,000, ISSUE STARTED AT AROUND 80,000. IT'S AT THE POINT NOW WHERE IT MAKES PEOPLE IN THE TRUCK SICK AND IT WON'T PASS STATE INSPECTION. CAM PHASERS MAKE NOISES AS WELL. WO KNOW WHEN THIS ENGINE WILL FAIL. COMMON PROBLEMS WITH THE 5.4 V8 ENGINE. WELL DOCUMENTED ON THE INTERNET.

TAKATA RECALL---MY DRIVER SIDE AIR BAG DEPLOYED AROUND OCT OF 2015. I STARTED THE VEHICLE IN A PARKING LOT, PUT MY SEAT BELT ON, PUT THE TRANSMISSION IN REVERSE AND THE BAG EXPLODED BEFORE EVEN LETTING OFF THE BRAKE. IT STARTLED ME BEYOND BELIEF, THE HORN WOULD NOT SHUT OFF, THE CLOUD OF IGNITION WAS ALL OVER ME AND FILLED THE CAB, AND THE IGNITOR BRUISED MY HAND. I CALLED FORD AND THEY SAID IT WAS A RECALL AND I HAD IT TOWED TO LEIF JOHNSON FORD IN AUSTIN TX. THE VEHICLE SAT IN THEIR LOT FOR ONE WEEK AS THE DEALER AND MYSELF WENT BACK AND FORTH WITH FORD HQ IN MICHIGAN. I FINALLY ENDED PICKING UP THE TRUCK BECAUSE I NEED IT FOR WORK. FORD SAID THEY SENT ME RECALL NOTICES IN THE MAIL...I NEVER RECEIVED ANY. THEY WOULD NOT PAY FOR REPAIRS OR NEW AIRBAGS. HAD I BEEN DRIVING ON A ROAD OR HIGHWAY I COULD HAVE EASILY CRASHED. I CAN'T BELIEVE THEY CAN GET AWAY WITH THIS.

UPON ACCELERATING WHILE MOVING THE VEHICLE JUMPS. SOMETIMES ONCE, SOMETIMES SEVERAL TIMES BEFORE KICKING IN.

TRANS FAULT ERROR

THERE IS A CURRENT RECALL FOR THIS SAME ISSUE BUT ITS TILL 2004, BUT SHOULD BE EXPANDED. I HAVE A 2005 F150 WITH THE SAME ISSUES AS A 2004 F150 AND THE CHASSIS SUFFERS FROM MASSIVE CORROSION. MY TRUCK IS DEEMED UNSAFE TO DRIVE. THE FRAME IS ROTTING THROUGH AND VERY DANGEROUS TO DRIVE. IT CAN SEPARATE AT ANY TIME. THE TRUCK ONLY HAS 88K MILES AND IT COULD SEPARATE AT ANYTIME. IF INVOLVED IN AN ACCIDENT IT CAN BE FATAL. NHTSA YOU NEED TO INVESTIGATE AND RECALL THIS SERIOUS ISSUE RIGHT AWAY AND SAVE PEOPLES LIVES.

VEHICLE WAS AT A COMPLETE STOP. TRUCK WAS REAR ENDED (BY VEHICLE GOING ABOUT 35 MPH) AND THEN PUSHED INTO THE VEHICLE DIRECTLY IN FRONT. IMPACT WAS ENOUGH TO CAUSE THE DRIVER'S SEAT TO BREAK, BUT THE AIR BAGS NEVER DEPLOYED.

TAKATA RECALL AT 80,000 MILES F150 TRANSMISSION WENT OUT. HAD IT REPAIRED NOW IN LESS THAN 12,000 MILES GONE AGAIN.

PURCHASED FORD F150 FROM OLD SAYBROOK FORD, FEB. 16. THE TRUCK HAS THE 5.4 ENGINE WHICH HAS NUMEROUS COMPLAINTS OF ENGINE FAILURE. DRIVING ON ROUTE 1 WHEN TRUCK ECCELORATES OR LOSES POWER. WHEN WE BOUGHT THE TRUCK THE CHAIN GUIDE WAS BROKE AND EATING THROUGH THE CASE. SPARK PLUGS GET STUCK IN ENGINE OR PROPEL THEM SELVES THROUGH THE TRUCK HOOD. DANGEROUS ENGINE TO HAVE ON ROAD. I OWE 8000.00 ON A TRUCK THAT NOW NEEDS 4-6000 WORTH OF WORK.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE OPERATING THE VEHICLE, THE ODOR OF EXHAUST FUMES WAS PRESENT INSIDE THE VEHICLE. ALSO, WHEN THE ENGINE WAS STARTED, A TICKING TYPE NOISE WAS HEARD UNDER THE HOOD ON THE PASSENGER SIDE. THE CAUSE OF THE FAILURES WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER AND LOCAL UNKNOWN DEALER WERE NOTIFIED, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 130,600.

WHEN CHANGING THE BRAKES ON MY 2005 F150 I FOUND THE FRAME COMPLETELY RUSTED THRU THE EXTERIOR IS IN GREAT SHAPE WITH MINIMAL CORROSION.

FOLLOWING PURCHASE FROM A FORD DEALERSHIP WITH A TUNE UP AND MILAGE RELATED SERVICE COMPLETED MY 2005 FORD F150 RAN FOR LESS THAN 6000 MILES BEFORE A STUCK FUEL INJECTOR CAUSED A FAILURE OF THE ENGINE. AT THE TIME I WAS COMING TO A STOP UNDER NORMAL CONDITIONS FOLLOWING A 18 MILE COMMUTE FROM MY PREVIOUS STOP. A METALLIC SOUND WAS HEARD AND THE DRIVE BECAME SHAKY AND WEAK IN ACCELARATION. I PROCEEDED 4 BLOCKS TO THE DEALERSHIP TO ASSESS THE PROBLEM.THE FAULTY FUEL INJECTOR WHICH WAS UNDETECTED UNTIL COMPLETE FAILURE AND RESULTING DAMAGE TO ENGINE COMPONENTS. THIS PROBLEM IS WELL DOCUMENTED BY OTHER FORD OWNERS ONLINE WILL COST MY FAMILY OVER $6000 WITHOUT A RECALL ON THE PARTS KNOWN TO FAIL WIDELY IN THESE VEHICLES.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 40 MPH, THE TWO FRONT WHEELS ON THE VEHICLE SEIZED WITHOUT WARNING. THE CONTACT STATED THAT THE FAILURE OCCURRED ON AT LEAST EIGHT OCCASIONS. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND PROVIDED CASE NUMBER: CAS12702472. IN ADDITION, THE CONTACT CITED NHTSA CAMPAIGN NUMBER: 08V208000 (SERVICE BRAKES, HYDRAULIC) AS A POSSIBLE CAUSE OF THE FAILURE. THE FAILURE MILEAGE WAS 230,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING, THE VEHICLE IDLED WITHOUT WARNING. THE CONTACT HAD TO PULL THE VEHICLE OVER TO RESTART IT, BUT IT CONTINUED TO IDLE. THE MAINTENANCE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL INJECTION CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE DEALER WAS NOT NOTIFIED. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THERE WAS NO RECALL ASSOCIATED WITH THE VIN. THE APPROXIMATE FAILURE MILEAGE WAS 98,778.

FRAME RUSTED AND CRACKED, 72,000 MILES. I'M THE ORIGINAL OWNER. NOTE, ALL OTHER UNDERBODY COMPONENTS APPEAR NORMAL FOR AGE AND MILES; THOUGH I DON'T HAVE TOO MUCH FAITH IN REAR DRIVE SHAFT. LOCATION IS IN FRONT LEAF SPRING ATTACHMENT BRACKET ADJACENT TO FUEL TANK.

I AM THE SECOND OWNER OF MY 2005 FORD F-150 XLT 5.4L 3V 4X4 CREW CAB (VIN# AVAILABLE ON REQUEST) AND THERE IS A LOUD KNOCKING NOISE COMING FROM THE ENGINE. I CAN HEAR THE NOISE WHILE IDLING IN DRIVE, IDLING IN REVERSE, IDLING IN NEUTRAL, IDLING IN PARK AND TRAVELING UNDER LOW THROTTLE AND/OR POWER IN ANY GEAR(IT IS ESPECIALLY LOUD WHEN THE ECHOES BOUNCE OFF OF A HARD-SIDED BUILDING, SUCH AS A DRIVE-THROUGH RESTAURANT). THE EVENTS LEADING TO MY BREAKDOWN ON A BUSY ACCELERATION RAMP ARE AS FOLLOWS: MY VEHICLE LOST ALMOST ALL POWER ON AN ACCELERATION RAMP, SLOWING ME DOWN TO A CRAWL. IT ALSO CAUSED MASSIVE OIL LEAKING FROM THE ENGINE COMPARTMENT, WHICH RESULTED IN ROAD SPILLAGE, CAUSING UNSAFE DRIVING CONDITIONS FOR ME AND THE PEOPLE AROUND ME. I'VE DONE SOME INDEPENDENT RESEARCH AND HAVE PERSONALLY HAD THIS ISSUE FIXED ONCE. I'VE HAD IT FIXED AT A MECHANIC, THE RESULTING REPAIR COSTS ENDED UP BEING ~$3500. FULL DIAGNOSTIC AND REPAIR RECEIPT IS AVAILABLE UPON REQUEST, BUT THE MAIN ISSUES WERE THE CAM PHASER, AND TIMING CHAIN. I HAVE SEEN MULTIPLE UPON MULTIPLE COMPLAINTS ABOUT THIS ISSUE, AND I AM FORMALLY REQUESTING THE NHSTA TO INVESTIGATE AND HOLD THE FORD MOTOR COMPANY (HEREAFTER REFERRED TO AS "FORD") RESPONSIBLE FOR THIS POOR DESIGN CHOICE. I WOULD LIKE TO SEE A RECALL FOR EVERY FORD F-150 REPORTED WITH THIS ISSUE, AS WELL AS REIMBURSEMENT FOR ANY DOCUMENTED REPAIRS CONDUCTED BY MECHANICS FROM FORD. THIS MAY BE AN OUTLANDISH REQUEST THAT MAY NOT EVEN BE IN THE NHSTA'S CUMULATIVE POWER, BUT, AS A TAXPAYER, A WORKING MAN, AND MOST IMPORTANTLY, A HUSBAND, I WOULD LIKE TO SEE ACTION TAKEN BY THE PEOPLE I PUT MY FAITH IN, TO RECTIFY THIS SITUATION. THANK YOU FOR YOUR TIME, AND GOOD DAY.

FORD F 150 CRACKED REAR FRAME RAILS TRUCK MADE IN 2004 THEY HAD A RECALL FOR TRUCKS MADE IN 2004 BUT MY TRUCK IS TITLED AS A 2005 THEY MUST STILL HAVE HAD BAD FRAMES LEFT OVER THEY USED TO BUILD 2005 TRUCKS REAR OF TRUCK IS FLOATING WHEN YOU DRIVE IT.

THE REAR DIFFERENTIAL HAD TO BE REPLACED( AT A FORD DEALERSHIP ). THE REASON FOR REPLACEMENT WAS THE SHAFT THAT GOES FROM THE WHEEL INTO THE DIFFERENTIAL HAD ADJUSTMENT ISSUES WHEN MAKING NORMAL TURNS( THIS OCCURRED WHEN DRIVING SLOWLY ALSO MORE NOTICEABLE WITH QUICK TURNS AND WHEN EXITING ON THE HIGHWAY AROUND THE CURVE ,MAKING THE REAR END JUMP ON TURNS. WHEN DRIVING IN A STRAIGHT LINE THERE WAS NO ISSUE PROBLEMS. SINCE REPLACEMENT THE SAME ISSUES STILL HAVE RECURRED. MY CONCERN IS THERE MAY BE AN ISSUE WITH THE FORD REAR END DIFFERENTIAL AND AXIAL PARTS BOTH ORIGINAL AND REPLACEMENT PARTS THAT MAY MAKE THE VEHICLE HAVE SAFETY ISSUES PARTICULARLY IN TURNS CAUSING JUMPING OF THE REAR END

VEHICLE WENT INTO "FAILSAFE" MODE ON TWO SEPARATE OCCASIONS WITHIN THE LAST YEAR! AND MOST RECENTLY, TWO WEEKS AGO! BOTH AT HIGHWAY SPEED ON TWO DIFFERENT INTERSTATES IN FLORIDA! VERY DANGEROUS, AND HARD TO CONTROL VEHICLE TO "LIMP" TO A SAFE PLACE TO STOP! MANY POSSIBLE CAUSES FROM ELECTRICAL, FUEL, OR ENGINE ISSUES THAT ARE WELL DOCUMENTED ON MANY INTERNET SITES AND F150 FORUMS! ALSO RUST ISSUES ON ROOF OF VEHICLE IN RAIN CHANNELS! VERY COMMON,AND VERY POOR DESIGN!

MY 2005 F150 XLT 4.6L ENGINE BLEW OUT THE #3 SPARK PLUG. THIS IS A TERRIBLE INCONVENIENCE AND FRIGHTENING TO THINK THAT IT COULD HAPPEN AT ANY TIME AND LEAVE YOU STRANDED IN THE MIDDLE OF "NO WHERE", A VERY DANGEROUS SITUATION, COULD EVEN BE LIFE THREATENING AND YET FORD WILL NOT OWN UP AND TAKE RESPONSIBILITY FOR THEIR INADEQUATE DESIGN. TO THINK THAT THIS COULD HAPPEN AT ANY TIME AND LEAVE ME STRANDED IN THE MIDDLE OF "NO WHERE" IS VERY FRIGHTENING AND COULD BE DANGEROUS AND LIFE THREATENING. THIS COULD PROVE VERY COSTLY AT $280 A PLUG..

I WAS DRIVING IN MY 2005 FORD F-150 5.4 WHEN THE ENGINE SHUT OFF ON ITS OWN. IT WAS NOT THE FIRST TIME. IT HAS HAPPENED WHILE I'M DRIVING IN THE MIDDLE OF TRAFFIC. JUST RECENTLY I WAS DRIVING WHEN I STARTED TO LOOSE POWER, BUT THIS TIME STARTED HEAR A LOUD BANGING COMING FROM THE ENGINE. I DROVE THE TRUCK WITH ALMOST NO POWER TO THE MECHANIC. THERE I WAS TOLD THAT IT A CAM SHAFT ISSUE. AS THEY UNCOVERED THE ENGINE II WAS TOLD I WOULD A NEW ENGINE AT THE COST OF $7500. AS I LATER WENT ONLINE I FOUND MANY PEOPLE COMPLAINING ABOUT THE SAME THING WITH FORD 5.4 ENGINES. IT SEEMS TO ME FORD KNOWS ABOUT THE PROBLEM BUT ARE NOT WILLING TO STAND BY THEIR PROBLEM. I HAVE KEPT UP WITH THE MAINTANANCE SINCE HAVE BEEN THE ONLY OWNER OF THE TRUCK. I LOVE THE TRUCK BUT I'M VERY DISAPPOINTED WITH FORD NOT TAKING RESPONSIBILITY FOR HAVING ENGINEERED A BAD ENGINE. I THE SINGLE PROVIDER OF MY FAMILY AND DON'T HAVE MONEY TO BE THROWING AWAY ON NEW VECHICAL. I ALSO BELIEVE THE TRUCK STALLING OUT IN THE MIDDLE OF A HIGHWAY WAS COMPLETELY DANGEROUS AND I WAS LUCKY NOT BE HIT BY ANYONE ELSE. PLEASE HELP.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE THE VEHICLE WAS AT THE DEALER FOR MAINTENANCE, THE CONTACT WAS INFORMED THAT THE SUBFRAME DISPLAYED EXCESSIVE CORROSION. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNSAFE AND SHOULD NOT BE DRIVEN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 39,000. THE VIN WAS NOT AVAILABLE. UPDATED 06/23/17*LJ CONSUMER STATED HE BELIEVES THAT THE FRAME HAD EXCESSIVE CORROSION DUE TO THE LIQUID SALT THAT MDOT PUTS ON HIGHWAYS AND FAILURE OF A WEAK FRAME MANUFACTURE. UPDATED 9/27/18*JB

2005 FORD F150, ONLY 85,000 MILES ON THE VEHICLE. THE OVERALL EXTERIOR BODY OF TRUCK HAS ZERO RUST AND IS IN EXCELLENT CONDITION. HOWEVER, THE MAIN "FRAME" OF THE TRUCK, WHICH SUPPORTS ALL THE WEIGHT AND STRUCTURE OF THE TRUCK IS RUSTED THROUGH. I LIVE IN WISCONSIN AND HAVE OWNED MANY FORDS, AND OTHER TRUCKS. NEVER HAVE I HAD A FRAME OF A TRUCK RUST OUT LIKE THIS. THESE TRUCK SHOULD LAST 200,000 MILES +, AND I HAVE DONE JUST THAT ON PREVIOUS VEHICLES. HOWEVER, WITH THE BODY HAVING ZERO RUST, IT IS OUT OF THE NORM TO SEE THIS FRAME RUSTED THROUGH WITH HOLES IN THE MAIN STRUCTURE OF THE FRAME. I WAS ADVISED BY MULTIPLE AUTO SHOPS THIS CAN NOT BE WELD REPAIRED DUE TO SAFETY STANDARDS. FURTHER, IN ORDER TO FIX THE ISSUE AND MAKE THE VEHICLE SAFE, THE ENTIRE FRAME MUST BE REPLACED. BEING THIS TRUCK ONLY HAS 85,000 MILES ON IT, I FIND IT ABSURD THAT THIS IS EVEN AN ISSUE. AS PREVIOUSLY MENTIONED, I HAVE NEVER SEEN THIS SORT OF CORROSION ON THE UNDER BODY, AND YET THE QUARTER PANELS, TAILGATE, BUMPER ARE ALL ZERO RUST. IT IS EVIDENT THAT THERE IS A METALLURGICAL DEFECT IN THE STEEL USED FOR THIS FRAME. I HAVE READ NUMEROUS POSTINGS BY OTHERS OWNING THE 2005 MODEL AND MANY HAVE EXPERIENCED THE SAME ISSUE. FRAME RUSTING OUT BEFORE IT EVEN HITS 100,000 MILES, AND THESE ARE DAILY DRIVERS. AS OF NOW, THIS VEHICLE IS DEEMED UNSAFE BY THE LOCAL FORD DEALER, AND EVEN THE MASTER TECHNICIAN ON SITE WAS PERPLEXED BY THE UNDERCARRIAGE CORRODING AS IT HAD, WHEN THE VEHICLE IS OTHERWISE "CLEAN" INSIDE AND OUT, WITH NO RUST.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE THREE OF THE FOUR SEAT BELTS FAILED TO RETRACT. THE LOCATION OF THE SEAT BELTS WERE UNKNOWN. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SEAT BELTS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WOULD NOT BE COVERED DUE TO AN EXPIRED WARRANTY. THE FAILURE MILEAGE WAS APPROXIMATELY 174,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING VARIOUS SPEEDS OR WHILE THE VEHICLE WAS PARKED, A LOUD NOISE COULD BE HEARD COMING FROM THE ENGINE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED WITH A CAM PHASER ISSUE. THE CONTACT STATED THAT THE CAM PHASER, SOLENOID, AND TENSIONER NEEDED REPLACEMENT. THE VEHICLE WAS REPAIRED, BUT THE ISSUE PERSISTED WITH AN EVEN LOUDER NOISE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 88,000.

NEW TRANS NEEDED, COMMON ON MOST F150. OVERDRIVE LIGHT FLASHES AND WON'T SHIFT OUT OF FIRST GEAR

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE LOST POWER AND MISFIRED, AND SMOKE COULD BE SEEN COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO INITIALLY DIAGNOSED A FUEL LEAK FROM THE EXHAUST. UPON FURTHER INVESTIGATION, THE MECHANIC STATED THAT INJECTOR NUMBER 7 WAS NOT CLOSING CORRECTLY AND CAUSING THE FUEL TO ENTER THE CYLINDER. AS A RESULT, THE MOTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE DEALER STATED THAT THE VIN WAS EXCLUDED FROM A RECALL ON THE INJECTORS. THE RECALL DETAILS WERE NOT PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 76,000.

TOOK MY TRUCK IN FOR SERVICE (ENGINE LIGHT ON FOR THE OXYGEN SENSOR) AND WHEN THEY PUT THE TRUCK ON THE LIFT THE FRAME FOLDED BECAUSE IT HAD RUSTED OUT ON BOTH SIDES. I WAS STILL DRIVING THIS TRUCK AT HIGHWAY SPEEDS. I BOUGHT THE TRUCK NEW AND IT WAS DRIVEWAY PARKED IN CONNECTICUT FOR THE 12 YEARS I HAVE OWNED IT. THE MILEAGE ON THE TRUCK IS A LITTLE OVER 40K AND THE BODY PARTS OF THE TRUCK LOOK VERY GOOD. I HAD TO SCRAP THE TRUCK FOR PARTS, VERY SAD. SOMEONE SHOULD NOTIFY OTHER OWNERS OF THE 2005 F150S TO CHECK THE FRAMES BECAUSE I HAD NO IDEA IT WAS THIS BAD.

I NEEDED A NEW TRANSMISSION LAST YEAR. JUST BLEW OUT OF NO WHERE. THIS YEAR ALONE I NEEDED NEW HUBS, ALL8 CYLINDERS HAVE A MISS FIRE MY TRUCK DROPPED FROM 60 TO TEN IN SECONDS SO SCARY

BOUGHT TRUCK NEW, HAS AN ENGINE TICKING THAT CONTINUES TO GET LOUDER. PROPERLY SERVICED AS PER OWNERS MANUAL. ENGINE NEEDS REPLACED PER MECHANIC.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT TOOK HIS VEHICLE IN FOR INSPECTION AND WAS INFORMED THAT THE VEHICLE FAILED BECAUSE BOTH FRONT COIL SPRINGS WERE FRACTURED. IT WAS DIAGNOSED THAT THE COIL SPRINGS FAILED AND NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 49,433. UPDATED 06/01/17*LJ *CN

FRAME ON DRIVERS SIDE IS ROTTING AWAY.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT A 15 MPH, THE AIR BAGS DEPLOYED WITHOUT IMPACT. THE CONTACT SUSTAINED LACERATIONS TO THE FACE AND A BLACK EYE, HOWEVER NO MEDICAL ATTENTION WAS SOUGHT. THERE WAS NO POLICE REPORT WAS FILED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V107000 (AIR BAGS) HOWEVER, THE CONTACT WAS INFORMED BY THE DEALER THAT THE RECALL HAD EXPIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 171,450.

HAD NEW BRAKES INSTALLED SEVERAL YEARS BECAUSE IT WAS SHAKING AND ALMOST IMPOSSIBLE TO STOP AT HIGHWAY SPEED. WELL IT IS HAPPENING AGAIN IF YOU ARE TRAVELING HIGHWAY SPEED. BRAKES ARE VERY BAD AGAIN. THIS VEHICLE HAS ABOUT 55,000 MILES ON IT AND SHOULD NOT HAVE WORN OUT BRAKES FOR THE SECOND TIME. SOMETHING IS TERRIBLY WRONG WITH THE BRAKING SYSTEM. I AM TO THE POINT OF BEING AFRAID TO DRIVE IT ON THE HIGHWAY BECAUSE YOU HAVE TO MASH HARD ON THE BRAKE AND FEEL THE FRONT SHAKING BEFORE IT WILL FINALLY STOP!

CPSC;2005 FORD F-150 TRANSMISSION AND MOTOR WENT OUT AT 89446 MILES. A DIAGNOSTIC WAS PERFORMED. *BF THE CONSUMER STATED AFTER THE TRANSMISSION WAS REPLACED, THE VEHICLES PERFORMANCE WAS NOT INDICATIVE OF HAVING BEEN AT A REPAIR SHOP. THE CONSUMER RETURNED TO THE DEALER AND ANOTHER DIAGNOSTIC WAS PERFORMED. THE CONSUMER WAS THEN INFORMED THE ENGINE NEEDED TO BE REPLACED. IT WAS ALSO DETERMINED THE INITIAL REPAIRS WERE COMPLETED WITH SALVAGED/USED PARTS. *JB

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING THE VEHICLE AT 65 MPH, THE VEHICLE BEGAN STALLING INTIMITTENTLY THEN THE ENGINE AND MAINTANENENCE WARNING LIGHT ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO A MECHANIC WHERE IT WAS DIAGNOSED THAT THE AIR FILTER WAS OUTDATED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 108,000.

TRUCK WAS BOUGHT AND I REPLACED ALL SPARK PLUGS AND EVEN HAD TO REPLACE A CLINOID BECAUSE WAS TOLD THAT WAS THE PROBLEM. ITS NOT... THERE IS A BALL VALVE IN THE TRANSMISSION THAT KEEPS THE TRUCK FROM BUILDING ENOUGH PRESSURE TO BE ABLE TO SHIFT WHICH THROWS A CODE AND SAYS MISFIRE ON 6 BEEN REPLACED TWICE NOW SO CLEARLY NOT THE PROBLEM. THIS IS A MAJOR ISSUE.. TRUCK FEELS AS IF FIXING TO FIE THEN CHECK ENGINE LIGHT WILL COME ON START FLASHING BUT THROW NO CODES AND YOU CANT SPEED BACK UP BECAUSE IT FEELS LIKE YOUR TRUCK IS ABOUT TO DIE AND YOU DON'T WANT TO BLOW YOUR MOTOR.

BOUGHT THE TRUCK USED AT 150000 MILES. AFTER 5000 MILES THE LOUD TICKING THAT THESE TRUCKS ARE KNOWN FOR BECAME LOUDER. AT 161000 MILES THE ENGINE DIED. I STARTED IT UP IN MY DRIVEWAY ONE MORNING AND INSTEAD OF JUST TICKING, IT WAS KNOCKING 100X LOUDER. THE TRUCK BEGAN SHAKING VIOLENTLY. THEN IT JUST DIED. ALL THIS HAPPENED IN A MATTER OF MINUTES. HAD IT TOWED TO A SHOP, AND THEY SAID I NEED A WHOLE NEW ENGINE. I CAN'T HELP BUT THINK IF I WAS DRIVING AND THIS HAPPENED, WHAT THE OUTCOME WOULD BE. I HAVE READ HUNDREDS OF COMPLAINTS FROM PEOPLE ONLINE SAYING SIMILAR THINGS. FORD IS AWARE OF THE PROBLEM, BUT NO RECALL WAS ISSUED. THAT IS IRRESPONSIBLE, AND VERY DANGEROUS ON FORD'S PART.

