2016 Ford Explorer 4 DR SUV AWD

The contact owns a 2016 Ford Explorer. The contact stated that the trim located around the front driver side windshield loosened and detached from the vehicle while driving at highway speeds. The contact took the vehicle to the dealer where they replaced the trim on the front driver side windshield and tightened the trim on the front passenger side windshield. Despite the repair, the contact stated that the trim loosened again on both sides of the windshield. The manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 60,000.

My vehicle have been leaking coolant which causes the engine to overheat. I had the same issue in 2020 and had it repaired, which cost a lot of money to repair. I have not driven the vehicle as much since the last leak. Now 2 years later, it's the same issue. I don't have money like that to continuously repair a defect Ford has on it vehicles. Now I'm afraid to even drive my vehicle not knowing what might happen.

Air bag warning light fluctuates on/off at times. Connection pins under rear passenger seat appears to be the cause. No contact of pins

My rack and pinion steering column and power steering pump went out causing a hefty cost to replace and it is starting to fail again creating hazardous conditions while driving. I do believe there is a steering issue in these models. Also my power lift gate in the back closes without stopping automatically while I’m loading the rear or unloading. There is NO STOPPING SAFETY SENSOR, I HAD THE BACK CLOSE ON ME MULTIPLE TIMES AND ALMOST CRUSH ME. there is no safety sensor to stop the power lift gate from closing on you, I have had to crawl in my rear end to avoid being crushed by my liftgate! This is not safe!

3 weeks ago my vehicle has had an exhaust smell in the cabin, the car has been in the shop since. I started googling to see what the issue could potentially be and found your lawsuit. My vehicle is currently at Blake Utter Ford in Dennison TX getting diagnostics ran. My concern is my son and I have experienced nausea, dizziness, vomiting(my son), fatigue, and bloody noses after we exit the vehicle. Ford has known about this issue under Field service actions 17N03 and 19N05. If Ford has known of the issue why will they not make the issue an active recall? This is a health and safety concern, and could potentially be fatal. I have called Ford and filed an official complaint, there is nothing they will do since there are no active recalls on my vehicle, so we have to foot the bill?? They asked if I had a warranty, which I do, but if I didn't? This is would be a large expense. When I called [XXX] in McKinney, TX they didn't seem to care or know anything about the exhaust leak, they had a 10 day wait for diagnostics, with no rental vehicles. I called Blake Utter Ford where we purchased the vehicle, they have a 2-day wait for diagnostics, and same no rental vehicles. I have 3 children and two jobs I cannot be without a car. Who knows how long the repairs will take? I have never received any correspondence regarding the Class action suit, how can I be included? INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2016 Ford Explorer. The contact stated while driving at various speeds, there was an abnormally strong odor coming into the cabin of the vehicle. The contact stopped the vehicle and rolled the windows down. There was no warning light illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was informed that Carbon Monoxide was leaking into the vehicle. After researching, the contact became aware that there were similar vehicles that were experiencing the same failure. The vehicle was not repaired. The manufacturer was contacted but provided no assistance; the contact was instead referred to the NHTSA for assistance. The approximate failure mileage was 98,000.

On January 4, 2022, while driving my children to school at 55pmh, my steering rack failed. I was able to get the vehicle parked before the steering wheel completely froze up. Multiple messages showed up on the dashboard, including a steering failure message. The vehicle was towed to my local mechanic, and he has determined that the steering rack needs to be replaced, at an estimate of $2200.00. The repair is scheduled to be done on 2/10/22.

The contact owns a 2016 Ford Explorer. The contact stated that while his wife was starting the vehicle, the “Steering Assist Fault-Service Required” and “Service Advance Tract” and “Hill Start Assist Not Available” warning lights illuminated. The contact stated that the vehicle lost power steering assist functionality. The contact’s father met his wife at the scene and was able to drive the vehicle to the residence driving the vehicle in manual steering mode. The vehicle was taken to the dealer and diagnosed that the steering rack needed to be replaced. The manufacturer was notified of the failure and a case was opened. The manufacturer referred the contact to NHTSA for assistance. The vehicle was not repaired. The failure mileage was approximately 66,000.

The contact owns a 2016 Ford Explorer. The contact stated while driving at an unknown speed, the vehicle began to emit white smoke from the tailpipe. The vehicle was taken to a local mechanic where it was diagnosed with needing the head gasket replaced. The vehicle was not repaired. The contact stated that the check engine warning light was illuminated. The manufacturer was informed of the failure and informed the contact that they were unable to assist. The failure mileage was approximately 54,000.

Fuel pump fail

My wife was driving to work and the steering wheel just locked up on her and almost caused a serious accident out of nowhere

The contact owns a 2016 Ford Explorer equipt with Bridgestone Dueler Alenza Plus tires size P245/60/18 N/A, and DOT: RBVDRIM0916. The contact stated that while driving approximately 65 mph, a rotational noise was present coming from the front driver side of the vehicle. Upon inspection, it was discovered that the front driver side and passenger side tires had experienced cracking located above the tire bead area on the inside wall of the tire. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure. The failure mileage was 41,000.

The airbag light comes on due to the connectors in the wiring harness used for the airbag and seatbelt restraint system. When the light is on the airbags will not deploy, making this a safety related issue. Ford has a technical service bulletin Ford TSB 16-0001 showing the issue. This is not covered for repair and the cost is $900.00 to $1100.00 per side (there are two sides) to replace the wire harness and connectors. https://www.tsbsearch.com/Ford/16-0001

The contact owns a 2016 Ford Explorer. The contact stated that the side panels on the rear passenger’s and driver’s side doors were cracked. The contact indicated that the failed body parts were attached to the vehicle by glue. The dealer was notified of the failure and the contact was given an estimate for the repair. The manufacturer was also notified of the failure and agreed to cover half the cost of repair. The contact was then referred to NHTSA for further assistance. The vehicle was not repaired. The failure mileage was approximately 50,000.

