2006 Ford F-150 Supercab

The contact owns a 2006 Ford F-150. The contact stated that the airbag warning light was illuminated on the instrument panel. The contact had taken the vehicle to a dealer and was informed that the VIN was not included in NHTSA Campaign Number: 11V107000 (Air Bags). The contact was provided the cost for a diagnostic fee to determine the cause of the failure. The contact declined. The manufacturer was notified of the failure and referred him to NHTSA for assistance. The vehicle was not repaired. The failure mileage was approximately 180,000.

THE VEHICLE THAT IS TALKED ABOUT IN THIS IS A 2006 FORD F-150 THAT RECENTLY WENT IN FOR AN ANNUAL NYS SAFETY INSPECTION AND FAILED DUE TO AN EXCESSIVELY RUSTED FRAME THAT RESULTED IN CRACKS ON BOTH FRAME RAILS. THIS TRUCK HAS ONLY ~50,000 MILES AND IT IS UNKNOWN HOW LONG THE FRAME HAS ACTUALLY BEEN CRACKED AND STILL DRIVEN.

i STARTED HEARING A LOUD NOISE FROM UNDER MY TRUCK AND NOTICED BOTH SPRINGS WERE BROKE IN HALF, ONLY THE MIDDLE LEAF...WOW

Random brake loss due to hydraulic control unit for ABS. The loss of brakes on more than 5 occasions has nearly caused several accidents as brakes fail to engage in traffic situations. The problem cannot be reproduced by automotive repair shops due to the random nature of the events. Inspection of the component does not reveal any problem. The component functions properly 80% of the time. There has never been any warning of any sort prior to the event happening which is why the severity of the incidents are not only surprising but have put me and other drivers at risk. These HCU components have had similar failures in other ford vehicles. Recalls are listed for those vehicles such as the MZk, Fusion, Millan.

My truck was sounding like it was going to fall apart, I brought it to my sons attention and u can see the truck sagging between front and bed of truck. We looked under vehicle and the frame is split in two all the way across. [XXX]. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Main truck frame is rusting through-presently the left frame rail just behind the left door is failing. The overall condition of truck is good, no body panel rust through(s)-note that I live in Northern Michigan. At this point I wouldn't lift with a floor hoist or heavy load the box with materials. A check of the web shows many of the same complaints........2006 Ford F150, I can provide pics if need or you can actually inspect.

The shift cable for the automatic transmission was routed next to the exhaust manifold on the engine. The shift cable gets hot and burns into from the heat off the exhaust manifold. I purchased the 2006 Ford F150 used. I had mechanic replace one shift cable with a new shift cable. The new shift cable burned into has I was backing in my driveway. I did research on the internet for trucks in that year range and it included other trucks 2007 and 2008 F150 having the same issue. You can find a ton of utube videos . ShowIng mechanics finding solutions to prevent the shift cables from burning into. I contacted Ford motor company about it. Ford wanted me to take the truck to a dealership and let them diagnosed the problem. The dealership wanted me to pay them a 150 dollars to look at it. I was not going to pay them for something that I already knew the answer too. So it is a manufacturing flaw with the way Ford put the shift cable on 2006 F150 and other F150's in that year range. I hope you research the issue and get back to me soon. Sincerely Yours [XXX] Ph [XXX] [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

There is a very common problem with the brake light always being on due to a short circuit in the cluster, many owners have reported this problem for several manufacturing years, the brake light is always on even though there is no problem with the brakes. This creates a great hazard because if you do have a brake problem since the light is always on you will never know, and you may be in a fatal vehicle accident. Ford motor company should replace or repair all clusters that have this problem.I just purchased this vehicle with this very common problem. Your inspector can google it and will find this is indeed a very common problem.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE DRIVING 55 MPH, AN ABNORMALLY LOUD SOUND WAS COMING FROM THE VEHICLE. THE CONTACT PULLED OFF THE ROAD AND SHUT-OFF THE VEHICLE. THE CONTACT STATED THAT SEVERAL UNKNOWN WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS RESTARTED BUT SPUTTERED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE PERSISTED, LEADING TO AN ENGINE FAILURE. THE LOCAL DEALER WAS NOT NOTIFIED. THE MANUFACTURE WAS NOTIFIED BUT PROVIDED NO ASSISTANCE. THE APPROXIMATE FAILURE MILEAGE WAS 13,000.

HAVE A NICE FORD F250 2006 TRUCK WHICK OUR MECHANIC TELLS US TGE FRAME US BROKEN DUE TO EXCESSIVE RUSTING, THE TRUCK HAS NEVER BEEN IN A FLOOD, NEVER BEEN USED UP NORTH IN EXCESSIVE SNOW AND SALT. THE TRUCK HAS 90,000 MILES AND NIW IS JUST JUNK. IN TESEARCHING THIS, FORD SHOULD ISSUE A RECALL ON THIS MODEL, SO NANY PEOPLE HAVE EXPERIENCED THIS SAME PROBLEM WITH THIS MODEL AND YEAR, IT IS TIME FORD STEPS UP AND TAKES RESPONSIBILITY FOR THIS ISSUE, WHICH BASICALLY CAUSES THE TRUCK TO BE IN DRIVABLE DUE TO SAFETY, AND CAUSES IT TO ACTUALLY JUST VE A VERY EXPENSIVE TRUCK FOR THE JUNK YARD! THERE NEEDS TO BE A RECALL. WHAT KIND OF RECOURSE DO WE AS OWNERS HAVE??? PLEASE HELP

I BROUGHT MY 2006 F150 IN FOR SERVICE THE OTHER DAY, AND MY MECHANIC POINTED OUT A RUST HOLE ON MY FRAME THAT SHOWED UP. AFTER I SCRAPED SOME OF THE SURFACE RUST OFF, I FOUND THAT A LARGE PORTION OF MY DRIVERS SIDE FRAME RAIL HAD SIGNIFICANT ROT SPREADING. MY TRUCK HAD JUST BARELY ABOVE 90,000 MILES ON IT, WITH NO OTHER RUST ON ANY OF THE BODY PANELS. I DRIVE A COMPANY VEHICLE DURING THE WEEK, AND MY TRUCK BARELY GETS DRIVEN ALL YEAR. IT SEEMS AS THOUGH THE FRAMES ON THESE MID 2000'S F150'S ARE VERY PRONE TO ROT DUE TO THE LACK OF WEEP HOLES IN THE BOTTOM OF THE FRAME. CORROSIVE ELEMENTS GET INSIDE, THEN HAVE NO WAY OUT OF THE FRAMES INTERIOR. WITH THIS POORLY DESIGNED DETAIL ON THE FRAME, CONSUMERS ARE LEFT WITH NEXT TO NO CHOICE BUT ANXIOUSLY WAIT FOR THE PREMATURE DECAY OF THE MOST CRUTIAL ELEMENT OF THEIR VEHICLE. AT THIS RATE, JUNK YARDS ARE GOING TO FILLED WITH LOW MILAGE FORD TRUCKS THAT RUSTED OUT BEFORE THEIR PRIME. FORD SHOULD BE HELD RESPONSIBLE FOR THEIR POOR STRUCTURAL ENGINEERING. CONSUMERS BUY A FORD TRUCK FOR THEIR "FORD TOUGH" REPUTATION, NOT FOR THE INADEQUATELY BUILT TRUCKS THAT THEY SOLD UNDER THAT "FORD TOUGH" GUISE AND NOW REFUSE TO STAND BEHIND. I BELIEVE A RECALL SHOULD BE ISSUED DUE TO THE SHEER NUMBER OF INCIDENTS I'VE READ ABOUT, ALL OF WHICH ARE CENTRAL TO THE MID 2000'S F150. HOW CAN A PROBLEM THIS PUBLIC GO UNADDRESSED? HOW MANY UNSUSPECTING PEOPLE ARE DRIVING A RUSTED DEATHTRAP AT THIS MOMENT, BUT WOULD NEVER SUSPECT A THING DUE TO LOW MILES AND A GREAT BODY? FORD SHOULD MAKE THIS RIGHT TO THE PEOPLE THAT SUPPORTED THEM FOR YEARS.

IT WAS HARD TO STOP

COMPUTER KEEPS THROWING CODE FOR INTERMITTENT CAM SHAFT POSITION SENSOR CIRCUIT A BANK 1. CAUSE TRUCK TO RUN ON ONLY HALF POWER. POOR MPG. NO HORSEPOWER. HESITATION IN SHIFTING.

WE BOUGHT OUR 2006 F150 IN 2015, THINKING WE'D HAVE IT FOR YEARS TO COME. BY 2017, TWO SEPARATE MECHANICS HAD TOLD US THAT THERE WAS 'CATASTROPHIC CORROSION' TO THE FRAME. BOTH RECOMMENDED THAT WE HAVE A NEW FRAME FABRICATED. ONE OF THEM FOUND OUT THAT EARLIER F150S WERE RECALLED BECAUSE OF A BAD FRAME COATING THAT CAUSED IRREPARABLE RUST. HE BELIEVES THE '06 SHOULD BE INCLUDED AS WELL. THIS CAR WAS ALWAYS GARAGE KEPT TILL WE GOT IT, AND HAD NEVER BEEN FLOODED. THERE ARE NUMEROUS OTHER COMPLAINTS ABOUT THIS ISSUE, BUT FORD REFUSES TO ACT. WE ENDED UP WITH A $12000 YARD ORNAMENT, AND CAN'T EVEN SELL IT BECAUSE NO ONE ELSE WANTS TO DEAL WITH REFABRICATING THE FRAME. WE WERE TOLD NOT TO DRIVE THE TRUCK, AS THE FRAME COULD BASICALLY BUCKLE AT ANY TIME. RIDICULOUS THAT THIS HASN'T BEEN INVESTIGATED. I FEAR THE MORE TIME THAT PASSES, THE LESS LIKELY IT WILL BE THAT AN INVESTIGATION TAKES PLACE.

MY 2006 FORD F 150 HAS 125,000 MILES. I WENT TO PUT MY TRUCK IN REVERSE TO BACK UP OUT OF MY DRIVEWAY AND IT MADE A NOISE. APPARENTLY REVERS BAND IN THE TRANSMISSION WENT. I NO LONGER CAN PUT MY VEHICLE IN REVERSE TO BACK UP. VERY FRUSTRATED BECAUSE THE VEHICLE IS VERY WELL MAINTAINED AND IT BROKE FOR NO REASON.

MY 2006 F150 FORD LARIAT. IT STARTED WITH THE FRONT MAP LIGHT ARE SOME LIGHT NOT SURE WHAT IT'S CALLED. IT WOULD COME ON BY ITSELF JUST SITTING STILL WITH ENGINE OFF. AND NO ONE IN THE TRUCK. IT WOULD DO THIS ALL HOURS OF DAY AND NIGHT. THEN THE DOOR JAR LIGHT CAME ON GOING DOWN THE HWY. AND WOULD NOT GO OFF. WE STOP TO CHECK ALL DOES AND THEY ALL WAS SHUT. IT STAYS ON AND WANT GO OFF. THEN WITH ALL THAT GOING ON ALL MY POWER WINDOWS STOP WORKING. THEY WAS WORKING FINE BUT WHEN THE DIME LIGHT PROBLEM. AND THE DOOR A JAR LIGHT ON WHEN YOU GET IN THE TRUCK AND TURN KEY ON. I HAVE TALK TO PEOPLE THAT OWN A FORD AND MOST ALL FORD'S HAVE HAD THIS PROBLEM. I ALSO HAVE GOOGLED THESE PROBLEMS AND A LOT OF PEOPLE HAVE HAD THE SAME PROBLEMS. BUT IT HASN'T BEEN ANY RECALL ON THESE PROBLEMS. IT REALLY NEEDS TO BE A RECALL FOR THESE PROBLEMS ON FORD'S. IT'S A ELECTRICAL PROBLEM.

I PURCHASED THIS 78,400 MILE VEHICLE FROM AN INTERNET SALE IN SEPT/OCT. 2019, WITHIN A FEW DAYS OF DELIVERY, WHILE TAKING IT AROUND FOR MAINTENANCE APPRAISALS (BRAKES, ETC.), ONE OF THE SHOPS WARNED ME OF MAJOR FRAME RUST. A VISUAL INSPECTION SHORTLY THEREAFTER SHOWED THE MAIN FRAME MEMBERS WERE RUSTED THROUGH AND PARTIALLY COLLAPSED FROM THE WEIGHT OF THE TRUCK WHILE BEING LIFTED ON A RACK.

THE STEERING LOWER SHAFT GETS FAULTY IN THIS YEARS TRUCK DO TO BEING CHEAP MADE AND GETS CORRODED WIN SALT FROM THE ROADS BARELY TOUCHES IT WHEN DRIVING YOU HAVE TO TURN EXTREMELY HARD TO MAKE IT STEER AND IT DOESN'T TAKE MUCH FOR IT TO BRAKE WHEN GOING DOWN A HIGHWAY ONE OF THE MOST IN SAFE DESIGNS I HAVE EVER SEEN IN A NEWER TRUCK THAN 2000 THERE WAS A RECALL ON THEM THE EXACT SAME DESIGN IN THE CROWN VICS FROM 2004 TO 2008 MINE BROKE WHEN GOING DOWN THE CITY ROAD GOING ABOUT 45MPH

FORDF150 TRUCK. BACK DOORS WILL NOT OPEN.

THE REAR OF THE FRAME HAS NEARLY COMPLETELY BROKEN THROUGH BOTH SIDES OF THE FRAME CAUSING THE BED OF THE VEHICLE TO CONTACT THE REAR CAB OF THE VEHICLE. BOTH SIDES ARE COMPLETELY RUSTED THROUGH CAUSING A SAFETY CONCERN AS THE REAR OF THE VEHICLE COULD COMPLETELY SEPARATE FROM THE FRONT END. I STARTED NOTICING A TAPPING SOUND COMING FROM THE BACK END OF THE VEHICLE ON FEB 5, 2020, WHICH WAS ABOUT A WEEK AGO. AFTER RESEARCHING THE NOISE I NOTICED THAT THE TOP OF THE BED WAS TOUCHING THE CAB WHILE THE BOTTOM OF THE BED WAS ABOUT 4-5 INCHES FROM THE CAB. AFTER INSPECTING THE FRAME OF THE TRUCK AT THE REAR, I SAW THAT THE FRAME WAS NEARLY COMPLETELY RUSTED THROUGH ON BOTH SIDES.

THE FRAME IS RUSTED THROUGH.

ABS BRAKE SYSTEM NOT WORKING PROPERLY PEDAL GOES TO FLOOR

HAD IMPACT WITH OTHER VEHICLE AIRBAG DETONATED TO LATE BROKE COLLAR BONE IN TWO PLACES AT ONCE . DRIVING BONE INTO HEART VALVE AND RIGHT LUNG CAUSING P.E. UNDERWENT SURGERY TO REMOVE BONE FROM HEART AND LUNG. ACCIDENT IN ARLINGTON TEXAS 10/6/2016 . ROTTED TO NHTSA IN SEPTEMBER OF 2018. YOU HAD REQUESTED TO FORWARD INFO TO FORD MOTOR CO.. ANY FEEDBACK WOULD BE APPRECIATED IF YOU COULD PLEASE Y ME ANY INFORMATION . THANK YOU SO MUCH. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE WAY THAT THE WHEEL IS MADE IT ALLOWS FOR WATER TO SEAT IN THE INTER GROOVE WHICH THEN RUST HOLE INTO THE WHEEL CAUSEING AIR TO LEAK OUT OF TIRE AND POSSIBLE DRIVER LOOSING CONTROL OF VEHICLE WHICH ALMOST HAPPENED TO ME AT 60 MPH ON AN INTERSTATE HWY I WAS ABLE TO PULL OVER IN TIME

MAIN FRAME RAILS RUSTED THROUGHOUT. MY STATE DOESN'T CHECK FRAMES FOR THIS DURING NORMAL STATE INSPECTIONS. THIS TRUCK PASSED INSPECTION. ONLY 78,000 MILES. WHY ISN'T A RECALL ISSUED FOR THIS PROBLEM?

BRAKE LIGHT CONTINUOUSLY ON DUE TO FAULT IN CLUSTER PANEL. SAFETY ISSUE IN NOT KNOWING WHEN THERE ARE BRAKING PROBLEMS.

MY F150 2006 IS GETTING A LOW OIL PRESSURE MESSAGE. I TOOK IT TO SEVERAL MECHANICS AND THEY ALL SAID THAT I NEED A NEW ENGINE. ONE CHANGED THE FAVORS CRANKSHAFT AND OIL PUMP. IT RAN FOR ABOUT THREE MONTHS. AFTER THAT I BEGIN TO HAVE THE SAME ERROR MESSAGE, LOW OIL PRESSURE. WHAT CAN I DO?

PURCHASED NEW TIRES IN JAN 2019 ALL 4 TIRES OVER $1000.(DUE TO SLOW LEAKS ON 2 TIRES ) ONLY TO HAVE FLAT TIRE EVERY MORNING HAD TO AIR UP TIRE .FINALLY YOU COULD HEAR AIR COMING OUT TOOK BACK TO AMERICA TIRES TO CK AND WAS INFORMED THAT STEEL FORD RIM IS CRACKED ON INSIDE THEY COULD NOT LEGALLY PUT TIRE AND RIM BACK ON MY TRUCK DUE TO SAFETY THEY SAID I NEED TO HAVE 3 OTHERS ALSO CKD FOR DEFECT ON FORD STEEL RIMS WELD SEPERATEING AND COUKD CAUSE SEVERE INJURY SO I SIT WITH NEW TIRES ON 3 RIM THAT I CANT CK XAUSE HAVE NO REPLACEMENT RIM S

MY TRUCK IS MAKING A CHAIN SLAPPING NOISE ONLY WHEN I FIRST START IT AFTER IT SITS FOR SEVERAL HRS. IT SOUNDS LIKE THEIR IS SLACK IN THE TIMING CHAIN. I KNOW THAT THE CHAIN TENSIONERS FAIL ON THIS MODEL. PLEASE HELP AS I LOVE MY TRUCK AND I DON'T WANNA LOOSE IT. BECAUSE IT ONLY HAPPENS WHEN I START THE VEHICLE AND THEN IMMEDIATELY GOES AWAY, IT WAS STATIONARY WHEN IT STARTED THE NOISE. I'M JUST AFRAID THAT IF IT KEEPS ON SLAPPING, IT WILL DAMAGE THE PLASTIC RUNNERS AND POSSIBLY HAVE A CHAIN COME OFF WHILE IT'S IN MOTION.

DOORS WILL NOT OPEN. THERE IS A DEFECT IN THE CORD THAT OPERATES THE DOOR OPENING AND CLOSING.

2006 F150 FRAME RUSTED THROUGH MAKING THE VEHICLE UNSAFE TO DRIVE AND WORTHLESS, THE VEHICLE WAS ALWAYS STORED INSIDE AND ONLY OTHER MINOR RUSTING HOWEVER THE FRAME HAS RUSTED THROUGH ON BOTH SIDES OF THE TRUCK WHERE THE CAB MEETS THE BED OF THE TRUCK.

AT CERTAIN SPEEDS THE CAR STALLS WHEN CHANGING GEARS

FORD F-150 FX4 140,000.0 MILES. BRAKE LIGHT HAS BEEN ON FOR SEVERAL YEARS STARTING AROUND 2010 WITH 76,000.0 MILES. THE BRAKES WERE REPLACED AND FLUSHED MULTIPLE TIMES SINCE THE PROBLEM STARTED. REPLACED BRAKE CABLE E-BRAKE SWITCH ETC... EVERYTHING POINTS TO THE CLUSTER AND THERE ARE MULTIPLE WEBSITES THE VERIFY THE SAME EXACT PROBLEM WITH THE BRAKE LIGHT BEGINNING FROM 2004-2010. IN SOME STATES THIS IS AN INDPECTABLE ITEM ADDING ADDITIONAL AND MANDATORY REPAIRS TO BE MADE. THE CLUSTER REPAIR PART COST ANYWHERE FROM $400.00-$600.00 AND WITH LABOR COULD RUN WELL OVER $1000.00 PENDING ON THE MODEL OF THE F-150. MY BOTTOM LINE IS THAT THIS ISSUE HAS GONE WITHOUT A RECALL FROM FORD OR THE NHTSA.

TL* THE CONTACT OWNS A 2006 FORD F-150. REQUIRED OIL AND MAINTANCE SERVICES AT 3,000 MILE INTERVALS WERE DONE SINCE HE PURCHASED THE TRUCK AND THE ENGINE WENT OUT. THE CONTACT STATED THAT THE CHECK ENGINE INDICATOR FLASHED. DENNY MENHOLT FORD (50 FORD LN, BUTTE, MT 59701, (406) 494-6333) DIAGNOSED THAT THE ENGINE ASSEMBLY NEEDED TO BE REPLACED. THE DEALER STATED THAT THERE WERE NO ENGINE RECALLS TO PROVIDE A RECALL REMEDY. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 54,000. *BF*JB

I WAS PULLING IN MY DRIVEWAY I BACK OUT TO BACK IN BACK IN TO UNLOAD MY FOURWHEELER AN THE TRUCK WOULDN'T MOVE, I TAPPED THE FUEL A COUPLE TIMES AN SOUND LIKE THE TRANSMISSION WENT OUT, I JUST BOUGHT THE TRUCK IN FEBRUARY

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT BOTH REAR DOORS FAILED TO OPEN. THE CONTACT CALLED WORLD FORD PENSACOLA (6397 PENSACOLA BLVD, PENSACOLA, FL 32505, (850) 476-9050) AND WAS INFORMED THAT THE DOOR CABLE ASSEMBLY NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 66,670.

INTERIOR LIGHTS DO NOT LIGHT UP ON OPENING THE DOOR. ADDITIONALLY, UPON STARTING THE ENGINE, THE ELECTRICAL PANEL BLINKS, FIZZLES, DEMANDS RESET, WHICH DOESN'T RESET, AND EVENTUALLY CORRECTS ITSELF SOMETIMES AFTER 15 MINUTES OF BLINKING. ADDITIONALLY, THE HIGH BEAMS IMPLEMENT AND THEN YOU CANNOT MAKE THE HIGH BEAMS TURN OFF. MAY ALL BE RELATED BUT, SEEMS LIKE 3 SEPARATE ISSUES, ALL SEEM TO BE RELATED TO THE ELECTRICAL PANEL. BLINKING BEGINS WHILE STATIONARY UPON STARTING TRUCK AND CONTINUES WHILE IN MOTION, INDICATES PROBLEM WITH EVERYTHING ELECTRICAL INCLUDING SPEEDOMETER AND STATES AUTO LOCKS FAIL, ALONG WITH BLINKING FAILURE OF ALL SYSTEMS STATING RESET BUT PUSHING RESET DOES NOT APPEAR TO FIX ANYTHING.....ONLY TIME FIXES IT.

TRUCK WAS IN SIGNIFICANT FRONT END COLLISION - SEE PHOTO. DRIVER SIDE AIRBAG DID NOT DEPLOY

THIS PROBLEM IS RELATED TO FORD 5.4 LITER TRITON V8 24 VALVE ENGINES AND FREQUENT FAILURES OF THE EXHAUST MANIFOLDS. A SEARCH OF ONLINE LITERATURE FROM AUTOMOTIVE EXPERTS AND MECHANICS REPORT AN UNUSUAL NUMBER OF THESE MANIFOLDS WARPING, CRACKING, AND BREAKING THE MOUNTING STUDS. REPAIRS ARE VERY EXPENSIVE, IN THE RANGE OF $1000 - $2000 PER MANIFOLD. LAST FALL 2018, MY 2006 F-150 5.4 TRITON, WITH ONLY 83,000 MILES, BEGAN LEAKING EXHAUST FROM THE RIGHT SIDE MANIFOLD. I TOOK IT TO A FORD DEALER FOR REPAIRS. (SOME INDEPENDENT REPAIR SHOPS STATED THEY WILL NOT WORK ON THESE FORD MODEL MANIFOLDS ANYMORE.) THE TOTAL COST TO REPLACE THE MANIFOLD WAS OVER $1800. THE PARTS AND MATERIALS WERE ONLY ABOUT $300. THERE WAS A LOT OF LABOR INVOLVED BECAUSE 6 OF 8 MOUNTING STUDS HAD TO REMOVED AND REPLACED. THE DEALER ALSO RECOMMENDED REPLACING THE LEFT SIDE MANIFOLD BECAUSE THE MOUNTING STUDS ON THAT SIDE WERE SHOWING SIGNS OF IMPENDING FAILURE. IN FACT, SOME OF THE STUDS MAY BE BROKEN ALREADY, BUT THE LEFT MANIFOLD IS NOT YET LEAKING, SO I DID NOT REPLACE THE LEFT MANIFOLD AT THAT TIME. I AM A RETIRED MINE ENGINEER/MANAGER. I WAS HEAVILY INVOLVED IN THE MAINTENANCE OF TRUCKS AND EQUIPMENT. I BELIEVE THERE IS A DESIGN PROBLEM IN THESE MANIFOLDS AND/OR THE HEADS THEY MOUNT ON. (THESE ARE THE HEADS THAT PROMPTED THE 5.4 TRITON SPARK PLUG SETTLEMENT.)

'TAKATA RECALL' THE FRAME IS RUSTED REALLY BAD AND ALMOST RUSTED INTO. THE TRUCK BED IS RUSTED IN BOTTOM AND RUSTED ALL OVER. I BOUGHT THIS TRUCK THINKING FORD DIDN'T RUST LIKE THIS. PLEASE HELP ME. TRUCK IS TOO DANGEROUS TO DRIVE BUT I CAN'T AFFORD TO GET A NEW FRAME AND TRUCK BED.

MOTOR IS MISSING AND THE CODES ARE P0345, P0349 AND P0171

THE U JOINT ARE FREEZING UP AND IT IS HARD TO TURN AND IT GETS WORSE

TL* THE CONTACT OWNED A 2006 FORD F-150. AFTER THE CONTACT PARKED THE VEHICLE IN THE DRIVEWAY, FLAMES WERE SEEN COMING FROM THE ENGINE COMPARTMENT APPROXIMATELY FIVE HOURS LATER. THE FIRE DEPARTMENT WAS CALLED TO THE HOME AND EXTINGUISHED THE FLAMES. A FIRE REPORT WAS FILED. THE VEHICLE WAS DESTROYED ALONG WITH TWO OTHER VEHICLES THAT WERE PARKED IN THE DRIVEWAY. THE CAUSE OF THE FIRE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE LOCAL DEALER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 120,000.

BOUGHT THE TRUCK, FOUND OUT THE TRUCK HAD BEEN WRECKED AND WE WERE NEVER INFORMED. WE WENT TO HAVE THE OIL CHANGED AND WAS TOLD ABOUT THE RECALLS. THE MAN TOLD ME THAT SOMEONE HAD REPLACED THE DRIVER SIDE AIRBAG, BUT INSTEAD OF BOLTING IT BACK IN, THE AIRBAG WAS RIVETED BACK IN. AFTER BEING TOLD ABOUT THE AIRBAG, WE CONTACTED THE PLACE WHERE WE BOUGHT THE TRUCK AND WAS TOLD THE GUY THAT SOLD US THE TRUCK WAS UNAVAILABLE AND THAT HE WOULD CALL US BACK. TO THIS DAY WE HAVEN'T HEARD BACK FROM THEM.

DRIVERS SIDE FRAME RAIL IS SO RUSTED OUT THEY TOLD ME TO STOP DRIVING IT

THE FRAME IS RUSTED TO THE POINT THAT I'VE HAD TO HAVE A SHOP WELD STEEL SECTIONS AROUND THE FRAME. BOUGHT THE TRUCK AND KEPT MILES OFF OF IT BECAUSE I PLANNED TO RETIRE AND KEEP THE TRUCK FOR QUITE SOMETIME RETIRED NOW FOR A YEAR AND I'M BEING TOLD I'LL HAVE TO JUNK THE TRUCK IN A YEAR OR SO. I HAVE A TRUCK WITH LOW MILES AND CAN'T USE IT. THANKS FORD MOTOR COMPANY!!!!

WOMAN RAN LEFT TURN SIGNAL I HIT HER BROADSIDE AIRBAG DEPLOYED WITHOUT BAG INFLATED STRUCK MEUPPER CHEST ATNECKLINE BREAKING CLAVICAL IN, 2PLASES DRIVE ING BONE INTO HEART AND LUNG JAN 4 2017 WAS GOING TO HAVE SURGERY FOR VENT TUBE PORT. WHEN AWAKEN FROM SURGERY WAS TOLD 4 INCHES OF CLAVICAL REMOVED FROM HEART AND RIGHT LUNG

HARD STEERING ON INITIAL START UP AND DRIVING . STEERING WOULD NOT GO BACK TO CENTER BY ITSELF HAD TO MANUALLY CORRECT..STEERING GETS BETTER THE LONGER YOU DRIVE IT.

TAKATA RECALL. FOR THREE YEARS OF ELECTRICAL ISSUES, BEEPING ELECTRICAL DASH PANEL AND LIGHTS IN TRUCK HARDLY EVER WORK. THE TRUCKS DEPENDABILITY AT MOMENT ISN'T GREAT DUE TO THESE ISSUES. CAN'T AFFORD A NEW TRUCK AT TIME BEING .. THIS TRUCK TRANSPORTS MY TODDLERS AROUND. THIS TYPICALLY HAPPENS WHEN TURNING ON CAR AND OPENING DOORS WE NEVER SEE LIGHTS ON. IT DOES HAPPEN ALSO WHEN DRIVING AT RANDOM TIMES. NOT SURE IF IT HAS ANYTHING TO DO WITH STOPPING OR TURNING. WILL HAPPEN AT ANY RATE OF SPEED.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE ATTEMPTING TO MAKE A TURN, THE STEERING WHEEL SEIZED. THE FAILURE PREVENTED THE VEHICLE FROM TURNING AND ALMOST DROVE OFF A BRIDGE INTO A RIVER. THE VEHICLE WAS ABLE TO BE VEERED TO SAFETY. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN.

THE FRAME IS RUSTED TO THE POINT THAT IT IS UNSAFE TO DRIVE. USING MY HAND TO GET LEVERAGE TO LOOK UNDER VEHICLE AS EXHAUST WAS DRIPPING WATER. THE FRAME CRUMPLED AND BROKE WITH THE FORCE OF MY HAND. I UNDERSTAND 2001-2004 VEHICLES WERE RECALLED FOR THE SAME REASON.

I WAS DRIVING DOWN THE INTERSTATE ON THE WAY TO WORK AROUND 8 PM. WHEN THE CAR IN FRONT OF MY SLAMMED ON THEIR BRAKES. I REACTED IN ACCORDANCE AND HIT MY BRAKES PRETTY HARD. WHEN I DID MY TRUCK PULLED TO THE LEFT AND TOOK ME INTO THE MEDIAN. WHEN I TRIED TO CORRECT MY VEHICLE THE BACK END STARTED SLIDING OUT AS I TRIED TO GET BACK ON THE ROAD. WHEN MY TRUCK FINALLY CAUGHT TRACTION IT SHOT ME TO THE OTHER SIDE OF THE ROAD WHERE IT DID THE SAME THING. SLIDING THE BACK END OUT. THIS TIME I WAS SLIDING PERPENDICULAR TO THE HIGHWAY AND WHEN MY TRUCK FOUND SOMETHING SOLID TO STOP THE SLIDE IT STARTED TO ROLL. DURING THE CRASH I WAS THROWN THROUGH THE WINDSHIELD AFTER THE FIRST ROLL AND KNOCKED UNCONSCIOUS. AFTER I WAS RELEASED FROM THE HOSPITAL I WENT TO COLLECT THE THINGS FROM MY TRUCK THAT HAD BEEN PICKED UP. WHEN I GOT TO THE VEHICLE I NOTICED THAT NON OF MY AIRBAGS HADN'T DEPLOYED EVEN THOUGH IT WAS A PRETTY SERIOUS CRASH THAT TOTALED MY TRUCK. THE CAB AND BED OF THE TRUCK WERE BOTH CRUMPLED BUT NOT A SINGLE AIR BAG HAD DEPLOYED.

HAVE A SLIGHT MISFIRE AND CALLED ALL MY LOCAL SHOPS AND NO SHOP WILL CHANGE THE PLUGS ON A F-150 WITH A 5.4L TRITON MOTOR. THEY SAID IT'S WELL KNOWN THAT ALL THE SPARK PLUGS WILL SNAP OFF IN THE BLOCK. I CALLED THE DEALER AND THEY WANT $1000 TO CHANGE THEM. WHILE IN ALL OTHER CARS AND TRUCKS IT'S $50-$100 JOB. RESEARCHING THIS ONLINE IT SEEMS THIS HAPPENS TO EVERY FORD THAT HAD THE 5.4L TRITON ENGINE. WHY IS THERE NO RECALL? I CAN'T AFFORD $1000 TO CHANGE MY SPARK PLUGS. I'M A SMALL BUSINESS OWNER AND THIS IS BEYOND MY MEANS CURRENTLY. I EMAILED FORD AND THEY DIDN'T SEEM TO ACKNOWLEDGE IT BEING A KNOWN ISSUE. YET EVERY MECHANIC SHOP WILL AND THERE ARE THOUSANDS OF CASES OF THIS ISSUE ALL OVER THE INTERNET.