#8 CYLINDER SPARK PLUG BLEW OUT WHILE DRIVING. REPLACED ALL SPARK PLUGS AND TORQUED. FOUR DAYS LATER #8 PLUG BLEW OUT AGAIN WHILE DRIVING.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE THE VEHICLE WAS IDLING AT A RED LIGHT, THE SEAT BELT TENSION SEIZED AND THE AIR BAG WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SEAT BELT PRETENSIONER FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

BRAKE BOOSTER VACUUM SUPPLY METAL STAND PIPE RUPTURED. THIS WAS WHILE DRIVING. LOSS OF VACUUM AND LOSS OF ENGINE PERFORMANCE AND BRAKES WERE SLUGGISH. HAVE TO PUSH ALL WAY TO FLOOR.

THE BRAKES FADED DURING A EMERGANCY STOP ON THE HIWAY. I WAS ABLE TO GET STOPPED BUT THE BREAK PEDDEL WENT CLEAR TO THE FLOOR.I COULD NOT PUMP UP THE PEDDEL TO MAKE THE BREAKE WORK ANY BETTER.

I PURCHASED THE VEHICLE AND NONE OF THE PREVIOUS OWNERS DID THE TIRE RECALL.

WHILE DRIVING 75 ON A TOLL ROAD THE ENGINE WENT INTO ENGINE FAIL SAFE MODE, I LOST ALL POWER AND ALMOST WRECKED INTO ONCOMING TRAFFIC TRYING TO GET TO THE SHOULDER, I WENT TO A MECHANIC AND THEY REPLACED THE THROTTLE BODY, 3 DAYS LATER SAME THING, I WAS TOLD THIS IS A COMMON PROBLEM ON THIS MOTOR 5.4, WHY IS THERE NOT A RECALL ON THIS ??

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 65 MPH, THE SUN ROOF SHATTERED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 141,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 60 MPH, THE SUN ROOF SHATTERED. THE VEHICLE WAS TAKEN TO THE AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 141,740.

5.4 3V TRITON. WHEN THE TRUCK IS AT IDLE AT A NORMAL OPERATING TEMP, IT HAS A HORRIBLE KNOCKING NOISE ON THE PASSENGER SIDE OF THE ENGINE. FROM WHAT I AM READING THIS ENGINE HAS MAJOR PROBLEMS WITH THE CAM PHASERS AND TIMING COMPONENTS. IT SOUNDS LIKE THE TIMING CHAIN IS ABOUT TO FLY OUT OF THE ENGINE. I HOPE MY TRUCK DOESN'T GIVE OUT ON ME BECAUSE THIS IS MY ONLY TRANSPORTATION TO WORK AND CANNOT AFFORD TO HAVE IT FIXED. I BOUGHT A FORD FOR RELIABILITY, BUT UNTIL THIS IS FIXED I FEEL IT'S UNRELIABLE. I HAVE USED A FULL SYN OIL AND THE RIGHT MOTORCRAFT 820S FILTER. THIS IS A MAJOR PROBLEM AND FORD NEEDS TO PAY FOR THIS AND EVERYONE ELSE WHO HAS HAD THIS PROBLEM OVER AND OVER! RECALL THIS FORD!

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE REVERSING AT 50 MPH, THE VEHICLE ACCELERATED ON ITS OWN AND CRASHED INTO THE FRONT OF ONE VEHICLE AND THE DRIVER'S SIDE OF ANOTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THERE WERE NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED FROM THE CRASH SCENE TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 78,000.

TRUCK BEGAN TICKING VERY LOUDLY, THEN BEGAN A KNOCKING NOISE, AND NOW THE ENGINE SHAKES THE TRUCK WHEN IDLING. CAM PHASERS BROKE APART CAUSING DAMAGE TO THE TIMING CHAIN. SUDDEN LOSS OF POWER TO THE ENGINE AS WELL AS INABILITY TO MAINTAIN SPEED WHILE ASCENDING AN INCLINE IS FREQUENT. THE LOSS OF SPEED AND POWER HAS CAUSED US SEVERAL CLOSE-CALL ACCIDENTS. TRUCK WILL SIMPLY NOT ACCELERATE WHILE PRESSING THE GAS PEDAL. ADDITIONALLY, IT ALSO FEELS LIKE THE TRUCK CANNOT CATCH GEARS WHILE IN MOTION.

!. VACUUM ADVANCE CONTROL FOR FOUR WHEEL DRIVE GETS WET, LOOSES PRESSURE AND FRONT WHEELS ENGAGE SLIGHTLY, CAUSING WHEEL HUB DAMAGE. 2. STEERING BECOMES HARD, ESPECIALLY IN COLD WEATHER. HARD TO INSPECT STEERING SHAFT UNTIL IT IS DISCONNECTED FROM STEERING RACK. COMMON PROBLEM WITH MID TO LATE 2000'S FORD CROWN VIC. POLICE VEHICLES. COME ON FORD, MAN UP AND MAKE THESE PROBLEMS A RECALL.

MY F150 FRAME IS RUSTED THROUGH WHERE IT ACTUALLY BROKE I WORK AS A WELDER AND I HAVE FIXED 3 DIFFRANT TRUCKS F150 AROUND THE SAME YEAR IT IS MOSTLY ON DRIVERS SIDE.

I WAS DRIVING THROUGH THE COUNTRY, AND SOMETHING FELT ODD. AT APPROXIMATELY 45 MPH, THE TRUCK STARTED TO SHAKE, (MORE THAN NORMAL) AND WAS THEN VANISH AFTER 55 MPH. AFTER THE NEXT FEW DAYS, THE SHAKING GOT WORSE. MY FIRST THOUGHT, "I HAVE A MISFIRE ON ONE OF MY CYLINDERS". ON MY WAY HOME FROM WORK MY TRUCK THROUGH A CHECK ENGINE LIGHT. I THEN PROCEEDED TO TAKE IT TO MY DEALER BECAUSE AT THIS POINT IT WOULD BARELY GO OVER 40 MPH. THEY CHECKED THE CODE AND TURNS OUT THAT THE TRUCK HAS A NUMBER OF PROBLEMS; THAT WHAT I HAVE SEEN ON THIS WEBSITE ARE A VERY COMMON ISSUE WITH THIS YEAR AND ENGINE TYPE (5.4L V8 TRITTON). I NEED NEW VCT SOLENOIDS, NEW CAMPHASERS, TIMING ADJUSTMENTS, AND NEW CAM SHAFT POSITION SENSORS. TO MAKE A LONG STORY SHORT, THE COMMON PROBLEM THAT HAPPENS TO THIS ENGINE, HAPPENED YET AGAIN. BAD CAM PHASERS. HAPPENED AROUND 138,4XX MILES. NOT SURE IF ANY PREVIOUS OWNER REPLACED THIS PART BEFORE OR NOT. BUT, IT SEEMS EVEN IF REPLACED, THE PROBLEM WILL STILL PERSIST IN THE FUTURE. THIS IS IN NEED OF RECALL.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE STATED WHILE DRIVING, THERE WAS AN ABNORMAL KNOCKING NOISE COMING FROM THE ENGINE. THE CONTACT STATED HE DROVE THE VEHICLE TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE CAM PHASER, THE BEARING AND THE TIMING CHAIN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT MENTIONED THAT THE VEHICLE WAS BACKFIRING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 40 MPH, THE DRIVER SIDE AIR BAG LIGHT REMAINED ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 190,000.

FUSE 14 CONTROLLING ABS MODULE, DTR SENSOR, REVERSE LIGHTS, PCV HEATER, AIR CONDITIONER COMPRESSOR, CRUISE CONTROL DEACTIVATOR SWITCH AND DAYTIME HEADLIGHTS WAS REPEATEDLY BLOWING. TRUCK WAS SERVICED BY DEALER ON 3-23-16, REPLACING THE A/C COMPRESSOR. REPLACING THE A/C COMPRESSOR DID NOT RESOLVE ANY ISSUES. THE TRUCK WAS RETURNED TO THE DEALER ON 4-6-16 FOR THE SAME ISSUE WITH THE SAME FUSE. THE DEALERSHIP REPLACED THE FUSE AND PERFORMED DIAGNOSTIC TESTS ON THE TRUCK, THEN INFORMING ME THAT THEY COULD NOT DIAGNOSE OR LOCATE THE SHORT. THE DEALERSHIP INFORMED ME THAT I WOULD HAVE TO DRIVE THE TRUCK UNTIL THE FUSE STARTED BLOWING MORE FREQUENTLY. THE FIRST TIME THE TRUCK WAS DRIVEN AFTER WORK WAS PERFORMED THE CRUISE CONTROL WAS NOT FUNCTIONING PROPERLY. THE TRUCK ENGINE WOULD SURGE AS THE TRUCK WENT DOWN THE ROAD WITH THE CRUISE CONTROL ON. THE ISSUE WITH THE CRUISE CONTROL HAPPENED ON 4-9-16. ON THE MORNING OF 4-10-16 THE TRUCK WAS DRIVEN APPROXIMATELY 4 MILES AND PARKED IN THE DRIVE OF MY HOME. AFTER ENTERING THE HOUSE THE ALARM WAS HEARD SOUNDING ON THE VEHICLE, AT WHICH TIME I STEPPED OUTSIDE TO FIND THE TRUCK ON FIRE. THE FIRE SEEMED TO HAVE STARTED ON THE INSIDE OF THE TRUCK.

INSIDE OF TIRE SIDEWALL SUDDENLY CRACKED OPEN LEADING TO RAPID PRESSURE LOSS. THIS SAME TIRE HAS BEEN RECALLED IN OTHER SIZES FOR THIS SAME FAILURE.

I DRIVE A 2005 5.4 TRITON AND AFTER 110000 MILES THE ENGINE HAS DIED. THE MECHANIC STATES ITS THE CAM PHASER AND I'VE SEEN SEVERAL WEBSITES COMPLAINING THE SAME ISSUE.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE SHIFTING INTO REVERSE, THE FRONT DRIVER SIDE AND REAR LOWER CONTROL ARM FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE PASSENGER SIDE LOWER CONTROL ARM AND THE SWAY BAR LINKS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 167,050.

PURCHASED MY VEHICLE USED AT THE DEALERSHIP WITH 85,000. WHICH IS TYPICALLY A GOOD BREAK-IN POINT FOR A TRUCK. WELL AFTER HAVING THE VEHICLE HOME FOR LESS THAN A MONTH I'VE NOTICED A TICKING IN THE ENGINE. A TICKING THAT I KNEW LITTLE ABOUT UNTIL FURTHER RESEARCH INTO THESE VEHICLES. SEEMS THAT ALONG WITH THOUSANDS OF OTHER PEOPLE IN THE WORLD I'VE PURCHASED A FORD LEMON. THE ENGINES RARELY MAKE IT PAST 75,000-100,000. FORD AS A WHOLE ARE AWARE OF THIS ISSUE AND DELIBERATELY FIND WAYS AROUND HAVING TO TAKE THE LIABILITY ON. THE ONLY SOLUTION TO THE TICKING IS 1,500 IN REPAIRS OF THE CAM PHASER, WHICH IN A TIMELY MANNER MELTS LIKE BUTTER OR REPLACE IT WITH A REMANUFACTURED ENGINE ONLY TO ENCOUNTER THE SAME ISSUE. WHETHER OR NOT THIS VEHICLE IS OVER 10 YEARS OLD THIS IS AN ISSUE THAT NEEDS TO BE ADDRESSED. AN ENGINE SHOULD BE ABLE TO LAST MORE THAN 100,000 MILES. I HAVE DRIVEN THIS VEHICLE LESS THAN 500 MILES AND THE PROBLEM IS EVIDENT.

STEERING GETS VERY HARD TO TURN. HAVE TO "MUSCLE" THE STEERING BACK AFTER A TURN. POWER STEERING RACK FAILED. FORD MOTOR CO. HAS A NATIONAL BACK ORDER ON REPLACEMENT PARTS. I THINK THERE'S A PROBLEM.

MY TRUCK HAS A KNOWN ISSUE WITH THE 5.4L'S CAM PHASERS. THE TRUCK MAKES A VERY LOUD NOISE AND SHAKES. TO REPAIR THIS, IT'S AROUND $3,000 AND ALSO I HAVE A KNOWN ISSUE WITH ALL 8 COILS WHICH HAD TO BE REPLACED FOR $1,200 AND A KNOWN MISFIRE. I DO NOT UNDERSTAND WHY FORD MOTOR IS AWARE OF THE ONGOING ISSUES IN THIS YEAR TRUCK AND HAS NOT DONE ANYTHING ABOUT IT. ALSO IF THE CAM PHASERS ARE NOT REPLACED THE ENGINE WILL BLOW!

ENGINE STARTED TICKING ENDED UP BEING CAM PHASERS AND NEEDED NEW MOTOR FORD KNOWS ITS A WELL KNOWN PROBLEM BUT REFUSES TO STAND BEHIND THEIR PRODUCTS.WAS TOLD IT WAS NORMAL ENGINE WEAR WHICH I FIND HARD TO BELIEVE AT 100,000MILES WITH RECOMMENDED MAINTENANCE DONE TO VEHICLE CLASS ACTION LAWSUIT WOULD BE THE BEST FOR ALL INVOLVED WHEN IT COMES TO THIS PRODUCT 7000 DOLLARS TO REPLACE MOTOR.

KNOWN ISSUE WITH FUEL INJECTORS CAUSED PREMATURE ENGINE FAILURE AT 45K MI. TOO MUCH FUEL WHEN COMPRESSED AND IGNITED BLEW THE PISTON APART. FORD REPLACED ENGINE. 80K MILES LATER SIMILAR PROBLEMS AND RECOMMENDATION IS ANOTHER ENGINE. TWO 5.4L ENGINES WITH LESS THAN 130K OVERALL MILES IS ABSOLUTELY UNACCEPTABLE. WEB SEARCHES SAY THERE IS CURRENT LITIGATION IN PROGRESS OVER THESE 5.4L ENGINES. I'M MAKING A FORMAL COMPLAINT THAT THE BASIS OF THE LAWSUIT HAS MERIT. FORD HAS ALREADY SETTLED A SUIT OVER THE SPARK PLUGS FOR THESE 5.4L BUT THE PROBLEMS WITH THESE ENGINES GOES MUCH DEEPER. I'M THANKFUL MY ENGINE FAILURES HAPPENED WITHOUT ANY ADDITIONAL INCIDENT.

F-150 BEGAN WITH A TICKING NOISE AND TURNED INTO A LOUD KNOCKING NOISE, VEHICLE LOOSES POWER OR COMPLETELY SHUTS OFF WHILE DRIVING. REPLACED COIL PACKS, AND SPARK PLUGS (ONE BROKE OFF DUE TO HORRIBLE DESIGN). BASICALLY, HAD TO TAKE APART THE ENTIRE ENGINE REPLACING SEVERAL PARTS TO STILL NOT HAVE A DRIVABLE VEHICLE. MECHANIC JUST INFORMED ME THERE IS NOTHING ELSE TO DO BUT REPLACE THE ENTIRE ENGINE. THANK YOU FORD I OWE ABOUT $8000 ON THIS POS. I HAVE ALREADY SUNK $1200 INTO THE VEHICLE AND WILL NOW BE LOOKING AT OVER $5000 TO REPLACE THE ENGINE. *TR

THE PHASERS AND TUNERS ARE SHOT INTERNAL ENGINE DAMAGE IT STARTED TO MAKE NOISE WHILE MOVING

I PURCHASED MY 2005 F150 WITH A 5.4L TRINITRON ENGINE USED IN 2010. I COMPLETED ALL REGULAR SCHEDULED MAINTENANCE USING THE RECOMMENDED PRODUCTS, MOST OF IT DONE IN FORD DEALERSHIPS. THIS 5.4L ENGINE IS A POOR DESIGN AND SHOULD BE RECALLED. IT HAS NUMEROUS PROBLEMS. I HAD A SAFETY INSPECTION DONE AT A FORD DEALERSHIP AND IT PASSED EVEN THOUGH IT HAD A TICKING SOUND IN THE ENGINE AND I HAD HESITATION AND LOSS OF POWER. REPLACE SPARK PLUGS, I HAD ALREADY REPLACED THE TRANSMISSION AT 98,000 MILES! THIS ENGINE IS A PIECE OF JUNK! FORD NEEDS TO STAND BEHIND ITS' "BUILT FORD TOUGH" TRUCKS AND MAKE THIS RIGHT. I CANT ENJOY MY TRUCK!!!

I PURCHASED MY 2005 F150 WITH A 5.4L TRINITRON ENGINE NEW IN 2005. I COMPLETED ALL REGULAR SCHEDULED MAINTENANCE USING THE RECOMMENDED PRODUCTS, MOST OF IT DONE IN FORD DEALERSHIPS. THIS 5.4L ENGINE IS A POOR DESIGN AND SHOULD BE RECALLED. IT HAS NUMEROUS PROBLEMS. I HAD A SAFETY INSPECTION DONE AT A FORD DEALERSHIP AND IT PASSED EVEN THOUGH IT HAD A TICKING SOUND IN THE ENGINE AND I HAD HESITATION AND LOSS OF POWER. AT THAT POINT, I HAD ALREADY REPLACED THE TRANSMISSION AT 62,000 MILES! NOW AT 105,000 MILES THE PLASTIC CAMPHASERS BROKE APART, THE TIMING CHAIN BROKE AND THE ENGINE IS BLOWN!! THAT IS UNACCEPTABLE FOR A FORD TRUCK TO LAST THAT LONG AND HAVE THAT MANY PROBLEMS. THIS ENGINE IS A PIECE OF JUNK! FORD NEEDS TO STAND BEHIND ITS' "BUILT FORD TOUGH" TRUCKS AND MAKE THIS RIGHT. I'LL NEVER BUY ANOTHER FORD.

HAD TO REPLACE SPARK PLUGS ON 2005 FORD F150. CAUSED MECHANICAL PROBLEMS. I GOT THEM REPLACED AT FORD DEALERSHIP IN RICE LAKE WISCONSIN.

THE HOSES FROM THE WINDOW WASHER PUMP TO THE SPRAYERS HAVE DETERIORATED

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT A STRONG FUEL ODOR WAS PRESENT IN THE VEHICLE OCCASIONALLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 124,000. .....UPDATED 04/15/16 *BF *CN

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING AND MAKING A RIGHT TURN, THE VEHICLE LOST POWER AND STALLED. THE CONTACT HEARD A BEEP SOUND PRIOR TO THE FAILURE. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DUPLICATE THE FAILURE OR RETRIEVE A FAULT CODE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

BRAKE WARNING LIGHT IS LIT ON THE DASHBOARD. THERE IS NOTHING WRONG WITH THE BRAKES. I HAVE READ THAT THERE IS A WIRING PROBLEM WHICH CAUSES THE BRAKE LIGHT TO STAY ON. FORD HAS RECALLED OTHER F150 MODEL YEARS BUT NOT 2005 F150S.

THE TRUCK HAS A TICKING SOUND INSIDE THE ENGINE. I HAVE HAD THAT NOISE SINCE I BOUGH IT. 3 YEARS AGO I HAD IT CHECKED OUT AT A FORD DEALERSHIP AND THEY SAID IT WAS NORMAL. THIS YEAR ON NOVEMBER 4, I TOOK IT AGAIN TO THE FORD DEALERSHIP AND THEY FOUND THE PROBLEM. ITS A BENT ROD. THE PROBLEM IS THAT THE EXTENDED WARRANTY THAT I HAVE WILL NOT COVER ITUNLESS THE KNOW THE CAUSE OF IT. SO FORD IS SAYING ITS A DEFECTED PART. INSURANCE WONT COVER IT AND THEY WANT ME TO PAY THOUSANDS OF DOLLARS TO REPAIR IT!! IF ITS A DEFECTED PART, DON'T YOU THINK FORD SHOULD PAY!!

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING AT APPROXIMATELY 55 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED AND THE VEHICLE LUNGED FORWARD WITHOUT WARNING. THE CONTACT STATED THAT WHEN THE VEHICLE WAS IDLE, THERE WAS A TICKING NOISE COMING FROM THE FRONT OF THE VEHICLE. THE FAILURES RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE VEHICLE CONSUMED EXCESSIVE OIL AT AN ACCELERATED RATE AND THE VEHICLE NEEDED AN OIL CHANGE. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 144,500.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING AT 70 MPH, THE VEHICLE SHOOK. WHILE MAKING A RIGHT TURN INTO A PARKING LOT, THE VEHICLE CRASHED INTO A MEDIAN AND A CURB. THE CONTACT SUSTAINED INJURIES TO THE SHOULDER, NECK, AND BACK, WHICH REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. NO POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 93,000.

SPARK PLUGS ARE IMPOSSIBLE TO BE REMOVED/REPLACED. WENT TO MECHANIC TO BE REMOVED/REPLACED AND WAS EXTREMELY EXPENSIVE. MUST BE SOME DEFECT ON FORD'S PART.

THE WARNING LIGHT FOR BRAKES, ON THE DASH, STAYS ON ALL OF THE TIME.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING, THERE WAS AN ABNORMAL NOISE COMING FROM THE ENGINE AREA AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT ALSO INDICATED THAT WHILE IDLE, THE VEHICLE WOULD SHAKE AND RATTLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ENGINE SOLENOID FAILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 140,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 20 MPH, THE VEHICLE SHOOK AND STALLED. THE CONTACT RESTARTED THE VEHICLE AND WAS ABLE TO DRIVE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE OIL PUMP WAS NOT SUPPLYING OIL TO THE TOP OF THE ENGINE AND THE ENGINE WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 106,200. UPDATED 1/12/16 *CN

DRIVER SIDE WINDOW REGULATOR FRAYED. WINDOW INOPERABLE.

REAR END SHAKING WHILE DRIVING DOWN ROAD ABOUT 60MPH. GETTING OFF GAS NOR PUTTING VEHICLE IN NEUTRAL WOULD NOT STOP SHAKING. HAD TO COME TO COMPLETE STOP BEFORE STARTING AGAIN TO MAKE VEHICLE DRIVE PROPERLY.

UNIT WAS RECALLED,DEALER HAD VEHICLE 3 DAYS,ADVISED THAT THEY DID NOT HAVE THE TOOLS REQUIRED TO FIX THE AIRBAG AND CONSEQUENTLY COULD NOT FIX THE PROBLEM.DEALER SAID THEY WOULD CALL ME LATER AND UPDATE PROGRESS ON COMPLETING THE RECALL.IT HAS BEEN A YEAR AND NO CALLS HAVE BEEN RECEIVED.

METAL SCRAPING SOUND FROM REAR END. MECHANIC HAS CHECKED AND SAYS PINION, BEARINGS, RING GEAR HAVE FAILED. LOOKS LIKE ITS A COMMON FAILURE. 9.75 RING GEAR, 3.55 RATIO

DRIVING VEHICLE HAVE NOTICED WHEN ENGINE IS IDLING, POWER STEERING IS SOMETIMES WEAK. FLUID IS REPLACED EVERY FALL, AS THE STEERING PUMP HAS BEEN A NOISY ONE SINCE THE TRUCK WAS NEW. DEALER SUGGESTED REPLACING FLUID WITH SYNTHETIC. IT WORKED THEN, SO I REPLACE IT EVERY YEAR. TODAY, WITH STEERING AT FULL LEFT LOCK, THE STEERING WAS STUCK AT THAT POINT. MOVED WHEEL BACK AND FORTH AND IT CAME LOOSE. HAVE NOT BEEN ABLE TO DUPLICATE SINCE. AS A NOTE AT 5 YEARS OLD AND 53,000 MILES POWER STEERING PRESSURE HOSE SPRUNG A LEAK UNDER THE CLAMP AT THE FRAME. REPLACED WITH AFTER MARKET PART, AS DEALER COULDN'T GET THE PART. BACK ORDERED!

ON HIGHWAY AT 60 MPH ENGINE STARTED TO MISS. WAS ABLE TO GET IT TO MY MECHANIC WHERE HE SAID A SPARK PLUG HAD FAILED. THE PLUG BROKE WHEN REMOVING. HE WAS ABLE TO REMOVE THE PLUG. THEN DUE TO A SQUEAL UNDER THE HOOD WHEN THE ENGINE WAS COLD, HE REMOVED THE INTAKE AND FOUND THE SEAL HAD FAILED, WHILE IT WAS APART HE NOTED 2 LEAKING FUEL INJECTORS. ALL DEFECTIVE PARTS WERE REPLACED. IN AUGUST THAT SAME YEAR I REPLACED THE OTHER 7 SPARKPLUGS, HAVING 4 MORE BRAKE OFF. THE EXTRACTOR TOOL WORKED GREAT.

I WAS STARTING THE TRUCK TO LEAVE A WAL-MART PARKING LOT AND MY LEFT FOOT WHICH WAS ON THE BRAKE WENT ALL THE WAY TO THE FLOOR OF THE TRUCK. I HAD NO BRAKES. IT WAS FORTUNATE THAT I WAS STOPPED AND NOT ON THE ROAD WITH OTHER CARS OR GOING DOWN A STEEP HILL. I HAD THE AUTO SHOP TOW THE TRUCK TO THE SHOP. THEY FIXED TWO BRAKE LINES. COMPLETE BRAKE FAILURE SHOULD NOT HAPPEN.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AND INDEPENDENT MECHANIC FOR SCHEDULED MAINTENANCE. WHILE THE VEHICLE WAS ON THE LIFT, THE MECHANIC NOTICED THAT THE ENTIRE FRAME WAS SEVERELY RUSTED AND THERE WERE FRACTURED AREAS IN FRONT OF THE WHEEL WELL ON BOTH SIDES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 67,000.

