2019 Ford Fusion 4 DR AWD

Vehicle stalls after getting gas. This is due to the canister purge valve not working correctly. It’s a common problem amongst fusion owners.

Driving on highway in a thunderstorm; windshield wipers were on full out max. They did not go fast enough to clear the water from the windshield so I could see the road. After this incident, I went to Ford and told them about it. They inspected it and said the wipers worked as designed. When I told them that was inefficient and unacceptable and a safety hazard for a downpour, they told me to "pull over" if I get caught in a storm. That is unacceptable. It is not always safe to pull over. I should be able to see for at least a half second to tell if I am driving within my lane. I had to drive on the bumper of a truck to follow their lights. I had the 2018 Ford Fusion and the windshield wipers worked properly.

The contact owns a 2019 Ford Fusion. The contact stated that while driving at various speeds, the vehicle experienced random hesitation and stalling with the check engine warning light illuminated. The vehicle was taken to the local dealer who diagnosed that the transmission was faulty and needed to be repaired. The vehicle was repaired but the failure had reoccurred. The contact indicated that the transmission had been rebuilt on three separate occasions. The manufacturer was notified of the failure. The approximate failure mileage was 5,000.

The contact owns a 2019 Ford Fusion. The contact stated that after starting the vehicle, the check engine warning light remained illuminated. The vehicle was taken to the local unknown dealer who diagnosed that the engine was faulty and needed to be replaced. No further information was available. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was 80,000.

The contact owns a 2019 Ford Fusion. The contact stated that while the wife was driving approximately 70 mph the vehicle crashed into a deer. During the crash, the front end of the vehicle was severely damaged but no airbags were deployed. The driver sustained back and neck injuries. A police report was taken at the scene and the vehicle was towed away. The manufacturer and local dealer were notified of the failure. The failure mileage was 65,000.

The contact owns a 2019 Ford Fusion. The contact stated that the check engine warning lights was illuminated. The vehicle was taken to a local dealer where it was diagnosed with needing the engine replaced. The vehicle was not repaired. The manufacturer was informed of the failure and told the contact to call NHTSA for assistance. The failure mileage was 25,841.

My Steering wheel is very loose. The steering wheel moves up and down, also the the steering wheel moves left to right. I am afraid to drive my car.

Cracked flex plate requiring new engine (out of warranty)

The contact owns a 2019 Ford Fusion. The contact stated that while operating the vehicle, the steering wheel was loose and would move up and down. Upon inspection, it was discovered that a bolt was unsecured under the steering wheel cover. The vehicle was taken to an independent mechanic who was unable to determine the cause of the failure. The local dealer and manufacturer were not yet notified of the failure. The failure mileage was 77,000.

In early spring of 2021 the trunk lid on the 2019 Ford Fusion hybrid opened by itself while driving through the parking lot. I was able to close it. Later that day it did it again. Then I came out to the vehicle to find the trunk open. I had not used the key fob, keypad on the door, or trunk release button that day. On the 16th of April I had a local shop inspect it, but all they could do was disconnect the release latch. I then took it to the dealership for further inspection and diagnosis. They did a number of procedures from reprogramming the BCM, to replacing it. It is now August 30 and the trunk lid is once again opening on its own. This is unsettling at the least, dangerous at its worst. I use the car to teach driver education. This is an unsafe condition and Ford needs to address this malfunction.

The contact owns a 2019 Ford Fusion. The contact stated that on several occasions while driving or stationary, the trunk would independently open without warning. The contact reached out to a dealer and made an appointment to have the vehicle inspected. The manufacturer had yet to be notified of the failure. The vehicle was not yet repaired. The failure mileage was approximately 36,000.

Was told by mechanic that new engine was needed. We have had this same issue happen to three of our 2019 Fusion's (company cars).

About a week or so ago I went out to crank my car and it sounded awful It was shuttering, sounded like it was going to shut off and the engine light came on, it's a 2019 Ford Fusion. I notice it does this every morning, well I took it to the dealer ship today, they said I have coolant leaking into the Engine.

Fusion traveling northbound and t-boned sedan traveling westbound in intersection. Fusion has significant front end damage. No airbags deployed in Fusion. All airbags deployed in other vehicle. Driver of Fusion, wearing seatbelt, suffered sternum fracture. Available for inspection. Failure of airbags to deploy likely cause sternum fracture. Fusion just arrived at car repair for scan and inspection. The Fusion was started less than 5 minutes prior to accident and driver received message indicating the front camera was unavailable.

Started the car with 24,007 miles on ODO and check eng light came on running real rough looked into ford pass app and it stated that it had a power train issue and misfire of cylinder. Took to dealership and was told that the short block had to be replaced to to coolant leaking into #2 cylinder from a crack.