AT 9:20 MONDAY MORNING 6/25/18 MY 2006 F-150 HAD BEEN SITTING STATIONARY, UNOCCUPIED AND TURNED OFF FOR 3 AND HALF HOURS. I WAS WAKEN UP BY MY WIFE TELLING ME MY TRUCK WAS ON FIRE. THE FIRE HAD BREACHED THROUGH THE HOOD AND CONTAINED TO THE ENGINE COMPARTMENT. I HAD NO PRIOR TROUBLE TO THE OPERATION OF MY TRUCK THAT WOULD INDICATE A PROBLEM. THE FIRE DESTROYED ENTIRE FRONT OF TRUCK.

AIR CONDITIONING CONDENSATION DRIPS DOWN INTO #4 CYLINDER CAUSING A MISFIRE

MY HUSBAND WAS BACKING OUT OF OUR DRIVEWAY AND HAD SUDDEN ACCELERATION THAT SPUN HIM UP ONTO THE LAWN AND FINALLY THE VEHICLE WAS STOPPED AFTER HITTING OUR HOUSE AND GOING THROUGH THE WALL. THE TRUCK STOPPED WITH THE BACK WHEELS INSIDE THE HOUSE WITH THE ENGINE CONTINUING TO REV.

THE MECHANIC SAID I NEED TO REPLACE MY TRANSMISSION, IT IS AN AUTOMATIC 4.6L MOTOR AND DOES NOT GET 4RD OR 4TH GEAR. MY VEHICLE WAS IN MOTION AND WHEN IT REACHED 40MPH IT WOULD NOT GO I HAD TO SWITCH TO 2ND GEAR.

BOUGHT A USED FORD F 150 WITH 65700 MILES IN APRIL 2011. AFTER 7 YEARS AND ONLY PUTTING ON 34700 MILES THERE IS A LOUD TICKING COMING FROM THE ENGINE. IT HAS GOTTEN SO BAD THAT THE TRUCK ENGINE LOOSES POWER AND WHEN IT DOES HAVE SOME POWER IT FEELS LIKE THE WHOLE FRONT SHAKES AS IF THE TIRE IS COMING OFF. FORD STATES THE ENGINE SHOULD BE REPLACED OR SOME OTHER PROBLEMS THAT SEEM TO BE INHERENT WITH THE 5.4 AND NO WAY IS FORD EVEN WANTING TO FIX

TL* THE CONTACT OWNED A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT LOST CONTROL OF THE VEHICLE DUE TO A PATCH OF ICE. AS A RESULT, THE VEHICLE WAS INVOLVED IN A FRONT END COLLISION WITH A GUARDRAIL. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO AUTOMAX FORD (3301 E CENTRAL TEXAS EXPY, KILEEN, TX), BUT THEY REFUSED TO DIAGNOSE THE VEHICLE. THE VEHICLE WAS DEEMED DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THERE WERE NO INJURIES. THE APPROXIMATE FAILURE MILEAGE WAS 117,000. THE VIN WAS NOT PROVIDED. *TT *TR

PULLING UP TO A STOP SIGN AND THE TRUCK ACCELERATED ON ITS OWN. APPLIED BRAKE AND PLACED IN NEUTRAL. ENGINE REVVED THEN ACCELERATION STOPPED FOR A FEW SECONDS THEN ENGINE REVVED AND PEGGED THE RPM GAUGE. HAD TO TURN TRUCK OFF TO GET ACCELERATION TO STOP.

THE VEHICLE THAT IS TALKED ABOUT IN THIS IS A 2006 FORD F-150 THAT RECENTLY WENT IN FOR AN ANNUAL NYS SAFETY INSPECTION AND FAILED DUE TO AN EXCESSIVELY RUSTED FRAME THAT RESULTED IN CRACKS ON BOTH FRAME RAILS. THIS TRUCK HAS ONLY ~50,000 MILES AND IT IS UNKNOWN HOW LONG THE FRAME HAS ACTUALLY BEEN CRACKED AND STILL DRIVEN.

TRANSMISSION HAS A DELAY SHIFTING OR KIND OF GET STOCK THE TRANSMISSION WAS REPLACED AT 80000 MILES AND DOING IT AGAIN

SMART JUNCTION BOX FAILED. CAUSING INTERIOR, DASH AND BACK LIGHTS NOT TO LIGHT AND INCLUDING THE HORN NOT TO WORK. WHEN TRYING TO REPLACE THE FUSE IT WOULD BLOW THE FUSE AND SMOKE. IT IS IN THE SHOP NOW TO HAVE THE SMART JUNCTION BOX REPLACED. FUSES STARTED BLOWING. AT FIRST IT WAS THE RADIO AND THE FUSE WAS REPLACED THEN THE OTHERS STARTED TO BLOW.

MY TRUCK CAUGHT ON FIRE YESTERDAY. DUE TO A HEAT SHIELD MISSING OVER PASSENGER SIDE CATALYTIC CONVERTER CAUSED THE PLASTIC GROMMETS THAT HOLD THE SOUND BARRIER MATERIAL ON THE FLOORBOARD TO DROP AND HANG ON TOP OF THE CATALYTIC CONVERTER UNTIL THE MATERIAL CAUGHT ON FIRE. MY INSURANCE COMPANY IS STILL INVESTIGATING HOW THE CATALYTIC CONVERTER HEAT SHIELD WAS MISSING. LESS THAN A MONTH AFTER I BOUGHT THE TRUCK AND IT WAS USED, THEY HAD TO DO SERVICE WORK ON IT BECAUSE I PURCHASED THE TRUCK WITH A BROKEN FRONT COIL SPRING AND THE TRANSMISSION DIPSTICK TUBE HAD ROTTED. EVEN THOUGH THE TRUCK WAS MISSING A HEAT SHIELD, I BELIEVE THERE SHOULD BE ANY KIND OF FLAMMABLE MATERIAL NEAR THE CATALYTIC CONVERTER JUST IN CASE A HEAT SHIELD HAPPENS TO ROT AND FALL OFF OR FOR ANY REASON THE HEAT SHIELD IS MISSING .THE FIRE TRAVELED THROUGH THE MATERIAL ALMOST TO THE TOP OF MY ENGINE. AFTER I GOT THE FLAMES OUT IT WAS STILL SMOLDERING AND SMOLDERED UP INTO A SPACE I COULD NOT REACH TO NOR SEE. I ALSO BELIEVE A FIRE RETARDANT SYSTEM SHOULD BE CREATED TO DOUSE FLAMES IN A SECTION OF AN ENGINE COMPARTMENT THAT CANNOT BE REACHED AND WOULD PROBABLY SAVE COUNTLESS LIVES PROPERTY AND INVESTED MONEY INTO VEHICLE AND OTHER THINGS THAT A VEHICLE ON FIRE COULD DESTROY.

TL* THE CONTACT'S HUSBAND OWNED A 2006 FORD F-150. WHILE DRIVING 70 MPH, ANOTHER VEHICLE DROVE IN FRONT OF THE CONTACT. THE CONTACT CRASHED INTO THE OTHER VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE HEAD AND THIGHS THAT REQUIRED MEDICAL ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A SALVAGE YARD. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER AND THE DEALER WERE NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 202,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STARTED TO MISFIRE. THE CONTACT NOTICED CARBON BUILD UP ON THE SPARK PLUG HEAD, WHICH CAUSED IT TO CEMENT ONTO THE ENGINE. THE VEHICLE WAS TAKEN TO FORD OF HONOLULU (1370 N KING ST, HONOLULU, HAWAII, 96817, PHONE NUMBER: (808) 824-3981) WHERE IT WAS DIAGNOSED THAT A "CRAPPY" DESIGN WAS ON THE SPARK PLUG THAT NEEDED TO BE REPLACED. THE DEALER REPLACED ALL FOUR SPARK PLUGS, BUT FRACTURED ONE OF THEM. THE CONTACT WAS INFORMED THAT HE WOULD HAVE TO PAY TO REPLACE THE FRACTURED SPARK PLUG. THE SPARK PLUG WAS NOT REPLACED DUE TO THE REPLACEMENT FEE. THE MANUFACTURER WAS CONTACTED AND REFERRED THE CONTACT TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING VARIOUS SPEEDS OR WHEN THE VEHICLE WAS STARTED, THE REDUCED POWER ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER (MULLINAX FORD OF CENTRAL FLORIDA, 1551 E SEMORAN BLVD, APOPKA, FL 32703) WHERE IT WAS DIAGNOSED THAT THE COOLANT PIPE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AT 800-392-3673 AND STATED THAT THE CONTACT NEEDED TO CALL NHTSA. A CASE NUMBER WAS NOT PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 134,600.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 08V208000 (SERVICE BRAKES, HYDRAULIC); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE AUTO NATION FORD DEALER WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 144,000. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHEN THE CONTACT ATTEMPTED TO SHIFT OUT OF THE PARK POSITION AT A CAR WASH, THE VEHICLE ACCELERATED OUT OF CONTROL. THE VEHICLE CROSSED THE ROAD, WENT INTO AN APARTMENT COMPLEX, AND CRASHED INTO A CONCRETE BLOCK. ALL FOUR TIRES WERE FLATTENED. THERE WERE NO WARNING INDICATORS ILLUMINATED. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE DEALER (SABINE RIVER FORD IN ORANGE, TEXAS) WAS CONTACTED AND STATED THAT THERE WAS NO RECALL AND THAT THE FAILURE WAS UNUSUAL. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE MANUFACTURER PLACED THE CONTACT ON HOLD FOR TWENTY-FIVE MINUTES AND DID NOT RETURN TO THE PHONE. THE FAILURE MILEAGE WAS 112,000.

BOUGHT 2006 FORD F150 HAD FOUR GENERAL TIRES ON IT AMERITRACK TR. P255/70R17 STARTED TO NOTICE AFTER A WEEK OF DRIVING TRUCK THERE WAS SO MUCH SHAKING AND VIBRATIONS WHILE DRIVING EVEN WHILE UNDER THE SPEED LIMIT .CHECKED TIRES TO MY SHOCK THE RUBBER WAS SPLITTING AND RUBBER WAS CRUMBLING APART RAN MY HANDS OVER TIRE AND COULD PLUCK PIECES OF RUBBER READY TO FALL OF WITH THE STRENGTH OF 2FINGERS

FORD F150 XLT 2006 SHOULD HAVE A MANDATORY SAFETY RECALL FOR THE FUEL CONTROL MODULE. THIS IS CLEARLY A DESIGN DEFECT AND A MAJOR SAFETY CONCERN. I WAS DRIVING DOWN VT116 (A HILLY, WINDING 2 LANE COUNTRY HIGHWAY WITH NO SHOULDER) IN THE RAIN AT ABOUT 40MPH WHEN MY TRUCK STARTED TO BUCK AND LOSE POWER. THERE WAS NO PLACE TO PULL OVER, SO I PUT MY HAZARDS ON AND TRIED TO LIMP IT TO A SAFE PLACE TO PULL OVER. THE ENGINE STALLED AND I LOST STEERING AND BRAKING POWER ON A CURVE. I APPLIED THE BRAKES MANUALLY AND WRESTLED THE STEERING WHEEL (WHICH NO LONGER HAD ANY POWER ASSIST). WITH MAJOR DIFFICULTY, I WAS ABLE TO BRING THE TRUCK TO A CONTROLLED STOP. I WAS THEN ABLE TO RESTART THE ENGINE, LIMPED ALONG AT 15MPH, BUCKING AND STALLING 3 MORE TIMES BEFORE GETTING TO A SAFE PLACE TO PULL OVER. THIS IS THE SECOND TIME I HAVE HAD MY FCM REPLACED (PRIOR WAS 1/5/2013) AND THE SECOND TIME I ALMOST CRASHED MY TRUCK BECAUSE OF THIS DEFECT. THE PREVIOUS TIME WAS JANUARY 2013 ON A MOUNTAIN ROAD IN WINTER ON SNOW. IF I WAS TOWING MY BOAT ON THE INTERSTATE AND LOST ALL POWER, I WOULD PROBABLY HAVE BEEN KILLED ALONG WITH ANYONE AROUND ME. WHY IS IT A DESIGN DEFECT? BECAUSE THIS ELECTRONIC COMPONENT IS INSTALLED IN A WEATHER-EXPOSED AREA ABOVE THE SPARE TIRE AND IS NOT CORROSION-PROOF. IN ANY RUST BELT STATE (OR A PLACE EXPOSED TO SALT), THE CASE WILL CORRODE, EXPOSING THE CIRCUIT BOARD TO WATER, CAUSING THE UNIT TO FAIL. WHY IS IT A SAFETY CONCERN? BECAUSE WHEN THE FCM FAILS, THE ENGINE WILL STALL, CAUSING A LOSS OF POWER TO THE STEERING AND BRAKING SYSTEMS. NHTSA SHOULD FORCE FORD TO DO A MANDATORY RECALL AND REDESIGN THIS POORLY DESIGNED PART. EVEN THE REPLACEMENT PARTS FAIL AFTER A FEW YEARS. CONSIDERING HOW MANY F150'S ARE ON THE ROAD AND HOW MANY OF THEM CARRY OR TOW HEAVY LOADS, I'D SAY THIS SHOULD BE A TOP PRIORITY FOR BOTH FORD AND NHTSA. RECALL!

TL* TAKATA RECALL. THE CONTACT OWNED A 2006 FORD F-150. WHILE DRIVING DURING INCLEMENT WEATHER (DOWNPOUR), THE VEHICLE HYDROPLANED AND FLIPPED OVER SEVERAL TIMES. THE VEHICLE ALSO WENT INTO A DITCH, WHICH IMPACTED THE FRONT AND REAR OF THE VEHICLE. THE STEERING WHEEL BENT IN HALF AND FRACTURED INTO THE ENGINE OFF OF THE MOUNTING BOLTS. NONE OF THE AIR BAGS DEPLOYED. THE CONTACT SUSTAINED BACK PAINS, HEAD INJURY, AND LEG PAINS, WHICH REQUIRED MEDICAL TREATMENT. THE VEHICLE WAS TOWED BY THE INSURANCE COMPANY WHO INDICATED THAT THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED. THE INSURANCE COMPANY PROVIDED NO REASON AS TO WHY THE AIR BAGS FAILED TO DEPLOY. THE DEALER STATED THAT THERE WERE NO AIR BAG RECALLS. THE MANUFACTURER WAS NOTIFIED AFTER THE CRASH HAPPENED TO DETERMINE IF THEY MAY BE ABLE TO INVESTIGATE THE FAILURE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

MY ABS BRAKE SYSTEM FAILED. THE LIGHT FOR ABS CAME ON AND THE BRAKES FAILED TO INGAGE ON A DRY ROAD. I HAD TO VEAR OFF THE ROAD TO AVOID ANOTHER TRUCK MAKING A TURN. THIS HAPPENED AGAIN WITH A CAR INFRONT OF ME, BEFORE I GOT HOME AND PARKED THE TRUCK. THE BRAKES SHUTTER ON PRESSING THEM AND THEN FAIL TO INGAUGE. I HAD THE PROBLEM FIXED IN GOODYEAR AZ AT THE FIRD DEALER FOR OVER 800 DOLLARS AND NOW THE PROBLEM BEGAN AGAIN. I LIVE IN LAKESIDE ARIZONA AND CANT DRIVE THE TRUCK BACK TO THAT DEALER WITHOUT FEAR OF DYING ON THE SIDE OF A CLIFF IR IN A BAD ACCIDENT BECAUSE MY BRAKES FAIL TO STOP THE VEHICLE AND BRAKES ARE NEEDED TO GO THROUGH THE MOUNTSINS TO GET TO THAT DEALER. VERY UPSET THAT I BOUGHT THIS TRUCK FROM CACTUS JACKS IN PHOENIX AZ. 560 DOLLARS A MONTH FOR A TRUCK I CANT DRIVE FOR MY SMALL FARM. I WOULD LIKE TO TRADE IN TBIS TRUCK FOR ONE I CAN TRUST THAT WONT BE THE DEATH OF ME OR MY FAMILY.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 45 MPH, THE FRONT OF THE VEHICLE SHOOK VIOLENTLY, THE ENGINE NEARLY STALLED AND LOST POWER REPEATEDLY, AND THE CHECK ENGINE INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE ALSO BRAKED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN UNCERTIFIED MECHANIC WHO DIAGNOSED THAT THE ENGINE WAS HAVING MULTIPLE MISFIRES, AND DID NOT KNOW HOW TO REPAIR THE VEHICLE. THE CONTACT ALSO CALLED A DEALER WHO WAS EXTREMELY RUDE AND DID NOT ASSIST. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CONTACT WAS INFORMED THAT THEY WOULD NOT ASSIST BECAUSE THE CLAIMS DEADLINE HAD BEEN MISSED. THE APPROXIMATE FAILURE MILEAGE WAS 128,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, THE AIR BAG WARNING LIGHT ILLUMINATED. THE WARNING LIGHT FLICKERED INTERMITTENTLY AND THEN REMAINED ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.

FUEL PUMP CONTROL MODULE CORROSION CAUSING ENGINE TO STALL AND NOT RESTART WHILE DRIVING ON SECONDARY ROAD. *TR

TL* THE CONTACT OWNED A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 5 TO 6 MPH AND TURNING LEFT, THE VEHICLE SLID ON WET PAVEMENT AND CRASHED INTO A WALL. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT WAS INJURED AND REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED AND TOWED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

WAS DRIVING MY 2006 F-150 OVER A MOUNTAIN PASS IN CANADA. THERE WAS COMPACT SNOW AND ICE ON THE ROADWAY AND I WAS TRAVELING WITH OTHER VEHICLES AROUND ME AT APPROXIMATELY 40 MPH. THE VEHICLES AHEAD OF ME BEGAN TO BRAKE, I AS WELL TRIED TO BRAKE ONLY TO FIND MY TRUCK HAD LOST POWER AND WAS NO LONGER RUNNING. I HAD LOST POWER TO MY BRAKES AND STEERING. THIS CAUSED MY TRUCK TO BEGIN SLIDING ON THE SNOW AND ICE AND I WAS UNABLE TO CONTROL MY VEHICLE. THE CARS AROUND ME WERE SLOWING AND STOPPING AND I COULD NOT. I BEGAN TO FISH TAIL IN BOTH DIRECTIONS WHILE TRYING DESPERATELY TO CONTROL MY TRUCK WITH NO BRAKES OR POWER STEERING, I EVENTUALLY DID A COMPLETE 360 DEGREE SPIN AND SOMEHOW MANAGED TO GET THE TRUCK UNDER CONTROL WITH OUT ROLLING OVER AND INTO THE DITCH OR SMASHING INTO THE OTHER VEHICLES AROUND ME. WHEN I CAME TO A STOP MY TRUCK WAS NOT RUNNING AND THE DASH LIGHTS WERE ON. I PLACED THE TRANSMISSION INTO DRIVE AND RESTARTED THE TRUCK WITHOUT ISSUE AND CONTINUED ON WITHOUT ISSUE. THIS IS THE SECOND TIME THIS HAS HAPPENED WITH THIS TRUCK, THE FIRST TIME I WAS ON A RESIDENTIAL STREET AND I WAS ABLE TO JUST COAST TO A STOP AND RESTARTED THE TRUCK. THIS LAST INCIDENT ON THE MOUNTAIN PASS HAS CONFIRMED TO ME THAT I WILL NOT OWN ANOTHER FORD AS I HAVE RESEARCHED THIS PROBLEM TO FIND THAT THIS IS A COMMON ISSUE WITH FORD TRUCKS. I AM CERTAIN THIS HAS CAUSED MAJOR ACCIDENTS IF NOT DEATHS AND THE FACT THERE ARE NO ERROR CODES LEFT BEHIND FROM THE EVENTS TO VERIFY THIS HAS HAPPENED WE MAY NEVER KNOW. THE FACT IT HAS HAPPENED TO ME TWICE AND ONCE ONLY A MIRACLE A SERIOUS ACCIDENT DIDN'T OCCUR I AM DONE WITH THE FORD MOTOR COMPANY. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. AFTER TAKING THE VEHICLE TO A DRIVE THRU CAR WASH SERVICE, WATER ENTERED THE PASSENGER SIDE. THE INTERIOR OF THE PASSENGER SIDE BECAME WET AND THE AIR BAG WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.

I WAS DRIVING ON THE ROAD WHEN THE "ENGINE FAILSAFE WARNING' LIGHT CAME ON. THE ENTIRE ENGINE SHUT DOWN. NO POWER AT ALL. VERY HARD TO STOP AND STEER. I NEARLY GOT INTO AN ACCIDENT. ANOTHER TIME I WAS ENTERING PARKING LOT WHEN IT HAPPENED. I HAD THE THROTTLE BODY REPLACED TO FIX THE PROBLEM. BUT SHUTTING OFF THE ENGINE ON A WARNING WHILE DRIVING IS VERY DANGEROUS. SOME INTERNET RESEARCH INDICATES THIS IS NOT A LONE OCCURRENCE.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WOULD SHOOK WHENEVER THE VEHICLE WAS IDLING. THE SHAKING INCREASED DURING ACCELERATION. THE CONTACT TOOK THE VEHICLE TO A DEALER WHO WAS UNABLE TO IDENTIFY THE CAUSE OF THE FAILURE, BUT INFORMED THE CONTACT THAT THE SHAKING WAS A COMMON ISSUE WITH THE YEAR, MAKE, AND MODEL. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.

TOOK TRUCK IN FOR ROUTINE 100,000 MAINTENANCE AND TUNE UP. SPARK PLUG STUCK IN THE CYLINDER HEAD AND ENDED UP GETTING CHARGED $3,500 FOR THE REPAIR. I AM READING ONLINE OF HOW WIDESPREAD THIS PROBLEM IS AND FORD SHOULD RECALL THESE SPARK PLUGS AND TAKE CARE OF THEIR CUSTOMERS. I WILL NEVER PURCHASE ANOTHER FORD IN MY LIFETIME IF THEY DON'T DO SOMETHING ABOUT THIS.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 8 MPH, THE VEHICLE STALLED WITHOUT WARNING AFTER A SHARP RIGHT TURN. THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO BE REPAIRED, BUT THE ISSUE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 158,818.

POWER STEERING HOSE RUST AND LEAKING-TRANSMISSION HOSES RUSTED AND LEAKING - SPARK PLUG BREAKING OFF WHEN HAVING THEM REPLACED

WAS SITTING AT A RESTAURANT DRIVE THRU WITH FOOT ON THE BRAKE WHEN THE BRAKE PEDAL SUDDENLY WENT TO THE FLOOR AND THE TRUCK STARTED MOVING. I WAS ABLE TO GET THE VEHICLE HOME AND BACK TO THE FORD DEALERSHIP THE NEXT MORNING VERY CAREFULLY AND BY PUMPING THE BRAKES TO GET THE VEHICLE TO STOP. WAS TOLD THAT THE BRAKE LINE HAD RUPTURED. LUCKILY, I WAS NOT TOWING MY 6000 POUND BOAT OR GOING DOWNHILL AT THE TIME OF THE FAILURE. I ASKED IF THIS WAS COMMON SINCE BRAKE LINES ARE NOT AN ITEM THAT ARE ROUTINELY INSPECTED OR REPLACED ON A NORMAL 17 POINT INSPECTION. I WAS TOLD THAT IT WAS UNCOMMON. I GOOGLED THE PROBLEM AND DISCOVERED THAT SEVERAL OTHER FORD F150 OWNERS OF VARIOUS MODEL YEARS HAD EXPERIENCED THE SAME ISSUE. LUCKILY, THERE HAVE BEEN NO REPORTS OF DEATHS OR SEVERE INJURY, BUT I AM REPORTING THIS TO HOPEFULLY PREVENT A DEATH FROM OCCURRING.

VEHICLE JERKED WHEN DRIVING DOWN HIGHWAY WHEN YOU REACH 45 TO 50 MPH. I WOULD LET OFF GAS AND THEN GIVE IT GAS AGAIN AND IT WOULD NOT JERK. CHECK ENGINE LIGHT APPEARED SO I TOOK IT TO FORD DEALERSHIP AND THEY RUN A CHECK . TOLD ME I NEED ANOTHER MOTOR. THIS TRUCK HAS 154000MILES. IT HAS NOT OVERHEATED.

I JUST HAD MY TRUCK SERVICED AT SAYVILLE FORD & THEY FOUND TWO BROKEN FRONT SPRINGS. THE TRUCK HAS 142000 MILES. I CANT FIND ANY RECALL INFO ON NHTSA. CAN YOU ADVISE ME IF THIS IS A CURRENT PROBLEM BEING INVESTIGATED?

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 15 MPH, THE VEHICLE MADE A LOUD POPPING NOISE AND THE INSTRUMENT PANEL BECAME INOPERABLE. IN ADDITION, THE REAR WINDOWS AND POWER LOCKS FAILED TO OPERATE AND THE VEHICLE STALLED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 55 MPH, TWO DEER JUMPED IN THE MIDDLE OF THE ROAD. THE CONTACT SLAMMED ON THE BRAKE PEDAL TO AVOID THE ANIMALS. AS A RESULT, THE VEHICLE DROVE INTO A DITCH AND ROLLED OVER THREE TIMES. NONE OF THE FRONTAL AIR BAGS DEPLOYED. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS TOWED AND WAS BEING EVALUATED BY THE INSURANCE COMPANY. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 114,000.

TOOK IN FOR A TUNE UP. BROKE OFF 7 SPARK PLUGS. GOT PIECE IN ENGINE. HAD TO TAKE ENGINE APART. TUNE UP WAS TO BE $535. NOW IT IS $2300.00

AFTER COUNTLESS HOURS SPENT DIAGNOSING A DASH BRAKE LITE WARNING. THESE VEHICLES FACTORY DEFECT IS THE ELECTRONICS BOARD OR SPEEDOMETER CLUSTER. COUNTLESS PEOPLE ARE DRIVING WITH A BRAKE LIGHT ON WITH NOTHING POSSIBLY WRONG.WHEN SOMETHING DOES GO WRONG THEY MAY NOT HAVE A CLUE UNTIL THE VEHICLE HAS NO BRAKES.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE THE VEHICLE WAS PARKED WITH THE BRAKE PEDAL DEPRESSED, THE VEHICLE SPONTANEOUSLY ACCELERATED WHEN PLACED IN REVERSE. THE ACCELERATION LASTED FOR APPROXIMATELY 30 SECONDS. THE FAILURE RECURRED, BUT WHILE IN FORWARD GEAR APPROXIMATELY THREE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY COULD NOT DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 31,000.

ON NOVEMBER 16,2011 I WAS ON MY WAY TO SEE MY MOTHER WHO PASSED AWAY AND WHILE DRIVING IT SOUNDED LIKE A BOMB WENT OFF AND I HAD VEHICLE TOWED AND IT WAS SPARK PLUG ISSUE, THEN TWO YEARS LATER IT HAPPENED AGAIN, I CHANGED ON PLUGS AND COIL PACKS AT GARAGE, NOW TWO YEARS LATER ANOTHER 3RD PLUG BREAKS INTO ENGINE, NOW IN NEED OF NEW ENGINE. MILES ARE OVER CLASS ACTION SUIT BUT NOT BY MANY. MY TRUCK IS WORTHLESS FOR FORDS LACK OF FIXING THIS ISSUE. I DO HAVE DOCUMENTS TO SHOW. THIS PROBLEM IS A REPEATED ISSUE AND END RESULT FOR THEM NOT TO RECALL ISSUE SOONER HAS ENDED WITH A NONE WORKING TRUCK ENGINE.

STEERING BECAME INTERMITTENTLY STIFF WHILE DRIVING. TRUCK HAD ABOUT 80000 MILES ON IT AND 9 YEARS OLD WHEN SYMPTOMS STARTED. STIFFNESS WOULD OCCUR SOMETIMES AT HIGHWAY SPEEDS WHEN I STARTED A LANE CHANGE, AND AT SLOW SPEEDS WHEN I WAS TURNING (FOR INSTANCE ON COMMUNITY STREETS). AS I WAS TURNING IT WOULD CYCLE FROM HARD TO REGULAR EFFORT, AS WOULD BE IF A UNIVERSAL JOINT WAS GOING BAD. MY NON-FORD MECHANIC DIAGNOSED IT AS A BAD LOWER STEERING SHAFT. I INSPECTED THE BAD SHAFT AND AGREED THAT ONE UNIVERSAL SHAFT WAS TIGHT AND THE OTHER WAS EXTREMELY TIGHT. $557 REPAIR.

TRUCK HAS ~116000 MILES. ENGINE RANDOMLY DIES WHILE IN MOTION (15 - 50 MPH) AND WHILE IDLING AT A STOP. NO POWER BRAKES OR STEERING UNTIL ENGINE IS RESTARTED. HAS OCCURRED DRIVING DOWN THE HIGHWAY AND IN THE CITY. MAINLY OCCURRED GOING STRAIGHT (NOT TURNING). IMMEDIATELY RESTARTS. NO ENGINE CODES OR CHECK ENGINE LIGHT. CAUSE UNKNOWN. THROTTLE BODY REPLACED WITHOUT FIXING CONDITION. "WRENCH" SYMBOL ON DRIVER DISPLAY HAS BEEN ON FOR A WHILE BUT CONDITION JUST STARTED.

ON 3 OCCASIONS MY VEHICLE ,OVER 4 MONTHS, HAS HAD A COMPLETE ENGINE FAILURE. THIS OCCURRED MOST RECENTLY WHILE I WAS EXITING THE INTERSTATE .WHEN THE ENGINE SHUTS DOWN SO DOES THE DASH AND BRAKE LIGHTS, IT ALSO STOPS POWER STEERING AND BRAKES. THIS TIME BY REACTING QUICKLY I WAS ABLE TO PUT THE VEHICLE IN NEUTRAL AND RESTART ,AFTER TURNING KEY TO OFF POSITION FIRST.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT WAS UNABLE TO LATCH THE FRONT DRIVER'S SEAT BELT. WHEN DRIVING ALONE, THE CONTACT WOULD LATCH HIS SEAT BELT INTO THE PASSENGER SIDE BUCKLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 135,000.

THE STEERING WHEEL FREEZES UP IN COLD WEATHER. MY MECHANIC DIAGNOSED A FAILED LOWER STEERING COLUMN THAT IS EXPOSED TO ROADWAY SPLASH AND CORROSION. THIS IS ALSO A TELESCOPING SECTION OF THE STEERING COLUMN DESIGNED TO PROTECT THE DRIVER IN CASE OF FRONTAL CRASH. SO OVERNITE IT FREEZES UP AND SLOWLY LOOSENS. WHILE DRIVING BECOMES STIF AND RESULTS IN DIFFICULT STEERING. 45,000 MILES ON ODOMETER.

DROVE F-150 NORMALLY DURING WEEK. ON WEEKEND MORNING WHILE PULLING OUT OF DRIVEWAY STEERING WHEEL SUDDENLY AND SPORADICALLY BEGAN RESISTING EFFORT TO TURN CAUSING TRUCK TO SWAY UNPREDICTABLY DURING TURNS. RESISTING DRIVER INPUT. WAS TOO DANGEROUS TO DRIVE. AFTER REVIEWING BLOGS ONLINE I REALIZED A LOT OF OTHER PEOPLE WHO DRIVE THIS ERA F-150 HAVE THE SAME PROBLEM. IT TURNS OUT THE LOWER STEERING COLUMN SHAFT CONTAINING THE U-JOINTS USES DEFECTIVE MATERIALS OR HAS BAD DESIGN. THE U-JOINTS ARE BINDING UP DURING DRIVING CAUSING THE DRIVER TO LOSE PARTIAL CONTROL OVER DIRECTION OF VEHICLE. TEMPORARY FIX MAY BE TO SPRAY WITH ANTI-CORROSIVE SPRAY, THEN LUBRICATING SPRAY, WHICH I DID. THIS LASTS ONLY A SHORT TIME SO THE LOWER SHAFT WITH U-JOINTS MUST BE REPLACED. FORD KNOWS OF THE DEFECT FOR THIS ERA F-150 AND HAS REDESIGNED THIS LOWER SHAFT TO ELIMINATE THE BINDING. THIS NEW DESIGN IS WHAT THEY SELL YOU AS A REPLACEMENT, NOT THE ORIGINAL DESIGN. IF YOU TRY TO BUY ONE ONLINE IT COSTS AT LEAST $245 FOR THE O.E.M. PART. IF YOU BUY ONE OF THE 2 AFTERMARKET KNOCKOFFS IT'LL SET YOU BACK APPROX $125. THE AFTERMARKET SHAFT ADVERTISING TOUTS THE FACT THAT IT HAS A DESIGN THAT WILL NOT BIND LIKE THE ORIGINAL FORD SHAFT DOES. THIS TRUCK HAD APPROX 69,700 MILES ON IT WHEN THE SHAFT BEGAN BINDING UP.