TL* THE CONTACT OWNS A 2005 FORD F-150 EQUIPPED WITH GENERAL AMERI-TRAC TIRES, SIZE: P255/70R17. THE CONTACT STATED THAT ALL THE TIRES EXHIBITED CRACKS IN BETWEEN THE TREAD PATTERN. THE TIRES WERE NOT DIAGNOSED OR REPLACED. THE TIRES WERE REPLACEMENT TIRES. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 116,000 AND THE TIRE FAILURE MILEAGE WAS 28,000.

ABOUT A YEAR AGO I WAS DRIVING MY F-150 PICKUP TRUCK DOWN STREET MAYBE 45 M.P.H WHEN OUT OF NOWHERE THE DRIVER SIDE WINDOW MADE A LOUD NOISE AND FELL DOWN INTO THE DOOR . ENDED UP THAT THE WINDOW REGULATOR HAD BROKEN . THEN YESTERDAY I WAS DRIVING ABOUT 50 M.P.H AND MY BACK WINDOW WAS OPEN ABOUT 2 INCHES I PUSHED THE BUTTON TO MAKE IT GO UP , IT MADE A LOUD GRINDING NOISE AND FELL INTO THE DOOR ALSO.

I PURCHASED MY 2005 FORD F-150 RIGHT OUT OF THE SHOW IN 2005 AND FIRST BEGAN HAVE JERKING ISSUES 6 MONTH LATER A MECHANIC THEN TOLD ME THAT IT WAS RELATED TO THE FUEL INJECTORS. SINCE THAT TIME I HAD TO REPLACE THE TRANSMISSION TWICE IN 2008, A TIMING CHAIN AND BENT RODS IN 2014 AND CURRENTLY ANOTHER TIMING BENT RODS AND DEBRI FROM THE OIL PAN. ALL CAUSED FROM THE INITIAL FAULTY FUEL INJECTOR ISSUES CONTINUING FROM LESS THAN ONE YEAR AFTER THE ORIGINAL PURCHASE IN 2005. I'VE SENT OVER $9500 IN MECHANIC COST TO DATE.

I WAS DRIVING AND HEARD A SOUND COME FROM MY ENGINE COMPARTMENT. I DIDN'T LOSE POWER, BUT PULLED OVER TO LOOK UNDER THE HOOD. NOT NOTICING ANYTHING OBVIOUS I CHECKED THE FLUID LEVELS AND NOTICED THAT MY TRANSMISSION FLUID WAS LOW. IT HAD BEEN CHECKED TWO MONTHS PRIOR DURING OIL CHANGE. I HAD NO VISIBLE SIGNS OF LEAKS. I FOUND A FORUM ON THE INTERNET THAT TALKED ABOUT TRANSMISSION FLUID GOING FROM THE TRANSMISSION TO THE TRANSFER CASE, BUT UNABLE TO RETURN. THEY HAD A $20 SEAL REPLACED UNDER WARRANTY. THE FORUM HAD STATED THAT THIS WAS A KNOWN CONDITION BUT NOTHING WAS BEING DONE BY FORD MOTOR COMPANY. A MECHANIC HAD SAID THAT IT ONLY EFFECTED 17-18% OF VEHICLES MANUFACTURED BETWEEN 2004-2008. I CALLED TWO LOCAL DEALERSHIPS AND THEY KNEW THE PROBLEM BUT SAID THAT THERE WAS NO RECALL ON IT. IT TAKES APPROXIMATELY 3 HOURS TO CHANGE, BY DROPPING THE TRANSFER CASE AND REPLACING THE SEAL. I CALLED FORD MOTOR COMPANY REPRESENTATIVE AND WAS TOLD THAT THERE WASN'T A RECALL AND THAT THEY COULDN'T HELP. I FEEL THAT THIS COULD RESULT IN A PREMATURE FAILURE OF THE TRANSMISSION AND POSSIBLY A CATASTROPHIC EVENT. I WAS TOLD BY FMC REP THAT SHOULD A RECALL OCCUR I COULD TAKE MY RECEIPT TO A DEALERSHIP AND THAT THEY WOULD POSSIBLY REIMBURSE ME. I DON'T FEEL THAT FORD SHOULD HAVE A KNOWN CONDITION BUT DO NOTHING TO CORRECT IT. PLEASE LOOK INTO THIS FOR ME AND OTHERS UNDER THE SAME SITUATION.

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING AT 15 MPH, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.

A NUMBER OF WIRES LEADING FROM THE BODY INTO THE DRIVER'S SIDE DOOR HAVE BEEN CUT/WORN POSSIBLY DUE TO CONTACT WITH THE INSIDE OF THE DOOR. THE RUBBER AND PLASTIC PARTS MEANT TO PROTECT THE WIRES WERE ALSO CUT/WORN. THIS HAS LED TO COMPLETE FAILURE OF ALL ELECTRONICS IN THE DOOR INCLUDING POWER LOCK, POWER WINDOWS, AUTOMATIC SHUTOFF OF RADIO, DOOR CHIME, KEYPAD, AND MIRRORS. DISCUSSION WITH FORD DEALER INDICATED THAT THEY HAVE SEEN THIS PROBLEM IN THE PAST.

TURNING LEFT INTO SOUTH BOUND LANE OF A HIGHWAY WHEN THE RIGHT FRONT UPPER CONTROL ARM ASSEMBLY CAUSED THE TIRE TO DETACH FROM THE THAT AREA. THE TIRE LANDED ON THE HIGHWAY HOWEVER REMAINED ATTACHED FROM THE LOWER ASSEMBLY. DUE TO THE MOMENTUM OF THE VEHICLE WAS ABLE TO GET ACROSS THE HIGHWAY TO PREVENT A COLLISION. VEHICLE WAS TOWED TO AN AUTOMOTIVE REPAIR CENTER. THE RIGHT FRONT UPPER CONTROL ARM ASSEMBLY WAS COMPLETELY RUSTED THROUGH

AIRBAG LIGHT STAYS ON.

SPARK PLUG BLEW OUT OF THE ENGINE CAUSING DAMAGE AND REQUIRING ENGINE REPLACEMENT.

ON THE MORNING OF MARCH 5TH 2015 I STARTED MY TRUCK TO WARM THE INSIDE AND ALSO MELT THE SNOW OFF MY WINDSHIELD. I GOT IN THE TRUCK AND BACKED OUT AWAY FROM HOUSE. DUE TO HAVING SNOW ON THE DRIVEWAY I TURNED ON THE 4 WHEEL DRIVE IN HIGH. MY FOUR WHEEL DRIVE WOULD NOT WORK SO I TRIED TO SWICTH TO 2 WHEEL DRIVE BACK TO FOUR WHEEL DRIVE BUT THE 4 WHEEL DRIVE WOULD NOT TURN ON. I GRABBED THE GEAR SHIFT TO PUT THE TRUCK BACK IN PARK WHEN I NOTICED MY GEAR SHIFT COULD FLOAT TO PARK TO 1ST GEAR FREELY AND WOULD NOT SHIFT. AT THIS TIME I NOTICED SMOKE STARTING TO COME INSIDE CAB FROM UNDER DASH AND THRU THE VENTS. I JUMPED OUT AND OPENED THE HOOD. A 1 FOOT SECTION OF A WIRING HARNES MOUNTED TO THE FIREWALL HAD CAUGHT FIRE. I MADE ATTEMPTS TO PUT OUT THE FIRE BUT WITHIN A FEW SECONDS THE ENGINE COMPARTMENT WAS ENGULFED. IN 2 TO 3 MINUTES THE ENTIRE INSIDE OF THE CAB WAS ALSO COMPLETELY ON FIRE. MY WIFE WHO WAS WATCHING ME IMMEDIATLY CALLED 911 TO GET THE FIRE DEPARTMENT. AFTER 3 MINUTES THE TRUCK WAS ALREADY A TOTAL LOSE. DUE TO THE TRUCK BEING ONLY 60' FROM MY HOUSE AND BURNING SO HOT I WAS CONCERNED ABOUT MY HOUSE CATCHING FIRE. TWO GENTLEMAN FROM THE RESCUE SQUAD ARRIVED BUT IT WAS TOO LATE FOR ANYTHING TO BE DONE. I WAS ABLE TO GET A BACKHOE AND PUT THE FIRE OUT WITH SNOW. UNFORTUNATELY I HAD LIABILITY INSURANCE ONLY WHICH MEANT A TOTAL LOSE. I NEVER DREAMED THAT THE TRUCK WOULD BURN UP SITTING IN MY DRIVEWAY!!!! I KNOW THERE HAVE BEEN SOME RECALLS FOR F150 DUE TO FIRE HAZARDS WITH THE CRUISE CONTROL FOR OTHER YEAR MODEL CLOSE TO 2005. A VEHICLE CATCHING FIRE WHILE ITS SITTING IN A DRIVEWAY RUNNING IS TOTALLY UNACCEPTABLE. THE TRUCK WAS IN EXCELLENT SHAPE AND HAD NO AFTER MARKET PARTS OR WORK PERFORMED. I HAVE NO IDEAL WHY THE WIRING HARNESS CAUGHT FIRE.

DRIVING ON INTERSTATE DOING 70 MPH (IN FAST LANE) WHEN TRUCK STOPPED/STALLED AND I GUESS FROM RESEARCH WENT INTO "LIMP MODE". I WAS UNABLE TO PRESS THE GAS PEDAL, IT JUST SHOOK THREE TIMES EACH OF WHICH SLOWED IT DOWN INCREDIBLY, THE CHECK ENGINE LIGHT WAS ON AND A WRENCH SHOWED UP, BUT THE RADIO STILL WORKED. WHILE TRYING TO PULL OVER ALMOST WRECKED (MEMORIAL DAY WEEKEND AND I WAS IN FAST LANE). FINALLY ABLE TO PULL OVER TO SIDE OF ROAD HYSTERICAL, SHUT OFF AND WAITED A MINUTE AND IT STARTED. DROVE REST OF WAY HOME *100 MILES* WITH CHECK ENGINE LIGHT ON AND ABS LIGHT ON. I AM SCARED TO DEATH TO DRIVE AGAIN. NOT FUN HAVING A VEHICLE STALL/QUIT WHATEVER ON INTERSTATE IN RUSH HOUR TRAFFIC.

MY 2005 F150 XLT FRAME IS RUSTED THROUGH ON THE DRIVER,S SIDE OF THE TRUCK. I PURCHASED IT IN DECEMBER OF 2005 SO IT HAS NOT SEEN TEN YEARS OF SERVICE YET. IT WILL NOT PASS VERMONT STATE INSPECTION WHICH MEANS I WILL NO LONGER BE ABLE TO DRIVE IT ON PUBLIC ROADS DUE TO SAFETY REASONS. THE BODY IS IN VERY GOOD CONDITION AND THE TRUCK HAS LESS THAN 41,000 MILES ON IT. I HAVE UNTIL THE END OF AUGUST, 2005 TO GET THE TRUCK FIXED SO IT WILL PASS INSPECTION. I DO NOT WANT TO DRIVE IT BECAUSE OF THIS SAFETY ISSUE. THE FRAME WHICH SUPPORTS ALL OTHER COMPONENTS OF THE TRUCK NEEDS TO AND SHOULD DEFINITELY LAST MUCH LONGER THAN TEN YEARS. WILL THERE BE A RECALL ON THESE TRUCKS TO REPAIR/REPLACE THE FRAMES SOON? IT WILL BE VERY EXPENSIVE TO HAVE IT REPAIRED LOCALLY.

I STARTED THE TRUCK AND THEN TURNED ON THE REAR DEFROST, WHICH I RARELY USE. IT WAS ABOUT 55 DEGREES OUTSIDE. AFTER ABOUT 2 MINUTES I HEARD A HISSING NOISE THAT LASTED FOR ABOUT 5 SECONDS AND THEN A HEARD LOUD POP AND THEN THE WINDSHIELD SHATTERED. MANY OTHER ARTICLES ON THE WEB INDICATE THAT THIS IS A KNOWN DEFECT WITH THE REAR DEFROST. I CALLED FORD AND THEY WILL NOT OFFER AND COMPENSATION TO HAVE IT FIXED EVEN THOUGH IT IS A KNOWN ISSUE. MY DAUGHTER WAS IN THE BACK SEAT AND GOT GLASS IN HER HAIR. *TR

I ATTEMPTED TO START MY TRUCK, IT TURNED OVER BUT WOULD NOT START. I HAD THE TRUCK TOWED TO THE LOCAL FORD DEALERSHIP WHERE I PURCHASED IT NEW, AND FOUND THE CAUSE OF THE NO START CONDITION TO BE THE FUEL PUMP DRIVER MODULE. (PART NUMBER 5L3A-9D370-AA) I ASKED TO HAVE THE PART SAVED FOR MY INSPECTION. WHAT I FOUND WAS VERY DISTURBING. THE ALUMINUM CASE OF THE MODULE WAS CRACKED IN HALF AND HAS A DIME SIZE HOLE ERODED THRU. BY CHANCE, ONE OF MY WORK ASSOCIATED WHO HAS A 2004 F150 HAD A FLAT TIRE THIS MORNING (JUST THREE DAYS AFTER MY EXPERIENCE WITH THIS PROBLEM) AND HAD THE SPARE TIRE DOWN. I LOOKED UNDERNEATH HIS TRUCK AND FOUND HIS TRUCK TO HAVE A MODULE IN AS POOR CONDITION AS THE ONE I HAD REPLACED. I TOOK A PICTURE THAT I WOULD BE HAPPY TO FORWARD. TWO ADDITIONAL WORK ASSOCIATES WITH 2004 - 2005 F150'S HAVE EXPERIENCED THIS SAME PROBLEM WITH THEIR TRUCKS, I HAVE ALSO READ SEVERAL ONLINE POSTS TODAY OF THIS VERY SAME PROBLEM. THIS IS NOT AN ISSUE OF NORMAL WEAR OF A PART, THIS IS A DEFINITE DESIGN FLAW AND SAFETY ISSUE. THE MODULE IN QUESTION IS MOUNTED ABOVE THE SPARE TIRE ON THE DRIVERS SIDE REAR AXLE. THE TIRE IS MOUNTED FOR STORAGE TO THE UNDERSIDE OF THE TRUCK. THE ALUMINUM COVER OF THE MODULE IS MOUNTED AGAINST THE STEEL AXLE AND SEEMS TO ACT LIKE A SACRIFICIAL ANODE AS THE MODULE COVER ERODES AND CRACKS TO THE POINT OF NEAR TOTAL DESTRUCTION EXPOSING A CIRCUIT BOARD TO THE ELEMENTS. IT WOULD SEEM THIS MODULE WOULD BE PLACED IN AN AREA THAT WOULD BE LESS LIKELY TO DESTROYED BY THE ELEMENTS OR ENCAPSULATED OR COATED IN A WAY THAT PROTECT IT. ANY VEHICLE THAT CAN BECOME SUBJECT TO STALL FROM A FAILED PART IS A SAFETY CONCERN AND ON THIS SCALE SHOULD BE CAUSE FOR RECALL CONSIDERATION. THE COST FOR THIS REPAIR "PARTS AND LABOR" AT A DEALERSHIP IS APPROXIMATELY $400.00. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE INDEPENDENTLY DECELERATED BEFORE RAPIDLY ACCELERATING WITHOUT WARNING. THE FAILURE PERSISTED AND WOULD CAUSE THE ENGINE TO MISFIRE. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE SPARK PLUG, IGNITION COIL, AND THE NUMBER FIVE COIL NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000.

UPON STARTING MY CAR THAT MORNING IT BACKFIRED AND WHITE SMOKE EXITED FROM THE EXHAUST WHICH IT HAS NEVER DONE BEFORE. ONCE IDLING I PUT THE TRUCK IN REVERSE WITH MY FOOT ON THE BRAKE AND MY TRUCK ROLLED DOWN THE DRIVEWAY. I HAD TO DEPRESS MY BRAKES WITH SIGNIFICANT FORCE TO GET IT TO STOP. UPON CHECKING THE ENGINE LATER THERE IS NO VACUUM DETECTED AT THE POWER BRAKE ASSIST. THERE IS A RECALL ON OTHER FORD TRUCKS OF THIS YEAR AND MODEL WITH THE SAME ISSUES THAT MINE WAS EXHIBITING. UPON CALLING FORD THEY SAID THAT MY VIN # WAS NOT ASSOCIATED WITH THIS RECALL. GO FIGURE! *TR

SPARK PLUGS BLOWING OUT. *TR

THIS ENGINE IS PRONE TO ENGINE FAILURE DUE TO CAM PHASERS ON 5.4 MOTOR ON A FORD F150 CAM PHASERS RESULTING IN ENGINE FAILURE WITH THE 5.4 MOTOR ## *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SHAKE AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,000.

2005 FORD F-150. CONSUMER WRITES IN REGARDS TO VEHICLE TUNE-UP ISSUES. *SMD THE CONSUMER STATED NO ONE CAN TELL HIM THE ESTIMATED COST OF A TUNE-UP BECAUSE THE SPARK PLUGS CAN BREAK OFF WHEN BEING REMOVED AND CAN COST SEVERAL HUNDRED OR EVEN THOUSANDS IF THE CYLINDER HEAD HAS TO BE REMOVED TO DEAL WITH THE BROKEN PLUG(S). *JB

THE VEHICLE HAS A REMOVABLE RUBBER COVER ON THE BRAKE PEDAL WHICH CAN COME OFF DURING BRAKING CAUSING ONE'S FOOT TO COME OFF THE PEDAL. THIS IS WHAT HAPPENED CAUSING ME TO HIT THE CAR IN FRONT OF ME AS I WAS COMING TO A STOP. *TR

TL*THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE ACCELERATOR PEDAL WAS DEPRESSED BUT THE VEHICLE DID NOT MOVE FORWARD. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 96.000. THE VIN WAS UNAVAILABLE.

THE LOWER UJOINT ON THE STEERING COLUMN IS FREEZING UP FROM CORROSION. IN THE PAST I HAD NOTICED IT WAS GETTING HARDER TO STEER SO I WOULD SPRAY THE JOINTS WITH PENETRATING OIL AND THEY WOULD IMPROVE. TODAY THE JOINTS WERE SO BAD IT WAS AS IF THE POWER STEERING HAD GIVEN OUT, TO THE POINT I PULLED OVER TO CHECK THAT I DIDN'T BLOW A POWER STEERING HOSE. I WILL NOT LET MY WIFE DRIVE THIS TRUCK UNTIL THE PART IS REPLACED BUT AT A COST OF $200 FOR THE PART IT WILL HAVE TO BE PARKED FOR A WHILE. I UNDERSTAND NORMAL WEAR BUT THIS IS COMMON ENOUGH TO DRAW SOME ATTENTION I HOPE. *TR

EXHAUST MANIFOLD ON THE FORDS' 5.4L ENGINE APPARENTLY WERE NOT ENGINEERED CORRECTLY. I HAVE HEARD OF MANY THAT HAVE LEAKED AND HAD TO BE REPLACED. I WORRY ABOUT THE POSSIBILITY OF FIRE. I HAVE CONTACTED FORD MOTOR CO. MULTIPLE TIMES HOWEVER THEY DECLINED ANY HELP WITH THERE REPLACEMENT ON MY TRUCK. IT SEEMS TO BE A VERY COMMON PROBLEM FROM WHAT I'VE HEARD AND SEE ONLINE. SHOULD FORD HAVE A RECALL ON THESE MANIFOLDS? *TR

I TOOK MY TRUCK IN FOR A REPAIR AND WHEN THEY LIFTED IT THEY FOUND HOLES IN THE FRAME OF THE TRUCK. I HAVE BEEN INFORMED THAT IT MAY FAIL WITHIN TWO YEARS. THIS TRUCK IS AROUND 10 YEARS OLD AND HAS BEEN PARKED IN A DRIVEWAY FOR THE FIRST HALF OF ITS LIFE AND UP TILL LAST YEAR HAS BEEN GARAGE KEPT. THERE IS 57,805 MILES ON IT TALKED TO MULTIPLE MECHANICS AND NONE OF THEM CAN BELIEVE THAT THERE IS ANY LOGICAL REASON FOR SUCH A FAST ROT OUT. *TR

I JUST WANTED TO ADD MY VEHICLE TO THE LIST OF COMPLAINTS ABOUT THE DIFFERENTIAL. MINE MAKES NOISE AND HAS MADE NOISE FOR QUITE SOME TIME. I THOUGHT IT MIGHT BE THE TIRES OR ROTORS. I FOUND OUT THAT IT WAS COMING DIRECTLY FROM THE REAR DIFFERENTIAL. BASED ON THE COMPLAINTS I HAVE HEARD, I AM PRETTY SURE THIS IS THE SAME THING. THE NOISE SOUNDS LIKE METAL RUNNING ON METAL. I BELIEVE THIS SHOULD BE SOMETHING FORD SHOULD PAY TO FIX. IF I HAVE TO PAY FOR IT, I'M DEFINITELY NOT USING FORD. I READ THAT'S MANY PEOPLE HAVE THE SAME COMPLAINTS. THIS FAILURE IS SECURITY PUBLIC PROBLEMS, BECAUSE ACCIDENTAL OR CRASH MAY OCCUR. *TR

WE HAVE HAD OUR 2005 F-150 KING RANCH FOR ABOUT 10 YEARS NOW. TODAY (FEB 10,2015), MY WIFE AND OUR ONE YEAR BABE WERE HEADING TO THE POST OFFICE THE TRUCK DISPLAYED A MESSAGE READING "ENGINE FAILSAFE MODE". THE TRUCK LOST ALL POWER, NO STEERING, AND IT STALL ON THE HIGHWAY GOING ABOUT 65 MPH. LUCKILY, SHE SAID THERE WERE VEHICLES BEHIND HER AND SHE PULLED IT OVER WITH NO STEERING AND THE ENGINE DEAD. MY WIFE THEN SAT ON THE HIGHWAY FOR ABOUT 10 MINUTES AND TRIED TO START THE VEHICLE, WHICH STARTED AND THERE WERE NO "ENGINE FAILSAFE MODE" ON DISPLAY ANYMORE. KNOW WITH-IN THE LAST YEAR OUR TRUCK HAS HAD THE CHECK ENGINE LIGHT AND THE ABS LIGHT HAS COME ON AND OFF EVERY OTHER MONTH. I HAVE CHECKED THE FUSES AND HAD REPLACE A FEW BUT AT TIME IT IS NOT THE FUSE. I'VE HAD THE INTERIOR DIM IN AND OUT AND AT TIMES IT DOES NOT WORK AT ALL. BY READING THE F150.NET FORUM FOUND OUT THE A WIRE THAT SPLITS INTO TWO WIRES WAS CORRODED ON THE PASSENGER SIDE FLOOR BOARD, IT SEEMS THAT CONDENSATION OR WATER COME IN AND STAYS IN THAT POCKET WERE THAT WIRING HARNESS GOES THRU. I AM NOW TERRIFIED THAT TRUCK WILL SHUT OFF ON THE HIGHWAY AGAIN WITH MY FAMILY AND I IN IT. THIS SEEMS TO BE A LIFE THREATENING PROBLEM. I HAVE READ THRU SOME FORUMS AND IT SEEMS THAT PEOPLE HAVE CALLED THE FORD DEALERSHIP AND THE SERVICE DEPARTMENT CLAIMED THEY HAVE NEVER HEARD OF THIS PROBLEM, BUT CAN WORK ON IT IF THEY BRING IT IN. BUT THAT FORD CLAIM THAT THEY FIX THE PROBLEM AND THE PEOPLE SAYS THAT THE PROBLEM STILL EXIST. HOPE SOME ONE CAN HELP OR ASSIST US IN FIXING THIS ISSUE NOT JUST FOR OUR FAMILY BUT FOR OTHERS TOO. SINCERELY [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

BOUGHT A 2005 F150 TRITON V8 5.4L NEW IN 2005. I HAVE NOW EXPERIENCED A CAM PHASE PROBLEM WHICH WILL COST APPX 2500 TO REPAIR. TALKING TO MY MECHANIC HE SAID THAT IT WAS NO PROMISE TO FIX THE ISSUE , BECAUSE THESE MOTORS ARE KNOWN FOR THIS ISSUE. WAS TOLD IT WOULD BE EASIER TO PUT ANOTHER MOTOR IN SO I WOULDN'T HAVE TO WORRY ABOUT ,IF IT WOULD FIX THE PROBLEM. MY BROTHER HAS A 2008 FORD WITH THE SAME MOTOR AND HAD THE SAME PROBLEM ,BUT HIS MOTOR AFTER HAVING THE CAM PHASER'S REPLACED BLEW UP AND HAD TO REPLACE THE MOTOR. AFTER RESEARCHING AND TALKING TO SEVERAL ASE QUALIFIED MECHANICS THEY ALL SAID THAT THERE'S AN ISSUE WITH THE 5.4 LITER TRITON MOTOR. UPON CALLING FORD MOTOR COMPANY AS I WELL FIGURED WOULD HAPPEN THEY SAID THAT THEY WOULDN'T HELP WITH THE COST AND THAT THERE WAS NOR RECALL. CONSUMERS SHOULD BE ABLE TO GET MORE THAN 100,000 MILES OUT OF A VEHICLE THEY BUY. IF FORD WANTS TO KEEP CUSTOMERS HAPPY THEY SHOULD ADDRESS THEPROBLEM AND THE GOVERNMENT SHOULD BE MORE VIGILANT IN ASSURING THE CONSUMER IS PROTECTED FROM COMPANIES WHOSE PRODUCT DOSEN'T MEET STANDARDS. I WOULD LIKE TO SEE THE GOVERNMENT TO LOOK AT ALL COMPLAINTS THROUGH A SURVEY ON THIS MOTOR TO FIND A SOLUTION FOR THE CONSUMER. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, THE ENGINE MISFIRE AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE PROBLEM RECURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE SPARK PLUG WAS FRACTURED AND THAT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000.

