2005 Jeep Wrangler 2-DR.

The dashboard will display odd behavior and all of a sudden the ignition will cut. Total loss of power. This has happened in the past with children in the vehicle. Very dangerous. Resetting the key will reset but it is random.

The contact owns a 2005 Jeep Wrangler. The contact stated while driving approximately 65 mph, the vehicle loss motive power. Several gauges became inoperable with unknown warning lights illuminated. The contact pulled over and waited approximately 15 minutes before the vehicle was restarted. The vehicle was towed to the dealer but was not yet diagnosed or repaired. The ignition switch was replaced. The manufacturer was not made aware of the failure. The approximate failure mileage was 66,666.

Engine failed, speedometer, tach went to 0, all gauges went to 0, power steering failed after I declutched and then coasted to a full stop (power brakes failed but still had some brake input) safely on the shoulder of an off ramp. (This not the first time this has happened, however it was the first time pulling a full trailer, so I drive as if it could happen again) Vehicle was at Branhaven Jeep in Branford, CT last July @ 64429 miles... they were unable to duplicate. It is now at Gengras Jeep in East Hartford, CT, same story. I've asked Gengras to replace the ignition switch again. I have the ignition switch from Branhaven which I found the copper plate worn off to steel and evidence of arcing on the contacts

At every fuel fill up, gasoline splashes back out onto the vehicle, the person filling the vehicle and creates a very unsafe puddle of gasoline on the ground. There is never a time that it does not happen. I would be readily available to make my vehicle available for inspection of this concern. Chrysler has issued recalls for this exact problem on several of their vehicle models all within the same time period of manufacturing. The fuel tank inlet check valve is a widely known and dangerous issue that should be seriously considered to repair the remaining vehicles on the road with this problem. It has been documented by numerous owners of Jeep Wranglers from 2005-2006 while the same issue forced a recall of the same Jeeps in later model years, 2007-2008. The Jeep has been inspected by a certified mechanic where I was notified of much of this information. With the amount of gasoline that spills out and the motorist re-enters their vehicle, there could be a static charge that could ignite the gasoline and cause extreme personal harm and property damage. There is no indication or warning sign to alert you that it is going to splash out gasoline. I am left to rarely fill my fuel tank to the maximum level to avoid being soaked in gasoline and irritating my skin or worse. I have owned this Jeep for going on 4 years and it has been a concern since day 1. I am noting this report of having been injured but the injuries at this point are only skin irritations as a result of gasoline coming in contact with our skin. I also noted the date as the first time this happened but as mentioned before, it happens or will happen at every fill up.

The camshaft sensor upper bushing does not get lubricated seizes up causes camshaft to wear out. In my jeep I replaced three of them on the inline 4.0 6cyl. I only have 66,660 miles on my jeep. June 4, 2021.

ECU STOPED WORKING NO REASON.

THE PCM HAS A KNOWN HIGH FAILURE RATE DUE TO THE VIBRATION. THE COMPONENTS ARE COVERED IN A RESIN THAT YOU CAN NOT REMOVE. THE PCM IS 500-1300 TO GET A REPAIRED AND REPROGRAMED ONE. I HAVE A 2005 AND THE PCM HAS FAILED AND GIVES BAD PERFORMANCE AND DOES NOT RUN ON TEH 14.7 STOKES FOR AIR/FUEL/ IT DUMPS FUELS AND I DO NOT THINK IT MEETS EMISSON LEVELS IN THIS CONDITION.

STEERING STABILIZER GOES OUT ON AVERAGE ABOUT 20,000 TO 30,000 MILES WITH NORMAL STREET OR HIGHWAY DRIVING. STEERING WHEEL STARTS SHAKING BACK AND FORTH AND WHEELS SHAKE VIOLENTLY . I SEE JEEP IS NOW RECALLING SOME 2018-2019 JEEPS AND WOULD LIKE MINE FIXED TOO .

HOOD FLUTTER WHEN DRIVING AT HIGHWAY SPEEDS AT OR ABOVE 50MPH. HAD TO REPLACE LATCHES WITH A NEW SYSTEM TO ELIMINATE THE FLUTTER AND POSSIBILITY OF IMPENDING FAILURE.

: I AM THE OWNER OF A 2005 JEEP WRANGLER. FOR THE LAST 10+ YEARS MY ACCELERATOR HAS STUCK AT FULL THROTTLE 5-7 TIMES. EVERY TIME I HAVE TAKEN IT TO A SHOP - THEY HAVE TEST DRIVEN IT BUT NO STICKING. LAST WEDNESDAY (5/22) AT A 4 WAY STOP SIGN MY ACCELERATOR STUCK AGAIN AT FULL THROTTLE & I HIT A CAR. NO ONE WAS HURT, BUT I WAS GIVEN A CITATION WITH WITNESSES TO THE ACCELERATOR BEING STUCK. THE MAN AT THE SHOP TOLD ME HIS JEEP WRANGLER HAD A RECALL FOR THE SAME ISSUE. I CONTACTED JEEP CORPORATION & FILED A REPORT (CASE [XXX]) WITH A WORKER "ALY". SHE TOLD ME TO PARK MY JEEP AND AN INSPECTOR WOULD BE THERE TO INVESTIGATE. THAT WAS MORE THAN A WEEK AGO & 5 CALLS TO 1-877-426-5337. CAN YOU HELP ME? MY INSURANCE CO. WANTS ME TO GET ESTIMATES FOR MY DAMAGE BUT I DON'T KNOW IF I CAN DRIVE ON THE ROAD DUE TO THE ACCELERATOR STICKING & NOT BEING INSPECTED BY JEEP RECALL INSPECTORS. PLEASE HELP ME...'. (XXXX) PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT

THE VEHICLE WAS IN MOTION AND PULLING FROM MY DRIVEWAY ONTO A CITY STREET WHEN THIS HAPPENED. BOTH DRIVERS AND PASSENGER CENTER SECTIONS OF THE FRAME RUSTED FROM THE INSIDE OUT WITH NO VISIBLE INDICATION ON THE OUTSIDE OF THE FRAME RAILS. WATER AND DEBRIS ENTER THROUGH HOLES USED IN THE MANUFACTURING PROCESS AND DUE TO NO DRAIN HOLES IN ANY OF THE LOWER POINTS THE WATER AND DEBRIS ROT THE FRAME AWAY. IN MY CASE THE TRANSMISSION PAN ON THE DRIVERS SIDE OF THE VEHICLE FELL FREE WHEN THE BOTTOM OF THE FRAME RAIL ON THAT SIDE CRUMBLED WHILE ENTERING A CITY ROAD FROM A PRIVATE DRIVE AT LESS THAN 5 MPH. DAMAGE WAS DONE TO THE TRANSMISSION, TRANSFER CASE, ONE AXLE, AND THE REAR DRIVE SHAFT. THE VEHICLE WAS TOWED TO A PRIVATE GARAGE BUT THEY WERE UNABLE TO PLACE IT ON A LIFT TO INSPECT THE DAMAGE AS THE FRAME WOULD HAVE CRUMBLED AND SNAPPED IN ADDITIONAL PLACES THUS CREATING A HAZARD AND POSSIBLY DEADLY SITUATION THE TECHNICIAN INSPECTING THE DAMAGE. THE VEHICLE WAS THEN PLACED ON A FLATBED AND BROUGHT BACK TO MY HOME.

TAKATA RECALL, OIL PUMP DRIVE GEAR, PCM POWERTERRAIN CONTROL MODULE I BELIEVE NEEDS TO BE REPROGRAMMED I HAVE A FAILURE OF POWER WHILE DRIVING DOWN THE ROAD LIKE ITS GETTING TO MUCH OR TO LITTLE FUEL AND LAST WEEK MY OIL PRESSURE WILL NOT BUDGE MY GAUGES ARE SLOWLY GOING OUT ON MY DASH AND THE AIRBAG LIGHT ON DASH BLINKS RAPIDLY WITH THE CHECK GAUGES BECAUSE OF MY OLD PRESSURE I HAVE TAKEN IT TO MULTIPLE PLACES TO GET IT DIAGNOSED AND THEY SAY IT IS THE OIL PUMP DRIVE GEAR AND THE PCM NEEDING TO BE REPROGRAMMED ALONG WITH THAT BEING OUT OF LINE MY GROUND CONNECTIONS SEEM TO BE BAD BUT I REPLACE ALL OF THEM FROM THE BATTERY TO THE ENGINE BLOCK THE DASH AND A COUPLE MORE IT HAS PRESSURE BUT DOESN'T SOUND LIKE IT. ALL OF THIS STARTED HAPPENING AT ABOUT 143,000 MILES I HAVE REPLACED MULTIPLE PARTS INCLUDING THE OIL PUMP OIL SENSOR ALL OF THE GROUND WIRES AND TERMINALS AND CHECKED AS MANY RELAYS AS I CAN. ALONG WITH MY DASH WHEN I HAD GOT IT IT HAD 130,000 MILES ON AND THE AIRBAG LIGHT HAS ALWAYS BLINKED AND NOTICED A LOSS IN POWER WHEN I DRIVE SINCE I'VE HAD IT, IT RUNS THROUGH SPARK PLUGS AND COILS PACKS MONTHLY AND HAS SINCE I'VE GOTTEN IT I DROVE IT TO GEORGIA AND BACK AND IT SOUNDED LIKE IT WAS GETTING WORSE AND JUST KEPT GETTING WORSE AND WORSE UNTIL LAST WEEK MY OIL PRESSURE GAUGE SAYS I HAVE NO PRESSURE AND THE ENGINE HAS OIL PRESSURE BUT YOU CAN TELL IT'S GOING MORE AND MORE OUT OF LINE. I KNOW WHEN I LOOK UP MY VIN NUMBER IT SAYS IT'S BEEN UPDATED SINCE MARCH 14, 2019 BUT WHEN I LOG INTO ANOTHER APP IT SAYS I HAVE RECALLS I DON'T KNOW WHAT TO DO OR HOW TO FIX IT BUT IT DEFINITELY IS THE THREE RECALLS THAT WAS PUT ON THE 2005 JEEP WRANGLER TJ.

I GET A CODE THAT POPS UP AFTER BEING ON THE HIGHWAY FOR A TIME THAT SAYS SOMETHING REGARDING TRANSMISSION. ALSO THE TRANSMISSION IS SLOW TO SHIFT BETWEEN DRIVE AND REVERSE SOMETIMES AND GRINDS (AUTO TRANS). THERE HAVE BEEN MULTIPLE REPORTS OF PCM ISSUES THAT REQUIRE REBUILD OR REPLACEMENT BUT AVAILABILITY IS SCARCE. COULD BE POOR DESIGN.

MY WRANGLER HAS SEVER RUST DAMAGE ON THE FRAME, WINDSHIELD FRAME, PASSENGER ROCKER, AND FIREWALL. THE FRAME HAS ROTTED FROM THE INSIDE OUT AND CAUSED THE TRANSFER CASE MOUNTING BOLTS TO PULL THROUGH. THE VEHICLE WAS IN MOTION WHEN THIS HAPPENED BUT LUCKILY I WAS PULLING OUT OF MY DRIVEWAY AND NOT ON THE HIGHWAY HEADED TO WORK. THE WINDSHIELD FRAME RUST CAUSED HOLES THAT ALLOWED WATER TO LEAK INSIDE THE VEHICLE CAUSING THE FLOOR TO RUST FROM THE INSIDE OUT AS WELL. THESE ISSUES CONTINUE TO HAPPEN AGAIN AND AGAIN WITH EACH NEW REVISION TO THIS MODEL. WHEN AND WHAT WILL IT TAKE FOR THE COMPANY TO BE HELD ACCOUNTABLE TO THEIR NEGLIGENCE?

THE SEAT BELT IS SITUATED IN A POSITION TO WHERE IT IS REGULARLY SMASHED AGAINST THE STRIKER PLATE ON THE DOOR WHEN THE DOOR IS CLOSED. THIS BREAKS THE FIBERS IN THE BELT THEREBY WEAKENING THE BELT AND MAKING IT VERY PRONE TO BREAKING IN THE EVENT OF A FRONTAL IMPACT WHERE THE BELT WOULD BE MOST NEEDED.

WHEN REFUELING MY JEEP HAS ALWAYS BELCHED GASOLINE BACK OUT OF THE FUEL FILLER NECK WHEN THE GAS PUMP AUTOMATICALLY SHUTS OFF WHEN THE TANK GETS FULL. THIS COULD EASILY CAUSE A DISASTER & MY WIFE IS AFRAID TO PUT FUEL IN IT. I THOUGHT THAT MINE WAS THE ONLY ONE TO DO THIS, BUT TALKING WITH OTHER OWNERS, I HAVE DISCOVERED THAT ALL SIMILAR JEEPS HAVE THE SAME DANGEROUS DEFECT.

JEEP STARTED STALLING EITHER WHEN PARKED OR IN TRAFFIC. DEALERSHIP SAYS ITS THE POWERTRAIN CONTROL UNIT (PCM OR COMPUTER). TWICE ENGINE STALLED AS I WAS DRIVING. ONCE AS I WAS MAKING A TURN LUCKILY HAD ENOUGH MOMENTUM TO PULL OVER AND ANOTHER TIME GETTING READY TO PROCEED AFTER A RED LIGHT IT STALLED ALL OF A SUDDEN AND AGAIN ABLE TO PULL OVER. I HAVE FOUND MANY JEEP OWNERS WITH THIS SAME PROBLEM AND I AM AWARE JEEP IS AWARE BUT NOTHING HAS EVER BEEN DONE. STARTED MOTHERS DAY 2018 AND A FEW TIMES UP TILL JULY WHEN I JUST PARKED IT AND HAD IT TOWED TO 3 SHOPS INCLUDING DEALERSHIP.

TRANSMISSION KEPT POPPING OUT OF REVERSE AND WOULDN'T GO INTO REVERSE, HAD TO HAVE IT REPLACED.

THE POOR DESIGN OF THE GAS TANK ROLLOVER SAFETY FLOAT BALL IN THIS VEHICLE CONTINUES TO ALLOW GASOLINE TO SPLASH BACK OUT OF THE GAS FILLER NECK OF THE VEHICLE EVERY SINGLE TIME AT AN AUTO SHUT OFF FUELING NOZZLE IS USED. THIS IS A KNOWN DEFECT BUT WHICH THEY OFFERED A REMEDY THAT HAD AN AGE OR MILEAGE LIMIT. THIS IS A GROSS SAFETY HAZARD AND SHOULD WARRANTY T A RECALL BEFORE SOME ONE BLOWS UP.

005-2006 JEEP WRANGLERS ARE INCURRING AN APPARENT LARGE NUMBER OF PCM/ECU FAILURES (AS EVIDENCED IN MANY ONLINE FORUMS AND A HIGH BACKLOG OF PCM ORDERS WHICH JEEP/CHRYSLER IS UNABLE TO FILL OR PROVIDE AN ETA FOR). THE FAILURE OF THE PCM REVEALS ITSELF IN MANY WAYS INCLUDING EMISSIONS SYSTEM FAILURES (AND RESULTANT VEHICLE INSPECTION FAILURES I WILL ADD), TRANSMISSIONS FAILING TO SHIFT, HARD FORCEFUL TRANSMISSION SHIFTS WITH VEHICLE LUNGES AND MORE. ON MY VEHICLE SPECIFICALLY THE TRANSMISSION CODES ARE COMING ON AND THE VEHICLE WILL RANDOMLY NOT SHIFT OUT OF SECOND GEAR AND RANDOMLY SHIFTS TO NEUTRAL WHILE DRIVING AT HIGHWAY SPEEDS AND PRESENTS ITSELF AS A SAFETY HAZARD WHEN ENTERING HIGH SPEED FREEWAYS AND INTERSTATES. TO THE PCM AND FURTHER ONLINE INVESTIGATION INDICATES THIS A FREQUENT AND RECURRING ISSUE. WHEN I ATTEMPTED TO REPLACE THE PCM THROUGH JEEP/CHRYSLER I AM UNABLE TO BECAUSE THE PART IS BA CKLOGGED. I HAVE PLACED A PRICEY $1600 ORDER FOR THE PART BUT THUS FAR OVER 3 MONTHS MY VEHICLE HAS NOT BEEN ABLE TO OBTAIN A WORKING REPLACEMENT PART BASED ON THE LARGE NUMBER AND TYPE OF ISSUES REPORTED ONLINE WITH THIS PCM I AM LEFT WONDERING WHY IT IS NOT A SAFETY, EMISSIONS AND/OR RECALL ISSUE.

EVERY TIME I FILL THE GAS TANK FUEL SPILLS OUT THE FILLER NECK CAUSING A SIGNIFICANT FUEL SPILL. THE JEEP IS STATIONARY AND ON LEVEL GROUND AT THE GAS STATION

EVERY TIME I FILL THE VEHICLE WITH GASOLINE, WHEN THE PUMP SHUTS OFF A LARGE AMOUNT OF GASOLINE 'BURPS' OUT AND ONTO THE GROUND. THIS IS DUE TO A FAULTY CHECK VALVE INSTALLED FROM THE FACTORY THAT STOPS WORKING BECAUSE OF THE ETHANOL IN THE FUEL. JEEP HAS RECALLED LATER WRANGLERS FOR THIS SAME ISSUE BUT LEFT US 2005-2006 OWNERS STUCK WITH THE ISSUE. THIS IS A SAFETY, HEALTH, AND ENVIRONMENTAL HAZARD. I WILL BE GLAD TO SEND YOU A VIDEO OF THIS HAPPENING.

GAS TANK OVERFLOW. ANYTIME I FILL MY TANK, A LARGE AMOUNT OF GASOLINE SHOOTS BACK OUT OF THE TANK, DRIPPING DOWN THE SIDE OF MY CAR, AND OFTEN SPLASHING ME OR GAS ATTENDANT. NOT ONLY IS THIS DANGEROUS, IT IS ALSO DAMAGING THE PLASTIC AND PAINT ON MY CAR, AS WELL AS WASTING GAS.

AT 45-50 MPH THE STEERING WHEEL SHAKES VIOLENTLY. IT HAS THE "DEATH WOBBLE".

I HAVE NOTICED THAT ALMOST EVERY MANUFATURER IS RECALLING AIR BAGS FROM YEARS 2002 AND UP, I CALLED CHRYSLER AND THEY SAID THE VEHICLE IS TOO OLD AND NOT ENOUGH OF THEM ARE STILL AROUND, WHICH IS NOT TRUE. THERE ARE LOTS OF OLDER JEEPS STILL IN SERVICE AS OFF ROAD VEHICLES, BUT MINE IS A DAILY DRIVE VEHICLE. HOW DO I KNOW IF MINE WILL WORK WHEN NEEDED? KNOCK ON WOOD IT WILL NEVER BE NEEDED, BUT I WOULD LIKE TO KNOW I'M SAFE WITH MY FAMILY. MY 2005 WRANGLER IS STRONG

I BOUGHT 4 NEW TIRES FROM DISCOUNT TIRE IN JACKSONVILLE FLORIDA. THEY ARE P235/75 R15 108S XL OWL PTF PATHFINDER SPORT SAT. I PAID $100 FOR EACH TIRE ON AUGUST 22, 2015 (NOT INCLUDING COST OF INSTALLATION, LIFETIME BALANCING, ETC) AND THEY WERE SUPPOSED TO COME WITH A 60,000 MILE WARRANTY. CURRENTLY THEY HAVE LESS THAN 28,000 MILES ON THEM AND HAVE EXTREMELY IRREGULAR WEAR. I HAVE HAD NUMEROUS FLATS AND LOSS OF PRESSURE OVER THE PAST 24 MONTHS. I SPOKE TO CHARLES (THE MANAGER OF THE TIRE STORE) WHEN I WAS IN THERE WITH MY 3RD FLAT IN 2 MONTHS ON DECEMBER 4TH, 2017. I EXPRESSED MY DISPLEASURE AT HAVING SO MANY ISSUES WITH RELATIVELY NEW TIRES. CHARLES RESPONDED THAT MY TROUBLE IS BECAUSE OF THE RECENT HURRICANES...AND I SHOULD HAVE BOUGHT MICHELIN TIRES! THESE TIRES ARE EXTREMELY INFERIOR QUALITY PRODUCTS, BUT HE SAYS IT'S NORMAL WEAR FOR THESE TIRES. CAN YOU HELP?

OVER A PERIOD OF SEVERAL DAYS THE VEHICLE STARTED SHIFTING HARD AND EVENTUALLY WENT INTO "LIMP" MODE AND STARTED THROWING DIFFERENT CODES FOR VARIOUS SENSORS. AFTER MANY VISITS TO DIFFERENT MECHANICS I RESEARCHED THE PROBLEM MYSELF AND PINPOINTED THE PCM AS THE PROBLEM.

WHILE FILLING WITH FUEL, IT WILL SPIT FUEL BACK OUT AND WILL NOT FILL WITH GAS PROPERLY. HAVE TRIED GOING AS SLOW AS POSSIBLE ON THE FUEL LEVER WHILE FUELING AND WILL STILL SPIT GAS BACK OUT LIKE THERE IS A PROBLEM IN THE FUEL FILLER HOSE AND FLAP INSIDE IT.

2005-2006 JEEP WRANGLERS ARE INCURRING AN APPARENT LARGE NUMBER OF PCM/ECU FAILURES (AS EVIDENCED IN MANY ONLINE FORUMS AND A HIGH BACKLOG OF PCM ORDERS WHICH JEEP/CHRYSLER IS UNABLE TO FILL OR PROVIDE AN ETA FOR). THE FAILURE OF THE PCM REVEALS ITSELF IN MANY WAYS INCLUDING EMISSIONS SYSTEM FAILURES (AND RESULTANT VEHICLE INSPECTION FAILURES I WILL ADD), TRANSMISSIONS FAILING TO SHIFT, HARD FORCEFUL TRANSMISSION SHIFTS WITH VEHICLE LUNGES AND MORE. ON MY VEHICLE SPECIFICALLY THE O2 SENSOR CODES ARE COMING ON AND THE VEHICLE WILL RANDOMLY NOT SHIFT OUT OF SECOND GEAR WHICH PRESENTS ITSELF AS A SAFETY HAZARD WHEN ENTERING HIGH SPEED FREEWAYS AND INTERSTATES. THE O2 SENSORS WERE REPLACED NEW WITH OEM PARTS AND THE CODES DID NOT GO AWAY. THE FAULT WAS TRACED BY A REPUTABLE MECHANIC (CHRISTIAN BROTHERS AUTOMOTIVE) TO THE PCM AND FURTHER ONLINE INVESTIGATION INDICATES THIS A FREQUENT AND RECURRING ISSUE. WHEN I ATTEMPTED TO REPLACE THE PCM THROUGH JEEP/CHRYSLER I AM UNABLE TO BECAUSE THE PART IS BACKLOGGED. I HAVE PLACED A PRICEY $1600 ORDER FOR THE PART BUT THUS FAR (1 WEEK) I HAVE NOT BEEN PROVIDED WITH AN ETA OR ANY ANSWERS AS TO WHY THIS DESIGN DEFECT HAS NOT BEEN ADDRESSED. BASED ON THE LARGE NUMBER AND TYPE OF ISSUES REPORTED ONLINE WITH THIS PCM I AM LEFT WONDERING WHY IT IS NOT A SAFETY, EMISSIONS AND/OR RECALL ISSUE. MY SPECIFIC PCM PN IS R6044529AC BUT MULTIPLE VARIATIONS OF THE PN APPEAR TO BE EFFECTED.

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. WHILE PULLING INTO A PARKING SPACE, THE BRAKE PEDAL EXTENDED TO THE FLOORBOARD WHILE ATTEMPTING TO STOP THE VEHICLE. DURING THE INCIDENT, THE BRAKE SENSOR INDICATOR ILLUMINATED AND THE DRIVER HAD TO ENGAGE THE PARKING BRAKE TO STOP THE VEHICLE. UPON INSPECTION, IT WAS DISCOVERED THAT BRAKE FLUID HAD LEAKED NEAR THE REAR DRIVER'S SIDE WHEEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE REAR DRIVER'S SIDE WHEEL BRAKE CYLINDER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER AND LOCAL DEALER (BAYSIDE CHRYSLER/JEEP IN QUEENS, NY) WERE NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 151,000.

THE 2005 JEEP WRANGLER SPORT WAS A TOTAL LOSS AFTER IT CAUGHT ON FIRE AND SEVERELY DAMAGED THE ENGINE AND THE INSIDE OF THE VEHICLE. IT JUST HAD THE TRANSMISSION REPLACED THE DAY BEFORE THE INCIDENT. THE VEHICLE CONTINUED TO DEMONSTRATE TRANSMISSION ISSUES DESPITE THE NEW TRANSMISSION (INCLUDING DIFFICULTY SHIFTING AND A LOSS OF POWER WHILE GOING UPHILL). WHILE DRIVING UPHILL, THE VEHICLE'S TRANSMISSION SLIPPED AND SMOKE STARTED POURING OUT OF THE ENGINE. THE DRIVER IMMEDIATELY PUT IT IN PARK AND TURNED OFF THE ENGINE. THE DRIVER RAN FROM THE VEHICLE AND SAW THAT THERE WAS A FIRE UNDERNEATH THE CAR - NEAR THE TRANSMISSION PAN. THE ENTIRE VEHICLE WENT UP IN FLAMES WITHIN 2 MINUTES. UNFORTUNATELY, IT WAS A TOTAL LOSS BY THE TIME THE FIRE DEPARTMENT ARRIVED TO PUT OUT THE FIRE. AN INVESTIGATION WILL BE COMPLETED TO DETERMINE IF A TRANSMISSION FLUID LEAK CAUSED THE FIRE. THE JEEP WRANGLER WAS A RIGHT HAND DRIVE THAT WAS BEING USED ON THE MAIL ROUTE THE DAY THAT THE FIRE OCCURRED.

CATALYTIC CONVERTER: WAS DRIVING AND CHECK ENGINE LIGHT WENT ON, VEHICLE BEGAN 'CHUGGING' AS THOUGH NOT GETTING ENOUGH FUEL. SMELLED GASOLINE. CALLED JEEP DEALER IN FLORIDA AND WAS ADVISED TO LET ENGINE COOL, THEN DRIVE TO LOCAL DEALER SINCE IT SOUNDED AS THOUGH THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. STATED THIS AS NORMAL FOR THE MILEAGE. EMISSIONS WARRANTY VALID. (WAS STATIONED IN NAPLES, ITALY.) JEEP DEALER IN NAPLES ADVISED HE WOULD NOT HONOR ANY WARRANTY AND WOULD NOT FIX UNTIL I PAID HIM 1K EUROS. OVERSEAS MILITARY CAR SALES GOT INVOLVED AND SAID NOT TO WORRY ABOUT IT: WORK WOULD BE DONE AND COVERED BY WARRANTY. DEALER PULLED ENTIRE EMISSIONS SYSTEM OUT AND REPLACED IT, THEN REFUSED TO RELEASE VEHICLE FOR 30 DAYS UNTIL I PAID THE 1K EUROS. DEALER STATED HE DID NOT HAVE TO HONOR WARRANTY ON A US-REGISTERED VEHICLE BECAUSE FIATCHRYSLER PAID HIM LESS THAN HE COULD GET FROM ME. THREATENED TO IMPOUND VEHICLE. FIATCHRYSLER REFUSED TO ASSIST ALTHOUGH DEALER WAS NOT AUTHORIZED TO PULL/REPLACE SYSTEM UNLESS COVERED BY WARRANTY. FLORIDA DEALER AND SELLING DEALER IN WA STATE ADVISED THAT IF WE COULD HAVE GOTTEN THE VEHICLE HOME, IT WOULD HAVE BEEN A WARRANTY REPLACEMENT WITHOUT ANY PROBLEMS BECAUSE IT WAS A COMMON ISSUE AT THIS MILEAGE (53K).