The contact owns a 2016 Ford Explorer. The contact indicated that the rear power-folding third-row passenger’s side and driver’s side seats would not properly fold down and remain secured. The vehicle was taken to the local dealer who was unable to determine the cause of the failure. The manufacturer was also contacted regarding the failure. The failure mileage was 100,000.

The contact owns a 2016 Ford Explorer. The contact stated that while driving approximately 70 MPH, the side panel on the passenger’s side detached from the vehicle. On another occasion, the plastic front pillar section on the passenger’s side suddenly detached from the vehicle. The contact indicated that the failed body parts were attached to the vehicle by glue. The local dealer and manufacturer were notified of the failure. The failure mileage was 47,000.

The contact owns a 2016 Ford Explorer. The contact stated that while driving at 65 MPH, there was a loud snap sound and smoke came from the air vents. The contact rolled down the windows and pulled over while smoke was billowing from the vehicle. The vehicle was towed to an independent mechanic and diagnosed with engine and transfer case housing failure, where the transfer case housing was fractured in half. The vehicle was repaired with an engine and transfer case housing replacement. The dealer and Napleton Ford in Libertyville (1010 S Milwaukee Ave, Libertyville, IL 60048) were made aware of the failure but informed the contact that the vehicle was out of warranty and the parts for the repair were not available. The manufacturer was made aware of the failure and referred the contact to file a complaint with NHTSA. The failure mileage was approximately 88,000.

The contact owns a 2016 Ford Explorer. The contact stated that starting the vehicle, he noticed the airbag warning light illuminated and remained illuminated. The contact called the local dealer to schedule an appointment to have the vehicle inspected however, the dealer would not be able to inspect the vehicle for several weeks due to a staffing shortage. The vehicle was taken to an independent mechanic to be diagnosed. The contact was notified of an error message with the driver’s side rear airbags. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 50,000.

rear suspension issue, causes both rear tires to wear abnormally on outside edge. causes unstable handling. had the vehicle realighned twice, 4000 miles between alighnments. the vehicle has now worn out two sets of new back tires and continues to exhibit unstable handling.

The Power transfer unit is leaking fluid onto the exhaust and it caught on fire as I pulled into my driveway. I was able to extinguish the fire before any damage was done. There is also a nauseous odor in the cabin of the vehicle that makes me sick, burns my eyes every time I drive my vehicle. I was told by a mechanic that this was the fluid from the PTU burning Did some research and discovered this is a common problem with these PTU's leaking fluid. Very concerned now that it will catch on fire again and cause damage or even a wreak if it locks up. I fear that this could harm me or someone else if this problem is not fixed ASAP. I have no other vehicle and not sure how to even get it fixed. The dealership said it would cost around $2000 to have it fixed. I would like someone to look at this issue, Ford advised that is not there problem and its not covered by any recalls. There is no way of knowing if it catches on fire going down the road until its actually on fire.

There has not yet been an incident, however, the Ford dealer is not returning any calls or service schedule requests to have the RECALL repairs done, and I am concerned the problems may become worse to the point that there is an incident. Can NHTSA force Ford to get their dealers to prioritize recall repairs?

Steering gear assembly completely failed, causing a total lock up of the steering wheel and loss of control. Happened at highway speeds, could barely pull off to side of road. Nearly crashed as there was no warning or indication of total steering loss. Ford dealer replacement cost of $3000. I was told this is a common issue with the Explorer, but there was no remedy offered by Ford.

When the SUV is warm there is a odor of something burning. Has been a couple of years now.

Hello, this is a issue with the heating and air conditioning. when i turn on the heat i have it set to anything about 75 degrees, the suv is blowing out cold air. and sometimes the AC turns on blowing air but the light for the AC is not turned on.

THE A PILLAR COVER HAVE DETACHED ON BOTH THE DRIVER AND PASSENGER SIDES. THE COVER THAT DETACHES WHILE DRIVING CAN CREATE A ROAD HAZARD FOR OTHER USERS, INCREASING THE RISK OF A CRASH. THIS ISSUE HAS NOT BEEN ADDRESSED BY THE MANUFACTURER. I HAVE OBSERVED SEVERAL VEHICLES OF THE SAME MAKE AND MODEL MISSING THESE SAME COVERS.

The contact owns a 2016 Ford Explorer. The contact stated that the vehicle constantly smelled of gasoline. The contact stated that the odor occurred when the vehicle was in motion but was stronger when the vehicle was idle. The vehicle was taken to an independent mechanic who was not able to properly diagnose the vehicle. The mechanic sealed several locations where the odor might have been coming from. The vehicle was taken to the dealer because the gasoline odor was stronger on the outside of the vehicle. The dealer was not able to determine the cause of the failure and referred the contact to NHTSA for assistance. The contact stated that the failure had gotten progressively worse. The manufacturer was not notified of the failure. The failure mileage was 90,000

I was driving down the highway at approximately 60mph when my steering wheel became extremely stiff and hard to turn. The vehicle became very hard to handle. The steering wheel ended up locking up completely and I had to have it towed to the dealership. After diagnostics it was determined that the entire steering gear had failed. The cost to fix is $2200.00. Keep in mind that there is only 26,000 miles on the odometer! There were also no warning lights on the dash. No recall or warranty coverage.