I HAVE A 2006 F-150 V8 4.6 THE HEATER COIL IN THE TRUCK HAS FAILED. AND THE WATER PUMP ALSO

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE REAR PASSENGER AND DRIVER WINDOWS WERE LEAKING DURING INCLEMENT WEATHER. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.

LAST WEEK I STARTED NOTICING MY STEERING STARTING TO GET STIFF AND THE WHEEL DOES NOT RECENTER AFTER A STEER TO THE LEFT OR RIGHT. IVE HAD TO DO SOME QUICK MUSCLING TO RECENTER THE WHEEL. I'VE JUST FINISHED RESEARCHING SOME OTHER FORD FORUMS FOR THIS VEHICLE AND MANY OWNERS HAVE REPORTED THE SAME ISSUE WITH THE U JOINTS ON THE STEERING COLUMN RUSTING OR SEIZING. I WILL TRY SPRAYING SOME ANTI SEIZE ON THE U JOINTS TOMMOROW UNTIL I CAN GET IT TO A GARAGE.MY TRUCK HAS APPROXIMATELY 103,000 MILES ON IT . THIS IS DANGEROUS AND WITH THE AMOUNT OF COMPLAINTS ON THIS IT SHOULD BE RECALLED BY FORD TO CORRECT.

LAST WEEK TRUCK SUDDENLY BECAME VERY HARD TO TURN GOING AROUND CORNERS. STEERING WHEEL LOCKED UP AND I ALMOST WENT OVER AN EMBANKMENT. HIT OR MISS SO I NEVER KNOW WHEN IT WILL GO OUT. THANKFULLY DID NOT HAVE MY 2 YOUNG CHILDREN! A WEEK LATER (11/29/15), TRUCK SUDDENLY STARTS TO VIOLENTLY SHAKE IF I GO OVER 50 MPH! SCARED THE DICKENS OUT OF ME! HOPING TO LIMP IT TO A DEALERSHIP AND TRADE IT IN. NOT SAFE FOR ME TO DRIVE. I HAVE PUT 20K MILES ON IT IN 2 YEARS AND HAS BEEN REGULARLY SERVICED. WHAT GIVES?!?

MY STEERING STARTED TO BIND WHILE DRIVING . COULD NOT MAKE FULL RIGHT OR LEFT TURNS. VERY UNSAFE. THE TRUCK HAS LEFT THAN 30,000 MILES. RARELY DRIVEN.

WHILE DRIVING INSTRUMENT PANAL SHUTS DOWN, RADIO SHUTS OFF, AIRBAG INDICATOR COMES ON, WINDOWS DON'T WORK, IF SHUT OFF LASTS MORE THAN 5 MINUTES SEAT BELT CHIME GOES OFF, TWICE WORD TEST CAME ON IN MILEAGE INDICATOR WINDOW. SOMETIMES GOES ON AND OFF WHILE TURNING OR HITTING BRAKES, OTHER TIMES JUST WHILE DRIVING.

CYLINDER #4 BLEW THE SPARK PLUG OUT, STRIPPING THE THREADS AS IT WENT. THIS IS THE 2ND CYLINDER TO DO THIS IN 6 MONTHS. WHILE DRIVING AT 45 MPH.

WHILE MY VEHICLE WAS IN THE SHOP FOR A FOUR WHEEL ALIGNMENT THE MECHANIC NOTED THAT THE U-JOINT IN INTERMEDIATE STEERING SHAFT IS GOING BAD AND THEREFORE THE REASON THERE IS SOME PLAY IN THE STEERING WHEEL. COST TO REPAIR IS GOING TO BE APPROXIMATELY $700

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE BRAKE PEDAL EXCESSIVELY ABNORMALLY TRAVELED TO THE FLOORBOARD. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS INFORMED THAT THE VEHICLE WAS FUNCTIONING AS DESIGNED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 200. UPDATED 1/12/2016 *CN THE CONSUMER STATED WHEN HE ATTEMPTED TO BRAKE, HIS FOOT ALSO HIT THE ACCELERATOR PEDAL. THE CONSUMER STATED THE BRAKE AND ACCELERATOR WERE TOO CLOSE TOGETHER. UPDATED 05/04/16

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING 35 MPH AND COMING TO A COMPLETE STOP, THE REAR DRIVER SIDE TIRE SEPARATED AND ROLLED INTO TRAFFIC. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE REAR ROTOR AND STUDS FAILED AND NEEDED TO BE TIGHTENED. THE CONTACT ALSO STATED THAT HE HAD TO ALSO REPLACE THE STEERING RACK AND PINION DUE TO THE FAILURE. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 136,000.

SPARK PLUGS ON THE 5.3 LITER ENGINE WHEN REPLACED BREAK--IN RETURN THE BOOK SAID PULL ENGINE AND PULL HEADS TO REPLACE SPARK PLUGS. THE LAW SUIT FILLED FORD ADMITS TO BAD DECISION ON SPARK PLUGS AND WILL REIMBURSE SOME OF THE COST. THE COST IS VERY HIGH--THE BOOK AND FORD'S SHOP SAID THE ENGINE NEEDS TO BE PULLED TO PULL THE HEADS TO REPLACE THE SPARK PLUGS. THERE WAS NEVER ANY SOFTWARE UPDATES, AND NOW THE VEHICLE REQUIRES THEM. THE ERROR IN THE CLUSTER SOFTWARE RECALL WAS SUPPOSE TO BE REPAIRED AND I READ FROM THE EXPERTS ALL SOFTWARE SHOULD HAVE BEEN UPGRADED WITH THE CLUSTER ERROR. THERE ARE 42 P.M. FORD AND NHSTA KNEW OR KNOWS ABOUT ON MY VEHICLE AND NOTHING HAS BEEN DONE, I AM A 100% DAV AND MY VEHICLE HAS BEEN BROKEN DOWN. THE 2006 HARLEY DAVIDSON F-150 THAT COST SO MUCH WITH IT'S ON BOARD COMPUTER SYSTEM DOES NOT WORK. I HAVE READ MANY COMPLAINTS ABOUT THE F-150 ENGINE CUTTING OUT, I PULLED OUT TO PASS ON A TWO LANE ROAD AND ALMOST GOT KILLED WHEN MINE CUT OUT SO BAD. A TWO CYLINDER WOULD HAVE DONE BETTER THAN THAT V-8.

FACTORY WELDS ON WHEELS FAILED CAUSING RAPID LOSS OF TIRE PRESSURE. THIS HAS HAPPENED TWO DIFFERENT TIMES ON TWO DIFFERENT WHEELS.

ORIGINALLY FACTORY INSTALLED SPARKPLUG BLOWS OUT OF THE ENGINE HEAD TRAVELING AT APPROXIMATELY 35 MPH. THIS WAS DISCLOSED AFTER TAKING VEHICLE TO A FORD DEALERSHIP FOR DIAGNOSTICS AS THERE WAS A LOUD NOISE WHILE ENGINE RUNNING AND LOSS OF POWER. REPAIR COST WAS $617. DISCUSSION WITH DEALER DISCLOSES THAT THIS A WELL KNOW PROBLEM BY FORD MANAGEMENT, A TBS HAS BEEN ISSUED. FURTHER FORD HAS DENIED ANY RESPONSIBILITY AND WILL NOT PROVIDE ANY MONETARY ASSISTANCE. THIS IS A FORD CREATED DESIGN ENGINEERING DEFECT THAT FORD JUST IGNORES AND LET'S THE CUSTOMER PAY FOR ITS MISTAKE. CUSTOMER IS SUBJECT TO COST OF REPAIR THAT IS FAR FROM NORMAL WEAR AND TEAR, A SAFETY CONCERN OF FIRE IN ENGINE COMPARTMENT FROM RAW FUEL BLOWN OUT OF THE HOLE VACATED BY SPARKPLUG, A RELIABILITY ISSUE AND A SAFETY CONCERN FROM SUDDEN LOSS OF POWER. THIS PROBLEM SHOULD BE COVERED BY A FEDERAL MANDATED RECALL SINCE FORD IS MAKING THIS A CONSUMER PROBLEM IGNORING THE FACT THAT IT IS A ENGINEERING, DESIGN OR MANUFACTURING PROBLEM FOR WHICH IT REFUSES TO ACCEPT RESPONSIBILITY. IN ADDITION THE TRADE IN VALUE OF THIS VEHICLE WILL BE REDUCED BY THE FORD DEALERSHIP THAT IS AWARE OF THE PROBLEM EVAN FOR THE CUSTOMER THAT DID NOT ENCOUNTER A SPARKPLUG BLOWOUT AND AT PRIVATE SALE IF PROSPECTIVE BUYER CHECKS ON VEHICLE VIA ANY INTERNET AUTOMOTIVE SITE. AGAIN FORD LETS CONSUMER ABSORB COST OF DEFECT IT CREATED.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING AT 45 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO A MECHANIC WHERE IT WAS DISCOVERED THAT THE IGNITION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. AFTER THE VEHICLE WAS REPAIRED, THE FAILURE CONTINUED WITH A TICKING NOISE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE.

IN JUNE 2015, THE AIR BAG LIGHT IN MY FORD F150 ILLUMINATED, INDICATING A PROBLEM. I TOOK MY VEHICLE TO A FORD DEALERSHIP. THEY TOLD ME THAT THE DEPLOYABLE RESTRAINT SYSTEM, SPECIFICALLY THE PRETENSIONER, HAD MALFUNCTIONED AND POSSIBLY WOULD FAIL TO FUNCTION AS INTENDED IN THE EVENT OF A CRASH. THE SERVICE TECHNICIAN INDICATED THAT THE RESTRAINT SYSTEM IS CONNECTED TO MY AIR BAGS, WHICH MIGHT FAIL TO WORK IN A CRASH, INCREASING THE RISK OF INJURY. AFTER PAYING THE DIAGNOSTIC FEE, I WAS GIVEN A REPAIR ESTIMATE OF AN ADDITIONAL $392.21. NOT WANTING TO RISK INJURY IN THE EVENT OF A CRASH, I HAD THE PRETENSIONER REPLACED. THE BUCKLE PRETENSIONER IS A CRITICAL SAFETY DEVICE THAT SHOULD NEVER FAIL UNDER NORMAL USE. MY VEHICLE HAS NEVER BEEN IN AN ACCIDENT. IT IS MY UNDERSTANDING THAT SOME PRETENSIONERS HAVE FAILED DUE TO SIMPLE SEAT POSITION ADJUSTMENTS, WHICH, TO ME, IS EVIDENCE OF A POOR DESIGN. FORD HAS RECENTLY RECALLED MANY 2013 ' 2014 VEHICLES FOR POORLY MADE PRETENSIONERS, RECOGNIZING THE SAFETY ISSUE SURROUNDING THEM. I REQUESTED THAT FORD REIMBURSE ME FOR THE COST OF THE PRETENSIONER BUCKLE; HOWEVER, FORD DENIED THIS REQUEST. I HAVE THE ORIGINAL PRETENSIONER AND ALL RECEIPTS AVAILABLE.

MORNING OF JULY 23,2015, I WAS DRIVING ABOUT 25 MPR SPEED WHEN NUMBER THREE SPARK PLUG BLOW OUT OF THE CYLANDERHEAD ON MY F-150 TRITON V8. TOOK IT TO THE LOCAL MACHANIC SHOP WALTON'S. THREE HOURS LATER, WALTON'S HAD TO REPLACE AND RESLEEVE NUMBER THREE CYLANDERHEAD AND REPLACED ELECTRICAL SPARKPLUG WIRE, PLUS REPLACED ALL EIGHT SPARK PLUGS. ALL AT A COST OF $543.00. NOT ONLY THIS HAPPENED TO ME BUT WALTON'S STATED THAT I WAS THE 10TH PERSON THIS WEEK THIS HAS HAPPENED TOO. I PRESENTED THE PART TO MY LOCAL FORD DEALERSHIP WHERE WE BOUGHT THE TRUCK (HALL'S FORD MOTOR COMPANY) BRAND NEW IN 2006 AND PAID CASH TO THE SUM OF $30,000.00. I ASKED THEM IF THEY KNOW OF THIS PROBLEM WITH TRITON V8'S. THEY STATED THEY DID BUT NO KNOW RECALLS AND THEY TOO HAD SEVERAL REPAIRS COME IN FOR THE SAME THING IN THE PASS WEEK. THEY ALSO STATED THAT THE FORD MOTOR COMPANY WAS AWARE OF THIS MATTER BUT NEVER LET THERE CUSTOMERS KNOW ABOUT THIS PROBLEM YET BECAUSE THERE WAS NO RECALL ON FILE TO LET THEM KNOW. THIS THING WHERE THE SPARK PLUGS COME FLYING OUT OF AN ENGINE CAN BE VERY HAZARDS, IT COULD CAUSE A CRASH OR EVEN GIVE A PERSON A HEART ATTACK BECAUSE THE TRUCK SOUNDS LIKE WORLD WAR III GOING OFF UNDER THE HOOD AND IT MAY EVEN START A FIRE. THIS MATTER NEEDS TO BE TAKEN CARE OF BY FORD.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR ROUTINE MAINTENANCE. WHILE AT THE INDEPENDENT MECHANIC, THE CONTACT WAS NOTIFIED THAT SEVEN OF THE EIGHT SPARK PLUGS IN THE VEHICLE WERE FRACTURED AND NEEDED TO BE REPLACED. THE CONTACT STATED THAT ONE OF THE FRACTURED SPARK PLUGS REMAINED IN THE CYLINDER HEAD. THE MECHANIC STATED THAT THE CYLINDER HEAD HAD TO BE REMOVED FROM THE ENGINE TO REMOVE THE FRACTURED SPARK PLUG. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE; HOWEVER, THE CONTACT WAS NOT OFFERED A REMEDY FOR THE FAILURE. THE FAILURE MILEAGE WAS 84,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING AT 20 MPH, THE BRAKES AUTO ENGAGED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. UPDATED 09/03/15*LJ UPDATED 10/26/2017*CN

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE STEERING WHEEL BECAME TIGHT AND LOOSENED UP AT RANDOM TIMES WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE DRIVESHAFT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT WAS UNABLE TO SHIFT THE GEAR INTO DRIVE OR REVERSE, ONLY NEUTRAL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE CLUTCHES AND BANDS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 28,854. UPDATED 7/16/15*CN THE CONSUMER STATED THE TAIL SHAFT HOUSING HAD A HAIRLINE FRACTURE/CRACK WITH. THE REPAIRMAN BELIEVED THE PART WAS DEFECTIVE. THERE WAS NO WEAR ON THE INSIDE OF THE TRANSMISSION, BEARING OR SEALS. UPDATED 08/04/15*JB

WHILE IN PASSING LANE OF THREE LANE WEST BOUND ROUTE 3 ENGINE SHUT DOWN, HAD TO NEGOTIATE TWO LANES OF HIGHWAY TRAFFIC TO GET TO SHOULDER WHILE COASTING. VEHICLE TOWED TO REPAIR SHOP. FUEL PUMP CONTROL MODULE FAILURE. MODULE CORRODED, HOLES THRU BACK OF MODULE WHERE IT MOUNTS TO FRAME. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 10 MPH, THE DRIVE SHAFT SEPARATED FROM THE VEHICLE. THE CONTACT WHO WAS A CERTIFIED MECHANIC REPAIRED THE REAR AXLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 106,000.

2006 F-150 LOST ALL POWER FUNCTION WHILE TRAVELING DOWN THE INTERSTATE. I LOST POWER STEERING AND BRAKES. THE CAUSE IS A CORROSIVE FUEL PUMP CONTROL MODULE. AFTER TAKING WITH MY LOCAL FORD DEALER I WAS MADE AWARE THAT THIS IS MAJOR SAFETY ISSUE AND ONE THAT FMC REFUSES TO RECOGNIZE. THIS INCIDENT COULD HAVE RESULTED IN A MAJOR ACCIDENT. I WAS LUCKY ENOUGH TO BE ABLE TO SIGNAL TO THE CARS AROUND ME THAT I WAS HAVING TROUBLE - HOWEVER I WAS STILL ALMOST REAR ENDED TWICE BEFORE BEING ABLE TO PULL OFF TO THE SIDE OF THE ROAD. *TR

THE ENGINE BUCKS,MISSES AND DOESN'T COME UP TO SPEED. THERE IS NO ADVANCED WARNING AS WHEN THIS WILL HAPPEN, THUS MAKING PULLING OUT INTO TRAFFIC A HAZARD! THE GARAGE WHERE I HAD THE PROBLEM FIXED WAS SURPRISED TO HEAR MY DESCRIPTION OF MY TROUBLE. THEY HAD A F150 IN THE WEEK BEFORE WITH THE SAME ISSUE!! THIS GENTLEMAN'S TRUCK ACTUALLY SHUT OFF IN TRAFFIC,SO I CONSIDER MYSELF LUCKY! *TR

FORD'S IWE SOLENOID HAS A TENDENCY TO MALFUNCTION DUE TO A POOR DESIGN. TSB 06-8-15 WAS ISSUED TO REPLACE THESE SOLENOIDS, BUT ONLY IF THERE WAS A PROBLEM AND ONLY IF IT WAS GIVING A PROBLEM. MY VEHICLE WAS IN STORAGE FOR 5 YEARS AND AFTER IT WAS BROUGHT OUT AND TO NY, THE WATER LEAKED ON THE SOLENOID DUE TO THE INADEQUATE DESIGN, CAUSING THE IWE'S TO MALFUNCTION. I STILL DON'T KNOW WHAT EXACTLY IT DID BUT DRIVING THE CAR DOWN THE ROAD, IT CAUSED ME TO FEEL LIKE I WAS DRIVING OVER SMALL SPEED BUMPS WITH THE FRONT DRIVERS SIDE TIRE. I'M AFRAID THAT IF THIS FAILED AT A HIGH RATE OF SPEED IT COULD CAUSE THE IWE TO ENGAGE AND POSSIBLY LOCK UP ONE OF THE FRONT TIRES. *TR

VEHICLE STARTED LOSING POWER AND UNABLE TO RUN CORRECTLY. TOOK TO GARAGE AND FUEL PUMP DRIVE MODULE WAS RUSTED WITH CIRCUITS BEING EXPOSED TO THE SALT AND MOISTURE ELEMENTS WHERE THERE WAS A LARGE HOLE IN BACK OF UNIT. NEW ONE WAS INSTALLED WITH SPACERS TO HELP PREVENT SALT AND MOISTURE FROM COLLECTING WHERE BACK OF MODULE MOUNTS ONTO AXLE BRACKET. VEHICLE RAN BETTER BUT ALSO HAD TO INSTALL NEW COIL DUE TO A CYLINDER MISSING. RUNS OK WITH WORK THAT WAS PERFORMED. MODULE SHOULD NOT HAVE BEEN INSTALLED AGAINST THE BRACKET SO SALT AND MOISTURE COULD COLLECT AND RUST IT SO BADLY AND CAUSE IT TO FAIL. FORD SHOULD PAY FOR THIS REPAIR DUE TO THE WAY IN WHICH THE MODULE WAS INSTALLED SO IT WOULD RUST SO BADLY. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE FAILED TO ACCELERATE AND THE SERVICE VEHICLE WARNING INDICATOR ILLUMINATED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT A SENSOR WAS FAULTY. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 89,069. UPDATED 04/10/15*LJ UPDATED 11/5/2015*JS

NOTICED STEERING WHEEL VERY HARD TO TURN. CHECKED POWER STEERING FLUID WHICH WAS OK. RESEARCHED PROBLEM ONLINE AND FOUND DOZENS OF SIMILAR COMPLAINTS REPORTED ON FORD CUSTOMER FORUMS AND ELSEWHERE ONLINE MENTIONING THAT THE U-JOINT(S) ON THE LOWER STEERING SHAFT POSSIBLY RUST AND CORRODE AND BECOME VERY STIFF. WHEN TURNING CORNERS WHEEL DOES NOT READILY RECENTER ITSELF. FEARFUL THAT STEERING JOINTS COULD FAIL, SEIZE OR BREAK RESULTING IN A COMPLETE LOSS OF STEERING AND SERIOUS INJURY OR DEATH. SAW THAT FORD REDESIGNED THE STEERING SHAFT AFTER 2006 AND THE NEW FORD PART LOOKS MUCH DIFFERENT THAN THE ORIGINAL SHAFT IN MY 2006 TRUCK. SPRAYED SOME PENETRATING OIL ON BOTH U-JOINTS YESTERDAY AND STEERING WAS NOTICEABLY MUCH EASIER WITHIN 5 MINUTES. THEN SPRAYED SOME LIQUID WRENCH LUBRICATING OIL (LIGHTWEIGHT AEROSOL OIL) ON BOTH JOINTS AND DROVE THE TRUCK. STEERING WAS LIKE NEW AND STEERING WHEEL EASY TO TURN. DO NOT KNOW HOWEVER IF THIS "OILING FIX" WILL LAST. FORD IS AWARE OF THIS ISSUE AS THEY REDESIGNED THE STEERING SHAFT/U-JOINTS AND HAD HUNDREDS OF COMPLAINTS. DEFECT IN DESIGN OF CRITICAL STEERING COMPONENT, FORD IS AWARE AND REDESIGNED STEERING SHAFT AND U-JOINTS. NOTE: OTHER CUSTOMERS WITH NON-FORD VEHICLES AND FORD VEHICLES OTHER THAN THE F-150 HAVE REPORTED NUMEROUS SIMILAR COMPLAINTS. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 25 MPH, THE TRANSMISSION CHANGED FROM TWO WHEEL DRIVE TO FOUR WHEEL DRIVE INDEPENDENTLY. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 72,000. UPDATED 3/4/15*CN THE CONSUMER STATED THE CAUSE OF THE FAILURE WAS A FAULTY SOLENOID. UPDATED 10/15/2015 *JS

THE ENGINE BEGAN TO TICK ON TOP. LATER IT BEGAN TO TICK ON THE BOTTOM. THE ENGINE LIGHT CAME ON AND I HAD IT CHECKED. THE CODE SAID IT WAS A CAM SENSOR. AS IT TURNED OUT THE ENGINE WAS NOT GETTING THE PROPER AMOUNT OF OIL DUE TO A CLOGGED A OIL PORT RESTRICTION. END RESULT HAD TO REPLACE THE ENGINE. WHILE AT THE SERVICE CENTER ANOTHER TRUCK CAME IN WITH THE SAME PROBLEM WITH SIMILAR MILEAGE. NOW MY SON WHO HAS A 2005 FORD F150 IS EXPERIENCING THE SAME ISSUES WITH HIS TRUCK WITH 96000 MILES THAT'S THREE THAT I KNOW OF. *TR

FRONT END BUSHINGS DETERIORATION - REPLACEMENT COST ESTIMATE $750.00

THE SEAT GETS WHOLE BECAUSE OF MEDAL BAR AND NOT ENOUGH CUSHION ON THE SIDE OF IT SO CAUSES IT HOLES. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 60 MPH, THE VEHICLE STALLED. THE VEHICLE RESTARTED BUT THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP CONTROL MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 87,000. THE VIN WAS UNAVAILABLE.

VEHICLE SUDDENLY STALLED WHILE DRIVING. WAS ABLE TO COAST TO A STOP AND PULLED OVER, BUT WAS STUCK IN A BUSY INTERSECTION FOR 15-20 MINUTES BEFORE THE TRUCK WOULD RESTART. WAS ABLE TO MAKE IT TO A PARKING LOT BEFORE IT STALLED AGAIN. TOWED TO A DEALERSHIP WAS INFORMED IT WAS A CORRODED FUEL CONTROL MODULE. DOING A LITTLE RESEARCH CONFIRMED THIS IS A VERY COMMON PROBLEM AND SHOULD BE ADDRESSED AS A POTENTIALLY DANGEROUS SITUATION COULD EASILY OCCUR. *TR

WHILE DRIVING THE FORD 2006 F150 IT JUST STARTED RUNNING SLUGGISH AND STOPPED. I WAS ABLE TO GET OFF THE SIDE OF THE ROAD. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE MAKING A TURN AT AN UNKNOWN SPEED, THE VEHICLE BEGAN TO SHAKE VIOLENTLY. THE DEALER STATED THAT THE REAR DIFFERENTIAL FLUID NEEDED TO BE REFILLED. THE FLUID WAS REPLENISHED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE REAR DIFFERENTIAL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 110,678.

PART #4L3Z 9D370 A (CONTROL UNIT) THIS IS THE FUEL PUMP DRIVER MODULE ON A 2006 FORD F150 THAT FAILED BECAUSE THE SHELL THAT HOLDS THE MICRO CHIPS RUSTED OUT. THIS SHOULD BE NOTED TO FORD MOTOR COMPANY BECAUSE IS A COMMON PROBLEM IN COLD WEATHER STATES. P.S. REPAIR COST AT FORD DEALERSHIP $458.78. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT UPON TRAVELING OVER APPROXIMATELY 40 MPH ATTEMPTING TO ACCELERATE, THE VEHICLE HESITATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO DIAGNOSED THAT THE SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.

MY STEERING WHEEL IS STIFF. AND HARD TO TURN THE MECHANIC SAID IT IS A RECALLED RACK AND PINION. *TR

ENGINE HAD BLOWN A PLUG OUT ABOUT 300 MILES AGO ON THE NUMBER 3 WAS REPAIRED WITH REPAIR KIT NEW PLUG AND COIL WAS PUT ON. WAS TRAVELING STARTED UP HILL ENGINE BEGAN TO MISS DROVE 20 MILES TO DESTINATION HAD TRUCK TESTED AT ADVANCE AUTO PARTS READOUT STATED MISFIRE ON CYLINDER 1 AND 3 AND BAD COIL ON 3. REPLACED COIL 3 AGAIN TOOK TO MECHANIC HIS COMPUTER READ OUT WAS NUMBER 8 COIL WAS BAD REPLACED IT ENGINE CONTINUED TO MISS TOOK IT TO THE MECHANIC HE CHANGED ALL THE PLUGS THE 2ND PLUG ON DRIVERS SIDE WAS LOOSE AND READY TO BLOW OUT AND HE TOOK THE NUMBER 3 PLUG OUT THAT HAD BEEN REPLACED PRIOR THE WHOLE BOTTOM OF PLUG WAS MELTED COULD HAVE RESULTED IN A FIRE LOOKED DOWN IN ENGINE WITH CAMERA THE PISTON WAS DESTROYED. THIS PROBLEM IS FROM THE FACTORY INSTALLED PLUG BLOWING OUT AND FRAGMENTS GOING INTO ENGINE. NOW I HAVE TO REPLACE MY ENGINE 2500 OUT OF MY POCKET D/T POOR HEAD DESIGN FORD IS WELL AWARE OF THIS PROBLEM AND REFUSES ANY ASSISTANCE FORD ACTUALLY HAS EXCLUDED BLOWN PLUG REPAIR FROM THEIR WARRANTY. WHEN YOU PURCHASE A NEW VEHICLE YOU EXPECT TO GET MORE THAN 106000 MILES. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 45 MPH, THE STEERING WHEEL SHOOK VIOLENTLY WITHOUT WARNING. THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE TIRES NEEDED TO BE REPLACED AND ALIGNED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,270.

VEHICLE STARTED MISSING AND BUCKING. BROUGHT INTO MECHANIC AND WAS TOLD THIS IS A VERY COMMON PROBLEM WITH TRITON 5.4L ENGINE. NEEDS SPARK PLUG CHANGE AND CHANCES ARE THEY WILL BREAK OFF IN ENGINE WHILE CHANGING (WHICH 5 OUT OF 8 DID). TOTAL COST A SHAMEFUL $800 (ESTIMATE WAS BETWEEN $600-$1200). MECHANIC PULLED OUT MANY PRIOR INVOICES FROM OWNERS WITH THE EXACT SAME ISSUE. THE SPARK PLUGS IN THESE ENGINES SHOULD BE RECALLED. *TR

THE ELECTRIC WINDOWS AND DOOR LOCKS AND MIRROR ADJUSTMENTS ALL STOPPED WORKING ON MY 2006 F150. AFTER DOING SOME LOOKING I FOUND THAT THE WIRE HARNESS THAT RUNS TO THE DOOR HAS MOST OF THE WIRES BROKEN OR BREAKING IN HALF THUS LEAVING BARE WIRES EXPOSED AND A POSSIBLE FIRE HAZARD THE WAY IT LOOKS TO ME. *TR

WENT TO STOP FOR TRAFFIC LIGHT APPLIED THE BRAKES AND VEHICLE TOOK OFF///////SLAMMED ON BRAKES TO TRY TO STOP AND SLAMMED IN PARK .CAME WITH IN INCHES OF CRASHING INTO CAR IN FRONT OF ME. TODAY IS SEPT.1ST HAVE NOT DRIVEN TRUCK AGAIN////// CALL FORD CORP. THEY WILL NOT PAY TO CHECK OUT TRUCK. AT 3100 MILES HAD TO REPLACE TIRES. ORIG. HAD DRY ROT,,,,,, *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE APPROACHING A TRAFFIC LIGHT, THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING. THE CONTACT APPLIED EXCESSIVE FORCE TO THE BRAKE PEDAL, BUT IT FAILED TO STOP THE VEHICLE. THE CONTACT HAD TO RAPIDLY SHIFT THE GEAR INTO PARK IN ORDER TO STOP THE ENGINE FROM REVVING. THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 3,200.

ENGINE STARTED MAKING A LOUD NOISE UPON INSPECTION OF ENGINE FOUND THAT THE BACK SPARK PLUG ON PASSENGER SIDE HAD BLOWN OUT FROM HEAD AND OF COURSE STRIPPED THE TREADS FROM THE HEAD THE SPARK PLUGS ARE THE ONES THAT CAME FROM FACTORY THEY HAVE NEVER BEEN REMOVED OR REPLACED VEHICLE WAS PURCHASED NEW AFTER REVIEWING INFORMATION ON THE INTERNET THIS SEEMS TO BE A MAJOR PROBLEM WITH FORDS 4.6 AND 5.4 ENGINE AS WELL AS RESULTING IN FIRES AND CONSIDERING FORD MAKES A REPAIR KIT. IF THIS HAS EFFECTED THIS MANY VEHICLE SHOULDN'T FORD FOOT THE BILL. *TR

GAS AND BRAKE PEDAL ARE TOO CLOSE TOGETHER. YOU COULD STILL BE GIVING IT GAS WHILE YOU ARE PUSHING ON THE BRAKES. I SEE HUNDREDS OF COMPLAINTS ABOUT THIS ONLINE.I WAS PULLING INTO A PARKING SPOT WHEN I THOUGHT I WAS APPLYING THE BRAKES THE OTHER HALF OF MY FOOT WAS ON THE GAS CAUSING ME TO JUMP THE CURB AND CRASH INTO A WALL. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING UPHILL, THERE WAS A ENGINE MISFIRE. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.