2014: DASH AND REAR LIGHTS STOPPED WORKING. HAD TO REPLACE MULTI-FUNCTION SWITCH. MODULE AND WIRING MELTED AND FUSED TOGETHER. 2017: DURING INSTALL OF NEW STEREO, MECHANIC DISCOVERED MULTI-FUNCTION SWITCH AND MODULE MELTED AGAIN. REPLACED ALL WIRING WITH HEAVIER GAUGE, REPLACED ALL BULBS WITH LOWER WATTAGE LEDS. WONDERING WHEN NEXT ELECTRICAL PROBLEM WILL SURFACE.

JULY 2016 - 83,000 MI. -FAILURE OF OIL PUMP GEAR DRIVE. REPAIRED BY JEEP DEALER IN MONTROSE, CO. JUNE 2017 - 88,000 MI. - OIL PUMP GEAR DRIVE FAILED AGAIN, THIS TIME CAM SHAFT GEAR DRIVE ALSO FAILED REQUIRING A MAJOR ENGINE OVERHAUL. REPAIRED BY JEEP DEALER IN MONTROSE, CO. RESEARCHING ON INTERNET I DISCOVERED THIS IS A REOCCURRING PROBLEM WITH THIS VEHICLE. A RECALL WAS ISSUED BY JEEP/CHRYSLER FOR A LIMITED NUMBER OF VIN NUMBERS BUT THERE ARE MANY COMPLAINTS OUTSIDE OF THEIR RECALL RANGE, INCLUDING MINE. I CONTACTED CHRYSLER WARRANTY DEPT BUT THEY REFUSE TO MAKE AN EXCEPTION.

I WAS DRIVING MY JEEP TO WORK ON SUNDAY JUNE 4TH GOING APPROXIMATELY 35MPH WHEN MY CHECK ENGINE LIGHT AND CHECK GAUGES LIGHT CAME ON AND I HAD NO OIL PRESSURE AND IT WAS MAKING A HORRIBLE NOISE FROM THE ENGINE BAY SO I IMMEDIATELY SHUT THE VEHICLE OFF. AFTER DOING SOME RESEARCH I HAD FOUND THAT THERE WAS AN E05 RECALL ON 2005 AND 2006 JEEPS FOR THE CAMSHAFT SYNCHRONIZER, CAMSHAFT GEAR AND OIL PUMP DRIVE ASSEMBLY. THE RECALL COVERS ALL JEEPS WITH THE 8TH CARACTER OF THE VIN BEING LETTER S WHICH MINE IS AND THEY ALSO COVER SPECIFIC BUILD DATES AND MY JEEP FALLS 1 MONTH SHORT OF THOSE DATES BUT I AM EXPERIENCING ALL THE SAME PROBLEMS AS OTHERS. I HAD CALLED CHRYSLER AND THEY ARE MAKING A CASE FOR ME BUT SAID IT IS NOT CERTAIN THAT ANYTHING CAN BE DONE AND THAT I SHOULD FILE ON NHTSA AS WELL. I AM VERY DISSAPOINTED AS WELL BECAUSE MY 2005 JEEP WRANGLER ONLY HAS 88K MILES ON IT AND ID LIKE TO GET ALOT MORE LIFE OUT OF IT

WHEN PUTTING GAS INTO THE JEEP, THE NOZZLE DOES NOT AUTOMATICALLY SHUT OFF AND GAS OVERFLOWS OUT OF THE GAS LINE (AT THE POINT WHERE THE CAP GOES ON).

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. WHILE DRIVING, THE RPMS WOULD NOT INCREASE PAST 3,000 RPMS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE OIL PUMP DRIVE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 57,201.

WHEN THE EMERGENCY/ PARKING BRAKE IS ON THE CAR WILL STILL ROLL. VERY DANGEROUS FOR ANYONE NEAR IT . CANNOT PARK ON ANY HILL AND MUST ALWAYS PARK ON FLAT SURFACES OR THE JEEP WILL ROLL DOWN THE HILL. THIS IS HOW IT HAS BEEN AN ONGOING PROBLEM SINCE I GOT THE JEEP INTO 2005. ALMOST RAN OVER ONE OF MY KIDS THE OTHER DAY BECAUSE OF THIS.

WHEN FILLING UP THE GAS TANK, GASOLINE ROUTINELY BACK FLOWS AS IT GETS FULL. THIS CAUSES GASOLINE TO SPILL OVER THE FUEL FILLER DOOR AND DOWN THE SIDE OF THE VEHICLE. I HAVE HAD THE VEHICLE FOR THREE YEARS AND SINCE 51K MILES WERE ON IT. THIS ALWAYS HAPPENS WHEN REFUELING.

THIS SPECIFIC PART WAS RECALLED ELEVEN OR SO YEARS AGO. SINCE THAT TIME, THE SAME PART HAS BEEN REPLACED 6 TIMES. ONE TIME REQUIRING A TOTAL ENGINE OVERHAUL. UPON RESEARCHING THIS PART, I HAVE FOUND THAT THERE ARE MANY COMPLAINTS WITH THE FAILURE OF THIS SAME MODEL YEAR OF JEEP WRANGLERS AND THIS PART (OIL PUMP DRIVE). WE HAVE POURED OVER $5000 INTO THIS VEHICLE DUE TO THIS PART AND WE STILL HAVE A VEHICLE THAT DOES NOT RUN. I HAVE CALLED JEEP THREE TIMES NOW AND THEY HAVE NO ADVICE FOR ME OR OFFER OF ASSISTANCE FOR THIS PART. ENGINE LOCKED UP WHILE DRIVING DOWN THE HIGHWAY. *TR

THIS IS AN UPDATE TO NHTSA COMPLAINT 10919986 - DEATH WOBBLE, I HAVE REPLACED THE STOCK STEERING DAMPER AND ADDED AN ADDITIONAL STEERING DAMPER FOR THE DRIVER SIDE STEERING ROD. THIS HAS RESOLVED THE REPORTED DEATH WOBBLE WHEN DRIVING OVER 50 MPH. ROD DEFLECTION HAS BEEN PREVENTED BY ADDING THE DRIVER SIDE DAMPER. PLEASE MAKE THIS AVAILABLE AS A SOLUTION. I SEE MANY PEOPLE HAVE SPENT WELL OVER $1,000 FOR NEW SUSPENSION PARTS ETC. THIS IS A $60 STEERING DAMPER SHOCK FIX!! PLEASE PASS ALONG. I SHOCKED THIS IS NOT OBVIOUS AT THE DEALER, THE DRIVER STEERING ROD IS LONG AND WILL HAVE DEFLECTION AT HIGH SPEED/BUMPS, LIKE A TUNING FORK. *TR

THIS IS AN UPDATE TO NHTSA COMPLAINT 10919983 - REGARDING CHRYLSER E05 CAMPAIGN CAMSHAFT REPLACEMENT - I STILL NEED A NEW CAMSHAFT BUT HAVE PERFORMED A TEMPORARY FIX IN REPLACING THE OPDA. THE NEW GEAR ON THE OPDA HAS PREVENTED ENOUGH WEAR GAP FOR THE ENGINE TO NOT GO INTO LIMP MODE AND WILL START IMMEDIATELY WHEN TEMPS ARE UNDER 40 DEGREES F. I STILL NEED A NEW CAMSHAFT TO COMPLETE THIS FIX. I MAY TRY THE CHRYSLER CUSTOMER SERVICE TO RESOLVE, BUT THE E05 RECALL DOES NOT COVER MY MANUFACTURE DATE AND THE CAMPAIGN HAS BEEN CLOSED. I AM STUCK WITH A USED LEMON! BUYER BEWARE OF THIS MODEL YEAR, THERE IS A CAMSHAFT GEAR ISSUE THAT WILL PREVENT ENGINE TIMING TO RUN CORRECTLY AND ABILITY TO PASS EMISSIONS! CODES P340 AND P344 PLUS ENGINE WILL NOT REV BEYOND 2500RPM (LIMP MODE) ARE THE TELL TALE SIGNS. A NEW OPDA IS WORTH A TRY TEMPORARY FIX $80. BUT DO NOT BUY THIS YEAR OR 2004, 2006 WITHOUT CHECKING IF CAMSHAFT HAS BEEN REPLACED, OR PLAN ON DOING SOME MAJOR ENGINE WORK/ENGINE REBUILD.

GAS OVERFLOWS AND SPILLS OUT OF VEHICLE WHEN FUELING.

ENGINE CODES P0340 AND P0344 CHRYSLER CAMPAIGN E05 REPLACE OPDA AND CAMSHAFT - MY MANUFACTURE DATE IS JUNE 2005, THERE IS 113K ON THE ENGINE, WHEN THE WEATHER IS COLD (40 F OR BELOW) THE ENGINE HAS LONG START ISSUES, THERE IS PLAY IN THE OPDA ENOUGH TO PUT THE ENGINE IN LIMP MODE NOT REVVING PAST 2500RPM. FOR SURE THIS NEEDS A NEW CAMSHAFT AND NEW OPDA, BOTH GEARS ARE WORN. THE CHRYSLER CAMPAIGN ONLY COVER UP TO A FEB 2005 MANUFACTURE. THIS SHOULD BE CONSIDERED FOR ADDITIONAL MANUFACTURE DATES WITH MULTIPLE COMPLAINTS ON NHTSA ABOUT THIS ISSUE.

JEEP DEATH WOBBLE - MINE TOO, OVER 50 MPH, RANDOM WOBBLE OTHER TIMES DRIVES SMOOTH, BUMPS DO INITIATE IT NOT ALWAYS THOUGH, READ ALL THE COMPLAINTS ON NHTSA, STABILIZER IS KEY TO RESOLVING THE ISSUE AND STEERING DAMPER. I BELIEVE THIS DESIGN PROMOTES ACCELERATED WEAR OF THESE PARTS WHICH IS WHY THERE ARE REPORTS OF IT COMING BACK AFTER A YEAR OR SO. I'M SURPRISED THERE IS NO DEALER FIX FOR THIS, ADMITTING THE NEED FOR HEAVIER STEERING COMPONENTS. I'LL BE GETTING AFTER MARKET HEAVY DUTY JUST TO DRIVE ON THE STREET. THE FUEL ISSUE IS ANOTHER ONE THAT SHOULD BE RECALLED, HAD TO GO THROUGH 300 PLUS ENTRIES HERE TO FIND ANSWERS TO THE OPDA PROBLEM. MINE HAS NOT STARTED WITH THE FUEL ISSUE BUT AT LEAST I WILL KNOW WHAT IT IS WHEN IT DOES OCCUR.

JEEP HAS SEVERE DEATH WOBBLE WHEN TRAVELING @60 MPH. FRONT WHEELS WILL START TO VIBRATE VIOLENTLY AT THIS SPEED AND SEEMS TO START WHEN HITTING A BUMP OR IMPERFECTION IN ROAD SURFACE. REQUIRED ACTION IS TO APPLY BRAKES UNTIL SHAKING STOPS WHICH COULD INVOLVE A DECREASE IN SPEED OF 15 MPH OR MORE CREATING A DANGEROUS SITUATION ESPECIALLY IN HEAVY TRAFFIC. I HAVE HAD VEHICLE INSPECTED AT THREE SHOPS WITH NO WORN COMPONENTS FOUND. HAD AN ALIGNMENT PERFORMED TIRES BALANCED TRACK BAR MOUNT REPLACED CONTROL ARM MOUNT REINFORCED REPLACED STEERING STABILIZER REPLACED TIE ROD END REPLACED SWAY BAR LINKS AND STILL PROBLEM IS NO BETTER. JEEP ONLY HAS 49,000 MILES SO NOTHING IS REALLY WORN TOO BAD. THIS PROBLEM STARTED ROUGHLY 10,000 MILES AGO AND I AM NOT SURE WHAT TO DO NEXT OTHER THAN REPLACING EVERY STEERING AND SUSPENSION COMPONENT AT A COST OF PROBABLY A COST OF THOUSANDS OF DOLLARS. FROM WHAT I HAVE READ THIS IS A COMMON PROBLEM WITH THE COIL SPRUNG JEEPS WITH A TRACK BAR WHICH SEEMS TO BE A DESIGN FLAW. JUST WANT TO ADD THE VEHICLE IS A SAFETY HAZARD DUE TO THE FACT YOU NEVER KNOW WHEN THE WOBBLE WILL START AND IF YOU ARE IN HEAVY TRAFFIC AND ALL OF A SUDDEN YOU HAVE TO SLAM ON THE BRAKES TO REGAIN CONTROL OF YOUR VEHICLE IT COULD BE A VERY DANGEROUS SITUATION. CHRYSLER/JEEP NEEDS TO REMEDY THIS ENGINEERING FLAW NOT EXPECT CONSUMERS TO FOOT THE BILL.

WHEN HAVING TO FILL UP ON GAS IT IS OVERFLOWING. EVEN IF YOU SET THE CONTROL ON THE PUMP, WHEN YOU PULL OUT THE NOZZLE, GAS IS SPILLING ALL OVER THE JEEP, FLOOR AND HAS EVEN HAS SPILLED ALL OVER MYSELF. THIS FULL TANK NEEDS TO BE RECALLED FOR THE SAFETY OF ALL CONSUMERS.

TL* THE CONTACT OWNED A 2005 JEEP WRANGLER. WHILE DRIVING VARIOUS SPEEDS, THE FRONT DRIVER SIDE WHEEL FRACTURED AND THE DRIVER LOST CONTROL OF THE VEHICLE. THE DRIVER CRASHED INTO A CULVERT. THE VEHICLE ROLLED OVER AND LANDED ON ITS ROOF IN A DITCH. THE DRIVER SIDE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE DRIVER SUSTAINED FATAL INJURIES TO THE HEAD. THE PASSENGER WAS ALSO FATALLY INJURED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED AND TOWED. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE. ...UPDATED 10/19/16 *BF .. ..UPDATED 03/31/17 *BF ...UPDATED 04/11/17 *BF UPDATED 08/08/2017*JS UPDATED 09/19/2017*JS *TR

AS THE FUEL TANK IS BEING FILLED WITH FUEL AND THE FUEL PUMP CUTS OFF WHEN THE TANK IS FULL, THE TANK ALLOWS A SIGNIFICANT AMOUNT OF FUEL TO BE "BURPED" OUT OF THE FUEL FILLER ONTO THE VEHICLE, GROUND, AND THE PERSON FILLING THE VEHICLE. THIS OCCURS EVERY TIME THE TANK IS FILLED AT EVERY FUEL DEPOT.

'DEATH WOBBLE" THE JEEP SHAKES UNCONTROLLABLY BETWEEN 50 AND 55 MPH MAKING SPEED AND STEERING VERY HARD TO CONTROL. NO ONE SEEMS TO KNOW WHAT CAUSES IT. BEEN TO MANY JEEP MECHANICS.

WHEN FILLING FUEL TANK, FUEL COMES OUT WITHOUT WARNING AND SPILLS ALL OVER THE GROUND AND THE VEHICLE. WHEN ADJACENT TO A HOT BRAKE CALIPER, THIS COULD CREATE A FIRE HAZARD. ABOUT A PINT OF FUEL IS SPILLED WITH EVERY FILL-UP. IF THE OPERATOR TRIES TO LISTEN FOR THE FUEL TO COME UP THE FILLER TO STOP, THERE IS A SPLASH AND EYE HAZARD.

WAS CROSSING A BUSY 4-LANE ST RT WHEN THE THROTTLE CABLE CAME APART AND PROPULSION WAS LOST. NEARLY GOT T-BONED BY ONCOMING TRAFFIC. A MULTI-CAR PILEUP WAS NARROWLY AVERTED. VEHICLE HAS ONLY 85,000 MILES. THROTTLE CABLE FRAYED JUST INSIDE THE FIREWALL IN THE PASSENGER COMPARTMENT. IT HAS NO HISTORY OF ACCIDENTS OR REPAIRS ON THIS ASSEMBLY. NO WARNING. VERY SCARY EXPERIENCE. STRANDED IN THE MIDDLE OF THE ROAD, PERPENDICULAR TO TRAFFIC.

ALSO FUEL TANK OVERFLOW SHUTOFF VALVE DOES NOT WORK. WHEN FILLING UP GAS TANK, FUEL OVERFLOWS ON CAR AND PERSON PUMPING GAS EVERY TIME THE TANK IS FILLED. MULTIPLE YEARS OF JEEP WRANGLERS WERE RECALLED, INCLUDING MANY 05'S FOR THIS SAME PROBLEM.

VEHICLE WILL NOT SHIFT INTO 3RD GEAR. THIS STARTED WHILE DRIVING THE VEHICLE IN TOWN AND NOW ONLY RUNS IN 1ST AND 2ND GEAR. DIAGNOSTIC CODE P0765 (SHIFT SOLENOID D) IS THE ONLY CODE SHOWING. OTHER (03-05) JEEPS WERE RECALLED FOR THE SAME PROBLEM.

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. WHILE PUMPING FUEL INTO THE VEHICLE, FUEL SPEWED OUT. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ROLLOVER CHECK VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 54,000. THE VIN WAS UNKNOWN.

WHEN FILLING FUEL WILL NOT SHUT OFF CAUSING FUEL OVERFLOW, WHICH SHOOTS OUT OF FUEL FILLER HOSE.

WHILE IN MOTION ON A COUNTRY ROAD, COMMING OUT OF SOME TURNS THE FRONT END/STEARING SUDDENLY BEGAN SHAKING HARD RENDERING THE VEHICLE UNABLE TO CONTROL. THE VEHICLE THEN BEGAN TO SWERVE UNTIL HITTING AN ENBANKMENT AND ROLLING MULTIPLE TIMES.

WHEN YOU FILL THE TANK WITH GAS, THE PUMP DOESN'T SHUT OFF RESULTING IN GAS LEAKING ONTO THE SIDE OF THE VEHICLE AS WELL AS THE GROUND. IT LOOKS LIKE THERE HAVE BEEN MULTIPLE COMPLAINTS ABOUT THIS PROBLEM FROM OTHERS THAT HAVE THIS SAME VEHICLE. IMAGE READ IT IS A FAULTY DESIGN AND FAULTY IVC .

FUEL SPILLS/SPRAYS OUT OF FILLER WHEN REFUELING. PUMP SHUT-OFF DOES NOT ENGAGE CORRECTLY. THIS HAPPENS EVERY TIME VEHICLE IS REFUELED AND RESULTS IN EXCESS FUEL SPILLAGE ON VEHICLE AND GROUND.

GAS OVERFLOWS WHEN FILLING GAS TANK. WHEN AUTO FILL LEVER IS ENGAGED AND TANK IS FULL GAS BURPS AND OVERFLOWS SPILLING ON GROUND

LIKE ALL THE OTHER JEEP WRANGLERS MINE CANNOT FILL UP WITH GAS WITHOUT THE GAS OVERFLOWING OUT OF THE FILLER NECK. THIS CAUSES POLLUTION, DAMAGES THE FINISH OF THE CAR AS WELL AS A MAJOR SAFETY ISSUE. PLEASE MAKE THEM RECALL THIS GAS ISSUE AS THE FLAPPER IN THE LINE GETS STUCK OPEN. AT LEAST THAT IS WHAT ALL THE FORUMS SEEM TO SAY. IF YOU WANT TO SEE WHAT IT LOOKS LIKE JUST GO TO YOUTUBE --> HTTPS://WWW.YOUTUBE.COM/RESULTS?SEARCH_QUERY=JEEP+WRANGLER+GAS+OVERFLOW OR PUT IN ANY OTHER SIMILAR SEARCH. THE MAJORITY OF THE JEEPS ON THE ROAD HAVE THIS ISSUE.

WHEN REFUELING THE PUMP DOES NOT SHUT OFF BEFORE GAS SPILLS OUT OF THE FUEL INLET.

WHEN FUELING UP AND THE HAND PUMP CLICKS OFF, GAS CONTINUES TO SHOOT OUT OF THE FUEL TANK. ITS ENOUGH TO LEAVE A SMALL PUDDLE ON THE GROUND NOT TO MENTION ALL OVER THE REAR OF MY JEEP AND IT HAS STAINED MY NEW FENDER FLARE. I UNDERSTAND THIS HAS BEEN AN ONGOING PROBLEM WITH JEEP WRANGLERS.

WHEN FUELING VEHICLE TANK OVERFLOWS LEAVING GASOLINE ON SIDE OF VEHICLE, ON SELF (HANDS, CLOTHING, SHOES, ETC.). NOT ONLY IS THIS UNECONOMICAL, BUT UNSAFE, UNHEALTHY, AND ENVIRONMENTALLY UNSOUND. I ORIGINALLY BROUGHT MY VEHICLE IN FOR REPAIR IN MAY OF 2010, THE DEALER CLAIMED THE EVAPORATION CANISTER WAS CLOGGED SO THEY REPLACED THE CANISTER AND FILTER FOR ALMOST $300. FOUR MONTHS LATER, IN OCTOBER OF 2010, I WAS HAVING THE EXACT SAME PROBLEM AND RETURNED TO THE DEALER. THEY THEN CLAIMED THE ROLL OVER VALVE WAS STUCK IN THE OPEN POSITION AND I NOW NEEDED A NEW FUEL TANK FOR ALMOST $800. I DECLINED AND WAS CHARGED $100 FOR THEIR TROUBLE. I NOW DON'T EVER FILL THE TANK COMPLETELY. I HAVE FOUND NUMEROUS COMPLAINTS ABOUT THIS PROBLEM ONLINE IN DIFFERENT FORUMS AND NOW HERE ON THIS WEBSITE. I DO BELIEVE JEEP NEEDS TO BE HELD RESPONSIBLE FOR THIS OBVIOUSLY ONGOING PROBLEM.

WHEN FILLING THE VEHICLE WITH GAS IT DOES NOT AUTOMATICALLY STOP FILLING WHEN THE TANK IS FULL, WHICH RESULTS IN GAS SQUIRTING OUT OF THE FILLER. THIS HAPPENS EVERY TIME I GET GAS. GETTING GAS ON MYSELF, MY CLOTHES, MY SHOES AND DOWN THE SIDE OF MY VEHICLE IS NOT ON MY TO DO LIST. JEEP/CHRYSLER SHOULD ISSUE A RECALL OR NOTICE TO FIX THIS ISSUE. THIS ISSUE IS A FIRE HAZARD AND IS NOT SAFE FOR WHOMEVER IS PUMPING GAS.

WHEN FILLING UP THE FUEL TANK THE BACK FLOW PREVENTER DOES NOT WORK AND UP TO A CUP OF GASOLINE WILL SPILL OUT OF THE NOZZLE LEAVING A FLAMMABLE MESS THAT NEEDS TO BE CLEANED.

EVERYTIME, WHILE FILLING MY TANK FUEL WILL SPILL OUT AS THE AUTO SHUT OFF ENGAGES ON THE PUMP. FUEL WILL SPILL OUT ONTO THE GROUND, MY CLOTHES, MY HANDS AND THE SIDE OF MY JEEP. I AM NOT ATTEMPTING TO TOP OFF MY TANK WHEN THE ISSUE OCCURS, IT HAPPENS EVERY TIME I FILL MY TANK HOWEVER I HOLD THE HANDLE WHEN THE AUTO SHUT OFF ENGAGES.

REGARDING MY 2005 JEEP WRANGLER, THIS HAS BEEN AN ONGOING ISSUE FOR THE PAST TWO YEARS OR MORE. FUEL SYSTEM/TANK OVERFLOWS WHEN ATTEMPTING TO FILL THE TANK. INSTEAD OF STOPPING, GAS SPEWS FROM THE FILL VALVE ONTO THE VEHICLE, GROUND, AND PERSON FILLING THE TANK. THIS IS NOT ONLY UNSAFE AND UNECONOMICAL, BUT BAD FOR THE ENVIRONMENT AND ONES HEALTH.

TL* THE CONTACT OWNED A 2005 JEEP WRANGLER. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 65 MPH, SMOKE EMITTED FROM UNDERNEATH THE VEHICLE. THE VEHICLE WAS MANEUVERED TO THE SIDE OF THE ROAD, WHERE THE ENGINE WAS TURNED OFF AND THEN THE FRONT END AND UNDERNEATH THE VEHICLE IGNITED INTO FLAMES. THE CONTACT EXITED THE VEHICLE SAFELY AND NOTICED THAT THE TRANSMISSION FLUID LEAKED ONTO THE GROUND. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES AND INFORMED THE FIRE ORIGINATED WITHIN THE TRANSMISSION. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED AND TOWED TO AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

SO WAS DRIVING MY JEEP WHEN I STOPED LOST ALL OIL PRESSURE DROPPED TO 0 PRESSURE WHEN ACCERLERATED OIL PRESSURE WENT BACK BUT CONTINUES TO DROP TO 0 WHEN STOPPED I HAVE REPLACE THE OIL PRESSURE SWITCH WITH NO CHANGE .I HAVE RESEARCHED ONLINE AND THIS SEEMS TO BE A PROBLEM WITH MOST 2005 HEEP WRANGLERS SO MY QUESTION IS IS WHEN IS ENOUGH /ENOUGH WHEN ARE YOU GOING TO RECALL AND DO THE RIGHT THING?

UNLESS I STOP FUELING PRIOR TO A COMPLETE FILL UP, GAS WILL SPILL OUT. I HAVE MENTIONED THIS TO A COUPLE DIFFERENT JEEP SERVICE ADVISORS AT MY LOCAL DEALERSHIPS THEY ARE NOT AWARE OF WHAT IS CAUSING IT. THIS CAN BE EXTREMELY DANGEROUS AND NEEDS TO BE ADDRESSED BY CHRYSLER.

MY JEEP STARTED MAKING A VERY LOUD NOISE WHEN DRIVING. THE MORE GAS I GAVE IT THE LOUDER IT GOT AND NOW IT IS UN DRIVABLE DUE TO A DISTRIBUTOR OIL PUMP. BIGGEST PROBLEM IS ALL THE JEEP PARTS PEOPLE HAD NO IDEA WHAT THE PART IT WAS AND NOW THEY DO NOT HAVE ANY IN THE SYSTEM NOR CAN THEY TELL ME WHEN THEY CAN HAVE ME ONE. THERE IS A LOT OF COMPLAINTS REGARDING THIS, STAND UP AND DO RIGHT FOR US JEEPERS!