Yesterday I parked my car and about 45 minutes later when I returned my trunk was open. This makes a few times now where I have parked my car and left, then when I returned my trunk was open. The first couple of times I dismissed it because the trunk was only open slightly. In one of the early instances I was standing there when the trunk opened by itself and thought it was because I hadn't closed it all the way. But yesterday the trunk was open halfway with the taillight flashing bringing further attention to it. There were no error messages or warnings (other than the taillight flashing). Yesterday when this happened, my car was charging at a public charging station. I suspect the taillight was flashing because the car was plugged in and charging. The other times this happened, it was not charging. This morning I googled Ford Fusion trunk opening by itself and saw multiple online forums with other Ford Fusion owners, who going back years, have been experiencing their trunks opening for no apparent reason. Some of them said it happens while driving. If my trunk were to open while I was driving the distraction would put myself and other drivers at risk. There would also be a danger if items started to fly out of my trunk. One of the forums suggested notifying the NHTSA about this issue. I also messaged Ford about this issue asking about a fix.

CAR SHUDDERS/SHAKES INTERMITTENTLY ON COLD STARTS. CHECK ENGINE LIGHT CAME ON MAY 3 AT 11AM. TAKEN TO DEALER ON MAY 3 AT 4PM. AFTER DEALER INSPECTION, ADVISED ON MAY 5 THAT COOLANT LEAK INTO CYLINDERS IS REQUIRING A NEW ENGINE AT 28,700 MILES. DEALER ADVISED THERE IS A TSB ON THIS AND IT IS A COMMON PROBLEM WITH THE ENGINE.

I HAVE 2019 FORD FUSION WITH ONLY 6400 MILES. AIRBAG LIGHT CAME ON AND TOOK THE CAR TO DEALERSHIP AND THEY DENIED TO COVER AIRBAG MODULE REPLACEMENT UNDER WARRANTY. AIRBAG MODULE WAS BAD AND DEALERSHIP DENIED TO COVER BECAUSE I HAD SMALL DENT DAMAGED ON THE QUARTER PANEL WHEN I BOUGHT IT. CAR DRIVES FINE BUT HAS AIRBAG LIGHT ON DUE TO BAD MODULE FROM THE MANUFACTURE.

MY CAR HAS HAD ONGOING ELECTRICAL PROBLEMS SINCE DAY ONE. THEY HAVE TRIED VARIOUS REMEDIES TO NO AVAIL. NOW THAT IT IS OUT OF WARRANTY THEY REFUSE TO COVER THIS ONGOING ISSUE

COMING TO STOP AT A PARKING LOT AND ALL OF SUDDEN THE CAR ACCELERATED (SEEM LIKED 90 MPH) ON IT'S OWN JUMPED THE CURB WENT UP ON THE LAWN BEFORE I COULD REACT AND APPLIED THE BRAKES! I WAS PROBABLY ALMOST STOPPED BEFORE THE CAR RAPIDLY ACCELERATED FOR NO REASON!

THE TRUNK CAME OPEN WHILE DRIVING ON A STREET AND BUSTED THE BACK WINDSHIELD OUT.

WHEN PLACING MY CAR IN TO PARK IT DOESN'T ACTUALLY GO IN TO PARK. IF YOU GET OUT AFTER IT DOES THIS THE CAR WILL ROLL. THIS IS TERRIFYING. IT STARTED TO ROLL OUT MY DRIVEWAY AFTER PUTTING IT IN PARK. I HAVE TO PUT MY EMERGENCY BRAKE ON SO IT DOESN'T ROLL. I HAVE A VIDEO OF THE INCIDENT BUT I CAN NOT ATTACH IT.

T O WHOM IT MAY CONCERN, THANK YOU FOR ASSISTING ME DURING THIS PROCESS. MY CAR I PURCHASED NEW AND I WOULD LIKE TO SAY A FEW MONTH INTO OWNING MY CAR IVE HAD SERVAL INCIDENCE WHERE MY CAR WOULD COMPLETELY SHUT OFF WHILE I'M A RED LIGHT FOR AWHILE DUE TO TRAFFICS. MY CAR HAS AN ECO BUTTON WHERE I CAN TURN IT OFF AND ON SO IT DOESN'T 'SHUT DOWN' WHEN I COME TO A STOP. THE REASON I'M SO UPSET WITH THIS IS BECAUSE 2-3 TIMES IT'S HAPPENED TO I'VE HAD MY TODDLER WITH ME AND IN ORDER FOR ME TO GO (WHEN THE CAR SHOULD AUTOMATICALLY TURN ON ONCE I REMOVE MY FOOT FROM THE BREAK), I HAVE TO TURN OFF MY CAR AND TURN IT BACK ON AND IT'S HAPPENED DURING TRAFFIC AND BUG INTERACTIONS. I DON'T FEEL SAFE IN MY CAR AND MOST IMPORTANTLY I'M SCARED A CAR WILL HIT ME FROM BEHIND DO TO THIS ISSUE WITH MY SON IN THE CAR. I'VE ADDRESSED THIS ISSUE TO FORD AND WHEN I TAKE IT IN THEY SAID THEY CAN'T DETECT THE PROBLEM. THEY'VE CHANGED THE BATTERY THINKING IT WOULD HELP HIT IT DIDN'T. I'VE GIVEN THEM THE OPPORTUNITY TO ASSIST ME AS MUCH AS THEY CAN BUT YET I FEEL LIKE NOTHINGS BEEN DONE.

