2006 Chevrolet Silverado Extended Cab

The contact owns a 2006 Chevrolet Silverado 1500 equipped with Continental General Grabber STX tires, tire size 24570R17, DOT Number vynhhm55. The contact stated that all four tire sidewalls had begun to deuterating exposing the white another. The vehicle returned the tires to Walmart where they purchased the tires from who confirmed the tires needed to be replaced. The tires had not been replaced. The manufacturer was not made aware of the issue. The vehicle's approximate mileage of 72,000. The tire's approximate failure mileage was 169,000 with the first set of tires purchased and 169,000 miles with the second set of tires. The contact was unsure of which tires had what mileage due to several tire rotations being completed.

My air bag singnol is on

The Frame has excessive rust especially the crossmembers that are in-between the two main lateral frame beams. In this vehicle they have rotted all the way through and there is nothing left of them and they look like swiss cheese. This particular vehicle also has only 130,000 miles on it which I personally feel is very excessive for them milage. I do understand it is a little older at this point but I have a dodge van and a Chevy sedan both having over 200,000 miles on them. Both also have been driven in West Virginia all winter long with salt exposure that do not show this amount of rust in the frame components. I feel this is a flaw in the manufacturing I have been looking online and it seems to beyond a common problem with this make and model of vehicle.

EXHAUST MANIFOLD BOLTS BROKE OFF AND IS NOW LEAKING EXHAUST FUMES IN SIDE THE TRUCK ALSO EMISSIONS IS EFFECTED FOR OSHA OR EMISSION TEST THIS IS A PROBLEM OF SAFETY I HAVE SEEN ALOT OF PEOPLE WITH SAME PROBLEM AND YET NO RECALL ,IT IS A PROBLEM IN ALL PHASES OF OPERATION OF THE TRUCK ONLY HAS 49,000 MILES DON'T HAVE A PHOTO BUT SURELY YOU ARE REALLY FAMILIAR WITH THIS PROBLEM USUALLY ITS THE FRONT AND REAR BOLTS CAUSE IS INFERIOR MATERIALS AND WORKMANSHIP ALSO CAN CAUSE CATALYTIC CONVERTER FAILURE THE COST OF THIS REPAIR SHOULD BE ON GM AS IT CAN RUN 1000S TO FIX

THE INTERIOR LIGHTS ON THE GAUGES ALL TURN OFF MAKING IT HARD TO SEE THE SPEED LIMITS. BRAKES SOUND AS IF GRINDING BUT CANT TELL IF ITS BRAKES OR DIFFERENTIAL AND U JOINTS. NOISE GETS LOUDER IN THE CABIN OF THE TRUCK AS I DRIVE ON THE ROAD. 3. SIGNAL LIGHTS TURN ON BRIGHT WHILE ON LEFT HAND TURN SIGNAL. AND CIGARETTE LIGHTER AND OTHER COMPONENTS WONT WORK

THE PASSLOCK LIGHT COMES ON AND THE TRUCK WON'T START. THE INTERIOR LIGHTS GETS BRIGHT THEN DIM. BACK AND FORTH. WHEN THE PASSLOCK COMES ON IT WILL KEEP THE TRUCK FROM STARTING FOR DAYS AT A TIME. I'M AFRAID TO DRIVE THE TRUCK ANYWHERE

TRUCK DRIVING TRANSFER CASE GO IN NEUTRAL, THEN NEED TO PARK AND PUT THE TRANSMISSION IN PARK AND IN NEUTRAL, THEN PUSH THE 4X4 BOTTOM,THEN CHANGE TO 2WLD. MAKES A LOT NOISE.UNSAFE TO DRIVE.HAPPEN IN THE HIGHWAY.

DUE TO FAULTY UNDERCOATING FROM FACTORY THE BACK CROSSMEMBERS ROT AND CAUSE SHOCKS TO BECOME DISPLACED AND GAS TANK TO UNSECURED ALONG WITH REAR SHAKELS TO GO THREW THE BOTTOM OF TRUCK BED.... WILL COST OVER $2500 FOR REPAIRS

THERE'S COMMON PROBLEM WITH GAS LINES AND FRAMES RUSTING OUT THE 2006 CHEVY PICKUP TRUCKS THAT IS A SAFETY PROBLEM. THE PRICE FOR THE GAS LINES ARE WAY OVER PRICED AT $318.

DURING A TRIP WITH 6 MONTH OLD TIRES, TWO OUT OF 6 TIRES FAILED. ONE WAS A DEEMED A ROAD HAZARD BY THE MANUFACTURER. GIVEN THESE TIRES WERE PURCHASED AND INSTALLED ON A TOW VEHICLE WITH RATINGS FOR THE VEHICLE AND FAILED ON A 75 DEGREE DAY WITH A LIGHT MIST. I WOULD SUSPECT THAT THE TIRES ARE NOT CAPABLE OF MEETING THE RATED SPECS. THE TIRES WERE PURCHASED JANUARY FROM TREADWRIGHT CORP.

WE WERE DRIVING AND STARTED RUNNING REALLY ROUGH AND THE CHECK ENGINE LIGHT CAME ON. IT SAID REDUCED ENGINE POWER TOOK IT TO A SHOP THEY SAID IT WAS SOME WIRING THEY REPLACE THE WIRING ABOUT A MONTH LATER I WAS PARKED AT HOME STARTED THE TRUCK AND IT WAS DURING THIS SAME THING ANGELITE I JUST TURNED ON RUNNING ROUGH SAID LOW ENGINE POWER I TOOK IT BACK TO THE PLACE WE HAD TO WORK DONE THEY SAID A WIRE JIGGLED LOOSE AND THEY SCREWED IT BACK IN SAID I WAS GOOD TO GO LAST WEEK I WAS TAKING MY TRUCK TO GET IT INSPECTED WAS FINE ALL THE WAY TO TOWN PARKED IT AT THE SHOP GO IN AND TELL THEM I NEED INSPECTION THEY COME OUT START THE TRUCK SAME SCENARIO AS BEFORE ENGINE LIGHT WAS ON LOW ENGINE POWER RUNNING ROUGH COULDN'T GET IT INSPECTED THEY PUT THE CODE DEVICE ON IT AND IT SAID THROTTLE POSITION SENSOR HARNESS SOMETHING LIKE THAT

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE BRAKING SYSTEM HAD MALFUNCTIONED AND DID NOT STOP THE VEHICLE WHEN PRESSING THE BRAKE PEDAL CAUSING THE VEHICLE TO CRASH INTO A TREE. DURING THE CRASH, THE FRONT END EXPERIENCED SEVERE DAMAGE BUT THE FRONT AIR BAG DID NOT DEPLOY. NO INJURIES WERE REPORTED AND NO POLICE REPORT WAS FILED. THE VEHICLE WAS MANEUVERED TO A PARKING LOT AND A TOWING COMPANY WAS CALLED. THE COSMETIC DAMAGES WERE BEING REPAIRED AND THE CAUSE OF THE FAILURE WAS NOT DETERMINED AS OF YET. A LOCAL DEALER (UNKNOWN) WAS CALLED AND INFORMED ABOUT THE FAILURE. THE MANUFACTURER THEN CALLED THE CONTACT AND OPENED A CASE. THE FAILURE MILEAGE WAS 200,000.

AT 45,000 MI, HAD TO REPLACE ABS HUB SENSOR ASSY DUE TO FALSE ACTIVATION. I HAVE SINCE REPLACE 3 MORE ASSYS COSTING OVER $400 EACH OCCURANCE. AT 100,000 MI, HAD TO REPLACE A LEAKING BRAKE LINE WHICH HAD RUSTED THROUGH AND AT 120,000 MI LOST ALL HYD PRESSURE WHILE BRAKING TO AVOID SEVERAL DEER ENTERING THE ROADWAY. REPLACED ALL BRAKE LINES AT A COST OF $1200. THERE HAVE BEEN MANY CONSUMER COMPLAINTS ON BOTH ISSUES, BUT GM WILL NOT ASSUME RESPONSIBILITY FOR EITHER.THIS IS THE 9TH SILVERADO I HAVE OWNED OVER THE PAST 40 YEARS. NEXT ONE WILL BE A FORD.

RANDOMLY MY TRUCK WILL GO IN ENGINE POWER REDUCED AND TOP SPEED IS 35 MPH. IT HAPPENED A COUPLE OF TIME ON THE INTERSTATE. THE CODE THAT POPS UP IS P2135 AND I LOOKED IT UP ON LINE. THE INTERNET IS FULL OF FORMS AND VIDEOS ABOUT THIS PROBLEM. EVERYTHING ON THE INTERNET POINTS TO THE THROTTLE POSITION SENSOR. I'VE REPLACED IT TWICE AND REPLACED THE THROTTLE BODY TWICE AND WIRING TWICE. I PUT TRUCK IN THE SHOP THREE TIMES. SPENT A GOOD $1500 TRYING TO FIX THE PROBLEM AND IT STILL POPS UP EVERY COUPLE OF MONTHS.

ANYTIME A TRAILER IS FIRST ATTACHED, THE TRUCK WILL RANDOMLY GO INTO REDUCED POWER MODE WHILE DRIVING. THIS IS VERY UNSAFE AS THE TRUCK CAN TO THIS AT HIGHWAY SPEED IN TRAFFIC. IT WILL DO THIS A FEW TIMES UNTIL THE PCM "LEARNS" THERE IS A TRAILER ATTACHED. GM IS AWARE OF THE ISSUE AND ISSUED SERVICE BULLETIN 06-06-04-042B TO ADDRESS THE ISSUE BY REPROGRAMMING THE PCM. BECAUSE OF THE SAFETY CONCERNS, THIS SHOULD BE ADDRESSED AS A RECALL. HOWEVER,I HAD TO TAKE THE TRUCK INTO THE DEALER FOR THE UPDATE AND WAS EXPECTED TO PAY FOR THEM FIXING A KNOWN SOFTWARE ISSUE. INSTEAD OF DOING THE UPDATE AT NO CHARGE, THEY MANAGED TO DAMAGE THE PCM WHILE PERFORMING THE UPDATE. THE PCM IS NO LONGER SERVICEABLE AND THE DEALER IS WANTING TO CHARGE ME FOR A REPLACEMENT EVEN THOUGH IT WAS DAMAGED DURING A CALLED FOR SERVICE BULLETIN UPDATE. THE VEHICLE WAS NOT ORIGINALLY EQUIPPED WITH A TRAILER HITCH SO THE PROBLEM DIDN'T ARISE UNTIL THE HITCH WAS INSTALLED AND A TRAILER WAS ATTACHED.

BRAKE PEDAL GOES TO FLOOR WITHOUT WARNING AT LOW SPEED.

BRAKE LINES HAVE ROTTED OUT AND NEED TO BE REPLACED

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 3500. WHILE THE CONTACT WAS TURNING INTO HIS DRIVEWAY AT 5 MPH, THE BRAKE LINE FRACTURED WITHOUT WARNING. THE CONTACT ATTEMPTED TO DEPRESS THE BRAKE PEDAL, BUT IT FAILED TO ENGAGE AND THE VEHICLE DID NOT COME TO A COMPLETE STOP. THE EMERGENCY BRAKE WAS NOT APPLIED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 42,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE UNDERCARRIAGE WAS RUSTED. IN ADDITION, THE BRAKE AND STEERING WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO CAPE COD CARZ (153 CORPORATION ST, HYANNIS, MA 02601, (508) 778-2279) WHERE IT WAS DIAGNOSED THAT THE FRAME NEEDED TO BE WELDED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE FRAME, BODY, AND BRAKE LINES WERE ALL RUSTED OUT. BEST CHEVROLET (128 DERBY ST, HINGHAM, MA 02043, (781) 347-1886) WAS CONTACTED AND STATED THAT THERE WAS NO RECALL. THE MANUFACTURER HAD NOT BEEN CONTACTED. THE FAILURE MILEAGE WAS 212,000. *TT*JB

IN LATE FEBRUARY 2019, I ACQUIRED A TRUCK FROM A USED DEALERSHIP THAT I HAVE DONE BUSINESS WITH BEFORE. UPON OBTAINING THIS VEHICLE I STARTED HAVING ISSUES RIGHT AWAY. FIRST ISSUE I ENCOUNTERED, I WAS DRIVING BACK TO KANSAS CITY FROM LEBANON,MO AND ALL OF THE SUDDEN MY BRAKES WENT OUT AND MY STEERING LOCKED UP AND TRUCK STARTED JERKING REALLY BAD. I DROVE LIKE THIS ALL THE WAY HOME AND TOOK IT TO A MECHANIC AND LOW AND BEHOLD IT'S COST ME $100 TO REPAIR THE PROBLEM. SHORTLY AFTER I NOTICED MY TRUCK WAS HAVING ISSUES WITH GETTING UP TO SPEED WHILE GETTING ON THE HIGHWAY. I WOULD END UP HAVING THE PETAL TO THE FLOOR AND IT WOULD STILL ACT LIKE IT DIDN'T WANT TO ACCELERATE ALMOST LIKE A DELAY AND THEN SLOWLY GAIN SPEED. IT FELT AS IF IT WAS SLIPPING OR IT JUST WASN'T GETTING ANY POWER. MY OIL PRESSURE SENSOR HAD WENT OUT WITHOUT ME KNOWING AT THE TIME SO I THOUGHT THE PROBLEM HAD TO DEAL WITH MY OIL PUMP. I FINALLY TOOK IT BACK TO THE MECHANIC I USED BEFORE AND HE RAN A DIAGNOSTIC TEST ON MY TRUCK DUE TO HIM NOT FINDING ANY ISSUES BESIDES MY OIL PRESSURE SENSOR WAS DEFECTIVE. THE DIAGNOSTIC CAME BACK WITH MULTIPLE CODES AND 3 OF THEM HAD TO DEAL WITH THE TRANSMISSION. I DECIDED TO TAKE MY TRUCK TO MY BROTHER AND HAVE HIM LOOK AT IT FOR A SECOND OPINION. UPON DOING SO HE TEST DROVE AND INSPECTED THE TRUCK ENTIRELY AND CONCLUDED THAT HE DIDN'T FEEL THERE WAS AN ISSUE WITH THE TRUCK AT ALL. HE RAN HIS OWN DIAGNOSTIC ON IT AS WELL BUT HIS CANE BACK WITH NO CODES THAT CAME UP AT ALL. SO I DROVE OFF CONFUSED BECAUSE OF ALL THE DIFFERENT INFORMATION THAT WAS GIVEN TO ME ON TOP OF THE PROBLEMS I KNEW I WAS HAVING BECAUSE THE TRUCK WASN'T RUNNING LIKE IT DID WHEN I DROVE IT OFF THE LOT. SOME TIME PAST AND THEN ANOTHER PROBLEM. MY BRAKES AND ROTORS WERE TRASHED AND NEEDED TO BE REPLACED ASAP AND THEN MY ODOMETER STARTED READING SERVICE AIR BAG AND WOULD NOT GO OFF.

TAKATA RECALL. THE SERVICE AIRBAG SOON LIGHT IS ON.

I PARKED MY TRUCK THE BLOWER WORKED FINE GOT IN IT 2 HOURS LATTER AND IT DID NOT WORK.THE WIRES TO MY BLOWER MELTED AND HOT ALMOST STARTED A FIRE IN MY TRUCK. NO SMELL NO SIGN OF THE WIRES GETTING HOT. THE ONLY THING I NOTICED WAS THE CONTROL PANEL GOT HOT WHEN IT WAS ON SO I KEPT IT OFF. IF I HAD NOT TAKEN IT TO THE SHOP 2 DAYS AFTER MY BLOWER STOPED WORKING I MIGHT NOT HAVE MY TRUCK. IT MIGHT HAVE CAUGHT FIRE WITH MY KIDS AND I IN IT OR WITH MY 17 YEAR OLD DRIVEING. A RECALL ON THIS PART WOULD BE NICE OR FIND OUT WHY IT IS DOING THIS.

WHILE DRIVING ON A DIVIDED 4 LANE HIGHWAY AT NIGHT, SEVERAL DEER RAN IN THE PAT( OF OUR VEHICLE. I APPLIED THE BRAKES, SND THEY WENT ALL THE WAY TO THE FLOOR. WE SLOWED DOWN BUT WERE UNABLE TO STOP. LUCKILY THEREVWAS NO ONE BESIDE US AND WE WERE ABLE TO AVOID THE LAST DEER BY SWERVING INTO THE LEFT LANE. I COULD ELL THERE WAS NO PRESSURE IN MY BRAKE PEDAL AFTER THAT. WE WERE ABOUT 20 MILES FROM HOME BUT I ONLY HAD 2 MORE STOP SIGNS UNTIL OUR RESIDENCE. THE BRAKE WARNING LIGHTS ON THE DASH DIDNT COME ON UNTIL LESS THAN 1/4 MILE FROM MY HOUSE. THERE WAS ALSO AN AUDIBLE ALARM AT THAT TIME. WAS ABLE TO COAST INTO MY DRIVEWAY AND GET STOPPED FROM THERE. THE MECHANIC SAID THE BRAKE LINES WERE CORRODED AND ONE HAD BURST. THE ADDITIONAL STRESS CAUSE BY THE RUPTURING OF THE LINE THEN AFFECTED THE OTHER LINES. I HAD TO PAY TO REPLACE ALL THE BRAKE LINES BEFORE IT WAS SAFE TO DRIVE AGAIN.

TAKATA INFLATORS: MY 2006 CHEVY 3500 DRIVER SIDE AIRBAG DEPLOYED OVERNIGHT WHILE THE TRUCK WAS LOCKED, NOT RUNNING, AND HAD NO KEYS IN IT IN MY DRIVEWAY. THIS IS UNACCEPTABLE! THE TRUCK WAS NOT IN AN ACCIDENT. THANKFULLY I WASN'T DRIVING DOWN THE ROAD WHEN IT DEPLOYED, OR I COULD HAVE BEEN KILLED. 2006 SHOULD BE INCLUDED IN THE RECALL. MY TRUCK WAS MANUFACTURED 5/2006 AND THE RECALL INCLUDES TRUCKS MADE 12/2006 AND NEWER. WHAT CAN BE DONE BY CHEVY TO PAY FOR MY REPAIR? ADDITIONALLY, THE NIGHT BEFORE THE AIR BAG DEPLOYED ON ITS OWN THE PASSENGER SIDE REAR WINDOW FELL INTO THE DOOR. AGAIN IT WAS PARKED IN THE DRIVEWAY LOCKED NOT RUNNING, KEYS NOT IN IT!

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE CHECK PASSENGER AIR BAG WARNING INDICATOR ILLUMINATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO BILL BLACK CHEVROLET (601 E BESSEMER AVE, GREENSBORO, NC 27405, (877) 352-6596) TO SCHEDULE A DIAGNOSTIC APPOINTMENT. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 170,000.

SUDDEN LOSS OF BRAKING ABILITY. ONE MINUTE BRAKES WORKED, BUT PEDAL WENT TO FLOOR ON SUBSEQUENT USE. INSPECTION REVEALED THIS WAS DUE TO RUST-THROUGH OF THE RIGID BRAKE LINES ON THE DRIVER'S SIDE FRAME

DID NOT INFLATE DESPITE 3 GOOD "SWATS" TO THE NOSE OF THE VEHICLE. VEHICLE RUNNING GOING THRU CORNERS AT APPROXIMATELY 35 MPH

MY 2006 CHEVY SILVERADO 1500 EXTENDED CAB HAS JUST OVER 116000 MILES ON IT AND THERE IS A LOUD KNOCKING COMING FROM THE #2 LIFTER. IT ONLY DOES IT WHEN IT GETS WARM OR GIVEN GAS ON TAKE OFF.. IT DOESN'T DO IT WHEN IDLING. I KNOW 2 OTHER PEOPLE THAT HAVE THE SAME YEAR AND MODEL TRUCK WITH THE SAME ISSUE. I LOVE MY TRUCK AND I TAKE EXTREMELY GOOD CARE OF IT BUT TO HAVE IT FIXED, MY MECHANIC SAID A NEW ENGINE IS BETTER AND CHEAPER THAN REBUILDING IT. TOTAL COST OF $6000 . AND THE PASSENGER SIDE DOOR LEAKS INSIDE THE TRUCK WHEN IT RAINS , BETWEEN THE FRONT AND REAR DOOR. THERE SHOULD BE SOMETHING THAT CHEVROLET CAN DO TO FIX THIS PROBLEM. I HAVE ALWAYS LOVED CHEVY, BUT I'M STARTING TO GET VERY DISAPPOINTED WITH THEM AND THE QUALITY BEING MADE AND SOLD FOR SUCH HIGH AMOUNTS OF CASH..

YET ANOTHER FAILURE OF INADEQUATELY SPECCED BRAKE LINES. I HAVE NOW HAD TO REPLACE TWO BRAKE LINES (FROM THE BPMV TO THE FRONT-RIGHT CALIPER AND BPMV TO THE REAR-LEFT DRUM) DUE TO BLOW-OUTS ORIGINATING FROM HEAVY CORROSION - BOTH OF WHICH OCCURRED IN HEAVY-TRAFFIC SITUATIONS. ON EVERY OTHER VEHICLE I HAVE OWNED, BRAKE LINES WERE AN ITEM THAT COULD MORE-OR-LESS BE PRESUMED A LIFETIME PART; THEY RARELY NEEDED TO BE REPLACED UNLESS DAMAGED. HOWEVER, ON MY TRUCK (AND HUNDREDS OF OTHERS JUST ON THE NHTSA'S COMPLAINTS PAGE FOR THE 06 SILVERADO ALONE), THE HARD BRAKE LINES ARE ABOUT AS FAR FROM A LONG-LASTING, HIGH-QUALITY PART AS YOU CAN GET. THERE IS AN ENDLESS AMOUNT OF DOCUMENTATION SCATTERED ACROSS THE INTERNET ON THIS MATTER, YET THE NHTSA SEEMS AVERSE TO HOLDING GM RESPONSIBLE FOR THE SAFETY OF THEIR PRODUCT. IT MAY WELL BE TOO LATE AT THIS POINT FOR THE NHTSA TO DO ANYTHING ABOUT IT, BUT WHY DIDN'T THEY DO ANYTHING SOONER? THE OLDEST RECORDED COMPLAINT ON THE NHTSA WEBSITE IS FROM 5-22-2012 (ID# 10459283), THERE ARE HUNDREDS ON THE EXACT SAME MATTER, AND YET THE NHTSA HAS PUBLICLY OPENED 0 INVESTIGATIONS ON THE TOPIC. TO THE NHTSA, PLEASE HOLD GM ACCOUNTABLE FOR SPECCING LINES THAT ARE NOT ADEQUATE FOR A SERVICE ENVIRONMENT, AND QUIT MAKING CONSUMERS RESPONSIBLE FOR GM'S CHOICES. THANK YOU.

GOING DOWN A SNOWY GRAVEL ROAD AND LOST CONTROL. HIT A DITCH/SNOW BANK HEAD ON AT APPROX. 30MPH. AIR BAGS DID NOT DEPLOY. AS A RESULT DRIVER SUSTAINED HAND INJURY, A BROKEN JAW REQUIRING SURGERY, AND OTHER MINOR BODILY INJURIES. VEHICLE HAD 313,000 MILES

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. WHILE DRIVING VARIOUS SPEEDS, THE GEAR DOWNSHIFTED INTO NEUTRAL WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED, BUT NO FAILURE COULD BE DETECTED. THE INDEPENDENT MECHANIC REPLACED THE TRANSMISSION, BUT THE FAILURE RECURRED. THE DEALER (GOSCH CHEVROLET, 400 CARRIAGE CIR, HEMET, CA 92545, (951)-216-3486) WAS CONTACTED AND STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 208,025.

TAKATA RECALL THE ENGINE IS NOT GETTING ENOUGH FUEL OIL PRESSURE GAUGE IS AT 80 TRANSMISSION IS SKIPPING ELECTRIC PROBLEMS SUSPENSION FAIL

THE HEATING BLOWER STOPPED WORKING FOR ABOUT 10 MIN LAST WEEK AND TODAY DIDN'T WORK AT ALL UNTIL I WIGGLED HARNESS. CAN'T KEEP IT GOING. KEEPS STOPPING UNTIL I WIGGLE WIRES AND THEN I ONLY GET A COUPLE MIN IF THAT.

EXHAUST MANIFOLD BOLTS ARE BROKEN OFF ON BOTH SIDES OF THE 6.0 ENGINE, CAUSING EXHAUST FUMES IN THE PASSENGER COMPARTMENT WHEN I DRIVING THE VEHICLE. I HAVE OWNED THIS VEHICLE SINCE NEW AND HAVE NEVER HAD ANY ENGINE WORK DONE TO THIS VEHICLE.

REPLACED BRAKE LINES ON A REGULAR BASIS - UNDERCARRIAGE ROTTING OUT

EXPERIENCING UNWANTED ABS ACTIVATION ON FRONT BRAKES AT LOW SPEED. BELOW 10 MPH. CAUSING INCREASE STOPPING DISTANCE DURING LOW SPEED APPLICATIONS. HAPPENS CONSTANTLY. I HAVE HEARD OF A SIMILAR ABS RECALL ON EARLY MODEL SILVERADO TRUCKS. RECALL N050068.

MY BLOWER MOTOR WIRING HARNESS AT THE RESISTOR LIGHTLY CAUGHT ON FIRE TODAY. I WAS DIVING ON THE HIGHWAY WITH THE FAN ON FULL BLAST. NO ONE WAS HURT AND I MANAGED TO STOP AND TURN OFF THE TRUCK INFO TIME TO STOP FURTHER DAMAGE. THE RESISTOR WAS EXTREMELY HOT YOU THE TOUCH AFTER. THIS IS A COMMON PROBLEM THAT I'VE READ ABOUT ALL OVER. MY VIN DID NOT HOWEVER PULL A RECALL...

THE HEATER FAN RESISTER AND CONNECTOR HAS BURNED. RECALLED BY CHEVY BUT NOT MY VEN NUMBER

TL* THE CONTACT OWNED A 2006 CHEVROLET SILVERADO 1500. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT SWERVED TO AVOID HITTING A DEER. THE CONTACT LOST CONTROL OF THE VEHICLE AND IT FLIPPED OVER AND LANDED ON ITS SIDE IN A DITCH. THE AIR BAGS FAILED TO DEPLOY. AS A RESULT, THE CONTACT SUSTAINED A BROKEN NECK, HEAD TRAUMA, AND BACK AND NECK BRUISES THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A TOW LOT AND DEEMED A TOTAL LOSS. THE DEALER AND MANUFACTURER WERE NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

SOMETIMES LOOSE POWER STEERING WHEN TURNING THE WHEEL THEN WORKS AGAIN

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 35 MPH, THE STEERING WHEEL SHOOK, THE BRAKES MADE A SCRAPING NOISE, AND THE ABS WARNING INDICATOR ILLUMINATED. WHILE THE CONTACT ATTEMPTED TO DECELERATE AND TURN THE VEHICLE, THE FRONT DRIVER'S SIDE WHEEL DETACHED FROM THE HUB. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR AN INDEPENDENT MECHANIC FOR A DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 145,000.

TAMARA RECALL. MY TRUCK HAS THE WARNING ON MY INSTRUMENT CLUSTER "SERVICE AIR BAG" JUST LIKE THE 2007 TO 2011 RECALL. I FEEL THAT THE 2006 SHOULD BE ON THE RECALL TOO.

THE REAR BRAKES FAILED WITH LITTLE OR NO WARNING. THE BRAKES WENT FROM GOOD TO MUSHY WITHOUT WARNING LIGHT. I ADDED BRAKE FLUID TO TEST IN DRIVE WAY. PUMPED THE BRAKES AND THE WARNING LIGHT CAME ON. THE REAR LINE FAILED. I HAD THE TRUCK INSPECTED AT A GENERAL MOTORS DEALER IN JANUARY OF 2018 AND ALSO AT THE END OF FEBRUARY. THE SAID MY VEHICLE IS MAINTAINED IN EXCELLENT CONDITION. IF THIS COULD HAPPEN TO ME....ALL GM VEHICLES WITH THESE BRAKE LINES ARE AT RISK. I READ THEIR WAS A SAFETY BULLETIN 13-05-22-001. TODAY IS 4/12/2018...BECAUSE I TOW A BOAT TO FLORIDA I HAD THE TRUCK CHECKED 2 TIMES IN THE LAST 12 WEEKS....IF THE DEALERS CAN'T DETECT FAULTY LINES....A RECALL IS NEEDED.

NEPHEW BORROWED MY TRUCK. HE WAS IN MOTION AND TRIED TO MAKE A LEFT HAND TURN ON A CITY STREET AND REALIZED BRAKES HAD FAILED. HE WISELY CONTINUED STRAIGHT TILL IT SLOWED DOWN ENOUGH AND HE MADE A RIGHT HAND TURN ONTO A ROAD AND PULLED INTO A PARKING LOT BEHIND A HOUSING PROJECT. HE USED A SNOW BANK/BOULDER TO STOP THE TRUCK. LUCKILY NO ONE WAS HURT. TRUCK WAS TOWED BACK TO MY HOUSE. I DO MY OWN REPAIRS. AFTER INSPECTION IT WAS DETERMINED THAT ONE OF THE SUPPLY LINES FROM THE MASTER CYLINDER INTO THE ABS MODULE HAD RUPTURED. THERE WAS COMPLETE FAILURE OF THE BRAKING SYSTEM AFTER A SINGLE PUSH ON THE BRAKES. THE TRUCK IS 11 YEARS OLD. HOW CAN THE BRAKE LINES BE RUSTING OUT. THERE IS A SERIOUS ISSUE AND A SERIOUS FLAW WITH THIS DESIGN. I'M ATTACHING 2 PICTURES FOR YOUR OBSERVATION. GM SHOULD BE HELD ACCOUNTABLE FOR FIXING THESE BAD DESIGNS. IS THIS ANOTHER CHEAP SOLUTION LIKE THE IGNITION KEY PROBLEM THAT COST COUNTLESS LIVES? THERE SHOULD BE THE UTMOST ACTION BY THIS AGENCY TO HOLD GM ACCOUNTABLE. THIS ABS MODULE SHOULD BE UP IN THE FRONT HOOD LIKE OTHER MANUFACTURERS DO. NOT UNDER THE CAB IN A WET ENVIRONMENT. SHAME ON GM.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE AIR BAG WARNING INDICATOR FLASHED. THE CONTACT STATED THAT THE FAILURE OCCURRED FOR APPROXIMATELY ONE YEAR. THE VEHICLE WAS TAKEN TO THE DEALER (PARADISE CHEVROLET/CADILLAC IN TEMECULA, CALIFORNIA. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 289,000.

UPON STARTING MY TRUCK, THE OIL PRESSURE GAUGE IMMEDIATELY GOES TO 80 WITH NO ACCELERATION. AT THIS POINT, THERE IS NO NOISE OR OTHER LIGHTS COMING ON TO WARN OF OTHER PROBLEMS. THIS PROBLEM STARTED A FEW DAYS AGO. WHEN TRUCK IS IN MOTION THE OIL PRESSURE GAUGE CONTINUES TO STAY ON 80. I KNOW THE 2006 CHEVY 2500 HEAVY DUTY 4X4 HAVE HAD RECALLS ON DIFFERENT THINGS, BUT NEED TO SEE IF THIS IS A PROBLEM FOR OTHER CHEVY TRUCKS AS WELL. I HAVE READ SEVERAL RECALLS ABOUT THESE TRUCKS AND A LOT OF THEM WE HAVE NEVER BEEN NOTIFIED TO TAKE IT TO A DEALER TO BE CHECKED. ANY HELP YOU CAN GIVE US WOULD BE DEEPLY APPRECIATED.

