2007 Ford F-150 Supercab

The contact owns a 2007 Ford F-150. The contact stated that while his son was driving out of a parking lot under 5 MPH, the air bags inadvertently deployed without impact. The air bag warning light illuminated. The contact had not taken the vehicle to the dealer. The vehicle had not been diagnosed or repaired. The manufacturer was made aware of the failure an opened a case. The approximate failure mileage was 143,000.

The airbag warning light stays on.

Yesterday I discovered that the frame of my truck is completely rusted through in at least 2 places on the passenger side. I cannot confirm these are the only areas. The passenger side appears much worse than the driver side.

The contact owns a 2007 Ford F-150. The contact stated that the fuel gauge was displaying the incorrect fuel level. The vehicle was not diagnosed nor repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 36,000.

STARTED TO DRIVE MY VEHICLE BUT IT IS STUCK IN PARK

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE ENGINE VIBRATED AND SHUDDERED UNCONTROLLABLY WITHOUT WARNING. THE CONTACT ALSO MENTIONED THAT ON OTHER OCCASIONS THE VEHICLE SHUT-OFF WITHOUT WARNING DUE TO THE FAILURE. THE CONTACT STATED THAT AFTER RESTARTING THE VEHICLE, THE RPM'S DROPPED VERY LOW. THE CONTACT REVVED THE ENGINE TO RESUME NORMAL VEHICLE OPERATION. THE CONTACT USED A SCAN TOOL TO DETERMINE THE FAILURE AND DISCOVERED THAT CHAFING ON THE WIRING HARNESS HAD CAUSED THE FAILURE. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 175,000.

TRANSMISSION COOLING LINE GOING THROUGH RADIATOR FAILED CAUSING COOLANT TO MIX WITH TRANSMISSION FLUID. RESULTING IN TRANSMISSION FAILURE. TRANSMISSION HAD TO BE ENTIRELY REBUILT AND RADIATOR ALSO HAD TO BE REPLACED. THIS OCCURRED AT HIGHWAY SPEED.

WHEN IDLE IT HAS A ROUGH SOUND CHANGED FADERS AND SENORS STILL SAME...IT HAS A SO TRYING GAS SMELL AROUND IT AND WHEN DRIVING IT IT MAY SHUT OFF AND ALSO IT DRIVES LIKE IT NEEDS A TUNE UP BUT HAS RECENTLY HAD ONE....THE WHEEL HUB ASSEMBLY IS ALSO ACTING UP

FRAME, BRAKE LINES AND ALL METAL UNDER CARRIAGE CORRODED TO THE POINT OF BEING UNSAFE. BODY ONLY HAS MINIMAL RUST ON REAR CORNER PILLARS. UNSAFE TO OPERATE.

AFTER HITTING THE HIGHWAY MEDIAN WALL AT A HIGH SPEED, THE DRIVER SIDE AIRBAG DID NOT DEPLOY AND I WAS INJURY IN THE ACCIDENT.

TL* THE CONTACT OWNED A 2007 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING AT 73 MPH, HE ATTEMPTED TO DEPRESS THE BRAKE PEDAL AND THE BRAKE PEDAL BROKE WITHOUT WARNING. AS A RESULT OF THE BRAKE FAILURE, THE CONTACT REAR ENDED AN 18-WHEELER TRUCK. THE AIR BAG DEPLOYED UPON IMPACT HOWEVER, THE SEAT BELT FAILED TO RETRACT. THE CONTACT RECEIVED MEDICAL ATTENTION AT THE SCENE AND WAS LATER TRANSPORTED TO A HOSPITAL. THE OTHER DRIVER WAS ALSO TREATED AT THE SCENE BUT HIS INJURIES WERE UNKNOWN. THE CONTACT SUSTAINED A BROKEN RIGHT ARM AND A BROKEN RIGHT FEMUR. A POLICE REPORT WAS FILED AT THE SCENE. THE VEHICLE WAS DESTROYED AND TOWED TO A LOCAL JUNK YARD. THE DEALER WAS NOT NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 141,000.

THE WIRING FOR MAP BURNT OUT IT'S MADE OF PLASTIC AND PARTIALLY MELTED .PASSENGER SIDE AIRBAG LIGHT

EXHAUST SMELL/RAW GAS SMELL COMING THROUGH THE HEATING DUCT SYSTEM INTO THE CAB OF TRUCK. ONLY HAPPENS WHEN USING THE HEATING/DEFROST SYSTEM. DOESN'T MATTER IF THE VEHICLE IS MOVING OR AT REST. MUST CRACK WINDOW FOR FRESH AIR OR TURN OFF HEATING/DEFROST SYSTEM. THIS HAS BEEN OCCURRING SINCE MID NOVEMBER BUT ONLY WHEN TURNING ON THE HEATING/DEFROST SYSTEM. HAPPENS AT HWY SPEEDS AND LOCAL DRIVING SPEED BETWEEN 30-50 MPH.

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING 70 MPH AND ATTEMPTING TO AVOID A DEER, THE CONTACT CRASHED INTO A GUARDRAIL. THE AIR BAGS DID NOT DEPLOY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT SUSTAINED INJURIES TO THE HEAD, FACE, AND CHEST THAT REQUIRED MEDICAL ATTENTION. POLICE REPORT NUMBER: 190668604 WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC, BUT WAS NOT DIAGNOSED OR REPAIRED. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 293,000. THE VIN WAS INVALID.

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT EVERY TIME HE ATTEMPTED TO STOP THE VEHICLE, IT MISFIRED. THE CONTACT OCCURRED DAILY SINCE MAY OF 2019. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CAMSHAFT, TENSIONERS, TIMING CHAIN, VCT VALVES, AND SPARK PLUGS WERE CHANGED BY THE CONTACT. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 180,000.

EVERY VEHICLE THAT FORD PUT OUT WITH A CAM PHASER IS EXPERIENCING ISSUES WITH THE CAN PHASER. ANY SAE CERTIFIED MECHANIC WILL VERIFY THIS. THIS IS A HORRIBLE DESIGN. WHY HASN'T FORD STEPPED UP TO THE PLATE AND FIXED THIS ISSUE? I BELIEVE THEY ARE TRYING TO BURY IT SO THAT THEY DON'T HAVE TO INCUR THE COST OF FIXING THEIR MISTAKE. DUE TO THIS ISSUE I'VE BEEN STRANDED ON THE HIGHWAY. THE TRUCK LOOSES POWER, WON'T GO INTO GEAR....ETC....THIS HAPPENS AFTER THE CAN PHASER HAS ACTIVATED AND THEN I COME TO A STOP. THEN IT'S MISFIRING STALLING NOT GOING INTO GEAR...YOU NAME IT IT'S AN ISSUE. A COMPUTE READ ON THE OBD2 STAYED THAT I HAD MISSES IN IGNITION COILS 1,3 AND 7 REPLACED THEM THEN THE TEACHING STAYED MISFIRED IS 2,4 AND 5 REPLACED THEM AND ALL THE SAME ISSUES... EVERY MECHANIC I'VE SPOKEN TO SAYS ABSOLUTEY THE PHASES AND THAT THEY HAVE TO PUT A CAM PHASER DELETE KIT IN THESE VEHICLES DO GET RID OF THESE PROBLEMS. WHY HASN'T FORD BEEN HELD RESPONSIBLE FOR SUCH A TERRIBLE DESIGN?

THIS IS AN UPDATE TO MY POST OF 8/14/19, CONCERNING FRAME RUST ON MY 2007 F150. THE TRUCK HAS NOW BEEN INSPECTED BY A COMPETENT BODY SHOP WITH THE BOX TAKEN OFF. THERE IS MORE RUST ON THE FRAME THAN ON THE TITANIC, NO HOPE OF FIXING IT. SO FAR FORD DOESN'T WANT TO KNOW ANYTHING. SOMEONE IS GOING TO BE KILLED IF THIS ISN'T ADDRESSED. THERE ARE A LOT OF THESE TRUCKS OUT THERE WITH A SERIOUSLY UNEXPECTED LEVEL OF RUST. LOOKING FOR OPTIONS!!

TRANSMISSION SLIPPING IN REVERSE.IT THROWS UP THE CODE PO720, WHICH IS THE OUTPUT SHAFT SPEED SENSOR. THE VEHICLE IS INCAPABLE OF TOWING ANYTHING. THIS IS AN ISSUE FOR THIS SPECIFIC TRANSMISSION DATED ALL THE WAY BACK TO 2002.WE BOUGHT THE VEHICLE LESS THAN A YEAR AGO.

I WENT TO HAVE MY BRAKES REPLACED ON MY F-150 WITH 54,000 MILES ON THE ODOMETER AND THE MECHANIC TOLD ME THE FRAME WAS COMPLETELY RUSTED OUT AND THAT HE WAS ABLE TO PUT A SCREWDRIVER THROUGH IT. HE DIDN'T WANT TO INSTALL THE BRAKES. I HAVE OWNED THIS TRUCK SINCE NEW AND IT HAS (MOSTLY) BEEN GARAGED THROUGHOUT. THE BODY PANELS, INTERIOR , TRANSMISSION, ENGINE, ETC. ARE IN EXCELLENT SHAPE. IT APPEARS TO BE THE SAME PROBLEM REPORTED BY MANY OTHERS, SO I'M NOT SURE WHY THERE HASN'T BEEN A FORD RECALL ON THIS DANGEROUS SITUATION. IT'S OBVIOUSLY BEEN GOING ON FOR SOME TIME, BUT I NEVER LOOKED UNDER THE TRUCK TO SEE THE EXTENT OF THE RUST, GIVEN THAT THE BODY WAS IN GREAT SHAPE (NO RUST).

I HAVE A 2007 F150 WITH 96,460 MILES. DRIVES ON PA ROADS NEVER OFF ROAD AND NO HAULING. DRIVER SIDE FRAME RAIL IS RUSTED AT A POINT IMMEDIATELY BEHIND THE FORWARD MOUNTING BRACKET OF THE REAR LEAF SPRING. THE AMOUNT OF RUST IS EXTENSIVE. THE INNER WALL OF THE RAIL IS RUSTED THROUGH CREATING A HOLE APPROX. 10 INCHES LONG AND RANGING FROM THE HEIGHT OF THE RAIL TAPERING REARWARD TO ABOUT 3/4 OF AN INCH. THE BOTTOM OF THE FRAME RAIL IS ALSO RUSTED THROUGH AT A POINT WHERE IT MEETS THE SPRING'S MOUNTING BRACKET. ALTHOUGH THE METAL APPEARS SOMEWHAT INTACT THERE IS NO STRUCTURAL INTEGRITY. THIS LEAVES ONLY THE UPPER PORTION AND OUTSIDE WALL OF THE FRAME RAIL INTACT BUT ALSO RUSTED. BASED ON MY OBSERVATION THIS TRUCK CANNOT BE DRIVEN SAFELY. I AM NOT AWARE OF ANY SOLUTION OTHER THAN TO REPLACE THE FRAME BUT THIS WILL BE DETERMINED BY A PROFESSIONAL IN THE NEAR FUTURE. AS TO THE CAUSE I DO NOT KNOW. THIS DAMAGE WAS FIRST NOTED TODAY 8/14/2019 AND WAS NOT DETECTED DURING AN INSPECTION IN 12/2018

TRUCK LOOSING POWER AND TAPPING AND KNOCKING NOISE, WAS TOLD IT IS PHAZERS AND TIMING CHAINS AND VCT'S AND COULD JUST STOP RUNNING WHILE DRIVING IF THE PHAZERS LOCK UP. NOW I FEEL UNSAFE DRIVING IT HAS 1700000 MILES AND FORD IS NOT STANDING BEHIND EVEN THO I HAVE TALKED TO DOZENS OF PEOPLE THAT HAVE THE SAME PROBLEM.

FIRST THE TRANS WENT OUT IN THE MIDDLE OF NO WHERE AT 1130 AT NIGHT WITH MY NEWBORN. THEN THE ENGINE WENT AS I WAS DRIVING TO WORK. WE FOUND OUT IT WAS THE CAM PHASERS WHICH WE HAD TO REPLACE THE ENGINE FOR. WE HAVE DONE $8000 IN REPAIRS AND IT'S NOT RECALLED??

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WATER DRAINED ONTO THE FRONT PASSENGER SIDE FLOORBOARD WHEN IT RAINED. THE DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERENCED TECHNICAL SERVICE BULLETIN NUMBER: 07-13-5. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 137,000.

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHEN THE GEAR WAS SHIFTED INTO REVERSE, THE VEHICLE WOULD NOT MOVE BACKWARDS. THERE WAS NO WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO ROBICHAUX FORD (985-446-3100, LOCATED AT 272 W MAIN ST, THIBODAUX, LA 70301) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THERE WAS NO RECALL. THE CONTACT WAS REFERRED TO NHTSA. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS NOT PROVIDED.

THIS IS REGARDING A 2007 FORD F150 SUPERCREW. DURING THE VEHICLES YEARLY INSPECTION IT WAS DISCOVERED THAT THE FRAME OF THE VEHICLE UNDER THE CAB IS COMPLETELY RUSTED OUT AND CRACKED EXTENSIVELY. IT IS CRACKED BEYOND REPAIR AND NO LONGER SAFE TO DRIVE. THIS VEHICLE IS ONLY 12 YEARS OLD AND SHOULD NOT BE EXPERIENCING EXTENSIVE PREMATURE RUST IN THIS WAY. THERE ARE ALOT OF THESE TRUCKS ON THE ROAD AND IT'S ONLY A MATTER OF TIME BEFORE SOMEONE GETS HURT.

LEFT WORK DROVE 1/4 OF A MILE AND CAR JERKED WHILE DRIVING AT 35 MPH, WRENCH LIGHT CAME ON AND CAR DIDN'T SEEM TO ACCELERATE AT FIRST BUT DID SLIGHTLY ACCELERATE SO I COULD GET OFF THE ROAD. TURNED CAR OFF WAITED A FEW MINUTES TURNED ON AND LIGHT WENT OFF. DROVE HOME 10 MILES AND STILL DOING IT WITHOUT EQUAL PATTERN

CAMPAIGN NUMBER: 18E069. I AM UNABLE TO GET ANYONE TO ANSWER THE NUMBER PROVIDED IN THE LETTER AT LRG. I HAVE THE EFFECTED RIMS AND THEY ARE NOW LEAKING AIR. I WOULD LIKE TO FILE A COMPLAINT.

TL* THE CONTACT OWNED A 2007 FORD F-150. WHILE DRIVING 45 MPH, THE CONTACT CRASHED INTO A COW AND THE FRONT DRIVER SIDE AIR BAGS DID NOT DEPLOY. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT'S BACK WAS INJURED AND MEDICAL ATTENTION WAS RECEIVED. THE VEHICLE WAS TOTALED AND TOWED TO A JUNK YARD. A POLICE REPORT WAS FILED. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURE. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE FAILURE MILEAGE WAS 160,000.

VEHICLE DIFFERENTIAL FAILED AND STARTS ERRATICALLY BUCKING WHILE DRIVING.

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT THE VEHICLE'S FRAME WAS RUSTED. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER WHO DIAGNOSED THAT THE FRAME WAS FRACTURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS 119,000. *TT VEHICLE PURCHASE DATE SHOULD BE ON OR BEFORE INCIDENT DATE *JB

HAD A WRECK AND THE ENTIRE FRONT OF TRUCK WAS BASICLY CRUSHED AND THE AIR BAGS DID NOT DEPLOY.

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT NOTICED AN ABNORMAL ODOR COMING FROM THE FUEL TANK AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. NO LEAKS WERE FOUND. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT TO CALL NHTSA AND FILE A COMPLAINT. THE FAILURE MILEAGE WAS 142,000.

DRIVING AND STARTED TO SHAKE, HAS NASTY RATTLE (DEATH RATTLE) THREW CODE P0355. FIXED THE CODE BY INSTALLING NEW WIRES $500.00. FIXED FOR 2 WEEKS THEN STARTED DOING IT AGAIN AND CODE P0355 CAME UP AGAIN. HAS LACK OF POWER AND SHAKES BAD. VERY MUCH A HAZARD TO DRIVE.

THE TIME CHAIN SKIPS A TOOTH. I HAVE BEEN HAVING ISSUES WITH THIS LEADING TO INJECTORS AND CONSTANT MISFIRES. I WAS DRIVING WHEN ALL OF THE SUDDEN THE CAR STARTED LOOSING POWER AND A RATTLING NOISE STARTED.

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING VARIOUS LOW SPEEDS, THE VEHICLE BEGAN SHAKING AND A KNOCKING NOISE SOUNDED FROM THE ENGINE. THERE WERE NO WARNING INDICATORS ILLUMINATED. AN INDEPENDENT MECHANIC TEST DROVE THE VEHICLE AND DETERMINED THAT THE ROCKER ARMS NEEDED TO BE REPLACED. IN ADDITION, THE INDEPENDENT MECHANIC STATED THAT THE "VARIABLE VALVE TIMINGS" WERE FAULTY AND CREATED A MISFIRE WITHIN THE ENGINE. AN UNKNOWN FORD DEALER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 180,000.

REAR DRIVER SIDE DOOR RATTLES AS IF NOT COMPLETELY SHUT WHEN DRIVING. SUN/MOON ROOF NOT OPENING.

MY VEHICLE HAS A 4.6L V-8 ENGINE. THE REAR SPARK PLUG ON THE PASSENGER SIDE OF THE VEHICLE EJECTED FROM IT'S CYLINDER. I WAS DRIVING AT ABOUT 50 MPH ON THE HIGHWAY WHEN THE EJECTION OCCURRED.

TL* THE CONTACT OWNS A 2007 FORD F-150. AFTER REFUELING THE VEHICLE, THE CONTACT NOTICED A STRONG FUEL ODOR INSIDE AND OUTSIDE THE VEHICLE. THE CONTACT STATED THAT THERE WAS EVIDENCE OF A FUEL LEAK ONLY AFTER FUELING THE VEHICLE. THE CONTACT ALSO STATED THAT THE CHECK ENGINE INDICATOR ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 07V278000 (FUEL SYSTEM, GASOLINE). THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 155,000.

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT THE CAM PHASER SENSORS FAILED, WHICH CAUSED THE ENGINE TO SHAKE ABNORMALLY AND THE VEHICLE TO STALL. THE VEHICLE WAS TAKEN TO SEVERAL INDEPENDENT MECHANICS WHERE IT WAS DIAGNOSED THAT THE CAM PHASER SENSORS NEEDED TO BE REPLACED. THE DEALER (FAIRWAY FORD OF EVANS, 4333 WASHINGTON RD, EVANS, GA 30809, (706) 854-9200) DIAGNOSED THAT THE CAM PHASER SENSORS HAD AN INTERNAL FAULT AND RECOMMEDED THAT THE ENGINE ASSEMBLY BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT HAD NOT ISSUED AN ENGINE RECALL TO ADDRESS THE FAILURE. THERE WERE NINE TSBS ON THE ENGINE AND ENGINE ASSEMBLY. THE VEHICLE REMAINED PARKED DUE TO THE INTERMITTENT FAILURES. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

VEHICLE LOSES POWER AT 45 TO 60 MPH OR ON A BUMPY ROAD DASHBOARD LIGHTS COME ON. IT HAS DONE THIS APPROX.3 TIMES.IT USUALLY STARTS BACK UP BUT I THINK ITS A SAFETY HAZARD.

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING VARIOUS SPEEDS, THERE WAS AN ODOR OF FUEL COMING FROM THE REAR OF THE VEHICLE. A LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL LINE HOSE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS 55,287. THE VIN WAS NOT AVAILABLE. *TT

WHILE DRIVING & APPLYING BRAKES, TRUCK REVS UP DOES A BURN OUT!!!! HAPPENED FEB 14TH 2018 & AGAIN MARCH 1 2018. TOOK TO MECHANIC....THERE IS NO VACUUM LEAK & NO CODES APPEARED.

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING VARIOUS SPEEDS AND WITHOUT DEPRESSING THE ACCELERATOR OR BRAKE PEDALS, THE VEHICLE INADVERTENTLY ACCELERATED AS THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE ENGINE REVVED. THE CONTACT STATED THAT THE FAILURES ALSO OCCURRED WHILE MAKING A LEFT TURN AND THE STEERING WHEEL SEIZED, WHICH MADE IT DIFFICULT TO MAKE THE LEFT TURN. THE BRAKE PEDAL WAS DEPRESSED IN ORDER TO STOP THE VEHICLE. AFTER STOPPING, TURNING OFF AND RESTARTING THE VEHICLE IT WAS ABLE TO OPERATE NORMALLY. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE CONTACT MENTIONED THAT THE FAILURE OCCURRED AT LEAST THREE OTHER TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND A CASE WAS OPENED. THE CONTACT WAS REFERRED TO NHTSA BY THE MANUFACTURER. THE APPROXIMATE FAILURE MILEAGE WAS 143,000.

TAKATA RECALL INFLATORS HAVE BEEN REMOVED. INSTRUMENT PANEL DISPLAYS TIRE INFLATION WARNING ALWAYS. THE MAIN SAFETY ISSUE I SEE WITH THIS VEHICLE IS THE BRAKE AND ACCELERATOR PEDALS ARE TO CLOSE TO EACH OTHER AND ARE NOT ADJUSTABLE. THE ISSUE COMES ABOUT WHEN DEPRESSING BRAKE TO SHIFT FROM PARK TO DRIVE OR REVERSE. I AM AWARE OF THIS AND IT STILL HAPPENS SOMETIMES. SOMETIMES THE MOTOR REVS BUT VEHICLE WILL STAY STATIONARY. SOMETIMES THERE'S MORE PRESSURE ON ACCELERATOR THAN BRAKE PEDAL AND THE VEHICLE WILL LURCH FORWARD OR BACKWARD. THIS BEING AN XL MODEL, ITS NOT EQUIPPED WITH ADJUSTABLE PEDALS WHICH MAY SOLVE PROBLEM BUT AM UNCERTAIN OF THAT. IT SEEMS TO BE IDEAL VEHICLE EXCEPT FOR THESE TO ISSUES.

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT THE ENGINE FAILED TO FUNCTION PROPERLY AND THAT THE VEHICLE STALLED SEVERAL TIMES WITHOUT WARNING. THE SPARK PLUGS AN INJECTORS WERE REPLACED, AND AN OIL PRESSURE TEST WAS PROVIDED. THE CONTACT ALSO STATED THAT THE ENGINE MISFIRED AND WAS DIAGNOSED BY MCLARTY FORD (3232 SUMMERHILL RD, TEXARKANA, TX 75503, (903) 792-7121). THE VEHICLE WAS ALSO TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE AND TRANSMISSION NEEDED TO BE REPLACED. THE MECHANIC REBUILT THE TRANSMISSION AND THE STARTER WAS REPLACED. THE MANUFACTURER HAD NOT ISSUED A RECALL, BUT ISSUED EIGHT TSBS FOR THE ENGINE. THE CONTACT HEARD AN ABNORMAL NOISE COMING FROM THE ENGINE COMPARTMENT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED NO SOLUTION OTHER THAN HAVING THE VEHICLE REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 87,402. *TT *TR

ENGINE TICKING, FROM PRIOR REPORTS LOOKS TO BE A COMMON ISSUE, ALSO WHEN FILLING UP WITH GAS IT SEEMS TO HAVE BACK PRESSURE AND KEEPS TURNING THE PUMP OFF.

THE FRAM IS EAT UP ON MY TRUCK AND FORD WONT FIX IT AT ALLI CALL AND THEY KEEP GIVING ME THE RUN AROUND I THINK THAT THE TRUCK WILL BREAK INTO AND CAUSE A SERIOUS WRECK BECAUSE OF IT

I BOUGHT A 2007 FORD F15 FX4 TRUCK A YEARS AGO, AND TOOK IT TO FORD TO ASKED THEM ABOUT THE TICKING NOISE COMING FROM ENGINE. THEY TOLD ME THAT IT WAS NORMAL ON THE 5.4 TRITON. ABOUT A WEEK AGO THE TICKING GOT LOUDER AND I LOOKED UP PROBLEMS ONLINE, AND FOUND THAT THERE IS A DESIGN FLAW IN THE ENGINE THAT CAUSES CAM PHASERS TO FAIL, AND OIL PRESSURE DROPS TO ZERO. FORD KNOWS ABOUT THE PROBLEM, BUT WHEN I CALLED THEY TOLD ME THAT I NEED TO REPLACE THE ENGINE, AND THAT IT WOULD BE ON ME. I LOOKED ON SEVERAL FORD FORUMS AND FOUND THAT THERE ARE 1000'S OF PEOPLE TALKING ABOUT THIS. IS IT GOING TO TAKE SOMEONE GETTING KILLED BEFORE FORD OWNS UP TO THERE PROBLEMS! THEY ARE IGNORING THE ISSUE AND HAVING THE CONSUMER PAY AYWHERE FROM 3500- 8000 DOLLARS TO REPAIR THIS ISSUE. ALSO, THE ENGINE HAS VERY BAD POWER LOSS AND SHAKES VIGOURESLY WHEN WARM AND PULLING UP TO STOP OR REVERSE.

I WAS STOPPED AT A TRAFFIC LIGHT, WHEN THE LIGHT TURNED GREEN I GAVE THE TRUCK SOME GAS AND IT STARTED MAKING NOISE AND ACTED AS IF SOMETHING WAS ABOUT READY TO FLY APART AND SEVERLY VIBRATING. I HAD TO STOP AS QUICK AS POSSIBLE WITH CARS BEHIND ME SWERVING TO GET AROUND ME. I HAD TO CALL A TOW SERVICE TO GET MY TRUCK HOME, AFTER INSPECTION OF THE DRIVESHAFT I FOUND THAT THE CARRIER BEARING HAD SLIP OUT OF IT'S HOUSING AND THE DRIVESHAFT WAS BOUNCING AROUND IN THE BEARING BRACKET. I COULD NOT LOCATE A CARRIER BEARING ANYWHERE SO I CALLED THE FORD DEALERSHIP AND WAS TOLD I WOULD HAVE TO BUY AND REPLACE THE ENTIRE DRIVESHAFT. I DID SOME SEARCHES ON THE INTERNET AND FOUND THAT THIS HAS HAPPENED NUMEROUS TIMES. IF YOU INSPECT THE DRIVESHAFTS NOW BEING SOLD FOR REPLACEMENTS YOU WILL FIND THAT THERE HAVE BEEN DESIGN CHANGES MADE BUT FORD WON'T ADMIT THAT THEY HAD A DESIGN FLAW WITH THE ORIGINAL DRIVESHAFT. BY THE WAY, MY 2007 F150 ONLY HAS 32000 MILES ON IT, IT'S NOT A WEAR ISSUE.

THE DRIVESHAFT WIELDED PART TO THE TRUCK BROKE OFF

MY EXHAUST MANIFOLD STARTED LEAKING AROUND 70000 MILES. IT IS TO THE POINT NOW THAT I CAN'T EVEN DRIVE MY TRUCK. I BOUGHT IT USED AND IT STARTED ABOUT 2 YEARS AFTER I BOUGHT IT.

TAKATA RECALL....BACK DOOR LATCHES FAILED. CANNOT OPEN MANUALLY.

O/D OFF LIGHT , TRANSMISSION FAULT ON INFORMATION DISPLAY INTERMITTENT LIGHT AND TONE! TRUCK WOULD NOT START, PCM FAILURE $3500 DOLLARS IN REPAIR, AT FORD DEALER STILL NOT FIXED!

BLOWN OUT SPARK PLUG #3 CYLINDER, REPAIR LASTED LESS THAN 3 WEEKS AND FAILED ON STATE HIGHER 41 IN CALIFORNIA WITCH CAUSE MAJOR LOSS OF POWER GOING UPHILL AND STALLED IN THE MIDDLE OF TRAFFIC WITH MY WIFE AND CHILD IN THE VEHICLE. THE INCIDENT LEFT US WITH NO CHOICE BUT TO WALK ACROSS HEAVY TRAFFIC TO THE SIDE OF THE HIGHWAY AND LEAVE THE VEHICLE IN THE ROAD WAY

I BOUGHT TRUCK ABOUT 2 YEARS AGO TOOK TO FORD TO HAVE TRANNY FLUSH ON IT ASKED THEM ABOUT THE TICKING NOISE COMING FROM ENGINE THEY TOLD ME THAT IT WAS NORMAL ON THE 5.4 TRITON ABOUT A WEEK AGO THE TICKING GOT LOUDER AND LOOKED UP PROBLEMS AND FOUND THAT THERE IS A DESIGN FLAW IN ENGINE THAT CAUSES CAM PHASERS FAIL ND OIL PRESSURE DROPS TO ZERO FORD KNOWS ABOUT PROBLEM BUT WHN YOU CALL THEY TELL YOU THAT YOU NEED TO REPLACE THE ENGINE WELL LOOKED UP FORUMS AND PEOPLE WHO HAVE REPLACED THE MOTOR HAD SAME PROBLEMS WITH IT LATER ON YESTERDAY I WAS DRIVING TAKING MY 2 DAUGHTERS TO SCHOOL WHEN ALL OF A SUDDEN THE ENGINE SHUT OFF I LOST BRAKES AND STEERING. THE TRUCK BEHIND ME HAD TO LOCK UP ITS BRAKES TO KEEP FROM HITTING ME AND MY KIDS SO I AM WRITING YOU TO SEE IF YOU CAN LOOK INTO THIS MY KIDS WERE SO SCARED THE TRUCK SLOWED INSTANTLY WHEN THE ENGINE FAILED I HAD MY FRIEND TOW IT BACK TO MY HOUSE WHERE I CHECKED THE CAM SENSORS AND CHANGED THEM AND DID NOT START STILL DOES NOT START NOW THERE ARE 1000'S OF PEOPLE ON FORUMS TALKING ABOUT THIS IS IT GOING TO TAKE SOMEONE GETTING KILLED BEFORE FORD OWNS UP TO THERE PROBLEMS THEY ARE IGNORING AND HAVING THE CONSUMER PAY AYWHERE FROM 3500- 8000 DOLLARS TO REPAIR THIS I FIRST ASKED WHEN I BOUGHT TRUCK WITH 81,000 MILES ON IT

I BOUGHT THIS TRUCK JUNE 28 2010. ON 2-11-14 I TOOK IT TO FORD DEALER BECAUSE OF FRAME ROT AND WAS TOLD THEY COULD NOT COVER THE REPAIR. I HAD IT REPAIRED AT A WELDING SHOP. THE TRUCK FRAME IS NOW SO BAD THAT IT IS UNSAFE AND WILL NOT PASS INSPECTION. IT HAS SEPARATED AT FACTORY WELD. OBVIOUS MANUFACTURING DEFECT.

WHILE UNDER WARRANTY THE ROTORS BECAME WARPED. I TOOK THE TRUCK INTO THE DEALER AND THEY GROUND THE ROTORS WHICH MADE THEM THINNER AND MORE VULNERABLE TO WARPING WHICH OCCURRED IMMEDIATELY. FORD REFUSED TO REPLACE THE ROTORS. THE PADS WERE FINE INDICATING THAT THE PROBLEM WAS NOT AN OPERATOR PROBLEM. I TOOK THE TRUCK TO AN INDEPENDENT REPAIR SHOP WHERE THEY CONCLUDED THAT THE ROTORS WERE NOT SUFFICIENT FOR THE VEHICLE. THEY REPLACED THE ROTORS WITH A MORE SUBSTANTIAL ROTOR AT A COST OF $1400 AND I HAVE HAD NO PROBLEM SINCE.

STEERING BINDS SO TIGHTLY WHEN VEHICLE IS IN MOTION THAT IT TAKES SIGNIFICANT FORCE TO TURN WHEEL. ONCE WHEEL GETS PAST AND FREE OF THE BINDING POSITION IT TRAVELS TOO FAR CREATING A NEED FOR A STEERING CORRECTION. I BELIEVE THAT THE TWO PIECE STEERING SHAFT AND THE TWO UNIVERSAL JOINTS ARE WORN AND CAUSING THE PROBLEM. IT FEELS LIKE YOU HAVE LOST POWER STEERING, HOWEVER NOT THE CASE. AS THE POWER STEERING FLUID IS AT THE PROPER LEVEL. THERE ARE NO FLUID LEAKS, FORD HAS RECALLED EXPEDITIONS AND LINCOLNS FOR THIS ISSUE, WHY NOT THE F-150 PICKUP TRUCKS?

FILED A CLAIM WITH THE STATE OF CALIFORNIA BUREAU OF AUTOMOTIVE REPAIR ON 4-3-17, COMPLAINT # OC 2017005088, AGAINST FOUR ENTITIES INCLUDING: EL CAJON, CA FORD DEALER, CERTIFIED CAR CLINIC, FORD AUTOMOTIVE INC., AND DREW/PENSKE FORD REGARDING MY 2007 5.4 TRITON FORD F-150 TRUCK PLATINUM SPARK PLUG DEFECT. I WAS TOLD BY THE BAR THAT MY COMPLAINT WOULD BE FILED WITH YOUR AGENCY. I WOULD LIKE TO VERIFY IN WRITING THAT YOUR AGENCY HAS RECEIVED THE STATE OF CALIFORNIA BAR COMPLAINT.

I NEED REPLACE SPARKS PLUS NO VARY LIKE DO THEY SAID FORD F150 5.4 POSIBLE LOOS PICE INSIDE MOTOR

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 40 MPH, THE ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

FRAME IS COMPLETELY RUSTED THROUGH TO THE POINT THAT IT CANNOT BE REPAIRED AND IS UNSAFE. IT CANNOT PASS A STATE SAFETY INSPECTION AND HAS DETERIORATED TO THE POINT WHERE IT CANNOT EVEN BE PUT ON A LIFT BECAUSE IT HAS NO STRUCTURAL INTEGRITY. THERE ARE LARGE HOLES RUSTED THROUGH AND WHERE IT HASN'T ENTIRELY RUSTED THROUGH, THE METAL HAS DETERIORATED TO BEING LESS THAN HALF OF ITS ORIGINAL THICKNESS. THE PROBLEM WENT UNNOTICED BECAUSE THE REST OF THE TRUCK SHOWED NO SIGNS OF ANY ADVANCED DETERIORATION.