THE SYSTEM BEGAN FAILING WHEN THE FIRST THE ALARM DOESN'T SET, THEN THE HORN DOESN'T WORK BUT THE VEHICLE DOES RUN

WAS AT COMPLETE STOP, HEARD A LOUD "POP" NOISE FROM MY CAR THAT SHOOK MY BREAK PEDAL. BREAK PEDAL HAS FELT "SQUISHY" AND GOES ALMOST TO THE FLOOR WHEN STOPPING.

ON MY 2019 FORD FUSION THE CHECK ENGINE LIGHT CAME ON FOR MY FUEL SYSTEM. IT IS READING THAT I HAVE A FAULTY PURGE VALVE. THE CODE WAS P0456.

SIMILAR TO NHTSA ID# 11290551, I TOO EXPERIENCED SUDDEN ACCELERATION OF MY VEHICLE OVER THE SET SPEED ON THE CRUISE CONTROL SYSTEMS IN BOTH MEDIUM (35-45MPH) AND HIGHWAY (50-65MPH) SPEEDS. I'M THE ORIGINAL OWNER OF THE VEHICLE, CURRENTLY UNDER 15K MILES. PERIODIC VISUAL INSPECTIONS BY OWNER, ALL VEHICLE MAINTENANCE PERFORMED BY DEALERSHIP AS PER OWNER'S MANUAL. WHILE I NEVER LET THE CAR TAKE OVER THE DRIVER, IT CONCERNS ME IF THIS HAPPENS WITH MY WIFE DRIVING IT AS SHE MAY NOT HAVE THE SAME THINKING THAT I DO. ASIDE OF THAT, THE ADAPTIVE CRUISE CONTROL FEATURE IS INCONSISTENT IN DETECTING VEHICLES WHILE SWITCHING LANES OR IN FLAT SURFACED CURVES, REGARDLESS OF THE WEATHER (HAPPENED MULTIPLE TIMES DURING CLEAR DAYS AND UNDER MODERATE RAIN). THIS CAUSES THE VEHICLE TO ACCELERATE SO IT RETURNS TO THE SET SPEED. WHILE THE FEATURE WORKS OK MOST OF THE TIME, THOSE INCONSISTENCIES CAN CAUSE SEVERE PROBLEMS ON HIGHWAY SPEEDS - WHICH IS THE PLACE THEY ARE MOST USED AT. ONCE AGAIN, WHILE I FEEL I AM ALWAYS IN CONTROL OF MY VEHICLE, I GET CONCERNED FOR MY WIFE. SHE DOES NOT DO HIGHWAYS OR DRIVES LONGER THAN A 10 MILES RADIUS TO A FEW KNOWN LOCATIONS BY HERSELF. BY THE FEW TIMES I EXPERIENCED THE REPORTED, I'VE CONSIDERED IF THE VEHICLE WITH THE CLAIMED ADDED SAFETY FEATURES WERE WORTH THE PURCHASE AND ARE TRULY READY FOR WIDE ADOPTION.

I WAS DRIVING OUT OF A STORE AND ALL OF A SUDDEN THE VEHICLE HAD THE BATTERY ENGINE COME OUT AND OTHER WEIRD VERBIAGE IVE NEVER SEEN. ALL OF A SUDDEN MY VEHICLE JUST STOP , BRAKES BECAME TOO STIFF TO TURN BACK THE VEHICLE AS YOU ARE SUPPOSE TO PRESS THE BRAKE AND PUSH THE START BUTTON. I WAIT WITH MY 9 YEAR OLD DAUGHTER ON A BUSY STREET AND IT WAS OVER 100 DEGREE WEATHER. WE WAITED MAYB 10MINS AND THE BRAKE BECAME SOMEONE MANAGEABLE TO PUSH AND THE VEHICLE STARTED AS SOON AS IT DID START SMOKE STARTED COMING OUT FROM THE HOOD DROVE TO A NEAR BY BUSINESS AND HAD TO WAIT OVER W HOURS FOR A TOW TRUCK. THIS IS SUCH A SAFETY HAZARD AS A MOTHER YOU WANT THE VEHICLE YOU DRIVE TO BE AS SAFE AS POSSIBLE BUT FOR A BRAND NEW VEHICLE ONLY A YEAR OLD TO STALL OUT THE WAY IT DID IS SO SCARY BECAUSE I COULD'VE BEEN HIT AND YOU NOT ONLY WORRY ABOUT YOUR SAFETY BUT YOUR CHILD'S SAFETY.