FUEL DUMPS OUT OF FILLER HOSE WHEN CLOSE TO FILLED UP, HAS BEEN HAPPENING SINCE I FIRST FILLED ,NOW ALMOST 5 YEARS HAVE STILL SEEN NO SOLUTION UNLESS I HAVE DO MYSELF. *TR

WHEN FUELING VEHICLE, FUEL WILL SPLASH OUT OF THE FILL TUBE BEFORE FILLER NOZZLE SHUTS OFF. THIS HAPPENS EVERY TIME I FUEL AND AT DIFFERENT GAS STATIONS. I ESTIMATE MY TOTAL FUEL SPILLED OVER THE PAST DECADE TO BE IN THE AREA OF 300 GALLONS. *TR

EVERY TIME I FILL UP WITH GAS, IT OVER FLOW SPRAYING GAS OUT CREATING A SAFETY AND ECOLOGICAL HAZARD. *TR

THE DEATH WOBBLE AT APPROX 60-65 MPH/ REPAIRED STEERING STABILIZER/FRONT AXEL JOINT/ RIGHT OUTER PITMAN ADJUSTMENT SLEEVE/ LEFT HAND STEERING ARM TO CONNECTING TIE ROD/ LEFT INNER TO LH ADJUSTMENT SLEEVE/ ALIGNMENT, REPAIRS COST $675, HAVE BEEN ON THE HIGHWAY AND STILL SHIMMIES. *TR

THE GAS TANK WILL OVERFLOW WHEN FUELING THE VEHICLE. *TR

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. WHILE DRIVING APPROXIMATELY 35 MPH AND DRIVING OVER A BUMP, THE FRONT TWO WHEELS STARTED TO SHAKE UNCONTROLLABLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SWAY BAR NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE PERSISTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.

VIOLENT FRONT END VIBRATION / WOBBLING KNOWN AS "DEATH WOBBLE". *TR

AT ANY REFUELING, BEFORE THE FUEL PUMP AUTO SHUT OFF IS ENGAGED, THERE IS FUEL SPIT BACK OUT OF THE FUEL FILLER. IT RUNS DOWN THE CORNER PANEL AND BEHIND THE LEFT REAR FENDER FLARE, AS WELL AS ONTO THE GROUND. DEPENDING ON WHAT SETTING YOU HAVE THE PUMP HANDLE SET TO (HIGH, MEDIUM, LOW), DEPENDS ON HOW MUCH FUEL IS SPAT BACK OUT. *TR

WHEN FILLING UP, EVEN ON THE LOWEST SETTING, THE AUTO SHUT-OFF DOESN'T OCCUR AND GASOLINE SPRAYS OUT. *JS

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE CONTACT STATED THAT FUEL WOULD SPILL FROM THE TANK EACH TIME THE VEHICLE WAS RE-FUELED. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. IT WAS DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 28,000.

FUEL FILLER SHUT OF FLAP DOES NOT SHUT OFF FUEL FILLER RESULTING IN GAS SPILLING OUT OF VEHICAL ON TO THE GROUND. *TR

SINCE PURCHASE IN NOVEMBER, THIS VEHICLE HAS ALWAYS SHOT FUEL OUT OF THE FUEL FILLER WHEN IT REACHES A FULL TANK. THE GAS PUMP WILL SHUT OFF, BUT NEVER BEFORE IT HAS EXPELLED FUEL ONTO ME PERSONALLY, MY SHOES, THE GROUND, THE FILLER CAP (WHICH IS ATTACHED TO THE VEHICLE BY TETHER), AND DOWN THE BODY PANEL BELOW THE FILLER. THIS IS A SERIOUS FIRE AND HEALTH HAZARD FOR MYSELF AND OTHER PATRONS OF THE FUEL STATION. *TR

THE EVAPORATED SYSTEM IN THE JEEP IN TURNING ENGINE LIGHT AND WILL NOT PASS SAFETY AND EMISSIONS WITHOUT FIXING IT. WE HAVE A NEW FUEL CAP AND HAVE ALSO CHECKED THE CONSOLE AND IT STILL TURNS ON HEARD THIS WAS A KNOWN ISSUE BUT NO RECALLS FOR IT. *TR

WHEN FILLING UP THE 2005 JEEP WRANGLER RUBICON WITH GASOLINE, THE TANK OVERFLOWS AT THE FILLING POINT EVERY TIME, BEFORE THE PUMP SHUTS OFF. IT HAPPENS AT EVERY STATION, EVERY TIME. IT IS NOT OPERATOR ERROR. *JS

DURING FILL UP, GAS OVERFLOWED CAUSING DANGEROUS FIRE HAZARD. SEE VIDEO HTTP://YOUTU.BE/4ROFZV8Z1EW. *TR

EVERY FILL UP THE FUEL SPLASHES BACK OUT OF THE FILL TUBE, SPILLING ABOUT A CUP OF FUEL DOWN THE SIDE OF THE VEHICLE AND ONTO THE GROUND.THIS HAPPENS REGARDLESS OF THE FILL RATE. I HAVE LOOKED THE FUEL SYSTEM OVER TO THE BEST OF MY ABILITY, AND CAN'T COME UP WITH THE CAUSE. *TR

THE BUSHING THAT ATTACHES THE TRANSMISSION SHIFTER LINKAGE CABLE BROKE AND THE TRANSMISSION WAS RENDERED INOPERABLE. THIS SITUATION HAS HUNDREDS OF INCIDENTS DETAILED ON THE INTERNET AND JEEP SHOULD BE FORCED TO RECALL THE EFFECTED VEHICLES SINCE THIS IS OBVIOUSLY A DEFECTIVE DESIGN AND MANUFACTURER PART. CHRYSLER/JEEP IS BEING DISHONEST WITH CONSUMERS BY SAYING THEY HAVE NOT HEARD OF THE PROBLEM, YET THE PARTS MANAGER AT MY DEALERSHIP TOLD ME THIS IS A WELL DOCUMENTED ISSUE AND JEEP IS AWARE OF THE PROBLEM. ALSO ASSOCIATED WITH THIS ISSUE, IS THE DEFECTIVE SHIFTER TUBE SLEEVE NYLON INSERT THAT CRACKS. THIS IS ALSO WELL DOCUMENTED ON THE JEEP FORUMS. JEEP IS AWARE THAT BOTH PARTS ARE DEFECTIVE AND THEY SHOULD BE FORCED TO FIX THE PROBLEM FREE OF CHARGE FOR OWNERS. PLEASE HELP! *TR

WHEN FILLING UP WITH GAS AT CALIFORNIA PUMPS, THE NOZZLE KEEPS SHUTTING OFF. IT DOESN'T SEEM TO MATTER HOW FAST OR SLOW I TRY TO FILL, WHAT ANGLE I TURN THE NOZZLE, OR HOW DEEP I ENTER THE NOZZLE, IT KEEPS SHUTTING OFF. IT TAKES ABOUT 15 MINUTES TO FILL THE TANK, A FEW SECONDS AT A TIME. *JS

JUST PURCHASED THIS USED JEEP WRANGLER UNLIMITED RUBICON ABOUT 2 1/2 MONTHS AGO AND EVERYTIME I FILL THE GAS TANK, FUEL PUKES BACK OUT THE FILLER OPENING AND RUNS DOWN THE SIDE ALL OVER THE GROUND BEFORE THE GAS PUMP CAN SHUT OFF. SEEMS REALLY DANGEROUS NOT TO MENTION MAKING A BIG, EMBARRASSING MESS. IT DOES NOT MATTER WHERE I REFUEL, HAPPENS AT ALL GAS STATIONS. *TR

EVERY TIME I FILL MY GAS TANK, THE FUEL "BURPS" BACK AND ANYWHERE FROM ONE TO TWO QUARTS OF GAS IS SPILLED. *TR

I OWN A 2005 JEEP WRANGLER UNLIMITED (LJ) THAT I PURCHASED IN MARCH OF THIS YEAR. FROM DAY 1, LIKE MANY OTHERS, WHEN I FILL THE VEHICLE'S FUEL TANK, THE PUMP WILL NOT SHUT OFF, CAUSING FUEL TO SPRAY / SPILL OUT AND RUN DOWN THE BODY ONTO THE GROUND. THIS IS OBVIOUSLY A FIRE AND ENVIRONMENTAL HAZARD AND NEEDS TO BE CHECKED INTO. DON'T EVEN GET ME STARTED ON THE DEATH WOBBLE. *TR

WHEN PUTTING GAS IN FUEL TANK IN JEEP WHEN FILLING UP TO FULL MARK GAS COMES OUT OF SPOUT AND RUNS DOWN THE SIDE OF JEEP. THIS HAPPENS EVERY TIME THE JEEP IS FILLED UP. AT ANY GAS STATION. *TR

DURING FILL UP OF THE FUEL TANK, FUEL SPRAYS OUT OF THE FILLER HOLE RESULTING IN A HEATH HAZARD, FIRE HAZARD, & ENVIRONMENTAL HAZARD. THIS NEEDS TO BE ADDRESSED! *TR

FUEL OVER FLOWS WHEN FUELING THE VEHICLE AT GAS STATION FUEL BLOWS OUT OF THE TANK ALL OVER THE GROUND.. THIS IS A ENVIRONMENTAL ISSUE.. AND FIRE HAZARD. *TR

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE CONTACT STATED THAT ALL FOUR TIRE PRESSURE SENSOR VALVE STEMS WERE CRACKED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT ALL FOUR TIRES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 22,000.

GAS OVERFLOWS DURING FILLUP. *TR

FOG LIGHTS WOULD NOT SHUT OFF, HAD TO PULL FUSE. MECHANIC FOUND LEFT SIDE MULTI FUNCTION SWITCH HAD AN INTERNAL DEFECT AND THE CONNECTOR WAS MELTED AT THE SWITCH. BOTH THE SWITCH AND THE CONNECTOR HAD TO BE REPLACED. CONCERNED THAT THIS A POTENTIAL FIRE HAZARD. *TR

WHEN FILLING UP THE TANK, THE SHUTOFF DOES NOT WORK AT ANY GAS STATION. THE FUEL SHOOTS OUT OF THE TANK. THIS IS HIGHLY DANGEROUS AND RESULTS IN ME NOT BEING ABLE TO FILL UP MY VEHICLE. IN ADDITION, I WORRY THAT THE SHUTOFF WOULD NOT WORK IN CASE OF ROLLOVER. *TR

I'VE ENCOUNTERED THE TERM OF THE DEATH WOBBLE IN THE JEEP I PURCHASED. I WAS WONDERING IF THERE IS SOME KIND OF RECALL ON THESE TYPES OF VEHICLES. I RECENTLY PURCHASED THE JEEP AND HAVEN'T DRIVEN IT MUCH. TRYING TO FIX PROBLEMS BUT IT WILL BE EXPENSIVE. *TR

HAPPENS PERIODICALLY, NO FOREWARNINGS JUST HAPPENS, ALWAYS WHEN GOING SLOW OR REVERSING LIKE TO PARK OR BACK INTO PARKING SPOT.....UNINTENDED ACCELERATION....SCARES THE BEJEBERS OUT OF THE PERSON DRIVING, SINCE YOU NEVER KNOW WHEN IT'S GONNA HAPPEN.....I BOUGHT THE JEEP USED (LIKE MAYBE A YEAR OLD) WITH 14,--- MILES ON IT...NOW HAVE ABOUT 52,--- MILES ON IT....ALL STREET DRIVING, NO OFF ROAD DRIVING..HAS HAPPENED FROM THE BEGINNING WHEN I BOUGHT IT... *TR

TURNED MY JEEP ON AND THE CHECK ENGINE LIGHT, SENTRY KEY LIGHT, FUEL LIGHT CAME ON AND FUEL GAUGE WENT TO 0, JEEP RAN FOR APPROX 30SEC AND SHUT OFF. FUSES WERE CHECKED, NOTHING FOUND OUT OF PLACE. TRIED IT AGAIN, SAME THING HAPPENED. WAS TOWED TO DEALERSHIP TO CHECK AND FIX. WAS INFORMED THAT THE MAIN WIRING HARNESS NEAR AN O2 SENSOR WAS "FRIED" AND THAT WIRES WERE FUSED AND MELTED TOGETHER. GRANTED, MY JEEP IS 9 YEARS OLD, BUT THIS IS A DESIGN ISSUE, NOT A WEAR AND TEAR ISSUE. WHY WOULD WIRING BE PLACED CLOSE ENOUGH TO A HEAT SOURCE TO WHERE IT'S ABLE TO CATCH FIRE AND FUSE TOGETHER? *TR

TL * THE CONTACT OWNS A 2005 JEEP WRANGLER. WHILE DRIVING BETWEEN 50-65 MPH, THE ENTIRE FRONT END OF THE VEHICLE BEGAN TO MOVE UP AND DOWN UNCONTROLLABLY. THE CONTACT HAD TO DEPRESS THE BRAKE PEDAL IN ORDER FOR THE FAILURE TO CEASE. THE FAILURE OCCURRED MULTIPLE TIMES. AN INDEPENDENT MECHANIC SPECULATED THAT THE STEERING STABILIZER, BALL JOINTS, BRAKES, OR CONTROL ARMS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 79,000.

WHEN FILLING GAS IN NJ THE GAS ALMOST ALWAYS SPITS OUT BEFORE THE TANK IS FULL. SINCE THIS IS NJ, BY LAW THIS HAS FULL SERVICE, SO THESE ARE PROFESSIONALS THAT ARE FILLING THE GAS, NOT ME. THIS IS A VERY DANGEROUS PROBLEM THAT NEEDS TO BE ADDRESSED. *TR

HAVE HAD ONGOING ELECTRICAL ISSUES BEGINNING IN AUGUST, 2010. CHECK ENGINE LIGHTS THAT HAVE BEEN PROVEN INACCURATE. HAVE REPLACED FAN MOTOR RESISTOR X 2, ELECTRICAL CONTROL UNIT X1, FAN BLOWER X1. WIRING IS MELTED (BURNT) AT LOCATIONS INDICATING FUSE SYSTEM/ WIRING HARNESS IS NOT FUNCTIONING PROPERLY. *TR

KEY SWITCH SPINDLE WENT BAD, HAD TO REPLACE KEY, THEN HAD TO REPLACE THE COMPLETE KEY SPINDLE AND THE WIRING HARNESS, IT STARTED TO SHORT OUT AND CAUSE A FIRE. HAD TO GO TO THE DEALERSHIP FOR REPAIRS, COST $ 2087.00 DOLLARS. *TR

WHILE FUELING MY JEEP, FUEL CAME SPEWING FROM THE FILLER NECK BEFORE THE PUMP SHUT OFF. THIS CAUSED APPROXIMATELY 1/8 GALLON OF FUEL TO SPILL ON MY VEHICLE AND MYSELF. WHILE DRIVING AFTER THIS INCIDENT I HAD TO PULL OVER AND GET OUT OF MY VEHICLE AS I WAS BECOMING DISORIENTED FROM EXPOSURE TO THE FUEL/FUEL VAPORS THAT SPILLED ON ME. LUCKILY I WAS ABLE TO REALIZE QUICKLY THAT MY LEVEL OF ALERTNESS WAS DETERIORATING AND WAS ABLE TO PULL OVER, ROLL DOWN MY WINDOWS, AND ALLOW THE FUMES TO DISSIPATE. I FEEL THAT THIS IS A VERY BIG SAFETY CONCERN THAT COULD CAUSE A SERIOUS ACCIDENT IF NOT ADDRESSED AND FIXED QUICKLY. *TR

WHEN REACHING SPEEDS OF 55 MILES PER HOUR THE JEEP SHAKES TO A POINT OF ALMOST LOSING CONTROL OF THE VEHICLE UNTIL THE JEEP REACHES A SPEED OF 65 - 70 MPH THEN SETTLES DOWN. *TR

EVERY TIME I FILL UP THE GAS SOME SPILL OUTS. FUEL SHUT OFF DOES NOT WORK. EVERY TIME I FILL UP AT EVERY STATION. *TR

GAS TANK OVERFLOWS WHEN FILLING WITH FUEL. *TR

WHEN FILLING GAS TANK SHUTOFF DOES NOT WORK AND GAS OVERFLOWS. HAPPENS AT EVERY STATION, EVERY TIME I FILLUP. *JS

WHEN FUELING, GAS OVERFLOWS EVERY TIME NO MATTER HOW CAREFUL IN FUELING AND WHEN PUMP SHUTS OFF AUTOMATICALLY IT GUSHES OUT CREATING HAZARDOUS SITUATION ,NOT TO MENTION ENVIRONMENTAL ISSUES. *TR

4/2009-FUEL SPITTING OUT WHEN GASSING UP ( WHEN FILLED, DOES NOT STOP) TOOK TO DEALERSHIP. STATES D/T BAD VENT VALVE. INSTALLED A NEW TANK. IN 2013- STARTED BACK DOING THE SAME THING AND CONTINUES. I HAVE TO GAUGE, WHEN I THINK IT'S FILLED AND STOP. *TR

GAS TANK VALVE SEEMS TO BE STUCK OPEN, EVERY TIME I FILL UP GAS SPILLS OUT. IF IT SPILLS OUT WHEN PUMPING, WHAT KEEPS IT FROM SPILLING OUT IN A ROLLOVER OR CRASH? *JS

WHEN I GET GAS THE PUMP DOESN'T SHUT OFF AND GAS SPILLS ON THE GROUND. IT HAS HAPPENED MULTIPLE TIMES AT MANY DIFFERENT FILLING STATIONS. *JS

EVERY TIME WHEN FUELING THE CAR, THE GAS TANK OVERFLOWS. THE SHUT OFF VALVE IS FAULTY. THE JEEP BOARDS HAVE MANY DOCUMENTED INCIDENTS OF THIS OCCURRING. THE CAR IS A 2005 BUT ONLY HAS 20,000 MILES ON IT. THERE ARE RECALLS FOR 2007 AND NEWER BUT NOTHING FOR MY CAR WHICH IS A 2005. THE RESPONSE FROM JEEP IS IT IS THE FAULT OF THE GAS. ETHANOL CAUSES THE SHUT OFF VALVE TO EXPAND. FROM MY PERSPECTIVE IT'S FAULTY ENGINEERING. *JS

GAS ERUPTS FROM FILL TUBE WHEN PUMP CLICKS OFF, SPILLING ON SIDE OF VEHICLE AND ON GROUND. HAPPENS WHENEVER PUMP IS ALLOWED TO RUN TILL IT AUTOMATICALLY CLICKS OFF. *TR

GAS ERUPTS FROM FILL TUBE WHEN PUMP CLICKS OFF, SPILLING ON SIDE OF VEHICLE AND ON GROUND, HAPPENS EVERY TIME THE PUMP IS ALLOWED TO RUN UNTIL IT AUTOMATICALLY CLICKS OFF. *TR

WHILE FILLING UP AT A GAS STATION, THE FUEL PUMP DID NOT "AUTOMATICALLY SHUT OFF" AND SHOT ROUGHLY 1/4 GALLON OF GASOLINE OUT ON THE SIDE OF THE VEHICLE AND ON THE GROUND. THOROUGHLY CLEANED VEHICLE BUT STILL SMELT GASOLINE VAPORS INSIDE OF THE CAB FOR 30 MINUTES WITH THE WINDOW DOWN. DID SOME RESEARCH AND FOUND IT IS DUE TO THE VEHICLE'S ICV BECOMING STUCK IN THE OPEN POSITION, WHICH BUILDS PRESSURE INSIDE OF THE GAS TANK, ALLOWING THE FILLER NECK TO FILL WITH GASOLINE, AND THEN RELEASES THE PRESSURE WHICH PROPELLS THE GASOLINE OUT OF THE FILLER NECK AND ONTO THE GROUND. IN ORDER TO FIX THIS PROBLEM I MUST REPLACE THE ENTIRE GAS TANK. *TR

MY CONTACT WITH YOU TODAY INVOLVES A FUEL SPIT BACK PROBLEM DURING REFUELING ON MY 2005 JEEP WRANGLER (TJ). I AM AWARE OF MANY BULLETINS AND RECALLS REGARDING THIS PROBLEM, MY VEHICLE IS INCLUDED IN ONE SUCH BULLETIN HOWEVER FALLS OUTSIDE OF ANY COVERAGE FOR REPAIR OF THIS PROBLEM BY THE MANUFACTURER. MY QUESTION IS; HOW CAN THE MANUFACTURER COVER REPAIRS AND PROVIDE AN EXTENDED OR IN SOME CASES A LIFETIME WARRANTY ON THIS FLAW FOR 2007 AND 2008 VEHICLES AND IGNORE ALL OF THE OTHER MODEL YEARS THAT HAVE THE SAME FLAW? THIS REPAIR WILL COST ME NEARLY ONE THOUSAND DOLLARS WHEREAS SOME PEOPLE GET THE PROBLEM RESOLVED AT NO COST TO THEM. PLEASE HELP. *TR

MY 2005 JEEP UNLIMITED RUBICON (TJ) HAS OVERFLOWED FUEL FOR YEARS. THE FUEL PUMP CONTINUES TO FLOW UNTIL FUEL HAS OVERFLOWED THE TANK AND FUEL POURS ONTO THE GROUND. CHRYSLER HAS COVERED THIS UNDER WARRANTY FOR OTHER YEAR JEEP WRANGLERS. MY YEAR IS NOT COVERED AND THE REPAIR IS OVER $900.00. I WAS TOLD THIS IS JUST A MALFUNCTION OF A VALVE IN THE FUEL FILLER PIPE. AND IS CAUSED FROM A POOR DESIGN. *TR

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE ENGINE AND CHECK GAUGE WARNING LIGHTS ILLUMINATED AND THE VEHICLE LOST ACCELERATION POWER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 76,000.

EVERY TIME I FILL-UP, GAS BLOWS OUT OF THE FILLER NECK, ABOUT 3 TO 6 OZ. *TR

THIS IS SECOND TIME THIS HAS HAPPENED; IT HAS HAPPENED TO ME AT LEAST 4 TIMES SINCE 11/30/2013. I WAS ACCELERATING, AND WHEN I HIT ABOUT 50MPH, MY LEFT TIRE HIT A SMALL POT HOLE. MY FRONT END BEGAN SHAKING VIOLENTLY; MY STEERING WHEEL WAS LITERALLY BOUNCING IN MY HANDS AND I COULD NOT ACTIVELY CONTROL THE JEEP. THE SHAKING WOULD NOT STOP UNTIL I SLOWED DOWN TO ABOUT 5 MILES PER HOUR ON A BUSY ROADWAY. I ALMOST CAUSED AN ACCIDENT. THIS JEEP HAS A SHIMMY/WOBBLE THAT OCCURS ON SOME BUMPS. SOME LEAD TO THE "DEATH WOBBLE," AND OTHERS DO NOT. THE SHAKING IS SO INTENSE THAT THE FRONT END FELT LIKE IT WAS GOING TO COME APART. I HAVE NEW TIRES, AND THE VEHICLE WAS JUST PURCHASED USED FROM THE DEALERSHIP, AFTER HAVING RECEIVED A FULL SERVICE. I TOOK IT INTO THE JEEP DEALERSHIP THAT CONFIRMED THAT EVERYTHING LOOKED OK, AND THE BUSHINGS WERE FINE. *TR

WHEN REFUELING, ONCE THE FUEL TANK IS FULL THE SERVICE STATION FUEL SUPPLY HOSE NOZZLE CLICKS OFF, THEN A SURGE OF FUEL EXPELS FROM THE JEEP FUEL TANK FILL PORT SPLASHING ONTO THE VEHICLE EXTERIOR, ONTO MYSELF, AND ONTO THE GROUND. THIS IS A SERIOUS FIRE HAZARD. IT APPEARS TO BE A COMMON PROBLEM WITH THE JEEP WRANGLER ACROSS MANY YEARS, WITH NO RESOLUTION TO DATE. *TR

FILLING UP MY GAS TANK THE TANK OVERFLOWS EVERY TIME. TRIED SEVERAL GAS STATIONS AND THE SAME THING HAPPENED EVERY TIME. TALKED TO OTHER JEEP WRANGLER OWNERS AND SEVERAL OF THEM HAVE HAD THE SAME PROBLEMS. *TR

EVERY TIME YOU FUEL THE VEHICLE, IT OVERFLOWS GAS BADLY AS THE PUMP CUTS OFF. THIS HAPPENS REGARDLESS OF THE PUMP OR LOCATION THAT I BUY FUEL FROM. IT DUMPS GAS ALL OVER THE SIDE OF THE CAR AND ON THE GROUND. SIGNIFICANT AMOUNT OF GAS SPILLS OUT. *TR

TANK OVERFLOWS AND SENDS GAS FLYING THROUGH THE AIR, ALL OVER THE PERSON PUMPING, AND THE GROUND, AT EVERY FILL UP. *TR

SPITS FUEL EVERY TIME I FILL UP, NO MATTER WHERE OR HOW SLOWLY I FILL IT. 3-5 OUNCES OF FUEL SPIT BACK OUT EVERY FILL UP, ON FIRST AUTO SHUT OFF OCCASIONALLY FUEL IS EXPELLED FORCEFULLY ENOUGH TO SPLASH ON OBJECTS18-24 INCHES AWAY. *TR

WHEN FILLING UP THE GAS TANK THE GAS PUMP AUTOMATICALLY SWITCHES OFF WHEN THE TANK IS FULL (LIKE IT DOES WITH ANY OTHER CAR), HOWEVER WITH THE JEEP GASOLINE IMMEDIATELY GUSHES OUT OF THE FILLER HOLE. I'D ESTIMATE THAT AT LEAST A PINT TO A QUART OF FUEL SPILLS (AND SOMETIMES SPRAYS) OUT. IF SOMEONE IS STANDING NEAR-BY THEY WILL GET SOAKED WITH GASOLINE. THIS DOESN'T ALWAYS HAPPEN, BUT SEEMS TO BE OCCURRING MORE FREQUENTLY. NOT ONLY IS THIS AN INCONVENIENCE, IT'S AN ENVIRONMENTAL HAZARD AND A FIRE RISK. WHAT HAPPENS IF SOMEONE'S PANT-LEG GETS SOAKED IN GASOLINE (AS HAS HAPPENED TO ME) AND THEN THEY PICK-UP A MILD STATIC CHARGE WHEN ENTERING/ EXITING THE VEHICLE (WHICH IS NOT UNCOMMON). SOMEONE IS GOING TO GET HURT. I CANNOT LET ANYONE PUT GAS IN THE JEEP (LIKE MY WIFE). ANYONE WHO IS NOT FAMILIAR WITH THIS 'QUIRK' WILL LIKELY GET SOAKED WITH FUEL AT SOME POINT WHEN FILLING UP THE JEEP. *TR

WHILE FILLING THE VEHICLE THE GAS PUMP SHUTS OFF AND THEN FUEL COMES POURING OUT OF THE FUEL FILL ON THE VEHICLE. THERE ARE LOTS OF COMPLAINTS ONLINE REGARDING THIS ISSUE WITH JEEP AND THIS HAS THE POTENTIAL FOR SEVERE INJURY AND PROPERTY DAMAGE DUE TO THE FUEL SPILLING ON THE GROUND AND POSSIBLY EXPLODING. *TR