Using the FORD PASS ap, I have two recalls for my 2016 Ford Explorer Sport. Recall 21S22 for the roof rack trim detachment and 21N01 for high speed cooling fan motor relay. I use Miracle Ford in Gallatin, TN. They have made incident reports on two separate occasions for my car. First, they lost the report in July and then the manager, Robert, brought me back in for a second report. I keep getting text messages that my service is complete, but it hasn't been completed. They haven't called me to bring my car back in for repair and I get the run around every time I call. I've attempted to reach supervisor and Robert, the manager, with no success. I'm starting to get worried!

Transmission failure, not shifting consistently, multiple times would not shift out of second gear after down shifting during driving. This is dangerous when merging into higher speeds where acceleration is needed, such as on highway. Took Vehicle to Ford dealership twice while under power train warranty and they stated they could not replicate the concern. They reset adaptive learning transmission, because they said shifting was likely due to different driving styles between husband and wife. Now 6 months later, issue continues and they admit it is a faulty transmission, but is no longer under warranty.

The contact owns a 2016 Ford Explorer. The contact stated that the air bag warning light was illuminated. The contact stated that previously the air bag warning light was illuminated however, the warning light disappeared independently. The vehicle was taken to the local dealer where the diagnostic trouble code: B141B was retrieved. The contact was informed that the connector for the second-row seats needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to NHTSA. The approximate failure mileage was 80,000.

About 2 weeks ago I heard a noise and from that point it sounded like my steering wheel was grinding. Steering is tight at slower speeds and it is making that same grinding noise. I took it to a dealership to get checked out and was told the steering gear had failed and that it needs to be repaired however the parts are on back order with no foreseeable ship date, but that it was ok to drive, just may be a little hard to steer at low speeds. This morning my steering wheel was totally locked up and could not turn in either direction. There are no warning lights or other indication of an issue. My concern is could this have happened while driving? What caused it to break in the first place and why did it ultimately seize up completely after being told it could be driven?

The contact owns a 2016 Ford Explorer. The contact stated while making a turn, the steering wheel became difficult to turn. The contact stated no warning light was illuminated. The vehicle was taken to a local mechanic where it was diagnosed with needing the steering gear replaced. The vehicle was not repaired. The manufacturer was informed of the failure and informed the contact that the VIN was not under recall. The failure mileage was approximately 55,000.

Steering rack failure on 2016 and 17 Explorers at 55,000 mile, haven't had the vehicle in a month due to acquiring parts because there are so many of these parts failing and was told by ford they can't release the vehicle until its repaired because the steering could lock up and it is also a $3000.00 dollar repair. Wouldn't this be a recall due to the low mileage, amount of failures and and result of the failure

When I turn right there is a popping noise. Sometimes the steering wheel gets stuck and I have to pull it hard to go back straight. It’s very scary, especially going around a curve.

My steering felt very out of control had to have car towed to dealer and they replaced rack and pinion there was internal damage to steering rack they had to replace it

Vehicle power stalled on acceleration after pulling onto lane of travel. Road traffic heavy in both directions. Vehicle would not shift beyond initial gear of automatic transmission. Available travel speed of 40-45 mph only. Wrench light/powertrain light came on. No prior warning lights. No prior operational issues detected. After stopping vehicle, would not operate in reverse. Warning light indicator and manual reported to get to dealer asap. Dealer indicated transmission issue. Transmission was replaced. Vehicle had 56,418 miles (within 60,000 warranty) but beyond 5 year warranty.

The vehicle surges when drive at low speeds, I have to keep my foot on the brake so it don't take off or hit something in front of me. About a month ago the surging almost made me hit a child in the roadway in front of my house. I am really uncomfortable driving the vehicle and don't feel its safe to drive due to this problem. Ford dealership is not giving any info on what tis problem could be. I found several problems on here related to this issue.

We purchased this vehicle through CarMax and there were several items that required repair/replacement. One of which is the front passenger seat belt. There is a small tear in the seat belt. We are told that it is too small for replacement. We have not been injured since the purchase of the vehicle, though this is a major safety concern for my family. I would like to know the safety data and recommendations for seat belt tears/defects.

2016 Ford Explorer 3.5 Liter (non-turbo) front wheel drive, 52k miles. We noticed coolant puddling on the ground and took the car in to the dealer for an inspection. The dealer pressure tested the cooling system and confirmed the internal water pump is failing. This issue could lead to engine overheating and engine shutdown at any given time, causing unknown safety issues. Dealer quoted $3,400 to repair.

2016 Ford Explorer 3.5 Liter (non-turbo) front wheel drive, automatic, 44k miles. Loss of power, vehicle jerked and stayed in one gear. We limped the car home and let it cool down. After the car cooled down, we went on small test drive and confirmed it was shifting erratically. We took the car to the dealer and they confirmed a component in the transmission had failed, disabling the vehicle. Over $3,000 worth of transmission repairs were made under warranty.

Passenger side piller trim detachment this has been an issue on the 2013 thru 2015 models and was issued a recall. Same thing is happening on the 2016 model. Drivers side is also loose. Many 2016 models are having this same problem

On October 17, 2021 the steering system on my 2016 explorer completely shutdown. The ABS, Hill Assist and Service Advance Trac lights all went on. The steering wheel would not turn either way. Luckily, this incident occurred in a parking lot and no injury or damage happened. I had AAA tow the car to Porter Ford, Newark DE.

The contact owns a 2016 Ford Explorer. The contact’s wife stated while driving approximately 45 MPH, the steering wheel became difficult to turn. The contact stated that the steering assist and traction control warning lights were illuminated. The vehicle was taken to a local dealer where it was diagnosed with needing rack and pinion to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure and informed the contact that the vehicle was not included in a recall. The failure mileage was approximately 84,000.

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V316000 (Structure) however, the part to do the recall repair was unavailable. The contact took the vehicle to the local dealer and it was confirmed that the part was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.