"TAKATA RECALL" ON 11/04/2016 ATTEMPTING TO PASS ANOTHER VEHICLE, SUDDENLY VEHICLE ON MY PASSENGER SIDE BEGIN TO SIDESWIPED MY VEHICLE, MY PASSING WAS DELAY AND HINDER; ONCOMING TRAFFIC AND SIDESWIPED CONTINUALLY FORCE ME OF THE LEFT SIDE PAVEMENT ONTO THE GRAVEL ON THE LEFT AND INTO A RESIDENT DOGWOOD TREES, NO DEPLOY FROM AIRBAGS VEHICLE WAS CONSIDER A TOTAL LOST BY MY INSURANCE COMPANY AND REPAIR SHOP

FAILURE OF BRAKE LINE COMPLETE LOSS OF BRAKES. GOING OUT OF DRIVEWAY TURN INTO A DTE POLE TO STOP

ONE MORNING WHEN TRY TO GO THE WORK, I START MY TRUCK BUT SEE THE BRAKE LIGHT SHOW UP, WHEN PUSH THE BRAKE PEDAL GOES ALL THE WAY DOWN, I LOOK BRAKE FLUID UNDER THE TRUCK DROOPING FLUID BY THE GAS TANK AREA. THANKS TO GOD NOT HAPPEN WHEN DRIVING AND JUST USED THE TRUCK NIGHT BEFORE, IF NOT COULD BE SOMETHING VERY BAD AND DANGEROUS.

THE RIGHT FRONT BRAKE LINE ON MY TRUCK RUSTED THROUGH. I LOST BRAKING WHEN LOADING MY 10 FT CAMPER IN THE DRIVEWAY. I TOOK THE TRUCK TO DEALERSHIP AND IT WAS FOUND THAT ALL THE BRAKE LINES ARE RUSTED AND IN DANGER OF FAILURE AT ANY TIME. ALL OF THE BRAKE LINES ON THE TRUCK ARE BARE METAL AND PRONE TO RUST. NEW BRAKE LINES ARE PAINTED TO PREVENT THIS FROM HAPPENING. HAD TO BUY COMPLETE BRAKE LINE KIT TO GET RIGHT FRONT LINE FOR REPLACEMENT BY DEALERSHIP FOR $452.85 . THEY RECOMMEND THAT I REPLACE ALL OF THE LINES. I CALLED CHEVROLET CUSTOMER SERVICE, COMPLAINT # 8-3176545196. I HAVE GOTTEN NO COOPERATION, THEY HAVE TOLD ME THERE IS NOTHING THAT THEY CAN DO. BECAUSE OF THIS POTENTIALLY CAUSING A CATASTROPHIC FATAL ACCIDENT DUE TO COMPLETE OR PARTIAL LOSS OF BRAKING POWER - IT GIVES NO WARNING UNTIL FAILURE OCCURS. I TOLD THEM THEY NEEDED TO PUT OUT AN ALERT TO OTHER DRIVERS AND THEY DECLINED STATING THAT THEY DID NOT HAVE ENOUGH COMPLAINTS. THIS TRUCK ONLY HAS 99546 MILES ON IT AND IN ALL OF MY YEARS WORKING WITH AUTOMOBILES I HAVE NEVER SEEN A BREAK LINE RUST THROUGH.

APPEARS GM'S FAULTY BLOWER MOTOR RESISTOR HAS CLAIMED MY 2ND TRUCK. FIRE STARTED WHILE PARKED IN PARKING LOT. FIRE OCCURS ON PASSENGER SIDE AROUND GLOVE BOX AND GROWS. THIS TRUCK GAVE NO INDICATION OF "MELTING WIRES" THERE WAS NO SMELL OR SMOKE WHEN PARKED. THIS PART OF A SPECIAL COVERAGE #10240

BRAKE LINE COMPLETELY RUSTED THROUGH ON FRONT, LEFT SIDE NEAR WHEEL. INSPECTION OF LINES REVEALED SIGNIFICANT RUST ON ALL BRAKE LINES. NO BRAKING ACTION AT ALL WHEN I TRIED TO STOP, BRAKE FLUID POURED OUT AND I HAD TO USE PARKING BRAKE TO STOP VEHICLE. OCCURRED WHEN I WAS DRIVING OUT OF MY GARAGE. IF I HAD BEEN ON HIGHWAY WHEN THIS HAPPENED, IT COULD HAVE CAUSED SIGNIFICANT INJURY TO MYSELF AND OTHERS. THIS VEHICLE SAW ONLY LIMITED USE DURING WINTER MONTHS BUT LINES ARE VERY RUSTED.

WE HAD A RECALL IN THE PAST ON THE STEERING COLUMN RATTLING. THE DEALERSHIP REPAIRED IT AND IT HAS STARTED IT AGAIN AND IT IS WORSE THAN EVER. THE VEHICLE ONLY HAS 59000. MILES ON IT. AND WE WERE TOLD BY DAVIS CHEVROLET IN LEXINGTON NC THAT IT COULD NOT BE REPAIRED AGAIN. SO I WANTED TO FIND OUT WHAT IS GOING TO BE DONE ABOUT IT.

DRIVING IN STOP AND GO TRAFFIC 3 -5 MPH BRAKE LINE BROKE, PEDAL WENT TO FLOOR. HAD TO SHIFT TO NEUTRAL AND EMERGENCY BRAKE TO STOP. CHEVY DEALERSHIP STATES THEY WERE AWARE OF RUSTING BRAKE LINES FAILING ON THIS MODEL. NO RECALL AT THIS TIME. $1,800.00 TO HAVE DEALERSHIP REPLACE.

STEEL BRAKE LINES (BRAKELINES) RUSTED THROUGH BY FRAME OF TRUCK. COMMON PROBLEM WITH THIS YEAR AND MODEL. VERY DANGEROUS AS USUALLY OCCURS (AND DID IN MY CASE) WHILE DRIVING SINCE PUMPS WILL PUSH BRAKE FLUID OUT OF LEAKING RUSTED LINES WHILE DRIVING.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE PERFORMING REGULAR MAINTENANCE THAT HE OBSERVED CORROSION AND A HOLE ON THE CROSS MEMBERS AND CHASSIS WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL, NOR COVERED UNDER WARRANTY. THE MANUFACTURER STATED THAT THEY COULD ARRANGE TO HAVE THE VEHICLE ON A ROLLBACK TO BE TAKEN TO THE DEALER AND THEN THEY PATCHED THE CONTACT OVER TO THE DEALER. THE DEALER ( WALTER GM AUTOMALL 505 N MAYO TRAIL, PIKEVILLE, KY, 41501) CONFIRMED THE VEHICLE WAS NOT UNDER WARRANTY THAT THEY COULD HAVE THE VEHICLE ROLLED BACK, HOWEVER THERE WOULD BE A DIAGNOSTIC FEE. THE FAILURE MILEAGE WAS 52,231.

SEVERELY RUSTED BRAKE LINES

WHEN BRAKING AT LOW SPEEDS, THE ABS SYSTEM IS ENGAGING AND THE VEHICLE WILL NOT STOP WHERE YOU INTENDED TO STOP. IT GOES SEVERAL FEET BEFORE STOPPING INCREASING THE RISK OF ACCIDENT BY REAR ENDING SOMEONE OR ENDING UP IN THE MIDDLE OF AN INTERSECTION.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. WHEN THE CONTACT STARTED THE ENGINE, FLAMES APPEARED UNDER THE HOOD. THE VEHICLE WAS TOWED TO BAYSIDE CHEVROLET IN PRINCE FREDERICK, MD (PHONE: (410) 525-1500) WHERE IT WAS DIAGNOSED THAT THE HYBRID MODULE OVERHEATED AND CAUSED THE WIRES TO BURN. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER ADVISED THAT THE VEHICLE'S WARRANTY HAD EXPIRED. THE FAILURE MILEAGE WAS 94,656.

FRAME AND SUSPENSION COMPONENTS EXCESSIVE RUSTING TO THE POINT OF FAILURE. LEAF SPRING SHACKLE FAILED LAST YEAR, CAUSING LEAF SPRING TO PUT A HOLE IN TRUCK BED WHILE DRIVING. BRAKES LINES RUSTED TO FAILURE LAST WEEK AND CAUSED NEAR BRAKE LOSS WHILE OPERATING. HAD TO USE E-BRAKE TO AVOID HITTING MY GARAGE. CROSS MEMBERS SUPPORTING SHOCK FAILED. GAS TANK ABOUT TO FALL OFF DUE TO RUST FAILURE. CANNOT DRIVE TRUCK. BRAKES NO LONGER FUNCTION AND TRUCK IS UNSAFE DUE TO FRAME BEING COMPROMISED.

DRIVING MY CHEVY SILVERADO DOWN THE ROAD. HIT THE BRAKES FOR A DEER AND THE BRAKE PEDAL WENT TO THE FLOOR. SMOKE STARTED COMING OUT FROM UNDER THE HOOD. FLUID WAS ALL OVER THE ENGINE AND ON THE ROAD. FOUND THAT THE METAL BRAKE LINE BLEW OUT. TALKED TO 3 COMPANIES ABOUT REPAIRS. ALL THE LINES ARE ROTTEN. MINIMUM COST IS $500. ALL PLACES SAID THIS IS A COMMON PROBLEM WITH GM TRUCKS-EVEN THE DEALER SAID OH BRAKE LINES GO BAD ALL THE TIME ON VEHICLES OVER 10 YEARS OLD. I HAVE BEEN DRIVING FOR ALMOST 50 YEARS; OWNED AT LEAST 20 VEHICLES AND NEVER HEARD OF THIS HAPPENING. IN CASE YOU DON'T KNOW IT-BRAKES ARE PRETTY IMPORTANT! I WAS LUCKY. NO ONE WAS HURT. I WAS ON A BACK ROAD. I READ THAT GM USED LOW QUALITY MATERIAL FOR THEIR LINES. IF SO, IT SHOULD BE EASY TO BREAK IT DOWN AND VERIFY. WAS THIS METAL SUSCEPTIBLE TO CORROSION? THEY KNOW ALL THE CONDITIONS THAT THEIR TRUCKS WILL BE IN. HOW MANY MORE OF UNREPORTED ISSUES ARE THERE? SOONER OR LATER IT WILL BE PEOPLE'S LIVES THAT WILL BE LOST. THANK YOU FOR YOUR TIME.

WHILE DRIVING OR SITTING STILL HEADLIGHTS GO OFF FROM SECONDS TO MINUTES THEN GO ON OR UNTIL I PUSH THE DIMMER SWITCH SIDEWAYS NOT UP AND DOWN,THE DASHBOARD LIGHTS AND CLOCK GO OFF FROM SECONDS OR UNTIL I PUSH THE DIMMER LIGHT SWITCH SIDEWAYS NOT UP AND DOWN,THE ENGINE SUDDENLY QUITS WHETHER SITTING STILL OR DRIVING.

MOVING BOAT IN MY YARD WHEN BRAKE PEDAL WENT TO THE FLOOR, USED EMERGENCY BRAKE TO STOP. BRAKE LINE TO LEFT FRONT WAS COMPLETELY SPLIT OPEN . LINE IS SEVERELY RUSTED IN SPOTS.

AT 45,000 MI. ABS BEGAN ACTIVATING, AT SLOW SPEED, WHEN STOPPING. ABS LIGHT WAS NOT LITE AND BRAKES WERE EFFECTIVE. BASED ON THE C0040 DIAGNOSTIC CODE, REPLACED RT FRONT HUB/ABS SENSOR ASSY. AT A COST OF $400. EVENTUALLY, ALL HUB SENSORS BEGAN GIVING FALSE INDICATIONS. WAS TOLD BY DEALER IT WAS ATTRIBUTED TO A DEFECTIVE DESIGN, BUT THERE WAS NO BULLETIN OR RECALL TO REMEDY THE PROBLEM. CANNOT AFFORD TO REPLACE ALL HUBS IF IT IS ONLY GOING TO HAPPEN AGAIN. GM SHOULD MAKE GOOD ON THESE REPAIRS.

SUDDEN FAILURE OF BRAKES DURING LOW SPEED STOP, BRAKE LINE FAILED NEAR FRAME UNDERSIDE IN DRIVER SEAT AREA. WAS ABLE TO QUICKLY STOP VEHICLE WITH EMERGENCY BRAKE JUST SHORT OF GOING INTO HEAVY TRAFFIC. THIS TRUCK IS METICULOUSLY MAINTAINED INCLUDING UNDERSIDE WASHES, NO BODY RUST ANYWHERE AND WAS UNDERCOAT PROTECTED FROM NEW. SHOCKED A LEVEL OF RUST ON WHAT ARE APPARENTLY HIGH CARBON STEEL LINES, THESE SHOULD BE STAINLESS STEEL.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE LOST ENGINE POWER WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT IT NEEDED TO BE COMPLETELY REPROGRAMMED AND THE IGNITION CONTROL MODULE HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED SEVERAL TIMES AFTER THE REPAIR. THE VEHICLE WAS TAKEN TO THE DEALER THREE OTHER TIMES, BUT THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 118,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500 EQUIPPED WITH COOPER TIRES, DOT NUMBER: UTV6C8E4808, TIRE LINE: COOPER DISCOVERER ATR, TIRE SIZE: 265/75/R16. THE CONTACT STATED THAT WHILE DRIVING AT 63 MPH, THE CONTACT STATED THAT THERE WAS AN ABNORMAL VIBRATION FROM THE REAR OF THE VEHICLE. THE CONTACT STATED THAT THE TREAD SEPARATED FROM THE TIRE WHICH CAUSED DAMAGE TO THE BED OF THE VEHICLE. THE FAILURE OCCURRED ON THE REAR DRIVER SIDE TIRE. THE CONTACT STATED THAT THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE TIRE FAILURE MILEAGE WAS UNKNOWN. THE FAILURE MILEAGE ON THE VEHICLE WAS 114,900.

RAILROAD HYRAIL VEHICLE EQUIPPED, AFTER MARKET, WITH HYRAIL WHEEL ASSEMBLIES WHICH ALLOW THE VEHICLE TO OPERATE ON RAILROAD TRACKS. ONCE HYRAIL (FLANGED) WHEELS ARE RETRACTED, THE VEHICLE IS OPERATED OVER THE HIGHWAYS AND PUBLIC ROADS LIKE ANY OTHER VEHICLE. ON 3/16/12 A BNSF EMPLOYEE WAS OPERATING THE HYRAIL VEHICLE ON HWY 34 NEAR TRENTON, NE. A SEMI PULLED OUT IN FROM OF HIM, CAUSING HIM TO REAR END THE SEMI AT ABOUT 65 MPH. DELAYED AIRBAG DEPLOYMENT LED TO HIM HAVING EXTENSIVE INJURIES, INCLUDING LACERATIONS TO HIS FOREHEAD, COLLAPSED LUNGS, SPINE FRACTURES AND RIB FRACTURES. CONCERN IS THAT THE INSTALLATION OF HYRAIL WHEEL ASSEMBLIES MIGHT BE IMPACTING THE AIRBAG SENSOR. THE HYRAIL WHEEL ASSEMBLIES EXTEND APPROX. ONE FOOT OF STEEL FRAMEWORK AHEAD OF THE FRONT AND REAR BUMPERS. THE PLACEMENT OF THESE ASSEMBLIES MIGHT INADVERTENTLY BE AFFECTING AIRBAG DEPLOYMENT IN CRASHES ON THE RAILROAD TRACK AND ON PUBLIC ROADS.

LOSS OF BREAKS,RUSTED OUT BREAKLINES.PEDAL WENT TO THE FLOOR,NO BREAKS AT ALL! (SOMEONES GOING TO DIE)

BRAKE LINES ROTTED/RUSTED OUT ,FRONT TO BACK. FLUID LEAKED OUT EVERYWHERE. HAD TO DRIVE TEN MILES PER HOUR ,BUT MADE IT HOME FROM WORK SAFELY! ($950 REPAIR BILL). THANK YOU GENERAL MOTORS. MY NEXT TRUCK WILL BE A FORD. *TR

WAS DRIVING VEHICLE ON US 131 IN HOLLAND MI. I WAS TRAVELING AT APPROX 50MPH WHEN I HAD TO BRAKE FOR STOPPED TRAFFIC AHEAD. VEHICLE BEGAN TO SLOW WHEN SUDDENLY BRAKE PEDAL FELL AND I LOST MUCH OF MY BRAKING. HAD TO VEER OFF TO THE SHOULDER OF THE ROAD TO AVOID POSSIBLE COLLISION WITH STOPPED TRAFFIC. WHEN I PULLED OVER TO INSPECT MY TRUCK, I NOTICED FLUID DRIPPING FROM THE FRAME RAIL NEAR THE FUEL TANK. IT WAS BRAKE FLUID. THE BRAKE LINE THAT GOES FROM THE ABS UNIT TO THE REAR BRAKE HOSE WAS RUSTED THROUGH AND LEAKING. THIS IS A 10YR OLD TRUCK WITH ONLY 122000 MILES ON IT. I DON'T BELIEVE THIS TYPE OF FAILURE IS ACCEPTABLE FOR A VEHICLE OF THIS AGE AND MILEAGE. I WAS ABLE TO CAREFULLY DRIVE THE TRUCK HOME AND PARKED IT. I CONTACTED MY LOCAL DEALER SERVICE MANAGER, WHO COULD ONLY REPAIR IT AT MY EXPENSE. I GOT GENERAL MOTOR CUSTOMER ASSISTANCE # FROM HER AND CONTACTED THEM. THEY OPENED A CASE, #8-2572108769, AND SAID THEY ALSO WOULD DO NOTHING TO ASSIST IN THE REPAIR OF THIS CONDITION. THEY ARE LUCKY NOT TO HAVE A DEATH OR INJURY LAWSUIT ON THEIR HANDS. I'VE SEEN SEVERAL OTHER COMPLAINTS ONLINE FROM OTHER OWNERS OF THIS MODEL. THESE NEED TO BE RECALLED BEFORE SOMEBODY GETS KILLED. *TR

THE BRAKES FAILED WHILE IN MOTION. THE CAUSE WAS THE STEEL HYDRAULIC BRAKE LINE TO THE REAR WHEELS RUSTED AND BECAME TOO WEAK TO HOLD BRAKING PRESSURE. UPON FURTHER INSPECTION, ALL STEEL BRAKE LINES WERE VERY RUSTY.

(PRO-YD-CS03-AM-BK_10-CL03PLEDG2JM ) HAVE THE WIRE FOR THE CORNER LEDS AND THE MAIN PROJECTOR BULBS SWAPPED, THE LEDS ARE WIRE WITH WHAT LOOKS LIKE CONDUCTOR RAPPED IN HIGH TEMP INSOLATION, AND THE PROJECTOR BULBS HAVE WHAT LOOK LIKE NORMAL BRIGHT BLUE INSOLATION THAT IS DISCOLORED ALMOST A YELLOW BROWNISH COLOR ON THE END THAT CLOSEST TO THE BULB, IT IS CLEAR THAT THE INSOLATION IS NOT RATED FOR THIS APP. AND IS A FIRE HAZARD.

BRAKE HYDRAULIC METAL PIPE FAILED TO RIGHT FRONT WHEEL, BRAKE PEDAL WENT TO FLOOR. VEHICLE WAS STOPPED BY DOWNSHIFTING AND USING PARK BRAKE. THIS OCCURRED AT LOW SPEED IN CITY TRAFFIC. NO ACCIDENT OCCURRED.

MY VEHICLE IS BURNING MORE OIL THAN NORMAL. I PURCHASED THE PICKUP ON AUG 10, 2016 AND THE DAY PRIOR THE DEALERSHIP HAD JUST DONE A FRESH OIL CHANGE. I DOUBLE CHECKED THE NEW OIL BEFORE DRIVING FROM THE LOT AND SEEN THE OIL WAS NEW AND FRESH. A MONTH AND A HALF LATER MY HUSBAND IS DRIVING HOME FROM CAPE MAY NEW JERSEY WHICH IS A 6 HOUR DRIVE AND JUST AFTER FILLING UP HIS GAS TANK AND DRIVING HOME...THE VEHICLE STARTS SMOKING PROFUSELY. HE HAD TO ADD 5 QUARTS OF OIL TO THE VEHICLE BECAUSE IT LOOKED AS THOUGH THE OIL WAS COMPLETELY DRAINED FROM THE ENGINE.

WHEN NORMAL STOPPING ABS ACTIVATES AND KEEPS ACTIVATING UNTIL PEDAL GOES TO FLOOR AND BRAKES DO NO FUNCTION, THERE ARE NO WARNING LITES AND NO INDICATION OF A PROBLEM.I WAS UNDER THE IMPRESSION THAT ANY ABS FAILURE WOULD REVERT SYSTEM TO REGULAR BRAKE SYSTEM. THIS IS VERY DANGEROUS.

WHILE TRAVELING AT HIGHWAY SPEED THE BREAKS WERE APPLIED TO STOP FOR A RED LIGHT, THE FRONT BREAK LINE BROKE AND THE BREAKING PETAL WENT TO THE FLOOR. THE BREAKS WERE THEN PUMPED BUT THERE WAS NO REAL REDUCTION IN SPEED ALLOWING THE TRUCK TO TRAVEL THRU THE INTERSECTION AT A HIGH RATE OF SPEED THRU THE RED LIGHT. THE TRUCK DID EVENTUALLY COME TO A STOP WITH THE CONTINUED PUMPING OF THE BREAKS

BLOWER MOTOR FOR THE HVAC STARTED ALL BY ITS SELF AND RAN FULL BLAST. THE CONTROL PANEL HAD NO EFFECT ON THE SYSTEM . I COULD NOT CONTROL OR SHUT OFF THE BLOWER. EVEN WHEN THE TRUCK WAS PARKED, IN PARK AND SHUT DOWN AND THE KEYS REMOVED THE BLOWER CONTINUED TO RUN AT FULL BLAST. HAD TO DISCONNECT THE BATTERY. LATER AFTER HAVING TO DRIVE THE TRUCK TO WORK I FOLLOWED THE FUSE SCHEMATIC AND REMOVED THE GREEN I BELIEVE FUSE BREAKER FROM THE UNDER HOOD FUSE BOX. I HAVE LEFT THIS FUSE REMOVED SO THE BATTERY DOESN'T RUN DOWN.

PLUGGED IN MINI VAC TO CIG LIGHTER AND CIG LIGHTER SHORTED TO GROUND CAUSING WIRES TO MELT AND SMOKE INCLUDING POWER OUTLET WIRES.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. WHEN THE VEHICLE WAS TURNED OFF, THE BLOWER MOTOR REMAINED ON AND THE CONTACT HAD TO CONSTANTLY DISCONNECT THE BATTERY. THE DEALER DIAGNOSED THAT THE BLOWER CONTROL MOTOR PREMATURELY FAILED AND NEEDED TO BE REPLACED. THE CONTACT WAS INFORMED BY THE DEALER AND MANUFACTURER THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL TO ADDRESS THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 3500. WHILE DRIVING 40 MPH, THE BRAKE PEDAL WAS DEPRESSED, BUT THE VEHICLE DID NOT STOP. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE CONTACT STATED THAT THE STEEL BRAKE LINE HAD RUSTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 109,110.

THE BRAKES WENT TO THE FLOOR AND COMPLETELY FAILED; THROUGH THE INTERSECTION WE WENT. I WAS ABLE TO USE THE EMERGENCY BRAKE TO SLOW AND THEN STOP THE TRUCK. SOMEHOW, WE WERE ABLE TO AVOID AN ACCIDENT. I WAS ABLE TO GET THE TRUCK THE REST OF THE WAY HOME USING THE EMERGENCY BRAKE. THE BRAKE FLUID RESERVOIR WAS FULL, BUT I COULD SEE FLUID LEAKING UNDER THE TRUCK FROM THE FRAME AREA NEAR THE DRIVER'S DOOR. LOOKING UNDER THE TRUCK, I NOTICED THE BRAKE LINES WERE RUSTED; EVERY BRAKE LINE ON THE TRUCK WAS RUSTED. LOOKING ON-LINE, I NOTICED I WASN'T THE ONLY ONE WITH THIS PROBLEM. I ORDERED A COMPLETE SET OF STAINLESS STEEL BRAKE LINES. WE HAD THE TRUCK TOWED THE TRUCK TO THE CHEVY DEALER ($200.00). THEY REPLACED EVERY BRAKE LINE ON THE TRUCK AS WELL AS THE FRONT CALIPERS ($2100). THE DEALER DID A GREAT JOB; $1600.00 OF THE COST WAS FOR LABOR.

ALL BRAKE LINES RUSTED OUT UNDER CAB ON DRIVERS SIDE BUSTED WHEN STOPING AT STOP SIGN

TRANSMISSION PROBLEMS, WHEN VEHICLE WAS NEW IT WAS SEEN FOR TRANSMISSION PROBLEMS MORE THEN ONCE. SINCE I'VE OWNED IT, I'VE HAD THE TRANNY REBUILT 2 TIMES.

WAS TRAVELING APPROXIMATELY 55 MPH DOWN A STATE HIGHWAY. AFTER COMING AROUND A BLIND CURVE, CAME UPON STOPPED TRAFFIC DUE TO ROAD WORK. APPLIED PRESSURE TO BRAKE PEDAL WHEN PEDAL WENT SOFT AND DEPRESSED ALL THE WAY TO THE FLOOR. AFTER RELEASING BRAKES AND PUSHING AGAIN STILL HAD NO BRAKES. HAD TO SWERVE OUT OF ROAD-WAY TO AVOID REAR ENDING MULTIPLE VEHICLES. AFTER RUNNING OUT OF ROAD, HIT 2 CULVERT PIPES ALONG WITH ROAD WORK SIGNAGE, FINALLY BRINGING THE TRUCK TO A STOP IN A RESIDENTIAL YARD. TRUCK BRAKE LINES FOR FRONT BRAKES HAD CORRODED AND RUPTURED CAUSING THE INCIDENT. FURTHER INVESTIGATION INTO THIS MATTER SHOWS AN APPARENT ISSUE WITH THIS MODEL GMS FOR BRAKE LINE CORROSION THAT GM HAS FAILED TO ADDRESS THROUGH THE RECALL PROCESS.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. WHILE THE VEHICLE WAS UNDERGOING AN INSPECTION, THE TECHNICIAN DIAGNOSED THAT THE FUEL LINES WERE SEVERELY CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT THE FUEL LINES WERE CONSIDERED A MAINTENANCE ITEM. THE FAILURE MILEAGE WAS APPROXIMATELY 39,000.

PARKED VEHICLE IN DRIVEWAY, MOVED IT ABOUT THREE FEET AND BRAKED. THE PEDAL WENT TO THE FLOOR. LOOKED UNDER THE TRUCK AND FOUND A LARGE PUDDLE OF BRAKE FLUID COMING FROM A RUSTED THROUGH BRAKE LINE. UPON FURTHER INSPECTION THE OTHERS WERE IN THE SAME STATE. LUCKY THIS DIDN'T HAPPEN WITH FAMILY ONBOARD WHILE DRIVING ON A ROADWAY, COULD HAVE RESULTED IN A TERRIBLE ACCIDENT.

RUSTED/RUPTURED BRAKE LINE IN 2012 WHILE BRAKING AT AN INTERSECTION - SWIRVED TO MISS A VEHICLE. PULLING OUT OF DRIVEWAY IN 2016 ANOTHER LINE RUPTURED. VEHICLE UNDERCARRAGE WASHED AFTER EACH WINTER BUT EXCESSIVE RUST ON ALL PARTS AND FRAME. BOTH INCEDENTS WITH LOW MILES [20K & 30K] ON A LIGHTLY USED VEHICLE.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 3500. WHILE DRIVING AT VARIOUS SPEEDS AND ATTEMPTING TO STOP THE VEHICLE, THE BRAKES FAILED. THE CONTACT REAR ENDED ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS CONFIRMED THAT THE BRAKE LINES WERE CORRODED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500 EQUIPPED WITH CAPITOL PRECISION TRAC II TIRES, SIZE: 265/70R17 (NA). WHILE DRIVING 65 MPH, THE VEHICLE FAILED TO REMAIN IN POSITION AND THE STEERING WHEEL VIBRATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE THREAD ON THE FRONT PASSENGER SIDE TIRE HAD SEPARATED AND NEEDED TO BE REPLACED. THE TIRE WAS REPLACED WITH THE SPARE TIRE. THE TIRE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 14T013000 (TIRES), BUT THE TIRE WAS NOT INCLUDED. THE VEHICLE FAILURE MILEAGE WAS 100,000 AND THE TIRE FAILURE MILEAGE WAS 20,000.

BRAKE LINES ARE RUSTING AWAY. I NOTICED A SOFT BRAKE PEDAL, ON MY WAY BACK TO ST. LOUIS FROM ATLANTA, GA. I NOTICED FLUID UNDER THE TRUCK IN MY DRIVEWAY AFTER I GOT HOME. I STARTED LOOKING AROUND THE TRUCK. THE MASTER CYLINDER WAS LOW ON FLUID. NO WARNING LIGHT CAME ON. I NOTICED FLUID UNDER THE DRIVERS SIDE DOOR. IT WAS BRAKE FLUID COMING FROM A RUSTED THRU BRAKE LINE. AFTER INSPECTION, ALL OF THE OTHER BRAKE LINES WERE BADLY RUSTED. THE REPAIR(REICHERS AUTO AND TIRE-WASHINGTON, MO) SHOP IS REPLACING ALL OF THE BRAKE LINES DUE TO HEAVY RUST. COST IS GOING TO BE OVER $800.

I WAS DRIVING MY TRUCK ON 3/30/16 ANOTHER VEHICLE PULLED OUT IN FRONT OF ME. I SLAMMED ON MY BRAKES TO AVOID A WRECK. AT THE NEXT RED LIGHT I NOTICED MY BRAKES WERE SOFT. I PULLED OVER TO CHECK MY FLUID. IT WAS DOWN ABOUT AN INCH. I DECIDED TO TRY TO MAKE IT HOME. THEN A SERVICE BRAKE LIGHT CAME ON. I DID MAKE IT HOME. I CRAWLED UNDER THE TRUCK AND BRAKE FLUID WAS FROM THE FRONT TO THE BACK OF THE TRUCK. I NOTICED TWO COMPROMISED METAL BRAKE LINES ON THE DRIVER SIDE FRAME RAIL THAT WERE RUSTED THROUGH. I TOUCHED THE LINES AND THEY WERE FALLING APART AND FLAKING OFF METAL AT THE TOUCH. I CONTACTED CHEVROLET AND IT WAS TOWED TO THE DEALER. THEY QUOTED ME $1,100 TO REPAIR THE PROBLEM. MY TRUCK IS A 2006 I BOUGHT IT BRAND NEW IT HAS 59,500 MILES ON IT AND I PAID RIGHT AT $50,000 FOR MY TRUCK. IT IS UNACCEPTABLE FOR THIS TO HAPPEN IN LESS THAN 10 YEARS OF OWNERSHIP. THIS IS A HUGE SAFETY ISSUE SINCE CHEVROLET USED INFERIOR AND CHEAP PRODUCTS IN THEIR TRUCKS. THERE SHOULD BE A RECALL ON THIS. SOMEONE COULD HAVE BEEN SERIOUSLY INJURED OR KILLED THE OTHER DAY WHEN I WAS DRIVING. I REPLACED ALL OF THE ROTORS AND BRAKE PADS AND ONE CALIPER NOT 9 MONTHS AGO. I NEVER THOUGHT THAT MY METAL LINES WERE COMPROMISED UNTIL I HAD A FAILURE. I HAVE LOST ALOT OF FAITH IN GM DUE TO THIS ISSUE. I AM STILL WORKING WITH GM AND THE DEALER TO GET THE PROBLEM RESOLVED, BUT IT IS NOT LOOKING GOOD. I AM WONDERING HOW MANY OTHER VEHICLES ARE COMPROMISED. I WAS TALKING TO MY UNCLE THE OTHER DAY AND A GENTLEMAN OVERHEARD MY CONVERSATION. HE TOLD ME THAT HE HAD A 2003 2500 CHEVROLET THE BRAKES ALSO FAILED ON. HE WAS TOWING A TRAILER AND TOATLED HIS TRUCK. I AM COMPLETELY OUT OF WARRANTY AS OF NEXT MONTH. GM SAYS TO KEEP MY BILL FOR THE REPLACEMENT OF THE LINES THAT I MAY GET PAID BACK. I DONT THINK THAT IS LIKELY AT ALL. THIS SHOULD BE A RECALL BECAUSE SAFETY IS COMPROMISED.