SPARK PLUG BLEW OUT OF HEAD. *TR

2005 F150 GOES INTO "FAIL SAFE MODE" AND SHUTS DOWN WHILE DRIVING. IT ONLY OCCURRED ONCE PER YEAR STARTING AT 65,000 MILES, BUT NOW HAPPENS EVERY 3-4 WEEKS AT 114,000 MILES. ONCE THE ENGINE SHUTS DOWN, I PUT THE TRANSMISSION INTO NEUTRAL WHILE COASTING AND IT RESTARTS EASILY. THE ENGINE LIGHT ILLUMINATES FOR 3-4 DAYS AND THEN TURNS OFF. IN RESEARCHING THE ISSUE, IT SEEMS TO BE A RATHER COMMON PROBLEM WITH THIS VEHICLE AND IS USUALLY CAUSED BY A FAULTY THROTTLE BODY. FORD STATES THAT THEY ARE AWARE OF THE PROBLEM. *TR

I OWN THE ABOVE MENTION VEHICLE, THERE WAS NO DISCLOSURE TO ME AT THE TIME OF PURCHASE OF A VERY SERIOUS DESIGN FLAW WITH THE SPARK PLUGS THAT COULD AND LIKELY WILL BREAK OFF IN THE ENGINE DURING REPLACEMENT AND THE EXTREME COST IN CHANGING THESE PLUGS AROUND 900 TO 1000 DOLLARS IF NO PLUGS BREAK OFF AND EVEN MORE IN THE PLUGS DO BREAK OFF OR HEADS HAVE TO REMOVED TO EXTRACT THE PLUGS EVEN WORSE PIECES OF PRSHELL COULD FALL INTO THE ENGINE CYLINDER AND CAUSE ENGINE DAMAGE TO AROUND 8000 DOLLARS NOW THAT I AWARE OF THE EXTREME COST 3 OR 4 TIMES THE AMOUNT FOR ROUTINE MAINTENANCE OF CHANGING SPARK PLUGS IN THESE FORD VEHICLES FORD IS NO HELP AT ALL SAYING ITS NOT A SAFETY ISSUE I CANT HELP IT THE DESIGN FLAW WITH THESE LONG 2 PIECE PLUGS IS SO SERIOUS AND THE PRICE GOUGING OF THE CONSUMER FOR THE COST TO CHANGE SPARK PLUGS IS SO EXPENSIVE AND SO BAD I STRONGLY FEEL THAT THE FEDERAL GOV SHOULD STEP INTO THE MATTER AND HELP THE CONSUMERS OUT AND NOT ALLOW FORD TO GET BY WITH THIS EXTREME BAD DESIGN FLAW AND THE OUTRAGEOUS COST THEY ARE CHARGING AND THE FED GOV SHOULD FORCE FORD TO RECALL ALL AFFECTED VEHICLES AND MANDATE THAT FORD EAT THE COST OF CHANGING THESE SPARK PLUGS AND PUT IN THE NEWLY DEVELOPED PLUGS THAT ARE NOT PRONE TO BECOME SEIZED TO THE ENGINE AND FORD SHALL DO SO AT NO COST TO THE CONSUMER SAFETY OR NOT IT IS JUST UNBELIEVABLE THEY CAN GET BY WITH SUCH A SERIOUS DESIGN FLAW WITH SUCH A HIGH EXPENSE TO THE CONSUMER FOR SOMETHING THAT IS SUPPOSED TO BE ROUTINE. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 25 MPH, THE FOUR WHEEL DRIVE ACTIVATED INDEPENDENTLY AS A LOUD ABNORMAL NOISE EMITTED FROM THE FRONT OF THE VEHICLE. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS REPAIRED ON NUMEROUS OCCASIONS BUT THE FAILURE PERSISTED. THE REPAIR SPECIFICS WERE NOT AVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 58,000.

CORROSION OF THE U-JOINTS ON THE LOWER STEERING SHAFT OF MY 2005 FORD F150 (4.6 L) IS CAUSING THE STEERING TO MALFUNCTION. STEERING WILL NOT RETURN TO CENTER AFTER TURNING, EVEN AT MODERATE SPEEDS. THE VEHICLE DRIVES AS IF IT HAS NO POWER STEERING. LUBRICATION OF THESE JOINTS WILL REMEDY THE PROBLEM FOR A PERIOD OF A WEEK OR SO, BUT THE PROBLEM PERSISTS. THIS IS A KNOWN DESIGN FLAW THAT HAS BEEN RECALLED IN OTHER FORD MODELS WITHIN SIMILAR MANUFACTURE DATES. I LIVE IN A COLD WEATHER STATE WHERE THE PROBLEM IN THE RECALLED VEHICLES HAS BEEN NOTED TO BE MORE OF AN ISSUE. THERE ARE MANY ONLINE COMPLAINTS REGARDING THIS DESIGN FLAW IN THE F150. THE COST FOR ME TO REPLACE THIS PART WILL RANGE FROM $300 TO $600. HOWEVER, THE REPLACEMENT PARTS ARE MADE WITHIN THE SAME ORIGINAL OEM DESIGN. THE PARTS NEED TO BE CORRECTED SO THAT REPLACEMENTS WILL NOT FALTER AS WELL. IT IS VERY SCARY TO THINK THAT I MAY NOT BE ABLE TO RELY ON MY STEERING DURING DIFFICULT WEATHER SITUATIONS. *JS

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING APPROXIMATELY 60 MPH, THE ENGINE STALLED AND THE ENGINE FAILURE SYSTEM WARNING LIGHT ILLUMINATED. THE VEHICLE WAS RESTARTED AFTER MULTIPLE ATTEMPTS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 103,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT REMAINED ILLUMINATED. THE INDEPENDENT MECHANIC DIAGNOSED THAT THE SEAT BELT PRETENSIONERS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 33,000.

AFTER THE RECALL TO PREVENT A SHORT BETWEEN HORN AND AIR BAG WAS COMPLETED IN 2011 A SHORT TIME THEREAFTER IN THE MIDDLE OF THE NIGHT THE HORN CAME ON BY ITSELF IN THE LOCKED VEHICLE WITH NO ONE IN IT. AFTER TRYING EVERYTHING I COULD THINK OF LIKE STARTING THE ENGINE AND PUSHING THE HORN BUTTON NUMEROUS TIMES. I WAS ABOUT READY TO DISCONNECT THE BATTERY WHEN IN ANGER I HIT THE CENTER OF THE STEERING WHEEL VERY HARD WITH MY HAND AND THE HORN STOPPED BLOWING. FROM THAT DAY ON THE AIRBAG WARNING LIGHT STAYS ON WHEN THE ENGINE RUNS. AND THE HORN BLOWS HALF AS LOUD AS IT ORIGINALLY DID WHEN ACTIVATED. FORD SAYS ITS MY PROBLEM BECAUSE THE RECALL WAS ALREADY COMPLETED. ONLY PROBLEM HERE IS THAT THEIR WAS NO PROBLEM AT ALL UNTIL AFTER THE RECALL WORK. *TR

OVER THE PAST 5 YEARS I HAVE HAD MY TRUCK GO INTO FAIL SAFE MODE. MY TRUCK WILL FLASH FAIL SAFE AND I WILL LOSE ALL POWER TO THE VEHICLE. I'M ABLE TO COAST TO A STOP. I HAVE BEEN ABLE TO RE START MY VEHICLE AND CONTINUE DRIVING. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN DIAGNOSED THAT THE FRONT SEAT BELT PRETENSIONER WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE HAS BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 33,000.

FRONT END COLLISION INTO THE REAR OF ANOTHER TRUCK. WHOLE FRONT END DAMAGED THROUGH RADIATOR, HOOD, HEADLIGHTS, BUMPERS ETC. AIRBAG NEVER DEPLOYED AND UPON RETURN OF VEHICLE AFTER REPAIRS, I AM NOW GETTING A CODE 42 THAT THE SENSOR IS BAD AND AFTER RESEARCH FIND OUT THERE IS A RECALL ON THIS BUT FOR THE OPPOSITE REASON BUT ALSO NOW UNDERSTAND THERE ARE CORROSION ISSUES WITH THE CONNECTION OF THE SENSOR ALSO. HOPE THIS HELPS. PLEASE ADVISE WHAT TO DO, WILL FORD FIX THIS WHOLE PROBLEM AND REPLACE WITH A NEW SENSOR AND THE WIRE CHAFFING PROBLEM? THANK YOU IN ADVANCE! *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE APPROACHING A TRAFFIC LIGHT, THE BRAKES WERE ENGAGED AND THE VEHICLE SURGED FORWARD. THE CONTACT MENTIONED THAT EXTREME FORCE WAS REQUIRED IN ORDER TO STOP THE VEHICLE. ALSO, THE CONTACT STATED THAT THE SAFE MODE AND CHECK ENGINE LIGHT ILLUMINATE AS THE VEHICLE STALLED. THE CONTACT HAD TO WAIT SEVERAL MINUTES BEFORE THE VEHICLE RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.

THE "AIRBAG" INDICATOR LIGHT CAME ON. STAYED ON FOR ABOUT 6 WEEKS WHEN VEHICLE WAS IN USE, THEN TURNED OFF. NOW, A MINUTE OR SO AFTER STARTING VEHICLE AN ALARM SOUNDS, 5 LOW SOUNDING BEEPS IN 5 ROUNDS, WILL DO IT ABOUT EVERY 30 MINUTES, SAME ALARM CYCLE. ACCORDING TO THE OWNERS MANUAL THIS IS AN INDICATION OF A PROBLEM WITH THE AIRBAG SYSTEM. I THOUGHT I WAS RESPONSIBLE FOR HAVING THIS FIXED. CURRENTLY WITH MY SCHEDULE AND FINANCIAL SITUATION I HAVE BEEN PUTTING OFF SERVICING THIS ISSUE HOWEVER, I HEARD ON THE NEWS EARLIER THIS WEEK ABOUT SEVERAL RECALLS AND MY VEHICLE FITS INTO THIS. I HAVE NOT RECEIVED ANY RECALL NOTICE FROM FORD. I'M NOT SURE IF MY VEHICLE IS ACTUALLY PART OF THIS, THIS IS WHY MY INQUIRY TO YOU. PLEASE ADVISE *TR

I HAVE OWNED MY FORD TRUCK FOR ALMOST 8 YEARS AND I HAVE EXPERIENCED NOTHING BUT BAD LUCK WITH THIS ENGINE AND ME AND OTHER FORD OWNERS AGREE THAT THIS ENGINE IS 1 OF THE WORST ENGINES THAT FORD HAS PRODUCED AND THEY KNOW IT. AND ARE RELUCTANT TO DO ANYTHING ABOUT IT. AND ITS COSTING ME THOUSANDS TO REPLACE SPARK PLUGS AND CAMPHASERS. MY TRUCK NOW WILL STALL WHEN PUT IN REVERSE. IT ALSO HAS A LOUD TICKING NOISE TO IT. I KNOW ITS THE CAMPHASERS AGAIN WHICH I ALREADY REPLACE ABOUT 4 YEARS AGO.THIS TRUCK IS COSTING ME MORE THAN ITS WORTH. I ONLY HAVE 85000 MILES ON IT. FORD NEEDS TO DO SOMETHING ABOUT THIS PROBLEM. ME AND OTHER FORD OWNERS OF THIS MODEL CANT KEEP SLAMMING MONEY INTO SOMETHING THAT IS A COMPLETE FAILURE FROM THE START. THIS TRUCK IS DANGEROUS AND THE PROBLEM NEEDS SOLVED. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE SEAT BELT PRETENSIONER AND STABILIZER BAR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. HOWEVER, THE DEALER ADVISED THE CONTACT THAT THE SEAT BELTS WERE NOT COVERED UNDER WARRANTY. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 33,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE FAILED TO RESTART AFTER BEING SHUT OFF. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT REPAIRED THE FUEL PUMP DRIVE MODULE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 123,000.

2005 FORD F-150. CONSUMER WRITES IN REGARDS TO SPARK PLUGS AND COILS PROBLEM. *SMD THE CONSUMER STATED THE VEHICLE STALLED, UPON ACCELERATION. THE CONSUMER ALSO STATED THE CHECK ENGINE LIGHT ILLUMINATED AND FLASHED WHEN A SPARK PLUS MISFIRED. *JB

WHILE STOPPING FOR A PEDESTRIAN, AT A SPEED OF APPROXIMATELY 10 MPH,THE REAR PASSENGER SIDE RUBBER BRAKE LINE SEPARATED FROM THE STEEL BRAKE LINE,RESULTING IN THE IMMEDIATE LOSS OF ALL BRAKE FLUID AND THE BRAKE PEDAL GOING TO THE FLOOR.THE CAUSE OF THIS SEPARATION ,WAS CORROSION OF THE FACTORY STEEL CLAMP ,CLAMPING THE RUBBER HOSE TO THE STEEL BRAKE LINE. UPON EXAMINATION,IT WAS FOUND THAT TWO OTHER CLAMPS WERE IN THE SAME CONDITION.I WAS ABLE TO COMPLETELY REMOVE ONE CLAMP ,BY RUBBING IT BETWEEN MY FINGER AND THUMB.THESE STEEL COMPONENTS ARE UNSAFE FOR USE IN STATES THAT USE SALT OR BRINE ON THEIR ROADS.THIS WAS MADE WORSE BY THE FACT THAT THE RESERVOIR USED,IS NOT SPLIT INTO TWO SECTIONS, ALLOWING LOSS OF ALL BRAKE FLUID FOR BOTH FRONT AND REAR BRAKES AT THE SAME TIME. *TR

FORD DESIGNED THE FACTORY SPARK PLUGS AS A TWO PIECE DESIGN. ONCE THE TRUCK REQUIRES A TUNE UP THE CURRENT SPARK PLUGS BREAK IN HALF AS THEY ARE REMOVED CAUSING AN ADDITION COST FOR EXTRA LABOR AND SPECIAL TOOLS DESIGNED TO REMOVE THESE PLUGS. I TOOK MY TRUCK TO THE FORD DEALER WHO THEN BROKE 6 OUT OF 8 PLUGS UPON REMOVAL AT AN EXTRA COST OF 80 DOLLARS A PIECE. THE TUNE UP WHICH ONLY INCLUDES THE REMOVAL OFF THE OLD AND THE INSTALLATION OF THE NEWLY DESIGNED ONE PIECE SPARK PLUGS ENDED UP COSTING ME 1000 DOLLARS. THESE SPARK PLUGS ALSO BREAK INSIDE THE ENGINE CAUSING A LOSS OF POWER AND POSSIBLE DAMAGE TO THE CATALYTIC CONVERTER. *TR

TRUCK SHAKES VIGOROUSLY AT SPEEDS OVER 55MPH, CANNOT EXCEL IN FAST ONCOMING TRAFFIC WITH CHILDREN IN VEHICLE! ENGINE CUTS OUT AND JERKS THE WHOLE VEHICLE. MISFIRING. CONTINUOUSLY HAVING TO GET TOWING BECAUSE THE VEHICLE FAILS TO START ALL TOGETHER! THIS COULD LEAD TO INJURY, DEATH, ACCIDENTS NOT ONLY FOR THE DRIVER/PASSENGERS BUT OTHERS ON THE ROADS AS WELL. THIS ISSUE HAS BEEN BROUGHT TO ATTENTION IN THE FORD F-150 5.4L ENGINE MORE THAN SEVERAL HUNDRED TIMES AND NO ACTION HAS BEEN TAKEN. YOU CAN FIND INFORMATION ALL OVER OF PEOPLE HAVING THE SAME ISSUES, THE FORD DEALERSHIP I TOOK IT TO TOLD ME I WOULD NEED A NEW ENGINE OR TO SPEND THOUSANDS TO FIX IT AND THEY SEE PEOPLE BACK IN THERE WITHIN THE MONTH OF SPENDING GRANDS TO FIX IT. SOMETHING NEEDS DONE ABOUT THIS BEFORE PEOPLE END UP DYING IN THESE VEHICLES. *TR

THE 5.4 LITER ENGINES HAVE A DESIGN PROBLEM THAT'S COSTING OWNERS A LOT OF MONEY JUST TO REPLACE THE SPARK PLUGS. THE PLUGS ARE TWISTING OFF OR BREAKING BECAUSE THE BLOCK DESIGN ALLOWS THE PLUG TO EXTEND INTO A HOLE THAT ALLOWS CARBON BUILDUP AROUND THE TIP OF THE PLUG. WHEN YOU TRY TO REMOVE THE SPARK PLUG THE BOTTOM OF THE PLUG IS SEALED TIGHT TO THE HEAD THEREFORE ALLOWING THE TOP OF THE PLUG TO TWIST AND NOT THE BOTTOM. THIS IS HAPPENING TO A LOT OF TRUCK OWNERS AND SOME DEALERS WON'T EVEN ATTEMPT TO REPLACE THE PLUGS. IF ONE BREAKS, IT COULD COST UP TO $2000 FOR THE REPAIRS. I HAVE 4 OF THEM BROKE OFF. I HAVE ORDERED THE EXTRACTOR KIT BUT THE BACK TWO CYLINDERS ARE GOING TO BE HARD TO REPAIR. I LIKE MY FORD TRUCK BUT SINCE THE EARLIER MODEL FORDS WERE BLOWING PLUGS OUT OF THE BLOCKS AND NOW WE CAN'T GET THEM OUT WITHOUT AN EXTRACTOR, TO ME THIS IS NOT GOOD ENGINEERING. I WOULD LIKE TO KNOW WHAT FORD IS DOING ABOUT THIS EXTREME COST TO ITS CUSTOMERS. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE AIRBAG WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 11V107000 (AIR BAGS). THE FAILURE MILEAGE WAS 79,000.

WE BOUGHT THIS VEHICLE NEW IN 2005. CHANGE OIL AS REQUIRED AND DID REGULAR SERVICES. ENGINE STARTED KNOCKING AND RUNNING ROUGH. TOOK TO DEALER WHO STATED CAM PHASERS WENT OUT WHICH IN TURN BLEW THE ENGINE. DEALER STATES NEW ENGINE IS REQUIRED ON A 9-YEAR OLD VEHICLE WITH LESS THEN 140,000. DEALER STATES CAM PHASERS ARE VERY COMMON PROBLEM IN THIS ENGINE (5.4L TRINITRON) . CALLS TO NUMEROUS OTHER LOCAL FORD DEALERS REVEAL NUMEROUS ENGINE REPAIRS DUE TO CAM PHASERS IN THE ENGINE INTERNET RESEARCH FIND NUMEROUS ISSUES WITH THE CAM PHASERS IN THIS ENGINE CAUSING COMPLETE ENGINE FAILURE. FORD REFUSES TO ACKNOWLEDGE THE PROBLEM. DEALER QUOTE TO REPLACE THE ENGINE ON A 9-YEAR OLD VEHICLE WAS $7150.00. *TR

THE VEHICLE BEGAN TO SMELL LIKE RAW FUEL, PARTICULARLY AT STOP SIGNS OR INTERSECTIONS. THE SMELL APPEARED TO BE COMING FROM THE ENGINE BAY. UPON DISASSEMBLY OF THE INTAKE COMPONENTS OF THE ENGINE TO EXPOSE THE FUEL INJECTION SYSTEM, IT WAS EVIDENT THAT THE FUEL RAIL HAD BEGUN LEAKING RAW FUEL INSIDE THE ENGINE BAY. THE FUEL RAIL DEVELOPED A SPECK OF CORROSION ABOUT 2-3MM IN DIAMETER ON THE TOP SURFACE OF THE RAIL. THE CORROSION EVIDENTLY PENETRATED THE ENTIRE RAIL AND BECAME A PINHOLE LEAK. RAW FUEL WAS SEEN LEAKING UP AND OUT OF THE PINHOLE. THIS HAPPENED ON THE PASSENGER SIDE FUEL RAIL, WHICH IS POSITIONED INCHES AWAY FROM THE HIGH VOLTAGE COIL PACK, AND ABOVE THE EXHAUST MANIFOLD AS WELL. CALLED FORD CUSTOMER SERVICE HOTLINE AND WAS TOLD THERE IS NO RECALL FOR IT, NO EXTENDED WARRANTY PROGRAM, NO ASSISTANCE WHATSOEVER. ORDERED A NEW FUEL RAIL THROUGH LOCAL FORD DEALER FOR $500 DOLLARS (4 TIMES WHAT A TYPICAL FUEL RAIL COSTS); PART HAS NOT BEEN SHIPPED, DEALER UNSURE IF FORD HAS ANY IN STOCK OR IS EVEN MAKING THE PART. TRUCK HAS BEEN INOPERABLE FOR OVER A WEEK WITH NO WAY TO FIX IT. *TR

THE NUMBER 3 SPARK PLUG BLEW LOOSE. THE FIRST TIME IT HAPPENED IT WAS JUST STARTED AND IDLING. IT GOT FIXED WITH A REPAIR KIT AND THEN IT HAPPENED AGAIN THE NEXT WEEK. IT WOULDN'T BE A HUGE CONCERN BUT THERE ARE MULTIPLE THINGS THAT COULD HAPPEN AND CAUSE SERIOUS INJURY AND OR A FATALITY. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE REVERSING, THE VEHICLE ACCELERATED INDEPENDENTLY AND CRASHED INTO THREE OTHER VEHICLES. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000.

TRUCK WENT INTO "LIMP" MODE ON START UP. VERY DIFFICULT TO GET HOME IN TRAFFIC. "FIX" WAS NEW THROTTLE BODY FROM FLECTHER FORD. $582.38. SEEMS TO BE AN ONGOING PROBLEM WITH FORD. *TR

AT 58,000 MILES ENGINE MALFUNCTION DUE TO A BROKEN VALVE SPRING. AT 101,879 MILE STARTED TO MAKE A LOUD RATTLING AT STARTUP AND SUBSIDED UNTIL THE ENGINE WAS WARMED UP. THIS CONTINUED UNTIL I REACHED 273,000 MILES AND THE ENGINE JUST STOPPED DUE TO OIL STARVATION AND CAM PHASER FAILURES. OIL WAS CHANGED AS REQUIRED THROUGH OUT OWNERSHIP. *TR

WHILE AT IDLE MY ENGINE STARTED TO TICK,SO I TOOK IT TO THE MECHANIC AND HE TOLD ME I HAD A BAD LASH ADJUSTER,AND IT WAS VERY COMMON FOR THIS TO HAPPEN WITH THE 5,4L 3VALVE ENGINE,SO I WENT ONLINE TO SEE IF I COULD FIND ANY INFO ABOUT MY ISSUE AND IT SEAMS THAT THOUSAND OF PEOPLE ARE HAVING THE SAME ISSUE,AND HOW FORD WILL NOT RECALL THE MOTORS FOR REPAIR OF A MAJOR DEFECT TO THAT TYPE OF ENGINE,THE MECHANIC TOLD ME TO DRIVE IT UNTIL IT DIES,BECAUSE THE COST WILL BE THE SAME TO REPAIR OR REPLACE THE ENGINE,POWERTRAIN.COM SELLS THE UPGRADED ENGINE WHICH CORRECTS THE THREE MAJOR ISSUES WITH THIS ENGINE,WHICH ARE,LASH ADJUSTERS,CAM PHASERS,AND THE SPARK PLUG TREADS STRIPPING OUT OF THE HEADS,WHY HAS FORD BEEN ABLE TO HIDE THIS FOR SO LONG. *TR

WHEN TAKING MY VEHICLE OUT FOR TEST DRIVE AFTER PUTTING NEW BRAKES ON. WHILE DRIVING AN SPARK PLUG BLEW OUT. WHILE CHECKING ONLINE I FOUND THAT THIS IS A MAJOR PROBLEM. I WAS VERY UPSET TO FIND OUT FROM THE DEALER THAT IT'S GONNA COST $585.70 TO FIX ONE SPARK PLUG AND REPLACE COIL. I ASKED ABOUT REPLACING ALL THE PLUG AND THEY QUOTED $900 TO DO ALL OF THEM. AS A RETIREE OF FORD I THINK THIS IS CRAZY. THEY TELL YOU IN THE MANUAL THAT THE PLUGS ARE GOOD FOR 100,000 MILES. THE MECHANIC SAID THERE IS NO GUARANTEE THAT THIS WON'T HAPPEN AGAIN EVEN IF WE REPLACED ALL THE PLUGS. I'M THINKING OF TRADING MY TRUCK OFF AND AM CONSIDERING ANOTHER BRAND. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE DRIVING 25 MPH, THE REAR PASSENGER SIDE SHOCK ABSORBER DETACHED FROM THE FRAME OF THE VEHICLE. THE DEALER STATED THAT THE ENTIRE FRAME WAS CORRODED AND NEEDED TO BE REPLACED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 13,000.

I HAD PROBLEMS STEERING MY CAR FOR THE LAST 3 WEEKS. I MADE AN APPOINTMENT AND THEY REPLACED THE SHAFT 8L3Z-3B676-B. THE SERVICE TECH SAID THE CROWN VICTORIA HAD THE SAME PROBLEM AND PART. HTTP://WWW.EDMUNDS.COM/CAR-NEWS/FORD-RECALLS-355000-VEHICLES-IN-US-FOR-POSSIBLE-STEERING-LOSS.HTML PLEASE DO SOMETHING, SO OTHER F150 OWNERS WILL BE WARNED, BEFORE THEY CRASH. THE REPAIR WAS OVER $400, BUT THAT MIGHT BE CHEAPER THAN CRASHING THE CAR. THANKS *TR

THE WINDOW REGULATOR LINKAGE CONTINUALLY BREAK. FIRST INCIDENT WAS THE DRIVER'S SIDE DOOR, AND ON 7/14/14, THE RIGHT REAR DOOR. BY THE NUMBER OF COMPLAINTS ON THE WEB, IT IS OBVIOUS THESE REGULATORS HAVE A MANUFACTURE DEFECT THAT CAUSES PREMATURE FAILURE. THE ONLY WINDOW FALL INTO THE DOOR WHEN THE DEVICE IS OPERATED. *TR

I WAS TRAVELING SOUTH COMING TO A INTERSECTION WHEN A VEHICLE TRAVELING NORTH AND DECIDED TO TURN AND HIT ME! HE WAS TRAVEL 50 MPH. THE DRIVER RECEIVED 2 TICKETS AT CRASH SITE ALSO 1 TICKET 3 MINUTE BEFORE CRASH. I ALMOST DROVE 1/3 INTO HIS CAR. NO AIR BAG WENT OFF IN MY VEHICLE. MY HIPS HAVE BEEN HURTING EVER SINCE CRASH. ALLSTATE FORCED ME TO SETTLE THEM. I BELIEVE IF AIRBAG WENT OFF MY HIPS WOULD BE FINE! X-RAYS SHOW THEM 1" OUT OF ALIMENT AND I NEED TO CONTINUALLY SEE A CHIROPRACTOR *TR

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE REAR DRIVER SIDE SHOCK ABSORBER MALFUNCTIONED. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE DEFECT WAS CAUSED BY A RUSTED SUB FRAME. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT BUT NO SOLUTION WAS OFFERED. THE FAILURE MILEAGE WAS 13,000.