Driving at 20mph, going through a moderate turn and lost Power Steering. No warning lights, no noise, just total loss of Steering and I felt as if I couldn't overpower the steering until 2 seconds later I regained power steering. The same problem occurred at 10mph while coming to a stop. Once again I did not have the ability to overpower the wheel and straighten it when I tried. Luckily once again power came back and I was able to control without issue. Several complaints on the same issue and NO RECALL has been issued by Ford. If the same issue occurs at highway speed I don't know what I'll do. Ford had a Service Bulletin out for 2013-2016 Explorers that stated they would simply reprogram the module. They did not extend the coverage beyond 2018 nor did they actually replace a faulty steering rack with the coverage. This is a severe safety concern and one that should have a recall out as it puts the driver and all other motorists at risk. If you can't steer your car, then everyone is at risk.

The driver seat advanced forward after hitting the preset button but did not stop. I was crushed between the steering wheel and the dash. There was only 3 inches between the seat and the dash for my knees. This is a major safety issue that caused bodily injury. It happened twice. I have video showing this issue but can’t seem to upload it to this site.

The contact owns a 2016 Ford Explorer. The contact stated while driving at an unknown speed, she started to smell exhaust fumes and the vehicle started to hesitate and became difficult to shift into other gears. The contact stated that there was no warning light illuminated. The contact took the vehicle to the local dealer, where it was diagnosed with needing the power transfer unit to be replaced. The vehicle was not repaired. The contact took the vehicle to an independent mechanic and had the power transfer unit replaced. The contact also stated while driving at various speeds on 10/4/52021, the steering wheel became difficult to turn. The contact stated no warning light was illuminated. The contact was able to drive to her destination. The contact took the vehicle to the local dealer, where it was diagnosed with needing the power steering to be replaced. The vehicle was not repaired but was pending repairs. The manufacturer had been informed of the failure. The failure mileage was approximately 67,800.

The contact owns a 2016 Ford Explorer. The contact stated while driving 35 MPH, the contact noticed that the engine coolant temperature warning light was illuminated, and the vehicle started to shudder. The contact pulled the vehicle over to the side of the road and waited a few minutes before restarting the vehicle and continuing driving however, the failure persisted. The contact took the vehicle to a local dealer to be diagnosed. The contact was informed that the water pump needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 77,000.

The contact owns a 2016 Ford Explorer. The contact stated while driving 5 MPH and making a turn, he heard an abnormal banging sound coming from the steering wheel and the steering wheel locked up. There were no warning lights illuminated. The contact stated as he veered to the side of the road, he was able to steer the steering wheel with no issues. The vehicle was taken to the dealer who diagnosed that the power steering rack needed to be replaced; however, the part for the repair was not yet available. The manufacturer was notified of the failure and advised the contact that they would follow up with the dealer. A case was opened. The vehicle was not repaired. The approximate failure mileage was 58,000.

Observed white smoke from exhaust, Took vehicle to for dealership, dealership said coolant was leaking into cylinder head and cylinder head was cracked. Car is 6 months and 1000 miles out of Ford Powertrain warranty. Ford TSB advisors I need a new engine. Looked at vehicle history report and discovered numerous other mechanical issues with the engine including a transmission replacement and turbo replacement all under 50 k miles on vehicle.

Beginning of day; felt like I was in a major windstorm & in a constant battle with the car steering. Middle of day: Power Steering Fault light came on and feeling like I was in a major windstorm & in a constant battle with the car steering GETTING WORSE. End of the day: Then Power Steering Failure "Pull over Safely" came on.. I didn't just lose power steering. I lost TOTAL STEERING capability at 57,400 miles... Car is at dealership now. Had my 90yr old mother been driving there would have been an accident. This is gonna get someone killed. I had just dropped off my Grandson before I lost total control.

Complete loss of basic steering of the car while under operation.

The contact owns a 2016 Ford Explorer. The contact stated that while his son was driving 40 MPH, the power steering failed, and the steering wheel was stiff and difficult to steer. The vehicle was taken to the dealer and diagnosed with steering rack failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 123,000.

Air bag light came on and I took it to Vancouver Auto Group. Finding from diagnose electrical system include: RCM: B141B:13, checked oasis, TSB 16-0001 applies, checked behind second row seat and inspected connectors C3133 and C3133 and C3134, connectors have not yet been rerouted and replaced, recommended wire in new pigtails and reroute wiring harness in both seats and retest. Estimated cost is $1500. I researched and found over 50 other complaints of Ford Explorer owners with the same complaint. This should be recalled as it is not the vehicle owners fault that the connectors have failed and car needs rewired. This is not covered by extended warranty. This is a safety concern and is not being addressed by Ford.

The contact owns a 2016 Ford Explorer. The contact stated while driving 75 MPH, the windshield plastic trim piece detached from vehicle. There were no reported injuries. The vehicle was taken to the local dealer and the contact was informed that the plastic trim piece needed to be replaced. The vehicle was not repaired. While driving the other plastic trim piece detached. The manufacturer was not notified. The failure mileage was approximately 153,000.

Exhaust leaks into cab under moderate to heavy acceleration with windows closed it is even worse when accelerating with the windows open

Component - passenger side rook rack rail cover. Safety of others - part flew off as I was driving vehicle between 55-60 mph. Not sure if it hit any other vehicles. Have not taken vehicle to dealer or other service center. Vehicle has not been inspected by any third party. The only symptom prior to the problem, was loud noises heard while driving. Waited until I could find an exit ramp to inspect the vehicle, but did not find anything. It was only after I arrived at my destination that I noticed the cover had fallen off. No warning lamps, messages, or indicators of any other kind were displayed to me.