TRUCK STUTTERED & STALLED, WOULD NOT RESTART. TOWED FORD TO DEALER. FAILURE CAUSED BY CORRODED, CRACKED FUEL PUMP MODULE. THE MODULE BODY IS MADE OF AN ALLOY METAL MATERIAL, AND THE MODULE IS BOLTED DIRECTLY TO THE STEEL FRAME NEAR THE GAS TANK, MOISTURE AND DIS-SIMILAR METALS (ELECTROLYSIS) CAUSED RAPID DETERIORATION OF MODULE BODY. THIS POOR DESIGN CAUSES THE VEHICLE TO SHUT DOWN AT ANY SPEED/SITUATION, LOSS OF POWER STEERING & BRAKES WOULD OCCUR. RESULT COULD BE DEATH OF OCCUPANTS OR THOSE PERSONS AROUND TRUCK WHEN ENGINE SHUT DOWN OCCURS *TR

AS A PART OF REGULAR MAINTENANCE I ALWAYS HAVE WELL IN ADVANCE PERFORMED SCHEDULED MAINTENANCE ON MY 06 F-150.ON AUG 23 2013 I HAD MY ROTORS AND BRAKE PADS ALL REPLACED AS WELL AS HAVING A HI PRESSURE BRAKE FLUID CHANGE PERFORMED AS PART OF THIS AS SUGGESTED BY THE BILL CURRIE FORD DEALERSHIP IN TAMPA. THE TRUCK HAD 83,996 MILES ON IT AT THIS TIME OF SERVICE. THE TRUCK WAS RARELY DRIVEN AFTER THAT AND USED ONLY ON SHORT TRIPS.OF 10-20 MILES OR LESS AFTER HAVING THE BRAKES SERVICED. FRIDAY JULY 18TH 2014..THE TUCK HAD ONLY APPROX. 2000 ADDITIONAL MILES ON IT AFTER THE BRAKES WERE SERVICED AT BILL CURRIE FORD.I AND A FRIEND WERE DRIVING TO PICKUP A WASHING MACHINE ABOUT 30 MILES AWAY. WITHOUT WARNING. UPON RETURNING THE RIGHT WHEEL BEGAN PULLING TO THE RIGHT AND SMOKE AND A RUBBER AND PLASTIC SMELL ACCOMPANIED BY SMOKE STARTING RISING FROM THE RIGHT WHEEL WELL WHICH WAS SCOTCHING HOT. THE HEAT WAS SO INTENSE THAT WHEN WE STOPPED THE PLASTIC WHEEL COVER FELL OFF BECAUSE ITS WAS MELTED.IT WAS TAKEN TO THE DEALERSHIP WERE THE ORIGINAL WORK WAS PERFORMED. I WAS INFORMED IT WAS THE CALIPER,THAT IT HAD SEIZED AND THAT AFTER ALREADY HAVING REPLACED THE FRONT ROTOR SEVERAL THOUSAND MILES BEFORE//THE RIGHT ROTOR AND CALIPER AND BRAKE LINE WOULD NOW HAVE TO BE REPLACED AGAIN..BECAUSE THEY SAID.."WE CAN'T TELL WHEN A CALIPER WILL FAIL". NOW IT HAS COST ME $2,300,00 TO GET MY BRAKES DONE..WHEN INITIALLY THEY WERE STILL IN SAFE LIMITS.WE WERE LUCKY THIS DIDN'T CAUSE A FIRE OR CAUSE THE TIRE TO BLOW OUT WHILE ON THE HIGHWAY. *TR

UPON ATTEMPTING TO START MY 2006 FORD F150 SUPER CREW CAB VEHICLE (5.4L), THE ENGINE WILL ATTEMPT TO CRANK OVER BUT WILL NOT TURN ON. UPON FURTHER DIAGNOSIS, IT WAS DETERMINED THAT THE FUEL PUMP MODULE IS NOT WORKING. IT BECAME COMPLETELY RUSTY AND EXHIBITS HOLES THROUGHOUT THE SURFACE OF THE MODULE. THIS APPEARS TO BE AN EXTREMELY COMMON PROBLEM THAT FORD IS VERY WELL AWARE OF AND HAS NOT ADDRESSED THE PROBLEM. I THINK A CIVIL CLASS ACTION LAWSUIT SHOULD HELP THEM WITH THEM MAKE THE RIGHT DECISION TO REPAIR THE MODULE AT NO COST TO THE CONSUMER. THIS IS AN EXTREMELY FRUSTRATING ISSUE THAT FORD HAS KNOWN ABOUT FOR SEVERAL YEARS. UPON SPEAKING WITH FORD DIRECTLY, I WAS ADVISED THAT THEIR HAS BEEN RECALLS FOR THAT EXACT PART BUT NOT FOR THE 2006 FORD F150. COMPLETELY UNACCEPTABLE AND INEXCUSABLE. THIS WILL BE MY LAST FORD PURCHASE. I'VE BEEN A FORD MAN ALL MY LIFE. NOT ANYMORE.... *TR

I WAS TRAVELING AT APPROXIMATELY 55MPH WHEN THE VEHICLE STARTED TO SPUTTER, AND AS I BEGAN TO SLOW DOWN AND TRIED TO PULL OVER TO THE SIDE OF THE ROAD BEFORE THE TRUCK QUIT ON ME. I TRIED TO START IT BACK UP IN ORDER TO GET OFF THE MAIN ROAD BUT THE VEHICLE DIDN'T START. I ENDED UP HAVING THE VEHICLE TOWED TO THE LOCAL SHOP AND AFTER A DIAGNOSIS THAT COST $124.95 THEY FOUND OUT THAT THE FUEL PUMP DRIVER MODULE WHEN BAD. THE FUEL PUMP DRIVER MODULE COST $234.44. SO ALL TOGETHER WITH PARTS, LABOR AND TAX IT COST ME $496.88 WITHOUT INCLUDING THE COST TO HAVE THE VEHICLE TOWED. THE FUEL PUMP DRIVER MODULE IS BOLTED DIRECTLY TO THE FRAME CROSS MEMBER, AND WITH MINNESOTA WINTERS SNOW AND ROAD SALT GET TRAPPED BETWEEN THE TWO PARTS. THE PART WILL EVENTUALLY RUST, CRACK, AND THEN THE FUEL PUMP DRIVER MODULE GOES BAD. IT WAS NICE TO SEE THAT THE REPLACEMENT PART HAS A PLASTIC HOUSING WITH A COUPLE SPACERS TO MOVE IT AWAY FROM THE CROSS MEMBER TO POSSIBLY ELIMINATE THIS PROBLEM. FORD HAD TO KNOW ABOUT A PROBLEM WITH THIS COMPONENT OTHERWISE THEY WOULDN'T HAVE CHANGED THE DESIGN RIGHT? *TR

SHUTTERS UPON ACCEL. REAR CLUTCH PATCH REPLACED. RETURNED 04/28/2014 FOR SAME PROBLEM. THE 3RD TIME I RETURNED ON 05/29/2014. AGAIN THE SHUTTERING CONTINUES..THIS PROBLEM WAS SINCE BEEN FIXED. HOPEFULLY. *TR

AT VERY LOW MILEAGE I CANNOT UNDERSTAND WHY I WAS HEARING A WHINING NOISE THAT APPEARED FROM COMING THE REAR OF MY TRUCK. I WAS ADVISED THAT THE GEARS WERE BREAKING DOWN AND SHOULD BE REPLACED. THE GEAR AND PINION WERE REPLACED. SEEMS TO BE FIXED. AGAIN AT 57814 MILES? *TR

FORD HAS AN ONGOING PROBLEM WITH THE 2006-2008 F150. THEY HAVE FAULTY SPARKPLUG THAT WHEN THEY NEED CHANGEDIRECTIONS SNAP. THIS RESULTS IN THEM HAVING TO RETAP THE MOTOR AND PUT DIFFERENT SPARK PLUGS IN WHICH THEY CHARGE $400/SPARK PLUG THAT SNAPS. THE PART THAT SNAPS FALLS INTO THE MOTOR THAT'S WHICH IT IS SO EXPENSIVE. FORD HAS KNOWN ABOUT THE PROBLEM FOR YEARS BECAUSE THEY MADE SURE TO GET NEW SPARK PLUGS AS SOON AS THERE WERE ISSUES. NUMEROUS PEOPLE INCLUDING MYSELF HAVE CALLED FORD AND COMPLAINED BUT THEY NEVER DO ANYTHING ABOUT IT. I HOPE THAT YOU WILL. *TR

MY TRUCK WAS NOT INVOLVED IN AN ACCIDENT. I HAVE 74,000 MILES ON MY TRUCK AND THE TRANSMISSION IS STARTING TO SLIP. WITH THIS LOW MILEAGE THIS SHOULD NOT BE HAPPENING. *TR

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED WHILE TRAVELING APPROXIMATELY 35 MPH, ANOTHER VEHICLE WENT THROUGH A STOP SIGN AND CRASHED INTO THE CONTACT'S VEHICLE. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT MENTIONED THAT THE AIR BAG SENSOR WAS ILLUMINATED BEFORE THE CRASH OCCURRED. THE CONTACT SUSTAINED WHIP LASH AND OTHER MINOR INJURIES, ONE OF THE PASSENGERS SUSTAINED LEG INJURIES, A SECOND PASSENGER SUSTAINED NECK INJURIES AND THE THIRD PASSENGER SUSTAINED MINOR INJURIES AND ABRASIONS. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE DEALER WAS NOTIFIED OF THE CONCERNS WITH THE AIR BAG FOR SEVERAL MONTHS BEFORE THE CRASH OCCURED TO NO AVAIL. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED UNDER RECALL NHTSA CAMPAIGN ID NUMBER: 11V107000 (AIR BAGS) BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 144,000. UPDATED 8/14/14*CN UPDATED 08/27/2014 *JS

TL-THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE DRIVING 5 MPH THE BRAKE WOULD NOT ENGAGE, IT WAS VERY HARD TO APPLY. THE CONTACT HAD TO APPLY THE MANUAL BRAKE TO STOP. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO NOTICED THE BRAKE BOOSTER VACUUM HOSE HAD COLLAPSED. THE CONTACT WAS MADE AWARE OF A RECALL NOTIFICATION UNDER NHTSA CAMPAIGN ID NUMBER 08V208000 (SERVICE BRAKES, HYDRAULIC),HOWEVER, HIS VIN WAS NOT INCLUDED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS INFORMED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.

ALL THE GAUGES IN MY TRUCK STOPPED WORKING. FIRST THE SPEEDOMETER THEN ALL THE GAUGES. AT FIRST THEY JUST FLUCTUATED THEN THEY ALL STOPPED. THEN THE LIGHTS STARTED FLASHING ON AND OFF INSIDE THE VEHICLE. THEN THE FUEL SENSOR WARNING STARTED BEEPING FOLLOWED BY THE SEATBELT BEEPER. OCCASIONALLY THE ENTIRE DASH GOES BLANK FOLLOWED BY A TEST SCREEN ON THE DASH. ALL INTERIOR ELECTRICAL SYSTEMS SHUT OFF FOR ABOUT TWO TO THREE SECONDS THEN COME BACK ON WHILE DRIVING. VERY WORRIED THAT THE VEHICLE WILL JUST STOP WHILE DRIVING. *TR

DRIVING WITH MY 2 KIDS ON US 23 I FELT THE STEERING GET TIGHT. STOPPED CHECK EVERYTHING LOOKED GOOD. STARTED BACK DRIVING AND ROAD CURVED TO LEFT AS I WAS DRIVING IT DID NOT WANT TO TURN BACK TO THE RIGHT. ALL MOST CAUSING TO HIT A VEHICLE HEAD ON. FINALLY GOT BACK TO THE HOUSE AND DONE SOME RESEARCH AND FIGURED OUT IT WAS LOWER STEERING SHAFT. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE FUEL ODOR WAS PRESENT INSIDE THE CABIN OF THE VEHICLE. THE FAILURE WAS NOT DIAGNOSED NOR WAS THE VEHICLE REPAIRED. THE MANUFACTURER WAS NOTIFIED REGARDING THE DEFECT. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 84,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 55 MPH, THE POWER STEERING SUDDENLY MALFUNCTIONED MAKING THE STEERING WHEEL DIFFICULT TO TURN AND CAUSING THE VEHICLE TO LOSE CONTROL AND DRIVE INTO ON COMING TRAFFIC NEARLY CAUSING A CRASH. THE VEHICLE WAS TAKEN TO THE DEALER AND DIAGNOSED THAT A LOWER JOINT IN THE STEERING COLUMN SHAFT SEIZED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE FAILURE MILEAGE WAS 58,000.

APRIL 14, 2014 AFTER LEAVING MY DOCTORS OFFICE I BUCKLED MY SEATBELT AS REQUIRED BY FEDERAL LAW I MADE ONE LEFT HAND TURN AND STOPPED FOR A RED LIGHT AS I BEGAN MY TURN TO THE RIGHT WHEN LIGHT CHANGED THE SEALBELT CAME LOOSE FROM THE BUCKLE. THE TOP OF THE BUCKLE WAS STUCK DOWNWARD AND WOULD NOT RELEASE FOR ME TO BUCKLE IT AGAIN. WHEN RETURNING HOME I CALLED MIKE SHAD FORD IN JACKSONVILLE FLORIDA WHERE I PURCHASED IT. I WAS TOLD MY TRUCK WAS OUT OF WARRANTY AND THEY WOULD REPLACE IT FOR $294.71 DOLLARS IT WAS NOT ON A RECALL LIST. I THEREFORE CALLED FORD MOTOR COMPANY AND TRIED TO EXPLAIN TO THE YOUNG LADY WHOM ANSWERED THE PHONE WHAT HAPPENED TELLING HER IT NEEDED TO BE PUT ON A RECALL LIST SHE REFUSED TO LISTEN AND HUNG UP. I THEN CALLED THE NHTSA AND REPORTED IT TO THEM. I AM SURE I AM NOT THE ONLY ONE WHO PURCHASED THAT YEAR TRUCK THAT THIS HAS HAPPENED TO. I FEEL THAT FORD SHOULD HAVE REPLACED MY PART FREE OF CHARGE HOWEVER THEY DID NOT. SO I PAID FOR THE NEW PART AND IT WAS INSTALLED BY A TRAINED FORD TECHNICIAN. I FEEL I SHOULD BE REIMBURSED BY FORD IF NOT THE DEALER. COMPLAINT NUMBER BY NHTSA 10584144. *JS

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE DRIVER'S SIDE SEAT BELT BUCKLE MALFUNCTIONED AND CAUSED THE BUCKLE NOT TO LATCH. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN VERIFIED THE FAILURE AND REPLACED THE SEAT BELT BUCKLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 63,900. UPDATED 6/10/14*CN UPDATED 8/23/2017*CN

OIL PUMP/PRESSURE PROBLEM CAUSING KNOCKING AND ENGINE TO STOP. *TT

VEHICLE ENGINE SUDDENLY SHUT DOWN. THE PROBLEM WAS THE FUEL CONTROL MODULE, FORD PART # 9D370, ALUMINUM CASING CORRODED THROUGH EXPOSING THE INTERNAL CIRCUIT BOARDS. THIS IS A COMMON OCCURRENCE FOR THE 2004 THROUGH 2006 F150 AND CAN CAUSE A VERY DANGEROUS SITUATION IF IT SHUTS DOWN WHILE IN TRAFFIC AT HIGHWAY SPEEDS. *TR

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE BRAKE PEDAL WAS DEPRESSED AND THERE WAS A DELAYED RESPONSE. THE VEHICLE HAD BEEN PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN ID NUMBER 08V208000 (SERVICE BRAKES, HYDRAULIC). THE FAILURE RECURRED BECAUSE THE RECALL REMEDY FAILED TO CORRECT THE PROBLEM. THE CONTACT DIAGNOSED THE VEHICLE AND REPLACED THE MANIFOLD HOSE HIMSELF. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 92,000.

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED THAT THE STEERING WHEEL BECAME UNSTABLE WHILE DRIVING AT AN UNKNOWN SPEED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER MULTIPLE TIMES. THE DIAGNOSIS WAS TO REPLACE THE STEERING SHAFT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 48,000.

I WAS DRIVING DOWN US 281(BUSY 3 LANE HIGHWAY) IN SAN ANTONIO AND THE ENGINE SHUT OFF CAUSING ME TO COAST TO A STOP IN THE MIDDLE OF TRAFFIC. ONCE I GOT OFF OF THE ROAD, THE ENGINE STARTED UP LIKE NOTHING WAS WRONG. AFTER I INSPECTED THE FLUIDS AND SAW EVERYTHING CHECKED OUT, I GOT BACK ON THE HIGHWAY ONLY TO HAVE THE ENGINE SHUT OFF AGAIN. I CALLED FORD TO SEE IF THERE WAS AN ISSUE REPORTED OR A RECALL, AND THERE WAS NOTHING. I FOUND OVER 300 COMPLAINTS ON VARIOUS FORUMS BY TYPING IN --2006 F150 FAILSAFE--IN THE SEARCH ENGINE. I THINK THIS IS A REAL SAFETY ISSUE THAT FORD NEEDS TO ADDRESS BEFORE SOMEONE GETS KILLED ON THE ROAD. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WHEN STOPPED AT A RED LIGHT MY ENGINE BEGAN TO REV. AT VERY HIGH RPM'S AND THE TIRES BURNED OUT WHEN I SHIFTED THE TRANSMISSION INTO NEUTRAL. I PURCHASED THIS TRUCK IN DEC. 2013 AND THIS WAS APPROX. THE 7TH INCIDENT OF SUDDEN ACCELERATION. IT SEEMS TO ONLY HAPPEN WHEN STOOPED OR SLOWING DOWN. ANY HELP IN THIS MATTER WOULD BE DEEPLY APPRECIATED. THANKS IN ADVANCE. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE INSIDE OF THE VEHICLE, SHE WOULD SMELL GASOLINE FUEL. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THAT THE FUEL INJECTOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 89,000. *TR

I TRIED TO START MY TRUCK, BUT IT WOULDN'T START. IT TURNED OVER PERFECTLY BUT WOULD NOT START. IT HAD STARTED TWICE EARLIER IN THE DAY. THE FUEL PUMP DRIVER MODULE, LOCATED ABOVE THE SPARE TIRE ON THE FRAME OF THE TRUCK, HAD CORRODED AND FAILED.

I BROUGHT MY TRUCK IN TO MY LOCAL FORD DEALER BECAUSE THE CHECK ENGINE LIGHT CAME ON. IT IS A 2006 F150 4.6L - AFTER HIS INSPECTION, THE MECHANIC STATED THAT THE BOTTOM OF THE #2 SPARK PLUG (MANUFACTURE INSTALLED) HAD DISINTEGRATED AND FELL INTO THE HEAD CAUSING SO MUCH DAMAGE TO THE #2 CYLINDER THAT I HAVE TO REPLACE THE ENTIRE ENGINE AT A COST OF OVER $6,000 PLUS TAX. IT WILL TAKE OVER A WEEK TO FIX AND I DO NOT HAVE ANOTHER VEHICLE. I WOULD LIKE FORD TO REIMBURSE ME FOR THE EXPENSE. I HAVE WRITTEN TO THEIR "CUSTOMER CARE"( [XXX]) DEPARTMENT, BUT HAVE HAD NO HELPFUL OR SATISFACTORY RESULTS. THIS IS A KNOWN ISSUE AS FORD HAS ISSUED A TSB AND DEVELOPED A TOOL TO ASSIST WITH THE REMOVAL OF FAULTY SPARK PLUGS. *TR

THE FRAME BROKE WHERE THE FRONT DIFFERENTIAL MOUNTS, THIS LET THE FRONT AXLE TWIST AND YOU CAN NOT STEER THE TRUCK!!! I THINK THIS IS VERY DANGEROUS, IF YOU WERE GOING OVER 5 MPH. YOU COULD NOT TURN.FORD FACTORY REP. SAYS THE TRUCK IS OUT OF WARRANTY SO NOT THERE PROBLEM, THEY WILL NOT DO ANYTHING ABOUT IT. FORD SHOULD FIX THIS AT THERE EXPENSE AS THIS A SAFETY CONCERN. HOW MANY OTHER FORD PICK UPS HAVE HAD THIS SAME PROBLEM BUT NOT REPORTED IT BECAUSE THEY DID NOT HOW TO OR WHO TO COMPLAIN TO. THE NTSB SHOULD LOOK INTO THIS VERY CAREFULLY TO SEE IF THIS IS A MAJOR PROBLEM. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS HESITANT TO ACCELERATION. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE SPARK PLUGS WERE DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH THE POWER STEERING FAILED WITHOUT WARNING. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO HER RESIDENCE. THE FAILURE WAS NOT DIAGNOSED BY A DEALER OR INDEPENDENT MECHANIC. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATELY FAILURE MILEAGE WAS 154,618.

WENT TO START TRUCK AND ENGINE WOULD CRANK BUT WOULD NOT FIRE. I TRIED THE STARTING FLUID TEST TO SEE IF IT WAS AN IGNITION PROBLEM OR FUEL PROBLEM. GAVE A LITTLE SHOT OF STARTING FLUID INTO THE INTAKE AND THEN TRIED TO START. MOTOR ACTED LIKE IT WAS GOING TO START BUT NEVER STARTED BEINGS I DIDN'T GIVE IT ENOUGH STARTING FLUID TO START BECAUSE I'M NOT A FAN OF USING IT. WITH THAT I ELIMINATED THE IGNITION HAD TO BE FUEL. I GOT ON THE INTERNET AND SEARCHED NO START PROBLEM FOR 2006 F-150 AND FOUND A YOU TUBE VIDEO OF THE FUEL PUMP CONTROL MODULE RUSTING OUT. WENT OUT AND DROPPED SPARE TIRE AND TOOK THE CONTROL MODULE OFF THE CROSS MEMBER AND NOTICED THE HOLE CORRODED THROUGH THE HOUSING JUST LIKE THE VIDEO. I GOT THE UPGRADED PART FROM A FORD DEALER FOR $163 AND INSTALLED. RUNS FINE NOW. MY BIGGEST COMPLAINT IS FORD KNOWS THERE'S A PROBLEM SINCE THE HAVE CAME OUT WITH AN UPGRADED CONTROL MODULE SO WHY ISN'T THIS A RECALL? I LIVE IN A STATE THAT TEMPERATURES IN THE WINTER MONTHS CAN BE BELOW 0 DEGREES FAHRENHEIT AND DRIVE AN HOUR ONE WAY TO WORK, THIS COULD HAVE HAPPENED WHEN I WAS ON THE ROAD IN EXTREME COLD, COULD OF HAD MY TWO CHILDREN WITH ME BROKE DOWN ON THE SIDE OF THE ROAD AND COLD OUT. LUCKILY IT HAPPENED AT HOME BUT STILL IT WAS 4 DEGREES OUT AND LAYING UNDER MY TRUCK TAKING THE MODULE OFF WAS NOT VERY PLEASANT. THINK THIS IS SOMETHING THAT FORD NEEDS TO DO SOMETHING ABOUT. *TR

MY FACTORY TIRES, BF GOODRICH LONG TRAIL T/A, ON MY FORD F-150 KING RANCH BOUGHT NEW IN 2006 LASTED ONLY 21,428 MILES. THEY GAVE ME A LOUSY $236. AND IT COST ME $708.TO REPLACE ALL 4. NOW, 18,270 MILES LATER THERE ARE LESS THE 4/32 LEFT ON THE TREAD. ON A RECENT OIL CHANGE, A DEALER WOULD NOT ROTATE MY TIRES BECAUSE OF THE WARE. NOW I AM BEING TOLD - SORRY NO WARRANTY LEFT! - I AM LIVID! CAN ANYTHING BE DONE? *TR

WHEN DRIVING HOME, CHECK ENGINE LIGHT STARTED FLASHING, IMMEDIATELY STOPPED AND HAD VEHICLE TOWED TO A WELL REPUTABLE SHOP FOR DIAGNOSIS AND REPAIR. WAS DIAGNOSED WITH TWO FUEL INJECTORS FAILING AND NEEDING REPLACED ALONG WITH ALL SPARK PLUGS NEEDED REPLACED. 6 OF THE 8 PLUGS SNAPPED IN HALF AND NEEDED TO BE BURROWED OUT ON TOP OF IT COSTING $90 PER PLUG DRILLING OUT. TOTAL FOR REPAIRS CAME TO $2300. BUT AFTER REPAIRS WERE COMPLETED I STILL DO NOT HAVE A RUNNING VEHICLE. THE ENGINE STARTS BUT OIL PRESSURE DROPS AFTER 5 MINS OF RUNNING. I WOULD LOVE TO FIND A SOLUTION TO THIS, IF THIS IS COMMON OR NOT. AND IF SO, WHY IS IT NOT RECALLED? *TR

VEHICLE BEGAN TO SMELL LIKE GAS IN THE CAB ON NUMEROUS OCCASIONS. TOOK IT TO FORD DEALERSHIP MECHANIC AND WAS TOLD THAT THE SOURCE OF THE GAS SMELL COULD NOT BE FOUND. A FEW DAYS LATER UPON STARTING THE VEHICLE, A VERY LOUD EXPLOSIVE SOUND WAS HEARD UNDER THE HOOD. THE VEHICLE WAS TURNED OFF AND TOWED BACK TO THE FORD DEALERSHIP WHERE IT WAS DETERMINED THAT THE ORIGINAL #2 SPARK PLUG HAD BLOWN OUT OF THE ENGINE AND DAMAGED THE HEAD. REPAIR EXCEEDING $700 WITH ABSOLUTELY NO RESPONSIBILITY TAKEN BY FORD. REPEAT INCIDENT LESS THAN ONE YEAR LATER WITH ANOTHER CYLINDER. *TR

TRUCK WAS AT DEALERSHIP FOR REPAIRS, WHEN I WAS TOLD NOT TO HAVE REPAIRS DONE BECAUSE THE FRAME IS CRACKED AND RUSTED THRU. THEY SAID THE VEHICLE IS UNSAFE TO DRIVE. THE TRUCK IS NOW WORTHLESS. IN MY 50 YEARS OF OWNING AND DRIVING NUMEROUS VEHICLES IN THE NORTHEAST, I NEVER HAD A RUSTED FRAME ISSUE. FORD WILL NOT HELP NOR INVESTIGATE THE SITUATION. *TR

I WAS INVOLVED ON A ACCIDENT ON FEBRUARY 17 2013 A CAR RUN IN TO MY TRUCK .DRIVER SIDE MY TRUCK SPIN AROUND AND I HIT THE DIVIDER IN THE MIDDLE AT THE STREET THE AIRBAG NEVER DEPLOY THE TOTAL DAMAGE ON MY TRUCK WAS $10,800 DOLLARS AND 2 MONTHS LATER A REVISE A LATTER FROM FORD COMPANY SAID THAT MY TRUCK HAS A RECALL ON THE AIRBAG ...SO I REVISE THE NOTIFICATION REALLY LATE ... SO I WAS THIS DRIVING A DEFECT TRUCK FOR YEARS REALLY I M REALLY UPSET ..WHEN I REVISE THE RECALL LATTER I TOOK MY TRUCK TO THE BIG VALLEY FORD DEALER SHIP AND THEY FIX MY AIRBAG ...SO THERE WAS A PROBLEM I TRY TO GET A HOLD OF THE FORD COMPANY AND THEY GIVE ME A CASE NUMBER BUT THEY DON'T DUE NOTHING ABUT IT I NEED HELP AND SOME INFO HOW CAN I GO AGAINST FORD COMPANY. *TR

HANKOOK DYNAPRO AS P255/65SR17 SEPARATED AT APPROX. 10,000 MILES. POTENTIAL FOR ACCIDENT SINCE IT WAS A STEERING TIRE. PURCHASED AT PEPBOYS STORE # 661 TUCSON, AZ. *TR

MY 2006 FORD F150 FX4 HAS STALLED ON THE HIGHWAY AT TWO DIFFERENT TIMES IN THE LAST 9,000 MILES. I AM DRIVING AT NORMAL SPEEDS, WITH NORMAL WEATHER CONDITIONS, HALF TANK OF GAS, AND I WAS COASTING AS HIGHWAY SPEEDS SLOWED - AS I WENT TO HIT THE ACCELERATOR TO SPEED UP, I LOST THE ABILITY TO ACCELERATE. FIRST THE WRENCH DASH LIGHT CAME ON, THEN I NOTICED STEERING WAS SLIGHTLY DIFFICULT AND THEN THE BATTERY AND TRANSMISSION LIGHT CAME ON. I GOT THE VEHICLE TO THE SIDE OF THE ROAD, BUT I DID NOT LOSE HEADLIGHTS, RADIO, HEAT, OR POWER. I TURNED THE TRUCK OFF AND WAITED 2 MINUTES, THEN IT STARTED BACK UP - A LITTLE DIFFICULT ON THE STARTER, BUT IT WORKED. I HAVE READ NUMEROUS CHAT FORUMS ONLINE WITH USERS HAVING THIS SAME ISSUE WITH 2006 V8'S IN THE F150. WHAT IS FORD DOING ABOUT THIS? MY VEHICLE HAS BEEN METICULOUSLY MAINTAINED AND CARED FOR. FROM WHAT I READ THIS IS A FUEL PUMP CONTROL PANEL ISSUE WITH CORROSION OF DISSIMILAR METALS - WHERE IS THE RECALL? *TR

WHILE APPROACHING A STOP THE TRUCK GAUGES STARTED GOING CRAZY. TRUCK STALLED BUT RESTARTED WITH GAUGES STILL ACTING CRAZY. ALL GAUGES WOULD BOTTOM OUT AND COME BACK UP AND RADIO WAS TURNING ON AND OFF. REPLACED BATTERY BUT ONLY STALLING ISSUE WAS RESOLVED. TOOK TO LOCAL FORD DEALER BUT SINCE THE TRUCK ONLY DOES THIS RANDOMLY, THEY WERE NOT ABLE TO DIAGNOSE THE PROBLEM. TRUCK RUNS PERFECTLY BUT GAUGES AND RADIO STILL GO ON AND OFF MAKING IT EXTREMELY ANNOYING TO DRIVE. VERY FRUSTRATING TO KNOW THAT SO MANY OTHER FORD OWNERS HAVE THE SAME PROBLEM BUT NO SOLUTION HAS BEEN OFFERED FROM FORD. *TR

WHEN I STARTED THE TRUCK, A SPARK PLUG BLEW INTO THE HEAD. THE MECHANIC AT THE FORD DEALERSHIP TOLD ME THIS WAS A COMMON PROBLEM WITH THESE TRUCKS. THE REPAIR COST ME $3,448. TO REPLACE THE HEAD. IF FORD IS AWARE OF THIS PROBLEM, THE VEHICLES SHOULD BE RECALLED AND THE PROBLEM CORRECTED. MY FAMILY WAS LEFT STRANDED 7 HOURS AWAY FROM HOME, HAD TO RENT A VEHICLE TO GET HOME AND THEN TWO WEEKS LATER, HAD TO RETURN TO DEALERSHIP AND PICK UP THE TRUCK. SO STRESSFUL AND EXPENSIVE. JUST GLAD WE WERE IN A TOWN WHEN THIS HAPPENED! *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED DURING ROUTINE MAINTENANCE ON THE VEHICLE SHE WAS INFORMED THAT THE SPARK PLUGS WERE FRACTURED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO REPAIRED THE VEHICLE. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 71,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE STEERING SHAFT EXHIBITED EXCESSIVE RUST, MAKING THE VEHICLE DIFFICULT TO STEER AT ALL SPEEDS. THE CONTACT CLEANED AND LUBRICATED THE STEERING SHAFT BUT THE SERVICE ONLY REMEDIED THE ISSUE TEMPORARILY. THE CONTACT DID NOT TAKE THE VEHICLE TO A DEALER. THE CONTACT CALLED THE MANUFACTURER AND OFFERED THE CONTACT A NEW PART TO PURCHASE. THE CONTACT DID NOT PURCHASE THE PART. THE FAILURE MILEAGE WAS 48,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS STARTED AND THE ENGINE EXHIBITED A LOUD NOISE. ADDITIONALLY, THE CONTACT SMELLED A BURNING ODOR. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC, WHO STATED THAT THE SPARK PLUG HAD MELTED DUE TO THE HEAT FROM THE HEAD GASKET. THERE WERE NO REPAIRS MADE TO THE VEHICLE. THE FAILURE MILEAGE WAS 40,000.

2006 FORD F-150. CONSUMER REQUESTS REIMBURSEMENT FOR VEHICLE REPAIRS. *SMD THE CONSUMER STATED HE WAS QUOTED A PRICE OF $447 TO REPLACE THE SPARK PLUGS. HOWEVER, WHEN HE RECEIVED THE BILL, THE PRICE HAD DOUBLED.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE BRAKES FAILED WHILE DRIVING 45 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHO ADVISED THAT THE BRAKE BOOSTER FAILED. THE CONTACT SPOKE TO THE MANUFACTURER AND WAS TOLD THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER:08V208000(SERVICE BRAKES, HYDRAULIC). THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 101,000.