I WAS IN A CAR ACCIDENT THAT ULTIMATELY TOTALED THE CAR. THE AIRBAG UNDER THE DRIVER SIDE DASH CAME OUT BUT THE AIRBAG IN THE STEERING WHEEL DID NOT COME OUT NOR DID THE SEATBELT LOCK. MY HEAD AND FACE HIT THE WINDSHIELD LEAVING ME WITH INJURIES TO MY FACE AND NOSE AND I HAD INJURIES ON THE ENTIRE LEFT SIDE OF MY BODY. I WAS GOING 45 MPH AND FELL ASLEEP AT THE WHEEL. I VEERED OFF INTO A DITCH AND HIT THE OTHER SIDE OF IT. *TR*DT*JB

TL* THE CONTACT OWNS A 2019 FORD FUSION. THE CONTACT STATED THAT HER DAUGHTER WAS DRIVING AT 45 MPH, THE VEHICLE BEGAN TO PULL TO THE LEFT AS AN ABNORMAL NOISE BEGAN EMITTING FROM THE VEHICLE. THE VEHICLE THEN INDEPENDENTLY TURNED TO LEFT AND HIT THE BARRIER WALL ON A BRIDGE WITHOUT WARNING. THE AIR BAGS DID NOT DEPLOY UPON IMPACT. HER DAUGHTER SUSTAINED NO MAJOR INJURIES, ONLY MINOR SORENESS. A POLICE REPORT WAS FILED AT THE SCENE. THE VEHICLE WAS TOWED TWICE TO TWO DIFFERENT INDEPENDENT MECHANICS. THE VEHICLE HAD YET TO BE REPAIRED. THE CONTACT SPOKE WITH A DEALER (JENKINS & WYNNE FORD, HONDA, & LINCOLN 2655 TRENTON RD, CLARKSVILLE, TN 37040) WHO INFORMED HER THAT THERE WERE NO ACTIVE RECALLS ON THE VEHICLE. THE MANUFACTURER WAS ALSO NOTIFIED OF THE FAILURE AND WAS REFERRED TO NHTSA FOR ASSISTANCE. THE FAILURE MILEAGE WAS 20,000. THE VIN WAS NOT AVAILABLE.

I HAD A RECALL REGARDING A COOLANT RELATED ISSUE. THIS WOULD CAUSE A MISFIRE, DAMAGING THE ENGINE AND CAT CONVERTER. I TOOK THE CAR DEALERSHIP. THEY SAID THEY FIXED. FOLLOWING DAY ENGINE LIGHT CAME ON. TOOK IT THE DEALERSHIP AGAIN. I AM TOLD ENGINE NEED TO BE REPLACED. THE CAR IS SITTING THERE. IT WOULD TAKE COUPLE MONTHS TO REPAIR THEY SAID. CAR HAS 18K MILEAGE ON IT. 2019 FORD FUSION.

DRIVING HOME FROM THE DEALER I WAS ON A WELL LIT ROAD. I LIVE IN A RURAL AREA AND EVEN WITH THE HIGH BEAMS ON IT WAS LIKE THERE WAS NO LIGHT. I DIDN'T SEE THE DEER STANDING ON THE SIDE OF THE ROAD UNTIL I WAS ALMOST NEXT TO IT, THE HIGH BEAMS WERE ON. WHEN I DON'T HAVE THE HIGH BEAMS ON THE LIGHTS ARE VERY DIM AND I'M LUCKY IF I CAN SEE 20 FEET AHEAD. I'M BRING THE VEHICLE BACK TO THE DEALER.

SO WHEN I'M DRIVING DOWN THE ROAD IT WILL START DOING WEIRD STUFF .. LIKE JERKING AND APPLYING THE BREAKS AND THEN THE CAR JUST SHUTS OFF AND THEN IT TAKE ABOUT A COUPLE MINS FOR IT TO COME BACK ON SO I THINK THIS IS A DANGER & SAFETY HAZARD