Anytime I accelerate above 55-60mph my vehicle smells like it is burning. This smell consumes the cab area for a period of time. I have owned the vehicle for 1 year now and it has done this since the day I purchased it.

The contact owns a 2016 Ford Explorer. The contact stated that his wife was driving at an undisclosed speed, the rubber from the windshield was flapping and making noises, almost causing a collision. The contact inspected the windshield and saw that the front passenger’s and driver’s side rubber on the windshield had deteriorated. The contact glued the rubber to the windshield to repair the failure. The dealer was made aware of the failure and informed the contact that there was no recall related to the failure and the contact had to pay for the same part already installed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to file a complaint with NHTSA. The failure mileage was approximately 26,000.

The tie rod on my 2016 Ford Explorer BROKE. Luckily my husband was just backing it out of our garage He heard a loud noise sounding like he had run over something metal and the car would not move. He got out to take a look and the right front wheel was turned completely sideways The dealership told us to bring it in. We had to hire a flat bed truck to get it there.so that was at our expense.When the flat bed truck driver came from another repair shop to help us, he immediately said "Oh,you have a broken tie rod huh?" We did not know. He said there is a rubber boot around the tie rods and our tie rod broke.My husband told the garage dealership this.They said they had never heard of that. BUT in taking it apart they discovered that was the case. We were without a car for 3 weeks as they had troubles locating a part. I wanted both sides fixed but they only fixed the one. They did give me the old part. It is a rusty, horrible looking piece of crap. It looks like it is 100 years old. It absolutely BROKE. Here is my concern. What if my husband and I and our friends would have been in the car driving 65 down the highway? I know what would have happened. There would have been deaths and severe injuries.THANK GOD it happened in our drive at home. We had no warning.Had there been an accident the report would have been "the driver and his passengers were killed after the driver lost control of the car". Never probably would have found this MAJOR LIFE THREATENING flaw in the car. How many accidents have there been with that conclusion. Did the driver really lost control or was there a major safety issue? I am scared to death to get in this car and go anywhere,Now we get a recall notice regarding possibility of a rear toe link fracture. REALLY? AND PARTS ARE UNAVAILABLE ACCORDING TO THE LETTER? Are we to park the car and wait for the parts to become available? we need a car to drive. Ford needs to replace or reimburse for these damaged vehicles. I feel very, very unsafe.

Plastic drivers seat mounting components have failed causing drivers seat to rock back & forth. Concerned that remainder of seat mounting system will fail and I will go through the windshield during a hard brake stop or cause me to swerve and hit or kill someone else.

The contact owns a 2016 Ford Explorer. The contact received notification of NHTSA Campaign Number: 21V316000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, tapping noises were heard coming from the roof of the vehicle before the roof rack trim detached and hit another vehicle. The dealer was made aware of the recall and informed the contact that parts were not yet available. The manufacturer was not made aware of the failure. The failure mileage was approximately 20,000. VIN tool confirms parts not available.

The contact owns a 2016 Ford Explorer. The contact stated while driving at various speeds, excessive force was needed to steer the vehicle without warning. The contact then took the vehicle to an independent mechanic where they informed her that the electrical rack and pinion needed to be replaced, followed by an alignment. The dealer was notified of the failure and informed her that the vehicle was not under recall or warranty. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 48,000.

On my 2016 Ford Explorer, the A Pillars on both the passenger and driver's side completely detached from the car while driving and flew back into the road while driving on the highway. The A pillars that detached could have easily hit another car/person and caused serious damage. My local Ford dealership inspected the car and pillars and confirmed this as a common failure. They have informed me that there is now a new version of this part because of this common failure. However, the part is currently back ordered and cannot be repaired on any timeline. They are currently duct taped onto the car to protect the car from any further damage. I believe since Ford acknowledged the failure and there was a need to create a new system/part, then this should be a recall of the current parts. There were no warnings or previous issues with the A pillar trim pieces before they just came completely detached, both within an hour of one another. A quick google search can find that this is a very common failure with many Ford explorers. I hope Ford would do the right thing and recall this part.

The contact owns a 2016 Ford Explorer. The contact stated while driving 70 MPH, the contact heard a knocking noise from the front driver’s side window. The contact pulled over to the side of the road and inspected the vehicle and noticed that the weatherstrip on the front driver’s side door was detaching from the molding that held the weatherstrip from the windshield. The contact pushed the weather strip back into the molding and continued to drive back to the residence. The contact took the vehicle to an independent mechanic who inspected the vehicle and stated that the weatherstrip had loosened over time. The mechanic glued the weather strip back into the molding as a temporary fix and referred the contact to a local dealer for assistance. The contact took the vehicle to the local dealer and was informed that the molding needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 58,000.

The front pillar cover has blown off my 2016 Explorer 3 times in the 4 years I’ve owned the vehicle. Two of the 3 times this occurred, I was traveling in heavy traffic on a limited access highway causing a hazard for the other drivers. I don’t know where the piece landed or if it hit other vehicles. I have complained about the flawed design to Ford, calling their Customer Service number and the tech told me he didn’t see any other complaints related to this from other Ford Explorer owners. What will it take for Ford to fix this design flaw to prevent repeat occurrences? Or at least acknowledge it in their database? The only risk to me is the distraction caused by the sudden noise which drew my attention from the road while I triaged the cause. I hope no motorcycle or convertibles were hit by the debris. I wouldn’t replace the trim but now the windshield is probably impacted. The windshield gasket is exposed and flapped in the wind for the entire trip home after this last time. It was like riding in a helicopter without ear protection.