THE RIGHT EXHAUST MANIFOLD STUDS HAD BROKEN APPROXIMATELY 5/5/2012, IN WHICH THEY DID NOT TELL ME THE FULL EXTENT OF THE DAMAGES. THEY JUST TOLD ME THE MANIFOLD WAS LEAKING AND THE COST TO REPAIR IT. THIS CAUSED THE MANIFOLD TO WARP AND LEAK. THE DEALER WOULD NOT REPAIR IT UNDER THE EXTENDED WARRANTY. APPROXIMATELY ONE YEAR LATER I CALLED THE WARRANTY COMPANY AND FOUND OUT IT WAS ACTUALLY COVERED. WHEN I HAD TAKEN IT IN, IN MAY 2012 THE DEALER WANTED TO CHARGE 1500.00 FOR THE REPAIRS. THE REPAIRS WERE FINALLY MADE IN MAY OF 2013 TO THE EXHAUST MANIFOLD, BUT NOT TO THE CATALYTIC.CONVERTER WHICH STARTED CAUSING PROBLEMS IN JANUARY OF THIS YEAR. THIS LEAK MAY HAVE CAUSED THE RIGHT CATALYTIC CONVERTER TO FAIL ALSO, BUT HAVE FOUND MANY FORUMS STATING THAT FAILURE OF THE CATALYTIC CONVERTERS ARE A COMMON PROBLEM ON THESE PICK UPS. AT THIS TIME I AM DRIVING THE PICK UP AND IT THROWS THE CODE P0420, FOR CATALYTIC CONVERTER BELOW EFFICIENCY THRESHOLD. THIS PROBLEM SHOULD ALSO BE FORWARDED TO THE E.P.A. BECAUSE PEOPLE CANNOT AFFORD TO REPLACE THEIR CATALYTIC CONVERTERS AT THE PRICE OF 1200.00 PER SIDE. IF THIS IS A COMMON PROBLEM WITH FORD F-150'S THIS NEEDS ADDRESSED. ALSO THE FAILURE OF THE EXHAUST MANIFOLD IS A SAFETY HAZARD THAT COULD CAUSE THE OCCUPANTS IN THE CABIN TO BE EXPOSED TO CARBON MONOXIDE. THE LEAKING MANIFOLD ALSO CONFUSES THE COMPUTER BY TELLING IT THAT THE OF BANK CYLINDERS IS RUNNING TO LEAN IN RESPONSE TO THOSE READINGS IT THEN ADDS FUEL TO THAT BANK WHICH CAUSES IT TO RUN RICHER ON THAT BANK THAN IT SHOULD. I BELIEVE THAT THIS CAUSED DAMAGE TO THE CATALYTIC CONVERTER MAKING IT FAIL PREMATURELY. *TR

WENT TO BACK UP AND NO REVERSE. *TR

SPARK PLUGS AND COIL PACKS HAVE FAILED ACROSS OUR ENTIRE FLEET OF 2005-2008 F-150'S. THE POTENTIAL FOR SEIZED SPARK PLUGS IS SIGNIFICANT DUE TO INCREASED HEAT FROM FAILED COIL PACKS. THE COIL PACKS SEEM TO FAIL APPROXIMATELY EVERY 25,000-75,000 MILES. THE REPAIRS HAVE BEEN VERY COSTLY - ESPECIALLY WITH A FLEET OF 200+ VEHICLES. FORD HAS NOT OFFERED ANY ASSISTANCE WITH ANY OF THE CLAIMS. SYMPTOMS - THE VEHICLE SPUTTERS OR BOGS DOWN UNDER LOAD WHILE TRAVELING UP A HILL OR UNDER HARD ACCELERATION. DANGERS - THE VEHICLE WILL NOT ACCELERATE WITH 100% POWER WHILE UNDER LOAD IN A DANGEROUS SITUATION. THE NEED TO QUICKLY ACCELERATE BECOMES ALTERED DUE TO POSSIBLE SPARK PLUG/ COIL PACK FAILURE. RISKS ARE ACCIDENTS, PERSONAL INJURY, OR EVEN WORSE. *TR

VEHICLES MISFIRING AND STUMBLING DURING MODERATE ACCELERATIONS AND CRUISING WHEN A LOAD IS PUT ON MOTOR. ( GOING UP A HILL, SLIGHT INCLINE AND PASSING). SPARK PLUGS WERE UNABLE TO BE REMOVED FOR REPLACEMENT. THE SPARK PLUGS WERE NOT OF GOOD QUALITY AND WOULD NEED TO BE REPLACED MORE OFTEN THAN USUAL. THE MANUFACTURER WAS MADE AWARE, HOWEVER NO ASSISTANCE WAS PROVIDED. $1249.00 TO CHANGE ONE SPARK PLUG. *TR

THE VEHICLE WAS BEING DRIVEN AT 35 MPH AND SIMPLY STOPPED RUNNING. VEHICLE COULD NOT BE RE-STARTED. TOWED TO REPAIR SHOP. THE MECHANIC TESTED THE FUEL SYSTEM AND DETERMINED THE FUEL PUMP HAD BURNED OUT. THE FUEL PUMP WAS REPLACED AT A COST OF $552.05. ONE DAY AFTER REPAIRS WERE COMPLETED THE CHECK ENGINE WARNING LIGHT WAS ACTIVATED AND THE CODE REVEALED A FUEL SYSTEM ISSUE. THE VEHICLE WAS IMMEDIATELY TAKEN BACK TO THE SAME REPAIR SHOP. THE FUEL PRESSURE WAS OPERATING AT 90 PSI. AFTER SEVERAL UNSUCCESSFUL VISITS, IT WAS EVENTUALLY DETERMINED THAT THE FUEL PUMP CONTROL MODULE WAS SEVERELY CORRODED AND MALFUNCTIONING. THE "POT" METAL HAS BEEN COMPLETELY CORRODED AND THERE IS AN APPROXIMATE 1 INCH DIAMETER HOLE LEADING DIRECTLY TO THE ELECTRIC PANEL. THE CONTROL MODULE WAS REPLACED FOR AN ADDITIONAL $399.89. THE DESIGN OF THIS MODULE USING "POT" METAL AND SIMPLY BOLTING TO THE STEEL AXLE IS RIDICULOUS. THIS ITEM SHOULD BE AN IMMEDIATE RECALL WITHIN THE "SALT BELT" AREAS OF NORTH AMERICA. I HAVE DOCUMENTED RECEIPTS FROM THE REPAIR SHOP AND HAVE KEPT THE ORIGINAL FUEL MODULE AS WELL. FORD MOTOR COMPANY SHOULD RECOGNIZE THIS ISSUE AS AN OBVIOUS RE-CALL ITEM AND BE HELD RESPONSIBLE FOR ASSOCIATED REPAIR BILLS. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE SHIFTED OUT OF GEAR WHILE AT A STOP AND THEN LUNGED FORWARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE TRANSMISSION HAD DEVELOPED A PLANETARY NOISE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE WAS REPORTED TO THE MANUFACTURER. THE FAILURE MILEAGE WAS 24,000. THE CURRENT MILEAGE WAS 35,800.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE INSTRUMENT CLUSTER SHUT OFF WHENEVER THE TEMPERATURE WAS ABOVE 70 DEGREES. THE CONTACT MENTIONED THAT IT WOULD RETURN TO NORMAL ONCE THE TEMPERATURE WAS COOLER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE INSTRUMENT CLUSTER NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 114,000. *TR

WHILE REPLACING THE SPARK PLUGS, EVERY PLUG BROKE OFF AND WAS VERY DIFFICULT TO REMOVE. MY MECHANIC GOT OUT THE FIRST SEVEN, BUT THE EIGHTH WOULD NOT COME OUT. IT SUBSEQUENTLY FELL INTO MY ENGINE, CAUSING IT TO SEIZE. I SHOULD HAVE GOTTEN ANOTHER 100,000 MILES OUT OF THIS TRUCK! *TR

THE LED DISPLAY THAT INDICATES THE MILEAGE, GEAR SELECTOR AND WARNING INDICATOR IS NO LONGER OPERABLE. FROM A QUICK WEB SEARCH AND A DISCUSSION WITH THE LOCAL FORD SERVICE DEPARTMENT THIS IS A KNOWN ISSUE THAT IS NOT CURRENTLY COVERED BY A RECALL. INABILITY TO VIEW MILEAGE AND WARNING INDICATORS RESULTS IN UNSAFE DRIVING CONDITIONS. *TR

DRIVING EAST ON I90 (ABOUT 20 MILES WEST OF STEWARTVILLE, MN) DURING FREAK MAY BLIZZARD. DUE TO ROAD CONDITIONS, COULD ONLY DRIVE BETWEEN 15-40 MPH. SUDDENLY THE ENGINE STOPPED RUNNING. I WAS ABLE TO START IT UP AGAIN AND DRIVE ABOUT 3 MINUTES AND THEN IT WOULD DIE AGAIN. THERE WAS NO PLACE TO PULL OVER, AS THE SHOULDERS OF THE ROAD WERE NOT CLEARED AND THERE WAS 12" OF WET HEAVY SNOW. MY TRUCK IS NOT 4WD SO WE WOULD HAVE GOTTEN STUCK. WE HAD TO DRIVE WITH THE HAZARDS ON, BUT IT WAS LOW VISIBILITY AND WE COULD EASILY HAVE BEEN HIT FROM BEHIND. WE COULD NOT GET OFF ON THE EXIT RAMP BECAUSE A SEMI TRUCK JACKNIFED AND THE EXIT WAS CLOSED. WE HAD TO CONTINUE THIS HAZARDOUS JOURNEY TO THE NEXT EXIT, WHICH WAS ABOUT 12 MILES AWAY, TO STEWARTVILLE, MN. WE FOUND A AUTO REPAIR SHOP AND DESCRIBED THE PROBLEM. THE MECHANIC SUSPECTED IMMEDIATELY THAT IT WAS THE FUEL PUMP CONTROL MODULE. HE SAID THAT HE HAS BEEN INSTALLING A LOT OF THESE LATELY ON F150S, ESPECIALLY 2006'S. HE SAID HE FELT THERE SHOULD BE A RECALL, AS IT IS WELL-KNOWN AMONG MECHANICS THAT THESE ARE FAILING AT AN ALARMING RATE. THE PROBLEM IS THAT THE MODULE IS LOCATED TIGHT AGAINST THE FRAME, NEXT TO THE SPARE TIRE, AND THE METAL OF THE MODULE (ALUMINUM) REACTS ADVERSELY WITH THE STEEL METAL OF THE FRAME, CAUSING OXIDATION BETWEEN THE TWO. THIS CAUSES THE MODULE TO BREAK AND FAIL, THUS SHORTING OUT THE CIRCUIT BOARD. FORD KNOWS THAT THIS IS A PROBLEM, AS THE REPLACEMENT PARTS HAVE SPACER PLATES TO KEEP THE MODULE & FRAME SEPARATED. FORD SHOULD ISSUE A RECALL ON THIS PART BEFORE SOMEONE GETS KILLED. WE COULD EASILY HAVE BEEN KILLED, AS WE COULD NOT PULL OFF THE INTERSTATE. THE PART IS RELATIVELY INEXPENSIVE (WE PAID $189 FOR THE PART). WE SHOULD HAVE BEEN NOTIFIED OF THIS ISSUE. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE REVERSING AT 3 MPH, THE VEHICLE STALLED AND WOULD NOT RESTART. AN INDEPENDENT MECHANIC DIAGNOSED THE VEHICLE AS HAVING A FAULTY FUEL PUMP AND/OR FAULTY FUEL DRIVER MODULE. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE VEHICLE HAD NOT BEEN REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 103,000.

A DEER RAN OUT IN FRONT OF VEHICLE..ROAD WET AND IT WAS FOGGY..TRIED TO KEEP FROM HITTING DEER..BACK OF TRUCK FISHTAILED..LOSS CONTROL..HIT A DITCH AND EMBANKMENT...AIR BAGS DID NOT EMPLOY AND SEAT BELT DID NOT LOCK...HAD A FRACTURE IN L2 VERTEBRAE OF BACK..FORD HAS DENIED ANY FAULT IN AIR BAG OR SEAT BELT FUNCTION...TRUCK WAS TOTALED BY INSURANCE COMPANY..... *TR

I WAS WARMING THE VEHICLE TO GO TO WORK, MY TRUCK JUST SUDDENLY STALLED, HAD TO GET A TOW TO THE NEAREST FORD DEALER, THE MECHANIC SAID THE FUEL PUMP MODULE UNIT WENT OUT, THE PART IS ON BACK ORDER OR EMERGENCY ORDER, I HAVE NO VEHICLE TO GET TO WORK, I NEED MY VEHICLE, THIS PART SHOULD BE ON RECALL FOR FORD F150. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING 44 MPH, THE VEHICLE SHOOK VIOLENTLY THEN STALLED. THE VEHICLE WAS RESTARTED AND THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TOWED TO A DEALER WHERE IT CONFIRMED THAT THE FUEL PUMP HAD FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 111,600. THE VIN WAS UNAVAILABLE.

DRIVING VEHICLE DRIVE AND OVERDRIVE WENT OUT THIS IS TWO TIMES THIS HAPPENED FORD NEEDS TO PAY FOR REPAIRS OTHER PEOPLE HAVE SAME PROBLEM THIS PROBLEM SHOULD BE LOOKED INTO. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH WITH THE CRUISE CONTROL ACTIVATED, THE ENGINE RPMS INCREASED AND THE VEHICLE WOULD NOT ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN ADVISED THE CONTACT THAT THE TRANSMISSION WOULD HAVE TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. *TR

I RECENTLY PURCHASED THIS VEHICLE USED BUT THE BODY WAS IN GREAT CONDITION AND IT RAN GOOD ON THE TEST DRIVE. AFTER THREE DAYS I NOTICED A FUEL SMELL IN THE CAB AND WHEN OVERTAKING A VEHICLE IT STARTED MISS FIRE. FORTUNATELY THE DEALER I BOUGHT IT FROM HAD ME TAKE IT TO THE MECHANIC HERE IN TOWN WHO SAID THAT IT WAS THE NUMBER FIVE IGNITION COIL WHICH HE REPLACED. THE NEXT DAY THE PROBLEM CONTINUED SO I TOOK IT BACK AND IT WAS THE SPARK PLUGS WHICH HE REPLACED (400.00) BUT IT RAN WELL. I DROVE IT TO PA. AND BACK WITH NO PROBLEM BUT YESTERDAY THE SAME PROBLEM HAPPENED AND NOW IT IS COIL NUMBER 2 (73.00). THE MECHANIC WHO HAS BEEN IN BUSINESS FOR 28 YEARS IN OUR FARM TOWN IN WHICH HE SERVICES NUMEROUS FORD TRUCKS SAID THAT THIS IS A SERIOUS PROBLEM WITH FORDS FROM THE COILS TO THE ILL DESIGNED SPARK PLUGS. NOW THAT I HAVE READ THE NUMEROUS COMPLAINTS WHICH ARE SYNONYMOUS WITH MY PROBLEM INCLUDING THE FUEL SMELL MAKES ME WONDER IF THE NHTSA IS ON THE TAKE FROM FORD TO OVERLOOK CERTAIN PROBLEMS. I THINK THAT I WILL USE SOME OF MY WELL CONNECTED FRIENDS IN CONGRESS TO LOOK INTO THIS IF I DO NOT GET A SATISFACTORY ANSWER TO THIS ISSUE. *TR

FUEL PUMP MODULE, ENOUGH SAID FORD. TIME TO MAKE A RECALL. NO RECALL BUT THERE'S AN UPDATE TO MOUNT IT ON STUDS...THINK THERE'S AN ISSUE? *TR

2006 FORD F-150 HARLEY DAVIDSON HAS COIL MISFIRE PROBLEM. ALL EIGHT COILS HAVE BEEN REPLACED IN THE LAST 24 MONTHS AND THREE HAVE BEEN REPLACED TWICE. CAT CONVERTER HAS BEEN REPLACED TWICE IN THE SAME TIME PERIOD. ALL PLUGS HAVE BEEN REPLACED. THE CAR CONTINUES TO MISFIRE. AS A RESULT, THE VEHICLE HAS AN EXTREMELY STRONG ODOR OF FUEL RESONATING. THE DEALER STATES THAT THEY CANNOT DO ANYTHING TO FIND THE ROOT OF THE PROBLEM. THIS VEHICLE IS DEALER SERVICED. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE BRAKING TO A STOP, THE VEHICLE SUDDENLY STALLED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE FAILURE COULD NOT BE REPLICATED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 127,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE REVERSING, THE ENGINE RPMS INCREASED EXCESSIVELY AND THE VEHICLE SUDDENLY ACCELERATED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNABLE TO BE REPLICATED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 34,000 AND CURRENT MILEAGE WAS 38,500. *TR UPDATED 5/7/13 *CN

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, THE DRIVER LOST CONTROL OF THE VEHICLE AND CRASHED HEAD-ON INTO A TREE. THE AIR BAGS FAILED TO DEPLOY. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED AND NO INJURIES WERE REPORTED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 76,624.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING 50 MPH, THERE WAS A LOUD BEEP AND THE SAFE MODE SIGNAL ILLUMINATED THEN THE VEHICLE STALLED. THE VEHICLE WAS MERGED TO THE SHOULDER AND AFTER WAITING FOR ABOUT 15 MINUTES, THE VEHICLE WAS ABLE TO BE RESTARTED. THE VEHICLE HAD NOT BEEN INSPECTED. THE FAILURE AND CURRENT MILEAGES WERE 50,100.

TRUCK KEEPS SHUTTING OFF. IF YOU WAIT 45 MINUTES TO RESTART IT WILL START AND IDLE FOR ABOUT 15 SECONDS AND SLOWLY DIE. OR YOU CAN DRIVE A SHORT DISTANCE AND IT WILL DIE. REPAIR IS FOR THE FUEL PUMP CONTROL MODULE. BECAUSE OF WHERE IT IS MOUNTED ON THE TRUCK IT CORRODES VERY FAST ESPECIALLY IN SNOW STATES DUE TO THE SALT ON ROADWAYS. FORD CAN YOU PLEASE DO A RECALL OF THIS PART AND REIMBURSE US FOR THE COST! *TR

MY 2006 FORD F150 HAS THE POSITRACTION REAR END. ITS WENT OUT AROUND 25000 TO 30000 MILES, WHILE THE TRUCK WAS STILL UNDER WARRANTY AND THE DEALER FIXED IT NO CHARGE. NOW THE TRUCK HAS A LITTLE OVER 62000 MILES AND THE REAR END HAS GONE OUT AGAIN. ALMOST EXACTLY THE SAME AMOUNT OF MILES ON THE REAR END. WARRANTY WAS UP AT 60000 MILES SO ITS NO LONGER COVERED. I THINK THIS SHOULD BE LOOKED INTO AS A RECALL BECAUSE THIS IS THE SECOND TIME ITS HAPPENED ON THE SAME TRUCK. *TR

WHILE TURNING TRUCK STARTED TO EMIT NOISES, SOUNDED LIKE AN EXHAUST PROBLEM, MANIFOLD ETC. NO SERVICE ENGINE LIGHT ON AND ALL GAUGES WERE NORMAL. THEN WHILE DRIVING, AS TRUCK SHIFTED DOWN TO OVERDRIVE, NOISE RETURNED, LOSS OF POWER, BUT AGAIN NO SERVICE ENGINE LIGHT, GAUGES ALL NORMAL. TOOK VEHICLE TO DEALER, HAVE BEEN TOLD, ENGINE NEEDS TO BE REPLACED,(81,250 MILES/130,000KM) FOR A MEAGER $6000. VEHICLE HAS BEEN DEALER MAINTAINED SINCE NEW, OIL CHANGED EVERY 3125, MILES/5000KM (BY DEALER) STILL NO SERVICE ENGINE LIGHT, GAUGES STILL READING NORMAL. MANUFACTURER WILL DO NOTHING. LOOKING FOR LAWYER WHO WOULD LIKE TO START CLASS ACTION SUIT AGAINST MANUFACTURER, CONSIDERING ALL THE ISSUES I HAVE FOUND ON THE 2006 F150 V8 TRITON SINCE STARTING RESEARCH YESTERDAY, THERE ARE A LOT OF US THAT FORD IS NOT WILLING TO ASSIST. *TR

WHILE APPROACHING AN INTERSECTION, ABOUT TO MAKE A RIGHT AT THE LIGHT, (I WAS DRIVING ABOUT 20MPH) ON 12/24/12 (WITH MY TWO CHILDREN AND HUSBAND IN THE TRUCK) THE VEHICLE BEEPS AND IT DISPLAYS "ENGINE SAFE MODE...LOW OIL PRESSURE" THEN THE POWER STEERING CUTS OFF AND THE WHOLE VEHICLE SHUT DOWN! I AM FRANTIC AT THIS POINT BECAUSE I HAVE NO CLUE WHAT IS GOING ON! I WAS IN THE MIDDLE OF TRAFFIC AND HAD TO CUT THE CAR OFF AND CRANK IT UP AGAIN. LUCKILY I DIDN'T GET REAR ENDED OR IN AN ACCIDENT. THAT SAME DAY I WENT AND GOT MY OIL CHANGE BECAUSE IT WAS OVER DUE. WELL ON 1/4/13 THE SAME THING HAPPENS AS I AM TURNING INTO THE PARKING LOT OF MCDONALD'S. I GET THE SAME ERROR MESSAGE AS BEFORE, THE STEERING WHEEL LOCKS UP, AND TRUCK CUTS OFF! THIS SO EXTREMELY DANGEROUS. I LOOKED THIS ISSUE UP ONLINE AND SEE THAT IT APPEARS TO BE A COMMON ISSUE WITH THE 2006 F-150 AND THE EXPEDITION. MY BOTHER-IN-LAW, WHO ALSO HAS A SIMILAR F-150 TO OURS, SAID THE SAME THING HAS HAPPENED TO HIM TWICE. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE FAILURE RECURRED FIVE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN ADVISED THE CONTACT THAT THE COIL PACKS WOULD NEED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 6,000.

2006 F-150 FUEL CONTROL MODULE SHOULD BE A MANDATORY SAFETY RECALL FOR FORD. THE 2006 F-150 HAS A POORLY DESIGNED FUEL MODULE THAT ABSOLUTELY WILL FAIL OVER TIME IN RUST BELT STATES, PRODUCING A LOSS OF POWER, INABILITY TO START OR A COMPLETE ENGINE STALL / LOSS OF CONTROL AT ANY SPEED, INCLUDING HIGHWAY SPEEDS. MY COMPLAINT STARTS AFTER THE FIRST SNOWSTORM THIS YEAR. THE TRUCK WAS SLUGGISH TO ACCELERATE ON THE HIGHWAY AND IT SEEMED TO NEED MORE GAS PEDAL JUST TO MAINTAIN SPEED. A FEW DAYS LATER I DROVE UP HEAVILY SALTED ROADS TO A SKI AREA. AT THE END OF THE DAY, THE TRUCK WOULD NOT START WITHOUT THE GAS PEDAL BEING FULLY DEPRESSED. (FIRST TIME I HAVE EVER HAD TO USE THE GAS PEDAL TO START IT.) I GOT IT RUNNING FOR ABOUT 2 MINUTES, THEN IT STALLED OUT WHILE STILL IN PARK. IT TOOK SEVERAL TRIES TO RESTART IT. I FINALLY GOT IT GOING AGAIN AND IT PERFORMED OK ON THE 60 MILE HOME TRIP, SOME OF THAT AT INTERSTATE SPEEDS. THE NEXT DAY THE TRUCK WOULD NOT START AT ALL. IT WOULD CRANK, BUT NOT TURN OVER. THE SHOP I TOOK IT TO DID THE DIAGNOSIS AND IT TURNED OUT THAT IT WAS NOT BAD GAS OR A CLOGGED FUEL LINE. IT WAS A FAULTY FUEL CONTROL MODULE LOCATED ABOVE THE SPARE TIRE. THIS MODULE IS FLAWED NOT ONLY IN DESIGN BUT IN PLACEMENT AS WELL. IT IS NOT WEATHERPROOF AND NOT EVEN THE RIGHT TYPE OF METAL TO BE EXPOSED TO SALT, SAND AND WATER. IT HAS DISSIMILAR METAL FROM THE TRUSS IT MOUNTS TO, DISINTEGRATED OVER TIME AND I ALSO QUESTION FORD'S SUPPOSED FIX TO THE PROBLEM (SPACERS). HTTP://WWW.YOUTUBE.COM/WATCH?V=_2E9KMF1_KG IT SHOULD BE COMPLETELY REDESIGNED WITH YEARS OF RUST BELT ELEMENT EXPOSURE IN MIND. YOU DON'T WANT TO HAVE AN ENGINE STALL - EVER. (I WOULD HAVE PUT IT INSIDE THE CAB OR UNDER THE HOOD). WHY IS THIS NOT MORE IMPORTANT THAN A FLAWED HEADLAMP? *TR

THE DRIVER'S SIDE WINDOW REGULATOR ON MY 2006 FORD F150 HAS BROKEN THREE TIMES, I WAS ABLE TO GET TWO REPLACED UNDER WARRANTY, BUT THE THIRD TIME HAPPENED THIS LAST MONTH, I AM REPLACING IT TODAY. I BELIEVE FROM MY EXPERIENCE, AND FROM THOUSANDS OF FORUM ENTRIES CITING THE SAME THING, THAT FORD SHOULD RECALL THIS PART. THIS PART IS GOING TO COST ME APPROXIMATELY $400.00 TO REPAIR. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150 SUPER CREW CAB. THE CONTACT STATED THAT THE DRIVER'S SIDE WINDOW REGULATOR FAILED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 108,000.

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED THAT WHILE DRIVING 30 MPH DURING A RAIN STORM AND DEPRESSING THE BRAKES, THE VEHICLE EXHIBITED AND UNUSUALLY LOUND DOUBLE CLUNKING NOISE AS THE VEHICLE SKIDDED AND FLIPPED OVER. THE VEHICLE DID NOT CRASH INTO ANY OTHER OBJECT. THE POLICE WERE NOTIFIED HOWEVER, A REPORT WAS NOT FILED. THE CONTACT SUSTAINED AN AMPUTATED ARM DURING THE CRASH. THE VEHICLE WAS TOWED BY THE POLICE AND WAS DEEMED AS DESTROYED. THE CONTACT MENTIONED THAT JUST PRIOR TO THE CRASH, THE VEHICLE WAS TAKEN TO FIRESTONE FOR MAINTENANCE AND THE REPLACEMENT OF THE ROTOR AND FRONT BRAKE PAD. THE MANUFACTURER WAS NOT NOTIFIED OF THE INCIDENT. THE FAILURE MILEAGE WAS 78,912. UPDATED 2/4/13 *CN UPDATED 2/20/2013 *JS

THE BRAKES STARTED JUMPING WHEN I STARTED SLOWING DOWN AND SO I REPLACED THE BRAKES .. AND NOW EVEN WITH NEW BRAKE PADS THEY GO DOWN TO THE FLOOR. *TR

I AM 6'5" AND WEAR SIZE 16 SHOES. WITH MY SIZE AND THE DISTANCE TO THE PEDAL MY LEGS GO A LITTLE TO THE SIDE AND MY SHOE IS AT AN ANGLE TO THE PETALS LETS SAY 30 DEGREES. I WEARING TYPICAL WORK BOOT (LIKE IN FORD COMMERCIALS) WHICH THE LACES HAVE PEGS THE SHOE LACES GO AROUND. THESE PEGS ARE THE SAME AS ALL WORK BOOTS (RED WINGS - $300 BOOT). WHAT HAPPENED IS BECAUSE THE BRAKE PEDAL HAS A THICK RUBBER PAD THAT STRETCHES AROUND THE METAL BRAKE PEDAL AND LEAVES A RIDGE IN THE BACK OF THE PEDAL ALL THE WAY AROUND (SO THE RUBBER FITTING GOES OVER IT LIKE A SHOWER CAP). ALSO THE TRUCK IS AN AUTOMATIC AND THE BREAK PEDAL IS VERY LARGE. WHILE BACKING UP GIVING JUST A LITTLE GAS MY BOOT SHOE LACE PEG GOT TRAPPED BEHIND THE BRAKE PEDAL AND WAS HOLDING MY FOOT ON THE GAS PEDAL DEPRESSING IT DOWN. BECAUSE THE RUBBER RIDGE RUNS ALL THE WAY AROUND MY PEDAL (AS DESIGNED) I COULD NOT MOVE MY FOOT TO THE SIDE OF THE BRAKE PEDAL TO RELEASE THE GAS. BECAUSE OF THE THICKNESS OF MY FOOT WHEN I PRESSED THE BREAK WITH MY OTHER FOOT, IT MOVES THE GAS PEDAL DOWN AT THE SAME RATE AS MY FOOT IS TRAPPED, SO THE MORE YOU PRESS THE BRAKE THE MORE YOU GIVE GAS AT A RATIO THAT DOES NOT LET ME STOP THE VEHICLE. (NOTE I USE ONLY ONE FOOT FOR THE GAS AND BRAKE NORMALLY BUT WITH MY RIGHT FOOT TRAPPED I HAD NO OTHER CHOICE BUT TO USE MY LEFT FOOT TO BRAKE AND TRY TO GET IT THE TRUCK OUT OF GEAR . I COULD NOT DO ANYTHING IN TIME AND HIT A STATIONARY BUILDING. IF SOMEONE WAS BEHIND ME, THEY WOULD HAVE BEEN KILLED. THE ONLY OTHER WAY I COULD HAVE GOTTEN MY FOOT LOOSE IS TO DEPRESS THE GAS PEDAL WHICH IS NOT AN OPTION IN A LOT OF SITUATIONS BECAUSE IT WOULD MAKE THE SPEED OF THE IMPENDING IMPACT FASTER AND HARDER. THIS IS A DESIGN FLAW THAT TRAPS WORK BOOTS AND AT CERTAIN TIMES AND CAUSES LOOSE CONTROL. *TR

ACCORDING TO THE MODEL YEAR FORD F150 MAINTENANCE MANUAL, SPARK PLUGS ARE TO BE CHANGED EVERY 100,000MI. JUST PRIOR TO THIS MILEAGE FOR REMOVAL AND REPLACEMENT OF THE SPARK PLUGS THE ENGINE STARTED TO DEVELOP A MISFIRE. FORD HAS RECOGNIZED THE PROBLEM WITH THE SPARK PLUGS AND THE DIFFICULTY TO REMOVE THEM. THIS KNOWN MAINTENANCE ISSUE LED FORD TO PROVIDE A TSB ON THE ISSUE. THIS MISFIRE HAS ALMOST CAUSED ME TO STALL SEVERAL TIMES WHILE TOWING A 7,000LB BOAT. THIS IS DANGEROUS AND CREATES A SAFETY ISSUE FOR MYSELF AND THE MOTORISTS AROUND ME. I EXPRESS CONCERN THAT FORD SHOULD BE REPLACING THESE DEFECTIVE PLUGS WITH UPDATED DESIGNS BEFORE TRAGEDIES START TO HAPPEN. THIS ENGINE/SPARK PLUG DESIGN ENTERED SERVICE IN 2004 AND VEHICLES, LIKE MINE, WILL BEGIN TO EXPERIENCE SERIOUS SAFETY RELATED INCIDENTS IF IT IS NOT ADDRESSED. *TR

I WAS DRIVING TOWARDS WORK WHEN ALL THE SUDDEN THE TRUCK DIED. AFTER SAFELY PULLING ON THE SIDE OF THE ROAD. THE TRUCK DID NOT START AT ALL. ACCORDING TO MY FAMILY MECHANIC, IT WAS THE FUEL PUMP. I PAID 540 FOR THE FIX INCLUDING THE PART FROM THE FORD DEALERSHIP. A FEW DAYS LATER, THE TRUCK DID NOT START ON THE MORNING GOING TO WORK. MY FAMILY MECHANIC CAME AND DID A FEW TEST AND FOUND OUT IT WAS THE FUEL PUMP MODULE. HE THEN REPLACED SUCH MODULE. THE MODULE WAS RUSTED AND IT WAS FALLING APART. AFTER HE REPLACE IT WITH A NEW ONE, THE TRUCK STARTED AND IS WORKING PROPERLY. HE CHARGED ME 300 INCLUDING THE PART FROM THE DEALER. *TR

THE PASSENGER ASSIST HANDLE ATTACHED TO THE A PILLAR ON THE PASSENGER SIDE OF THE VEHICLE FAILED AT BOTH CONNECTION POINTS TO THE A PILLAR WHILE MY WIFE WAS ENTERING THE VEHICLE. MY WIFE WAS STANDING ON THE RUNNING BOARD AT THE TIME OF THE FAILURE OF THE ASSIST HANDLE, THE HANDLE COMPLETELY SEPARATED FROM THE VEHICLE AND SHE FELL OFF THE RUNNING BOARD WITH THE HANDLE IN HER HAND, LANDING ON HER BACK AGAINST A CURB IN THE PARKING LOT. THIS IS THE THIRD FAILURE OF THIS PART SINCE THIS VEHICLE WAS PURCHASED NEW ON 10/06/2006. THE FIRST FAILURE OCCURRED WITHIN THE FIRST 12 MONTHS OF OWNERSHIP. THE SECOND FAILURE HAPPENED WITHIN THE FIRST 36 MONTHS OF OWNERSHIP. AFTER EACH INCIDENT, FORD REPLACED THE DEFECTIVE PART WITH AN IDENTICAL PART. THE FIRST TWO INCIDENTS DID NOT RESULT IN INJURY TO MY PASSENGER. FORTUNATELY, MY WIFE WAS NOT SERIOUSLY INJURED IN THE RECENT EVENT. *TR

I WAS DRIVING HOME AND SLOWED DOWN TO 15 MILES PER HR TO MAKE A LEFT HAND TURN AND HEARD A BIG BANG I DID NOT KNOW WHAT HAPPENED AT THE MOMENT I CONTINUED TO PROCEED ON AND THE NOISE WAS LOUD LIKE AN EXHAUST LEAK BUT TO COME FIND OUT THE NEXT TWO DAYS ON THINKING WHAT TO DO I PULLED OFF THE #4 PLUG IT WAS OUT OF THE MOTOR ALREADY IT ACTUALLY BLEW OUT OF THE ENGINE. WHAT ARE MY RIGHTS IF ANY? *TR

ABS SENSOR SHORTED OUT AND FUSED TO WIRE HARNESS FOR WHOLE ELECTRICAL SYSTEM, FORD CLAIMS NO RECALL, COULD HAVE CAUSED MAJOR FIRE, NOTED COMPLAINT #10195595 WAS VERY SIMILAR. CAUSED $2300 DOLLAR REPAIR. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE COVER TAIL GATE FELL AND DETACHED FROM THE VEHICLE. THE FAILURE RECURRED AND THE ENTIRE PART THAT COVERED THE TAIL GATE WAS MISSING. THE VEHICLE WAS TAKEN TO A REPAIR SHOP HOWEVER, THE VEHICLE WAS NOT REPAIRED AND THE PART WAS STILL MISSING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT NO ASSISTANCE WAS PROVIDED. THE VIN WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGE WAS 62,000.

