2006 GMC Sierra 2-DR.

MY PASSENGER SIDE WHEEL BROKE AND WENT SIDEWAYS WHEN I TURN OFF THE HIGHWAY IN MONTZUMA ONLY GOING ABOUT 30MPH

MY VEHICLE WAS TOTALED AND I SEE THEIR IS A RECALL FOR THE PITMAN ARM THAT CAN CAUSE TOTAL LOSS IF STEERING AND THAT IS WHAT HAPPENED TO ME

I HAD A CRACK IN THE WINDSHIELD AND WHEN THEY REPLACED IT THE TECHNICIAN SAID IT WAS SO RUSTED FROM THE INSIDE THAT IF ANYTHING HAPPENED AGAIN THEY WOULD NOT REPLACE IT HE HAD TO REALLY DO SOME WORK AROUNDS HE SAID TO EVEN REPLACE THIS ONE. THAT MAKES ME FEEL THAT THIS IS A REAL SAFETY ISSUE IF WE WERE TO GET IN A SERIOUS ACCIDENT. THERE IS NO RUST ON THE OUTSIDE AROUND THE WINDSHIELD AT ALL. SO I WAS VERY SURPRISED WHEN THE TECHNICIAN TOLD ME THAT.

BRAKES FAILED "COMPLETELY", WITH NO WARNING. NO "WARNING LIGHT" ON THE INSTRUMENT PANEL WHILE DRIVING ON A PUBLIC ROAD IN THE COUNTY. ALL OF A SUDDEN ABSOLUTELY NO BRAKES. HAD RECENTLY HAULED A CAR ON A TRAILER FROM EMPORIA, KANSAS. WAS PREPARING TO HAUL CALVES TO THE SALE BARN. NOW THAT WOULD HAVE BEEN A TOTAL DISASTER. UPON INSPECTION, THE BRAKE LINES ARE SO RUSTED, THAT PINCHING OFF THE LINE RESULTED IN A RUPTURE IN ANOTHER LOCATION. I WAS TRYING TO GET SOME BRAKING ACTION, SO I COULD DRIVE IT TO A REPAIR SHOP. I'LL HAVE TO HAUL IT. *TR

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. THE CONTACT STATED THAT THE HEATER BLOWER RELAY SWITCH WAS REPLACED HOWEVER, THE FAILURE RECURRED. THE CONTACT STATED WHILE VEHICLE WAS IN A STAND STILL, AND ATTEMPTING TO TURN ON THE AIR CONDITIONER, THE AIR CONDITIONER WAS INOPERABLE. THE CONTACT STATED THAT A DEALER WAS NOT CONTACTED. THE CONTACT STATED THAT THE HEATER BLOWER REPLAY SWITCH AND HARNESS NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED AS OF YET. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000. *BF THE CONSUMER STATED IN 2015 THE SWITCH WAS REPLACED, BUT IN 2020 IT WAS REPLACED AGAIN ALONG WITH THE MELTER WIRE HARNESS. *AS

EVEN THOUGH MY TRUCK HAS ALWAYS BEEN GARAGE KEPT AND ONLY HAS 30 THOUSAND MILES ON IT, MY BRAKING SYSTEM WENT OUT WHILE DRIVING BECAUSE MY METAL BRAKE LINES ARE RUSTED . *TR

BRAKE LINES BUSTED. THIS IS A VERY SERIOUS PROBLEM BECAUSE I WAS HAULING A LOAD AND GOT EXTREMELY EXTREMELY LUCKY THAT IT BUSTED AS I WAS PULLING IN DRIVEWAY. I WAS PULLING A LOADED TRAILER WITH NO BRAKES. THIS IS A VERY COMMON ISSUE WITH THE 2005 AND 2006 2500 TRUCKS. I CAN NAME 6 VEHICLES I KNOW OF IN THE PAST 6 MONTHS THAT THIS HAS HAPPENED TOO. MECHANIC SAYS IT'S A VERY SERIOUS AND COMMON ISSUE THAT GM SHOULD BE RECALLING. IF I WOULD HAVE BEEN AT A STOPLIGHT IT WOULD HAVE BEEN BAD. CHEAP MATERIALS IS THE PROBLEM WITH THESE BRAKE LINES. 2006 YEAR MODEL IS MINE.

TL* THE CONTACT OWNS A 2006 GMC SIERRA 2500. THE CONTACT STATED THAT THE BRAKES WERE INEFFECTIVE AND EXCESSIVE PRESSURE HAD TO BE APPLIED TO THE BRAKE PEDAL TO FULLY STOP THE VEHICLE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO SULLIVAN AUTOMOTIVE GROUP (2406 N SECTION ST, SULLIVAN, IN 47882, 812-268-4321), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 0. *BF *TR

FUEL GAGE SHOWS HALF A TANK BUT I RAN OUT OF GAS. LIGHTS BLOW ALL THETIME.

ABS LIGHT KEEPS COMING ON WHILE DRIVING

WHILE DRIVING AT LOW SPEEDS, ABOUT 20 MPH OR LOWER, THE BRAKE PEDAL FADES TO THE FLOOR. THERE ARE NO LIGHTS OR CODES AND BRAKE FLUID AT THE PROPER LEVEL. THIS HAPPENS QUITE FREQUENTLY AND ANYWHERE.

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. WHILE DRIVING APPROXIMATELY 8 MPH AND ATTEMPTING TO STOP THE VEHICLE, THE ANTI-LOCK BRAKING SYSTEM SEIZED WITHOUT WARNING. THE FAILURE RECURRED SEVERAL TIMES. THE CONTACT CALLED CHAMPION CHEVROLET OF AVON AT 317-350-1023 (LOCATED AT 183 S COUNTY RD 525, AVON, IN 46123) AND A DIAGNOSTIC TEST WAS RECOMMENDED. THE TEST WAS NOT PERFORMED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 36,000.

TL* THE CONTACT OWNED A 2006 GMC SIERRA 1500. WHILE THE CONTACT'S SON WAS DRIVING 30 MPH, THE POWER STEERING SEIZED AND THE VEHICLE DRIFTED AND CRASHED INTO THE GUARDRAIL OF A BRIDGE. THE AIR BAGS DID NOT DEPLOY. THE VEHICLE WAS TOTALED. A POLICE REPORT WAS FILED. THE DRIVER WAS INJURED, BUT DID NOT REQUIRE MEDICAL ATTENTION. THE VEHICLE WAS TOWED TO A WRECKING YARD. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 154,000.

NOT ONLY DOES THE RIGHT SIDE MIRROR HAVE THE OBJECTS ARE CLOSER THAN IT APPEARS STYLE MIRROR USED FOR CARS MAKING IT IMPOSSIBLE TO USE FOR TOWING ( ON A TRUCK WITH A TOW PACKAGE ) IT HAS RED LIGHTS THAT FLASH IN THE MIRROR. NOT ONLY DOES THE FLASHING RED LIGHTS MAKE IT HARD TO SEE ANYTHING IN THE MIRROR AT NIGHT, IT MAKES IT ALMOST IMPOSSIBLE TO USE IT IN THE RAIN AT NIGHT, AS IT MAKES THE WATER DROPS ON THE WINDOW FLASH RED AS WELL . IT IS A SAFETY HAZARD THAT COULD ALSO BE A PROBLEM FOR SOMEONE WITH PHOTOSENSITIVE EPILEPSY (PSE) IS A FORM OF EPILEPSY IN WHICH SEIZURES ARE TRIGGERED BY VISUAL STIMULI THAT FORM PATTERNS IN TIME OR SPACE, SUCH AS FLASHING LIGHTS; BOLD, REGULAR PATTERNS; OR REGULAR MOVING PATTERNS.

IN THE CITY STOPPING FOR A STOPLIGHT THE BRAKES FAILED. THE VEHICLE LUCKILY WAS ABLE TO TURN INTO A PARKING LOT. ALL FLUID WAS LOST BECAUSE THE BRAKE LINES FAILED DUE TO RUST. NO BRAKES WHATSOEVER EXCEPT EMERGENCY BRAKE. MY STATE EVEN REQUIRES A SAFETY INSPECTION YEARLY. IF THE CONSUMER IS NOT GOING TO BE NOTIFIED OF THIS SERIOUS PROBLEM AT LEAST LET THE SAFETY INSPECTORS KNOW.

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. WHILE DRIVING APPROXIMATELY 35 MPH, THE FORTY TWO VOLT CHARGING WARNING INDICATOR ILLUMINATED. DUE TO THE WARNING, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE CONTACT TURNED OFF THE VEHICLE AND IT FAILED TO RESTART. THE VEHICLE WAS TOWED TO JOHN PAUL'S BUICK GMC (3615 S 108TH ST, GREENFIELD, WI 53228, (414) 208-4113) WHERE IT WAS DIAGNOSED THAT THE GENERATOR STARTER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED DUE TO THE PART NO LONGER BEING MANUFACTURED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 92,350.

I TOOK OUR TRUCK IN FOR SERVICING AT THE O'NEILL GMC DEALERSHIP IN WARMINSTER, PA AND WAS TOLD THAT ALL OF OUR BRAKE LINES NEEDED TO BE REPLACED DUE TO RUSTING. WE PURCHASED OUR VEHICLE NEW FROM O'NEILL AND HAVE CONTINUED TO HAVE IT SERVICED THERE. THE TRUCK IS TREATED WITH GREAT RESPECT AND ONLY HAS 40,000 MILES ON IT. I CONTACTED GMC DUE TO THE DEFECTIVE MATERIALS OF THE VEHICLE THEY SOLD US AND THEY CLAIM THAT THIS IS NORMAL. I NOW AM STRAPPED WITH A BILL FOR $2700.00 TO REPLACE ALL FOUR DEFECTIVE, RUSTING BRAKE LINES THEIR WEBSITE SAYS CUSTOMER SATISFACTION GUARANTEED. I BELIEVE GMC SHOULD CONTRIBUTE $1700 TOWARDS THE BILL. I NOTE THAT THERE ARE OVER TEN PAGES OF COMPLAINTS ON THE INTERNET REGARDING CORROSION PROBLEMS. PLEASE HOLD GMC ACCOUNTABLE. THIS VEHICLE WAS PURCHASED IN GOOD FAITH AND THEY SHOULD ADMIT RESPONSIBILITY FOR THEIR INFERIOR BRAKE LINE MATERIALS. I AM DISAPPOINTED WITH GMC'S EXCUSES AND NONSENSE. I TOLD THEM THEY SHOULD PAY $1700 OUT OF THE MONEY THEY BANKED FROM THE EXPIRED, EXTENDED WARRANTY WE PURCHASED. THIS IS A GMC ISSUE; NOT A [XXX] ISSUE. AGAIN, PLEASE HOLD THEM RESPONSIBLE FOR SELLING A DEFECTIVE TRUCK. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

BRAKE LINE FAILURE, FRONT LEFT. STEEL LINE HAD RUSTED NEXT TO A PLASTIC CLIP THAT SECURED A WIRING HARNESS TO THE BRAKE LINE. BRAKE FLUID WAS SPRAYING ONTO THE SIDE OF THE ENGINE. NOTICED THE LEAK AFTER RETURNING HOME; HAD FAILED IN STOP-AND-GO TRAFFIC.

WHEN BRAKING AT THE END OF OUR DRIVEWAY BEFORE PROCEEDING INTO THE ROAD THE BRAKE PEDAL PULSATES LIKE ABS IS KICKING IN BUT THE VEHICLE HESITATES TO STOP. ALSO WHEN TURNING TO THE LEFT AT LOW SPEED, CAN HEAR THE ABS SYSTEM ACTIVATING AND GET PULSING IN THE BRAKES AS WELL.

WHILE DRIVING ON TWO LANE ROAD,SERVICE BRAKE SYSTEM LIGHT FLASHED, VEHICLE WAS HARD TOO SLOW DOWN AND STOP. STOPPED VEHICLE AND SAW BRAKE FLUID WAS LEAKING FROM LEFT FRONT WHEEL BRAKE LINES.

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE MADE A LOUD CLUNKING NOISE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED. IN ADDITION, THE VEHICLE SHIFTED HARD WHEN SWITCHING GEARS. AN INDEPENDENT MECHANIC DIAGNOSED THAT THE VALVE BODY INSIDE THE TRANSMISSION WAS DEFECTIVE. THE VEHICLE WAS NOT REPAIRED. GMC OF PLATTSBURGH, NEW YORK (518)-563-2000 WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL ON THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND PROVIDED THE CONTACT WITH CASE NUMBER: 8-3309303524. THE FAILURE MILEAGE WAS APPROXIMATELY 20,000. UPDATED 12/13/2017 *LN CONSUMER STATED DOES NOT SHIFT DOWN GOING DOWN HILLS HALF TO RIDE BRAKES AT ALL TIMES. LIGHT DID NOT COME ON WHEN WE HAD TROUBLE WITH ABS CABLE TO WHEEL BEARING, YOU LOSE BRAKE POWER. ALSO TRANSMISSON DOES NOT SHIFT DOWN. UPDATED 7/18/18*JB

SERVICE AIR BAG LIGHT IS ON

TL* THE CONTACT OWNS A 2006 GMC SIERRA 3500. WHILE THE VEHICLE WAS STATIONARY, THE POWER STEERING FLUID LEAKED INTO THE BRAKING SYSTEM AND CAUSED THE BRAKES TO SEIZE. THE VEHICLE WAS REPAIRED AND ALL OF THE HOSES AFFECTED BY THE BRAKE FLUID WERE REPLACED. THE CONTACT STATED THAT THIS WAS THE THIRD TIME THE VEHICLE WAS REPAIRED FOR THE SAME FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 161,108.

TL* THE CONTACT OWNED A 2006 GMC SIERRA 2500. WHILE DRIVING 65 MPH, THE CONTACT'S VEHICLE CRASHED INTO A GUARDRAIL. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED INJURIES TO THE LEFT KNEE, LEFT ANKLE, LEFT HIP, AND ABDOMEN. MEDICAL ATTENTION WAS REQUIRED. THE VEHICLE WAS DESTROYED AND TOWED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 103,000.

I OWN A 2006 GMC SIERRA 1500 PICK-UP WITH LESS THAN 75,000 MILES ON JANUARY 23, 2017 I LOST MY BRAKING CAPABILITY DUE TO THE BRAKE LINES BEING COMPLETELY CORRODED/RUSTED THROUGH CAUSING THE LOST OF BRAKE FLUID. LUCKILY I LOST MY BRAKES IN A PARKING LOT AND NOT ON A BUSY MAIN STREET OR HIGHWAY WITH THE POSSIBILITY OF HAVING AN ACCIDENT AND SERIOUSLY HURTING MYSELF OR SOMEONE ELSE. FROM WHAT I HAVE READ GM HAS KNOWN ABOUT THIS PROBLEM FOR SOMETIME AND SAYS IT IS NOT A SAFETY CONCERN. FROM FIRST HAND EXPERIENCE I BELIEVE THIS IS A MAJOR SAFETY CONCERN. *TR

I WAS DRIVING AROUND A CURVE (50MPH)AND STEERING FAILED. THE STEERING WHEEL TURNED COMPLETELY AROUND BUT WHEELS DID NOT RESPOND. I HAD A STRONG ODOR OF BURNING POWER STEERING FLUID JUST PRIOR TO MALFUNCTION. *TR

TL* THE CONTACT OWNS A 2006 GMC SIERRA 800 (NA). THE CONTACT ENGAGED THE HORN AND IT FAILED TO FUNCTION INTERMITTENTLY. THE RELAY IN THE FUSE BOX WAS REPLACED, WHICH DID NOT CORRECT THE FAILURE. DURING AN OIL CHANGE, THE DEALER STATED THAT THE AIR BAG CONTACT COIL, WHICH WAS TIED TO THE HORN, NEEDED TO BE REPLACED. THE DEALER STATED THEY COULD NOT GUARANTEE THAT THE REPAIR WOULD CORRECT THE FAILURE. THE DEALER REQUESTED A DIAGNOSTIC TEST OF $78 AND ADVISED THE CONTACT THE ESTIMATE FOR THE REPAIR WOULD RANGE FROM $393.12 TO $1,000. A COMPLAINT WAS FILED WITH THE MANUFACTURER WHO STATED THAT SINCE THE VEHICLE WAS TEN YEARS OLD, THEY WOULD NOT OFFER ANY ASSISTANCE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 51,190. *TR

MY WIFE WHILE DRIVING OUR 2006 GMC SIERRA WAS INVOLVED IN A T-BONE ACCIDENT. SHE WAS DRIVING SOUTH IN HER LANE AND WAS CUT OFF CAUSING HER TO HIT THE CAR THAT TURNED IN FRONT OF HER. SHE COULD NOT STOP IN TIME AND WHEN SHE HIT THE OTHER CAR HER AIRBAG DID NOT DEPLOY. SHE DIED FROM BROKEN RIBS THAT PUNCHER-ED HER HEART AND SHE BLED TO DEATH AT WORK TWO HOURS LATER, THE CORONER DETERMINED HER DEATH TO BE FROM BLUNT FORCE CHEST TRAUMA.

TOTAL BRAKE FAILURE WHILE TRYING TO STOP ON A RESIDENTIAL STREET. VEHICLE TOWED TO DEALERSHIP & WAS TOLD BRAKES HAD RUSTED OUT. COST OF REPAIRS WAS AROUND $2000.00

REDUCED ENGINE POWER AND ENGINE LIGHT. HAVE HAD JUST ABOUT EVERYTHING REPLACED I HAVE MY REPAIR BILLS. TRUCK WILL RUN FINE AFTER BEING IN SHOP THEN STARTS ALL OVER AGAIN. THROTTLE BODY HAS BEEN REPLACED TWICE. IT WILL DROP ME DOWN TO 20MPH ON THE HIGHWAY AND I AM AFRAID IT IS GOING TO CAUSE A BAD WRECK. IT HAPPENED TO ME TODAY AND I AM OUT OF TOWN I HAVE DROVE 600 MILES WITH A HORSE TRAILER TO PICK UP A RESCUE HORSE AND AM AFRAID TO START HOME WITH NO CLUE WHAT IS WRONG WITH THIS TRUCK WHEN I RESET THE BATTERY IT WILL WORK FINE BUT I AM TELLING YOU THAT IT IS GOING TO CAUSE A BAD WRECK. I DON'T MIND PAYING FOR IT JUST TELL WHAT THE HELL IS WRONG SO I CAN GET IT FIXED PROBABLY BEFORE SOMEONE GETS HURT OR KILLED.

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. WHILE DRIVING AT A VERY SLOW SPEED, THE BRAKE PEDAL DEPRESSED AND FAILED TO OPERATE. THE CONTACT WAS UNAWARE IF THE EMERGENCY BRAKE WAS DEPRESSED; HOWEVER, THERE WAS NO CRASH. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE LINE WAS RUSTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 83,000.

1.RUSTED BRAKE LINES BLOWOUT.FORTUNATELY MINE HAPPENED IN A PARKING LOT,NOT ON THE TURNPIKE,AND REQUIRING AN EMERGENCY STOP. 2.CLUTCH MASTER CYLINDER PLASTIC MOUNTING FLANGE SEPARATES WHEN CLUTCH IS DEPRESSED,DISABELING STD.TRANSMISSION.ON RESIDENTIAL STREET.

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. WHEN THE BRAKE PEDAL WAS DEPRESSED AT VARIOUS SPEEDS, THE VEHICLE VIBRATED WITHOUT WARNING. WHILE THE VEHICLE WAS BEING SERVICED FOR NHTSA CAMPAIGN NUMBER: 06E050000 (SERVICE BRAKES, AIR), THE PASSENGER SIDE HUB FRACTURED AND WAS UNABLE TO BE REPAIRED. THE CONTACT STATED THAT THE FRONT DRIVER SIDE HUB ASSEMBLY WAS DEEMED AFTER MARKET AND THE REPAIR WAS DENIED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 322,566.

2006 GMC SIENNA. CONSUMER WRITES IN REGARDS TO TRANSMISSION GEAR SHIFTER STICKS/ GRINDS WHEN CLUTCH IS DEPRESSED. *SMD THE CONSUMER STATED HE HAD TROUBLE SHIFTING THE FIVE SPEED TRANSMISSION FROM THE TIME, HE PURCHASED THE VEHICLE. IT WOULD STICK IN GEAR WHEN SHIFTING, MOVE WITH THE CLUTCH DEPRESSED WHEN HE STARTED IT IN GEAR, AND SCRAPE WHEN SHIFTING BETWEEN GEARS. OVERALL, THE CLUTCH WAS NOT DISENGAGING/ THE DEALER CLAIMED THE VEHICLE WAS SELF-ADJUSTING AND THERE WAS NOTHING THAT COULD BE DONE. THE CONSUMER RECEIVED INFORMATION ABOUT AN INCORRECT CLUTCH MASTER CYLINDER BEING INSTALLED IN 2006 SIERRA'S. *JB

DEFECTIVE CASTECH HEADS. LEAKING ANTIFREEZE INTO ENGINE. THINS OUT THE ENGINE OIL AND COULD ENGINE TO OVER HEAT OR SIEZE UP WHILE DRIVING. GM KNOWS OF THE DEFECTIVE HEADS BUT WILL NOT WARRENTY THEM. PLEASE CAN SOMEONE PLEASE HELP US POOR PEOPLE WHO HAVE GOT STUCK WITH THIS BAD DEFECTIVE DESIGN.

I HAVE A 2006 GMC SIERRA WITH THE 5.3L VORTEC ENGINE AND I FOUND OUT THAT THE CASTECH HEADS ARE FAULTY AND LEAKING COOLANT INTO THE ENGINE ALSO FOUND OUT THIS IS A COMMON ISSUE AND GM KNOWS ABOUT IT ,TECHNICAL SERVICE BULLETIN IS 06-06-01-019B WHICH STATES GM IS AWARE OF THE DEFECT THIS TRUCK WAS BOUGHT BY MY BOSS BRAND NEW AND I PURCHASED IT FROM HIM I BELIEVE GM SHOULD TAKE CARE OF THIS FOR MY FAMILY'S SAFETY. JUST NOTICED THIS THIS MONTH AND THIS TRUCK HAS BEEN SERVICED REGULARLY.

TOTAL BRAKE FAILURE WHILE IN MOTION. CORRODED BRAKE LINE RUPTURED CAUSING IMMEDIATE LOSS OF ALL FLUID. HAD THIS HAPPENED 5 MINUTES EARLIER, I WOULD HAVE BEEN ON A FOUR LANE HIGHWAY IN BUMPER TO BUMPER CHRISTMAS TRAFFIC. AT 70 YEARS OLD I CAN ONLY IMAGINE HOW CATASTROPHIC AN ACCIDENT MY REFLEXES WOULD HAVE GENERATED. THE FLUID SPRAYED ON THE HOT ENGINE CREATING A CLOUD OF SMOKE. I WAS AFRAID THE TRUCK WAS ON FIRE. THE FLUID COOKED OFF THE ENGINE AS SMOKE AND AGAIN LUCKILY THERE WAS NO FIRE. NOW AFTER EXTENSIVE REPAIRS, I AM VERY NERVOUS BEHIND THE WHEEL OF THIS VEHICLE. THIS VERY DANGEROUS SITUATION WITH CORROSION SHOULD BE ADDRESSED AS BLOGS ON THE INTERNET INDICATE THIS DANGEROUS ISSUE HAS BEEN ONGOING FOR QUITE AWHILE. I HAVE ATTACHED THE INVOICE OF THE REPAIRS REQUIRED. I WAS IN THE DRIVE THROUGH OF A MCDONALDS AND HAD PLACED MY ORDER AND WAS PULLING TO THE WINDOW TO PAY WHEN THE BRAKES FAILED. LUCKILY I WAS ONLY MOVING SLOWLY AT THAT TIME, THUS ABLE TO AVOID INJURING ANYONE OR DAMAGING ANY OTHER VEHICLES.

ABS ACTIVATION AT LOW SPEEDS RESULTING IN INCREASE STOPPING DISTANCE. IT RESULTED ALMOST STRIKING A PEDESTRIAN IN A CROSSWALK. THIS HAD PREVIOUSLY BEEN REPAIRED AT MY OWN COST IN 2011 AND THE PROBLEM HAS AGAIN RETURNED. PREVIOUSLY GMC SIERRAS WERE RECALLED WITH THE SAME PROBLEM. RECALL NUMBER: 05V379000 RECALL DATE: 08/29/2005 COMPONENT: SERVICE BRAKES, HYDRAULIC:ANTILOCK PROBLEM SUMMARY: CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES MAY EXPERIENCE UNWANTED ANTILOCK BRAKE SYSTEM (ABS) ACTIVATION. CONSEQUENCE: THIS CAN CAUSE INCREASED STOPPING DISTANCES DURING LOW-SPEED BRAKE APPLICATIONS, WHICH COULD RESULT IN A CRASH.

VEHICLE IN MOTION. BRAKE LINE FAILURE (BURST) WHILE DRIVING ON CROWDED CITY STREET - 30MPH. PEDAL SANK TO FLOOR. TOTAL LOSS OF BRAKES. USED EMERGENCY BRAKE AND GEAR IN PARK TO STOP. NEAR COLLISION WITH BICYCLIST.

MY TRUCK EXHIBITED THE SAME ISSUES AS #10240: SPECIAL COVERAGE ADJUSTMENT-HEATING, VENTILATION, AND AIR CONDITIONING BLOWER NOT FULLY FUNCTIONAL OR INOPERATIVE - (MAY 9, 2011). HOWEVER MY AUTO CLIMATE FAN WAS NOT COVERED. I BELIEVE THIS IS A RECALL ISSUE. MY TRUCK BECAME SMOKY FROM THE OVERHEATING WIRES AND THE HVAC SYSTEM WOULD RUN AFTER CUTTING OFF THE IGNITION.