THE VEHICLE IS A 2005 FORD F 150. SHOCK FELL OFF DOING 30 MILES MPH. TOOK TO MY BODY SHOP TO REPAIR. SAID I NEEDED TO GO TO DEALER. I BOUGHT IT BRAND NEW. DEALER WAS NO HELP HE SAID HE HAD NEVER SEEN A FRAME AS BAD AS MINE. WHEN I ASKED WHAT AND TO DO, HE TOLD ME TO DECIDE FOR MYSELF WHAT TO DO. THE FRAME AND SUSPENSION WERE SO BAD HE SAID THE VEHICLE WAS UNSAFE TO DRIVE. CONFIRMED BY ANOTHER FORD DEALERSHIP. I NOW HAVE A VEHICLE WHICH IS FORD'S SIGNATURE TRUCK WHICH MAY SIMPLY GO TO THE JUNK YARD. ALL SAID IT CAN NOT BE FIXED. I WOULD NEED A NEW FRAME FOR CA. 18000. NOT WORTH REPAIRING. CALLED FORD AND THEY SIMPLY SAID THERE WAS NOTHING THEY COULD DO. IT IS EVIDENT THE FRAME WAS DEFECTIVE WHEN ASSEMBLED. *TR

2005 FORD F-150. CONSUMER WRITES IN REGARDS TO ENGINE FAIL SAFE MODE MALFUNCTIONS CAUSES VEHICLE TO LOSE ALL POWER, BRAKES AND STEERING. CONSUMER HAS DIFFERENT VEHICLE COMPLAINT IN ARTEMIS. *SMD THE DEALER INVESTIGATED THE COMPLAINT, BUT WAS UNABLE TO IDENTIFY THE CAUSE. *JB

I STARTED THE TRUCK AND THE ALL THE INITIAL BEFORE ENGINE STARTS LIGHTS CAME ON, TACHOMETER WENT TO ZERO AND THERE WAS A WARNING BUZZER. I RAPPED THE TOP OF THE DASH AFTER TRYING THREE RESTARTS WHERE NOTHING CHANGED. THE TRUCK NORMALIZED AND I DROVE IT. I DO NOT OFTEN DRIVE THE TRUCK, SO ABOUT THREE WEEKS LATER I WAS HEADED TO PENNSYLVANIA AND WAS ABOUT TO ENTER THE HRBT TUNNEL WHEN THE INSTRUMENT CLUSTER WENT TO KEY ON STATUS (NO TACHOMETER OR SPEEDOMETER FUNCTION, MULTITUDE OF WARNING LIGHTS AND WARNING BUZZER). SO AT 55MPH I HIT THE TOP OF THE DASH AND THE INSTRUMENT CLUSTER BRIEFLY CAME BACK ON THEN SHUT OFF AGAIN. I REPEATED THE BLOW ON THE TOP OF THE DASH AND THE PROBLEM WENT AWAY FOR ABOUT FIVE HOURS AND THEN CAME BACK AGAIN. IT'S QUITE DISCONCERTING TO HAVE THE SPEEDOMETER SHUT DOWN WHILE DRIVING AND THE REST OF THE INSTRUMENT CLUSTER NOT FUNCTION. THIS CONTINUES TO HAPPEN AND FORD'S FIX IS FOR ME TO HAVE TO SPEND APPROXIMATELY $900.00 TO COMPLETELY REPLACE THE CLUSTER. *JS

5.4L TRUCK ALWAYS MAINTAINED AND SERVICED AT FORD DEALERSHIPS. IT WAS RUNNING PERFECT UNTIL IT IMMEDIATELY BEGAN IDLING ROUGH AT A STOP. NO CHECK ENGINE LIGHT, WE JUST KNOW OUR TRUCK. TOOK IT IN FOR A TUNE-UP (REPLACED SPARK PLUGS, ETC.) AND OIL CHANGE. PERFECT BILL OF HEALTH - COULDN'T REPLICATE PROBLEM. ENGINE CHECKED OUT DIAGNOSTICALLY- PERFECT. THEY SUGGESTED IT COULD BE AN INTERMITTENT STICKING FUEL INJECTOR, SO WE WERE GOING TO GET AN ADDITIVE TO ADD TO THE FUEL TANK. DIDN'T MAKE IT THAT FAR. DROVE IT HOME - 35 MILES - GOT HOME AND ENGINE STALLED IN DRIVEWAY. TURNED BACK ON, ENGINE DIED AGAIN. LONG STORY SHORT - TOWED IT BACK TO FORD - THEY WERE ABLE TO REPLICATE THE PROBLEM - OIL PRESSURE DROPS SUDDENLY (INTERMITTENTLY)- POINTING TO CAM PHASER, TIMING AREA OF ENGINE - END RESULT - NEED NEW ENGINE - THIS ONE IS SHOT AT ONLY 68K MILES - ESTIMATED COST $7,400 PLUS TAX. EXTENDED WARRANTY EXPIRED. DID SOME INTERNET RESEARCH, APPEARS TO BE A COMMON PROBLEM. THESE 5.4L ENGINES ARE BREAKING DOWN LEFT AND RIGHT IN THESE TRUCKS. DON'T KNOW WHAT CHANGED. HAD A 1999 EXPEDITION WITH A 5.4L - GREAT VEHICLE. CONTACTED FORD CUSTOMER CARE - WAS TOLD TO KEEP ALL RECEIPTS IN THE EVENT OF A RECALL. AN ENGINE SHOULD NOT BLOW AT 68K MILES, ESPECIALLY A BUILT FORD TOUGH ENGINE. WE'VE OWNED FORDS SINCE HIGH SCHOOL AND THEY USED TO BE RELIABLE, LONG DRIVING VEHICLES. *TR

I BOUGHT A 2005 FORD F 150 USED NOT KNOWING ABOUT THE ENGINE AND REAR END PROBLEMS UNTIL I HEARD THE RATTLE COMING FROM UNDER THE HOOD SO I GO ASK DEALER ABOUT THIS PROBLEM HE SAID THIS TYPE ENGINE WAS FROM FORD WAS NOT GOOD LUCKY FOR ME THEY WERE REPAIRING ONE IT HAD BLOWN A SPARK PLUG OUT AND THEY WERE REPLACE PARTS FOR THE CAM HE SAID GET RID OF THE TRUCK OR RUN IT TILL IT BLOWS UP IT HAS NO POWER IT STALLS IN THE MOST BAD PLACES I AM AFRAID I AM GOING TO HAVE A WRECK AND HURT SOME ONE FORD NEEDS TO RECALL THESE ENGINE AND FIX THE REAR END PROBLEM ALSO I DON'T HAVE 5 TO 8 GRAND TO FIX IT. *TR

ON 6/01/2014 I WAS DRIVING MY TRUCK WHEN I STARTED TO APPROACH AN INTERSECTION TO STOP AND WHEN I PRESSED THE BRAKE PEDAL TO STOP AND THE TRUCK THE BRAKES WOULD NOT ACTIVATE. THE BRAKE PEDAL WENT ALL AWAY TO THE FLOOR, THEN I REALIZED THAT EITHER I WOULD HAVE TO CRASH THE TRUCK INTO THE WALL OF THE BRIDGE AND POSSIBLY GO OVER OR CRASH THE TRUCK IN TO OTHER VEHICLES. HOWEVER THIS WAS A PANICKY SITUATION IN THE LAST SECOND BEFORE CRASHING THE TRUCK I APPLIED THE EMERGENCY BRAKES. AFTER TOWING THE TRUCK TO THE GARAGE I TOOK FEW PHOTOS OF THE FRONT BRAKE LINE HOSES AND HOW CLOSE THEY ARE TO THE TIRE RIMS. ONE OF THOSE BREAK LINES WERE DAMAGE BY RUBBING AGAINST THE TIRE RIM. OTHER BREAK LINES PHOTO IS SHOWING HOW CLOSE THE BREAK LINES ARE TO THE TIRE RIM. I AM VERY DISAPPOINTED THAT FORD WOULD INSTALL OR DESIGN THE HOLDING BRACKETS THAT COULD POSSIBLY MOVE CLOSE TO THE TIRE RIM FOR THE BRAKE HOSES THAT CLOSE TO THE TIRE RIM. ALSO I STOP OVER TO A FORD DEALER IN READING PA WHY THEY WOULD NOT ADDRESS THIS PROBLEM WHEN I HAVE THE TRUCK INSPECTED IN OCTOBER OF 2013. THE SUPERVISOR AT THE DESK HAVE NO ANSWER TO MY QUESTION. THEN I CHECK SIMILAR TRUCKS THE YEAR WAS 2008 AND THE BRAKE LINE WAS LESS THAN .250" FROM THE TIRE RIM. WHEN I CHECKED THE 2014 E150 IT LOOKS THAT THE BRAKE LINES LOCATION WERE REDESIGN. SO OBVIOUSLY SOMEBODY NEW ABOUT THIS PROBLEM HOWEVER I WAS NEVER NOTIFY ABOUT THIS PROBLEM, THE BRACKET THAT HOLD THE BRAKE LINES WERE NEVER ADJUSTED AWAY FROM BEING THAT CLOSE TO A TIRE RIM AT THE INSPECTION. I AM DISAPPOINTED THAT A GOVERNMENT AGENCY WOULD ALLOW THE BREAK HOSES TO BE INSTALLED ABOUT .250" FROM THE TIRE RIMS OR MOVING PARTS. I WOULD LIKE TO BE REIMBURSED FOR A TOWING AND THE REPAIR OF THE TRUCK. *TR

I HAD JUST CHANGED THE OIL AND CHECKED THE FLUIDS AND HAD TO RUN SOME ERRANDS UP TOWN ABOUT A MILE AND A HALF UP THE ROAD THE ENGINE STARTED MAKING A KNOCKING NOISE, I WAS CLOSE ENOUGH TO THE GARAGE I USE SO I PULLED IN THERE TO SEE WHAT WAS GOING ON THE OIL PAN WAS ON FIRE OIL AND WHAT LOOKED LIKE ANTI FREEZE WAS COMING OUT OF A HOLE FROM WHAT USE TO BE THE OIL PAN OR WHAT WAS LEFT OF THE PAN, THE FELLOW THAT RAN THE STATION TOLD ME IT HAD HYDRO LOCKED AND BENT A ROD AND PUSHED IT THRU THE OIL PAN, HE WENT ON TO SAY HE HAD SEEN SEVERAL OF THE 4.2 DO THIS AND IT LOOKED LIKE FORD WOULD HAVE DONE SOMETHING WHEN THEY WERE AWARE OF THE PROBLEMS WITH THE 4.2,I TALKED TO FORD ABOUT IT AND GOT THE RUN AROUND FROM THEM, JUST COULDN'T BELIEVE IT I HAD NEVER PULLED OR HAULED ANY HEAVY OBJECTS OR MISTREATED IT IN ANY WAY, DON'T UNDERSTAND WHEN THE POWERS THAT BE WERE AWARE OF THE PROBLEM WITH THIS ENGINE THE CONSUMER WAS LEFT HOLDING THE BAG TO A TUNE OF THOUSANDS OF DOLLARS IN REPAIRS, NOW GOT TO DO WITH OUT TO TRY AND SAVE THE MONEY TO GET IT FIXED, MOSTLY USED THE TRUCK TO GET MY WIFE BACK AND FORTH TO THE DR. SHE HAS M/S AND A HEART CONDITION, THE POOR ALWAYS CATCH IT IF THERE WAS ANYTHING TO FORD THEY WOULD MAKE IT GOOD AND THE SAME GOES FOR THE NHTSA THEY KNOW THE PROBLEM IS THERE JUST LOOK AT THE FORD FORMS, BUT GOD ALWAYS MAKES A WAY JUST HAVE TO WAIT AND SEE WHAT HIS PLAN ARE, ALOT OF FOLKS LIKE US HAVE NO FAMILY SO WE TAKE CARE OF OR TRUCKS, IT SURE WASN'T ABUSE THAT CAUSE THE PROBLEM. *TR

FORD FUEL PUMP DRIVER CORRODES BADLY CAUSING NO START AND/OR TOTAL FAILURE OF ENGINE POWER. REDUCTION OF POWER OR ENGINE STALLING CAN AND WILL HAPPEN AT HIGHWAY SPEEDS. WHEN ENGINE STALLS DRIVER CAN LOSE POWER STEERING POWER BRAKES AND CONTROL VEHICLE. THIS IS KNOWN BY FORD. FORD ALONG WITH A AFTERMAKET COMPANY HAS REDESIGNED THE PART. THE UPDATED PART HAS STANDOFFS ALONG WITH A PROTECTIVE COATING PREVENTING CORROSION. THE CORROSION OF THE PART HAPPENS FASTER IN THE SALT BELT STATES. I REPLACED MINE AND THE PART HAD A HOLE IN IT LETTING WATER AND PARTS OF METAL INSIDE UNIT. I STILL HAVE PART IF NEEDED. DO AN INTERNET SEARCH AND YOU WILL FIND ALLOT OF EXAMPLES OF THIS ISSUE. THIS ISSUE AFFECTS MILLIONS OF VEHICLES. *TR

BAD PERFORATION CORROSION AROUND WHEEL ARCHES. PAINT BLISTERING. *TR

THE 5.4L ENGINE INSTALLED IN THE FORD F150 HAS NOTHING BUT A BAD REPUTATION FOR COSTING CONSUMERS THOUSANDS AND NEVER BEING ABLE TO FULLY FIX THE ISSUE WITHOUT REPLACING THE ENTIRE ENGINE. THE VEHICLE CUTS OUT OF POWER, SHAKES VIGOROUSLY, MISFIRES AND IS DANGEROUS ON HIGHWAYS, HILLS, OR ANY ROADWAY FOR THAT MATTER. OUR PERSONAL EXPERIENCE ALMOST GOT US REAR ENDED BY A SEMI TRUCK WITH OUR CHILDREN IN THE VEHICLE BECAUSE WE COULD NOT GET IT TO MOVE WITHOUT LOSING POWER AND SHAKING AND JERKING! THERE HAVE BEEN SEVERAL THOUSAND COMPLAINTS FILED ON THIS ENGINE I'M SURE, JUDGING BY THE FORUMS, WEBSITES, CAR COMPLAINT SITES ETC. MEANWHILE, WE TOOK OUR TRUCK INTO A FORD DEALERSHIP AND WERE TOLD THAT THEY GET HUNDREDS OF PEOPLE WHO BRING THESE VEHICLES IN AND SPEND THOUSANDS TO REPLACE THE CAM PHASERS JUST TO HAVE THE SAME ISSUE THE NEXT MONTH! BY THE TIME YOU ARE ABLE TO FIX THE PROBLEM YOU'VE PUT OUT MORE MONEY THAN THE VEHICLE IS WORTH AT THAT POINT! GET THESE ENGINES RECALLED AND GET THEM OFF THE ROADS. THEY'RE UNSAFE FOR DRIVERS, FAMILIES AND OTHERS ON THE ROADWAYS! *TR

VEHICLE WENT INTO 'FAILSAFE MODE' AND STOPPED RUNNING WITH NO WARNING. MANUAL SAID THIS WOULD ALLOW THE VEHICLE TO PROCEED SAFELY HOME. DID NOT GET FAR BEFORE IT WOULD NOT RUN. WHEN IT DID RUN, IT RAN AT ABOUT 2 MPH BEFORE FAILING TO GO ANY FARTHER. LOOKING ON THE INTERNET, LOTS OF PEOPLE HAVE HAD THIS OCCUR WITH VARIOUS FORD VEHICLES. *TR

ENGINE CUT OUT WHILE DRIVING VEHICLE. WOULD NOT RESTART. BECAUSE I WAS STRANDED IN THE MIDDLE OF A BUSY ROAD, THERE WAS A 2 CAR REAR COLLISION THAT OCCURRED BEHIND ME. REPAIRS WERE $400.00 FOR ME NOT TO MENTION THE COST AND INJURY OF THE OTHER CARS INVOLVED IN THE ACCIDENT BEHIND ME. I HAVE SINCE LEARNED THAT THIS FUEL PUMP MODULE IS A COMMON PROBLEM IN THIS TRUCK DUE TO CORROSION PROBLEMS RESULTING FROM A POOR DESIGN. IT IS MY OPINION THAT THIS SHOULD BE A RECALLED ITEM. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHENEVER HE CAME TO STOP, THE GEARS WOULD ENGAGE INDEPENDENTLY AND MAKE A LOUD NOISE. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES WHERE THE TECHNICIAN DIAGNOSED THAT THE ALTERNATOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE CONTACT MENTIONED THAT HE HAD TO REPLACE THE ALTERNATOR A TOTAL OF FOUR TIMES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 175,000 AND THE CURRENT MILEAGE WAS 190,000.

AROUND MIDDAY WHILE DRIVING ON A CITY STREET, I HEARD A VIBRATION COMING FROM THE UNDERSIDE OF THE VEHICLE. I DROVE A FEW BLOCKS BACK TO MY OFFICE AND THE VEHICLE SAT UNTIL I LEFT TO GO HOME LATER THAT DAY. A FEW BLOCKS FROM MY OFFICE ALSO WHILE DRIVING ON A CITY STREET, I HEARD A LOUDER VIBRATION AND THIS TIME A METAL ON METAL CLANKING SOUND. I IMMEDIATELY PULLED OFF INTO A PARKING AREA AND LOOKED UNDER THE VEHICLE TO SEE THAT THE DRIVE SHAFT HAD FALLEN FROM ITS CENTER MOUNT. THE TWO PIECE DRIVE SHAFT CARRIER BEARING MOUNTING BRACKET HAD FAILED DUE TO CORROSION OF THE MOUNTING BRACKET CAUSING THE DRIVE SHAFT TO NO LONGER BE MOUNTED TO THE FRAME. FORTUNATELY, I WAS ON A CITY STREET DRIVING AND ONLY DRIVING APPROXIMATELY 20 MPH AND NOT AT HIGHWAY SPEED WHERE I COULD HAVE LOSS DRIVER CONTROL OF THE VEHICLE. LESS THAN A YEAR EARLIER, THE VEHICLE FAILED A STATE SAFETY INSPECTION DUE TO AN EXCESSIVELY CORRODED STEERING SHAFT U JOINT. THE MECHANIC SAID THIS U JOINT COULD FAIL DURING DRIVING CAUSING LOSS OF DRIVER CONTROL. EITHER OF THESE COMPONENT PART FAILURE COULD HAVE CAUSED LOSS OF VEHICLE CONTROL, AN ACCIDENT AND INJURY OR DEATH TO MYSELF, MY PASSENGERS OR OTHERS IN OTHER VEHICLES OR ON OR NEAR THE ROADWAY. I HAVE HAD MULTIPLE OTHER NON LIFE SAFETY MECHANICAL DEFECTS WITH THIS VEHICLE BUT MORE IMPORTANTLY, THIS CONDITION EXISTS WITH MANY OF THESE VEHICLES ON THE ROADS TODAY AND ANY OF THOSE DRIVERS COULD EXPERIENCE A FAILURE OF EITHER THE STEERING SHAFT OR THE DRIVE SHAFT AT ANY TIME AND BE THE CAUSE OF AN ACCIDENT. *TR

FIRST OFF I WANT TO SAY THAT I WORK FOR FORD AND I AM VERY DISAPPOINTED THAT THE FIRST OF THE TWO ISSUE I HAVE HASN'T BEEN RECALLED AND I'M NOT 100% SURE ABOUT THE DATES THAT THESE PROBLEMS OCCURRED ON. MY TRUCK HAS SOUNDED LIKE IT HAS A DIESEL ENGINE IN IT SINCE I BOUGHT IT BRAD NEW IN 2005 AND AFTER TALKING TO SOME GUYS AT WORK I FIND OUT THAT IT IS CAUSED BY CAM PHASERS THAT ARE IN THE 2004-07 5.4LITRE ENGINES AND IF THESE FAIL YOU HAVE TO GET A NEW MOTOR WHICH I WAS TOLD JUST A COUPLE OF MONTHS AGO WOULD BE $8900.00 WHICH IS ABSOLUTELY CRAZY. IF YOU LOOK THEM UP ONLINE YOU WILL SEE THAT THIS IS A HUGE AND COSTLY PROBLEM. MY SECOND ISSUE IS I HAVE HAD MY REAREND REBUILT TWICE SINCE I HAVE OWNED THIS VEHICLE. THE FIRST TIME WAS BEFORE IT WAS OUT OF IT 36,000 MILE FACTORY WARRANTY, THE SECOND TIME WAS BEFORE IT WAS OUT OF THE 100,000 EXTENDED WARRANTY THAT I PURCHASED SO LUCKILY THOSE TWO TIMES DID NOT COST ME ANYTHING BUT NOW IT NEEDS IT AGAIN AND THE MECHANIC TELL ME IT COULD COST $5000 SO WITH THE MOTOR ISSUE AND THE REAREND ISSUE I COULD POSSIBLY SPEND $14,000 IN REPAIRS WHICH AGAIN IS CRAZY WHEN YOU SPENT CLOSE TO $50,000.00 ON THE VEHICLE TO BEGIN WITH. *TR

THE STEERING WHEEL ON THIS 2005 IS EXTREMELY LOOSE AT THE TOP OF THE WHEEL AND FEELS VERY UNSECURED AS FAR AS IT BEING CONNECTED OR SECURED UNDERNEATH. IT IS ALSO DETERIORATING GREATLY IN THAT SAME AREA AT THE TOP OF THE WHEEL AND NEVER HAVE SEEN THIS BEFORE. THE REASON I AM SO CONCERNED ABOUT THE SAFETY OF ME AND ESPECIALLY MY FAMILY WHERE WE HAD A HEAD-ON COLLISION AND WERE VERY LUCKY TO BE ALIVE. MY WIFE HAS NEVER FULLY RECUPERATED FROM THAT HORRIBLE NIGHT. FOR HER TO DRIVE MY PICKUP AND FEEL UNSAFE BECAUSE OF A DEFECT THAT THE FORD MOTOR COMPANY OBVIOUSLY OVERLOOKED OR IS NEGLECTING IS UNTHINKABLE. I CANNOT EMPHASIZE THIS ENOUGH DUE TO A FRIEND OF MINE WHICH WAS KILLED IN ONE OF YOUR FORD EXPLORERS MANY YEARS AGO DUE TO DEFECTIVE TIRES FROM FIRESTONE. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE WINDOWS DROPPED INSIDE OF THE DOOR PANEL WHILE BEING OPENED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE REGULATORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 114,000. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE IDLING AT A LIGHT, HE HEARD A KNOCKING NOISE FROM THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE CAM PHASERS AND LIFTERS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000. THE VIN WAS UNAVAILABLE.