PRIOR TO RECALL NOTICE; ON 12-20-19 HUSBAND NOTICED COOLANT L LEVEL DOWN AT APPROXIMATELY 7,000 MILES. WENT TO LOCAL FORD DEALER TO PURCHASE COOLANT. WHILE THERE DEALER ASKED SEVERAL QUESTIONS CONCERNING SPECIFICS; LIKE, IS COOLANT LEAKING FROM YOUR ENGINE AND IS IT VISIBLE ON THE GROUND; HUSBAND SAID NO. RETUNED HOME WITH COOLANT AND FILLED THE RESERVOIR. JANUARY 18TH, 2020, RECEIVE RECALL NOTICE FROM FORD ADVISING COOLANT MAY BE INTRUDING INTO THE CYLINDERS; ADVISING TO CONTACT LOCAL DEALER FOR SERVICE. JANUARY 21ST, CAR INTO SERVICE TO REPROGRAM POWER TRAIN /CLEARED ALL CODES. JANUARY 22ST, 2020 TOOK AN 81 MILE TRIP TO LAKE AND BACK; HOURS LATER CHECKED THE COOLANT AND IT WAS DOWN AGAIN 5/8 'S INCH FROM MAX. JANUARY 23RD CALLED THE SCHEDULED ANOTHER APPT FOR JANUARY 29TH. JANUARY 29TH 2020, MCSPADDEN FORD HAD VEHICLE FOR 4.5 HOURS TO CONTINUE INVESTIGATION INTO EXCESSIVE COOLANT USE. UPON PICK UP OF VEHICLE, SERVICE MANAGER ADVISED THEY PUT CAR UP ON LIFT TO LOOK FOR LEAKS, NEGATIVE. HOOKED UP COMPUTER AND RAN CAR FOR 20 MINUTES LOOKING FOR ANYTHING UNUSUAL, NO PROBLEMS FOUND. REMOVE VALVE COVERS, INSPECTED BLOCK, PISTONS & CYLINDERS. IN PROCESS BOKE A SPARK PLUG THAT WAS REPLACED AT NO CHARGE. SERVICE MANAGER ADVISED THEY DID NOT FIND ANYTHING TO FIX; WE SHOULD JUST DRIVE IT LIKE NORMAL. DRIVING HOME AT 1.3 MILES (4 MIN) CAR SPUTTERS. ANOTHER .3 MILES (1 MIN) CAR SPUTTERS, BUCKS, STEERING VIBRATES, CAR SHAKES. ANOTHER .6 MILES (1 MIN) , CAR SPUTTERS & BUCKS, STEERING VIBRATES, CARE SHAKES, RPM GAUGE BOUNCING, CHECK ENGINE LITE COMES ON. ANOTHER .5 MILES (1 MIN) I PULL OFF THE HIGHWAY INTO RESIDENTIAL NEIGHBORHOOD AND CALL MCSPADDEN SERVICE WHO ADVISE TO IMMEDIATELY RETURN THE CAR TO THEM IF I AM ABLE. CAR LEFT AGAIN AT THE SHOP AT 1-29-2020 5:45.

STARTED THE CAR MANUAL AND A POWER TRAIN MALFUNCTION WILL COME ON MY FORD PASS APP. ALSO ON THE DASHBOARD IT WILL SAY SHIFT SYSTEM FAULT. ONCE I PUT THE CAR IN DRIVE THE SERVICE LIGHT DISAPPEARS. THE VEHICLE WAS IN MY DRIVEWAY STATIONARY. ON 1 OTHER OCCASIONS JANUARY 1ST 2020 THE CAR WAS IN MY DRIVEWAY STATIONARY. I STARTED THE CAR MANUALLY CAR WOULD NOT START (NO ENGINE TURN OVER) BUT CAR START STOP BUTTON WOULD BE GREEN AS IF CAR WAS RUNNING.

TL* THE CONTACT OWNS A 2019 FORD FUSION. THE CONTACT STATED WHILE DRIVING AT 25 MPH, THE FRONT AXLE ON THE PASSENGER SIDE FRACTURED CAUSING THE TIRE TO FOLD UNDER THE VEHICLE. AS A RESULT, THE CONTACT LOST CONTROL OF THE VEHICLE AND THE VEHICLE COULD NOT BE TURNED TO THE LEFT OR RIGHT DIRECTION. THE VEHICLE HEADED STRAIGHT FOR 30 YARDS AND WENT OVER A CURB LANDING ON AN INCLINE OF A PRIVATE PROPERTY. ALL THE AIR BAGS DEPLOYED EXCEPT FOR THE FRONT DRIVER SIDE AND STEERING WHEEL AIR BAGS WHICH FAILED. A POLICE REPORT WAS FILED UNDER REPORT NUMBER: 212000012. THE CONTACT SUSTAINED TWO 9 CM LACERATIONS TO THE HEAD AND 19 STITCHES, A CONTUSION TO THE HEAD, CONCUSSION, LOSS OF MEMORY, AND MASSIVE BODY ACHES THAT REQUIRED MEDICAL ATTENTION. A POLICE OFFICER DROVE THE CONTACT TO THE HOSPITAL AFTER THE IMPACT. THE CONTACT MENTIONED THAT THE INFORMATION PROVIDED WERE BASED ON PICTURES AND VIDEOS OF THE EVENTS OF THE IMPACT DUE TO HIM HAVING MEMORY LOSS. THE FOLLOWING DAY THE CONTACT WENT BACK TO THE SCENE AND FOUND THE PASSENGER FRONT AXLE ON THE ROAD. THE VEHICLE WAS TOWED TO A TOW TRUCK COMPANY. THE INSURANCE COMPANY WAS SCHEDULE TO INSPECT THE VEHICLE. THE MANUFACTURER WAS NOT CONTACTED AS OF YET. THE FAILURE MILEAGE 13,000. *LN *JB *TR

2019 FORD FUSION. CONSUMER WRITES IN REGARDS TO ISSUES WITH CRUISE CONTROL. *LD THE CONSUMER STATED THE CRUISE CONTROL WOULD CAUSE THE VEHICLE TO SPEED UP UNINTENTIONALLY. THE CONSUMER RECIEVED A SPEEDING TICKET WHILE USING THE CRUISE CONTROL.*JS

THE HEADLIGHTS ON THE 2019 FORD FUSION ARE HORRENDOUS! THERE IS VERY LITTLE VISIBILITY, I'M CONSTANTLY HAVING TO TURN ON MY BRIGHTS TO EVEN SEE SOME ASPECTS OF THE ROAD I'M ON. THIS IS IRRESPONSIBLE ON FORDS PART AND NEEDS TO BE ADDRESSED AS SOON AS POSSIBLE! THERE'S NO TELLING HOW MANY ACCIDENTS THIS HAS CAUSE AND OR WILL CAUSE IN THE FUTURE.