THE TRUCK WAS PURCHASED WITH 113,000 MILES ON IT AND NO APPARENT PROBLEMS WHEN BOUGHT. AFTER ABOUT 3 MONTHS OF OWNERSHIP, THE "SERVICE AIRBAG" MESSAGE APPEARED INTERMITTENTLY FOR THE NEXT FEW WEEKS. AFTER THAT TIME, THE MESSAGE WAS CONSTANT ON. TOOK THE TRUCK TO MY LOCAL DEALER WHO CHARGED TO "REPAIR" IT. MESSAGE CAME BACK AFTER ABOUT A WEEK OF DRIVING. MESSAGE NOW REAPPEARS AT RANDOM INTERVALS. DON'T KNOW IF THE PROBLEM IS WITH THE AIRBAG SENSORS, THE CONTROL UNIT, OR ANY PERIPHERAL SWITCHES. DEALER IS INCOMPETENT AND DO NOT TRUST TO FIX THE PROBLEM. ALREADY PAID GOOD MONEY TO HAVE THIS PROBLEM REPAIRED AND AM NOT GOING TO CONTINUE TO PAY FOR INCOMPETENCE. MESSAGE APPEARS WHEN VEHICLE IS IN MOTION AND WHEN VEHICLE IS STARTED AT RANDOM. MESSAGE WILL SOMETIMES DISAPPEAR FOR WEEKS AT A TIME, THEN, REAPPEAR AT RANDOM.

2006 GMC SIERRA QUIT RUNNING ON A TRIP WE WERE TAKING. IT STARTED MISSING AND EVENTUALLY WOULDN'T RESTART. THE TRUCK HAS 82K ON IT AND IS VERY WELL MAINTAINED. THE ENGINE WOULD TURN OVER BUT NOT START... NO SPARK? IT HAS BEEN TO VARIOUS SERVICE MECHANICS AS WELL AS MY ATTEMPT TO FIGURE OUT WHAT IS WRONG WITH IT. MANY NEW PARTS HAVE BEEN USED: ICM, CRANK SENSOR, CAM SENSOR, COIL... NO DIFFERENCE. THIS VEHICLE QUITTING ON A VERY BUSY HIGHWAY COULD HAVE CAUSED SIGNIFICANT INJURY TO MYSELF AND/OR MY PASSENGER. WHEN THE TRUCK WAS NEW IT HAD AN INTERMITTENT MISS AND WHILE STILL UNDER WARRANTY I RETURNED TO THE DEALER. THERE THEY WERE UNABLE TO FIND ANYTHING THAT WOULD CAUSE THE PROBLEM. THIS SAME MISS WAS PERIODICALLY PRESENT UP UNTIL THE TIME IT QUIT RUNNING ALTOGETHER.

INVOLVED IN ACCIDENT, VEHICLE DRIVEN INTO REAR OF PICK-UP AND U-HAUL TRAILER ON HIGHWAY 50 CANYON CITY,CO ,LEFT FRONT SIDE OF GMC 3500 DESTROYED ALONG WITH HOOD AREA AND THE AIRBAGS DID NOT DEPLOY. DRIVER HAD TO BE CUT OUT OF GMC3500. GMC TOTALED DRIVER SUFFERED BROKEN NECK. PHOTOS OBTAINED BUT NOT ABLE TO UPLOAD.

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. THE CONTACT STATED THAT THE VEHICLE WAS FILLED WITH FUEL AND THE GAUGES SHOWED THAT THE TANK WAS FULL. THE FOLLOWING DAY, WHEN THE VEHICLE WAS STARTED, THE FUEL GAUGE SHOWED LESS THAN A HALF TANK OF FUEL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT THERE WAS NO SIGNS OF A FUEL LEAK OR ANY FUEL ODOR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

APPROACHING RED LIGHT SIGNAL APPLIED BRAKES. DRIVER REAR BRAKE LINE RUPTURED DUE TO RUST THROUGH. WAS ABLE TO SAFELY STOP VEHICLE AS MY SPEED WAS ONLY ABOUT 20 MPH. IF THIS WERE AT HIGHWAY SPEEDS IT WOULD HAVE BEEN EXTREMELY DANGEROUS. FYI THERE IS ALSO EXTENSIVE FRAME AND BODY SURFACE RUST THAT THE MANUFACTURER REFUSED TO HELP WITH. THIS VEHICLE IS MOSTLY PARKED OUTSIDE IN THE MID ATLANTIC REGIONS. GETS VERY LITTLE USE SO LOW MILEAGE. THE RUST IS FROM A MANUFACTURING ISSUE NOT AN ENVIRONMENTAL ISSUE .

PULLING OUT OF DRIVEWAY AND BRAKES GAVE OUT.. STEPPED ON THE BRAKES AND TRUCK DID NOT STOP. A RUSTY BRAKE LINE WAS LEAKING. IT IT HAD A SPLIT IN IT. DO TO RUST ANAND CORROSION. THIS SAME THING HAS HAPPENED TO MY FATHER'S 03 SILVERADO A FEW YEARS BACK. WHY HAS THIS BEEN AN ISSUE WITH NO RECALL. I HAD A KIA SPECTRA FOR 15 YEARS AND NEVER HAD PROBLEMS WITH RUSTY BRAKE LINES LEAKING... IT'S A TRUCK THEY SHOULD BE BUILT TO LAST.. SMH NOT HAPPY..

BRAKE LINE TO REAR BRAKES RUSTED OUT.

RIGHT FRONT BRAKE LINE RUPTURED WHEN APPLYING BRAKES IN A PARKING LOT. BRAKE FLUID STARTED TO LEAK OUT FROM THE LINE THAT CROSSES FROM THE DRIVER'S SIDE TO THE PASSENGER'S SIDE OF THE VEHICLE. IT APPEARS THE RUPTURE WAS DUE TO CORROSION OF THE ORIGINAL LINES.

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. WHILE APPROACHING A TRAFFIC LIGHT AT AN UNKNOWN SPEED, THE BRAKE PEDAL WAS DEPRESSED AND FAILED TO RESPOND. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 54,000. MA 10/1 THE CONSUMER STATED THE MANUFACTURE DID NOT OFFER ANY ASSISTANCE, STATING THE FAILURE IS A MAINTENANCE ISSUE DUE TO ROAD SALT AND NOT A SAFETY ISSUE. UPDATED 12/28/2015*JS

BRAKE PEDAL WENT TO FLOOR ALMOST CAUSING AN ACCIDENT BEFORE THE VEHICLE CAME TO A STOP. BEFORE THE SERVICE LIGHT CAME ON. THE SERVICE LIGHT DID COME EVENTUALLY AT WHICH TIME WE CHECKED THE MASTER CYLINDER WHICH WAS EXTREMELY LOW SO WE FILLED IT THINKING THAT WAS THE PROBLEM. THE NEXT DAY WE NOTICED BRAKE FLUID DRIPPING AND AFTER CHECKING REALIZED THAT AT LEAST ONE OF THE BRAKE LINES WERE WERE RUSTED THROUGH IN SEVERAL PLACES AND ALL OF THE OTHER LINES ARE TERRIBLY RUSTED AND PROBABLY ON THE VERGE OF LEAKING ALSO. THIS IS A TRUCK THAT WE USUALLY PULL OUR CAMPER WITH. LUCKILY WE WERE NOT PULLING IT AT THE TIME THIS OCCURRED.

THE TRANSMISSION BEGAN TO SLIP. AT TIMES, I HAD TO STOP THE TRUCK AND PUT IN PARK BEFORE IT WOULD ENGAGE IN DRIVE. FINALLY IT LOST ALL BUT 1ST GEAR. TOOK TO DEALER AND TORQUE CONVERTER HAD TO BE REPLACED. GMC MADE ME PAY HALF THE $3200 REPAIR. I DO NOT LIVE IN A COLD CLIMATE. A HEAVY DUTY TRUCK SHOULD NOT BE LOSING THE TRANSMISSION AT LESS THAN 50,000 MILES!

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE DECELERATED TO LESS THAN 10 MPH. THE CONTACT ALSO STATED THAT THE AIR BAG WARNING LIGHT CONTINUOUSLY ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 150,000.

TURNED OFF ENGINE, HVAC FAN STILL ON. WILL NOT TURN OFF. THIS IS THE DUAL CLIMATE CONTROL SYSTEM. HAD TO REMOVE FUSE SO THE BATTERY WILL NOT DISCHARGE. SERVICE BULLETINS WERE ISSUED FOR THIS PROBLEM BUT DID NOT INCLUDE ALL VEHICLES, INCLUDING OURS.

CORRODED BRAKE LINES. NO INCIDENT AS OF YET. SERIOUS SAFETY CONCERN BECAUSE OF THE QUALITY OF THE BRAKE LINES. COULD LEAD TO BRAKE SYSTEM FAILURE RESULTING IN UNCONTROLLABLE VEHICLE. WILL NEED TO BE REPLACED/REMEDIATED AT SIGNIFICANT EXPENSE. *TR

BRAKE FAILURE CAUSED BY CORRODED BRAKE LINES. *TR

THE VIN NUMBER IS COMING UP AS A 2006 GMC SAVANNA ON YOUR SITE SAFECAR.GOV UNDER RECALL LOOKUP BY VIN. IT SHOULD BE 2006 GMC SIERRA DENALI 1500 TRUCK.I WOULD LIKE IT CORRECTED IF POSSIBLE SO I CAN SEE CURRENT RECALLS. THANK YOU *TR

THE VEHICLE WAS PARKED AND NOT RUNNING WHEN BOTH DRIVER AND PASSENGER AIRBAGS DEPLOYED. THE STEERING WHEEL IS TORN APART. THE HANDLE ON THE DASH BOARD, PASSENGER SIDE, IS BENT AND THE VENT ON PASSENGER SIDE IS CRACKED. *TR

TL* THE CONTACT OWNS A 2006 GMC SIERRA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE SEAT BELT WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 10,000. UPDATED 7/23/15*CN THE CONSUMER STATED THE FRONT IMPACT SENSOR DID NOT WORK. THE RED LIGHT WAS STILL ON. THE CONSUMER WAS INFORMED IT WAS RELATED TO THE DRIVER'S SEAT. THE DEALER HIS VEHICLE WAS NOT ON THE RECALL LIST. UPDATED 07/28/15*JB

I HAD JUST REPLACED THE THIRD SET OF WHEEL BEARINGS, ASKED MY WIFE TO HOLD BRAKE SO THAT I COULD TORQUE AXEL NUT. WHEN SHE PUSHED THE BRAKE PEDAL, I SEEN BRAKE FLUID POURING DOWN THE FRAME OF TRUCK. CHECKED LINES ALL WERE RUSTED VERY BAD. CALLED MATHENY MOTORS OF PARKERSBURG WV. THE COST OF REPLACEMENT OF LINES WAS QUOTED AT OVER $1200.00 I CAN NOT EXPRESS ENOUGH HOW UPSET I AM THAT THIS SAFETY ITEM WAS NOT MADE OF STAINLESS STEEL ON A VEHICLE THAT WAS AT THE COST OF ALMOST $40,000.00. *TR

BRAKE LINES RUSTING OUT NEEDED IMMEDIATE REPLACEMENT IN VIRGINIA WHERE LITTLE SALT IS USED. *TR

DROVE FROM BALTIMORE, MD TO CLEVELAND, OH. PARKED, THE NEXT DAY ATTEMPTED TO DRIVE AND BRAKE PEDAL WENT TO FLOOR. BRAKE LINE ON DRIVERS SIDE TOWARD THE REAR HAD RUSTED OUT, HAD TO HAVE TRUCK TOWED AND BRAKE LINE REPLACED. IN DEC. 2014, ONE YEAR LATER, TRUCK WAS PARKED FOR 4 DAYS IN DRIVE, WENT TO DRIVE BRAKE PEDAL TO FLOOR AGAIN, HAD TO HAVE TOWED, 4 LINES REPLACED. *TR

MY FAN HIGH SPEED BURST OUT AND I HAD A STRONG ELSE TRIAL BURNING SMELL. I HAD MY TRUCK LOOKED AT TO FIND THAT MY WIRING HARNESS AND RESISTOR HAD BURNT. I HAD THEM REPLACED THIS LAST SEPTEMBER. SINCE THEN I HAVE HAD TO REPLACE TWO MORE RESISTORS AND ONE MORE WIRING HARNESS. I TALKED TO TWO DEALERSHIPS AND NO ONE TOLD ME ABOUT THE, "SPECIAL WARRANTY ADJUSTMENT". I HAD TO RESEARCH THE INTERNET TO FIND THIS OUT. WHEN I TOOK MY TRUCK BACK TO THE ORIGINAL DEALER, THEY BLAMED ME FOR NOT KNOWING THE LANGUAGE. I AM GLAD I DID NOT BURN MY TRUCK UP LIKE SEVERAL OTHER HAD (FOUND ON THE INTERNET). NOW THE DEALER TELLS ME THAT MAIN CONTROLLER HAS FAILED AND I HAVE TO PAY OVER $400 IN REPAIRS. HOW DO I KNOW THAT THE MAIN CONTROLLER DID NOT BURN OUT THE RESISTOR OR WIRING HARNESS? I AM CONCERNED THAT LARGE CORPORATIONS ARE PLAYING WITH OUR LIVES. *TR

WAS COMING TO A STOP LIGHT AND BRAKE PEDAL WENT ALL THE WAY TO FLOOR. HAD TO STEP ON SEVERAL TIMES TO GET STOPPED. THE FACTORY ELECTRICAL WIRE IN FACTORY LOOM IN FACTORY CLAMP HOOKED TO BRAKE LINE WORE A HOLE THROUGH BRAKE LINE TO RIGHT FRONT WHEEL. WORE THROUGH DIRECTLY UNDER THE MASTER CYLINDER. LUCKILY I WAS NOT GOING AT HIGH SPEED OR THIS COULD HAVE BEEN A FATAL INCIDENT!!!!!!!!! THIS IS SOMETHING THAT COME FROM FACTORY AND NEEDS TO BE ADDRESSED. *TR

ANTI-LOCK BRAKES ACTIVATE FOR NO REASON AT SLOW SPEEDS *TR

MY 2006 GMC HAS ONLY 29,000 MILES ON IT. I BOUGHT THE TRUCK IN OCTOBER 2009 WITH 16,000 MILES. I KEEP THE TRUCK CLEAN INSIDE AND OUT, TOP TO BOTTOM INCLUDING UNDER THE VEHICLE. PEOPLE COMMENT TO ME ALL THE TIME ON HOW NICE THE TRUCK LOOKS. BRAKE LINE LET GO IN YARD. PEDAL WENT TO THE FLOOR, NO BRAKES HAD TO HIT REVERSE THEN NEUTRAL AND THE EMERGENCY BRAKE. I HAD JUST RETURNED HOME FROM GOING UP TOWN. THANK GOD IT HAPPENED WHERE IT DID. I HAVE BEEN DRIVING 40 YEARS AND ONLY REPLACED ONE BRAKE LINE IN A 11 YEAR OLD FORD TRUCK AND THAT WAS JUST A SECTION NEAR A BEND. THIS TRUCK NEEDS TO HAVE ALL THE LINES REPLACED. I JUST REPLACED ALL THE TRANSMISSION LINES 4 MONTHS AGO FOR $800.00. SAME THING, ALL RUSTED. I LIVED IN MASSACHUSETTS MY WHOLE LIFE AND I DO MY BEST TO KEEP THE SALT OFF THE TRUCK. LAST TIME I EVER SEEN RUST ISSUES THIS BAD WAS IN THE 1970S WHEN CARS WOULD START RUSTING OUT AFTER 3 YEARS BECAUSE OF THE REUSED STEEL THAT CAME FROM OVERSEAS. *TR

IN LATE OCTOBER, 2013, I PURCHASED MY 2006 GMC SIERRA C1500 STANDARD CAB, 2WD PICKUP FROM A PRIVATE OWNER. ON OR ABOUT, DECEMBER 01, 2013, I NOTICED THAT THE "SERVICE AIR BAG" WARNING MESSAGE APPEARED INTERMITTENTLY. THE "AIRBAG" ILLUMINATED SYMBOL IN THE DASH INSTRUMENTATION AREA WAS ALSO ILLUMINATED. THIS WOULD RANDOMLY COME ON AND GO OFF DURING NORMAL OPERATION OF THE VEHICLE. I SUBSEQUENTLY TOOK THE TRUCK TO A LOCAL GMC/CHEVROLET DEALER FOR SERVICE OF THIS PROBLEM. THEY CHARGED ME TO FIX THE ISSUE AND IT DID NOT APPEAR FOR ABOUT A WEEK AFTER THEIR REPAIR. I SHOULD HAVE KNOWN BETTER, AS THE DEALERSHIP HAS BEEN UNABLE TO SUCCESSFULLY REPAIR PREVIOUS ISSUES ON OTHER VEHICLES THAT I HAVE HAD SERVICED THERE. THE "SERVICE AIR BAG" MESSAGE HAS BEEN ON CONSTANTLY SINCE ABOUT FEBRUARY, 2014, AS WELL AS THE ILLUMINATED ICON IN THE INSTRUMENT CLUSTER. I HAVE NO CONFIDENCE IN MY LOCAL DEALERSHIP WITH THEIR ABILITY TO REMEDY THE SITUATION AND MAY HAVE TO SEEK THIRD PARTY REPAIR FOR THIS ISSUE. GENERAL MOTORS SEEMS TO HAVE NO WEB SITE TO ASSIST OWNERS AND I MUST NOW GLEAN KNOWLEDGE FROM THE INTERNET IN AN ATTEMPT TO REMEDY THE ISSUE. I CAN FIND NO RECALL INFORMATION FOR MY MAKE AND YEAR OF VEHICLE FOR THIS PROBLEM, BUT, THAT DOES NOT MEAN THAT ONE DOES NOT EXIST. *TR

SINCE ROUGHLY JUNE OF 2014 COMPLETE VEHICLE SHAKES VIOLENTLY WHEN BRAKES ARE APPLIED. I HAVE HAD IT LOOKED AT AND HAVE BEEN TOLD THAT IT IS THE BRAKE LINES ABS AND NEEDS REPLACEMENT. I AM A SINGLE FATHER OF TWO BOYS STRUGGLING FINANCIALLY AND CANNOT AFFORD NEW BRAKE LINES. I ALSO HAVE A CURRENT SITUATION WHERE THE REAR BUMPER IS COMPLETELY ROTTED THROUGH AND AS A RESULT CANNOT PASS STATE VEHICLE INSPECTION I HAVE SEARCHED FOR 2 MONTHS AND CANNOT FIND A USED REAR BUMPER AND MANUFACTURER COST IS $450-$500 WHICH I CANNOT AFFORD AT THE MOMENT. I HAVE ALWAYS HAD A GMC PICKUP AND AM VERY DISSATISFIED WITH MY PRESENT SITUATION AS I HAVE ONLY PUT 25,000 MILES ON THE VEHICLE SINCE PURCHASED. *TR

TL* THE CONTACT OWNS A 2006 GMC SIERRA. THE CONTACT STATED THAT THE AIR BAG LIGHTS WERE ILLUMINATED. THE DEALER STATED THAT THE AIR BAG SENSORS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 120,000.

HYDRAULIC BRAKE LINE RUST OUT RESULTS IN LOSS OF STOPPING ABILITY. THE "BLOW OUT" OCCURRED WHILE THE VEHICLE WAS STOPPED (I WAS VERY LUCKY!). UPON INSPECTION, SEVERAL OF THE HYDRAULIC LINES WERE RUSTED BADLY. I FELT THAT I HAD TO REPLACE THEM ALL (WITH STAINLESS STEEL LINES) TO PREVENT ANOTHER FAILURE WHICH COULD HAVE DIRE CONSEQUENCES. THE COST OF THE REPLACEMENT STAINLESS STEEL HYDRAULIC LINES WAS OVER $300. I PERFORMED THE REPLACEMENT OF THESE LINES MYSELF. IT COST ME AN ADDITIONAL $180 TO GET THE COMPLETE ABS BRAKING SYSTEM BLED OUT. *TR

I HAVE HAD TO REPLACE THE TAIL LIGHT LENSES SEVERAL TIMES BECAUSE THE TAB THAT SECURES THE LENSES TO THE VEHICLE BREAKS AND THE RESULT IS LIGHTS JUST HANGING ON THE TRUCK BY THE ELECTRICAL CORDS. I HAVE THE SAME PROBLEM INVOLVING MY OTHER VEHICLES IN THE PAST MADE BY GMC NAMELY A SECOND FAMILY GMC SIERRA THAT WAS MADE IN THE YEAR 2004, AND A CHEVROLET SILVERADO. THE ELECTRICAL LIGHTING ON THE DASHBOARD HAS BEEN MALFUNCTIONING FOR A LONG TIME. I NOTICED THE MALFUNCTION DURING THE FIRST YEAR I BOUGHT THE TRUCK. I HAVE HAD TO REPLACE ELECTRICAL SWITCH IN THE AIR CONDITIONING/HEATING THE MECHANIC TOLD ME THAT THE WIRING IS HEATING UP AND CAUSING THE SHORT TO THE SWITCH. THE NEW SWITCH HAS SHORTED OUT JUST LIKE HE SAID IT WOULD. I HAVE A NOTIFICATION THAT MY AIRBAG NEEDS SERVICING. THERE HAS BEEN NO ACCIDENT INVOLVED TO CAUSE THIS ISSUE. I BOUGHT THIS VEHICLE NEW AND HAVE BEEN THE PRIMARY DRIVER SINCE 2006 WHEN I BOUGHT THE VEHICLE. *TR

I WAKE UP EARLY ON SUNDAY, ON 11/16/15 AND TOOK A COMPANY TRUCK A 2006 GMC SIERRA 1500, TO BRING SOME CARGO. ON MY WAY BACK HOME ON 836 WEST EXPRESSWAY, I TOOK MY EXIT AND WHEN PRESS THE BRAKE PEDAL TO REDUCE SPEED, THE PEDAL WENT TO THE FLOOR OF THE CAR AND THE BRAKE ACTION WAS MINIMUM TO NOTHING. ANOTHER VEHICLE WAS STOP AT THE TRAFFIC LIGHT, AND TO AVOID THE OBVIOUS IMPACT TO THE STOPPED CAR, I PUMPED THE BRAKES SEVERAL TIMES AND APPLIED THE PARKING BRAKES AT APPROX. 30 MPH. SEEING NO WAY TO AVOID THE COLLISION, I PULL THE CAR TO THE SIDE OF THE ROAD AND HIT A CONCRETE WATER DRAIN, RESULTING IN ABRUPTLY SOPPING OF MY CAR AND MY KNEE HIT THE LOWER DASHBOARD. THE GUY OF THE OTHER CAR WENT OUT AND ASK ME, ARE YOU "DRUNK" "ARE YOU OK" I CALLED A FLATBED AND BRING MY TRUCK TO MY WORK PLACE AND THEN NOTICE THAT A BRAKE LINE WAS BROKE AND MOST OF THE BRAKE FLUID SPILLED ALL OVER THE FRONT OF THE CHASSIS, UNDER THE RADIATOR. THE BRAKE LINE WAS INCREDIBLE RUSTED, REASON FOR THE BRAKE DOWN, I HAD CARS WITH A LOT MORE YEARS WITH NO PROBLEM WITH BRAKE LINES. WHEN I INSPECT THE OTHER BRAKE LINES DEEPLY, NOTICED THAT AN EXCESSIVE CORROSION WAS IN ALL OF THEM. GMC SHOULD DO SOMETHING ABOUT THIS, SAFETY ISSUE, IS NO REASON FOR A 2006, ONLY 8 YEARS VEHICLE, PRESENT THAT LEVEL OF CORROSION ON BRAKE LINES. "COKE CAN THICKNESS APPARENTLY" . SOMEBODY WILL DIE OR SERIOUSLY INJURE, OR WILL KILL SOMEBODY, PEDESTRIAN OR DRIVER BECAUSE THE SUDDEN BRAKE FAILURE IN A CASE LIKE THIS. I WILL BRING THE VEHICLE TO A GARAGE TO REPLACE THE BROKEN LINE AND PROBABLY ALL OF THEM.. ITS RIDICULOUS, AND VERY DANGEROUS THAT THIS THINGS HAPPENS IN A VEHICLE THAT AGE. I REALLY APPRECIATE TO BRING THIS CASE TO THE PROPER ATTENTION OF THE MANUFACTURER IN ORDER TO AVOID MORE INCIDENTS LIKE MINE.I CONSIDER MYSELF VERY LUCKY,.COULD NOT BE WRITING THIS IF THIS HAPPENS TO ME AT A HIGH SPEED. THANKS. *TR

BRAKES FAILED AT HIGHWAY SPEED, BRAKE PEDAL WENT TO THE FLOOR WITH VERY LITTLE BRAKING. ON INVESTIGATION, BRAKE OIL WOULD SPRAY FROM THE BRAKE LINE UNDER THE TRUCK. *TR

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. THE CONTACT STATED THAT THERE WAS AN UNKNOWN SUBSTANCE LEAKING FROM THE VEHICLE. IN ADDITION, THE BRAKE LINES WERE RUSTED AND HAD HOLES CAUSING IT TO POTENTIALLY FRACTURE. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE BRAKE LINES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. ADDITIONALLY, THE CONTACT STATED THAT THERE WAS A LOUD NOISE COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. UPDATED 12/10/14*LJ UPDATED 9/29/2015*JS