DEATH WOBBLE!!!! STARTED ABOUT DEC 2011 AROUND SPEEDS OF 55-60 MPH. CAR WILL SUDDENLY START TO VIOLENTLY SHAKE. WHEN VIEWING FROM BEHIND IN ANOTHER CAR IT APPEARS AS IF THE WHEELS MAY COME OFF. I HAVE REPLACED THE SHOCKS, STRUTS, STABILIZER BAR, TRACK BAR, SPRINGS, SPACERS, CALIPERS, HUBS, NEW TIRES, BALANCE AND ROTATE TIRE EVERY 5000-6000 MILES, NEW FRONT BRAKES, NEW BACK BRAKES, TWO REAR ALIGNMENTS, 3 FRONT ALIGNMENTS, AND ROTORS, I DEATH WOBBLE HAS GONE FROM BAD TO DANGEROUSLY WORSE. MY WRANGLER IS A FACTORY RIGHT HAND DRIVE JEEP THAT I USE TO DELIVER MAIL. I WAS USING AS MY PRIMARY CAR AS WELL. I MUST DRIVE 25 MILES TO WORK VIA INTERSTATE AND THEN ANOTHER 65 MILES ON MY ROUTE. THE CAR CONSISTENTLY SHAKES WHEN I HIT SPEEDS OF 45 MPH OR HIGHER. A BUMP IN THE ROAD WILL TRIGGER THE WOBBLE AS WELL. I SPOKE TO TWO DIFFERENT JEEP DEALERSHIPS TODAY AND WAS TOLD THAT THERE IS NO SOLUTION TO MY PROBLEM. I HAVE BEEN TO AT LEAST 6 DIFFERENT MECHANIC SHOPS, ONE OFF ROAD SHOP, AND TWO DIFFERENT ALIGNMENT SHOPS. I WAS TOLD THAT I COULD TRY REPLACING THE GEAR BOX ($899.99) AND ALSO TRY REPLACING MY RIMS! IF THE MAKER OF MY VEHICLE HAS NO IDEA ON WHAT OR HOW TO FIX IT........THEN WHO WILL? I WOULD LIKE TO RESOLVE MY DEATH WOBBLE. I AM EXTREMELY ANNOYED! I NO LONGER FEEL SAFE DRIVING MY CAR TO AND FROM WORK AND WHEN IT RAINS I AM A NERVOUS WRECK JUST KNOWING I WILL HAVE TO DRIVE MY JEEP ON THE INTERSTATE. SADLY ITS GOTTEN TO THE POINT THAT I WILL NOT ALLOW ANY OF MY KIDS IN THIS VEHICLE. I END UP HAVING TO LEAVE MY JEEP AT WORK IN ANOTHER TOWN IF MY HUSBAND ISN'T ABLE TO DRIVE IT TO AND FROM WORK FOR ME. I AM WILLING TO FIX THE PROBLEM.......IF JEEP WOULD JUST LET ME KNOW WHAT THAT IS!!!! IN GOOD CONSCIOUS I COULD NEVER SELL AND STICK SOMEONE ELSE WITH THIS PROBLEM/HEADACHE!! ALSO, WHEN I FILL MY JEEP UP WITH GAS, IT OVERFLOWS SPLASHING GAS EVERYWHERE! *TR

WHEN GAS TANK IS FILLED COMPLETELY AT A GAS STATION. THE PUMP KICKS OFF AND THEN FUEL PROCEEDS TO SPILL BACK OUT OF THE JEEP. IT SEEMS TO BE ABOUT 8 OZ OR SO. *TR

I HAD MY FUEL TANK REPLACED BY JEEP A LITTLE OVER 2 YEARS AGO FOR THE "ROLL OVER VALVE" PROBLEM - FAULTY FUEL TANK DESIGN THAT JEEP REFUSES TO ACKNOWLEDGE THAT ITS A COMMON PROBLEM. AS WELL AS A SAFETY AND ENVIRONMENTAL HAZARD -- EVERY TIME THE GAS PUMP CLICKS OFF, FUEL VIOLENTLY SHOOTS ALL OVER THE PAINT, GROUND, AND MY PERSON. THE REPLACEMENT TANK HAS STARTED DOING THIS AGAIN AFTER MAYBE 20,000 MILES! JEEP REPLACED A FAULTY, HAZARDOUS PART WITH ANOTHER. THIS IS AN OUTRAGE THAT EVERY TIME I GO TO THE GAS STATION I HAVE TO WORRY ABOUT FUEL SHOOTING ALL OVER THE PLACE, ITS EMBARRASSING AS WELL. I MADE AN NHTSA COMPLAINT THE FIRST TIME BUT I AM MAKING ANOTHER SINCE THE REPLACEMENT PART IS DOING THE EXACT SAME THING! *TR

EVERY TIME SINCE PURCHASING MY JEEP ON NOV 26TH 2013 WHEN FILLING THE FUEL TANK AS IT CLICKS OFF FUEL SPITS OUT OF THE FILLER NECK AND ON TO THE BODY AND ON THE GROUND. EVEN WHEN MANUALLY FILLING IT SPITS FUEL OUT BEFORE YOU CAN RELEASE THE NOZZLE. IF YOU ARE STANDING IN THE WRONG POSITION IT LANDS ON YOUR CLOTHES AND SHOES. THIS CREATES A SAFETY RISK OF FIRE AS WELL AS THE ENVIRONMENTAL DAMAGE. *TR

I TRACED A LOUD SCREECHING NOISE TO THE OIL PUMP DRIVE ASSEMBLY. AS THE ENGINE WARMED UP THE NOISE SUBSIDED BUT CONTINUES TO OCCUR.ON LINE RESEARCH SHOWS THIS TO BE A COMMON PROBLEM FOR THE 05-06 WRANGLERS DUE TO A DESIGN CHANGE FROM 04 TO 05 MODEL YEARS WHERE A BUSHING AT THE TOP OF THE CAM POSITION SENSOR/OIL PUMP DRIVE THAT SEIZES DUE TO LACK OF LUBRICATION AND CAUSES THE DRIVE GEAR ON THE OIL PUMP SHAFT TO SELF DESTRUCT TAKING WITH IT THE CAMSHAFT DRIVE GEAR WHICH CAUSES LOSS OF OIL PRESSURE.DODGE ISSUED THE E05 MAR 2005 CAMPAIGN-ENGINE OIL PUMP DRIVE GEAR/CAM REPLACEMENT. LETTERS WERE SENT TO DEALERS TO REPLACE THE DRIVE GEARS AND CAMS DAMAGED BY THIS PROBLEM. THE NOTIFICATION APPLIES TO THE 4.0 L ENGINE BUILT FROM OCT 20, 2004 TO FEB 1, 2005. MY LOCAL DODGE DEALER INFORMED ME THAT MY JEEP HAS AN OCT 9, 2004 BUILD DATE AND IS THEREFORE NOT ELIGIBLE FOR THE RECALL EVEN THOUGH THE PICTURES I SHOWED HIM OF THE DAMAGE TO THE GEARS IN MY ENGINE. THE DEALER SUGGESTED I TRY CUSTOMER SERVICE. THEY REFERRED ME TO NHTSA TO SEEK A RESOLUTION. SO AFTER INVESTING OVER $12,000 DOLLARS A MONTH AGO TO PURCHASE WHAT I EXPECTED WOULD BE A RELIABLE WINTER VEHICLE I INSTEAD HAVE A VEHICLE THAT SITS IN MY DRIVEWAY BECAUSE WE ARE AFRAID TO DRIVE IT. IT CAN'T BE TRUSTED ON THE ROAD AND I CAN'T RISK USING IT AND FACING A $4,000.00 ENGINE REBUILD IF IT SEIZES. I NEED SOME HELP. *TR

THE VEHICLE WILL SPILL GAS OUT OF THE FILLER NECK EVERY TIME AFTER THE PUMP HANDLE SHUTS OFF. IT DOESN'T MATTER IF I USE THE LOWEST SETTING ON THE GAS PUMP OR IF I MANUALLY USE AS LITTLE PRESSURE AS POSSIBLE. IT OVERFILLS EVERY SINGLE TIME AND GAS POURS OUT OF THE FILL SPOUT RUNNING DOWN THE BODY OF THE VEHICLE ON MY HAND ON MY CLOTHES AND ON THE GROUND. *TR

EVERY TIME I FILL UP WITH FUEL, IT SPILLS AND SPLASHES ALL OVER THE PLACE CAUSING PUDDLES OF FUEL ALL OVER THE GROUND AND RUNNING DOWN THE SIDE OF MY VEHICLE. *TR

EVERY TIME I FUEL UP MY 2005 JEEP WRANGLER GAS SPILLS OUT ONTO THE GROUND. IT HAS BEEN HAPPENING FOR YEARS EVERY TIME I FUEL REGARDLESS OF THE GAS STATION. *TR

THE GAS TANK OF MY 2005 JEEP RUBICON OVERFLOWS EVERY TIME I REFUEL, BECAUSE IT DOES NOT SHUT OFF THE GAS WHEN THE TANK IS FULL. THIS HAS BEEN A RECURRING PROBLEM CITED BY MANY OTHER JEEP OWNERS (AS CHRYSLER MUST BE AWARE). THIS MALFUNCTION IS DANGEROUS, WASTEFUL, AND ENVIRONMENTALLY DAMAGING. PLEASE LIVE UP TO THE REPUTATION THAT JEEP OWNERS APPRECIATE AND RESPECT REGARDING OUR JEEPS. QUALITY AND RELIABILITY ARE IMPORTANT TO US--OR WE WOULD NOT BUY JEEP VEHICLES. DEVOTED JEEP OWNERS SHOULDN'T HAVE TO BEG FOR ASSISTANCE TO RECTIFY A DESIGN FLAW. *TR

WHEN I GO TO FILL UP WHEN IT GETS FULL IT SPILLS OUT OF THE TOP ALL OVER SIDE OF JEEP AND GROUND SAW THERE IS OTHERS OUT THERE HAVING SAME PROBLEM VERY UNSAFE. I AM SECOND OWNER JEEP SHOULD DOING SOMETHING ABOUT THIS. PLEASE HELP. *TR

VEHICLE OVERFLOWS GASOLINE WHEN FILLING TANK. AFTER NOZZLE CLICKS OFF, SEVERAL OUNCES OF FUEL ARE EXPELLED THROUGH THE FILLER NECK, DAMAGING PAINT AND CAUSING A SAFETY HAZARD. *TR

EVERY TIME I PUMP GAS IT OVERFLOWS. THE FLAPPER IN THE TOP OF THE GAS TANK ISN'T WORKING CORRECTLY. THIS IS APPARENTLY AN ISSUE FOR THE MAJORITY OF 05 AND 06 MODELS. CHRYSLER DECIDED TO FIX THE 07-08 MODELS AND DO NOTHING FOR THE 05-06. *TR

WHEN FILLING WITH GAS . GAS SHOT OUT SOAKING MY CLOTHES HANDS AND FACE . LUCKILY HAD SOMEONE ASSIST ME TO RESTROOM TO CLEAR EYES AND WASH FACE .. THIS IS SO SCARY MY GRAND SON WAS RIGHT THERE COULD HAVE BEEN BAD .PLEASE HELP THIS NEEDS FIXED. RECALL PLEASE HELP! *TR

HAD BEEN NOTICING A PLASTIC BURNING SMELL FOR A COUPLE MONTHS, NEVER FOUND A CAUSE OR ANYTHING NOT WORKING PROPERLY. DRIVING HOME EARLY ONE MORNING I NOTICED MY HEADLIGHTS WERE NOT WORKING, THE BRIGHTS WORKED AND SO DID THE FOG LIGHTS, BUT NO LOW BEAMS. AFTER LOOKING ON JEEP FORUMS AND NOTICING A LOT OF PEOPLE WERE HAVING THE SAME PROBLEM I DECIDED TO TAKE THE COVER OFF MY COLUMN AND TAKE A LOOK. THE WIRING HARNESS CONNECTED TO MY MULTIFUNCTION SWITCH WAS BURNT, PROOF OF AT LEAST ONE SMALL ELECTRICAL FIRE, IF NOT MULTIPLE SMALL FIRES. I CANNOT BE THE ONLY ONE WITH THIS PROBLEM, MULTIPLE POSTERS ON JEEP FORUMS HAVE REPORTED SIMILAR EVENTS. *TR

FUEL FILLER OVERFLOWS WHEN FUELING TANK, EVERY TIME. *TR

EVERY TIME I FILL UP THE GAS TANK THE GAS SPITS OUT OF THE FILLER NECK. IT DOES NOT MATTER IF I GO SLOW OR FAST. IT ALWAYS HAPPENS. *TR

EACH TIME I FUEL MY JEEP IF I LET THE GAS AUTOMATICALLY RUN IT WILL NOT CLICK THE PUMP OFF WHEN THE GAS TANK IS FULL. IT CONTINUES TO RUN OVERFLOWING EVERYWHERE. *JS

FUEL SPILLS OUT OF FILLER HOSE ALMOST EVERY TIME I FILL UP FUEL. THE GAS SPILLS OUT ALL OVER THE GROUND AT THE GAS STATION. I COMPLAINED TO CHRYSLLER HQ AND THEY SAID, ITS BEEN NOTED AND MY VEHICLE DOES NOT QUALIFY FOR THE RECALLS THAT THEY HAVE ON THE LATER MODEL JEEP WRANGLERS WITH THE SAME PROBLEM.

EACH AND EVERY TIME I FILL THE VEHICLE UP WITH GASOLINE, THE FUEL SPILLS OUT OF THE GAS TANK ALL OVER THE VEHICLE. IT HAS RUINED MY FENDER FLARE NOT TO MENTION THE GASOLINE ON THE GROUND AS A RESULT OF THE FAULTY GAS TANK. THIS HAPPENS EVERY SINGLE TIME I FILL UP THE VEHICLE (REGARDLESS OF THE GAS STATION). THE ONLY WAY TO STOP THIS IS TO HANDLE IT IS IN A MANUAL PROCESS (NOT USING THE PUMP HANDLE SWITCH TO KEEP PUMP ON), HOWEVER THAT STILL DOES NOT STOP THE FUEL FROM FILLING OUT THE TANK. THIS HAS RUINED SOME OF MY CLOTHES AND AS MENTIONED, IS CREATING PLENTY OF POLLUTION EVERY SPILL. THIS IS A COMMON PROBLEM WITH WRANGLERS AS IT IS COMMONLY REPORTED IN ONLINE FORUMS. I AM ASKING FOR CHRYSLER'S ASSISTANCE IN GETTING THIS ISSUE ADDRESSED AND THE FUEL TANK REPLACED. *TR

GAS OVERFLOWS AND RUSHES OUT WHEN PUMPING GAS WHEN TANK BECOMES FULL. *TR

FUEL SPITS OUT OF THE REFUEL RECEPTACLE EVERY TIME I FILL THE TANK. *TR

EACH TIME I FILL UP MY GAS TANK WITH FUEL, THE FUEL OVERFLOWS OUT OF THE TANK. AS I AM NOT THE ORIGINAL OWNER OF THE VEHICLE, I AM FILING THIS COMPLAINT ONLY AFTER LEARNING FROM MANY OTHER JEEP OWNERS THEY ALSO EXPERIENCE THIS ISSUE. IT SEEMS VERY DANGEROUS FOR THIS AMOUNT OF FUEL TO BE SPILLED (AND SPEWED) FROM THE GAS TANK, THE ONLY WAY TO PREVENT IT IS TO MONITOR THE GALLONS GOING IN AND STOP IT MANUALLY WHICH, UNFORTUNATELY, IS NOT ALWAYS A SUCCESSFUL APPROACH. THANKS! *TR

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER EQUIPPED WITH GOODYEAR WRANGLER GS-A TIRES, SIZE 30X9.50 R 15. THE CONTACT STATED THAT WHILE TRAVELING 75 MPH, THE REAR DRIVER'S SIDE TIRE BLEW AND CAUSED THE VEHICLE TO ROLL OVER. THE CONTACT SUSTAINED A CRUSHED HAND AND BACK INJURIES. THE DRIVER SUSTAINED A HAND INJURY. THE FRONT PASSENGER SUSTAINED CHEST INJURIES. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT CONTACTED. THE TIRE WAS NOT REPLACED. THE FAILURE MILEAGES WERE 41,000. THE DOT NUMBER WAS UNAVAILABLE.

WHEN FILLING UP THE GAS TANK ON MY 2005 JEEP WRANGLER UNLIMITED, THE GAS TANK OVER FLOWS AND SPEWS GAS OUT DOWN THE SIDE OF THE BODY AND ONTO THE CONCRETE. IT LEAVES A PUDDLE OF GASOLINE ABOUT 8 OUNCES OR SO. *TR

WHEN REFILLING GAS THE AUTO SHUTOFF DOESN'T WORK CORRECTLY AND FUEL SPILLS OUT ONTO VEHICLE AND GROUND AS IT DOESN'T SHUT OFF SOON ENOUGH. GAS CAN SPLASH ON PERSON HOLDING NOZZLE OR NEAR VEHICLE. FIRE AND POLLUTION RISK. *TR

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE CONTACT STATED THAT WHILE DRIVING 20 MPH OVER A ROAD BUMP, THE ENTIRE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTIONS AND THEY STATED THAT THEY DID NOT HAVE A REPAIR AVAILABLE TO RECTIFY THE "DEATH WOBBLE" HE HAD EXPERIENCED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 43,000. UPDATED 09/18/13*LJ

I HAVE A 2005 JEEP WRANGLER UNLIMITED...WHILE DRIVING ON THE HIGHWAY HITTING A SPEED OF ABOUT 62 MY JEEP STARTING SHAKING SO VIOLENTLY THAT I THOUGHT I WAS GOING TO LOOSE MY FRONT END! THE STEERING WHEEL FELT LIKE IT WAS GOING TO COME OFF IN MY HANDS AND THAT MY TIRES WERE READY TO FALL OFF AS WELL! THIS WAS VERY VERY SCARY SINCE I HAD MY GRANDCHILD IN THE JEEP WITH ME! I PAID OVER $800 TO HAVE THE SUSPENSION ROD/TIE RODS REPLACED. THEN SHORTLY THEREAFTER, MY JEEP WOULD NOT START. A LITTLE PIN IN THE STEERING COLUMN BROKE AND THE THAT PART IS NOT SOLD SEPARATELY SO I HAD TO HAVE THE WHOLE STEERING COLUMN REPLACED...ABOUT ANOTHER $600. *TR

I HAVE A 2005 JEEP WRANGLER UNLIMITED....IT WOULD NOT START ONE MORNING AND I HAD IT TOWED TO MY MECHANIC. A TINY PIN IN THE STEERING COLUMN BROKE. THIS 1/2" PIN IS NOT SOLD SEPARATELY AND I HAD TO HAVE THE WHOLE STEERING COLUMN REPLACED AT A COST OVER $600! *TR

HI, APPARENTLY MY SITUATION ISN'T UNIQUE, I HAVE A 2005 JEEP WRANGLER UNLIMITED WITH LESS THAN 70K MILES. AT ABOUT 50MPH IT STARTS SHAKING VIOLENTLY, THIS HAS HAPPENED TO ME AT LEAST 5 TIMES SINCE I'VE OWNED THIS JEEP, ABOUT 2 1/2 MONTHS. I TOOK IT TO THE TIRE SHOP AND THEY INSPECTED THE TIE-ROD ENDS AND FOUND NO PROBLEM. IT WAS SHAKING SO BAD I THOUGHT THAT SURELY MY FRONT END WAS COMING APART SO, I GOOGLED MY PROBLEM AND WAS LED TO A PLETHORA OF INFORMATION AND FOUND THE TERM "DEATH WOBBLE", I THOUGHT IT FELT LIKE DRIVING OVER RAILROAD TRACKS, BUT DEATH WOBBLE SEEMS TO ALSO BE AN APPROPRIATE TERM AS WELL, BECAUSE THE FRONT END SEEMS TO BE SHAKING TO DEATH. I, LIKE SO MANY OTHERS, WENT TO KEVIN'S OFF ROAD, KOR, WEBSITE AND READ ABOUT THE POTENTIAL CAUSES AND CURES. IN MY PARTICULAR CASE THERE HASN'T BEEN ANY AFTERMARKET MODIFICATIONS, IT'S AS STOCK AS THEY COME. ANYWAY, KEVIN'S RECOMMENDED SOLUTION TO MY "WOBBLE" IS TO REPLACE THE TRACK BAR, THE STEERING DAMPER, CONTROL ARMS AND BUSHINGS. THE COST FOR THIS IS AROUND $366 FOR THE PARTS AND I'M NOT SURE WHAT THE LABOR COSTS WILL BE. IT SEEMS TO ME THAT MAYBE SOMEONE AT CHRYSLER SHOULD ACTUALLY GO DRIVE ONE BEFORE THEY SAY "IT'S NOT OUR FAULT". THEY SHOULD BE PART OF THE SOLUTION SINCE THEY CREATED THE PROBLEM. MY 1989 JEEP DOESN'T HAVE THIS PROBLEM, LEAF SPRINGS VS. INDEPENDENT COIL SPRINGS, PERHAPS,... A SMOOTHER RIDE BUT AT WHAT COST? $366 PLUS LABOR FOR ME. CAN YOU PLEASE HELP APPLY PRESSURE TO CHRYSLER TO MAKE THIS RIGHT? THANKS FOR YOUR TIME AND INTEREST. *TR

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHIFT GEARS. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS ADVISED THAT THE SHIFTER CABLE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. *TR

WHEN FUELING UP, NOZZLE DOES NOT SHUT OFF AND FUEL SPILLS OUT ONTO ME AND GROUND. *TR

I BOUGHT THIS VEHICLE USED AND NOTICED THAT WHEN FILLING THE TANK IT ACTUALLY SPLASHES FUEL OUT OF THE FILL TUBE EVERY TIME THE GAS STATION NOZZLE CLICKS OFF WHEN FULL. I HAVE DRIVEN THIS JEEP FROM NORTH CAROLINA TO MICHIGAN AND USED SEVERAL DIFFERENT STYLES OF NOZZLES FROM GAS STATIONS IN MANY STATES. I HAVE ATTEMPTED TO SLOW THE FUEL DELIVERY, ANGLE THE NOZZLE DIFFERENTLY, STOP EARLY AND RESUME FILLING. THE RESULT IS ALWAYS THE SAME. ENOUGH FUEL TO RUN DOWN A SQUARE FOOT AREA ON MY CAR AND LEAVE A PUDDLE ON THE GROUND WILL ALWAYS SHOOT OUT UNDER PRESSURE. I END UP WITH GAS ON MY CAR, ON ME AND ON THE GROUND. THIS CAN NOT BE CONSIDERED SAFE FOR MY WELL BEING OR THE ENVIRONMENT. I HAVE BEEN TOLD THAT I NEED TO REPLACE MY GAS TANK, A $1200 REPAIR, TO FIX THE PROBLEM. *TR

WHEN THE GAS TANK IS FILLED ON MY 05 JEEP WRANGLER UNLIMITED, THE PUMP DOES NOT STOP PROPERLY, SPILLING GAS OVER THE VEHICLE, THE GROUND, AND THE INDIVIDUAL PUMPING THE GAS. THIS HAPPENS EVERY TIME, REGARDLESS OF GAS STATION.

I WAS DRIVING ON THE INSIDE LANE AT OR ABOUT 43MPH ON A STATE HWY WHEN IT HIT A VERY SMALL BUMP IN THE ROAD. ALMOST IMMEDIATELY AFTER MY 2005 JEEP WRANGLER BEGAN SHAKING VIOLENTLY CAUSING ME TO LOSE MY GRIP ON THE STEERING WHEEL BEFORE I COULD REGAIN CONTROL, NEARLY STRIKING ANOTHER VEHICLE TRAVELING ON THE OUTSIDE LANE. THE SHAKING WAS SO VIOLENT I THOUGHT MY JEEP WAS LITERALLY GOING TO FALL APART AND/OR FLIP OVER. I WORK OUT OF TOWN AND WAS FORCED TO RETURN HOME AND TAKE MY WIFE'S TRUCK. *TR

WHEN REFUELING MY JEEP, FUEL WAS EXPELLED FROM THE FILER NECK AT THE SAME TIME THE FUEL PUMP CUT OFF AUTOMATICALLY. I WAS COVERED IN GASOLINE THIS TIME AFTER THE FUEL WAS EXPELLED FROM THE TANK. THIS HAS HAPPENED ON EVERY REFILL STARTING ABOUT 6 MONTHS AGO BUT THE FIRST TIME I HAVE BEEN DOUSED WITH FUEL. THE JEEP DEALER INDICATED THAT A RECALL HAD BEEN INITIATED ON HUNDREDS OF WRANGLERS BUT NOT THE 2005 JEEP WRANGLERS FOR THE SAME PROBLEM. THIS IS AN INCREDIBLY DANGEROUS SITUATION AND THE CONSUMER NEEDS YOUR HELP!! MANY ONLINE ARTICLES FROM ORGANIZATIONS LIKE EDMUNDS AND CONSUMER REPORTS HAS INDICATED THIS IS A SERIOUS PROBLEM AND THE PROBLEM NEEDS TO BE IDENTIFIED BY YOUR ORGANIZATION AND CHRYSLER NEEDS TO RECALL THE VEHICLES. *TR

I WAS DRIVING DOWN A STRAIGHT ROAD AT ABOUT 47 MPH WHEN I MY STEERING WHEEL STARTED SHAKING UNCONTROLLABLY. IT SERIOUSLY FELT AS IF MY WRANGLER WAS GOING TO SHAKE THE STEERING WHEEL AND TIRES RIGHT OFF. THE ONLY WAY I ABLE TO STOP THE SHAKING WAS TO PULL OVER AND SLOW DOWN, THEN AS SOON AS I HIT 47 MPH THIS HAPPENED ALL OVER AGAIN. DID SOME RESEARCH ON THIS AND THEY CALL IT A "DEATH WOBBLE," AND THIS HAS BEEN ASSOCIATED WITH JEEP WRANGLERS FOR SOME TIME NOW. BUT FOR SOME REASON CHRYSLER DOESN'T WANT TO ACKNOWLEDGE THE SEVERITY AND DANGEROUS NATURE OF THIS MALFUNCTION. THIS KIND OF DEFECT COULD KILL SOMEONE! *TR

EVERY TIME I GO TO FILL UP MY GAS TANK- ONCE THE FUEL PUMP REACHES THE FULL AMOUNT THE FUEL STARTS COMING OUT OF THE TANK SPILLING ALL OVER THE SIDE OF MY WRANGLER AND SOMETIMES ON MY SHOES. EVEN WHEN I SLOW PUMP THE GAS INTO THE TANK, ONCE IT REACHES A CERTAIN POINT (WHICH I CAN NEVER TELL BECAUSE MOST VEHICLES MAKE THE GAS PUMP CLICK OFF ONCE FULL) IT ALMOST ALWAYS AUTOMATICALLY PURGES ITSELF. *TR

I WAS FILLING UP MY GAS TANK. WHEN TANK WAS FULL, GAS SPILLED OUT OF FILLER ALL OVER MY VEHICLE AND GROUND BEFORE IT WOULD STOP. AFTER FURTHER RESEARCH, THIS IS A KNOWN PROBLEM WITH THIS YEAR WRANGLER. *TR

WHENEVER JEEP REACHES SPEEDS OF 50 MPH AND HITS A BUMP FRONT WHEELS AND STEERING WHEEL SHAKES VIOLENTLY. YOU MUST SLOW AT ONCE TO GET IT TO STOP. AFTER ASKING OTHER JEEP OWNERS I HAVE FOUND THIS TO BE A COMMON PROBLEM. WENT TO THE JEEP DEALER AND WAS ONLY GIVEN A SERVICE BULLETIN AND NO ANSWERS. *TR

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE CONTACT STATED THAT THE FUEL TANK FILLER NECK AND WHEN REFUELING, THE FUEL WOULD SPILL TO THE GROUND. THE VEHICLE WAS TAKEN TO THE DEALER AND THE FUEL TANK FILLER NECK WAS REPLACED HOWEVER, THE FAILURE WAS NOT CORRECTED. THE FUEL CONTINUED TO SPILL TO THE GROUND AS THE FUEL TANK WAS BEING FILLED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 75,344 AND THE APPROXIMATE CURRENT MILEAGE WAS 76,000. UPDATED 04/30/13*LJ THE DEALER ORDERED A NEW FUEL TANK.