PICKED UP MY SON FROM SCHOOL AND WHILE DRIVING DOWN THE HIGHWAY AT 55MPH I HEARD A LOUD NOISE AND IT GOT REALLY LOUD . MY SPARK PLUG JUST BLEW OUT FOR NO REASON.

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING 45 MPH, THE VEHICLE DECELERATED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SPARK PLUGS AND THE COIL SPRINGS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE MANUFACTURER ADVISED THE CONTACT TO CALL NHTSA TO CHECK FOR ANY OPEN RECALLS. THE FAILURE MILEAGE WAS 88,000.

DURING SHIFTING ON STREETS AND HWY'S MY RPMS RAMP UP TO 3000-5000. I HAVE BEEN DRIVING WHILE MAINTAINING SPEED AND THEN THE RPMS WILL RAMP UP THEN THE SPEED STEADILY DROPS WHILE MY FOOT IS STILL ON THE ACCELERATOR. TURNING THE OVERDRIVE OFF SEEMS TO HELP OCCASIONALLY. I HAVE ALSO ATTEMPTED TO BRAKE AT LIGHTS AND THE RPMS WILL RAMP UP AND LURCH FORWARD ALMOST CAUSING ME TO REAR END OTHER VEHICLES. THIS IS A MAJOR SAFETY CONCERN AND I DONT UNDERSTAND WHY FORD HASN'T ISSUED A RECALL AND ADDRESSED THIS SAFETY HAZARD. MY O/D LIGHT OCCASIONALLY FLASHES AND WHEN IN "PARK" THEN PUTTING THE GEAR IN "REVERSE" IT WOULDN'T OPERATE AND WHERE MY DIGITAL MILEAGE IS SAID "TRANS FAULT". I TURNED THE VEHICLE OFF, THEN BACK ON AND THE O/D WAS OFF AND WAS ABLE TO BACK UP. NONE OF MY WARNING LIGHTS HAVE COME ON AT ALL. OCCASIONALLY AT A STOP SIGN WHEN I ATTEMPT TO ACCELERATE THERE'S A DELAY IN MOVEMENT. SPEED VARIES AT TIMES OF INCIDENTS.

SPARK PLUG BLEW OUT OF HEAD.

THE FUEL PUMP DRIVER MODULE, WHICH IS LOCATED EXTERNAL TO TANK MOUNTED ON FRAME, FAILED BECAUSE IT CORRODED THRU TO THE INSIDE OF UNIT. AT THE TIME OF FAILURE CAR WAS PARKED, BUT WHAT WOULD HAPPEN IF ON HIGHWAY AND FUEL PUMP STOPPED WORKING? FORD WOULD NOT REPLACE THE PART EVEN THOUGH THEY KNEW THERE WAS A PROBLEM BECAUSE IT WAS REDESIGNED WITH STAND-OFFS TO PREVENT DISSIMILAR METAL REACTION.

TRUCK WOULDN'T START. UPON FURTHER INSPECTION FOUND THE FUEL PUMP DRIVER MODULE FAILED DUE TO CORROSION. THE PART WAS BOLTED TO THE CROSS MEMBER ON THE BACK OF THE FRAME. THE BOTTOM OF THE PART IS ALUMINUM AND THE CROSS MEMBER IS STEEL, AND THEY WERE BOLTED FLUSH TOGETHER. REPLACED THE PART AND TRUCK WORKS FINE. I WOULD LIKE FORD TO ACKNOWLEDGE THAT THEY HAVE AN ISSUE WITH THIS AND REIMBURSE ALL PARTIES WHO HAVE HAD THIS PROBLEM.01

A SPARK PLUG BACKED OUT. STRIPPED THE THREADS IN THE HEAD. THIS HAPPENED WHILE DRIVING THE TRUCK. *TR

PUT TRUCK IN REVERSE, IT SPED UP AND BRAKES DID NOT WORK. STOPPED BY BACKING INTO A TREE, THEN DROVE FINE. THREE DAYS LATER CAME TO AN INTERSECTION AND WAS UNABLE TO STOP. HIT ANOTHER VEHICLE IN THE INTERSECTION.

TL* THE CONTACT OWNS A 2007 FORD F-150. AFTER THE CONTACT GRABBED THE SAFETY HANDLE ON THE DRIVER'S SIDE DOOR, IT DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT THE HANDLE DETACHED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 20 MPH, THERE WAS A KNOCKING NOISE COMING FROM THE ENGINE AND THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE NUMBER THREE SPARK PLUG DETACHED AND NEEDED TO BE REPLACED THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 102,890. UPDATED 08/09/17*LJ *CN

CRACKED OR WARPED EXHAUST MANIFOLD. I'VE HAD IT LOOKED AT BY TWO AUTO MECHANICS AND HAVE READ ONLINE WITH THIS WIDESPREAD PROBLEM.

WHILE DRIVING MY TRUCK SUDDENLY LOST POWER AND SHIFTED INTO "LIMP HOME MODE" WHILE THE WRENCH AND CHECK ENGINE LIGHT CAME ON. THIS HAPPENED TO ME A FEW YEAR BACK AS WELL SO I IMMEDIATELY ASSUMED IT WAS THE THROTTLE BODY OR SENSOR GOING BAD. I BROUGHT INTO THE FORD DEALERSHIP WHO CONFIRMED TO ME IT WAS THE THROTTLE BODY THAT WENT OUT. THIS IS NOW THE 3 THROTTLE BODY THAT MY TRUCK HAD HAD (9 YEARS OLD AND 130,000 MILES). AFTER DOING RESEARCH I SAW WHERE FORD HAD THIS SAME ISSUE WITH OTHER MODEL VEHICLES AND INSTEAD OF RECALLING EXTENDED WARRANTIES TO COVER THE COST OF REPLACEMENT. THIS IS EXTREMELY DANGEROUS AS IF IT OCCURS WHEN MERGING INTO TRAFFIC YOU LOSE ALL ABILITY TO ACCELERATE. I THINK FORD HAS A MAJOR ISSUE HERE THAT IT IS REFUSING TO ADDRESS.

WHILE DRIVING AT 35MPH OR LESS THE DRIVER SIDE FRONT HUB ASSEMBLY MAY EMIT AN INTERMITENT GRINDING NOISE AS IF THE HUB IS TRYING TO LOCK INTO FOUR WHEEL DRIVE. GRINDING NOISE STOPS WHEN VEHICLE IS SLOWED TO 15MPH OR LESS. SOMETIMES FULL STOP IS NEEDED TO CEASE GRINDING NOISE. WHEN NOISE STOP A JERK CAN BE FELT AS IF THE HUB LOCKS BACK INTO ITS PLACE. TOOK VEHICLE TO FORD DEALERSHIP AND THEY RECOMMENDED BRINGING VEHICLE IN WHEN GRINDING NOISE WAS PRESENT. THAT IS NOT POSSIBLE BECAUSE THE NOISE WILL STOP WHEN I SLOW DOWN. DEALERSHIP COULD NOT RECOMMEND ANY WAY TO DIAGNOSE IT WITHOUT PAYING TO HAVE IT INSPECTED. PROBLEM HAS NOT BEEN DIAGNOSED AND MANUFACTURER HAS NOT BEEN NOTIFIED. VEHICLE WAS BOUGHT 3 YEARS AGO AT 43K MILES AND HAS APPROX. 80K CURRENT MILES. NOISE IS INTERMITTENT WITH OCCAISIONAL LONG PERIODS BETWEEN OCCURENCES. CAN HAPPEN WITHIN 5 MILES OF DRIVING OR AFTER 500 MILES OF DRIVING.

TL* THE CONTACT OWNED A 2007 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE PASSENGER'S SIDE FRONT AXLE FRACTURED AND CAUSED THE WHEEL TO SEPARATE FROM THE VEHICLE. THE CONTACT STATED THAT THE AIR BAGS DEPLOYED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED BRUISES THAT DID NOT REQUIRE MEDICAL ATTENTION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 76,000. THE VEHICLE WAS DESTROYED.

ANOTHER INCIDENT OF A "DEATH WOBBLE" IN THE FRONT END. GOING DOWN THE HWY THERE IS A SIGNIFICANT WOBBLE. FRONT END OF TRUCK SHAKES DANGEROUSLY. SLOWING TO 20 MPH RESOLVES WOBBLE BUT HITTING A BUMP IN THE RD INITIATES THIS WOBBLE AGAIN. THIS WOBBLE HAS ACTUALLY CAUSED MY TRUCK TO PULL INTO ANOTHER LANE. I HAVE HAD THE ALIGNMENT CHECKED AS WELL AS NEW TIRES AND BALANCING. BALL JOINTS AND OTHER PARTS REPLACED. THIS IS A FACTORY ISSUE AND FORD HAS FAILED TO ADDRESS WITH OWNERS. DEATHS ARE A CERTAIN OUTCOME IF NOT FINALLY ADDRESSED. LATEST EPISODE WAS LAST NIGHT BUT HAS BEEN GOING ON FOR YEARS.

WHEN MY TRUCK IS AT OPERATING TEMP. AND COMING TO A STOP IT SOUNDS LIKE A DIESEL, IT FIRST STARTS BY KNOCKING AND TICKING THEN IT SHUTS DOWN.. THIS IS A SERIOUS PROBLEM FOR WHEN YOUR PULLING ANYTHING WITH THE TRUCK ALWAYS IT WANTS TO DIE, OF COURSE UNLESS YOUR GOOD AND CAN THROW IT INTO NEUTRAL AND REV THE MOTOR TO 2000 RPM'S WITH KILLING ANYONE. YOU START LOSING STEERING AND BRAKES WHEN THE MOTORS RPM'S GET VERY LOW.

TAKATA RECALL.ENGINE HAS VERY BAD POWER LOSS AND SHAKES VIGOURESLY WHEN WARM AND PULLING UP TO STOP OR REVERSE.

WHILE DRIVING AT SPEEDS OF 5 TO 15MPH WHEN THE BRAKE IS ENGAGED THE TRUCKS ENGINE WILL REV AND PULL THE TRUCK FORWARD. THE ONLY WAY TO STOP IS TO PUT IT IN N AND PUMP THE BRAKES, THIS WILL STOP THE ACCELERATION.

ACCELERATES WITHOUT NOTICE WHEN BRAKING SHIFTING ETC. VERY DANGEROUS AND FRUSTRATRING.

2007 FORD F-150 XLT WITH 5.4L TRITON V8,ENGINE BEGAN SHAKING VIOLENTLY WHILE AT STOP LIGHT, THEN HESITATED CONSISTENTLY WHILE ACCELERATING 40-50MPH, NO WARNING LIGHTS OR INDICATORS ON IN TRUCK. FORD DEALERSHIP REPLACED COIL I BELIEVE, JUST PURCHASED THE TRUCK USED AND DIDN'T GET ANY DOCUMENTATION WHEN THEY FIXED IT.

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 15 MPH, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND THE VEHICLE STARTED TO LOSE ACCELERATION AND POWER. THE CONTACT HAD TO PULL INTO A FUEL STATION. THE MECHANIC AT THE STATION DETERMINED THAT THE IGNITION COIL AND A SPARK PLUG FAILED AND NEEDED TO BE CHANGED. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED THREE OTHER TIMES AND WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 116,000.

I WAS IN AN ACCIDENT IN MY 2007 F150 AND ENDED HITTING A TELEPHONE POLE HEAD ON AND MY AIRBAG DID NOT COME OUT WHY DIDNT IT BECAUSE I TOTALED THE TRUCK EVEN THE POLICE WAS LIKE ME WHY I DIDNT COME OUT

WHEN AT A RED LIGHT OR STOP SIGN THE TRUCK SURGES THE RPM GAGE IS OUT OF CONTROL ALMOST SURGING ME INTO ONCOMING TRAFFIC THIS IS THE SECOND TIME THIS HAS HAPPEN IT ALSO HAPPENED IN 2015, TOOK IT TO THE SHOP AND IT COST ME 385.00 AND NOW A YESR LATER ITS HAPPENING AGAIN.

I BOUGHT THIS TRUCK IN 2015 HAD 120,000 MILES ON IT NOW PROBLEMS AFTER 5,000 MILES I NOTICED A KNOCKING IN THE ENGINE AND THE WHOLE TRUCK WILL BEGIN TO SHAKE AFTER A FEW MILES DOWN THE ROAD. THIS STARTED AT 125,000 MILES. I WOULD HAVE TO TURN THE TRUCK OFF AND TURN IT BACK ON, WHILE AT A STOP LIGHT. JUST RECENTLY MY WIFE AND I TOOK A TRIP OUT OF STATE WHILE ON THE HIGHWAY THE ENGINE STARED TO KNOCK AND TRUCK BEGAN TO SHAKE. I HAD TO PULL OVER TURN THE TRUCK OFF AND TURN IT BACK ON. HAVE TO DO THIS THREE TIMES ON OUR TRIP, NOT A HAPPY TRIP IN THE TRUCK. AFTER OUR TRIP THE I CALLED FORD MOTOR COMPANY AND TOLD THEM WHAT WAS HAPPENING WITH THE TRUCK THEY TOLD ME IT WAS NOT THERE PROBLEM AND WOULD NOT PAY TO HAVE IT FIXED. I TOOK MY TRUCK TO AN INDEPENDENT MECHANIC WHO TOLD ME THAT IT WAS THE CAM SENSOR OR CAM PHASOR. TO HAVE IT REPLACED WOULD COST ME $4,000. I TOOK THE TRUCK TO A FORD DEALERSHIP THAT TOLD ME THE SAME THING THE MECHANIC SAID AND THAT THEY WOULD CHARGE ME $2,000 TO REPLACE. THEY ALSO INFORMED THE THAT MOST OF THE 2007 F150 THAT COME ARE HAVING THE SAME PROBLEM. I HAVE LET IT SIT IN MY GARAGE TILL FORD DOES A RECALL. I AM NOT PAYING FOR THERE MISTAKE FOR SHODDY WORK.

FORD 150 PICK UP TRUCK REGULARLY MAINTAINED WITH 70,836 MILES WAS TRAVEL ON CITY STREETS AT SPEED LIMITS WHEN A "POPPING" SOUND WAS HEARD AND TRUCK WOULD NOT TRAVEL OVER 25MPH. NO CABIN LIGHTS, NO INDICATION OF PROBLEM. IMMEDIATELY TOOK TO AUTOMOTIVE CENTER, FOUND NO ERROR OR TROUBLE CODES ON DIAGNOSTIC EQUIPMENT AND ALL FLUID LEVELS WERE FULL AND CLEAN. AUTOMOTIVE CENTER DISCOVERED FAILED TRANSMISSION WITH PIECES OF METAL IN TRANSMISSION COOLER AND LINES DURING TRANSMISSION FLUSH USING FACTORY RECOMMENDED SOLUTION. FACTORY DEFECT OF TRANSMISSION, ENGINEERING DEFECT FOR LACK OF CABIN WARNING LIGHTS AND MAINTENANCE DIAGNOSTIC EQUIPMENT.

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING 40 MPH, THE CONTACT FELT A VIBRATION FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 99,000.

TL* THE CONTACT OWNS A 2007 FORD F-150 EQUIPPED WITH GENERAL GRABBER HTS TIRES, SIZE: 265/70R16 (NA). WHILE THE VEHICLE WAS PARKED, THE FRONT PASSENGER SIDE TIRE SUDDENLY BLEW OUT. THE VEHICLE WAS TOWED TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE TIRE WAS NOT REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE FAILURE MILEAGE WAS 49,000 AND THE TIRE FAILURE MILEAGE WAS 20. THE DOT NUMBER WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING AT VARIOUS SPEEDS, AN UNKNOWN SOUND WAS HEARD FROM THE ENGINE AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE CAMSHAFT FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. SOMETIME AFTER THE REPAIRS, WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STARTED TO VIBRATE SEVERELY. THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO ANOTHER INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 115,000.

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING 70 MPH, THE VEHICLE STALLED ON THE HIGHWAY WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED AFTER IT COOLED OFF. THE VEHICLE WAS DIAGNOSED BY AN INDEPENDENT MECHANIC WHO REPAIRED THE VARIABLE SPEED TIMING SOLENOID. THE REMEDY DID NOT REPAIR THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 1,334,000.

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE TRAVELING APPROXIMATELY 40 MPH, THE CONTACT SMELLED FUEL INSIDE THE VEHICLE. THE DEALER WAS NOTIFIED, BUT THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

SPARK PLUG BLEW OUT. MECHANIC REPLACED IT FOR $350 THEN IT BLEW OUT AGAIN 2 DAYS LATER. PROBLEM WITH FORD SPARK PLUG TEARING THREADS OUT AND NOT BEING ABLE TO REPLACE SPARK PLUG WITHOUT REPLACING ENTIRE ENGINE. MY SON WAS ON HIS WAY BACK TO COLLEGE (5HR DRIVE) WHEN THE SPARK PLUG BLEW. IT SOUNDED LIKE A SHOTGUN! HAD IT TOWED TO MECHANIC AND THEY REPLACED SPARK PLUG AND 2 DAYS LATER SAME ONE BLEW AGAIN WHILE DRIVING TO WORK. TOWED A SECOND TIME AND MECHANIC IS SEARCHING FOR WAYS TO RESOLVE. HE SAYS WE MAY HAVE TO REPLACE ENTIRE ENGINE BECAUSE OF THREADS BEING STRIPED WHEN IT BLEW OUT. FORD MECHANIC HAS LOOKED AT AND DOES NOT HAVE ANY SOLUTIONS. IN RESEARCHING ONLINE I HAVE DISCOVERED THAT THIS COULD HAVE POTENTIALLY BEEN VERY DANGEROUS. OTHERS WITH SAME PROBLEM HAVE HAD ENGINE FIRE WHEN SPARKPLUG BLEW. WE WERE IN PROCESS OF SELLING VEHICLE SO NOW WE ARE SOL! WE DON'T HAVE $4000 TO REPLACE ENGINE AND OUR FAMILY NEEDS A 2ND CAR. NEVER AGAIN WILL I BUY A FORD. THEY DO NOT STAND BEHIND THEIR PRODUCT!

2007 FORD F-150. CONSUMER WRITES IN REGARDS TO VEHICLE PASSENGER ASSIST HANDLE BROKE OFF. *SMD THE CONSUMER STATED HIS WIFE FELL WHILE ATTEMPTING TO ENTER THE FRONT PASSENGER SIDE OF THE VEHICLE. SHE WAS USING THE PASSENGER ASSIST HANDLE LOCATED AT THE POST BETWEEN THE DOOR AND THE WINDSHIELD. SHE HAD ONE FOOT ON THE RUNNING BOARD AND HAD JUST STARTED USING THE ASSIST HANDLE TO ENTER THE VEHICLE WHEN THE ASSIST HANDLE BROKE OFF AND SENT HER BACK FROM THE VEHICLE. FORTUNATELY, SHE STILL HAD ONE FOOT ON THE GROUND AND WAS ABLE TO CATCH HERSELF AND WAS NOT HURT. THE PART WAS REPLACED AT A COST OF $ 213.86. *JB

MY BRAKE LIGHT INDICATOR ON THE DASHBOARD IS COMING ON. THIS SEEMS TO BE DO TO THE FACT THAT THE RESISTORS WERE NOT SODERED CORRECTLY. I'VE BEEN LOOKING ON MULTIPLE FORMS AND THIS HAS HAPPENED TO A LOT OF THE F150'S. FORD SHOULD BE RESPONSIBLE FOR THSI.

POWER WINDOWS, RADIO, WIRE HARNESS IMPROPER DESIGN CAUSING SHORTAGE IN THE HARNESS. POTENTIAL SAFETY HARNESS DUE TO THIS MANUFACTURING DEFECT.

DRIVING ALONG, ABOUT 35MPH, STOPPED VEHICLE AT TRAFFIC LIGHT, ENGINE STARTED REVVING, PLACED BOTH FEET ON BRAKE, TRIED SHIFTING TO NEUTRAL, PROBLEM GOT WORSE (REVVED HIGHER), LIGHT TURNED GREEN, LET GO OF BRAKE, ENGINE REVVED AND VEHICLE WENT TO 45MPH WITHOUT ACCELERATING, APPLIED BRAKE, PULLED OVER, SHUT OFF ENGINE, RESTARTED ENGINE, STILL REVVING, PULLED BACK ON GAS PEDAL WITH FOOT, ENGINE RPMS FINALLY DROPPED TO NORMAL, INSPECTED FLOOR AREA -FOUND NO OBSTRUCTIONS NOR DEBRIS IN PEDAL. ALSO CONCERNED THAT THIS MAY HAVE HAPPENED ONCE BEFORE ABOUT 2 YEARS AGO, WHEN I WAS INVOLVED IN AN ACCIDENT.

TL* THE CONTACT OWNS A 2007 F-150. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH AND COMING TO A STOP LIGHT, THE VEHICLE STALLED AND THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE ENGINE FAILED AND THE MOTOR NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 123,000.

WHILE ATTEMPTING TO TURN LEFT (ACROSS ONCOMING TRAFFIC LANES) THE STEERING WHEEL SEIZED AFTER ROTATING ONLY A FEW DEGREES. THIS WAS SUDDEN AND ABRUPT WITH NO PRIOR SYMPTOMS. SUBSTANTIAL FORCE WAS APPLIED IN AN ATTEMPT TO CONTINUE THE TURN. THE STEERING WHEEL BECAME FREE AND ROTATED A FEW MORE DEGREES BEFORE SEIZING AGAIN. AS BEFORE, SUBSTANTIAL PRESSURE WAS APPLIED AND I BELIEVE SOME BACK ROTATION (WIGGLING) WAS INPUT. THE STEERING FINALLY BECAME FREE AND FELT NORMAL. THIS DID NOT REPEAT AGAIN DURING THE USE OF THE VEHICLE THAT DAY. THE SEIZURE DID NOT FEEL LIKE A FAILURE OF THE STEERING ASSIST (PUMP) SYSTEM AS THE STEERING WHEEL COULD NOT BE ROTATED AS IT CAN BE IF THE STEERING PUMP ISN'T RUNNING. SOME RESEARCH FOUND REFERENCE TO BINDING OF THE U-JOINTS ON THE INTERMEDIATE STEERING SHAFT LOCATED IN THE ENGINE COMPARTMENT. EXAMINATION OF THESE JOINTS FOUND THAT THEY ARE NOT PROTECTED BY RUBBER BOOTS AND SHOWED EVIDENCE OF CORROSION. A SPRAY LUBRICANT WAS USED IN AN ATTEMPT TO PREVENT THE ISSUE FROM RECURRING. THE INABILITY TO STEER THE VEHICLE IS, IN MY OPINION, A SUBSTANTIAL SAFETY ISSUE. ANY NUMBER OF SCENARIOS COULD BE IMAGINED, BUT IN MY PARTICULAR CASE, HAD THE SEIZURE NOT RELEASED, I WOULD HAVE FOUND MYSELF STOPPED IN THE PATH OF ONCOMING TRAFFIC WITH THE VEHICLE ONLY PARTIALLY TURNED.

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT 40 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER WITHOUT WARNING. THE CONTACT INSPECTED THE VEHICLE AND DETERMINED THAT THE STEERING SHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 77,000.

ENGINE WAS REPLACED IN 2011 UNDER WARRANTY AT 51,864 MILES. NOW AT 105,662 THIS ENGINE IS DOING THE SAME THING. THERE IS DEFIANTLY A PROBLEM WITH THE ENGINES. FORD NEEDS TO RECOGNIZE AND ACKNOWLEDGE AND FIX THIS ISSUE WITH THEIR PRODUCT. IF YOUR ENGINE DOES NOT WORK CORRECTLY, HOW CAN YOUR FORD BE - FORD TOUGH!

THE COIL SPRING ON THE DRIVER'S SIDE STRUT BROKE WHICH APPEARS TO BE A WELL DOCUMENTED RELIABILITY PROBLEM ON THE F150 TRUCKS. THE MECHANIC SAID THAT THIS FAILURE ALWAYS HAPPENS ON THE DRIVERS SIDE AND THE SPRING BREAKAGE IS ALWAYS IN THE SAME SPOT. THE ID TAG ON THE PART WAS U 4L34 5310- BUT THE REST WAS NOT LEGIBLE.

THE THREADS IN MY 07 FORD F 150 FOR MY SPARK PLUG IN ONE OF MY CYLINDER'S WENT BAD. AND MY PLUG LEAKED HIGH PRESSURE COMPRESSED HEATED EXHAUST. CAUSING MY IGNITION COIL TO PARTIALLY MELT. ITS RIGHT BELOW THE FUEL RAIL SENSOR TOO. ITS THE BIGGEST PAIN IN THE BUTT TO FIX. USED A HELICOIL. DIDN'T LAST TOO LONG. TRYING A MORE PERMANENT FIX NEXT. I WAS ON THE HIGHWAY GOING 70 WHEN THE PLUG BEGAN A VERY NOTICEABLY LOUD RHYTHMIC LEAK WITH THE IGNITION OF THAT CYLINDER. ALSO, WHEN I SAW THE PROBLEM WHEN I LOOKED AT THE SPARK PLUG. IT HAD ALREADY HAD AN EXISTING HELICOIL PUT IN. AND YOU COULD TELL THIS HAPPEND WAY BEFORE 200K MILES. BECAUSE THE OLD SPARK PLUG WAS WORN ALMOST ALL THE WAY DOWN. I STILL HAVE THE OLD SPARK PLUG.

SHIFTER WON'T COME OUT OF PARKING. I HAVE RESEARCHED AND MANY PEOPLE HAVE REPORTED THE SAME ISSUE WITH FORD F150. SERVICE MANAGER SAID SHIFTER SENSOR WAS NOT WORKING.

IN APRIL 2015 I BEGAN EXPERIENCING ENGINE KNOCKING ON MY 2007 FORD F-150 WHICH HAD 57,532 MILES ON IT. I TOOK IT TO FORD SERVICE DEPARTMENT AND ENDED UP SPENDING $3,080.79 TO REPLACE CAMSHAFT, SOLENOID, AND TIMING CHAINS. I WAS TOLD THIS WORK WAS GUARANTEED. NOW, LESS THAN 7 MONTHS LATER AT 61,452 MILES I BEGAN HEARING SQUEAKING AS I DRIVE. TOOK IT BACK TO FORD AND THEY TELL ME IT IS NOW THE HARMONIC BALANCER IS OUT AND EXCESSIVE CRANK SHAFT END PLAY. I AM TOLD THAT THE ISSUE IS NOT RELATED TO THE PRIOR REPAIR WORK SO I WILL HAVE TO SPEND ANOTHER $3,000 OR MORE TO FIX THIS ISSUE. THIS IS ALL AFTER I SPENT OVER $300 IN DECEMBER 2014 TO REPLACE THE INGNITION COILS. I DRIVE MOSTLY CITY DRIVING. WE PICKED UP VEHICLE WITHOUT REPAIRING IT THIS TIME SO WE COULD FIGURE OUT WHAT TO DO.

VEHICLE HAS STARTED TO JERK AROUND 40-50 MPH. REVIEWS STATES THE SPARK PLUGS AND COILS ARE THE ISSUES. WANTED TO CHANGE OUT SPARK PLUGS, BUT UNDERSTAND THE PLUGS BREAKS UPON REMOVAL AND VERY EXPENSIVE TO FIX. KNOW ISSUE BY FORD MOTOR COMPANY. NOW I DON'T EVEN WANT TO ATTEMPT CHANGING OUT THE PLUGS. THIS ISSUE SHOULD BE RECALL OR PAID BY FORD FOR REPLACEMENT, SINCE THIS ISSUE IS KNOW BY FORD. ISSUE IS STILL ONGOING, HELP, DON'T WANT TO PAY $1000 FOR A SIMPLY MAINTENANCE.

I HAVE HAD SEVERAL ELECTRICAL FAILURES ON THIS VEHICLE AFTER BUYING IT NEW IN OCTOBER 2007, IN OCTOBER 2009 THE CIGARETTE LIGHTER STOPPED WORKING WAS REPAIRED AND AGAIN MONTHS LATER STOPPED WORKING. THE WINDOWS STOPPED WORKING A TOTAL OF SIX TIMES WITH THREE OF THOSE BEING THIS YEAR. I HAVE TAKEN MY CAR IN TO BE REPAIRED A TOTAL OF THREE TIMES THIS YEAR ALONE AND THE LAST TIME , ABOUT FOUR OR FIVE WEEKS AGO I INSTRUCTED THE WORKER TO JUST LET THE WINDOWS UP AND DISCONNECT THEM AFTER BEING TOLD THAT I NEEDED A COMPLETE NEW WIRING HARNESS WHICH WERE NO LONGER AVAILABLE. I WAS TOLD THAT THE WIRING WAS BRITTLE AND THAT THIS WAS A COMMON PROBLEM WITH THE F 150. I FEEL THAT THIS COULD POSE A DANGER IN AN EMERGENCY ESCAPE SITUATION AS WELL AS OTHER PROBLEMS. THIS PROBLEM ALSO INVOLVE THE ELECTRONIC LOCKING SYSTEM WHICH IS A GREAT SAFETY HAZARD, I CAN GET NO REAL RESPONSE FROM FORD.

I'VE HAD THE SPARK PLUG BLOW OUT IN CYLINDER 6 TWICE WHILE DRIVING AT ABOUT 55MPH. MY HUSBAND HAD HIS IN 2008 F150 ALSO. I'VE HAD TO HAVE THE PLUGS REPLACED 2X. JUST WAITING FOR THE FUEL MODULE AND STEERING TO GO AS NOTED IN OTHER NUMEROUS COMPLAINTS.

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING 55 MPH, THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CAM PHASERS FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 132,000.

THE FAILURES STEM FROM BAD OIL FLOW TO THE TOP END OF THE ENGINE DUE TO A FLAW IN DESIGN. SPECIFICALLY MY CAMSHAFT, CAM PHASER, TIMING COMPONENTS AND LIFTERS ROLLERS HAVE FAILED. THE PROBLEM FIRST SHOWED UP AT 42256 MILES AND HAS SINCE RESURFACED TWICE EVEN AFTER EXPENSIVE REPAIRS. THE WORRISOME PART IS THAT THE WEB IS FILLED WITH THOUSANDS UPON THOUSANDS OF SIMILAR COMPLAINTS ABOUT THIS ENGINE WHICH IS ALSO IN EXPEDITIONS AND CROWN VICTORIAS AND PROBABLY OTHER FORD VEHICLES.

BOUGHT THE T07 F150 AT 28K AND AT 61K THIS HAPPENED. WHILE DRIVING AT LOW GEAR 2ND THE ENGING CHUGGED A LITTLE ( LKE AN OLD DIESAL) TOOK IT TO THE DEALER THEY SAID IT WAS PROBABLY THE SMALL OIL SEAL BEHIND THE CAM. THEY WAS GOING TO CHARGE BE 5600 FOR A NEW ENGINE. THEY TRIED LIKE HE11 TO GET ME TO SAY I DIDNT HAVE THE OIL CHANGED REGULARLY. I NEVER BACKED DOWN, THEN REMINDED THEM THAT I HAD BOUGHT THE $2700.00 EXTENDED WARRENTY (WHICH I USUALLY NEVER DID) THEY BAUKED AND CRIED. BUY SAID THAT THEY WOULD FIND ANOTHER USED ENGINE, THEY CALLED ME AND SAID THAT THEY FOUND ONE FOR 3500 (OR SOMETHING LIKE THAT) I BEGAN A LONG SEARCH ONLINE AND FOUND A REBUILD FOR LESS AND GAVE THEM THE INFORMATION. THEY DECIDED TO GO WITH THAT. THEY ORDERED THE ENGINE AND INSTALLED IT ( WELL WHAT DO YOU KNOW THE REPLACEMENT HAD THE SAME PROB) THEY HAD TO PULL THAT ENGINE AND GET ANOTHER FROM THE COMPANY . TOOK AN EXTRA WEEK AND GOT THE TRUCK BACK ITS NOW AT 100K AND STILL RUNS WELL (SO I KNOW IT WASNT MY DRIVING) SO IT HAD TO BE THE INCORRECT PLACEMENT OF THAT SEAL FROM THE DEALER, WHICH WOULD LEAKED HOT OIL ONTO THE ENGINE AND CAUSE A FIRE. I LOOKED AT THE ORIGIONAL PAPER WORK THAT THEY HAD TO REPLACE TH ORIGIONAL WIRING HARNESS BEFORE IT EVEN LEFT THE FACTORY.

WHILE ACCELERATING TO ENTER THE HIGHWAY A LOUD POP SOUND WAS HEARD AND THE ENGINE LOST POWER. I HAD ENOUGH SPEED TO MAKE THE BREAK-DOWN LANE. THE SOUND WAS COMING FROM THE #3 CYLINDER ON THE RIGHT SIDE OF THE MOTOR. 4.6L V8. THESE WERE FACTORY PLUGS AND THE VEHICLE IS MAINTAINED EVERY 3000-5000 MILES.

VEHICLE HAS STOPPED RUNNING GOING DOWN THE ROAD SEVERAL TIMES. IT DOES THIS UNEXPECTEDLY, AND I LET IT COAST TO THE SHOULDER AND IT CRANKS UP. I DROVE IT TO THE LOCAL DEALER, AND THEY COULD NOT FIND A PROBLEM. IT NOW SITS IN MY DRIVEWAY, BECAUSE IT IS UNSAFE TO DRIVE IT IN TRAFFIC. I NEVER INTEND TO BUY ANOTHER FORD.