TL* THE CONTACT OWNS A 2006 GMC SIERRA. WHILE DRIVING 25 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE RACK AND PINION WAS FAULTY AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000. ..UPDATED 01/14/15 *BF UPDATED 01/15/15*JB..........UPDATED 02-02-15*BF..UPDATED 03-02/15 *BF STATUS UPDATE 03/17/15*JB UPDATED 8/31/2017*CN

BRAKE LINE RUPTURED DUE TO CORROSION WHICH WAS NOT VISIBLE DURING SAFETY INSPECTIONS. AFTER APPLYING BRAKES TO STOP AT AN INTERSECTION, BRAKE LINE BROKE, CAUSING A COMPLETE LOSS OF BRAKES AND LOSS OF VEHICLE CONTROL. I HAD TO USE THE TRANSMISSION AND THE EMERGENCY BRAKE TO STOP THE TRUCK. SEVERAL LOCAL MECHANICS COMMENTED THAT THEY ARE SEEING AN INCREASE IN THE NUMBER OF THIS TYPE OF FAILURE ON SIMILAR MODEL YEARS. WITH NO FAILOVER SYSTEM TO STOP THE TRUCK, THIS SHOULD BE LISTED AS A SAFETY ISSUE. *TR

TRUCK STARTED TO HAVE BRAKE PEDAL PULSING AS YOU COME TO A STOP. PROBLEM LEAD TO INCREASED STOPPING DISTANCE AT SLOW SPEED. DEALER KNOWS OF PROBLEM, BUT SAID MY TRUCK WAS NOT COVERED UNDER RECALL. *TR

THE DRIVER'S SIDE SEAT HEATER RANDOMLY COMES ON. IF YOU TURN IT OFF IT COMES RIGHT BACK ON AGAIN AND CYCLES THROUGH THE VARIOUS HEAT SETTINGS. IT CREATES A DANGEROUS DISTRACTION IN THE FLORIDA HEAT. I'VE TAKEN IT TO NUMEROUS DEALERS, NONE OF WHICH CAN FIX IT. I CALL GM AND THEY WON'T EVEN CONSIDER IT UNTIL I TAKE IT BACK TO A DEALER SAYING THEY WILL ONLY GET INVOLVED IF I HAVE TAKEN IT TO A DEALER WITHIN THE LAST 30 DAYS. ONE DEALER TOLD ME THAT WAS A LIE, THERE IS NO 30 DAY REQUIREMENT. THIS ISSUE IS MORE OF A DISTRACTION THAN TEXTING. LOOKING IT UP ONLINE IT'S A COMMON PROBLEM BUT GM DENIES IT EVEN THOUGH GM DID ISSUE A TSB TO HAVE THE DRIVERS DOOR MODULE REPROGRAMMED. I HAD THAT DONE AND IT MADE THE PROBLEM WORSE. A STRAIGHT UP SAFETY ISSUE. I HAVE THE SAME PROBLEM WITH A 2005 SUBURBAN AND FILED A COMPLAINT ON THAT ONE TOO. NOTHING CAME OF THAT EITHER SO IT APPEARS THIS SITE AND AGENCY IS NOTHING MORE THAN A SOUNDING BOARD. GM AND NHTSA CANNOT AFFORD TO DISTANCE THEMSELVES FROM THIS. *TR

I WENT OUT TO MY TRUCK IN THE MORNING AND MY DASH BOARD INDICATOR TOLD ME TO GET MY BRAKES CHECKED; EVERYTHING WAS FINE THE NIGHT BEFORE. I BROUGHT THE TRUCK INTO MYMECHANIC AND FOUND OUT THAT MY BRAKE LINE IS CORRODED AND BROKEN. ALSO FOUND OUT THAT THIS A RECURRING AND CONSISTENT PROBLEM WITH THE GMC SIERRAS. I HAVE MY TRUCK SERVICED BY AN AUTHORIZED SERVICE CENTER ON A REGULAR BASIS AND THIS HAS NEVER BEEN MENTIONED TO ME. THIS NEEDS TO BE A RECALL ITEM! SERIOUS SAFETY THREAT. CANNOT IMAGINE WHAT COULD HAVE HAPPENED IF THIS OCCURRED 2 DAYS LATER WHEN I WAS PULLING OUR 40 FOOT RV. SHOULDN'T GM BE RESPONSIBLE FOR THIS? MY TRUCK IS NOW IN THE SHOP GETTING THE BRAKE LINE REPLACED. *TR

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. THE CONTACT STATED THAT THE AIR BAG LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.

YOU CAN TAKE THE KEY OUT OF THE IGNITION WITH THE MOTOR RUNNING. TO START ENGINE YOU NEED TO 'WIGGLE' THE KEY OR TAKE IT OUT AND RE-INSERT ABOUT 50% OF THE TIME. PLEASE NOTE; BECAUSE OF THE PAST "WE DON'T CARE" ATTITUDE OF GM ON OTHER COMPLAINTS- I PERSONALLY DON'T WANT THEM TO CONTACT ME- I'M JUST LETTING YOU KNOW OF THIS IN CASE OF OTHERS THAT HAVE PROBLEMS. *TR

BRAKES FAILED WHILE COMING TO A STOP IN LIGHT TRAFFIC. BRAKING ACTION REDUCED TO APPROX 10 TO 20 PERCENT OF NORMAL. DRIVER FELT A "POP" AND THE BRAKE PEDAL WENT TO THE FLOOR, FOLLOWED BY A 'SERVICE BRAKE SYSTEM' WARNING MESSAGE. A LARGE PUDDLE OF FLUID FORMED UNDER THE TRUCK WHEN PARKED AND A QUICK LOOK UNDER THE TRUCK SHOWED LOTS OF FLUID FROM THE FRONT OF THE BED TO THE REAR OF THE TRUCK. FURTHER INVESTIGATION SHOWED HEAVY CORROSION ON ALL RIGID BRAKE LINES. ALL BRAKES LINES WILL BE REPLACED. THE FAILED LINE POWERED THE REAR BRAKES. THIS TRUCK IS ONLY EIGHT (8) YEARS OLD. THIS COULD HAVE BEEN LOTS WORSE IF THE BRAKES FAILED ONE WEEK EARLIER WHEN I WAS PULLING A CAMPER THROUGH THE TENNESSEE MOUNTAINS. *TR

I WENT TO PUT ON MY BRAKES, I FIRST STARTED TO STOP THEN MY BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. I HIT A VEHICLE IN FRONT OF ME. THE COLLISION SHOP THAT I HAD IT REPAIRED AT SAID THE BRAKE LINES WERE RUSTED. AFTER FURTHER INVESTIGATION I READ A LOT OF COMPLAINTS ABOUT THIS SAME DEFECT IN CHEVY AND GMC TRUCKS. *TR

JUST DID A 4 WHEELBRAKEJOB;PADS AND ROTORS FOR THEFRONT, SHOES FOR THE REAR! HAD TO REPLACE ONE REAR WHEEL BRAKE CYLINDER. STARTED TO BLEED SYSTEM, REAR BRAKELINE BURST, WAS RUSTED REAL BAD, REPLACED THE AFFECTED LINE THEN FRONT LINE BURST AND THAT WAS RUSTED REAL BAD ALSO. IN CHECKING THINGS OVER DISCOVERED THEY ARE ALL VERY RUSTY, AFRAID IF I DON'T REPLACE THEM ALL WILL HAVE TO SHORTLY BECAUSE THEY ARE ALL IN SAME CONDITION. NOTE;HAD TO REPLACE TRANSMISSION LINES LAST YEAR DUE TO CORROSION AND RUST!!!! *TR

WHILE DRIVING I NOTICED SMOKE COMING FROM UNDER THE HOOD AND A FLUID DRIPPING ONTO THE FLOOR OF THE TRUCK. THEN THERE WAS ABSOLUTELY NO BRAKES. PEDAL TO THE FLOOR. I WAS ABLE TO GET IT INTO A PARKING LOT AND COASTED IN NEUTRAL TIL IT STOPPED ON A PARKING CURB. THE BRAKE LINE HAD RUSTED THROUGH AND RUPTURED, AND THE FLUID WAS SPRAYING INTO A HOLE IN THE FIREWALL AND INTO THE CAB OF THE TRUCK. THIS IS THE THIRD BRAKE LINE THAT HAS RUPTURED IN SUCH A MANNER. NO WARNING AT ALL, AND THEN SUDDEN LOSS OF BRAKING. THE WARNING LIGHT DID NOT COME ON UNTIL THE TRUCK HAD BEEN SITTING FOR OVER AN HOUR WHILE I WAS WAITING FOR A TOW, AND A LARGE AMOUNT OF FLUID HAD LEAKED OUT. I'M JUST GLAD THIS HAD HAPPENED AT A LOW SPEED AND NOT ON AN EXIT RAMP FROM THE FREEWAY. THE RUPTURES ARE OCCURRING WHERE THE LINES RUN FLAT ACROSS A SUPPORT. THIS IS A POOR DESIGN. *TR

I BROUGHT MY 2006 GMC SIERRA 2500 HD IN FOR A BRAKE SERVICE AS NORMAL. TECHNICIAN INSTALLED BRAKES AND ROTORS AND TOOK TRUCK FOR A TEST RIDE. AS TECHNICIAN WAS BRINGING TRUCK BACK FROM THE TEST RIDE, BRAKE LINE RUPTURED AND SPLIT! THIS WAS THE REAR DRIVERS SIDE BRAKE LINE LOCATED UNDER A PLATE. TECHNICIAN SAID HE NEARLY CRASHED THE TRUCK INTO ANOTHER VEHICLE AND HAD TO USE THE EMERGENCY BRAKE AND CURB TO STOP THE TRUCK! WITH ALL THE TRUCKS OUT THERE, GM'S TRUCKS SEEM TO HAVE THE HIGHEST BRAKE LINE FAILURE. I AM WRITING TO YOU TO INFORM YOU OF THE PROBLEM THAT COULD ENDANGER THE LIVES OF ANYONE DRIVING THE VEHICLE AS WELL AS THE PEOPLE AROUND IT! MY HOPE IS THAT GM SEES THERE IS A PROBLEM AND CORRECTS IT BEFORE ANY FATALITIES ARISE FROM BRAKE FAILURE! *TR

I WAS APPROACHING THE STOPLIGHT FLETCHER DRIVE AND LEE HIGHWAY AT APPROXIMATELY 25 MPH HEADING EAST ON LEE HIGHWAY AROUND 1600 EDT IN WARRENTON, VA. THERE WERE FOUR (4) CARS WAITING TO TURN LEFT ONTO FLETCHER DRIVE IN FRONT OF ME. THE CAR IN FRONT OF ME CAME TO A SUDDEN STOP. I APPLIED THE BRAKE WITH APPROXIMATELY 2 CAR LENGTHS IN FRONT OF ME. THE BRAKES STARTED TO GRAB BUT THEN THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOORBOARD. I PUMPED THE BRAKES AND MY TRUCK CONTINUED TO ROLL AND THEN HIT MR. [XXX] VEHICLE AT APPROXIMATELY 5-7 MPH. I WAS UNABLE TO COME TO A COMPLETE STOP UNTIL MAKING CONTACT WITH [XXX] CAR. I ASKED IF HE WAS OK OR HURT AND HE REPLIED YES, I AM OK. WHY DIDN'T YOU STOP?? I EXPLAINED THAT I TRIED. I THEN SUGGESTED THAT BOTH OF US PULL INTO THE FAUQUIER BANK PARKING LOT AND EXCHANGE INSURANCE INFORMATION. AT THIS TIME, I NOTICED MY BRAKES HAD COMPLETELY FAILED AND THE TRUCK WAS LEAKING A SIGNIFICANT AMOUNT OF BRAKE FLUID ONTO THE PARKING LOT (COFFEE CAN OR MORE IN 10 MINS). I STATED THAT SINCE IT WAS A MECHANICAL FAILURE ON MY VEHICLE, I WOULD FEEL BETTER SUBMITTING IT THROUGH INSURANCE. I ALSO SHOWED HIM THE LEAKING BRAKE FLUID. [XXX]. ASKED WHY I WAS DRIVING WITH FAILED BRAKES AND I EXPLAINED THAT THE BRAKES HAD FAILED AT THE INTERSECTION, THAT MY BRAKES WERE WORKING PROPERLY PRIOR TO THE ACCIDENT AND THAT MY TRUCK HAD JUST BEEN PICKED-UP FROM SERVICE AT THE DEALERSHIP (COUNTRY CHEVROLET) ON MONDAY WITH NO PROBLEMS. THE DEALERSHIP JUST INFORMED ME THAT ALL THE BRAKE LINES NEED TO BE REPLACED AND THAT THEY HAVE CORRODED THROUGH AND BASICALLY "EXPLODED". A SIMILAR ISSUE OCCURRED WITH MY 2003 GMC SIERRA IN 2009, BUT WITH NO ACCIDENT. ALL BRAKE LINES HAD TO BE REPLACED DUE TO CORROSION. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

GRINDING NOISE AND BRAKING DIMINISHED ALONG WITH SMOKING WHEEL. FRONT WHEEL BEARING HUB ASSEMBLY IS COMING APART INSIDE WITH ONLY 36000 MILES. *JS

THE SERVICE AIRBAG LIGHT CAME ON AND OFF. TOOK IT TO DEALER TO HAVE TESTED. TROUBLE CODE P0084, DRIVER SEAT POSITION SENSOR. DIAGNOSTIC SHOWED FAULT IS IN AIRBAG SENSING AND DIAGNOSTIC MODULE, SHOWED FALSE HIGH RESISTANCE READING. SENSOR KIT AND MODULE NEEDED REPLACED, ALMOST $600 JUST FOR PARTS. TOOK 2 TIMES AT THE DEALER TO GET THIS FIXED AS FIRST REPLACEMENT PARTS DID NOT WORK. NO COVERAGE BY GMC FOR FAILURE OF SWITCH FOR AIRBAG. TRUCK NEVER IN ANY TYPE ACCIDENT SO AIRBAG WAS NEVER USED. SURPRISED THAT THERE WAS NO ASSISTANCE FROM GMC CONCERNING THIS SAFETY ISSUE AS WORKING AIRBAGS ARE REQUIRED. *TR

MY 2006 GMC SIERRA 1500 4X4 CREWCAB WAS RUNNING IDLE AS I WAS PREPARING TO LEAVE FOR CAMPING TRIP. I WAS CHECKING TO INSURE ALL LIGHTS ON VEHICLE AND TRAILER WERE FUNCTIONING PROPERLY BEFORE DEPARTING. I NOTICED UPON DEPARTURE THAT SMOKE WAS COMING FROM INSIDE THE STEERING COLUMN. I TURNED OFF RUNNING LIGHTS AND WHEN I TRIED TO TURN OFF THE VEHICLE I FOUND THAT I COULD NOT AS THE KEY WAS FROZE/STUCK IN THE ON/RUN POSITION. THE CAB OF THE VEHICLE WAS FILLING WITH SMOKE AND I COULD NOT TURN THE VEHICLE OFF. I QUICKLY DROVE TO THE NEAREST GM DEALERSHIP WHO WAS UNABLE TO HELP DUE TO A HEAVY BACKLOG. I WAS ABLE TO FIND A LOCAL MECHANIC WHO PROMPTLY ASSESSED AND SERVICED MY TRUCK. THE MECHANIC ALERTED ME THAT WHILE THIS TRUCK IS NOT ON THE RECALL LIST, THE PART HE REPLACED (THE IGNITION SWITCH) IS THE PURPOSE BEHIND THE ENTIRE RECALL AND THAT THE PART HAD FAILED EXACTLY HOW THE RECALLED ASSEMBLIES WERE LISTED AS FAILING. I DO NOT KNOW WHY THIS TRUCK HAS NOT BEEN LOOKED INTO FURTHER FOR THIS RECALL BUT HAD I BEEN FURTHER INTO MY TRIP AND NOT HAD A MECHANIC CLOSE BY TO GET THE TRUCK TO, THE END RESULT COULD HAVE BEEN FAR MORE DAMAGING THEN A COUPLE HUNDRED DOLLARS... *TR

WITHOUT ANY WARNINGS WHEN ATTEMPTING TO COME TO A QUICK STOP BRAKE PEDAL WENT TO THE FLOOR AND HAD NO BRAKING POWER. AVOIDED CRASH BY DRIVING ONTO A LAWN. I HAVE FOUND THAT ALL THE BRAKE LINES WHERE THEY ARE ATTACHED TO THE FRAME IN A PLASTIC SUPPORT UNDER THE DRIVERS DOOR HAVE ROTTED THROUGH. CONTACTED GMC WITH NO SUCCESS JUST INFORMING THEY ARE AWARE BUT NO RE-CALLS. *TR

DRIVING THE TRUCK IN MY DRIVEWAY WITH A LANDSCAPE TRAILER ATTACHED, APPLIED THE BRAKES AND THE PEDAL WENT TO THE FLOOR. ONE OF THE BRAKE LINES FAILED DUE TO CORROSION. HAD TO HAVE ALL OF THE BRAKE LINES REPLACED. *JS

WHILE SLOWING TO MAKE A TURN I APPLIED THE BRAKES AND HAD A SUDDEN AND COMPLETE LOSS OF BRAKES. HAD I NOT BEEN ON A SUBURBAN ROAD OR IN TRAFFIC OR A HIGH SPEED HIGHWAY THE SITUATION COULD HAVE BEEN CATASTROPHIC AND RESULTED IN A CRASH. I WAS NEAR MY REPAIRING GARAGE AND MANAGED TO GET THE VEHICLE THERE BY USING THE EMERGENCY BRAKE AND LOW SPEED. IT WAS LESS THAN A MILE. I HAD THIS REPAIRED AT A COST OF $849.27. JUST YESTERDAY (6-30-2014) I WAS PARKED ON A HILL AND AS I RELEASED THE PARKING BRAKE MY FOOT SUDDENLY WENT TO THE FLOOR AND I EXPERIENCED A SECOND LOSS OF BRAKES DUE TO FAILURE OF THE REMAINING TWO BRAKE LINES. I WAS ON A HILL AND HAD ONLY A TINY AMOUNT OF BRAKING POWER. THE VEHICLE IS AT THE GARAGE AND THE COST OF THIS REPAIR HAS YET TO BE DETERMINED. THEY WILL REPLACE THE REMAINING TWO BRAKE LINES. I RECENTLY HAD TO REPLACE THE TRANSMISSION COOLING LINES WHICH RUPTURED AND ARE LOCATED IN A NEARBY LOCATION ON THE VEHICLE. ALL ARE EXPOSED AND UN-SHIELDED. THE MANUFACTURER ADVERTISES THAT THE VEHICLE IS "PROFESSIONAL GRADE" AND "HEAVY DUTY" BUT I FIND BOTH THESE CLAIMS TO BE GREAT EXAGGERATIONS. THESE SITUATIONS HAVE SCARED ME AND I DESIRE TO ACQUIRE A DIFFERENT VEHICLE AS SOON AS I AM ABLE. UNFORTUNATELY, THIS WILL NOT BE SOON. I WILL HAVE TO DRIVE WITH THE FEAR THAT ANOTHER POTENTIALLY CATASTROPHIC PROBLEM COULD DEVELOP AT ANY MOMENT. FORTUNATELY, NEITHER OF THESE INCIDENTS WERE PANIC STOPS.

TL* THE CONTACT OWNS A 2006 GMC SIERRA. THE CONTACT STATED THAT THE AIR CONDITIONER WOULD SHUT OFF INDEPENDETLY AND THERE WAS AN ELECTRICAL BURNING ODOR NEAR THE INSTRUMENT PANEL AND THROUGHOUT THE VEHICLE. WHEN THE AIR CONDITIONER WAS DEACTIVATED, THE BURNING SMELL CEASED. THE FAILURE OCCURRED ON TWELVE DIFFERENT OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 16,000. JCC

THERE IS NO WARNING THE PEDAL GOES TO THE FLOOR AND YOU DON'T STOP. I HAD A 5TH WHEEL TRAILER HOOKED TO MY 2006 GMC 2500 EXT. CAB LONG BED SIERRA P/U WITH 62,459 MILES ON IT. I WAS ABLE TO STOP IT WITH THE TRAILER BRAKES AND A SCRATCH ON MY FRONT BUMPER FROM A TRACTOR TRAILER THAT WAS IN FRONT OF ME. I HAVE OWNED OVER 200 CARS + TRUCKS SINCE I STARTED DRIVING. I DO ALL MY ONE WORK ON THEM AND I NEVER HAD A BRAKE LINE FAIL, I WILL BE 70 THIS YEAR. IT IS RIDICULOUS FOR AN 8 YEAR OLD TRUCK TO HAVE RUSTED BRAKE LINES TO FAIL. THE WORST PART OF THIS IS THAT NOBODY NOTIFIED THE PUBLIC THAT THIS WAS A PROBLEM WHEN THEY GMC KNOWS ABOUT THIS PROBLEM. I FOUND A GARAGE THAT FIXED THE TWO FRONT LINES. SO WE COULD GET HOME. THEN I INSPECTED THE OTHER LINES AND ORDERED THE COMPLETE SET OF STAINLESS STEEL LINES FROM EBAY, WHEN I REMOVED THE OLD LINES THEY ALL WERE RUSTED AT HIDDEN SPOTS TWO WERE CLOSE TO FAILING. WHY DO THEY HAVE TO WAIT FOR SOME ONE TO DIE BEFORE THEY NOTIFY THE PUBLIC THERE IS A SAFETY PROBLEM. THIS IS GMC AND OUR GOVERNMENT (NHTSA) FAILING THE PEOPLE. *TR

CLUNKING SOUND FROM STEERING SHAFT IN COLUMN, CLUNKING BUMPING LOOSENESS IN STEERING HYDRAULIC SLAVE CYLINDER AT ALL SPEEDS. THIS SEEMS TO CAUSE THE TRUCK TO WANDER AT HIGHWAY SPEED, SYMPTOMS ARE WORSE WHEN HIGH WINDS ARE ENCOUNTERED. *TR

WE WERE IN A STORAGE FACILITY PARKING OUR CAMPER WHEN I GOT OUT OF MY GMC TRUCK...I LEFT IT RUNNING IN PARK BECAUSE IT WAS SO HOT OUTSIDE...WHILE I DIRECTED MY BROTHER TO PUT THE CAMPER IN PLACE WITH HIS VEHICLE. THIS TOOK APPROX. 20-30 MINUTES WHEN ALL OF A SUDDEN MY TRUCK IS GOING IN REVERSE ALL ON ITS OWN RUNNING INTO SOME BOATS THAT WERE STORED THERE. WTH!! MY TRUCK GOT REAR END DAMAGE,BUMPER DAMAGE,LIGHT BROKEN AND MY TOPPER WAS MESSED UP AS WELL....ALONG WITH THE BOAT TRAILERS THAT IT HIT! WAS THERE ANY RECALL WITH THIS PROBLEM? I BOUGHT THIS TRUCK ABOUT 2 YEARS AGO WITH ONLY 29,000 MILES ON IT AND IT STILL ONLY HAS 38,000. *TR

I HAD TOWED MY BOAT ON THE INTERSTATE FOR 2 HOURS TO A LAKE. UPON REACHING THE DESTINATION I WAS ATTEMPTING TO LAUNCH THE BOAT AT THE BOAT RAMP. WHILE I WAS BACKING MY BOAT TRAILER INTO THE WATER I WAS USING THE BRAKES TO EASE DOWN THE RAMP. TWO FAMILY MEMBERS WERE IN THE BOAT TO BACK IT OFF THE TRAILER ONCE IN THE WATER. THE PEDAL SUDDENLY WENT COMPLETELY TO THE FLOOR, I STEPPED ON THE EMERGENCY BRAKE TO STOP THE TRUCK FROM ROLLING INTO THE WATER. I GOT OUT AND SAW A LARGE PUDDLE OF BRAKE FLUID UNDER THE TRUCK ON THE DRIVERS SIDE JUST BEHIND THE FRONT WHEEL AREA. I GOT IN THE TRUCK TO SEE IF THE BRAKES COULD BE APPLIED AGAIN BUT WENT COMPLETELY TO THE FLOOR. IN ORDER TO GET THE TRUCK, TRAILER AND BOAT OFF THE RAMP I HAD TO PUT THE TRUCK IN DRIVE, QUICKLY RELEASE THE EMERGENCY BRAKE AND APPLY THE GAS TO PREVENT TRUCK FROM ROLLING BACKWARDS. UPON LOOKING UNDER THE HOOD I FOUND THE BRAKE LINE WAS RUSTED IN A CLIP AND HAD RUPTURED WHERE THE LEFT FRONT WHEEL BRAKE LINE WAS RETAINED IN A CLIP ON THE DRIVERS SIDE FRAME JUST NEXT TO THE STEERING COLUMN. SINCE IT WAS EARLY ENOUGH I WAS ABLE TO GET THE TRUCK TOWED TO A LOCAL MECHANIC TO GET THE RUPTURED LINE REPLACED. ON 5/29/2014 WHILE MOVING THE TRUCK IN THE DRIVEWAY THE BRAKE LINE FOR THE RIGHT FRONT WHEEL HAS NOW RUPTURED, UPON INSPECTION THE RUPTURE IS IN THE EXACT SAME LOCATION WHERE THE BRAKE LINE IS RETAINED IN THE CLIP ATTACHED TO THE FRAME ON THE FRONT DRIVERS SIDE NEXT TO THE STEERING COLUMN. AT THIS POINT I CAN ONLY ASSUME I WILL NEED TO REPLACE ALL THE BRAKE LINES ON THE VEHICLE. IF THIS HAD HAPPENED ON THE INTERSTATE OR HAD TO MAKE AN EMERGENCY STOP DURING THE INITIAL INCIDENT I WOULD HAVE LIKELY HIT SOMEONE, LOST MY BOAT AND INJURED OR KILLED MYSELF OR FAMILY MEMBERS. BRAKE LINES SHOULD NOT RUST LIKE THIS IN FL AND THE LOSS OF ONE BRAKE LINE SHOULD NOT ELIMINATE YOUR ENTIRE BRAKING SYSTEM TO ALL FOUR WHEELS. *TR