THE PASSENGER SIDE SEAT BELT HAS BECOME UNUSABLE DUE TO NOT COMING OUT TO BE ABLE TO BELT IN PASSENGERS. ALSO, IT WILL NOT RETRACT FULLY. THIS IS A SERIOUS SAFETY ISSUE, DUE TO SEAT BELT LAWS AND REGULATIONS AND PASSENGER SAFETY ISSUES, AND SHOULD BE ADDRESSED AND FIXED ON ANY FORD THAT IS HAVING SUCH ISSUES OR SIMILAR ISSUES. *TR

ON JULY 1, 2012, MY 2006 FORD F-150 SUPER CREW TRUCK CAUGHT ON FIRE WHILE SITTING IN MY DRIVEWAY. THE TRUCK HAD BEEN SITTING UNTOUCHED FOR A WEEK WHEN IT CAUGHT ON FIRE WITHOUT ANY EXPLANATION. FIRE INVESTIGATORS WERE UNABLE TO DETERMINE THE CAUSE OF THE FIRE BECAUSE THE TRUCK WAS APPROXIMATELY 90% BURNED. *TR

STEERING BECAME VERY HARD TO TURN. WOULD NOT CENTER AFTER TURNING, WOULD LOCK ON WET ROADS. I HAD TO TURN THE STEERING WHEEL BY HAND TO GET IT BACK TO CENTER. I CHECKED TO FIND THE U JOINTS ON STEERING SHAFT WHERE RUSTED SO I LUBED WITH OIL. STEERING BECAME MUCH BETTER. I WENT TO A LOCAL FORD DEALER THEY SAID THERE WAS NO RECALLS AND KNEW OF NO PROBLEMS WITH THE STEERING ON THE F150'S. THE FORD DEALER WANTED ME TO LET THEM TAKE EVERYTHING APART BUT SAID IT COULD RUN INTO A LOT OF MONEY DEPENDING ON WHAT THEY FIND. SO FOR OVER THREE YEARS I'VE BEEN OILING THE JOINTS ON THE SHAFT AND LIVING WITH THE PROBLEM. WAITING FOR TOTAL FAILURE TO SUE FORD FOR POOR DESIGN OF THE STEERING COLUMN SHAFT JOINTS. *TR

I WAS DRIVING ON THE HIGHWAY WHEN ALL OF MY GAUGES WENT DEAD INCLUDING THE SPEEDOMETER, A COUPLE OF MINUTES LATER THEY CAME BACK ON AND WHEN THEY DID THE AIRBAG WARNING LIGHT STARTED BLINKING RAPIDLY. A FEW MOMENTS LATER THE GAUGES WENT DEAD AGAIN, WHEN THEY CAME BACK ON THE SECOND TIME THE AIRBAG WARNING LIGHT STARTED BLINKING RAPIDLY AND ERRATICALLY. SINCE THAT TIME MY GAUGES HAVE FAILED 3 MORE TIMES WITH THE SAME BEHAVIOR FROM THE AIRBAG WARNING LIGHT. I DID SOME RESEARCH ONLINE AND FOUND THAT EVEN THOUGH FORD HAS NOT RECALLED THIS PROBLEM IT HAS BEEN EXPERIENCED BY HUNDREDS OF 2006 FORD F150 OWNERS. *TR

I HAD A FUEL INJECTOR FAIL THAT COMPLETELY RUINED THE ENGINE AT 71K MILES. I HAD TO HAVE IT REPLACED. I WAS VERY SURPRISED TO SEE THAT MY PROBLEM WAS EXACTLY LIKE THE FORD 2005 CUSTOMER SATISFACTION PROGRAM 07M08 PROBLEM. MY TRUCK WAS BUILT IN 2005, BUT TITLED AS A 2006. I HAVE TALKED AND WROTE TO FORD BUT THEY WOULD NOT HELP ME. I TOLD THEM I STILL HAVE THE FAILED INJECTOR AND THEY WOULDN'T EVEN LOOK AT IT TO SEE IF IT WAS ONE OF THE DEFECTIVE PARTS THAT SPURRED THE 07M08 PROGRAM. I BELIEVE FORD NEEDS TO EXPAND THE CUSTOMER SATISFACTION PROGRAM 07M08 TO INCLUDE 2006 MODELS. I WOULD LOVE FOR THE NHTSA TO PRESSURE FORD TO REVISIT THIS ISSUE. THIS WAS HARD FOR ME BECAUSE I STILL HAVE THE INJECTOR THAT FAILED. I KEEP IT AS A REMINDER OF THE $8,000 I HAD TO SPEND ON A NEW ENGINE. I BELIEVE THE NHTSA SHOULD PRESSURE FORD TO ADMIT WHICH INJECTORS WERE AN ISSUE SO PEOPLE LIKE ME HAVE LEVERAGE TO FIGHT GIANTS LIKE FORD THAT IN THIS CASE SCREWED THEIR CUSTOMER. *JS

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT BOTH OF THE DECALS ON THE VEHICLE WERE FADED AND DELAMINATED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT CONTACTED. UPDATED 07/13/12*LJ UPDATED 07/17/12

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT TOOK THE VEHICLE FOR A ROUTINE OIL CHANGE WHEN HE WAS ADVISED BY THE MECHANIC THAT FOUR OF THE SPARK PLUGS WERE UNABLE TO BE REMOVED FOR REPLACEMENT. THE SPARK PLUGS WERE NOT OF GOOD QUALITY AND WOULD NEED TO BE REPLACED MORE OFTEN THAN USUAL. THE MANUFACTURER WAS MADE AWARE, HOWEVER NO ASSISTANCE WAS PROVIDED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE CURRENT AND FAILURE MILEAGE WAS 72,000.

THE PASSENGER IN MY VEHICLE TRIED ROLLING UP THE WINDOW WHILE AT A STOPLIGHT AND IT WOULD NOT GO UP. THE WINDOW SWITCH WILL WORK TO ROLL THE WINDOW DOWN BUT NOT TO ROLL IT UP. AFTER APPROXIMATELY 11 MONTHS THE DRIVERS SIDE WINDOW IS DOING THE SAME THING, WILL GO DOWN BUT NOT UP. WITH THE WINDOW STUCK IN THE DOWN POSITION, MY VEHICLE IS NOW EXPOSED TO THE ELEMENTS, RAIN PARTICULARLY, AND I FEAR THE WATER FROM THE RAIN IS GOING TO AFFECT THE REST OF MY DOOR SWITCHES, AND POSSIBLY RUIN THE LEATHER SEATS AND THE POWER FUNCTIONS FOR MY SEATS AS WELL. IT IS A DISTRACTION AND A HAZARD TO HAVE TO DRIVE WITH THE WINDOW DOWN CONSTANTLY. *TR

TRANSMISSION SHIFT CABLE OUTER SHEATH WAS MELTED ON EXHAUST SYSTEM. CABLE HAD UNKNOWINGLY COME LOOSE OF A RETAINING CLIP AND WAS THEN ALLOWED TO CONTACT HOT EXHAUST MANIFOLD. MELTED THE OUTER PLASTIC OF SHIFT CABLE CAUSING THE SHIFT SELECTOR TO BECOME INOPERABLE. SHIFT SELECTOR COULD BE PLACED IN PARK BUT TRANSMISSION WOULD NOT BE IN PARK; IF I HAD NOT REALIZED THERE WAS A PROBLEM I COULD HAVE BELIEVED THE TRANSMISSION WAS IN PARK WHEN IT WAS NOT AND THE TRUCK COULD HAVE ROLLED FREELY. TRUCK IS A WELL MAINTAINED 2006 FORD F150 CREW CAB 4X4 WITH THE COLUMN SHIFTER. *TT

WHILE PULLING VEHICLE INTO GARAGE THE VEHICLE SUDDENLY ACCELERATED. I DID NOT HAVE A FLOOR MAT ON THE FLOOR. THIS IS ABOUT THE FOURTH TIME THIS HAS HAPPENED SINCE I BOUGHT THE VEHICLE NEW. I TOOK THE VEHICLE TO THE FORD DEALER APPROXIMATELY 2 YEARS AGO AND THEY COULD NOT DUPLICATE OR DETERMINE THE PROBLEM. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE TRAVELING 40 MPH, THE VEHICLE ATTEMPTED TO STALL AND WOULD NO LONGER ACCELERATE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE FAILURE WAS CAUSED BY A BAD SPARK PLUG DESIGN. THE CONTACT WAS ALSO INFORMED THAT THE SPARKS HAD FRACTURED EACH TIME THEY ATTEMPTED TO REMOVE THE SPARK PLUGS. THE VEHICLE WAS NOT REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 52,000.

SEAT BELT TENSIONER ON VEHICLE GOES BAD AND AIRBAG LIGHT WILL COME ON INTERMITTENTLY AND STAY ON WHILE DRIVING. PER FORD MOTOR COMPANY AIR BAG MIGHT OR MIGHT NOT DEPLOY IN ACCIDENT WHICH PUTS MY LIFE ENDANGER. *TR

TL* THE CONTACT OWNS 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE POWER STEERING FAILED AND SEIZED. THE CONTACT THEN DROVE TO HIS RESIDENCE AND ADDED POWER STEERING FLUID BUT THE FLUID LEAKED OUT OF THE VEHICLE. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER WHERE THEY COULD NOT DUPLICATE THE FAILURE. THE DEALER STATED THAT THE POWER STEERING WAS REPAIRED. AFTER SEVERAL MONTHS, THE POWER STEERING FAILED AGAIN. THE VEHICLE WAS NOT COMPLETELY REPAIRED. THE FAILURE MILEAGE WAS 70,000 AND THE CURRENT MILEAGE WAS 87,000. UPDATED 07/06/12 *BF THE CONSUMER TOOK THE VEHICLE TO A REPAIR A SHOP AND A DIAGNOSIS REVEALED THE RACK AND PINION NEEDED TO BE REPLACED. ALSO, THE POWER STEERING HOSE WAS REPLACED TWICE, THE O-RING, POWER STEERING PUMP AND POWER STEERING LINE WERE REPLACED. UPDATED 08/08/12

BRAKES FAILED AT LOW SPEED AVOIDING INCIDENT. LOST VACUUM TO BRAKING SYSTEM RESULTING IN STIFF MANUAL STYLE BRAKING. LOOKED ONLINE FOR RECALL AND SAW WHAT APPEARED TO BE THE EXACT SAME THING FOR MY YEAR AND VEHICLE DESCRIPTION. CALLED DEALERSHIP AND WAS TOLD THAT MY VEHICLE IS NOT PART OF THIS RECALL. WELL, IT SHOULD BE. IT WAS THE EXACT ISSUE AND PART AS IS DESCRIBED IN RECALL NHTSA CAMPAIGN ID NUMBER : 08V208000 NHTSA ACTION NUMBER: PE08001 COMPONENT: SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM:HOSES, LINES/PIPING, AND FITTINGS. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED HIM THAT THE SPARK PLUGS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 55,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE VEHICLE DRIFTED BACKWARD AND CRASHED INTO ANOTHER VEHICLE. THE CRASH CAUSED NO INJURIES AND A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 96,000 AND THE CURRENT MILEAGE WAS 96,500.

THE NUMBER 3 SPARK PLUG WAS BLOWN OUT OF THE CYLINDER HEAD. THIS IS THE SECOND OCCURRENCE OF THE SAME SPARK PLUG. THE FIRST INCIDENT OCCURRED ON 10/21/2011 AT 82781 MILES. THE FIRST REPAIR WAS COMPLETED BY MIKE NAUGHTON FORD IN AURORA CO. THE MECHANIC INSTALLED A SLEEVE INTO THE CYLINDER HEAD TO REINSTALL A NEW SPARK PLUG. THE MECHANIC EXPLAINED THAT THIS IS A KNOWN PROBLEM BECAUSE THE CYLINDER HEAD ONLY HAS 3-4 THREADS FOR THE SPARK PLUG TO SCREW INTO. *TR

THERE IS A FUEL DRIVE MODULE AND CONTROLS THE ELECTRICAL OUTPUT TO THE FUEL PUMP. OEM PART NUMBER FL8A-9D370-AA. THE MODULE IS MOUNTED TO THE ONE OF THE REAR FRAME CROSSBARS, ABOVE THE SPARE TIRE ON THE F150 PICKUPS. DUE TO THE PLACEMENT AND MOUNTING SALT AND ROAD DEBRIS GET STUCK BETWEEN MODULE AND FRAME AND CAUSE MASSIVE ERODING OF THE METAL HOUSING CAUSING THE MODULE TO FAIL. MY TRUCKS MODULE FAILED AT AROUND 44,000 MILES. *TR

I WAS DRIVING CASUALLY ON US17 NORTH ON MY WAY TO WORK. MY TRUCK SUDDENLY LOST POWER AND SERVICE ENGINE LIGHT ILLUMINATED. I TOOK IT IN TO THE DEALER THEY TOLD ME NOTHING WAS FOUND TO BE WRONG. THEN THE SAME EVENT HAPPENED ABOUT 7 MONTHS AFTER THAT. I BROUGHT THE VEHICLE BACK IN FOR DIAGNOSIS AND REPAIR. THEY TOLD ME NOTHING WAS WRONG AND TO TAKE IT BACK AND STOP WASTING THEIR TIME. I ASKED THEM TO KEEP IT AND GIVE ME A DIFFERENT VEHICLE IN WHICH THEY WOULD NOT. I LEFT THE TRUCK WITH THE DEALER AND FORD MOTOR CREDIT REPOSSESSED THE FAULTY VEHICLE. *TR

TRUCK DOES NOT START FUEL PUMP DOES NOT RUN . REMOVE SPARE TIRE FOR ACCESS AND FOUND FUEL PUMP DRIVER MODULE BROKEN AND CORRODED. SHOULD BE A RECALL!!! *KB

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE DEALER ADVISED THE CONTACT THAT THE FUEL MODULE WAS FRACTURED, DETERIORATED AND NEEDED TO BE REPLACED. THE MANUFACTURER HAD NOT BEEN NOTIFIED OF THE FAILURE. NO REPAIRS WERE PERFORMED. THE CURRENT AND THE FAILURE MILEAGES WERE 58,000.

I HAD TO REPLACE ALL OF THE GEARS AND THE INSIDE AND OUTSIDE BEARINGS AND SEALS IN THE REAR END - ON A TRUCK THAT HAD 87,000 MILES. EVERY DEALERSHIP I'VE SPOKEN TO HAS TALKED ABOUT THE CHEAP BEARINGS IN THE FRONT AND REAR END ON THESE FORD F-150'S. 18,000 MILES AGO I HAD TO FIX THE FRONT END. *KB

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT WAS DRIVING APPROXIMATELY 55 MPH IN THE CENTER LANE AND SUDDENLY CRASHED INTO THE PROCEEDING VEHICLE. THE CONTACT SUSTAINED AN INJURY TO THE NECK AND LEFT HAND. IN ADDITION, THE LEFT SIDE OF HER SHOULDER WAS BRUISED. THE VEHICLE WAS COMPLETELY DESTROYED AND TOWED TO A SAVAGE FACILITY. THE AIR BAGS FAILED TO DEPLOY WITH THE IMPACT. THE MANUFACTURER WAS NOT NOTIFIED OF THE AIR BAG MALFUNCTION. THE APPROXIMATE FAILURE MILEAGE WAS 61,000.

THE STEERING SHAFT IS SIEZIHG CAUSING THE WHEEL NOT TO CENTER IT SELF AND STEERS HARD . IT DOES NOT SELF CENTER AFTER CORNERING. YOU CAN'T TELL IF YOUR WHEEL IS TURNED ON SLIPPERY ROADS . I CALLED FORD MOTOR COMPANY AND THEY TOLD ME IT'S NOT A SAFETY ISSUE . I'M A LICENSED MECHANIC AND THIS HARD STEERING WOULD NOT PASS A MOTOR VEHICLE SAFETY INSPECTION IN OUR SHOP.I THINK FOMOCO SHOULD FIX THIS . AS FAR AS I'M AWARE IT IS ONLY THE 2004-2008 MODEL TRUCKS.

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT WAS DRIVING APPROXIMATELY 35 MPH AND NOTICED THE INSTRUMENT PANEL LED LIGHT FAILED TO ILLUMINATE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO ADVISED THE CONTACT THAT THE INSTRUMENT PANEL CLUSTER WOULD NEED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE MALFUNCTION. THE APPROXIMATE FAILURE MILEAGE WAS 23,000. UPDATED 02/08/12

UNDER NORMAL OPERATION THE GAS PEDAL STOPS RESPONDING,THE CHECK ENGINE LIGHT COMES ON AND AFTER ABOUT 30 SECONDS THE ENGINE SHUTS OFF. I HAVE TO STOP , PUT THE TRUCK IN PARK , TURN OFF THE KEY AND RESTART THE TRUCK. THIS RESETS THE COMPUTER AND THE TRUCK SEEMS FINE FOR A WHILE TILL IT HAPPENS AGAIN. THIS HAS HAPPENED SEVERAL TIMES MOSTLY ON BACK ROADS. TODAY IT HAPPENED WHILE I WAS ENTERING A BUSY HIGHWAY. I WAS ALMOST HIT BY ON COMING TRAFFIC. *TR

ON THREE OCCASIONS, WHILE PUMPING GAS INTO MY TRUCK, THE FUEL NOZZLE SHUTS OFF AND OVERSPRAYS ON TO THE SIDE OF MY TRUCK. THIS HAS HAPPENED AT 3 DIFFERENT GAS STATIONS. I FEEL THAT THIS COULD BE A FIRE HAZARD AS WELL AS A HEALTH HAZARD IT WERE TO HAPPEN TO AN ELDERLY PERSON. THE PUMP NOZZLE DOES NOT FIT SNUGLY INTO THE FUEL TANK. I THINK IT IS BECAUSE OF THE ANGLE THAT THE FUEL LINE GOING INTO THE FUEL TANK IS POSITIONED, IT ALMOST SEEMS TO STEEP OF A TURN. ALL THREE TIMES THE FUEL BACKS UP INTO THE TANK AND OVERSPRAYS ME IF I'M STANDING CLOSE. I'VE LEARNED NOT TO STAND CLOSE NOW, BUT I STILL GET FUEL ALL ON ME WHEN I HAVE TO HANG UP THE FUEL PUMP, AND FUEL IS ALL ON THE SIDE OF MY TRUCK NOW TOO.... VERY IRRITATING FORD! *TR

WHEN DRIVING VEHICLE AT ALL DIFFERENT SPEEDS, STEERING BECOMES DIFFICULT AND WHEEL RESISTS TURNING. AFTER TURN IS MADE WHEEL DOES NOT RETURN BY ITSELF BUT NEEDS TO BE FORCED BACK WITH GREAT RESISTANCE. CONDITION WENT AWAY FOR A MONTH BUT THEN RETURNED IN OCTOBER OF 2011, AND HAS BEEN DIFFICULT SINCE. VERY DANGEROUS. *TR

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE DEALER PERFORMED A DIAGNOSTIC AND LOCATED THE FAILURE AS THE ENGINE LOCKING DUE TO DEFECTIVE PARTS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND THE CURRENT MILEAGE WAS 128,183.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE HAVING ROUTINE MAINTENANCE PERFORMED ON THE VEHICLE, THE DEALER ADVISED HIM THAT THE SPARK PLUGS NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 52,000.

THIS IS IN REGARDS TO FORD'S 2006 F150 DRIVER SIDE AIR BAG RECALL. FORD IS REFUSING TO GIVE THE DEALERSHIPS THE KEY TO UNLOCK THE ANTI THEFT BOX THAT THE AIR BAG IS IN TO DO THE SAFETY RECALL. THEY INSTRUCT THE SERVICE TEAM TO "USE A DREMEL TOOL". THIS IS NOT ACCEPTABLE. SERVICE TEAM IS "NOT COMFORTABLE" USING A DREMEL TO FIX THIS. ANY THING DONE LIKE THIS TO THIS VEHICLE WILL VOID ANY AND ALL WARRANTIES!!!! SAFETY RECALL HAS NOT BEEN DONE ON THIS VEHICLE. *TR

ON 3 SEPARATE OCCASIONS WHEN BRAKES WERE APPLIED THE VEHICLE ACTUALLY SPED-UP AND WAS ONLY BROUGHT TO A STOP THROUGH HEAVY PRESSURE TO THE BRAKE PEDAL. *TR

THIS IS THE SAME THING THAT HAPPENS TO MINE AS SOMEONE ELSE HAD ALREADY POSTED.. POWER STEERING BECOMES 'HARD'. STEERING WHEEL SUDDENLY BECOMES STIFF AND DIFFICULT TO HANDLE. HARD TO TURN. CHOPPY WHILE TURNING AND SNAPS BACK IN INCREMENTS INSTEAD OF A SMOOTH, EASY RETURN TO CENTER. FEELS LIKE MANUAL STEERING THEN RETURNS TO POWER STEERING. OCCURS AT ANY SPEED, VERY DANGEROUS AT HIGHER SPEEDS. MAKES THE VEHICLE STEER 'CHOPPY' AND UNPREDICTABLE. HAVE STOPPED USING THE VEHICLE, CAUSES A DANGEROUS SITUATION WHILE DRIVING AND TRYING TO MAINTAIN CONTROL OF THE TRUCK. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE DRIVING 55 MPH THERE WAS A KNOCKING AND BANGING NOISE IN THE ENGINE WHICH CAUSED THE VEHICLE TO MALFUNCTION. THE VEHICLE WAS THEN DRIVEN HOME. THE DEALER WAS NOT NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 66,000. RVK

POWER STEERING BECOMES 'HARD'. STEERING WHEEL SUDDENLY BECOMES STIFF AND DIFFICULT TO HANDLE. HARD TO TURN. CHOPPY WHILE TURNING AND SNAPS BACK IN INCREMENTS INSTEAD OF A SMOOTH, EASY RETURN TO CENTER. FEELS LIKE MANUAL STEERING THEN RETURNS TO POWER STEERING. OCCURS AT ANY SPEED, VERY DANGEROUS AT HIGHER SPEEDS. MAKES THE VEHICLE STEER 'CHOPPY' AND UNPREDICTABLE. HAVE STOPPED USING THE VEHICLE, CAUSES A DANGEROUS SITUATION WHILE DRIVING AND TRYING TO MAINTAIN CONTROL OF THE TRUCK. *TR

TRANSMISSION JUMPS IN HIGH GEAR WHEN OVERDRIVE IS ACTIVE. *TR

SPARK PLUGS ARE ENGINEERED COUNTER SUNK IN HOLES IN TOP OF THE HEADS, WHEN THE PLUGS ARE UNSCREWED THE BOTTOM OF THE PLUG MORE OFTEN THAN NOT BREAKS OFF INSIDE THE SPARK PLUG HOLE. THIS REQUIRES VERY EXPENSIVE TOOLS AND A SKILLED MECHANIC TO EXTRACT. I FEEL THE PART WAS ENGINEERED TO FAIL TO FORCE THE PRICE OF REPAIRS UP. LEADING UP TO THIS WHEN THE PLUGS BEGIN TO FAIL THE ENGINE WILL FAIL WITHOUT WARNING AND WITHOUT THE ENGINE NEEDS SERVICE LIGHT EVER COMING ON. WHEN THIS HAPPENS AND THEIR IS NO PLACE TO PULL OVER YOU HOPE YOUR NOT RAN INTO BY ONCOMING TRAFFIC. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING HIGHWAY SPEEDS, THE WRENCH WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE THEN DECELERATED, LOST POWER AND STALLED. THE DEALER AND THE MANUFACTURER WERE CONTACTED BUT DENIED ANY ASSISTANCE WITH REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 52,000.

DRIVER PASSED OUT. VEHICLE CROSSED ONCOMING LANE OF TRAFFIC, LEFT ROAD ON SOUTH SIDE, CRASHED THROUGH A FENCE AND TRAVELED APPROXIMATELY 125'+ HITTING A LARGE OAK TREE HEAD ON. DRIVER (WHO WAS WEARING SEAT BELT) SLAMMED INTO STEERING WHEEL & COLUMN, AND WAS SERIOUSLY INJURED. VEHICLE HAD HEAVY DAMAGE, AND NOT REPAIRABLE.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VACUUM HOSE WAS LEAKING AND DID NOT APPLY POWER TO THE BRAKING SYSTEM. THE FAILURE CAUSED EXTREME RESISTANCE IN THE BRAKE PEDAL WHEN DEPRESSED. THE CONTACT HAD TO UTILIZE THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS ADVISED THAT THE VACUUM HOSE NEEDED TO BE REPLACED. THE DEALER WAS NOTIFIED OF THE FAILURE WHO STATED THAT THERE WAS A RECALL FOR THE FAILURE UNDER NHTSA CAMPAIGN ID NUMBER: 08V208000 (SERVICE BRAKES, HYDRAULIC: POWER ASSIST: VACUUM: HOSES, LINES/PIPING, AND FITTINGS) BUT THE CONTACT'S VIN WAS NOT INCLUDED IN THE RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE WHO OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 82,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE BEGAN TO SHAKE VIGOROUSLY AND THERE WAS A STRONG GASOLINE ODOR IN THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE MECHANIC ADVISED THAT THE FUEL INJECTORS WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 56,000.

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED THAT ALL FOUR WINDOW REGULATORS FAILED AND AS A RESULT, SHE WAS UNABLE TO OPEN OR CLOSE THE WINDOW. AFTER SEVERAL ATTEMPTS, THE WINDOW WOULD OPEN HOWEVER, IT WOULD FAIL TO CLOSE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE ALL FOUR WINDOW SWITCHES WERE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE CURRENT MILEAGE WAS 57,900 AND THE APPROXIMATE FAILURE MILEAGE WAS 53,000.

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED THAT THE ENGINE EXHIBITED AN ABNORMAL NOISE WHILE DRIVING AT ANY SPEED OVER 30 MPH. THE VEHICLE WAS TAKEN TO THE LOCAL MECHANIC WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE NUMBER SEVEN AND EIGHT SPARK-PLUGS. THE MECHANIC ADVISED THAT THE SPARK PLUGS HAD SEPARATED FROM THE HOLDER AND CAUSED A PIECE OF THE SPARK PLUG TO PENETRATE THE ENGINE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 116,000. UPDATED 10/27/11*LJ UPDATED 12/06/2011 *LN

2006 FORD F-150. CONSUMER WRITES IN REGARDS TO REAR END OVERHAUL BEARINGS REPAIR *TGW THE CONSUMER STATED THE REAR PINION SEALS WERE REPLACED TWO YEARS AGO. THE CONSUMER BELIEVED THERE WAS SOMETHING WRONG WITH THE QUALITY OF WORK OR THERE WAS A MANUFACTURING DEFECT. THE DEALER AND FORD HAVE AGREED TO CUT THE BILL IN HALF TO $650. *JB

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT WAS DRIVING 70 MPH WHEN THE VEHICLE EXHIBITED A LOUD, ABNORMAL NOISE FROM UNDER THE HOOD FOLLOWED BY THE VEHICLE STALLING. THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AS THE NUMBER SEVEN SPARK PLUG HAVING RELEASED FROM THE COIL HEAD CAUSING THE COIL ASSEMBLY TO FAIL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 83,000.

PURCHASED A FORD 2006 F150 LARIAT HARLEY DAVIDSON EDITION FROM A USED CAR DEALERSHIP TOOK VEHICLE OUT FOR A TEST DRIVE AND NOTICED THAT IT HAD A MISSFIRE, DEALERSHIP PROMISED TO REPAIR A COIL WHICH THEY BELIEVED WAS THE ISSUE I WAS SENT TO A REPAIR FACILITY WHICH THE DEALERSHIP HAS ALL THEIR VEHICLES SERVICED. AFTER DIAGNOSING THE ISSUE WAS TOLD THAT THREE COILS WERE BAD AND THREE SPARK PLUGS WERE BROKEN OFF IN THE CYLINDER HEAD WHICH HAD TO BE REMOVED TO CLEAN OUT AND RESURFACED ALONG WITH THE VALVES AND PISTONS AT A COST OF $1,800.00 WHICH MY PURCHASED WARRANTY WOULD NOT COVER OR THE DEALERSHIP WOULD NOT COVER EITHER, SO AFTER READING NUMEROUS COMPLAINTS ON THIS ISSUE LISTED ON SEVERAL COMPLAINT FORUMS WAS WONDERING WHETHER THIS ORGANIZATION HAS TAKEN UP THE ISSUE WITH FORD? *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH, THE STEERING WHEEL BEGAN TO SHAKE EXCESSIVELY. THE CONTACT ALSO STATED THAT THERE WAS SMOKE COMING FROM UNDER THE HOOD. THE VEHICLE WAS SAFELY DRIVEN HOME, WHERE IT WAS INSPECTED BY AN INDEPENDENT MECHANIC. THE MECHANIC STATED THAT THE STEERING SHAFT, CENTER CAPS AND THE CALIPERS NEEDED TO BE REPLACED. THE MECHANIC ALSO STATED THAT THE CENTER HUB CAP BURNT DUE TO THE CALIPERS FRACTURING AND DETACHING FROM THE VEHICLE .THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 68,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THERE WAS NOISE IN THE REAR OF THE VEHICLE. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE REAR END NEEDED TO BE REPLACED. THE DEALER STATED THE WHEEL BEARINGS FAILED AND ALSO CAUSED THE GEARS TO FAIL. THE CONTACT STATED THE FAILURE WAS A MANUFACTURERS DEFECT BECAUSE THE MILEAGE WAS LOW WHEN THE FAILURE OCCURRED. THE FAILURE AND CURRENT MILEAGE WAS 50,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 25 MPH OVER A BUMP IN THE ROAD, THE AIR BAG WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHERE THEY STATED THAT THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER 1V107000 (AIR BAGS: FRONTAL: DRIVER SIDE INFLATOR MODULE). THE FAILURE OCCURRED WHENEVER THE ENGINE WAS IN OPERATION. THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

TRUCK RAN ROUGH WITH HAVE SMOKE FROM EXHAUST. TOOK TRUCK IN AT 41,000 TO FIX A BAD COIL ASSEMBLY, THEN AT 99,000 TO FIX A BAD COIL ASSEMBLY, INJECTOR AND O2 SENSOR. AT 111,000 MILES TWO MORE INJECTORS WENT BAD CAUSING TWO RODS TO BE BENT ALONG WITH ANOTHER BAD O2 SENSOR. SAME PROBLEM AS THE 2005 FORD THAT HAD A RECALL, BUT NOT THE 2006. TOTAL ESTIMATE TO FIX TRUCK $7500 PLUS TAX! FORD KNOWS ABOUT PROBLEM BUT WONT RECALL. *TR

TL* THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 20-55 MPH, THERE WAS EXCESSIVE HESITATION WITH AN INTERMITTENT ILLUMINATION OF THE CHECK ENGINE WARNING LIGHT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHO STATED A SPARK PLUG FRACTURED WITHIN THE ENGINE AND IT WOULD NEED A TUNE-UP. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED DURING ROUTINE MAINTENANCE, HE WAS NOTIFIED THAT BOTH OF THE COIL SPRINGS BROKE DUE TO CORROSION. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 95,000.

POWER STEERING FAILURE, STEERING BECAME HARD AT 10 AND 2, REPLACED THE PS PUMP, PROBLEM STILL EXISTS BUT AT 9 AND 3 NOW, STEERING SO HARD WHILE TURNING THAT IT COULD CAUSE A WRECK. AFTER READING ONLINE THINKING NOW THAT IT IS IN THE STEERING SHAFT. MANY PEOPLE HAVE HAD THE SAME TROUBLE AND SAYS THEY LUBRICATED THE PART AND IT GOT BETTER. I JUST DON'T WANT TO WRECK WHILE DRIVING WITH MY 4 CHILDREN. WOULD TAKE IT TO FORD BUT AFRAID THEY WILL SAY THINGS ARE WRONG THAT ARE NOT...DON'T WANT IT TO TURN INTO A MONEY GIMMICK. EXTREMELY HARD TO TURN FROM DEAD STOP. STILL TRYING TO FIGURE THE PROBLEM OUT ONE PART AT A TIME....62,000 APPROX. *KB

ON MAY 1,2011 I RECEIVED A RECALL NOTICE FROM FORD MOTOR CO. FOR RECALL # 11S18 ON MY 2006 F-150 TRUCK. I MADE AN APPOINTMENT WITH MCREE FORD IN DCKENSON, TX. THE NEXT DAY THEY CANCELLED THE SAYING APPOINTMENT STATING THEY DIDN'T HAVE THE PART AND WOULD GET BACK TO ME. I TRIED TO RESCHEDULE AGAIN, TO NO AVAIL. I CALLED FORD AGAIN WHO SAID I WOULD BE PUT ON THE PRIORITY LIST. 21/2 MONTHS HAVE PASSED AND STILL NO RESOLUTION. PLEASE HELP TO RESOLVE THIS MATTER. *TR

FORD F-150 AIR BAGS FAILED TO DEPLOY. *TT

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT HAD TO HAVE THE FRONT BEARINGS AND ROTORS REPLACED ON BOTH FRONT WHEELS OF THE VEHICLE AS A RECURRING FAILURE. THE CONTACT SPOKE WITH THE MANUFACTURER AND WAS TOLD THERE WERE NO RECALLS FOR THE VEHICLE. THE CONTACT BELIEVED THE FAILURE TO BE A SAFETY ISSUE AND WAS CONCERNED THAT THE WHEELS WOULD DETACH FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR POSSIBLE REPAIRS. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 136,000.