REAR BRAKE LINE RUSTED COMPLETELY THROUGH DURING NORMAL DRIVING OPERATION WHICH RESULTED IN A BRAKE FLUID SPILL AND REDUCED BRAKING CAPACITY OF THE VEHICLE. VEHICLE WAS ON A CITY STREET TURNING ONTO A HIGHWAY WHEN THE INCIDENT HAPPENED. FURTHER INSPECTION FOUND THAT ALL BRAKE LINES ON THE VEHICLE HAD EXTENSIVE CORROSION AND HAD TO BE REPLACED. VEHICLE HAD 120,000 MILES ON IT WITH NO ACCIDENT HISTORY.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 3500. WHILE DRIVING UP A MOUNTAIN AT APPROXIMATELY 30 MPH, THE STEERING WHEEL TURNED IN THE OPPOSITE DIRECTION OF THE INTENDED TURN. AS A RESULT, THE VEHICLE WANDERED OFF THE ROAD UNCONTROLLABLY. THERE WAS ALSO A LOSS OF BRAKING ABILITY; HOWEVER, THE VEHICLE EVENTUALLY CAME TO A STOP AFTER APPLYING THE BRAKE PEDAL NUMEROUS TIMES. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE INTERMEDIATE SHAFT BOLTS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 308,000.

BRAKE PEDAL WENT TO FLOOR ON RURAL ROAD. ABLE TO STOP BY DOWNSHIFTING AND RUNNING OFF ROAD. BRAKE LINES HAD ROTTED OUT. DURING THIS REPAIR IT WAS FOUND THAT GAS LINE HAD ALSO ROTTED AND WAS LEAKING. TOTAL COST OF REPAIRS, NEARLY $2,000.00

RUSTED BRAKE LINE RESULTING IN TOTAL BRAKE FAILURE WHILE DRIVING AND ATTEMPTING TO STOP

BREAK LINES ARE COMPLETELY RUSTED AND I AM AFRAID THEY WILL GO OUT WITHOUT WARNING. TRUCK ONLY HAS 67,000 MILES ON IT.

DRIVING TO WORK TODAY THE METAL BRAKE LINE UNDER THE DRIVER DOOR BURST LEAVING ME WITH VERY LITTLE STOPPING POWER. THIS IS THE SECOND TIME THIS LINE HAS FAILED.

AS I COME TO A STOP, THE BRAKE PEDAL PULSATES FROM ABS ACTIVATION INCREASING BRAKING TIME AND DISTANCE. THE GROUND IS DRY WHILE THIS HAPPENS. AFTER A WHILE THE AND LIGHT COMES ON. WAS TOLD BY A DEALER MECHANIC IT WAS A BAD ABS SENSOR AND TO REPLACE HUB. I DID AND NOW, TWO YEARS LATER, IT IS HAPPENING AGAIN. NOW I'M BEING TOLD IT IS A PROBLEM WITH ELEMENTS IN MY AREA, BEING IN A SNOWBELT STATE, GETTING INTO WHEEL SPEED SENSOR AND BLOCKING SIGNAL. SAME EXACT SYMPTOMS AS LAST TIME, DIFFERENT DIAGNOSIS. NEITHER TIME DID THEY PLUG INTO MY TRUCK FOR CODES. BOTH TIMES, I HAVE TO OPEN MY WALLET FOR FAULTY PRODUCTS.

AIR BAG WARNING LIGHT COMING ON, HAVE NEVER HAD AN ACCIDENT IN THIS TRUCK.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT HEARD AN ABNORMAL GRINDING NOISE COMING FROM THE WHEEL AREA. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HUB ASSEMBLY FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07E106000 (WHEELS). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 104,649.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. AS SOON AS THE VEHICLE WAS STARTED, THE DRIVER'S SEAT HEATED UP AUTOMATICALLY. WHEN THE VEHICLE WAS TURNED OFF, THE SEAT HEATER ACTIVATED ON HIGH. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED AND REMAINED ON FOR THE PAST TWO WEEKS. THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 105,647.

BRAKE LINE FAILURE DUE TO EXCESSIVE CORROSION AS THE LINES LAY ON THE FRAME. LUCKILY, THE BREAK WAS AT HOME AND I WAS ABLE TO GET IT INTO THE SHOP FOR REPAIR. LESS THAN A MONTH LATER, ANOTHER LINE BROKE AS I WAS PULLING INTO MY DRIVE.

LOST BRAKES WHILE DRIVING IN RESIDENTIAL NEIGHBORHOOD DUE TO RUSTED BRAKE LINE. HAD IT TOWED TO MY MECHANIC WHO DID AN INSPECTION AND SAID ALL THE BRAKE LINES WERE RUSTED AT THE BRACKETS HOLDING THE LINES. MY MECHANIC IS IN THE PROCESS OF REPLACING THE BRAKE LINES. I TALKED TO SEVERAL OTHER PEOPLE WITH THE SAME YEAR TRUCK AND BOTH HAD ALSO EXPERIENCED BRAKE LINE FAILURE FROM RUST. TRUCK HAS ONLY 20K MILES AND HAS ONLY BEEN IN THE SALT TWICE AS I HAD AN OLDER VEHICLE I USED WHEN IT SNOWED. GM NEEDS TO CORRECT THIS SAFETY DEFECT.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. WHILE THE TODDLER WAS PLACED IN THE DRIVER SEAT OF THE VEHICLE, SHE TURNED THE KEY TO THE ACCESSORY POSITION. THE VEHICLE ROLLED DOWN THE HILL AND CRASHED INTO A TREE. THE AIR BAGS DID NOT DEPLOY. THE TODDLER DID NOT SUSTAIN ANY INJURIES. A POLICE REPORT WAS NOT FILED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR DIAGNOSED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 215,000.

THERE WAS A RECALL IN 2011 ON THE RESISTOR AND CONNECTOR FOR THE FAN MOTOR AND THAT WAS REPLACED IN MY TRUCK THEN. I JUST HAD TO REPLACE THE SAME PARTS AGAIN. AFTER HAVING A RECALL ON THESE PARTS WHY WOULD THEY GO OUT AGAIN IN SUCH A SHORT PERIOD OF TIME?

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING 35 MPH AND ATTEMPTING TO DECREASE IN SPEED, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD AND FAILED TO STOP THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 86,642.

THIS VEHICLE HAS HAD MULTIPLE BRAKE ISSUES SINCE NEW. FIRST OFF, IT GOES THROUGH FRONT BRAKE PADS AND ROTORS TOO FREQUENTLY. FIRST REPLACED AROUND 25K AND AGAIN AROUND 60K. THIS VEHICLE HAS MOSTLY BEEN USED FOR LONG HIGHWAY TRIPS, NY TO FL ETC., NOT AROUND TOWN. USED IN RURAL AREA. NEXT, SEVERAL BRAKES LINES HAVE BURST AND HAD TO BE REPLACED. THE LAST INCIDENT LUCKILY WAS IN MY DRIVEWAY. HAVING DUAL BRAKE CYLINDERS ON THESE TRUCKS DOES NOT SEEM TO HELP IF A BRAKE LINE BURSTS. I NEEDED THE EMERGENCY BRAKE TO STOP IT ON ALMOST FLAT GROUND. A RECURRING PROBLEM IS WITH THE ABS. EVIDENTLY THEY RUST EASILY, ESPECIALLY IN SALT BELT STATES, THEN CORROSION ON THE SENSOR AND HUB CAUSES IT TO ACTIVATE FOR NO REASON. IT DOES NOT ACTIVATE THE COMPUTER CONTROL OR GIVE WARNING. IT HAPPENS INTERMITTENTLY. I HAD TO HAVE ONE FRONT HUB REPLACED IN 2013 AND ANOTHER IN 2014. NOW I AM HAVING TO REPLACE ONE OF THOSE AGAIN WITH THE DEALER RECOMMENDING TO REPLACE BOTH. THE COST IS OVER $750 PER SIDE. THERE WERE RECALLS ON PREVIOUS YEAR MODELS BUT NOT 2006. THIS IS RIDICULOUS AND THE BRAKE LINE ISSUE HAS BEEN GOING ON WITH CHEVROLET FOR A VERY LONG TIME. I HAD TO REPLACE MOST LINES ON MY 1996 SILVERADO. I CAN'T BELIEVE THAT NHSTA ALLOWS THIS TO GO ON YEAR AFTER YEAR. NOTHING IS MORE IMPORTANT THAN BRAKING, NOTHING!

THERE WERE TWO INCIDENTS WITH THE 2006 SILVERADO AND BOTH RELATED TO THE STEEL BRAKE LINES. A) DURING INNER CITY DRIVING, THE REAR BRAKES FAILED. CAUSE WAS A BROKEN STEEL BRAKE LINE FROM THE ABS MODULE TO THE REAR 'Y' BLOCK. BELIEVE THE LEAK WAS CLOSER TO THE REAR AXLE. NEW STAINLESS STEEL LINE WAS INSTALLED. B) AGAIN DURING INNER CITY DRIVING, THE FRONT BRAKES FAILED. ONE OF THE STEEL LINES FAILED. IT LOOKED LIKE THE ISSUE WAS NEAR THE ABS MODULE. BUT IN REMOVING ALL OF THE REMAINING BRAKE LINES IT WAS HARD TO TELL WHAT WAS THE EXACT FAILURE POINT. WITH THE EXCEPTION OF THE COATED STEEL LINES ON THE REAR AXLE; ALL OF THE ORIGINAL GENERAL MOTORS LINES WERE IN RUSTED/CORRODED STATE. ALL STEEL BRAKE LINES HAVE BEEN REPLACED WITH STAINLESS STEEL LINES. THE TRUCK BELONGS TO MY FATHER [XXX] AND WAS DRIVING IT BOTH INSTANCES. HIS EMAIL IS: [XXX]@AOC.GOV INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *JB

I HAVE A HOME IN THE HILLS OF WEST VIRGINIA AND HAD JUST RETURNED FROM TOWN AFTER DRIVING UP AND DOWN LOCAL MOUNTAIN ROADS. I PARKED IN THE DRIVEWAY WITHOUT INCIDENT. WHEN I STARTED THE TRUCK TO MOVE IT IN DRIVEWAY AND PRESSED ON THE BRAKE PEDDLE, THE PEDDLE WENT COMPLETELY TO THE FLOOR AND I WAS TOTALLY WITHOUT BRAKES. LUCKILY, I WAS ON A FLAT SURFACE AND USED MY EMERGENCY BRAKE TO STOP VEHICLE. WHEN I STEPPED ON THE BRAKES AGAIN, I NOTICED A STREAM OF BRAKE FLUID SQUIRTING OUT FROM THE AREA UNDER THE DRIVER SIDE DOOR. UPON FURTHER INVESTIGATION I REALIZED THAT ONE OF THE BRAKE LINES ALONG THE FRAME HAD FAILED DUE TO CORROSION. ONLY ONE OF THE 4 BRAKE LINES HAD FAILED, HOWEVER, THE ENTIRE BRAKING SYSTEM WAS RENDERED COMPLETELY INOPERABLE. ABSOLUTELY NO REDUNDANT BRAKING AVAILABLE, EXCEPT FOR THE EMERGENCY BRAKE. IF THIS HAPPENED WHILE DRIVE ON THE HIGHWAY OR DOWN THE MOUNTAIN, IT COULD HAVE BEEN CATASTROPHIC. THE TRUCK HAS NO VISIBLE BODY OR FRAME CORROSION. HOW COULD THE THE SAFETY-CRITICAL BRAKE LINES CORRODE WHEN THE REST OF THE VEHICLE IS IN GOOD SHAPE RUST-WISE? SEEMS GM HAS USED SUB-STANDARD BRAKE LINES IN THE VEHICLE. I HAVE RESEARCHED THIS ISSUE AND IT IS A WELL-DOCUMENTED PROBLEM THAT GM KNOWS ABOUT AND SHOULD BE REQUIRED TO ADDRESS.

BRAKE LINE RUPTURE DO TO RUSTED LINES, SPEED 45 MPH NO BRAKES AT ALL AND USED EMERGENCY BRAKE TO FINALLY STOP ON SHOULDER OF ROAD.. BRAKE FLUID UNDER DRIVES SIDE DOOR NEAR THE FRAME.

THERE IS EXTREME FRAME RUST CAUSING THE SPARE TIRE MOUNT TO BECOME DETACHED FROM THE FRAME WHILE DRIVING ALONG THE HIGHWAY. FORTUNATELY THIS HAPPENED ON A SECONDARY ROAD IN SOUTH WEST VIRGINIA. THE SHOCK ABSORBER WAS THE ONLY THING THAT HELD THE SPARE TIRE MOUNT FROM COMING COMPLETELY LOOSE FROM THE TRUCK. AFTER INSPECTING THE FRAME, THERE IS EXCESSIVE RUST ON THE MAIN FRAME AND ONE OF THE CROSS MEMBERS IS NEARLY RUSTED THROUGH. THIS TRUCK IS NINE YEARS OLD AND ONLY HAS 63K MILES. I HAVE THE TRUCK AT THE DEALERSHIP FOR THEM TO SEE IF IT IS SAFE TO DRIVE I AM AWAITING TO HEAR FROM THEM TO SEE IF GM IS GOING TO HELP ME WITH THIS MATTER.

BAKE LINES FAILED AT 114874 MILES. HAD TO REPLACE BAKE LINES. 10/14/2015. HAD TO USE THE PARKING BAKE TO STOP THE TRUCK. LUCK I DID NOT RACK! THANK GOD.

MY VEHICLE WITH 57,000 MILES HAD THE BRAKES GO OUT WHILE DRIVING WITHOUT WARNING. I TOOK IT TO A MECHANIC WHO SAID THE FRONT BRAKE LINES HAD RUSTED AND BROKE. I HAVE HAD THE WORK COMPLETED. I FEEL THIS IS A PRODUCT DEFECT FOR A LOW MILEAGE VEHICLE. IT IS VERY WELL TAKEN CARE OF AND HAS VERY FEW MILES ON IT, AND I HAVE OWNED IT SINCE IT WAS NEW. I HAVE BEEN IN CONTACT WITH CHEVROLET AND THEY WILL NOT PROVIDE ME WITH ANY ANSWERS. THEY KEEP TELLING ME TO TAKE IT TO A DEALERSHIP, HOWEVER THE DEALERSHIP HAS TOLD ME THERE IS NOTHING THEY CAN DO.

ONE BRAKE LINE BURST FROM BEING RUSTED OUT AND THE REMAINING 4 FRONT BRAKE LINES ARE IN BAD SHAPE AND NEED TO BE REPLACED. THE BRAKE LINE BURST WHILE I WAS PULLING MY BOAT TRAILER AND I NARROWLY AVOIDED AN ACCIDENT. I WAS IN A RESIDENTIAL AREA AND WAS ONLY GOING ABOUT 15MPH.AND WAS ABLE TO APPLY THE EMERGENCY BRAKE TO STOP THE TRUCK.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING AT 25 MPH, ANOTHER VEHICLE FAILED TO YIELD. AS A RESULT, THE CONTACT CRASHED INTO THE PASSENGER SIDE OF ANOTHER VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED HIP AND PELVIC INJURIES ON THE RIGHT SIDE THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 35 MPH, THE BRAKE PEDAL WAS DEPRESSED, BUT THE VEHICLE HESITATED TO STOP. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC REPLACED THE BRAKE SYSTEM BUT THE FAILURE RECURRED. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

WHILE APPROACHING A TRAFFIC SIGNAL MY BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. I DROVE MY VEHICLE SLOWLY HOME AND CHECKED BRAKE FLUID LEVEL. IT WAS LOW AND I TOPPED IT OFF. I TRIED THE BRAKES AGAIN AND ONCE AGAIN THE PEDAL WENT TO FLOOR. I WENT UNDER THE VEHICLE AND BRAKE FLUID WAS DRIPPING OFF THE CROSS MEMBER JUST BEHIND THE ENGINE. I COULD SEE THAT ALL THE BRAKE LINES WERE VERY RUSTY. I WAS ABLE TO GET THE VEHICLE TO BIG O TIRES. AFTER INSPECTION, IT WAS FOUND THAT THE BRAKE LINE HAD RUSTED THROUGH AND ALL THE OTHERS WERE IN VERY BAD SHAPE AND I HAD ALL THE LINES REPLACED. AFTER SOME RESEARCH I FOUND THIS WAS A KNOWN PROBLEM AND GM HAS REDESIGNED THE LINES BUT, REFUSED TO RECALL AND REPLACE THE LINES. YOU NEED TO RESEARCH THIS PROBLEM FURTHER AND INSIST ON A RECALL BEFORE SOMEONE IS KILLED. I AM THE ORIGINAL OWNER AND AS INDICATED BY THE MILEAGE THE VEHICLE IS NOT DRIVEN THAT MUCH AND VERY WELL TAKEN CARE OF.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. UPON INSPECTING UNDERNEATH THE VEHICLE, THERE WAS EXTENSIVE RUST AND CORROSION ON THE BRAKE LINES. THE CONTACT ALSO INDICATED THAT THE BRAKE LINES PREMATURELY FRACTURED. VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 87,000. UPDATED 11/04/15*LJ UPDATED2/2/2016*JS

I FILLED UP MY GAS TANK ON 8-10-2015 AND WAS DRIVING AT 70 MILES A HOUR WHEN THE ENGINE JUST SHUT DOWN. I RESTARTED IT AND IT STARTED MISSING OUR REAL BAD, I THOUGHT IT WAS MAYBE SOME BAD GAS. I NOTIFIED THE GAS STATION AND THEY STARTED CHECKING THE GAS OUT. WHILE THEY WERE DOING THAT, I TOOK IT TO A MECH. AS THEY SAID IT WAS PROBABLE THE GAS, PUT A CAN OF SEAFOAM AND TRY TO USE THE GAS UP. I DID AND IT KEPT GETTING WORSE , IT WOULD NOT IDLE AND KEPT STALLING OUT. I TOOK IT TO A MECH AND THEY FOUND A INTERMITTING WIREING PROBLEM. IT WAS A "IGNITION COIL WIRE HARNESS"TOOK TO DAYS TO FIND, THEY REPLACED IT AND RUNS GOOD NOW..ODOMETER READING WAS 55315. THEY CHECKED EVERY THING TWICE BEFORE THEY FOUND THE PROBLEM IN THE 2 DAYS THEY HAD IT.

WHEN SLOWING DOWN TO STOP,APP 5 TO 10 MPH,BEFORE STOP.BRAKE PEDEL WILL SOFT AND PLUSE LIKE BRAKES WENT AWAY BUT STOPING YOU.ITS FEELS LIKE YOU LOST YOUR BRAKES.ITS BEEN STEATY APP 9 OUT OF 10 TIMES. HAD VEHICLE CHECK OUT SEVERAL PLACES FOR BAKES ISSUES,NEW ROTORS ,PADS ,DRUMS,AND SHOES .PLUG IN COMPUTER NO CODES ON BRAKES OR ABS SYSTEM.ITS CAN BE SCARY WHEN DRIVING TRYING TO STOP.

TRAVELED TO STORE ABOUT FOUR BLOCKS AWAY FROM MY RESIDENCE. UPON RETURNING, I NOTICED MY BRAKES BARELY WORKING WHILE GOING DOWNHILL ON STREET. I HAD TO DOWNSHIFT AND USE EMERGENCY BRAKE TO GET TO BOTTOM OF HILL. AT BOTTOM OF HILL IS MY DRIVEWAY. I WAS ABLE TO ENTER MY DRIVEWAY AND PARK. I COULD SEE A LIQUID DRIPPING RAPIDLY -- BRAKE FLUID-- UNDER THE TRUCK ABOUT THE MIDDLE OF THE DRIVERS SIDE DOOR. I OPENED THE HOOD AND CHECKED THE BRAKE FLUID LEVEL, ONLY A SMALL AMOUNT LEFT. WITHIN FIVE MINUTES THE REST OF THE BRAKE FLUID HAD DRAINED OUT WITH GRAVITY. THANKFULLY NO ONE WAS IN FRONT OF ME OR CROSSING THE STREET. NOTE: THERE WAS NO INDICATION ON DASH LIT PRIOR TO THIS HAPPENING. BRAKING LOSS HAPPENED FIRST. SEEMS LIKE BRAKE LINE JUST SPLIT/BURST.

LEAVING MY DRIVE WAY MY BRAKE PEDDLE WENT ALL THE WAY TO THE FLOOR. I HAD TO USE EMERGENCY BRAKE TO STOP TRUCK. AFTER CHECKING FOR PROBLEM I FOUND THAT THE METAL BRAKE LINE FROM THE MASTER CYLINDER TO THE BRAKES HAD RUSTED THROUGH IN THE ENGINE AREA AND BRAKE FLUID WAS BEING SPRAYED ON THE MANIFOLD. (IF ENGINE WAS HOTTER THEIR COULD HAVE BEEN A FIRE.) TRUCK IS SITTING IN MY DRIVEWAY STILL NOT FIXED.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE THE VEHICLE WAS COMING TO A STOP, THE ANTI-BRAKE SYSTEM ENGAGED INDEPENDENTLY AND CAUSED THE BRAKES TO FAIL. THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 9,000.

I WAS BACKING OUT OF MY DRIVEWAY WHEN ALL OF A SUDDEN I LOST POWER STEERING AND TRIED TO APPLY THE BRAKES AND I HAD NO BRAKES. GOOD THING I WASN'T ON THE INTERSTATE DOING 70MPH!!

I WAS DRIVING THE TRUCK AWAY FROM MY HOME , WHEN I STEPED ON THE BRAKE PEDAL IT WENT TO THE FLOOR. I GOT THE TRUCK STOPPED WITH THE PARKING BRAKE. WHEN I INSPECTED THE BRAKE LINES THEY WERE ALL EXTREMELY RUSTY AND ONE HAD BURST. FLUID LEAKED OUT AND THERE WAS NO PEDAL AT ALL. THE BRAKES WERE GONE WITH NO WARNING.

TRAVELING 60 MPH ON THE HIGHWAY AND APPROACHED A RED TRAFFIC LIGHT. APPLIED THE BRAKES TO STOP WITH OTHER TRAFFIC. BRAKE PEDAL WENT COMPLETELY TO THE FLOOR WITH APPROXIMATELY 10% BRAKING POWER. NO WARNING LIGHTS ON DASH. FORTUNATELY THE TRAFFIC LIGHT TURNED GREEN AND TRAFFIC MOVED PRIOR TO A CRASH. CRASH WAS GUARANTEED IF TRAFFIC LIGHT HAD NOT CHANGED. BRAKE FLUID LEVEL FINE. BRAKE LINE UNDER DRIVERS SIDE RUSTED AND BURST. NO WARNING SIGNS.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE BACKING OUT OF THE GARAGE, THE VEHICLE LUNGED BACKWARDS WITHOUT WARNING. THE CONTACT CONTINUED TO DEPRESS THE BRAKE PEDAL AND THE VEHICLE EVENTUALLY RESPONDED. THE VEHICLE WAS DRIVEN TO THE DEALER, WHO DIAGNOSED THAT THE HYDRO BOOSTER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 54,942.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE FRAME UNDERNEATH THE VEHICLE WAS RUSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE MANUFACTURER USED AN INFERIOR STEEL MATERIAL TO MAKE THE VEHICLE. THE CONTACT STATED THAT THE MANUFACTURER ACKNOWLEDGED THAT AN INFERIOR MATERIAL WAS USED, BUT DID NOT OFFER ANY HELP. THE FAILURE MILEAGE WAS 150,000. THE VIN WAS UNAVAILABLE.

MY WIFE AND I WERE TRAVELING A REMOTE AREA OF COLORADO WHEN WE HAD A TIRE GO FLAT. OK, I'LL JUST GET THE SPARE TIRE AND REPLACE IT. EASY RIGHT? NO! THIS CHEVROLET SPARE TIRE SECONDARY RELEASE WOULD NOT RELEASE NO MATTER WHAT I DID. I WORKED ON IT FOR HOURS AND SEVERAL OTHER DRIVERS STOPPED TO HELP. THERE IS NO WAY ANYONE COULD EVER RELEASE THIS TIRE. MY WIFE IS A TYPE 1 DIABETIC AND HERE WE ARE STRANDED IN THE MIDDLE OF NO WHERE FOR 6 HOURS AND SHE HAS NO FOOD. THIS COULD HAVE ENDED VERY BADLY. ALL BECAUSE OF THIS HORRIFIC POOR DESIGN. NOW AFTER SOME RESEARCH I FOUND OUT NEARLY EVERY CHEVY TRUCK HAS THE SAME PROBLEM. WHY HAS THERE BEEN NO RECALL ON THIS? WE MADE IT BACK TO OUR HOME 10 HOURS AND $450 LATER. THE SPARE TIRE IS STILL STUCK EVEN AFTER THE LOCAL GARAGE WORKED ON IT ALSO SAYING THIS IS A COMMON PROBLEM. THIS IS A SAFETY ISSUE THAT SHOULD BE ADDRESSED.

WHILE APPLYING BREAKS ON DRY SURFACES AND COMING TO A STOP THE ABS KICKS IN AND PEDAL GOES TO THE FLOOR. THIS CAUSES THE STOPPING DISTANCE TO INCREASE. I HAVE ALMOST REAR-ENDED STOPPED AND PARKED CARS AND RAN INTO MY GARAGE DOOR. THERE HAVE BEEN TO MANY CLOSE CALLS SO I HAVE PULLED THE FUSE TO SHUT OFF THE ABS.

APPROACHING A STOP SIGN I APPLIED THE BRAKES AND THE PEDAL WENT TO THE FLOOR. UPON EXAMINATION I FOUND THE BRAKE FLUID WAS LEAKING FROM A RUSTED LINE AT THE READ RIGHT OF THE TRUCK WHERE THE BRAKE LINE FROM THE FRONT OF THE VEHICLE CONNECTS TO THE RUBBER HOSE THAT FEEDS BOTH SIDES OF THE REAR BRAKES. THE REST OF THE LINES LOOK GREAT BUT THAT MAIN FEED IS RUSTED AND FAILED. THIS HAS NEVER HAPPENED TO ME IN ALL YEARS OWNING VEHICLES.

ANTI-LOCK SENSORS DEVELOP RUST AND FAIL. AT SLOW SPEEDS WHEN YOU APPLY THE BRAKES THEY PULSE AND TAKE EXTRA TIME AND DISTANCE TO STOP

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING AT 20 MPH, THE CLUTCH ASSEMBLY FAILED AND COULD NOT SHIFT INTO GEAR. THE FAILURE RECURRED TWICE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 126,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE BRAKE PEDAL WAS DEPRESSED AND THERE WAS AN INCREASED IN STOPPING DISTANCE. THE CONTACT DISCOVERED THAT THE BRAKE LINES RUSTED AND CORRODED CAUSING THE BRAKE FLUID TO LEAK FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE BRAKE LINES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 26,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. WHILE PULLING INTO THE DRIVEWAY AT APPROXIMATELY 7 MPH, THE BRAKE PEDAL WAS DEPRESSED TO THE FLOOR BUT THE VEHICLE DID NOT STOP. THE VEHICLE CRASHED INTO THE CONTACT'S PORCH. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. THE CONTACT OBSERVED BRAKE FLUID UNDER THE FRONT OF THE VEHICLE AND THE BRAKE LINES WERE COMPLETELY RUSTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000. MA 09/03/15 UPDATED 11/03/2017*CN

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING AT APPROXIMATELY 50 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND WITHOUT WARNING. AFTER THE BRAKES WERE APPLIED CONTINUOUSLY, THE SPEED REDUCED TO 10 MPH. THE VEHICLE CAME TO A COMPLETE STOP WHEN THE EMERGENCY BRAKE WAS APPLIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 103,000.

WHILE TRAVELING ON THE EXPRESSWAY IN MY 2006 CHEVROLET SILVERADO WITH 26,000 MILES ON THE ODOMETER, I ATTEMPTED A TRANSIENT LANE CHANGE WHILE TAKING EVASIVE ACTION IN ORDER TO AVOID A HAZARDOUS SITUATION. WHEN COUPLED WITH THE BRAKES I NOTICED LONGER THAN USUAL ENGAGEMENT. AS A RESULT, I WAS FORCED ONTO THE SHOULDER AND HAD TO USE MULTIPLE DOWNSHIFTS IN CONCERT WITH THE EMERGENCY BRAKE TO BRING THE VEHICLE TO A HALT. IT SOUNDED LIKE A TRAIN STOPPING ON RAILS. I PROCEEDED TO DRIVE HOME WITH HAZARDS ON,U NEVER EXCEEDING THIRD GEAR. THE FOLLOWING MORNING I NOTICED CLEAR OIL UNDERNEATH THE FRONT END OF THE VEHICLE. I BELIEVE THIS IS AN EXTREMELY DANGEROUS VEHICLE AND A LESS EXPERIENCED DRIVER WOULD HAVE BEEN KILLED OR EXTREMELY INJURED. LASTLY, I HAVE ALSO BEEN NOTICING INCONSISTENCY WITH STEERING RESISTANCE. SOMETIMES THE STEERING IS CONSIDERABLY LOOSER THAN AT OTHER TIMES. I HAVE DISMISSED THIS DISCONCERTING SENSATION BY ASSUMING IT IS WEATHER/HUMIDITY RELATED.

THE BRAKE LINES CORRODED IN THE MIDDLE OF THE BRAKE LINE, SPRAYING OUT BRAKE FLUID ALL OVER THE SUSPENSION AND RELEASING ALL PRESSURE IN THE BRAKE SYSTEM. THE BRAKES FAILED TO STOP THE VEHICLE AND I HAD TO STOP WITH THE EMERGENCY BRAKE INSTEAD.

BRAKE LINE BLEW OUT WHEN APPLING BRAKES TO MAKE A LEFT TURN. NO PEDAL RESPONSE, PEDAL WENT TO THE FLOOR.

THIS IS THE 2ND TIME THAT A BRAKE LINE BLEW OUT ON THIS TRUCK. NO WARNING THAT ANYTHING WAS WRONG. APPLIED BRAKES COMING TO A STOP SIGN AND BRAKE PEDAL WENT TO THE FLOOR. NO PEDAL RESPONSE. THIS TRUCK IS KEPT CLEAN AND MILEAGE IS UNDER 34000. PLEASE LOOK INTO THIS.

NO WARNING THAT ANYTHING WAS WRONG WITH THE BRAKES. THIS IS THE 3RD TIME A BRAKE LINE HAS BLOWN OUT ON THIS TRUCK. I APPLIED THE BRAKE PEDAL TO NO RESISTANCE UNTIL THE PEDAL HIT SOMETHING METAL. THE TRUCK DID COME TO A GRADUAL STOP. THIS IS A WELL MAINTAINED TRUCK WITH JUST UNDER 39000 MILES ON IT. REGULAR NYS INSPECTIONS, OIL AND GREASED AND LOOKED OVER BY A MECHANIC EVERY 3000 MILES. THIS IS NOT A WEAR PROBLEM AS GM MAINTAINS.

DRIVING DOWNHILL ON MY (400' LONG) DRIVEWAY I DEPRESSED BRAKE PEDAL TO STOP AT THE BOTTOM BEFORE ENTERING TRAFIC. THE BRAKE PEDAL WENT COMPLETLEY TO THE FLOOR. LUCKILY THERE WERE NO CARS COMING. I WAS ABLE TO SWERVE OFF THE SIDE OF THE ROAD AND STOP. I DISCOVERED BRAKE FLUID LEAKING FROM RUSTED LINES ON THE DRIVERS SIDE, MID-WAY DOWN THE LENGTH OF THE TRUCK. UPON FURTHUR INVESTICATION I NOTED ALL BRAKES LINES ARE SEVERLY RUSTED. BASED ON THE LOCATION AND MANNER THESE LINES ARE ROUTED, I WOULD NOT CLASSIFY THEM AS A MAINTENANCE ITEM. PLEASE HELP.

HOLE CAME IN BREAK LINE DUE TO RUST. ALL MOST RAN THRU A BUSY INTERSECTION. ALSO HAD A BREAK LINE TO RUST INTO ON 4/10/15.