IN TRYING TO START MY VEHICLE, A PART INSIDE OF THE IGNITION BROKE. I AM TOLD I CANNOT GET THE PART THAT BROKE AND I MUST PURCHASE AN ENTIRE STEERING COLUMN TO REPLACE THIS PART IN BETWEEN THE KEY AND THE ELECTRICAL COMPONENT THAT STARTS MY VEHICLE. IT IS A SMALL PART, AND I CANNOT SEE HAVING THE ENTIRE STEERING COLUMN TO REPLACE THIS SMALL PART. I AM TOLD BY CHRYSLER THAT THE COST TO REPAIR THIS IS ABOUT $800.00. I THINK THIS IS ENTIRELY UNREASONABLE AND IRRESPONSIBLE ON THE PART OF THE MANUFACTURER. THIS PART IS USED DAILY AND SHOULD NOT FAIL AFTER 60,000 MILES OF WEAR. MY SEVEN YEAR / 70,000 MI WARRANTY HAS JUST EXPIRED AND I AM APPALLED THAT SUCH A LARGE COMPANY CANNOT AFFORD TO FIX OR EVEN STAND BEHIND THEIR PRODUCT. THIS IS OBVIOUSLY A DEFECTIVE PIECE OF EQUIPMENT TO HAVE FAILED SO PREMATURELY. IT IS USED EVERY TIME YOU START THIS VEHICLE, AND UPON CLOSER EXAMINATION OF THIS PART, IT SEEMS THAT IT IS MADE OF SUB-STANDARD MATERIAL TO BE A PART THAT MUST ENDURE DAILY USE.

ABOUT 1 YEAR AGO THE GAS TANK STARTED OVER FLOWING WHEN I PUT GAS IN. I INITIALLY THOUGHT IT WAS A PUMP PROBLEM BUT IT GOT WORSE OVER TIME. WHEN I FILL THE TANK IT OVER FLOWS ABOUT A CUP OF GAS. WHEN I CONTACTED THE DEALER THEY KNEW ABOUT THE PROBLEM AND SAID IT HAPPENS ON SOME JEEPS. THE PROBLEM IS THE ROLL OVER VALVE STICKS OPEN. THE ONLY FIX IS TO REPLACE THE COMPLETE GAS TANK - $1,250.00. NEITHER THE DEALER NOR CHRYSLER WOULD TAKE RESPONSIBILITY FOR FIXING THE PROBLEM ALTHOUGH CHRYSLER ACKNOWLEDGED IT WAS A DESIGN DEFECT NOT A MANUFACTURING DEFECT. IF THERE ARE 1 MILLION JEEPS ON THE ROAD WITH THIS PROBLEM, THEIR DRIVERS FILL UP ONCE A WEEK, AND SPILL A CUP EACH THAT AMOUNTS TO 60 THOUSAND GALLONS OF GAS DUMPED INTO THE ENVIRONMENT A WEEK. SEEMS LIKE CHRYSLER SHOULD BE MORE CONCERNED ABOUT THE PROBLEM AND EITHER YOU OR THE EPA SHOULD ENCOURAGE THEM TO TAKE OWNERSHIP. *TR

FUEL SPILL OCCURS DURING FILL UPS. FUEL WILL SPILL ONTO THE GROUND AS WELL AS SPEW OUTWARD FROM THE VEHICLE. FUEL HAS GOTTEN ONTO MY CLOTHING AND SKIN ON TWO OCCASIONS. *TR

WHEN I FILL UP MY TANK AT THE GAS STATION, THE AUTO FILL WON'T CLICK OFF UNTIL THE GAS TANK IS OVERFILLED, AND SPRAYS OUT, THEN RUNS DOWN THE SIDE OF MY JEEP. IT DOESN'T MATTER IF I USE THEIR AUTO FILL NOTCHES AND WALK AWAY OR HOLD IT BY HAND, THE GAS WONT CLICK OFF UNTIL THE TANK HAS OVERFLOWED. IT SPILLS BETWEEN A LITER AND A PINT EACH TIME. *TR

WHEN FILLING GAS TANK, GAS WILL OVERFLOW OUT OF TANK, THIS HAS HAPPENED SINCE VEHICLE WAS BRAND NEW. *TR

I JUST BOUGHT THIS JEEP 2 WEEKS AGO, EVERY TIME I GO TO FILL UP WITH GAS, NO MATTER WHICH GAS STATION I AM AT THE GAS ALWAYS COMES SPEWING OUT. I HAVE TRIED MANY THINGS, EVEN POSITIONING THE GAS HANDLE AT DIFFERENT ANGLES ECT. I HAVE DONE A LOT OF RESEARCH AND IT SEEMS THIS IS A FAULTY FUEL TANK/EVAP. THAT NEEDS TO BE REPLACED TO FIX THIS. I HAVE TALKED TO DEALER SHIPS SAYING THAT THE TANK NEEDS TO BE REPLACED. IN MY OPINION THIS SHOULD BE A RECALL. MY JEEP ONLY HAS 37000 MILES ON IT, AND I ALREADY HAVE TO REPLACE THE FUEL TANK!? I THINK JEEP/CHRYSLER NEEDS TO FOOT THE BILL ON THIS ONE... *TR

FUEL SYSTEM DOES NOT RESPOND TO A SHUT-OFF MECHANISM. EVERY TIME WE FILL UP THE GAS ON OUR 2005 WRANGLER UNLIMITED, GAS WILL COME BACK OUT AND SPILL DOWN THE SIDE OF THE JEEP AND SOMETIMES SPRAY SURROUNDING AREA. SO IF YOU ARE STANDING ANYWHERE NEAR IT, MOST LIKELY YOU WILL HAVE GAS ALL OVER YOURSELF. WE ARE THE SECOND OWNERS OF THE 2005 WRANGLER THAT ONLY HAD 5500 MILES ON IT WHEN WE BOUGHT THE JEEP AND NOW HAVE ABOUT 7500 MILES AND HAVE SEEN THIS ISSUE EVERY TIME WE FILL THE GAS TANK. DEALERSHIP WANTS $1400.00 TO REPLACE PLUS LABOR. *TR

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE CONTACT STATED THAT WHILE DRIVING 60 MPH OR ABOVE, THE VEHICLE WOULD SHAKE UNCONTROLLABLY. THE CONTACT HAD TO REDUCE SPEED TO REGAIN CONTROL. THE VEHICLE WAS TAKEN TO THE DEALER WHO TEST DROVE AND WAS ABLE TO RECREATE THE FAILURE IN THE VEHICLE HOWEVER, THEY ADVISED THAT THEY WERE UNABLE TO REMEDY THE FAILURE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE A DIAGNOSTIC WAS PERFORMED THAT LOCATED THE FAILURE AT THE STEERING ASSEMBLY. THE STEERING ASSEMBLY WAS REPLACED AND THE FAILURE WAS CORRECTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 75,000 AND THE CURRENT MILEAGE WA 82,000. THE DEALER DID ACKNOWLEDGE THERE WAS A PROBLEM WITH THE STEERING. HOWEVER, THEY DID NOT HAVE A FIX FOR IT. THE CONSUMER STATED HE FOUND A MECHANIC THAT WAS FAMILIAR WITH THE PROBLEM AND ALL FOUR CONTROL ARMS, TRAC BAR AND STEERING SHOCK WERE REPLACED. UPDATED 02/07/13

MY JEEP OVERFLOWS GASOLINE EVERYTIME I FILL UP AT THE PUMP! *TR

I HAD JUST BOUGHT AN UNLIMITED 2005 JEEP WRANGLER- THE FIRST TIME I STOPPED TO GET GAS I FOUND OUT VERY QUICKLY THAT THERE IS AN OVERFLOW PROBLEM WITH THESE MODELS. EVERYONE WHO IS A JEEP OWNER KNOWS ABOUT IT AND SAYS THERE ARE SOME FIXES, BUT THEY ARE LENGTHY. EVERYONE WHO ISN'T WONDERS WHY IT HASN'T BEEN RECALLED AND FIXED. THIS IS AN ONGOING PROBLEM THAT COULD POSE A LARGE HAZARD AT GAS STATIONS. *TR

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER 4X4. THE CONTACT STATED THAT AFTER FILLING THE FUEL TANK TO CAPACITY, GASOLINE WOULD SPILL FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THEY ADVISED HIM THAT THE FUEL TANK WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 52,000. THE CURRENT MILEAGE WAS APPROXIMATELY 54,000. THE VIN WAS UNAVAILABLE.

AUTOMATIC TRANSMISSION SHIFT LINKAGE CABLE BROKE. UNABLE TO START VEHICLE WITH TRANSMISSION SELECTED IN EITHER "PARK" OR "NEUTRAL." SHIFT LINKAGE CABLE REPLACED BY DEALER, NOT UNDER WARRANTY OR RECALL. *TR

FUEL TANK SPILL WHEN FUELING. HAPPENS EVERY TIME I FUEL THIS VEHICLE. GAS SPILLS OUT OF THE FILL TUBE WHEN PUMP SHUTS OFF. I THINK THIS COULD BE A SERIUOS FIRE HAZARD AND ENVIRONMENTAL DISASTER. *TR

GAS TANK OVERFLOWS WHEN FILLING. OCCURS AT BOTH HIGH/LOW SPEED AUTOFILL. WILL OVERFLOW AT MANUAL FILL AS WELL, UNLESS YOU HEAR GURGLING AND SHUT OFF PUMP BEFORE OVERFLOW. *TR

WHEN FILLING UP AT THE GAS STATION, GASOLINE SPILLS OUT ALL OVER THE PLACE, RUNS DOWN THE SIDE OF THE VEHICLE AND SPILLS OUT ONTO THE GROUND. *TR

WHEN FILLING THE FUEL TANK, THE PUMP WILL SHUT OFF BUT FUEL WILL SPILL OUT OF THE FUEL FILLER ACCESS ONTO THE SIDE OF THE JEEP AND THE GROUND. *TR

FUELING UP AT THE GAS STATION, CANNOT FILL UP WITHOUT GAS SPITTING OUT ONTO ME, THE VEHICLE, AND THE GROUND. NO OTHER VEHICLE I'VE OWNED HAS THIS PROBLEM, INCLUDING AN 03 JEEP WRANGLER AND A 2000 DODGE DURANGO, BOTH OF WHICH IN MORE RECENT MODEL YEARS HAVE HAD A RECALL FOR THIS SAME PROBLEM. IT IS AN ENVIRONMENTAL AND HEALTH HAZARD, AS FUEL IS A CARCINOGEN. *TR

EVERY TIME I FILL UP WITH GAS, THE ROLLOVER CHECK VALVE FAILS AND GAS GUSHES OUT ONTO GROUND. THIS IS A FIRE HAZARD AND ENVIROMENTAL ISSUE. *TR

WE HAVE HAD SEVERAL SHIMMY AND WOBBLE PROBLEMS AT VARIOUS SPEEDS. WE HAVE HAD THE VEHICLE TO THE DEALERSHIP FOR REPAIR OF THIS SEVERAL TIMES WITHOUT RESOLUTION (THE LATEST WAS AS RECENT AS 9/17/2012. FOR SAFETY WE NO LONGER DRIVE THE VEHICLE ON THE FREEWAY. *TR

WHILE FUELING THIS VEHICLE, AS THE TANK GOT FULL AND THE PUMP SHUT OFF, THE FUEL BELCHED OUT, AT FIRST I THOUGHT IT WAS THE GAS PUMP SO I HAVE TRIED DIFFERENT GAS STATIONS, IT HAS NOW GOTTEN TO THE POINT WHERE IT DOES IT EVERY TIME, AT EVERY DIFFERENT GAS STATION. I LOOKED ON THE INTERNET AND FOUND THAT IT IS A COMMON PROBLEM WITH PLENTY OF VIDEO TO SUPPORT THESE COMPLAINTS, WHAT IS DIFFICULT TO UNDERSTAND IS WHY YOU AREN'T DOING ANYTHING ABOUT IT. OTHER GOVERNMENT AGENCIES HAVE FORCED ALL GAS STATIONS TO LIMIT/RECOVER FUGITIVE EMISSIONS, BUT ALL THIS VIDEO EVIDENCE ISN'T ENOUGH TO SUPPORT A RECALL OF ALL AFFECTED VEHICLES? *TR

WAS ON VACATION IN ALASKA WHEN WE STARTED TO GET THE JEEP DEATH WOBBLE ( SHIMMY) . WE TRIED WHEEL BALANCE AS I THOUGHT MAYBE WE LOST A WHEEL WEIGHT. STILL SHIMMYING. INSTALLED A NEW STEERING DAMPENER AND THIS HELPED A LITTLE. STILL SHAKING AT AROUND 55 TO 60 MPH. ENDED UP BUYING 4 NEW TIRES AND THAT SEEMS TO HAVE HELPED BUT THERE IS ALWAYS A SLIGHT SHIMMY IN THE STEERING WHEEL. NOTHING LIKE B/4 THOU WHEN YOU WOULD HAVE TO SLAM THE BRAKES ON TO GET IT TO STOP SHAKING. WAITING FOR IT TO START AGAIN. *TR

THIS PROBLEM HAS BEEN OCCURRING SINCE THE FIRST WEEK I BOUGHT THE JEEP USED BACK IN 2007. I RETURNED TO THE DEALERSHIP THREE TIMES IN THE FIRST MONTH TO HAVE THEM BALANCE, ROTATE TIRES, CHECK ALIGNMENT. WAS TOLD I NEEDED NEW TIRES. NEW TIRES DOES FIX THE PROBLEM FOR A WHILE. I HAVE REPLACED BRAKES, ROTORS, TIRES, HAD ALIGNMENTS, ROTATIONS ETC. ONLY TO HAVE THE PROBLEM RECUR. I HAVE NOW FOUND THAT THIS PROBLEM IS CALLED THE "JEEP DEATH WOBBLE" AND HAS HUNDREDS OF LIKE COMPLAINTS. MY TIRE WOBBLES TERRIBLY AT AROUND 55 MILES PER HOUR. I AM NOW TOLD THAT I SHOULD REPLACE MY UPPER AND LOWER BALL JOINTS. CHRYSLER/JEEP HAS ALREADY ACKNOWLEDGED A SIMILAR PROBLEM ON THEIR LIBERTY. THEY NEED TO DISCOVER THE PROBLEM SO THAT WE CAN FIX THIS AND RIDE SAFELY BEFORE SOMEONE DIES FROM THIS DEFECT. *TR

EACH TIME I FILL THE GAS TANK, GAS GUSHES OUT ALL OVER THE SIDE OF MY JEEP AND SOMETIMES ON MYSELF. I AM AFRAID THAT SOONER OR LATER I'M GOING TO CATCH ON FIRE. PLEASE HELP. *TR

WHEN I HIT SPEEDS OF 50MPH, MY JEEP WOBBLES TERRIBLY. I HAVE READ NUMEROUS REVIEWS AND COMPLAINTS THAT THIS IS NOT UNCOMMON AND IT EVEN HAS A NAME, THE "DEATH WOBBLE". WE ARE GOING TO PASS THE JEEP ONTO OUR 16 YR OLD DAUGHTER, BUT WOULD LIKE TO KNOW IF IT IS GOING TO BE RECALLED OR IF IT IS FIXABLE. I WOULD HATE ANYTHING TO HAPPEN TO OUR DAUGHTER, ESPECIALLY IF JEEP IS AWARE OF THIS PROBLEM,

WE PURCHASED THE VEHICLE USED WITH AROUND 12,000 MILES LAST YEAR. EVER SINCE WE BOUGHT IT, IT WILL RUN OVER WHEN PUMPING GAS. IT DOES NOT CUT OFF SO YOU JUST HAVE TO LISTEN TO STOP IT. I GOOGLED AND SAW THERE HAVE BEEN ISSUES WITH OTHER YEARS. IT WOULD BE GREAT IF THE PROBLEM COULD BE FIXED. *TR

I AM EXPERIENCING FUEL SPIT-BACK DURING EVERY REFUELING OF MY VEHICLE. I PURCHASED A REPLACEMENT TANK AND THE PROBLEM HAS AGAIN OCCURRED ON THE REPLACEMENT FUEL TANK. I AM CONSIDERING A CLASS ACTION LAWSUIT AGAINST CHRYSLER TO FIX THIS PROBLEM WITH 2005-2006 JEEP WRANGLERS AS WELL AS THE 2007-2008 JEEP WRANGLERS. I KNOW A RECALL FOR THIS SAME ISSUE IS IN EFFECT FOR THE 2007-2008 JEEP WRANGLERS. HERE IS A LINK TO AN EDMONDS ARTICLE: HTTP://WWW.AUTOOBSERVER.COM/2011/02/CHRYSLER-REPLACES-SOME-FUEL-TANKS-FOR-GAS-SPIT-BACK.HTML HERE IS A LINK TO A JEEP FORUM WITH NUMEROUS COMPLAINTS FOR THE SAME ISSUE AND IT IS NOT ISOLATED TO THE 2007-2008 JEEP WRANGLERS: HTTP://WWW.WRANGLERFORUM.COM/F19/OVERFLOW-AT-THE-GAS-PUMP-46693-2.HTML. *TR

WHEN FUELING THE JEEP THE GAS OVERFLOWS. EVEN THOUGH WE ARE VERY CAREFUL IT IS IMPOSSIBLE TO GAS UP THE CAR AND NOT HAVE GAS ALL OVER YOUR HANDS AND THE GROUND. THE GAS DRIPS DOWN THE SIDE OF THE CAR AND IS A SERIOUS SAFETY CONCERN. WE HAVE TRIED DIFFERENT PUMPS AND DIFFERENT ANGLES TO NO AVAIL. IT IS NOT HUMAN ERROR AS WE HAVE OTHER VEHICLES THAT WE NEVER HAVE A PROBLEM AT THE SAME PUMPS WITH ANY OTHER CAR. *TR

WHEN REFUELING AND FILLING UP GAS TANK, THE AUTOMATIC GAS PUMP NOZZLE DOES NOT SHUT-OFF IN TIME RESULTING IN GAS OVERFLOW/SPILLING. TYPICALLY A FEW CUPS OF GAS WILL SPILL OUT BEFORE NOZZLE SHUTS OFF THE GAS FLOW. HAVE TRIED FILLING AT DIFFERENT GAS STATIONS, WITH DIFFERENT PUMPS, AND POSITIONING NOZZLE IN DIFFERENT POSITIONS BUT RESULT IS THE SAME AND GAS OVERFLOWS. ONLY WAY TO PREVENT IS TO GUESS HOW MUCH GAS IS NEEDED -- THEN STOP PUMP BEFORE TANK IS FULL -- THEN FILL REMAINDER OF TANK WITH PUMP ON SLOWEST SETTING. *TR

GAS TANK OVERFLOWS EVERYTIME I FILL UP. DOESN'T MATTER WHAT GAS STATION I GO TO, THE GAS ALWAYS SPITS OUT OF THE TANK AND ALL OVER THE SIDE OF THE CAR BEFORE THE PUMP STOPS. SOMETHING IS WRONG WITH THE TANK OR AN INTERNAL CHECK VALVE WHICH SHOULD PREVENT THIS. I CAN NEVER FILL THE GAS TANK UP FULL BECAUSE OF THIS ISSUE. THE ONLY FIX I HAVE FOUND THROUGH RESEARCH IS A BRAND NEW GAS TANK, WHICH IS RIDICULOUS. *TR

EVERYTIME I FILL THE GAS TANK THE GAS OVERFLOW ON TO THE GROUND AFTER THE GAS HOSE SHUTS OFF. *JS

AFTER I HAD MY TIRES ROTATED AND WAS TRAVELING ABOUT 45 MPH THE FRONT END BEGAN TO SEVERELY SHIMMY. IT OCCURRED SEVERAL TIMES. THE ONLY WAY TO GET IT TO STOP WAS TO DECELERATE. I HAD THE DAMPENER AND TIRES REPLACED (THEY WERE WORN UNEVENLY) TODAY. I HAVE MAJOR CONCERNS ABOUT THE SAFETY OF THE VEHICLE LONG TERM. THERE ARE MANY ANECDOTAL REFERENCES ON GOOGLE CONCERNING THIS BEING A MAJOR PROBLEM (GOOGLE SEARCH WRANGLER "DEATH WOBBLE." ) ONE STORY INDICATED THAT THERE WERE A LIMITED NUMBER OF FORMAL COMPLAINTS TO YOUR ORGANIZATION SO I WANTED TO MAKE SURE I ADDED A COMPLAINT AS THIS CONDITION COULD CAUSE AN ACCIDENT FOR AN UNSUSPECTING DRIVER. I WILL UPDATE THE RESULT OF THE REPAIR IN TERMS OF WHETHER IT RESOLVES THE INCIDENT OR NOT. *JS

THE VEHICLE GAS FILLER TUBE OVER FLOWS NEARLY EVERY FILL UP. GAS SPILLS OUT ONTO THE JEEP AND ONTO THE GROUND. *JS

APPROXIMATELY 1 YEAR AFTER PURCHASING MY USED 2005 WRANGLER, GAS STARTED TO OVERFLOW FROM THE FILLER TUBE UPON FUELING. THE FIRST TIME THIS OCCURRED, I THOUGHT IT WAS A DEFECTIVE PUMP SHUT-OFF AT THE STATION UNTIL IT HAPPENED THE NEXT TIME AND THE NEXT AND SO ON. I HAVE BEEN DEALING WITH THIS FOR AT LEAST 2 YEARS WITH NO RESOLVE. A GOOD AMOUNT OF GAS WILL SPILL OUT OF THE TANK ONCE THE TANK HAS REACHED CAPACITY, SPRAYING GAS ALL OVER THE VEHICLE AND THE GROUND. THIS CAN BE MINIMIZED BY SLOWING THE FLOW FROM THE NOZZLE, BUT THERE IS NO WAY TO TELL WHEN THE TANK IS GOING TO BE FULL OR NOT. THIS IS NOT ONLY A SAFETY ISSUE AS THERE IS NOW A VOLATILE SUBSTANCE ON THE GROUND, BUT AN ENVIRONMENTAL ISSUE AS THERE IS NOW GASOLINE THAT COULD EASILY ENTER THE GROUND WATER. IT IS UNACCEPTABLE THAT CHRYSLER IS AWARE OF THIS PROBLEM, HAS ADMITTED THAT IT AFFECTS OTHER MODEL YEARS YET REFUSES TO ACCEPT FURTHER RESPONSIBILITY. *TR

AROUND JUNE 2010, I PARKED THE VEHICLE IN A HOSPITAL PARKING LOT. UPON RETURNING TO VEHICLE, SHIFT LEVER JUST FLOPPED BACK AND FORTH. COULD NOT SHIFT OUT OF PARK. HAD JEEP TOWED TO JEEP DEALERSHIP. THEY REPLACED THE SHIFTER CABLE AT A COST OF OVER $300.00. TWO WEEKS AGO, JUNE 2012, WHILE DRIVING, JEEP SHIFTER BROKE AGAIN WHILE LOCKED IN DRIVE. SAME DEALERSHIP REPLACED THE SHIFT CABLE BUSHING. ANOTHER $100. I CALLED JEEP/CHRYSLER AND THEIR REPRESENTATIVE INFORMED ME THAT THEY HAD NO OTHER COMPLAINTS ABOUT THIS PROBLEM. FUNNY, SINCE THERE ARE MANY WEBSITES ABOUT THIS VERY, ONGOING, PROBLEM WITH JEEP SHIFTER CABLES. IN MY OPINION, THIS COULD BE A VERY DANGEROUS PROBLEM. THERE IS NO WARNING OF FAILURE. IF IT HAD OCCURRED A DAY PRIOR, I COULD HAVE BEEN BACKING DOWN THE BOAT RAMP! I FEEL A RECALL, OR AT LEAST, A NOTIFICATION TO JEEP OWNERS, SHOULD BE INITIATED BY JEEP/CHRYSLER. THANK YOU FOR YOUR TIME. *TR

WHEN FILLING UP THE JEEP WITH GASOLINE, GAS PUMPS WILL NOT CLICK OFF, AND THE FUEL TANK OVERFILLS, BUT SPRAYS OUT WITH GREAT FORCE SOAKING THE INDIVIDUAL PUMPING GASOLINE. *TR

WHEN REFUELING THE VEHICLE, THE AUTOMATIC SHUTOFF DOES NOT ENGAGE FROM THE VEHICLE ITSELF PROPERLY, CAUSING FUEL TO CONTINUE TO FLOW AND OUT AND ALL OVER THE SIDE OF THE VEHICLE. IT ALSO SPRAYS OUT AND ON THE OPERATOR FUELING THE VEHICLE. THERE IS A TECHNICAL SERVICE BULLETIN FROM JEEP ABOUT THE ISSUE, BUT ACTION HAS NOT BEEN TAKEN BY THE MANUFACTURER. I REQUEST THIS BE REPAIRED UNDER WARRANTY. MATERIAL SAFETY DATA SHEETS CLASSIFY GASOLINE AS A HAZARDOUS MATERIAL, KNOWN TO CAUSE HEALTH DEFECTS WHEN IN CONTACT WITH SKIN, AND ENVIRONMENTAL IMPACTS WHEN IMPROPERLY CONTAINED. *TR

FILLED UP FUEL TANK, WHEN IT GOT TO THE TOP IT DIDN'T SHUT OFF WITHOUT SPILLING OUT. NOW IT DOES IT ALL THE TIME. *TR

OUR 2005 JEEP WRANGLER HAS BEEN OVERFLOWING WHEN FILLING UP THE GAS TANK FOR TWO MONTHS NOW. THERE IS NO WARNING AND THE GAS SPEWS OUT OF THE NOZZLE/TANK. THE GAS OFTEN GETS ALL OVER MY SHOES, HANDS AND PANTS. WE ARE NOT IGNORING THE SHUT OFF CLICK, SINCE THIS PROBLEM BEGAN THERE HASN'T BEEN ONE. FOR OUR OWN SAFETY WE WAIT UNTIL THE GAS LIGHT IS ON TO GET GAS AND THEN ESTIMATE HOW MUCH GAS WE NEED IN ORDER TO STAY GAS FREE. WE HAVE RESEARCHED THE PROBLEM AND IT SEEMS TO BE A COMMON PROBLEM WITH JEEP AND CHRYSLER VEHICLES INVOLVING THE INLET CHECK VALVE, YET THEY HAVE DONE NOTHING. *TR

EVERY-TIME I FILL UP MY GAS TANK IT OVERFLOWS AND SPILLS OUT VIOLENTLY. *TT

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE CONTACT STATED WHEN HE SHIFTED THE VEHICLE IN REVERSE, THE GEAR SHIFT LINK FELL OFF AND THE VEHICLE WOULD NOT MOVE. THE CONTACT ALSO STATED THAT HE HAD TO CLIMB UNDERNEATH THE VEHICLE IN ORDER TO SHIFT IT INTO GEAR; WHERE HE RAN THE RISK OF THE VEHICLE ROLLING OVER HIM. THE DEALER WAS NOTIFIED AND STATED THERE WERE NO RELATED COMPLAINTS RELATED TO THE FAILURE. THE MANUFACTURER STATED THAT IF HE TOOK THE VEHICLE TO THE DEALER, THEY WOULD PAY A PORTION OF THE REPAIR COST. THE VEHICLE WAS REPAIRED; HOWEVER, THE FAILURE RECURRED. THE FAILURE MILEAGE WAS 25000.