TO START OUT, IT SHOULD NOT COST $1249.00 TO CHANGE ONE SPARK PLUG... DUE TO FORD'S DESIGN FLAW ON THEIR MOTOR CRAFT SPARK PLUGS WHICH CAUSES TH EM TO BREAK EXTREMELY EASY, I AM BEING CHARGED TO TEAR DOWN MY ENTIRE ENGINE TO RETREIVE ONE SPARK PLUG!!! THIS IS FORD'S FAULT AND I FEEL THEY SHOULD BE HELD LIABLE FOR THE COST OF REPAIR. I HAVE BEEN TOLD BY SEVERAL MECHANICS THAT FORD DESIGNED THEIR MOTOR CRAFT PLUGS TO BREAK!! FORD IS ALSO THE ONLY ONE WHO CAN FIX THE PROBLEM. IT WAS NOT UNTIL I PAID OVER $400.00 TO CHANGE 2 COIL PACKS THAT I WAS HIT WITH THIS PRICE. THIS F-150 WOULONLY DO 30-35 MPH ON THE INTERSTATE HIGHWAY...I COULD HAVE BEEN KILLED IF I WAS HIT FROM BEHIND!! THESE SPARK PLUGS SHOULD BE RECALLED AND I SHOULD BE REIMBURSED! MY TRUCK IS STILL AT THE FORD DEALERSHIP AFTER A WEEK...I ALREADY PAID $126.00 FOR MY MOTOR CRAFT PARTS BY CASH EVEN BEFORE TAKING MY TRUCK TO THEM. THIS IS NOT RIGHT ON THE PART OF FORD TO DESIGN A VEHICLE LIKE THAT. PLEASE INVESTIGATE THIS DEFECT PROBLEM SO OTHERS ARE NOT CHARGED LIKE I AM BEING CHARGED. PLEASE RECALL THESE SPARK PLUGS !!!! *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE SPARK PLUGS FRACTURED WHEN A MECHANIC ATTEMPTED TO REMOVE AND REPLACE THEM. AN AUTHORIZED DEALER WAS NOTIFIED AND INFORMED THE CONTACT THAT HE WOULD HAVE TO PAY ADDITIONAL COSTS TO HAVE THE VEHICLE REPAIRED DUE TO THE SPARK PLUGS BREAKING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 93,000. ..UPDATED 09/15/11 *BF UPDATED 09/26/11

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED WHILE HAVING A TUNE-UP PERFORMED AT THE DEALER, ONE OF THE SPARK PLUGS BECAME LODGED IN THE CYLINDER HEAD. THE DEALER ADVISED THAT THE CYLINDER HEAD WOULD BE SENT OUT TO HAVE THE SPARK PLUG MACHINED OUT. THE VEHICLE WAS LEFT WITH THE DEALER WHERE THE CONTACT WAS AWAITING REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 91,000.

SPARK PLUGS ARE SNAPPING OFF BECAUSE OF HEAT IN THE ALUMINUM HEAD.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED AN APPOINTMENT WAS SCHEDULE WITH THE DEALER THREE WEEKS AGO TO HAVE NHTSA RECALL CAMPAIGN ID NUMBER: 11V107000 (AIR BAG: FRONTAL: DRIVER SIDE INFLATOR MODULE) REPLACED. THE DEALER CALLED THE DAY BEFORE THE APPOINTMENT AND STATED THE VEHICLE WOULD NOT BE REPAIRED SINCE THE MANUFACTURER WAS NO LONGER MAKING THE PARTS AVAILABLE. THE ORIGINAL APPOINTMENT WAS MADE THREE WEEKS AGO AND THEY STILL HAVE NOT BEEN ABLE TO REPAIR THE VEHICLE. THE CURRENT MILEAGE WAS 40,000.

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THE VEHICLE WAS INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 11V107000 (AIR BAGS:FRONTAL:DRIVER SIDE INFLATOR MODULE). AN AUTHORIZED DEALER WAS NOTIFIED AND THE CONTACT WAS INFORMED THE PARTS NECESSARY TO REMEDY THE FAILURE WERE UNAVAILABLE. THE CONTACT HAD BEEN ATTEMPTING TO MAKE AN APPOINTMENT FOR APPROXIMATELY ONE MONTH, BUT THE DEALER HAD CONSTANTLY INFORMED HIM OF THE UNAVAILABILITY OF PARTS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 25,000.

TL*THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT RECEIVED A RECALL NOTICE ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 11V107000 (AIR BAGS:FRONTAL:DRIVER SIDE INFLATOR MODULE). SINCE THE NOTICE WAS RECEIVED THE CONTACT NOTIFIED AN AUTHORIZED DEALER ON SEVERAL OCCASIONS AND WAS INFORMED THAT THE PARTS NECESSARY TO REMEDY THE RECALL WERE UNAVAILABLE. A REASON FOR THE LACK OF PARTS WERE NOT PROVIDED TO THE CONTACT. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 34,000.

DRIVING ON INTERSTATE 90 IN MICHIGAN TRUCK STARTED MISFIRING AND ABOUT 1000 FEET LATER THE ENGINE QUIT ALTOGETHER. REPLACED THE FUEL PUMP MODULE WHICH THE MECHANIC SAID WAS VERY COMMON IN NORTHERN STATES. CORROSION BETWEEN DISSIMILAR METALS CAUSED THE MODULE CASE TO BREAK AND ALLOW WATER INSIDE AND SHORT THE MODULE OUT. *TR

STEERING SHAFT ASSEMBLY BINDING CAUSING SERIOUS SAFETY ISSUE. VEHICLE HAS 37,000 MILES CURRENTLY. I PAID FORD DEALER TO INSPECT THE VEHICLE AND THEY STATE THE STEERING SHAFT ASSEMBLY WAS "BINDING". IT WAS REPORTED THAT THE PART WAS ON A "NATIONAL BACKORDER". WHEN I CONTACTED FORD THEY WOULD NOT ASSIST WITH THE REPAIR, ONLY MAKE A NOTE IN "MY FILE". SERIOUS SAFETY ISSUE AND THE NEED FOR A RECALL NEEDS TO BE INVESTIGATED. *TR

SOMETIME IN FEBRUARY 2011 I NOTICED THE STEERING IN MY 2006 FORD F-150 TO BE GETTING VERY TIGHT AND EXTREMELY HARD TO STEER. SOMETIMES IT WOULD GET BETTER OTHERS IT WAS WORSE. WHEN MAKING A TURN THE STEERING WHEEL WOULD NEVER RETURN ON ITS OWN. I TOOK THE TRUCK TO THE DEALER I PURCHASED VEHICLE FOR A NEW CONTROL MODULE AND EXPLAINED MY STEERING PROBLEM THEY FLUSHED THE FLUID THE VEHICLE SEEMED BETTER FOR A WEEK AND GRADUALLY GOT WORSE. ON 05/31/2011 I AGAIN TOOK THE TRUCK TO THE DEALER. A COUPLE DAYS LATER THEY SAID IT WAS THE SOMETHING TO DO WITH STEERING SHAFT BINDING AND THE PART WOULD BE IN ON FRIDAY 06/04/2011. WHEN I SPOKE WITH THEM AGAIN THEY SAID THE PART WAS NOW ON BACKORDER AND THEY ALSO HAD 3 OTHER TRUCKS AT THE DEALER WITH THE SAME PROBLEM. COULD IT BE THAT THIS IS A WIDESPREAD PROBLEM AND THAT IS WHY THE PARTS ARE BACKORDERED OR WORSE FORD KNOWS THERE IS A PROBLEM AND IS TRYING TO FIGURE IT OUT WHILE I SIT HOME WITH NO VEHICLE. SERIOUS SAFETY ISSUE. *TR

I RECEIVED A RECALL NOTICE (11S18) FROM FORD MOTOR COMPANY FOR AIR BAG DEPLOYMENT ISSUES THAT COULD CAUSE INJURY TO DRIVER. I SCHEDULED APPOINTMENT FOR THIS REPAIR AND DROPPED 2006 FORD F150 AT THE DEALER ON SCHEDULED DATE. THE TRUCK REPAIR COULDN'T BE PERFORMED BECAUSE FORD MOTOR COMPANY DID NOT SUPPLY THE PARTS. I HAVE A HARD TIME GETTING THE TRUCK TO THE DEALER FOR THE DAY AS IT IS MY ONLY TRANSPORTATION AS I WORK 20 MILES AWAY FROM HOME. FORD MOTOR COMPANY SHOULD HAVE SUPPLIED THIS PART PRIOR TO THE SCHEDULED DATE PROVIDED TO ME. I THINK FORD MOTOR COMPANY OWES ME SOME TIME AND TRANSPORTATION NOW TO GET THIS PROBLEM FIXED OR TAKE THE PIECE OF YOU KNOW WHAT BACK. I HAVE NOT HAD A GOOD TO SAY THE LEAST EXPERIENCE WITH THIS FORD TRUCK AND I AM NOT THE ONLY ONE THAT FEELS THE WAY I DO ABOUT FORD.AND THE PROBLEMS THEY ARE PUTTING ON THE ROAD AND TO THE CUSTOMERS. *TR

TL*THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE HAVING THE TIRES CHANGED THE MECHANIC NOTICED THAT THE REAR COVER ON THE DIFFERENTIAL WAS COVERED WITH RUST AND CAUSED A LEAK. THE VEHICLE WAS REPAIRED FOR THE REAR COVER AND OIL WAS ADDED FOR LUBRICATION. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 102,000. UPDATED 07/08/11 *BF UPDATED 09/16/11

TL*THE CONTACT OWNS 2006 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE AIR BAGS DEPLOYED CAUSING THE CONTACT TO LOSE CONTROL OF THE VEHICLE. SHE DROVE ONTO THE SHOULDER OF THE ROAD AND CRASHED INTO THE WALL ON THE DRIVERS SIDE OF THE VEHICLE. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 11V107000 (AIR BAGS: FRONTAL, DRIVER SIDE INFLATOR MODULE), SHE RECEIVED IN THE MAIL. THE VEHICLE WAS TOWED TO THE CONTACTS HOME. NEITHER THE MANUFACTURER NOR DEALER WERE NOTIFIED REGARDING THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNAVAILABLE, BUT THE CURRENT MILEAGE WAS 120,000. UPDATED 06/06/11 *BF PICTURES ADDED. UPDATED 2/15/2012 *LN *TR

TL*THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TO REPAIRED FOR RECALL 11V107000 (AIR BAGS:FRONTAL DRIVER SIDE INFLATOR MODULE). AFTER RECEIVING THE VEHICLE FROM THE DEALER, THE AIR BAG LIGHT ILLUMINATED IMMEDIATELY. WHEN SHE TOOK THE VEHICLE BACK TO THE DEALER, THE MECHANIC STATED THAT THE SENSOR WAS THE CAUSE OF THE FAILURE. THE CONTACT NOTICED NO PROBLEMS WITH THE AIR BAGS UNTIL THE VEHICLE WAS TAKEN IN FOR THE RECALL REPAIR. THE CONTACT CALLED THE MANUFACTURER WHO REFERRED HER TO A DIFFERENT DEALER THAT REFUSED TO REPAIR THE VEHICLE. THE VEHICLE HAD NOT BEEN REPAIRED A SECOND TIME. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 83,000.

I PURCHASED A NEW 2006 FORD F150 FROM A LOCAL FORD DEALER IN HUNTSVILLE, TX. AFTER PICKING UP THE VEHICLE WHILE DRIVING HOME IT WAS VERY AN APPARENT THERE WAS A PROBLEM WITH THE TIRES, THE VEHICLE HAD AN EXTREME VIBRATION. I RETURNED TO THE DEALER, REPORTED THE PROBLEM AND REQUESTED THEM TO ADDRESS IT, THEIR SERVICE DEPARTMENT EMPLOYEE EXPLAINED THAT THE TRUCK HAD SET ON THE CAR LOT FOR SOME TIME AND THE TIRES GET FLAT SPOTS AND THIS IS THE PROBLEM, SHE TOLD ME TO DRIVE THE VEHICLE AND THE PROBLEM WOULD GO AWAY. THIS VEHICLE WAS JUST DRIVEN OVER 160 MILES (FROM AUSTIN, TEXAS TO HUNTSVILLE, TEXAS, AS IT WAS A DEALER SWAP, IN ORDER TO GET A VEHICLE WITH THE SPECS I HAD REQUESTED), BEFORE I TOOK POSSESSION OF THE VEHICLE. I HAD DRIVEN THE VEHICLE OVER 100 MILES BEFORE RETURNING TO THE DEALER TO REQUEST THIS PROBLEM BE CORRECTED, AFTER TALKING TO THEIR SERVICE PERSON, I PUT MORE MILES ON THE VEHICLE, THE VIBRATION STILL EXIST, WENT BACK TO THE HUNTSVILLE FORD DEALER SERVICE DEPT, AGAIN REQUESTED THE ROTATE AND BALANCE THE TIRES, LEFT THE VEHICLE FOR REPAIRS, MY RIDE HOME WAS NOT MUCH BETTER, STILL A VIBRATION, LATE TOOK THE VEHICLE BACK TO THE DEALER, THEY TOLD ME TO DRIVE IT AND IT WILL GET BETTER, SO I DROVE IT 34,000 MILES, NO CHANGE IN THE VIBRATION, HE ONLY CHANGE WAS A VERY UNEVEN WARE IN THE TIRES. WENT BACK TO THE DEALER WHERE THEY CAME UP WITH ALL KINDS OF REASONS WHY THEY ARE NOT LIABLE. I STILL HAVE THESE TIRES IN THE SHED BEHIND MY HOME, REMOVED AND REPLACED THEM WITH BF GOODRICH TIRES; THIS RESOLVED THE PROBLEM OF VIBRATION. NOW I WOULD LIKE A NEW SET OF TIRES TO REPLACE THESE DEFECTIVE CONTINENTAL TIRES AND HAVE SOMEONE LOOK INTO THE FORD DEALERS UNSAFE PRACTICE. *TR

AIR BAG LIGHT HAS BEEN ON FOR 5 MONTHS AND THE DASH BOARD AND RADIO SHORTS OUT AND SHUTS OFF ALL POWER IN DASH. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 08V208000(SERVICE BRAKES, HYDRAULIC:POWER ASSIST:VACUUM:HOSES, LINES/PIPING, AND FITTINGS WAS THE REPAIRS WERE PERFORMED ON THE VEHICLE. LATER, WHILE DRIVING APPROXIMATELY 55 MPH, THE CONTACT ENGAGED THE BRAKES AS HARD AS POSSIBLE BUT THE BRAKES FAILED WITHOUT WARNING. THE CONTACT ABRUPTLY APPLIED THE BRAKES BUT THE BRAKE PEDAL WAS RESISTANT. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS ADVISED THAT THE BRAKE BOOSTER VACUUM HOSES WERE DEFECTIVE AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. SHE CALLED THE DEALER THAT PERFORMED THE RECALL AND WAS ADVISED TO BRING THE VEHICLE IN TO HAVE THE REPAIR WORK PERFORMED AT THE MANUFACTURER'S EXPENSE. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN.

2006 FORD F150 5.4L ONLY 32K MILES, MUST SPEND OVER $400 DUE TO BAD SPARK PLUG DESIGN. *TR

OVER A PERIOD OF 3 MONTHS, I WAS EXPERIENCING A ROUGH IDLE, LOSS OF POWER WHEN ACCELERATING ON FLAT SURFACES AS WELL AS CLIMBING HILLS. I TOOK IT TO A MECHANIC WHO SAID IT WAS 2 BAD COIL PACKS. THEY FIXED IT AND 2 WEEKS LATER SAME INCIDENT OCCURRED AND THEY REPLACED IT. DURING THIS TIME, I COULD ALWAYS SMELL THE ODOR OF GASOLINE. AFTER THE LARGE EXPENSE I WAS ASSUMING, I CALLED THE FORD DEALER WHERE I BOUGHT MY 2006 F-150 LARIAT. THE SERVICE MANAGER OF 22 YEARS APPARENTLY NEVER HEARD OF THE COIL PACK GOING BAD ALONG WITH THE SPARK PLUGS BREAKING DUE TO THIS. AFTER ARGUING FOR A WEEK WITH THEM, THEY FINALLY AGREED TO PAY FOR THE REPLACEMENT OF ALL 8 COIL PACKS. DURING THIS SEQUENCE, A COIL PACK WAS GOING BAD WEEKLY AND I HAD TO CONTINUALLY HAVE IT IN THE SHOP. FORD NEEDS TO ADDRESS THIS ISSUE AND AS I CAN SEE, THERE ARE A LOT OF THESE ISSUES OUT THERE AND FORD CONTINUES TO DISREGARD A RECALL. THERE IS A DEFINITE SAFETY ISSUE AS GASOLINE WILL EMIT FROM THE CRACK IN THE COIL PACK AND COULD CAUSE A FIRE UNDER THE RIGHT CONDITION. THIS IS UNACCEPTABLE. *TR

I HAVE A 2006 FORD F-150 AND UPON REMOVING THE SPARK PLUGS AT 60,00 MILES, WHICH AREN'T DUE TO BE DONE UNTIL 100,00 MILES, THE SPARK PLUGS BROKE OFF IN THE HEAD. I HAVE BEEN A CERTIFIED MECHANIC IN THE PAST SO I KNOW HOW TO REMOVE SPARK PLUGS. FORD SHOULD BE ISSUING A RECALL ON THIS PROBLEM. THE PROBLEM IS DISCUSSED A LOT ON INTERNET SITES AND WELL DOCUMENTED TO BE A PROBLEM. *TR

2006 FORD F150 STX. CONSUMER STATES AIR BAGS FAILED TO DEPLOY UPON COLLISION *TGW THE CONSUMER STATED HE LOST CONTROL OF THE VEHICLE WHEN HE HIT A PATCH OF ICE AND CRASHED INTO A TELEPHONE POLE, SNAPPING IT IN HALF. THE CONSUMERS HEAD STRUCK THE SIDE CABIN ENTRANCE HANDLE CAUSING INJURY, DUE TO THE AIR BAGS NOT DEPLOYING. FORD INFORMED THE CONSUMER THE IMPACT WAS NOT SEVERE ENOUGH FOR THE AIR BAGS TO DEPLOY. *JB UPDATED 04/27/11. *JB UPDATED 08/16/11. *JB..UPDATED 05/16/16 *BF UPDATED 8/1/2017*JS *TR*JS*JS*JS*TR*TR*TR *JS*JS*JS*JS*JS*JS*JS

2006 FORD F150 WITH 39,000 MILES ACTING FUNNY. TOOK IT TO GARAGE AND WAS CATALYTIC CONVERTER. STATED THEY WOULDN'T COVER IT BECAUSE I DROVE TO GARAGE. *TR

LIGHT BULB INSIDE THE AUTOMATIC SHIFTER CAME LOOSE AND WAS INSIDE CONSOLE, WHEN I TURNED ON MY LIGHTS, I SMELLED PLASTIC BURNING THE LIGHT BULB BURNED A HOLE THROUGH THE SIDE OF THE CONSOLE WHICH IN TURN BURNED MY HAND, FORD DEALERSHIP REMOVED LIGHTBULB, BUT WAS INSISTING I PAY APPROX.$900.00 FOR REPAIRS, WHICH I REFUSE TO DO. *TR

WHILE DRIVING DOWN THE ROAD THE THREADS IN THE RIGHT REAR CYLINDER HEAD OF MY 2006 FORD F150 5.4L TRITON V8 FAILED CAUSING SPARK PLUG EJECTION AND COIL DAMAGE. IT IS CURRENTLY BEING TOWED TO THE REPAIR SHOP AND, ACCORDING TO THE DEALERSHIP, THE WHOLE CYLINDER HEAD WILL HAVE TO BE REPLACED. IT IS UNKNOWN, AT THIS TIME, WHAT THE DEALERSHIP WILL COVER AND WHAT MY EXPENSES WILL BE. *TR

ODOMETER FLASH THEN QUITS WORKING ALL INFO THE IS IN THAT INFO CENTER WON'T WORK. *TR

ODOMETER DOES WORK. *TR

WHILE STOPPED IN TRAFFIC, I WAS HIT IN THE REAR END BY ANOTHER VEHICLE DURING NORMAL ROAD CONDITIONS, BOTH THE DRIVER SEAT AND THE PASSENGER SEAT COLLAPSED, BOTH MYSELF (DRIVER) AND THE PASSENGER RECEIVED NECK, SHOULDER, AND BACK INJURIES. MY VEHICLE RECEIVED HEAVY DAMAGE. A POLICE ACCIDENT REPORT WAS TAKEN. *TR

WHAT A SHOCKER, I GO TO THE FORD DEALER FOR THE 100K TUNE UP FOR MY F-150 KING RANCH ORIGINAL COST $450. ALMOST TWO WEEKS LATER, TRUCK STILL ISN'T FINISHED COST IS AT $3, 500 STILL CAN GO. THEY DON'T KNOW YET UNTIL THEIR FINISHED PUTTING EVERYTHING BACK TOGETHER. 7 OF THE 8 PLUGS BROKE, TWO WOULD NOT COME OUT. FINALLY, THEY GOT ONE OF THE TWO OUT. THE ONE IS SEIZED UP PRETTY GOOD. THE HAD TO TAKE THE HEAD OFF AND WAITING ON THE OUTCOME. I'M UP IN ARMS ON WHAT TO DO. I DON'T HAVE AN EXTRA $3, 000 LAYING AROUND TO PAY FOR THIS PLUS THE PRICE CAN STILL GO UP. HOW CAN THEY NOT TELL YOU THIS UP FRONT AND KEEP PADDING THE PRICE AND NOT KNOWING WHAT ITS GOING TO COST UNTIL YOU PICK YOUR VEHICLE UP. PLEASE CONTACT ME, I WOULD LIKE TO FILE A SUIT AGAINST FORD BUT NEED ASSISTANCE. I TALKED TO SOMEONE FROM FORDS FRONT OFFICE ABOUT THIS ISSUE. THEY ARE WELL AWARE OF THIS MATTER. ALL THEY SAY IS THAT ITS NOT UNDER WARRANTY AND MY VEHICLE IS OVER THE 100K MAX. COME TO FIND OUT, NO MATTER WHAT WARRANTY YOU HAVE, THIS PARTICULAR ISSUE HAS NO WARRANTY TO BEGIN WITH. ALL THEY WOULD DO IS OFFER ME THE "X PLAN" ON A NEW VEHICLE. NOW, WHY WOULD I WANT TO BUY A NEW VEHICLE. I'VE BEEN RAISED ON FORD VEHICLES MY ENTIRE LIFE. I MUST SAY THIS WILL BE MY LAST FORD TRUCK FOR SURE. A FRIEND OF MINE HAS A TOYOTA TRUCK AND HAS OVER 200K MILES. NEVER HAS HAD A ISSUE WITH ANYTHING. PLEASE ADVISE ON WHAT TO DO, THIS NEEDS TO STOP AND FORD NEEDS TO DO SOMETHING ABOUT THIS. BUT I HAVE A FEELING THEY WON'T OR THEY WOULD OF DONE IT ALREADY. *TR

TL*THE CONTACT OWNS A 2006 FORD F150. WHILE DRIVING APPROXIMATELY 55 MPH THE ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE OXYGEN SENSORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. AFTER THE VEHICLE WAS REPAIRED, THE CHECK ENGINE LIGHT ILLUMINATED AGAIN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE FAILURE WAS CAUSED BY THE OXYGEN SENSORS, WHICH NEEDED TO BE REPLACED A SECOND TIME. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 157,000.

TL*THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED THAT WHILE DRIVING 70 MPH THE VEHICLE STALLED. SHE WAS ABLE TO RESTART IT AND TWO ATTEMPTS. THE VEHICLE WAS TAKEN TO THE DEALER AND THEY WERE UNABLE TO DUPLICATE THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 52,000 AND CURRENT MILEAGE WAS 95,429. UPDATED 03/16/11 *BF UPDATED 04/25/11

THE TRUCK WAS TRAVELING APPROXIMATELY 30 MPH ON A WET TWO-LANE ROAD. THE TRUCK SLIPPED TO THE RIGHT OFF THE ROADWAY AND CLIPPED SOME DEAD TREES, TRAVELED APPROXIMATELY 60 FEET OVER SOME BOULDERS, AND STRUCK A CEDAR TREE APPROXIMATELY SIX INCHES IN DIAMETER, COMING TO REST. THE TRUCK STRUCK THE TREE MIDWAY ON THE FRONT END, COMPRESSING THE HOOD, WITH THE FRONT FENDER WRAPPED AROUND THE TREE. THE DRIVER'S SIDE AIR BAG DID NOT DEPLOY. I CONTACTED FORD CUSTOMER SERVICE, REQUESTING INFORMATION TO BE GATHERED ON WHY THE AIR BAG FAILED TO DEPLOY. THE CUSTOMER SERVICE REPRESENTATIVE REFERRED ME TO THE INSURANCE COMPANY. THE INSURANCE COMPANY REPRESENTATIVE CALLED ON MY BEHALF AND GAVE PERMISSION FOR FORD TO NON-DESTRUCTIVELY COLLECT DATA AT THE SALVAGE SITE, BUT FORD REFUSED. I HAVE PHOTOGRAPHS THAT I CAN PROVIDE IF REQUESTED.

TL* 2006 FORD F150. THE CONTACT STATED THAT WHILE DRIVING HE STARTED TO ACCELERATED WHEN THE GAS PEDAL STUCK CAUSING THE VEHICLE TO PICK UP SPEED. THE VEHICLE CRASHED INTO A BUILDING AND STOPPED WHEN IT HIT A SNOW BANK. THE CONTACT WAS NOT INJURED. THE VEHICLE WAS TOWED TO A LOCAL SHOP WHERE THEY DIAGNOSED THAT IT WAS POSSIBLE FOR THE PEDALS TO GET STUCK IN COLD WEATHER. THE VEHICLE WAS BEING REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE CONTACT DID NOT FILE A POLICE REPORT. THE FAILURE AND CURRENT MILEAGE WAS 50,000. UPADTED 04/28/11

I WAS PARKED IN A PARKING LOT STARTED UP MY TRUCK AND THE AIR BAG DEPLOYED FOR NO REASON. *TR

I OWN A FORD F150 2006 TRUCK. I TOOK THE TRUCK IN FOR THE 100K SERVICE PER THE FACTORY SPECS FOR A TUNE UP/CHANGING OF THE SPARK PLUGS. THE SPARK PLUGS ARE DEFECTIVE AND BUILD CARBON AROUND THE BOTTOM AND WHEN THEY ARE REMOVED, THE CERAMIC BOTTOMS BREAK OFF INTO THE CYLINDER OF THE ENGINE. *TR

OEM SPARKPLUG IN 2006 F-150 KING RANCH (3-VALVE ENGINE). EXPERIENCED PREMATURE PLUG FAILURE AND RESULTING HIGH REPLACEMENT COSTS DUE TO DEFECTIVE SPARKPLUG DESIGN. PLUG FAILURE RESULTED IN SLUGGISH ENGINE PERFORMANCE THAT LED TO A NEAR ACCIDENT. *TR

THE CROSSOVER PIPE FOR THE EXHAUST SYSTEM IS LOCATED DIRECTLY IN FRONT OF A CROSS BRACE UNDER THE TRANSMISSION. THE BRACE ACCUMULATES DEBRIS EASILY AND IT PACKS UP AGAINST THE EXHAUST PIPE RESULTING IN A FIRE UNDER THE TRUCK. *TR

STEERING WHEEL SHIMMIES AT 50-70MPH. HAVE HAD TIRES ROTATED, TIRES REPLACED, FRONT END ALIGNED, BRAKE ROTORS REPLACED STILL THE SHIMMY IS THERE AND HAVE BEEN TOLD THAT THE BIG TIRES 18"RIMS 235/75 MAY PARTIALLY BEEN THE PROBLEM. WHAT? WHY WOULD FORD USE A TIRE THAT IS TOO BIG? AND CAUSE THE STEERING WHEEL TO SHAKE AND SHIMMY. HAVE HAD AN INDEPENDENT SHOP LOOK AT TRUCK AND CAN FIND NOTHING WRONG, BUT I HAVE NEVER HAD A VEHICLE HAVE SUCH A NOTICEABLE SHIMMY IN THE STEERING WHEEL. VERY UNSETTLING FEELING. *TR

TL*THE CONTACT OWNS A 2006 FORD F150. WHILE DRIVING APPROXIMATELY 15 MPH, THERE WAS AN UNEXPECTED REDUCTION IN THE ENGINE POWER. THE CONTACT CONTINUED TO DRIVE TO HIS RESIDENCE WITH AN EXCESSIVE LOSS OF ENGINE POWER DURING ACCELERATION. THE VEHICLE WAS TOWED FROM THE RESIDENCE TO AN AUTHORIZED DEALER WHERE THEY STATED THE ENGINE WOULD NEED TO BE REPLACED AS A RESULT OF DEFECTIVE FUEL INJECTORS. THE ESTIMATED REPAIR COST WAS $8,000. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 58,000.

TL*THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THEY HAD TO REPLACE THE IGNITION COILS FIVE TIMES IN LESS THAN ONE YEAR. THE FAILURE CAUSED THE SPARK PLUGS TO CRACK AND HAVE TO BE REPLACED. THE SPARK PLUGS THAT CRACKED WERE ON TWO SEPARATE CYLINDERS. THE FAILURE CAUSED FUEL TO BE SPILLED ONTO THE ENGINE WHICH COULD CAUSE PROBLEMS WITH THE CATALYTIC CONVERTER. THE CONTACT STATED THAT THE VEHICLE WOULD SPUTTER AT TIMES WHEN HE TRIED TO ACCELERATE TO PASS SOMEONE. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THERE WAS NO REMEDY FOR THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 21,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 49,000.

TL*THE CONTACT OWNS A 2006 FORD F150. WHILE DRIVING APPROXIMATELY 10-15 MPH THE STEERING WHEEL BECAME VERY DIFFICULT TO TURN AND THE VEHICLE WAS ALSO DIFFICULT TO DRIVE. THE FAILURE HAD OCCURRED FOR APPROXIMATELY 2 WEEKS. THE VEHICLE WAS NOT TAKEN TO AN AUTHORIZED DEALER OR A LOCAL MECHANIC. HE CALLED THE MANUFACTURER AND WAS ADVISED THAT THERE WERE NO RECALLS AND THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 58,345 AND THE CURRENT MILEAGE WAS 58,622.

I HAVE A 2006 F-150 WITH 99,000 MILES. THE ENGINE DEVELOPED A MISS WHEN UNDER HEAVY LOAD. CHECKING THE SCHEDULED MAINTENANCE RECOMMEND BY FORD, THE SPARK PLUGS NEED TO BE CHANGED AT 100,000 MILES. I TRIED TO CHANGE THE PLUGS MYSELF AND BROKE THE FIRST ONE. I STOPPED AT THAT POINT AND HAD IT TOWED TO THE DEALER. THEY BROKE FIVE ADDITIONAL PLUGS AND THE VEHICLE WAS DOWN OVER NIGHT. FORD HAS ISSUED TECHNICAL SERVICE BULLETINS ON CHANGING THE SPARK PLUGS. THIS IS A KNOWN ISSUE TO FORD. WHEN I CONTACTED FORD THEY SAID THERE WAS NOTHING THEY CAN DUE SINCE ITS OUT OF WARRANTY. I WAS STUCK WITH A $300 LABOR BILL WHICH DID NOT INCLUDE $75 FOR SPARK PLUGS AND $98 FOR THE TOW. FORD NEEDS TO BE HELD ACCOUNTABLE FOR THERE ENGINEERING MISTAKE. *TR

TL-THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHILE ACCELERATING OR DECELERATING, THE VEHICLE SUDDENLY HESITATED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THERE WERE ONLY TWO QUARTS OF OIL IN THE ENGINE INSTEAD OF THE SEVEN IT WAS SUPPOSED TO CONTAIN; THE DEALER COULD NOT FIGURE OUT WHY THE VEHICLE WAS LOSING SO MUCH OIL. THE DEALER ALSO STATED THAT THE TIMING CHAIN CAUSED THE VEHICLE TO HESITATE. THE FAILURE MILEAGE WAS APPROXIMATELY 23,400 AND THE CURRENT MILEAGE WAS 23,423. UPDATED 01/13/11*LJ THE CONSUMER STATED IT WAS DIFFICULT TO ET THE VEHICLE OUT OF 4-WHEEL DRIVE. ALSO, THE TIMING CHAIN WAS MAKING A SCRAPING NOISE DUE TO LACK OF OIL. UPDATED 03/31/11

TL*THE CONTACT OWNS A 2006 FORD F150. WHILE DRIVING 10 MPH, THE CONTACT CRASHED INTO A TREE. THE AIR BAGS DID NOT DEPLOY. NO THERE WERE NO INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO A REPAIR SHOP AND THEN DRIVEN TO THE DEALER. THE DEALER ADVISED THE CONTACT TO CALL NHTSA. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE FAILURE MILEAGE WAS 41,000.