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE PARKED, THE VEHICLE FAILED TO START. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED; HOWEVER, THE TECHNICIAN STATED THAT THE FUEL DRIVER MODULE WAS CORRODED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000. MA 08/14/15 UPDATED 10/19/2017*CN

UPON SPEEDING UP FROM A STOP THE VEHICLE STUTTERED AND STALLED. I COASTED TO A PARKING LOT AND TRIED TO RESTART. THE ENGINE WOULD CRANK BUT NO ATTEMPT TO START. AFTER SEVERAL TRIES I STOPPED. UPON CHECKING INTERNET FOR PROBLEMS DISCOVERED MANY COMPLAINTS ABOUT THE FUEL PUMP DRIVER MODULE RUSTING AND FAILING SUDDENLY. I CHECKED MODULE AND IT WAS RUSTED THROUGH. I REPLACED MODULE AND TRUCK NOW RUNS FINE. I NOTICED THAT THE MOUNTING BOLTS HAVE CHANGED ALLOWING SPACE BETWEEN MODULE AND CROSS MEMBER. OBVIOUSLY THIS IS AN ISSUE AS THE PART MOUNT HAS CHANGED. IF THIS SUDDEN FAILURE WOULD HAVE OCCURRED AT HIGH SPEED SERIOUS PROBLEMS MAY HAVE RESULTED. THIS IS A FORD ISSUE IN DESIGN THAT SHOULD BE ADDRESSED AND FIXED BY FORD.

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 3 MPH, THE CONTACT HEARD AN ABNORMAL NOISE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED THE DRIVESHAFT WAS FRACTURED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DRIVESHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 99,000.

THE ENGINE WAS REPLACED IN 2012 WITH 53,000 MILES ON THE TRUCK DUE TO A SIGNIFICANT KNOCKING COMING FROM THE ENGINE. THE TRUCK WAS STILL UNDER WARRANTY SO IT COST ME NOTHING TO REPLACE. THE ENGINE STARTED TO MAKE THE SAME SOUND IN FEB 2015 (84,000 MILES ON THE TRUCK, 30,000 MILES ON THE ENGINE). I HAD IT TAKEN TO AN AUTO MECH AND THEY TOLD ME ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE AND RIPPED ALL THE THREADING OUT. THEY ALSO FOUND THAT ON E OF THE CYLINDERS BROKE OFF THE CRANK SHAFT AND CEASED. THE ENGINE HAS TO BE REPLACED AGAIN AND THE TRUCK IS NO LONGER UNDER WARRANTY. BOTH THE ORIGINAL DEALERSHIP THAT REPLACED THE ENGINE AND THE AUTO MECH THAT I HAD THE TRUCK TAKEN TO, ARE RESEARCHING IF THE PARTS ARE STILL UNDER WARRANTY.

WENT TO HAVE TRUCK TUNED UP--MECHANIC WOULD NOT EVEN TOUCH SPARK PLUGS BECAUSE THEY BREAK OFF AND THE ENTIRE HEAD HAS TO BE REMOVED FOR REPAIR. TOLD US TUNE UP WOULD BE VERY EXPENSIVE AND IF THEY BROKE IT WOULD BE EVEN HIGH. FROM WHAT I WAS TOLD IF SPARK PLUG IS BAD IT CAN RESULT IN FAILURE OF CATALYTIC CONVERT AND RESULT IN A CAR FIRE. WILL IT TAKE A DEATH BEFORE FORD DOES A RECALL HOW DO CONSUMERS MAINTAIN A VEHICLE WHEN AND AUTHORIZED MECHANIC WILL NOT DO THE WORK. *TR

BROKEN WIRES IN THE WIRING HARNESS GOING TO THE DRIVER'S DOOR. CAUSES AUTOMATIC WINDOWS TO NOT BE ABLE TO ROLL DOWN, RADIO DOES NOT TURN OFF WHEN KEY IS OFF AND DOOR IS OPEN, KEYLESS ENTRY KEYPAD DOESN'T WORK, FOLDING MIRRORS DO NOT WORK. *TR

POWER WINDOWS STOPPED WORKING ENTIRELY. AT ALL SWITCHES. NO POWER TO THEM. WIRES IN DOOR JAM FOR POWER WINDOWS RUBBED TILL THEY BROKE. LEAVING NO POWER TO ANY WINDOW AT ANY SWITCH. COST $ 370.00 FOR FORD TO DIAGNOSE AND FIX BROKEN WIRES RIGHT WHERE MECHANIC KNEW THEY WERE BROKE BEFORE LOOKING.. THIS IS A RECURRING PROBLEM IN THESE TRUCKS AND FORD SHOULD OWN UP TO IT AND FIX THEM FREE OF CHARGE. I HAVE ALWAYS OWNED FORDS BUT AFTER THIS EPISODE WITH THE DEALERSHIP. NOT TO HAPPY......CHECKED INTERNET. MANY REPORTS OF THIS EXACTLY AS IT HAPPENED AND IN SAME AREA OF VEHICLE..HAVE SEEN MANY COMPLAINTS SAME PROBLEM, SAME FIX, SAME PLACE, SIMILAR COSTS TO CUSTOMER...NOT RIGHT. FORD IS FULLY AWARE OF THIS AND DOESN'T CARE. COULD HAVE CAUSED A FIRE. HAD A BURNT SMELL. *TR

TL*THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT AFTER ACCELERATING AT APPROXIMATELY 5 MPH, THE VEHICLE STALLED AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 59,000.

TRUCK JERKS AND JUMPS BECAUSE THE CYLINDERS AREN'T FIRING. JUST SPENT $1000 FOR NEW PLUGS A FEW MONTHS AGO. I HAVE HAD TO REPLACE SEVERAL COILS IN THE LAST 3 YEARS. PROBLEMS STARTED AROUND 100K MILES. *TR

TL* THE CONTACT OWNED A 2007 FORD F-150. THE CONTACT STATED THAT WHILE ATTEMPTING TO START THE VEHICLE, THE ENGINE EXPLODED AND CAUGHT FIRE. THE INSURANCE COMPANY INSPECTED THE VEHICLE AND FOUND THAT THE FIRE INITIATED AT THE MOTOR HELI COIL. WHEN FUEL PENETRATED THE HELI COIL, MOTOR, AND SPARK PLUGS, IT CAUSED THE ENGINE TO EXPLODE. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE CONTACT SUFFERED BURNS AND CUTS TO THE LEFT HAND. THE FAILURE MILEAGE WAS 125,000.

WHILE DRIVING ON A NEW YORK INTERSTATE AT APPROXIMATELY 60 MPH IN A SNOW STORM, MY TRUCK STARTED TO MISS. IT THEN SLOWED DOWN AND SHUT OFF. I DID NOT HAVE ENOUGH TIME TO MAKE IT TO THE SIDE OF THE ROAD. A TRUCK STOPPED AND I HAD HIM PUSH MY TRUCK TO THE SIDE OF THE ROAD, CAUSING ME TO HAVE DAMAGE TO MY TRUCK. FOUND OUT THAT THE FUEL PUMP DRIVER MODULE FAILED. IT IS LOCATED ABOVE THE SPARE TIRE AND DUE TO A DESIGN ERROR, WATER AND ROAD SALT GET TRAPPED BETWEEN MODULE AND MOUNTING BRACE. IT ERODES OUT FROM THE BOTTOM SIDE AND THE MOUNTING BRACKET. WHEN REPLACED, WAS INFORMED THAT IT IS A REDESIGNED COMPONENT, LIFTING IT AWAY FROM MOUNTING BRACKET. IF I HAD NOT HAD ENOUGH ROOM BETWEEN ME AND THE TRACTOR TRAILER TRAVELING BEHIND ME, OR IF I HAD ANOTHER VEHICLE TRAVELING NEXT TO ME, IT COULD BE A TOTAL DIFFERENT OUTCOME. I KNOW FOR A FACT, THAT PART COMPONENT IS EXTENDED IN STATES WHERE THERE IS A HIGH RISK OF SALT CORROSION, AND BELIEVE THAT A SAFETY ISSUE LIKE THIS SHOULD BE ONE OF THEM. SITTING ON A HIGHWAY IN A SNOW STORM IS ALWAYS DANGEROUS. *TR

OVER THE PAST SIX WEEKS, I HAVE ENCOUNTERED THREE EVENTS IN WHICH MY VEHICLE WAS ACCELERATING WHILE I HAD MY FOOT ON THE BRAKE. THE FIRST TIME, THE TRUCK WAS ATTEMPTING TO PULL FORWARD, VIBRATING, AND REVVING THE ENGINE WHILE I WAS STOPPED AT A LIGHT .I THOUGHT IT WAS A FLUKE OR AN ERROR ON MY PART AND DISREGARDED IT. THE SECOND AND THIRD TIME, I WAS TRYING TO SLOW DOWN FOR THE LIGHT WITH VEHICLES AHEAD OF ME. INSTEAD OF STOPPING AS I WAS DEPRESSING THE BRAKE, THE ENGINE BEGAN TO REV AND PULL FORWARD. I DEPRESSED MY BRAKES TO FLOOR AND THE TRUCK STOPPED BUT THE ENGINE CONTINUED TO REV AND ATTEMPT TO PULL FORWARD WITH THE BRAKE ON. FORD COMPANY AND MY DEALERSHIP, OF COURSE, DENIED ANY PROBLEMS EVEN AFTER I CITED SEVERAL CASES IN WHICH THIS OCCURRED WITH OTHER CARS. THEY SAID SOMETIMES SENSORS GO OUT AND THEY SHOULD NOT BE RESPONSIBLE FOR IT BUT WERE HAPPY TO DO A DIAGNOSIS FOR $100. I SEE SEVERAL COMPLAINTS REGARDING THE ELECTRONIC THROTTLE CONTROL SYSTEMS COMPARED TO THE NEW BRAKE OVERRIDE SYSTEMS AND AM TOTALLY UNNERVED THAT FORD WILL NOT TAKE RESPONSIBILITY FOR THIS. I AM CONCERNED ABOUT DRIVING THE TRUCK WITH ONLY 45,000 MILES ON IT. I FEAR THAT ANY MOMENT, MY TRUCK IS GOING TO ACCELERATE INTO ANOTHER VEHICLE WHILE MY FOOT IS ON THE BRAKE. I WILL NEVER BUY A FORD AGAIN--A TOTAL DISREGARD FOR CONSUMER SAFETY. *TR

TL*THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE DECELERATED AS THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE CAMSHAFT PHASER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.

CAB CORNER RUST OUT ROCK PALL RUST OUT WHEN I PAY 38000 GRAND FOR A TRUCK NEW OFF THE LOT NOW WITH 30000 MILES SHOULD NOT BE THAT MUCH RUST COME TO FIND OUT ON THE BACK OF THE CAB CORNER THERE A GAP WHERE WATER LEAK IN TO THE ROCKER AND THE WATER LAYS IN THERE AND RUST OUT THE BOTTOM OF THE DOOR AND HOW HARD WOULD OF BEEN TO RUN A BEAD OF SEAM SEALER FOR WATER COULD OF GOT DOWN IN THERE. *TR

3 OUT OF 8 SPARK PLUGS HAVE BLOWN OUT OF HEAD IH MOTOR. THIS SEEMS TO BE A COMMON PROBLEM AFTER RESEARCHING SEVERAL OTHER MAKES AND MODELS OF ALL FORD VEHICLES. I HAVE SEARCHED FOR RECALL INFORMATION FROM FAULTY DESIGN WITH NO LUCK. *TR

TRUCK WOULDN'T START. HAD TO BE TOWED TO DEALER. PROBLEM WAS CORRODED FUEL PUMP DRIVER MODULE. NEW PART COST $195.07 AND LABOR WAS $285.00. GOING ON LINE TO SEE WHAT WAS DONE, THE LABOR CHARGES SEEM VERY EXCESSIVE! THIS ISSUE LOOKS TO BE VERY WIDESPREAD AND SHOULD BE A RECALL BY FORD. *TR

I WAS STOPPED AT A STOP SIGN AND THE OTHER DRIVER RAN A STOP SIGN AT 55 MPH AND HIT ME ON THE PASSENGER SIDE FRONT FENDER AND MY AIR BAGS NEVER WENT OFF. I HAVE HAD TO GO TO THE HOSPITAL WITH HURT SHOULDER AND BACK AND BRUISED KIDNEYS FRACTURED RIBS AND BRUISED LIVER AND MY ORGANS SWOLLEN AND A DISPLACED HIP. I AM STILL TRYING TO RECOVER FROM THE MAJOR SOFT TISSUE DAMAGE AND THE TRUCK WAS A TOTAL LOSS. *TR

TL* THE CONTACT OWNED A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 99 MPH, THE VEHICLE STRUCK AN EMBANKMENT AND ROLLED OVER TWO AND A HALF TIMES. THE AIR BAGS DID NOT DEPLOY. THE DRIVER WAS WEARING A SEAT BELT; HOWEVER, HE WAS EJECTED FROM THE VEHICLE THROUGH THE REAR DRIVER SIDE WINDOW. THE DRIVER SUSTAINED FATAL INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 64,000. THE VIN WAS UNAVAILABLE.

WHILE DRIVING ON THE FREEWAY AT 75MPH A WARNING LIGHT CAME ON SAYING TRANSMISSION FAULT. THE OVERDRIVE LIGHT WAS FLASHING. THE TRUCK CONTINUED TO DRIVE NORMALLY BUT THE WARNING INDICATORS KEPT GOING ON. THERE WERE NO CODES WHEN IT WAS TAKEN TO THE SHOP ALTHOUGH THE SHOP SAID THEY HAVE A RETAINING CLIP THAT WEARS OUT AND CAUSES ALL THE PARTS TO SHIFT. THIS RESULTED IN HAVING TO REPLACE THE TRANSMISSION. FORD NEEDS TO RECALL THE DEFECTIVE PARTS. MANY OTHER F 150 OWNERS HAVE HAD THE SAME PROBLEM. TRANSMISSION REPLACEMENT COST MORE THAN I BOUGHT THE TRUCK FOR! *TR

HANKOOK DYNAPRO AS P235-70-R17S TIRE WITH APPROXIMATELY 60% WEAR (ACCORDING TO FORD DEALERSHIP WHERE VEHICLE WAS PURCHASED AND TIRES REPLACED). DURING NORMAL DRIVING NOTICED ABNORMAL BUMPING THAT APPEARED TO BE ASSOCIATED WITH TIRE OR FRONT END. TOOK VEHICLE TO SHOP TO CHECK BALANCE AND WHEEL ALIGNMENT. TECH FOUND THE ABOVE DESCRIBED TIRE HAD SEPARATED AND THE STEEL BELTING WAS PROTRUDING THROUGH THE TREAD AND TOP OF SIDEWALL. TIRE WAS ABOUT TO FAIL. DRIVER CONTACTED HANKOOK AND FORWARDED A PHOTOGRAPH OF THE TIRE TO THE REPRESENTATIVE. HANKOOK AGREED TO A 40% REFUND OF THE AMOUNT THAT FORD PAID (NOT WHAT I PAID) FOR THE TIRE IF I WOULD RETURN THE TIRE OR A PIECE FROM IT CONTAINING THE DOT NUMBER. FORD TOOK THE TIRE FOR RETURN TO HANKOOK. THREE WEEKS HAVE PASSED AND I HAVE NOT HEARD BACK FROM FORD OR HANKOOK. *TR

STARTED TO ACCELERATE OUT OF A PARKING LOT AND HEARD A LOUD THUMPING SO I PULLED OVER GOT OUT LOOKED AT THE DRIVESHAFT SEEN IT HAD SLID BACK. A BIT OUT OF THE TRANSMISSION ALSO OUT OF THE CARRIER BEARING. *TR

GEAR SLIPPED OUT OF PARK AS I WAS EXITING VEHICLE. I HAD NOT YET CLOSED THE DOOR AND THE TRUCK BEGAN TO MOVE DOWN THE DRIVEWAY. I WAS CAUGHT BY THE DOOR AND DRAGGED ALONG UNTIL THE DOOR THREW ME TO THE GROUND, INJURING MY BACK. THE TRUCK CAME TO REST ON BOTH OF MY LEGS. I WAS ABLE TO PULL OUT MY LEFT LEG EASILY RESULTING IN JUST A FEW CUTS, SCRAPES AND PARTIAL BLACK AND BLUE SPOTS. WOUNDS ALL HEELED THEMSELVES. HOWEVER MY RIGHT WAS THOROUGHLY PINNED AND I HAD TO PULL LONG AND HARD TO REMOVE IT FROM UNDER THE TIRE RESULTING IN LOST FLESH AT MY ANKLE BONE TO RIGHT BELOW MY KNEE AND ABOUT 4 TO 5 INCHES WIDE. *TR

DRIVING ON A POSTED 40 MPH COUNTY ROAD APPROACHING A STOP SIGN. THE VEHICLE MADE A LOUD NOISE FROM THE ENGINE COMPARTMENT AND LOST 80% POWER. TOOK IT TO A LOCAL MECHANIC AND THEY EXPLAINED THAT THE SPARK PLUG(S) WERE BAD AND THE TUNE UP WOULD BE $500-$800 DEPENDING ON "IF" ONE OR ALL OF THEM BROKE DURING REMOVAL. ONE HAD ALREADY BLOWN OUT DURING AFOREMENTIONED INCIDENT. I UNDERSTAND THAT THIS WAS A PROBLEM FOR A LOT OF FORD VEHICLES DURING THE YEARS 2004 THRU 2008. I BELIEVE THIS SHOULD HAVE BEEN A RECALL REPAIR. THANK YOU. *TR

WATER LEAKING FROM INTAKE MANIFOLD COOLANT CROSSOVER LINE. CROSSOVER IS AN ALUMINUM PIPE THAT CONNECTS TO THE PLASTIC INTAKE MANIFOLD. WHEN MANIFOLD STARTED LEAKING COOLANT, 1 & 2 SPARK PLUG HOLES FILLED WITH WATER CAUSING SPARK PLUGS TO SHORT OUT AND STALL THE ENGINE AT LOW SPEED. PER FORD THE ONLY REPAIR IS REPLACEMENT OF THE COMPLETE INTAKE MANIFOLD AT A COST OF OVER $1200.00. THIS IS A COMMON PROBLEM WITH THIS ENGINE. I HAVE SEEN MANY COMPLAINTS ON F-150 FORUMS VIA THE INTERNET OF PEOPLE HAVING THE SAME PROBLEM. MY TRUCK HAS ONLY 105000 MILES ON IT. *TR

ON OCTOBER 31 2014 WHILE VISITING FAMILY AFTER 350 MILE DRIVE MY 2007 FORD F-150 XLT SUPER CAB 4X4 4.6L MOTOR MADE A NOISE SIMILAR TO AN EXPLOSION THAT WAS FELT IN THE CAB BY ALL PASSENGERS. RIGHT AFTER THE EXPLOSION THE TRUCK LOST POWER AND SOUNDED LIKE AN EXHAUST PIPE HAD FALLEN OFF THE MOTOR. THERE WAS A STRONG SMELL OF GAS AND EXHAUST BUT TRUCK WAS DRIVABLE. BROUGHT TRUCK TO DEALERSHIP AND WAS TOLD THAT 2 SPARK PLUGS HAS BLOWN OUT AND ONE OF THE TWO HAD TAKEN THE THREADS WITH IT. ADVISED ME THAT THIS WAS VERY RARE AND I HAD TO OPTIONS TO FIX. ONE WAS TO RE-THREAD AND REPLACE ALL SPARK PLUGS FOR $899. SECOND WAS TO REPLACE HEAD AT $2100. TOLD DEALERSHIP TO DO THE LESSER OPTION. HAD TO LEAVE TRUCK THERE AND OBTAIN A ONE WAY RENTAL FOR 5 PEOPLE AT $300. HAVE NOW FOUND OUT THAT ITS NOT RARE AND MAY NOT BE FIXED EVEN AFTER THE REPAIR. I AM GLAD THAT THIS HAPPENED ON A SURFACE ROAD AT LOW SPEED AND NOT ON THE HWY. *TR

I HAD THE PUMP, RACK AND PINION REPLACED AND THE SENSOR. AFTER ALL THIS WAS REPLACED SOME TIME LATER THE STEERING GOT TIGHT . I TOOK IT BACK THE MECHANIC THOUGHT I HAD ANOTHER PROBLEM. HE SPRAYED A LUBRICANT ON BOTH UNIVERSALS ON THE STEERING SHAFT. WHEN IT GETS TIGHT AGAIN I WILL GO AND SATURATE THESE TWO UNIVERSALS WITH A SPRAY LUBRICANT. *TR

COOL WET MORNING (65F) BUT NOT RAINING AT THE TIME. DROVE DOWN HILL TO STOP SIGN AT 35MPH. AFTER SLOWING TO ABOUT 5MPH, TRUCK SUDDENLY SURGED DESPITE BRAKING HARD ENOUGH TO ENGAGE ANTILOCK BRAKES DRAGGING THE TRUCK INTO THE INTERSECTION. LESS THAN A MILE LATER, STILL GOING DOWN HILL AT 25MPH SLOWED FOR ANOTHER STOP SIGN. ENGINE SURGED AGAIN TO 3000RPM. DRAG INTO INTERSECTION WAS AVOIDED BY SHIFTING TO NEUTRAL. SURGE DROPPED SPONTANEOUSLY WITHIN 10 SECONDS. *TR

NOTED POWER STEERING FLUID LEAKAGE OVER PERIOD OF TIME. EVENTUALLY FLUID COMPLETELY LEAKED OUT. FORD GARAGE TOLD ME THAT STEERING RACK AND HOSES NEEDED REPLACED DUE TO EXTENSIVE CORROSION FROM SLURRY USED ON ROADS IN OHIO. WAS TOLD NO PREVENTIVE MEASURES WOULD HAVE AVOIDED THE PROBLEM WHICH WAS INEVITABLE. REPAIR COSTS WERE 1900 DOLLARS. COMPLAINT IS THAT I CONTEND THAT INFERIOR MATERIALS WERE USED FOR LINES. THIS IS A 7 Y/O VEHICLE AND SHOULD NOT HAVE CORRODED IN VITAL AREA SUCH AS STEERING. COULD HAVE HAD SERIOUS CONSEQUENCES UNDER HIGH SPEED DRIVING. WOULD SUSPECT THAT UNREPORTED INCIDENTS HAVE OCCURRED. *TR

THE FUEL PUMP DRIVER MODULE DESIGN IS TERRIBLE ON THESE TRUCKS. LUCK FOR MY FAMILY WE WERE IN TOWN GOING SLOW WHEN THIS UNIT SHORTED OUT. IF WE WOULD HAVE BEEN AT HIGHWAY SPEEDS WHO KNOWS WHAT COULD HAVE HAPPENED. THIS COULD HAVE BEEN A VERY GRAVE AND DANGEROUS SITUATION. FROM READING ON THE INTERNET THERE IS A SERIOUS PROBLEM WITH THIS PART. *TR

BLEW #2 SPARK PLUG AND COIL OUT OF HEAD. *TR

NOTICED LEAKAGE UNDER FRONT LEFT TIRE. ALL TRANSMISSION FLUID HAD LEAKED OUT. TRANSMISSION OIL LINE RUSTED THROUGH. HAD PREVIOUS LEAKAGE WHICH I REPAIRED WITH A PIECE OF HIGH PRESSURE LINE. CHECKED METAL LINES OF TRANSMISSION OIL COOLING SYSTEM AND FOUND NUMEROUS AREAS RUSTED OUT AND READY TO BURST. HAD TRUCK TOWED TO DEALER TO REPLACE COOLING SYSTEM LINES. WAS TOLD CORROSION IS A COMMON PROBLEM WITH THE LINES ON F150. CAN'T UNDERSTAND WHY IF THIS IS A COMMON PROBLEM FORD DOES NOT NOTIFY OWNERS ABOUT POSSIBLE PREVENTIVE ACTION TO DEAL WITH THE CORROSION OR USE NON-CORROSION MATERIALS FOR PRESSURE LINES. *TR

ON 9-26-14 THE AIRBAG LIGHT CAME ON THEN WENT OFF AFTER 10-15 MINUTES. I DROVE THE VEHICLE APPROXIMATELY 10 MILES ON 9-26. AT 1PM ON 9-27 I STARTED THE TRUCK AND WITHIN 5-10 SECONDS THE AIRBAG EXPLODED. THE VEHICLE WAS STILL IN PARK AS I WAS OPENING MAIL BEFORE LEAVING. I WAS NOT SERIOUSLY INJURED BUT HAD A SORE RIGHT SHOULDER MOST OF THE DAY. FORD IS TELLING ME I HAVE TO PAY FOR A NEW AIRBAG AS THEY ARE ONLY GUARANTEED FOR 5 YEARS. MY TRUCK HAS NEVER BEEN IN AN ACCIDENT, PURCHASED IT NEW IN 2007 AND IT JUST TURNED 41000. THIS IS A MAJOR HAZARD AS I HAD NO WARNING OF DEPLOYMENT, ONLY MY AIRBAG LIGHT WENT ON. I TOLD FORD OF I HAD TO PAY FOR THE AIRBAG THEN I WANTED ALL PARTS REMOVED. FORD IS GOING TO CALL ME ON 9-29-30. *TR

SON WAS IN AN ACCIDENT, ON THE FREEWAY, TRUCK WAS HIT FRONTEND MAJOR DAMAGE FRONTEND WAS "V" SHAPE IN ACCIDENT TO INCLUDE BOTH SIDES AND THROWN APPROX: 200+ ONE OF THE AIRBAG SENSORS IN LOCATED AT RADIATOR AIRBAGS DID NOT DEPLOY, FORD SAID THERE WAS A WARNING PRIOR TO ACCIDENT WHICH IS NOT TRUE IF THERE WAS A FLASHING FAULT LIGHT GOING OFF I ASSURED THEM I WOULD OF HAVE TAKEN VEHICLE TO DEALERSHIP ASAP. *TR

I WAS JUST LEAVING A BUSINESS. AS I WAS PULLING OUT OF THE PARKING LOT MY STEERING HAD GOTTEN VERY STIFF AND WOULD NOT GO BACK TO CENTER AFTER TURNING A CORNER. IT WAS A LITTLE SCARY BECAUSE I HAD 50 MILES TO DRIVE AND GET BACK HOME. OUT OF THE BLUE THIS HAPPENED. I HAVE HAD NO PROBLEM BEFORE THIS!!! *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT NOTICED THAT THE FRONT PASSENGER COIL SPRING FRACTURED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 109,000.

WHILE TRAVELING FROM NYS TO NJ, I NOTICED THAT IT BECAME HARDER TO STEER THE TRUCK AS THE TRIP PROGRESSED. WHILE ON 80E IN NJ IT BECAME SO SEVERE THAT TO CHANGE LANES AND TAKE AN OFF RAMP TOOK ALL THE STRENGTH I COULD MUSTER. I KNEW IT WASN'T MY POWER STEERING PUMP BECAUSE I CONTINUED TO LOSE RANGE OF STEERING MOTION IN THE STEERING WHEEL. I LIMPED THE TRUCK TO A GAS STATION IN DENVILLE NJ. FLUID LEVEL WAS OK, BELT WAS GOOD AND TURNING PROPERLY ON THE PS PULLEY. I NOTICED THE TWO UNIVERSAL JOINTS ON THE STEERING SHAFT LOOKED CORRODED SO ON A HUNCH I POURED SOME MOTOR OIL ON BOTH U-JOINTS. THAT FIXED THE PROBLEM AND GOT ME OUT OF A VERY DANGEROUS SITUATION. SOMEBODY IS GOING TO GET KILLED BECAUSE THEIR STEERING IS GOING TO LOCK UP DUE TO THOSE U-JOINTS AND THEY WON'T BE ABLE TO STEER OUT OF A BAD SITUATION. *TR

AS I ACCELERATE AND HIT THE PASSING GEAR THE TRUCK SPITS AND SPUTTERS. IF I BACK OFF IT RUNS FINE. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 5 MPH, THE STEERING WHEEL SUDDENLY BECAME VERY DIFFICULT TO TURN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE UNIVERSAL STEERING SHAFT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000. UPDATED 10/22/14*LJ

OVER THE PAST SEVEN YEARS I HAVE A FEW INCIDENTS WERE WHEN I PUT THE TRUCK IN REVERSE,IT ACTUALLY ROLLED FORWARD BEFORE I SLAMMED ON BRAKES; STOPPED; PUT GEAR SHIFT IN PARK; MOVED TO REVERSE AND WENT ON. BUT I ALWAYS HAD TO COMPLETELY STOP AND PARK. IT DOESN'T HAPPEN OFTEN - IN SEVEN YEARS, PERHAPS 8 OR 9 TIMES. THIS PAST FRIDAY WAS THE WORST, BUT I WAS FACING DOWN IN MY MOTHER'S DRIVE-WAY. BUT STILL...I CHECKED FOR A RECALL AND FOUND NONE. JUST FYI.. *TR

I BOUGHT THIS TRUCK NEW. AT APPROX. 22000, I WAS DRIVING AT APPROX 50 MPH WHEN THE ENGINE STARTED A SHAKE, RATTLE AND ROLL. IN LESS THAN 1/4 MILE, THE ENGINE LOCKED BUT I WAS ABLE TO COAST OFF THE HIGHWAY. IT WAS LATE SATURDAY BUT AFTER 2-3 HOURS FOUND A TOW TRUCK AND HAD IT TOWED TO THE LOCAL FORD DEALER AND LEFT IT THEIR BACK LOT. I WAS TOLD THE NEXT WEEK THAT FORD WANTED THE ENGINE BACK INTACT. AFTER AROUND THREE WEEKS AND $800+ FOR A RENTAL I GOT THE TRICK BACK WITH A NEW ENGINE. 2800 MILES LATER, THE EXACT SAME THING HAPPENED. MY WARRANTY WAS OUT ON TIME BUT FORD DID REPLACE THE ENGINE AGAIN BUT I WAS OUT THE RENTAL CAR--AGAIN $800+. THIS WAS SOME 6 MONTHS BACK AND ALL IS OK FOR NOW BUT I WAS TOLD IF THE ENGINE BLOWS AGAIN FORD WILL NOT COVER IT. AND ON THE 2ND REPLACEMENT (3RD TOTAL) ENGINE THAT PISTONS WERE IN THE OIL PAN. 5.4 ENGINE. *TR

REPEATED FAILURE 2007 FORD F150 IGNITION COIL.HAVE REPLACED 3 IGNITION COIL ASSEMBLY'S IN MY FORD F150. ONE IN "2011" AND 2 IN 2014. ( DO NOT REMEMBER THE EXACT DATE OF FIRST , WAS ABOUT 2011 ) SEARCHED THE NET AND READ TIME AFTER TIME FORD F150 OWNERS WITH THE SAME ISSUE. SEEMS FORD MUST KNOW ABOUT ISSUE , BUT NOT FIXED OR RECALLED. MY 2014 IGNITION COIL REPAIR COST $94 EACH ONE PLUS LABOR. ( X3 SO FAR ) THIS YEAR , I WANTED 3 MONTHS WITH THE IGNITION COIL ISSUE TO GET THE TIME AND MONEY TO HAVE FORD FIX. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. WHEN THE VEHICLE ACCELERATED FROM A STOP, THE CONTACT HEARD A LOUD EXPLOSION NEAR THE REAR OF THE VEHICLE. THE VEHICLE STALLED IN THE MIDDLE OF THE INTERSECTION AND WAS TOWED TO A DEALER. THE DEALER STATED THAT ONE OF THE BOLTS THAT SECURED THE REAR END BECAME DETACHED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 74,000.

I WAS DRIVING DOWN THE HIGHWAY AND AS I WAS MAKING A RIGHT HAND TURN MY MOTOR TURNED OFF. I HAD NO STEERING AND LITTLE BRAKES TO GET ME OFF THE ROAD. I TOOK THE TRUCK TO MY MECHANIC AND HE TOLD ME THE FUEL MODULE WAS CRACKED. THIS IS COMMON ON F150'S AND I FEEL FORD SHOULD HAVE A RECALL ON THIS BEFORE SOMEONE GETS HURT. THANKS *TR

I WAS DRIVING DOWN THE ROAD AND I HEARD A LOUD POPPING NOISE SO I PULLED OFF ON THE SIDE OF THE ROAD AND TURNED THE TRUCK OFF. I THEN SAW SMOKE LIKE THE ENGINE HAD OVERHEATED BUT IN A MATTER OF SECONDS FLAMES IGNITED AND I QUICKLY GOT OUT OF THE VEHICLE AND CALLED 911. AS I WAS SPEAKING TO THE DISPATCHER THERE WAS A LOUD EXPLOSION AND THE WHOLE FRONT OF MY TRUCK WAS ENGULFED IN FLAMES. BY THE TIME THE FIRE DEPARTMENT ARRIVED AND PUT OUT THE FIRE MY HOOD WAS TOTALLY BURNED UP THE ENGINE IS BURNED UP AND MELTED AND THE WINDSHIELD AND DRIVER'S SIDE WINDOW BLEW OUT AND THE DASH AND FRONT INTERIOR IS BURNED AND MELTED. I AM LUCKY THAT I WAS ABLE TO GET OUT IN TIME BECAUSE IT HAPPENED SO QUICKLY. I AM ALSO GLAD MY 10 MONTH OLD SON WAS NOT WITH ME ON THIS DAY. *TR

WE PURCHASED THE VEHICLE NEW. BEFORE IT WAS A YEAR OLD, WE HEARD A KNOCKING SOUND. WE WERE TOLD IT WAS NORMAL. AFTER A COUPLE OF YEARS, THE KNOCKING GOT LOUDER, TOOK IT TO THE DEALER SHIP, THEY SAID IT WAS NORMAL. AS THE YEARS PASSED, WE ASKED OTHER DEALERSHIPS, REPAIR SHOPS, AND THERE WAS NEVER A RECALL. WE WERE ALWAYS TOLD NOT TO WORRY ABOUT IT. THE KNOCKING SOUND GOT LOUDER, THE ENGINE WAS BOGGING AND TODAY IT IS IN THE SHOP FOR A NEW ENGINE AND WE HAVE TO COME UP WITH $6,000.00. THERE ARE THOUSANDS OF COMPLAINTS LIKE MINE. WHY IS THERE NOT A RECALL????? *TR

STOPPED AT A LIGHT AND TRUCK STARTED TO SHAKE VIOLENTLY THEN DIED. TRUCK RESTARTED AND DROVE TO A MECHANIC. WAS TOLD THAT THE ERROR CODES STATED THE CAM SENSORS AND EVERY ERROR FOR THEM CAME UP. HE PULLED UP A BLOG AND SAID THAT ALOT OF PEOPLE ARE COMPLAINING ABOUT THE EXACT ERRORS. SOME DID A QUICK FIX TO SELL OTHERS NEED A NEW MOTOR. I CALLED FORD AND THEY SAY A MEMO WENT TO DEALERS BUT UNTIL MORE COME UP THEY WON'T / CAN'T HELP. WAS TOLD IF I GET IT FIXED SAVE THE RECEIPTS. CALLED THE DEALER AND POSSIBLE $6,000-$7,000 FOR NEW MOTOR. *TR

WAS DRIVING ON THE HIGHWAY WENT TO CHANGE LANES AND STEERING FELT REALLY TIGHT COULD BARELY TURN THE STEERING WHEEL. PULLED OVER AND CHECKED IT OUT STEERING FLUID WAS GOOD. WAS REALLY HARD TO STEER AND MADE IT HM. CHECKED OUT FORUM AND DECIDED TO SPRAY WD40 ON TURN BUCKLES ON STEERING SHAFT IT STARTED TURNING EASY AGAIN. WILL SEE IF IT LAST. HAVE A FRIEND WHO WORKS FOR THE CITY AS A MECHANIC AND THEY SAID FORD SENT PEOPLE IN TO CHANGE ALL THE CROWN VICS STEERING SHAFT SO THEY KNOW IT IS AN ISSUE. THEY NEED TO FIX ALL OF THE VEHICLES WITH THE PROBLEM. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE SKIDDED ACROSS THE ROAD INTO A DITCH WHEN THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE THEN FLIPPED OVER UPSIDE DOWN. THE AIR BAGS FAILED TO DEPLOY. THE CONTACT INJURED HER RIGHT LEG AND RECEIVED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED AND TOWED TO THE CONTACT'S RESIDENCE. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000.