APPLIED BRAKES WHEN ON A DOWNHILL ON RAMP TO MERGE INTO TRAFFIC. BRAKE PEDAL WENT TO FLOOR WITHOUT SLOWING VEHICLE. HAD TO SWERVE OFF ROAD TO AVOID A COLLISION .HAD TRUCK TOWED TO DEALER TO REPAIR RUSTED OUT BRAKE LINES $1750.00 EST. WAS TOLD FUEL LINES ALSO LOOKED RUSTED $700.00 EST. *TR

BRAKE LINE RUPTURED DUE TO CORROSION. I WAS LEAVING A HESS STATION IN MASSACHUSETTS AFTER FILLING UP AND WHEN I STEPPED ON THE BRAKE BEFORE PULLING OUT INTO TRAFFIC THE PEDAL DEPRESSED ALL THE WAY TO THE FLOOR. I IMMEDIATELY ENGAGED THE EMERGENCY BRAKE AND PUT THE TRUCK INTO REVERSE TO PARK THE VEHICLE AND INVESTIGATE THE PROBLEM. I FOUND A LARGE BRAKE FLUID LEAK UNDER THE HOOD NEAR THE BASE OF THE STEERING COLUMN WHERE THE HARD BRAKE LINE CLIPS TO THE TRUCK FRAME. THERE WAS A SIGNIFICANT AMOUNT OF CORROSION ON THE BRAKE LINE. ALL FOUR (4) BRAKE LINES ARE CURRENTLY BEING REPLACED AT THE DEALERSHIP WHERE I BOUGHT THE VEHICLE FOR A COST OF ~$2400. *TR

TOTAL BRAKE FAILURE DUE TO RUPTURED HYDRAULIC BRAKE LINE. NO PRIOR WARNING. TOTAL FAILURE, I THOUGHT DUAL MASTER CYLINDER WOULD PROVIDE SOME BRAKING. *TR

BRAKE LINE BLEW OUT. *TR

I AM THE ORIGINAL OWNER OF THIS TRUCK WAS ON MY WAY HOME FROM SHOPPING, LIGHTS ON THE DASH STARTED BLINKING. I ATTEMPTED TO STOP THE TRUCK NOT KNOWING WHAT WAS WRONG, THE BRAKE PEDAL WENT TO THE FLOOR. I STOPPED THE TRUCK WITH THE EMERGENCY BRAKE. OPENED THE HOOD AND THE MASTER CYLINDER WAS EMPTY. I WAS CLOSE TO HOME SO I TOOK THE TRUCK HOME USING THE EMERGENCY BRAKE. I HAVE THIS TRUCK SERVICED BY THE DEALER WHERE WE BOUGHT IT NEW BOB HOOK CHEVROLET AND ALSO MONTGOMERY CHEVROLET, WHO HAD JUST SERVICED THIS TRUCK AND NOTHING WAS SAID ABOUT LOW BRAKE FLUID OR RUSTING BRAKE LINES. THE TRUCK IS NOW IN A REPAIR SHOP WAITING FOR PARTS. THE TRUCK IS NOW NOT DRIVABLE AND STILL AT THE REPAIR SHOP. *TR

I HAVE A 2006 GMC SIERRA WITH THE SAME ABS ISSUES THAT ARE RECALLED FOR OLDER VEHICLES. ABS ENGAGES AT LOW SPEEDS WHEN COMING TO A STOP INCREASING STOPPING DISTANCES. I TOOK IT TO DEALER AND THEY REPLACED THE REAR BRAKES. TRUCK HAS ONLY 41000 MILES ON IT, I WOULDN'T THINK THE REAR DRUM BRAKES WOULD BE WORN OUT. I DROVE IT HOME LAST NIGHT AND TO WORK TODAY. SAME PROBLEM STILL EXISTS. WILL RECALL BE EXTENDED TO INCLUDE MY VEHICLE SOMEDAY? *TR

WAS READY TO LEAVE WORK,HAD FOOT ON BRAKE PEDAL,IT FELT SPONGY STARTED TRUCK,PUMPED IT UP IT STILL FELT SPONGY AS I GOT TO END OF THE ROAD I WAS DRIVING ON I WENT TO HIT BRAKE FOR STOP SIGN/THE BRAKE PEDAL WENT RIGHT DOWN TO THE FLOOR AND BRAKE LIGHT/CHECK IDIOT LIGHT AND MESSAGE CAME ON DASH,OIL REMINDER AS SERVICE BRAKE FAILURE CAME ON UP AS THE MESSAGE. BARELY WAS I ABLE TO STOP HAD TO SHIFT TRUCK TO 3 LOW FOR ADDITIONAL ENGINE BRAKING AS I GOT UP TO THE INTERSECTION AND ALMOST BLEW THROUGH THE STOP SIGN,DROVE IT BOUT A MILE HOME,LOOKED UNDER TRUCK AND SAW BRAKE FLUID SHOOTING OUT AND DRIPPING OFF EVERYTHING BY THE GAS TANK. HAVEN'T DRIVEN IT SINCE. *TR

ARRIVING AT MY RV SITE IN ALABAMA FROM UPPER MICHIGAN A NEIGHBOR SAW SOMETHING LEAKING FROM NEAR THE LEFT FRONT TIRE OF MY PICKUP. UPON DETERMINING IT WAS DIESEL I IMMEDIATELY DROVE TO THE LOCAL CHEVY DEALER. THEY SAID DUE TO THE CONDITION OF THE LINES THEY ALL BE REPLACED. NEXT DAY I WAS ASKED TO COME TO THE GARAGE TO LOOK AT THE BRAKE LINES AS THEY COULD NOT MOVE ANY TO GET PROPER ROUTING OF THE FUEL LINES.THE LINES ATTACHING TO THE ABS MODULATOR, TOTAL OF 6, LOOKED LIKE YOU COULD CRUMBLE THEM WITH YOUR HAND SO ALL WERE REPLACED AS WELL. I PULL A 33 FOOT FIFTH WHEEL AND CONSIDER WE WERE EXTREMELY FORTUNATE NOTHING HAPPENED ON THE ROAD. *TR

BRAKE LINE RUST THRU REAR DRIVERS SIDE AND ALL ARE IN POOR SHAPE. *TR

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500 EQUIPPED WITH HANKOOK DYNAPRO TIRES SIZE LT 265/70 R17. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THERE WAS A BULGE IN THE PASSENGER REAR TIRE'S SIDEWALL. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE TIRE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 96,800. THE DOT NUMBER AND VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, HE ATTEMPTED TO ENGAGE THE BRAKES BUT THE PEDAL SUNK TO THE FLOORBOARD AND THE BRAKE WARNING LAMP ILLUMINATED. THE CONTACT MENTIONED THAT AFTER INSPECTING THE VEHICLE HE NOTICED THAT THE BRAKE LINES WERE CORRODED AND LEAKING BRAKE FLUID. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 61,000.

TL - THE CONTACT OWNS A 2006 GMC SIERRA 1500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THE BRAKES WERE ENGAGED AND FAILED TO RESPOND. THE CONTACT MENTIONED THAT THE SERVICE BRAKE SYSTEM WARNING LIGHT ILLUMINATED AND THAT THE EMERGENCY BRAKES WERE ENGAGED FOR THE VEHICLE TO COME TO A STOP. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE BRAKE LINE WAS CORRODED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 35,000. DR

WHEN BRAKING AT SLOW SPEEDS THE ANTI LOCK BRAKES APPEAR TO ENGAGE CAUSING THE PULSATING BRAKE IN THE PEDAL. THE TRUCK STOPPING DISTANCE IS INCREASED AND THE BRAKES DO NOT FULLY ENGAGE CAUSING THE TRUCK TO BUMP THE CURB. THE PROBLEM ALSO MAY HAPPEN AT HIGHER SPEEDS SUCH AS 25 MPH AND CORRECTS WHEN THE PEDAL IS DEPRESSED FULLY TO THE FLOOR CAUSING THE BRAKES TO FULLY ENGAGE (LOCK UP). THE PROBLEM IS INTERMITTENT AND DOES NOT HAPPEN EVERY TIME. *TR

I BOUGHT A 2006 SIERRA DENALI WITH 65000 MILES ON THE TRUCK IN MAY OF 2013. I LOST MY BRAKES AND ALMOST REARENDED A MAN PULLING INTO HIS DRIVEWAY. I ALSO HAD MY 3 KIDS AND MY FIANCE IN THE TRUCK WITH ME. I TOOK MY TRUCK TO ROBERTSONS GMC IN WAREHAM,MA AND THEY TOLD ME MY BRAKE LINES WERE COMPLETELY ROTTED AS WELL AS MY FRAME. I ALSO HAD A EXTENDED WARRANTY WHICH DID NOT COVER IT BECAUSE IT WAS A PRE-EXISTING PROBLEM. I JUST DON'T UNDERSTAND HOW GM CAN GET AWAY WITH ALL OF THESE FRAME CORROSION AND BRAKE LINE CORROSION PROBLEMS WITHOUT HAVING TO FIX THE PROBLEMS WITH THERE TRUCKS. I HAVE RESEARCHED ALOT ON THESE PROBLEMS AND IT SEEMS LIKE NO ONE IS HOLDING GM RESPONSIBLE AND MAKING THEM FIX THE CORROSION PROBLEM.I THINK THEY SHOULD HAVE TO FIX THE PROBLEM LIKE TOYOTA DID WHEN THEY HAD FRAME PROBLEMS SO THAT THEY CAN STOP PRODUCING VEHICLES THAT DONT LAST 10 YEARS WITHOUT ROTTING AWAY. *TR

I WAS DRIVING DOWN A HILL AND APPLIED THE BRAKES AND THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOR. THERE WAS NO RESISTANCE TO THE BRAKE PEDAL AT ALL. THE BRAKES FUNCTIONED PROPERLY WHEN I STOPPED AT A STOP SIGN, THEN WHEN I WAS GOING DOWN THE HILL THE BRAKE LINE BROKE. *TR

WHEN I WENT TO START THE TRUCK IN THE MORNING, I PUT MY FOOT ON THE BRAKE PEDAL AND IT WENT TO THE FLOOR. GOT OUT AND SAW THE BRAKE FLUID ON MY DRIVEWAY. EXAMINED THE TRUCK AND FOUND A STEEL BRAKE LINE HAD RUSTED THROUGH AND OTHERS HAD SIGNIFICANT RUST. *TR

I HAVE A 2006 GMC SIERRA 2500 HD ON 7/24/2013 THE TRUCK WAS HAVING TIRES INSTALLED AT A LOCAL STORE. THEY TRUCK WAS BROUGHT IN FOR A WHEEL ALIGNMENT SERVICE BY A MECHANIC . THE MECHANIC SHOWED THE LEAK AND THE CORROSION ON THE BRAKE LINES ABOVE THE I BEAM. THEY SAID TO CALL THE DEALERSHIP IN TOWN. I CALLED MY INSURANCE COMPANY TO TOW THE 2006 GMC TO THE DEALERSHIP. AFTER THE DEALERSHIP DISCOVERED THE PROBLEM WITH THE RUSTED LINES THEY ASKED FOR $ 1400.00 FOR REPLACING THE RUSTED LINES. *TR

WHILE TOWING MY TRAILER I LOST MOST OF MY BRAKING CAPACITY. I HAD TO USE THE TRAILER BREAKING MECHANISM TO STOP THE TRUCK. THERE WAS NO CRASH OR INJURIES. *TR

TRUCK HAS HAD AN UNDERCARRIAGE RUST ISSUE AT LEAST SINCE 2007. THE FUEL AND BRAKE LINES MUST BE REPLACED AND THE FRAME AND SUSPENSION ARE DETERIORATING. *TR

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THE BRAKES BEGAN TO PULSATE UPON ENGAGEMENT WITH A SUDDEN ACTIVATION OF THE ANTI-LOCK BRAKING SYSTEM (ABS). AS A RESULT, THERE WAS A DELAYED RESPONSE IN BRAKING TO A STOP. THE FAILURE RECURRED FOUR TIMES AS THE CONTACT WAS DRIVING AT LOW SPEEDS OF 10 MPH OR LESS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT BOTH FRONT ABS SPEED SENSORS WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE MALFUNCTION. THE APPROXIMATE FAILURE MILEAGE WAS 29,000.

WHEN SLOWING TO COMPLETE STOP, THE ABS MOTOR ENGAGES UNDER 10 MPH ON DRY PAVEMENT. THIS CAUSES THE TRUCK TO TAKE A FEW MORE FEET TO STOP. ABS LIGHT COMES ON WHILE MOVING AT TIMES. *TR

WE TOOK OUR 28 FT CAMPER TO BE REPAIRED WHICH CONSISTED OF DRIVING ON INTERSTATE AN AT A HIGH RATE OF SPEED BUT DOING THE SPEED LIMIT. ON OUR WAY HOME WE WERE NO LONGER HAULING THE CAMPER BECAUSE IT HAD BEEN LEFT BEHIND FOR REPAIR. I THANK GOD FOR THIS BECAUSE I WOULD HATE TO THINK WHAT WOULD HAVE HAPPENED IF WE WERE HAULING THE CAMPER ON THE INTERSTATE AND THE BRAKE LINE WOULD HAVE BROKEN THEN. WHEN WE WERE ALMOST HOME I FELT SOMETHING WAS WRONG WITH THE BRAKES. I HAD TO PRESS THEM ALL THE WAY TO THE FLOOR TO GET MY VEHICLE TO STOP. I WAS CLOSE TO A ADVANCED AUTO SO I DROVE VERY SLOWLY AND STAYED FAR FROM VEHICLES SO THAT I COULD MAKE IT THERE FOR THEM LOOK TO SEE IF I WAS LOW ON FLUID. BUT WHEN I TURNED INTO THEIR PARKING LOT IMMEDIATELY AFTER I PUT ON THE BRAKES TO PARK IT THE BRAKE LINE BROKE. I HAD TO HAVE MY VEHICLE TOWED TO A LOCAL DEALERSHIP WHERE I HAD TO HAVE REPAIRS DONE. NOT ONLY THE BRAKE LINES WERE CHANGED BUT THE CALIPERS ALSO. THE BILL WAS JUST UNDER 5 THOUSAND DOLLARS. I CALLED GMC ALL THEY DID WAS CALL THE DEALERSHIP TO MAKE SURE EVERYTHING WAS DONE. WHICH WAS NO HELP TO ME. I COULD HAVE TAKEN CARE OF THAT MYSELF. I BELIEVE THIS IS A GREAT INJUSTICE TO GMC OWNERS THAT THEY KNOW OF A SITUATION AND WOULD LET US USE THESE VEHICLES TO HAUL OUR CHILDREN ON CAMPING TRIPS PUTTING THEIR SAFETY IN DANGER. I WILL NOT PURCHASE ANOTHER GMC VEHICLE. ALSO MY EXTENDED WARRANTY ENDED A FEW WEEKS BEFORE. ALTHOUGH I WAS TOLD THEY WOULD NOT HAVE COVERED IT . I ALSO BRING MY VEHICLE FOR OIL CHANGES AS REQUIRED TO THE DEALERSHIP WHICH THEY DO CHECK OTHER THINGS AS A ROUTINE. I CANNOT UNDERSTAND WHY THESE AUTO REPAIRMEN DIDN'T CATCH THIS . THERE IS NO REASON THIS SHOULD HAVE HAPPENED TO THIS VEHICLE. .. WHEN YOUR BRAKES GO OUT YOU LOOKING AT A MAJOR DANGER TO YOURSELF AND OTHERS. *TR

DRIVING IN RESIDENTIAL NEIGHBORHOOD AT APPROX. 25 MPH. UPON ENGAGING BRAKES TO STOP AT STOP SIGN, PEDAL SUDDENLY BECAME EXTREMELY SOFT AND TRAVELED NEARLY TO FLOOR. IT TOOK ME A MOMENT TO FIGURE OUT WHAT WAS GOING ON AND I HAD TO PRESS WITH FULL FORCE TO STOP. DROVE SLOWLY TO NEAREST GMC DEALER, NOT FAR AWAY. ALMOST ALL OF THE BRAKE PEDAL TRAVEL PROVIDED NO RESPONSE; THE REMAINDER OF TRAVEL WAS SOFT AND PROVIDED MINIMAL BRAKING PERFORMANCE. DIAGNOSIS BY THE DEALER WAS EXCESSIVE CORROSION ON ALL SOLID BRAKE LINES AND FITTINGS. BURST/LEAKAGE ON A LINE NEAR THE DRIVER'S SIDE REAR WHEEL WAS CAUSING THE SOFT, NEARLY UNRESPONSIVE BRAKE PEDAL. RECOMMENDATION BY DEALER WAS TO REPLACE ALL SOLID BRAKE LINES AND FITTINGS, FROM MASTER CYLINDER TO ABS UNIT TO EACH WHEEL END. I WAS TOLD THAT ONLY FIXING THE AREA THAT HAD BURST WOULD BE TOO "RISKY" DUE TO CONDITION OF THE REST OF THE SOLID BRAKE LINES AND THAT FAILURE IN ANOTHER PART OF THE LINES WAS "PROBABLY GOING TO HAPPEN." THE FLEXIBLE/RUBBER BRAKE LINES AND FITTINGS AT CALIPERS/DRUMS WERE "OK" AND NOT REPLACED. TOTAL CHARGE: $1380.46. THIS IS A 7-YEAR OLD VEHICLE WITH ABOUT 40K MILEAGE THAT HAS BEEN WELL-MAINTAINED IN PERSONAL USE/COMMUTING. I HAVE NEVER EXPERIENCED THIS FAILURE BEFORE, ON ANY VEHICLE AT ANY AGE, INCLUDING NUMEROUS VEHICLES 10+ YEARS OLD ALL DRIVEN IN NE OHIO. I AM GRATEFUL THE BRAKES GAVE UP WHEN/WHERE THEY DID: AT LOW SPEED AND WITHOUT ANY OTHER VEHICLE (OR PEDESTRIAN) AROUND. I CONTACTED GM AND REGISTERED MY COMPLAINT; THEY OFFERED NO RELIEF OR EXPLANATION (BEYOND "ENVIRONMENTAL" CAUSE), THOUGH THEY EXPRESSED SERIOUS INTEREST IN MY EXPERIENCE. I THINK THIS FAILURE IS UNACCEPTABLE AT THIS STAGE OF A VEHICLE SERVICE LIFE, REGARDLESS OF WHETHER IT IS USED IN THE "SALT BELT." PLEASE CONSIDER EXPANSION OF EA11-001 TO LATER MODEL YEARS OF GMT800-SERIES VEHICLES. *TR

I PURCHASED THE 2006 2500HD DIESEL PICKUP NEW. THE TRUCK HAS HAD POOR BRAKING SINCE NEW AND THE DEALER HAS ALWAYS SAID IT FUNCTIONS NORMALLY. I HAVE HAD THE DEALER DO ALL THE MAINTENANCE ON THE TRUCK OTHER THAN OIL AND FILTER CHANGES. THE UNDERCARRIAGE OF THE TRUCK INCLUDING ALL LINES, BRAKES ROTORS, HUBS HAS BEEN RUSTING SINCE NEW. THE UNDERSIDE OF THE TRUCK LOOKS LIKE A 20 YEAR OLD PLOW TRUCK. ON 12-6-2012 I WAS DRIVING ON THE HIGHWAY IN TRAFFIC AND THE EXPERIENCED A COMPLETE BRAKE FAILURE. SOME HOW I DID NOT HIT ANYTHING AND WAS ABLE TO GET TO THE SHOULDER AND COAST TO A STOP (VERY LUCKY IN N.J. TRAFFIC). THE BRAKE LINES BLEW THE TRUCK WAS TOWED BACK TO THE DEALER AND THEY FIND THE LINES ARE GONE AS WELL AS THE ROTORS THAT THEY REPLACED ABOUT 2 YEARS AGO. THE PADS ARE STILL IN GREAT SHAPE BUT THE ROTORS ARE RUSTED BEYOND USABILITY. LOOKING INTO THIS I FIND I AM NOT ALONE AND WOULD LIKE TO KNOW IF I CAN GET INFO ON THE ISSUE INCLUDING, IS THE PROBLEM FIXED IN THE NEW TRUCKS AND IS COMPENSATION AVAILABLE AS THE TRUCK IS ON ITS WAY TO THE RUST GRAVE YARD WITH THE SHEET METAL RUSTING FROM THE UNDERSIDE ALSO. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2006 GMC 2500 EQUIPPED WITH BF GOODRICH MUDD KM2 TIRES, SIZE 35 12.5 R18. THE CONTACT STATED THAT THE REAR PASSENGER SIDE TIRE BLEW OUT AND DAMAGED THE REAR SQUARE PANEL AND WHEEL WELL OF THE TIRE. THE CONTACT STATED THAT THEY WERE ABLE TO PREVENT THAT THE FRONT DRIVER SIDE TIRE BLEW OUT. THE TIRES HAD PLENTY OF TREAD AND THE TIME OF THE BLOW OUT. THE CURRENT MILEAGE WAS 93,000.

I WAS DRIVING DOWN THE ROAD WHEN THE STEERING WHEEL LOCKED INTO PLACE. I HAD TO JERK IT HARD IN ORDER TO GET IT TO RELEASED FROM THE LOCKED POSITION. THIS HAS HAPPENED TWICE ALREADY. CAN EASILY CAUSE A CRASH. NEEDS TO BE FIXED BY MANUFACTURER. *TR

BRAKES FADE NEAR THE END OF A BRAKING CYCLE. NO WARNING LIGHTS DISPLAYED EVEN THOUGH BRAKE PEDAL FELT LIKE IT HAD INCREASED TRAVEL OR MUSHINESS. CAUSE; EXCESSIVE AND PREMATURE CORROSION AND PITTING OF ALL FOUR ORIGINAL EQUIPMENT BRAKE ROTORS. ALSO, EXCESSIVE CORROSION OF BRAKE SENSORS AND BRAKE CALIPERS NECESSITATES AN EXTENSIVE REPAIR. ORIGINAL BRAKE PADS ARE IN GOOD CONDITION REPAIRS NEEDED; REPLACEMENT OF ROTORS, SENSOR, CALIPERS AND BRAKE PADS. BOLTS SEIZED BY CORROSION BROKE ON REMOVAL OF BRAKE COMPONENTS AND THIS RESULTED IN REPLACEMENT OF SENSOR AND ALL CALIPERS. THE COST OF THE REPAIR WAS $2100.00. MY OPINION; POOR QUALITY METALS IN ORIGINAL FACTORY ROTORS CAUSED A SIGNIFICANT BRAKE FAILURE ON THIS VEHICLE WHICH CAUSED BRAKING SAFETY ISSUES AND AN EXPENSIVE REPAIR. THIS IS A SAFETY ISSUE BECAUSE; POOR BRAKING OCCURS AND THE HIGH COST OF REPAIR WILL MEAN SOME OWNERS OF THIS VEHICLE WILL PUT OFF REPAIRS AND CONTINUE OPERATING THIS VEHICLE WITH DAMAGED BRAKE SYSTEMS. I THINK THIS VEHICLE SHOULD BE RECALLED BECAUSE THIS IS A SAFETY ISSUE AND THE MANUFACTURER SHOULD TAKE AT LEAST SOME RESPONSIBILITY TO REPAIR THIS MODEL. THE 2500 (3/4 TON) SERIES THAT I OWN IS MOSTLY USED BY CONTRACTORS AND OTHERS WHO PULL OR HAUL HEAVY LOADS. SO, THE BRAKES REALLY DO NEED TO WORK. *TR

I PURCHASED MY PICKUP NEW IN JAN. 2007 AND USE IT TO TOW AN 8X16 TRAILER W/ELECTRIC BRAKES FOR A PART TIME BUSINESS THROUGHOUT THE SUMMER. THE TRAILER WEIGHS APPROX. 6000 LBS. LOADED AND THE TRUCK IS RATED FOR 8,000 LBS. APPROXIMATE TOWING MILEAGE IS 3 TO 4,000 MILES PER YEAR. AFTER TOWING THE TRAILER 200 MILES ON SEPT. 14, 2012 MY WIFE NOTICED SEVERAL OIL LEAKS ON THE ASPHALT NEARBY. I SUSPECTED SOMETHING IN THE DIFFERENTIAL AREA AND DROVE TO THE NEAREST GMC DEALERSHIP SEVERAL MILES AWAY. THEY DIAGNOSED IT AS A REAR BRAKE LINE AND ENDED UP REPLACING 6' OF IT ALONG WITH BOTH ROTORS AND CALIPERS AND A BRAKE SYSTEM FLUSH FOR A TOTAL OF $958.76. I'M 66 YRS. OLD AND HAVE NEVER HAD A BRAKE LINE GO IN ANY VEHICLE I'VE EVER OWNED AND I'VE LIVED IN MASSACHUSETTS ALL MY LIFE. MY LOCAL MECHANIC JUST TOLD ME THIS WEEK THAT THE REST OF THE BRAKE LINES ARE BADLY CORRODED AND SHOULD BE REPLACED ASAP. THIS WILL ADD ANOTHER $900 TO THE ENTIRE COST. THERE IS NO QUESTION IN MY MIND THAT GM HAS ALLOWED QUALITY IN WORKMANSHIP ON ITS BRAKE LINES TO FALL THROUGH THE CRACKS...AND AT THE PUBLIC'S EXPENSE. *TR

FIRESTONE DESTINATION A/T LT285/75R16 TIRES - CATASTROPHIC FAILURE OF TIRE WHILE TRAVELING AT 60 MPH IN MIDDLE LANE OF THREE LANE HWY. NO PUNCTURE. SIDE WALL BLEW OUT . TIRES HAD ONLY 15,000 MILES. *TR

BRAKE LINE FAILURE BETWEEN ABS FLOW CONTROL AND REAR BRAKES. FOLLOWED BY A SECOND FAILURE ABOUT A MONTH LATER WITH A FRONT BRAKE LINE. REPLACE ALL LINES AT THAT POINT DUE TO RUSTING. VEHICLE WAS GARAGED IN NEW ENGLAND, AND SPENT LAST 3 WINTERS IN FLORIDA WHERE THE LINES FAILED. *TR

FOUND REAR BRAKE PADS AND DISCS COMPLETELY WORN OUT DURING TIRE ROTATION AND BRAKE CLEANING AND INSPECTION. *TR

I WAS BACKING OUT OF MY DRIVEWAY (DOWN HILL SLOPE) AND LOST POWER STEERING AND BRAKING IN MY 2006 GMC 2500HD DIESEL TRUCK. I PUT THE TRANSMISSION IN NEUTRAL AND DEPLOYED THE EMERGENCY BRAKE TO STOP. THE MECHANIC DETERMINED THE POWER STEERING PUMP HAD FAILED AND THIS RESULTED IN THE HYDRO BOOST FAILURE WITH SUBSEQUENT BRAKE LOSS. AFTER REPLACING THE POWER STEERING PUMP THE POWER STEERING LINES SPLIT TWO WEEKS LATER. *TR

ANTILOCK BRAKING SYSTEM (ABS) ACTIVATES CONSISTENTLY AS VEHICLE NEARS FULL STOP. IT'S AUDIBLE AND YOU FEEL THE PULSATION IN THE BRAKES. THE ROAD CONDITIONS ARE NORMAL AND THERE IS NO REASON FOR THE ABS TO ACTIVATE. *TR

ABS MOTOR ENGAGES ON DRY PAVEMENT AT LOW SPEEDS WHEN COMING TO A STOP, ABOUT 10 MPH OR LESS. *TR

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. THE CONTACT STATED THAT THE ABS ENGAGED WHILE BRAKING AT LOW SPEEDS. AS A RESULT, THE VEHICLE EXPERIENCED AN INCREASED STOPPING DISTANCE. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 120,000.