TL* THE CONTACT'S SPOUSE RENTED A 2019 FORD FUSION. WHILE DRIVING APPROXIMATELY 35-40 MPH, THE STEERING SEIZED WITHOUT WARNING. THE DRIVER WAS UNABLE TO MANEUVER THE VEHICLE. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE SUSPENSION FRACTURED AND CAUSED THE FRONT DRIVER'S SIDE WHEEL TO MAKE CONTACT WITH THE INNER WHEEL WELL AND SEIZE IN PLACE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE FRONT SUSPENSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. ENTERPRISE RENTAL CAR WAS NOTIFIED OF THE FAILURE AND THE RECOVERY TEAM WAS SCHEDULED TO RETRIEVE THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 35,000.

A COUPLE MONTHS BACK, I RENTED A 2019 FORD FUSION, SO THE VIN NUMBER IN THIS REPORT IS ONLY A SAMPLE. TWICE, WHEN I WENT TO BUCKLE THE DRIVER-SIDE SEATBELT, THE END WENT NOT INTO THE LATCH, BUT INSTEAD INTO THE CASING AROUND THE LATCH (SEE PICTURES). THERE WAS JUST ENOUGH FRICTION TO HOLD IT IN PLACE AND MAKE IT FEEL LIKE IT WAS LATCHED, WHEN IN ACTUALITY, IT WAS NOT. I CONTACTED THE LOCAL FORD DEALER TWICE, BUT GOT NO REPLY. I THEN WROTE A LETTER TO FORD MOTOR CO. SIMPLY SAYING I HAD FOUND AN ISSUE, BUT ONLY GOT AN OBVIOUS FORM LETTER SAYING "THANK YOU". THEY DIDN'T EVEN ASK FOR ANY DETAILS. UPON DISCUSSION OF THE ISSUE WITH A FRIEND, HE SAID HE HAD THE SAME EXACT ISSUE WITH A 2015 FUSION.

STARTED THE CAR WHETHER MANUAL OR BY REMOTE START A POWERTRAIN MALFUNCTION WILL COME ON MY FORD PASS APP. ALSO ON THE DASHBOARD IT WILL SAY SHIFT SYSTEM FAULT. ONCE I PUT THE CAR IN DRIVE THE SERVICE LIGHT DISAPPEARS. THE VEHICLE WAS IN MY DRIVEWAY STATIONARY. ON 2 OTHER OCCASIONS SEPTEMBER 18 2019 AND SEPTEMBER 25 2019 THE CAR WAS IN MY DRIVEWAY STATIONARY. I STARTED THE CAR MANUALLY CAR WOULD NOT START (NO ENGINE TURN OVER) BUT CAR START STOP BUTTON WOULD BE GREEN AS IF CAR WAS RUNNING. THE DASHBOARD WOULD SAY FULL ACCESSORY MODE ACTIVE, TRANSMISSION NOT IN PARK, SHIFT SYSTEM MALFUNCTION. THE CAR DASHBOARD WOULD SAY THE CAR WAS IN DRIVE BUT THE TURN DIAL GEAR WOULD SHOW PARK. THE CAR GEAR DIAL WAS ALSO LOCKED AND WOULD NOT TURN. IF I TOOK OFF THE EMERGENCY BRAKE THE CAR WOULD ROLL BACKWARDS. ALSO I COULD NOT TURN THE CAR OFF AFTER THAT. AFTER 40- 60 MIN THE CAR SHOWED IT WAS GOING TO TURN OFF IN 15 MIN TO SAVE POWER. ONCE IT TURNED OFF. THE CAR WOULD START AND ENGINE WOULD TURN OVER AS IF NOTHING HAPPEND. I ALSO HAVE VIDEO OF BOTH TIMES CAR WOULD NOT START. WEBSITE WILL NOT LET ME UPLOAD VIDEOS

BOUGHT THE CAR LESS THAN 30 DAYS AGO. WASHING THE FRONT WINDSHIELD AND NOTICED A HAIRLINE CRACK ON THE OUTSIDE ABOUT 4-5 INCHES LONG. NO DAMAGES OF A ROCK HITTING THE WINDSHIELD.

I REACHED DOWN ON THE RIGHT SIDE OF THE DRIVER'S SEAT TO RETRIEVE A FALLEN OBJECT AND CUT MY WRIST ON A SHARP, RAW, METAL EDGE OF A STAMPING ON THE SIDE OF THE SEAT. LOTS OF BLOOD, BUT NOT A DEEP CUT.