RECENTLY PURCHASED THE WRANGLER USED. FUEL SPILL EVERY TIME YOU FILL THE GAS TANK. WHEN THE FUEL PUMP CLICKS OFF FUEL SHOOTS OUT THE FILL SPOUT. *TR

PURCHASE A USED 2005 JEEP WRANGLER (SPORT) WITH 103,000 MILES IN EARLY 2011. THE SIX SPEED MANUAL TRANSMISSION POPS OUT OF FIRST GEAR ABOUT ONCE A DAY WHEN ACCELERATING FROM A STOPPED POSITION. IT ALMOST SEEMS RANDOM, NEVER KNOW WHEN TO EXPECT THE EVENT. THE EVENT IS QUITE DISTURBING AND LOUD, WITH A LOUD "POP". THE JEEP ROLLS FORWARD BUT OUT OF GEAR. I MUST QUICKLY PUT IT BACK IN FIRST GEAR TO CLEAR THE INTERSECTION, RED LIGHT, ETC. WHAT IS GOING ON WITH THIS TRANSMISSION? IS IT NORMAL WEAR-AND-TARE, OR IS THERE A DESIGN DEFECT WITH THE TRANSMISSION? WHAT IS THE SOLUTION TO THIS UNSAFE DRIVING CONDITION? HAS THERE BEEN A RECALL? *TR

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED TWICE UNDER THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 05V460000 (POWER TRAIN:AUTOMATIC TRANSMISSION). THE CONTACT STATED THAT THE VEHICLE WAS PARKED AND ROLLED BACKWARD UNTIL HE ENGAGED THE EMERGENCY BRAKE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE CONTACT WAS ADVISED TO CONTACT THE MANUFACTURER. THE MANUFACTURER WAS NOTIFIED AND THE CONTACT WAS AWAITING A RESPONSE. THE FAILURE MILEAGE WAS 58,000.

ON FEBRUARY 18TH 2012, I PURCHASED A USED 2005 JEEP WRANGLER RUBICON FROM A JEEP DEALERSHIP. EVERY TIME I'VE FILLED UP FOR GAS, THERE IS AN OVER SPILL OF ABOUT 1/8 OF A GALLON. THIS HAPPENED ON 2/27/12, 2/29/12 , 3/15/12, 3/25/12, AND 4/23/12. EVEN WHEN SLOWING DOWN TOWARDS THE END OF THE FILL UP, IT STILL SPILLS OVER, JUST LESS SEVERE. I TOOK IT INTO THE DEALER. THEY PERFORMED A FUEL SYSTEM SOFTWARE UPGRADE ON 4/06/12, BUT THAT DID NOT CORRECT THE PROBLEM. THIS IS A HUGE NUISANCE (NOT TO MENTION SAFETY/FIRE HAZARD) AND FROM WHAT LITTLE RESEARCH I'VE DONE, DOES NOT SOUND LIKE AN ISOLATED PROBLEM. *TR

2005 JEEP WRANGLER. CONSUMER STATES WITHIN TWO WEEKS OF PURCHASE VEHICLE BEGAN EXPERIENCING ELECTRICAL PROBLEMS *TGW THE CONSUMER STATED THE HEATER/FAN SWITCH WAS REPLACED NUMEROUS TIMES. ON MARCH 22, 2010, SMOKE BEGAN EMITTING FROM THE VENTS INTO THE INTERIOR OF THE VEHICLE. WITHIN MINUTES, THE VEHICLE WAS FULLY ENGULFED IN FLAMES AND BURNED COMPLETELY TO THE FRAME. CHRYSLER DETERMINED THERE WERE NO MANUFACTURING DEFECTS DESPITE THE NUMEROUS PROBLEMS THE CONSUMER ENCOUNTERED WITH THE VEHICLE. *JB

I HAD BOUGHT A JEEP WRANGLER WITH APPROX 45000 MILES. RIGHT AROUND THE 55000 THE CHECK ENGINE LIGHT CAME ON AND THEN I STARTED HAVING GAS BLOW OUT OF THE GAS TANK DURING REFUELING. THE JEEP NOW HAS 85000 AND STILL HAS THE GAS BLOW BACK. I HAD TAKEN IT TO A JEEP DEALER AND THE MENTION THAT IT NEEDED A SMOKE TEST. I FOUND THAT I HAD A MAJOR EVAP LEAK IN THE FUEL SYSTEM, I HAD A MECHANIC REPLACE THE FUEL HOSES. AFTER THE REPAIRS. I STILL HAVE THE FUEL BLOW BACK. I LIVE IN THE VA BEACH AREA, WHERE FUEL ON THE GROUND CAUSES AN ENVIRONMENT PROBLEM ESPECIALLY WHEN I FUEL ON NORFOLK NAVAL BASE. I HAD FUEL SPRAYED ON ME AND ALSO CAUTIONED THE WIFE, WHO ALREADY HAD IT SPLASH ON HER FACE. LUCKILY, DID NOT SPRAY IN THE EYES. WHEN PUMPING GAS THE AUTOMATIC SHUTOFF DOES NOT KICK IN FAST ENOUGH BEFORE BLOW BACK OCCURS. IT HAPPENS WITH OUT WARNING. IS THERE A RESOLUTION TO THIS ISSUE WITH THE JEEP WRANGLERS? *TR

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE DRIVER WAS REFUELING WHEN FUEL WAS SPEWED OUT FROM THE FILLER NECK AND ONTO THE DRIVER'S LEG. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTICS. THE MECHANIC STATED THE FUEL TANK WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 20,000.

2005 JEEP WRANGLER UNLIMITED - THERE IS A BACK-SPLASH ISSUE WHEN FUELING THE VEHICLE, EVERY TIME! IF YOU DO NOT JUST STOP IT EARLY (BEFORE IT IS FULL) IT WILL SPLASH BACK EVERY TIME YOU FUEL, SOMETIMES QUITE A BIT OF FUEL SPILLED. I HAVE TALKED TO SEVERAL OTHER OWNERS OF THIS MAKE AND MODEL JEEP AND MOST OF THEM SAID THEY HAVE THE SAME PROBLEM. I CALLED CHRYSLER ABOUT THIS AND ASKED IF THIS WAS AN ONGOING ISSUE. THE REPRESENTATIVE SAID THEY WERE NOT AWARE OF THE ISSUE. I FIND THAT UNLIKELY. *TR

HELLO, I OWN A 2005 JEEP WRANGLER UNLIMITED. WHILE DRIVING ON THE HIGHWAY, TRYING TO "MAINTAIN" THE PROPER SPEED LIMIT, MY JEEP WILL DEVELOP A DEATH WOBBLE TO THE FRONT END. THIS ERRATIC AND ALMOST UNCONTROLLABLE BEHAVIOR OCCURS AT ANYWHERE FROM 55 TO 60MPH. AFTER TRYING TO RESEARCH THE SOLUTION TO THIS PROBLEM, I HAVE NOTICED MULTIPLE OTHER JEEP OWNERS HAVING THE SAME ISSUE. MY JEEP IS MY DAILY DRIVER, AND ALSO IS USED TO TRANSPORT MY 4 AND 5 YEAR OLD KIDS AROUND. DUE TO THE ECONOMY I CAN NOT AFFORD TO PURCHASE ANOTHER VEHICLE, NOR WILL I SELL THESE PROBLEMS TO SOMEONE ELSE. I AM SURPRISED THERE HASN'T BEEN MORE HIGHWAY RELATED INCIDENTS/FATALITIES DUE TO THIS ISSUE. ANY HELP WILL BE GREATLY APPRECIATED IN SOLVING THIS ISSUE. DEALERSHIPS ARE NO HELP AND I CANT AFFORD TO REPLACE THE WHOLE FRONT END JUST TO END UP WITH THE SAME PROBLEMS. THANK YOU FOR YOUR TIME IN THIS MATTER, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

SIGNIFICANT FUEL SPILLAGE WHILE FUELING VEHICLE AT THE POINT OF GAS PUMP CUT-OFF. FUEL IS "BURPED" OUT OF THE FUEL FILLING PORT ON THE VEHICLE ONTO PUMP OPERATOR'S HANDS, ARMS, AND CLOTHING, IN ADDITION TO THE SIDE OF THE VEHICLE AND FILL NOZZLE. THIS HAPPENS EVERY TIME THE VEHICLE IS FUELED NO MATTER WHERE IT IS FUELED, WHAT SPEED FUEL IS PUMPED AND WHETHER OR NOT THE NOZZLE IS BEING HAND OPERATED OR "AUTOMATICALLY" OPERATED. ON RESEARCH, THIS IS AN ENGINEERING FAILURE KNOWN BY CHRYSLER THAT IS DUE TO NON-ETHANOL RESISTANT PLASTICS BEING USED IN A CHECK VALVE CONTAINED IN THE FUEL TANK ASSEMBLY, CAUSING THE VALVE TO SWELL AND GET JAMMED WHEN FUEL CONTAINING ETHANOL IS USED IN THE VEHICLE. I WOULD THINK THAT DRIVERS, THEIR VEHICLES, AND THE GROUND BEING DOUSED WITH SIGNIFICANT QUANTITIES OF GASOLINE AT EVERY FUELING STOP WOULD QUALIFY AS A SAFETY ISSUE. *JS

WHEN FILLING GAS TANK, FUEL SPLASHES BACK OUT OF FILL PIPE. IT DOESN'T MATTER HOW FAST OR SLOW THE TANK IS FILLED, OR WHAT POSITION THE FILL NOZZLE IS PLACED IN THE FILL OPENING, IT SPLASHES BACK OUT OF THE FILL PIPE, COVERING THE SIDE OF THE VEHICLE, AS WELL AS THE PERSON FILLING IF STANDING TOO CLOSE. I SEE THIS AS A VERY DANGEROUS SITUATION, AS STATIC ELECTRICITY COULD EASILY IGNITE THE FUEL IN THIS SCENARIO. I'VE READ ON JEEP BLOGS THAT THE CURE IS TO REPLACE THE FUEL TANK DUE TO A DEFECTIVE VALVE IN THE TANK AT THE COST OF OVER $900. BUT UNFORTUNATELY THE REPLACEMENT TANK IS JUST ANOTHER DEFECTIVE TANK, AS THERE IS NOT AN UPDATED UNIT AVAILABLE, THUS SETTING UP ANOTHER FUTURE FAILURE. THERE IS NOT RECALL ON THIS, I THINK THERE SHOULD BE. PLEASE KEEP ME ADVISED OF ANY ACTIONS TAKEN IN THIS MATTER. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TR

FRONT END STARTS INTO A VIOLENT WOBBLE BETWEEN 50 & 55 MPH. THE ONLY WAY TO STOP IT IS TO SLAM ON THE BRAKES. I HAVE TRIED DIFFERENT TIRES AND DIFFERENT TIRE PRESSURES AND THE WOBBLE STILL PERSIST. THE SUSPENSION HASN'T BEEN MODIFIED IN ANY WAY AND THE ENTIRE VEHICLE IS IN STOCK CONDITION. I THINK THAT THIS IS A WELL KNOWN PROBLEM THAT COULD RESULT IN LOSS OF LIFE AND THERE SHOULD BE A RECALL TO FIX IT. *JS

WHEN FILLING GAS TANK NECK REPEATEDLY OVERFLOWS AT CUTOFF, SPILLING SEVERAL OUNCES OF GAS ON CAR AND GROUND. *JS

WHEN REFUELING THE VEHICLE, FUEL PUMP NEVER SHUTS OFF. THIS HAS BEEN A PROBLEM WITH THE VEHICLE NOW FOR A LONG TIME. THE FUEL SYSTEM ALLOWS THE PUMP TO CONTINUE RUNNING AFTER THE TANK IS FULL. IT DOES NOT MATTER WHAT GAS STATION I GO TO. GASOLINE ALWAYS OVERFLOWS AND SPILLS OUT ONTO THE GROUND. I WAS RECENTLY REFUELING MY AND THE VEHICLE AND THE PUMP DID NOT SHUT OFF. A SUBSTANTIAL AMOUNT OF GAS FLOWED OUT ONTO THE GROUND AND SOMETHING LIT THE FUEL VAPORS CAUSING A SMALL FIRE. I WAS ABLE TO PUT IT OUT WITH AN EXTINGUISHER. THIS COULD HAVE CAUSED THE ENTIRE GAS STATION TO CATCH FIRE/EXPLODE AND IS EXTREMELY DANGEROUS. *TR ..UPDATED 09/12/12 *BF UPDATED 09/12/2012 *JS

WHENEVER YOU FILL THE TANK IT OVERFILLS AND ENDS UP ON THE PAVEMENT. NO MATTER HOW SLOW OR FAST YOU FILL IT. *TR

GASOLINE SPEWS OUT OF TANK WHEN CLICKING OFF WHEN FULL. THIS CAN BE VERY DANGEROUS AND GETS GASOLINE ON MY TRUCK AND I HAVE HAD GASOLINE SPEWED ON ME BEFORE. IT'S NOT FUN GOING TO WORK SMELLING LIKE A GAS STATION. THERE ARE SO MANY COMPLAINTS ON THIS ISSUE, WHY ISN'T THE MANUFACTURER REQUIRED TO FIX THIS DANGEROUS PROBLEM? *TR

WHEN FILLING UP WITH GAS THE FUEL GUSHES OUT OF THE GAS HOLE WHEN THE PUMP CLICKS OFF. *TR

VEHICLE CONSISTENTLY SPEWS FUEL WHEN FILLING FUEL TANK REGARDLESS OF WHICH GAS STATION I USE. *TR

WHEN FILLING THE VEHICLE UP WITH GASOLINE AT A SERVICE STATION AN OVERFLOW CONDITION OCCURS WHERE A SIGNIFICANT VOLUME OF GASOLINE SPEWS OUT OF THE FILLER NECK. THE OVERFLOW OF GASOLINE IS ENOUGH TO DOUSE THE OPERATOR PERFORMING THE FILLUP, RUN DOWN THE SIDE OF THE VEHICLE, AND LEAVE A LARGE PUDDLE OF GASOLINE ON THE GROUND. *TR

FUEL SPILLS FROM FILLER NECK WHILE FILLING UP AND TANK IS FULL. GAS STATION PUMP DOES NOT TURN OFF. HAPPENS AT DIFFERENT GAS STATIONS 100% OF THE TIME. *TR

WHEN FILLING MY JEEP AT A GAS STATION GAS WILL OVERFLOW AND SPLASH OUT OF THE TANK WHEN THE PUMP STOPS. *TR

AS GAS TANK APPROACHES FULL WHILE FUELING, THE FUEL SPILLS OUT OF THE FILLER NECK AT A HIGH RATE WITHOUT WARNING. *TR

WHEN FULLING THE VEHICLE THE FUEL OVERFLOWS OUT OF THE GAS TANK SPILLING THE FUEL ONTO THE REAR OF THE VEHICLE AND GROUND. THIS HAPPENS EVERY TIME THE VEHICLE IS FUELED AND IT HAS HAPPENED AT DIFFERENT GAS STATIONS. *TR IT DOES NOT MATTER IF THE GAS HANDLE IS ON AUTO PILOT NOR MANUAL FUELING.

WHEN FILLING UP WITH FUEL, THE FUEL TANK SYSTEM DOES NOT AUTOMATICALLY SHUT OFF UNTIL AFTER FUEL HAS SPILLED OUT OF THE FUEL TANK DOOR AND ONTO THE GROUND. *TR

GAS TANK OVER FLOWS EVERY TIME AT FILL UP. *TR

WHEN FILLING THE CAR WITH GASOLINE, THE AUTOMATIC SHUT OFF DOES NOT OCCUR AND FUEL BLOWS OUT OF THE JEEP AND DOWN ON THE GROUND AND ME IF I AM CLOSE. IT APPEARS THAT A SUBSTANTIAL AMOUNT OF FUEL SPILLS. THIS OCCURS AT ALL FILL UPS IT IS NOT GAS STATION SPECIFIC. THIS CAN BE A DANGER IF IT SPEWS ON SOMETHING HOT. ALSO I WOULD THINK THAT IT'S AN ENVIRONMENTAL CONCERN AND IT STINKS. VERY FRUSTRATING PROBLEM! *TR

DEATH WOBBLE VIOLENT SHAKING OF STEERING WHEEL WITH AFTER MARKET PARTS I HAVE SPENT THOUSANDS OF DOLLARS TRYING TO FIX THE PROBLEM AND IT STILL DEATH WOBBLES JEEP NEED TO REIMBURSE PEOPLE FOR THIS IF I WOULD HAVE BEEN TOLD THIS BY A DISCLOSURE OF SOME SORT WHEN I WENT TO PURCHASE THE JEEP I WOULD HAVE NOT PURCHASED IT. *TR

WHEN FILLING THE VEHICLE'S FUEL TANK, FUEL SPLASHES OUT OF THE TANK AND COVERS THE SIDE OF THE JEEP AND THE GROUND BELOW. THIS HAPPENS WITH EVERY FILL UP. *TR

THE AUTOMATIC FUEL SHUT-OFF DOES NOT WORK CAUSING FUEL TANK TO BE OVERFILLED. I HAVE FUEL SPILLAGE EVERY TIME AND IT DOESN'T A MATTER HOW FAST THE FUEL IS PUMPED. *TR

PUMP KICKS OFF EVERY 2/10THS OF A GALLON WHILE PUMPING FUEL. HAPPENS WHETHER YOU ARE AT FULL FLOW OR JUST LETTING IT TRICKLE. *TR

THE DESIGN OF THE FUEL TANK IN THE WRANGLER UNLIMITED EDITION MADE FROM 2004 TO 2006 CAUSES IT TO HOLD AN AIR BUBBLE AND BLOW A LARGE AMOUNT OF GAS OUT OF THE FILLER SPOUT WHEN PUTTING FUEL IN. THIS HAPPENS EVERY TIME THE JEEP IS FILLED UP WITH GAS. THESE SPILLS ARE AN ENVIRONMENTAL ISSUE AS WELL AS A SAFETY ISSUE. *TR

EVERY TIME THAT I REFILL THE TANK, GAS WILL OVERFLOW OUT OF THE TANK AFTER THE PUMP SHUTS OFF. SOMETIMES THE GAS WILL SPRAY OUT VIOLENTLY, OTHER TIMES THE GAS WILL JUST SPILL DOWN THE SIDE OF THE JEEP AND ONTO THE GROUND. *TR

THE OIL PUMP DRIVE ASSEMBLY (OPDA) UPPER BUSHING HAS NO WAY TO LUBRICATE DUE TO MANUFACTURING ERROR IN THE 2005 AND 2006 4.0 ENGINE. THIS CAUSES HIGH METAL TO METAL SCRAPING SOUND AND WILL RESULT IN ENGINE FAILURE. HAPPENED AFTER 38000 MILES IN A WELL MAINTAINED VEHICLE. TALKED TO MANY JEEP DEALERS AND SERVICE TECH'S AND THEY REFUSE TO GIVE ANY ASSISTANCE OR SUGGESTIONS FOR A FIX. *TR

I RECENTLY PURCHASED A 2005 JEEP WRANGLER. EVERY TIME I FILL GAS, WHEN THE PUMP SHUTS OFF GASOLINE COMES SPRAYING OUT OF THE VEHICLE'S TANK AND ALL OVER THE GROUND. APPROXIMATELY A CUP OR MORE COMES OUT OF THE JEEP'S TANK. I THINK THIS IS A POTENTIAL FIRE HAZARD AND SHOULD BE ADDRESSED BY THE NHTSA AS SOON AS POSSIBLE BEFORE SOMEONE IS HURT BY THIS DEFECT. A RECALL FOR THE ITEM SHOULD BE MANDATED BY THE GOVERNMENT AND JEEP SHOULD BE FORCED TO FIX THIS PROBLEM. I HAVE RESEARCHED THIS PROBLEM ON THE INTERNET AND IT SEEMS PRETTY WIDESPREAD. *TR

GAS TANK SPITS BACK OUT GAS AS SOON AS THE FILLING STOPS. THERE IS ENOUGH GAS LOST TO SPILL DOWN THE SIDE OF THE JEEP AND ONTO THE GROUND. I HAVE USED DIFFERENT PUMPS AT THE SAME STATION AND FINALLY WENT TO OTHER STATIONS AND THE SAME HAS HAPPENED EACH TIME I GAS UP MY VEHICLE. I JUST RETURNED FROM THE JEEP DEALERSHIP AND THEY TOLD ME THE PROBLEM WAS IN THE CHECK VALVE AND I WOULD NEED A COSTLY REPLACEMENT OF THE WHOLE TANK. I SEE NOW THAT THIS IS A COMMON PROBLEM WITH THIS GAS TANK. LOSING EVEN A SMALL AMOUNT OF GAS IS COSTLY NOT TO MENTION THE POTENTIAL DANGER OF FREE GAS SPILLING OUT. A RECALL IS NEEDED WHICH IS NOT LIMITED TO ONLY CERTAIN YEARS. *KB

WHEN FILLING THE FUEL TANK, GASOLINE SHOOTS OUT THE FILLER NECK BEFORE THE PUMP SHUTS OFF. THIS HAPPENS CONSISTENTLY AND AT ALL GAS STATIONS TRIED. MY UNDERSTANDING IS THAT THIS IS NOT AN ISOLATED INCIDENT AND OCCURS ON MANY JEEP WRANGLER VEHICLES. *TT

FUEL GUSHES OUT OF TANK DURING EVERY FILL UP. MAYBE 3-9 FL. OUNCES POUR OUT, MAYBE MORE. THIS HAPPENS IF THE PUMP IS SET ON AUTO FILL, THE PUMP CLICKS OFF, BUT A SPLIT-SECOND LATER FUELS COMES OUT FOAMING. IF THE PUMP IS MANUALLY OPERATED AND THE LEVER IS EASED SO THAT IT PUMPS ABOUT HALF SPEED OR LESS, IT DOES NOT GUSH OUT. THIS HAS HAPPENED SINCE I BOUGH THE CAR NEW, I'M THE ORIGINAL OWNER. I HAS NEVER NOT DONE IT ON AUTO FILL AND IT TAKES SKILL TO AVOID IT. *TT

EVERY TIME I FILL UP MY GAS TANK, THE AUTO SHUT OFF DOESN'T HAPPEN UNTIL THE TANK OVERFLOWS, THIS HAS CAUSED GAS TO SPILL OUT SOMETIMES ONTO THE PERSON FILLING UP THE TANK. THIS HAPPENS EVERY TIME AT ANY STATION I USE. *TR

WHEN FILLING WITH FUEL, THIS JEEP SPITS FUEL BACK OUT THE FILLER ON YOU WHEN IT GETS FULL. HAPPENS LIKE 95% OF THE TIME NO MATTER HOW SLOW YOU FUEL IT. THIS WILL GET SOMEONE BURNED SOONER OR LATER. COMMON JEEP PROBLEM LISTED IN ONLINE FORUMS. *TR

FUEL FILL SPITS OUT FUEL EVERY TIME I FILL THE TANK. IT IS A DANGEROUS SITUATION DUE TO THE VOLATILITY OF GAS. *TR

GAS OVERFLOWS / SPEWS OUT WHEN FILLING UP DUE TO BAD DESIGN OF FUEL TANK VENT SYSTEM.

WHEN FILLING GAS TANK, GASOLINE SPEWS FROM THE FILLER NECK PRIOR TO THE AUTOMATIC SHUT-OFF ON THE PUMP ENGAGING. THIS HAS BEEN AN ISSUE WITH THIS PARTICULAR VEHICLE SINCE 2008.

FUEL TANK OVERFLOWS EACH AND EVERY TIME THE VEHICLE IS FILLED WITH FUEL. I HAD A 2004 JEEP WRANGLER AND NEVER HAD THIS PROBLEM.