VEHICLE DEVELOPED A GAS LINE LEAK, AND UPON INSPECTION, DISCOVERED THAT ALL FUEL AND BRAKE LINES ON VEHICLE HAVE EXTENSIVE CORROSION AND ARE IN NEED OF REPLACEMENT. THE VEHICLE INTERIOR AND EXTERIOR ARE IN NEAR NEW CONDITION, THE ISSUE WITH THE BRAKE AND GAS LINES IS CLEARLY A METALLURGICAL ISSUE AND TO THE EXTENT THIS PROBLEM IS, IS NOT A NORMAL MAINTENANCE ISSUE. THERE HAS BEEN EXTENSIVE REPORTS OF THIS PROBLEM AND IT PUTS LARGE NUMBERS OF CONSUMERS AT RISK. THERE IS NO WAY THAT A WELL MAINTAINED VEHICLE SHOULD REQUIRE REPAIR COSTS IN EXCESS OF $3000.00 FOR THIS TYPE OF SAFETY ISSUE.

WE WERE GETTING READY FOR A LONG TRIP (MARYLAND TO FLORIDA). WE HITCHED OUR TRAILER TO OUR TRUCK AND WERE TESTING LIGHTS, BRAKES, ETC. AT THE CAMPGROUND BEFORE WE LEFT. AS WE TESTED THE BRAKES AT A LOW SPEED, WE REALIZED THE BRAKES DID NOT WORK AT ALL. WE PARKED IT RIGHT THERE ON THE ROAD IN THE CAMPGROUND AND CALLED A TOW TRUCK TO TAKE US TO OUR MECHANIC'S SHOP. WHEN HE LOOKED AT IT, HE FOUND HE HAD TO REPLACE ALL THE BRAKE TUBING BECAUSE THEY WERE ALL RUSTED OUT. HAD WE BEEN ON THE ROAD WITH OUR TRAILER, WE WOULD HAVE HAD A CRASH AND COULD HAVE BEEN KILLED OR SEVERELY HURT.

I PRESSED THE BRAKE PEDAL AND IT WENT TO THE FLOOR AS THE STEEL LINE LEADING TOWARD THE REAR AXLE BURST, THE FAILURE OCCURRED NEAR THE LEFT REAR WHEEL WELL IN THE LINE FOLLOWING THE TOP OF THE LEFT FRAME RAIL TOWARD THE REAR AXLE. LUCKILY THE VEHICLE WAS STATIONARY WHEN IT HAPPENED, SO NO PERSONAL INJURY OCCURRED.THE BRAKE LINES HAVE BEEN INSPECTED AND PASSED ANNUALLY, WITH THE LAST INSPECTION TAKING PLACE EIGHT MONTHS AGO IN SEPTEMBER 2014.

WHILE SLOWING DOWN AND COMING TO A STOP THE AT A JUCTION THE OTHER DAY THE BRAKE PEDAL TRAVELLED ALL THE WAY TO THE FLOOR, NO WARNING. I WAS ABLE TO PRESS THE FOOT BRAKE AND LOCK IT TO STOP THE TRUCK, SCARIEST THING EVER HAVE GONE THROUGH. NOT TO BE IN CONTROL OF A 1/2 TON TRUCK COMING TO A STOP. I THOUGHT FOR SURE I WAS GOING TO BE IN AN ACCIDENT. I FOUND IT HARD TO BELIEVE THAT THE BRAKE LINES COULD BE LEAKING BUT AFTER LOOKING AT THEM, SURE ENOUGH THEY WERE RUSTED THROUGH AND THE BRAKE FLUID WAS POURING OUT. IT TOOK ABOUT 10 MINUTES FOR ALL THE FLUID TO EMPTYED FROM THE MASTER CYCLINDER. AFTER SOME ONLINE RESEARCH I LEARNED THIS HAS BEEN A PROBLEM FOR GM AND THE CHEVY SILVERADO AND OTHER GM TRUCKS. BRAKES LINES RUSTING OUT AFTER AS LITTLE AS 4 YEARS. I CHECKED TO SEE IF THERE WAS A RECALL AND LEARNED THAT IT'S A "REGULAR MAINTAINCE ISSUE". ALTHOUGH MANY 1000'S OF PEOPLE HAVE EXPERIENCED THE SAME ISSUE OF BRAKE LINES RUSTING PREMATURLY. ESTIMATED COST TO REPLACE ALL BRAKE LINES $1500!!! SOME OF US JUST DONT HAVE THAT KIND OF MONEY TO SPEND BUT ILL HAVE TOSAFTLY COMES FIRST GM

I HAD ISSUES WITH STEERING CONTROL,SPECIALLY ON CURVES AT 40 T0 65 MILES P/H ON THE ROAD FROM BEGINNING OF THE PURCHASE.I HAVE BEEN TO CHEVY DEALER TO COMPLAIN ABOUT SAFETY ISSUE ON THE ROAD.BUT DEALER FINDS NO PHYSICAL DEFECT ON THE CAR.ON MAT 15 2015 FINALLY I LOST THE CONTROL OF STEERING WHEEL AND HIT THE SIDE WALK CURB AND BROKE FRONT AND REAR AXLES.LIKELY NO PERSONAL INJURY.I AM VERY CONCERNED ABOUT SAFETY OF OTHER OWNERS IN THIS REGARD.I HAVE CHECKED OTHER RESOURCES TO FIND IF THERE ARE SIMILAR CASES LIKE MINE,AND SURPRISINGLY THERE ARE TOO MANY OF THEM. PLEASE LET ME HELP TO SAVE OTHERS FROM LOOSING THEIR LIVES. THANKS.

GM MAD A FAULTY BOLT DESIGN AND NO ONE IS HOLDING THEM ACCOUNTABLE. I HAVE 3 BROKEN MANIFOLD BOLTS AND THE DEALERSHIP WANTS $2100 TO REPAIR. THERE ARE THOUSANDS UPON THOUSANDS OF OTHERS JUST LIKE ME WHO ARE HELPLESS. WHY ARE YOU AND THE EPA DOING NOTHING? THE VEHICLE CAN'T PASS EMISSIONS LIKE THIS!

MY LEFT FRONT WHEEL HUB ASSEMBLY FAILED WHILE DRIVING. BRAKE SYSTEM WAS COMPROMISED. I WAS ABLE TO PULL OVER AND STOP SAFELY, BUT BRAKES DID NOT RESPOND AS THEY SHOULD. MOREOVER, THERE WAS NO INDICATION THAT THE WHEEL BEARING WAS FAILING, AND I AM QUITE AWARE OF WHAT THIS SOUNDS LIKE BECAUSE THIS WILL BE THE FOURTH TIME I HAVE REPLACED THE WHEEL HUB ASSEMBLY ON THE LEFT SIDE. I HAVE REPLACED THE RIGHT HUB ASSEMBLY TWICE. IN ALL PREVIOUS TIMES, I HEARD A SLIGHT WHIRLING NOISE OR AT WORSE SLIGHT GRINDING, WHICH WOULD LEAD ME TO INSPECTION AND REPLACEMENT BEFORE FAILURE. THIS TIME IT FAILED WITHOUT ANY WARNING. I BELIEVE GM HAS MADE A SERIOUS DESIGN AND/OR QUALITY ERROR IN THIS TRUCK. THIS SHOULD BE INVESTIGATED BECAUSE THIS IS A COMMON PROBLEM.

THE DRIVERS HEATED SEAT COMES ON AND CHANGES SETTINGS AT WILL, AND WHEN IT WILL TURN ITSELF ON IT GOES TO EACH LEVEL OF HEATING LEVELS. I.E, ( LOW/MED/ HIGH) ,AND STAY ON EVEN IF I TURN IT OFF. THEN COMES BACK ON WITH -IN A FEW MUNITIES AS IT IS NOT WORKING PROPERLY. DOES NOT MATTER IF IT IS RAINY, SNOWY OR FOGGY, OR SUNNY, THE DRIVERS HEATED SEAT WILL COME ON, OFF, AND CHANGE SETTINGS CONSTANTLY, THAT I HAVE TO PULL OVER BECAUSE THE SEAT GETS SO HOT!!!!!!!!!!!!!!!!!!!!!!!!.

DRIVING DOWN MY STREET TO GO TO STORE WENT TO STOP AT END OF STREET TO TURN LEFT THE BRAKE PEDAL WENT TO THE FLOOR AND I ALMOST RUN INTO A CAR IN FRONT OF ME. I THEN BACK UP AND BUT IT IN FRONT OF HOUSE. IF I WOULD HAVE BEEN ON A MAIN ROAD AND HAD TO STOP I WOULD HAVE BEEN IN AN ACCIDENT . THE ABS DIDN'T WORK AT ALL IF THIS IS WHAT IT IS SUPPOSE TO DO, THERE WAS NO STOPPING OF THIS TRUCK. THIS WAS THE REAR BRAKE LINE UP BY THE FRAME OF THE TRUCK WITH CONNECTOR. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THE VEHICLE WAS LEAKING FLUID FROM THE BOTTOM. THE VEHICLE WAS TAKEN TO THE AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE STRUT SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 45,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL AND MADE A DINGING SOUND AS THE SERVICE BRAKE LIGHT ILLUMINATED. THE CONTACT MENTIONED THAT THE BRAKE PEDAL HAD BECOME LOOSE. THE VEHICLE WAS NOT INSPECTED OR REPAIRED. THE FAILURE MILEAGE WAS 146,000.

FOR THE THIRD TIME A BRAKE LINE HAS RUSTED COMPLETELY THROUGH AND CAUSED COMPLETE LOSS OF CONTROL. IT WAS LOCATED UNDER THE DRIVERS SEAT ABOVE THE FRAME. I HAD ABSOLUTELY NO BRAKES AT 70 MPH ON HWY 5. I TOOK IT TO A CHEVY DEALERSHIP AND THEY TOLD ME IT WAS NOT THEIR PROBLEM. I AM EXTREMELY CONCERNED ABOUT THE FORTH BRAKE LINE THAT IS COMPLEXLY COVERED IN RUST. THIS IS GOING TO KILL SOMEONE WHEN IT RUSTS THROUGH. *TR

ENGINE IDLER PULLEY SEIZED CAUSING SERPENTINE BELT TO BREAK WHICH RESULTED IN LOSS OF POWER STEERING AND LOSS OF POWER BRAKES..2 LOCAL GM DEALER PARTS DEPARTMENT'S STATED THIS IS COMMON ON THE DURAMAX DIESEL ENGINE. *TR

BRAKE LINE RUPTURE RESULTING IN IMMEDIATE BRAKE FAILURE WITHOUT WARNING. PARALLEL PARKING A 2006 SILVERADO WHEN WE ENCOUNTERED A COMPLETE BRAKE FAILURE AND NEARLY STRUCK ANOTHER PARKED VEHICLE. BRAKE PETAL DEPRESSED COMPLETELY TO THE FLOOR WITHOUT WARNING. STEERED TRUCK TOWARD CURB TO FULLY STOP BEFORE STRIKING OTHER VEHICLE. IMMEDIATE INSPECTION REVEALED BRAKE LINE RUPTURE ON DRIVERS SIDE OF VEHICLE IN UNDERCARRIAGE AREA NEAR BACK OF DRIVERS SEAT. SIGNIFICANT LOSS OF BRAKE FLUID AND COMPLETE BRAKE FAILURE. FORTUNATELY TRAVELING LESS THAN 5 MPH - FIVE MINUTES EARLIER WE WERE TRAVELING AT SPEEDS OF 70 MPH ON INTERSTATE HIGHWAY. THIS COULD HAVE BEEN A CATASTROPHIC EVENT HAD IT OCCURRED ON THE INTERSTATE OR THE OFFRAMP. VEHICLE PASSED A VIRGINIA STATE SAFETY INSPECTION THREE WEEKS EARLIER. GM OR NHTSA SHOULD WARN GM OWNERS TO CHECK THEIR BRAKE LINES AND ALSO CONSIDER A RECALL. *TR

I WAS POSITIONING MY CHEVY SILVERADO 2500 YEAR 2006 TO HOOK UP MY TRAVEL TRAILER RV. AS I WAS BACKING UP TO LINE UP THE HITCH TO THE RV BALL THE BRAKE PEDAL WENT TO THE FLOOR AND I LOST ALL BRAKING. I HAD TO PUT THE GEAR SHIFT IN PARK TO STOP THE SLIGHT ROLL. I LOOKED UNDER THE TRUCK AND THERE WAS BRAKE FLUID ALL OVER MY DRIVEWAY WHERE IT HAD COME OUT OF A CORRODED BRAKE LINE UNDER THE DRIVERS SEAT. THIS TRUCK ONLY HAS 97,797 MILE ON IT. I AM VERY FORTUNATE THAT THE CORRODED BRAKE LINE FAILED BEFORE I WAS ABLE TO HOOK UP THE RV AND START DRIVING, I COULD HAVE HAD A SERIOUS ACCIDENT THAT MIGHT HAVE KILLED SOMEONE. *TR

POWER STEERING WENT OUT COMPLETELY INOPERABLE I APPLY THE BRAKES TO SLOW DOWN AND I HAVE NO BRAKES STILL DON'T KNOW WHAT THE PROBLEM IS THE DEALERSHIP IS TRYING TO RESEARCH FOR A WEEK NOW. *TR

WHEN APPLYING THE BRAKES TO STOP AT AN INTERSECTION, THE VEHICLE LURCHES FOR A FEW FEET THEN JUST LETS GO UNTIL IT COMES TO A COMPLETE STOP SEVERAL FEET INTO THE INTERSECTION. THIS ALSO OCCURS EVERY TIME THE BRAKES ARE APPLIED WHEN TRYING TO STOP. THE BRAKES SEEM TO SLOW YOU DOWN TO 10 MILES PER HOUR THEN THEY LET GO. AT THIS TIME WE ARE FORCED TO USE THIS VEHICLE EVEN THOUGH IT IS UNSAFE. WE WOULD LIKE THIS PROBLEM FIXED ASAP. *TR

LEAVING THE CAR WASH, FAN QUIT WORKING AND I SMELLED A BURNING ODOR. PIGTAIL TO RESISTOR HAD A BURNT WIRE. GOT PIGTAIL FROM DEALER FOR $95.00. PARTS MANAGER TOLD ME THEY REPLACE 4 OR 5 A MONTH. STILL DIDN'T FIX THE PROBLEM. PURCHASED FAN RESISTOR FROM AUTO PARTS STORE. PROBLEM FIXED. APRIL 2010 THE SAME THING HAPPENED AGAIN. WENT TO SALVAGE YARD AND GOT 2 USED PIGTAILS AND INSTALLED ONE OF THEM. RESISTOR SEEMED TO BE OK. APPROX. NOVEMBER 2011 RECEIVED LETTER FROM GENERAL MOTORS SAYING THEY WOULD REIMBURSE ME FOR THE PARTS. I DID GET $95.00 BACK FOR THE PIGTAIL BUT COULDN'T FIND THE RECEIPT FOR THE RESISTOR. APRIL 2015 PROBLEM OCCURRING AGAIN. I STILL HAVE ONE USED PIGTAIL I WILL HAVE TO INSTALL, MAYBE THE RESISTOR. THIS IS A SAFETY ISSUE. THERE SHOULD BE A RECALL. IF I PARK MY TRUCK IN THE GARAGE I TAKE A CHANCE OF BURNING DOWN MY HOUSE. PLEASE SOMEONE DO SOMETHING. *TR

BRAKE PEDAL WENT TO THE FLOOR WHEN TRYING TO BRAKE. GOT THE TRUCK HOME AND TOWED IT TO A AUTO REPAIR BUSINESS. THE BRAKE LINES HAD RUSTED OUT AND WERE LEAKING THE BRAKE FLUID OUT, ALSO HAD TO REPLACE THE CALIPERS BECAUSE THE FLUID BLEEDING MECHANISM RUSTED OUT TOO THIS IS A SAFETY ISSUE AND GM SHOULD HAVE ISSUED A RECALL, THIS REPAIR HAS COST ME 1350 $. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT THERE WAS CORROSION ON THE FRAME OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000.

THE SPARE TIRE STRUCTURE DISINTEGRATED DUE TO RUST. THE SPARE TIRE WAS HANGING AND WAS EASILY PULLED OUT BY HAND. THE STRUCTURE THAT HOLDS THE SPARE TIRE IN PLACE IS BLOCKED BY THE SPARE TIRE AND DOES NOT GET WASHED, CREATING AN AREA WHERE THE DIRT AND SALT ACCUMULATE. THIS EASILY COULD HAVE FALLEN OFF ON THE HIGHWAY. *TR

NOTICED A PECULIAR EXHAUST NOTE SOMEWHAT LIKE A TICK THAT WAS REMINESCENT OF AN EXHAUST LEAK. TOOK VEHICLE TO LOCAL MUFFLER EXHAUST SHOP AND THEY INFORM ME IT IS A MANIFOLD EXHAUST LEAK DUE TO BROKEN BOLT(S) ON THE DRIVER SIDE. WAS ABLE TO LOOK FOR MYSELF AND I SEE ONE BOLT HEAD MISSING IN THE VERY BACK NEAR THE FIREWALL. *TR

WHILE I WAS DRIVING DOWN THE STREET MY BRAKES WHEN OUT. I WAS ABLE TO MAKE IT TO MY DRIVEWAY TO DISCOVER MY BRAKE LINE RUTSTED AND THERE WAS A 1 CM HOLE IN THE BRAKE LINE. *TR

BRAKE LINES ARE SEEPING BRAKE FLUID DUE TO CORROSION AND ARE FAILING. NOTICEABLE SMELL OF BRAKE FLUID AND LEAKAGE IN FRONT OF TRUCK. BRAKE LINES NEED TO BE REPLACED. *TR

ON APPROX. 28 APRIL 2013 AFTER A 200 MILE TRIP I WAS PARKING MY TRUCK WHEN THE BRAKE LINE BROKE. I THEN USED THE EMERGENCY BRAKE TO STOP THE TRUCK. AT THIS TIME I MADE THE NECESSARY REPAIRS TO GET US BACK HOME. ONCE THERE I RESPONDED TO LEN STOLER CHEVEROLET IN WESTMINSTER MD. WHERE I PURCHASED THE VEHICLE. I ASKED THEM IF THEY COULD BLEED THE BRAKES, BECAUSE I DID NOT THINK I GOT ALL THE AIR OUT OF LINES. AT THIS TIME I WAS WAITING IN THE WAITING ROOM WHEN A SERVICE ADVISOR CAME IN AND ASK ME TO GO INTO THE SHOP BECAUSE THEY WANTED TO SHOW ME SOMETHING. WHEN I ARRIVED AT MY TRUCK (WHICH WAS ON THE LIFT) THEY STATED THE ENTIRE BRAKE LINES WERE SO CORRODED THAT THEY NEEDED TO BE REPLACED AT A PRICE OF $1610.80. I STATED THAT THE SO CALL METAL USED HAD TO BE DEFECTED TO ALLOW THE WHOLE SYSTEM OF LINES TO RUST TO THIS POINT IN ONLY SEVEN YEARS. SHE THEN REPLIED THAT IT WAS NOT CAUSE BY THE METAL USED, IT WAS THE NEW SALT THAT THE STATES USES NOW. WHEN THEY REPLACED THE OLD LINES WITH THE NEW,I ASK THE SERVICE ADVISOR IS THE METAL BRAKE LINES BEING INSTALLED , WERE THEY USING THE SAME KIND OF METAL AND SHE REPLIED, NO THEY ARE USING ZINK COATED LINES NOW. MY QUESTION DID ANY OTHER TRUCKS LIKE MINE HAVE THE SAME PROBLEM AND WHY DID THEY USE A NEW METAL IF THERE WAS NOTHING WRONG WITH ORIGINAL METAL. *TR

TRANSMISSION SLIPPING, BANGING PERIODICALLY 1,2,3 GEAR AND DOWN SHIFT. TRANSMISSION GAUGE RED-LINED, NOW IS NOT PROPERLY SHOWING TEMP. OIL GAUGE IS MOVING 0 TO 80 ALL THE TIME. SOME LIGHTS HAVE BEEN GOING OUT ON PANEL AND STEERING WHEEL. CHECK ENGINE LIGHT ON AND OFF. TRANSMISSION COMPANY DIAGNOSED AS A POSSIBLE ELECTRICAL ISSUE AND CHEVY STATES THE TRANSMISSION BANG AND SLIP IS COMMON AND NO REPAIRS ARE NEEDED? HELP.

TL*THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 15 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND. AS A RESULT, THE CONTACT CRASHED INTO A TREE AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKE LINE WAS RUSTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.

I WAS BACKING UP THE TRUCK WHEN A CAR CAME UP BEHIND ME AND HAD TO HIT THE BRAKES HARD. THE PEDDLE WENT ALL THE WAY TO THE FLOOR, NO BRAKES AT ALL. HAD TO STEER THE TRUCK INTO A SNOW BANK TO AVOID AN ACCIDENT. THE CAB OF THE TRUCK IMMEDIATELY SMELLED LIKE BRAKE FLUID. TOOK THE TRUCK TO THE SHOP AND DISCOVERED THE BRAKE LINES ARE RUSTED AT EVERY POINT WHERE THEY CONNECT TO THE FRAME. REPAIRED THE FIRST LEAK AND ANOTHER LEAK STARTED IN ANOTHER LINE IN THE SAME AREA THE LINES ATTACHED TO THE FRAME BEHIND THE DRIVERS SIDE FRONT WHEEL. REPAIRED THE SECOND LEAK AND A 3RD LEAK APPEARED INSIDE THE FRAME RAIL BEHIND THE CAB WHERE THE LINE ATTACHES TO THE FRAME. THE LINES CAN NOT BE SAFELY REPAIRED. ALL NEW LINES MUST BE INSTALLED. THE TRUCK ONLY HAS 10,250 MILES ON IT AND IS ALWAYS WASHED INCLUDING THE UNDER CARRIAGE AFTER DRIVING ON SALTED ROADS. *TR

I HAD A BRAKE LINE BRAKE DRIVING MY BABY TO THE DOC, TOWED IF TO THE SHOP & FOUND OUT ALL THE BRAKE LINES & HARDWARE WERE RUSTED BEYOND REPAIR & EVERYTHING NEEDED REPLACED, WE FOUND THAT GM HAD USED BAD PRODUCTS ON THEIR CHEVY TRUCKS FROM 99-07 BUT ONLY RECALLED 99-03, APPARENTLY THERE'S NOT ENOUGH DEATHS IN MODEL YEARS 04-07 TO RECALL, WELL IF WE WERE GOING FASTER IT PROB WOULDN'T HAVE ENDED WELL FOR US, THE COST OF THE REPAIRS WERE AROUND $700. *TR

TL*THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 10 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE FAILURE OCCURRED ON TWO OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FAILURE COULD NOT BE DUPLICATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, ANOTHER VEHICLE CUT THE CONTACT'S VEHICLE OFF CAUSING HIM TO SLAM DOWN ON THE BRAKES. AS A RESULT, THE BRAKE LINE FRACTURED AND THE VEHICLE BEGAN TO LEAK BRAKE FLUID. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE BRAKE LINES NEEDED TO BE REPLACED DUE TO CORROSION. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000. THE VIN WAS UNAVAILABLE.

UNIROYAL LAREDO HD/H LT265/75 R15 HAD A TREAD SEPARATION THAT CAUSED CONSIDERABLE SHEET METAL DAMAGE WITHIN AND BEHIND THE RIGHT REAR WHEEL WELL OF MY CHEVY SILVERADO 2500 HD PICKUP. THE INCIDENT OCCURRED AT 60 MPH WHILE I WAS TOWING A TRAVEL TRAILER. I NEVER LOST CONTROL OF THE VEHICLE AND WAS ABLE TO BRING IT SAFELY TO A CONTROLLED STOP. THE TIRE WAS ONE OF FOUR INSTALLED NEW BY THE AUTO DEALER IN EARLY 2012 WHEN I PURCHASED THE TRUCK USED. THE TIRE HAD APPROXIMATELY 17,000 MILES OF USE WHEN THE SEPARATION OCCURRED. I ALWAYS KEPT THE TIRE INFLATED TO THE TRUCK AND TIRE MANUFACTURERS' RECOMMENDED 80 PSI AND HAD JUST INFLATED THE TIRE TO THAT PRESSURE (IT WAS AT 74 PSI BEFORE I TOPPED IT OFF) THREE DAYS EARLIER, BEFORE STARTING MY TRIP. I NOTICED A RECALL OF TIRES OF SIMILAR VINTAGE IN THE UNIROYAL LAREDO HD/H LT 245/75 R16 SERIES, AND I AM CURIOUS IF MANY TREAD SEPARATIONS HAVE ALSO BEEN REPORTED FOR THE 265/75 R16 SERIES OR IF THIS IS A ONE OFF INCIDENT. *TR

STOPPING THE TRUCK IN FRONT OF MY GARAGE WHEN THE BRAKE PEDAL WENT ALMOST TO THE FLOOR. I INSPECTED BELOW THE TRUCK AND NOTED FLUID LEAKING FORWARD OF THE ABS MODULE. I STILL HAD PARTIAL BRAKES AND WAS ABLE TO TAKE IT THE FEW MILES DOWN THE ROAD TO MY MECHANIC. HE INSPECTED ALL MY BRAKE LINES AND ENDED UP REPLACING THEM ALL AS THEY WERE SHOWING THE SAME PITTING AND CORROSION PROBLEMS AS THE ONE THAT BURST. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING 10 MPH, THE BRAKE PEDAL SHOOK WHEN IT WAS DEPRESSED. THE FAILURE RECURRED SEVERAL TIMES. THE DEALER STATED THAT THE SENSOR WAS RUSTED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

DURING A NORMAL STOP AT A LIGHT, JUST AS THE VEHICLE WAS GETTING CLOSE TO A COMPLETE STOP THERE WAS A NOTICEABLE BUMP FELT IN THE BRAKE PEDAL AND RELEASE OF BRAKE APPLICATION ON ITS OWN WHILE STILL PUSHING ON THE BRAKE PEDAL. THIS OCCURRED AS VEHICLE WAS SLOWING, JUST BEFORE A COMPLETE STOP WAS ACHIEVED . AFTER RESEARCHING THE PROBLEM WHICH SEEMS TO BE WELL KNOWN IN AUTOMOTIVE FORUMS AND BY GM. I REMOVED THE FRONT WHEEL SPEED SENSORS, CLEANED THE CORROSION FROM THE MOUNTING PADS AND REASSEMBLED. BEFORE CLEANING THE SENSOR MOUNTING THE PROBLEM WOULD OCCUR 80-90% OF THE TIME BRAKES WERE APPLIED. AFTER CLEANING IT HAS NOT HAPPENED AGAIN. THERE IS A RECALL ON THIS VERY ISSUE ON EARLIER YEAR MODELS, CLEARLY THIS NEEDS TO BE EXPANDED TO MORE MODEL YEARS. IF SOMEONE HAD BEEN IN FRONT OF ME WHEN THIS OCCURRED THERE IS A VERY GOOD POSSIBILITY I WOULD HAVE HIT THE BACK OF THEIR VEHICLE. *TR

STARTING FROM A WAITING LINE FOR MY ANNUAL VEHICLE INSPECTION I WAS DIRECTED TO STOP, WHILE TRYING TO DEPRESS THE BRAKE PEDAL IT WENT TO THE FLOOR WITH NO RESISTANCE AND NOT WARNING LIGHT. I HIT THE EMERGENCY BRAKE TO HALT THE VEHICLE AND ASK THE MECHANIC ON DUTY TO ASSIST IN DETERMINING THE PROBLEM. WHILE PUMPING THE BRAKE TRYING TO BUILD UP PRESSURE I WAS TOLD TO STOP AS FLUID RUNNING ON THE GROUND IT APPEARED TO BE COMING FROM UNDER THE LEFT FRONT HEADLIGHT AREA. AFTER IT WAS LIFTED ON THE RACK IT WAS DETERMINED THAT MY STEEL BRAKELINE HAD DEVELOPED A HOLE DUE TO EXCESSIVE CORROSION. I WAS LUCKY AS JUST PRIOR I WAS ON A MAJOR FREEWAY AND TRAVELING AT A MUCH HIGHER RATE OF SPEED. THE MECHANIC EXPLAINED THAT WHERE THE LINE RUNS ACROSS FROM LEFT TO RIGHT THAT IT APPEARS THAT WATER IS CONSTANTLY BEING DIVERTED FROM THE RADIATOR DOWN ONTO THE LINE. THIS SOUNDS LIKE A DESIGN FLAW THAT SHOULD HAVE BEEN DISCOVERED A LONG TIME AGO OR THE BRAKE LINE SHOULD BE STAINLESS STEEL TO PREVENT THE CORROSION. *TR

MY AIR BAG LIGHT CAME ON FOR NO REASON AND IT IS NOT ON THE RECALL LIST. IS THERE ANOTHER LIST FOR RECALLS. I HAVE NEVER HAD A ACCIDENT OR MY AIR BAG HAS NEVER BEEN DEPLOYED. CAN YOU TELL ME IF THIS WILL BE FIX THOUGH THE RECALL. I'M CONCERNED WITH DRIVING IT WITHOUT NO AIR BAGS. *TR

2006 CHEVROLET SILVERADO LT. CONSUMER IS CONCERNED ABOUT ISSUES WITH RUSTING BRAKE LINES ON GM PICKUP TRUCKS.*TA AN INSPECTION REVEALED, THE BRAKE LINES WERE RUSTED ON THE CONSUMERS VEHICLE. JB

THE REAR TAIL LIGHT ASSEMBLY IS BREAKING OUT OF THESE PICKUP TRUCKS BECAUSE OF A WEAK DESIGN TO SECURE THE LIGHT ASSEMBLY IN PLACE. THE PLASTIC CLIPS ON THE SIDE OF THE LIGHT ASSEMBLY THAT ATTACHES TO THE SMALL METAL CLIP AND SCREW BREAKS OFF ALLOWING THE LIGHT ASSEMBLY TO FALL OUT OF THE TRUCK BED AND HANG BY THE REAR LIGHT WIRING HARNESS. WHILE DRIVING THE TRUCK IT STRIKES A POTHOLE OR ROUGH PLACE IN THE ROAD THE PLASTIC CLIPS BREAK AND THE TAIL LIGHT ASSEMBLY FALLS OUT OF THE TRUCK. I HAVE SEEN SEVERAL TRUCKS WITH THE REAR LIGHT ASSEMBLY TAPED UP TO SECURE THE LIGHTS. THIS IS VERY EXPENSIVE TO REPLACE THIS LIGHT ASSEMBLY. *TR

BRAKE LINES RUSTED OUT. *TR

DRIVING ON HIGHWAY AT 60MPH TRAFFIC SLOWED SUDDENLY WHILE PRESSING DOWN ON BRAKES WHEN TO FLOOR I SWERVED TO AVOID SLOWING TRAFFIC AND RAN OFF SHOULDER IN TO GRASS AND SMALL TREES TO COME TO A STOP HAD TRUCK TOWED TO MY HOUSE FOUND LINE OVER GAS TANK SPLIT OPEN THEIR WAS NO PEDAL AT ALL AND NO WARNING LIGHT FOR BRAKES UNTIL ALL THE FLUID DRIPPED OUT IN TO MY DRIVEWAY. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 15 MPH, THE BRAKE PEDAL EXTENDED TO THE FLOOR WITHOUT WARNING AND IT BECAME DIFFICULT TO STOP THE VEHICLE. THE DEALER STATED THAT THE BRAKE LINES WERE RUSTED AND LEAKING. THE FUEL LINES WERE ALSO RUSTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 36,900.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKE PEDAL WAS APPLIED AND TRAVELED ABNORMALLY TO THE FLOORBOARD. THE CONTACT MENTIONED THAT THE VEHICLE HESITATED TO STOP. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS INFORMED THAT THE FRONT AND REAR BRAKE LINES NEEDED TO BE REPLACED DUE TO CORROSION. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. WHILE DRIVING APPROXIMATELY 15 MPH, THE BRAKE PEDAL SANK TO THE FLOORBOARD WITHOUT WARNING AND THE VEHICLE FAILED TO STOP. THE DEALER STATED THAT THE BRAKE LINES WERE RUSTED AND CONTAINED LEAKS. ALSO, THE TECHNICIAN DIAGNOSED THAT THE FUEL LINES WERE RUSTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 36,900. UPDATED 3/31/15*CN UPDATED 9/7/2017*CN

VEHICLE LOST BRAKES DUE TO CORRODED STEEL BRAKE LINES. *TR

BRAKE LINES HAVE RUSTED OUT. ABS WARNING LIGHT CAME ON, THEN SOON AFTER ABS SERVICE LIGHT CAME ON. HAD TO REPLACE ALL OF THE LINES AND 3 CALIPERS WHERE LINES HAD RUSTED TO THE CALIPER. VEHICLE ONLY HAS 41200 MILES ON IT. COST ME $861 TO HAVE THEM REPLACED. SERVICE TECHNICIAN SAID HE HAD NEVER SEEN LINES THAT WERE THAT BAD FOR A VEHICLE WITH SUCH LOW MILEAGE. ONE OF THE LINES CRUMBLED AT THE TOUCH WHEN IT WAS REMOVED. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 70 MPH, THE REAR END OF THE VEHICLE SUDDENLY BEGAN TO SHAKE VIOLENTLY MAKING THE VEHICLE VERY DIFFICULT TO CONTROL. THE CONTACT WAS ABLE TO SAFELY STOP THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE GEARS IN THE REAR DRIVE TRAIN FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 135,000.