WHILE BRAKING AT LOW SPEEDS AND COMING TO A FULL STOP, TRUCK LURCHES FORWARD AND BRAKE PEDAL GOES DOWN 1/8 OF AN INCH. DRIVER MUST USE MORE BRAKE TO STOP TRUCK ( THIS IS WITH NO LOAD IN TRUCK AT ALL, ONLY PASSENGER ). ALSO WHILE STOPPED AND TURNING THE WHEEL LEFT OR RIGHT TO PARK, STEERING WHEEL LOOSES POWER STEERING UNTIL BRAKE IS RELEASED AND TRUCK STARTS ROLLING. HAD TRUCK LOOKED AT TWICE BEFORE AT DEALER FOR SAME PROBLEM ( ONCE AT 32,000 AND AGAIN AT 35,000 ) AND WAS TOLD, AS LONG AS NO HARD CODES OR FAILURES ARE FOUND, THEY WERE UNABLE TO ADDRESS THE ISSUE. *JB

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. THE CONTACT STATED THAT WHILE DRIVING 75 MPH, THE SERVICE 4-WHEEL DRIVE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS AND THE TRANSFER CASE ENCODER MOTOR AND TRANSFER CASE SELECTOR SWITCH WERE BOTH REPLACED. THREE YEARS LATER THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO THE CONTACT'S PERSONAL MECHANIC AND THE SAME PARTS WERE REPLACED. THE FAILURE MILEAGE WAS 53,012 AND THE CURRENT MILEAGE IS 115,603 UPDATED 7/26/12*CN UPDATED 08/07/12

WAS DRIVING HOME FROM WORK. SMELLED SOMETHING HOT, THEN SMOKE CAME OUT VENTS, WITHIN LESS THAN A MINUTE FLAMES WERE COMING OUT FROM UNDER PASSENGER'S SIDE DASH. HAD TO PULL OVER AND PUT OUT FIRE WITH FIRE EXTINGUISHER. IF THERE HAD BEEN A PASSENGER LIKE MY CHILDREN THEY WOULD HAVE BEEN SEVERELY BURNED OR KILLED.I AM A GM TECHNICIAN AND THE FUSE FOR THE HVAC DID NOT BLOW AND TAKING AWAY POWER DID NOT STOP THE ISSUE. I KNOW THAT THERE ARE ISSUES WITH THE RESISTOR WIRING. MY VEHICLE SYSTEMS ALL WORKED FINE BEFORE THE INCIDENT AND GAVE NO INDICATIONS OF FAILING. THIS INCIDENT HAPPENED FAST ENOUGH THAT THE VEHICLE WOULD HAVE BEEN TOTALLY IN FLAMES IF A FIRE EXTINGUISHER WAS NOT RIGHT HANDY. YOU ARE AWARE OF THIS ISSUE WHY IS NOTHING BEING DONE ABOUT IT. GM IS VERY LUCKY THAT I DID NOT HAVE A PASSENGER TONIGHT. *JS

FRONT DIFFERENTIAL VIBRATION/NOISE AT 47-70 MPH. INTERNAL BEARINGS REPLACED DUE TO SIGNIFICANT METAL FOUND ON MAGNETIC DRAIN PLUG. TECHNICIAN STATEMENT "BEARINGS COMING APART" STATED. IDENTICAL COMPLAINT WITH IDENTICAL REPAIR REPEATED 4 TIMES WITHIN 85,000 MILES. FIRST REPAIR OCCURRED AT 34,000 MILES. LATEST (4TH) PERFORMED AT 85,919 MILES. *JS

I HAVE A 2006 GMC SIERRA 2500 HD WITH 32000 MILES. I HAVE HAD TO REPLACE THE BRAKES AND ROTORS TWICE BECAUSE THEY HAVE RUSTED AND ROTTED AWAY. I HAVE HAD TO REPLACE MY EXHAUST BECAUSE OF RUST AND THE ENTIRE UNDER CARRIAGE AND FRAME ARE HEAVILY RUSTED. I HAVE JUST RECENTLY NOTICED THAT THERE IS EVEN RUST INSIDE THE CAB, INTERIOR DOORS, CHROME IS BUBBLING. *TR

FRONT ABS SPEED SENSORS FAILED AT 26,000 MILES. THE MANUFACTURE SAID THIS WAS DUE TO NORMAL WEAR AND TEAR, THIS MODEL YEAR SHOULD HAVE 60,000 MILES ON IT. THEY HAVE REIMBURSED SOME OWNERS FOR THIS PROBLEM AND REFUSE TO PAY OTHERS. NO ONE AT GM COULD EXPLAIN WHY BOTH SENSORS WENT OUT AT THE TIME. *TR

2006 GMC SIERRA 1500. CONSUMER WRITES IN REGARDS TO A LETTER RECEIVED FROM GMC REGARDING AN HEATING ISSUE WITH THE VEHICLE *TGW THE CONSUMER STATED THE PROBLEM SEEMS SERIOUS ENOUGH TO WARRANT A RECALL, RATHER THAN WAITING FOR THE PROBLEM TO OCCUR.

TL* THE CONTACT OWNS A 2006 GMC SIERRA. THE CONTACT STATED THE VEHICLE CAUGHT FIRE WHILE IT WAS PARKED IN THE GARAGE. THE FIRE DEPARTMENT STATED THE FIRE ORIGINATED IN THE ENGINE COMPARTMENT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHICH WAS UNDER INVESTIGATION. THE VEHICLE FAILURE AND CURRENT MILEAGE WAS 36,000. UPDATED 03/05/12*LJ UPDATED 03/06/12

TL* THE CONTACT OWNS A 2006 GENERAL MOTOR COMPANY SIERRA 1500. THE CONTACT DISCOVERED THE BRAKE LINE AND REAR BUMPER WAS CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 74,000 AND THE CURRENT MILEAGE WAS 75,000.

DESCRIBE BELOW IS EXACTLY WHAT HAS OCCURRED WITH MY VEHICLE. HOWEVER GM REPLACEMENT PART IS DEFECTIVE AND ISSUE IS UNDER RECALL IN CANADA???? NOT U.S.??? PART IS BEING REDESIGNED MAY BE A COUPLE OF MONTHS?? BEING TOLD WILL HAVE TO WAIT IN MEAN TIME I HAVE MANUALLY BRING HEAT UP FROM LOW AND MAY HAVE HEAT MAY HAVE TO SHUT DOWN VEHICLE AND START AT LOW. NOT VERY REASSURING WHEN TEMPS ARE -40F BELOW ZERO. UNTIL PART IS RE-DESIGNED OR ENGINEERED??? I AM SUPPOSE TO DRIVE THIS VEHICLE WHICH IS LISTED UNDER A SAFETY RECALL AND ENCOUNTER CONTINUED FAILURE AND POSSIBLE ENGINE FIRE???? NOT ACCEPTABLE! HTTP://WWWAPPS.TC.GC.CA/SAF-SEC-SUR/7/VRDB-BDRV/SEARCH/RECALLDETAIL.ASPX?RN=2011074&LANG=ENG RECALL DATE 2011/02/21 NOTIFICATION TYPE SAFETY TC MANUFACTURER RECALL NUMBER 11046 UNITS AFFECTED 190,310 CATEGORY LIGHT TRUCK & VAN, SUV RECALL DETAILS ON CERTAIN VEHICLES, THE INTERFACE BETWEEN THE ELECTRICAL TERMINALS OF THE HEATING, VENTILATION, AND AIR CONDITIONING (HVAC) BLOWER RELAY RESISTOR MODULE AND THE WIRING CONNECTOR (WHICH POWERS THE MODULE) MAY BE INCAPABLE OF CONDUCTING HIGHER CURRENT LEVELS FOR SUSTAINED PERIODS OF OPERATION. IN ADDITION, MOISTURE AND OTHER CONTAMINANTS (SUCH AS ROAD DE-ICING MATERIALS) MAY ENTER THE FRESH AIR INTAKE PLENUM AND CONTACT THE INTERNAL CIRCUIT OF THE MODULE OR CORRODE THE TERMINALS. THESE CONDITIONS MAY CAUSE THE RELAY RESISTOR MODULE OR WIRING CONNECTOR TO OVERHEAT, CAUSING VARIOUS SYMPTOMS SUCH AS: THE HVAC BLOWER MAY NOT FUNCTION ON CERTAIN OR ALL BLOWER SPEED SETTINGS; A BURNING-PLASTIC SMELL OR SMOKE MAY BE PRESENT IN THE VEHICLE, OR; THE HVAC BLOWER MAY RUN CONTINUALLY WITH THE IGNITION IN THE OFF POSITION. THESE WARNING SIGNS COULD, IN CERTAIN INSTANCES, BE LEADING INDICATORS OF AN IMPENDING VEHICLE FIRE, WHICH COULD RESULT IN PROPERTY DAMAGE AND/OR PERSONAL INJURY. GMC SIERRA 2003 2004 2005 2006 2007. *TR

2006 SIERRA -75000MILES CLUNKING IN DRIVETRAIN WHEN TRANS. SHIFTS REAREND CLUNKS AND JUMPS IN AND OUT WHEN DIFF LOCK IS NEEDED CHATTER IN STEERING COLUMN ENGINE LIGHT COMES ON WHEN DOWN TO 1/2 -3/4 TANK (EVERYTIME) REFUEL IT GOES OUT DASH LIGHTS FOR THE RADIO BUTTONS SLOWLY GOING OUT DASH LIGHTS ON THE SLIDER FOR HEATER CONTROLS GOING OUT VERY POOR MPG 12-13 ON A GOOD DAY! SURE WOULD LIKE TO HAVE ALL THE RECALLS AND BULLETINS TAKEN CARE OF! NOTE TO MYSELF!! NEVER PURCHASE A GMC AGAIN! *TR

MY 2006 GMC SIERRA 1500 WITH 25000 MILES ON IT HAD BOTH FRONT WHEEL ABS SENSORS FAILED. CAUSING ENGAGING OF THE ANTI LOCK BRAKES, WHEN BRAKES IS DEPRESSED WHEN MOVING AT LESS THAN 10 MPH. *TR

BRAKE LINE FAILURE. LOW SPEED BACKING UP BRAKE PEDAL WENT TO FLOOR . BRAKE FLUID SPRAYED ON EXHAUST, PRODUCING A LOT OF SMOKE.TRUCK WAS COLD, IF RUNNING LONGER THERE COULD HAVE BEEN A FIRE. CONTACTED GM IN 2009 ABOUT BRAKE LINE RUST AND THEY STATED IT WAS NORMAL. TRUCK HAD ONLY 32000 MILES AT TIME OF COMPLAINT. TRUCK NOW HAS 58000 MILES. *KB

2006 GMC SIERRA. CONSUMER WRITES IN REGARDS TO RECALL CONCERNING HUB BEARING *TGW THE CONSUMER ALSO STATED, THE BRAKES WERE NOT FUNCTIONING PROPERLY. THERE WERE TIMES, WHEN IT FELT AS THOUGH THE BRAKES DIDN'T GRAB. *JB

AFTER FILLING THE TANK I DROVE FOR SEVERAL HUNDRED MILES AND I LOOKED AT THE TANK AND IT SHOWED I HAD GAS SO I KEPT DRIVING, SOON THE ENGINE STOPPED AND I WAS LEFT STRANDED BY MY TRUCK AND I AM DISABLED. I THEN HAD THE VEHICLE TOWED AND THE SERVICE STATION FOUND NOTHING WRONG WITH IT OTHER THAN THEY ADDED GAS AND IT STARTED AND RAN FINE. I CONTINUED TO DRIVE THE TRUCK AND NOTICED THAT THE GAS WAS NOT GOING DOWN ON THE GAUGE LIKE IT SHOULD. ONE DAY I GOT IN MY TRUCK AND STARTED IT AND THE LOW FUEL SENSOR LIGHT CAME ON ALONG WITH A CHIME , THE (DIC) SAID THE FUEL WAS LOW BUT I HAD JUST FILLED IT UP AND HAD ONLY DRIVEN A FEW MILES. THE LOW GAS LIGHT STAYS ON ALL THE TIME NOW EVEN WHEN I FILL IT UP ALONG WITH THE SERVICE ENGINE LIGHT AND IT WILL CHIME EVERY TIME I START IT UP. I TOOK THE VEHICLE TO A MECHANIC AND HE STATED IT WAS A WORN FUEL LEVEL SENSOR AND HE HAS HAD SEVERAL GM VEHICLE THAT HAVE HAD THE SAME PROBLEM. I FEEL LIKE THIS IS A SAFETY PROBLEM ESPECIALLY WHEN YOU ARE DISABLED AND HAVE PROBLEMS GETTING AROUND IN THE FIRST PLACE. *TR

THE BRAKE LINES ARE RUSTED THROUGH ALLOWING ALL OF THE BRAKE FLUID TO LEAK FROM THE VEHICLE RESULTING IN NO BRAKES. *TR

AMERITRAC GENERAL PURCHASED FROM WAL-MART 72653. TWO TRUCK TIRES P245/70R17 ON 2 DAYS WITH 7100 MILES HAD FAILURE ON LEFT SIDE TIRE AT CENTER.TIRE DESIGNEGRATED FROM CENTER;2ND TIRE TREAD STARTED TO FAIL AT TIME OF 1ST TIRE FAILURE. *TR WAL-MART TIRES 72653 @9:50AM CONFIRMED OTHER SIMILAR TIRE FAILURES. PLEASE CHECK THESE TIRES. [XXX] PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *CC

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT ENGAGED THE BRAKES AND THE ANTI-LOCK BRAKE SYSTEM ACTIVATED WITHOUT INTENT. THE CONTACT PLANNED TO TAKE THE VEHICLE TO A DEALER FOR DIAGNOSIS AND REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

TL* THE CONTACT OWNS A 2006 GMC SIERRA. THE CONTACT NOTICED THE RIGHT AND LEFT FRONT HUB ASSEMBLY WAS WORN. THE DEALER DID NOT OFFER ANY ASSISTANCE SINCE THE WARRANTY HAD EXPIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO INFORMED THE CONTACT THAT SHE WOULD NEED TO REPLACE THE ENTIRE HUB ASSEMBLY. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS 77,465. THE APPROXIMATE FAILURE MILEAGE WAS 77,365. UPDATED 9/19/11 *CN THE HUB ASSEMBLY WAS REPLACED THREE TIMES. UPDATED 12/08/11

2006 GMC SIERRA C1500. CONSUMER WRITES IN REGARDS TO RESISTOR AND CONNECTOR WIRING REPLACEMENT.*TGW

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. THE CONTACT WAS DRIVING 10 MPH WHEN THE ABS SYSTEM ACTIVATED ABNORMALLY AND CAUSED AN INCREASE IN STOPPING DISTANCE WHEN ATTEMPTING TO BRAKE. THE ABS WARNING LIGHT DID NOT ILLUMINATE TO WARN THE CONTACT OF THE FAILURE. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO ADVISED THAT THE BRAKE DRUMS WOULD NEED REPLACING DUE TO DEBRIS BUILD UP, WHICH WAS CAUSING THE ABS SYSTEM TO PROVIDE A FAULTY READING TO ACTIVATE. THE MANUFACTURER SUGGESTED TAKING THE VEHICLE TO A DEALER FOR DIAGNOSTIC TESTING. THE CONTACT BELIEVED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE FAILURE MILEAGE WAS 72,000.

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. THE CONTACT STATED THAT WHEN DEPRESSING THE BRAKE PEDAL, HE WOULD EXPERIENCE A VIBRATING OR POPPING FEELING. THE VEHICLE WAS TAKEN AND INSPECTED BY AN INDEPENDENT MECHANIC, WHO STATED THAT THE ANTI-LOCK BRAKING SYSTEM FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 75,000. UPDATED 8/30/11 *CN UPDATED 09/28/11

TL* THE CONTACT OWNS A 2006 GMC SIERRA 2500 HD. THE CONTACT WAS DRIVING APPROXIMATELY 50 MPH AND SMELLED BURNING COOLANT AND THE TEMPERATURE GAUGE BEGAN TO RAPIDLY INCREASE. THE CONTACT INSPECTED UNDER THE HOOD AND NOTICED THE ENGINE OVERHEATING WITH COMPLETE LOSS OF COOLANT. IMMEDIATELY, WATER WAS DISPENSED INTO THE RADIATOR RESERVOIR. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TWO DIFFERENT TIMES FOR THE SAME FAILURE. THE WATER PUMP WAS REPLACED TWICE. THE MANUFACTURER WAS NOTIFIED AND A COMPLAINT WAS FILED. THE APPROXIMATE FAILURE MILEAGE WAS 22,000.

EXCESSIVE RUST THAT IS ROTTING AWAY THE FRAME OF MY 2006 GMC SIERRA. CHUNKS OF RUSTED METAL ARE FALLING OFF ON MY GARAGE FLOOR AND GMC SAYS THIS IS NORMAL CORROSION NOT COVERED. SO MUCH FOR WELL MADE AMERICAN VEHICLES. *TR

TL * THE CONTACT OWNS A 2006 GMC SIERRA. THE CONTACT STATED THAT THE BRAKES MALFUNCTIONED WHILE ATTEMPTING TO STOP WITH THE ILLUMINATION OF THE CHECK BRAKE SYSTEM WARNING LIGHT. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE BRAKE LINE WAS LEAKING DUE TO CORROSION AND AS A RESULT, THE BRAKE LINES WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE AND CURRENT MILEAGE WAS 69,000.

NO EVENT JUST EVERY DAY DRIVING AND A TIRE A YEAR LEAKS FROM INNER LINING TO FORM A BUBBLE ON OUTSIDE OF TIRE WHICH BLOWS OUT. A TIRE A YEAR FOR THE LAST THREE YEARS. *TR

AT LOW SPEED THE ABS ACTIVATES CAUSING EXTENDED TRAVEL WHEN STOPPING, WHICH TURNS OUT TO BE VERY SCARY FOR DRIVER AND PEDESTRIANS IN CROSS WALKS.

MY HUSBAND AND I STOPPED AT LOWES TO PICK UP SOME ITEMS AND I DECIDED TO WAIT IN OUR 2006 GMC SIERRA. WE BOTH OPENED THE DOORS AT SAME TIME AND HE LOCKED THE VEHICLE TAKING THE KEYS WITH HIM. I STILL HAD MY DOOR OPEN AND WAS STANDING OUTSIDE THE VEHICLE FOR SEVERAL MINUTES THEN DECIDED TO GET BACK IN. WHEN THE DOOR SHUT IT WAS LOCKED AND I WAS UNABLE TO UNLOCK ANY OF THE DOORS WITH THE OUTSIDE TEMP BEING 96 DEGREES IT DIDN'T TAKE LONG BEFORE THE INSIDE OF VEHICLE HEATED UP WITH ME IN THERE FANNING MYSELF TO KEEP COOL. HAD HE NOT COME OUT OF THE STORE WITHIN 5 MINUTES (HIS CELL PHONE WAS IN THE VEHICLE) OF MY GETTING LOCKED INSIDE I WOULD HAVE USED THE HORN TO GET SOMEONE'S ATTENTION. THERE IS NOTHING THAT WE COULD FIND IN THE MANUAL THAT ADDRESSES BEING LOCKED INSIDE. I'M 62 YEARS OLD AND I DOUBT ANYONE WOULD THINK TO CHECK ON ANYONE OTHER THAN A CHILD LEFT ALONE IN A VEHICLE. *TR

TL* THE CONTACT OWNS A 2006 GMC SIERRA DENALI. THE CONTACT STATED THAT THE CHECK ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL WHILE DRIVING APPROXIMATELY 45 MPH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE CONTACT WAS INFORMED THAT THE FUEL SYSTEM NEEDED TO BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 06E043000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 52,000 AND THE CURRENT MILEAGE WAS 77,000. THE VIN WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2006 GMC SIERRA 2500. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT HEARD A POPPING SOUND WHILE TURNING THE STEERING WHEEL. IN ADDITION, THERE WAS AN ABNORMAL GRINDING SOUND WHILE THE VEHICLE WAS IN MOTION. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE FRONT DRIVER SIDE HUB WAS REPLACED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 83,000.

TL*THE CONTACT OWNS A 2006 GMC SIERRA. THE CONTACT STATED THE FUEL GAUGE MALFUNCTIONED AND HE WAS UNABLE TO READ THE AMOUNT OF FUEL THAT WAS IN THE VEHICLE. THE DEALER STATED THAT THE READER INSIDE THE FUEL TANK NEEDED TO BE REPLACED. THE CONTACT DID NOT REPLACE THE READER ALTHOUGH THE VEHICLE COULD SHUT OFF WHEN THE FUEL TANK WAS EMPTY WITHOUT ANY WARNING. THE FAILURE MILEAGE WAS 110,000.

I HAVE A 2006 GMC SIERRA PICK-UP TRUCK WITH LESS THAN 20,000 MILE ON IT AND HAVE RUN OUT OF GAS TWICE WHEN THE GAS GAUGE READS MORE THAN A QUARTER TANK OF FUEL ON THE GAUGE. I JUST LISTENED TO A REPORT ON THE RADIO OF A POSSIBLE RECALL ON MANY GM VEHICLES WITH GAS GAUGE PROBLEMS JUST LIKE MINE. I WISH YOU WOULD LOOK INTO ADDING THE GM SIERRA PICK-UP TO THIS LIST FOR RECALL. *TR

RIGHT REAR TAIL LIGHT ASSEMBLY FELL OFF - FOR NO REASON. *TR

I HAVE A 2006 GMC SIERRA 2500 WITH THE LBZ DURAMAX AND ALLISON TRANSMISSION. TWO OF THE TRANSMISSION COOLANT LINES BEGAN LEAKING TRANSMISSION FLUID AT THE CRIMP ENDS IN DEC OF 2010. THE TRUCK ONLY HAD 30,000 MILES, BUT WAS THE 36 MONTH WARRANTY PERIOD. SERVICE UNDER WARRANTY WAS DENIED. AN ON-LINE SEARCH REVEALS SEVERAL OTHERS HAVE COMPLAINED ABOUT THIS ISSUE AND THAT THE DEALER INSTALLED OEM REPLACEMENT LINES ARE NO BETTER (DEVELOPING LEAKS SOON AFTER REPLACEMENT), YET NO TSB OR CORRECTIVE ACTION HAS BEEN ISSUED BY GM. LEAKING TRANSMISSION FLUID IS A FIRE AND ENVIRONMENTAL HAZARD. THE LEAKS ARE GETTING WORSE. *TR

2006 GMC 1500 SIERRA WITH 16,734 MILES, THE ABS SYSTEM ENGAGES AROUND 5 MPH AND WHEN THE TRUCK WILL ACTUALLY STOP IS ANY ONE'S GUESS. VERY DANGEROUS IN PARKING LOTS, AND AROUND PEDESTRIANS AS WELL AS NORMAL DRIVING. I SEE THERE ARE THOUSANDS OF SIMILAR COMPLAINTS ON THE WEB. PLEASE PUT MY TAX DOLLARS TO WORK AND DO SOMETHING. THANK YOU. *TR

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS OR SITTING IDLE IN PARK, THE FOUR WHEEL DRIVE SWITCH WOULD INTERMITTENTLY ACTIVATE AND INDEPENDENTLY SHIFT INTO LOW DRIVE. THE VEHICLE WAS INSPECTED BY A DEALER WHO INFORMED THE CONTACT THAT HE WOULD NEED TO REPLACE THE MODULE IN THE TRANSFER CASE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 36,000.