LOSS OF STEERING BECAUSE OF A LEAK IN HYDRAULIC HOSES. HOSE ROTTED OUT REPLACED HOSE AND RACK. HAPPENED AGAIN 11/23/13 SAME CONDITIONED BUT PARTS HAVE NOT BEEN AVAILABLE AS OF THIS DATE. *TR

DASH ELECTRICAL RELAY ISSUE,PAINT PEELING TAILGATE,TRANSMISSION SHUTTER GOING INTO OVERDRIVE 45 MPH. *TR

I PURCHASES A USED 2005 FORD F150 ABOUT 5 MONTHS AGO. TODAY, FEB 28, 2014, I WAS LEAVING MY NEIGHBORHOOD AND MY TRUCKS DISPLAY FLASHED AN MESSAGE READING "ENGINE FAILSAFE MODE". MY TRUCK LOST ALL POWER, NO STEERING AND DIED. LUCKILY I WAS ON SURFACE STREETS AND PULLED IT OVER WITH NO POWER STEERING AND ENGINE DEAD. THE MECHANICS CANNOT FIND THE CAUSE AND THE ENGINE WILL START BUT CONTINUES TO TURN OFF AND THE VEHICLE'S COMPUTER SHUTS DOWN. ONLINE I READ OF THIS HAPPENING ON THE FREEWAY AT 65 MPH. IAM NOW TERRIFIED THAT MY TRUCK WILL SHUT OFF ON THE FREEWAY WITH MY CHILDREN IN THE TRUCK WITH ME. THIS SEEMS TO BE A LIFE THREATENING PROBLEM. I CALLED A FORD DEALERSHIP AND THE SERVICE DEPT CLAIMED THEY NEVER HEARD OF THIS BUT CAN WORK ON IT IF I BRING IT IN. WHAT IS MY RECOURSE? THANK YOU. *TR

WHILE DRIVING HOME TRUCK SHUT OFF ENGINE FAIL SAFE MODE INDICATOR CAME ON ENGINE SHUT OFF ALL FUNCTIONS,BRAKES POWER STEERING. *TR

I HAD JUST ROLLED UP THE WINDOWS ON MY TRUCK, WHEN I HEARD A LOUD POP COME FROM THE PASSENGER DOOR. ABOUT 15 MINUTES LATER THE WINDOW DROPPED DOWN INTO THE DOOR. THIS HAPPENED ABOUT 4 YEARS AGO. THIS IS TWICE IN THE 8 YEARS I HAVE HAD THE TRUCK. NEEDS TO BE A RECALL ON THIS SINCE SEEMS TO BE HAPPENING TO A LOT OF PEOPLE. *TR

TL- THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD TO RESTART IT. ONCE RESTARTED, THE VEHICLE FUNCTIONED PROPERLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION BUT THEY COULD NOT DETERMINE THE CAUSE OF FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT WAS UNABLE TO PROVIDE A REMEDY. THE FAILURE MILEAGE WAS 88,000. AP

TRUCK STARTED STALLING IN TRAFFIC & INTERSECTIONS. HAD TO CONTINUE TO RESTART. FINALLY MADE IT HOME. THEN TOOK IT IN FOR REPAIR. REMOVE & REPLACE FUEL PUMP CONTROL MODULE (PART WAS SEVERELY CORRODED) TECHNICIAN WAS SURPRISED THAT THE TRUCK EVEN RAN. FORD PICK A POOR LOCATION FOR SUCH AN IMPORTANT PART OF THE FUEL DELIVERY SYSTEM. SHOULD HAVE BEEN A RECALL ITEM. REPAIR COST ME $413.08. *TR

I WAS DRIVING TO TOWN WHEN ENGINE STARTED MAKING A SOUND LIKE A LARGE COMPRESSOR, STOPPED TRUCK, COULD FEEL AIR COMING FROM THE TOP OF THE HEAD BY INTAKE MANIFOLD, TOOK TO A GARAGE WHERE I WAS INFORMED THAT THE PLUG CAME OUT OF THE #2 CYLINDER AND BUSTED THE COIL PAK. I KNOW THIS HAS HAPPENED TO MANY F150 TRUCK OWNERS, I KNOW OF 3 LOCALLY, AND HAVE FOUND MANY MORE COMPLAINTS WITH THE SAME PROBLEM. FORD SHOULD RECALL, THIS PROBLEM. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE GEAR SHIFTER COULD NOT BE REMOVED FROM PARK UNTIL AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THE SHIFT LOCK SOLENOID, BRAKE SWITCH AND BRAKE MODULE WERE REPLACED HOWEVER, THE FAILURE CONTINUED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 200.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE SEAT BELT FAILED TO BUCKLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 88,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WOULD SOUND AS IF IT WAS EQUIPPED WITH A DIESEL ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE SPARK PLUGS, COILS, PULLEY AND SERPENTINE BELT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE REMEDY FAILED TO CORRECT THE FAILURE. THE DEALER THEN STATED THAT THE CAMSHAFT PHASER WAS DEFECTIVE AND AS A RESULT, THE ENGINE WOULD POSSIBLY NEED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 120,000. UPDATED 02/11/14*LJ

TRUCK WOULD NOT START AFTER IT WAS PARKED. AFTER SEVERAL TRIES IT STARTED LONG ENOUGH TO DRIVER TO A LOCAL MECHANIC. MECHANIC FOUND A FUEL INJECTOR WAS STUCK OPEN POURING GAS INTO THE CYLINDER AND OIL. VEHICLE TOWED TO FORD DEALER FOR REPAIR. DEALER FOUND A FUEL INJECTOR WAS STUCK OPEN POURING GAS INTO THE CYLINDER AND OIL AND A BENT ROD, THEIR RECOMMENDATION IS A NEW ENGINE. FORD HAD ISSUED A CUSTOMER SATISFACTION PROGRAM 07M08 TO COVER THE FUEL INJECTORS TO 11 YEARS OR 120,000 MILES BUT SINCE I WAS AT ALMOST 9 YEARS AND 134,000 MILES FORD NO LONGER CLAIMS NO RESPONSIBILITY FOR THE COST OF REPAIR OF A KNOWN AND PUBLISHED PROBLEM OR TO ITS CUSTOMER. SOME SATISFACTION PROGRAM. *TR

I WAS PULLING OUT INTO TRAFFIC WHEN THE ENGINE WOULDN'T RESPOND. LUCKILY IT WASN'T ON A HIGHWAY THE ON COMING TRAFFIC HAD ENOUGH TIME TO AVOID ME. THERE WAS NO WARNING I THOUGHT THE TRUCK HAD DIED AND WENT TO RESTART BUT THE ENGINE WAS IDLING. I THEN PUT THE TRUCK INTO LOW TRANSFER AND WAS ABLE TO MOVE TO A SAFE PLACE BY IDLING UNTIL A TOW TRUCK COULD REMOVE IT. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS A LOUD KNOCKING SOUND COMING FROM THE MOTOR. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 215,000. UPDATED 1/14/14*CN

HIT A TREE FULL FORCE DAMAGING THE FRONT OF THE TRUCK, SEAT BELT WAS BUCKLED AND AIR BAG DID NOT DEPLOY. *TR

AFTER THE TRUCK PASSED 76000 I STARTED TO NOTICE A TICK/KNOCK IN THE ENGINE. I BROUGHT IT TO FORD AND THEY TOLD ME THIS WAS NORMAL NOISE FOR THESE ENGINES, TO ME THIS WAS NO NORMAL. NOW THE TICK/KNOCK/RATTLE HAS BECOME WORSE AND I HAVE BEEN TOLD BY FORD I WOULD NEED A NEW ENGINE. THIS IS A VERY VERY COMMON SITUATION WITH THE 2004-2008 5.4L 3V ENGINES. WHAT US FORD OWNERS WOULD LIKE IS A RECALL ON THE CAM PHASERS AND VCT SOLENOIDS. FORD HAS REDESIGNED BOTH OF THESE PARTS SO THEY KNOW THIS WAS CAUSING BIG ISSUES WITH OWNERS OF THE MENTIONED MAKE/MODEL/YEAR FORDS. I DO NOT KNOW HOW A COMPANY, AN AMERICAN COMPANY, CAN GET AWAY WITH SELLING VEHICLES WHERE THE INTERNAL PARTS OF THE ENGINE, AND AMERICAN MADE ENGINE, GO FAULTY BEFORE THE ODOMETER HIT'S 100,000 MILES. THERE ARE NORMAL WEAR AND TEAR REPLACEABLE PARTS ON EVERY CAR, BUT WHEN INTERNAL ENGINE COMPONENTS FAIL WITH A VEHICLE THAT IS JUST 7 YEARS OLD THAT IS NOT ACCEPTABLE! *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, THE ACCELERATOR PEDAL BECAME STUCK TO THE BOTTOM OF THE FLOORBOARD AND THERE WAS A SUDDEN ACCELERATION FAILURE. THE CONTACT MENTIONED THAT THE BRAKES WERE DEPRESSED BUT FAILED TO STOP THE VEHICLE. THE VEHICLE CRASHED INTO A BOULDER IN A RIVER. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR A DIAGNOSTIC TEST. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 86,000.

THIS WOULD BE THE SECOND TIME A SPARK PLUG HAS POPPED OUT OF THE ENGINE ON MY 2005 FORD F-150 WITH THE 4.6 LITER V8 ENGINE IT. THE FIRST SPARK PLUG POPPED OUT IN AUGUST 2011 AND NOW IT HAS HAPPENED AGAIN IN SEPTEMBER 2013. I HAVE HEARD THAT I AM NOT THE ONLY PERSON THIS IS HAPPENED TO. THIS SEEMS TO BE A RECURRING PROBLEM IN NOT ONLY THE 4.6 LITER V-8 BUT THE 5.4 LITER V-8 AND THE 6.8 LITER V-10. WITH THIS PROBLEM HAPPENING OVER AND OVER AGAIN WHY HASN'T FORD DONE ANYTHING ABOUT IT. FORDPROBLEMS.COM SUGGESTS THAT FORD INSISTS THE PROBLEM IS DUE TO IMPROPER TORQUING OF NEW PLUGS OR ANY NUMBER OF OTHER REASONS. HOWEVER MANY PEOPLE HAVE HAD THE ORIGINAL FACTORY SPARK PLUGS EJECT FROM THE ENGINE, WHICH INDICATES THERE IS A DEFECT WITH THE ENGINE & CYLINDER HEAD DESIGN. THE REPAIR IS RELATIVELY EASY - DO NOT BE FOOLED BY A DEALER OFFERING TO REPAIR THE ISSUE FOR $700 OR MORE. AN INEXPENSIVE HELICOIL KIT WILL DO THE TRICK. ALSO, WE DO NOT RECOMMEND SIMPLY RE-TAPPING THE SPARK PLUG THREADS BECAUSE THE THREADS ARE PROBABLY TOO DAMAGED ALREADY & THE SPARK PLUG MAY JUST BLOW OUT AGAIN CAUSING MORE DAMAGE. SPARK PLUG EJECTION IS DANGEROUS BECAUSE FUEL VAPOR STARTS COMING OUT THE SPARK PLUG HOLE, WHICH IS CLEARLY A SERIOUS SAFETY ISSUE. THE FUEL VAPOR CAN BE IGNITED BY THE LOOSE SPARK PLUG AND IN FACT THERE HAVE BEEN A SMALL NUMBER OF CASES REPORTED OF ENGINE FIRES DUE TO SPARK PLUG EJECTION/BLOWOUT. I AS WELL AS OTHER FORD OWNERS WOULD LIKE THE NHTSA TO LOOK INTO AND FORCE A RECALL ORDER TO FORD MOTOR COMPANY TO GET THESE ISSUE FIXED, REPAIR, AND REMEMBERS ALL AFFECTED BY THIS ISSUE. *TR

WHEN I PULLED OUT OF PARKING LOT AT APPROX. 5 MPH I HEARD A VERY LOUD NOISE IN THE REAR OF THE TRUCK. SOUNDED LIKE SOMETHING HIT MY VEHICLES BACK DOOR. WHEN I LOOKED BACK ALL LOOKED NORMAL. A FEW MINUTES LATER I HEARD AIR BLOWING. LIKE A WINDOW WAS DOWN. REAR WINDOW HAD STARTED TO SLOWLY SLIDE DOWN. MECHANIC INFORMED ME THE WINDOW REGULATOR HAD FAILED. 203.00 JUST FOR THE PART !!!! AND HE SAID MORE WILL BREAK TOO. NICE JOB FORD. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, ALL OF THE GAUGES AND LIGHTS ON THE INSTRUMENT PANEL BEGAN TO MALFUNCTION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 83,490.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE FRONT DRIVER'S SIDE WINDOW FELL INTO THE DOOR PANEL. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE WINDOW REGULATOR WOULD NEED TO BE REPLACED. THE CONTACT STATED THAT THE FAILURE HAD OCCURRED TWO YEARS PRIOR ON THE FRONT PASSENGER'S SIDE WINDOW. THE VEHICLE HAD BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 40,491.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE IT WAS STATED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 107,000.

I TOOK MY VEHICLE IN FOR A SERVICE ENGINE LIGHT ISSUE. I WAS TOLD I NEED NEW SPARK PLUGS. THE ISSUE IS HUNDREDS OF 2004 -2008 FORD F-150 5.4 LITER ENGINE HAVE FAULTY SPARK PLUGS THAT BREAK OFF IN THE HEAD CREATING ADDITIONAL EXPENSE. THE PRICES ARE BETWEEN 500- 1000 TO CHANGE OUT SPARK PLUGS. THE FAULTY DESIGN OF THE PLUGS CREATED THIS ISSUE AND FORD HAD NOT ADDRESSED THIS PROBLEM. PLEASE, RESEARCH THIS ISSUE AND HELP CONSUMERS WITH THIS PROBLEM. LISLE DESIGNED A TOOL TO EXTRACT THE BROKEN PLUGS MODEL # 65600 IT IS FOR THE YEARS 2004-2008 FORD 5.4 LITER ENGINES. MANY DEALERS ARE AWARE OF THIS PROBLEM AND JUST CHARGE ADDITIONAL MONIES TO THE CUSTOMER BECAUSE OF FAULITY PART DESIGN. PLEASE, HELP. *TR

WHEN YOU ACCELERATE AT 40 TO 50MPH THE ENGINE STRUGGLES TO PICK UP SPEED LIKE IT IS NOT GETTING FUEL. IT HAS ALSO STALLED SEVERAL TIMES AT VARIOUS SPEEDS CAUSING ME TO PUT IT IN NEUTRAL WHILE STILL ROLLING,OR COME TO A STOP, TURN THE KEY COMPLETELY OFF AND THEN RESTART.TOOK THE VEHICLE TO THE FORD DEALER AND TO BE TOLD IT WAS THE CAM PHASERS WHICH WILL COST ABOUT $2,900.00 TO FIX WERE THE PROBLEM. HE ALSO SAID THE WORST DECISION FORD EVER MADE WAS USING THE 5.4 TRITON V8 FROM 2005-2008. YOU WOULD THINK IF A MANAGER OF A FORD MECHANIC SHOP TELLS YOU THIS, I AM NOT THE ONLY ONE HAVING THIS PROBLEM. IT ALSO HAS A CONSTANT TICKING NOISE IN THE ENGINE WHICH I WAS TOLD IS THE TENSIONER FOR THE TIMING CHAIN. THE TRUCK CURRENTLY HAS 138,000 MILES. *TR

OK SO WE BOUGHT A FORD F150 2005 ON FRIDAY OF LAST WEEK WHICH WOULD BE 08/09/2013 . THE MAN ASSURED US THIS WAS A SAFE AND RELIABLE VEHICLE. SO WE START OUR TRIP ACROSS THE COUNTRY TO LOOK AT A NEW HOUSE IN EASTERN NORTH CAROLINA. WE STOPPED IN ARIZONA TO SEE MY GIRLFRIENDS MOM. SUR ENOUGH THE TRUCK WOULD NOT START THE NEXT DAY. WE TAKE IT TO A MECHANIC AND HE SAYS ITS THE FUEL PUMP SO HE CHANGES IT OUT WE DRIVE IT 2 BLOCKS DOWN THE STREET BACK TO HER PARENTS HOUSE TURN OFF THE TRUCK LOAD IT UP WITH OUR STUFF AND IT WILL NOT START AGAIN. SO THE MECHANIC COMES BACK OVER SAYS OK IT MUST BE THE FUEL MODULATOR. SO HE CHANGES OUT THE FUEL MODULATOR AND SURE ENOUGH IT WORKED WE DROVE IT TWO BLOCKS TURNED IT OFF, RELOADED THE TRUCK AGAIN. AGAIN IT WOULD NOT START BACK UP, APPARENTLY THE NEW MODULATOR KILLED THE BRAND NEW FUEL PUMP WE JUST PAID $500 FOR SO NOW WE HAVE TO GET ANOTHER FUEL PUMP AS WELL. I AM NOT HAPPY AFTER DOING RESEARCH THERE IS THOUSANDS OF PEOPLE HAVING THE SAME PROBLEM AND IF ANYTHING LIKE US WE NOW HAVE PAID NEARLY $1000 TO FIX A PROBLEM THAT COULD EASILY BE CHANGED BY FORD MOUNTING THE FUEL MODULATE UNDER THE HOOD NEAR THE ENGINE LIKE THE REST OF THE MODULATORS. WOULD YOU PLEASE LOOK INTO THIS AS SOON AS YOU CAN THIS IS SO UNCALLED FOR A LOT OF US WORK TO HARD FOR OUR MONEY AND OUR VEHICLES TO HAVE THEM BREAK DOWN WITH THE SAME PROBLEM EVERY TIME WE STOP. INCLUDED IS A LINK TO VIDEO WHERE THE GUY EXPLAINS THE PROBLEM AND ALL THE PEOPLE WHO HAVE HAD THE PROBLEM AS WELL. HTTP://WWW.YOUTUBE.COM/WATCH?V=_2E9KMF1_KG. *TR

WHEN DRIVING DOWN THE ROAD A 35 MPH MY DRIVER SIDE WINDOW MADE A LOUD POP SOUND AND THE WINDOW FELL DOWN INTO THE DOOR. I HAD TO BUY A WHOLE NEW WINDOW REGULATOR ASSEMBLY. I HAVE SEEN THIS TO BE A PROBLEM ON THIS SITE AND MANY OTHER ONLINE FORUMS. THERE MUST BE A DEFECT WITH THE REGULATORS. MINE WAS SO BAD THAT THE CABLE ACTUALLY FRAYED AND SNAPPED. THIS IS A SAFETY HAZARD THAT SHOULD BE ADDRESSED. *TR

AFTER WASHING AND WAXING MY TRUCK I NOTICED THAT ON BOTH OF THE BACK FENDERS THE PAINT IS STARTING TO BUBBLE UP AND THERE APPEARS TO BE RUST COMING OUT OF THE BUBBLES. I HAVE SEEN OTHERS ONLINE THAT ARE HAVING THIS SAME PROBLEM AND FORD KNOWS ABOUT IT CHECK THE LINK HTTP://WWW.LEMONLAW.COM/WORDPRESS/MORE-PROBLEMS-FOR-FORD-PAINT-DEFECTS-IN-2000-2005-MODELS/ CAR AND TRUCK COMPANIES SHOULD BE HELD RESPONSIBLE FOR THEIR MISTAKES. *TR

FAILURE OF THE LOWER STEERING SHAFT CAUSES VEHICLE TO RESTRICT CORRECTING ITSELF AFTER A TURN. DRIVER HAS TO PHYSICALLY STRUGGLE TO STRAIGHTEN THE VEHICLE AFTER TURNING. *TR

TURNED TO GO AROUND CORNER STEERING WHEEL WOULD NOT TURN BACK. ENDED UP ON SIDEWALK. VERY HARD TIME TO TURN STEERING WHEEL BACK. MY MECHANIC IT WAS POOR DESIGN OF THE LOWER STEERING SHAFT. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 20 MPH AND DECELERATING, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DETERMINED THAT THE ENGINE HAD FAILED. THE TIMING CHAIN, AND OIL PUMP WERE REPLACED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 175,412. UPDATED 12/23/13*LJ

FRONT PASSENGER WINDOW FELL TO BOTTOM OF DOOR. *TRW

REAR PASSENGER WINDOW REGULATOR STOPPED WORKING AND WINDOW FELL INTO DOOR. HAD MY WIFE DONE THIS WHILE DRIVING SHE WOULD HAVE BEEN SCARED BY THE LOUD POPPING NOISE AND POTENTIALLY CRASHED INTO OBJECT INJURING HERSELF AND OR OTHERS. THIS IS A COMMON PROBLEM AND FORD NEEDS TO RECALL THE TRUCKS WITH THE PLASTIC PARTS AND FAULTY MECHANISM. SEARCH THE WEB AND THERE ARE HUNDREDS OF VEHICLES WITH THE SAME ISSUE . YEARS 2004-2006. FORD NEEDS TO RECALL! *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH AND DEPRESSING THE BRAKE PEDAL, THE VEHICLE STALLED. THE CONTACT STATED THAT HE REPLACED THE BATTERY PRIOR TO THE FAILURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 77,000. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE STEERING WHEEL FAILED AND SEIZED WITHOUT WARNING. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 85,000. *TR

WE HAD JUST LEFT OUR HOUSE AND THE DRIVER SIDE WINDOW FELL DOWN INTO THE DOOR AND WOULD NOT COME BACK UP. I LOOKED ON THE INTERNET AND YOUTUBE TO FIND OUT THIS HAS HAPPENED TO 100'S OF THE F150'S. THIS IS VERY DANGEROUS BECAUSE EVIDENTLY IT CAN HAPPEN TO ANY OF THE WINDOWS ON THE TRUCK. ONE OF MY GRANDCHILDREN COULD HAVE BEEN RIDING WITH US AND POSSIBLE FALL OUT A WINDOW. I UNDERSTAND THERE IS NO RECALL FOR THIS. I EMAILED FORD ABOUT THIS BUT IT STATED THE MIGHT NOT EVEN ACKNOWLEDGE IT. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE VEHICLE BEGAN TO DECELERATE IN A JERKING MOTION. THERE WAS NO PRIOR WARNING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THE TECHNICIAN INFORMED THE CONTACT THAT ONE SPARK PLUG FRACTURED. AN APPOINTMENT WAS SCHEDULED FOR THE VEHICLE TO BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 128,542.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE SHIFTING INTO REVERSE, THE DRIVER FRONTAL AIR BAG DEPLOYED ERRONEOUSLY. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN AND THE VIN WAS NOT AVAILABLE. *TR

I BOUGHT MY FORD-F 150 DIRECTLY FROM THE FORD DEALERSHIP BRAND NEW WITH ONLY 30 MILES IN AUGUST 2005. BY NOVEMBER 2005, WE BROUGHT IT IN TO THE DEALERSHIP WITH CONCERNS OF THE TRANNY SLIPPING. THE DEALERSHIP COULD NOT FIND THE PROBLEM, AND WE WENT HOME. WITH-IN 1 YR. WE HAD TO REPLACE THE POWER WINDOWS, AND WITH-IN 2 YRS, THE TRANSMISSION WENT OUT COMPLETELY. LUCKILY IT WAS UNDER WARRANTY, AND WAS REPLACED. WE HAVE REPLACED EVERY PIECE IN THAT TRUCK AT LEAST ONCE AND SOME SEVERAL TIMES. AND THE TRANSMISSION TWICE. LAST MONTH THE TRANSMISSION WENT OUT AGAIN. WE PAID $2700. TO ONLY BRING IT HOME, AND IMMEDIATELY IT WENT OUT AGAIN. THE MECHANIC IS BAFFLED. HE HAS BEEN TRYING FOR 4 WEEKS TO FIX IT, AND HAS NOW THROWN IN THE TOWEL. HERE I HAVE A GORGEOUS TRUCK, WITH A HUGE PAYMENT, AND IT'S A PIECE OF JUNK. WE HAVE MAINTAINED EVERYTHING SO PRECISELY, NEVER TOWED, NEVER LONG TRIPS, AND HAVE HAD ALL THE UP KEEP NEEDED FOR THIS TRUCK TO LAST, SO OUR SON COULD TAKE OVER WHEN HE IS OF AGE. I DON'T KNOW WHAT TO DO! *TR

WHILE APPROACHING A STOP DURING A HEAVY RAIN SHOWER I BROUGHT THE VEHICLE TO A COMPLETE STOP ABOUT 10 FEET FROM THE VEHICLE IN FRONT OF ME. SUDDENLY, THE VEHICLE ACCELERATED FORWARD. I PRESSED HARDER ON THE BRAKE AND THE VEHICLE JERKED AND SHUDDERED VIOLENTLY. MY FIRST THOUGHT WAS THAT I WAS STRUCK FROM BEHIND BY ANOTHER VEHICLE. I WAS ISSUED A VIOLATION FROM LOUISIANA STATE POLICE FOR FOLLOWING TOO CLOSELY. MY BELIEF IS THAT THE SHUDDERING WAS THE EFFECT OF THE ANTI LOCK BRAKES ACTIVATING. THE DAMAGE TO BOTH VEHICLES WAS RELATIVELY MINOR. THE VEHICLE WAS CHECKED FOR A DEFECT BUT NONE COULD BE FOUND.

DURING A RECENT REQUIRED NYS INSPECTION, PLAY WAS FOUND IN THE LOWER U JOINT OF THE STEERING SHAFT. I WAS TOLD BY THE MECHANIC DOING THE INSPECTION THAT THE JOINT HAD SO MUCH PLAY IN IT THAT IT COULD BREAK CAUSING LOSS OF STEERING AND VEHICLE CONTROL. THE ENTIRE SHAFT WAS REPLACED. THE FORD DEALERSHIP WHERE THE VEHICLE WAS PURCHASED SAID TO MY AMAZEMENT, IT WAS POSSIBLY CAUSED BY THE VEHICLE HAVING TOO FEW MILES ON IT. *TR ## VIN FAILED ##

CONSTANT TICKING NOISE FROM ENGINE, SOUNDS LIKE A DIESEL ENGINE, REMAINS TICKING THE ENTIRE TIME./ WHEN APPLYING BRAKES EITHER ON A HARD STOP OR ROLLING OVER TRACTION IN ROAD, GRINDING FEELING IN PEDAL AND NOISE AND WILL NOT STOP IMMEDIATELY.-----WAS TOLD BY DEALERSHIP THAT THE "TICKING" WAS TYPICAL FOR FORD AND THE BRAKES WAS PART OF THE ANTILOCK SYSTEM, I DO NOT THINK SO. *TR

REAR PASSENGER WINDOW REGULATOR STOPPED WORKING AND WINDOW FELL INTO DOOR. HAD MY DAUGHTER DONE THIS WHILE DRIVING SHE WOULD HAVE BEEN SCARED BY THE LOUD POPPING NOISE AND POTENTIALLY CRASHED INTO OBJECT INJURING HERSELF AND OR OTHERS. THIS IS A COMMON PROBLEM AND FORD NEEDS TO RECALL THE TRUCKS WITH THE PLASTIC PARTS AND FALTY MECHANISM. SEARCH THE WEB AND THERE ARE HUNDREDS OF VEHICLES WITH THE SAME ISSUE . YEARS 2004-2006. FORD NEEDS TO RECALL!! *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT WAS DRIVING 25 MPH AND ATTEMPTING A TURN WHEN THE STEERING WHEEL SEIZED AND COULD NOT BE MOVED IN ANY DIRECTION. THE CONTACT APPLIED FORCE TO THE STEERING WHEEL IN ORDER TO CONTINUE DRIVING. THE FAILURE RECURRED SPORADICALLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE STEERING SHAFT U-JOINT WAS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

WHILE DRIVING AT POSTED SPEED LIMIT THE ENGINE QUIT RUNNING, AS IF THE KEY HAD BEEN TURNED OFF. THIS STOPPED ALL CONTROL OF THE POWER STEERING AND HYDRAULIC BRAKE CONTROL. TRAFFIC BEHIND ME WAS FORCED TO STOP QUICKLY AND AVOID ME. WHILE TRYING TO PULL OVER I ALMOST WENT INTO THE DITCH BECAUSE OF LACK OF STEERING CONTROL. WHEN I TOOK THE VEHICLE TO THE FORD DEALER THE SERVICE MGR SAID THIS WAS A COMMON PROBLEM WHERE THE FUEL PUMP DRIVER MODULE CORRODES AND CAUSES PROBLEMS BUT THAT THERE WAS NO RECALL ON IT. IF I HAD NOT BEEN AN EXPERIENCED DRIVER THIS COULD HAVE CAUSED A HORRIBLE ACCIDENT. *TR

DRIVING HOME AND SUDDENLY THERE WAS A LOUD BANG. I THOUGHT SOMEONE SHOT OUT MY WINDOW. AFTER ARRIVING HOME I LOOKED AT IT AND REALIZED THAT THE GLASS HAD DROPPED DOWN INTO THE DOOR. I TOOK IT TO THE DEALER AND PAID $350 FOR THE REPAIR. THESE WINDOW REGULATORS NEED TO BE RECALLED OR BANNED!!!!!!!!!!!!!!!!! *TR

GOODYEAR TIREWALL RUBBER PEELING, EXPOSING INNER LAYERS. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE ENGINE RPMS INCREASED AND THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 76,000. *TR

ON AUGUST 3, 2012 THE PASSENGER WINDOW DROPPED AND THE REGULATOR ASSEMBLY HAD TO BE REPLACED. YESTERDAY, MARCH 2, 2013 THE DRIVER SIDE WINDOW WOULD NOT GO UP. THE REGULATOR WITH MOTOR HAD TO BE REPLACED. I THINK FORD NEEDS TO RECALL THEIR VEHICLES, AND REPLACE THEIR DEFECTIVE PARTS. *TR

WHEN VEHICLE'S ENGINE IS COLD, AND APPROXIMATELY 8 MINUTES INTO DRIVING, VEHICLE WILL CUT OFF WHILE IN MOTION & WRENCH LIGHT COMES ON. VEHICLE THEN HAS TO BE GUIDED TO A STOP WITH NO POWER OR CAN BE SHIFTED INTO NEUTRAL & RESTARTED WHILE STILL MOVING. FOLLOWING VEHICLE RESTART ENGINE LIGHT IS ON. CODE INDICATES TRUCK HAS BEEN PLACED IN "LIMP HOME MODE". AFTER ABOUT 2 WEEKS, ENGINE LIGHT GOES OFF. I WAS ADVISED TO REPLACE THE THROTTLE BODY IN FEB. 2010, HOWEVER THE THROTTLE BODY HAD JUST BEEN REPLACED IN APRIL 2007 WHEN THE VEHICLE WAS ONLY 2 YEARS OLD. *TR

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT HE HEARD A TICKING SOUND FROM THE ENGINE THAT CAUSED THE VEHICLE TO EXHIBIT AN ABNORMAL SOUND, SIMILAR TO BREWING COFFEE. THE CONTACT PERFORMED ONLINE RESEARCH AND DETERMINED THAT THE FAILURE WAS CAUSED BY THE CAM PHASERS. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 34,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THE FUEL PUMP DRIVER MODULE WAS CORRODED. THE CONTACT REPLACED THE FUEL PUMP DRIVER MODULE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 69,950.