AT APPROXIMATELY 2:30 AM, NOVEMBER 10TH, MY HUSBAND HAD JUST GOTTEN BACK FROM THE STORE, AND HAD TURNED THE TRUCK OFF. THE KEYS WERE NOT IN THE IGNITION AT THE TIME. HE WAS SITTING IN THE TRUCK FOR ABOUT 10 MINUTES, WHEN HE NOTICED SMOKE COMING FROM THE DASHBOARD. HE OPENED THE HOOD, NOTICED FLAMES, AND TRIED TO PUT IT OUT WITH A FIRE EXTINGUISHER. WE CALLED THE FIRE DEPARTMENT, BUT BY THE TIME THEY GOT TO THE HOUSE, THE ENTIRE CAB OF THE TRUCK WAS ENGULFED IN FLAMES. THE HEAT WAS SO INTENSE IT MELTED THE SIDING OFF MY HOUSE. THE TRUCK WAS USED FOR HIS BUSINESS, AND HE HAD TWO CHAINSAWS IN THE BACK THAT WERE DESTROYED. THERE IS ABSOLUTELY NOTHING LEFT. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND AS THE BRAKE AND ABS WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS DRIVEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKE LINES FAILED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 91,000.

FIRST OFF THERE'S VERY LITTLE SNOW HERE SO THE BODY AND FRAME ISN'T RUSTING OUT BECAUSE OF THAT BUT ITS DEFINITELY RUSTING VERY BAD THE BRAKE LINES HAVE RUSTED COMPLETELY IN HALF THE TRANSMISSION HAS WENT OUT TWICE THE OIL GAUGE DON'T WORK THERE HAVE BEEN TIMES THE MOTOR KNOCKED BUT THEN SMOOTHED OUT AGAIN I'VE BEEN A CHEVY FAN MY ENTIRE LIFE BUT THE COMPANY ISN'T UP TO STANDARD'S OF THE CONSUMERS IN MY BOOK IF YOUR ASKING 35000 FOR A [XXX] TRUCK IT SHOULD LAST A LONG TIME WITH NO ISSUES. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE RIGHT AND LEFT WHEEL HUB ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 45,000. THE VIN WAS UNAVAILABLE.

BROKEN/LOOSE BOLTS ON EXHAUST MANIFOLD CAUSING TAPPING AND EXHAUST AND EMISSIONS LEAK. *TR

MY VEHICLE IS 9 YEARS OLD WITH 80,000 WHICH MEANS IT HAS NOT EVEN HAD A TUNE-UP YET. EVERYTHING UNDERNEATH IS RUSTED THROUGH, BRAKE LINES ARE BUSTING AND IT LOOKS LIKE THE FUEL LINES ARE NEXT. I WOULD EXPECT THIS IN NORTH DAKOTA BUT THE TRUCK HAS BEEN IN KENTUCKY IT'S ENTIRE LIFE. STEEL LINES WITH LITTLE PROTECTION I WOULD WILLINGLY PAY A LITTLE MORE FOR STAINLESS STEEL SHAME ON YOU CHEVY. *TR

MY TRUCK AT SPEEDS AROUND 35MPH WHILE LETTING OFF THE ACCELERATOR IT WOULD JUMP OUT OF GEAR. SO THEN, IN 2012, I HAD THE TRANSFER CASE ACTUATOR MOTOR REPLACED AND IT FIXED THE PROBLEM. THEN JUST YESTERDAY (OCT. 31, 2014) I HAD CRUISE CONTROL SET AT 70MPH AND WHEN IT WOULD COAST OR TRY TO SLOW ITSELF DOWN TO MAINTAIN ITS SPEED, I WOULD HERE A CLUNKING NOISE AND IT WOULD JERK. WHEN I LET OFF THE CRUISE CONTROL AND WOULD LET IT ROLL TO A STOP IT WOULD POP OUT OF GEAR! I MADE IT BACK TO TOWN AND EVEN AT SLOWER SPEEDS IT WOULD JUMP OUT OF GEAR TO THE POINT WHERE I HAD TO PUT IT IN 4WD HIGH TO BE ABLE TO MOVE. I SPOKE WITH A MECHANIC AT THE LOCAL DEALERSHIP AND HE SAID THEY HAVE A LOT OF PROBLEMS WITH THEM LIKE MINE WHICH IS WHY I THINK THERE NEEDS TO BE SOME ATTENTION BROUGHT TO THEM. *TR

MY SON WAS DRIVING MY TRUCK AND AS HE TRIED TO STOP TO TURN INTO A DRIVE, THE TRUCK WOULD NOT STOP. LUCKILY HE DRIFTED TO A STOP AND CALLED MY HUSBAND IMMEDIATELY. WE TOWED THE TRUCK TO AN AUTO REPAIR STATION IN TOWN WHERE THEY FOUND THAT THE BRAKE LINES HAD RUSTED THROUGH. THEY REPLACED THE BRAKE LINES WHICH ENDED UP COSTING US $767.80. AFTER SPEAKING TO A FRIEND ABOUT THIS, HE SHOWED MY HUSBAND AN ARTICLE ABOUT HOW GM PICKUPS HAVE BEEN HAVING ISSUES WITH RUSTED BRAKE LINES AND THAT THEY SHOULD BE RECALLING THESE VEHICLES. *TR

AS I WAS PROCEDIN TOWARDS A YIELD SIGN, MY BRAKES SEEMED TO HAVE GIVEN OUT. THE VEHICLE WOULD STOP BUT SLOWLY AND NEARLY CAUSED ME TO GET SIDESWIPED BY AN ONCOMING VEHICLE. UPON RETURNING HOME I SAW A MASSIVE POL OF BRAKE FLUID UNDERNEATH THE VEHICLE. HAVING ANOTHER PERSON HIT THE BRAKES I SAW THAT THE FLUID WAS ESCAPING FROM THE METAL BRAKE LINE RUNNING UNDERNEATH THE COOLING FANS. THE LINE WAS SEVERELY CORRODED BY RUST. *TR

FIRST THE RADIO DOES TURN OFF SOMETIME WHEN OPENING THE DOOR . THEN I HAVE TO REPLACE THE HEATER FAN RESISTER EVERY THREE TO FOUR MONTHS BECAUSE IT BURNS OUT WHILE I DRIVE I CAN,T USE DEFROSTER OR ANY TEMP. OPTIONC. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE DRIVER SIDE AIR BAG WARNING LIGHT ILLUMINATED. THE CONTACT MENTIONED THAT THE FAILURE WAS PREVIOUSLY REPAIRED IN 2007 BUT THE REPAIRS WERE UNKNOWN. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 6,000. UPDATED 02/04/15*LJ UPDATED 10/6/2015*JS

BRAKE LINE RUSTED THROUGH. GM KNOWS THIS IS A PROBLEM WITH THESE TRUCKS, BUT WON'T RECALL. *TR

I WAS COMING HOME FROM MY DAUGHTERS SOCCER GAME WITH HER AND MY EX-WIFE AS PASSENGERS.WE WERE APPROXIMATELY 50 MILES FROM HOME TRAVELING ON THE INTERSTATE WHEN I APPLIED MY BRAKES AND PEDDLE WENT SLOWLY TO THE FLOOR. I MANAGED TO GET SLOWED DOWN AND BY QUICKLY PUMPING MY BRAKES I COULD GET ENOUGH PRESSURE TO STOP THE TRUCK. I PHONED A FRIEND AND HE BROUGHT A TRAILER AND WE HAULED IT HOME. I DO A LOT OF MY MECHANIC WORK BECAUSE OF GARAGE COST. I REPLACED THE ONE LINE, HAD ANOTHER ONE RUST OUT SO REPLACED ALL 4 OF THEM. THEN JUST THIS PAST WEEK I WAS GOING DOWN MY STEEP DRIVEWAY APPROXIMATELY 1/8 MILE LONG AND BRAKE LINE UNDER RADIATOR BROKE AND HAD TO USE EMERGENCY BRAKE TO GET STOPPED. I KEEP MY TRUCK CLEAN UNDERNEATH AND ON TOP AND THE FRAME IS RUSTING SO BAD IT'S SHAMEFUL!! THE BUMPERS AND CAB CORNERS ARE RUSTING TOO. *TR

AFTER DRIVING 30 MILES ON INTERSTATE 95, I PARKED IN MY DRIVEWAY. WHEN I ATTEMPTED TO MOVE THE TRUCK, I STEPPED ON BRAKES AS USUAL EXCEPT THE PEDAL WENT TO THE FLOOR. I LOST MY BRAKES BECAUSE THE BRAKE LINE UNDER THE DRIVER POSITION RUPTURED. WHEN I TALKED TO THE SERVICE DEPARTMENT, I TOLD THEM I LOST THE BRAKES IN MY TRUCK. THE RESPONSE WAS "IT IS A KNOWN PROBLEM WITH SILVERADO TRUCKS AND SUBURBANS". THEY SAID "BRING IT IN AND WE'LL CHECK IT OUT". I TOLD THEM IF IT IS A KNOWN PROBLEM, THERE SHOULD BE A RECALL ON IT! I CAN'T BELIEVE THE COMPANY DOES NOT PUT A RECALL OUT FOR THIS. THAT TRUCK WEIGHS ABOUT 7000 POUNDS, I DO MOSTLY HIGHWAY DRIVING AT SPEEDS UP TO 75 MPH (IF YOU DRIVE 65MPH ON I-95 YOU'LL EITHER BE TAILGATED OR PUSHED OUT OF THE WAY), AND IT IS TERRIFYING TO KNOW THAT YOU CAN LOSE YOUR BRAKES LIKE THAT WITHOUT ANY WARNING. MOST OF THESE VEHICLES HAUL HEAVY LOADS OR PULL TRAILERS OR BOTH. *TR

AFTER DRIVING 30 MILES ON INTERSTATE 95, I PARKED IN MY DRIVEWAY. WHEN I ATTEMPTED TO MOVE THE TRUCK, I STEPPED ON BRAKES AS USUAL EXCEPT THE PEDAL WENT TO THE FLOOR. I LOST MY BRAKES BECAUSE THE BRAKE LINE UNDER THE DRIVER POSITION RUPTURED. WHEN I TALKED TO THE SERVICE DEPARTMENT, I TOLD THEM I LOST THE BRAKES IN MY TRUCK. THE RESPONSE WAS "IT IS A KNOWN PROBLEM WITH SILVERADO TRUCKS AND SUBURBANS". THEY SAID "BRING IT IN AND WE'LL CHECK IT OUT". I TOLD THEM IF IT IS A KNOWN PROBLEM, THERE SHOULD BE A RECALL ON IT! I CAN'T BELIEVE THE COMPANY DOES NOT PUT A RECALL OUT FOR THIS. THAT TRUCK WEIGHS ABOUT 7000 POUNDS, I DO MOSTLY HIGHWAY DRIVING AT SPEEDS UP TO 75 MPH (IF YOU DRIVE 65MPH ON I-95 YOU'LL EITHER BE TAILGATED OR PUSHED OUT OF THE WAY), AND IT IS TERRIFYING TO KNOW THAT YOU CAN LOSE YOUR BRAKES LIKE THAT WITHOUT ANY WARNING. MOST OF THESE VEHICLES HAUL HEAVY LOADS OR PULL TRAILERS OR BOTH. *TR

BRAKE LINES BLEW FRONT AND REAR WHEN A MOTORCYCLE IN FRONT OF ME SLAMMED HIS BRAKES IN AN EMERGENCY STOP. LUCKILY HE WAS TOWARDS THE SIDE OF THE ROAD, I SLAMMED MY BRAKES AND MY PEDAL WENT TO THE FLOOR, I QUICKLY SWERVED AND DOWNSHIFTED AND EBRAKED AND MIRACULOUSLY WAS ABLE TO COME TO A SWERVING STOP AVOIDING COLLISION BUT IT COULD HAVE BEEN MUCH WORSE IF I HADN'T BEEN ABLE TO REACT SO QUICKLY. MY TRUCK IS VERY LOW MILEAGE AND METICULOUSLY MAINTAINED, I HAVE OWNED IT SINCE 2009. THERE AREN'T ANY OTHER CARS OUT THERE THAT WOULD HAVE A BRAKE LINE FAILURE WITHIN 8 YEARS AND ONLY 64K MILES, I'M VERY UPSET OVER WHAT HAPPENED. *TR

AC/HEATER FAN BLOWER MOTOR STOPPED WORKING. WINTER STARTED TRUCK TO DEFROST WINDSHIELD BLOWER WOULD NOT WORK TOOK TO DEALER REPLACED BY DEALER UNDER VEHICLE WARRANTY. SEPTEMBER 24, 2014 (MILES 94000)STOPPED WORKING AGAIN REPLACED BY DEALER AT NO COST. I RECEIVED A RECALL LETTER FROM CHEVROLET STATING I HAD 10 YEARS FROM DATE OF PURCHASE OR 150000 MILES TO BE ABLE TO BE REPAIRED AT NO COST. NOT SURE WHY IT IS NOT LISTED HERE ON THIS WEBSITE. *TR

2006 DURAMAX LBZ. FROM NEW TRUCK INTERMITTENTLY HAS CODE P003A - TURBOCHARGER BOOST CONTROL POSITION NOT LEARNED, P0087 LOW FUEL PRESSURE AND CHANGE FUEL FILTER DISPLAY ON DASH. TRUCK IS TOTALLY STOCK. FIRST COUPLE OF TIMES WHEN AT DEALER THEY WOULD DO DIAGNOSTICS AND CHANGE FUEL FILTER SAYING THAT WAS IT AND THEY WOULD RESET ALL CODES. NO DRIVABILITY ISSUES WHEN THIS HAPPENED. RECENTLY (AUGUST 5, 2014) WHILE TRAVELING PULLING A TRAILER TRUCK WENT INTO DERATE/LIMP MODE (FIRST TIME) ALL CODES RETURNED. TOOK TO DEALER, CHANGED FUEL FILTER AND RESET CODES NOW IT IS HAPPENING ABOUT WEEKLY OCTOBER 1, 2014 TOOK TO DEALER RESET CODES DID NOT CHANGE FILTER AS IT WAS JUST DONE AND THEY DID NOT FIND ANYTHING WRONG WITH FUEL. (MILES 94000) DEALERSHIP SAID EVERYTHING CHECKS NORMAL AND CHEVROLET DOES NOT SHOW AND BULLETINS FOR THIS ISSUE. *TR

BRAKES LINES RUSTY PRESSED BRAKE PEDAL BRAKES FAILED. *TR

DRIVING ON THE ROAD AT APPROX. 35 MPH AND HAD TO MAKE A ABRUPT STOP. AFTER MAKING THE ABRUPT STOP, I PROCEEDED DOWN THE ROAD. THE NEXT TIME I PUSHED THE BRAKES THE PEDAL FELT SOFT. AFTER PULLING TO THE SIDE OF THE ROAD AND CHECKING THE VEHICLE THERE WAS A LARGE AMOUNT OF BRAKE FLUID COMING FROM THE REAR OF THE VEHICLE. AFTER FUTHER INSPECTION, I FOUND THAT THE REAR METAL BRAKE LINE HAD RUSTED AND BUSTED OPEN. *TR

I WAS AT OUR TOWN DUMP WHEN I HIT A SMALL POT HOLE AND WHEN I APPLIED THE BRAKES THEY WENT TO THE FLOOR. I FOUND BRAKE FLUID SPLATTERED ON THE INSIDE OF THE DRIVERS SIDE REAR WHEEL. I FOUND THAT THE BRAKE LINE GAVE AWAY RIGHT ABOVE A SMALL METAL BRACKET THAT CONNECTS THE RUBBER HOSE TO THE MAIN BRAKE LINE FROM THE ABS BOX. THE CONDITION OF THE REST OF THE BRAKE LINE REVEALS SERIOUS CORROSION, I LIVE IN CT AND DEAL WITH WINTER CONDITIONS. THE TRUCK IS A 2006 SILVERADO WITH 62000 MILES. I WAS VERY FORTUNATE THAT THIS DID NOT HAPPEN ON THE OPEN ROAD OR WHEN WE PULL OUR HORSE TRAILER. I HAVE READ ABOUT MANY ISSUES ABOUT GM BRAKE LINE ISSUES AND FEEL THAT A RECALL WOULD BE PRUDENT. *TR

I WAS DRIVING DOWN MY DRIVEWAY AND ATTEMPTED TO STOP BEFORE PULLING OUT ONTO MY STREET AND THE PEDDLE WENT TO THE FLOOR AND TRUCK DIDN'T STOP UNTIL I WAS IN THE MIDDLE OF THE ROAD. THANKFULLY THERE WASN'T ANY TRAFFIC AT THE TIME. PRIOR TO THIS INCIDENT THERE WASN'T ANY SIGNS OF POSSIBLE BRAKE ISSUES. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE ATTEMPTING TO COME TO A COMPLETE STOP, THE BRAKES FAILED TO STOP THE VEHICLE AND THE EMERGENCY BRAKE HAD TO BE ENGAGED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT ALL OF THE BRAKE LINES AND FUEL LINES NEEDED TO BE REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 21,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. WHILE DRIVING APPROXIMATELY 10 MPH, THE BRAKES FAILED AND THE BRAKE PEDAL TRAVELED TO THE FLOOR. THE DEALER REPLACED THE BRAKE LINES, WHICH WERE CORRODED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 97,000. UPDATED 10/22/2014*LJ THE CONSUMER STATED STEERING SHAFT RUSTED AND LOCKED UP. THE TRANSMISSION COOLING LINES RUSTED AND WERE LEAKING. UPDATED 05/19/2015 *JS

COMPLETE BRAKE FAILURE. AFTER INSPECTION BY MECHANIC IT WAS DISCOVERED THAT BRAKE LINE HAD COMPLETELY RUSTED APART IN ONE AREA. ALL OTHER BRAKE LINES WERE IN A RUSTY STATE AND MECHANIC FEELS THAT THEY ARE DUE TO LEAK ANY TIME. COMPLETE REPLACEMENT OF ALL UNDERBODY BRAKE LINES WILL HAVE TO BE DONE. CHEVROLET ISSUED A SIMILAR RECALL FOR VEHICLES UP TO 2005. PERHAPS IT IS TIME FOR THEM TO EXTEND THIS RECALL. IF I HAD NOT BEEN AN EXPERIENCED DRIVER (THIS IS THE PRIMARY VEHICLE FOR MY 17 YEAR OLD) I WOULD HAVE CRASHED. I WAS ABLE TO GEAR DOWN AND PULL INTO A GRASSY FIELD TO SLOW THE VEHICLE ENOUGH TO ENGAGE THE EMERGENCY BRAKE. *TR

BACKING UP SMALL GRADE, APPLIED BRAKES AND THE PEDAL FELT SOFT, PUMPED BRAKE SECOND TIME AND PEDAL WENT ALL THE WAY TO THE EXTENT OF ITS TRAVEL. DRIFTED TO LEVEL AREA CHECKED BRAKE FLUID WHICH WAS NEAR EMPTY. THE BRAKE LINE UNDER DRIVER SIDE FLOOR AREA ALONG FRAME RAIL HAD BURST. THE LINES ARE RUSTED AND FLAKING. HAD VEHICLE TOWED TO INDEPENDENT REPAIR SHOP AS I DID NOT FIND A RECALL ON THIS. REPAIR SHOP INDICATED THAT THIS IS A NORMAL PROBLEM FOR THIS MAKE/ MODEL VEHICLE. *TR

I WAS GETTING READY TO PULL OUT ON THE MAIN HWY. WHEN HITTING MY BRAKES TO STOP BEFORE ENTERING, THE BRAKE PEDAL WENT TO FLOOR, I,M GLAD NO ONE GOT HURT AND I PARKED THE TRUCK SAFELY. AFTER PARKING IT THERE WAS A PUDDLE OF BRAKE FLUID ON THE ROAD. ALL THE FOUR LINES WERE RUSTED AND ONE OR TWO BROKE. I'VE BOUGHT 4 NEW CHEV. THIS 2006 HAS HAD RUSTY BRAKE LINES SINCE 2008 OR 2009 WHEN I BOUGHT IT. THESE LINES HAVE RUSTED ON A LOT OF THESE 2006 CHEV. TRUCKS I'VE HEARD. I THINK GM SHOULD DO SOMETHING ABOUT THEM, BEFORE WE HAVE ANOTHER COBALT TRAGIC. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500 THAT WAS EQUIPPED WITH BF GOODRICH COMMERCIAL T/A TIRES, SIZE LT265/75R16. THE CONTACT STATED THAT THREE OF THE FOUR TIRES EXPERIENCED TREAD SEPARATION WITHIN THE PAST SIX MONTHS. EACH TIRE NEEDED TO BE REPLACED, EXCEPT FOR THE FRONT PASSENGER SIDE TIRE. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE TIRE FAILURE MILEAGE WAS APPROXIMATELY 20,000. THE VEHICLE FAILURE MILEAGE WAS 180,000.

WAS DRIVING DOWN THE ROAD, AND STOPPED AT A TRAFFIC LIGHT. LEFT FROM THE TRAFFIC LIGHT ,AND THE ENGINE JUST STALLED, LIKE IT WAS OUT OF GAS. THE GAS GAUGE SHOWED THAT I HAD A 1\4 TANK OF GAS. SO I HAD IT TOWED HOME ANYWAY. THE NEXT DAY I WENT OUT TO START IT WITH NO LUCK. THEN I PUT 2 GALLONS OF GAS IN THE TANK, AND THE TRUCK STARTED RIGHT UP. NOW I KNOW THAT THE GAUGE IS 1\4 OF A TANK OFF. SOME AUTO TECHS HAVE TOLD ME THAT WHAT THEY CALL A FUEL CARD THAT IS LOCATED ON THE FUEL PUMP ASSEMBLY IS BAD. JUST WONDERING IF THIS IS TRUE, BECAUSE IT IS A LOT CHEAPER THAN A FUEL PUMP ASSEMBLY. THANK YOU. *TR

APPLIED PRESSURE TO THE BRAKES AND THEY WENT TO THE FLOOR WITH JUST A LITTLE CATCH. I WAS ONLY DOING ABOUT 25 MPH AND JUST SO HAPPENED I WAS ALMOST AT MY GARAGE THAT WORKS ON IT. (100 YARDS) I WAS ABLE TO TURN IN AND COAST TO A STOP. THE BRAKE LINE ON THE DRIVER SIDE UNDERNEATH THE DRIVER AND BACK OF THE MASTER CYLINDER HAD RUSTED AND RUPTURED. THE MASTER CYLINDER STILL HAD FLUID IN IT WHEN WE CHECKED IT, SO THE RUPTURE HAD JUST OCCURED.I AM HAVING TO REPLACE ALL THE LINES. THE VEHICLE HAS NOT BEEN USED BY ME IN WATER SITUATION EXCEPT FOR NORMAL DRIVING IN WET WEATHER. WHEN WE TRIED TO PUMP THE BRAKES UP, THE FLUID JUST POURED OUT ON THE GROUND. THAT WAS WHEN WE DETERMINED THE LINE WAS RUSTED AND HAD BURST WHEN I APPLIED THE BRAKES LUCKILY I WAS GOING SLOW AND DID NOT HAVE TO STOP COMPLETELY OR I WOULD HAVE HIT ANYTHING IN FRONT OF ME. I AM HAVING THE STEEL LINES REPLACED WITH STAINLESS ON THE RECOMMENDATION OF MY SERVICE CENTER. (APPROX COST $1000.00) THIS INCIDENT WAS MY FIRST AND ONLY INDICATION THERE WAS A BRAKE PROBLEM. I CONSIDER MYSELF VERY LUCKY THAT I WAS NOT IN AN ACCIDENT AND WAS NOT TOWING MY TRAILER AND TRACTOR. USING JUST PLAIN STEEL BRAKE LINES IN JUST INEXCUSABLE AND IRRESPONSIBLE. *TR

COMPLETE LOSS OF BRAKES WHILE ATTENDING A REENACTING CEREMONY AT THE ECKLEY MINERS VILLAGE AND DELIVERING SUPPLIES - ALL BRAKE LINES WERE COMPLETELY RUSTED OUT. *TR

THE AIR BAG LIGHT HAS BEEN CONSTANTLY ON AND AND I DO NOT KNOW IF THE DRIVERS SIDE AIR BAG WILL DEPLOY IN A CRASH. *TR

WHEN USING A/C DRIVERS SIDE OF CAB WILL BLOW HEAT WHILE PASSENGER SIDE BLOWS COLD. THIS IS A CONTINUOUS PROBLEM THAT STARTED WHILE STILL IN WARRANTY. *TR

AFTER READING AN ARTICLE ABOUT A PARAPLEGIC WOMAN WHO GOT SEVERELY BURNED BY HER FRIENDS SUBURBAN'S HEATED SEATS, I FIND IT ESSENTIAL TO REPORT THAT I'VE ALWAYS FOUND THAT MY DRIVERS HEATED SEAT SOMETIMES GET EXTREMELY HOT. FORTUNATELY, I HAVE BEEN ABLE TO TURN THEM OFF BEFORE ANY INJURIES. THE WOMAN REPORTED NOT KNOWING HOW HER HEATED SEAT GOT TURNED ON. IF HER FRIENDS VEHICLE IS LIKE MINE, AN MANY OTHERS WHO HAVE COMPLAINED ON MULTIPLE OPEN FORUM WEBSITES, THE HEATED SEATS IN MANY OF CHEVROLET'S TRUCKS AND SUVS ARE KNOWN TO TURN ON THEIR OWN. I HAVE HAD TO UNPLUG MY SEATS DUE TO THE HEATER TURNING ON ERRATICALLY AND CYCLING THROUGH THE 3 HEAT LEVELS ON THEIR OWN. IT HAS BEEN REPORTED ON MULTIPLE WEBSITES THAT PEOPLE HAVE COMPLAINED TO GM ABOUT THIS ISSUE AND PEOPLE WHOSE VEHICLE WERE NOT COVERED UNDER WARRANTY HAVE BEEN FORCED TO PURCHASE A VERY EXPENSIVE DOOR SWITCH ASSEMBLY. ALTHOUGH NOT A SAFETY ISSUE TO ME, I CAN SEE HOW THIS ERRATIC BEHAVIOR OF THE HEATED SEATS AND THE POTENTIAL FOR EXTREMELY HIGH TEMPERATURES COULD BE A DANGER TO SOMEBODY WITHOUT ALL THE SENSATIONS IN THEIR LOWER HALF. I HOPE THAT THIS REPORT WILL HELP WITH ANY STATISTICAL ANALYSIS OF HEATED SEAT PROBLEMS THE NHTSA ACCOMPLISHES. AND I HOPE THE ISSUE IS RESOLVED BY GM. *TR

BRAKE LINES FAILED, CAUSING ME TO RUN OFF THE ROAD WHEN TRYING TO AVOID HITTING A DEER. HAD TO REPLACE ALL THE LINES DUE TO CORROSION ON MANY OF THEM. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. THE VEHICLE IS EQUIPPED WITH FEDERAL COURAGIA A/T TIRES, SIZE 33512.50R/20LT (NA). THE CONTACT STATED THAT THE SIDEWALLS OF THE TIRES CONTAINED BUBBLES. THE TIRES WERE NOT REPLACED AND THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNAVAILABLE. THE TIRE FAILURE MILEAGE WAS 103,000 AND THE VEHICLE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

IN THE PROCESS OF EXITING FROM OUR HOME, WHILE TOWING A LARGE BOAT, A BRAKE LINE RUPTURED RELEASING THE BRAKE FLUID AND CAUSING A COMPLETE FAILURE OF THE BRAKE SYSTEM. I INSPECTED THE RUPTURED AREA AND FOUND THAT ALL THE BRAKE LINES WERE SEVERELY RUSTED AND READY TO FAIL AT ANY TIME IN THE NEAR FUTURE. THE VEHICLE WAS TOWED TO A REPAIR FACILITY TO HAVE THE BRAKE LINES REPLACED. ESTIMATED COST IS $950. HAD THIS FAILURE HAPPENED ONE MINUTE LATER THE RESULTS COULD HAVE BEEN CATASTROPHIC! *TR

AFTER PICKING UP MY 5YR OLD GRANDSON, WE CAME TO A STOP SIGN AT A VERY BUSY INTERSECTION WHERE THE CROSS TRAFFIC IS GOING ABOUT 50-60MPH. WHEN I APPLIED THE BRAKES THE PEDAL WENT TO THE FLOORBOARD. I MANAGED TO DEPRESS THE EMERGENCY BRAKE JUST IN TIME TO KEEP FROM BEING HIT BY A SEMI TRUCK GOING VERY FAST. THERE WERE NO WARNING LIGHTS OR INDICATION THAT THERE WAS A PROBLEM WITH THE BRAKES. THE DEALER SAID THE BRAKE LINES HAD RUSTED OUT AND WOULD NEED REPLACEMENT. I CONTACTED GM CUSTOMER SERVICE AND FINALLY GOT TO A COST ASSISTANCE REPRESENTATIVE WHO INFORMED ME THAT GM WOULD NOT HELP DUE TO THE AGE AND MILEAGE OF THE VEHICLE. REALLY, THE TRUCK IS 8 YEARS OLD AND OTHERWISE IN VERY GOOD CONDITION. ALSO I DON'T UNDERSTAND HOW MILEAGE AFFECTS A NON-MOVING PART.I BELIEVE THE BRAKE LINES WERE MADE FROM INFERIOR METAL FOR THIS APPLICATION. TO ME, THE BRAKE LINES SHOULD BE CONSIDERED A SAFETY ITEM SIMILAR TO THE AIR BAGS. IF BRAKE LINES ARE NOW EXPECTED TO FAIL IN VEHICLES 8 YEARS OR OLDER I EXPECT THERE WILL BE A LOT OF INJURED OR DEAD PEOPLE DUE TO THIS. AFTER CHECKING THE INTERNET FOR THE SAME PROBLEM, I COUNTED OVER 300 PEOPLE WHO EXPERIENCED THE SAME ISSUE ON THIS VEHICLE. I BELIEVE GM SHOULD ACCEPT RESPONSIBILITY AND CORRECT THIS ISSUE AND REIMBURSE THOSE WHO HAVE ALREADY HAD THE LINES REPLACED. *TR

COMPLETE BRAKE FAILURE WHEN BRAKES APPLIED IN BRAKE SYSTEM. PEDAL WENT TO THE FLOORBOARD WITHOUT ANY WARNING OR BRAKING ACTION. REAR BRAKE LINE RUSTED THRU ABOVE GAS TANK AND EXPELLED ALL BRAKE FLUID WHEN PEDAL WAS DEPRESSED. THERE WAS NO BRAKING OR SLOWING FROM ANY WHEEL. FLUID WAS ALL OVER TIRE AND AXLE ON THE LEFT REAR. LUCKY THAT I DID NOT HAVE ANY VEHICLES DIRECTLY IN FRONT OF ME AS I HAD TO COAST TO A STOP. DEFINITELY READING THE OTHER POSTS ON THE WEB THAT THIS IS NO FLUKE AND DOES NOT NEED TO BE A HIGH MILEAGE VEHICLE. TRUCK IS NOT USED FOR SNOW REMOVAL AND SEES LIMITED DRIVING DURING WINTER MONTHS.