A LARGE AMOUNT OF FUEL VIOLENTLY ERUPTS FROM TANK MOUTH WHEN FILLING AND OVERFLOWS ONTO THE VEHICLE, GROUND & MYSELF. THIS OCCURS AT EACH COMPLETE FILL-UP. THIS 2005 JEEP WRANGLER SPORADICALLY TRIPS OBD-2 CHECK ENGINE CODES FOR EMISSION EVAPORATIVE COMPONENTS, IN THE P0440-P0456 RANGE. *TR

WHEN FILLING THE GAS TANK THE PUMP WILL NOT AUTOMATICALLY SHUT OFF AND THERE IS A HUGE SPRAY OF GASOLINE OUT OF THE TANK. THIS HAPPENS ALMOST EVERY TIME, YOU ARE FORCED TO LISTEN TO THE SOUND OF THE GAS AND JUDGE WHEN IT IS ABOUT TO SPILL OUT IN ORDER TO PREVENT IT. (NOTE: I NO LONGER OWN THIS VEHICLE, BUT I AM DOCUMENTING IT HERE SINCE I HAVE HEARD THAT IT IS A COMMON PROBLEM.) *TR

GAS IS OVERFLOWING WHEN I FUEL UP. THIS HAS HAPPENED 5 TIMES ALREADY. *TR

FRONT END SHAKES VIOLENTLY AFTER HITTING A BUMP AND WILL NOT STOP SHAKING UNTIL VEHICLE IS BROUGHT TO A STOP. DEALER HAS ATTEMPTED TO FIX IT 5 TIMES BETWEEN AUGUST 06 AND JANUARY 07. DEALER REPLACED STEERING DAMPNER IN AUGUST, 2006. REPLACED TRAC BAR IN DECEMBER, 2006. I HAD INDEPENDENT SHOP CHECK FRONT END. FOUND NOTHING OUT OF SPEC. AT ONE POINT DEALER CLAIMED THAT IT WAS CAUSED BY TIRES. NEW TIRES FIXED PROBLEM FOR A SHORT TIME. HAD TIRES BALANCED 4 TIMES IN 2009. REPLACED STABILIZER SHOCK AGAIN IN AUGUST, 2009 AND AGAIN IN DECEMBER OF 2011 WITH HEAVY DUTY ONE. PROBLEM PERSISTS TODAY IN JANUARY OF 2012. *TR

THE FUEL ALWAYS SPEWS OUT OF THE TANK WHEN ALLOWING THE AUTOMATIC SHUTOFF OF THE GAS PUMP. IT HAPPENS WITH EVERY GAS STATION I USE. I WOULD ESTIMATE ABOUT 1 TO 2 CUPS OF FUEL SPILL OUT AND ONTO THE GROUND EACH TIME I FILL UP. I HAVE BEEN INFORMED THIS IS AN ISSUE THAT INVOLVES A FAULTY VALVE IN THE WRANGLER GAS TANK. JEEP NEEDS TO TAKE OWNERSHIP OF THIS ISSUE. *TR

AFTER FILLING THE FUEL TANK, THE GAS PUMP STOPS BUT THE GAS COMES GUSHING OUT OF THE FILLER TUBE. THIS HAS NOW HAPPENED EVERY TIME I HAVE FILLED UP MY JEEP SINCE THE FIRST TIME IT HAPPENED IN JAN 2011. *TR

MY 2005 JEEP WRANGLER TJ WILL SPIT FUEL EACH TIME I FILL THE VEHICLE (OVERFLOW) AND IT WILL SPILL GASOLINE ALL OVER THE SIDE OF THE VEHICLE AND ON THE GROUND. *TR

WHEN FUELING THE VEHICLE, GASOLINE OVERFLOWS AND SPEWS OUT OF THE GAS TANK OPENING. THIS HAPPENS EACH TIME THE VEHICLE IS FUELED AND OCCURS AS THE TANK REACHES FULL. THIS IS AN EXTREMELY DANGEROUS AND UNHEALTHY SITUATION WHICH NEEDS TO BE ADDRESSED BY THE VEHICLE MANUFACTURER. I WAS SHOCKED TO FIND THIS IS A KNOWN AND WIDELY REPORTED ISSUE, BUT NOT YET RESOLVED BY CHRYSLER. *TR

WHEN REFUELING A SIGNIFICANT QUANTITY (ESTIMATED AT 8 OUNCES OR MORE) OF GASOLINE IS "SPIT BACK" OR DISCHARGED FROM THE FUEL FILLER OPENING AS THE TANK REACHES FULL. THIS DISCHARGE PRODUCES A PUDDLE OF GASOLINE AT LEAST 24" IN DIAMETER AND LEAVES THE EXTERIOR AND UNDERSIDE OF THE FENDER DRIPPING WITH GASOLINE AND DEPENDING ON THE FILLER HOSE CONFIGURATION MAY SOAK THE CLOTHING OF THE PERSON OPERATING THE PUMP. THIS EVENT OCCURS EVERY TIME THE VEHICLE IS REFUELED UNLESS CARE IS TAKEN TO STOP ADDING FUEL BEFORE THE TANK REACHES FULL CAPACITY. CLEARLY THIS CREATES A VERY DANGEROUS, ENVIRONMENTALLY HAZARDOUS AND POTENTIALLY LIFE THREATENING SITUATION!! *TR

WHEN I TRY TO FILL MY TANK USING THE AUTOFILL OPTION ON THE FUEL PUMP HANDLE, THE FUEL DOESN'T SHUT OFF WHEN THE TANK IS FULL AND WILL COME SPLASHING OUT IN FORCE. MY SOLUTION THUS FAR IS TO BE AWARE OF THE GALLON AMOUNT AS I FUEL THE VEHICLE, THEN WHEN IT GETS FAIRLY CLOSE, I TRY TO TRICKLE THE FUEL IN SO AS NOT TO SPLASH TOO MUCH FUEL OUT ON TO THE GROUND OR MY PANTS AND SHOES. *KB

WHEN FILLING THE FUEL TANK WITH GAS, THE GAS PUMP DOES NOT SHUT OFF WHEN THE TANK IS FULL. THIS CAUSES OVERFLOW OF GAS FROM THE TANK. AN INTERNET SEARCH INDICATES THAT THIS IS A COMMON ISSUE WITH JEEP WRANGLERS. *TR

FUEL SPILLS WHEN GAS TANK IS FULL EVERY TIME I FILL UP THE JEEP. MY FATHER HAS THIS SAME PROBLEM ALSO. *TR

WHEN FILING GAS TANK, GAS DOES NOT SHUT OFF BEFORE OVERFILLING AND CAUSING A SPILLAGE ON GROUND AT GAS PUMPS. ALWAYS RUNS OUT AND IS DAMAGING PAINT AROUND FILLER HOLE. *TR

WHEN FILLING THE GAS TANK THE PUMP WILL STOP PUMPING GAS BUT THE FUEL WILL SPLASH OUT OF THE FILL PORT ON MY JEEP. THERE ARE MANY YOUTUBE VIDS SHOWING THIS PROBLEM. GAS IS EXPENSIVE SO I WOULD LIKE TO KNOW WHY THIS IS HAPPENING. *TR

WHEN FILLING THE GAS TANK, THE SHUTOFF VALVE TO PREVENT FUEL OVERFLOW DOES NOT APPEAR TO WORK PROPERLY AND THE RESULT IS THAT FUEL OVERFLOWS FROM THE FILLER NECK AND RUNS ALL OVER THE VEHICLE AND GROUND. THIS HAPPENS EVERY TIME IT'S FILLED UP REGARDLESS OF HOW QUICKLY OR SLOWLY I REGULATE THE FLOW OF FUEL INTO THE TANK. *TR

WHENEVER THE VEHICLE IS FILLED COMPLETELY WITH GAS THE GAS PUMP WILL QUIT PUMPING FUEL BUT 1/2 - 1 CUP OF FUEL SPILLS OUT EVERY TIME AFTER THE FUEL PUMP SHUTS OFF. *TR

EVERY TIME I FILL MY 2005 JEEP WRANGLER, THE FULL HOSE WILL NOT SHUT OFF AND GAS SHOOTS OUT ALL OVER THE FENDER AND THE GROUND. THIS HAPPENS AT ALL GAS STATIONS AND IT DOESN'T MATTER WHETHER I USE THE AUTO SHUT OFF OR HOLD THE NOZZLE, THE GAS STILL SHOOTS OUT CREATING A SAFETY AND ENVIRONMENTAL HAZARD. *TR

WHEN I WAS AT A GAS STATION THAT DIDN'T HAVE A FUEL VAPOR RECOVERY SYSTEM ON THE FUEL PUMP HANDLE, FUEL WOULD SPIT BACK OUT WHEN THE FUEL TANK GOT FULL, GETTING FUEL ON THE PUMP HANDLE AND DOWN THE SIDE OF THE JEEP. *TR

WHEN FILLING THE VEHICLE WITH GASOLINE IT WILL NOT STOP THE PUMP AND BEGIN TO OVERFLOW. *TR

FUELING STOPPER ASSEMBLY DOES NOT TRIGGER GAS STATION PUMP NOZZLE TO STOP DISPENSING FUEL ON TIME. THE RESULT IS SPILLED FUEL EVERY TIME DUE TO FUEL OVER FLOW FROM FUEL TANK WHEN EVER A FUEL FILL UP IS ATTEMPTED. THIS HAPPENS 100% OF THE TIME. *TR

INCIDENT MILEAGE ON MY REPORT IS DUE TO BUYING THE VEHICLE USED, BUT HAS MOST LIKELY OCCURRED SINCE DATE OF ORIGINAL PURCHASE. DUE TO AN BAD CHECK VALVE IN THE FUEL TANK, OVERFILLING OCCURS AT ALMOST EVERY FILL-UP, CREATING BOTH ENVIRONMENTAL CONCERNS AND POTENTIAL HAZARDOUS CONDITIONS. *TR

WHEN TRYING TO PUT GAS INTO TANK THE GAS OVERFLOWS OUT THE FILL TUBE. *TR

EVERY TIME YOU FILL THE FUEL TANK, FUEL SPILL'S OUT ON THE SIDE OF THE VEHICLE AND ON THE GROUND CAUSING A VERY DANGEROUS FIRE PROBABILITY. *TR

2005 JEEP WRANGLER. WELL MAINTAINED. HIGHEST QUALITY OIL, SPARK PLUGS, AIR FILTERS, COOLING SYSTEM. CAMSHAFT FAILURE AT ROUGHLY 50,000 MILES. EXCESSIVE WEAR CAUSING KNOCKING. DIAGNOSIS FROM CHRYSLER: NEW ENGINE REQUIRED. NO OVERHEATING, NO ABUSE. THE OIL PUMP DRIVE ASSEMBLY GEARS ARE WORN DOWN SO OIL IS NOT FLOWING PROPERLY. THIS IS A POSSIBLE CAUSE FOR THE CAMSHAFT FAILURE. THE OTHER POSSIBLE CAUSE FOR THE CAMSHAFT FAILURE IS THAT IT IS A FLAT TAPPET CAMSHAFT FROM THE FACTORY. THIS SPECIFIC TYPE OF CAMSHAFT NEEDS THE ZDDP OIL ADDITIVE. MODERN OIL DOES NOT CONTAIN ZDDP BECAUSE IT CAUSES CATALYTIC CONVERTER FAILURE. WITHOUT ZDDP EXCESSIVE WEAR OCCURS. THIS IS COVERED IN SAE BULLETIN # 770087. SAE IS THE SOCIETY OF AUTOMOTIVE ENGINEERS. ONCE WEAR REACHES A CERTAIN LEVEL FURTHER WEAR IS RAPID AND CAUSES CATASTROPHIC ENGINE FAILURE.FURTHERMORE, MY JEEP IS STILL UNDER POWERTRAIN WARRANTY. HOWEVER, MY WARRANTY HAS BEEN UNLAWFULLY DENIED BECAUSE I HAVE SOME UNRELATED AFTERMARKET PARTS ON MY JEEP. LITIGATION IS PENDING ON THIS ISSUE. CHRYSLER HAS GONE AGAINST THEIR OWN WRITTEN WARRANTY, AND WELL AS FEDERAL LAW (MAGNUSON-MOSS WARRANTY ACT). *TR

GAS SPILLS OUT WHENEVER I FUEL-UP. *TR

WHEN FILLING UP GAS TANK, GAS WILL SPILL OUT FOR FILL SPOUT BEFORE THE GAS NOSSEL SHUTS OFF. *TR

FUEL OVERFLOWS AND SPILLS ALL OVER THE EXTERIOR, GROUND AND SOMETIMES MY SHOES EVERY TIME I FILL MY GAS TANK. I KNOW THIS IS AN EXTREMELY COMMON ISSUE, AND AM HOPING FOR A RECALL. THANKS!!! *TR

GAS TANK SPILLS EVERY TIME I FILL IT UP. SQUIRTS OUT AND ONTO MY CLOTHES, GROUND, PAINT JOB AND FENDER. ME AND MANY OTHERS ARE HAVING THIS PROBLEM. RECALL!!!! *TR

WHEN I FILL MY 05 WRANGLER IT OVERFLOWS BEFORE PUMP SHUTS OFF,THIS HAPPENS EVERYTIME I FILL UP. *TR

GAS OVER FLOWS AND SOAKED MY PANTS. *KB

WAS DRIVING OVER 50 MILES PER HOUR WHEN I HIT A LITTLE BUMP AND MY WHOLE FRONT END OF MY JEEP STARTED TO SHAKE VIOLENTLY, I THOUGHT THE WHEELS WERE GOING TO COME OFF, I COULD BEARLY CONTROL THE STEERING WHEEL TO MAKE IT TO THE SIDE OF ROAD, I HAVE HAD LESS VIOLENT ONES BUT THEY ARE BECOMING MORE FREQUENT NOW, I JUST WENT TO DEALER AND THEY SAID MY STEERING DAMPER WILL HAVE TO BE REPLACED FOR 255.00 , I HAVE BEEN READING ALL THE COMPLAINTS ABOUT THIS " DEATH WOBBLE" AND ALL THE WORK THAT PEOPLE ARE HAVING DONE ONLY TO HAVE THE ISSUE COME BACK, I DO NOT WANT TO WASTE MONEY ON ALL THE THINGS THAT THEY WILL TRY AND REPLACE ONLY TO FIND ITS NOT THE REAL ISSUE. PLEASE HELP! *TR

I BOUGHT MY 05 JEEP LJ WRANGLER UNLIMITED WITH 20,600 MILES AND THE 1ST TIME I FILLED IT AT 20,800 AND EVERY SINGLE TIME IT WHETHER I HAVE THE HANDLE SET TO AUTOMATIC SHUTOFF OR HAND PUMP IT SLOW OR FAST DOESN'T MATTER WHAT GAS STATION IT SPEWS GAS ALL OVER BEFORE STOPPING TODAY AT 31K MILES I'VE HAD IT SLEW SO BAD I GOT SOAKED FROM THE WAIST DOWN HAVING MY LEGS FEEL A BURNING SENSATION ALONG WITH MY FEET DUE TO BEING SOAKED IN GAS!!!!!!!!!! I WANT A RECALL I LOOKED ONLINE MOST WRANGLER OWNERS COMPLAIN OF THIS ISSUE THIS ISN'T A SOLE COMPLAINT AS FAR AS IM AWARE WHY HASN'T IT BEEN RECALLED?? *TR

EVERYTIME I FILL UP MY VEHICLE THE NOZZLE DOESN'T KICK OFF, GAS POURS OUT THE FILLER NECK, GAS IS EXPENSIVE THESE DAYS TO JUST POUR IT ON THE GROUND AND BAD FOR THE ENVIRONMENT, I TRY TO NOT LET IT HAPPEN BUT STILL IT DOES, I FEEL THAT JEEP SHOULD BRING OUT A RECALL ON THIS. I CANT FILL MY VEHICLE UP ALL THE WAY AS I LIKE TO BE ABLE TO. THE FENDER FLARE IS DISCOLORED BECAUSE OF THE GAS SPILLING OUT ON TO IT AND THEN I HAVE TO GO AND GET THE GAS OFF MY HANDS AND SHOES WHEN I SHOULDN'T HAVE TO. I KNOW THERE ARE MORE PROBLEMS OTHER THAN MINE AS YOU CAN GO TO HTTP://WWW.JEEPFORUM.COM/FORUM/F176/HAVE-FUEL-SPILL-PROBLEMS-LIKE-MANY-US-SUBMIT-COMPLAINT-FORCE-RECALL-974337/ AND SEE MANY ON THERE HAS HAD THIS PROBLEM ASWELL AND HAVE VIDEOS OF THIS HAPPENING. IM JUST AFRAID THAT STATIC ELECTRICITY MY SPARK ON IT AT THE TIME THIS HAPPENS AND CAUSES A BIG MESS. PLEASE HELP ME AND OTHERS MAKE JEEP SEND OUT A RECALL ON THIS. MY VEHICLE IS COMPLETELY STOCK NO MODIFICATIONS HAS BEEN DONE TO IT TO ALTER THE WAY GAS GOES INTO THE TANK. THANK YOU FOR YOUR TIME. *TR

FUELS SPRAYS OUT OF THE FILL POINT WHEN FILLING AT A GAS STATION. I HAVE HAD IT SPRAY INTO THE AIR AND INTO MY MOUTH AND CLOSE TO MY EYES. I HAVE THE NOZZLE IN THE HOLE AND ON AUTO STOP AND WHEN IT IS FULL, THE PUMP STOPS THE FUELING AFTER THE FUEL COME SQUIRTING OUT. THIS IS A KNOWN PROBLEM AND I AM SICK AND DANG TIRED OF GETTING FUEL ALL OVER MY HANDS, FACE AND CLOTHING! *TR

THE ACCELERATOR (GAS PEDAL) INITIALLY FELT AS THOUGH IT WERE STUCK, AS IF THERE WAS A BLOCK UNDER IT, WHEN DRIVING AT APPROXIMATELY 20 MPH. THEN SUDDENLY THERE WAS UNINTENDED ACCELERATION WITH THE ACCELERATOR STUCK AT FULL THROTTLE. ONLY AFTER THE VEHICLE HIT 2 PARKED CARS DID THE VEHICLE COME TO A STOP.

WHEN FUELING VEHICLE GAS SPLASHES OUT OF FUEL FILLER INTAKE. THIS HAPPENS ON JUST ABOUT EVERY FILL UP. IT DOESN'T APPEAR TO MAKE ANY DIFFERENCE IF YOU FILL UP SLOWLY OR AT NORMAL FILL SPEED. GASOLINE SPILLING ON THE SIDE OF THE VEHICLE AND SPILLING ONTO THE GROUND CAN'T BE A SAFE THING.

FUEL TANK OVERFLOWS AT EVERY FILL UP REGARDLESS OF THE GAS STATION. *TR

EVERY TIME I FILL UP MY 2005 JEEP WRANGLER UNLIMITED THE TANK WILL OVERFLOW. IT DOESN'T MATTER IF I LET THE AUTO STOP CLICK TO STOP THE GAS OR IF I SLOW DOWN WHEN I KNOW IT IS GETTING FULL, THE GAS WILL OVERFLOW AND LEAK EVERYWHERE. IT'S A DECENT SIZE PUDDLE TOO, NOT JUST A COUPLE DRIPS. *TR

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE CONTACT WAS DRIVING 50 MPH WHEN THE FRONT OF THE VEHICLE BEGAN SHAKING EXTREMELY VIOLENTLY. THE CONTACT STATED THAT THE FAILURE WAS SO EXTREME THAT THE VEHICLE WOULD VENTURE OFF THE ROADWAY WHEN THE FAILURE OCCURRED. THE VEHICLE WAS TAKEN TO THE DEALER WHO INSPECTED THE VEHICLE AND WAS UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT PROVIDED NO ASSISTANCE. THE FAILURE MILEAGE WAS 39,000.

WHEN FILLING THE GAS TANK ON MY 2005 JEEP WRANGLER, I GET A BACK SPLASH OF GAS MORE OFTEN THAN NOT. I'VE TAKEN THE PRECAUTION OF SLOWING THE PUMP DOWN WHEN CLOSE TO FULL, BUT STILL SPILL GAS. WHEN I SPOKE TO CHRYSLER ABOUT ANOTHER ISSUE, I MENTIONED THE OVERFLOW ISSUE. I WAS TOLD TO HAVE THE "FUEL TANK INLET CHECK VALVE" LOOKED AT THE NEXT TIME I WAS AT THE DEALERSHIP. *TR

SPIT BACK OF FUEL WHEN TANK IS FULL. *TR

GAS TANK OVERFLOWS EVERYTIME DURING FILL-UP. *TR

UPON REFILLING MY 2005 JEEP WRANGLER UNLIMITED WITH GASOLINE WHEN THE GAS PUMP SHUTS OFF THERE IS A BLOW BACK OF ROUGHLY 1 QUART OF GASOLINE. THIS HAPPENS EACH AND EVERY TIME I RE-FUEL AND EACH TIME IT IS ROUGHLY THE SAME AMOUNT OF BLOW BACK. *TR

AT SPEEDS IN THE RANGE OF 45-50MPH, AND USUALLY AROUND 47MPH, THE STEERING WHEEL AND FRONT WHEELS WILL VIOLENTLY SHAKE AND WOBBLE FROM SIDE TO SIDE. THE ONLY WAY TO RECOVER IS TO EITHER SPEED UP OR SLOW DOWN. THIS SEEMS TO BE A COMMON PROBLEM WITH JEEPS AS THERE ARE YOUTUBE VIDEOS OF THE JEEP "DEATH WOBBLE". IT BECOMES VERY SERIOUS AND COULD CAUSE A PERSON TO LOSE CONTROL OF THE VEHICLE. THIS IS AN ONGOING PROBLEM, AND SEEMS LIKE SOMETHING THE MANUFACTURER SHOULD ADDRESS. *TR

EVERY SINGLE TIME I FILL MY JEEP UP WITH GASOLINE IT SPITS BACK AT ME. I HAVE TO STAND BACK WHILE FILLING THE TANK AND GAUGE APPROXIMATELY HOW MUCH GAS I AM LOW SO I CAN PREDICT WHEN TO SLOW DOWN THE PUMP, JUST TO SOFTEN THE AMOUNT OF GAS THAT IS SPIT BACK. THIS ONLY LIMITS THE AMOUNT THAT SPITS BACK, IT DOES NOT STOP IT ENTIRELY. HALF OF THE TIME I END UP WET WITH GASOLINE. *TR

WHEN FILLING UP THE JEEP WITH GAS THIS MORNING, FUEL SHOT OUT OF THE JEEP ABOUT 3 FEET AND ALSO RAN DOWN THE SIDE OF THE JEEP RIGHT WHEN THE FUEL PUMP SHUT OFF. HAD I BEEN STANDING IN FRONT OF THE FUEL TANK, I WOULD HAVE BEEN COVERED IN GAS TO INCLUDE MY FACE. THIS IS A KNOWN PROBLEM AND CHRYSLER NEEDS TO RECALL THIS! THIS IS NOT ONLY A SAFETY PROBLEM, BUT A HAZMAT PROBLEM AS WELL. *TR

EVERY SINGLE TIME I PUT GAS IN THE JEEP, IT OVERFLOWS. EVEN IF I LISTEN CAREFULLY AND TRY TO STOP IT BEFORE IT IS COMPLETELY FULL. IT SPRAYS GAS ALL OVER ME, THE PARKING LOT AND THE JEEP. THIS IS VERY DANGEROUS AND I'M AFRAID OF A FIRE. *TR

FUEL TANK OVERFLOWS EVERY TIME I FILL UP. GAS SPILLS ON THE GROUND. IT HAPPENS AT ALL THE GAS STATIONS I VISIT IN MULTIPLE STATES, INCLUDING TEXAS, ARKANSAS, MISSOURI, ILLINOIS AND INDIANA. *TR

EVERY TIME I FILL UP MY GAS TANK AT THE PUMP FUEL FLIES UP OUT OF THE TANK AND ALL OVER THE PLACE. EVERYTIME I FILL UP I HAVE TO CLEAN GAS OFF OF MY VEHICLE AND THE GROUND. *TR

WHILE FILLING UP MY 2005 JEEP WRANGLER NO MATTER THE SPEED OF THE GAS FLOW THERE IS A VERY LARGE AMOUNT OF GAS OVERFLOW. THIS HAPPENS EVERY TIME AND AT ALL GAS STATIONS I TRY. *TT

MY 2005 JEEP WRANGLER HAS STARTED SPITTING FUEL OUT WHEN I FILL UP. IT NEVER DID IT UP UNTIL THIS TIME. IT SPLASHES FUEL ON THE GROUND AND DOWN THE SIDE OF MY VEHICLE. WE ALSO GET A STRONG SMELL OF GAS IN THE VEHICLE WHEN IT HAPPENS. *TR

MY FUEL TANK OVERFLOWED DURING FUEL FILL UP. THIS HAS HAPPENED THE LAST 4 OR 5 TIMES CONSISTENTLY. I EVEN TRIED TO FILL THE FUEL TANK AT THE SLOWEST SPEED POSSIBLE AND IT STILL OVERFLOWED AND CAME OUT THE FILLER NECK WHEN FULL. *TT

DEATH WOBBLE AT SPEEDS BETWEEN 55 AND 60 MPH.L *TT

WHEN FUELING THE VEHICLE IT OVERFLOWS. THE FUEL ALWAYS OVERFLOWS BEFORE IT TRIGGERS THE PUMP TO STOP FUELING. *TR

EVERY TIME DURING REFUELING THE GAS SPITS, OR SPLASHES OUT. THIS CAUSES A SIGNIFICANT AMOUNT OF GASOLINE TO BE SPILLED ON THE VEHICLE AND THE GROUND. IT IS NOT ONLY A WASTE, AN ENVIRONMENTAL HAZARD, BUT A SAFETY HAZARD. PLEASE DISCUSS THE MATTER FURTHER WITH JEEP. I AM NOT THE ONLY OWNER WITH THIS ISSUE, AND FAR MANY MORE OWNERS HAVE YET TO REPORT THIS PROBLEM. *TR

WHENEVER I AM FILLING UP MY JEEP IT REGULARLY OVERFLOWS CAUSING FUEL TO SPILL ALL OVER MYSELF, VEHICLE, AND GROUND. IT TYPICALLY SPILLS FOR A FEW SECONDS UNTIL THE PUMP SHUTS OFF BUT IT IS A HASSLE, FIRE HAZARD, AND COSTLY. I AM AWARE OF MANY OTHER JEEP WRANGLER OWNERS THAT HAVE THIS PROBLEM. *KB

WHEN REFUELING, THE PUMP DOES NOT SHUT OFF BEFORE SPRAYING GASOLINE OUT OF THE TANK. THIS OCCURS WHETHER THE PUMP IS RUNNING FAST OR SLOW AND WHETHER THE NOZZLE IS ALL THE WAY IN OR NOT. *TR

WHEN FUELING AT GAS STATION THE FUEL DOES NOT CUT OFF AND FUEL SPILLS BACK OUT OF THE VEHICLE ONTO THE PERSON FUELING AND/OR THE VEHICLE AND GROUND. THERE IS NO WARNING AND THE PUMP DOES NOT CUT OFF. *TR

WHEN I FILL UP THE GAS TANK. THE VALVE IN THE TANK IS STUCK. SO IT WILL NOT AUTOMATICALLY TURN OFF THE PUMP CAUSING ME TO NOT KNOW IF IT IS FULL OR NOT. SINCE THERE IS NO WAY TO KNOW WHEN IT IS FULL IT SPILLS OUT IF THE TANK AND ALL OVER ME THE BODY OF MY CAR AND GROUND. THIS IS A WELL KNOWN COMPLAINT WITH ALL WRANGLERS IN THIS MODEL. PLEASE HELP FIX THIS. *TR

I WAS DRIVING ON THE BYPASS NEAR MY HOME AND EXPERIENCED "THE DEATH WOBBLE" BETWEEN 50-55 I THOUGHT THE FRONT END WAS FALLING OUT SO I SLOWED DOWN AND GOT TO THE SISE OF THE ROAD AND BEGAN CHECKING OUT THE VEHICLE. IT HAS HAPPENED SEVERAL TIMES SINCE. MY JEEP IS AT THE DEALERS AS I WRITE THIS GETTING CHECKED OUT. I THINK JEEP SHOULD PUT A RECALL ON THIS PROBLEM BEFORE SOMEONE GETS HURT OR KILLED. *TT

I DO NOT RECALL EXACTLY WHEN THIS ISSUE BEGAN. BUT MY 2005 JEEP WRANGLER RUBICON UNLIMITED SPILLS FUEL EVERY TIME I FILL UP THE TANK. THE GAS DOES NOT SHUT OFF WHEN FULL AND OVER A CUP OF FUEL SPILLS OUT. THE DEALER SHIP CLAIMS THAT THEY HAVE NEVER HEARD OF SUCH A PROBLEM ON JEEPS OLDER THAN 2007. *TT

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE CONTACT STATED THAT WHILE REFUELING THE VEHICLE, FUEL STARTED TO SPEW BACK OUT FROM THE FILLER NECK VALVE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 49,000 AND THE CURRENT MILEAGE WAS 50,000.

WHEN FILLING UP AT THE GAS STATION, GASOLINE SPILLS OUT ALL OVER THE PLACE, RUNS DOWN THE SIDE OF THE VEHICLE AND SPILLS OUT ONTO THE GROUND. *KB

FUEL OVERFLOWS FROM FILLER NECK EVERYTIME PURCHASING FUEL REGARDLESS OF FUEL STATION. THIS IS A SUBSTANTIAL QUANTITY OF FUEL THAT REPRESENTS A FIRE AND ENVIRONMENTAL HAZARD. FUEL SPLASHED OUT AND GOT ON MY 3.5 YEAR OLD DAUGHTER EVEN THOUGH SHE WAS STANDING AT WHAT WAS CONSIDERED TO BE A SAFE DISTANCE. IT IS NOT UNCOMMON FOR FUEL TO SHOOT OUT CLOSE TO 3 FEET. WHEN YOU THINK THE TANK IS ALMOST FULL EVEN WHEN SLOWING DOWN THE PUMP FUEL WILL STILL SPLASH OUT. *TT

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE CONTACT STATED THAT THE TRANSMISSION WAS FAILING. THE CONTACT STATED THAT WHEN RESTARTING THE VEHICLE AFTER DRIVING FOR A SHORT WHILE AND SHIFTING INTO DRIVE, THE TRANSMISSION WOULD HESITATE TO RESPOND. THE VEHICLE WAS INSPECTED BY THE DEALER AND WAS FOUND THAT THE COMPUTER NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 46,000 AND THE CURRENT MILEAGE WAS 52,000.

