2012 Mini Cooper S Roadster C FWD

OUR VEHICLE HAS THE AIRBAG LIGHT ON AND I AM AM VERY CONCERNED WITH THE SAFETY OF OUR FAMILY. AFTER RESEARCHING THIS ISSUE, THERE ARE MANY MINI OWNERS THAT ARE HAVING THE SAME PROBLEM WHICH LEADS ME TO BELIEVE THAT THIS IS DEEPER THAN AN ISOLATED ISSUE ON MY VEHICLE. I ALSO FOUND OUT THAT THIS HAS BEEN AN ISSUES THAT WAS CONVERTED INTO A RECALL FOR SEVERAL YEARS BEFORE. MINI SHOULD CONSIDERED DOING AN INVESTIGATION AND EXTENDING THE RECALL TO OTHER YEAR MODELS INCLUDING MY 2012.

I LOVE MY MINI COOPER S. BUT THERE IS A ISSUE. TODAY I STARTED UP THE CAR AND IT STARTS SMOKING. TWICE THIS HAS HAPPENED IN TWO WEEKS. WHEN I BOUGHT IT 2 YEARS AGO I NOTICED ON THE INSIDE OF MY HOOD OF THE CAR IT'S A BLACK BURNT MARK. THE DEALERSHIP SAID THE PROBLEM HAD BEEN FIXED. LAST WEEK I TOOK IT TO A OIL SHOP AND THEY SAID MY TURBO IS BURNING MY CAR AND WOULD CATCH FIRE SOON. I'M IN THE PROCESS OF GETTING A NEW TURBO BUT THIS IS A BIG PROBLEM CAUSE NOW IT'S SMOKING ONLY WHEN IN IDLE OR STARTED UP.BUT THE HOOD IS SUPER HOT AFTER A SHORT DRIVE. I HOPE YOUR CREW CAN LOOK INTO THIS PART AND SAVE SOMEONE THE TERROR OF A CAR ON FIRE. THANK YOU FOR YOUR TIME.

ELECTRICAL CONTROL UNIT WENT OUT

THE CAR STALLED WHILE DRIVING ON FREEWAY ONCE AND HIGH PRESSURE FUEL PUMP WAS REPLACED BY MINI COOPER AND AGAIN SECOND TIME ON INNER ROADS DRIVING AT 20 MILES AN HOUR....WITHOUT ANY WARNING

WHILE MOVING IN TRAFFIC AND ACCELERATING, THE FUEL PUMP CUT OUT AND THE ENGINE DIED, FORCING THE DRIVER TO MANEUVER IN TRAFFIC (COASTING) EVENTUALLY COMING TO STOP IN A LEFT HAND TURN LANE WHICH WAS THEN BLOCKED WITH THE DEAD VEHICLE. THOUGH THE VEHICLE WAS UNDAMAGED, THE POSSIBILITY OF A COLLISION EXISTED. RESEARCH INDICATES THAT MINIS FROM 2010-EARLY 2012 HAD SIMILAR PROBLEMS, RESULTING IN MINI USA EXTENDING THE WARRANTY ON THE FUEL PUMP TO 10 YEARS/ 120,000 MILES. VEHICLES PRODUCED ON OR AFTER 3/1/2012 (INCLUDING MINE) WERE FITTED WITH DIFFERENT EQUIPMENT. NO RECALL WAS CONDUCTED. MY CAR HAD 25,000 MILES ON IT WHEN THE FUEL PUMP FAILED.

TAKATA INFLATORS" I NOTICE A BURNING SMELL INSIDE MY VEHICLE WHICH I REPORTED TO THE DEALER. THEY STATED "THEY COULDN'T FIND ANYTHING. THEN I WOULD DEPART FROM MY CAR WITH THE WINDOWS UP SUNROOF CLOSED AND LOCK IT I WOULD RETURN THE WINDOWS WOULD BE ALL THE WAY DOWN AND TOP UP. THIS TOOK PLACE AGAIN ON 3/6/19.

THERMOSTAT HOUSING BEGAN TO LEAK, THE PART IS PLASTIC AND HAD BECOME CRACKED UNDER NORMAL WEAR.

TL* THE CONTACT OWNS A 2012 MINI COOPER S. THE CONTACT STATED THAT THE FRONT AND REAR DRIVER SIDE CARPET WAS WET. ALSO, WHILE DRIVING, THE SOUND OF WATER SWISHING AROUND COULD BE HEARD COMING FROM THE BOTTOM AND THE TOP OF THE VEHICLE. THE CONTACT ALSO MENTIONED THAT THE VEHICLE ALARM WOULD INDEPENDENTLY ACTIVATE. THE VEHICLE WAS TAKEN TO MINI OF MANHATTAN (793 11TH AVE, NEW YORK, NY 10019, (212) 586-6464), BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 70,000.

VEHICLE HAD BEEN DRIVEN 24 MILES AND PARKED FOR ABOUT 10 MINUTES WHEN ENGINE COMPARTMENT CAUGHT FIRE. MASTER MECHANIC DIAGNOSED IT ORIGINATED WITH THE COOLANT PUMP AND CAUSED A SHORT CIRCUIT WITH THE ELECTRONICS OF THE PUMP IGNITING A FIRE.

TL* THE CONTACT OWNS A 2012 MINI COOPER S. WHILE ATTEMPTING TO EXIT THE VEHICLE, THE FRONT PASSENGER AND DRIVER SIDE AND THE REAR DRIVER SIDE DOORS FAILED TO OPEN WITHOUT WARNING. THE FAILURES RECURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DOOR ACTUATORS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED EXCEPT FOR THE REAR DRIVER SIDE DOOR. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

ENGINE RATTLING NOISE (TIMING CHAIN AND TENSIONER) AT ALL TIMES, VEHICLE HAS ONLY 50,000 MILES

TL* THE CONTACT OWNS A 2012 MINI COOPER S. THE CONTACT STATED THAT WHILE HAVING MAINTENANCE PERFORMED, THE CONTACT WAS NOTIFIED THAT THREE OF THE FOUR TIRE RIMS WERE CRACKED. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE THREE TIRE RIMS WERE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 44,342. DATED 01/23/15*LJ UPDATED 9/7/2017*CN

TL* THE CONTACT OWNS A 2012 MINI COOPER S. THE CONTACT STATED THAT UPON ENTERING THE VEHICLE, THERE WERE STRONG GASOLINE FUMES EMITTING FROM THE FRONT OF THE VEHICLE. THE CONTACT NOTICED THAT THE FRONT PASSENGER SIDE SEAT HAD CAUGHT ON FIRE AND EXTINGUISHED INDEPENDENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO DIAGNOSED THAT THE SEAT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 24,000.