2006 SIERRA DENALI WITH JUST OVER 75,000 MILES. WITH 1/2 BLOCK WARNING AND ONLY TRAVELING AT A SPEED OF 20MPH, I WAS UNABLE TO COME TO A COMPLETE STOP. THE BRAKE PEDAL WAS ALL OF THE WAY TO THE FLOOR WHEN I RAN INTO A VAN IN THE INTERSECTION. I FELT VERY LITTLE RESISTANCE FROM THE PEDAL AND THE ABS DEFINITELY DID NOT GO OFF. THERE WAS NO SNOW OR ICE ON THE ROAD SURFACE. HOWEVER AFTER TOWING THE VEHICLE TO THE LOCAL DEALERSHIP, I WAS TOLD NOTHING WAS WRONG WITH THE TRUCK. TWO INDEPENDENT THIRD PARTIES HAVE SUGGESTED THIS COULD BE A MASTER CYLINDER ISSUE EVEN THOUGH GMC GAVE IT A CLEAN BILL OF HEALTH. *TR

TL*THE CONTACT OWNS A 2006 GMC SIERRA. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT NOTICED A BURNING ODOR. SHE THEN NOTICED THAT THE BLOWER MOTOR ON THE WIRING HARNESS MELTED, CAUSING THE VEHICLE TO SMOKE. THE CONTACT CALLED THE DEALER WHO OFFERED NO ASSISTANCE. THE CONTACT DID NOT INFORM THE MANUFACTURE. THE VEHICLE WAS NOT REPAIRED. THE CURRENT MILEAGE WAS APPROXIMATELY 68,000. THE FAILURE MILEAGE WAS APPROXIMATELY 67,800. THE VIN WAS UNAVAILABLE.

10 DAYS AFTER I GOT THIS TRUCK THE AC BLOWER STOPPED WORKING. I HAD TO PAY $60 TO GET IT FIXED. CONDENSATION FROM THE AC HAD FRIED THE WIRES. BUT I HAD TO PAY TO GET IT FIXED!!! NOT RIGHT!!!! NOW THE BLOWER AND AC WORKS BUT I HAVE NO HEAT! SO I TOOK IT BACK TO THE DEALER I BOUGHT IT FROM AND THEY WANTED ME TO PAY THEM $60 ~ $100 JUST TO TELL WHAT IS WRONG THEN I WOULD HAVE TO PAY MY DEDUCTIBLE OF $60!!!! WHAT THE [XXX]!!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

RUSTED BRAKE LINES. *TR

BLOWER MOTOR WIRING HARNESS WIRES MELTED AND STARTED SMOKING ON MY 2006 GMC SIERRA. *TR

REAR TAIL LIGHT ASSEMBLY (BOTH) CONNECTION TABS WHICH HOLD ASSEMBLY IN PLACE FAIL FOR NO REASON ALLOWING LIGHT ASSEMBLE TO FALL OUT. HAVE REPLACED THE REAR TAIL LIGHT ASSEMBLIES THREE TIMES. FIRST LIGHT ASSEMBLY FELL OUT AT 8 MONTHS AGE (APPROX 20,000 MILES), RETURNED TO DEALER THEY ADVISED ASSEMBLY MUST HAVE BEEN DAMAGED NO WARRANTY REPAIR. REPLACED BOTH WITH AFTER-MARKET ASSEMBLIES, 18 MONTHS LATER REAR LIGHT ASSEMBLY CONNECTION TABS FAILED. REPLACED WITH DEALER SUPPLIED PARTS (APPROX 75,000 MILES). NOW ABOUT 18 MONTHS LATER REAR LIGHT ASSEMBLY IS FAILING AGAIN (109,000 MILES). POSSIBLE CAUSE IS THAT PLASTIC TABS DO NOT SECURE LIGHT ASSEMBLE IN PLACE, ALLOWING NORMAL USE AND VIBRATION TO CAUSE CONNECTION TAB TO FAIL. *TR

2006 GMC SIERRA 1500. FRONT BRAKES LOCKED UP AT 17,000 MILES. NEEDED TO BE REPLACED AS THEY WERE RUSTED OUT. FRONT WHEEL ASSEMBLY RUSTED OUT AT 19600 MILES. NEEDED TO BE REPLACED AS FRONT WHEELS COULD COME OFF THE VEHICLE WHILE DRIVING. REAR BRAKES LOCKED UP AT 19000 MILES, NEEDED TO BE CLEANED AND LUBRICATED. THIS VEHICLE BECAME UNSAFE TO DRIVE AFTER ONLY 17000 MILES! TOTAL COST (WARRANTY EXPIRED) $1500. *TR

I OWN A 2006 GMC SIERRA. I PURCHASED THIS VEHICLE FROM A RELATIVE (70 YEAR OLD WOMAN) AND IT HAS 22,000 MILES ON IT. I HAVE JUST HAD A MECHANICAL ISSUE BEGIN. WHEN SLOWING THE VEHICLE TO APPROXIMATELY 5 MPH, THE VEHICLE ABS ACTIVATES AND THE TRUCK THRUSTS FORWARD. I WAS ADVISED BY A MECHANIC THAT THIS IS A FAILURE OF BOTH FRONT WHEEL HUB ASSEMBLIES. BECAUSE THIS VEHICLE HAS SO FEW MILES ON IT I BEGAN LOOKING ON LINE FOR RECALL INFORMATION. I AM SHOCK HOW MANY PEOPLE HAVE ALSO EXPERIENCED PROBLEMS AROUND 20,000 MILES, SOME RESULTING IN CRASHES. I ALSO LEARNED THAT THE COMPANY THAT MANUFACTURES THE HUB ASSEMBLIES HAS ISSUED A RECALL FOR THE PARTS UNLESS IT WAS INSTALLED BY THE FACTORY (GM). THIS ISN'T RIGHT AND SOMEONE WILL GET INJURED BADLY. GM SHOULD RECALL THE VEHICLE. *TR

WHEN STOPPING AT LOW SPEEDS, ABS KICKS IN. THEN BRAKES LOCK UP AND ABS DOES NOT WORK. *TR

ABS SYSTEM FAILURE, CLEAN SENSORS WORKS FOR A WHILE THEN WARNING LAMP LITE COMES BACK ON. *TR

INTERMEDIATE STEERING SHAFT. *TR

DRIVING INTERSTATE 95 LEFT FRONT WHEEL BEARING FAILURE CAUSING LOUD NOISE AND STEERING SHAKE. *TR

DRIVING INTERSTATE 95 RIGHT FRONT WHEEL BEARING FAILURE. *TR

TL*THE CONTACT OWNS A 2005 GMC SIERRA 1500. WHILE ATTEMPTING TO USE THE AIR CONDITIONER THE CONTACT NOTICED THAT NO AIR WOULD BLOW OUT OF THE VENTS. THE CONTACT EXAMINED THE VEHICLE AND STATED THAT THE RESISTOR FAILED. THE FAILURE WAS NOT DIAGNOSED AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 130000.

THE BLOWER MOTOR RESISTOR OVERHEATED AND MELTED THE WIRING HARNESS,ALMOST CAUSED A FIRE,BURNT MY FINGERS TRYING TO STOP IT FROM STARTING TO BURN,MY 7 YEAR OLD WAS WITH ME. *TR

TRANSMISSION COOLING LINES LEAKING. *TR

AT 5 MILE PER HOUR ABS COMES ON NO MATTER WHAT ROAD CONDITION IS..A RECALL WITH THE SAME PROBLEM HAS BEEN ISSUED FOR YEARS PRIOR. *TR

LOSS OF FAN - BLOWER MOTOR (HVAC) HIGH SPEED OPERATION FAILURE. WITH LOSS OF HIGH SPEED FAN, OTHER FAN SPEEDS (LOWER) OPERATION BECAME INTERMITTENT, WORKS AFTER JIGGLING BLOWER MOTOR WIRE BUNDLE AT CONNECTION POINT ON BLOWER MOTOR RESISTOR. VISUAL INSPECTION SHOWS MELTED WIRE HARNESS CONNECTOR AT BLOWER MOTOR RESISTOR, UNABLE TO SEPARATE (REMOVE) THE CONNECTOR. SEARCHED NHTSA ODI DATABASE AND FOUND THREE VERY RELATED DEFECT COMPLAINTS - INOP FAN, SMOKE AND MELTED WIRES, FAN LOSS. FAN FAILURE COULD LEAD TO FIRE FROM MELTED ELECTRICAL CONNECTIONS, LOSS OF VISIBILITY DUE TO WINDSHIELD ICING IN WINTER, FOGGING OVER WHEN DRIVING IN CHANGING WEATHER. WINDSHIELD DEFROSTER REQUIRES OPERATIVE FAN AND DEFROSTER IS A REQUIRED SAFETY ITEM. DEALER REPLACED BLOWER MOTOR ELECTRICAL CONNECTOR, WIRE HARNESS, AND FUSE, CHARGING PARTS TO WARRANTY AND ME FOR THE LABOR. THIS APPEARS TO BE A VERY COMMON DEFECT IN THIS PRODUCT LINE. THERE IS A TECHNICAL SERVICE BULLETIN FOR THE REPAIR INCLUDING REPLACEMENT OF THE CONNECTION WIRING TO INSURE ANY MELTED INSULATION IS REMOVED. THIS SHOULD BE A SAFETY RECALL. DEALER HAS OLD PARTS. *TR

ABS ACTIVATION AT LOW SPEEDS. NO DTSC CODES SET. *TR

TL*THE CONTACT OWNS A 2006 GMC SIERRA. WHILE DRIVING APPROXIMATELY 55 MPH, THE BRAKES WERE ENGAGED AND THE VEHICLE BEGAN TO SHAKE EXCESSIVELY. A RATTLING NOISE WAS HEARD IN THE FRONT END OF THE VEHICLE WHILE DRIVING OVER GRAVEL OR ROUGH ROAD SURFACES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR ROUTINE MAINTENANCE AND THE TECHNICIAN WAS UNABLE TO DUPLICATE OR DIAGNOSE THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING AND THE FRONT PASSENGER SIDE WHEEL HUB WAS REPLACED. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000.

2006 GMC SIERRA HD 2500 - 4X4 CREW CAB SLT - WHILE PARKED IN OUR DRIVEWAY AND WITH KEYS OUT OF THE IGNITION, THE AIR BAG DEPLOYED. WE CALLED THE DEALERSHIP FERGUSON PONTIAC GMC AND WE WERE TOLD THAT IT WAS NOT POSSIBLE AND OUT OF WARRANTY. WE HAD OUR MECHANIC TOW IT IN. THEY HOOKED UP THE COMPUTER TO SEE IF A SENSOR HAD TRIPPED THE AIR BAG AND THE RUG STARTED TO SMOKE. THEY REMOVED THE MELTED MAT TO THE RUG AND FOUND THE WIRING HARNESS WAS MELTED AWAY. BOTTOM SIDE OF THE RUG WAS BURNT. WE WENT TO GMC IN PERSON WITH PICTURES AND ASKED HOW THIS COULD HAPPENED AND WERE TOLD "IT CAN HAPPEN AT ANYTIME WITH SAND AND MOISTURE AROUND THE WIRING HARNESS". WE WERE TOLD THIS COULD HAVE ALSO HAPPENED WHILE DRIVING THE VEHICLE. WE WANT THIS TRUCK FIXED AND ASSURED THAT IT WILL NOT HAPPEN AGAIN. THIS COULD HAVE CAUSED A FOREST FIRE, A HORRIBLE ACCIDENT, AND OR DEATH. NO ONE SEEMS TO CARE. WE HAVE SEVERAL GMC VEHICLES AND ARE CONCERNED IF THE OTHER ONES WILL DO THE SAME. WE ARE NOT SATISFIED WITH THEIR COMPLETE DISREGARD FOR OUR SAFETY AND DID NOT WANT TO EVEN LOOK AT IT. WE HAVE PICTURES IF YOU WOULD LIKE US TO EMAIL THEM TO YOU. THIS IS OUT OF THE NORMAL REALM OF "WARRANTY" AND BELIEVE IT IS GM'S RESPONIBILITY TO FIX THIS AND MAKE SURE IT DOESN'T HAPPEN AGAIN. ALSO THE PUBLIC NEEDS TO KNOW THAT THIS "CAN HAPPEN AT ANYTIME". THIS WAS QUOTED FROM [XXX]THE SERVICE MANAGER AT FERGUSON PONITAC GMC. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL*THE CONTACT OWNS A 2006 GMC 2500. WHILE DRIVING IN REVERSE, THE CONTACT HEARD A GRINDING NOISE FROM THE FRONT BRAKE AREA. WHEN THE CONTACT INSPECTED THE VEHICLE, HE NOTICED THAT THE BOLTS THAT HELD THE CALIPERS IN PLACE HAD SHEARED OFF ON BOTH FRONT WHEELS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP TO BE INSPECTED. THE CURRENT AND FAILURE MILEAGES WERE 86,762.

TL* THE CONTACT OWNS A 2006 GMC SIERRA 1500. THE CONTACT STATED WHEN BRAKING OR DRIVING AT RELATIVELY LOW SPEEDS OF AT LEAST 5 MPH, THE ANTI-LOCK BRAKES WOULD ENGAGE AND THE CONTACT WOULD HAVE TO ABRUPT BRAKING PRESSURE TO STOP THE VEHICLE. THE DEALER ADVISED THE VEHICLE WAS NOT UNDER RECALL AND DID NOT PROVIDE ANY FURTHER ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 28,663.

TL*THE CONTACT OWNS A 2006 GMC 2500 CARGO VAN. WHILE THE VEHICLE WAS PARKED, THE CONTACT WAS UNABLE TO OPEN THE REAR PASSENGER CARGO DOOR. THE HINGE WAS BENT AND MISALIGNED; THE BOTTOM PINS WERE ALSO RUSTED. THE VEHICLE HAD NOT BEEN INSPECTED OR REPAIRED AT THE TIME OF THE COMPLAINT. THE CONTACT CALLED THE MANUFACTURER WHO REFERRED HIM TO THE DEALERSHIP TO HAVE THE VEHICLE REPAIRED AT HIS EXPENSE; THEY STATED THAT THEY WOULD DECIDE IF THEY WOULD ASSIST IN THE EXPENSES. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000. THE CURRENT MILEAGE WAS APPROXIMATELY 43,000.

TRUCK IS A 2006 GMC WITH 60,200 (APROX) MILES ON IT. VEHICLE BLEW A BRAKE LINE GOING DOWN A STEEP HILL. *TR

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

A/C & HEATER FAN CONTROL AND PASSENGER AIR BAG RESISTER/CONNECTOR FOUND UNDER THE PASSENGER DASH, POSSIBLE FIRE AND SAFETY ISSUES IF VEHICLE IS PARKED IN A GARAGE. *TR

2006 GMC DIESEL WITH ALLISON TRANSMISSION...LINES TO TRANSMISSION COOLER LEAKING. IT IS A FIRE HAZARD...FROM WHAT I READ ON THE INTERNET IT HAS BEEN A PROBLEM WITH ALL THE TRANSMISSION LINES INSTALLED ON THIS TRUCK

ON MARCH 8,2010 I TOOK MY CAR THAT I BOUGHT 2 YEARS AGO TO AN OFFICIAL EMISSIONS INSPECTION STATION; THE VEHICLE FAILED. AT THIS TIME I WAS GIVEN A SET OF RECALL PAPERS 09014 SPECIAL COVERAGE ADJUSTMENT ENGINE CONTROL MODULE- EMISSION RELATED REPROGRAMMING THAT EXPLAINED WHAT THE PROBLEM WAS. IN THE MEAN TIME I TOOK THE CAR TO GM . THEY TOLD ME IT WOULD COST $125 TO DIAGNOSE THE PROBLEM BY THE TIME THEY WERE DONE I HAD A BILL FOR $280 AND TOLD IT WOULD COST OVER $1000TO FIX THE CAR SO THAT COULD PASS (THEY NEED TO REPLACE THE STEERING COLUMN TO RECEIVE COMMUNICATION I SEE THERE IS A RECALL ON THAT) I WANT TO STATE THAT I SHOWED THE WORKERS AT GM THE PAPERS SHOWING WHAT THE PROBLEM WAS BUT I WAS TOLD THAT WAS NOT THE PROBLEM AND THEY THEN TOLD ME IF I WANT IT FIXED I WOULD HAVE TO PAY FOR IT.THIS OCCURRED AFTER I SIGNED A PAPER ALLOWING THEM TO "LOOK" AT THE CAR . I NEED SOMEONE IN AUTHORITY TO HELP ME FIND OUT THIS PROBLEM SHOULD HAVE BEEN TAKEN CARE OF BY GM AND WHETHER OR NOT THE ACTION OF GM WAS FRAUDULENT. THANK YOU TOOK THE VEHICLE INSPECTION TO THE STATE OF CONNECTICUT ON 3/19/2010 AND IT PASS INSPECTION. *TR

2006 GMC SIERRA 1500 PICKUP TRUCK. FRONT WHEEL BEARING ASSEMBLY ON BOTH DRIVER AND PASSENGER SIDE FAILURE. THE WHEEL BEARING HUB ASSEMBLY FAILURE CAUSES THE VEHICLE TO LOOSE DRIVING ABILITY WHILE DRIVING. THE WHEELS WILL START SHAKING CAUSING OPERATING THE VEHICLE IMPOSSIBLE. GMC HAS A PROBLEM WITH FRONT WHEEL BEARING ASSEMBLIES ON THEIR PICKUP TRUCKS. REPLACED HUB ASSEMBLY WITH NEW PARTS BY A GM CERTIFIED MECHANIC. GM MECHANIC STATED THAT THEY HAVE REPLACED MANY GMC AND CHEVY HUB ASSEMBLIES ON TRUCKS DUE TO PART FAILURE. *TR

VERY DIFFICULT, IF NOT IMPOSSIBLE, TO TURN STEERING AT IDLE. DURATION OF PROBLEM APPROX. 1 YEAR. JUNE 2009 DEALER REPLACED PART IN STEERING. DEALER COLD NOT FIND A PROBLEM IN STEERING, BUT REPLACED A PART. PROBLEM CONTINUES; VERY DIFFICULT TO TURN AT IDLE OR LOW SPEED. I DO NOT FEEL IT IS SAFE. *TR

WHILE TOWING MY CAMPING TRAILER ON THE INTERSTATE I PULLED INTO A REST STOP. THEN I NOTICED THE RIGHT REAR TIRE WAS FLAT. LATER AT A GARAGE THE SERVICEMAN FOUND THE VALVE STEM HAD SPLIT. THIS WAS A SNAP-IN RUBBER STEM. I BELIEVE THE TIRES ON A TRUCK OF THIS SIZE (GMC 2500HD) AND WITH THIS AIR PRESSURE (80 PSI REAR, 55 FRONT) SHOULD HAVE STEEL CLAMP-IN TYPE STEMS. *TR

TRUCK WAS PARKED IN GARAGE ON A FRIDAY NIGHT, WITH NO PROBLEMS. STARTED TRUCK SATURDAY AM TO BACK OUT OF THE GARAGE TO HOOK UP A TRAILER. I PUT THE TRUCK IN REVERSE, THEN DISCOVERED IT WOULDN'T STEER AND IT WOULDN'T STOP. NEARLY TOOK OUT THE SIDE OF THE GARAGE DOOR WITH THE MIRROR, NOT TO MENTION, NEARLY RUNNING OVER ONE OF MY KIDS! I HAD TO ENGAGE THE EMERGENCY BRAKE IN ORDER TO GET THE VEHICLE TO STOP - HALF IN AND HALF OUT OF THE GARAGE. I SHUT THE TRUCK OFF AND RESTARTED IT, BUT NOTHING CHANGED. CALLED A FLATBED TRUCK TO TAKE THE TRUCK TO THE DEALERSHIP. POWER STEERING PUMP HAD FAILED AND THEY REPLACED IT. I'M VERY LUCKY THAT I WASN'T PULLING THE TRAILER WHEN THIS HAPPENED, AS I COULD HAVE BEEN KILLED, OR KILLED SOMEONE ELSE. VERY SCARY SITUATION. THERE HAD BEEN NO TROUBLE WITH THE BRAKES OR STEERING LEADING UP TO THIS INCIDENT - IT WAS JUST BOOM - IT HAPPENED. I PURCHASED THIS DIESEL TRUCK NEW, AND HAVE HAD THE DEALERSHIP DO ALL SCHEDULED MAINTENANCE. IT HAS NEVER BEEN INVOLVED IN ANY ACCIDENT, AND IT IS KEPT INSIDE A GARAGE WHEN NOT IN USE. *TR

TL*THE CONTACT OWNS A 2006 GMC SIERRA. WHILE DRIVING APPROXIMATELY 35 MPH AND DEPRESSING THE BRAKES, THE ANTI-LOCK BRAKING SYSTEM ENGAGED AND MOMENTARILY FAILED TO STOP THE VEHICLE. THERE WAS ALSO A MOANING SOUND IN THE VEHICLE WHICH AND INCREASED THE STOPPING DISTANCE. THE WEATHER WAS NOT A FACTOR. THE DEALER ADVISED HAVING THE WHEEL SPEED SENSORS REPLACED ON THE VEHICLE TO CORRECT THE FAILURE. THERE WERE NO REPAIRS MADE TO THE VEHICLE OR RELATED RECALLS. THE FAILURE AND CURRENT MILEAGES WERE UNDER 40,320.

TL*THE CONTACT OWNS A 2006 GMC SIERRA. THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH ON NORMAL ROAD CONDITIONS WITH THE BRAKE PEDAL ENGAGED WHICH WAS FOLLOWED BY AN ACTIVATION OF THE ANTI-LOCK BRAKE SYSTEM. THE FAILURE OCCURRED INTERMITTENTLY. AN AUTHORIZED DEALER WAS NOTIFIED OF THE MALFUNCTION. THE FAILURE MILEAGE WAS 18,000. UPDATED 3/8/10 *CN UPDATED 05/10/10*JB

TL* THE CONTACT OWNS A 2006 GMC SIERRA 3500. WHILE EXAMINING THE VEHICLE HE NOTICED FLUID LEAKING FROM UNDER THE FRONT PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND HE WAS ADVISED THAT THE TRANSMISSION COOLING LINES NEEDED TO BE REPLACED. THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 44000.