I HAVE FOUND THAT THE STEEL LINES RUNNING ALONG THE FRAME RAILS ARE RUSTING AND FOUND A PATCH IN ONE PLACE AND THE POSSIBILITY OF MORE LEAKS HAPPENING. *TR

WHILE LOOKING OVER MY TRUCK PRIOR TO INSPECTION I DISCOVERED THREE CROSS MEMBERS TOTALLY RUSTED THRU. THE ARE ALSO THE MAIN SUPPORTS FOR THE GAS TANK AND THE SHOCKS. I HAVE BEEN TRYING TO FIND REPLACEMENT PARTS AND THE MORE I LOOK THE MORE I HEAR HOW COMMON THE RUSTED CROSS MEMBERS ARE. I WENT TO THE LOCAL DEALERS PARTS DEPT. AND WHEN I ASKED FOR CROSS MEMBERS HE TOLD ME WHICH ONES I NEEDED AND POINTED THEM OUT ON AN ILLUSTRATED BRAKE DOWN. AFTER THE TRUCK BED WAS REMOVED I NOTICED THE EMERGENCY BRAKE CABLE IS RUBBING AGAINST THE PLASTIC GAS TANK AND IS JUST ABOUT WORE THRU THE TANK TO ABOUT THE THICKNESS OF A PLASTIC SANDWICH BAG. THE CABLE HAS ALSO RUBBED AGAINST IT'S SUPPORT BRACKET ALMOST ALL THE WAY THRU AS WELL AS INTO THE CABLE. *TR

DRIVING AT ABOUT 35MPH WHEN THE CAR AHEAD PUT ON BRAKES MY PEDAL WENT STRAIGHT TO THE FLOOR AND I ENDED UP USING THE EMERGENCY BRAKE TO STOP. I HAD THE TRUCK TAKEN TO THE DEALERSHIP WHO TOLD ME THE BRAKE LINES WERE COMPLETELY RUSTED OUT. I CALLED CHEVROLET'S SERVICE NUMBER AND WAS TOLD THIS WAS NOT A PROBLEM WITH MY YEAR. BUT IT HAD BEEN IN THE PAST SO NO HELP AVAILABLE. *TR

TL* THE CONTACT OWNS 2006 CHEVROLET SILVERADO. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 2 MPH IN REVERSE THE VEHICLE FAILED TO RESPOND TO DECELERATION ATTEMPTS. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE MECHANIC STATED THAT THE BRAKE LINES WERE COVERED WITH RUST. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

THE SERVICE AIRBAG LIGHT CAME ON. CALLED DEALER TOLD ME WARRANTY WAS OVER. I THOUGHT IT IS A NATIONAL WARRANTY ON AIRBAGS BECAUSE OF THE BEING A SAFETY HAZARD FOR THEM TO WORK PROPERLY. UPDATED 4/24/2015 *JS

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE PIVOT ARM FAILED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 63,000. UPDATED 8/28/14*CN

BRAKES SEEMED SOFT WHILE DRIVING ON MOUNTAIN ROADS YESTERDAY. THIS MORNING PUDDLE UNDER THE DRIVER SIDE DOOR AND BRAKES WENT TO THE FLOOR. NO BRAKE WARNING LIGHTS CAME ON. HOUR LATER WHEN TOW TRUCK CAME, MOVED TRUCK FOR TOWING AND BRAKE WARNING LIGHT CAME ON. IT DID NOT WANT TO STOP WITH BRAKES - ROLLED TO STOP. HAD IT TOWED TO DEALER WHO IS CHECKING FOR THE REASON FOR THE LEAK. NOT REPAIRED YET - WAITING FOR DEALER TO GET BACK TO ME. *TR

ANOTHER VEHICLE RAN A RED LIGHT IN FRONT OF ME AND I HAD TO APPLY BRAKES QUICKLY. THE BRAKE LINE RUPTURED , I SWERVED, AND BARELY MISSED THE OTHER CAR. THEY WOULD HAVE BEEN KILLED IF I WAS NOT ABLE TO MOVE INTO THE OPPOSITE LANE. LATTER FOUND THAT THE RUPTURE WAS CAUSED BY EXCESSIVE RUST. HAD THAT SECTION REPLACED BUT ITS TOO EXPENSIVE TO REPLACE ALL THE LINES - WAITING FOR ANOTHER FAILURE. *TR

7-12-14, 11:15 MTN TIME MY WIFE AND I WERE DRIVING WESTBOUND ON I-76, IN A 2006 CHEVY SILVERADO, 2500 HD DURAMAX DIESEL TOWING A 24" CATALINA 5TH WHEEL, APPROXIMATELY 6,500 LBS, IN THE RIGHT HAND LANE, AT APPROXIMATELY 50 MPH IN COMMERCE CITY, CO APPROACHING 104TH AVE. AT THE 104TH AVE OVERPASS A DRUNK DRIVER PULLED OUT FROM BEHIND THE OVERPASS SUPPORT COLUMN IN THE CENTER MEDIUM AREA OF THE DIVIDED HIGHWAY APPROXIMATELY 1-2 CAR LENGTHS IN FRONT OF US. WE IMMEDIATELY HIT HIS VEHICLE IN THE RIGHT REAR. AT THE TIME HE WAS MOVING FORWARD 2-5 MPH. THE COLLISION WAS CATASTROPHIC WITH VERY SIGNIFICANT DAMAGE TO ALL VEHICLES. THE FRONT AIRBAGS OF THE 2006 CHEVY SILVERADO DID NOT DEPLOY. THIS VEHICLE IS A ONE OWNER VEHICLE. IN 2007 IT WAS INVOLVED IN A FRONTAL ACCIDENT IN WHICH A DRIVER TURNED IN FRONT OF THE DRIVER AT AN INTERSECTION RESULTING IN A FRONTAL COLLISION AT 35 MPH AND THE FRONTAL AIRBAGS DID NOT DEPLOY. CHEVY DID THE REPAIR AND CERTIFIED THE REPAIR OF THE VEHICLE. *TR

7-12-14, 11:15 MTN TIME MY WIFE AND I WERE DRIVING WESTBOUND ON I-76, IN A 2006 CHEVY SILVERADO, 2500 HD DURAMAX DIESEL TOWING A 24" CATALINA 5TH WHEEL, APPROXIMATELY 6,500 LBS, IN THE RIGHT HAND LANE, AT APPROXIMATELY 50 MPH IN COMMERCE CITY, CO APPROACHING 104TH AVE. AT THE 104TH AVE OVERPASS A DRUNK DRIVER PULLED OUT FROM BEHIND THE OVERPASS SUPPORT COLUMN IN THE CENTER MEDIUM AREA OF THE DIVIDED HIGHWAY APPROXIMATELY 1-2 CAR LENGTHS IN FRONT OF US. WE IMMEDIATELY HIT HIS VEHICLE IN THE RIGHT REAR. AT THE TIME HE WAS MOVING FORWARD 2-5 MPH. THE COLLISION WAS CATASTROPHIC WITH VERY SIGNIFICANT DAMAGE TO ALL VEHICLES. THE FRONT AIRBAGS OF THE 2006 CHEVY SILVERADO DID NOT DEPLOY. THIS VEHICLE IS A ONE OWNER VEHICLE. IN 2007 IT WAS INVOLVED IN A FRONTAL ACCIDENT IN WHICH A DRIVER TURNED IN FRONT OF THE DRIVER AT AN INTERSECTION RESULTING IN A FRONTAL COLLISION AT 35 MPH AND THE FRONTAL AIRBAGS DID NOT DEPLOY. CHEVY DID THE REPAIR AND CERTIFIED THE REPAIR OF THE VEHICLE. *TR

MY WIFE WHILE DRIVING THE ABOVE TRUCK STATED THAT THE BRAKE PEDDLE "FELT FUNNY" AND CONTINUED TO DRIVE IT. SHE STATED THAT SHE HAD ALMOST COMPLETELY LOST THE ABILITY TO STOP. WHEN I WAS ABLE TO INSPECT THE TRUCK I FOUND A RUPTURED BRAKE LINE THAT LEAD TO THE REAR BRAKES. ALSO ALL THE BRAKE FLUID HAD LEAKED OUT OF THE RUPTURED LINE. I HAVE SINCE HAVE HAD ALL THE BRAKE LINES REPLACED WITH STAINLESS STEEL LINES. I AM LEARNING THAT THIS IS AN ON GOING ISSUE WITH THIS MODEL OF TRUCK AND MY CONCERN SHOULD BE OBVIOUS. MY WIFE COULD HAVE SERIOUSLY INJURED HERSELF OR OTHERS. *TR

BRAKES FAILED, PEDAL WENT TO THE FLOOR WHEN I WAS PULLING INTO MY DRIVEWAY. CHECKED UNDER TRUCK AND THE BRAKE LINES ARE RUSTED AND 1 OR 2 WERE LEAKING BRAKE FLUID. COULD STOP ONLY BY USING EMERGENCY BRAKE. IF I WAS DRIVING ON THE ROAD I WOULD HAVE HAD AN ACCIDENT. BRAKE LINES SHOULD NOT RUST OUT IN 8 YEARS. THESE TRUCKS NEED TO BE RECALLED. IT IS GOING TO COAST CLOSE TO $1000 IF I REPLACED ALL THE LINES. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND. THE CONTACT DEPRESSED THE BRAKE HARDER AS A RESULT, THE BRAKE LINES FRACTURED AND THE BRAKE FLUID WAS LEAKING. THE CONTACT DISCOVERED THAT THERE WAS RUST UNDER THE VEHICLE WHERE THE BRAKE LINES WERE LOCATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 64,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT AFTER REVERSING OUT OF THE RESIDENTIAL DRIVEWAY, THE FRONT AND REAR BRAKES FAILED. THE BRAKE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT MENTIONED THAT THE VEHICLE CAME TO COMPLETE STOP AFTER THE EMERGENCY BRAKE WAS ENGAGED. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT BRAKE FLUID WAS LEAKING FROM THE BRAKE LINES. THE CONTACT ADDED MORE BRAKE FLUID INTO THE VEHICLE BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS CONTACTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE BRAKE LINES WERE FAULTY DUE TO THE SALT DAMAGE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 74,000 AND THE CURRENT MILEAGE WAS 78,000. UPDATED 9/12/14*CN UPDATED 2/12/2015 *JS

I WAS MOVING MY TRAVEL TRAILER IN MY DRIVEWAY, IN PREPARATION FOR A VACATION TRIP. WHEN I STEPPED ON THE BRAKE, A RUSTED BRAKE LINE FAILED AND THE BRAKE PEDAL WENT TO THE FLOOR. I WAS ABLE TO STOP THE VEHICLE SAFELY. FURTHER INSPECTION REVEALS THAT ALL THE BRAKE LINES ON THE TRUCK ARE BADLY RUSTED AND WILL HAVE TO BE REPLACED. *JS

BRAKE LINES HAD HOLES IN THEM CAUSED BY CORROSION,FUEL LINE ALSO. NOTICED PROBLEM BEFORE ANYTHING SERIOUS HAPPENED. COST OVER 1000.00 TO REPLACE BRAKE AND FUEL LINES. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 3500. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT WAS ABLE TO REMOVE THE KEY FROM THE IGNITION. THE VEHICLE CONTINUED TO DRIVE AS NORMAL. AFTER SHUTTING THE VEHICLE OFF, THE CONTACT REMOVED THE KEY FROM THE IGNITION WHILE THE VEHICLE WAS STILL IN THE DRIVE GEAR. THE FAILURE CAUSED THE BATTERY TO DRAIN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 175,000.

I HAD MY TRUCK FIXED AT SEAR AUTOMOTIVE IN HUNT VALLEY MARYLAND AFTER 3 WEEK AFTER I WAS PROMISED 1 WEEK.WAS TOLD IT NEEDED A NEW REAR DIFFERENTIAL AND NEW BRAKE LINES. I GOT MY TRUCK BACK I LOST BRAKES GOING DOWN THE ROAD AND MY ABS LIGHT CAME ON BROUGHT MY TRUCK BACK TO SEARS. IT WAS FIXED SO I WAS TOLD AND I LOST BRAKES AGING. AND THEN I BROUGHT IT BACK A 3RD TIME THEY FINALLY FIXED IT. BUT THEY MADE ME DRIVE MY TRUCK WITH NO BRAKES BACK TO THEM. NEXT MY REAR DIFFERENTIAL LOCKED UP ON 695 AND I SPUN OUT I BROUGHT THE TRUCK BACK TO THEM. THEY CLAIMED IT WAS OUT OF WARRANTY WHEN THE WARRANTY EXPIRED WELL THE TRUCK WAS IN THE SHOP. SO I STARTED TO DRIVE THE TRUCK HOME AND 4 WHEEL DRIVE TURNED ON AND MY FRONT 2 WHEELS STARTED DRAGGING ALONG WITH MY BACK WHICH MADE MY TRUCK COME TO A STOP IN THE MIDDLE OF YORK ROAD. WHICH AUTO NATION TOLD ME THAT MY FRONT DIFFERENTIAL IS BAD NOT THE REAR THAT'S WHY IT HAPPENED. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, HE CRASHED INTO A STOPED VEHICLE ON THE HIGHWAY AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE CONTACT AND TWO PASSENGERS IN THE SECOND VEHICLE WERE TRANSPORTED TO A HOSPITAL FOR TREATMENT OF INJURIES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 85,000.

THE AIR BAG SERVICE LIGHT AND IS LIT AS WELL AS THE SERVICE CENTER SAYING IT NEEDS SERVICE, ALSO HAS THE SAME BRAKE PROBLEMS THE 2007 AND UP SILVERADOS WHERE RECALLED FOR WITH THE FAILURE OF THE FRONT ABS SENSORS. THE ABS PROBLEM COULD CAUSE AN ACCIDENT AT LOW SPEED BECAUSE EVERYTIME YOU STOP THE ABS SYSTEM ACTIVATES AND PULSES UNTIL STOPPED AT 15 TO 20 MPH AND INCREASES STOPPING DISTANCE. THE AIR BAG LIGHT IS BECAUSE OF A SENSOR FAILURE IN THE FRONT END AREA AND REQUIRES REPLACEMENT. FROM WHAT I READ ON THE INTERNET THESE ARE WELL KNOWN SAFETY ISSUES WITH THE MODEL TRUCKS. THE OTHER PROBLEMS WITH THE PREMATURE FAILURE OF BRAKE LINES THAT HAVE CORRODED, AND THE CHECK ENGINE LIGHT BEING ON FOR THE EVER WELL KNOWN PROBLEM OF THE VACUUM SOLENOID NEAR THE FULL TANK. THESE ARE CONSTANT PROBLEMS WITH THIS YR AND OTHER MODELS AT GM. THEY SHOULD BE RECALLED. *TR

AS I WAS BACKING OUT OF MY DRIVEWAY MY BRAKE PEDAL WENT TO THE FLOOR. I STOPPED JUST IN TIME TO AVOID BEING HIT BY ON COMING TRAFFIC. TOOK IT TO A DEALER LATER THAT DAY AND WAS TOLD THAT THE BRAKE LINES WERE RUSTED THROUGH AND WOULD COST OVER $700 TO REPAIR. *TR

STARTED THE VEHICLE FASTEN SEAT BELT EXITED THE CARPORT STARTED TO LEAVE MY YARD HAD TO STOP A GO BACK IN HOUSE TURNED THE VEHICLE OFF REMOVED THE KEY WENT BACK IN THE HOUSE CAME BACK GOT IN THE VEHICLE FASTEN SEAT BELT STARTED THE VEHICLE PUT IT IN DRIVE AND THE SERVICE AIR BAG LIGHT FLASHED SEVERAL TIME WE OUT AND CAME BACK AND WILL NOT GO BACK OUT IT WILL FLASH SEVERAL TIME GO OUT AND COME BACK ON AND STAY. *TR

SAW WET SPOT UNDER DRIVER'S SIDE OF TRUCK, JUST BEHIND ENGINE COMPARTMENT. KNEW IT WASN'T GOOD AS THE AC IS ON THE OTHER SIDE. FIGURED I'D CHECK IT LATER. STARTED TRUCK AND AS SOON AS I PUT MY FOOT ON THE BRAKE PEDAL, I COULD FEEL SOMETHING WAS WRONG. STOPPED TRUCK, POPPED HOOD AND CHECKED BRAKE FLUID LEVEL IN MASTER CYLINDER. SAW IT WAS LOW. ADDED A PINT OF FLUID AND LOOKED UNDER THE TRUCK. SAW IT LEAKING FROM A RUSTED OUT BRAKE LINE NEAR THE ABS MODULE. ALL LINES ARE RUSTED AND IN NEED OF REPLACEMENT. *TR

I WAS IN FAST LANE ON HIGHWAY APPROACHING SOME CONSTRUCTION AND WAS CUT OFF BY SOMEONE WHO PASSED ME ON THE RIGHT . I STEPPED HARD ON MY BRAKES AND THE PEDAL WENT ALL THE WAY TO THE FLOOR . . I HIT THE PERSON IN FRONT OF ME AND RUINED MY FRONT BUMPER. UPON INSPECTION OF MY VEHICLE I NOTICED BRAKE FLUID DRIPPING FROM FRAME RAIL . .I LOOKED AND NOTICED A LINE RUPTURED DUE TO RUST / ROT AND ALL THE BRAKE LINES WHERE IN BAD CONDITION . I WAS ABLE TO CRUTCH THE TRUCK TO A REPAIR SHOP AND THE REPAIRED THE STEEL LINE. MECHANIC MADE ME AWARE OF THE TERRIBLE CONDITION ALL THE STEEL LINES WERE IN ( FUEL LINES, TRANSMISSION LINES,ECT) AND THAT THE BRAKE BLEEDERS ON FRONT CALIPERS WHERE ALSO ROTTED BEYOND SAVING . . I BELIEVE ALL THESE LINES SHOULD HAVE BEEN STAINLESS STEEL AS THEY ARE EXPOSED TO THE ELEMENTS AND I'M LUCKY TO HAVE NOT TOTALED THE TRUCK , INJURED SOMEONE ELSE AND OR MYSELF. *TR

BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. LATER ON, THE INFORMATION CONSOLE DISPLAYED A SERVICE BRAKE SYSTEM MESSAGE. THE BRAKE LINES ARE SO RUSTED OUT THAT THEY ARE NOW LEAKING BRAKE FLUID. *TR

DRIVERS SEAT HEATER COMES ON ALL THE TIME BY IT SELF AND ON HIGH. YOU CAN SWITCH IT OFF AND IT KEEPS COMING BACK ON. VERY DISTRACTING AT HIGH SPEEDS TURNING IT OFF ALL THE TIME. IT GETS VERY HOT AND OUT OF CONTROL. MAYBE COULD CATCH FIRE?? I HAVE IT DISCONNECTED NOW BUT DOING THAT NONE OF THE SEAT CONTROLS WORK. TO WORK SEAT YOU MUST PLUG IT BACK IN TO OPERATE THE SEATS. CHECKED ONLINE AND MANY SEAT HEAT SWITCHES COME ON BY IT SELF ON MANY GMC CARS AND TRUCKS. *TR

DRIVING HOME FROM A CAMPING TRIP PULLING 30FT 5TH WHEEL , PUSHED ON BRAKE PEDAL TO SLOW DOWN & PEDAL WENT ALMOST TO THE FLOOR , PULLED OVER & FOUND BRAKE LINE LEAKING UNDER MASTER CYLINDER ON TOP OF FRAME RAIL , REPAIRED LINE TO GET HOME , UPON INSPECTION OF BRAKE LINES, THEY ARE VERY WEAK, SINCE THEN I'VE HAD TO FIX 2 MORE BRAKE LINES, LUCKILY NOT PULLING ANYTHING ,I HAVE FRIENDS WITH THESE SAME TRUCKS & INSPECTED THERE'S & ALSO LOOK THE SAME,1 FRIEND TOOK HIS TO DEALERSHIP & THEY TOLD HIM THAT THIS IS NORMAL? I FEEL THEY DID NOT USE THE CORRECT KIND OF METAL WHEN PRODUCING THESE VEHICLES BRAKE LINES .I WORK IN THE SERVICE FIELD & HAVE NEVER SEEN BRAKE LINES ROT THE WAY THESE TRUCKS DO , THESE TRUCKS ARE BOUGHT FOR PULLING & A LOT OF THEM ON THE ROAD, SO I WAS HOPING YOU COULD LOOK INTO THIS MATTER FOR SAFETY REASONS. THANK YOU *TR

TRANSMISSION JUST WENT WHEN DRIVING HOME FROM OKLAHOMA CITY, OKLAHOMA. I HAD TO DRIVE IT IN FIRST GEAR ALL THE WAY HOME FROM SHAWNEE, OKLAHOMA TO ATOKA, OKLAHOMA. *TR

PURCHASED A SET OF 4 .FEDERAL COURAGIA MT 33/12.50/20 FROM SD WHEELCORP IN APRIL 2012. AFTER APPROX 16000 MILES 2 OF THE FOUR HAVE TREAD/BELT SEPARATION CREATING BUBBLES ON THE TIRES. THE TIRES HAVE ALWAYS BEEN ROTATED AND CORRECT PRESSURE WAS MAINTAINED. THIS IS A DEFECTIVE AND POSSIBLY DEADLY TIRE AND SHOULD BE RECALLED. *JS

"SERVICE AIR BAG" CHECK ENGINE LIGHT ON WHEN STARTING 2006 SILVERADO; GM DEALERS DIAGNOSED AIRBAG SENSOR MALFUNCTIONING REQUIRES REPLACEMENT. THIS SAFETY ISSUE HAS BEEN REPORTED IN 2009 AT EDMUNDS.COM BY OTHERS. CALLED, EMAILED AND TWITTED GM SINCE 14 MAY 2014. AFTER 13 PHONE TAGS WITH 4 GM CUSTOMER CARE SPECIALISTS AND 2 DEALER SERVICE REPS (INCLUDE MANAGER) AND 5 DAYS, A VERBAL WORD FROM GM "YOUR VEHICLE IS WAY BELONG GM'S RESPONSIBILITY"...WE ARE 'TICKED" AROUND BY GM AND THE DEALER WITH A CASE # AND DON'T SEE THIS SAFETY CONCERN IS BEING ADDRESSED BY GM. @ GM ALSO HAS ELECTRICAL HEATING/COOLING ISSUES WITH THIS VEHICLE. @PLEASE BE WARNED THAT IF YOU ARE DRIVING A GM VEHICLE, SERIOUSLY CONSIDER YOU, YOUR FAMILY AND ANYONE ELSE SAFETY ON THE ROAD! LET'S NOT PLACE OURS AND ANYONE ELSE ON THE LINE AGAIN FOR GM! #SADLY AFTER WE, THE AMERICAN PUBLIC HAVE BAILED OUT GM..... :( *JS

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE SERVICE ENGINE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO A DEALER, WHO CLEARED THE CODE FROM THE COMPUTER BUT THE FAILURE RECURRED. ADDITIONALLY, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SOLENOID EVAPORATION EM HAD BEEN MODIFIED AND THAT THE SOLENOID EVAPORATION EM, THE CANISTER EVAPORATION EMI, THE SOLENOID, THE GAS CAP, THE CANISTER PURGE, THE FUEL TANK PRESSURE SENSOR, AND THE TUBING NEEDED TO BE REPAIRED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MIELAGE WAS NOT AVAILABLE.

STEEL BRAKE LINE RUPTURED DUE TO APPARENT RUSTING. BRAKE FLUID DRAINED FROM SYSTEM AND ABILITY TO BRAKE WAS NEARLY DIMINISHED. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED WHILE TRAVELING APPROXIMATELY 5 MPH, THE BRAKES FAILED AND THE EMERGENCY BRAKE HAD TO BE APPLIED IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO A MECHANIC, WHO DIAGNOSED THAT THE BRAKE LINES WERE CORRODED AND THERE WAS A LOSS OF BRAKE FLUID. AS A RESULT, THE FRONT AND REAR BRAKE LINES WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 84,000. UPDATED 10/7/14*CN

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH, THE AUTOMATIC CLIMATE CONTROL WAS ACTIVATED AND SMOKE EMITTED INTO THE CAB. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE BLOWER MOTOR RESISTOR, RESISTOR HARNESS, AND CONNECTORS. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 86,700.

I APPLIED THE BRAKES. THE BRAKE PEDAL WENT TO THE FLOOR WITH LITTLE RESISTANCE. I GOT THE TRUCK HOME AND NOTICED BRAKE FLUID DRAINING FROM THE DRIVERS SIDE METAL BRAKE LINE JUST FORWARD OF THE REAR AXLE. *TR

I WAS DRIVING MY TRUCK AND THE BRAKE PEDAL WENT TO THE FLOOR. I WAS ABLE TO STOP THE TRUCK IN MY DRIVEWAY AFTER PUMPING THE BRAKE PEDAL. THERE WAS NO TROUBLE LIGHT OR INDICATION ON THE DASHBOARD OF ANY BRAKE PROBLEM. WHEN I GOT OUT OF THE TRUCK I SAW A PUDDLE OF FLUID UNDER THE MIDDLE OF THE TRUCK ON THE DRIVER'S SIDE. UPON FURTHER INSPECTION, THERE IS A HOLE IN THE REAR BRAKE LINE AND ALL THE BRAKE LINES ARE COMPLETELY RUSTED AND ROTTING. I WAS TOLD BY THE CHEVROLET DEALER ALL THE BRAKE LINES NEED TO BE REPLACED AT A COST OF $1000. HOW CAN THE NHTSA ALLOW MANUFACTURERS TO INSTALL BRAKE LINE MATERIALS THAT CAN FAIL WITHOUT WARNING IN 7 YEARS OR LESS? *TR

BRAKE PEDAL BECAME SPONGY WHILE DRIVING. UPON REAPPLYING THE BRAKES, PEDAL WENT STRAIGHT TO THE FLOOR AND VEHICLE CREEPED TO A STOP. UPON INSPECTION, SAW BRAKE FLUID ON GROUND AND SPEWING OUT FROM BRAKE LINES BY DRIVER'S REAR SIDE. HAD VEHICLE TOWED TO DEALERSHIP, WHERE THEY SAID THAT ALL OF THE BRAKE LINES WERE RUSTED OUT. *TR

LEFT REAR BRAKE LINE BLEW OUT AND RUSTED THROUGH. DO NOT TRUST ANY OTHER BRAKE LINE ON THIS TRUCK NOW. *TR

WHILE DRIVING ON A PUBLIC MICHIGAN ROAD I STOPPED AT A FOUR WAY ROAD AT A STOP SIGN AND WAS HIT BY ANOTHER DRIVER. *JS

OIL GAUGE READS FROM ZERO TO 80 (HIGHEST READING) WITH ALARMS BEING SOUNDED REPEATEDLY. THE GAUGE IS BOUNCING, CAUSING THE ALARM TO COME ON AND GO OFF WHILE IN TRAFFIC. WHEN ACCELERATING THE PRESSURE WILL DROP TO ZERO THEN BOUNCE. OIL LEVEL IS PERFECT. TRUCK IS WELL CARED FOR. *JS

BRAKE PEDAL WENT TO THE FLOOR WITH NO BRAKING AVAILABLE. THIS WAS JUST AFTER A 300 + MILE TRIP HAULING A HORSE TRAILER AND TWO HORSES. SERVICE INVESTIGATION REVEALED RUPTURED HYDRAULIC BRAKE LINES. ALL BRAKE LINES ARE SEVERELY CORRODED AND ALL MUST BE REPLACED. WORST PORTION IS JUST UNDER THE DRIVERS SEAT AREA WHERE THREE LINES RUN TOGETHER. CALLED DEALER AND GM, IT APPEARS TO BE A COMMON PROBLEM SINCE GM NOW OFFERS A DISCOUNTED BRAKE LINE KIT. MAY POSTS ON CHEVY FORUMS REVEAL THE EXACT PROBLEM. SOMETHING SHOULD BE DONE AS THIS APPEARS TO BE A BAD DESIGN. FORTUNATE THAT THIS DID NOT HAPPEN WHILE ON THE TURNPIKE. *JS

BRAKELINES HAVE CORRODED,ROTTED OUT. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE HEATED SEATS WOULD SPORADICALLY AND INDEPENDENTLY ACTIVATE WITHOUT WARNING. THE CONTACT STATED THAT WHEN THE FAILURE OCCURRED, THE HEATED SEAT FUNCTION COULD NOT BE DEACTIVATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE HEATED SEAT SWITCH WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 114,937.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 5 MPH, THE STEERING WHEEL SEIZED FOR A FEW SECONDS. ADDITIONALLY, THE FRONT END OF THE VEHICLE VIBRATED SEVERELY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER THREE TIMES FOR THE REPLACEMENT OF THE INTERMEDIATE DRIVE SHAFT ON THREE VISITS. THE BRAKE LINES, TRANSMISSION COOLING LINES AND INTERMEDIATE STEERING SHAFT WERE COVERED WITH RUST AND WERE REPLACED BY THE DEALER. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 32,800.

ACTIVE RECALL #12138 TRANSMISSION DIPSTICK TUBE BROKEN AT WELD IN HALF. WAS JUST TOLD BY GM DEALER AND GM OWNERS CENTER THAT MY VEHICLE WAS NOT COVERED BY RECALL, EVEN THOUGH MY VEHICLE HAS THE EXACT FAILURE UNDER THE 12138 RECALL. TRANSMISSION FLUID HAS LEAKED ONTO HOT SURFACES AND SMOKED TO A NEAR FIRE. PLEASE HELP! *TR

WHEN I BACKED OUT OF MY DRIVEWAY , WHICH IS ON AN INCLINE , THE BRAKE PEDAL WENT TO THE FLOOR AND I JUST MISSED BACKING OUT INTO A BUSY ROAD. I TOOK THE TRUCK IN FOR REPAIRS IMMEDIATELY FOLLOWING THE INCIDENT. THE REPAIRS COST NEARLY $750. THEY SAID THAT MOST ALL OF THE BRAKE LINES WERE RUSTED AND THE ONE ON THE REAR DRIVERS SIDE HAD A HOLE RUSTED THROUGH. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS AND TOWING A TRAILER, THE LIMP MODE WARNING LAMP ILLUMINATED AS THE VEHICLE DECELERATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 99,950 AND THE CURRENT MILEAGE WAS 205,000.

I BOUGHT MY CHEVY 3500 DUALLY 4X4 TO DRIVE WHEN I NEEDED IT TO HAUL THINGS OR FOR THE 4WD . I TOLD MY DAUGHTER IT WAS GOING TO SNOW AND MAKE THE ROADS DANGEROUS SO I WOULD TAKE HER TO WORK AND PICK HER UP WHEN SHE WAS DONE EVERYTHING WENT WELL NO SIGNS OF ANY PROBLEMS BEFORE AND AFTER I HAD TAKEN HER TO WORK SO WHEN SHE CALLED I WENT TO PICK HER UP AT WORK AND HAD TO WAIT A LITTLE WHILE FOR HER TO FINISH UP AFTER I HAD GOTTEN TO HER WORK THEN I DROVE HER HOME AND JUST AFTER GETTING OFF THE INTERSTATE WE PULLED INTO THE DRIVEWAY AND I PULLED UP TO THE HOUSE AND ALMOST WENT THROUGH MY GARAGE DOOR WHEN MY BRAKE PEDAL WENT TO THE FLOOR AT ABOUT 10-15 MPH WITH ABSOLUTLY NO WARNING WHAT SO EVER I WOULD HAVE NEVER USED THE TRUCK IF I HAD REMOTELY THOUGHT SOMETHING WAS WRONG WITH THE BRAKES I DRIVE SEMI TRUCKS FOR A LIVING AND ALWAYS CHECK THINGS AROUND MY VEHICLES BY SECOND NATURE SINCE I AM RESPONSIBLE FOR THE SAFE OPERATION OF THE VEHICLES I DRIVE. I HAD MY TRUCK TOWED TO THE DEALER WHERE I PURCHASED IT NEW AND TOLD THEM I HAD CONTACTED GM ABOUT THE PROBLEM AND THAT I TOLD THEM I EXPECTED IT TO BE REPAIRED FREE OF CHARGE AND GM RESPONSE WAS THAT THEY WANTED THE DEALER TO EVALUATE IT AND THE EVALUATION WOULD BE FREE OF CHARGE THEY DID AND THEY FOUND THE BRAKE LINES RUSTED IN HALF AND ALSO BUSTED AT THE RUBBER HOSE CONNECTIONS SO GM SAID THAT THEY WOULD COVER 30% OF THE REPAIR OF THE BRAKE LINES IN WHICH THEY DID BUT IT STILL COST ME $1800 . GM INSISTED THAT MY BRAKE LINES RUSTED IN HALF BECAUSE MY TRUCK SITS A LOT I TOLD THEM I HAVE A 1990 MAZDA I BOUGHT NEW THAT SITS BESIDE IT THAT I HAVE NEVER HAD ANY SAFETY PROBLEMS OUT OF . GM ALSO HAS CHANGED THE BRAKE LINES TO A PLASTIC COATED LINE . I HAD ALSO TOLD THEM THAT IT WAS A POOR DESIGN WHERE THE WATER RAN OFF THE WINDSHIELD AND DOWN ONTO THE BRAKE LINES RIGHT WHERE THEY RUSTED AND BROKE GM NEEDS TO STAND BEHIND ITS PRODUCT. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC WHERE UNKNOWN REPAIRS WERE MADE TO THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 3,000 AND THE CURRENT MILEAGE WAS 36,000.