BOTH FRONT SUSPENSION SPRINGS FOUND TO BE BROKEN DURING ROUTINE INSPECTION, HEARD ONE BREAK A MONTH AGO BUT DIDN'T IDENTIFY THE SOURCE OF THE BREAK UNTIL RECENTLY. ONE BROKEN SPRING WAS HANGING BELOW THE SHOCK, WHICH COULD HAVE CAUSED A COMPLETE FAILURE OF THE SUSPENSION ON THE RIGHT HAND SIDE. *TR

NOTICED SEVERE GAS FUMES INSIDE CAB, AS WELL AS OUTSIDE CAB. RAISE HOOD , STARTED ENGINE AND NOTICED FUEL LEAK ABOUT THE SIZE OF A PENCIL STREAMING OUT FROM HOSE THAT IS ATTACHED TO FUEL RAIL. REMOVED FUEL RAIL THE NEXT DAY AND FOUND A SPLIT IN THE HOSE UNDER THE CLOTH PROTECTIVE OUTER LINING. IS THERE A RECALL FOR THIS PARTICULAR FAILURE. ?. THIS COULD HAVE BEEN A SERIOUS SITUATION IF IT WOULD HAVE BEEN A LONGER DISTANCE ROAD TRIP. FAILURE P/N 5C3Z97F792DA FUEL RAIL. *TR

STEERING COLUMN SHAFT HAS 2 UNIVERSAL JOINTS IN IT. THE JOINTS ARE NON SERVICEABLE AND SEIZED UP DUE TO CORROSION. THE TRUCK BECAME ALMOST IMPOSSIBLE TO STEER AND THE STEERING COLUMN WOULD NOT RETURN WHEN GOING AROUND A CORNER. VERY DANGEROUS. *TR

ELECTRICAL WIRING ON THE FRAME UNDER DRIVERS DOOR WIRES ARE CORRODING . MANY OF THE 2007 FORD F150 HAS UNDER LAY WIRES GOING TO THE FUEL TAKE TO THE COMPUTER UNDER THE HOOD. *TR

DRIVING ON A 2 LANE ROAD COMING UP TO A RED LIGHT, TRUCK SHUT OFF COMPLETELY, COULD NOT RESTART, HAD TO CALL FOR TOW TRUCK, SITTING ON ROADWAY AT A 3 WAY RUSH HOUR INTERSECTION FOR HALF HOUR WAITING FOR TOW. REPAIR COST $350.00 DOLLARS. PLUS $100.00 DOLLARS TOWING. *TR

IN STARTING THE VEHICLE, THERE WAS A LOUD BANG, AND THEN CLATTERING. IT TURNED OUT TO BE A BLOWN SPARK PLUG. THE THREADS ON THE ENGINE HEAD AND SPARK PLUG WERE STRIPPED/SMASHED. THE COIL WAS COIL WAS ALSO DAMAGED BEYOND REPAIR. BOTH MECHANICS I SAW TO FIX THE PROBLEM WERE WELL AWARE OF PROBLEMS WITH BLOWN SPARK PLUGS IN THE F150, AND ON-LINE RESEARCH INDICATES THIS HAS BEEN A PROBLEM WITH THE F150 SINCE 1997. THE SPARK PLUGS WERE FACTORY INSTALLED, AND I WAS SILL UNDER THE MILEAGE RECOMMENDATION FOR NEW PLUGS. VERY DISAPPOINTING THAT FORD WOULD NOT STEP-UP TO ACKNOWLEDGE THAT THIS IS THEIR PROBLEM AND PAY FOR THE FIX. THE FORD CORPORATE HEADQUARTERS REP I SPOKE WITH CLAIMED TO HAVE NEVER HEARD OF THIS PROBLEM BEFORE. *TR

THIS TRUCK WAS NEVER DRIVEN MUCH AND DRIVEN 24 MILES ROUND TRIP A DAY. DONT UNDERSTAND WHY SOMETHING SO MAJOR COULD HAPPEN WITHOUT WARNING. WILL NEVER BUY A FORD. THE TRUCK DONT STAND UP TO PREFORMANCE. *TR

MY 2007 FORD F150 HAS A MAJOR PROBLEM, WHEN COMING TO A STOP AT A STOP SIGN OR RED LIGHT, THE ENGINE SURGES FORWARD THE RPM GAUGE WILL FALL TO 400 RPM AND WITHOUT WARNING IT SURGES TO 1000 TO 1200 RPM MAKING IT HARD TO CONTROL THE TRUCK, I'M VERY DISAPPOINTED WITH FORD, I AM A REPEAT FORD CUSTOMER, BUT WITH THIS PROBLEM WITH MY F150 IT HAS ONLY 35000 MILES FORD WILL LOOSE ME AS A CUSTOMER FOR SURE . *TR

I HAVE FORDS 35.6 GALLON TANK, HOWEVER THE SENSOR KEEPS RESETTING TO 28 GALLONS FOR A NORMAL GAS READING. I HAVE HAD IT REPLACED 3 TIMES NOW AND FORD SAYS THE SENSOR IS THE SAME THING WITH A SWITCH THAT NO LONGER WORKS, THE REFUSE TO REPAIR THE GAS SENSOR AND I NEVER HAVE ANY IDEA HOW MUCH GAS I HAVE IN MY TANK. IT OFTEN CHANGES MID DRIVE FROM A 3/4 TANK TO JUST ABOVE HALF A TANK AND IS NOT STEADY. IT WON'T REGISTER ACCURATELY. THE DEALERSHIP NOTIFIED THE ENGINEERS AND THEY SAID THAT THEY DON'T CARE AND WON'T COME OUT AND FIX IT BUT ITS A KNOWN ISSUE. CAUSING ME TO BE LEFT ON THE SIDE OF THE ROAD WITH WHAT I THOUGHT WAS GAS, BUT TURNED OUT WAS AN EMPTY TANK. *TR

THERE IS A KNOCKING SOUND COMING FROM THE MOTOR ALREADY REPLACED THE CATALYTIC CONVERTERS AND O2 SENSORS AND THE SOUND IS STILL THERE WITH THE CHECK ENGINE LIGHT ON.WHEN THE TRUCK GAINS SOME SPEED THE TRUCK SHAKES DON'T FEEL REAL SAFE DRIVING IT LONG DISTANCES. *TR

I HAVE A 2007 FORD F-150 WITH A 5.4L V8 ENGINE. THERE WAS INTERMITTENT RATTLE NOISE (KNOCKING) AND ROUGH IDLE. AFTER THE VEHICLE WARMS UP AND I COME TO A STOP OR SLOW ROLL THE VEHICLE BEGINS TO SHAKE AND A LOUD KNOCKING NOISE IS HEARD IN THE ENGINE. THIS IS A KNOWN ISSUE WITH THIS ENGINE AND FORD DENIES IT IS. I HAD IT FIXED IN SEPTEMBER 2011, WHICH WAS COVERED UNDER WARRANTY WITH 49,934 MILES. THE VEHICLE HAS STARTED TO DO THE SAME THING AND CURRENTLY HAS 82,000 MILES ON IT. I WAS INFORMED BY BOTH THE DEALER AND FORD MOTOR COMPANY THEY WILL NOT REPAIR UNDER WARRANTY EVEN THOUGH THIS WAS PRIOR ISSUE DURING THE WARRANTLY TIME. DEALER WANTS APPROXIMATELY $300.00 TO INSPECT TO DETERMINE THE EXTENT OF DAMAGE TO THE ENGINE. THIS IS SAFETY ISSUE AS IT HAPPENS DURING SLOW SPEEDS OR IDLE AT STOP LIGHTS AND ONLY WAY TO MAKE IT STOP IS TO SHUT OFF THE VEHICLE OR REV UP THE RPMS. I BELIEVE THE TSB WAS AWARE OF THIS ISSUE IN 2010 BUT THE MANUFACTURE HAS NOT NOTIFIED CONSUMERS. THIS IS A MANUFACTURER DEFECT AND FORD MOTOR NEEDS TO REPAIR OR REPLACE THE ENGINE AT THEIR COST. *JS

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS THE STEERING WHEEL BECAME VERY HARD TO MANEUVER. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE STEERING SHAFT NEEDED TO BE REPLACED AND THE STEERING FLUIDS NEEDED TO BE FLUSHED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 65,000. THE CURRENT MILEAGE WAS 77,000.

I WAS DRIVING THREW TOWN LAST JUNE & ALL THE SUDDEN MY CHECK ENGINE LIGHT CAME ON & TRUCK STARTED RUNNING REALLY ROUGH & ACTED LIKE IT WAS STARVING FOR GAS OR FIRE SO I TOOK MY TRUCK TO A PARTS STORE & HAD CODE READ IT SHOWED A MISS FIRE @ #6 CYLINDER / SPARK PLUG IT COST ME ALMOST $1,200 TO GET IT FIXED . THAT WAS FOR ALL 8 PLUGS & COILS FOR REALLY NEEDS TO FIX THERE DESIGN FLAW ON THE 4.6L & 5.4L ENGINE THERE IS NO REASON A VEHICLE SHOULD COST THAT MUCH JUST TO CHANGE PLUGS JUST CAUSE THEY DON'T WANT TO FIX THERE MESS UP TO MAKE IT MORE AFFORDABLE TO THE PUBLIC.THEY SAY TILL THE NHTSA ISSUES A RECALL THEY WILL IGNORE THE PROBLEM WITH THE SPARK PLUGS & ALL THE ISSUES THAT COME WITH THEM SINCE THEY CHANGED THE MOTORS DESIGNS. THANK YOU CONSERNED CONSUMER/FIREFIGHTER [XXX] PLEASE TAKE SOME ACTION IN THIS MATTER. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE AIR BAG CODE- 16 WARNING MESSAGE INTERMITTENTLY FLASHED. THE VEHICLE WAS INSPECTED BY A MECHANIC, WHO DIAGNOSED THAT THE PASSENGER SIDE OCCUPANCY SEAT SWITCH FAILED. AS A RESULT, THE ENTIRE SEAT WOULD NEED REPLACING. THE CONTACT STATED THAT THE REPAIR WAS THE MANUFACTURE WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 48,000 AND THE CURRENT MILEAGE WAS 75,000.

I HAVE A 2007 F150 SUPERCREW CAB TRUCK. I WAS DRIVING DOWN A PARKING LOT WHEN THE TRUCK MADE A HUGE GRINDING SOUND FROM THE TRANSMISSION. I THEN RECEIVED A TRANSMISSION MALFUNCTION WARNING LIGHT. THE TRUCK SLAMMED INTO A STOP CAUSING DRIVER AND PASSENGER TO BE TOSSED FORWARD. I HAVE READ ONLINE OF SEVERAL OTHERS HAVING THE SAME PROBLEMS WITH THE 2007 F150 TRANSMISSIONS. FORD CLAIMS NO DEFECTS ON THIS MODEL YEAR. YET ON THE INTERNET THERE ARE SEVERAL FORD OWNERS WITH SAME TRANSMISSION ISSUES WITH TRUCK. FORD NEEDS TO RECALL THIS TRANSMISSION ASAP BEFORE SOMEONE GETS HURT BAD. I AM THE ORIGINAL OWNER WITH NO ACCIDENTS WITH TRUCK. TRUCK IS LOW MILEAGE. *JS

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE CONTACT HEARD A LOUD BANG IN THE ENGINE COMPARTMENT. UPON INSPECTION, IT WAS FOUND THAT THE SPARK PLUG HAD ERRONEOUSLY EJECTED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE SPARK PLUG COIL NEEDED TO BE REPLACED. THE VEHICLE WAS BEING REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 67,000. THE VIN WAS NOT AVAILABLE.

WHILE DRIVING THE TRUCK A NOTICEABLE NOISE WAS GENERATED FROM THE ENGINE AND THE TRUCK SHUT OFF. THE LOW OIL SENOR CAME ON DURING OPERATION. SHUT ENGINE OFF AND RESTARTED NOISE STOPPED. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, A LOUD KNOCKING NOISE WAS HEARD FROM THE ENGINE COMPARTMENT. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO STATED THAT BOTH THE VTC SENSOR AND THE CAM PHASER WOULD NEED TO BE REPLACED. THE VEHICLE WAS BEING REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 45,871.

VEHICLE QUIT RUNNING WHILE DRIVING , LEFT ON THE SIDE OF THE RIDE IN VERY COLD WEATHER , THE FUEL CONTROL MODULE WAS SO CORRODED AND BROKE OFF FRAME CAUSE VEHICLE'S ENGINE NOT TO RUN. THERE SHOULD BE A SAFETY RECALL ON THESE MODULES. MY TRUCK IS IN VERY GOOD CONDITION AND YOU SHOULD SEE HOW BAD OF CONDITION THE MODULE LOOKS.. LOOKS LIKE IT WAS IN ACID AND COMPLETELY DISSOLVED THE BACK PANEL. *TR

THE TRUCK HAS BEEN RUNNING ROUGH AND STALLING OUT AT RANDOM. THIS HAPPENS WHILE DRIVING, WHILE AT THE CAR WASH AND WHILE,SITTING AT THE STOP LIGHT, BUT EVERYTIME IT HAS BEEN WET OUTSIDE. TAKEN TRUCK TO FORD DEALERSHIP, AND HAD LOTS OF WORK DONE, NEW PLUGS, COILPACKS, INJECTOR SERVICE, AND THROTLEBODY CLEANING DONE WITH NO IMPROVEMENT. BROUGHT ISSUE TO A FRIEND AND TO ONE LOOK AT THE FUEL CONTROL MODULE UNDER THE REAR AXEL AND IT WAS SPLIT WIDE OPEN, BAD ENOUGH THE CIRCUIT BOARD WAS JUST HANGING OUT. WHEN ISSUE WAS BROUGHT TO LOCAL FORD DEALER, THE PARTS GUY JUST HAD A LAUGH AND SAID THEY DO AT LEAST THREE A WEEK. "I DIDN'T FIND IT THAT FUNNY" A CONTROL BOX WITH A ALUMINUM BACK PLATE ON A STEEL AXEL WITH NO BUFFER, IS JUST BAD DESIGN AND SHOULD BE RECALLED. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE SUDDENLY STALLED. THE ENGINE WAS RESTARTED AND THE VEHICLE RESUMED NORMALLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 55,000.

HAD A BAD MISS AT HIGHWAY SPEEDS AND LIMPED HOME 15 MILES. REPLACED SPARK PLUGS AND IN THE PROCESS BROKE TWO IN THE HEAD. ONE DID NOT BREAK COMPLETELY OFF (#4) AND I NEEDED TO BORROW A PROTOTYPE TOOL FROM LISLE TOOL CORP. REMOVED AND REPLACED PLUGS FOLLOWING FORD PROCEDURES. TRUCK STILL HAD A MISS. REPLACED ALL EIGHT COIL PACKS WHICH FIXED THE PROBLEM. TOTAL COST$380.00. TRUCK DOWN FOR 6 DAYS AWAITING TOOLS AND PARTS. DEVELOPED A VIBRATION AT HIGHWAY SPEEDS. ORIGINAL TIRES(PIRELLI) WERE SEPARATING. REPLACED TIRES(976.00), MUCH BETTER. STILL HAVE SLIGHT VIBRATION AT HIGHWAY SPEEEDS. FOUND LEFT FRONT HUB BEARING SEEPING GREASE AND FEELS STIFF. AWAITING PARTS TO DO REPAIRS. (98.00) HAD A TRANSMISSION SHUDDER AT LIGHT LOAD IN OVERDRIVE. FLUSHED TRANSMISSION WITH BG PRODUCTS AND FLUSH MACHINE. ADDED NEW TRANS FLUID AND CONDITIONER. TRANSMISSION NOW SHUDDERS AT ALL SPEEDS WHEN HOT. WILL ORDER NEW FILTER AND REPLACE. WILL ADD FRICTION MODIFIER AND TRY AGAIN. HAVE TO TOW ANOTHER VEHICLE THIS WEEKEND AND AM AFRAID TO DO SO. I AM COMPLETELY BLOWN AWAY THAT THESE PROBLEMS COULD HAPPEN TO ANY VEHICLE STARTING AT 48,000 MILES. ALL MAINTENANCE HAS BEEN PERFORMED WITH TOP OF THE LINE PRODUCTS. HAVE BEEN A FORD OWNER ALL MY LIFE AND AM COMPLETELY DIS-SATISFIED WITH THE PERFORMANCE OF THIS SUPPOSED NUMBER ONE SELLING TRUCK. THE STICKER PRICES OF THESE TRUCKS SHOULD BE A BUNCH LESS SINCE CHEAPLY PRODUCED CHINESE PARTS ARE SO PREVALENTLY USED. NOT HAPPY. *TR

WHEN I STARTED MY ENGINE IT BACKFIRED. FROM THAT POINT ON I HAD TO PRESS EXTREMELY HARD ON THE BRAKE PEDAL JUST TO SLOW DOWN AND EVENTUALLY TO STOP. IN AN EMERGENCY SITUATION IT WOULD WITHOUT A DOUBT HAVE RESULTED IN AN ACCIDENT. THE INCIDENT IS EXACTLY AS INDICATED IN THE RECALL NHTSA CAMPAIGN NUMBER: 08V208000 (FORD RECALL #08S05) FOR THE SAME VEHICLE, EXCEPT MODEL YEAR 2005 AND 2006. WHEN I CONTACTED FORD I WAS TOLD THAT THE VEHICLE WAS MANUFACTURED IN AUGUST OF 2006, BUT THAT IT WAS NOT COVERED UNDER THIS RECALL. *TR

ENGINE QUIT RUNNING WHILE DRIVING AT 40MPH ON A COUNTRY ROAD. NO SHOULDER ON THIS ROAD SO HAD TO LEAVE IT SIT IN THE ROAD WHILE I WAITED FOR A TOW TRUCK. TOOK IT TO LOCAL FORD DEALER AND THE PROBLEM WAS A CORRODED FUEL PUMP MODULE. $125.00 FOR THE TOW AND $350.00 TO FIX THE TRUCK. NOT A VERY GOOD DAY. *TR

FIRST WHY WAS" THIS VEHICLE INCLUDED IN THE RECALL OF BAD THROTTLE BODY I HAD THE SAME PROBLEM AS PEOPLE ARE HAVING WITH THE FORD ESCAPE. I REPORTED THIS BACK IN 2012 WHEN IT WAS BROUGHT TO THE ATTENTION OF THE NHTSA I DID NOT RECEIVE A RESPONSE THEN BUT THERE ARE THE SAME PROBLEMS WITH THE F-150 I HAD TO REPLACE MINE @ A COST OF OVER $600.00 AND ALSO DAMAGED MY ALTERNATOR I WAS DRIVING IN TRAFFIC WHEN IT WENT IN LIMP HOME MODE SHOWING A WRENCH SYMBOL WITH LOST OF POWER AND ACCELERATION, I ALMOST WAS HIT BY SEVERAL VEHICLES AS THERE WAS KNOW WHERE TO PULL OVER TIME. THIS IS THE SAME THROTTLE BODY THAT COMES ON THE FORD ESCAPE AND IT SHOULD BE INCLUDED WITH THAT GROUP OF RECALLS. *TR

TL* THE CONTACT OWNS A 2007 FORD-150. THE CONTACT STATED THAT WHEN HE CAME TO A COMPLETE STOP, HE HEARD A LOUD NOISE COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO A DEALER, WHO DIAGNOSED THAT THE TIMING CHAIN NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE WAS RECURRING. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 152,000.

THE TRUCK SUDDENLY STALLED. UNABLE TO BE RESTARTED. AFTER BEING TOWED HOME, I FOUND THE FUEL PUMP MODULE CORRODED COMPLETELY THROUGH THE BACK SIDE. THE ALUMINUM BACK HOUSING WAS DETERIORATING BAD ENOUGH THAT IT CRUMBLED APART AS I WAS REMOVING IT. MY WIFE AND CHILDREN WERE IN THIS VEHICLE WHEN IT STOPPED. IT WAS 5 DEGREES OUTSIDE AND NOT SAFE TO WALK ANY DISTANCE FOR HELP ESPECIALLY ON OUR SECONDARY ROADS. THIS PART IS AN ENGINEERING FAILURE. THE ALUMINUM DOES NOT MATE WITH THE STEEL ON THE TRUCK FRAME. I HAVE FOUND SEVERAL COMPLAINTS AS TO THIS PART AND NO INVESTIGATION. THIS COULD HAVE BEEN LIFE THREATENING TO MY FAMILY. THE COLD, NO HEAT, AND SMALL CHILDREN ADD UP TO PROBLEMS. A VEHICLE OWNER SHOULD NOT HAVE TO WORRY ABOUT AN ELECTRICAL ISSUE LIKE THIS ESPECIALLY WHEN IT COULD BE RECTIFIED BY CHANGING THE MATERIAL IT IS MADE OF. PLEASE FOR THE SAKE OF THE MANY FAMILIES DRIVING THIS COMMON TRUCK, MAKE THE COMPANY OWN UP TO THE FAILURE OF THIS PART BEFORE IT IS RESPONSIBLE FOR INJURING SOMEBODY OR WORSE YET A CHILD OR INFANT. *TR

MY 2007 FORD F-150 XLT 5.4 TRITON WAS BROUGHT IN FOR A ROUTINE TUNE UP. WHEN REMOVAL OF THE SPARK PLUGS 6 OF 8 BROKE OFF. THE MECHANICS ATTEMPTED TO REMOVE THE BROKEN PARTS BUT COULD NOT. NOW I AM TOLD I NEED TO HAVE THE HEADS OF THE MOTOR TAKEN OFF AND OR HAVE THE ENGINE REPLACED. THIS MOTOR HAS RUN FINE EXCEPT FOR MIS FIREING SPARK PLUGS. I TALKED TO OTHER MECHANICS AND AUTO PART STORES, PRIOR TO HAVING THIS WORK DONE AND THEY ALL WARNED ME THAT THIS MAY HAPPEN, THE BREAKING OFF OF THE SPARK PLUGS. I CAN`T AFFORD TO HAVE THIS MAJOR WORK DONE AT THIS TIME, AND I FEEL THAT FORD HAS A BAD PRODUCT IN IT`S SPARK PLUG. HAS THERE BEEN ANY OTHER COMPLAINTS IN THIS MATTER [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

I WAS ACCELERATING FROM A STOP AND VEHICLE SHUT OFF. I AM 8MTHS PREGNANT AND WAS STUCK ON THE SIDE OF THE ROAD FOR OVER A 1/2 HOUR IN -45 DEGREE WEATHER WAITING FOR TOW TRUCK, BECAUSE VEHICLE WOULD NOT START. MECHANIC LOOKED AT VEHICLE AND FOUND #9 FUSE FOR FUEL PUMP BLOWN. FUSE REPLACED, AND VEHICLE RAN FOR 30SECONDS AND ELECTRICAL PLUG TO DRIVER CONTROL MODULE BEGAN TO SMOKE AND MELT. DRIVER CONTROL MODULE AND ELECTRICAL PLUG REPLACED, AND VEHICLE RUNS. I WOULD HAVE LIKE TO HAVE BEEN NOTIFIED BY FORD TO AVOID MY STRANDED EXPERIENCE IN -45 DEGREE WEATHER. THIS WAS A HUGE SAFETY RISK AND IT CAN BE AVOIDED. FORD SHOULD HAVE LOCATED THIS DEVICE NEAR THE FUSE BOX OR UNDER HOOD BY FIRE WALL PLENTY OF ROOM AND SAME AMOUNT OF WIRE. *TR

TL* THE CONTACT OWNS A 2007 FORD F150. THE CONTACT STATED THAT WHILE DRIVING 35 MPH, AN ABNORMAL NOISE WAS HEARD FROM THE ENGINE AS THE VEHICLE SUDDENLY STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND TOOK IT TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED A LACK OF PRESSURE ON THE RIGHT SIDE OF THE ENGINE. IN ADDITION, WATER FROM THE COOLING SYSTEM HAD LEAKED INTO THE ENGINE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 84,000.

TL* THE CONTACT OWNS A 2007 FORD F -150. THE CONTACT STATED THE INSTRUMENT PANEL FAILED TO FUNCTION. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENTIRE INSTRUMENT PANEL NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 86,000. UPDATED 2/26/14*CN

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE TRAVELING VARIOUS SPEEDS, THE CONTACT LOST CONTROL OF THE VEHICLE DUE TO ICE ON THE HIGHWAY AND FLIPPED THE VEHICLE SEVERAL TIMES. UPON IMPACT, THE AIR BAGS FAILED TO DEPLOY. THE VEHICLE WAS DESTROYED. THERE WERE NO INJURIES. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000.

I STARTED MY TRUCK AFTER WASHING IT, IT WAS RUNNING ROUGH SO I SHUT IT OFF AND TRIED TO RESTART IT AND IT WOULD NOT START. AFTER HAVING IT TOWED TO A REPAIR GARAGE THE TECHNICIAN DISCOVERED THE FUEL MODULE WAS BAD, AND HAD TO BE REPLACED IT. AFTER LOOKING ON LINE I FOUND OUT THAT THIS IS A COMMON PROBLEM WITH THESE TRUCKS FROM 2004-2008 MODELS. SOUNDS LIKE A POOR DESIGN. *TR

HAVING ISSUE WITH THE TIMING,TIMING SOLENOIDS. I HAD THIS SAME ISSUE IN NOV. 2012. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT WAS DRIVING 70 MPH WHEN TIRE PRESSURE SENSOR ILLUMINATED. THE CONTACT NOTICED THAT THE REAR PASSENGER'S SIDE TIRE WAS LOW AND THE TIRE WAS REPLACED WITH A SPARE. THE VEHICLE WAS TAKEN AN INDEPENDENT MECHANIC FOR INSPECTION WHERE THE CONTACT WAS ADVISED THAT THE VALVE STEM WAS LEAKING. THE ISSUE RECURRED ON THE REAR DRIVER'S SIDE VALVE, WHICH ALSO BECAME FRACTURED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE INCIDENT. THE APPROXIMATE FAILURE MILEAGE WAS 39,000.

AS I WAS DRIVING THE TRUCK ENGINE STARTED TO SHAKE AND THEN A LOUD BANG .UPON INSPECTION FOUND THAT THE SPARK PLUG FOR CYLINDER 3 HAD BLOWN OUT(FORD RECOMMENDS SPARK PLUG REPLACEMENT AT 100000 MILES HAD ONLY 65000 MILES) AFTER I GOT THE TRUCK HOME I CALLED FORDS HELPLINE AND WAS TOLD THAT THERE WAS NOTHING THEY WOULD DO TO HELP .HAD TO FIX AND PAY FOR THE REPAIR MYSELF AND ALSO FOUND THAT THE CYLINDER #2 PLUG WAS DEFECTIVE TO. *TR

TL* THE CONTACT OWNS A 2007 FORD F150. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE FUEL PUMP DRIVER MODULE HAD TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 47,000. THE CURRENT MILEAGE WAS 53,000. UPDATED 11/30/13*CN

TL* THE CONTACT OWNS A 2007 FORD F150. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD LEAK POWER STEERING FLUID WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE POWER STEERING LINES HAD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 53,000. UPDATED 11/29/13*LJ THE VEHICLE WAS REPAIRED ON 10/18/13. UPDATED 12/02/13

THE VEHICLES STEERING SHAFT IS CORRODED AND LOCKS UP WHEN TURNING, CAUSING A SAFETY HAZARD. FORD HAS RECALLED THE STEERING SHAFTS ON THEIR CROWN VICS, GRAND MARQUIS AND TOWN CARS. I FEAR THAT FORD USED THE SAME DESIGN AND MATERIAL FOR THE STEERING SHAFTS ON THE F150'S, WHICH WOULD CREATE A HECK OF A LOT MORE DAMAGE, INJURY AND/OR DEATH IF ONE WERE TO LOOSE THE ABILITY TO STEER THE VEHICLE. STEERING IS JUMPY AND LOCKS UP AT CERTAIN INTERVALS DURING THE STEERING ACTION. I HAVE LOST CONTROL, BUT WAS ABLE TO CORRECT THE PROBLEM WITH BRUTE STRENGTH. THIS PROBLEM MUST ME INVESTIGATED. I HAVE RESEARCHED AND HAVE FOUND NUMEROUS COMPLAINTS ABOUT THIS PROBLEM, MY MECHANIC SAYS THAT THIS IS AN ONGOING PROBLEM AND THAT FORD SHOULD RECALL THESE STEERING SHAFTS, AS THEY HAVE THE OTHERS. I CONTACTED FORD AND THEY HAVE NOT INTENTIONS OF RECALLING THEM. *TR

TRUCK RANDOMLY STOPS RUNNING. *TR

TURNS OVER WILL NOT START. DEALER SAYS FUEL SENDING UNIT $407.00 REPLACED!!!!!!! *JB

I WAS DRIVING DOWN THE STREET ABOUT A 1/2 MILE FROM MY DESTINATION WHEN ALL OF A SUDDEN A WRENCH SIGNAL CAME ON, MY DASH. MY TRUCK STOP PULLING WHILE I WAS IN TRAFFIC AND UNABLE TO EXCEL I HAD TO PULL OVER QUICKLY TO AVOID GETTING REAR ENDED I LIMPED WITH NO EXCEL TO DESTINATION WHERE I CALL FORD TO PICK IT UP.AFTER GOING TO PICK IT UP I WAS SURPRISED TO FIND OUT THAT MY WARRANTY DID NOT COVER MY PART WHICH WAS OVER $600.00 I MEAN ME AND MY SPOUSE COULD HAVE BEEN HURT SEVERELY BECAUSE OF THIS IS A ISSUE FORD NEED TO ADDRESS. I FOUND OUT IT WAS THE THROTTLE BODY. *TR

ON THE ABOVE LISTED DATE, WHILE DRIVING IN RUSH HOUR TRAFFIC IN A BUSY METROPOLITAN CITY MY DRIVE SHAFT CENTER SUPPORT BEARING ALLOWED THE DRIVE SHAFT OF MY 2007 FORD F150 TO SLIP BACKWARDS COMPLETELY DETACHING FROM THE TRANSMISSION. LUCKILY, MY SPEED AT THAT TIME WAS ONLY 10-15MPH. WHEN CALLING THE FOR DEALERSHIP TO INQUIRE ABOUT REPLACING THE PART OR ADVISE THE SALES PERSON WAS ONLY INTERESTED IN SELLING ME AN ENTIRE DRIVE SHAFT AND ADAMANTLY STATED THE PART IN WHICH I WAS SEARCHING WAS NOT OBTAINABLE IN NO POSSIBLE WAY. AFTER SEARCHING FOR THE EXACT PART ON FORD'S PARTS WEBSITE I DID LOCATE THE INDIVIDUAL PART ALLOWABLE FOR ORDER ONLINE. MY MAIN CONCERN AT THIS TIME IS THERE WAS NO REGARD FOR THE TREMENDOUS SAFETY HAZARD OF THIS PARTICULAR DEVICE OR PIECE OF EQUIPMENT, MOREOVER THERE WAS MORE CONCERN WITH OBTAINING A LARGER SELL. AFTER READING ONLINE I HAVE FOUND OTHER ISSUES WITH THIS EXACT DEVICE OR PARTS PERTAINING TO IT'S FUNCTION BUT THERE DOES NOT SEEM TO BE ANY RECALL OR INVESTIGATION REGARDING THESE MATTERS. I AM ONLY ADDRESSING THIS ISSUE BECAUSE OF THE DEFINITE SAFETY RISKS THAT ARE AT HAND AND TO ADVISE TO OTHER OWNERS OF THIS YEAR MAKE AND MODEL TO HAVE YOUR VEHICLE INSPECTED FOR THIS POSSIBLE SAFETY HAZARD. ALSO, TO THE FORD MOTOR COMPANY, BEING A MASSIVE ENTITY IN THE VEHICLE DEVELOPMENT AND SALES INDUSTRY I WAS APPALLED TO LEARN OF NO EXISTING INVESTIGATIONS IN THIS MATTER. PLEASE, FOR THE SAFETY OF THE FAMILIES DRIVING YOUR PRODUCT ALONE WITH MY FAMILY AS WELL, PLEASE TAKE AN INITIATIVE IN FURTHER INVESTIGATING THIS MATTER. THANK YOU, SATISFIED BUT DISSATISFIED CUSTOMER. *TR

ON 08/14/13 I WAS AT A BANK IN THE CITY OF FAIRFIELD CA. 94533, THERE WAS AN ACCIDENT IN THE PARKING LOT, WHICH IS A 1 DIRECTION ENTRANCE, MYSELF AND SEVERAL VEHICLES HAD TO BACK OUT OF THE LOT. AS I PRECEDED TO ACCELERATE TO EXIT THE LOT, I HEARD A LOUD THUMP. THE NEXT THING I KNEW WAS I WAS UNABLE TO MOVE. I EXITED MY VEHICLE AS OTHERS WHO WERE IN THE PARKING LOT OF THE BANK APPROACHED ME AND ASKED IF THAT WAS MY DRIVE SHAFT HANGING DOWN. WHEN I BENT DOWN TO LOOK I NOTICED THAT IT HAD BROKEN AT THE WELD AT THE YOKE OF THE TRANSMISSION. WHEN I RETURNED HOME AFTER BEING TOWED, I WENT ON LINE TO SEE OF ANY OTHER SITUATIONS OF DRIVE SHAFTS BRAKING ON FORD TRUCKS, AND I HAVE FOUND SEVERAL, WHICH ONE BROKE AND THE DRIVER LOST CONTROL AND HAD AN ACCIDENT WITH MASSIVE VEHICLE DAMAGE. I WENT TO THE LOCAL FORD DEALER, AND THEY SAID THEY HAVE NO RECALLS WITH THAT ISSUE. BUT FORD HAS HAD SEVERAL COMPLAINTS OF A LOUD THUMPING WHEN THE VEHICLE IS BEING PLACED IN GEAR WHICH IS ALL A RESULT OF DRIVELINE AND DRIVE TRAIN PROBLEMS. MY CONCERN IS THAT IF I HAD BEEN TRAVELING AT HIGHWAY SPEEDS AND THIS HAD HAPPENED, THE DRIVE-LINE WOULD HAVE DUG INTO THE ASPHALT AND PERHAPS FLIPPED MY TRUCK. KILLING MYSELF AND PERHAPS OTHERS. I ALSO CALLED FORDS CUSTOMER CARE CENTER IN MICHIGAN, BUT THEIR RESPONSE IS THAT THERE HAS BEEN NO COMPLAINTS OR RECALLS. TO WHICH I INFORMED THE REPRESENTATIVE THAT THERE WERE SEVERAL BLOGS ON LINE OF PEOPLE HAVING DRIVE-LINE PROBLEMS ON THE FORD F150 TRUCKS. I WAS IN A PARKING LOT BACKING UP WHEN MY INCIDENT OCCURRED BUT WHAT HAPPENS WHEN IT OCCURS ON THE HIGHWAY WITH CHILDREN IN THE VEHICLE. I AM NOW PRESENTLY WITHOUT A VEHICLE UNTIL I AM ABLE TO HAVE REPAIRS DONE AND I HAVE A $600 MONTHLY CAR NOTE. I FEEL THAT THIS IS A DEFECT THAT FORD NEEDS TO BE RESPONSIBLE FOR TAKING CARE OF. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED WHILE DRIVING 70 MPH THE VEHICLE BEGIN TO STALL AND SHAKE. THE CONTACT PULLED ONTO THE SIDE OF THE ROAD. THE CONTACT SHUT THE OVER DRIVE FUNCTION OFF AND WAS ABLE TO CONTINUE DRIVING. THE CONTACT STATED THE DEFECT CAME FROM THE POWER TRAIN. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR A LOCAL MECHANIC FOR A DIAGNOSTIC TEST. THE FAILURE MILEAGE WAS 55,522.