I HAVE A 2006 GMC SIERRA 2500 WITH THE LBZ DURAMAX AND ALLISON TRANSMISSION. TWO OF THE TRANSMISSION COOLANT LINES BEGAN LEAKING TRANSMISSION FLUID AT THE CRIMP ENDS IN MARCH OF 2009. THE TRUCK ONLY HAD 32,000 MILES, BUT WAS 3 MONTHS BEYOND THE 36 MONTH WARRANTY PERIOD. SERVICE UNDER WARRANTY WAS DENIED. AN ON-LINE SEARCH REVEALS SEVERAL OTHERS HAVE COMPLAINED ABOUT THIS ISSUE AND THAT THE DEALER INSTALLED OEM REPLACEMENT LINES ARE NO BETTER (DEVELOPING LEAKS SOON AFTER REPLACEMENT), YET NO TSB OR CORRECTIVE ACTION HAS BEEN ISSUED BY GM. LEAKING TRANSMISSION FLUID IS A FIRE AND ENVIRONMENTAL HAZARD. THE LEAKS ARE GETTING WORSE. *TR

MY SON WAS DRIVING HIS 2006 GMC SIERRA PICKUP, WHEN THE ABS WARNING LIGHT ILLUMINATED,FOLLOWED BY THE TRUCK WANTING TO STEER TO THE RIGHT. HE INVESTIGATED AND FOUND THAT THE RIGHT FRONT WHEEL WAS TILTED INBOARD AND DECIDED TO HAVE THE TRUCK TOWED HOME. TODAY WE REMOVED THE WHEEL, AND FOUND A TOTAL FAILURE OF THE WHEEL HUB ASSEMBLY. THIS IS A SEALED UNIT THAT CONTAINS THE WHEEL BEARINGS, AND HAS THE WHEEL STUDS MOUNTED TO IT ALSO. APPARENTLY THIS IS NOT AN ITEM THAT CAN BE SERVICED IN THE FIELD, SUCH AS REPACKING OF THE BEARINGS. BOTH WHEEL BEARINGS WERE COMPLETELY DESTROYED, AND THE ONLY THING HOLDING THE WHEEL ON WAS THE BRAKE CALIPER. WE INSTALLED A NEW HUB ASSEMBLY AND BRAKE DISC TO CORRECT THE PROBLEM. OLD PARTS ARE AVAILABLE. *TR

UNDER NORMAL DRIVING CONDITIONS WITHOUT CAUSE THE FUEL FILTER WATER-IN-GAS SENSOR BLEED VALVE LEAKS FUEL. THIS CAUSES FUEL TO LEAK INTO THE ENGINE COMPARTMENT. SYMPTOMS INCLUDE FUEL ON THE GROUND, FUEL ODOR, HARD/LONGER ENGINE CRANKING. THERE ARE OTHER REPORTS OF THIS PROBLEM AT : HTTP://WWW.DIESELPLACE.COM/FORUM/SHOWTHREAD.PHP?P=3452490 ALSO HTTP://WWW.GOOGLE.COM/SEARCH?HL=EN&RLS=COM.MICROSOFT:*&Q=DURAMAX+FUEL+FILTER+LEAKING+WATER+SENSOR&START=10&SA=N. *TR

WE WERE ON VACATION IN ALABAMA AND OUR 2006 GMC SIERRA TRUCK WITH 62,000 MILES ON IT. WHEN THE TRANSMISSION STARTED TO SLIP WE PULLED OVER AND CHECK THE TRANSMISSION FLUID, IT WAS FINE. SO WE CONTINUED ON UNTIL WE GOT TO THE NEXT TOWN. TILLSMAN CORNER. WE WENT TO A TRANSMISSION SHOP AND THEY SAID THAT THE TRANSMISSION COMPLETELY BURNT UP. WE CALLED GMC AND THEY SAID THAT THE WARRANTY ON THE DRIVE TRAIN WAS ONLY 36,000 MILES. WHEN WE BROUGHT THE VEHICLE THEY WERE TELLING US IT WAS 7 YEARS, 70,000 MILES ON THE DRIVE TRAIN. *TR

IMPROPER ABS ACTIVATION A LOW SPEED. OCCURS IN THE LAST FEW MPH OF DECELERATION AT A STOP SIGN OR RED LIGHT. ALSO OCCURS WHEN COMING TO A STOP DURING PARKING, WORSE WHEN TURNING. PAVEMENT IS DRY. NO ABS ACTIVATION AT SPEEDS ABOVE 5 MPH. PEDAL VIBRATES LIGHTLY AND BECOMES SOFTER UNTIL COMPLETE STOP IS ATTAINED. VERY CONCERNED THAT BRAKING DISTANCE IS COMPROMISED AND MIGHT IMPACT VEHICLE IN FRONT OR STOP WITHIN INTERSECTION. *TR

PURCHASED 2006 GMC SIERRA 1500 NEW IN APRIL 2006 WITH 208 MSL SHOWING ON ODOMETER. AT 10,000 MILES STARTED GETTING VIBRATION WHEN APPLYING BRAKES. TOOK VEHICLE INTO DEALER ROTORS WERE TURNED, VIBRATION GONE. AT ABOUT 18,000 MILES VIBRATION RETURNED. TOOK VEHICLE BACK TO DEALER, ROTORS TURNED AGAIN AND TIRES BALANCED AND ROTATED. AGAIN SMOOTH BRAKING. AT 32,000 MLS VIBRATION RETURNED AGAIN. TOOK BACK TO DEALER, THIS TIME THEY REPLACED FRONT BRAKE ROTORS WITH NEW NEW ONES. BRAKES SMOOTH AGAIN. I NOW HAVE 44.500 MILES AND THE VIBRATION IS BACK AGAIN AS BAD AS EVER. VEHICLE IS NOW OUT OF WARRANTY. DEALER WILL NOT DO ANYTHING UNLESS I PAY. THESE ARE HIGHWAY MILES. I AM NOT RIDING THE BRAKES GETTING THEM HOT. $30,000 FOR A PICK UP TRUCK AND GM CAN"T OR WON"T FIX THE PROBLEM. I WILL NEVER BY ANOTHER GM PRODUCT!!! *TR

PURCHASED A NEW GMC TRUCK VALUED AT $40,000 AT 38,000 MILES THE DRIVERS SIDE FRONT WHEEL BEARING FAILED AND AT 48,000 MILES PASSENGER SIDE FRONT WHEEL BEARING FAILED. SEEMS TO BE THAT DEFECTIVE PARTS ARE BEING INSTALLED ON TRUCKS AT ASSEMBLY. WHEN PASSENGER SIDE FAILED ALSO RUINED BRAKE ROTOR. AFTER RESEARCHING ON THE INTERNET IT SEEMS TO BE A ONGOING PROBLEM WITH THESE GM TRUCKS. *TR

TL*THE CONTACT OWNS A 2006 GMC SIERRA 2500. THE FLY WHEEL, WHICH RUNS WITH THE TRANSMISSION AND HELPS CHANGE GEARS HAS HAD TO BE REPLACED THREE TIMES WITHIN TWO YEARS. WHILE DRIVING APPROXIMATELY 10 MPH DURING THE FIRST FAILURE, THERE WAS A LOUD CLICKING NOISE AND IT BECAME LOUDER OVER TIME. THE DEALER STATED THE VEHICLE WAS OPERATING NORMALLY. A FEW WEEKS LATER, THE NOISE WAS MUCH LOUDER; HOWEVER, A DIFFERENT DEALER 2 HOURS AWAY DIAGNOSED THE VEHICLE AND STATED THAT THE FLY WHEEL FAILED. AFTER BEING REPAIRED 24,000 MILES AND A YEAR LATER, THE FAILURE RECURRED. THE FLY WHEEL WAS REPLACED AGAIN AND LASTED 5 MONTHS BEFORE IT FAILED. THE POWER STEERING SHAFT ALSO NEEDED TO BE REPLACED DUE TO IT BEING WORN OUT AND FAILED AGAIN NINE MONTHS LATER. THE FAILURE MILEAGE WAS 22,800 AND THE CURRENT MILEAGE WAS 55,000. UPDATED 06/08/09 *BF THE POWER STEERING GEAR WAS LEAKING DUE TO LEAKING GEAR ASSEMBLY, THE HVAC BLOWER WAS INOPERATIVE, THE FLYWHEEL WAS CRACKED. THE DEALER REPLACED THE STRIPPED AND BROKEN EXHAUST STUDS. UPDATED 06/18/09.*JB

2006 GMC SIERRA BRAKE ISSUES. ROTORS HAVE BEEN TURNED 6 PLUS TIMES IN 90K MILES. BRAKES SQUEAK, PULSATE, AND VIBRATE CONTINUOUSLY. DEALER HAS CHECKED MULTIPLE TIMES AND ADVISED THAT I JUST NEED MY ROTORS TURNED. *TR

TL*THE CONTACT OWNS A 2006 GMC SIERRA 1500. WHILE THE VEHICLE WAS PARKED ON A NON-LEVELED SURFACE, IT ROLLED BACKWARDS INTO A RIVER. A POLICE REPORT WAS FILED. AFTER INSPECTION, THE CONTACT CONCLUDED THAT THE TRANSMISSION DID NOT ENGAGE ITSELF INTO PARK, WHICH ALLOWED THE VEHICLE TO SHIFT INTO REVERSE. HE IS IN THE PROCESS OF NOTIFYING THE DEALER AND THE MANUFACTURER. THE FAILURE AND CURRENT MILEAGES WERE 54,000. UPDATED 5/7/09 *CN UPDATED 05/12/09.*JB

NEW LOOKING SNOW TIRE, TREAD SEPARATED FROM TIRE. APPROX. 62 MPH DOING DAMAGE TO TRUCK WHEEL WELL. TIRE DID NOT GO FLAT. CHECK OTHER THREE MATCHING TIRES , ALL LOOKED OK. CONTINUED ON TRIP, PARKED FOR THE NIGHT. APPROX. 70 MORE MILES INTO TRIP OTHER REAR TIRE SEPARATED AND WENT FLAT, CAUSING DAMAGE TO OTHER SIDE OF PICKUP WHEEL WELL. CALLED AAA TOW TO TIRE STORE FOR A NEW SET OF FOUR. PICKUP IS AN GMC 2500 HD, 2006. BETWEEN THE TWO SEPARATIONS APPROX. 6500.00 DOLLARS DAMAGE. *TR

I ATTEMPTED TO PREVIOUSLY MAKE SEVERAL REPAIRS TO THE VEHICLE. THE FIRST OF THE PROBLEMS OCCURRED WHEN DRIVING. THE SUSPENSION MADE LOUD GRINDING NOISES AND AFTER 3 ATTEMPTS MADE IT WAS REPAIRED. NOW THE PROBLEM SEEMS TO HAVE RETURNED AND I AM NOT SURE WHAT I SHOULD DO. *TR

HEATER AND A/C BLOWER MALFUNCTION. WIRES AND CONNECTORS WERE HOT TO THE TOUCH AND AFTER A CLOSER LOOK WIRES PROTECTIVE WIRE COVER WERE EXPOSED AND CONNECTORS WERE MELTED THROUGH. THERE WAS ALSO SMOKE IN THE CAB. *TR

I WAS DRIVING DOWN THE ROAD GOING 35 MILES AN HOUR AND NOTICED A LOUD GRINDING NOISE THEN MY ABS LIGHT CAME ON. MY STEERING WAS MUCH LESS RESPONSIVE. I HIT A BUMP IN THE ROAD AND MY TRUCK RAN INTO A FENCE. I HAD TO CHANGE THE WHEEL BEARINGS TO CORRECT THE PROBLEM. *TR

2006 GMC SIERRA WITH A FRONT WHEEL BEARING BURN OUT. CONSUMER STATES THAT THE WHEEL BEARING BURN OUT WAS PRIOR TO THE TIRE WEARING OUT. GM DECIDED TO SEAL THE BEARING TO PROLONG THE LIFE. *KB THE CONSUMER STATED THE FAILURE OCCURRED WHILE DRIVING 70 MPH. ONCE HE WAS ABLE TO STOP THE VEHICLE, THE CONSUMER DISCOVERED THE BRAKE LINE HAD BROKEN AND A FIRE HAD IGNITED UNDER THE VEHICLE. THE AXLE AND ALL THE BRAKE COMPONENTS HAD TO BE REPLACED. *JB

I AM THE SHOP FOREMAN FOR A CONSTRUCTION COMPANY IN ALASKA. I DROPPED OFF A 2006 GMC 2500 PICKUP LAST WEEK TO THE DEALER TO HAVE A LEAK LOOKED AT. I GOT A CALL BACK FROM THEM SAYING MY TORQUE CONVERTER WAS BLOWN. THEY SAID GMC IS HAVING PROBLEMS WITH THE ALLISON TRANSMISSION AT COLD TEMPS (CAMPAIGN # 07293) I HAD THIS TRUCK IN AT 25000 MILES TO BE RE-PROGRAMMED AND AGAIN AT 49000 MILES. NOW, AT 58,000 MILES THE TORQUE CONVERTER IS BLOWN AND AFTER ARGUING WITH GMC, THEY WILL NOT WARRANTY THE WORK, THEY WANT ME TO PAY HALF OF THE 3200. I DROVE UP IN OUT COMPANY'S BRAND NEW '08 GMC 3500, HAD THE DEALERS MECHANIC LOOK AT IT. HE SNIFFED THE TRANNY DIPSTICK, GRIMMANCED, AND SAID THAT IT TOO WAS BLOWN. AT 4120 MILES, ANOTHER BLOWN TORQUE CONVERTER. THE SERVICE MANAGER SAID 17 TRUCKS SO FAR IN FAIRBANKS ALASKA HAVE SUFFERED SIMILAR FATES, DUE TO THIS MANUFACTURER ERROR. I AM LIVID, TO SAY THE LEAST! GMC NEEDS TO BE HELD ACCOUNTABLE FOR THIS, AND OWNERS NEED TO BE CONTACTED AND TOLD THAT THERE IS A PROBLEM! THERE IS A SAFETY ANGLE AS WELL, ACCORDING TO THE MECHANIC--AT A STOP LIGHT, THE TORQUE CONVERTER WENT OUT, LOCKED UP, AND PUSHED THE VEHICLE THROUGH THE LIGHT! *TR

TL*THE CONTACT OWNS A 2006 GMC SIERRA 1500. WHILE DRIVING APPROXIMATELY 45 MPH ON NORMAL ROAD CONDITIONS, THE CONTACT HEARD AN EXCESSIVELY LOUD GRINDING NOISE COMING FROM THE OUTSIDE OF THE VEHICLE. THE NOISE WAS INTERMITTENT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION AND THEY REPLACED THE FRONT WHEEL BEARINGS AND HUBS UNDER WARRANTY. THE VEHICLE WAS TAKEN TO THE AUTHORIZED DEALER ON TWO SEPARATE OCCASIONS FOR IDENTICAL FAILURES, BUT THERE WERE NO RESOLUTIONS. THE TECHNICIAN STATED THAT THE LOUD NOISE WAS NORMAL. THE CONTACT WAS UNAWARE IF HIS VIN WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07E106000 (WHEELS:CAP/COVER/HUB). CURRENTLY, THE VEHICLE IS AT THE DEALER FOR REPAIR. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS UNAVAILABLE AND THE CURRENT MILEAGE WAS 67,000.

TL*THE CONTACT OWNS A 2006 GMC SIERRA 1500. THE CONTACT STATED THAT THE MASTER CYLINDER FAILED ON HIS VEHICLE. WHILE DRIVING AT AN UNKNOWN SPEED, THE BRAKE PEDAL EXTENDED TO THE FLOOR AND THE VEHICLE FAILED TO STOP. THE CONTACT REAR ENDED ANOTHER VEHICLE. THERE WERE NO INJURIES. THE FRONT END, HOOD, AND GRILL WERE DAMAGED. THE VEHICLE WAS TOWED FROM THE SCENE AND RETURNED TO THE SHOP IT WAS REPAIRED AT THREE MONTHS PRIOR TO THE CRASH. THE TECHNICIAN STATED THAT THE MASTER CYLINDER WAS THE CAUSE OF THE FAILURE. THE CONTACT HAS CALLED DIFFERENT GMC DEALERS AND REPAIR SHOPS TO PURCHASE A MASTER CYLINDER, BUT THERE ARE NONE IN STOCK. IT WOULD TAKE A WEEK FOR THE PART TO ARRIVE SO THAT THE REPAIR CAN BE COMPLETED. THE FAILURE MILEAGE WAS 50,000.

TL*THE CONTACT OWNS A 2006 GMC SIERRA 1500. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT HEARD A SQUEAKING NOISE COMING FROM THE FRONT END OF THE VEHICLE. THE BLOWER MOTOR STOPPED WORKING. THE VEHICLE WAS DRIVEN TO THE DEALER AND THEY STATED THAT THE RESISTOR FOR THE FAN MOTOR OVERHEATED AND FUSED WITH THE WIRING HARNESS. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 6,422 AND FAILURE MILEAGE WAS 6,000.

I OWN A 2006 GMC 2500HD DURAMAX/ALLISON CREW CAB. I TOOK OWNERSHIP IN FEB OF 2007 WITH 32K MILES. TRANSMISSION LINES WERE LEAKING AT THAT TIME. DEALER REPLACED THE LINES UNDER WARRANTY. NOW AT 100K MILES AND SAME "NEW" LINES ARE LEAKING ONCE AGAIN. THIS IS A FLAMMABLE FLUID AND CONSTITUTES A POTENTIAL FIRE HAZARD. *TR

TL*THE CONTACT OWNS A 2006 GMC SIERRA 2500. THE CONTACT HAS A MANUAL TRANSMISSION VEHICLE WITH THE WRONG HYDRAULIC FLUID IN THE CLUTCH SYSTEM. THIS COULD CAUSE THE CLUTCH TO FAIL WITHOUT WARNING. WHEN THE CONTACT DEPRESSES THE CLUTCH PEDAL, IT DOES NOT ENGAGE THE TRANSMISSION AND STOP THE VEHICLE. THE FAILURE OCCURS INTERMITTENTLY. THE CLUTCH AND ALL THE HYDRAULIC PARTS WERE REPLACED MORE THAN ONCE, BUT THE FAILURE PERSISTS. HE CALLED GMC AND WAS INFORMED THAT ALL THE VEHICLES WERE MADE WITH THE INCORRECT FLUID. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 40,000.

GENERAL AMERITRAC TIRES ON A 2006 GMC SIERRA CREW CAB 2WD ARE SHOWING EXCESSIVE WEAR AND TREAD LOSS. THE TIRES HAVE ONLY 24000 MILES AND NEED TO BE REPLACED. DURING A RECENT RAINSTORM I WAS HYDROPLANING ON THE FREEWAY. THE TIRES HAVE HARDLY ANY TREAD LEFT ON THE OUTSIDE OF THE FRONT TIRES. THE TIRES WILL BE REPLACED IN THE VERY NEAR FUTURE. *TR

THIS COMPLAINT IS ABOUT AN ELECTRICAL SHORT IN THE WIRING AND PLUG GOING TO THE FAN MOTOR ON THE INSIDE CAB OF MY 2006 GMC TRUCK. THIS TRUCK HAS 43000 MILES ON IT AND CARRIED IT IN TO BE FIXED AND WAS TOLD NOTHING COULD BE DONE BECAUSE IT WAS OUT OF WARRANTY. I'M VERY DISAPPOINTED BECAUSE I FEEL THAT THIS IS A HAZARD. THIS PLUG HAS BEEN GOING BAD FOR SOME TIME NOW BECAUSE I COULD SMELL THE ODOR IN THE TRUCK BUT COULD NOT PINPOINT WHERE IT WAS COMING FROM. AFTER THE FAN MOTOR STOPPED WORKING I TRACED THE PROBLEM DOWN TO THE PLUG AND FOUND WHERE IT HAD BEEN MELTING AWAY. THIS IS WHEN I DROVE IT BACK TO THE DEALERSHIP AND WAS TOLD NOTHING COULD BE DONE BECAUSE IT WAS OUT OF WARRANTY. I FEEL THIS SHOULD BE A DEFECT AND NOT SOMETHING THAT SHOULD BE A WARRANTY ISSUE. THIS PLUG GOT VERY HOT FOR A LONG PERIOD OF TIME AND MELTED IT COULD HAVE STARTED A FIRE. *TR

DOWN HILL AT 80MPH BRAKES ON MY 2006 GMC 1500 CAUSED MY STEERING WHEEL TO SHAKE SO HARD MY HEART WAS IN MY PANTS. 18K MILES ON MY TRUCK AND HAD TO HAVE MY ROTORS TURNED AND SHOES ADJUSTED IN REAR DRUMS. SIGN OF GLOBAL MARKET. LOW BIDDER GETS THE JOB TO MFG ALL PARTS AND YOU GUYS AT NHTSA GET A PAY X TWICE A MONTH. NHTSA HAS TWO OTHER STORIES RE BAD BRAKES ON 2006 GMC 1500. NO ACTION UNTIL SOMEONE GET HURT IS THE WORD OF THE DAY. PS: I DON'T DRIVE AT 80MPH BUT GET FAST ON CA ROUTE 15 OR GET RUN OVER BY CAR/BIG RIGS SO YOU SHOULD AT ALL TIMES HAVE PERFECT BRAKES AND WORRY ABOUT THE OTHER SMALL STUFF.PLS CALL GM AND TELL THEM MY LIFE IS IN THEIR HANDS AND IN THE COMING YEARS NO MORE GM PRODUCTS FOR ME IF THEY CAN'T MFG A BRAKE SYSTEM THAT CAN GO MORE THEN 18K. NAVY AIRCRAFT I LANDED HAD BRAKE ROTORS THAT WOULD TURN RED FROM HEAT BUT DID NOT NEED A CHANGE OUT AFTER 200 LANDINGS. X IT OUT NHTSA THE NEXT PERSON YOU SAVE MAYBE YOUR SON OR HIS FRIEND. *TR

BRAKES MAKING NOISE AT REAR OF VEHICLE THEY HOWLED, I HAVE THE BRAKES RESUFACED AT 12,000 AND AGAIN AT 24000 AND THEY STILL MAKE NOISE. THE DRIVERS SEAT POPS AND CRACKES AND MAKES A METAL TO METAL NOISE IT HAS BEEN REPAIRED COUNTLESS TIMES AND IT STILL MAKES A OBSENE NOISE. *TR

TRANSMISSION COOLER LINE LEAKING TRANSMISSION FLUID AT AN ALUMINUM CRIMP THAT CONNECTS A RUBBER HOSE TO THE TRANSMISSION COOLER; AN INFERIOR DESIGN. AS SUCH, A TRANSMISSION OIL LEAK IS A FIRE HAZARD. I AM AWARE OF TWO CAR FIRES THAT WERE CAUSED BY LEAKING TRANSMISSION COOLER LINES. THE LAST ONE INVOLVED A FORD TAURUS STATION WAGON WHERE THE OWNER HAD THE TRANSMISSION REBUILT BY HIS LOCAL TRANSMISSION SHOP (A NATIONAL FRANCHISE TRANSMISSION REPAIR SHOP) AND THEY CROSS-THREADED THE LOWER COOLER LINE AT THE TRANSMISSION. THE TRANSMISSION FLUID LEAKED ON TO THE EXHAUST CROSS-OVER PIPE AND THE CAR BURNED TO THE GROUND ON THE SIDE OF ROAD IN THE INTERSTATE. THE OWNER'S INSURANCE COMPANY SUBROGATED AGAINST THE TRANSMISSION SHOP FOR THE DAMAGES. FORTUNATELY, NO ONE GOT HURT, BUT THEY CAME CLOSE. *TR

TRANSMISSION COOLING PIPES HAVE BEEN REPLACE TWO TIMES IN LAST THAN 20 MONTHS BECAUSE OF FLUID LEAKING. *TR

TL*THE CONTACT OWNS A 2006 GMC SIERRA 3500. WHILE DRIVING 10-75 MPH, THE ENGINE STALLED. THERE WAS A LOSS OF POWER STEERING AND BRAKES. THE VEHICLE WOULD RESTART BY ITSELF AFTER DRIFTING FOR 50 YARDS. THERE WERE NO WARNING INDICATOR LIGHTS PRIOR TO THE FAILURE. THE CONTACT NOTICED THICK, BLACK SMOKE COMING FROM THE EXHAUST PIPE OCCASIONALLY. THE DEALER REPLACED THE EXHAUST AND INSTALLED A NEW PROGRAMMER; HOWEVER, THE FAILURES CONTINUED. THE FAILURE MILEAGE WAS 300 AND CURRENT MILEAGE WAS 36,439.

I HAVE A 2006 GMC 2500HD THAT HAS 31000 MILES ON IT. THE TRANSMISSION COOL ER LINES ARE LEAKING AND THE DEALER HAS BEEN NOTIFIED ABOUT THIS PROBLEM. THE NEW PARTS ARE ON BACKORDER, MEANWHILE THE TRUCK LEAKS TRANSMISSION OIL ON THE GROUND WHICH COULD BE A POTENTIAL FIRE HAZARD ALONE WITH AN ENVIRONMENTAL HAZARD. MANY GMC 2500HD OWNERS ARE HAVING THIS PROBLEM. THIS IS NOT YET A RECALL BUT NEEDS TO BE ADDRESSED. *TR

I HAVE A 2006 GMC SIERRA THAT HAS HAD TRANSMISSION LINES REPLACED AND THAT KEEP HAVING TO BE REPLACED BECAUSE OF HOSE LEAKING EVERY YEAR. *TR

WENT TO GMC DEALER BECAUSE TRUCK HAS A TRANSMISSION OIL LEAK. TECHNICIAN NOTED THAT ALL THREE TRANSMISSION OIL COOLER LINE ARE LEAKING. ACCORDING TO INTERNET FORUM (HTTP://DIESELPLACE.COM/FORUM/SHOWTHREAD.PHP?T=202078), THIS IS A KNOW DEFECT ON THE 2006 SILVERADO AND SIERRA TRUCKS EQUIPPED WITH DIESEL ENGINE AND ALLISON AUTOMATIC TRANSMISSION. SEVERAL OWNERS HAVE HAD 2 OR MORE INCIDENTS. REPLACEMENT LINES ARE NO BETTER THAN THE ORIGINALS. I AM AN ENGINEER AND HAVE BEEN INVOLVED IN VEHICLE FIRE INVESTIGATIONS IN THE PAST, SOME WERE CAUSED BY LEAKING TRANSMISSION COOLER LINES DRIPPING ON HOT EXHAUST PIPES AND MANIFOLDS. THIS IS A POTENTIAL FIRE HAZARD! THIS REQUIRES A NEW DESIGN FOR THESE TRANSMISSION OIL COOLER LINES. *TR

VEHICLE HAD BANGING UNDERNEATH THE DRIVER'S FEET WHILE GOING OVER THE SLIGHTEST BUMP. ALSO VERY LOOSE FRONT END SWAY. TOOK TO THE DEALER AND THE REPLACED THE LEFT FRONT TORSION BAR MOUNT, CORRECTING PROBLEM. MADE A BIG DIFFERENCE IN RIDE PERFORMANCE. *TR

SUDDEN AND COMPLETE FAILURE OF BRAKES AND STEERING. STARTED VEHICLE, PLACED IN REVERSE, UNABLE TO STOP OR STEER. NO EMERGENCY ASSIST FROM ACCUMULATOR, MANUAL BRAKES ONLY. VEHICLE WAS PLACED IN NEUTRAL, THEN STOPPED WITH E-BRAKES AND SERVICE BRAKES. POWER STEERING RESERVOIR OVERFLOWING, PUDDLE ON GARAGE FLOOR OF FLUID, FLUID GUSHED WHEN CAP REMOVED. VEHICLE TOWED TO DEALER WHERE IT OPERATED NORMALLY! DEALER UNABLE TO DIAGNOSE AT TIME OF THIS WRITING. SIMILAR COMPLAINT FROM RELATIVE WITH THE EXACT SAME VEHICLE, HAD SAME THING HAPPEN 4 TIMES. HYDRO-BOOST SYSTEM ON A DIESEL 2500 HD. *TR

TL*THE CONTACT OWNS A 2006 GMC SIERRA 1500. THE CHILD RESTRAINT SYSTEM AT THE LOWER ANCHOR POINT ON THE BODY OF THE VEHICLE, IN ADDITION TO THE NUTS THAT HOLD DOWN THE LOWER ANCHOR ARE NOT TIGHT ENOUGH FOR ANYONE USING THE LATCH SYSTEM. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 22,000.