2005 JEEP WRANGLER GAS TANK SPILLS GAS OUT OF THE FILL LINE ONTO THE GROUND AT EVERY FILLUP, EVEN WHEN FILLING SLOWLY. AS I READ ON THE JEEP WRANGLER FORUMS THIS IS A VERY COMMON PROBLEM. *TR

THIS JEEP BOUGHT "USED' IN 2007 WITH 18K MILES AND NO MODIFICATIONS. NO POST-PURCHASE MODIFICATIONS HAVE BEEN MADE. PROBLEM FIRST NOTICED AT 20K MILES AND HAPPENS INTERMITTENTLY AND WITHOUT WARNING. AT 45+ MPH, WHILE ENTERING FREEWAY ON-RAMP OVERPASS, HIT EXPANSION JOINT IN ROAD. JEEP BEGAN TO VIOLENTLY SHAKE FROM THE FRONT END OF VEHICLE, AND STEERING WHEEL WOBBLED LEFT TO RIGHT, 5 TO 6 INCHES EACH SIDE, UNCONTROLLABLY. VEHICLE SOUNDED AND FELT LIKE IT WAS GOING TO LITERALLY FALL APART. DRIVER TRIED BREAKING GENTLY BUT VEHICLE CONTINUED TO SHAKE/WOBBLE EVEN WORSE. WITH DIFFICULTY, DRIVER GOT VEHICLE TO SIDE OF ROAD AND CALLED FOR HELP. ANOTHER OCCASION, WHILE DRIVING DOWNHILL 55 - 60 MPH AND DECELERATING, VEHICLE STARTED VIOLENTLY SHAKING/WOBBLING, UNPROVOKED BY ROADWAY DEFECT OR OBSTRUCTION. DRIVER BROKE HARD, DOWN-SHIFTED, GOT VEHICLE TO SHOULDER OF ROAD AND CAME TO COMPLETE STOP. WOBBLE DID NOT CEASE UNTIL CAR STOPPED. OTHER OCCASIONS, TYPICALLY WHILE DRIVING BETWEEN 45 - 60 MPH ON FREEWAY, STEERING WHEEL WILL START WOBBLING, SUBTLY AT FIRST, THEN ALL-OUT SHIMMY/WOBBLE FROM FRONT END. ON ONE OCCASION VEHICLE SEEMED TO SELF-CORRECT, BUT DRIVER SENSED WOBBLING TRYING TO RETURN. ON ALL OCCASIONS DRIVER(S) GRASPED STEERING WHEEL HARD TO TRY TO "CALM" VEHICLE. THREE DIFFERENT FAMILY DRIVERS (AND ONLY DRIVERS) OF THIS VEHICLE ALL EXPERIENCED SIMILAR VEHICLE MALFUNCTION. JEEP HAS BEEN TAKEN TO THREE DIFFERENT SERVICE CENTERS (CHRYSLER/JEEP, LES SCHWAB, KEN'S TIRES) FOR INSPECTION AND REPAIR. OWNERS PURCHASED SUGGESTED PARTS AND SERVICE EACH TIME. PROBLEM EVENTUALLY RETURNS. *TR

FUEL SPURTS OUT OF FILLER UPON EACH FILL UP PRIOR TO PUMP KICKING OFF. IT COMES OUT WITH ENOUGH FORCE TO GET ONTO CLOTHING, ETC. THIS IS AN OBVIOUS SAFETY HAZARD. *TR

DURING EACH FUEL FILL UP WITH MY 2005 JEEP WRANGLER UNLIMITED WHEN THE TANK REACHES ALMOST FULL, THERE IS A BACK SPLASH THAT OCCURS. FUEL IS FORCED OUT OF THE FUEL TANK AND SPILL OVER THE SIDE OF THE VEHICLE AND ON THE GROUND AROUND THE VEHICLE. *TR

THE GAS TANK OVERFLOWS AND SPITS BACK GAS EVERYTIME I REFILL THE JEEP'S FUEL TANK. WHEN THE AUTOMATIC SHUTOFF ON THE GAS STATION PUMP IS ENGAGED THE GAS SPRAYS OUT OF THE FUEL CAP AREA OF THE 2005 JEEP WRANGLER. THIS HAPPENS EVERY TIME REGARDLESS OF THE SPEED I AM FILLING THE TANK. *KB

FUEL OVERFLOWS AT ALL FILLUPS. *KB

WHEN PUMPING GAS, THE GAS TANK OVERFLOWS BEFORE THE GAS PUMP SENSES IT IS FULL. HAPPENS WITH A 99% CHANCE OF HAPPENING AND EASILY REPRODUCIBLE. *KB

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE CONTACT STATED THAT FUEL ESCAPED FROM THE FUEL TANK WHEN THE FUEL TANK WAS FULL. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP FOR A DIAGNOSTIC TEST AND THE TEST INDICATED THAT THE ROLLOVER VALVE FAILED. THE VEHICLE WAS ALSO TAKEN TO AN AUTHORIZED DEALER, BUT IT WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000 AND THE CURRENT MILEAGE WAS 53,000. THE VIN WAS UNKNOWN.

EVERY TIME I NEED TO FILL MY 2005 JEEP WRANGLER WITH GAS IT SPILLS OUT OF THE NOZZLE AND ALL OVER THE GROUND RIGHT AT THE PUMP. THIS SITUATION IS EXTREMELY DANGEROUS, BAD FOR THE ENVIRONMENT AND WASTEFUL. NO MATTER HOW THE NOZZLE IS HELD, WHAT GAS COMPANY I USE OR HOW SLOW I LET IT PUMP IN THE FUEL SEEMS TO CHANGE THE FINAL OUTCOME OF A LARGE SLOSH OF GASOLINE GUSHING OUT ONTO THE GROUND. AS AN ADDED CONSEQUENCE, MANY GAS STATIONS DON'T EVEN HAVE THE MEANS OR PROPER EQUIPMENT TO CLEAN UP THIS HAZARDOUS WASTE SPILL. I HAVE SEEN NOTHING RELEASED AND NO FIXES FOR THIS PROBLEM FROM JEEP OR ANY OTHER COMPANY BECAUSE APPARENTLY JEEP DOES NOT FEEL THAT IT IS IMPORTANT ENOUGH, DANGEROUS ENOUGH OR EVEN ENOUGH OF A PAIN TO THEIR CUSTOMERS TO OFFER A REMEDY. IF IT WASN'T SO DANGEROUS TO HOLD AN ELECTRONIC DEVICE WHILE FILLING MY VEHICLE, I'D HAPPILY SEND A VIDEO IN OF WHAT IT DOES WHEN IT REACHES THE TOP OF THE TANK. *TR

UPON FILLING THE GAS TANK, FUEL OVERFLOWS, AT TIMES IT SPRAYS ALL OVER THE PLACE. *TR

THE GAS TANK ON MY 2005 WRANGLER X HAS AN ISSUE WITH OVERFLOWING OR SPURTING GAS INSTEAD OF SHUTTING OFF LIKE IT SHOULD. THIS HAS HAPPENED AT ALMOST EVERY GAS STATION I HAVE TAKEN IT TO SO I'M CERTAIN ITS NOT AN ISSUE WITH A PARTICULAR PUMP. I HAVE ALSO READ ABOUT OTHER JEEP OWNERS HAVING THIS PROBLEM. *TT

I LOVE MY 2005 JEEP WRANGLER BUT I'M AFRAID IT'S GOING TO KILL ME OR CAUSE A MAJOR ACCIDENT. HITTING A BUMP OR ROUGH PATCH AT SPEEDS OVER 50 CAN TRIGGER A "DEATH WOBBLE." THE TIRES SPIN SIDEWAYS- UNCONTROLLABLY- AND THE CAR LITERALLY JUMPS AND SHIMMIES OUT OF CONTROL. IF I'M LUCKY I CAN GUIDE IT OFF THE FREEWAY TO A STOP. THIS HAPPENED A YEAR AGO AND I HAD MY TIRES ALIGNED, WHICH HELPED FOR A WHILE. IT STARTED AGAIN, SO I TOOK IT TO THE DEALER WHO ALIGNED MY TIRES AND REPLACED MY STEERING DAMPER. JEEP KNOWS ABOUT THIS PROBLEM- THERE'S A REPLACEMENT PART AVAILABLE FOR NEWER MODELS. I DRIVE CONSERVATIVELY, AND NEVER OFF-ROAD, AND HAVE NOT MADE ANY MODIFICATIONS TO THE FACTORY PARTS. THIS IS A DANGEROUS AND COMMON COMPLAINT- JEEP SHOULD BE MADE TO RECALL AND FIX THIS PROBLEM BEFORE PEOPLE ARE KILLED!! HOW CAN THERE HAVE BEEN NO ACTION TO DATE WITH SO MANY COMPLAINTS! *KB

WHEN FILLING UP THE GAS TANK IN MY 2005 JEEP WRANGLER GAS SPEWS OUT OF THE TANK ONCE FULL. *KB

I JUST BOUGHT A USED 2005 JEEP WRANGLER UNLIMITED RUBICON AND EVERY TIME I ATTEMPT TO FILL UP AT A GAS STATION, THE PUMP FAILS TO SHUT OFF CAUSING ABOUT A HALF GALLON OF FUEL TO SPILL OUT ONTO THE VEHICLE AND THE GROUND. THIS SPILLING HAPPENS EVERY TIME REGARDLESS OF THE STATION, THE PUMP AND/OR THE TECHNIQUE USED TO FILL (AUTO, MANUAL, FAST, SLOW, NOZZLE ALL THE WAY IN, PARTIALLY OUT ETC). *TR

2005 JEEP WRANGLER RUBICON UNLIMITED OVERFLOW FUEL ONTO THE GROUND (MORE THAN 1 CUP) AT EVERY FILL UP. THE TANK ALSO STOPS SHORT OF THE EXPECTED VOLUME. VEHICLE HAS 47K MILES AND IS PAST WARRANTY. AS STATED, THIS HAPPENS AT EVERY FILLUP. THE EVAPORATIVE CONTROL FILLING UNITS (LIKE FOUND IN HOUSTON) HAVE A FURTHER ISSUE OF NOT OPERATING FASTER THAN THE FIRST 'CLICK'. THE SAFETY AND ENVIRONMENTAL ISSUE IS DIRECTLY TIED TO THE RELEASE (SOMETIMES VIOLENT) OF FUEL FROM THE FILLER NECK ONTO THE GROUND OR BYSTANDERS. WATERSHED WILL PUSH THIS RAW FUEL DIRECTLY INTO STORM DRAINS, AND IN THIS AREA, INTO OUR DRINKING WATER AQUAFER RECHARGE ZONES. *TR

GAS OVERFLOWS WHEN FILLING UP. *TR

EVERY TIME I TRY AND FILL UP THE GAS TANK ON MY 2005 JEEP WRANGLER TJ, GAS OVERFLOWS DOWN THE SIDE OF MY VEHICLE. THIS HAPPENS AT ANY AND EVERY PUMP I GO TO. I'VE NEVER HAD THIS PROBLEM WITH ANY OTHER CAR. *TT WHY HASN'T THIS BEEN RECALLED? BESIDES BEING DANGEROUS, IT'S ALSO WASTING MY MONEY, SINCE UP TO A QUART OF GASOLINE COMES SHOOTING OUT EVERY TIME I FILL UP.

GAS OVERFLOWS AND SPILLS OUT ON EVERY FUEL FILL-UP ATTEMPT.

THE VEHICLE HAS SPEWED GASOLINE ALL OVER THE VEHICLE AND THE PERSON WHO FUELS THE VEHICLE SINCE THE FIRST TIME THE VEHICLE WAS FILLED WITH FUEL AFTER PURCHASE. THE ISSUE WAS REPORTED TO THE DEALER AND WAS IGNORED. THERE WAS NOTHING PRINTED ON WARRANTY PRINT OUT AFTER SERVICE FOR MULTIPLE ITEMS(STEERING DAMPENER). YEARS AFTER I SPOKE WITH SAME DEALER AND WAS TOLD TO BRING IT IN AS IT WAS A "COMMON" PROBLEM AND CHRYSLER HAD BEEN REPAIRING ON OTHER VEHICLES. UPON ARRIVAL THEY TRY TO CHARGE ME FOR REPAIR. I REFUSED. I AM STUNNED THAT THE NHTSA HAS ELECTED TO IGNORE THIS PROBLEM AND LABEL IT AS AN INTERNET SENSATION WHEN THERE IS LITERALLY A MOUNTAIN OF EMPIRICAL EVIDENCE. I CAN PROVIDE VIDEOS, PICTURES, AND MAKE MY SELF AVAILABLE FOR INSPECTION TODAY. I CAN SHOW THIS PROBLEM IS WIDESPREAD AND CAN BE REPEATED ON A LARGE NUMBER VEHICLES USING THE SAME PART. THIS IS ALSO AN ENVIRONMENTAL ISSUE AS LARGE QUANTITIES OF FUEL ARE BEING DUMPED ON THE GROUND ON A DAILY BASIS. I FIND THAT THE CHRYSLER AS WELL AS NHTSA ARE IN FACT NEGLIGENT BY NOT PURSUING THEIR INVESTIGATION OF THIS HAZARDOUS CONDITION. I HAVE TO QUESTION THE RELEVANCE OF NHTSA WHEN SUCH AN OBVIOUS DEFECT IS REPORTED ONLY TO BE IGNORED. YOUR ORGANIZATION HAS ESSENTIALLY TOLD THE VEHICLE OWNERS THAT IF THEY ORGANIZE ON THE INTERNET THEIR CLAIMS WILL BE CONSIDERED TO LACK MERIT. IN ADDITION, THE SAME PARTS IN OTHER CHRYSLER PRODUCTS CAN BE SHOWN TO HAVE BEEN CONSIDERED BY YOUR ORGANIZATION TO BE FAULTY, YET IGNORED IN EARLIER MODELS. IN FACT, CHRYSLER AT TIMES REPLACES THESE SAME PARTS AT RANDOM IN OTHER MODELS THAT HAVE NOT BEEN DECLARED IN A RECALL. *NOTE: THE DATE OF FIRST INSTANCE IS NOT CORRECT AS I CANNOT RECALL THE EXACT DATE OF PURCHASE. HOWEVER, THIS HAS OCCURRED EVERY SINGLE TIME I FILL THE VEHICLE UP AND HAS SO SINCE THE FIRST TIME. I PURCHASED THE VEHICLE USED BUT UNDER MFG WARRANTY

I PURCHASED MY JEEP WRANGLER RUBICON SAHARA IN JULY 2005. OVER THE YEARS, THE BIGGEST PROBLEMS I HAD WERE THE INFAMOUS SHAKING OF THE CAR AT SPEEDS OVER ABOUT 55MPH AND THE CONSTANT NEED TO JUMP THE CAR AND BUY NEW BATTERIES. THE LATTER PROBLEM SEEMED LIKE SOMETHING I COULD LIVE WITH BUT OVER TIME IT BECAME WORSE AND YOU COULD NO LONGER RELY ON THE CAR TO START. JEEP HAS ALWAYS BEEN VERY CAVALIER ABOUT THESE PROBLEMS, BUT THEY ARE REAL. MY CAR NOW HAS ONLY ABOUT 17,000 MILES ON IT BECAUSE OF THE RELIABILITY PROBLEM. IN JANUARY 2011 THERE WAS AN ELECTRICAL EXPLOSION AND SMOKE IN THE CAR. IT WAS TOWED TO LITHIA JEEP IN SANTA FE NM (WHERE I ORIGINALLY BOUGHT IT). THEY COULDN'T REALLY FIGURE OUT THE PROBLEM, BUT CHARGED ME FOR SOME REWIRING AND SENT IT BACK TO ME. WITHIN DAYS, THE BATTERY WAS DEAD AGAIN, SO I BOUGHT A NEW BATTERY. WITHIN DAYS, THAT BATTERY WAS DEAD AND THE CAR WAS AGAIN TOWED TO JEEP. THIS TIME, I FILED A FORMAL COMPLAINT WITH CHRYSLER, WHO ACCEPTED THE CASE.THE DEALER FIDDLED AROUND WITH THE CAR WITHOUT SUCCESS FOR A MONTH, BEFORE CHRYSLER AGREED TO ACCEPT MOST OF THE CHARGES FOR A COMPREHENSIVE REWIRING OF THE CAR. THE DEALER ALSO INFORMED ME AT THE TIME THAT IT WAS UNABLE TO DO THE RECALL WORK ON THE CAR'S TRANSMISSION, BECAUSE THE BOLTS SECURING THE TRANSMISSION HAD BEEN STRIPPED AT THE FACTORY. THIS SEEMED ODD TO ME, THAT A DEALER WAS TELLING ME IT COULDN'T DO THE RECALL WORK ON A DANGEROUS CONDITION, SO I JUST HAD TO LIVE WITH IT. IN MARCH THE DEALER COMMENCED THE INTENSIVE REWIRING WORK, AND BY APRIL, THE DEALER SAID THAT THE PROBLEM HAD NOT YET BEEN RESOLVED, SO IT WOULD NEED ADDITIONAL FUNDS FROM CHRYSLER. THIS CARRIED ON INTO MAY, AND I STILL DID NOT HAVE THE CAR. FINALLY, IN LATE MAY, THE DEALER CALLED AND SAID THEY "THOUGHT THE CAR MIGHT BE FIXED" BUT WEREN'T SURE, BECAUSE THE COMPUTER WAS STILL IDENTIFYING AN UNKNOWN DRAIN ON THE BATTERY WITH POTENTIAL ELECTRICAL SHORT IMPLICATIONS. NO MORE PROGRESS. ABOUT $3500 EXPENDED. *TR

PURCHASED 2005 JEEP WRANGLER X FROM INDIVIDUAL NOVEMBER 2010. VEHICLE HAD 21K MILES. DEATH WOBBLE OCCURS EVERYTIME VEHICLE REACHES SPEEDS ABOVE 45 MPH. JEEP IS OUT OF CONTROL AND YOU MUST COME TO A SWIFT, BUT COMPLETE STOP TO KEEP FROM LOSING CONTROL. DRIVER OF VEHICLE AND OTHER VEHICLES LESS THAN 10 FEET AWAY ARE IN DANGER WHEN THIS OCCURS. DISCOVERED THAT THIS PROBLEM IS COMMON TODAY AND I HOPE THAT JEEP COMES UP WITH A SOLUTION TO THIS ISSUE. *KB

DRIVING OVER UNEVEN ROAD SURFACES, MAN HOLE COVERS, POT HOLES, EXPANSION JOINTS IN CONCRETE, OR ANY RIPPLES IN THE ROAD SURFACE, WHAT IS COMMONLY KNOWN AS "DEATH WOBBLE" OCCURS. THIS IS AN UNCONTROLLABLE LEFT AND RIGHT PROGRESSIVE WOBBLE OF THE FRONT WHEELS. THIS WOBBLE DOES NOT STOP UNTIL THE VEHICLE IS SLOWED DOWN TO APPROXIMATELY 10 MPH. PARTS REPLACED HAVE BEEN THE STEERING STABILIZER, TRACK BAR BUSHINGS, PITMAN ARM AND PITMAN TIE ROD END, TIRES, TIRES BALANCED THREE TIMES (TWICE IN TWO WEEKS), ALIGNMENT PERFORMED TWICE, AND STEERING GEAR BOX ADJUSTED. TWO DIFFERENT JEEP DEALERSHIPS CLAIM THE STABILIZER IS THE PROBLEM, AND THE ONE REPLACED MUST BE FAULTY. DO THE RESEARCH, THE STEERING STABILIZER IS NOT THE PROBLEM... ONLY A MASK. THE "DEATH WOBBLE" HAPPENS DAILY. USUALLY MULTIPLE TIMES. *TR

FUEL OVERFLOWS OUTSIDE AND ON THE FLOOR WHEN CAR IS REFUELED. *TR

FUEL SPILLS/SPLASHES OUT WITH EVERY FILL-UP. NOZZLE POSITION OR RATE OF FILL DOES NOT CHANGE RESULT. HAVE ONLY EVER USED REGULAR UNLEADED FUEL, 87 GRADE W/ 10% OR LESS ETHANOL. APPROXIMATELY 1 CUP OF FUEL ENDS UP ON THE GROUND, THE BODY OF THE JEEP, SHOES, PANTS, AND/OR HANDS EVERY SINGLE TIME. THIS IS AN ENVIRONMENTAL AND HEALTH HAZARD.

HAVING TROUBLE WITH MY 2005 JEEP WRANGLER GOING INTO PARK. *TR

I BOUGHT A 2005 SE SPORT JEEP WRANGLER ABOUT TWO YEARS AGO. IN THE PAST FEW MONTHS I HAVE NOTICED VIBRATIONS INCREASING IN THE STEERING WHEEL AND JUST IN THE PAST MONTH THE SHAKINGS HAVE BECOME EXTREMELY VIOLENT BETWEEN 52-60 MPH, CAUSING ME TO HAVE TO PULL OVER AND STOP ON THE INTERSTATE. I TOOK IT TO THE SHOP AND HAVE HAD THE BRAKE PAD REPLACED, NEW SHOCKS, NEW ALIGNMENT, TIRES ROTATED, TIRES BALANCED, ROTORS REPLACED AND THE ENTIRE FRONT END CHECKED. THE SHAKING IS STILL PRESENT AND I CANNOT AFFORD TO KEEP REPLACING ONE THING AT A TIME WHEN NOTHING SEEMS TO HELP. THE VIOLENT SHAKING IS OCCURRING CONSISTENTLY EVERY TIME I REACH 52 MPH NOW AND I AM SCARED TO DRIVE IT ON THE INTERSTATE OR HAVE MY FAMILY DRIVE IT. I DON'T KNOW WHAT TO DO, WHERE TO GO OR WHO TO TALK TO TO HELP ME GET THIS FIXED WITHOUT COSTING ME MY ENTIRE MONTHS SALARY OR MORE. MY TIRES ALSO APPEAR TO BE WEARING WRONG DUE TO THE SHAKING, WHICH WILL COST ME MORE MONEY TO REPLACE. I HAVE DONE RESEARCH ON THIS "DEATH WOBBLE" AND AM FINDING THAT IT IS VERY COMMON. WE NEED SOMEONE TO HELP US SO NO ONE GETS SERIOUSLY INJURED AND SO WE AREN'T PAYING OUT OF POCKET FOR A TECHNICAL ERROR. *TR

2005 JEEP WRANGLER X, WHEN FILLING UP WITH GAS AT THE PUMP, THE GAS DOES NOT SHUT OFF WHEN FULL AND GASOLINE SPILLS OUT ALL OVER THE PLACE. *TR

WHEN FILLING THE GAS TANK, PRIOR TO GETTING FULL, THERE IS GAS "BURPING"/SPLASHING OUT OF THE FILL OPENING. *TR

GAS OVERFLOWS FROM THE FILL POINT EVERY TIME I REFUEL, REGARDLESS OF GAS STATION USED OR FILL SPEED. THIS PRESENTS A FIRE AND HEALTH HAZARD TO THE PERSON REFUELING. *TR

ON MY 2005 JEEP WRANGLER GAS OVER FLOWS OUT OF THE FILL TUBE EVERY TIME I GAS UP. I HAVE USED MANY DIFFERENT GAS STATIONS WITH THE PUMPS AT MANY DIFFERENT SPEEDS. NO MATTER WHAT I DO, THE GAS ALWAYS OVERFLOWS WHEN I GAS UP. IT HAS DONE THIS SINCE I PURCHASE THE JEEP 3 YEARS AGO. I WOULD ESTIMATE ABOUT A QUART OF GASOLINE SPLASHES OUT ALL OVER ME, MY JEEP, AND ON THE GROUND. THIS IS A SERIOUS FIRE AND SAFETY HAZARD. SOME THING NEEDS TO BE DONE. WHEN I LEAVE THE GAS STATION THERE IS A VISIBLE PUDDLE OF GASOLINE ON THE GROUND BECAUSE THE FUEL BACKSTOP VALVE IN THE JEEP DOES NOT STOP THE GAS FROM SPLASHING OUT. *TR

GAS TANK OVERFLOWS AND SPLASHES OUT GAS WHEN FILLING THE VEHICLE WITH GAS. IT OCCURS AT EVERY FILL UP AND AT VARIOUS GAS STATIONS/PUMPS. THE RESULT IS GAS SPLASHING AND FLOWING OUT OF THE FILLER NOZZLE POSING A FIRE HAZARD AND EXPOSURE TO A SOLVENT. THE GAS TANK WAS REMOVED AND THE VENT HOSES INSPECTED WITH NO ABNORMALITIES FOUND. *TR

WHEN FILLING THE GAS TANK THE GAS ALWAYS SPEWS OUT WITHOUT THE NOZZLE CUTTING OFF. *TR

FUEL SPRAYS OUT AND RUNS OVER SIDE OF FUEL INLET WHEN TANK HAS FILLED. THIS HAPPENS ON 100% OF FILLUPS, ELIMINATING A DEFECTIVE PUMP NOZZLE FROM POSSIBLE CAUSES. SPILLED FUEL CAN BE ANYWHERE FROM A FEW TABLESPOONS TO HALF A LITER. *TR

WHEN FILLING GAS TANK WITH THE LOCK ON THE PUMP, THE PUMP DOESN'T SHUT OFF UNTIL IT HAS OVERFLOWED. THERE IS ALWAYS GAS ALL OVER THE GROUND WHEN FINISHED. THIS EVENT OCCURS APPROX 98% OF THE TIME. *TR

GAS EXITS MY GAS TANK WITH FORCE BEHIND IT AFTER EVERY FILL UP. *TR

GAS SPITS OUT OF FILLER NECK BECAUSE THE PUMP WONT CUT OFF. *TR

MY 2005 JEEP WRANGLER RUBICON OVERFLOWS AND SPILLS WHEN FILLING THE GAS TANK. NOT JUST SOMETIMES, EVERY SINGLE TIME. *TR

DURING REFUELING OF THE VEHICLE, WHEN THE TANK GETS FULL IT WILL SHOOT GAS OUT ALL OVER THE PLACE. MANY TIMES IT HAS NOT ONLY SPLASHED ON THE GROUND AROUND THE JEEP, BUT ALSO ON ME. *TR

GAS SPRAYS OUT WHEN FILLING JEEP. *TR

WHEN FILLING THE CAR WITH FUEL AT VARIOUS GAS STATIONS OVER THE LAST 3 MONTHS THE FUEL PUMP DOES NOT SHUT OFF. THIS CAUSES GASOLINE TO SPILL OUT OVER THE FILLER NECK. THE SPILL IS STRONG ENOUGH WHERE IT SPEWS BACK A FEW INCHES TOWARDS THE PERSON STANDING NEXT TO THE TANK. *TR

TL* THE CONTACT OWNS A 2005 JEEP WRANGLER. THE CONTACT STATED THAT WHEN REFUELING THE VEHICLE, THE FUEL WOULD SPEW FROM THE TANK ONTO THE SIDE OF THE VEHICLE AND ONTO THE CONTACT. THE FAILURE RECURRED WHENEVER THE VEHICLE WAS REFUELED. THE VEHICLE WAS NOT INSPECTED OR REPAIRED AND THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CURRENT MILEAGE WAS 52,512 AND THE FAILURE MILEAGE WAS APPROXIMATELY 51,000.

TL*THE CONTACT OWNS A 2005 JEEP WRANGLER. WHEN ATTEMPTING TO ADD FUEL TO THE VEHICLE, THE CONTACT NOTICED THAT IT WOULD SPILL OUT ONTO HIS CLOTHING SIMILAR TO NHTSA CAMPAIGN ID NUMBER: 05V034000 (FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY:FILLER PIPE AND CAP). THE DEALER ADVISED THE CONTACT TO REPLACE THE FUEL TANK. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 24,000 AND THE FAILURE MILEAGE WAS 22,500.