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT THE SIDE SUPPORT HANDLES USED TO LIFT ONESELF INTO THE VEHICLE BECAME FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER BUT WAS NOT REPAIRED. THE CONTACT STATED THAT IT WAS THE SECOND OCCURRENCE OF THE FAILURE. THE FAILURE MILEAGE WAS 48,000. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT THE VEHICLE STALLED WITH THE ILLUMINATION OF THE CHECK ENGINE WARNING LIGHT. THE VEHICLE WAS TAKEN TO THE DEALER, WHO PERFORMED A DIAGNOSTIC THAT DETERMINED THAT THE SPARK PLUGS WERE MISFIRING ON THE SIXTH AND EIGHTH CYLINDERS. THE VEHICLE WAS NOT REPAIRED. THE FAILURE WAS REPORTED TO THE MANUFACTURER. THE FAILURE MILEAGE WAS 65,000. THE CURRENT MILEAGE WAS 96,000.

THREE TIMES SINCE JANUARY 1, 2013 MY FORD F-150 HAS ACCELERATED ON ITS OWN. EACH TIME I WAS TRAVELING LESS THAN 10 MPH. EACH TIME I HAD TO PUT THE TRUCK INTO NEUTRAL AND TURN IT OFF. THE RPM'S WENT OVER 3000 AND MY FOOT WAS NOT ON THE GAS. EACH TIME I CHECKED TO MAKE SURE THERE WAS NOTHING HUNG UP IN THE GAS PEDDLE LIKE CARPET OR TRASH. I TOOK MY TRUCK TO FORD COUNTRY IN LAS VEGAS AND THE SERVICE WRITER SAID I WAS DREAMING THAT SOMETHING LIKE THAT COULD NOT HAPPEN. I ASSURE YOU THAT MY TRUCK ACCELERATED ON ITS OWN THREE TIMES AT SPEEDS LESS THAN 10 MPH. I WOULD LIKE TO FIND OUT IF THIS IS A REPORTED PROBLEM WITH A FIX. I DO NOT FEEL SAFE DRIVING MY TRUCK IN TOWN AND ESPECIALLY IN TRAFFIC WHERE IT MIGHT ACCELERATE ON ITS OWN AND HURT SOMEONE. ANY INFORMATION THAT YOU NEED I CAN PROVIDE. I AM WILLING TO LET YOU PUT ANY TYPE OF MONITORING DEVICE ON MY TRUCK SO IF OR WHEN IT HAPPENS AGAIN YOU CAN SEE THE RESULTS. THANK YOU FOR YOUR TIME. *TR

MY TRUCK ACCELERATED ON IT'S OWN WHILE HITTING THE BRAKE, I THOUGHT IT MIGHT BE MY NEW MAT SO I REMOVED IT AND IT HAPPENED AGAIN. NOT SURE IF I HIT THE GAS PEDAL AT THE SAME TIME AS THE BRAKE? I HAVE NEVER HAD THIS HAPPEN IN ALL THE YEARS I DROVE FORDS OR GMC. YOUR FORM WOULD BE EASIER IF YOU COULD JUST TYPE IN INFO AND BOY I WISH THESE PROGRAMS WOULD GET RID OF THE STATE BOX AND LET US TYPE IT IN. *TR

WHILE SLOWING DOWN TO STOP THE ENGINE REVVED AND THE TRUCK ACCELERATED. WE WERE OUT OF TOWN AND WITHIN A SHORT WHILE THE SAME THING HAPPENED 4 TIMES. NOW 2 MORE TIMES. THE DEALER SAID IT MIGHT BE THE THROTTLE CONTROL BOX BUT HE COULD DO A 75 DOLLAR DIAGNOSTIC TOO. I DECLINED. THIS HAS HAPPENED BEFORE BUT NOT AS BAD, I THOUGHT MY FOOT HIT THE GAS PEDAL WHICH IS DEFINITELY NOT THE CASE. *TR

THE VEHICLE GEAR SHIFT CAN BE MOVED AT ANYTIME WITHOUT DEPRESSING THE BRAKE OR THE RELEASE BUTTON BOTH WHEN DRIVING AT 60 MPH OR THE VEHICLE IS PARKED IN MY YARD. EASILY A CHILD CAN MOVE THE VEHICLE INTO GEAR AND START IT ROLLING OR BRING IT TO A DEAD STOP WHILE DRIVING ON THE HIGHWAY BY JUST BUMPING INTO IT. I CONTACTED FORD AND THEY WERE UNWILLING TO HELP WITH THIS OBVIOUS SAFETY ISSUE. WHICH WILL NOW COST ME OVER $800.00 TO FIX. THIS AMOUNT SEEMS EXCESSIVE AND I FEAR WILL KEEP MANY PEOPLE WHO EXPERIENCE THIS DANGEROUS PROBLEM FROM FIXING IT BECAUSE THE VEHICLE OTHERWISE PERFORMS FINE. I HAVE CONTACTED SALVAGE COMPANIES WHO HAVE STATED THAT THEIR PRICE ON THIS PART IS WHAT IT IS BECAUSE THEY CAN SELL THESE PARTS ALL DAY INDICATING THAT THIS IS A COMMON PROBLEM. FORD WILL NOT RECOGNIZE THE DEFECT IN THE VEHICLE. HOW LONG SHOULD A SHIFTER LEVER LAST? I'M 48 YRS OLD, I HAVE OWNED MANY VEHICLES SOME WITH MANY MORE MILES THAN THIS ONE AND I HAVE NEVER HAD AN ISSUE WITH THIS PART. HOPEFULLY YOU CAN PERSUADE THE FORD MOTOR COMPANY TO DO THE RIGHT THING AND STAND BEHIND THEIR PRODUCTS AND INSTITUTE A RECALL FOR THIS PART. *TR

THE CRANKSHAFT THRUST BEARING MALFUNCTIONED. I WAS ABLE TO GET THE TRUCK OFF OF THE HIGHWAY AND BACK TO MY HOUSE. I HAD TO HAVE IT TOWED TO A FORD DEALER. I HAVE BEEN DOING ALOT OF ONLINE RESEARCH AND FOUND THAT THIS IS A PROBLEM WITH ALOT OF THE F150'S FROM 2005-2008. MAINLY ON THE TRITON 5.4L V8. I HAVE CONTACTED FORD BUT THEY SAY THAT THEY DO NOT KNOW OF ANY PROBLEMS. MY TRUCK WAS NOT UNDER A WARRANTY AND FORD WILL NOT COVER IT. I AM TRYING TO GET THEM TO RECALL THESE ENGINES TO HELP THE MANY OTHERS OUT THERE THAT HAVE HAD TO SHELL OUT $6000+ DOLLARS AS I HAVE. *TR

WHILE DOING PMCS A SPARK PLUG EJECTED FROM THE MOTOR. I DONT LIKE BEING SHOT AT FROM MY TRUCK. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT THE ENGINE LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THAT THE COIL PACK WOULD HAVE TO BE REPLACED. AFTER THE REPAIR, THE FAILURE CONTINUED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 150,000. *TR

HAULING MY DAUGHTER'S BASKETBALL TEAM BACK FROM KING CITY, CA ON US 101 NORTHBOUND. ACCELERATED TO MERGE ON TO HIGHWAY, ENGINE COUGHED, LURCHED, COUGHED, LURCHED, SHOOK AND FINALLY PROCEEDED. TOOK IT TO THE SHOP AND WAS TOLD THAT A BAD SPARK PLUG HAD FRIED MY COIL. THAT EXPLAINED SOME OF IT. I WAS TOLD BY THE SERVICE MANAGER TO BRING IT BACK BEFORE 100K MILES, AND I DID. NOW I AM TOLD THAT ALL THE REMAINING SPARK PLUGS ARE EFFECTED, BUT THEY DON'T SEE ANY ISSUE WHEN THEY RUN DIAGNOSTICS. THEREFORE, IT CANNOT BE REPAIRED. GREAT. JUST MADE THE LAST PAYMENT ON IT TOO. *TR

WENT TO START TRUCK AT HOME AND IT WOULD NOT START. ENGINE WOULD TURN OVER, BUT WOULD NOT START. I HAD VEHICLE TOWED TO THE FORD DEALERSHIP. TOLD BY THE FORD SERVICE MANAGER THAT IT PROBABLY WAS THE FUEL CONTROL MODULE LOCATED BY THE REAR SPARE TIRE AND THEY HAVE REPLACED MANY OF THEM. THE FORD DEALERSHIP CONFIRMED IT AND REPLACED THE FUEL CONTROL MODULE. MY COST $312.83. WE AVERAGE 160 INCHES OF SNOW PER YEAR. LONG WINTERS AND LOTS OF SALT. *TR

I DECELERATED AND TURNED A CORNER ONTO A TWO WAY STREET. I THOUGHT I HAD HIT ICE AS MY 2007 F150 TRUCK ACCELERATED AND SWERVED INTO THE OTHER LANE. MY FOOT WAS ON THE BRAKE AND MY TIRES WERE SCREECHING AS I LANDED ON A SNOWBANK ON THE OTHER SIDE OF THE HIGHWAY. I HAD TO APPLY HEAVY PRESSURE TO THE BRAKE TO STOP! IT WAS NOT HUMAN ERROR NOR ICE! VERY RECENTLY THE SPEED CONTROL HAD STOPPED WORKING ON THE VEHICLE. *TR

I WAS DRIVING DOWN THE HIGHWAY TOWING A TRAILER WEIGHING ABOUT 4, 000 LBS. WE WERE TRAVELING APPROX 45MPH WHEN THE TRUCK HAD NO THROTTLE RESPONSE AND STALLED. AFTER STOPPING AT A MAJOR INTERSECTION I HAD TO CALL 911 BECAUSE I WAS BLOCKING TRAFFIC. THEY HAD TO CALL A TOW TRUCK CAPABLE OF TOWING TRUCK AND TRAILER OUT OF THE INTERSECTION. AFTER THE TOW BILL AND LOCAL FORD DEALER SINKING THEIR TEETH INTO ME THE TOTAL WAS $518. *TR ## VIN FAILED ##

I RETURNED MY FORD F-150 TO THE DEALERSHIP FOR THE THIRD TIME TO CORRECT THE PROBLEM WITH THE BRAKE PEDAL TRAVELING PAST THE ACCELERATOR PEDAL DURING NORMAL BRAKING. FORD IS NOT RECOGNIZING THE PROBLEM AND THE DEALERSHIP SALES MANAGER ACKNOWLEDGES HE HAS REPLICATED THE PROBLEM INTERMITTENTLY; HOWEVER, BECAUSE FORD REFUSES TO ACKNOWLEDGE THE PROBLEM THERE IS NOTHING THEY CAN DO. I HAVE SEEN THIS PROBLEM REPORTED IN OTHER CASES ON THE NHTSA WEBSITE, AND I BELIEVE IT IS TIME FOR NHTSA TO INVESTIGATE BEFORE DEATHS ARE REPORTED FROM BRAKING/ACCELERATING THROUGH STOP SIGNS/LIGHTS AND HITTING OR BEING HIT BY SOMEONE. I BELIEVE THE PROBLEM IS SOMEHOW ALSO RELATED TO THE FRONT BRAKE ROTORS WARPING WITHIN A SHORT PERIOD OF TIME (20K - 30K MILES). *TR

AFTER REPLACING THE FRONT BRAKE ROTORS AND BRAKE PADS DURING 8/07/10 - 8/10/10 TO TRY AND ALLEVIATE A PROBLEM WITH THE BRAKE PEDAL TRAVELING PAST THE ACCELERATOR WHEN BRAKING (NORMAL BRAKING), I HAD TO RETURN TO THE DEALERSHIP WITH THE SAME PROBLEM. IT IS A SAFETY ISSUE AS I CANNOT ALLOW ANYONE ELSE TO DRIVE THE TRUCK WHO IS NOT FAMILIAR WITH THE PROBLEM. THE DEALERSHIP KEPT THE VEHICLE FROM 8/11/10 THROUGH 8/25/10 WITH THE SERVICE MANAGER DRIVING IT EVERY DAY TO AND FROM WORK TO SEE IF THE PROBLEM COULD BE REPLICATED. THE SERVICE MANAGER SAID HE NOTICED THE SAME PROBLEM WITH THE BRAKE PEDAL GOING PAST THE ACCELERATOR WITH NORMAL BRAKING; HOWEVER, DID NOT HAPPEN EVERYTIME. I AGREED WITH THAT. AFTER THE SERVICE MANAGER CALLED THE FACTORY REPRESENTATIVE TO DISCUSS THE PROBLEM, THE FACTORY REPRESENTATIVE SAID THERE IS NOT A KNOWN PROBLEM AND THE BRAKING SYSTEM WAS WITHIN SPECIFICATIONS. I WAS TOLD BY MY DEALERSHIP THAT FORD DOES NOT RECOGNIZE THE PROBLEM AND THEY COULD NOT RESOLVE THE ISSUE FOR ME. IT APPEARS TO BE A DESIGN PROBLEM, AS I DROVE SEVERAL 2007 AND 2008 F-150'S THAT THE DEALERSHIP HAD ON THE LOT. EACH ONE OF THEM HAD THE PROBLEM I NOTED ABOVE. THE 2009 F-150 DOES NOT HAVE THE BRAKING PROBLEM I FOUND OUT WHEN I TEST DROVE ONE. THE SERVICE MANAGER AT MY DEALERSHIP TOLD ME THAT THE ENTIRE BRAKING SYSTEM WAS RE-DESIGNED FOR THE 2009 MODEL YEAR. *TR

WHEN APPLYING THE BRAKE, THE PEDAL TRAVELS BELOW THE ACCELERATOR CAUSING THE FOOT TO PRESS ON THE BRAKE AND ACCELERATOR AT THE SAME TIME. ON MULTIPLE OCCASIONS, I HAVE RUN THROUGH STOP LIGHTS/SIGNS TRYING TO COME TO A STOP, AND ON OCCASION HAVE ALMOST HIT OTHER VEHICLES. ANOTHER TIME, I WAS BEHIND THE TRUCK GUIDING SOMEONE IN THE TRUCK WHILE BACKING UP. NOT BEING FAMILIAR WITH THE TRUCK, WHEN THE BRAKE PEDAL TRAVELLED PASE THE ACCELERATOR, HIS FOOT CAUSED BOTH TO BE DEPRESSED AT THE SAME TIME ALMOST RUNNING OVER ME BEFORE JUMPING OUT OF THE WAY JUST IN TIME. THIS CONTINUES TO HAPPEN AND RELATED TO THE PROBLEM I BELIEVE IS THE FRONT ROTORS KEEP WARPING. THE ROTORS WERE REPLACED AT THIS INCIDENT TIME BECAUSE THE FORD DEALERSHIP THOUGHT THAT MIGHT BE THE ISSUE. IT DID NOT CORRECT THE ISSUE AND THEY ONLY CHARGED MY HALF-PRICE. *TR

THE FRONT BRAKE ROTORS WARPED FOR THE SECOND TIME. THE FIRST TIME WAS AT APPROXIMATELY 49K MILES. THIRTY-THREE THOUSAND MILES LATER THEY ARE WARPED AGAIN. THE FIRST TIME THEY HAD TO BE COMPLETELY REPLACED. THEY WERE WARPED TOO BAD TO MACHINE THEM. THIS TIME, THE RIGHT FRONT ROTOR HAD TO BE TURNED FOUR TIMES BY THE DEALERSHIP TO GET THE WARPING OUT. THE OTHERS ONLY ONE TURN. THERE SEEMS TO BE A DESIGN FLAW IN THE BRAKING SYSTEM FOR MULTIPLE YEARS OF FORD F-150 TRUCKS. THE SYSTEM WAS COMPLETELY REDESIGNED FOR MODEL YEAR 2009 AND THE PROBLEM SEEMS TO BE GONE. UNFORTUNATELY, I BELIEVE THE DESIGN IS ALSO CONNECTED WITH THE BRAKE PEDAL AND ACCELERATOR PEDAL PROBLEM REPORTED ALSO TO THE NHTSA FOR THIS YEAR (2007) MODEL F-150. UNFORTUNATELY, BECAUSE IT IS CLASSIFIED AS A BRAKING PROBLEM, THE WARRANTIES (FACTORY AND EXTENDED) DO NOT COVER THE EXPENSE OF MACHINING OR REPLACING THE ROTORS. THIS CAN BE SEVERAL HUNDRED DOLLARS EXPENSE TO THE VEHICLE OWNER WHEN IT APPEARS TO BE A DESIGN PROBLEM THAT SHOULD BE HANDLED BY THE FACTORY THRU A RECALL. FORTUNATELY, MY DEALERSHIP HAS WORKED WITH ME SO FAR TO HELP HANDLE THE EXPENSE. FOR CUSTOMER SATISFACTION REASONS, THEY DID NOT CHARGE ME THIS LAST TIME AS THEY REALIZE ROTORS, UNDER NORMAL DRIVING, SHOULD NOT HAVE TO BE REPLACED OR MACHINED WITHIN 30K MILES, ESPECIALLY WHEN THERE IS HARDLY ANY BRAKE PAD WEAR. *TR

I WAS DRIVING DOWN A TOWNSHIP ROAD AND MY TRUCK JUST SHUT OFF WITH NO WARNING AND WOULD NOT START AGAIN HAD TO GET IT TOWED LUCKILY I WASN'T ON A BIGGER ROAD OR ELSE IT COULD HAVE BEEN A SERIOUS ACCIDENT DIDN'T KNOW MY TRUCK JUST SHUT DOWN IN THE MIDDLE OF THE ROAD AT FIRST. IT ENDED UP BEING THE FUEL PUMP DRIVER MODULE WHICH WAS PUT RIGHT ON THE FRAME AND IT CAUSES CORROSION IF THE PART IS THAT IMPORTANT TO WHERE IT JUST MAKES YOUR TRUCK SHUT OFF IT SHOULDN'T BE WHERE IT IS. I FEEL THESE SHOULD BE RECALLED BEFORE THERE IS A SERIOUS ACCIDENT. *TR

WAS EXPERIENCING A SHUTTER SIMILAR TO THE FEELING OF A MISFIRE WHEN ACCELERATING UP A GRADE FROM LEVEL ROAD CONDITIONS. THIS SHUTTER WAS BETWEEN 1250 AND 1500 RPM. TOOK THE VEHICLE TO FORD DEALERSHIP WHO ELIMINATED COIL PACK AND TORQUE CONVERTER AS THE SOURCE OF THE PROBLEM. I HAD TAKEN ANOTHER VEHICLE I OWN TO A REPAIR SHOP I HAVE USED FOE SEVERAL YEARS FOR AN OIL CHANGE AND WHEN I PICKED UP MY VEHICLE I MENTIONED THE PROBLEM I WAS HAVING WITH MY 2007 FORD F150 AND THEY ADVISED THAT MY PROBLEM WAS PROBABLY MISFIRE ON ONE OR MORE PLUGS. THEY ADVISED ME THAT THEY HAD DEALT WITH THIS SAME PROBLEM OVER THE PAST FEW YEARS. THEY PROCEEDED TO INFORM ME THAT THERE WAS A MAJOR PROBLEM WITH REPLACING THE PLUGS-THEY COULD BREAK WHEN REMOVING. IF THAT HAPPENS AND IT DID (4 PLUGS BROKE) THEN ADDITIONAL LABOR COSTS WOULD BE ADDED TO MY BILL. END RESULT A BILL FOR $600.00 TO REPLACE 8 SPARK PLUGS. ABSOLUTELY ABSURD. AS A PART OF THIS EXPERIENCE I HAVE LEARNED THAT FORD MFG THIS ENGINE FROM 2005-2007 AND WHEN THIS ISSUE BEGAN TO SURFACE THAT THEY CHANGED THE ENGINE DESIGN TO ELIMINATE THIS PROBLEM. FORD WAS OBVIOUSLY AWARE THAT A FUTURE PROBLEM WAS GOING TO BE FACED BY THE CONSUMER. WHY SHOULD WE THE CONSUMER HAVE TO BEAR THE FULL EXPENSE TO PAY FOR THEIR FLAWED DESIGN IN THIS ENGINE. THEY SHOULD BE WILLING TO ADMIT THEIR MISTAKE BUT APPARENTLY IT IS GOING TO TAKE SOME LEGAL PRESSURE TO GET THIS DONE. IF THEY DO NOT STEP UP I WILL NEVER BY ANOTHER FORD.

ON MY 2007 FORD F 150 SPORT I WAS INVOLVED IN A CRASH. I STRUCK A LIGHT POLE ON THE SIDE OF THE INTERSTATE ON THE RIGHT FRONT BUMPER AND THE RIGHT FRONT PANEL. AFTER HITTING THE POLE, I WENT DOWN A HILL AND HIT TREES FROM THERE. IT DID MORE DAMAGE TO THE FRONT OF MY TRUCK YET STILL NOTHING FROM THE AIRBAGS. IT WAS ENOUGH FORCE TO CRUSH THE HOOD, AND THE ENTIRE RIGHT PANEL. THE AIRBAGS DIDN'T DEPLOY AND 1 PERSON WAS SERIOUSLY INJURED. FROM WHAT I AM READING, IT TAKE 18-20 LBS OF PRESSURE TO HAVE THEM DEPLOY. IT WAS FOR SURE ENOUGH FORCE TO HAVE THEM DEPLOY AND ACCORDING TO OFFICERS AT THE SCENE, NO ONE CAN UNDERSTAND AS TO WHY THEY NEVER DEPLOYED? I WOULD REALLY LIKE TO GET AN ANSWER ON THIS, AND WOULD LIKE TO KNOW IF FORD EVER RECALLED THIS ISSUE? I ALSO HAVE PICTURES OF THE ACCIDENT. THANK YOU! *TR

I WAS STOPPING AND ABOUT TO PARK INTO A PARKING STALL. AS I WAS APPLYING MY BRAKE, THE VEHICLE SUDDENLY ACCELERATED. IT JUMPED A CURB, CROSSED A LANDSCAPE ISLAND, TOOK DOWN SHRUBS, THEN STOPPED ON THE OTHER SIDE. IT HAPPENED FEW OTHER TIMES, BUT NOT TO THIS EXTEND. OTHER TIMES I THOUGHT I MAY HAVE ACCIDENTALLY PRESSED ON THE GAS PEDAL, AND DID NOT PAY TOO MUCH ATTENTION. ONE OTHER TIME IT HAPPENED, IT WAS RAINING WHEN I THOUGHT PERHAPS IT WAS THE RAIN THAT CAUSED IT. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT FUEL WAS ABNORMALLY LEAKING FROM THE FUEL RAIL TO THE MOTOR. THE CONTACT STATED THAT THE VEHICLE FELT AS IF IT HAD A LOSS OF POWER ONCE THE FAILURE OCCURRED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 31,000.

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 55 MPH WITH THE CRUISE CONTROL ACTIVATED, THE CRUISE CONTROL SYSTEM SUDDENLY STOPPED FUNCTIONING WITH THE ILLUMINATION OF THE WRENCH WARNING ICON. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT APPEARED THAT THE POWER STEERING BEARING FAILED AND THE SERPENTINE BELT BECAME DETACHED FROM THE VEHICLE. AS A RESULT, THE SERPENTINE BELT ERRONEOUSLY CAME INTO CONTACT WITH THE ENGINE TEMPERATURE SENDING UNIT AND FRACTURED THE WIRES FROM THE SENSOR, STRUCK THE CLUTCH FAN AND WAS DESTROYED. THE FAILURE CAUSED ALL OF THE PLUGS AND WIRES TO BE EXPOSED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THE SENSOR UNIT, POWER STEERING PUMP, CLUTCH FAN AND ALL ASSOCIATED PARTS WERE REPLACED. THE MANUFACTURER WAS NOTIFIED AND LODGED A COMPLAINT. THE FAILURE AND CURRENT MILEAGE WAS 57,319. ... UPDATED 12/26/12 *BF

TL* THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 40 MPH, THE VEHICLE BEGAN TO DECELERATE INDEPENDENTLY. THE VEHICLE INCREASED ACCELERATION AFTER CONTINUALLY APPLYING THE ACCELERATOR PEDAL. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 83,000.

I HAVE FACTORY 20 INCH FORD WHEELS ON THIS TRUCK. THESE ARE THE 20 INCH WHEELS THAT CAME ON THE TRUCK NEW. TWO OF THE FACTORY WHEELS HAVE HAD CRACKS THAT APPEAR ON THE WHEEL WHERE THE TIRE BEAD MEETS THE WHEEL. I DO NOT ABUSE MY TRUCK. I CONTACTED FORD MOTOR COMPANY AND THEY SAID THAT THEY HAVE NEVER HEARD OF THIS BEFORE. I HAVE HAD TWO WHEELS DO THIS. IF YOU DO A SEARCH ON THE NET THERE ARE SEVERAL PEOPLE HAVING THIS PROBLEM. I THINK FORD IS TRYING TO HIDE SOMETHING AND IT LOOKS LIKE SOMEONE WILL HAVE TO GET HURT OR DIE BEFORE ANYONE ADDRESS THIS PROBLEM. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE DRIVING 50 MPH THE ELECTRONIC ALL WHEEL DRIVE SHIFTED FROM TWO WHEELS TO FOUR WHEEL DRIVE INDEPENDENTLY. THE CONTACT STATED THAT THE TWO FRONT TIRES LOCKED UP WHEN THE FAILURE OCCURRED. THIS CAUSED THE VEHICLE TO SLIDE TO A STOP. AS A RESULT OF THE FAILURE, THE DRIVE TRAIN SPLIT IN HALF. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 50,000.

I HAVE A 2007 F150 AT THE TIME OF INCIDENT MY FAMILY AND I WERE IN CT AND WERE DOING APPROXIMATELY 45 MPH ON A HIGHWAY. THE TRUCK BEGAN TO BUCK VIOLENTLY AND DROPPED TO 20MPH WITH OUT A WARNING OR LIGHTS. THEN IT STARTED TO RUN NORMAL THEN STARTED THE SAME THING ALL OVER 20 MINUTES LATER. COME TO FIND OUT THAT THE SPARK PLUGS NEEDS TO BE REPLACED. NO GARAGE WILL TOUCH IT DUE TO FORDS POOR DESIGN FORD SAYS IT WILL COST APPROXIMATELY FIVE HUNDRED DOLLARS PLUS DUE TO THE POOR DESIGN THE SPARK PLUGS CAN BRAKE IN THE CYLINDER HEADS. THEY SAID IT CAN BE $50.00 PER BROKEN SPARK PLUG AND POSSIBLY MORE IF THE PLUG CANNOT REMOVE BROKEN PART. I SHOULD ONLY PAY FOR PLUGS NOT FORDS DESIGN FLOOR WHICH NEED TO BE RECALLED. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHEN THE BRAKE WAS DEPRESSED, THE ENGINE RPMS WOULD INCREASE ABNORMALLY, CAUSING THE VEHICLE TO RAPIDLY ACCELERATE. THE CONTACT HAD TO APPLY ABRUPT PRESSURE TO THE BRAKES AND SHIFT INTO NEUTRAL IN ORDER TO STOP THE FAILURE. THE VEHICLE WAS TAKEN TO THE DEALER HOWEVER, THE TECHNICIANS WERE UNABLE TO DIAGNOSE THE FAILURE. THE FAILURE MILEAGE WAS 10,000 AND THE CURRENT MILEAGE WAS 21,000. UPDATED 10/11/12*LJ UPDATED 10/17/2012 *JS

HANKOOK DYNAPRO ATM 285/55/R20 TIRES DEVELOPING SEVERE SIDEWALL CRACK. PURCHASED 4 ABOUT A YEAR AGO. HAD TO REPLACE 2 THIS SPRING AND NOW HAVE TO REPLACE 2 MORE AGAIN WHICH MEANS I WILL HAVE SPENT AN ADDITIONAL $800 FOR ADJUSTMENTS. TIRES ARE RELIGIOUSLY CHECKED AND ARE ROTATED EVERY 10,000 MILES. *TR

FUEL PUMP CONTROL MODULE FAILURE RESULTING IN ENGINE STALLING CAUSING LOSS OF POWER AND CONTROL TO STEERING AND BRAKING FUNCTIONS AT HIGH SPEED AND IN HEAVY TRAFFIC. THE FUEL PUMP CONTROL MODULE ON THE TRUCK FAILED AT INTERMITTENT AND ERRATIC INTERVALS, CAUSING IMMEDIATE SHUT OFF OF FUEL TO THE ENGINE. CONTROL FUNCTIONS, PARTICULARLY POWER STEERING WERE COMPROMISED AND ACCIDENTS WERE BARELY AVOIDED. THE ENGINE WOULD EVENTUALLY RESTART- UP TO THE POINT THAT THE MODULE FAILED COMPLETELY. THE FIRST FUEL PUMP CONTROL MODULE WAS REPLACED AROUND 14000 MILES IN 2010. THE SECOND WAS JUST REPLACED AT 24446 MILES. THE COST TO REPLACE THE FUEL PUMP CONTROL MODULE IS APPROXIMATELY $500.

TL* THE CONTACT OWNS A 2007 FORD F150. THE CONTACT STATED THAT THE VEHICLE EMITTED A GASOLINE FUEL ODOR. THE CONTACT INSPECTED THE VEHICLE AND FOUND THAT THE TOP OF THE FUEL TANK WAS SEPARATED FROM THE BOTTOM LINING DUE TO DEFECTIVE WELDING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 07V278000 (FUEL SYSTEM, GASOLINE: STORAGE: TANK). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 119,000.