Ecoboost Base 76k miles had a steering rack failure . Over looking all other complaints, looks like I’m not the only one with the 2500$ bill . Ford dealership acknowledged that it was a very common issue and was easy to diagnosed . I was met with light flashing on dash then would disappear after I restarted the SUV . Until I turned it on one day at a sonic drive in and would not steer . I’ve read reports where people are driving on the freeway when it happens and I could only imagine how that would’ve been like especially since I drive with my child onboard . Dash says “ Advance Track Failure; Hill Assist Needs Maintence “ . It was quickly diagnosed over the phone but still took it to get looked at, at Ford . 100% should be a recall at such a low mileage, just thought since police use them in their fleet they had to be reliable . For it to be a 300$ core as well, sounds like it’s still a valuable part broken

At approximately 102,000 miles, vehicle started making loud grinding noise when turning the steering wheel in either direction, very noticeable both inside and outside the vehicle, both when stopped and when driving. The steering wheel sticks in certain positions while driving, requiring extra force to maintain the vehicle's direction. Issue is worse at highway speeds, creating a dangerous condition that was getting progressively worse. Made it to a Ford dealership who indicated that a new rack and pinion assembly is required at $2,900. They also recommended not driving the vehicle in that the condition was unsafe.

Lost steering all at once could not turn wheel luckily i was in my drive way when it happened i paid yes ford 1600.00 dollars for a new rack and pinion on 8-13-21 was given a release date on part for 8-24-21 then 8-25-21 and now 9-3-21 this is an emergency order thru ford they was quick to take my money but cant deliver part.I have turned in a complaint to ford and it has not helped no calls back from ford. Looks like this is a huge problem ford has with its explorer rack and pinion failure I guess there waiting on somebody to get killed with faulty racks before they do anything. My explorer has 65000 miles on it and it looks like this is a common failure for this vehicle.

The contact owns a 2016 Ford Explorer. The contact stated that while operating the vehicle, the 2nd row seating air bag warning light was illuminated. The cause of the failure was not yet determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 39,000.

Power Steering Assist Failure indicator appeared on dashboard resulting in inability to steer car. Vehicle was towed to dealership and reprogramming was attempted with no success. Requires replacement of EPS steering.

EL RACK AN PINON YA FUE REMPLAZADO. ENTIENDO QUE ES MUY PREMATURO PARA REMPLARLO. ES UN FALLA DE FABRICA. TRANSLATION: "THE RACK AND PINION WAS REPLACED. TO MY UNDERSTANDING IS TOO PREMATURE TO BE REPLACED. IT SEEMS LIKE IS A MANUGACTURING DEFECT"

Extreme sulphur/rotten egg smell coming into the cabin. It also reeks of exhaust fumes that are making me nauseous and light headed. This comes out of the A/C and you can smell it when you exit the vehicle too.

Was driving on I-40 at approximately 75mph and vehicle lost all acceleration, wrench icon came on in dash. Pressed. Gas pedal to the floor, no acceleration. Had to pull over on side of road. Pulled over vehicle stared shaken. Cut off vehicle for about 1min. Tried to retest vehicle, vehicle did not want to restart/crank. Tried again vehicle stared up. Vehicle power is not the same. Thank God I was on the right side of the highway instead of the middle so I could get off the road. This could have been worse.

Vehicle has a known airbag malfunction that is covered by a manufacturer published service bulletin. Ford and their Dealerships refuse to perform published safety service bulletin without charging for parts and labor. Ford and dealerships response to issue is that without the at owner cost repair of the faulty safety restraint, the entire safety system may not function. Bulletin is TSB 16-0001 Owners have no operable safety system unless paying to repair a known safety issue.

The contact owns a 2016 Ford Explorer. The contact stated that while driving approximately 45 MPH, the power steering and power steering assist failed. The contact was able to drive the vehicle home, however, the steering was manual making it more difficult to maneuver the vehicle. The contact had not taken the vehicle to the dealer. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 100,000.

Over the last year or so, my 2016 Ford Explorer would suddenly out of nowhere say on the dashboard that there is a steering fault that needed to be serviced. The steering would be a little off but after turning the car on and off, it would reset and wouldn’t happen again for a week or two. I took it in to the dealership to get a recall fixed and had them take a look at my actual steering issue (with videos and pictures of the problem) but they could not replicate the problem as the dashboard would reset. Fast forward to last Thursday when the problem was more persistent than normal. A few times in the last couple months or so, my steering wheel would LOCK UP completely because the power steering would give out and a few times I was ON A FREEWAY. I had to manually hand crank a very very stiff steering wheel and pull over which was extremely dangerous. Once I would, I would turn the car on and off again which then it would reset. The dashboard warning about the steering fault would come on more often than the steering wheel locking up but the several times it did lock it, proved a very dangerous situation. It happened again this past week which I had to drive slowly to my local mechanic. Due to it being a power steering/programming issue, the recommended me going back to the dealership. At that point, my car would no longer reset the issue and I was unable to drive home that day because the power steering permanently gave out. Thank god I was at the mechanic already. Currently, I have the car towed to the dealership and they are working on the problem. Because my extended warranty ended 2k miles ago, I am supposed to pay $3800 out of pocket for this?? It should be a RECALL situation. Extremely dangerous. Forum related issue that I did research on and it seems to be a common problem!!! : https://www.carproblemzoo.com/ford/explorer/2016/steering-rack-and-pinion-problems.php Please help make Ford do a recall for this dangerous issue!!