I HAVE A 2006 CHEVROLET SILVERADO 2500HD ALL OF THE BRAKE LININGS HAD RUSTED. MY BRAKES FAILED WHILE I WAS DRIVING. FORTUNATELY I CONTROLLED THE VEHICLE AND WAS ABLE TO STOP, SAW THE LEAK AND WAS TOWED .A PRIVATE COMPANY REPLACED ALL LINES. I EMAILED MY CONCERN TO CHEVROLET, ASKED TO HAVE MY COMMENTS FORWARDED TO CEO-PRODUCT IMPROVEMENT. SUBSEQUENTLY HAD A PHONE CONVERSATION (866-790-5600) [XXX]WITH [XXX] COULD NOT SEND THIS INFORMATION TO CEO PRODUCT IMPROVEMENT. IF THE BRAKE LININGS FAIL YOU HAVE NO BRAKES. MY SERVICE REQUEST[XXX] I SPOKE TO PRIVATE MECHANICS THEY SAID THIS WAS SYSTEMIC ISSUE TO CHEVROLET. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

ON STARTING THE VEHICLE THE DIC LIGHT CAME ON & STATED THAT THE 42V BATTERIES WAS NOT CHANGING . AT THE SAME TIME THE SERVICE ENGINE LIGHT WAS ON . I SHUT THE ENGINE OFF TO MOVE DEBRIS FROM THE REAR OF THE TRUCK ,THEN WHEN TRYING TO RESTART THE VEHICLE , IT WOULD NOT START. THE TRUCK HAVE POWER INSIDE BUT WILL NOT START AT ALL. I HAVE NO IDEA AS TO WHAT IS THE PROBLEM. I NEED SOME TYPE IDEA AS TO WHAT IS WRONG SO I COULD TELL A REPAIR SHOP OR DEALER SERVICE CENTER. PLEASE. *TR

MY MECHANIC TOLD ME THAT MY BRAKES WILL FAIL FROM RUSTED BRAKE LINES AT ANY TIME. A PROBLEM HE SEES EVERY WEEK.THE UNDER SIDE OF MY TRUCK IS COMPLETELY RUST FREE AND THE BRAKE LINES LOOK LIKE THE CAME FROM THE BOTTOM OF THE OCEAN! I AM AFRAID TO PUT MY SELF AND MY FAMILY AND OTHER PEOPLE AT RISK DRIVING THIS TRUCK.THE REPAIR COST IS OUT OF MY GRASP.I ALSO HAVE A 2002 SUBARU WITH MANY MORE MILES ON IT DRIVEN ON THE SAME ROADS IN THE SAME WEATHER AND YOU COULD TAKE THOSE LINES OFF AND SELL THEM FOR NEW!I AM 62 AND HAVE OWNED ALOT OF CARS AND TRUCKS IN MY LIFE AND NEVER HAVE SEEN ANY THING WITH THAT POOR OF METAL USED ON SOMETHING YOU USE EVERY DAY.I ONLY HAVE TO MENTION TO A SERVICE CENTER WHAT TRUCK I HAVE AND BEFORE I TELL THEM WHY I AM CALLING THEY ASK I STILL HAVE BRAKES. *TR

ABS ENGAGES AT SLOW SPEEDS - EVIDENTLY THERE IS A KNOWN PROBLEM WITH THE ABS SENSORS ENGAGING AT LOW SPEEDS. THIS IS A POTENTIALLY DANGEROUS DEFECT. IT IS SCARY WHEN YOU APPROACH A STOP AND THE BRAKES RELEASE. GM HAS KNOWN ABOUT THIS PROBLEM AND HAS ISSUED A SERVICE BULLETIN. THERE WAS A RECALL ON PREVIOUS YEARS BUT STOPPED IN 06 EVEN THOUGH THEY NEVER FIXED THE PROBLEMS. THEY SHOULD REINSTATE THE RECALL AND FIX THE REMAINING VEHICLES. WE HAVE NOT BEEN INVOLVED IN AN ACCIDENT BECAUSE OF THE DEFECTIVE SENSORS BUT I CONSIDER US FORTUNATE. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING IN REVERSE AT APPROXIMATELY 5 MPH, THE BRAKES FAILED TO RESPOND WHEN DEPRESSED. THE GEAR LEVER WAS SHIFTED INTO PARK HOWEVER, THE VEHICLE DID NOT RESPOND. THE CONTACT WAS A CERTIFIED MECHANIC AND STATED THAT THE FRONT AND REAR BRAKE LINES WOULD NEED TO BE REPLACED DUE TO CORROSION HOWEVER, THE REQUIRED PARTS WERE NO LONGER BEING PRODUCED BY THE MANUFACTURER. THE VEHICLE WS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 60,000. THE VIN WAS UNAVAILABLE.

MY 16 YR OLD SON AND 12 YR OLD SON WERE COMING HOME FROM SCHOOL ON 11/10/2006, MY 16 YR OLD WAS DRIVING, HE TOOK DRIVERS ED AND PASSED THE CLASS WITH AN A+. AND WHEN HE TOOK HIS DRIVING PART OF THE TEST HE PAST WITH A PERFECT SCORE THE FIRST TIME. HE ALSO RACED GOKARTS, SO HE KNEW HOW TO CONTROL VEHICLES AND PREVENT WRECKS. WHEN THE WRECK HAPPENED, THE TRUCK JUST WENT UP AN EMBANKMENT, AND WENT THROW THE AIR AND HIT A TREE AND PEALED THE ROOF BACK LIKE IT WAS A TIN CAN. THERE WAS NO SKID MARKS, THE TIRE TRACKS WENT STRAIGHT UP THE BANK, LIKE THE STEERING WHEEL WAS LOCKED. AND NOT ONE AIR BAG OPENED. THEY WERE LESS THAN A 1/4 OF A MILE FROM HOME. I WAS AT THE BUS STOP WAITING ON MY DAUGHTER, I HEARD THE WRECK AND THE ALARM FROM THE TRUCK WAS GOING OFF. I WENT TO THE SITE AND THE ALARM WAS STILL GOING OFF, AND THE STEERING WHEEL WAS LOCKED. MY 12YR OLD DIED ON SITE, MY 16 YR OLD DIED 4 DAYS LATER. I HAVE KNOWN SOMETHING CAUSED THE WRECK, BUT NOT SURE WHAT UNTIL NOW. NOW I KNOW WITH ALL MY HEART THE SWITCH LOCKED THE STEERING AND ALSO MADE THE AIR BAGS NOT WORK. *TR

TL* THE CONTACT OWNED A 2006 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, ANOTHER VEHICLE CRASHED INTO THE CONTACT'S VEHICLE. THE AIR BAGS FAILED TO DEPLOY AND THE SEAT BELT RIPPED. THE CONTACT SUSTAINED BACK, SHOULDER, CHEST, AND WRIST INJURIES. THE DRIVER OF THE SECOND VEHICLE WAS FATALLY INJURED. THE VEHICLE WAS DESTROYED AND WAS NOT DIAGNOSED TO DETERMINE THE CAUSE OF THE AIR BAG FAILURE. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE AND VIN WAS NOT AVAILABLE.

RUSTED BRAKE LINES 1 HAS RUPTURED. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT AFTER TURNING THE AIR CONDITIONER OFF, THE FAN CONTINUED TO OPERATE. THE CONTACT THEN SHUT THE ENGINE OFF BY REMOVING THE KEY FROM THE IGNITION AND THE FAN CONTINUED TO OPERATE. THE CONTACT NOTICED A BURNING ELECTRICAL ODOR COMING FROM THE VENTS. THE CONTACT REMOVED THE MASTER FUSE AND THE FAN TURNED OFF. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 59,000. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE DRIVING 4 MPH, THE VEHICLE MADE A LOUD POPPING SOUND AS THE CLUTCH PEDAL SANK INTO THE FLOORBOARD. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE MASTER CYLINDER HOUSING FAILED. AS A RESULT, THE HOUSING AND CLUTCH ASSEMBLY NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 98,000. UPDATED 04/22/14*LJ *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. THE CONTACT STATED THAT HE THE GEAR SHIFTER BECAME INOPERABLE. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS FOUND THAT THE CLUTCH ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 98,000.

THE WHEEL SPEED SENSOR FOR THE ABS SYSTEM IS AFFECTED ON MULTIPLE TRUCKS CHEVY PRODUCED FROM 99-06. THIS CAUSES THE BRAKING BELOW 10 MPH TO CAUSE PULSATION AND ABS MALFUNCTIONING CAUSING ME TO ALMOST REAR END VEHICLES AND BE UNABLE TO SLOW DOWN CORRECTLY. CHEVY KNOWS OF THE ISSUE YET IT IS NOT A RECALL FOR MY VEHICLE. *TR

THE LINE RUNNING FROM THE TRANSMISSION TO THE RADIATOR IS EXTREMELY PRONE TO LEAKING DUE TO A WEAK/IMPROPER CRIMP IN THE HOSE. AS TIME GOES ON TRANSMISSION FLUID IS DEPLETED AND COULD LEAD TO TRANSMISSION FAILURE. THE LEAK IS WIDESPREAD ACROSS MOST ALLISON TRANSMISSIONS DUE TO A FAULTY HOSE CRIMP AND LEAKS THROUGH THE CRIMP IN THE HOSE. *TR

MASTER CYLINDER RESERVOIR FLUID LEVEL DROPPED FROM FULL TO ACTIVATION OF BRAKE SERVICE LIGHT. INVESTIGATION OF THE CAUSE LED TO THE DISCOVERY A LEAK IN THE BRAKE LINE FROM THE ANTI LOCK BRAKE ACTUATOR TO THE RIGHT FRONT BRAKE CALIPER. ALL THE BRAKE LINES APPEAR TO BE EXTENSIVELY CORRODED. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE BRAKES FAILED AND THE EMERGENCY BRAKE HAD TO BE USED TO STOP THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC, WHO ADVISED THAT THE BRAKE LINES WERE RUSTED. THE MECHANIC REPLACED ONE OF THE FUEL LINES. THE CONTACT DID NOT CALL THE MANUFACTURER. THE FAILURE MILEAGE WAS 120,000.

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. THE CONTACT STATED THAT THE HEAT WOULD NOT ACTIVATE ON THE HIGH SETTING. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE HEATER SWITCH WAS FOUND TO BE MELTED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FAILURE RECURRED SEVERAL YEARS LATER IN WHICH THE HEATER SWITCH OVERHEATED AND CAUSED THE DASHBOARD TO CATCH ON FIRE. THE CONTACT DID NOT SUSTAIN ANY INJURIES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

BRAKE LINES ARE SEVERELY CORRODED AND NEED TO BE REPLACED BEFORE THEY FAIL AND RESULT IN AN ACCIDENT. *TR

I WAS PREPARING TO SLOW DOWN AS I APPROACHED MY DRIVEWAY. WHEN I APPLIED MY VEHICLE'S BRAKES, THE BRAKE PEDAL WENT COMPLETELY TO THE FLOOR. MY VEHICLE DID NOT SLOW DOWN AND I HAD TO UTILIZE ME EMERGENCY BRAKE AND ALSO SHIFT INTO A LOWER GEAR IN ORDER TO SLOW DOWN. I WAS UNABLE TO SLOW DOWN ENOUGH TO SAFELY MAKE A TURN AND SUBSEQUENTLY MY VEHICLE TRAVELLED THRU A DITCH AREA AND CAME TO A STOP IN MY FRONT YARD. COMPLETING A CHECK OF MY VEHICLE'S BRAKE SYSTEM, I LEARNED THAT MY MASTER CYLINDER WAS COMPLETELY EMPTY. I HAD MY VEHICLE TOWED TO A LOCAL GARAGE WHERE I WAS TOLD THE VEHICLE'S COMPLETE BRAKING SYSTEM LINES HAD RUSTED AWAY CAUSING ALL BRAKE FLUID LOSS AND NEEDED TO BE REPLACED. ALL BRAKES LINES WERE REPLACED FROM THE MASTER CYLINDER TO THE ABS MODULE AND THEN TO EACH BRAKE SYSTEM AT THE WHEEL. THE COST OF THE WORK WAS $598.00. MY VEHICLE IS A 2006 MODEL YEAR AND IS IN EXCELLENT SHAPE, HOWEVER I'M VERY UNHAPPY WITH THE BRAKING FLUID LINES FAILING WITH ONLY 52,500 MILES ON MY VEHICLE. I DON'T UNDERSTAND WHY THERE HAS BEEN NO SAFETY RECALL NOTICE ON THE PART OF GENERAL MOTORS. THE LOCAL DEALERSHIP REFUSED TO ASSIST ME WITH THE MATTER AND AT THIS TIME I'M COMPLETING THIS COMPLAINT. THE NATIONAL HIGHWAY TRANSPORTATION SAFETY ADMINISTRATION NEEDS TO TAKE IMMEDIATE ACTION UPON GENERAL MOTORS TO ENSURE HIGHER QUALITY OF BRAKE LINES ARE INSTALLED INSTEAD OF SUBSTANDARD BRAKE LINES. I WAS LUCKY THAT I WAS NOT INVOLVED IN A MORE SERIOUS ACCIDENT/INCIDENT WITH THE BRAKES FAILING. I WOULD ALSO LIKE TO SEE GENERAL MOTORS REIMBURSE ME IN FULL FOR THE COST OF THE REPAIRS. *TR

HAPPENED IN THE DRIVEWAY, THANKFULLY. BRAKE PEDAL SPONGY, PUSHED AGAIN AND WENT TO THE FLOOR. GOT OUT OF THE TRUCK AND FOUND A PUDDLE OF BRAKE FLUID UNDER THE DRIVER'S SIDE. FURTHER INSPECTION, THE BRAKE LINE HAS RUSTED THROUGH AND WAS SPRAYING FLUID WHEN THE PEDAL WAS PUSHED. COMPLETE FAILURE OF BRAKES. THANK GOODNESS FOR THE E BRAKE. *TR

WHILE TRAVELING ALONG RT 80 IN NEW JERSEY AT 65 MPH, TRAFFIC BEGAN TO SLOW IN ALL LANES. I HIT MY BRAKES ONLY TO FIND THAT MY FOOT WENT COMPLETELY TO THE FLOOR AND HAD POSSIBLY 10% BRAKING ABILITY REMAINING TO STOP THE TRUCK. I WAS ONLY ABLE TO AVOID CONTACTING THE VEHICLES IN FRONT OF ME BY DOWNSHIFTING, USING THE EMERGENCY BRAKE AND RUNNING ONTO THE HIGHWAY SHOULDER AND OFF THE ROAD TO AVOID AN ACCIDENT. I WAS ABLE TO DRIVE SLOWLY TO THE CLOSEST REPAIR SHOP WHERE I WAS INFORMED THAT THE BRAKE LINES WERE CORRODED AND LEAKING BRAKE FLUID. AS A RESULT, WHEN I HIT MY BRAKES, THE BRAKE FLUID LEAKED CAUSING THE LACK OF PEDDLE PRESSURE AND DID NOT OPERATE THE BRAKES PROPERLY. I HAD NO PREVIOUS WARNING THAT THERE WAS ANY BRAKE PROBLEMS. ADDITIONALLY, THE GAS LINES WERE CORRODED AND REQUIRED REPLACEMENT. THIS IS AN ADDITIONAL HAZARD THAT COULD CAUSE A FIRE. THE CORRODED BRAKE LINE ISSUE IS A WELL KNOWN (EXCEPT TO ME PRIOR TO THE INCIDENT) AND DOCUMENTED PROBLEM OF WHICH CHEVROLET REFUSES TO NOTIFY VEHICLE OWNERS. THE FIRST TIME OWNERS ARE AWARE OF THE BRAKE LINE PROBLEM IS WHEN THEY TRY TO STOP THE TRUCK AND BY THAT POINT, IT IS TOO LATE. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. THE CONTACT STATED WHILE DRIVING 20 MPH, HE DEPRESSED THE BRAKE PEDAL BUT THE VEHICLE DID NOT STOP IMMEDIATELY. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE BRAKE LINES WERE CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 52,000. THE VIN WAS UNAVAILABLE.

BRAKE FAILURE WHEN STEPPING ON BRAKES ON HIGHWAY. STEEL BRAKE LINE FROM FRONT TO REAR BRAKES RUPTURED AND PEDAL WENT TO FLOOR WITH NO WARNING. FROM READING ON WEB THIS IS A COMMEND PROBLEM WITH CORROSION ON BRAKE LINES DUE TO POOR QUALITY MATERIALS USED IN MANUFACTURING. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 3500. THE CONTACT STATED THAT WHILE DRIVING 25 MPH AFTER REFUELING, HE NOTICED FUEL LEAKING FROM THE FRONT FUEL TANK. THE CONTACT MENTIONED THAT HE COULD HEAR THE REAR PUMP RUNNING AND WHILE ATTEMPTING TO INSPECT THE FUEL CAB, IT SPEW DIESEL ALL OVER HIM. THE VEHICLE WAS TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 52,621.

BRAKE LINES RUSTED COMPLETELY THROUGH AND BLEW OUT WHILE BRAKING AND LOST ALL PRESSURE. FUEL LINES ARE SEVERELY RUSTED. *TR

DESCENDING SMALL HILL TO MAKE TURN AND BRAKES FAILED. WAS ABLE TO GET VEHICLE STOPPED, BUT WAS IN-TOWN SITUATION AND VERY DICEY FOR A FEW MOMENTS. INVESTIGATION REVEALED ROTTED BRAKE LINE(S). REPAIRED REAR LINES FOR $500 . . WAS FRI AFTERNOON AND 100 MILES FROM HOME AND COULDN'T GET BRAKES REPAIRED UNTIL TUES. MECHANIC SAID ALL LINES SHOULD BE REPLACED AND I AGREED FRONT LINES STILL NEED DOING. $300-500. I HAVE HAD THE LOW SPEED ABS ISSUE IN THIS VEHICLE AS WELL. THIS IS AN ISSUE THAT IS WAY PREMATURE! THIS IS A SERIOUS SAFETY ISSUE AND GM NEEDS TO STEP UP! IT'S OBVIOUSLY COMMON. PEOPLE WILL BE KILLED OR SERIOUSLY INJURED. BUT THE PERSON KILLED WON'T BE WRITING THIS LETTER, EH? NHTSA--WHERE ARE YOU? *TR

WHILE STOPPING FOR TRAFFIC LIGHT, BRAKES WERE WEAK AND REQUIRED EXCESSIVE PRESSURE TO ACTIVATE ENOUGH TO STOP VEHICLE. PULLED INTO NEAREST PARKING LOT AND FOUND BRAKE FLUID DRIPPING FROM CHASSIS UNDER DRIVER DOOR AREA. CALLED TOW TRUCK TO TAKE VEHICLE TO DEALER. TRIED TO MOVE VEHICLE TO MAKE IT EASIER FOR TOW TRUCK OPERATOR TO HOOK UP AND PEDAL WENT COMPLETELY TO FLOOR WITH NO BRAKING EFFECT. USED PARKING BRAKE TO STOP. DEALER SAID ENTIRE BRAKE SYSTEM NEEDS TO BE REPLACED DUE TO CORROSION. *TR

THE BRAKE LINES RUSTED OUT AND THE FLUID LEAKED OUT CAUSING BRAKE FAILURE. *TR

BRAKE LINE TO THE REAR DRIVER'S SIDE BRAKE FAILED AND BROKE AND LOST HYDRAULIC PRESSURE TO BRAKING SYSTEM. PULLED OVER INTO A GAS STATION AND HAD THE VEHICLE TOWED TO LOCAL DEALER FOR REPAIR/REPLACEMENT. *TR

SERVICE BRAKELINES ROTTED AND CAUSED A COMPLETE LOSS OF SERVICE BRAKES - WHILE DRIVING AND CLOSE TO HOME - USED EMERGENCY BRAKES AND LOW GEAR TO GET TO HOME. SPOKE TO FRIEND AT CHEVY DEALER. THEY ARE HAVING PROBLEMS WITH THIS TRUCK SERIES DUE TO CORROSION AND PREMATURE RUSTING. TRUCK IS CURRENTLY IN GARAGE DUE TO FAILURE (CORROSION) OF TRANSMISSION COOLING LINES. CURRENT MILEAGE 15,211. LOST BOTH ANTI-LOCK BRAKE MODULES AND ALTERNATOR AND TEMPERATURE SENSORS. *TR

BRAKE LINE FAILURE. RUSTY BRAKE LINES. LEAVING FLUID ON GROUND ALMOST HITTING BUILDING. *TR

COMPLETE BRAKE FAILURE DUE TO BRAKE LINE DEFECT / LEAK. REPAIR ESTIMATE FROM DEALERSHIP $2800.00+. *TR

CHEVROLET SILVERADO 2500 HD (2006) WAS PURCHASED NEW, FROM GENGRAS CHEVROLET-585 CONNECTICUT BLVD.- EAST HARTFORD, CT. 06108- TELEPHONE # 860-528-2575. BRAKE LINE RUPTURED DUE TO CORROSION, FORTUNATELY, VEHICLE WAS BEING OPERATED AT A SLOW SPEED (25) MPH. UPON INSPECTION OF UNDER THE VEHICLE, I WAS APPALLED AT THE CONDITION OF BRAKE LINES,FITTINGS,BRACKETS AND RELATED COMPONENTS. THE RUST ON THE UNDERSIDE INCLUDING THE FRAME WAS SUCH THAT IT COULD BE FLAKED OFF IN 1/16" THICK CHUNKS. THIS TRUCK HAS ONLY 9028 MILES, WHAT KIND OF AUTO INDUSTRY DO WE HAVE !!!!! ? I WAS MADE AWARE OF THIS CORROSION PROBLEM (THAT CHEVROLET IS AWARE OF) BY A LOCAL AUTO MECHANIC THAT THIS CORROSION PROBLEM WAS IN PRIMARILY (2004-2005-2006) SILVERADOS. THE MATERIALS GM IS USING TO CAUSE THESE PROBLEMS IS A DISGUSTING SAMPLE OF OUR MANUFACTURING SYSTEM. THIS VEHICLE WAS PARKED OUTDOORS (ON A ASPHALT DRIVEWAY). THE REPAIRS FOR THIS SITUATION ARE IN LINE WITH THE POOR QUALITY MATERIALS THAT WERE USED, I WAS INFORMED THAT THE BODY OF THE TRUCK BED HAD TO BE REMOVED (LIFTED-OFF) TO ACCESS BRAKE LINES AND GET THIS, THE FUEL LINE IS ALSO IN THE SAME LOCATION, MIGHT BE SUSPECT TO CORROSION. THE COST OF THESE REPAIRS IS OFF THE CHARTS. (WHO IS RESPONSIBLE FOR THESE DESIGN FLAWS). AS AN AMERICAN, WHO ADVOCATES BUYING DOMESTIC VEHICLES, I WONDER WHO IS WATCHING WHAT IS GOING ON. I HOPE SOMEONE OF AUTHORITY READS THIS AND ACTS ON IT, BEFORE IT IS TO LATE FOR ALL OF US. REMEMBER, THIS VEHICLE HAS (9028) MILES ON IT, AND EXPERIENCING THESE PROBLEMS. YES, THAT IS CORRECT (9028) MILES !!!!!!!!!! *TR

MY TRUCK HAS A SERIOUS RUST PROBLEM. I WAS DRIVING FROM PENNSYLVANIA TO BUFFALO WHEN MY BRAKE LINE SNAPPED "SPEWING BRAKE FLUID ALL OVER"ON THE HIGHWAY WHILE DRIVING AT 65MPH. AT THE DEALER I WAS SHOWED THAT NOT ONLY WHERE MY BRAKE LINES ROTTED BUT EVERYTHING INVOLVING THE BRAKES "CALIPERS,ROTORS, PADS " FUEL LINES, FRAME CONTROL ARMS, EVERYTHING UNDER THE TRUCK, WHICH WAS BOUGHT NEW. THE BRAKE PADS, CALIPERS & ROTORS WERE REPLACED BY MY MECHANIC AT 25,000 WITH PARTS BOUGHT BY GM. MY TRUCK IS IN EXCELLENT SHAPE FROM WHAT YOU CAN SEE & IS GARAGE KEPT.FROM WHAT I SEE THIS IS A COMMON PROBLEM WITH GM TRUCKS FROM 2000-2012. *TR

STEPPED ON THE BRAKES, THE BRAKE PEDAL WENT TO THE FLOOR. I WAS FORTUNATELY ABLE TO EXIT THE ROAD AND, UPON INSPECTION, SAW FLUID LEAKING FROM A HEAVILY CORRODED FRONT LEFT BRAKE LINE. I HAD TO HAVE BOTH FRONT BRAKE LINES REPLACED BY THE DEALER AT A VERY SIGNIFICANT COST. I HAVE N EVER HAD A CORRODED BRAKE LINE ON ANY OTHER VEHICLE. I BELIEVE GM SHOULD TAKE RESPONSIBILITY FOR THIS PROBLEM ? IT IS A SAFETY ISSUE CAUSED BY THE USE OF INFERIOR MATERIALS OR IMPROPER BRAKE LINE PLACEMENT/LAYOUT. *TR

I WAS GOING BACK TO MY JOB LOCATION AFTER LEAVING A TRAINING CLASS. APPLIED BRAKES AS I APPROACHED A STOP SIGN. BRAKE PEDAL HAD NO RESISTANCE AND WENT TO THE FLOOR. LUCKILY, I WAS ON SCHOOL DISTRICT PROPERTY SO THE SPEED LIMIT WAS 15. WAS ABLE TO GET TO MY LOCAL MECHANIC WHO FOUND A RUPTURED BRAKE LINE. HE ALSO INFORMED ME THAT ALL BRAKE LINES WERE RUSTED AND WHILE HE COULD NOT SAY ANOTHER ONE WILL RUPTURE TOMORROW, HE FELT TO BE SAFE THEY SHOULD ALL BE REPLACED. WE TOW A CAMPER WITH THIS TRUCK AND WHILE I KNOW THE CAMPER'S BRAKES WILL STOP THE TRUCK, SOME OF THE CAMPGROUND WE VISIT ARE MOUNTAIN CAMPGROUNDS WITH STEEP GRADES AND WHEN WE LEAVE THE CAMPGROUND TO DO SOMETHING (EXAMPLE: GO OUT TO EAT), NOT KNOWING IF THE TRUCK BRAKES WILL WORK IS NOT VERY COMFORTING. *TR

UPON DRIVING HOME ON MY STREET MY BRAKE PEDAL WENT TO THE FLOOR. HAVE BREAK LINE CORRODED AND LEAKING BELOW DRIVER SIDE DOOR. WAS ABLE TO STOP SAFELY AS I WAS ON A RESIDENTIAL ROAD WITH A LOW SPEED LIMIT. *TR

I WAS DRIVING ON THE HIGHWAY, AND APPROACHING A RED LIGHT, STEPPED ON THE BRAKES. UPON DOING SO, THE BRAKE PEDAL WENT TO THE FLOOR. I WAS ABLE TO PUMP THE PEDAL, AND DRIVE INTO THE NEXT PARKING LOT. I WALKED AROUND TO THE REAR OF THE TRUCK, WHERE I SAW A PUDDLE OF BRAKE FLUID. I LOOKED UNDER THE TRUCK, AND SAW THE FLUID LEAKING FROM A HEAVILY CORRODED BRAKE LINE. WHEN I GOT THE TRUCK HOME, I DID A MORE THOROUGH INSPECTION, AND DISCOVERED THAT ALL THE BRAKE LINES WERE HEAVILY CORRODED, AND WOULD NEED REPLACEMENT. I ORDERED AN AFTERMARKET, PRE-BENT STAINLESS LINE KIT. I TOOK THE TRUCK TO A LOCAL MECHANIC WHO WAS ABLE TO REPLACE THE LEAKING LINE, AND A FEW OTHERS, BUT WAS UNABLE TO REPLACE THE LINES GOING INTO THE ABS MODULE DUE TO THEIR LOCATION ON TOP OF THE FRAME, UNDER THE CAB. I AM ABLE TO DRIVE THE TRUCK NOW, BUT WILL NEED TO FIND ANOTHER MECHANIC WHO IS WILLING TO SEPARATE THE CAB FROM THE FRAME TO REPLACE THE REST OF THE LINES. I HAVE OWNED MANY VEHICLES OVER THE YEARS, AND NONE HAVE EVER HAD A CORRODED BRAKE LINE. THE LAST TRUCK I OWNED WAS A 1993 CHEVY SILVERADO, WHICH I HAD FOR 15 YEARS, AND RACKED UP 300,000 MILES, WITH NO BRAKE OR FLUID LINE ISSUES, AND DRIVEN IN THE SAME NORTHEAST CLIMATE AS THE 2006 SILVERADO. JUDGING BY THE AMOUNT OF COMPLAINTS I HAVE READ ONLINE, DESCRIBING THE SAME PROBLEM I AM EXPERIENCING, I BELIEVE GM SHOULD TAKE RESPONSIBILITY FOR THE REPAIRS. THIS PROBLEM IS A SAFETY ISSUE CAUSED BY WHAT I BELIEVE TO BE THE USE OF INFERIOR MATERIALS. *TR

2006 CHEVROLET SILVERADO 1500 WITH 5.3L V8 MAKES TICKING NOISE WHEN COLD. EXHAUST SMELL IN PASSENGER CABIN. NOISE DECREASES AS ENGINE HITS NORMAL OPERATING TEMPERATURE. AFTER A SERVICE CALL TO REPAIR. THE MECHANIC STATED THAT THE FORWARD MOST AND REAR MOST EXHAUST MANIFOLD BOLTS WERE BROKEN OFF INSIDE THE ENGINE BLOCK ON THE DRIVER SIDE OF THE ENGINE, THIS ALLOWS EXHAUST GAS TO ESCAPE WHEN COLD AND ACCOUNTS FOR EXHAUST SMELL IN THE CABIN. PER THE MECHANIC THIS IS VERY COMMON AND SHOULD BE A RECALL ITEM. *TR

WHILE DRIVING AT 10 MPH THE REAR BRAKES FAILED. UPON INVESTIGATION IT WAS FOUND THAT THE REAR BRAKE LINE HAD RUSTED OUT AT THE CONNECTION TO THE SPLITTER LOCATED ON FRAME ABOVE THE REAR AXLE. *TR

EVERY BRAKE GAS AND COOLING LINE RUSTED. I HAVE LOOKED AT OTHER VEHICLES OF SAME YEAR AND MILES DIFFERENT MAKES. NO WHERE AS RUSTED AS MY 06 SILVERADO. *TR