2007 F150 5.4 ENGINE OIL DIPSTICK DOES NOT SEAT INTO THE DIPSTICK TUBE PROPERLY,APPROX 1/2", CAUSING THE ENGINE OIL LEVEL TO ALWAYS SHOW 1/2 QUART LOW LEVEL. *TR

THE MOLDING WITH BUILT IN HANDLE BROKE WHILE I WAS GETTING INTO MY TRUCK. I FELL BACKWARD AND CAUGHT MYSELF ON THE TRUCK DOOR SO THAT I WOULD NOT FALL ONTO THE PARKING LOT. THE PART NUMBER IS 4L3Z-1503599-AAA. I REPAIRED THE TRUCK PUT IN NEW MOLDING. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT THE ENGINE BECAME INOPERABLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO ADVISED THAT THE FAILURE COULD HAVE BEEN A MANUFACTURING DEFECT. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE FAILURE WAS FROM THE INTERIOR OF THE ENGINE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ADVISED THE CONTACT THAT THE ONLY WAY THE VEHICLE COULD BE REPAIRED IS IF THE CONTACT COULD PROVIDE THE MANUFACTURE WITH PROOF THAT THE VEHICLE WAS HAVING AN OIL CHANGE PERFORMED EVERY THREE MONTHS AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS 94,000.

WANT ME TO SPEND $689 TO CHANGE SPARK PLUGS DUE TO POSSIBLE BREAKING OF PLUGS AT REMOVAL. APPARENTLY THIS IS A KNOWN PROBLEM.*TR

TOOK TO DEALER FOR CHECK ENGINE LITE. THEY FOUND FPCM READY TO CRACK IN HALF. TOLD ME I WAS LUCKY THE TRUCK MADE IT TO THE SHOP. EXCESSIVE CORROSION BETWEEN FRAME AND MODULE RESULT OF A VERY POOR DESIGN. NOT COVERED BY WARRANTY. SHOULD BE A RECALL. THEY CLAIM THEIR REPLACING 2 TO 3 A WEEK. THIS DEALER DIDN'T EVEN PUT UPGRADE SPACER BOLTS ON. HERE I THOUGHT THEY WERE HELPING ME! *JS

VEHICLE SHAKES AT LOW SPEED VIOLENTLY. DID RESEARCH ON THE WEB THIS IS A COMMON PROBLEM WITH FORD TRUCKS. STORIES OF GETTING THE RUN AROUND FROM THE DEALER FOR SHAKING NEW TRUCK TO EXPENSIVE REPAIRS THAT DIDN'T REMEDY THE PROBLEM. I'M A FAMILY MAN WITH 6 KIDS AND LIMITED MEANS WHICH MEANS I WILL ATTEMPT TO FIX THIS MYSELF BECAUSE I CAN'T AFFORD A PRO-TECH TO TELL ME THE SHAKING IS NORMAL FOR FORD TRUCKS AS IN THE STORIES POSTED ALL OVER WEB DATING BACK SEVERAL YEARS. I'M STILL PAYING FOR MY TRUCK FOR ABOUT ANOTHER YEAR $647.00 A MONTH BOUGHT IT NEW IN 07 ZERO DOWN WHICH IT SEEMS THAT I WILL END UP WITH ZERO. WIFE AND KIDS CAN'T RIDE IN THE TRUCK UNTIL I FIX IT BECAUSE SHE HAS DONE SOMETHING IN ONE DAY THAT IT SEEMS IS TAKING YOU GUYS SEVERAL YEARS TO DO. SHE DEEMED OUR FAMILY CAR UNSAFE AND DANGEROUS. OH WELL I SUPPOSE THERE MIGHT BE A CERTAIN AMOUNT A PEOPLE THAT HAVE TO DIE FIRST BEFORE THIS AGENCY ACTS. I REMEMBER THE ROLL OVER TIRE THING. LETS HOPE I'M NOT ONE OF THEM BECAUSE THAT WOULD LEAVE MY WIFE ON THE HOOK FOR REST OF THE TRUCK PAYMENTS SHE'S A GREAT STAY AT HOME MOTHER BUT THAT'S NOT GONNA PAY OFF THIS TRUCK MC SHAKY. I BET THAT LAST PART MADE YOU SMILE.WISH ME LUCK AND DO YOUR JOB. I GOTTA GO TRY TO DO MINE. *TR

VEHICLE WAS SITTING IN A PARKING SPOT AT A POST OFFICE. I STARTED THE VEHICLE AND DID NOT GIVE IT ANY GAS AND THE ENGINE REVVED TO 6000 RPM'S. NOT KNOWING WHAT HAPPENED, I TURNED THE ENGINE OFF. I STARTED IT AGAIN AND IT DID THE SAME THING BUT STARTED TO COME DOWN IN THE RPM'S BUT I STILL TURNED ENGINE OFF. I STARTED IT A THIRD TIME AND IT REVVED AGAIN BUT CAME BACK TO NORMAL RPM'S. ALL THIS WITHOUT GIVING IT ANY GAS. IN APRIL OF THIS YEAR THE SAME THING HAPPENED TO MY OTHER F-150 THAT IS A 2005 WHICH I WILL ALSO FILE A DETAILED REPORT ON FOLLOWING THIS REPORT. THE FORD DEALERSHIP SAID IT WAS THE THROTTLEBODY AND IT HAD TO BE REPLACED. THEY SAID OTHER FORDS WERE HAVING THE SAME PROBLEM BUT FORD HAS NOT DONE A RECALL AND HAS FAILED TO RECOGNIZE THE SERIOUSNESS OF THIS PROBLEM. AS YOU WILL SEE IN MY REPORT ON MY 2005, IT COULD HAVE RESULTED IN A FATALITY DUE TO THIS ISSUE. LOOKING AT BLOGS IN THE INTERNET, OTHERS HAVE HAD THIS SAME PROBLEM. MY WIFE WAS DRIVING THE 2005 APPROACHING A STOP SIGN ENTERING INTO A VERY BUSY STREET AND THE ENGINE REVVED AND PULLED THE VEHICLE INTO ONCOMING TRAFFIC BEFORE MY WIFE WAS ABLE TO DEPRESS THE EMERGENCY BRAKE AND BRING THE VEHICLE TO A STOP. THE SAME ISSUE ACCORDING TO THE FORD DEALERSHIP WAS THE THROTTLEBODY. *TR

TL* THE CONTACT OWNS A 2007 FORD F150. THE CONTACT STATED THAT WHILE SITTING AT A TRAFFIC STOP, THE RPMS INCREASED EXCESSIVELY. THE VEHICLE WAS PUT INTO PARK, TURNED OFF AND ONCE RESTARTED THE VEHICLE HESITATED BEFORE RESUMING NORMAL FUNCTION. THE VEHICLE WAS TAKEN TO THE DEALER WHO INSPECTED THE FAILURE BUT COULD NOT LOCATE THE PROBLEM. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE WHO ADVISED THE CONTACT THAT THERE WERE NO RECALLS AND OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 12,750.

THE STEERING WHEEL TURNS ABOUT AN EIGHTH OF A TURN AND STICKS,YOU FORCE IT THROUGH THAT AND YOU GET ABOUT ANOTHER EIGHTH TURN...DOESN'T MATTER WITCH WAY YOUR TURNING. *TR

WHILE DRIVING AT A 15 MPH (1000 RPMS) TRUCK WOULD KNOCK AND TRY TO STALL WHEN COMING TO A STOP AND ALMOST CAUSE AN ACCIDENT. I WOULD HAVE TO PRESS THE GAS PEDAL TO KEPT IT FROM STALLING OR PUT INTO NEUTRAL AND PRESS THE GAS TO KEEP IT FROM STALLING. TOOK IT TO FORD DEALERSHIP ON 4/24/2007 AND THEY SAID THAT THE CAM PHASERS WERE THE PROBLEM OF MY ENGINE TRYING TO STALL. AS I DID MY RESEARCH ONLINE THIS SEEMS TO BE A BIG PROBLEM WITH THE 5.4L 3 VALVE ENGINES FROM FORD. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT SPORADICALLY, THE GEAR SHIFTER COULD NOT BE MOVED OUT OF PARK. THE CONTACT NOTICED ALUMINUM SHAVINGS AROUND THE GEAR SHIFTER AND TOOK THE VEHICLE TO THE DEALER. THE DEALER ADVISED THAT THE GEAR SHIFTER WOULD NEED TO BE REPLACED. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNAVAILABLE AND THE CURRENT MILEAGE WAS 87,000.

TL* THE CONTACT OWNS A 2007 FORD F-150 WITH MICHELIN LTX M/S2 SIZE P275 /65 R18. THE CONTACT STATED THAT ALL FOUR TIRES WERE WEARING DOWN IN THE MIDDLE ABNORMALLY. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS TOLD THAT THE TIRES WERE NOT COVERED UNDER RECALL AND THEY COULD ONLY PROVIDE A 20 PERCENT DISCOUNT. THE CONTACT STATED THAT THE TIRES HAD A 75,000 MILE WARRANTY AND THE TIRES WERE ONLY AT 45,000 MILES OF USAGE. THE DOT NUMBER AND VIN WERE NOT AVAILABLE. THE TIRE FAILURE MILEAGE WAS 45,000. THE VEHICLE FAILURE MILEAGE WAS 100,000. UPDATED 5/7/12 *CN

2007 F 150 KING RANCH SPARK PLUGS BREAK WHEN REMOVING THEM (FORD CHEAP SPARK PLUG SYSTEM). THE TRUCK ALSO PULL/TUGS LIKE IF YOUR TRANSMISSION IS MISSING HOWEVER, I'VE BEEN TO THE DEALER MULTIPLE TIMES FOR IGNITION COIL ISSUES. THEY SAID I NEED TO CHANGE SPARK PLUGS. THESE SPARK PLUGS FORD SAID WAS TO LAST 100,000 MILES. *TR

I READ AN ARTICLE IN THE NEWSPAPER ABOUT AN INVESTIGATION YOU ARE DOING ON FORD TAURUS AND SABLE VEHICLES IN THE 2001 TO 2006 MODEL YEARS FOR ACCELERATING ON THEIR OWN. I PURCHASED MY TRUCK IN FEBRUARY OF 2009 USED AND, IN THE THREE YEARS I HAVE OWNED IT, IT HAS DONE THE SAME THING ON FOUR SEPERATE OCCASIONS. I HAD IT CHECKED OUT BY THE LOCAL FORD DEALER IN MY HOME TOWN AND THEY COULD FIND NOTHING WRONG WITH IT. NOTHING SHOWED UP ON THEIR ELECTRONIC EQUIPMENT. THE FIRST TIME IT HAPPENED, I WAS UNHOOKING MY TRAVEL TRAILER AND PUT IT IN DRIVE TO PULL AWAY AND IT SURGED FORWARD IN MY DRIVEWAY. THE SECOND TIME, I WAS IN A CROWDED PARKING LOT AND IT SURGED FORWARD WHILE I WAS TRYING TO PARK. THE THIRD TIME, I WAS PULLING OUT OF MY DRIVEWAY. THE FOURTH TIME, I WAS PULLING INTO AN AUTOMATED CAR WASH AND NEARLY RAN PAST THE ATTENDANTS AND NEARLY CRASHED INTO THE EQUIPMENT. EACH TIME I WAS ABLE TO SHIFT IT INTO NEUTRAL AND TURN THE ENGINE OFF. IT REVS UP SO MUCH THAT I CAN'T HOLD IT WITH THE BRAKE. I THINK THIS SOUNDS LIKE WHAT YOU ARE INVESTIGATING ON THE OTHER VEHICLES AND IT MAY BE HAPPENING IN A WIDER RANGE OF FORD VEHICLES. I WOULD LOVE NOT HAVING TO WORRY ABOUT WHEN IT WILL HAPPEN NEXT. *TR

WHILE DRIVING TRUCK IT SHUT OFF SUDDENLY WITHOUT AND WARNING, DRIVER FUEL PUMP CONTROL MODULE. THIS UNIT IS LOCATED IN AN AREA THAT IS HIGHLY CORROSIVE AND HAS NO PROTECTION AGAINST THE ELEMENTS. WHEN THIS PART FAILED I WAS DRIVING IN A PARKING LOT AT A LOW SPEED HOWEVER I WAS TOLD IT CAN HAPPEN ANY TIME AT ALL. ONCE THIS PART GOES THE VEHICLE IS TOTALLY INOP. I HAD TO HAVE THE TRUCK TOWED IN TO THE DEALER AND THE PART REPLACED AT A COST OF $356.00 LABOR $125.00 PARTS. I WAS ALSO TOLD I WAS LUCKY IT TOOK THIS LONG AND HAD BETTER PLAN ON DOING IT AGAIN IN THE NEAR FUTURE AS IT IS A COMMON ISSUE WITH ALL FORD TRUCKS. FORD REDESIGNED THE PART BUT THE SERVICE MANAGER TOLD ME IT WILL HAPPEN AGAIN AS IT IS ONLY NICKEL COATED AND OFFERS NO PROTECTION FROM THE ELEMENTS. *TR

BOUGHT THE TRUCK NEW. HAS 4 WINTERS ON IT. COST ME $421.12 TO FIX AT A FORD DEALER, PLUS ANOTHER $54.00 TO HAVE TOWED TO DEALER. BAD PLACEMENT OR DESIGN OF PLACEMENT. 118,000 MILES I EXPECT TO START REPLACING PARTS, BUT NOT THIS. WHY SHOULD PEOPLE WHO LIVE IN COLD CLIMATES BE PENALIZED. *TR

DRIVING DOWN INTERSTATE GOING 65 MPH HERE ALOUD POP . ENGINE EJECTED OUT SPARKPLUG CAUSING DAMAGE TO CYL. HEAD. *TR

WHILE DRIVING IN A PARKING LOT THE VEHICLE SHUT OFF COMPLETELY WITHOUT WARNING CAUSING LOSE TO ALL POWER SYSTEMS. THE VEHICLE WOULD NOT START, DEALER STATED THAT THE FUEL PUMP DRIVER CONTROL MODULE IS THE CAUSE OF THIS. THEY FURTHER STATED IT IS A COMMON ISSUE AND SHOULD HAVE A RECALL OR SOME THING FOR THE NORTHERN STATES. ALSO REPLACED WAS THE FUEL RAIL PRESSURE SENSOR(P0191 CODE). STILL NO RESOLVE TO ISSUE. *TR

TWICE NOW, MANUFACTURER INSTALLED SPARK PLUGS HAVE BEEN EJECTED FROM THE ENGINE. BOTH FROM THE PASSENGER SIDE CYLINDER HEAD. *TR

I WENT ONLINE AND FOUND A LOT OF PROBLEMS WITH THE FUEL CONTROL MODULE ON FORD F150. MY CONCERN IS I BROKE DOWN ON THE FREEWAY BECAUSE OF CONTROL MODULE FAILURE. ON A 2007 MODEL. LITTLE SCARY ON THE FREEWAY. I THINK SOME ONE SHOULD LOOK IN TO MAYBE A RECALL ON THIS PART. SO NO ONE ELSE WILL EXPERIENCE THE SCARY BRAKE DOWN I HAD ON THE FREEWAY [I-75]. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE STOPPED, THERE WAS AN INCREASE IN THE ENGINE RPMS. THE FAILURE HAD SINCE RECURRED ON TWO OCCASIONS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 30,000. THE VIN WAS UNAVAILABLE.

THE TRUCK BEGAN TO MAKE A CRACKLING SOUND THE CHECK ENGINE LIGHT CAME ON, LOW OIL PRESSURE LIGHT CAME ON. THE TRUCK MOVED VERY SLOW. THE TRUCK CUT OFF THE TRUCK WAS TOWED TO THE DORDS COMPANY THE NEXT DAY. WAS TOLD IN THE SERVICE DEPARTMENT I NEEDED (3) SPROCKETS TO ADJUST THE TIMING BELT. ON MONDAY I WAS TOLD I NEEDED A NEW MOTOR THAT ONE WAS ALL CHIMED UP. I ASKED WHY I EXPLAINED I CHANGED MY OIL AT THE APPROPRIATE TIMES THE TRUCK IS AT 80,000 MILES. *TR

ENGINE MAKES A KNOCKING NOISE. I WAS TOLD BY A FORD DEALER THAT THEY CAN'T REPAIR IT BECAUSE FORD DOESN'T KNOW WHAT IS WRONG WITH THE ENGINE. I WAS TOLD BY FORD DEALER TO DRIVE IT TILL IT QUITS. THE ENGINE COULD LOCK UP AT ANY TIME, POSSIBLY ON THE HIGHWAY WHICH COULD CAUSE AN ACCIDENT TO OCCUR. I CALLED FORD CUSTOMER SERVICE AND WAS TOLD THERE WAS NOTHING THEY CAN DO. *TR

AIR VENT ADJUSTMENT FAILURE, REQUIRED REPLACEMENT OF PLENUM CHAMBER. CAUSE OF THIS PROBLEM WAS THE FAILURE OF THE ADHESIVE ON TWO FOAM PIECES ATTACHED TO TWO AIR BLEND DOORS WHICH JAMMED BECAUSE THE FOAM FELL OFF AND PREVENTED THE DOORS FROM MOVING. IN ORDER TO REPAIR THE PROBLEM THE ENTIRE DASHBOARD NEEDED TO BE REMOVED AT A COST OF JUST UNDER $1000. I HAVE CONTACTED FORD FOR HELP IN COVERING THIS EXPENSE AND THEY HAVE DENIED IT SINCE THERE IS NO RECALL NOTICE OUTSTANDING. ON LINE SITES ABOUT THIS ISSUE AND THE EXTENSIVE REPAIR COST ARE IN THE HUNDREDS. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT WAS ENTERING THE VEHICLE AND GRABBED THE PULL UP HANDLE LOCATED ON THE DRIVER'S SIDE FRONT DOOR. AS THE CONTACT GRABBED THE HANDLE, THE HANDLE DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER AND THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 68,000.

TL* THE CONTACT OWNS A 2007 FORD F150. THE CONTACT STATED THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY DISCOVERED THAT ALL OF THE ENGINE SPARK PLUGS WERE DEFECTIVE. THERE WERE SIX OR EIGHT SPARK PLUGS REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE FAILURE MILEAGE AND THE VIN WERE UNAVAILABLE. ...UPDATE 01/20/12 *BF UPDATED 01/27/12

CHANGED THE SPARKPLUGS ON OUR 2007 FORD F-150, AND SPARKPLUG BROKE OFF IN THE HEAD, HAD TO BUY A SPECIAL TOOL TO REMOVE IT. THIS IS A MAJOR PROBLEM WITH THESE TRUCKS AND ARE CAUSING SERIOUS DAMAGE TO OTHER VEHICLES. HOW CAN FORD AND MOTORCRAFT GET AWAY WITH A POOR DESIGN WHILE CONSUMERS HAVE TO SUFFER AND FOOT THE BILL FOR THEIR MISTAKES. THIS NEEDS TO BE A RECALL. *KB

HAVING PROBLEMS WITH THE STEERING, I HAVE HAD IT BACK TO THE DEALERSHIP 2 TIMES IN 6 MONTHS. THEY HAVE REPLACED 2 OTHER PARTS, BUT I AM STILL HAVING THE SAME PROBLEM WITH THE STEERING. *TR

VEHICLE WAS PURCHASED USED FROM LOCAL FORD DEALER 10 MONTHS PRIOR (75,000 MILES), AND WAS A DEALER MAINTAINED VEHICLE. I DROVE VEHICLE 3,000 MILES SINCE PURCHASE. WHILE DRIVING AT 20 MPH, I EXPERIENCED SUDDEN AND SEVERE VIBRATION MAKING THE VEHICLE DIFFICULT TO CONTROL. I WAS ABLE TO PULL VEHICLE TO SIDE OF ROAD BUT COULD NOT MOVE VEHICLE > 1 MPH WITHOUT SEVERE VIBRATION. PROBLEM WAS FROM COMPLETE FAILURE OF DRIVE SHAFT CENTER SUPPORT BEARING. THERE WERE NO PREVIOUS INDICATIONS OF IMPENDING FAILURE. THE FAILURE WAS SUDDEN, UNEXPECTED AND COMPLETE. I HAVE SAFETY CONCERNS ABOUT VEHICLE CONTROLLABILITY SHOULD A BEARING FAILURE OCCUR AT HIGHWAY SPEED. IN ADDITION THE BEARING IS LOCATED IN CLOSE PROXIMITY TO THE FUEL TANK. SHATTERED BEARING PARTS COULD POTENTIALLY PENETRATE THE FUEL TANK. THE BEARING IS A NON-SERVICEABLE PART AND THE ENTIRE DRIVESHAFT MUST BE PURCHASED AT A COST OF $1,000, MAKING BEARING CHANGE PRIOR TO FAILURE HIGHLY UNLIKELY. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT LOST STEERING OF THE VEHICLE AND CRASHED INTO A CURVE AND A FENCE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FRONT PASSENGER SIDE TIE ROD WAS FOUND TO BE FRACTURED AND THE CAUSE OF THE CRASH. THE CONTACT WAS ADVISED THAT THE STEERING COLUMN WAS FRACTURED WHEN THE CONTACT CRASHED INTO THE CURVE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 11,000.

MY WIFE AND BABY WERE TRAVELING DOWN THE 405 FREEWAY AT 70MPH WHEN OUT OF NO WHERE THE TRUCKS DASHBOARD LIT UP AND THE TRUCK COMPLETELY SHUT DOWN IN THE FAST LANE. THE GAS PEDAL DID NOTHING AND THERE WAS NO WAY OUT OF THE FAST LANE SAFELY. I NORMALLY WOULDN'T FILE A COMPLAINT EXCEPT IN THIS SITUATION WE HAD JUST PURCHASED THIS "CERTIFIED" USED VEHICLE, IT PUT MY FAMILY IN EXTREME DANGER, AND THE SERVICE CONSULTANT AT FORD HAD INDICATED TO ME THAT THIS WAS A COMMON PROBLEM WITH THE F150 MODEL. I WAS INFORMED THAT IT WAS THE ELECTRONIC THROTTLE BODY OR ELECTRONIC THROTTLE SENSOR THAT HAD GONE OUT AND THAT THE SERVICE CONSULTANT HAD SEEN IT ON FORD F150 TRUCKS RANGING FROM BRAND NEW TO OLDER MODELS. *TR

VEHICLE TAKEN TO DEALER FOR TUNE UP WHICH WAS QUOTED AT A MINIMUM TO BE $500 FOR PARTS AND LABOR DUE TO KNOWN ENGINEERING FLAW WITH THE SPARK PLUGS. SPARK PLUGS BREAK WHEN ATTEMPTING TO REMOVE AND ONE PLUG REMAINED IN THE CYLINDER HEAD. THIS LEAD TO REPLACING THE HEAD WITH A FINAL TOTAL OF $3,500. THIS HAS BEEN A KNOWN PROBLEM WITH MODEL YEARS 2004-2008 AND FORD HAS NOT ISSUED A RECALL OR DISCLOSED THIS KNOWN DEFECT. PREVIOUSLY INSTRUCTED BY DEALER TO NOT HAVE PLUGS CHANGED UNTIL ENGINE STARTED HAVING PROBLEMS.

VEHICLE DOES NOT START, AFTER SPENDING WEEKS AT THE DEALERSHIP AND HAVING THE PCM REPLACED...IT RAN FOR A FEW DAYS AND NOW AGAIN IT WILL NOT START. THE DRIVER IS STRANDED AGAIN OUT ON A REMOTE JOB SITE. THIS PROBLEM HAS BEEN ONGOING NOW FOR TWO YEARS. FORD HAS NOT BEEN ABLE TO GET IT REPAIRED. *TR

SPARK PLUGS BROKE WHEN CHANGING. I'VE HAD MANY FORD VEHICLES AND CHANGED SPARK PLUGS ON A FEW AND NEVER HAVE I ENCOUNTERED THIS ISSUE BEFORE.

2007 FORD F150 @54,000 MILES ROTORS, BRAKES, TOP BALL JOINTS, BOTTOM BALL JOINTS UPPER LEVER ARM, AND NOW MY FRONT BRAKES LOCKED UP LUCKY THERE WAS NO ACCIDENT , AND SEVERAL TIMES I HAVE PRESSED ON GAS AND BRAKE PEDAL AT SAME TIME BECAUSE THEY ARE SO CLOSE TOGETHER. BOTH THE LOCKING UP OF THE BRAKES AND SUDDEN ACCELERATION ARE VERY DANGEROUS. THE MILEAGE IS 54,000 AND HAVE HAD ALL THESE PROBLEMS. IS FORD NOT TELLING THE CUSTOMER OF THESE DANGEROUS PROBLEMS. *TR

THIS VEHICLE HAS HAD A MINIMUM OF 200 NO START CONDITIONS SINCE WE PURCHASED IT. IT HAS BEEN TO THE DEALERSHIP 20 OR MORE TIME FOR THIS PROBLEM. THEY CAN NOT OR WILL NOT FIX IT. *KB

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED WATER WAS ENTERING THE VEHICLE FROM THE THIRD BRAKE LIGHT ABOVE THE CABIN. AS A RESULT, THE INTERIOR OF THE VEHICLE WAS BEGINNING TO MILDEW. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE FAILURE. THE DEALER INSPECTED THE VEHICLE AND REPLACED THE BRAKE LIGHT ASSEMBLY SEVERAL TIMES, BUT THE REPAIR DID NOT CORRECT THE FAILURE AND THE FAILURE PERSISTED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 34,000 AND THE CURRENT MILEAGE WAS 54,000.

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT WAS DRIVING 70 MPH WHEN THE VEHICLE ACCELERATED WITHOUT WARNING. THE CONTACT APPLIED THE BRAKES AND THE VEHICLE BEGIN TO JERK. THE CONTACT WAS ABLE TO STOP THE VEHICLE AND SHUT OFF THE ENGINE. THE VEHICLE WAS RESTARTED THAN PROCEEDED WITHOUT FURTHER INCIDENT. THE CONTACT WAS CONCERNED THAT THE FAILURE COULD POTENTIALLY LEAD TO A MAJOR CRASH AND BELIEVED THE VEHICLE WAS UNSAFE TO DRIVE. THE FAILURE MILEAGE WAS 89,000.

3 OUT OF 8 SPARK PLUGS BROKE DURING A ROUTINE SPARK PLUG CHANGE INCURRING HUNDREDS OF DOLLARS IN REPAIRS. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THE FRONT DRIVERS SIDE BRAKES LOCKED, AND THE VEHICLE CAME TO A SLOW STOP. A LOCAL MECHANIC DIAGNOSED THAT A NEW HOSE WAS NEEDED TO REPAIR THE FAILURE. THE DEALER WAS NOTIFIED, BUT DENIED ASSISTANCE WITH THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 22,000 AND THE CURRENT MILEAGE WAS 22,397.

2007 FORD F-150. CONSUMER WRITES TO EXPRESS DISSATISFACTION WITH LOCAL DEALER *TGW THE CONSUMER STATED AFTER HE PURCHASED THE VEHICLE, HE IMMEDIATELY COMPLAINED TO THE DEALER ABOUT NOT BEEN ABLE TO READ ONE GAUGE DURING DAYLIGHT BECAUSE OF THE COLOR ARRANGEMENT. THE CONSUMER ALSO STATED THERE WAS AN ISSUE WITH THE BRAKE AND GAS PEDALS, BUT SOMEONE MADE AN ADJUSTMENT AND CORRECTED THE PROBLEM. *JB

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT THE ENGINE WOULD NEED REPLACING. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THE FAILURE HAD OCCURRED BECAUSE THE CONTACT PERFORMED THE OIL CHANGES TO THE VEHICLE AND USED A FRAM OIL FILTER, WHICH UTILIZED CARDBOARD IN THE FILTER AND CAUSED DAMAGE TO THE ENGINE. THE MANUFACTURER DENIED ASSISTANCE BECAUSE THE CONTACT HAD NOT HAD THE OIL CHANGED BY AN AUTHORIZED DEALER. THE VIN WAS UNAVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 77,000.

THIS VEHICLE HAS EXPERIENCED A NO STARTING CONDITION 40-50 TIMES SINCE WE PURCHASE IT. IT HAS BEEN TO THE LOCAL FORD DEALERSHIP MULTIPLE TIMES(20 OR MORE) FOR THE CONDITION. THIS VEHICLE IS OPERATED BY THE CHARLESTON COUNTY PUBLIC WORKS DEPARTMENT AND HAS REPEATEDLY STRANDED OUR EMPLOYEE AT REMOTE LOCATIONS AROUND THE COUNTY AND PREVENTED THE EMPLOYEE FROM RESPONDING TO WORK ASSIGNMENTS. BETWEEN THE DTE OF 6/21/11 AND 7/5/2011 OT HAS BEEN TOWED TO THE DEALERSHIP FOUR TIMES!!!! *TR

FORD SPARK PLUGS BLOW OUT OF HEAD BECAUSE THEY ARE NOT THE CORRECT PLUGS FROM FACTORY AND ARE NOT TIGHTEN CORRECTLY. THERE NEEDS TO BE A RECALL.

TL*THE CONTACT OWNS A 2007 FORD F150. WHILE ATTEMPTING TO MAKE A LEFT TURN, THE CONTACT STATED THAT THE STEERING WHEEL VIOLENTLY JERKED AND PULLED THE VEHICLE TO THE RIGHT, WHICH CAUSED HIM TO CRASH INTO A FENCE. THE CONTACT SUSTAINED A LARGE CUT ON HIS FOREARM, WHIPLASH, KNOT ON THE HEAD, AND A BROKEN FINGER. A POLICE REPORT WAS FILED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THEY INSPECTED THE VEHICLE AND CONFIRMED THAT THE STEERING COLUMN FRACTURED. THE MANUFACTURER WAS NOT NOTIFIED. THE CURRENT AND FAILURE MILEAGE WAS 12,000. THE VIN WAS UNAVAILABLE.

TL*THE CONTACT OWNS A 2007 FORD F-150 5.7 V8. THE CONTACT STATED THAT HIS VEHICLE EXPERIENCED A LEAK IN THE EXHAUST GASKET MANIFOLD; WHICH WAS LETTING OFF TOXIC FUMES IN THE AIR. THE DEALERSHIP WAS CONTACTED AND DIAGNOSED THAT THE CONTACT MAY NEED A NEW GASKET OR MANIFOLD. THE FAILURE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 45,000 AND THE CURRENT MILEAGE WAS 70,000. UPDATED 07/21/11 *BF UPDATED 09/19/11

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHILE THE ENGINE WAS RUNNING, THE CONTACT SMELLED FUEL INSIDE THE VEHICLE. UPON FURTHER INSPECTION, A FUEL LEAK WAS DISCOVERED. THE CONTACT THEN CALLED A TOWING SERVICE AND THE TOWING COMPANY CALLED THE FIRE DEPARTMENT. THE FIRE DEPARTMENT APPROVED OF THE VEHICLE BEING TOWED TO A LOCAL REPAIR FACILITY. THE MECHANIC NOTICED TWO HOLES IN THE FUEL LINE AND THE FUEL LINE WAS REPLACED. AFTER THE REPAIRS, THE CONTACT HAD NO FURTHER ISSUES. THE CONTACT STATED THE FUEL LINE SHOULD HAVE BEEN COVERED OR MADE WITH SHEET METAL BECAUSE AN ANIMAL WAS ABLE TO CHEW THROUGH THE FUEL LINES, CAUSING A LEAK. THE FAILURE MILEAGE WAS 18,200.

MY F150 WITH ABOUT 45000 MILES HAS TWICE HAD AN ENGINE SURGE AS I PULLED TO STOP WITH MY FOOT ON THE BRAKE. IT BASICALLY REVS TO ABOUT 4500 RPM FOR ABOUT 3 SECONDS. I BROUGHT IT INTO THE DEALER TWICE. THE FIRST TIME THE CHARGED ME ABOUT $140 TO RESET MY COMPUTER CHIP. THE SECOND TIME I BROUGHT IT IN AND THEY SAID THERE WERE NO RECALLS AND BASICALLY I SHOULD PAY 300+ AND REPLACE THE THROTTLE BODY. I'M CERTAIN THERE IS A DEFECTIVE CHIP OF SOME SORT SO REPLACING A MECHANICAL DEVICE WILL NOT SOLVE THE PROBLEM. I'M GLAD I READ THESE BULLETINS BECAUSE I KNOW THIS SHOULD BE A MAJOR RECALL. I AM SAVING THIS EMAIL IN CASE I DAMAGE PROPERTY OR RUN SOMEONE OVER AT AN INTERSECTION OR PARKING LOT. PLEASE RESPOND TO ME TO LET ME KNOW WHAT IT WILL TAKE FOR A RECALL TO OCCUR. IT DOES SCARE ME TO DRIVE MY TRUCK! THE FIRST TIME I ENDED UP IN THE INTERSECTION AND THE SECOND, I ALMOST HIT THE CAR IN FRONT. *TR

SEAT BELT IS FRAYING ON THE INSIDE OF THE DRIVERS SIDE BELT. THE BELT RUBS AGAINST ITS PLASTIC RETAINER GUIDE. *TR

DRIVELINE HAS BEEN VIBRATING AT 55 MPH FOR MONTHS. FORD SERVICE TOLD ME IT WAS THE TIRES, SO I PUT A NEW SET OF TIRES ON MY 2007 F150 KING RANCH SUPERCREW. STILL NOT THE PROBLEM. HAD IT CHECKED OUT BY THE TIRE SHOP AND THEY SAID IT WAS THE DRIVELINE NEEDED REBALANCING. THE TRUCK IS ONLY 4 YEARS OLD AND SHOULD NOT BE DOING THIS. PROBLEM STARTED ABOUT 50000 MILES - OUT OF WARRANTY OF COURSE. A RECALL SHOULD BE INSTATED FOR FORD TO CORRECT THE ISSUE. *TR

TL* THE CONTACT OWNS A 2007 FORD F150. THE CONTACT WAS DRIVING 35 MPH AND DECELERATING IN AN ATTEMPT TO MAKE A LEFT TURN WHEN THE VEHICLE STALLED AND THE BRAKES BECAME UNRESPONSIVE. THE VEHICLE WAS TAKEN TO THE DEALER WHO PERFORMED A DIAGNOSTIC THAT LOCATED THE FAILURE AT THE CAM-SHAFT POSITION SENSOR, THE CRANK SENSOR, THE TIMING SOLENOIDS AND THE VALVE GASKET. THE PARTS WERE REPLACED BUT THE REPAIR DID NOT CORRECT FAILURE AND THE VEHICLE CONTINUED TO STALL SPORADICALLY. IN ADDITION, THE CONTACT STATED THAT THE ENGINE WAS EXTREMELY LOUD AS IF IT WERE A DIESEL ENGINE. THE VEHICLE WAS TAKEN BACK TO THE DEALER FOR FURTHER DIAGNOSIS. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 78,000.