Vehicle displays airbag warning light. Dealership diagnostic test determined there is a faulty connection to the 2nd-row inflatable seatbelt sensor. Ford issued a service bulletin to replace the wire harness pigtail connection. When the airbag light is illuminated due to this faulty connection, all of the airbags in the vehicle are deactivated. Directly from site: Https://Ford.oemdtc.com/1203/air-bag-warning-light-illuminated-with-dtc-B141B-B141C-2014-2016-Ford-Explorer tsb 16-0001 airbag warning light illuminated with diagnostic trouble code (dtc) B141B and/or B141C. This is not normal wear and tear but a safety item design by Ford that has failed in the vehicle. Ford dealership claims that this is not warranty failure. Cost to repair $1085 plus $230 diagnostic test charge.

NY CAR OVERHEATED AND SPILLED ALL THE COOLANT DUE TO THE ENGINE BLOCK HEATERS IT HAS. I TOOK IT FOR AN INSPECTION AND THEY TOLD ME THESE ARE VERY DANGEROUS AND NEED TO BE CHANGED ASAP, I CALLED THE DEALER AND THEY TOLD ME MY CAR DOES NOT HAVE THIS RECALL AND THEY WANT TO CHARGE ME WHEN CLEARLY IT IS THE EXACT PROBLEM WITH RECALL # 16S14 FROM FORD. I NEED THIS FIXED ASAP AT NO CHARGE TO ME AS IT IS FORDS PROBLEM. I NEED MY CAR BACK TO GET TO WORK PLEASE

Vehicle started to feel heavy, and vibrate harder through the gas pedal and steering wheel. I took it to my local auto shop and the wheel bearing needs replaced.

The contact owns a 2016 Ford Explorer. The contact stated while driving at various speeds, there was an abnormal odor inside the vehicle. There was no warning light illuminated. The vehicle was not diagnosed nor repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 89,000. The Vin was not available.

On approximately July 5th, I was driving on freeway at approximately 70mph. I approached a work zone and had to move to shoulder when I lost power steering. It continued to give me issues at higher speeds for the next 40 miles and it seemed to disappear for the next two weeks of city driving. I thought it was an isolated incident and on July 16th we took the vehicle on a family vacation and when traveling on the freeway it again lost ( and never regained) power steering but we were more than 200 miles from home and the closest Ford dealer couldn't see us until early August. At lower speeds the steering was sticking but it seemed to free up some the more cornering or movement you made with the steering wheel. We were able to carefully drive the vehicle home and took it to Taylor Ford on Monday July 26th. On Tuesday July 27th I received a call from our service rep telling me nothing was wrong with the power steering but that the steering column failed and it would need to be replaced. I said that I had never heard of such a thing and he said he hadn't either. I searched on line and discovered hundreds of complaints referencing similar issues. There were no warning lamps, messages or other symptoms prior to the problem and they never appeared during problems.

The system that failed is the seat belt buckle on the 40 seat (of the 60/40 second row seating). The clip inside the seatbelt broke while securing my child in the seat. This faulty belt buckle put my child's safety at risk. We could not travel, delaying our trip on the day we were to leave. If an accident occurred, this could have resulted in serious injury to my child. The belt buckle was removed and taken to the closest Ford dealership. A new belt buckle was ordered, costing $115. The seatbelt buckle was removed and brought into Ford to examine. No concern was observed by the service parts employee as he glanced over broken buckle to ensure he ordered the correct part. No warnings or "symptoms" were present previously to the failed seatbelt buckle. A cheap piece of plastic to hold my child in a seatbelt buckle failed. The broken buckle is available for inspection. A new one is being installed.

Constant smell of exhaust inside the vehicle. Took it to dealer and they could not figure out issue.

It appears Ford had a prior recall for certain model year 2011-2013 Ford Explorer vehicles manufactured May 17, 2010, through February 28, 2012 for a power steering failure. The recall was due to vehicles experiencing a loss of power steering assist and required extra steering effort at lower speeds, increasing the risk of a vehicle crash. I have a 2016 Ford Explorer and the issue appears to be occurring in later models like mine. I experienced it on July 21, 2021. I was driving on the freeway at 70mph and with no prior warning I my power steering goes out and I see the message "power steering module failure". Luckily I was able to fight the car to the shoulder, but I can only imagine what would have happened if my wife or daughter had been driving at the time. Ford needs to have a system failure alert added or better yet fix the issue from occurring, especially in a fairly new vehicle.

The contact owns a 2016 Ford Explorer. The contact stated that while operating the vehicle, the steering wheel was difficult to turn and would cease when turning in either direction. The vehicle was taken to the local dealer who diagnosed that the steering rack and pinion were faulty and needed to be replaced. The failure was not yet repaired. The manufacturer was also notified of the failure. The failure mileage was approximately 46,000.

The contact owns a 2016 Ford Explorer. The contact stated that while his wife was driving at an undisclosed speed, the electric power steering failed, and the steering wheel ceased. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the power steering rack and pinion was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA to file a complaint. The failure mileage was approximately 40,000.

The contact owns a 2016 Ford Explorer. The contact stated while driving at various speeds, the vehicle lost power steering functionality and became difficult to steer. The contact also stated that the vehicle would start shaking abnormally whenever the brake pedal was depressed. There was no warning light illuminated. The vehicle was taken to a local dealer where it was diagnosed with the electronic steering gear needing to be replaced. The vehicle was repaired however, the failure recurred a year later. The manufacturer had not been informed of the failure. The failure mileage was approximately 144,000.

2016 Ford Explorer Sport. Roof rail recall may be the cause for extreme water damage that burned out the sunroof motor, drenched the interior carpet, interior roof material, navigation and charging docks do not work. Ford not acknowledging and states after diagnostic check I have to pay 2600 to replace motor and once sunroof opens they can determine where the water leak is coming from. Also after complaining of carbon monoxide smell in cabin and multiple doctors visit with dizziness, trouble breathing I found that this is not just an issue I’m having. This car has had many more issues and Ford just repeats that warranty doesn’t cover it warranty expired. These are huge issues with the manufacturing. Car only has 35k miles and issues started in 2020.