I OWN A 2006 FORD F150 TRUCK WITH 44,000 MILES ON IT. OVER THE PAST MONTH OR SO IT HAS DEVELOPED A SEVERE BRAKING ISSUE WHICH WHEN UNDER MODERATE TO HEAVY BRAKING CAUSES THE VEHICLE TO SHUDDER SEVERELY AND MAKE IT DIFFICULT TO STOP. IT OCCURS EVERTIME YOU APPLY THE BRAKES. I HAVE SPOKEN TO OTHER F150 OWNERS WHO HAVE HAD THE SAME ISSUE ON THE SAME VEHICLE AND THE 2007 MODEL ALSO. THE BRAKE PADS ARE IN GOOD CONDITION, HOWEVER THE BREAK ROTORS HAVE A VERY UNUSUAL SCRATCH PATTERNS RUNNING FROM THE CENTER OF THE BRAKE ROTOR SURFACE TO THE OUTSIDE OF THE SURFACE. I HAVE NEVER SEEN THIS ON A VEHICLE BEFORE. I DO KNOW THAT ONE FELLOW HAD TO REPLACE ALL 4 OF HIS BRAKE ROTORS ON A 2007 MODEL TO CORRECT THE PROBLEM, NOT NORMAL IF YOU ASK ME. I HAVE SEEN THIS SAME COMPLAINT ON OTHER CONSUMER WEB SITES FOR THE SAME ISSUE. MY VEHICLE IS STILL IN THIS SAME CONDITION, I AM TRYING TO GET INFORMATION ON WHAT IS CAUSING THE FAILURE BEFORE I SPEND $$$$ TO FIX IT. THANKS FOR YOUR CONCERN! *TR

I HAVE A 2006 F150 WITH THE 5.4 ENGINE. I HAVE NEVER REPLACED THE SPARK PLUGS AND THE TRUCK HAS 144K MILES. I AM NOW STUCK WITH ~$1800 TO PULL THE CAB TO GET TO THE HEADS TO GET THE PLUGS OUT. 2 MECHANICS CANNOT GET IT OUT NORMALLY. I AM TOLD THAT A FIX FOR STRIPPING THE HEADS IS WITH A SLEAVE THAT I CANNOT GET OUT OF CYLINDER #8. I WAS NEVER INFORMED TO HAVE THE PLUGS CHANGED AT 80KTO 100K MILES. I WOULD NOT HAVE KNOWN ANYTHING ABOUT THIS. I THINK THE FIX IS A POOR DESIGN AND I WAS DESIGNED TO COVER ANOTHER PLUG ISSUE. I AM WONDERING WHY 2 WRONGS DO NOT MAKE A RIGHT AND I AM WONDERING WHAT RECOURSE I HAVE. I HAVE PURCHASED OR TRADED 3 NEW TRUCKS AND CURRENTLY DRIVE A MUSTANG, ALL PURCHASED IN THE LAST 4 YEARS. I AM SERIOUSLY WONDERING IF I SHOULD EVER BUY ANOTHER FORD TRUCK AT THIS TIME. I HAVE BEEN MORE THAN LOYAL TO FORD PRODUCTS OVER THE YEARS. *TR

TL. THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THE POWER STEERING MALFUNCTIONED CAUSING DAMAGE TO THE RACK AND PINION. THE CONTACT STATED WHILE DRIVING AT 15 MPH THE VEHICLE BECOMES DIFFICULT TO TURN. THE CONTACT CALLED THE MANUFACTURER AND THEY INFORMED THE CONTACT THAT THE VEHICLE IS OUT OF WARRANTY SO THERE IS NOTHING THEY CAN DO. THE CONTACT HAS NOT TAKEN THE VEHICLE TO THE DEALER AT THIS. THE CONTACT STATED THE MANUFACTURER SHOULD ISSUE A RECALL BECAUSE THIS IS A MAJOR SAFETY ISSUE. THE FAILURE MILEAGE WAS 47,052. JO

TL*THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED THERE WAS AN ABNORMAL NOISE COMING FROM THE VEHICLE REAR WHEN PERFORMING A TURN. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE REPAIRS WERE MADE TO THE VEHICLE. THE FAILURE RECURRED WITHIN TWO WEEKS. IN ADDITION, THE CONTACT STATED THAT THE VEHICLE WOULD NOT START. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 80,000. UPDATED 12/01/10. *LJ THE CONSUMER STATED THERE WAS STILL A NOISE COMING FROM THE VEHICLE. ALSO, THE VEHICLE WOULD NOT START ON SEVERAL OCCASIONS. UPDATED 12/14/10*JB

TL* THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT THE BRAKES WOULD FAIL INTERMITTENTLY. THE CONTACT WOULD HAVE TO APPLY ABRUPT PRESSURE TO THE PEDAL IN ORDER FOR THE BRAKES TO RESPOND. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE IT WAS DISCOVERED THAT THE BRAKE POWER ASSIST VACUUM FAILED. THE CONTACT WAS ABLE TO LOCATE A RECALL FOR THE FAILURE (NHTSA CAMPAIGN ID NUMBER: 08V208000 -SERVICE BRAKES, HYDRAULIC: POWER ASSIST: VACUUM: HOSES, LINES/PIPING, AND FITTINGS) BUT WAS ADVISED BY THE DEALER THAT HIV VIN WAS NOT INCLUDED. THE MANUFACTURER ADVISED TAKING THE VEHICLE TO AN AUTHORIZED DEALER FOR REPAIRS. THE VEHICLE WAS REPAIRED. THE CURRENT AND FAILURE MILEAGE WAS APPROXIMATELY 40,000.

2006 FORD F-150 SUPER CREW 5.4L V8 WITH APPROXIMATELY 28000 MILES BEGAN TO RUN ROUGH WHEN I LET OFF THE ACCELERATOR. UPON RESTART, THE VEHICLE WAS SMOKING HEAVILY AND VERY ROUGH TO IDLE. CHECK ENGINE LIGHT CAME ON AT THAT POINT. VEHICLE WAS SLUGGISH, HAD HARDLY ANY POWER. TOOK TO LOCAL FORD DEALER WHO ADVISED THAT FUEL INJECTORS FOR CYLINDERS 7 AND 8 FAILED, FLOODED THE CYLINDERS AND CAUSED A HYDROLOCK. INITIALLY I WAS ADVISED THAT THIS WAS A $400 REPAIR TO SWITCH OUT THE INJECTORS. UPON SUBSEQUENT INSPECTION, IT WAS DETERMINED THAT SIGNIFICANT ENGINE DAMAGE HAD OCCURRED FROM A THROWN ROD. DEALER NOW ADVISING THAT A NEW MOTOR WILL BE REQUIRED. VEHICLE HAS MANUFACTURE DATE AS 1/2006 (DRIVERS DOOR STICKER). FORD ADVISES THAT WHILE 2005 ENGINES HAD THIS SAME ISSUE, MY ENGINE WAS NOT AFFECTED AND IS NOT SUBJECT TO RECALL. *TR

LOUD SCREECHING NOISES FROM THE FRONT END. IT HAPPENED SEVERAL TIMES AND I TOOK IT TO AN OUT OF TOWN DEALERSHIP BECAUSE I WAS OVER 125 MILES FROM HOME. IT SEEMS A 4 YEAR OLD TRUCK WITH 69K MILES HAD TO HAVE BOTH HUB ASSEMBLIES REPLACED, BOTH ACTUATORS AND BOTH VALVE ASSEMBLIES. MECHANIC STATED THAT HE'S HAD TO REPLACE OVER 25 FORD F-150 TRUCKS FOR THE SAME DEFECT (HIS WORDS). *TR

TL*THE CONTACT OWNS A 2006 FORD F150. THE CONTACT STATED THAT THE LED DISPLAY FOR THE ODOMETER MALFUNCTIONED INTERMITTENTLY. FORD STATED THAT WOULD REPAIR THE VEHICLE FOR $500. THE CONTACT WAS CONCERNED ABOUT THE SAFETY RISK. THE FAILURE MILEAGE WAS APPROXIMATELY 62,000.

I HAD AN INJECTOR STICK OPEN ON MY 2006 F150 AND IT CAUSED THE ENGINE TO HYDROLOCK AND SEIZED UP THE ENGINE. MY COMPLAINT IS THAT THE 2005 F150 HAD AN EXTENSION ON THE WARRANTY DUE TO THIS PROBLEM. I HEARD THAT SOME OF THE EARLY 2006'S (WHICH WERE MADE IT 2005) HAS ALSO HAD THESES PROBLEMS BUT FORD DID NOT EXTEND THE WARRANTY ON THE 2006. *TR

TL*THE CONTACT OWNS A 2006 FORD F-150. THE CONTACT STATED THAT WHEN HE APPLIED THE BRAKES, THE VEHICLE LUNGED FORWARD. THE FAILURE CONTINUED TO RECUR. THE VEHICLE WAS TAKEN TO A FORD DEALER WHO STATED THAT THEY WERE UNABLE TO DETERMINE WHAT CAUSED THE FAILURE TO OCCUR. THE FAILURE WAS UNSUCCESSFULLY DIAGNOSED BY THE DEALER TWICE. THE CONTACT STATED THAT THE FAILURE HAD OCCURRED FOR FOUR YEARS AND HAD BECOME PROGRESSIVELY WORSE OVER TIME. THE FORD MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 4,000. THE CURRENT MILEAGE WAS APPROXIMATELY 82,000.

I OWN A 2006 FORD F150 PICKUP TRUCK. ON 07/15/2010 I NOTICED THAT THE CRUISE CONTROL DASHBOARD INDICATOR LAMP CAME ON SEVERAL TIMES WITHOUT ME ENGAGING THE CONTROL. LATER I DURING THE EVENING I NOTICED NOT ONLY THE CRUISE CONTROL DASHBOARD INDICATOR LAMP TURNING ON AND OFF, BUT ALSO THE RIGHT SIDE STEERING WHEEL CRUISE CONTROL BUTTONS WERE NOT LIGHTING UP THOUGH THE HEADLAMPS WERE ON. I ATTEMPTED TO GET THE ISSUED REPAIRED AT THE LOCAL DEALER, BUT CLOSEST APPOINTMENT WAS AT THE END OF FOLLOWING WEEK. TWO DAYS LATER, ON 07/17/2010 I WAS OPERATING THE TRUCK, I EXPERIENCED THE CRUISE CONTROL ENGAGING AS I ACCELERATED. THE TRUCK CONTINUED TO ACCELERATE EVEN THOUGH I HAD NOT ENGAGED THE CRUISE CONTROL, NOR WAS MY FOOT ON THE ACCELERATOR PEDAL. I WAS ABLE TO REGAIN CONTROL BY DEPRESSING THE BRAKE PEDAL AND PUTTING THE TRANSMISSION INTO NEUTRAL. I BROUGHT THE TRUCK TO NEAREST FORD DEALER FOR REPAIR. WHILE TRAVELING THE APPROXIMATELY 5 MILE RIDE, THE CRUISE CONTROL CONTINUE TO ENGAGE ON ITS OWN. THE FORD DEALER WAS ABLE TO DIAGNOSE THE PROBLEM, CITING A DEFECTIVE CRUISE CONTROL SWITCH. THE SWITCH WAS REPLACED AND NOW THE VEHICLE APPEARS TO OPERATING PROPERLY. *TR

MY VEHICLE IS SHOWING EXTREME HESITATION IN ACCELERATION WHEN ENTERING A HIGHWAY OR PASSING ANOTHER VEHICLE. DURING THESE PROCESSES, MY VEHICLE WILL START BACKFIRING AND MISSING. THE "CHECK ENGINE" LIGHT COMES ON AT THIS TIME. I TOOK MY VEHICLE TO TWO DIFFERENT STATE LICENSED MECHANICS, AND CHAPMAN FORD DEALERSHIP IN PHILADELPHIA. ALL THREE TOLD ME THE PLUGS SHOULD HAVE LASTED 100,000 MILES OR BETTER AND THAT THEY HAVE HAD PROBLEMS WITH THE DESIGN OF THE ENGINE AND THESE PLUGS ARE VERY COMPLICATED TO REPLACE. SPECIAL TOOLS WOULD BE NEEDED TO REPLACE THEM. THEY ALSO SAID IT IS VERY COMMON THESE PLUGS WOULD BREAK OFF WHEN BEING REMOVED. THE COST TO REPLACE THE PLUGS WOULD BE APPROXIMATELY $400 TO $550, WITH AN ADDITIONAL COST IF ANY PLUGS BREAK. THE DEALERSHIP TOLD ME THERE IS NO RECALL WHEN THERE SHOULD BE. THIS IS A MAJOR PROBLEM AT THE EXPENSE OF THE OWNER, AS WELL AS A SAFETY ISSUE. I REALIZE SPARK PLUGS ARE NOT UNDER WARRANTY, BUT THE COST TO REPLACE THEM IS RIDICULOUS BECAUSE AS THE MECHANICS STATED, IT WAS A FLAW IN THE DESIGN OF THE PLUGS AND THEY CORRODE TO THE ENGINE BLOCK. FORD REALIZED THIS AND CHANGED THE PLUGS IN NEWER VEHICLES TO A NON-CORROSIVE PLUG. I FEEL THE CUSTOMER SHOULD NOT HAVE TO PAY FOR A POOR DESIGN FROM FORD. I AM SCHEDULED TO HAVE THIS WORK COMPLETED ON JULY 21, 2010 AT CHAPMAN FORD IN PHILADELPHIA BECAUSE MY VEHICLE IS UNSAFE TO CONTINUE DRIVING ON THE HIGHWAY AND IS USING AN ACCESS AMOUNT OF GASOLINE. *TR

THIS PROBLEM FIRST SURFACED ON THE MORNING OF 6/25/2010. I, ALONG WITH A FRONT SEAT PASSENGER, WERE RETURNING FROM RUNNING AN ERRAND WHEN I NOTICED THAT THE AIR BAG LIGHT WAS FLASHING INTERMITTENTLY AND THAT THE 'PASSENGER AIR BAG DISABLED' INDICATOR WAS LIT. THE LATER EVENTUALLY RETURNED TO ITS NORMAL STATE, OFF, BUT THE AIR BAG INDICATOR REMAINED ON INTERMITTENTLY. I DROVE THE VEHICLE AGAIN ON 6/27/2010 WITH THE FOLLOWING SYMPTOMS: THE AIR BAG LIGHT WAS INTERMITTENT AND AT THE SAME TIME THE AN WARNING CHIME, AT 1 SECOND INTERVALS, WAS HEARD. THE 'PASSENGER AIR BAG DISABLED' INDICATOR REMAINED LIT WITHOUT A FRONT SEAT PASSENGER. THE VEHICLE WAS AGAIN DRIVEN ON 7/5/2010 WITH THE SAME INDICATIONS. AS A RESULT, I AM HESITANT TO DRIVE THIS VEHICLE UNTIL I DO MORE RESEARCH OR SPEAK TO A CERTIFIED SERVICE FACILITY. I TRULY FEEL THAT I'D BE AT RISK OF AN INADVERTENT AIR BAG DEPLOYEMENT WHILE DRIVING ON THE INTERSTATE , POSSIBLY CAUSING INJURIES TO MYSELF, PASSENGERS, AND OTHER VEHICLES, AND THUS I'M REQUESTING HELP AND ADVICE FROM YOUR ORGANIZATION. *TR

TL*THE CONTACT OWNS A 2006 FORD F150. WHILE DRIVING 65 MPH WITHOUT WARNING, THE VEHICLE STALLED. SHE WAS ABLE TO RESTART THE VEHICLE AND CONTINUE DRIVING. THE FAILURE OCCURRED MULTIPLE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE ELECTRONIC THROTTLE ASSEMBLY CAUSED THE FAILURE TO OCCUR AND IT WAS REPLACED. THE FAILURE MILEAGE WAS 62928 AND THE CURRENT MILEAGE WAS 63000.

CERTAIN FORD MAKES, MODELS AND MOTORS ARE KNOWN FOR EJECTING SPARK PLUGS WHICH DESTROYS THE IGNITION COIL AND IS A FIRE HAZARD. THEY ARE ALSO KNOWN FOR THE SPARK PLUG BREAKING WHILE TRYING TO REMOVE THEM WHICH IS A FINANCIAL BURDEN ON THE CUSTOMER AS WELL AS A RISK THE MOTOR WHILE TRYING TO RESOLVE THE ISSUE. THERE ARE TSB'S ON THIS. I NEVER RECEIVED A LETTER FROM FORD TO GIVE ME THE HEADS UP ON THIS AND LEARNED AFTER THE FACT OF ATTEMPTING TO GET A TUNE UP.........NOW STUCK WITH TWO BROKEN SPARK PLUGS STUCK IN THE MOTOR AND HAVE NO IDEA HOW MUCH THIS IS GOING TO COST ME IN THE END. I AM WITHOUT MY TRUCK WHILE WE WAIT FOR A TOOL THAT WILL HOPEFULLY REMOVE THE BROKE OFF SLEEVES. IF IT DOESN'T WORK I WILL HAVE TO HAVE THE HEAD PULLED AND WHO KNOWS IF IT WILL NEED TO BE REPLACED. EVEN IF IT REMOVES IT, I WON'T KNOW UNTIL SOMETHING HAPPENS IF IT ENDS UP CAUSING DAMAGE TO MY ENGINE. I HAVE HAD BAD EXPERIENCES WITH FORD - TWO VEHICLES NOW. THEY DO NOT BACK UP THEIR KNOWN DEFECTS. MY FIRST PROBLEM WITH THIS F150 (TRITON) WAS WHEN THE COMPUTER SHUT DOWN LEAVING ME STRANDED IN ANOTHER STATE BECAUSE THE WIRES WERE RUBBING AGAINST THE STEERING COLUMN BRACKET. I PUT A LOT OF MILES ON SO IT WAS IN EXTENDED WARRANTY AND THE DEDUCTIBLE PAID THE REPAIR. FORD HAD NO INTENTION OF TAKING RESPONSIBILITY FOR IT EVEN THOUGH IT WOULD HAVE NORMALLY BEEN UNDER ORIGINAL WARRANTY EXCEPT FOR THE MILES I PUT ON A VEHICLE. THERE WAS NO ROADSIDE SERVICE IN THE AREA I WAS IN AND I GOT STUCK WITH ALL KINDS OF EXPENSES FROM IT. SEEMS OUR AMERICAN MANUFACTURERS SHOULD BE HELD ACCOUNTABLE FOR THEIR MULTIPLE KNOWN DEFECTS AS WELL AS OUR FOREIGN MANUFACTURERS. I AM ONLY ANSWERING YES TO THE FIRE BECAUSE I AM AWARE THAT OTHERS HAVE HAD THIS AS A PROBLEM. I HAVE NOT HAD A FIRE YET, BUT WE ARE NOT DONE TRYING TO RESOLVE THE PROBLEM. *TR

TL* THE CONTACT OWNS A 2006 FORD F150. WITH CONTINENTAL TIRES, SIZE P25565R17, LINE RADIAL CONTITRAC, AND DOT A3K34SMW. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 65MPH THE RIGHT LEFT REAR TIRE BLEW, AND THE TIRE TUBE FAILED. THE VEHICLE COLLIDED INTO A CEMENT GUARD DAMAGING THE VEHICLE REAR RIGHT END. THE CONTACT WAS NOT INJURED. THE VEHICLE WAS REPAIRED. THE INSURANCE COMPANY WAS INVESTIGATING THE TIRE FAILURE. THE FAILURE AND THE CURRENT MILEAGE WAS 30,000.

DURING ROUTINE MAINTENANCE SPARK PLUG CHANGE SIX OF THE OEM INSTALLED SPARKPLUGS BROKE OFF IN THE CYLINDER HEAD OF THE ENGINE. FORD DEALER ADMITS TO HAVING PROBLEMS WITH THIS DESIGN ENGINE AND STATES THIS OCCURS OFTEN. FORD DEALER STATED THAT FORD ADMITS AN ISSUE WITH THIS DESIGN SPARKPLUG AND HAS A TSB DETAILING THE PROCEDURE FOR BROKEN PLUG REMOVAL BUT HAS ISSUED NO FORMAL RECALL. DEALER ADVISED THAT FORD ALSO HAS A "SPECIAL TOOL" DESIGNED FOR THIS 5.4 3 VALVE SERIES MOTOR THAT IS ENGINE SPECIFIC TO REMOVE THE BROKEN PIECE OF THE SPARKPLUG BECAUSE THIS HAPPENS SO OFTEN. ALL BUT ONE OF THE BROKEN PLUGS WAS ABLE TO BE REMOVED USING A SPECIALTY TOOL PURCHASED AT AN AUTOMOTIVE PARTS STORE. FORD DEALER WAS UNABLE TO GET THE LAST BROKEN PLUG EXTRACTED FROM CYLINDER HEAD WITH THEIR "SPECIAL TOOL". ENGINE NEEDED TO BE DISSEMBLED AND CYLINDER HEAD REMOVED SO THAT THE BROKEN PIECE COULD BE EXTRACTED. THIS REPAIR COST $1708.00 TO COMPLETE. ALONG WITH $85.00 DIAGNOSTIC FEE TO TELL ME THEY COULD NOT GET THE BROKEN PIECE OUT. THE REPAIR TOOK TWO WEEKS TO HAVE COMPLETED. I FEEL THAT FORD SHOULD ISSUE A RECALL FOR THIS ISSUE AND THEY SHOULD REIMBURSE ME FOR MY COSTS DUE TO THEIR FAULTY DESIGN FLAW. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE ATTEMPTING TO REPLACE THE SPARK PLUGS IN THE ENGINE, THE CONTACT NOTICED THAT FOUR OF THE SPARK PLUGS WERE WEDGED INTO THE HEAD GASKET AND COULD NOT BE REMOVED. THE VEHICLE WAS NOT DIAGNOSED AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WAS 46,000. UPDATED 11/08/10 * BF UPDATED 11/10/10*JB

INADVERTENT AIRBAG DEPLOYMENT WHILE STOPPED, NO COLLISION OR INCIDENT ON MY 2006 F-150 TRUCK. *TR

TL* THE CONTACT OWNS A 2006 FORD F-150. WHILE TRAVELING IN 4-WHEEL DRIVE AT 30-50 MPH THERE WAS AN UNUSUAL CLUNKING NOISE COMING FROM UNDER THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 54,000. UPDATED 8/2/10 *CN THE CONSUMER STATED THE VEHICLE PULLED SEVERLY TO THE LEFT AND RIGHT. UPDATED 08/09/10*JB

GLAZE ON REAR END CLUTCH CAUSING TRUCK TO DRIVE INCORRECTLY...CONTACTED COMPANY AND THEY HAD A POSSIBLE RESOLUTION THAT DIDN'T WORK....WORRIED THAT THE REAR END WILL LOCK UP WHEN DRIVING CAUSING A WRECK!! *TR

BRAKES FAILED ON PICKUP WHILE DRIVING. REPAIR SHOP DETERMINED MASTER CYLINDER WAS FAULTY. *TR

MY 2006 FORD F-150 HAD A SPARK PLUG BROKE OFF AND NOW THE ONLY WAY TO FIX THIS IS TO REMOVE THE HEAD APPROX 3000.00 TO CORRECT. FORD SAYS THEY ARE AWARE OF THE PROBLEM BUT THEY REFUSE TO DO ANYTHING ABOUT IT. THE VEHICLE ONLY HAS 45,000 MILES AND THE TRUCK IS NOW NON DRIVABLE. WHY AREN'T THEY BEING HELD ACCOUNTABLE FOR SOMETHING WHEN THEY KNOW IT IS A PROBLEM WITH THIS STYLE VEHICLE. *TR

GAS POURS OUT OF THE FILLER NECK AFTER EVERY FILL UP. I DO NOT CLICK EXTRA TO "TOP IT OFF" AND STILL GAS POURS OUT OF THE NECK WHEN I REMOVE THE PUMP FROM THE FILLER NECK. *TR

BOTH DRIVER AND PASSENGER SIDE REVIEW MIRRORS ARE NOT STATIONARY. THEY ARE LOOSE AND PIVOT WHEN CLOSING A DOOR. DRIVER'S SIDE ALSO VIBRATES WHILE DRIVING MAKING IT DIFFICULT TO SEE OUT OF. THIS HAS BEEN REPORTED TO FORD DEALERSHIP WHERE THEY STATED "IT IS JUST A POOR DESIGN WITH A 'BREAK-AWAY FEATURE' THAT APPEARS TO HAVE BEEN 'OVERWORN' BY PREVIOUS OWNER, POSSIBLY DUE TO USE OF THINNER GASKETS IN MIRROR ASSEMBLY". WHEN ASKED ABOUT LONGEVITY AND ANTICIPATED LIFESPAN OF MIRRORS PRIOR TO FAILURE DUE TO WEAR, THEY STATED IT WAS NOT A WEAR-PART, HOWEVER, THEY ALSO DENIED IT BEING DEFECTIVE AND QUOTED ME $1200 FOR PARTS AND LABOR TO REPLACE. WARRANTY WOULD NOT COVER SINCE THE DEFECT WAS MECHANICAL AND NOT ELECTRICAL. THE DEALERSHIP ALSO STATED THE MIRRORS THAT WOULD BE INSTALLED WOULD BE EXACTLY THE SAME AND THERE WAS NO GUARANTEE THIS WOULD NOT HAPPEN AGAIN. I WAS UNABLE TO GET A CORRECTIVE ACTION OR REASONING WHY MY PARTICULAR MIRRORS ARE NOT SATISFACTORY, BUT I HAVE HEARD THIS IS NOT A NEW PROBLEM FOR THIS VEHICLE. LOOKING AT BOTH OF MY MIRRORS, IT IS OBVIOUS THEY SHOULD HAVE SOME SORT OF LOCKING MECHANISM (SNAP-IN-PLACE DESIGN) LIKE MOST VEHICLES. THERE HAS NOT BEEN ANY ACCIDENT INVOLVED WITH THIS SAFETY ISSUE. THIS IS TO DOCUMENT A KNOWN PROBLEM FOR AWARENESS PURPOSES AND TO POTENTIALLY RECEIVE A CORRECTIVE ACTION FOR MY FAULTY MIRRORS. THIS ISSUE HAS BEEN ON-GOING, AND AN ARBITRARY INCIDENT DATE HAS BEEN ASSIGNED. *TR

SPARK PLUGS FAIL AND ENGINE STOPS. PLUGS CAN'T BE REPLACED;LONG SHAFT SEIZES TO HEAD WALLS. SCHEDULED MAINTENANCE ITEM FOR 100,000 MILES.DANGEROUS DESIGN OF PLUGS FOR ALL FORD F-150 5.4 V-8 ; AS LOSS OF STEERING,BRAKES WITH ENGINE FAILURE.

TL* THE CONTACT OWNS A 2006 FORD F-150 EQUIPPED WITH 4 WHEEL DRIVE. THE CONTACT STATED THAT THE REAR DIFFERIENTIAL WAS NOT FUNCTIONING CORRECTLY AND THE REAR WHEELS FELT AS IF THEY WERE SLIDING FROM THE REAR OF THE VEHICLE. ALSO, THE REAR OF THE VEHICLE SEEMED TO HAVE NO TRACTION. HE HAD THE REAR DIFFERENTIAL REPLACED. THE CONTACT'S MAJOR CONCERN WAS THAT ONE COULD LOSE CONTROL OF THE ENTIRE VEHICLE IF THE REAR FUNCTIONED IN THIS MANNER. THE FAILURE MILEAGE WAS APPROXIMATELY 38,000. THE CURRENT MILEAGE WAS APPROXIMATELY 40,000.

SUBJ: BROKEN GAS TANK AT SEAMS ON MY 2006 FORD F150 TRUCK I HAVE A MAJOR PROBLEM WITH MY 2006 FORD F150 FUEL TANK LEAKING AT THE MANUFACTURES PLASTIC WELDED SEAMS. I BOUGHT MY LAST 3 TRUCKS FROM NORTH COUNTY FORD, IN VISTA, CALIFORNIA. MY 3RD TRUCK WAS A BRAND NEW 2006 FORD F150, AND ALL 3 TRUCKS I BOUGHT FROM NORTH COUNTY FORD, I PAID EXTENDED WARRANTY ON EACH ONE OF THEM, AND THAT WAS OVER $9,000, AND I NEVER USED 1 PENNY OF IT, I NEVER NEEDED ANY WARRANTY OR EXTENDED WARRANTY WORK UNTIL NOW, FOR THE FAULTY LEAKY PLASTIC GAS FUEL TANK UNDER MY TRUCK. I COULD NOT FIGURE OUT WHY MY GAS GAUGE SAID LOW FUEL, WHEN I HAD JUST PUT FUEL IN THE TRUCK THE SAME DAY. WHEN I STARTED MY TRUCK, I SMELLED GAS, SO I GOT OUT OF THE TRUCK, AND COULD SEE IT COMING OUT OF THE FUEL TANK AREA. I WENT TO THE GAS STATION WITH THE LOW FUEL LIGHT ON, BECAUSE I WANTED TO GET HOME BEFORE SOMETHING BAD HAPPENED, AND I PUT MORE FUEL IN THE TRUCK, AND JUST GOING ONLY 15 MILES THE GAS DISAPPEARED AND THE LOW FUEL LIGHT CAME ON AGAIN, BUT I DID GET IT HOME. I JACKED UP THE TRUCK AND STARTED IT, AND CLIMBED UNDERNEATH, AND WAS SURPRISED TO SEE THAT IT WAS A PLASTIC BLACK FUEL TANK, NOT STEEL OR METAL. I WAS JUST LIKE A CHEAP SWIMMING POOL THAT YOU WOULD PUT TWO OF THEM TOGETHER, AND YOU WOULD SEAL IT IN THE MIDDLE TO MAKE A TANK. BUT THE SEAL IS NOW BROKE, AND IM TRYING TO PUT SOME PLASTIC SEAL ON IT, BUT EVERYTHING I READ ON THE INTERNET, TOLD ME FORD WAS ALREADY AWARE OF THIS PROBLEM, BECAUSE I PUT AN AD UP ON CRAIGSLIST UNDER THE AUTOMOTIVE SECTION, ASKING MECHANICS FOR HELP ON WHY THIS WOULD HAPPEN TO SUCH A NEW TRUCK. ITS NOT LIKE I RAN OVER SOMETHING, AS THAT WOULD OF MADE A HOLE IN THE TANK, AND I COULD UNDERSTAND THAT BEING MY FAULT, BUT THE SEAMS COMING APART, AND THE GAS JUST GOING ALL OVER THE GROUND. THIS IS AN EXTREME FIRE HAZARD, AND DONT BE SURPRISED IF THIS THING CATCHES ON FIRE ON ME, HOPEFULLY NOT?

MY SON WAS KILLED IN HIS 2006 FORD 150 PICKUP TRUCK DRIVING 45 MILES AN HOUR. HIS TRUCK APPARENTLY LEFT THE ROAD WITH NO SIGNS OF BRAKES BEING APPLIED, FLIPPED SEVERAL TIMES. THE AIRBAGS NEVER DEPLOYED. HIS INSURANCE COMPANY WAS THREATENING ME TO RELEASE THE TRUCK FROM STORAGE WHICH I DID. I HAVE SINCE REGAINED MY SENSES ENOUGH TO SEARCH THE WEB AND SEE THAT THERE WERE MANY RECALLS ON THE BRAKE LINES OF THIS MAKE TRUCK. *TR

LOSS OF POWER STEERING. *TR

TL*THE CONTACT OWNS A 2006 FORD F150. THE VEHICLE WAS EQUIPPED WITH CONTINENTAL CONTI TRAC TIRES, AND TIRE SIZE P255-65-R17. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH. SUDDENLY, THERE WAS A SEVERE VIBRATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE TECHNICIAN STATED THE TIRES MET THE TREAD REQUIREMENTS. THE CONTACT OBSERVED AT A LATER DATE THAT ALL FOUR TIRES EXHIBITED EXCESSIVE TREAD SEPARATION. THE MANUFACTURER WAS NOTIFIED AND OFFERED A DISCOUNT PRICE ON A SET OF TIRES. THE TIRES WERE REPLACED. THE FAILURE MILEAGE WAS UNKNOWN. THE DOT NUMBER A3K345MW4605. UPDATED 4/30/10 *CN THE TIRES HAD A VIBRATION FROM BEGINNING. THE CONSUMER STATED THE TREAD SEPARATED AS WELL AS THE BELTS ON TWO TIRES. UPDATED 05/17/10