TL* THE CONTACT OWNS A 2007 FORD F150. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH WHEN THE VEHICLE CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE CONTACT STATED THAT THE FRONT DRIVER AND PASSENGER SIDE SEAT BELTS DID NOT RESTRAIN THE DRIVER AND PASSENGER. IN ADDITION, THE AIR BAGS DID NOT DEPLOY AND THE CONTACT STRUCK HIS HEAD ON THE WINDSHIELD. AS A RESULT, HE SUFFERED A CONCUSSION AND DEVELOPED POST CONCUSSION SYNDROME. THE CONTACT ALSO SUFFERED INJURIES TO HIS BACK. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE FROM THE SCENE OF THE CRASH AND THE VEHICLE WAS TAKEN TO A COLLISION CENTER WHERE THE BODY DAMAGE WAS REPAIRED. THE VEHICLE WAS THEN TAKEN TO THE DEALER WHERE THE TECHNICIAN STATED THAT THE SEAT BELT MODULES WERE FAULTY. THE DEALER DID NOT INFORM THE CONTACT IF THERE WAS A FAILURE WITHIN THE AIR BAGS. THE VEHICLE WAS LEFT WITH THE DEALER AND WAS UNDERGOING FURTHER INSPECTION. THE TECHNICIAN ALSO STATED THAT THE MANUFACTURER WOULD NOT ASSIST WITH THE COST OF REPAIRS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 42,500.

TL* THE CONTACT OWNS A 2007 FORD F150. THE CONTACT NOTICED THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED WHILE THE VEHICLE WAS PARKED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIANS STATED THAT THE CABLE IN THE STEERING COLUMN THAT CONNECTED TO THE AIR BAG SENSOR IN THE STEERING WHEEL WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER INFORMED THE CONTACT THERE WAS A RECALL FOR THE AIR BAGS WHICH DID NOT INCLUDE HIS YEAR, MAKE AND MODEL BUT THE PRIOR YEAR ONLY. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

BACK UP SENSORS ON MY F150 TRUCK FAILED TO WORK. I BACKING OUT OF A DARK, UNLIT, WINDING DRIVEWAY AND BACKED INTO A TREE. *TR

CENTER BEARING FAILED ON DRIVESHAFT AT 88,000 MILES TRUCK WAS SHAKING VIOLENTLY.BELIEVE THERE IS A SAFETY ISSUE AND A DEFECT WITH THIS DRIVE SHAFT. LOOKED ON THE INTERNET AND I CAN SEE I AM NOT THE ONLY ONE WITH THIS PROBLEM.HOPE THIS IS LOOKED AT CAREFULLY SO NO ONE GETS HURT. THANK YOU *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHEN ATTEMPTING TO DECELERATE, THE VEHICLE WOULD ABNORMALLY ACCELERATE INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE SHE WAS ADVISED THAT THE VEHICLE WOULD HAVE TO REMAIN WITH THE DEALER UNTIL THEY WERE ABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 45,000.

OUR 2007 F150 INTERMITTENTLY LOSSES POWER UNDERLOAD, STUMBLES, BUG DOWN AND STALLS. WE HAD A VERY HORRENDOUS EXPERIENCE THE LAST TIME IT HAPPENED WE ALMOST GOT WIPED OUT BY AN 18-WHEELER TRACTOR BECAUSE OF EXTREME DIFFICULTY MANEUVERING BACKWARDS DOWNHILL WITH STALLED ENGINE, NO POWER STEERING, NO POWER BRAKES. OTHER DRIVERS WERE SO IRATE BECAUSE WE BECAME ROAD HAZARD AT THAT MOMENT IN TIME. MY HUSBAND KEEP ONTRYING TO START THE ENGINE AND LOTS OF SMOKE CAME OUT OF THE DASH. HE IMMEDIATELY OPENED THE HOOD AND ISOLATED THE BATTERY. A CERTIFIED MECHANIC RECOMMENDED THAT WE SHOULD ADDRESS THE IGNITION SPARK PLUG PROBLEM DUE TO THE SYMPTOM AND MILEAGE OF THE TRUCK. WE THEN FOUND OUT THAT #4 FIREWALL-PASSENGER SIDE SPARK PLUG WAS BROKEN (SPECIALTY TOOLING ROTUNDA AND CAL CANNOT REMOVE IT). GOT LUCKY ON THE OTHER 3 SEPARATED ONCE THE TOOLS MANAGED TO REMOVE THEM. IT NEEDS $1000-$3300 TO RECTIFY THE DAMAGE DONE BY THE BAD PRODUCT DESIGNED MOTORCRAFT SPARK PLUGS. FORD DENIED HELP ON POTENTIAL REPAIR BILL DUE TO WARRANTY LAPSE. THE DEALER RECOMMENDED NOT TO NEED ANY TUNE UP EXCEPT FILTER/OIL CHANGES PRIOR TO 100,000 MILES. AT THE PRESENT WE GOT ROB OF OUR ONLY "RELIABLE?" MOBILITY.HOWEVER FORD CREDIT KEEPS COLLECTING FROM ME TO PAY FOR A DEAD HORSE. FORD HAD FULL AWARENESS OF THE CANCER IN THESE SAID ENGINES BUT FAILED TO NOTIFY THE F150 OWNERS. FOR THE SAFETY OF BOTH MOTORISTS AND PEDESTRIANS ALIKE, DOES THIS VERY SERIOUS DRIVEABILITY PROBLEM WARRANTS AN IMMEDIATE INVESTIGATION AND RECALL. THE PROBLEM STARTED OCT 2010, NOV 2010 WE THOUGHT IT WAS BAD GAS SO WE KEEP CHANGING FUEL FILTERS, THEN DEC 22, 2010 IT DIED ON THE FREEWAY. *TR

DRIVER'S SIDE WHEEL ROTOR AND BALL BEARINGS, ROTOR STARTED MAKING NOISE OF A GRINDING APRIL 2009 WE REPLACED THE ROTOR AND 2 MONTHS LATER THE NOISE STARTED UP AGAIN, WE THEN REPLACED IT AGAIN. THE ROTOR EVERY 2 MONTHS WILL BE COMPLETELY ATE UP AND BROKEN DOWN. THIS LAST TIME WE REPLACED ROTOR ON THE DRIVERS SIDE THE LEFT FRONT AND AGAIN 2 MONTHS LATER HAD TO DO IT AGAIN IN DEC. 2010. IT IS NOW FEB 2011 AND THE ROTOR IS AGAIN MAKING THE NOISE AND NOW THE WHEEL IS SHAKING AND WE ARE GETTING A KNOCKING NOISE ON THE DRIVERS SIDE FRONT FLOOR BOARD. *TR

IN THE EVENT OF ICE OR SNOW ON, THE DOOR HANDLE , THE SPRING CAN FAIL CAUSING THE DOOR LATCH TO RELEASE/ AND DOOR OPEN WHILE DRIVING AND OCCUPANT(DRIVER) CAN FALL OUT OF VEHICLE BECAUSE DOOR DOES NOT CLOSE AND BOUNCES WHEN CLOSED DUE TO SPRING FAILURE TO CATCH. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT WAS SHIFTING FROM PARK TO REVERSE WHEN THE VEHICLE ABNORMALLY ACCELERATED IN REVERSE UNTIL HEAVY PRESSURE WAS APPLIED TO THE BRAKE PEDAL. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED. APPROXIMATELY FOUR DAYS LATER, THE FAILURE RECURRED WHILE DECELERATING FROM APPROXIMATELY 5 MPH. THE CONTACT WAS UNABLE TO STOP THE UNINTENDED ACCELERATION BY APPLYING THE BRAKES AND WAS INVOLVED IN A CRASH. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS REPAIRED FOR THE BODY DAMAGES. THE FAILURE AND CURRENT MILEAGE WAS 55,000.

DEFECTIVE SPARK PLUGS IN 2007 FORD F150 5.4 L 3VALVE V8. I WAS INFORMED BY MY MECHANIC AT FORD THAT THERE IS A STRONG POSSIBILITY THAT ONE OR ALL OF MY SPARK PLUGS MIGHT BREAK DURING REMOVAL, AND THAT IT WILL COST AN ADDITIONAL 90.00 TO EXTRACT EACH BROKEN PLUG. IN FACT THERE IS A TSB BULLETIN WITH PROCEDURES TO ADDRESS THIS ISSUE. TSB 08-1-9 . I CAN NOT BELIEVE THAT IN THE MODERN AGE WE HAVE SUCH A DEFECTIVE SITUATION. AND NO REMEDY. FORD HAS STATED THAT THEY WILL NOT ADDRESS THIS PROBLEM UNTIL THERE ARE SUFFICIENT COMPLAINTS AND INSTRUCTED BY YOUR AGENCY. LEAVING THOSE OWNERS OF THE 5.4L ENGINE TO FOOT THE REPAIR BILL ON AN OTHERWISE SIMPLE PROCESS FOR OTHER VEHICLES. IN ADDITIONTHE FORD MANUAL STATES THE SPARK PLUGS ARE GOOD FOR 100,000 MI. BUT THE SERVICE DEPARTMENT HIGHLY RECOMMENDS REPLACING THE SPARK PLUGS AT 60,000 MI TO PREVENT SEIZED SPARK PLUGS. QUITE A CONTRADICTION. IF THIS IS POOR ENGINEERING ON FORDS PART, THE CONSUMER SHOULD NOT HAVE TO BEAR THE BURDEN. *TR

DRIVING ALONG, HEARD A BANG, SMELLED VERY STRONG SMELL OF FUEL, TRUCK STARTED BACKFIRING AND VIBRATING SO MUCH IT WAS HARD TO CONTROL, FORWARD MOTION SLOWED RAPIDLY, VIBRATION, ATTEMPTED TO PULL THE TRUCK OVER ACROSS 4 LANE OF TRAFFIC, OPENED WINDOWS AS THE SMELL OF FUEL WAS CHOKING EVERYONE IN THE CAB. STOPPED TRUCK, ENGINE RUNNING VERY ROUGH AND HAD STRANGE NOISE, UNABLE TO LOCATE. EVENTUALLY FOUND RIGHT REAR MOST SPARK PLUG BLEW OUT OF HEAD (LEAVING METAL THREADED PART AND BASE IN HEAD), CONTACTED DEALER "BIG FORD, VANCOUVER, WA" AND "COURTESY FORD, PORTLAND, OREGON" BOTH CLAIM THE "FLEX FUEL ENGINES HAVE A COMMON PROBLEM WITH THE SPARK PLUGS SEPARATING, STICKING IN THE HEAD, AND/OR EXPLODING OUT OF THE HEAD" THE ALSO STATED THE FORD WAS AWARE OF THE PROBLEM BUT NO RECALL WAS TAKING PLACE AS THERE WERE NOT ENOUGH COMPLAINTS AS OF YET (THE TRUCK ENGINE IS DAMAGED, STILL SMELLS LIKE FUEL INSIDE THE CAB, PLUGS, COIL, AND INJECTOR HAVE BEEN CHANGED, DEALER WOULD NOT HONER "BUMPER TO BUMPER WARRANTY" THIS ISSUE WILL EVENTUALLY CAUSE A GREAT NUMBER OF DEATHS AND OR INJURIES AND THE FUEL ISSUE COULD LIKELY CAUSE AN EXPLOSION (EVEN IN MY VEHICLE AFTER THE REPAIRS)(DEALERS WANTED BETWEEN $2,000.00 AND $6,000.00 TO EXTRACT THE SPARK PLUG BASES AND STATED REPEATEDLY IT WAS A COMMON ISSUE AND IT WAS "NOT COVERED UNDER WARRENTLY"

MY TRUCK WAS GIVING HESITATION GOING UP HILLS AND I CALLED TO MAKE AN APPOINTMENT WITH FORD (MIND YOU THERE WAS NO ENGINE LIGHT ON) BUT BEFORE I COULD GET IT LOOKED AT THE SPARKPLUG BLEW OUT OF IT AND ALTHOUGH I HAVE A WARRANTY FORD IS TELLING ME IT IS NOT COVERED BECAUSE I DROVE IT THAT WAY LIKE I WAS SUPPOSE TO KNOW THE PLUG WAS LOOSE AS HE SAYS. THE GARAGE HAS THE OPTION OF HOW THEY WORD IT TO DETERMINE IF IT IS COVERED AND THEY WOULD NOT LISTEN TO ME WHEN I TOLD THEM THERE WAS NO WARNING. ALL THEY SAID IS I DROVE IT THAT WAY FOR SO LONG THAT IT WAS MY PROBLEM. *TR

AT SLOW SPEEDS, 5 TO 10 MPH, AND WHEN THE ENGINE IS COLD, WHEN YOU ATTEMPT TO BRAKE FOR A STOP, THE ENGINE CAN REV TO 1750 TO 2000 RPM, PROHIBITING YOUR STOP, POTENTIALLY CAUSING AN ACCIDENT. A HARD BRAKING ACTION IS NECESSARY OR SHIFTING TO NEUTRAL IS REQUIRED. AFTER DISCUSSING THIS COMPLAINT WITH ANOTHER FORD TRUCK OWN, WE'D DECIDED THAT OUR RIGHT FOOT WAS NOT ONLY ATTEMPTING TO DEPRESS THE BRAKE PEDAL, BUT ALSO THE GAS PEDAL SIMULTANEOUSLY. BOTH ARE IN CLOSE PROXIMITY OF EACH OTHER, WHICH PROVIDES FOR THIS OPPORTUNITY. I'D SUGGEST A DESIGN CHANGE, TOWARD FORD, SEPARATING THE TWO PEDALS SLIGHTLY IN A BETTER ATTEMPT TO AVOID THIS FROM HAPPENING. I'M SORRY FOR THE FORM SUBMISSION, BUT IT WAS IN AN ATTEMPT TO CORRECT A SOMETHING I'D THOUGHT WAS A REAL ISSUE. THANK YOU FOR YOUR TIME.

MY WIFE WAS DRIVING HER 2007 F150 CREW CAB WITH 33,000 MILES. SHE WAS APPROACHING A STOP SIGN AND THE ENGINE REVVED VARY HIGH AND SHE COULD NOT STOP FOR THE INTERSECTION. FORTUNATELY THERE WAS NO ONCOMING TRAFFIC AS SHE SHOT STRAIGHT THROUGH THE INTERSECTION BEFORE SHE GOT THE VEHICLE UNDER CONTROL. SHE WAS SCARED TO DEATH. I CALLED THE FORD DEALER AND THEY SAY THEY NEVER HEARD OF THE PROBLEM! I TOLD THEM TO DO AN INTERNET SEARCH AND THEY WILL SEE THOUSANDS OF DOCUMENTED CASES BUT I'VE YET TO SEE A SOLUTION POSTED. *TR

I BOUGHT A USED FORD 2007 F-150 SUPER CREW CAB 4X4. NEW TIRES WERE PUT ON BY THE DEALER. I HAVE HAD THREE SEPARATE INCIDENTS OF THE TIRE VALVE STEMS BREAKING AND CAUSING DEFLATION WHILE IN MOVEMENT. AFTER TWO BREAKING I WENT TO THE DEALER AND COMPLAINED. I WAS TOLD THEY HAD NO REASON OR COMPLAINTS OF THIS OCCURRING.WHILE TRAVELING OUT OF STATE I HAD A THIRD STEM BREAK. EACH TIME I HAD NEW STEMS REPLACED. I BEGAN RESEARCHING FOR MYSELF AND FOUND AN ARTICLE WHICH STATED THAT FORD HAD COMPLAINTS OF DEFECTIVE VALVE STEMS ON ALMOST ALL THEIR VEHICLES INCLUDING MERCURY'S. AFTER TWO ATTEMPTS AND COMPLAINTS TO MY DEALER I WENT TO A LOCAL TIRE DISTRIBUTOR AND THEY RECOMMENDED REPLACING ALL RUBBER VALVE STEMS WITH BRASS HIGH PRESSURE VALVE STEMS. AFTER DOING THIS I HAVE NOT HAD A PROBLEM. THE COST FOR RUBBER STEMS ARE AROUND $1.50 EACH AND I PAID $6.00 EACH FOR THE GOOD STEMS. THIS IS A SMALL PRICE TO PAY FOR YOU AND YOUR FAMILY'S SAFETY. MY DEALER STILL HASN'T CONTACTED ME WITH A SUGGESTION AS TO CORRECTING THE PROBLEM. FIRST INCIDENT WAS AROUND APRIL 5, 2010 AND SECOND INCIDENT AUGUST 24, 2010 AND THIRD WAS OCTOBER 18,2010. *TR

2007 FORD F150 4X4 MY WIFE CANE HOME FROM WORK AND SAID THE REAR END WAS MAKING A SOUND I WENT OUT TO LOOK AND FOUND THE REAR HOUSING HAD BROKE OFF AT THE HOUSING BELL AND WAS RESTING ON THE AXLE. IN ALL MY LIFE I HAVE NEVER SEEN THIS. ALL PEOPLE I TALK TOHAVE NEVER SEEN THIS. I DO THINK THIS IS A DEFECT IN THE HOUSING. JUST WANTED TO KNOW IF THIS HAS EVER BEEN REPORTED BEFORE. IF SO CAN ANY THING BE DONE ABOUT IT. CAN FORD BE HELD RESPONSIBLE FOR IT. THANK GOD SHE WAS NOT IN A WRECK. PICKUP WILL ONLY BE FOUR YEARS OLD IN DEC. *TR

THIS EVENT HAS OCCURRED TWICE IN THE LAST 3 MONTHS. THE VEHICLE IS A 2007 FORD F150 STX MODEL WITH THE 4.6L V8. IN THE LAST 3 MONTHS TWICE THE #3 CYLINDER HAS BLOWN A COIL PACK. THE FIRST TIME ALL I HAD TO DO WAS REPLACE THE COIL PACK. THIS MOST RECENT TIME IT ACTUALLY BLEW THE SPARK PLUG OUT OF THE CYLINDER HEAD. I AGAIN HAD TO REPLACE THE COIL PACK BUT THIS TIME I HAD TO BUY A KIT TO REPAIR THE STRIPPED HEAD. THE VEHICLE SHUT OFF AND WOULD NOT RESTART. I WAS ABLE TO GET THE VEHICLE TO THE SIDE OF THE HIGHWAY WITH OUT INCIDENT. I WAS DRIVING ON A MAIN HIGH WAY BUT LUCKILY I WAS IN THE FAR RIGHT HAND LANE. HAD I NOT BEEN I DON'T KNOW IF I WOULD HAVE BEEN ABLE TO GUIDE THE VEHICLE TO SAFETY AS IT HAD NO POWER. *TR

EVIDENTLY, FORD HAS HAD A MAJOR PROBLEM WITH THEIR TRUCK SPARK PLUGS FOR YEARS. JUST GOOGLE "FORD TRUCK SPARK PLUGS" AND YOU WILL FIND MANY COMPLAINING ABOUT THIS ALONG WITH THEIR UNBELIEVABLE STORIES OF MISERY THIS HAS CAUSED. I AM CONTINUALLY HAVING THE COILS ON THE SPARK PLUGS GO OUT. I REPLACED ONE AND IT COST ME $262. NOW, I HAVE ANOTHER GOING OUT. THE TRUCK RUNS ROUGH. I WOULD REPLACE ALL OF THEM, BUT THE FORD DEALERSHIP RECOMMENDED NOT TO BECAUSE THEY SAID THESE PLUGS BREAK OFF WHEN TRYING TO REMOVE THEM AND THEN TEND TO BLOW OUT OF THE ENGINE AFTER REMOVING AND REPLACING THEM. THEN, I RESEARCHED THIS ON THE INTERNET AND READ ABOUT THE HORROR STORIES ABOUT THESE FORD SPARK PLUGS. I HAVE CONTACTED FORD BY EMAIL, BUT THEY SAID UNTIL THE NHTSA ISSUES A RECALL, THEY WILL DO NOTHING. PLEASE HELP US WITH THIS.

I BOUGHT A NEW 2007 FORD F150 IN 2007. IT IS NOW 2010 WITH 44K MILES. I HAVE HAD MULTIPLE ISSUES SINCE I PURCHASED IT WITH THE EMER. BRAKE, TIRES AND FRONT END POPPING, BUT TODAY WAS THE WORST! I WAS DRIVING APPROX 50 MPH TOOK MY FOOT OFF THE GAS AND MY TRUCK BEGAN ACCELERATING! I STARTED BRAKING AND IT FAILED TO SLOW DOWN AS IT APPROACHED 60MPH. I PUT BOTH FEET ON THE BRAKE PRACTICALLY STANDING ON IT USING THE STEERING WHEEL FOR LEVERAGE AND IT DID FINALLY SLOW TO ALMOST A STOP BUT THE ENGINE WAS REVVING VERY LOUD AND YOU COULD FEEL THE TRUCK PULLING FORWARD AS I HAD THE BRAKE TO THE FLOOR. I HAD TO START CUTTING THE STEERING WHEEL TO THE LEFT TO KEEP FROM HITTING A CAR IN FRONT OF ME AT THE STOP LIGHT. I FINALLY IN PANIC MODE KEPT MY FEET ON THE BRAKE, ENGINE REVVING THE WHOLE TIME AND SHIFTED INTO PARK. IT FINALLY STOPPED AND THE ENGINE SLOWED. I WAS SCARED TO PUT IT BACK INTO DRIVE. I DID HOWEVER PUT IT IN DRIVE AND SLOWLY STARTED MOVING FORWARD AS A POLICEMAN BEHIND ME BLUE LIGHTED ME TO PULL OVER. I WAS RELIEVED TO SEE HIM THINKING HE HAD WITNESSED THE EVENT AND WAS GOING TO HELP. I WAS PHYSICALLY SHAKING AND MY 7 YEAR OLD WAS CRYING VERY SCARED ASKING ME, "MOMMY WHY DID OUR TRUCK NOT STOP AND SOUND LIKE A RACE CAR?" I ASKED THE POLICEMAN DID YOU SEE WHAT HAPPENED? HE SAID, "YES MAM I SAW YOU TRYING TO STOP BUT THAT ISN'T WHY I PULLED YOU, I CLOCKED YOU GOING 60 IN A 45 APPROACHING THE LIGHT." I TRIED TO EXPLAIN TO HIM WHAT HAPPENED. HE DID SEE HOW THE TRUCK DIDN'T WANT TO STOP BUT HAD TO TICKET ME NEVER THE LESS BECAUSE OF THE ACCELERATION. I JUST GOT HOME AND STARTED LOOKING ONLINE TO SEE IF THERE IS A RECALL AND FOUND THAT THERE ARE 148 OTHER COMPLAINTS ABOUT THIS ISSUE WITH NO RECALL OR EXPLANATION FROM FORD! I AM TAKING MY TRUCK TOMORROW TO THE SHOP TO HAVE IT CHECKED AND THE COMPUTER SCANNED FOR ANY ERROR CODES! WE COULD HAVE BEEN KILLED OR KILLED SOMEONE ELSE! PLEASE DON'T WAIT LIKE TOYOTA UNTIL SOMEONE DIES TO FIX THIS PROBLEM! PLEASE HELP! *TR

ON 10/22/2010 I WAS THE 2. TIME IN A VEHICLE CRASH, WITH A 2007 FORD F 150 AND THE AIRBAG DID NOT DEPLOYED. 1. IN 2008 FRONT RIGHT DAMAGE BROKEN FRONT AXEL FENDER TIRE RIM DAMAGE, SPEED 55MPH .. CUTS AND BRUISES REPAIR $6,000.00 2. FRONT DAMAGE SIDE DAMAGE BROKEN AXEL FENDER DOOR TIRE RIM DAMAGE .. TRUCK MIGHT BE TOTALED. CUTS AND BRUISES TO FACE AND LEG BOTH TIMES AIRBAG DID NOT DEPLOYED EVEN WITH SEVERE FRONT DAMAGE, PICS ARE AVAILABLE. *TR

MY TRUCK STARTING HAVING BRAKES PROBLEMS (VIBRATION WHEN STOPPING) AT AROUND 25,000 MILES. TOOK IT IN TO DEALERSHIP FOR INSPECTION WITH 29,000 MILES ON IT. ENDED UP MACHINING ALL ROTORS (NOT UNDER WARRANTY). I'M NOW EXPERIENCING THE SAME PROBLEM AT 42,000 MILES. I BELIEVE THE ROTORS AND CALIPERS ARE SEVERELY UNDERSIZED CONSIDERING THE WEIGHT OF THE TRUCK. I SUGGEST THAT FORD MAKE GOOD ON THE NEXT BRAKE JOB. HAD A 88 CHEVY P/U AND WENT 75,000 MILES BEFORE REPLACING THE FRONT PADS. FORD HAS ERRED ON IT'S ENGINEERING. *TR

TL* THE CONTACT OWNS A 2007 FORD F150. THE CONTACT STATED THAT THE CRUISE CONTROL WAS SET AT 65 MPH AND WOULD NOT DEACTIVATE WHEN THE BRAKE WAS DEPRESSED. THE CONTACT STATED THAT THE FAILURE OCCURRED SEVERAL TIMES AND THE CONTACT HAD COME CLOSE TO CRASHING ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO THE DEALER NUMEROUS TIMES FOR THE FAILURE. THE DEALER WAS UNABLE TO DIAGNOSE OR DUPLICATE THE FAILURE. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY WHERE THE CONTACT WAS ADVISED THAT THE FAILURE COULD HAVE BEEN CAUSED BY A VACUUM LEAK. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT THAT THE VEHICLE COULD BE TRADED. THE FAILURE MILEAGE WAS 4,000 AND THE CURRENT MILEAGE WAS 12,500.

ACCELERATES WHILE DEPRESSING THE BRAKE, WENT TO STOP AND TRUCK ACCELERATED, DO TO THE FACT THE BRAKE PEDAL IS TO CLOSE TO THE GAS PEDAL, HAS HAPPENED NUMEROUS TIMES, INCIDENTS, 1 ALMOST DROVE INTO AN INTERSECTION, 2 ALMOST RAN OVER A PEDESTRIAN STOPPING TO LET THEM CROSS THE ROAD, 3 ALMOST REAR ENDED ANOTHER CAR, THESE PROBLEMS HAVE ALL HAPPENED NUMEROUS TIMES, EVENTUALLY SOMEONE IS GOING TO DIE BECAUSE OF THIS PROBLEM. *TR

DRIVER'S SIDE WINDOW IS BROKEN FROM THE TRACK ASSEMBLY. I BELIEVE THIS COULD POSE DANGEROUSLY IN THE EVENT OF AN ACCIDENT, WINDOW COULD BE BECOME AN PROJECTILE AND DISLODGE WHERE NO ONE WILL BE ABLE TO EXIT OUT OF THE VEHICLE. *TR

SPARK PLUG BLOW OUT ON MY 2007 F150 WITH THE 5.4L MODULAR ENGINE. SPARK PLUGS WERE THE FACTORY PLUGS AND AS I BOUGHT THE TRUCK NEW THEIR IS NO WAY THAT THEY HAVE EVER BEEN CHANGED AND IMPROPERLY TORQUED AS THE FORD DEALER TOLD ME AFTER IT HAPPENED. I EXPLAINED THAT FORD HAS ISSUED A TSB ON THE PROBLEM AS IT IS SO RAMPANT IN EVERY FORD V8 ENGINE FROM 1993 TO CURRENT. THIS IS THE 3RD FORD VEHICLE THAT I HAVE HAD THIS HAPPEN TO ME. *TR

TL*THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 1 MPH HE APPLIED PRESSURE TO THE BRAKE PEDAL AND THE PEDAL REMAINED DEPRESSED UNTIL HIS FOOT WAS ALSO APPLYING PRESSURE TO THE ACCELERATOR PEDAL. HE HAD TO QUICKLY MANEUVER HIS FOOT OFF OF THE ACCELERATOR PEDAL TO PREVENT THE VEHICLE FROM ACCELERATING. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER WHERE HE WAS INFORMED THAT THERE WERE NO REPAIRS FOR THAT TYPE OF FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE BEGAN TO RECUR INTERMITTENTLY AND THE VEHICLE WAS TAKEN BACK TO AN AUTHORIZED DEALER WHERE HE WAS AGAIN INFORMED THAT THERE WERE NO REPAIRS FOR THIS TYPE OF FAILURE. THE VEHICLE WAS NOT REPAIRED AND THE FAILURE CONTINUED TO RECUR INTERMITTENTLY. THE FAILURE MILEAGE WAS 42,000 AND THE CURRENT MILEAGE WAS 50,000. THE VIN WAS UNAVAILABLE.

I HAVE A 2007 FORD F150 4WD PICKUP TRUCK. I HAVE 22,000 MILES ON THE TRUCK AND JUST HAD TO REPLACE BOTH FRONT UPPER BALL JOINTS. WHEN I TOOK IT TO THE FORD GARAGE THEY INDICATED THIS IS A COMMON FAILURE. MY CONCERN IS THAT THE FAILURE MECHANISM IF THE UPPER BALL JOINT FAILS IS FOR THE WHEEL TO FOLD UNDER THE VEHICLE AND POTENTIALLY RUPTURE THE BRAKE LINES IN THE PROCESS. THEY INDICATED THIS FAILURE WOULD BE WORSE WHILE PULLING A TRAILER. I CONTACTED FORD MOTOR COMPANY AND THEY OFFERED NO EXPLANATION OR ASSISTANCE AS THE TRUCK IS OFF WARRANTY. *TR

I OWNED A 2003 AND 2007 FORD F-150 SUPERCREW THE 2003 CAR WAS REARENDED AT 40 MILES PER HOUR AND NO AIR BAG DEPLOYED. THE 2007 WAS INVOLVED IN ACCIDENT FRONTEND AT 60 MILES PER HOUR AND THE AIR BAG DID NOT DEPLOY AS WELL. *TR

TL* THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THE REAR VALVES CONTINUED TO FRACTURE FROM THE VEHICLE. THE REAR PASSENGER SIDE VALVE FRACTURED ONE YEAR AGO AND MOST RECENTLY; THE REAR DRIVER SIDE VALVE WAS FRACTURED. WHEN THE FAILURE WOULD OCCUR, THE TIRE PRESSURE SENSOR WOULD FAIL. THE DEALER FOUND THERE WAS METAL CUTTING THROUGH THE SIDEWALL THAT PUNCTURED AND SLICED THROUGH THE INSIDE OF THE TIRE. THE FAILURE MILEAGE WAS 20,000 AND THE CURRENT MILEAGE WAS 32,000.

2007 F150 PURCHASED NEW. IN THE SPRING OF 2010 I STARTED NOTICING THE PAINT BUBBLE ON THE LEADING EDGE OF THE HOOD. SUBSEQUENTLY THE PAINT HAS STARTED TO FALL OFF. THERE ARE NO PRIOR MAINTENANCE ACTIVITIES WHICH WOULD HAVE CAUSED THIS (E.G. RE-PAINT / ACCIDENT DAMAGE). THE REMAINDER OF THE PAINT IS SHOWROOM QUALITY, IT APPEARS TO BE LIMITED TO THE HOOD AREA. *TR

TL* THE CONTACT OWNS A 2007 FORD F 150. THE CONTACT STATED THE POWER STEERING PUMP FAILED AND THERE WAS POWER STEERING FLUID LEAKING FROM THE VEHICLE. THE POWER STEERING ASSIST WOULD SPORADICALLY FAIL WHILE DRIVING AT VARIOUS SPEEDS. THERE WERE NO WARNING LIGHTS TO ALARM THE CONTACT OF THE FAILURE. THE DEALER ADVISED REPLACING THE ENTIRE POWER STEERING RACK AT THE CONTACT'S EXPENSE. THE MANUFACTURER OFFERED TO REDUCE THE PRICE OF THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 45,000.

MY 2007 FORD F150 JUST EXPERIENCED ITS 3RD VALVE STEM FAILURE FROM A TOPSEAL AUTO PARTS TR414 VALVE STEM THAT IS SUPPOSEDLY MANUFACTURED BY SHANGAI BAOLONG AUTOMOTIVE CORPORATION. I RECEIVED A NOTICE FROM FORD TO CHECK MY VALVE STEMS BACK ABOUT A YEAR AND A HALF AGO, BUT ALL OF THEM APPEARED OKAY AT THE TIME I CHECKED THEM AND AS I RECALL THE BULLETIN DID NOT INSIST THAT THE VEHICLE NEEDED TO BE INSPECTED BY A DEALER. I EXPERIENCED MY FIRST VALVE STEM FAILURE ON 9/6/09 REQUIRING A NEW TIRE. MY DEALERSHIP TOLD ME TOUGH LUCK, SAYING I SHOULD HAVE BROUGHT THE VEHICLE IN FOR IT TO BE CHECKED BY THEM. I HAD TO REPLACE THAT TIRE MYSELF FOR ABOUT $185. I THEN REQUESTED THAT THE 3 REMAINING STEMS BE REPLACED BY THE FUGATE MOTORS DEALERSHIP IN EL DORADO SPRINGS, MO. THE VEHICLE WAS STILL IN WARRANTY IN SEPTEMBER 2009. THE DEALER LOOKED AT THE VALVE STEMS BUT SAID THEY DID NOT HAVE REPLACEMENT STEMS AND SAID THEY HAD CHECKED THE 3 REMAINING STEMS AND THEY WERE FINE AND DID NOT NEED TO BE REPLACED. WHILE RETURNING FROM COLORADO LAST WEEK I EXPERIENCED ANOTHER FAILURE ON 6/24/10 REQUIRING A CHANGED VALVE STEM AT A WALMART AND AND A 3RD FAILURE ON 6/25/10 WHICH WILL REQUIRE ANOTHER NEW TIRE. THE DEALER AND FORD MOTOR COMPANY NOW DENY ANY RESPONSIBILITY FOR A SHREDDED TIRE THAT COULD HAVE CAUSED A SERIOUS WRECK. THEY ALSO POINTED OUT THAT MY TIRE PRESSURE SENSOR MAY BE BAD DUE TO THE EXTENT OF THE TIRE SHREDDING. THEY NOW ALSO REMIND ME THAT MY VEHICLE IS OUT OF WARRANTY. SOMETHING IS DESPERATELY WRONG HERE! *TR

TL* THE CONTACT OWNS A 1997 FORD F150. HE STATED THE VEHICLE WAS PARKED WHEN HE NOTICED THAT THERE WAS SMOKE AND FLAMES COVERING THE VEHICLE. THE FIRE DEPARTMENT AND POLICE WERE CONTACTED AND THERE WERE REPORTS FILED. THE VEHICLE WAS DESTROYED BY THE FIRE AND THEN IMPOUNDED. THE MANUFACTURER HAD NOT YET BEEN CONTACTED TO REPORT THE FAILURE. THE CAUSE OF THE FIRE WAS UNDETERMINED. THE FAILURE AND CURRENT MILEAGES WERE 179,000.