2005FORD F-150 4.6 TRITON V8 SPARK PLUG EJECTED BLOWING OUT COIL WHILE DRIVING. THIS RESULTING IN A STRIPPED HEAD AND NEEDING TO REPLACE THE ENGINE. WITH RESEARCH ON THE WEB SEEMS THIS IS A COMMON PROBLEM WITH THIS MODEL ENGINE WITH MANY COMPLAINTS THAT FORD WILL NOT ACKNOWLEDGE. *TR

SPARK PLUG BLEW OUT OF HEAD. CALLED FORD NO RECALL. CAN SEE WHY SO MANY SUV, TRUCKS,ECT. HAVE THIS PROBLEM. FORD SHOULD HAVE PAID. WENT TRUCK SHOPPING GOT A NEW DODGE. *TR

THE COIL PACKS AND PLUGS HAVE BEEN CHANGED ON DIFFERENT TIMES AND THE VEHICLE STILL HAS THE SAME PROBLEMS. FORD HAS TO FIND A BETTER SOLUTION TO FIX THESE ONGOING ISSUES SO THE CUSTOMER DOES NOT HAVE TO KEEP PAYING ALL THIS MONEY FOR THE SAME PROBLEMS OVER AND OVER AGAIN. ENGINE LOST POWER ON SEVERAL OCCASIONS AND SHAKES WHEN IDLING. PAINT ON FRONT OF VEHICLE STARTED PEELING OFF. ALL SERVICE WORK HAS BEEN CONDUCTED A T A FORD DEALERSHIP SINCE THE VEHICLE WAS PURCHASED EXCEPT FOR TODAY WITH (2) MORE COIL PACKS HAD TO BE INSTALLED AT A LOCAL GARAGE. THIS IS APPARENTLY A BIG PROBLEM AND SOMETHING HAS TO BE DONE ABOUT IT OR FORD WILL FIND GOOD CUSTOMERS GOING TO OTHER VEHICLE BRANDS. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE DRIVER'S SIDE AIR BAG ERRONEOUSLY DEPLOYED WITHOUT THE VEHICLE BEING INVOLVED IN A CRASH. THE DRIVER SUSTAINED FIRST DEGREE BURNS TO THE RIGHT WRIST. THE VEHICLE WAS TAKEN TO THE DEALER BUT THE DEALER DID NOT PROVIDE ANY ASSISTANCE SINCE THEY WOULD HAVE TO WAIT FOR THE LEGAL DEPARTMENT TO AUTHORIZE ANY REPAIRS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 219,671.

WOULD NOT START BROKE DOWN HAD TO TOW RUSTED FUEL PUMP MODULE. *TR

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT HE SHIFTED INTO PARK AND EXITED THE VEHICLE HOWEVER, IT BEGAN TO ROLL AWAY IN REVERSE. THE CONTACT JUMPED BACK IN THE VEHICLE AND APPLIED THE PARKING BRAKE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 115,000.

BOUGHT THIS FORD F150 USED WITH 95,000 MILES. I WAS TOLD THE PLUGS AND FUEL FILTER NEEDED REPLACED BY THE 100,000 RANGE. MY LOCAL GARAGE SPENT HOURS REPLACING ONE PLUG AND WHEN THEY CHECKED WITH THE LOCAL FORD DEALER ABOUT THE PROBLEM THEY WERE TOLD IT WAS A LONG ON GOING PROBLEM. THE DEALER SAID, THEY COULD REMOVE THE PLUGS BUT IT WOULD BE $500.00 DOLLARS TO START AND IF THE PLUGS BROKE OFF IN THE HEADS THE COST COULD BE AS MUCH AS $3,000.00 IF THEY HAD TO REMOVE THE HEADS. RESEARCH SHOWS ME THIS HAS BEEN GOING ON FOR EVER AND FORD REFUSES TO REPAIR OR RECALL THE F150 5.4 3V SPARK PLUG PROBLEM. BUILD UP AROUND THE BASE OF THE PLUGS FROM POOR HEAD DESIGN IS COSTING US CONSUMERS THOUSANDS. PEOPLE ARE GETTING HURT JUST TRYING TO REMOVE THESE PLUGS. I FEEL FORD SHOULD RECALL THE F150 WITH THIS ENGINE AND REPAIR OR REPLACE THE ENGINE HEADS WITH A PLUG THAT CAN BE REPLACED AT A FAIR PRICE NOT THIS STUPID THOUSANDS PEOPLE ARE SPENDING. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150 EQUIPPED WITH CONTINENTAL CONTITRAC BSW TIRES, SIZE: LT245 75 R17. THE CONTACT STATED THAT ALL FOUR TIRES WERE CRACKED ON THE SIDEWALL. THE CONTACT TOOK THE VEHICLE TO A MECHANIC TO HAVE THE BRAKES CHANGED AND WAS INFORMED OF THE FAILURE. THE CONTACT SPOKE TO THE MANUFACTURER IN REGARD TO NHTSA CAMPAIGN ID NUMBER: 05T022000 (TIRES: TREAD/BELT), BUT WAS TOLD THAT THE TIRE SIZE WAS NOT INCLUDED. THE FAILURE AND THE CURRENT MILEAGES WERE 37,125....UPDATED 02-13-13 *BF UPDATED 02-19-2013 *JS

MICHELIN LTX AT2 TIRES. EXCESSIVE CRACKING. TIRES WITH 30,000 MILES ON THEM AND WELL OVER ONE-HALF TREAD REMAINING HAVE DEVELOPED WIDESPREAD SIDEWALL CRACKS. CRACKS ARE MORE THAN COSMETIC, YOU CAN ACTUALLY FEEL RAISED BUMPS IF YOU RUN YOUR HAND OVER THEM. THE CRACKS SEEM SEVERE ENOUGH THAT I AM CONCERNED ABOUT TIRE FAILURES, PARTICULARLY AT HIGHWAY SPEEDS. INTERNET SEARCH SHOWS MANY SIMILAR COMPLAINTS, AND EVIDENCE THAT MICHELIN HAS BEEN QUIETLY OFFERING DISCOUNTED REPLACEMENTS TO THOSE WHO COMPLAIN DIRECTLY TO THEM. I RECENTLY FILED A COMPLAINT ON THEIR WEBSITE BUT HAVE NOT HEARD BACK. THIS PROBLEM IS WIDESPREAD ENOUGH THAT A MORE FORMAL PROGRAM ON MICHELIN'S PART SEEMS WARRANTED. *TR

WHEN ACCELERATING SLOWLY FROM A STOP LIGHT, THE DRIVERS SIDE WINDOW FELL DOWN INTO THE DOOR. APPARENTLY THE WINDOW REGULATOR BROKE, AN ISSUE WHICH IS DOCUMENTED ON NUMEROUS INTERNET SITES. THE WINDOW DROPPING INTO THE DOOR CREATED A VERY DISTRACTING DRIVING SITUATION, NOT TO MENTION VISUAL SAFETY HAZARDS AS IN TODAY DURING RAINY, FOGGY, HUMID CONDITIONS AFFECTING THE VISIBILITY THROUGH THE REMAINING GLASS IN THE VEHICLE. *TR

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, ANOTHER VEHICLE CRASHED INTO THE FRONT END OF THE CONTACT'S VEHICLE. THE VEHICLE WAS DESTROYED. THE AIR BAGS FAILED TO DEPLOY AND THE CONTACT SUSTAINED INJURIES TO THE NECK AND BACK. AN INDEPENDENT MECHANIC INSPECTED THE VEHICLE AND ADVISED THAT THE AIR BAG SENSORS WERE NOT FUNCTIONING. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 80,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT IN AN ATTEMPT TO AVOID CRASHING INTO A DEER, THE CONTACT CRASHED INTO A DITCH AND THE DRIVER'S SIDE SEAT BELT FAILED TO RESTRAIN THE CONTACT. THE CONTACT SUFFERED A BROKEN LEG AND WRIST. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 130,000.

ON THREE SEPARATE OCCASIONS, MY FORD 2005 F150 KING RANCH SUPERCREW 4X4 ENGINE SUDDENLY DIED WHILE DRIVING AT APPROXIMATELY 55-60MPH. ON ALL THREE OCCASIONS, I FORTUNATELY WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD WITH THE ENGINE DIED AND NO POWER STEERING. IF I HAD NOT BEEN IN THE RIGHT HAND LANE AND ABLE TO PULL OFF OF THE ROAD, THEN AN REAR ENGINE COLLISION WOULD MORE THAN LIKELY OCCURRED IF I WOULD HAVE BEEN IN AN OUTER LANE OF A MULTIPLE LANE HIGHWAY. AFTER THE THIRD OCCASION THIS PAST WEEK, I TOOK THE VEHICLE TO THE FORD DEALERSHIP IN ROCKWALL, TEXAS WHERE IT COST ME $700.00 TO HAVE THROTTLE BODY/MOTOR ASSEMBLY REPLACED. MY OBD READINGS AT HOME WERE P2104 AND P2112. IF NOT ALREADY, THIS ISSUE IS A FATALLY WAITING TO HAPPEN. LOTS OF CHATTER ON INTERNET OF SIMILAR ISSUES. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE GEAR WAS SHIFTED INTO DRIVE AS THE BRAKES WERE DEPRESSED WHEN THE VEHICLE LUNGED FORWARD ABNORMALLY. IN ADDITION, THE ENGINE RPMS INCREASED EXCESSIVELY AND WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THE CONTACT WAS ADVISED THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 106,000.

MY FUEL CONTROL MODULE SHORTED OUT WHICH CAUSED MY PCM TO BE ERASED. IT SEEMS TO BE A COMMON PROBLEM AFTER RESEARCHING IT, BUT NO RECALL HAS BEEN ISSUED. MY PREGNANT WIFE WAS DRIVING MY TRUCK AND LOST ALL POWER. THIS RESULTED IN A NEAR ACCIDENT DUE TO HAVING NO POWER STEERING AND LESS BRAKE CONTROL. IF THIS IS SUCH A COMMON PROBLEM WITH THE PLACEMENT OF THE CONTROL MODULE WHY HAS THIS NOT BEEN RECALLED. $1000 LATER I HOPE THIS DOESN'T HAPPEN AGAIN. *TR

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT WHILE DRIVING 30 MPH THE VEHICLE BEGAN TO SPILL FUEL INTO THE STREET. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS AND THE CONTACT WAS INFORMED THAT THE JOINT ON THE TANK HAD BECOME DELAMINATED. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 52,300. UPDATED 01/09/13*LJ UPDATED 1/11/2013 *JS

THERE IS A OBVIOUS PROBLEM WITH THE MANIFOLDS ON THIS TRUCK. MY TRUCK IS AN FX4 AND RARELY SEEN ANY OFF ROADING. MY MANIFOLDS ARE CRACKED AND THE TRUCK HAS BEEN BABIED THIS RESULTS IN A VERY ANNOYING NOISE. ALSO THE TRANSMISSION HAD BE REPLACED AT 30,000 MILES UNDER WARRANTY, THE NEW ONE IS STILL SLIPPING. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150 EQUIPPED WITH MICHELIN LTX/MS 2 TIRES, SIZE: P275/65/R18. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE REAR DRIVER'S SIDE TIRE EXPLODED. THE CONTACT NOTICED THAT THE SIDE WALL WAS SEPARATED FROM THE TREAD. THE TIRE WAS TAKEN TO AN INDEPENDENT TIRE SHOP WHERE THEY STATED THAT THE TIRE WERE DEFECTIVE. THE TIRE WAS THEN TAKEN TO A MICHELIN DEALER WHERE THE CONTACT WAS ADVISED THAT THE BLOWOUT WAS CAUSED BY A SCREW. THE VEHICLE FAILURE MILEAGE WAS 61,000 AND THE CURRENT MILEAGE WAS 61,863. THE TIRE FAILURE MILEAGE WAS 25,581. ..UPDATED 11/14/12 *BF THE CONSUMER STATED A SECOND TIRE HAD TO REPLACED BECAUSE THE TREAD DEPTH CANNOT BE MORE THAN 4/32 ON SAME AXLE ON A 4 WHEEL DRIVE. UPDATED 11/19/2012 *JS

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT THE HEADLIGHTS BECAME INOPERABLE WHILE DRIVING 55 MPH. THE CONTACT STATED THAT HE WAS DRIVING WITH THE LOW BEAMS ACTIVATED WHEN THEY FAILED AND NEVER RE-ILLUMINATED. THE DEALER WAS NOTIFIED WHO ADVISED THAT WITHER THE MULTI-SWITCH OR THE MODULE UNDER THE DASHBOARD WOULD NEED REPLACING. THERE WERE NO RECALLS FOR THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 164,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED WHILE TRAVELING 30 MPH, THE REAR DRIVER SIDE WINDOW COLLAPSED INTO THE DOOR PANEL. THE CONTACT MERGED TO THE SIDE OF THE ROAD AND THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS CONFIRMED THAT THE WINDOW REGULATOR FAILED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE LATER RECURRED WITH ANOTHER WINDOW. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 66,000. ..UPDATED 09-28-12 *BF THE CONSUMER STATED TWO OF THE WINDOWS FAILED WITHIN TWO DAYS OF EACH OTHER. THE FIRST FAILURE HAPPENED AT 30 MPH AND THE SECOND INCIDENT HAPPENED AT 65 MPH, WHILE HIS WIFE WAS DRIVING ON THE FREEWAY. THE CONSUMER'S WIFE ALMOST LOST CONTROL OF THE VEHICLE, BECAUSE SHE THOUGHT IT WAS A GUN SHOT. THE WINDOW DROPPED INSIDE THE DOOR, LEAVING THE INABILITY TO ROLL UP THE WINDOW. UPDATED 10/01/12

TL* THE CONTACT OWNS A 2005 FORD F-150. WHILE PARKED, THE CONTACT INSPECTED THE VEHICLE AND NOTICED THAT THE FRONT PASSENGER SIDE COIL SPRING WAS FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE FRONT PASSENGER SIDE COIL SPRING WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 62,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, A LOUD NOISE EMITTED OUTSIDE OF THE VEHICLE. THE CONTACT MANEUVERED TO THE SIDE OF THE ROAD AND THEN RESUMED DRIVING. THE VEHICLE WAS INSPECTED UPON ARRIVING TO THE RESIDENCE. THE CONTACT DETECTED THE NUMBER SEVEN SPARK PLUG DISLODGED FROM THE ENGINE CYLINDER HEAD. THE DEALER WAS CONTACT WHO INFORMED HIM THAT THERE WAS NO RECALLS PERTAINING TO THE DEFECT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

I HAVE POWERED WINDOWS ON MY TRUCK. TODAY WHILE DRIVING TO WORK AND GETTING ON THE HIGHWAY GOING SOUTH ON I-35 IN OKC, OK. I HAD THE DRIVER SIDE WINDOW PARTIALLY ROLLED DOWN AND ONCE I WAS AT HIGHWAY SPEEDS I DECIDED TO ROLL THE WINDOW UP, AS I USUALLY HAVE ALWAYS DONE BEFORE. AFTER THE WINDOW REACHED THE CLOSED POSITION, I HEARD A LOUD POP AS IF A ROCK HIT THE WINDOW AND IMMEDIATELY AFTER THAT, THE WINDOW FELL DOWN AND SLAMMED INTO THE BOTTOM WELL OF THE DOOR PANEL. TO MY AMAZEMENT AND NOT UNDERSTANDING WHAT JUST OCCURRED, I TRIED TO RE-RAISE THE WINDOW BACK UP UNSUCCESSFULLY. SO FAR ITS SITTING IN THE PARKING LOT, TAPED UP WITH PLASTIC OVER IT SINCE ITS ABOUT TO RAIN UNTIL I CAN GET IT TAKEN CARE OF. ON ANOTHER NOTE THE OTHER REAR BACK PASSENGERS WINDOWS SQUEAK WHEN THEY ARE RAISED OR LOWERED. WHAT NEXT!! PROBABLY MORE OF THE SAME. SWEET!! *TR

TL* THE CONTACT OWNS A 2005 FORD F150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE AIR BAG WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO THE DEALER AND REPAIRED AT THE OWNER'S EXPENSE, EVEN THOUGH THERE WAS A RECALL ISSUED FOR THE SIMILAR DEFECT UNDER NHTSA CAMPAIGN ID NUMBER 11V107000 (AIR BAGS:FRONTAL:DRIVER SIDE INFLATOR MODULE). THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. IN ADDITION, THE STEERING WHEEL WOULD EMIT A LOUD CLUNKING AND RATTLING NOISE WHEN THE VEHICLE WAS IN OPERATION. THE STEERING WHEEL WOULD ALSO LOCK WHENEVER THE VEHICLE WAS BEING DRIVEN FOR OVER A PERIOD OF TWENTY MINUTES AND EVENTUALLY UNLOCK WHEN THE ENGINE WAS SHUT OFF. THERE WAS A TECHNICAL SERVICE BULLETIN PERTAINING TO THE NHTSA ITEM NUMBER 10014252 (STEERING). THE STEERING WHEEL WAS REPAIRED BY THE DEALER AND THE PROBLEM CONTINUED TO OCCUR. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

THE TRUCK LOSES ITS POWER STEERING CAPABILITY AFTER ABOUT 10-15MIN OF DRIVING DOWN THE ROAD. IF A TURN NEEDS TO BE MADE,THE STEERING WHEEL FREEZES WITHOUT NOTICE, WHICH CAUSES PANIC; ADDITIONALLY, IT RATTLES AND CLUNKS AS IT IS MANUALLY MANEUVERED. IT BECOMES NECESSARY TO QUICKLY STRONG-ARM THE STEERING WHEEL, IN HOPES OF FORCIBLY COMPLETING THE TURN SO THAT IT DOESN'T GO OFF THE PATH POSSIBLY CRASHING INTO SOMETHING OR SOMEONE. FORD HAS ISSUED A TSB #05-9-23 PERTAINING TO THIS ISSUE. WHY IS A MECHANICAL PROBLEM THAT CAN BE SO DANGEROUS TO THE DRIVER, PASSENGERS AND OTHERS NOT IDENTIFIED AS A RECALL VS. A TSB? *TR

I HAVE READ MANY COMPLAINTS JUST LIKE MINE, FORD TOLD SOME PEOPLE THEY HAD WAY TOO MANY COMPLAINTS TO DO ANYTHING ABOUT A RECALL ON THIS. LAST YEAR THE DRIVERS WINDOW POPPED AND THE WINDOW DROPPED INSIDE THE DOOR I WENT TO FORD BOUGHT THE CABLE AND REGULATOR AND HAD A WINDOW COMPANY REPLACE IT. 2 WEEKS AGO SAME THING ON THE PASSENGERS FRONT WINDOW, NEXT DAY THE PASSENGERS BACK WINDOW DROPPED WHILE I WAS IN MY HOUSE, THE DRIVERS BACK WINDOW IS THE ONLY ONE LEFT. THIS TRUCK IS A 2005 THE PARTS ARE NOT THAT OLD. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE DRIVER STARTED THE VEHICLE AND HEARD A POPPING NOISE. THERE WAS SMOKE SEEN RISING FROM UNDER THE HOOD. THE CONTACT APPEARED ON THE SCENE TO EXAMINE THE VEHICLE AND NOTICED THAT THE POWER ASSIST FEATURE ON THE BRAKES WAS NO LONGER FUNCTIONING. THE VEHICLE WAS THEN TOWED TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT VARIOUS HOSES FOR THE BRAKING SYSTEM FAILED. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 08V208000 (SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM:HOSES, LINES/PIPING, AND FITTINGS). THE MANUFACTURER WOULD NOT HONOR THE RECALL A SECOND TIME. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 95,173.

THIS 5.4 LITER V8 MOTOR REQUIRED REPLACEMENT OF SPARK PLUGS (CHECK ENGINE MESSAGE FLASHED ON THE DASHBOARD). THE SPARK PLUGS HAD WELDED THEMSELVES TO THE ENGINE HEAD, ULTIMATELY REQUIRING THE REMOVEL OF THE ENGINE HEAD TO EXTRACT SPARK PLUG-COST $2,000 IN ADDITIONAL COST TO CONSUMER. INTERNET IS FULL OF SIMILAR REPORTS. MECHANICS AT FORD DEALERSHIP AND MIDAS REPORT FREQUENT ENCOUNTER WITH THIS ISSUE WITH SIMILAR RESULT. I HAVE CONTACTED FORD AND THEY CLAIM NO LIABILITY, STATING NHTSA HASN'T REQUIRED THEM TO DO A RECALL. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150 EQUIPPED WITH HANKOOK SNM TIRES, SIZE: P235 70 R17. THE CONTACT STATED THAT WHILE TRAVELING 55 MPH, THE REAR DRIVER SIDE TIRE BLEW. THE CONTACT STATED THAT TWO WEEKS PRIOR TO THE FAILURE, THE VEHICLE PASSED STATE INSPECTION WITH NO INDICATION OF A FAILURE. THE CONTACT STATED THAT THE TIRE TREAD SEPARATED AND CAUSED THE FAILURE. THE CONTACT WAS TOLD THE TIRES WERE IMPORTED FROM KOREA AND THAT THE RUBBER DID NOT WEAR EVENLY. THE FAILURE AND THE CURRENT MILEAGE WAS 30,000. .. UPDATED 08-30-12 *BF UPDATED 08/31/2012 *JS

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE SHIFTER CABLE DETACHED FROM THE CONNECTION IN THE TRANSMISSION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING AND THE MECHANIC REPLACED THE SHIFTER CABLE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

PARKING MY TRUCK IN MY GARAGE, STOPPED, PUT TRANSMISSION IN PARK, CLOSED DRIVERS DOOR POWER WINDOW, HEARD LOUD POP, SOUNDED AS IF GLASS BROKE, BUT IT DID NOT. WINDOW FELL DOWN INTO DOOR, WOULD NOT RAISE UP. PRESSING POWER BUTTON, I COULD HEAR MOTOR RUNNING, BUT WINDOW WOULD NOT MOVE. *JS

WHILE SITTING AT REST, THE LEFT FRONT COIL SPRING BROKE AT THE BOTTOM RUNG. THE ENGINE WAS NOT RUNNING AND THE TRUCK WAS UNLOADED. I HEARD A LOUD SNAP AND THE TRUCK SHOOK. NO PARTS OR FRAGMENTS WERE RELEASED AND THE BREAK WAS CLEAN AND RATHER EVEN ACROSS THE BODY OF THE SPRING. THE STANCE OF THE TRUCK HAS BEEN ALTERED ALTHOUGH NO CHANGE IN DRIVABLILITY TO DATE (NEXT DAY). *TR

TL* THE CONTACT OWNS A 2005 FORD F-150 EQUIPPED WITH GOODYEAR WRANGLER TIRES, SIZE 235/70/R17. THE CONTACT STATED THAT WHILE DRIVING 75 MPH, THE FRONT DRIVER'S TIRE BLEW OUT. THE ROAD CONDITIONS WERE CLEAR. THE CONTACT STATED THAT THE TREAD AROUND THE TIRE SEPARATED COMPLETELY FROM THE REST OF TIRE. THE LEFT AND RIGHT SIDES ATTACHED TO THE RIM REMAINED INTACT. THE VEHICLE WAS NOT TAKEN TO A DEALER OR REPAIR SHOP TO GET THE TIRES INSPECTED. THE APPROXIMATE FAILURE AND CURRENT MILEAGES WERE 115,000. THE FAILURE AND CURRENT MILEAGE OF THE TIRE WAS 1,000.