3 WEEKS AFTER I LEASED THE VEHICLE NEW, THE WINDSHIELD SHATTERED WITHOUT ANYTHING HITTING IT. IT IS NOW 3 MONTHS LATER AND I ABOVE 7500 MILES ON THE CAR AND WHILE SITTING IN STOPPED TRAFFIC THE BACK GLASS EXPLODED ON ITS OWN. FORD CORPORATE ONLY ACCEPTED PHOTOS TAKEN AND SUBMITTED BY THE DEALERSHIP TO REVIEW THE CLAIM AFTER TELLING ME A 'TECHNICIAN WILL DETERMINE' WHAT HAPPENED. FORD SAID GLASS IS NOT COVERED UNDER WARRANTY. I EXPLAINED TO THEM THAT I UNDERSTAND BUT I AM MODE CONCERNED OF THE OVERALL SAFETY OF THE CAR AFTER THIS HAPPENED. 2 PHONE REPS AND THEIR SUPERVISOR REPEATEDLY SAID THERE IS NOTHING THEY CAN DO, TOLD ME IT IS NORMAL WEAR AND TEAR, AND THERE IS NO OTHER PHONE NUMBER OR DEPARTMENT I CAN CONTACT TO FURTHER PURSUE THIS ISSUE.

TL* THE CONTACT OWNS A 2019 FORD FUSION. WHILE DRIVING 35 MPH WITH THE CRUISE CONTROL ENGAGED, THE CONTACT APPLIED PRESSURE TO THE BRAKE PEDAL. UPON RELEASING THE BRAKE PEDAL,THE VEHICLE ACCELERATED ON ITS OWN AT A HIGH RATE OF SPEED. THE FAILURE OCCURRED TWICE AND THE SPEED REACHED EXACTLY 71 MPH. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO KEN GRODY FORD CARLSBAD SAN DIEGO (5555 PASEO DEL NORTE, CARLSBAD, CA 92008, (760) 438-9171), BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 350.

WITH CRUISE CONTROL SET, PRESSING THE + BUTTON AND HOLDING FOR A FEW SECONDS TO INCREASE THE SPEED A FEW MILE PER HOUR WILL CAUSE THE VEHICLE TO CONTINUE ACCELERATING UNTIL THE 'CANCEL' BUTTON OR THE 'OFF' BUTTON IS PRESSED. PRESSING THE BRAKE PEDAL WILL ALSO STOP THE RUN AWAY ACCELERATION. DURING THE RUN-AWAY ACCELERATING, PRESSING THE + BUTTON OR THE - BUTTON WILL NOT STOP THE ACCELERATION. ADDITIONALLY, WITH CRUISE SET, PRESSING THE - BUTTON FOR A FEW SECONDS WILL CAUSE A RUN-AWAY DECELERATION. THE VEHICLE IS PRESENTLY BEING LOOKED AT BY THE DEALERSHIP WHERE IT WAS BOUGHT. IN THE MEAN TIME, I WAS GIVEN A 2019 FUSION HYBRID AS A LOANER VEHICLE AND THAT CRUISE CONTROL DOES THE SAME THING: RUN-AWAY ACCELERATION AND DECELERATION WHEN PRESSING THE + OR - BUTTON. THE VEHICLE WAS CHECKED MANY TIMES AND WAS CRUISING ANYWHERE FROM 50 MPH TO 70 MPH WHEN THE + AND - BUTTON WAS PRESSED. I NOTICED THAT THE RUN-AWAY DECELERATION WAS QUITE PRONOUNCED COMPARED TO THE ACCELERATION.

I WAS DRIVING A AVIS RENTAL CAR - FORD FUSION 2019 IN AN INTERSTATE FROM CHATTANOOGA, TENNESSEE TO DALTON, GEORGIA. I SAW AN ERROR MESSAGE ON THE SCREEN ALL OF A SUDDEN (LIKE COMMUNICATION ERROR) AND THE ENGINE JUST SHUT OFF, ALL LIGHTS TURNED OFF AND SEAT STARTED MOVING BACK. IT WAS ALMOST 15 - 20 SECONDS AND I WAS TERRIFIED TO JUST KEEP THE CAR ON MIDDLE LANE AND NOT TO BE HIT BY SOMEONE FROM BEHIND. THE GUY WHO WAS IN THE PASSENGER SEAT PUSHED THE START BUTTON AND IT STARTED AND I MANAGED TO DRIVE LAST 5 MILES TO REACH HOTEL. I CALLED AVIS ROADSIDE ASSISTANCE IMMEDIATELY ON RETURN TO HOTEL AND ASKED THEM TO RECORD THIS ISSUE. I ALSO INFORMED THE RETURN CAR ATTENDANT WHEN I RETURNED TODAY AT AVIS ATLANTA AIRPORT.