TL*THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT THE SPARK PLUGS WERE DEFECTIVE. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALERSHIP FOR REPLACEMENT AND THE CONTACT WAS INFORMED THAT THE PLUGS WERE DEFECTIVE DUE TO A DESIGN FLAW AND SHOULD BE CHANGED. THE DEALER ALSO STATED THAT THEY WOULD SWITCH THEM OUT BUT IF THEY DID NOT FUNCTION PROPERLY, THE CONTACT WOULD HAVE TO PAY TO TAKE THEM OUT. THE CONTACT CALLED THE MANUFACTURER AND WAS OFFERED NO ASSISTANCE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 101,000.

LOWER BALL JOINTS WEARING OUT AT 25,000 MILES, UPPER BALL JOINTS GONE AT 50,000 MILES ON A 2007 FORD F150 LARIAT. *TR

2007 FORD F-150. SEVERE WHEEL SHAKE WAS REPORTED. UPON INSPECTION FOUND OUTER WHEEL RIM WAS SEPARATING FROM WHEEL. DISCOVERED LARGE CRACK IN THE WELD. THIS IS THE THIRD WHEEL FROM DEFERENT TRUCKS OF SAME YEAR VINTAGE WITH THIS PROBLEM. CONTACTED FORD AND THEY ARE AWARE OF PROBLEM, BUT DECLINED TO DUE ANYTHING ABOUT IT. WE HAVE HAD A EQUAL AMOUNT OF BOTH 2006 AND 2007 F-150'S THAT THIS PROBLEM HAS OCCURRED ON. ALL OF THESE TRUCK PERFORM DIFFERENT DUTIES, SO THE TYPE OF USE IS NOT PART OF THE PROBLEM. FORTUNATELY THERE HAVE BEEN NO ACCIDENTS OR INJURIES FROM THIS PROBLEM, BUT CERTAINLY THERE IS THE POTENTIAL FOR INJURIES IF THE WHEELS WERE TO COME COMPLETELY APART AND THE TIRE LEAVE THE RIM. I'M CURIOUS AS TO HOW MANY OTHER PEOPLE HAVE HAD THIS PROBLEM OR HAVE THE POTENTIAL OF HAVING THE PROBLEM. *TR

TL* THE CONTACT OWNS A 2007 FORD F150. THE CONTACT WAS DRIVING WITH THE CRUISE CONTROL ENGAGED WHEN IT DEACTIVATED. THE CONTACT DOES NOT REMEMBER WHAT SPEED HE WAS DRIVING WHEN THE FAILURE OCCURRED. WITHIN A FEW MINUTES, THE CRUISE CONTROL ENGAGED ON ITS OWN WHEN THE SPEED BEGAN TO INCREASE. THE CONTACT WAS UNABLE TO TURN THE CRUISE CONTROL OFF AND THE FAILURE PERSISTED UNTIL THE VEHICLE ACCELERATED BACKWARDS AND CRASHED INTO A TREE. THE CONTACT WAS NOT INJURED; HOWEVER, THE VEHICLE WAS SEVERELY DAMAGED. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND WOULD NOT PROVIDE ANY ASSISTANCE. THE FAILURE MILEAGE WAS 29,728.

FORD SPEED CONTROL BLEWUP. *TR

TL* THE CONTACT OWNS A 2007 FORD F150. WHILE DRIVING AT RELATIVELY LOW SPEEDS OF 5 MPH AND PULLING INTO A THE DRIVEWAY, THE VEHICLE ABNORMALLY ACCELERATED WITHOUT WARRANT. THE VEHICLE PROCEEDED TO CRASH THROUGH THE GARAGE DOOR. THE CONTACT WAS UNINJURED YET THE VEHICLE SUSTAINED SUBSTANTIAL FRONT END DAMAGE. THE DEALER WAS UNABLE TO DUPLICATE THE FAILURE AND ADVISED THERE WAS NOTHING WRONG WITH THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 16,402.

ON 4-29,2010 I WAS DRIVING AT ABOUT 25 MPH WITH MY FOOT ON THE GAS PEDAL WHEN WITHOUT WARNING, THE ENGINE REVVED UP AND THE TRUCK ACCELERATED ON ITS OWN. TAKING MY FOOT OFF OF THE GAS, I PUT THE BRAKE ON, THE TRUCK CONTINUED TO ACCELERATE AND WAS LURCHING, THE TIRE WERE SQUEALING, BUT I WAS NOT SLOWING DOWN, I WAS GOING ABOUT 60 MPH BY NOW, THE ENGINE WAS STILL ACCELERATING, I TURNED THE IGNITION OFF, AND WAS COMING TO A STOP SLOWING, THERE WAS AN INTERSECTION WITH CROSS TRAFFIC IN FRONT OF ME.. I WAS STILL MOVING.. SO I JAMMED IT INTO PARK TO STOP.. I RESTARTED IT IN A FEW SECONDS THINKING I COULD MOVE IT OUT OF TRAFFIC, BUT WHEN I STARED IT THE ENGINE WAS STILL RACING. I HAD THE CAR TOWED TO THEADORE ROBBINS FORD IN COSTA MESA CA. THEY HAD THE TRUCK 2 DAYS AND WERE UNABLE TO RECREATE THE SITUATION, FIXED NOTHING AND RETURNED THE TRUCK TO ME. THE TRUCK IS A 2007 F 150 WITH 26,072 MILES ON IT. *TR

TL*THE CONTACT OWNS A 2007 FORD F150. THE CONTACT STATED THAT WHEN DEPRESSING THE BRAKES, THE PEDAL WOULD VIBRATE. THE DEALER STATED THAT THE ROTORS WERE NOT ALIGNED AND MADE THE NECESSARY REPAIRS. WITHIN 10,000 MILES, THE FAILURE RECURRED. THE VEHICLE WAS INSPECTED BY AN INDEPENDENT MECHANIC WHERE THE ROTORS WERE REPLACED. THE MANUFACTURER ADVISED THE BRAKES WOULD NOT BE COVERED UNDER WARRANTY AND THERE WERE NO RECALLS ON THE VEHICLE PERTAINING TO BRAKES. THE FAILURE MILEAGE WAS 10,000 AND THE CURRENT MILEAGE 40,606.

TL*THE CONTACT OWNS A 2010 FORD F-150. THE CONTACT STATED THAT ON MARCH 20, 2010, HIS VEHICLE WAS STRUCK FROM BEHIND BY ANOTHER VEHICLE TRAVELLING AT APPROXIMATELY 60 MPH WHILE THE VEHICLE WAS AT A TRAFFIC LIGHT. UPON IMPACT, THE CONTACTS VEHICLE LUNGED FORWARD AND REAR ENDED ANOTHER VEHICLE WHICH ALSO REAR ENDED A VEHICLE. THE AIR BAGS DID NOT DEPLOY AND BOTH THE CONTACT AND PASSENGER WERE INJURED AS A RESULT; THEY WERE TRANSPORTED THE HOSPITAL. A POLICE REPORT WAS FILED. THE VEHICLE WAS DESTROYED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 1,400.

SDAF

TL*THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT WHEN DRIVING AT SPEEDS OF AT LEAST 65 MPH, THE STEERING WHEEL WOULD VIBRATE WHEN DEPRESSING THE BRAKE PEDAL. THE BRAKE PEDAL WOULD ALSO VIBRATE THE LONGER PRESSURE WAS APPLIED TO THE PEDAL. THE DEALER REPLACED THE ROTORS, STATING THAT THEY WERE WARPED ALSO CAUSED THE FAILURE. THE REPAIR DID NOT CORRECT THE FAILURE. THE FAILURE MILEAGE WAS 9,000 AND THE CURRENT MILEAGE WAS 29,000.

FOR THE SECOND TIME MY F-150 WILL HAVE TO HAVE THE TRANSMISSION REPLACED. IT IS AN 2007 MODEL. THE CAR WENT INTO THE PROTECT MODE. IT IS NOW IN THE FORD DEALER. THEY WANT 3600 TO REPLACE IT. I HAD A SIMILAR INCIDENT IN 2008 WHERE THEY FIXED THE TRANSMISSION FOR FREE. *TR

2007 FORD F-150 4X4 HAD THE 4X4 SHIFT ON THE FLY ACTIVATE ON HARD PAVEMENT WHILE MERGING ONTO HIGHWAY WHILE ON THE ON RAMP, CAR LURCHED FORWARD AND VERY LOUD BANG ALMOST LIKE A GUNSHOT HAPPENED AT 50 MILES AN HOUR. CAUSED THE TRUCK TO SWERVE TO THE RIGHT ONTO SHOULDER NARROWLY MISSING THE ABUTMENT . THE CAUSE IS FAULTY VACUUM ACTUATORS AND SHIFT MOTOR. THIS HAPPENED REPEATEDLY AND WAS ESPECIALLY PRONOUNCED IN RIGHT TURNS CAUSING FOR IMPRECISE TURNING AND HANDLING OF THE VEHICLE. *TR

TL*THE CONTACT OWNS A 2007 FORD F150. THE CONTACT WAS DRIVING APPROXIMATELY 50 MPH ON NORMAL ROAD CONDITIONS. THERE WAS AN EXCESSIVE FORCE APPLIED TO THE BRAKE PEDAL. THE VEHICLE FAILED TO SLOW DOWN AND CRASHED INTO THE REAR OF A PROCEEDING VEHICLE. THE BRAKE PEDAL BROKE AS A RESULT OF THE PRESSURE APPLIED TO IT. THE POLICE AND AMBULANCE WERE CALLED TO THE SCENE. THE DRIVER SUSTAINED A MINOR INJURY AND THE PASSENGER SUSTAINED SEVERE INJURIES TO THE NECK AND HEAD. THE AIR BAGS FAILED TO DEPLOY ON IMPACT. THE VEHICLE WAS TOWED TO A COLLISION SHOP AND REPAIRED FOR THE DAMAGES. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR THE REPAIR OF THE BRAKE SYSTEM AND REPLACEMENT OF THE AIR BAG SENSOR. IN ADDITION, WHEN PROCEEDING TO MAKE A SHARP TURN THERE WAS A LOUD POPPING NOISE COMING FROM THE FRONT END OF THE VEHICLE. THE FAILURE MILEAGE WAS 30,000.

THE BRAKE PEDAL AND GAS PEDAL ARE TOO CLOSE AND THE BRAKE PEDAL ISN'T RAISED ABOVE THE GAS PEDAL, THEY ARE LATERAL AND TOO CLOSE MAKING FOR DANGEROUS STOPPING AND ACCELERATING ISSUES. *TR

2007 FORD F150 HAS A PROBLEM WITH THE PLACEMENT OF ITS GAS AND BRAKE PEDAL. WHEN BRAKING YOU ACCIDENTALLY HIT BOTH PEDALS WHICH CAUSES YOU TO ACCELERATE. I JUST PURCHASED THIS TRUCK AND NOTICED THIS ISSUE. MY BROTHER ALSO NOTICED THIS. IF I LEND MY TRUCK OUT I MAKE SURE I INFORM THE PERSON ABOUT THIS PROBLEM. WHEN SEARCHING THE WEB MANY OTHER SITES ARE ADDRESSING THIS SAFETY ISSUE OF ACCELERATION WHEN BRAKING. I WONDER WHAT YOUR AGENCY IS DOING REGARDING THIS SAFETY PROBLEM? THE PUBLIC IS AWARE OF IT SO MUCH SO THEY ARE POSTING ABOUT IT. FORD KNOWS ABOUT THIS, CUSTOMERS HAVE COMPLAINED. SO WHEN IS YOUR AGENCY GOING TO ACKNOWLEDGE AND ADDRESS THIS SAFETY ISSUE? *TR

WHILE DRIVING ON STATE HIGHWAY, APPLIED BRAKE, BRAKE PEDAL WENT SLOWLY TO THE FLOOR, AND VEHICLE DID NOT SLOW, CONTINUED ON HELPLESS, UNTIL STRIKING A VEHICLE IN FRONT OF ME. CALLED DEALER WHERE VEHICLE WAS PURCHASED, THEY SAID THEY WERE NOT AWARE OF ANY BRAKE PROBLEMS WITH THIS MODEL. CALLED FORD DIRECT, AND THEY SAID THEY WERE NOT AWARE OF ANY BRAKE PROBLEMS WITH THIS MODEL. INSURANCE ADJUSTER WILL BE HERE TODAY, I WILL NOT LET ANYONE TOUCH THIS VEHICLE UNTIL THIS PROBLEM IS RESOLVED, I HAVE NOT SLEPT FOR DAYS, NOT BECAUSE OF MY INJURIES, BUT THE HAUNTING THOUGHTS OF KNOWING I COULD HAVE KILLED SOMEONE. *TR

WHEN I TOOK MY 2007 FORD F150 IN FOR TIRE ROTATION, THE FORD TECHNICIAN HAD SAID THAT I HAD CUPPED FRONT TIRES, AT THAT TIME MIRE TIRES HAD ABOUT 9 TO 11 THOUSAND MILES ON THEM AND WERE ONLY A FEW MONTHS OLD, FORD WOULD NOT COVER THE ABNORMAL ROUNDING OF THE TIRE AND SAID I SHOULD BUY SOME NEW ONES FROM THEM. A FEW MONTHS LATER MY OTHER TWO TIRES HAD STARTED FORMING BALLS ON THE INSIDE SIDE WALL OF THE TIRE, WHICH I WAS NOT AWARE UNTIL I WENT TO GET MY STATE INSPECTION STICKER, THE TECHNICIAN AT PUEBLO TIRES TOLD ME I HAD SEVERAL BALLS ON THE SIDES OF MY TIRES HE ALSO TOLD ME MY VEHICLE WOULD NOT PASS INSPECTION BECAUSE THE TREAD WAS TO WORN, HE EVEN SHOWED ME THE TREAD LEVELS WITH A TREAD METER AND I VERIFIED THERE WAS NOT ENOUGH TREAD ON THE TIRES. THE MILEAGE ON THE TRUCK AT THAT TIME WAS ONLY 15000 MILES SO I REPLACED THEM SO IT WOULD BASS INSPECTION AND FOR MY SAFETY AND OTHERS AS WELL..
WHEN I PURCHASED MY VEHICLE IT CAME WITH A MANUAL STATING HOW MUCH AIR AND HOW MANY MILES A CERTAIN BRAND OF TIRE WAS SUPPOSED TO AVERAGE MINE SAID I SHOULD HAVE GOTTEN 30000 MILES MINIMUM BEFORE REPLACEMENT, FORD IS OBVIOUSLY USING FALSE STATISTICS TO MARKET THESE DEFECTIVE TIRES. *TR

PICKUP WOULD NOT STOP AT STOP SIGN WITH THE BRAKE ON. THE REAR WHEELS WERE SPINNING WITH THE BRAKES ON FIRMLY. THIS HAS NOW HAPPENED TWICE AND BOTH TIMES I THREW THE TRANSMISSION INTO NEUTRAL TO STOP THE MALFUNCTION.. *TR

I HAD A BLOWOUT ON THE PASSENGER FRONT TIRE GOING 65 MPH IN THE LEFT LANE OF A HIGHWAY. MY 2007 FORD 150- SUPERCREW DROPPED DOWN AND IMMEDIATELY PULLED RIGHT. I COULD NOT STEER AWAY FROM AN 18 WHEELER THAT WAS IN THE RIGHT LANE. I BOUNCED OFF THE 18 WHEELER AND IT KNOCKED MY WHEEL STRAIGHT. I WAS ABLE TO GAIN CONTROL OF MY TRUCK. I HAD $5000 IN PROPERTY DAMAGE . THE 18 WHEELER DID GO OFF THE ROAD AND HAD $70000 WORTH OF DAMAGE. THE NEXT MORNING AFTER PICKING MY TRUCK UP FROM THE BODYSHOP I HAD ANOTHER BLOWOUT ON THE FRONT DRIVER SIDE. THIS TIME I WAS GOING 35 MPH AND WAS ABLE TO CONTROL MY TRUCK. THE BACK TIRES WERE FINE. THESE 2 BLOWOUTS OCCURRED WITHIN 1. 5 HOURS OF DRIVING ALL IN THE FRONT. TIRES ARE NOT DESIGNED TO HANDLE THE EXCESS WEIGHT OF A F150 SUPERCREW. I HAD BF GOODRICH LONG TRAIL ON MY LAST SUPERCREW AND HAD EXCELLENT RESULTS. I SPENT $690 TO REPLACE ALL GENERAL AMERITRAC TIRES. *TR

2007 FORD F-150 FUEL VAPOR LEAK FROM FUEL PUMP ASSEMBLY DUE TO INFERIOR PLASTIC. *TR

PASSENGER SEAT AIR BAG TURNS OFF. OCCASIONAL PROBLEM, HAS BECOME CONSTANT PROBLEM. WIFE WEIGHS 100 LB+. NEVER HAD THIS PROBLEM WITH ANY OTHER CAR,DO NOT HAVE THE PROBLEM WITH OUR 09, SMART CAR. ONE DEALER SAID SHE DOESN'T WEIGH ENOUGH,ANOTHER SAID,BAG WILL STILL DEPLOY BUT NOT AS HARD. THINK IT IS A SENSOR IN THE SEAT ,WHEN THE LIGHT SAYS BAG OFF, MEANS NO PROTECTION, AND IT WILL NOT DEPLOY. HAPPENS INTERMITTENTLY,SOME TIMES RE CONNECTING THE SEAT BELT CORRECTS IT BUT ONLY FOR A WHILE. JUST COMPLETED 3,000 MILE TRIP ACROSS COUNTRY, BAG OFF LIGHT WAS ON MOST OF THE TIME. DIDN'T SEEM TO MATTER HOW THE WIFE POSITIONED HER SELF,THIS IS NOT A WEIGHT/SIZE ISSUE,BUT A FAILURE OF A SAFETY DEVICE. IS IT AN '07' ISSUE?*TR

TL*THE CONTACT OWNS A 2007 FORD F150. WHILE DRIVING APPROXIMATELY 55MPH. THE ENGINE FAILED AND A FIRE OCCURRED WITHIN THE ENGINE COMPARTMENT. THE FIRE CHIEF INVESTIGATOR LOCATED THE FAILURE AT THE FUEL CROSS OVER LINE. THE FIRE REPORT INCIDENT NUMBER IS 2009-09331. THE VEHICLE WAS CRASHED. THE CURRENT AND THE FAILURE MILEAGES WERE 52,000.

FAILURE OF TIRE VALVE STEM RESULTING IN A RAPID FLAT TIRE. *TR

TL*THE CONTACT OWNS A 2007 FORD F-150. THE SERVICE ENGINE LIGHT ILLUMINATED. THE DEALER ADVISED THE CONTACT THAT THE ENGINE NEEDED TO BE REPLACED WHILE HE WAS REPLACING THE SPARK PLUGS. THE DEALER WAS UNABLE TO IDENTIFY THE REASON THE ENGINE NEEDED TO BE REPLACED OTHER THAN HE KNEW OTHER VEHICLE OWNERS WHO HAD THE SAME ISSUE. THE COST TO REPLACE THE ENGINE WAS $6,400 SINCE IT HAD TO BE REPLACED WITH THE UPDATED VERSION PRODUCED BY THE MANUFACTURER. THE MANUFACTURER STATED THAT THEY COULD NOT OFFER HIM ANY ASSISTANCE AND ADVISED HIM TO SPEAK WITH THE DEALER. HE ASKED THE MANUFACTURER IF HE COULD BUY AN ENGINE FOR $1,800 BUT THEY REFUSED TO ANSWER THE QUESTION. THE CURRENT MILEAGE WAS APPROXIMATELY 148,000. THE FAILURE MILEAGE WAS APPROXIMATELY 146,000.

TL*THE CONTACT OWNS A 2007 FORD F-150. HE WAS FORCED TO APPLY EXTREME PRESSURE TO THE BRAKE PEDAL IN ORDER TO STOP THE VEHICLE. THE BRAKE FAILURE NEARLY CAUSED A CRASH TO OCCUR. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION; HOWEVER, THE TECHNICIAN WAS UNABLE TO IDENTIFY THE FAILURE OR PROVIDE A FREE REMEDY. THE FAILURE MILEAGE WAS UNKNOWN AND THE CURRENT MILEAGE WAS 22000.

TL*THE CONTACT OWNS A 2007 FORD F-150. THE CONTACT STATED THAT THE WEBBING ON THE DRIVER SIDE FRONT SEAT BELT IS SEPARATING. AS A CONSEQUENCE HE IS NOT PROPERLY SECURED IN THE VEHICLE. HE WAS IN THE PROCESS OF HAVING THE VEHICLE INSPECTED AND REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 16,000.

BOUGHT NEW IN 2007 FORD F-150 PICKUP TRUCK ALL ORIGINAL EQUIPMENT AND OWNER ONLY 19,000 MILES ON ORIGINAL TIRES. BLEW OUT DURING NORMAL DRY DRIVING CONDITIONS PULLING A EMPTY 16 FT TRAILER. IF IT HADN'T BEEN THAT IT WAS THE REAR PASSENGER SIDE TIRE AND LATE AT NIGHT ON A DIVIDED HIGHWAY WOULD HAVE HAD A WRECK. TRUCK WENT ALL OVER THE ROAD DUE TO THE BLOW OUT. VALVE STEM COMPLETELY GONE. THESE TIRES WERE THE ORIGINAL HANKOOK 17 INCH TIRES THAT WERE SOLD WITH THIS TRUCK AND THE TRUCK ONLY HAD 19K MILES THE WHOLE SIDE OF THE TIRE BLEW THE TREAD IS STILL THERE SIDE OF TIRE IN SHREDS AND NO VALVE STEM AT ALL JUST AN EMPTY HOLE WHERE IT SHOULD BE. IF THIS HAD OF BEEN A STEERING TIRE COULD HAVE POSSIBLY LOST CONTROL. I STILL HAVE 3 MORE OF THESE TIRES ON THE TRUCK; IS THERE A RECALL ON THE STEMS OR TIRES FOR THESE TRUCKS WHAT SHOULD I DO? I CURRENTLY HAVE THE SPARE ON THE TRUCK WILL THIS HAPPEN TO IT? DO THE TIRES NEED REPLACING? THEY STILL HAVE PLENTY OF TREAD BUT ARE THEY DEFECTIVE/SAFE? WILL OR SHOULDN'T THE TRUCK WARRANTY COVER THIS? *TR

TL*THE CONTACT OWNS A 2007 FORD F-150. WHILE DRIVING APPROXIMATELY 35 MPH, THE DRIVERS SIDE REAR TIRE BECAME FLAT. THE CONTACT REPLACED THE TIRE AND CONTINUED TO HIS DESTINATION. THE DEALER INSPECTED THE VEHICLE AND DETERMINED THAT THE VALVE STEM CAUSED THE TIRE FAILURE. THE DEALER REPLACED THE VALVE STEM ON THE TIRE THAT FAILED AND CHECKED THE OTHER TIRES. THE VEHICLE IS CURRENTLY BEING REPAIRED. THE MANUFACTURER ADVISED HIM THAT THE VEHICLE IS UNDER WARRANTY; HOWEVER, THEY WILL ONLY REPLACE DEFECTIVE PARTS BUT NOT PARTS. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS 16,000.

AT 12000 MILES THE ROTORS ARE COMPLETELY WARPING. IT'S ESPECIALLY NOTICEABLE WHEN DRIVING AT SPEEDS OF OVER 50 MPH. I CAN SEE AND FEEL THE BED BOUNCING AND CAN FEEL IT IN THE STEERING WHEEL. DEALER WILL DO NOTHING UNDER WARRANTY. THEY SAID THEY WOULD LOOK AT THEM BUT WOULD HAVE TO CHARGE ME. I ALSO SPOKE WITH FORD DIRECTLY, THEY WILL ALSO OFFER NO ASSISTANCE. I'VE HEARD OF THIS SITUATION HAPPENING MANY TIMES AND FORD WILL DO NOTHING TO CORRECT IT. *TR

VALVE STEMS ON 2007 F 150 BAD VALVE STEMS ON TRUCK FORD SENT OUT A NOTICE ON THEM AFTER LOSING 1 TIRE AND SPINNING 3 OTHER VALVES EVERY WEEK AFTER FORD WOULD NOT STAND BUY THE NOTICE ON THE REPAIRS. *TR

TUESDAY MORNING WHEN I WENT OUT TO MY TRUCK THE TIRE LOOKED TO ME TO BE LOW ON AIR AND LOW PRESSURE LIGHT WAS ON IN THE TRUCK. I DROVE TO MY SHOP (APPROX. 7.2 MI.), TOOK OFF THE WHEEL TO CHECK FOR LEAKS (FOUND NON), CHECKED THE AIR PRESSURE AND IT WAS AT 28 LBS, I FILLED THE TIRE WITH AIR TO 36 LBS. THE LOW PRESSURE INDICATOR LIGHT DID NOT GO OUT. I CHECKED THE OTHER 3 TIRES AND FOUND THEM ALL TO BE LOW SO I FILLED THEM WITH AIR TO 36 LBS AND THE LIGHT WENT OUT. AT THE END OF THE DAY I DROVE HOME, THEN TOOK MY WIFE TO DINNER (APPROX. 5 MI.). WHEN WE PULLED INTO THE RESTAURANT PARKING LOT AND TURNED RIGHT INTO A PARKING SPOT, THE LEFT FRONT TIRE BLEW OFF THE RIM AS I CAME TO A STOP. I AM NOT AS CONCERNED ABOUT GETTING A 'FREE' TIRE AS I AM OF THE SAFETY FACTOR INVOLVED. I HAVE 4 HANKOOK TIRES ON THIS TRUCK AND IT CONCERNS ME THAT ANOTHER ONE MAY BLOW APART (POSSIBLY AT FREEWAY SPEED). I DO BELIEVE THAT THIS WAS A DEFECTIVE TIRE. I AM 65 YEARS OLD AND I'VE WORKED ON CARS ALL MY LIFE AND I'VE NEVER SEEN A TIRE BEAD SPLIT THE WAY THIS ONE DID. I ALSO HAVE ASSOCIATES IN THE AUTOMOTIVE BUSINESS WHO AFTER SEEING THE DAMAGED TIRE COMPLETELY AGREE WITH ME. I WOULD HATE TO SEE A REPEAT OF THE FORD EXPLORER TIRE PROBLEM THAT OCCURRED WITH FIRESTONE SEVERAL YEARS BACK; AND I HATE TO THINK THERE ARE MORE DEFECTIVE TIRES OUT THERE. I SPOKE WITH AND EMAILED THIS INFORMATION TO AL ABRADOR AT HANKOOK TIRE AND HE SAID 'IT WAS THE FAULT OF THE PERSON THAT MOUNTED THE TIRES', HE ALSO SAID THAT HANKOOK HAS HAD NO OTHER COMPLAINTS REGARDING THESE TIRES. I WENT TO THE TIRE SHOP WHERE I'VE DONE BUSINESS FOR THE PAST 20 YEARS AND THEY SAID THEY HAD NEVER SEEN A BROKEN BEAD LIKE THIS ONE. AFTER LOOKING AT THE NHTSA SITE I SEE THERE ARE INDEED MANY COMPLAINTS REGARDING HANKOOK TIRES. AGAIN, I AM CONCERNED WITH MY OWN AS WELL AS PUBLIC SAFETY IN THIS MATTER. *TR

HAVE EXPERIENCED EXTENSIVE BRAKE DUST ON THE FRONT WHEELS ALMOST FROM DAY 1. LATELY, AT ABOUT 28,000 MILES THE FRONT END WOBBLES AND SHIMMIES WHEN BRAKING. NOT SO BAD AT LOWER SPEEDS BUT REALLY BAD IF YOU HAVE TO BRAKE FAIRLY HARD WHILE ON AN INTERSTATE HIGHWAY FROM SPEEDS OF 65 MPH OR MORE. HAD TIRES ROTATED AND BALANCED WHICH HELPED A BIT BUT PROBLEM STILL EXISTS. *TR

I HAVE A 2007 FORD, F150 EXTENDED CAB, THE BRAKE ROTOR HAVE WARPED. THIS COULD BE A SAFETY PROBLEM IF THIS A REGULAR OCCURRENCE WITH THIS MODEL. THE SHOP WHICH I CARRIED MY VEHICLE TO TOLD ME THAT IF THE COMPANY USED CERTAIN BRANDS OF ROTORS THAT WERE MADE IN FOREIGN COUNTRIES WON'T STAND UP TO HEAT. IF FORD USED THESE PRODUCTS ON THE ASSEMBLY LINE BECAUSE THEY'RE CHEAPER, SOMETHING SHOULD BE DONE. *TR

TIRE VALVE STEM FAILURE ON MY 2007 FORD F150. I'VE RECEIVED FORD'S SAFETY NOTICE 5 MONTHS AFTER ONE OF MY TIRE VALVE STEMS HAVE FAILED. THEIR NOTICE GAVE NO INDICATION THAT THEY INTEND TO REPLACE THE DEFECTIVE VALVE STEMS. THEIR REMEDY AS OUTLINED FOR CORRECTION OF THE PROBLEM BY MONTHLY INSPECTION OF VALVE STEM IS FAR FROM CORRECTIVE OR PREVENTIVE. I HAD VERY RECENTLY CHECKED TIRE PRESSURE, AND INSPECTED TIRES, VALVE STEMS, AND LUG NUT TORQUE PRIOR TO A LONG TRIP WHEN MY VALVE STEM FAILED. FORTUNATELY THEIR WAS NOT AN ACCIDENT RELATED TO THIS FAILURE. HOWEVER, IF THERE HAVE BEEN OTHER ACCIDENTS RELATED TO THIS PROBLEM: YOU MAY CONTACT ME FOR ANY LITIGATION TESTIMONY. *TR

1. TIRE PRESSURE LIGHT ALERT, FOLLOWED BY IMMEDIATE DROP IN TIRE PRESSURE. TRIED TO ADD ADDITIONAL AIR, BUT TIRE WOULD NOT MAINTAIN AIR PRESSURE. AIR COULD BE HEARD ESCAPING FROM VALVE STEM. 2. TIRE PRESSURE LIGHT WOULD COME ON ONCE ABOUT EVERY 6 MONTHS SINCE PURCHASE OF NEW VEHICLE. TIRE PRESSURE WAS CHECKED MONTHLY. 3. SERVICED AT NATIONWIDE, NON-DEALERSHIP SERVICE CENTER; MECHANIC FOUND 4 DEFECTIVE, UNREPAIRABLE VALVE STEMS. REPLACED WITH NEW VALVE STEMS. WAS TOLD BY SERVICE MANAGER TO CONTACT LOCAL DEALERSHIP/MANUFACTURER FOR REIMBURSEMENT OF PARTS. *TR

TRUCK HAS A ROUGH IDLE ISSUE SINCE 6K. I NOW HAVE 30K. THE PROBLEM HAPPENS WHEN THE TRUCK IS STARTED COLD SOMETIMES IS VERY BAD ENGINE SHAKE, ALSO WHEN IDLING AT A STOP LIGHT ENGINE SEEMS TO SHAKE. NO CHECK ENGINE LIGHT COMES ON EVEN WHEN THE TRUCK IS RUNNING SO BAD IT SEEMS LIKE IT IS GOING TO STALL. I HAVE HAD IT AT THE DEALER MANY TIMES AND THEY CAN'T FIND A PROBLEM THEY SAY BECAUSE NO TROUBLE CODES SHOW IN THE COMPUTER OR CHECK ENGINE LIGHT DOES NOT COME ON. *TR

2007 FORD F150 VALVE STEM BROKE AND CAUSED A BLOWOUT ON THE HIGHWAY. AFTER RECOVERING FROM BEING DRIVEN OFF THE ROAD, I NOTICED THAT MY THREE OTHER TIRES HAD CRACKED VALVE STEMS AS WELL. FORD NEEDS TO ISSUE AN IMMEDIATE RECALL AND DEAL WITH THIS HAZARD BEFORE SOMEONE GETS KILLED OR SERIOUSLY INJURED. *TR

BATTERY DEAD AFTER LESS THAN 2 YEARS. DEALER WILL NOT REPLACE. DEALER CLAIMS NON-EOM STEREO DRAINS BATTERY IN ONLY MINUTES. STEREO UNHOOKED.. PROBLEM PERSISTS. THE TRUCK TOOK A COUPLE OF RETRIES TO GET IT FROM START TO FINISH OF A TX STATE INSPECTION BECAUSE THE BATTERY DIES, EVEN AFTER CHARGING OVERNIGHT. LAST TIME. IT GOT THROUGH INSPECTION, BUT NEEDED A JUMP START AFTER INSPECTION. I CONTACTED FORD CUSTOMER SERVICE. THE CSR INFORMED ME THAT THEY ARE GOING TO BELIEVE THEIR DEALER OVER A CUSTOMER. NO HELP. *TR