JUNE 24, 2012 DEAR FORD MOTOR COMPANY, I OWN A 2005 FORD F150 4X4 CREW CAB TRUCK, WHICH I HAVE HAD SINCE 2005, AND WHICH YOU HAVE EXCLUDED FROM YOUR PRESENT RECALL OF 2005-2006 FORD F150'S. HOWEVER, IT HAS PRESENTED AN ILLUMINATED AIR BAG LIGHT EVERY TIME IT HAS BEEN STARTED NOW FOR OVER 2 YEARS.THIS I HAVE LEARNED IS THE SINGLE WARNING SIGN CAPABLE OF WARNING OF ITS FAULTY AIR BAG SYSTEM. I AM AWARE THAT NHTSA WANTED FORD TO RECALL 1.2+ MILLION TRUCKS AND THAT FORD HAS AVOIDED SUCH A WIDE-SPREAD RECALL SAYING THEY HAD MADE PRODUCTION CHANGES THAT MINIMIZED THE NUMBER OF AFFECTED TRUCKS, AND THAT NHTSA SENT ANOTHER LETTER WARNING FORD THAT IF THEY DIDN'T AGREE TO A COMPLETE RECALL, THE AGENCY COULD CONVENE A FORMAL PUBLIC HEARING TO COMPEL A RECALL, AND THAT NOW FORD HAS AGREED TO RECALL 2004 THROUGH 2006 F-150 VEHICLES, APPROXIMATELY 1.2 MILLION MORE TRUCKS. YET STILL MY TRUCK IS A 2005, THE VERY YEAR MODEL INCLUDED IN YOUR ORIGINAL RECALL, YET FOR WHATEVER REASON MY 2005 FORD F150 IS EXCLUDED, LEAVING ME TO CHANCE THE SAFETY OF MY FAMILY'S LIFE EVERY TIME ANY OF US GET IN MY TRUCK (WHICH ONLY LIKES 2 PAYMENTS BEING PAID FOR). BY THE WAY, I AM A MOTHER OF 3, DAUGHTER OF 2, SISTER TO 1 AND THE GIRLFRIEND OF A MEAN BIKER, SHOULD I PARISH MY CHILDREN WOULD BE ORPHANS, BUT MORE IMPORTANTLY TO FORD MOTOR COMPANY, SHOULD ANY OF MY CHILDREN BE SO MUCH AS HARMED DUE TO THIS WELL DEPICTED ISSUE, FORD MOTOR COMPANY IS GOING TO WISH MY CHILDREN WERE ORPHANED! [XXX] P.S. I ALSO COME FROM A FAMILY OF FORD ENTHUSIASTS, THUS I HAVE GREAT FAITH IN YOUR LOYALTY AND THEREFORE WILL ALLOW YOU A MINIMAL AMOUNT OF TIME TO INCLUDE MY 2005 FORD F-150 IN YOUR RECALL (AND NOTIFY ME OF IT), BEFORE I FORWARD THIS CORRESPONDENCE TO THE NHTSA AND EVERYWHERE ELSE ADDITIONAL RESEARCH INSTRUCTS ME TO. *TR

DRIVING OUT OF A PARKING LOT, ONLY 10 MPH OR SO, LOUD POP ON PASSENGER SIDE DOOR. STOPPED THE VEHICLE, AND PASSENGER WINDOW DROPPED DOWN INTO THE DOOR. GRATEFUL I WAS NOT GOING FAST AND HAD THE ABILITY TO STOP QUICKLY, OTHERWISE POTENTIAL ACCIDENT. LOOKING ONLINE, CAN SEE THIS IS A FREQUENT PROBLEM WITH THIS YEAR, MAKE, MODEL TRUCK. A MATTER OF TIME BEFORE SOMEONE GETS HURT FROM THIS. *JS

I WAS LEAVING AN ATM (IT WAS RAINING), I ROLLED UP THE DRIVERS WINDOW. WHEN THE WINDOW REACHED THE TOP THE WINDOW FELL (FREE FALL WAS MORE LIKE IT) IN TO THE DOOR. ONCE I REMOVED THE DOOR PANEL AND INSPECTED THE WINDOW PARTS I FOUND THE REGULATOR FAILED/BROKE. WE ARE THANKFUL THE WINDOW DID NOT BREAK AND INJURE US. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS BEING EXAMINED FOR ROUTINE MAINTENANCE WHEN HE WAS INFORMED THAT FOUR SPARK PLUGS WERE FRACTURED. THE CONTACT ALSO STATED THAT THE SPARK PLUGS WERE SUPPOSED TO LAST FOR APPROXIMATELY 100,000 MILES BEFORE BEING REPLACED. THE DEALER STATED THAT A CARBON BUILD UP ON THE TIPS OF THE PLUGS CAUSED THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 81,000.

I WAS DRIVING ON A RESIDENTIAL STREET (GRAY ST. )APPROACHING A BUSY TWO LANE STREET THAT WAS ONE WAY HEADING SOUTH (ARMENIA AVENUE) IN TAMPA, FLORIDA. AS I WAS APPROACHING THE STOP SIGN, MY FOOT WAS ON THE BRAKE. PREPARING TO STOP, BUT INSTEAD OF STOPPING THE ENGINE REVVED AND ACCELERATED INTO THE LANES OF TRAFFIC TRAVELING SOUTH. I WAS STANDING ON THE BRAKE SO HARD THAT MY LEG WAS SHAKING WHEN I FINALLY STOPPED. I STOPPED THE VEHICLE BY DEPRESSING THE EMERGENCY BRAKE AND THE RPM'S FINALLY CAME DOWN AND THE ENGINE RETURNED TO NORMAL. I WAS SO NERVOUS BECAUSE IF THERE HAD BEEN CARS COMING I WOULD HAVE BEEN HIT ON THE DRIVER'S SIDE. THE STREET IS USUALLY VERY HEAVY WITH TRAFFIC. I WAS VERY LUCKY THAT THERE WAS NO ONE CLOSE OR I MAY NOT BE WRITING THIS TODAY. A FEW DAYS LATER I CAME TO THE SAME CORNER AND A BICYCLIST CROSSED RIGHT IN FRONT OF ME. IF THIS HAD HAPPENED ON APRIL 12TH, I WOULD HAVE RUN OVER THE BICYCLIST. I DROVE AROUND THE BLOCK VERY SLOWLY CONTINUING TO STOP AND RPM'S WERE NORMAL. I REALLY THOUGHT EVERYONE WOULD THINK I WAS CRAZY FOR WHAT HAD JUST HAPPENED. WHEN THE FORD DEALERSHIP FOUND THE PROBLEM ON THE COMPUTER I WAS RELIEVED TO KNOW THAT THERE WAS A PROBLEM THAT COULD BE FIXED. IT WAS THE THROTTLE BODY. A MONTH LATER OUR OTHER FORD F-150, A 2007, HAD THE SAME PROBLEM AND THIS TIME MY HUSBAND WAS DRIVING IT. THERE WAS A REPORT ON THIS VEHICLE ALSO. FORD IS NOT RECOGNIZING THAT THERE IS A PROBLEM AND OTHER VEHICLES ARE BEING BROUGHT IN FOR THE SAME ISSUES WHICH COULD RESULT IN SERIOUS INJURY OR FATALITIES TO INNOCENT PARTIES DUE TO SOME DEFECT IN THE THROTTLE BODY'S ON THE F-150'S. MY REPORT NUMBER ON OUR 2007 F-150 IS 10459967. *TR

THE TRUCK HAS BEEN BACK TO FORD MANY TIMES FOR DRAINING THE BATTERY. IF IT IS PARKED FOR 2 TO 3 DAYS I WOULD HAVE TO JUMP START IT. THE DEALERS COULD NOT FIND THE PROBLEM AND KEEP REPLACING THE BATTERY. AFTER IT WAS OUT OF WARRANTY PAID OUT OF MY OWN POCKET TO FIND THE PROBLEM STILL COULD NOT FIND. I HAVE A VIDEO OF THE TRUCK IN12/11 OF THE HEATER/DEFROSTER RUNNING AFTER THE TRUCK WAS PARKED FOR 3 HOURS WITH NO KEYS IN THE TRUCK. ON 5/16/2012 THE TRUCK WAS PARKED IN MY DRIVEWAY AND CAUGHT FIRE UNDER THE DASH. *TR

CROSS-REFERENCE FORD TSB 07-13-5: WATER LEAK FROM AC HAS FLOODED THE PASSENGER FLOOR PAN AND ALL ASSOCIATED CARPETING AND PADDING. SIGNIFICANT HEALTH HAZARD EXISTS IN WARM CLIMATES DUE TO THE PROLIFERATION OF RESPIRATORY HAZARDS INCLUDING BUT NOT LIMITED TO LEGIONNAIRE'S DISEASE. THE ITEM SHOULD BE A RECALL FOR THIS REASON. I HAVE LOST USE OF MY TRUCK DUE TO THE INABILITY TO SUFFICIENTLY DRY THE PADDING - I HAVE HAD THE VEHICLE DRYING FOR ONE WEEK IN HOT FLORIDA SUN TO NO AVAIL. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE VEHICLE SUDDENLY ACCELERATED. THE CONTACT HAD TO APPLY EXCESSIVE FORCE TO THE BRAKES AND SHIFT INTO NEUTRAL IN ORDER TO GET THE VEHICLE TO STOP. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND AFTER TWO DAYS OF TESTING, THE DEALER ADVISED THAT HE WAS UNABLE TO DIAGNOSE A FAILURE WITHIN THE VEHICLE. THE VEHICLE WAS NOT DRIVEN DURING THE WINTER, ONLY THE SUMMER AND THE CONTACT HAD EXPERIENCED THE FAILURE FOR TWO CONSEQUENT YEARS. AN ENGINEER WAS SENT BY THE MANUFACTURER TO INSTALL A VEHICLE REGISTRATION MARK (VRM) IN THE VEHICLE TO MONITOR THE FAILURE BUT TO NO AVAIL. THE VRM WAS REMOVED AND THE FAILURE RECURRED SHORTLY AFTERWARD. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 53,000. UPDATED 06/12/12*LJ THE CONSUMER STATED THE SUDDEN ACCELERATON OCCURRED FOUR TIMES. UPDATED 06/13/12

DRIVING MY SON HOME FROM SCHOOL, HEARD A LOUD POP IN THE DRIVER'S SIDE DOOR, WHICH MADE ME JERK THE WHEEL (GLAD I WASN'T GOING VERY FAST), THEN THE DRIVER'S SIDE WINDOW FELL INTO THE FRAME. DEALERSHIP CLAIMS BROKEN WINDOW REGULATOR. WENT ONLINE AND FOUND HUNDREDS OF COMPLAINTS OF THE SAME. CALLED FORD COMPLAINT NUMBER; THEY VERY KINDLY TOLD ME THERE WAS NOTHING THEY COULD DO AT THIS TIME. TOO MANY COMPLAINTS OF THE SAME ISSUE TO NOT BE ON RECALL LIST. *TR

DRIVING TO CHURCH ON MAY 6TH, 2012 @ 0900 A.M. ON THE INTERSTATE TRAVELING @ 70 MPH. I LOWERED THE WINDOW ABOUT AN INCH. WHEN I PRESSED THE BUTTON TO RAISE THE WINDOW A LOUD POP OCCURRED AND THE WINDOW DROPPED INTO THE DOOR-WELL. IT SCARED EVERYONE IN THE TRUCK. IT WAS A SUNNY DAY. POTENTIAL FOR LOSS OF LIFE IS PRESENT WITH THIS ISSUE. INCLEMENT WEATHER OR BLINDING DEBRIS WITHIN THE CAB COULD RAISE THE POTENTIAL FOR LOSS OF LIFE. PLEASE PETITION FORD MOTOR COMPANY FOR A RECALL ON THIS POTENTIALLY LIFE THREATENING ISSUE. *TR

SITTING IN PARK AS I HAD JUST STARTED THE VEHICLE WHEN THE AIRBAG DEPLOYED. *TR

#3 SPARK PLUG BLEW OUT WHILE TRAVELING AWAY FROM HOME IN ANOTHER STATE. IN DRIVING TWO MILES BACK TO MY SON'S HOUSE, I HAD TWO EXPLOSIONS FROM EXCESS GASOLINE AND SPARK PLUG FIRING. THE SPARK PLUGS WERE ORIGINAL AND BLEW OUT BECAUSE OF THE FINE THREADS AND ALUMINUM CYLINDER HEADS. THIS IS A DESIGN DEFECT AND SAFETY PROBLEM KNOWN TO FORD. TOWING AND INSERT INSTALLATION BY A FORD DEALER WAS $950. THE ENGINE IS A 4.6 V-8 UPDATED 05/17/12 *BF

FOR THE THIRD TIME, I HAVE HAD A DOOR WINDOW DROP FROM A FULLY CLOSED POSITION TO A FULLY OPEN POSITION. IN DOING RESEACH ON THE ISSUE, I FIND THAT THIS IS A COMMON PROBLEM WITH 2004 - 2005 MODEL YEAR F150 CREW CABS. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH HE NOTICED THAT THE ENGINE MISFIRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE MECHANIC STATED THAT THE REVERSE SPARK PLUGS WELDED THEMSELVES TO THE ENGINE HEAD. THE MECHANIC PERFORMED A TUNE UP AND REPLACED THE SPARK PLUGS. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 94,000. THE VIN WAS UNAVAILABLE. UPDATED 06/05/12*LJ THE CUSTOMER STATED FORD REPLACEDTHE FAULTY FUEL INJECTORS. UPDATED 06/06/12 *JS

THE FIRST REGULATOR THAT BROKE WAS ON THE DRIVERS SIDE. MY WIFE AND I CAME HOME IN HER CAR, MY TRUCK WAS PARKED IN THE DRIVEWAY AND WE NOTICED THE WINDOW ON THE DRIVERS SIDE WAS DOWN AND ON INSPECTION THE GLASS WAS DOWN INSIDE THE DOOR. THE NEXT TIME WAS THIS SUNDAY, MARCH 1, 2012, WHEN WE GOT HOME FROM CHURCH THE SAME THING HAPPENED EXCEPT IT WAS THE PASSENGER SIDE. *TR

FORD FACTORY SPARK PLUG BREAKS WITHIN THE HEAD CAUSING POTENTIAL INTERNAL ENGINE DAMAGE. AN EXTREMELY COMMON ISSUE THAT HAS LEAD TO THE INVENTION OF A SPECIAL TOOL USED JUST BECAUSE F THE ISSUE. COMMONLY REACHING HUNDREDS AND EVEN THOUSANDS OF DOLLARS TO REPAIR. FORD HAS CHANGED THEIR TSB FROM CHANGING PLUGS AT 100K MILES TO 60K MILES. HOWEVER BY THE TIME A ISSUE WAS NOTICED MANY OF US OWNERS HAVE OVER THE 60K MILE MARK. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN HE NOTICED THAT FLUID WAS LEAKING INTO A PUDDLE UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER BUT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS THEN TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE POWER STEERING LINES WERE LEAKING. THE VEHICLE WAS NOT REPAIRED BECAUSE THE NECESSARY PARTS WERE ON BACK ORDER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 248,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, A LOUD POP NOISE WAS HEARD AND THE VEHICLE ERUPTED INTO FLAMES. THE VEHICLE CAUSED EXTENSIVE DAMAGE TO A COMMERCIAL BUILDING IN WHICH IT WAS PARKED NEAR. THE POLICE WERE CONTACTED AND A POLICE REPORT WAS FILED. THE FIRE DEPARTMENT DID NOT DETERMINE THE CAUSE OF THE FIRE. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 78,000. UPDATED 03/28/12 *BF UPDATED 03/30/12

WARNING LIGHT: ENGINE FAIL SAFE ON I WAS FORCED TO COAST TO A STOP AND TURN OFF THE VEHICLE. I RESTARTED THE VEHICLE CLEARING THE WARNING AND CONTINUED ON. I TOOK THE VEHICLE TO A LOCAL FORD DEALER WHERE IT WAS DETERMINED I NEEDED TO REPLACE THE THROTTLE BODY AND THROTTLE POSITION SENSOR.

DRIVER SIDE WINDOW JUST FELL IN THE DOOR WHILE DRIVING. *TR

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE FRONT DRIVER SIDE WINDOW MALFUNCTIONED AND THE WINDOW COULD NOT BE OPENED. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC WHERE THE MECHANIC REPLACED THE WINDOW REGULATOR MOTOR. THE REPAIR DID NOT REMEDY THE ISSUE SO THE CONTACT TOOK THE VEHICLE BACK TO THE MECHANIC FOR A DIAGNOSTIC TEST. THE TEST RESULTS DISPLAYED THAT THE DM MODULE WAS DEFECTIVE. THE CONTACT DID NOT CALL THE MANUFACTURER. THE FAILURE MILEAGE WAS 80,690.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WOULD VIBRATE VIOLENTLY WHILE DRIVING ON THE HIGHWAY. THE DEALER AND MANUFACTURER WERE NOTIFIED, BUT WERE UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 10 AND THE CURRENT MILEAGE WAS 76,000.

TL* THE CONTACT OWNED A 2005 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING 35 MPH IN RAINY WEATHER CONDITIONS, THE DRIVER CRASHED INTO A TREE THAT HAD FALLEN AND OBSTRUCTED THE ROADWAY. AS THE VEHICLE ROLLED OVER THE IMPALED TREE, ONE OF THE TREE BRANCHES FRACTURED THE FRONT WINDSHIELD AND STRUCK THE DRIVER. THE AIR BAGS DID NOT DEPLOY AND THE DRIVER WAS KILLED. THE VEHICLE WAS DESTROYED. THE FAILURE AND THE CURRENT MILEAGES WERE UNKNOWN. UPDATED 04/10/12*LJ UPDATED 06/07/12*JS

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE BRAKES STARTED TO PULSATE AND THE STEERING WHEEL JERKED VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE ROTORS WERE WARPED AND AS A RESULT, THE ROTORS NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 12,000 AND THE CURRENT MILEAGE WAS 31,000. UPDATED 03/16/12*LJ UPDATED 04/19/12

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH WHEN HE HEARD A LOUD NOISE IN THE DOOR. AFTER A GUST OF WIND HIT HIM, HE REALIZED THAT THE WINDOW FALLEN DOWN INTO THE DOOR PANEL UNEXPECTEDLY. THE VEHICLE WAS INSPECTED BY THE OWNER WHO NOTICED THAT THE CONTROL FOR THE WINDOW WAS FRACTURED, CAUSING THE WINDOW TO FALL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 52,000. UPDATED 04/11/12*LJ THE CONSUMER STATED HE REPLACED THE WINDOW REGULATOR ON HIS OWN. THE PLASTIC FEED FOR THE CABLES HAD BROKEN AND THE REGULATOR CABLE DRUM GROOVES HAD WORN OUT. UPDATED 04/23/12

MY FUEL PUMP MODULE SHORTED OUT. IT HAD BECOME CORRODED. THERE WAS A MELTING OF PLASTIC PARTS IN THE MODULE. I COULD SMELL THE PLASTIC BURNING BEFORE THE UNIT FAILED. THE TRUCK WAS RUNNING FINE AND THEN SUDDENLY DIED WHEN THE MODULE FAILED. FORTUNATELY, I WAS DRIVING THROUGH A SMALL TOWN WHEN THIS HAPPENED. IF IT WOULD HAVE HAPPENED ON THE HIGHWAY IT COULD HAVE BEEN A VERY DANGEROUS SITUATION. I FEEL FORD SHOULD BE PERFORMING A RECALL ON THESE MODULES. IT'S A VERY POOR DESIGN. I ALSO FEEL THAT THE TRUCK OWNERS SHOULD BE COMPENSATED FOR THE REPAIRS THAT HAVE ALREADY BEEN DONE. *TR

THIS IS THE SECOND COOPER DISCOVERER H/T DE-TREADING INCIDENT IN SEVERAL MONTHS. IN BOTH CASES, TIRE PRESSURES WERE INFLATED PER SPECIFICATION PRIOR TO AN EXTENDED TRIP AND FAILED AFTER LESS THAN 200 MILES OF SUSTAINED HIGHWAY DRIVING. ALL TIRES WERE INSPECTED PRIOR TO THE TRIP AND NO ROAD HAZARDS WERE CAUSE OF THE TIRES DE-TREADING. THE FIRST INCIDENT IN OCTOBER ON HIGHWAY 10 WEST WAS REPORTED TO NTHSB. THIS SECOND INCIDENT OCCURRED ON FEBRUARY 9, 2012 WHILE TRAVELING AT A SPEED OF 70 MPH ON HIGHWAY 10 EAST, APPROXIMATELY 130 MILES FROM LAKE HAVASU CITY, ARIZONA. ON BOTH OCCASIONS, THE TIRES HELD PRESSURE WHILE THE TREADS SHEARED FROM THE TIRE. BOTH DEFECTIVE TIRES MAINTAINED THE CORRECT PRESSURE AFTER TESTING. IT IS ALSO NOTED THAT THE VEHICLE HAS NEVER TOWED A TRAILER. THE VEHICLE SUSTAINED SEVERE DAMAGE IN BOTH INCIDENTS, WITH THE FIRST OCCURRENCE FORCING THE TRUCK OFF THE ROADWAY AND INTO A NEAR FATAL SITUATION. *TR

2005 FORD F150. CONSUMER STATES ENGINE SHUTS OFF AND VEHICLE CONTINUES TO GO INTO "FAIL SAFE MODE" *TGW THE CONSUMER STATED THERE WERE TIMES WHEN THE VEHICLE WOULD RE-START, AND OTHER TIMES IT WOULDN'T. THE CONSUMER STATED SEVERAL COMPONENTS SUCH AS THE FUEL FILTER, CATALYTIC CONVERTER, FUEL PUMP MODULE, THROTTLE BODY, AND CRANKSHAFT POSITION SENSOR WERE REPLACED TO TRY AND RECTIFY THE PROBLEM. THE ENGINE BEGAN TO MISFIRE AND THE CHECK ENGINE LIGHT ILLUMINATED. THE CONSUMER STATED IT WAS FINALLY DETERMINED, THE CASING ON THE CRANKSHAFT POSITION SENSOR WIRE HAD RUBBED THROUGH AND WAS SHORTING OUT ON THE AC LINE RUNNING ALONG THE RIGHT FENDER WELL. THE CONSUMER STATED AT SOME POINT WHEN HIS VEHICLE WAS BEING SERVICED AT THE DEALER, A COVER WAS REMOVED FROM THE FAR LEFT WIRING HARNESS AT THE PCM, WHICH PERMITTED WATER TO RUN DOWN THE INSIDE OF THE WIRING HARNESS AND SHORTED OUT THE CONNECTOR. JB

MY 2005 F-150 TRUCK STALLED RIGHT IN FRONT OF MY HOUSE JUST OUTSIDE OF MY DRIVEWAY, MY NEIGHBOR AND I HAD TO PUSH IT IN AS TO NOT BLOCK MY STREET. LUCKILY IT DIDN'T DIE OUT ON THE HIGHWAY WHICH I WAS ON FIVE MINUTES BEFORE IT DIED OUT. I WAS THINKING THE FUEL PUMP WENT, BUT WITH ONLY 68,000 MILES THAT WOULD NOT BE VERY GOOD. AFTER SOME RESEARCH ON THE NET THIS LITTLE PART NAMED FUEL PUMP DRIVE MODULE GETS MY ATTENTION. I TOOK DOWN THE SPARE TIRE TOOK OUT THE TWO BOLTS THAT HOLD THE FPDM IN AND WOW THIS PART WAS CORRODED WITH A HOLE IN IT AND A CRACK!!! SO AFTER $144.00 FOR PART # 4L3Z-9D370-A FROM FORD DEALER AND ABOUT 45 MINUTES OF MY TIME, I'M ROLLING AGAIN, LUCKY FOR ME NO TOW FEES JUST A FEW BEERS FOR MY NEIGHBOR. WHAT A JOKE THAT FORD CAN ALLOW THIS BAD DESIGN TO CONTINUE AND NOT BE RECTIFIED BY RECALLING ALL THE VEHICLES THIS WAS INSTALLED ON. I GUESS THAT WONT HAPPEN TILL A FEW PEOPLE LOSE THERE LIVES BECAUSE OF IT. *KB

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THE FRONT ROTORS HAD TO BE REPLACED TWICE BECAUSE THEY WERE WARPED. THE FAILURE CAUSED THE STEERING TO WHEEL TO SHAKE VIOLENTLY WHEN DRIVING AT HIGH SPEEDS AND BRAKING. THE CONTACT ALSO STATED THAT THE ROTORS WERE REPLACED TWICE WITHIN 7,000 MILES OF DRIVING. THE DEALER HAD NOT GIVEN A REASON FOR WHY THE FAILURE OCCURRED. THE FAILURE MILEAGE WAS 23,000 AND THE CURRENT MILEAGE WAS 30,000.

TL* THE CONTACT OWNS A 2005 FORD F-150. THE CONTACT STATED THAT THE AIR BAGS EXPLODED FIVE SECONDS AFTER STARTING THE VEHICLE. AS A RESULT, THE CONTACT SUFFERED BURNS ON THE LEFT HAND AND WRIST. THE MANUFACTURER SENT AND INVESTIGATOR TO EXAMINE THE VEHICLE AND THE INVESTIGATOR COULD NOT LOCATE A FAILURE. THE MANUFACTURER ALSO INFORMED THE CONTACT THAT THERE WAS NO REMEDY FOR THE FAILURE. THE CONTACT LATER RECEIVED A RECALL NOTICE ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 11V107000 (AIR BAG: FRONTAL: DRIVER SIDE INFLATOR MODULE), BUT THE MANUFACTURER REFUSED TO REPAIR THE VEHICLE. THE FAILURE AND CURRENT MILEAGES WERE 50,000. UPDATED 02/23/12

PAINT CHIPPING ON THE VARIOUS AREAS OF THE TRUCK. *TR