VEHICLE SHAKES VIOLENTLY ENOUGH TO JAR YOUR INTERNAL EQUIPMENT EVEN IF YOU GO OVER THE SMALLEST BUMP OR EXPANSION JOINT IN THE ROAD . RETURNED TO DEALER 5 TIMES FOR SAME COMPLAINT DEALER SAID THERE IS NO FIX. EVEN THOUGH WE INFORMED HIM THAT TRUCK WAS UNCONTROLLABLE ON WET PAVEMENT AND MADE YOU MOTION SICK. DEALERS SERVICE MANAGER WAS CONVINCED TO RIDE IN THE TRUCK AND STATED " THIS RIDE IS UNACCEPTABLE". *TR

AT THE FIRST OIL CHANGE IN MY NEW 2006 GMC SIERRA, I FOUND PIECES OF METAL (ASSEMBLY FROM THE ENGINE) ATTACHED TO THE MAGNETIC DRAIN BOLT. SUCH IS USUALLY SYMPTOMATIC OF A DEFECTIVE BEARING OR SOMETHING. NO PROBLEM AS OF YET WITH THE VEHICLE, BUT REGISTERING THIS OBSERVATION. FOR RECORD PURPOSES. THE ATTENDANT AT THE PLACE WHERE I GOT THE OIL CHANGED SAID MY VEHICLE WAS THE FOURTH ONE HE'S OBSERVED WITH THE SAME KIND OF METAL PIECES. *TR

TL*THE CONTACT OWNS A 2006 GMC SIERRA. THE VEHICLE HAS GOODYEAR WRANGLER AT, SIZE LT255/85R16 TIRES. THE CONTACT STATED THAT THE BEAD AREA OF ALL THE TIRES WAS EXTREMELY INDENTED. SHE NOTICED A HUGE BULGE ON THE PASSENGER SIDE FRONT TIRE. THE DEALER ACKNOWLEDGED THE FAILURE AND REPLACED THREE OF THE SIX TIRES. THE MANUFACTURER REFUSED TO REPLACE THE REMAINING THREE TIRES. THE FAILURE MILEAGE WAS 20,100 AND CURRENT MILEAGE WAS 21,000.

POOR BRAKE SYSTEM PERFORMANCE-HAVE HAD ROTORS & DRUMS RESURFACED STARTING AT 24,500 MILES & AT 33,000 MILES . NOW AT ~36,000 MILES THE ROTORS & DRUMS NEED TO BE REPLACED!THIS IS MY EVERY DAY VEHICLE & IS NOT A WORK TRUCK. *TR

DRIVING 2006 GMC SIERRA PICK UP IN UTAH ON HWY 191 IN A CROSS COUNTRY MOVE AND PUSHED OFF THE ROAD TO THE SIDE BY A TRUCKER FRANTICLY TELLING ME TO RUN FROM THE TRUCK,IT WAS ON FIRE. LOCAL FIRE DEPARTMENT CONCLUDED THEIR INVESTIGATION THAT IT WAS THE FUEL LINE LEAKING AS CAUSE OF ORIGIN. ALSO STATE HIGHWAY PATROL CONCLUDED THE SAME AT A LATER DATE. I SUBMITTED A CLAIM FOR THE CONTENTS TO GM AND WAS LIED TO FOR 2 MONTHS BEFORE THEM SAYING IT WAS NOT THEIR FAULT. THEY INVESTIGATED THE VEHICLE WITHOUT CONSENT FROM STATE FARM. THE ONLY CONSENT WAS TO PHOTOGRAPH. THEY SPENT 3.5 HOURS COMPLETELY INVESTIGATING WITH NO SUPERVISION. THE WOMAN HANDLING THE CLAIM AT GM SAID TO ME AT THE END THAT QUOTE "SOMETIMES THEY STEP UP TO THE PLATE AND SOMETIMES THEY DON'T,SORRY" AND DENIED THE CLAIM. NOW THEY REFUSE TO SPEAK TO ME OR RELEASE THEIR REPORT SO I CAN RETAIN AN ATTORNEY. THEY HAVE LIED AND CHEATED THROUGH THIS WHOLE PROCESS WITH OTHER BURNED LATE MODEL GM PU'S ARE BURNED RIGHT NEXT TO MINE IN THAT YARD. THE TRUCK HAS BEEN STOLEN FROM, RIFLED THROUGH,A ND COMPROMISED BY RAIN AND GM. NOW IT IS FINALLY SHRINK WRAPPED IN PLASTIC AND WAITING FOR THE NEXT STEP. PLEASE HELP AS SOON AS YOU CAN BY INVESTIGATING THIS. THANK YOU. *JB

TL*THE CONTACT OWNS A 2006 GMC SIERRA 1500. WHILE DRIVING 55 MPH, THE CONTACT STRUCK A DEER. THE DEER WENT UNDER THE FRONT DRIVER SIDE WHEEL AND CAUSED THE VEHICLE TO CRASH INTO A TREE AT 45 MPH. THE FRONT AIR BAGS FAILED TO DEPLOY. THE VEHICLE IS CURRENTLY AT THE BODY SHOP. THE INSURANCE COMPANY IS INVESTIGATING THE FAILURE AND THEY ALSO WANT GMC TO EXPLAIN WHY THE AIR BAGS DID NOT DEPLOY. THE CURRENT AND FAILURE MILEAGES WERE 25,300.

TL*THE CONTACT OWNS A 2006 GMC SIERRA 2500. WHILE ATTEMPTING TO EXIT A PARALLEL PARKED POSITION, THE POWER STEERING FAILED. THE STEERING WHEEL WAS ONLY ABLE TO BE TURNED ONE QUARTER TURN IN EITHER DIRECTION. THE VEHICLE WAS TAKEN TO A SERVICE DEALER ON THREE OCCASION, WHERE THEY WERE UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM. THE MANUFACTURER STATED THAT WITHOUT A RECALL THEY ARE UNABLE TO REPAIR IT. THE FAILURE MILEAGE WAS 650 AND THE CURRENT MILEAGE WAS 3745.

2006 GMC SIERRA 1500 CREW CAB. ONLY A YEAR OLD AND WITH LESS THAN 15,000 MILES, THE RIGHT TAIL LIGHT ASSEMBLY FELL OFF. THERE HAD BEEN NO ACCIDENT, IMPACT OR ABUSE. THE CAUSE WAS THE BREAKING OF THE TWO PLASTIC THREADS IN THE TAILLIGHT ASSEMBLY. THESE FLIMSY, WEAK, THREADED PARTS ARE ALL THAT HOLD THE TAILLIGHT ON AND ARE CLEARLY INADEQUATE FOR THE LOAD. THIS SHOULD NOT BE A WEAR AND TEAR ITEM; IT IS A DESIGN DEFECT. THERE SHOULD BE SOME METAL HOLDING THE SCREWS, NOT THIN PLASTIC. *TR

TL*THE CONTACT OWNS A 2006 GMC SIERRA 1500. THE CONTACT PURCHASED THE VEHICLE WITH AN ODOMETER READING OF 257 MILES. HE HAS EXPERIENCED BRAKE ROTOR FAILURE FOR THE SECOND TIME. THE CAUSE OF FAILURE WAS DIAGNOSED AS THE GROVES NEEDING TO BE REPAIRED OR REPLACED. THE ROTORS WERE MAKING A GRINDING NOISE AND THE DEALER WOULD NOT REPAIR THE VEHICLE FOR FREE. THE DEALER STATED THAT THERE ARE NO FAILURES WITH THE BRAKES. THE GROVES ARE GETTING DEEPER AND DEEPER, BUT THE DEALER CLAIMED THAT THIS IS NOT A SAFETY ISSUE BECAUSE NOTHING IS WRONG WITH THE BRAKES. HE HAS CALLED THE MANUFACTURER, BUT NO ONE IS INVESTIGATING THE FAILURE. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE IS 11,450 AND FAILURE MILEAGE WAS 9,000.

THIS CONCERNS AN GENERAL TIRE P245/70R17. THIS TIRE WAS ON MY GMC SIERRA PICK-UP TRUCK. THESE TIRES CAME WITH THE TRUCK. WITHIN A MONTH OF OWNING THIS TRUCK THE TREAD TORE AWAY FROM THE TIRE LEAVING LARGE HOLES THE DEALERSHIP REPLACED THOSE TIRES IN 2006. THIS INCIDENT HAPPENED JUNE 23, 2007. THE PASSENGER REAR TIRE EXPLODED WHILE DRIVING 65 MPH. IT ONLY HAD 17600 MILES ON THE TIRE. THE INCIDENT LED ME TO LOSS OF CONTROL OF THE VEHICLE AND DAMAGE TO THE RIM AS I TRIED TO PULL OVER. THE DEALERSHIP SAID GENERAL WOULD NOT REPLACE THIS TIRE BECAUSE THIS CAN HAPPEN AND IS A RISK YOU TAKE, I DISAGREE. IF THIS HAD BEEN ON THE FRONT TIRE I HAVE NO DOUBT I WOULD OF EITHER CAUSED AN ACCIDENT OR LOST TOTAL CONTROL. *AK

REPLACED DRIVERS HUB BEARING ASSEMBLY, STILL HAVING VIBRATION IN FRONT END. *JB

SUSPENSION MADE A 'THUNKING' NOISE WHILE DRIVING OVER BUMPS. I TOOK IT INTO THE DEALER AND WAS TOLD THE R. REAR TENSIONER LEAF SPRING WORN OR WAS WORN AND NEEDED REPLACEMENT. I NEVER GOT A STRAIGHT ANSWER AS TO WHY, BAD METAL OR WHAT? I'VE NEVER TOWED ANYTHING AND HAVE NEVER HAD ANY HEAVY LOADS IN THE BED CAUSING OVER COMPRESSION OF THE LEAF SPRINGS. TRUCK HAS ALWAYS SEEMED TO LEAN TO ONE SIDE AND LOOKS LOWER THAN FACTORY HEIGHT. DEALER FIXED UNDER WARRANTY. IT NOW SEEMS TO BE MAKING A SIMILAR NOISE BUT FROM THE FRONT SUSPENSION AREA WHILE DRIVING OVER SPEED BUMPS AND INTO DRIVEWAYS. I HAVE TO VERIFY THIS AND GET IT BACK INTO THE DEALERSHIP FOR MORE WORK...AND TRY TO GET ANSWERS. *JB

WHEN THE TRANSMISSION SHIFTS FROM 2ND TO 3RD THERE IS A HARD CLUNKING, ALSO WHEN IT DOWN SHIFTS FROM 3RD TO 2ND. I HAVE HAD THIS 2006 GMC FOR ONLY 10 MONTHS AND I PURCHASED IT NEW. I TOOK IT TO MY LOCAL DEALER FOR THE PROBLEM AND THEY TOLD ME THAT THIS IS NORMAL NOISE FOR A FOUR WHEEL DRIVE. I HAVE HAD MANY 4X4 GMS IN THE PAST AND NOT ONE OF THEM HAS HAD THIS KIND OF A SHIFTING PROBLEM. I HAVE PURCHASED THREE NEW GM'S IN THE LAST 4 YEARS AND I HAVE HAD PROBLEMS WITH ALL OF THEM, I THINK I'M GOING TO TRADE IT IN FOR A TOYOTA. *JB

I WAS DRIVING DOWN AIRLINE HWY NORTH BOUND BEFORE PEQUE LANE RIGHT BY GOLF COURSE AT BRIDGE THE ROAD IS NOT REALLY A POT HOLE BUT ROAD IS VERY DISTORTED AND THE WAY I HIT IT, IT PUT A BIG EGG AND SPLIT IN MY TIRE. THIS IS AN AREA WERE IT HAS BEEN LIKE THIS FOR AWHILE AND IF YOU HIT THAT SPOT IT WILL MESS YOUR CAR UP OR MAKE IT HARD TO CONTROL YOUR CAR. THE TIRES I OWN ARE VERY HIGH PRICED AND I PURCHASED NOT TO LONG AGO. I WOULD LIKE HELP IN REPLACING THE TIRE. I DID GO BACK AND TAKE PICTURES OF THE AREA IN WITCH I HIT TO CAUSE THIS TO HAPPEN TO THE TIRE. THE TIRES ARE $700 TO $800 EACH BUT ONLY ONE FRONT RIGHT TIRE WAS DAMAGED. I WILL HAVE TO ORDER IT. *JB

TL* - THE CONTACT OWNS A 2006/GMC/SIERRA 1500, WHILE DRIVING AT 60 MPH TIRE SIDEWALL BLEW OUT. THE FAILURE MILEAGE WAS 2000 MILES. THE CONTACT'S TIRES ARE GENERAL TIRE & RUBBER CO. , SIZE P235/70R16. THESE WERE THE ORIGINAL TIRES, THE VEHICLE WAS DELIVERED WITH PASSENGER TIRES NOT LIGHT TRUCK TIRES. THE DEALER WOULD NOT ADJUST THE TIRE, BUT RECOMMENDED FOR THE TIRES TO BE REPLACED AT SEARS. THE CONTACT REPLACED THE TIRES AT HIS OWN EXPENSE. *AK

4.3 ENGINE STARTED SHAKING FOR NOT APPARENT REASON, MILEAGE AT INCIDENT 10,000 MILES. ENGINE RPM'S WOULD GO UP & DOWN AT IDLE & ROUGH IDLE IT DID THIS FOR A COUPLE OF DAYS. ENGINE SHOOK VIOLENTLY AND JERKED. THE VEHICLE STOPPED RUNNING WOULD NOT TURN ON. VEHICLE TOWED TO DEALER. DEALER HAD TO REPLACE ECM (COMPUTER) & CRANK SHAFT SENSOR. VEHICLE AFTER TWO WEEKS IS NOW ROUGH IDLE AT TIMES AT START UP & RPM'S AT IDLE STILL VARY AT TIMES. VEHICLE TAKEN IN TO DEALER AND TECH STATED NO HIDDEN CODES VEHICLE CHECKED OUT OKAY ACCORDING TO DEALER??? *NM

ACCORDING TO THE DISTRICT DISTRIBUTOR REPRESENTATIVE FOR FIRESTONE HE SAID THE TERM "STONE CHIPPING" IS WHAT'S HAPPENING TO SOME OF THEIR TIRES. WHEN I LOOK AT MY TIRE, I SEE CHIPS OF RUBBER COMING OUT OF THE TIRE EVEN IN THE TREAD. *JB

DT*: THE CONTACT STATED WHILE ATTEMPTING TO EXIT A PARALLEL PARKED POSITION, THE POWER STEERING FAILED. THE STEERING WHEEL WAS ONLY ABLE TO BE TURNED ONE QUARTER TURN IN EITHER DIRECTION. THE VEHICLE WAS TAKEN TO A SERVICE DEALER, WHERE THEY WERE UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM. THE MANUFACTURER WAS ALSO NOTIFIED. UPDATED 08/27/07 *TR

DT*: WHILE DRIVING VARIOUS SPEEDS GOING DOWN HILL AND APPLIYING THE BRAKES THE VEHICEL RATTLED AND SHOOK. THE VEHICLE WAS DRIVEN TO THE DEALER, WHO DETERMINED THIS WAS A CHARACTERISTIC OF THE VEHICLE. UPDATED 1/31/2007 - *NM

MY TIRES STARTED FALLING APART AROUND 11000 MILES. THE SIDEWALLS ARE INDENTING AND THE TREAD IS COMING OFF THE TIRE AS WELL AS EXTREME FEATHERING. THE DEALER HAS TESTED THE ALIGNMENT AND BALANCE. I CURRENTLY HAVE 13000 ON MY TRUCK AND FINALLY GOT THE DEALER TO REPLACE THEM BUT ONLY WITH THE SAME BRAND OF TIRE. *NM

LOSS OF TRACTION ON WET ROAD , HIT ROCK CUT AT 50 MPH NO BRAKE NO ANTI-LOCK NO STEERING NO CONTROL . VERY THIN WATER ON ROAD DID NOT FELL SLICK AFTER CRASH BY HAND OR MY SHOES. 8JB

DT*: THE CONTACT STATED WHILE DRIVING 40 MPH ON THE HIGHWAY, A PASSING MOTORIST MOTIONED TO PULL THE VEHICLE OVER. THE CONTACT PULLED THE VEHICLE TO THE SIDE OF THE ROAD AND WHITE SMOKE ERUPTED FROM BETWEEN THE BED AND CAB OF THE TRUCK AS WELL AS UNDERNEATH. THE FIRE DEPARTMENT WAS ALERTED, AND EXTINGUISHED THE FLAMES. ALSO, THE POLICE WERE ALERTED, AND A REPORT WAS TAKEN. THE VEHICLE WAS DEEMED A TOTAL LOSS DUE TO THE EXTENSIVE FIRE DAMAGE. THE FIRE DEPARTMENT INSPECTED THE VEHICLE AND DETERMINED THERE WAS A SMALL HOLE IN THE FUEL TANK WHICH RESULTED IN GASOLINE LEAKING ONTO A NEARBY WIRING HARNESS AND ULTIMATELY CAUSING AN IGNITION SOURCE WHICH LED TO A FIRE. THE MANUFACTURER WAS NOT ALERTED.

DT*: THE CONTACT STATED WHILE TOWING THE VEHICLE, THE TRANSMISSION DOWNSHIFTED TO A LOWER GEAR WHICH CAUSED THE TIRES TO SKID. THE VEHICLE WAS DRIVEN TO THE DEALER WHO DETERMINED THE VEHICLE WAS DESIGNED THAT WAY.

DT*: THE CONTACT STATED THE REAR PASSENGER WHEEL VALVE SYSTEM BLISTERED CAUSING AN AIR LEAK. THE CONTACT CHANGED THE TIRE AND THE PROBLEM RECURRED. THE VEHICLE LOST CONTROL AND WAS IN A SINGLE CAR ACCIDENT CAUSING DAMAGE TO THE VEHICLE. NO INJURIES WERE SUSTAINED.

DT*: THE CONTACT STATED BEFORE PULLING A NEWLY PURCHASED VEHICLE OFF THE DEALER'S LOT, A VIBRATION WAS NOTICED. THE DEALER WAS MADE AWARE OF THE OBSERVATION AND THEY STATED THAT THE VIBRATION WAS COMING FROM THE TIRE DUE TO SITTING FOR A LONG PERIOD OF TIME IN THE LOT. THE VEHICLE HAS CONSISTENTLY VIBRATED ON NORMAL ROAD CONDITIONS TRAVELING AT SPEEDS OF 65 MPH. THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR FURTHER INSPECTION. THE DEALER DETERMINED THAT THE VIBRATIONS WERE COMING FROM THE FRAME OF THE VEHICLE.

DT*: THE CONTACT STATED WHILE TRAVELING VARIOUS SPEEDS, THE VEHICLE BOUNCED UNCONTROLLABLY WHEN HITTING A RUT IN THE ROAD. THE VEHICLE WAS TAKEN TO THE DEALERSHIP, WHO DETERMINED BIGGER SHOCKS NEEDED TO BE INSTALLED. UPDATED 10/17/2006 - *NM

DT*: THE CONTACT STATED WHILE DRIVING 55 MPH ON THE HIGHWAY, THE LEFT FRONT WHEEL WOBBLED FROM SIDE TO SIDE WITHOUT WARNING. THE CONTACT MANAGED TO PULL THE VEHICLE OVER WITHOUT INCIDENT. THE VEHICLE WAS TOWED TO THE DEALER WHO DETERMINED THE LEFT FRONT WHEEL BEARINGS WERE LOOSE AND NEEDED TO BE REPLACED. AFTER NEW WHEEL BEARINGS WERE INSTALLED, THE PROBLEM WAS CORRECTED. THE MANUFACTURER WAS ALERTED.

2006 GMC SIERRA 2500 HD BRAKE PEDAL FEELS SPONGY AND HARDER TO STOP WHILE TOWING A BOAT. *KB THE HYDROBOOST SEEMS TO EMIT A HUMMING SOUND WHEN THE BRAKE PEDAL IS APPLIED. THE INCIDENT OCCURS WHEN THE TRANSMISSION TEMPERATURE REACHES 180- 190 DEGREES ACCORDING TO THE GAUGE. *JB

AIR CONDITIONER FAN RESISTOR FAILED FILLING PICKUP CAB WITH SMOKE. WAS REPAIRED UNDER WARRANTY AND FAILED AGAIN, BURNING PART OF THE WIRING HARNESS. *NM

DT*: THE CONTACT STATED WHILE BACKING OUT OF THE DRIVEWAY AT A LOW SPEED, THE LEFT FRONT WHEEL COLLAPSED TO THE PAVEMENT WITHOUT WARNING. UPON INSPECTION, THE RIGHT FRONT TIRE WAS INTACT. THE VEHICLE WAS TOWED TO A DEALER FOR FURTHER INSPECTION. THE DEALER DETERMINED THE FRONT TIE ROD FRACTURED AND NEEDED TO BE REPLACED.

VEHICLE- 2006 GMC SIERRA 2500HD 4X4 DURAMAX/ALLISON THERE IS A VERY NOTICEABLE CLUNK/LOOSENESS IN THE STEERING. I HAVE GREASED/LUBRICATED THE WHOLE STEERING MECHANISM WITH NO REDUCTION IN THE PROBLEM. MY FEAR IS THE LOOSENESS WILL RESULT IN A COMPLETE FAILURE OR LOSS OF STEERING. PRIOR TO THAT I FEAR POOR DRIVING/MANEUVER ABILITY WHILE THIS ISSUE PERSIST. *JB

DT*: THE CONTACT STATED THE VEHICLE'S HYDROBOOST WAS TOO SMALL FOR THE TRUCK AND MADE TOO MUCH NOISE WHEN THE BRAKES OR STEERING WERE USED. THE DEALER DETERMINED THE VEHICLE HAS NO PROBLEMS, BUT THE CONTACT EXPRESSED THERE WILL BE DIFFICULTY DOING TOWING WORK PARTICULARLY GOING UPHILL AND DOWNHILL. THE VEHICLE IS ONLY TWO MONTHS OLD AND HAS BEEN DEMONSTRATING THIS PROBLEM SINCE THE BEGINNING OF THE SECOND MONTH.

DT*: THE CONTACT STATED THREE OF THE FOUR ORIGINAL TIRES HAVE GONE FLAT BECAUSE THE VALVE STEMS LEAK AIR. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND THE VALVE STEMS WERE REPLACED. *AK

SEATS POPPING NOISE WHEN WEIGHT SHIFTS (START,STOP,ETC.)FIRST ATTEMPT WAS TO REPLACE THE SEAT BACK. SECOND WAS TO REPLACE THE ENTIRE SEAT MINUS THE COVER. THIRD TIME IN THE SERVICE MANAGER WANTED TO CONTACT THE AREA GM MANAGER FOR DIRECTION. THE GM AREA MANAGER TOLD THE SERVICE MANAGER TO MAKE NO REPAIR AND DIRECT ME TO CALL GM. THIS TRUCK ALSO HAS BEEN IN FOR SERVICE TO THE BRAKE ROTORS TO BE RE SURFACED WITH ONLY 4,600 MILES ON THE TRUCK. THE TRANSMISSION HAS RE CALIBRATED TWO TIMES ONE FOR THE LOCK-UP TORQUE CONVERTER,AND ONCE FOR A HARD SHIFT FROM FIRST TO SECOND GEAR. THE TRUCK HAS A HARDER SHIFT NOW THAN BEFORE. *JB

DT*: THE CONTACT STATED WHILE TRAVELING 50 MPH, A BUMPING NOISE WAS HEARD COMING FROM THE REAR OF THE VEHICLE. WHEN THE CONTACT LOOKED IN THE REARVIEW MIRROR, NOTHING WAS NOTICED. WHEN THE VEHICLE WAS PARKED, THE CONTACT FOUND THE DRIVER SIDE TAILLIGHT ASSEMBLY WAS HANGING BY THE WIRES. THE DEALERSHIP DETERMINED THE TABS HOLDING THE TAILLIGHT FRACTURED AND ORDERED A NEW TAILLIGHT ASSEMBLY.

DT*: THE CONTACT STATED THE SPEEDOMETER DISPLAYED AN INCORRECT READING UP TO 10 MPH MORE THAN THE DRIVEN SPEED. THE VEHICLE WAS SEEN BY A DEALER, WHO DETERMINED THIS WAS DUE TO THE OVERSIZED TIRES ON THE VEHICLE WHICH AFFECTED THE OVERALL TELEMETRY. THE VEHICLE WAS SENT TO AN INDEPENDENT REPAIR SHOP AND AN AFTER MARKET HYPER-TECH COMPUTER CHIP WAS INSTALLED TO OVERRIDE THE COMPUTERIZED TELEMETRY OF THE VEHICLE. UPDATED 05/30/06. *AK

DT: THE CONTACT STATED THE STEERING WHEEL LOCKED WHEN HE APPLIED THE BRAKE. AFTER THREE ATTEMPTS THE DEALER HAS BEEN UNABLE TO REPAIR THE PROBLEM. ANOTHER DEALER INFORMED HIM THIS WAS THE DESIGN OF THE VEHICLE. THE MANUFACTURER ADVISED HIM TO TAKE IT TO THE DEALER. *AK UPDATED 11/29/05. *JB

DT: THE CONTACT STATED THAT AS SOON AS HE PURCHASED THE VEHICLE SOME KIND OF SMELL STARTED, AND THEN IT STARTED MAKING A RUBBING NOISE THAT SOUNDED LIKE THE SERPENTINE BELT OR SOME KIND BEARINGS. THE VEHICLE HAS BEEN TAKEN TO THE DEALERSHIP, AND TOLD THE CONTACT THAT THE AIR CONDITIONER WAS MAKING THE NOISE. *AK