I PURCHASED THIS VEHICLE FROM A DEALER WITH A ONE YEAR CERTIFIED USED WARRANTY AT 49K MILES. WITHIN A MONTH OF PURCHASE I NOTICED AN EXCESSIVE AMOUNT OF FREE-PLAY IN THE STEERING AND NOTICED A LOOSE PITMAN ARM WHEN ROTATING THE STEERING WHEEL AND OBSERVING THIS PART. I TOOK THE VEHICLE TO TWO DIFFERENT DEALERS IN THE INDIANAPOLIS AREA. AFTER THEIR INSPECTION AND CONSULTING GM CONCERNING THIS ISSUE, I WAS TOLD FREE-PLAY WAS NORMAL OR WITHIN PARAMETERS. ONE YEAR LATER AND 69K MILES, I TAKE THE VEHICLE IN FOR SERVICE (OIL & FILTER CHANGES ETC) AND TO HAVE THEM PLEASE LOOK AT THE BRAKES AS I COULD FEEL A VIBRATION. THE VEHICLE IS NOW OUT OF WARRANTY... THEY TELL ME NOW THAT THESE PARTS (PITMAN ARM / STEERING BOX) WILL NEED TO BE REPLACED ALONG WITH BOTH FRONT WHEEL BEARINGS TO THE TUNE OF JUST UNDER $2,000. I HAVE DONE MY OWN RESEARCH AND HAVE FOUND MANY COMPLAINTS IN REGARDS TO STEERING ASSEMBLY / PARTS ON THESE TRUCKS. NOTHING I HAVE FOUND SAYS THAT THIS MUCH FREE-PLAY IS "NORMAL" IN REGARDS TO THIS VEHICLE AND IN FACT, SOME FRONT WHEEL AXLES AND WHEEL ASSEMBLIES HAVE ACTUALLY SEPARATED FROM THE VEHICLE. MY WHEELS OR BEARINGS (I SAW FOR MYSELF WHEN IT WAS ON THE LIFT AND I HAVE THE OLD PARTS) HAD A DANGEROUS AMOUNT OF WOBBLE IN THEM, WITH THE RIGHT WHEEL HAVING IN EXCESS OF 1" OF TILT OR LOOSENESS. THIS IN MY OPINION DOES NOT CONSTITUTE "NORMAL" PLAY AND I QUESTION GM'S HONESTY CONCERNING THIS ISSUE... WHY IS THIS ACCEPTABLE WHEN UNDER WARRANTY BUT NEEDS EXPENSIVE REPAIR WHEN ITS ON MY DIME? I BELIEVE GM IS AWARE OF THE PROBLEM BUT IS PUSHING THE COST OFF TO THEIR CUSTOMERS. *JS

DRIVING HOME FROM STORE ONLY TO HAVE A VEHICLE STOP SHORT IN FRONT OF ME. APPLIED BRAKES AND TO MY SURPRISE THE PEDAL WENT TO THE FLOOR. LUCKILY I HAD ROOM TO MANEUVER AROUND TRAFFIC AND AVOID AN ACCIDENT. VEHICLE WAS TOWED TO REPAIR SHOP AND I WAS TOLD LEFT FRONT BREAK LINE RUSTED OUT. I PURCHASED THIS VEHICLE NEW AND I CAN ATTEST THAT NO UNUSUAL CIRCUMSTANCES OCCURRED TO WARRANT BRAKE LINE RUSTING OUT. MOVING FORWARD 16 MONTHS I WAS LEAVING THE HOUSE ONLY TO HAVE BRAKES GO TO THE FLOOR. VEHICLE TOWED TO CHEVY DEALER. DEALER TELLS ME ALL BRAKE LINES RUSTED BADLY (EXCEPT ONE PREVIOUSLY REPLACED) AND IN NEED OF REPLACEMENT TO THE TUNE OF $2700.00. GOOD THING I WAS NOT DRIVING OR WORSE YET PULLING MY 8000 POUND CAMPER. IS IT GOING TO TAKE SOME ONE GETTING KILLED BEFORE CHEVY IS MADE TO ADMIT THEY HAVE A SERIOUS SAFETY ISSUE WITH THESE BRAKE LINES. *JS

I SEE YOU RECALLING BMW CARS FOR LIGHTS FAILING! WHY DON'T YOU RECALL GM TRUCKS AND SUV'S FOR FAILING RUNNING LIGHTS? FROM THEIR INTRODUCTION THEY HAVE BEEN ADVERTISED AS A SAFETY FEATURE! I WOULD GUESS 97% OF ALL GM TRUCKS AND SUV'S HAVE ONE OR BOTH OF THE LIGHTS NOT WORKING! AN OBVIOUS DESIGN FLAW!! MY 2006 SILVERADO HAS HAD THE PASSENGER SIDE LIGHT REPLACED 4 TIMES. IF THIS IS NOT A SAFETY ISSUE, EVEN THOUGH ADVERTISED AS SUCH, IT COST OWNERS A BIG SUM OF MONEY TO KEEP REPAIRING THEM BECAUSE OF GM'S OBVIOUS FAULTY DESIGN!! WHY DOES GM GET A PASS BUT BMW DOES NO? THANKS

WHILE DRIVING I WENT TO STOP AT INTERSECTION AND THE BRAKE PEDAL WENT TO THE FLOOR,AND I USED PARKING BRAKE TO STOP.I GOT OUT AND THERE WAS BRAKE FLUID ALL OVER,I CAREFULLY DROVE HOME ,1/2 MILE AND CHECKED OUT TRUCK AND THE BRAKE LINES WERE ALL RUSTED AND LEAKING. I TRIED TO FIX WITH NEW PARTS BUT AFTER FIXING IT WOULD LEAK IN ANOTHER SPOT. I HAVE TO REPLACE ALL BRAKE LINES TO BE SAFE. I THINK THAT GM SHOULD HAVE TO HAVE A RECALL ON THESE BRAKE LINES. THANKS *TR

RETURNING HOME, I APPROACHED A 4-WAY STOP AT ABOUT 40 MPH. ATTEMPTED TO STOP, ONLY LIMITED BRAKES. GEARING DOWN AND DEFENSIVE DRIVING NECESSARY TO AVOID ACCIDENT AT INTERSECTION. ABLE TO COMPLETE SHORT DISTANCE HOME WHERE I INSPECTED BRAKES AND UNCOVERED RUSTED AND LEAKING BREAK LINES. VEHICLE WITH LESS THAN 90,000 MILES. EXTREMELY DANGEROUS AND GM/NHTSA SHOULD BE ASHAMED THAT A RECALL HAS NOT BEEN INITIATED. ONLY A MATTER OF TIME BEFORE SOMEONE IS NOT AS LUCKY AS ME AND OTHER COMPLAINANTS. *JB

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO. THE CONTACT STATED THAT WHILE DRIVING, THE BRAKES FAILED TO STOP IN A TIMELY MANNER. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 21,000.

ALL FRONT BRAKE LINES BELOW THE DRIVERS SEAT RUSTED THROUGH. A COMPLETE LOSS OF BRAKES WAS EXPERIENCED. *TR

MY WIFE WAS DRIVING MY TRUCK A 2006 SILVERADO AND SAID THE BRAKE LIGHT CAME ON SO I FILLED IT UP DIDN'T THINK MUCH OF IT DID A QUICK LOOK DIDN'T SEE ANYTHING 2 WEEKS LATER SHE SAID IT WAS ON AGAIN SO I FILLED IT UP AGAIN AND THIS TIME DID A THOROUGH INSPECTION CHECKED THE MASTER CYLINDER, BOOSTER STARTED CHECKED EACH CALIPER AND NOTHING SO I GOT UNDER THE TRUCK AND ITS LEAKING FROM THE MIDDLE OF THE TRUCK UNDER THE DRIVERS SEAT THE BRAKE LINES ARE ALL RUSTY. I DO ALL OF MY WORK ON MY CARS BUT THIS LOOKS RIDICULOUS WHERE DO YOU START RIP THEM ALL OUT AND REPLACE ALL? THEY ARE ON TOP OF THE FRAME RAIL WHICH LOOK IMPOSSIBLE TO GET TO IT LOOKS LIKE ITS GOING TO BE A LOT OF MONEY IS THERE A RECALL FOR THIS? I HOPE SOME CAN HELP ME OUT THE TRUCK IS VERY CLEAN ESPECIALLY UNDERNEATH THAT'S THE ONLY THING RUSTED OUT OF EVERYTHING. *LN

WHILE PULLING INTO A STORE PARKING LOT THE BRAKES GAVE OUT, CAUSING THE BRAKE PEDAL TO GO STRAIGHT TO THE FLOOR. UPON INSPECTION I NOTICED A BRAKE LINE COMPLETELY ROTTED GOING TO THE REAR SPLITTER NEAR THE FRAME AND ELECTRICAL HARNESS. THE REST OF THE LINE SEEMS PERFECTLY INTACT SO THIS SECTION OF LINE SHOULD NOT HAVE DETERIORATED. AFTER RESEARCHING THIS ISSUE, I FOUND THAT THIS IS A HUGE PROBLEM FOR CHEVY OWNERS. I HOPE THAT THIS ISSUE IS LOOKED INTO AND A RESOLUTION IS FOUND BEFORE SOMEONE IS INJURED OR WORSE. INCIDENTALLY, MY WIFE WAS DRIVING WITH MY CHILDREN WHEN THIS INCIDENT OCCURRED. *JS

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT WHILE ATTEMPTING TO DECELERATE, THE BRAKES FAILED TO FUNCTION PROPERLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE BRAKE SENSOR HAD FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 50,000. UPDATED 10/17/13*LJ A MECHANIC INFORMED THE CONSUMER THAT DUST AND SALT MADE ITS WAY INTO THE SENSORS WHICH CAUSED THEM TO CORRODE AND THEY WERE NOT READING CORRECTLY.

WE HAD JUST GOTTEN TO THE BOTTOM OF A HILL WHEN WE APPLIED THE BRAKES THE PEDAL FELT NORMAL THEN INSTANTLY IT WENT TO THE FLOOR. WE ATTEMPTED TO PUMP THE BRAKES BUT THE PEDAL WAS COMPLETELY TO THE FLOOR. WHEN WE FINALLY WERE ABLE TO STOP WE JUMPED OUT AND SAW BRAKE FLUID PUDDLE ON THE GROUND AND ALL UNDERNEATH THE CAB OF THE TRUCK. AFTER THE FLUID WAS GONE THERE WAS ABSOLUTELY NO BRAKES TO EVEN PANIC STOP. THERE IS ALSO EXTENSIVE RUST UNDER THE TRUCK EVEN THOUGH UNDERCOATING WAS APPLIED IN THE FACTORY. *TR

BRAKE LINES RUSTED THROUGH AND LOST BRAKE POWER. BRAKE FLUID ALL OVER DUE TO THE LINES RUPTURING. ABSOLUTELY UNACCEPTABLE!!!!!! HUGE SAFETY ISSUE. *TR

LOST BRAKES, REPAIR SHOP FOUND BRAKE LINE RUSTED THRU AND ALL THE LINES WERE RUSTED AND NEEDED TO BE REPLACED ! *TR

COMING UP TO TRAFFIC SIGNAL AND BRAKE PEDAL WENT TO THE FLOOR. BRAKE LINE RUSTED OUT. STOPPED BY SLAMMING IT INTO 1ST GEAR AND USING THE PARKING BRAKE. VERY DANGEROUS! *TR

TL * THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 1500. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 45 MPH, THE FRONT PASSENGER AIR BAGS FAILED TO DEPLOY DURING A FRONT END CRASH. THE CONTACT, THE PASSENGER, AND THE BACK SEAT PASSENGER WERE TAKEN TO THE HOSPITAL WHERE THERE WERE NO INJURIES REPORTED. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A PRIVATE MECHANIC WHERE THERE WAS NO DIAGNOSTIC TEST PERFORMED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 100,000.

TOWING TRAILER, WHILE PARKING TRAILER, BRAKE PEDAL GOT SPONGY, THEN WENT TO FLOOR, TOTAL BRAKE LOSS. RUSTED BRAKE LINE RUPTURED UNDER DRIVERS SEAT BY ABS MODULE, ALL BRAKE LINES WILL NEED REPLACEMENT. *TR

DURAMAX DIESEL. CHECK ENGINE LIGHT CAME ON WHEN STARTED. INVOICE STATED CODE WAS: "CHECK ENGINE LIGHT IS ON. THE VANES INSIDE AREN'T WORKING. P2563=TURBOCHARGER BOOST CONTROL. COMMAND SOLENOID WITH TECH2, WON'T OPERATE SOLENOID NOT OPERATING. REPLACE SOLENOID AND RETEST. SOLENOID NOW OPERATES BUT TC VANE PLACE STOPS/STICKS AT 69% AND WON'T MOVE. REMOVE AND REPLACE TURBOCHARGER POSITION SENSOR TO INSPECT. VANE CAM WON'T MOVE. TAC CASE #11223434. SEE RO FOR DETAILS. REPLACE TURBOCHARGER, CLEAR DTC, RELEARN TC POSITION AND RETEST." TURBOCHARGER REPLACED UNDER ORIGINAL WARRANTY WITH $100 DEDUCTIBLE. *TR

DURAMAX DIESEL TURBOCHARGER REPLACEMENT. SECOND IDENTICAL OCCURRENCE, SEE ODI NUMBER 10522941. WORK ORDER STATES "CUSTOMER STATES THE CHECK ENGINE LIGHT CAME ON THIS MORNING. ADVISE. DTC P2563=TURBOCHARGER BOOST CONTROL. SYSTEM TEST FOUND TURBO VANE STICKING IN TURBO. CONTROL SOLENOID AND POSITION SENSOR OPERATING. REPLACE TURBOCHARGER AND ALL NEEDED SEALS AND GASKETS. REPROGRAM ECM AS NEEDED. FILL COOLING SYSTEM." THIS SECOND P2563 TROUBLE CODE AND TURBOCHARGER REPLACEMENT, 28,342 MILES SINCE THE FIRST REPLACEMENT, COST ME $2,889.74. THERE SEEMS TO BE A TREND OF THIS SPECIFIC FAILURE. *TR

BRAKE LINE HAS COMPLETELY DETERIORATED AND LEAKING AND SHOULD BE RECALLED. RECENTLY HAD TO REPLACE WHEEL SPEED SENSORS AS WELL. *TR

PULLING TRUCK OUT OF GARAGE THE BRAKE PEDAL WENT TO THE FLOOR. UPON EXAMINATION THE BRAKE LINE HAD BLOWN A HOLE THRU THE RUSTED BRAKE LINES. ALL OF THE BRAKE LINES THAT ARE NOT COATED ARE RUSTED AND INTEGRITY OF THE METAL IS POOR. HAD TO HAVE ALL BRAKE LINES REPLACED FOR A SUM OF $900.. *TR

THE BRAKES ON MY TRUCK TAKE FOREVER TO WORK. I HAVE REPLACED THE ABS SENSOR AND BEARING AND FUSE AND THE LIGHTS CONTINUE TO COME ON AFTER I DRIVE A MILE AFTER STARTING IT UP. THIS IS VERY SCARY. IF I NEEDED TO STOP SUDDENLY IT WOULD CAUSE A CRASH. I HAVE RESEARCHED AND I AM NOT THE ONLY ONE WITH THIS PROBLEM. PLEASE DO A RECALL. CHEVY HAS ALREADY DONE A RECALL FOR THE SAME BREAK SYSTEM FOR THE 00' TO '05 SILVERADO. THIS HAS POTENTIONAL TO HURT MY FAMILY AND MAYBE SOMEONE ELSE'S. *TR

FOUR BUBBLES ON THE SIDEWALL OF MY TIRE APPEARED - I TOOK THE TIRE TO A GOODYEAR DEALER AND HE CONCLUDED THAT THE TIRE WAS DEFECTIVE FROM THE BEGINNING WHEN I BOUGHT IT. IT HAD 10,000 MILES ON THE TIRE WITH ORIGINAL TIRE TREAD OF 7/32 - IT NOW HAS 6/32 TREAD. GOODYEAR GAVE ME A $80.00 DISCOUNT ON A NEW TIRE - I CALLED THEM AND ASKED FOR A 100% DISCOUNT SINCE THE TIRE WAS DEFECTIVE FROM THE BEGINNING. I HAVE THREE OTHER TIRES ON THE TRUCK ALL GOODYEAR TIRES AND IT APPEARS THEY COULD BE DOING THE SAME THING. I ALSO DISCOVERED THAT THERE WAS RECALL ON GOODYEAR WRANGLER TIRES HAVING THE SAME ISSUES JUST NOT ON MY TIRE SINCE IT IS MUCH LARGER AND NOT THAT POPULAR. *TR

ROTTEN BRAKE LINES. I LOOKED AT THE BRAKE LINES WHILE CHANGING MY OIL. MY TRUCK HAS 47K ON IT. I CALLED GM. THEY TOLD ME THAT I HAD TO BRING IT TO A DEALER. I DID. THEY CONFIRMED THAT THE BRAKE LINES ARE BAD AND NEED TO BE REPLACED. $1500 ALSO THE TRANSMISSION COOLING LINES ARE LEAKING. I HAVE BEEN THROUGH ALMOST ALL OF THE BRAKE PROBLEMS LISTED ON THIS WEB CITE. ABS LIGHT COMES ON, TWICE, 2ND TIME I REPLACED THE LEFT HUB BEARING ASSEMBLY. THE 1ST TIME THE DEALER REPLACED THE FRONT ABS SENSORS. AIR BAG LIGHT COMES ON, I REPLACED A BAD FRONT AIR BAG SENSOR, RIGHT SIDE. THIS TRUCK IS TURNING INTO A MONEY PIT!!!!! THIS NEW (ROTTEN LINES) ISSUE IS A SAFETY ISSUE AS WAS THE ABS ISSUE. GM NEEDS TO DO A FULL RECALL AND REPLACE THE BRAKE LINES BEFORE SOMEONE GETS KILLED. *TR

FAILED INSPECTION FOR CORRODED BRAKE LINES. *TR

VEHICLE WAS TAKEN TO HAVE 4 NEW TIRES INSTALLED. AS PART OF THIS PROCESS THE VEHICLE WAS LIFTED OFF THE GROUND AND THE STEERING COMPONENTS AND SUSPENSION SYSTEM WAS CHECKED FOR WEAR. AS THIS PROCESS WAS TAKING PLACE ONE OF THE MECHANICS NOTICED THE RUSTED BRAKE LINES AND CALLED ME OVER TO SHOW HOW BAD THE LINES WERE RUSTED. *TR

VEHICLE UNDER CARRIAGE LOOKS MORE LIKE A 30 YEAR OLD VEHICLE. BRAKES LINES HAVE FAILED CAUSING EXTENDED STOPPING DISTANCE OR SWERVING OFF ROAD TO AVOID COLLISION. OIL COOLER LINED RUPTURED AND LEAKED OIL ON EXHAUST MANIFOLD, A POTENTIAL FIRE HAZARD, ESPECIALLY WHEN ALL THE EXHAUST MANIFOLDS ROTTED AS WELL SO HOT EXHAUST GASES ARE NOT DIRECTED OUT THE EXHAUST, ALSO A CONCERN FOR POISONING OCCUPANTS WITH TOXIC EXHAUST GASES . POWER STEERING FITTINGS ROTTED CAUSING LOSS OF STEERING. GM IS USELESS, WHEN I CONTACTED THEM THEY SAID IT IS THE ENVIRONMENT. I ASKED THEM WHY A TOYOTA AND ACURA, BOTH 8 YEARS OLDER SHOWED NO SUCH FAILURES OR EVEN SIGNS OF RUST ON CRITICAL COMPONENTS. GM RESPONDED THAT THEY COULDN'T ANSWER THAT QUESTION. HMMM, I WONDER WHY. IN 39 YEARS OF DRIVING, IT IS THE MOST I EVER PAID FOR A VEHICLE, 48,000 DOLLARS, AND THE MANUFACTURER REFUSES ANY ASSISTANCE. THAT'S THE THANKS FOR BAILING THEM OUT. IT HAS ALSO HAD WIRES TO BLOWER MOTOR BURN, REAR BRAKE ROTORS ROTTED AWAY AT 22,000 MILES, GROUND WIRES UNDER HOOD HAVE ROTTED AND FALLEN OF... MORE POTENTIAL HAZARDS, A/C COMPRESSOR SEIZED A CAME APART. I COULD GO ON AND ON. THERE NEEDS TO BE A SERIOUS INVESTIGATION INTO GM AND.THE POOR QUALITY AND LACK OF CONCERN FOR THE SAFETY OF THE PUBLIC. IT IS BY FAR THE WORST VEHICLE I HAVE OWNED, EVER. *TR

I PARKED MY TRUCK IN A BANK PARKING LOT AFTER RUNNING ERRANDS. I WENT INTO THE BANK LOBBY, LOOKED BACK, AND NOTICED MY HEADLIGHTS FLASHING. I RETURNED TO THE TRUCK, THINKING I SET OFF MY PANIC ALARM, ONLY TO FIND SMOKE FILLING THE CABIN. AFTER THE SMOKE CLEARED, I TURNED THE IGNITION KEY TO AUX POWER AND NONE OF MY ELECTRICAL SYSTEMS WERE WORKING (E.G. WINDOWS, DOOR LOCKS, ONSTAR, RADIO). AFTER INSPECTION, THE CHEVY DEALERSHIP FOUND THE MAIN BODY WIRE HARNESS HAD MELTED THROUGH FROM HEAT. THE FINAL ANALYSIS IS THAT THERE IS A SHORT IN THE WIRE HARNESS THAT CAUSED THE ENTIRE HARNESS TO MELT. DAMAGE WAS LIMITED TO THE HARNESS AND CARPET BECAUSE THE SHORT IMMEDIATELY DRAINED THE BATTERY AND DID NOT ALLOW THE HARNESS TO HEAT UP TO A COMBUSTIBLE TEMPERATURE. *TR

THE VEHICLE WAS PARKED AND I ENTERED IT TO START IT. WHEN I APPLIED MY FOOT TO THE BRAKE PEDAL I HEARD A LOUD POP (LIKE A BALLOON POPPING) AND A RECOIL IN THE BRAKE PEDAL. COME TO FIND OUT, THE DIAPHRAGM IN THE BRAKE BOOSTER BROKE THUS LEAVING ME WITH VERY LITTLE BRAKES. I AM JUST GLAD I WAS THE ONE BEHIND THE WHEEL AND THE VEHICLE WAS IN PARK. I CAN ONLY IMAGINE IF THIS HAD HAPPENED WHILE DRIVING THROUGH TOWN. OR IF SOMEONE LIKE MY 18 YEAR OLD SON HAD BEEN DRIVING. AFTER SPEAKING WITH MULTIPLE MECHANICS, IT WAS BROUGHT TO MY ATTENTION THAT THIS IS ONE OF THOSE THINGS THAT "NEVER HAPPENS"...ESPECIALLY ON A 2006 WITH ONLY 63K MILES ON IT. WHEN I CALLED CHEVROLET THEY TOLD ME THAT IT WOULD BE NOTED BUT THEY COULD NOT HELP COVER THE COST OF REPAIR AS IT WAS NOT UNDER WARRANTY. ALTHOUGH I DO KNOW IT'S OUT OF WARRANTY, I THOUGHT THEY MIGHT COVER IT AS IT IS NOT A WEAR AND TEAR ISSUE...IT IS A MECHANICAL DEFECT AND A MAJOR SAFETY ISSUE. IT HAS BEEN REPAIRED AND I'M JUST HOPING IT DOES NOT OCCUR AGAIN. UNFORTUNATELY THERE IS ABSOLUTELY NO WAY AT ALL TO PREDICT IF AND WHEN THIS WILL EVER OCCUR ON ANY OTHER VEHICLE. I JUST HOPE IT DOESN'T HAPPEN TO MINE AGAIN. *TR

BRAKE LINES RUSTED OUT. THIS IS THE SECOND TIME I HAVE HAD THIS PROBLEM WITH THIS VEHICLE. A HOLE DEVELOPED IN A BRAKE LINE WHICH RESULTED IN NO BRAKES AT ALL. I HAD TO SPEND $1400 AT THE CHEVY DEALERSHIP TO HAVE ALL OF MY BRAKE LINES AND FRONT CALIPERS REPLACED. *TR

PARKING BRAKE FAILED TO HOLD TRUCK STATIONARY DURING INSPECTION. WE TRIED TO ADJUST PEDAL FOLLOWING THE GM SERVICE MANUAL AND BRAKE STILL WOULD NOT HOLD. REMOVED REAR BRAKE ROTORS AND FOUND LINING ON SHOES WORN OFF. REPLACED SHOES, HARDWARE, AND ROTOR. CHECKED CABLES AND ACTUATORS FOR SHOES. ASSEMBLED, ADJUSTED AND BURNISHED SHOES AS PER SERVICE MANUAL, BRAKE STILL WOULD NOT HOLD TRUCK ON GRADE INSPECTION WAS CONDUCTED ON. ADJUSTED SHOES UNTIL THEY WERE DRAGGING ON DRUMS AND COULD FINALLY GET BRAKES TO HOLD TRUCK. THE DRAGGING SHOES WILL BE WORN OFF IN A MATTER OF DAYS AND THE BRAKE WILL NOT WORK. OUR COMPANY HAS SEVEN TRUCKS WITH THIS SAME STYLE PARKING BRAKE AND THEY WILL NOT HOLD EVEN AN EMPTY TRUCK DAYS AFTER LEAVING OUR SHOP. I KNOW OF THE RECALL FOR MANUAL TRANSMISSION TRUCKS AND IT SHOULD BE CARRIED OVER TO ALL SILVERADO TRUCKS. *TR

THE INSTRUMENT PANEL ON MY TRUCK HAS GONE BAD. THE AMPERES ARE POINTING STRAIGHT DOWN. THE TEMPERATURE REGISTER HAS GONE COMPLETELY AROUND, THE OIL PRESSURE GAGE IS PEGGED ALL THE WAY. THE SPEEDOMETER WORKS FOR 20 MINUTES AND THEN LOCKS UP. I HAVE TALKED WITH OTHERS WHO HAVE SILVERADOS AND THEY STATE THEY HAD THE SAME PROBLEM. THE TRUCK HAS BEEN GREAT BESIDE THE INSTRUMENT PANEL AND THE AC BLOWING HOT ON ONE SIDE AND COLD ON THE OTHER. WITH THE NUMBER OF COMPLAINTS I HAVE SEEN ON THESE TWO ITEMS, IT SHOWS WITHOUT A SHADOW OF A DOUBT TO BE A MANUFACTURER DEFECT. MY FAMILY BELIEVES IN CHEVY TRUCKS BUT THEY SHOULD KEEP OUR LOYALTY BUT CORRECTING THE SMALL MANUFACTURER DEFECT TO PROVE THEY ARE THE BETTER PRODUCT INSTEAD OF LEAVING THEIR LOYAL PATRONS TO FIX SUBSTANDARD ITEMS PLACED IN A GREAT TRUCK. *TR

TL* THE CONTACT OWNS A 2006 CHEVROLET SILVERADO 2500. THE CONTACT STATED THAT WHILE SHIFTING INTO DRIVE, THE BRAKES AND THE POWER STEERING FAILED WITHOUT WARNING. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 89,000. *TR

DRIVING MY 2006 SILVERADO 3500 HD WHEN THE CAR AHEAD DECIDED ON A SUDDEN LEFT TURN. WENT TO APPLY MY BRAKES AND HAD TO STAND ON THE PEDAL WHILE SWERVING, NARROWLY MISSING THE COMPACT CAR. AFTER EVALUATION AT THE GM CERTIFIED DEALERSHIP WE USE FOR INSPECTION AND REPAIR ON ALL 8 OF OUR GM BUSINESS AND PERSONAL VEHICLES, WE WERE INFORMED THAT THE BRAKE EROSION/RUSTING WAS A COMMON DEFECT IN THE BRAKE LINES USED. CONTACTED GM AND THEY OFFERED TO PAY HALF OF THE $1400.00 BILL AND STATED THAT THERE IS NO RECALL FOR THIS ISSUE. THERE NEEDS TO BE A RECALL FOR THE SAFETY OF EVERYONE ON THE ROAD! *TR

DRIVING MY 2006 SILVERADO 3500 HD WHEN THE CAR AHEAD DECIDED ON A SUDDEN LEFT TURN. WENT TO APPLY MY BRAKES AND HAD TO STAND ON THE PEDAL WHILE SWERVING, NARROWLY MISSING THE COMPACT CAR. AFTER EVALUATION AT THE GM CERTIFIED DEALERSHIP THAT WE USE FOR INSPECTION AND REPAIR ON ALL 8 OF OUR GM BUSINESS AND PERSONAL VEHICLES, WE WERE INFORMED THAT THE BRAKE EROSION/RUSTING WAS A COMMON DEFECT IN THE BRAKE LINES USED. CONTACTED GM AND THEY OFFERED TO PAY HALF OF THE $1400.00 BILL AND STATED THAT THERE IS NO RECALL FOR THIS ISSUE. THERE NEEDS TO BE A RECALL FOR THE SAFETY OF EVERYONE ON THE ROAD! *TR

ABS KICK IN AT LOW SPEEDS INCREASING STOPPING DISTANCE BY SEVERAL FEET. *TR

2006 SILVERADO 1500 IN OCTOBER 2012, AS I APPROACHED A STOP LIGHT, MY BRAKE PEDAL LOST PRESSURE AND WENT TO THE FLOOR. I WAS ABLE TO PULL INTO A PARKING LOT AND STOP BY PUMPING THE PEDAL AND USING THE PARKING BRAKE. THE CAUSE WAS A RUSTED OUT BRAKE LINE, WHICH I PAID THE SHOP TO REPLACE. IN FEBRUARY 2013, I PRESSED THE BRAKE PEDAL TO SHIFT INTO DRIVE IN MY DRIVEWAY AND THE BRAKE PEDAL AGAIN LOST PRESSURE AND WENT TO THE FLOOR. I HAD THE TRUCK TOWED TO A MECHANIC AND UPON INSPECTION LEARNED THAT ALL OF THE BRAKE LINES ARE RUSTED OUT INCLUDING AT THE ABS MODULE CONNECTION POINT. THE ONLY REPAIR OPTION IS A $2000 JOB TO REMOVE THE BODY FROM THE TRUCK TO REPLACE EVERY SINGLE BRAKE LINE. THROUGH INTERNET SEARCHES AND BY MY MECHANIC'S EXPERIENCE, THIS IS CLEARLY A KNOWN PROBLEM THAT GM SHOULD BE RECALLING SILVERADOS FOR. *TR

BRAKE LINE RUST THROUGH. DRIVING DOWN THE ROAD HIT BRAKES WENT TO FLOOR. STILL HAD FRONT BRAKES AND WAS ABLE TO STOP. HAVING THE TRUCK TOWED TO HAVE LINES REPLACED. *TR

AT THE WORST POSSIBLE TIME WITH ICY ROADS AND SNOW. I WAS ON MY DRIVEWAY TRYING TO GET TO THE TOP OFF IT WHEN I LOST TRACTION. I STOPPED AND APPLIED THE BRAKES. I STARTED TO BACK DOWN THE DRIVE WHEN THE PEDDLE FELL TO THE FLOOR CAUSING THE TRUCK TO GO VIOLENTLY OUT OF CONTROL AND CRASH DOWN OVER AN EMBANKMENT. THERE WAS NO WARNING, JUST TOTAL LOSS OF BRAKES BOTH FRONT AND REAR. MECHANIC SAYS THE LINES BLEW APART FROM RUST. *TR

EXPERIENCED BRAKING FAILURE AND ACTIVATION OF ANTI-LOCK BRAKES WHEN BRAKING AT LOW SPEEDS. THIS CAUSES LONGER BRAKING TIMES AND DISTANCES AND I HAVE NARROWLY AVOIDED HITTING CARS IN FRONT OF ME, RUNNING STOP SIGNS, ETC. ON NUMEROUS OCCASIONS. AFTER RESEARCHING THIS PHENOMENON, IT IS KNOWN AS UNINTENDED LOW SPEED ABS ACTIVATION - A COMMON PROBLEM FOR OLDER MODEL GM TRUCKS. ADDITIONAL RESEARCH HAS REVEALED THAT IT IS A COMMON PROBLEM FOR 2006 SILVERADOS, YET IT HAS YET TO BE ADDRESSED BY THE MANUFACTURER. IT IS COMMONLY THE RESULT OF AN INCREASED AIR GAP BETWEEN THE WHEEL SPEED SENSOR AND HUB RELUCTOR RING DUE TO RUST AND DEBRIS BUILD UP ON THE SENSOR MOUNTING SURFACE. THIS IS A SERIOUS HAZARD THAT NEEDS TO BE ADDRESSED FOR SILVERADO TRUCKS FROM RUST-BELT STATES. *TR

BRAKE PEDAL WENT ALMOST TO FLOOR. AFTER INSPECTION METAL BRAKE LINE WAS RUSTED AND HAS HOLE IN LINE RESULTING IN LOSS OF FLUID. *TR