I WAS DRIVING A AVIS RENTAL CAR - FORD FUSION 2019 IN AN INTERSTATE FROM CHATTANOOGA, TENNESSEE TO DALTON, GEORGIA ON 5/1/2019 WEDNESDAY. I SAW AN ERROR MESSAGE ON THE SCREEN ALL OF A SUDDEN (LIKE COMMUNICATION ERROR) AND THE ENGINE JUST SHUT OFF, ALL LIGHTS TURNED OFF AND SEAT STARTED MOVING BACK. IT WAS ALMOST 15 - 20 SECONDS AND I WAS TERRIFIED TO JUST KEEP THE CAR ON MIDDLE LANE AND NOT TO BE HIT BY SOMEONE FROM BEHIND. THE GUY WHO WAS IN THE PASSENGER SEAT PUSHED THE START BUTTON AND IT STARTED AND I MANAGED TO DRIVE LAST 5 MILES TO REACH HOTEL. I CALLED AVIS ROADSIDE ASSISTANCE AND ASK D THEM TO REGISTER A COMPLAINT .I ALSO INFORMED THE ATTENDANT WHEN I RETURNED THE CAR AT ATLANTA AIRPORT TODAY.

TL* THE CONTACT OWNS A 2019 FORD FUSION. WHILE ATTEMPTING TO ACCELERATE FROM A STOP, THE ACCELERATOR PEDAL SEIZED. WHEN THE CONTACT TURNED OFF AND RESTARTED THE VEHICLE, THE ACCELERATOR PEDAL RETURNED TO NORMAL. IN ADDITION, THE CONTACT STATED THAT THE BRAKES SEIZED WHILE IN TRAFFIC THIS WEEK, WHICH ALMOST CAUSED A CRASH AND THE CHECK MANUAL WARNING MESSAGE ILLUMINATED. THE VEHICLE WAS TAKEN TO FLAMMER FORD (3335 COMMERCIAL WAY, SPRING HILL, FL 34606, (352) 686-8255) WHERE IT WAS DIAGNOSED THAT AN AUTO STOP/START MODULE NEEDED TO BE INSTALLED. THE VEHICLE WAS NOT REPAIRED, BUT AN APPOINTMENT WAS SCHEDULED FOR APRIL 9, 2019. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND WOULD NOT ALLOW THE DEALER TO REPAIR THE VEHICLE BECAUSE THE DIAGNOSTIC TROUBLE CODE COULD NOT BE READ DURING THE DIAGNOSTIC TEST. THE FAILURE MILEAGE WAS 8,070.

TL* THE CONTACT OWNS A 2019 FORD FUSION. AS THE CONTACT PULLED THE VEHICLE INTO A PARKING SPACE AND PLACED THE GEAR INTO PARK, THE ENGINE REVVED THREE TIMES. THE VEHICLE JERKED FORWARD BEFORE SHUTTING OFF ON ITS OWN. A FEW MINUTES LATER, THE CONTACT RESTARTED THE VEHICLE AND IT OPERATED NORMALLY. THE CONTACT MANAGED TO DRIVE THE VEHICLE HOME. THE CONTACT CALLED JORGENSEN FORD SALES, INC. (8333 MICHIGAN AVE, DETROIT, MI 48210, (313) 584-2250) AND WAS INFORMED TO BRING THE VEHICLE TO THEIR SERVICE DEPARTMENT. THE VEHICLE WAS TOWED TO THE DEALER, BUT NO FAILURE WAS FOUND. THE CONTACT STATED THAT SHE NO LONGER WANTED THE VEHICLE. THE DEALER REFERRED THE CONTACT TO THE MANUFACTURER TO TRY TO GET OUT OF THE LEASE. THE MANUFACTURER ASSIGNED A CASE NUMBER AND MANAGER TO THE CONTACT. THE CASE MANGER INFORMED THE CONTACT THAT THE DEALER FOUND NO FAILURE AND COULD NOT LEASE HER ANOTHER VEHICLE. THE CONTACT REFUSED TO TAKE THE VEHICLE BACK AND THREATENED TO MAKE NO MORE PAYMENTS ON IT EVEN IF IT RUINED HER CREDIT. THE FOLLOWING DAY, THE DEALER TRIED TO RETURN THE VEHICLE, BUT THE CONTACT REFUSED. THE CONTACT SPOKE WITH THE DEALER MANAGER AND THEY FINALLY AGREED TO LET THE CONTACT LEASE A NEW VEHICLE; HOWEVER, THEY ROLLED OVER THE OTHER LEASE INTO THE NEW VEHICLE, WHICH DOUBLED THE MONTHLY PAYMENTS. THE DEALER JUSTIFIED THIS BY STATING THAT NO FAILURE WAS FOUND WITH THE FIRST VEHICLE AND BLAMED THE CONTACT. THE FAILURE MILEAGE WAS 100.

COLLISION AT 35MPH FRONT END OF FUSION HIT THE ENTIRE PASSENGER SIDE OF ANOTHER VEHICLE . NO AIRBAG DEPLOYED. OTHER VEHICLE WAS TOTALED.