2021 Ford Bronco 4DR SUV 4WD

One of the engine valve rods failed and punched a 3" hole in the engine block. I was traveling about 70 MPH when the engine light came on and the vehicle started to loose power. At the time I was on a major highway and barely had enough time to get off on the shoulder before the engine quit entirely. Fortunately, I had enough time to get off the highway, but what if this had happened somewhere on a highway where I could not safely pull off on the shoulder???

The contact owns a 2021 Ford Bronco. The contact stated that while at a stop sign, the vehicle experienced a catastrophic engine failure. There were no warning lights illuminated. The vehicle was towed to the local dealer where it was diagnosed that the engine needed to be replaced. The vehicle was repaired after several weeks. The manufacturer was notified of the failure however, no further assistance was provided. The approximate failure mileage was 2,322.

On November 14th, 2021, the 2.7 ecoboost engine on my 2021 Bronco, with 2744 miles, shut off without warning. I was traveling on the interstate, going approximately 75 mph, with my girlfriend and elderly mother as passengers. The Bronco lost all acceleration and the "service engine" light came on. Fortunately, I was able to coast to the nearest exit ramp. After bringing the vehicle to a stop, I attempted to restart the Bronco to no avail. The starter would engage, but the engine would not fire back up. I unhooked the battery cable in an attempt to reset the electronics, but this did not work either. I then checked to make sure all of the fuses were tight, but the vehicle still wouldn't start. The vehicle was transported to the nearest Ford dealership. After 6 1/2 weeks at the dealership, the Bronco's repairs were finally complete. The dealership had to replace the entire engine. Based on the paperwork given to me by the dealership, cylinders 4, 5, and 6 had low compression, cylinder 6 spark plug was found mashed from the piston, and they found catastrophic failure in cylinders 4, 5, and 6. Also, the paperwork states that metal was found in the oil, cylinder 6 intake valve was found in the intake manifold, and metal chunks were found in the intake manifold and turbos. Needless to say, we were all pretty shaken up over losing complete acceleration and power on the interstate. We were very fortunate there was an exit ramp close to us, but this could have turned out very differently. I feel like we were unnecessarily put in a dangerous situation in an essentially brand new vehicle.

While driving on interstate engine shut off. Was able to get to side of the road easily because it was late at night. Was not able to restart once coming to a complete stop. Had towed to dealer. Dealer could not get engine to start. Dealer found what looked to be a dropped valve. No indicators on the dash as to what was happening.

pulled up to stop light. car shuddred coughed and conked out. Got it started, coughing and sputtering. Made is 2 miles to get home. Had it towed to dealer. Dealer first said I got water in engine. There is no way that happend. Then they said ford will be paying for it to be repaired. 4,400 miles on her.

broke down with 2058 miles. Flashing engine light, strong fumes smell and vigorously shaking. Ford customer care said there’s nothing they could do. Not even a loaner for a $63k vehicle.

Without any warning lamps, messages or any other symptoms, lost acceleration power going roughly 45mph. I was traveling on a rural road, but this could have caused a serious accident if this would’ve happened in traffic or a highway. Dealer diagnosed a dropped valve in 2.7L engine, almost 2400 miles.

The 2.7 L engine failed going down the interstate in the middle lane. Complete loss of power. Was fortunate to be able to coast to the shoulder. Dealer says the engine failed and needs to be replaced.

water is leaking from the passenger side roof through the passenger side door airbag when it rains. The passenger side top door airbag is constantly getting wet from this leak as water passes through.

Rear glass lift gate exploded. Wind advisory was in effect but no surrounding cars were disturbed. The vehicle was parked and fully secure.

The contact owns a 2021 Ford Bronco. The contact received Manufacturer recall number: 21C23 (Air Bags), NHTSA Campaign Number: (Awaiting) however, the dealer informed the contact that the parts for the recall repair were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue and informed the contact that the remedy was not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2021 Ford Bronco. The contact received notification of NHTSA Campaign Number: 21V770000 (Air Bags) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2021 Ford Bronco. The contact stated after the vehicle was parked in the rain, he noticed on the passenger’s side A-pillar, where the air bag marking was located that water was leaking into the vehicle. No warning lights were illuminated. The vehicle was taken to the dealer where the cause was discovered as a clip was damaged allowing the water to get into the A-pillar. The dealer repaired the failure by adding additional sealant to the area. The contact stated he looked at the repair and contacted the dealer stating the repair was not proper. The dealer informed the contact that a TSB was recently issued for the failure. The contact was waiting for an appointment as parts needed to be ordered to repair the failure. The manufacturer was notified, and a case was opened. The approximate failure mileage was 600.

MY FRONT WINDSHIELD HAS CRACKED IN A MANNER THAT IS UNSAFE. IT HAS 2 IDENTICAL CRACKS ON EACH SIDE. SMALL ROCKS HIT THE GLASS AND CAUSED INSTANT CRACKS WELL OVER 8 INCHES IN LENGTH. I FEEL THAT THE GLASS IS NOT IMPACT RATED CORRECTLY OR TOO THIN. I HAVE NEVER SEEN A WINDSHIELD CRACK LIKE THIS FROM THE IMPACT OF A SMALL ROCK. THERE HAVE BEEN MANY COMPLAINTS ON ONLINE FORUMS OF THESE WINDSHIELDS CRACKING ON THE NEW BRONCO.

At present no incident has occurred. I am in the process of purchasing a 2021 Ford Bronco with the associated VIN number. The vehicle was delivered to the dealership, but as per guidance from corporate they are unable to now sell the vehicle. Ford has not determined a course of action and I am unable to purchase the vehicle. This is wholly unacceptable.