Electronic steering assist seems to fail on rainy days. Starts like a sound grinding on the bottom like it needs lubrication. Afraid to drive this thing because of other owners comments regarding the steering assist causing accidents.

The Contact owns a 2016 Ford Explorer. The contact stated that while attempting to turn the steering wheel, the steering wheel was firm. The power steering assist warning light was illuminated. The vehicle was taken to the dealer to be diagnosed. The contact was not provided a cause for the failure but was informed that the steering wheel needed to be replaced. The vehicle was not yet repaired. The manufacturer was contacted and informed of the failure. The approximate failure mileage was 62,000.

While driving around a corner at a speed of 45 miles an hour the power steering quit working. The message on the instrument panel stated steering fault. I no longer had power steering and it was very hard to pull the vehicle over. I shut off the motor and then restarted the vehicle and i now had power steering. It is currently at Varney Ford in Newport Maine having the whole steering assembly replaced at a cost of 2300.00. From my research I have found that the steering assembly is located near the catalytic converter which gets every every hot, and can damage the internal circuit board. This is a very scary safety concern! I do not have the invoice for the repair, as it is being worked on July 19th or July 20th

The contact owns a 2016 Ford Explorer. The contact received a recall notification for NHTSA Campaign number: 21V316000 (Structure) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was notified of the issue. The contact had not experienced a failure. Vin tool confirms parts not available.

Steering locked up while driving, causing a dangerous situation, fortunalty it was at low speeds an no harm came of it. 61,000 miles on the vehicle, Failed rack and pinion steering, needed to be replaced. $2,500 .

I was driving down the highway into a turn and my power steering failed causing the SUV to want to recall into a straight pattern almost causing me to crash my truck into a barrier wall with my child inside. With the sudden ability to fight the wheel back into a turning position I was able to narrowly avoid crashing with my child. Numerous indicators displayed (Steering Assist Fault, Service Advance Track, Hill Start Assist not available). I immediately took it to a Ford dealer , where they advised me that the power steering rack has electronically failed.

The contact owns a 2016 Ford Explorer. The contact stated that while yielding to merge onto the highway, the vehicle would not accelerate above 3 mph, with the accelerator pedal depressed. The vehicle was taken to an independent mechanic and diagnosed with transmission failure. The independent mechanic informed the contact that the transmission needed to be replaced. The vehicle was not repaired and remained at the independent mechanic. The manufacturer was made aware of the failure but informed the contact that there was no recall associated with the Vin for the transmission. The failure mileage was 104,000.

My airbags light comes on and stays on someone's and I looked it up in my owners manual and it says to get it checked immediately due to a malfunction with the [XXX] bags. My problem is when I called them the light had went back out. Everytime it comes on and stays on I'm nowhere near my dealer. So it hasn't been checked out by them yet. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Driving on express way going 70 mph and vehicle dash started lighting up and beeping with a bunch of different things and lost power steering. It said “power steering fault” was in construction and it was extremely scary. Thankfully there was a dealership on the exit and they said it was the power steering rack.

While driving at 55+mph both driver side and passenger side A-pillar windshield covers vibrate. Eventually the passenger side blew off during the drying cycle at a car wash. Thankfully it was contained and did not fly off on the road and cause an incident. There are more cases of this occurring on the highways as seen by searching the internet.

With less than 75k miles, the steering began to grind when turning. We had to get an entirely new rack and pinion unit replaced for over $2400. Thousands of 2016 Explorers have reported this problem but it is still not been deemed a recall. Recently, at 84K miles, the clutch on the AC compressor went out causing a $720 bill for a new compressor. We have also just found out the water pump is now bad and appears to be defective. In fact there was a class action lawsuit in 2020 regarding these defective pumps but this wonderful government we pay exorbitant taxes to, threw the case out on technicalities. Absolutely shameful.

i have had NOTHING but issues with this vehicle and have made more calls to complain to ford with no help. as an example i complained for 2 years about this rattle and clunk in my transmission..finally i got the ford dealership in clarion, pa to believe me..here it was the torque converter..after 2 years of complaining and after i got it back...a week later..i get a recall notice from ford! but, the purpose of this is my tailgate...has a mind of it's own...it will open on it's own and close...i don't know how many times this has happened...thank God it hasn't happened while i am driving...i have had it to the garage...nothing can be found...yet i researched this issue and found others having similar experience!!!! i have called ford and of course...they refuse to acknowledge my concerns...i have been clunked on the head more than once loading groceries...hopefully you will be an agency that actually does something as opposed to those that talk tough...but do nothing! thank you.

The contact owned a 2016 Ford Explorer. The contact stated that while driving at 65 - 67 mph, the contact lost control of the vehicle when the rear driver side toe link fractured. The vehicle ended up in a ditch and crashed into several trees. The contact was transported to the hospital by ambulance but his wife, who was a passenger, did not receive medical attention. A police report was filed. The vehicle was towed to a towing yard and deemed totaled by the insurance company. The contact stated that the rear toe link had fractured a month prior to the collision and was replaced by an independent mechanic. The dealer and manufacturer were made aware of the failure but offered no assistance. The failure mileage was 91,000.

I was driving my car and received a warning that the Power Steering System Failure. Within a few minutes, the power steering in the car went out. Had to have the vehicle towed to mechanic. The mechanic reported the code of C200D-49. 2 Ford Dealerships stated that they had never heard of any issues yet my mechanic recently had another Ford vehicle in with the same situation.

The electronic door clocks are continuously failing where the door cannot be opened in an emergent situation. On 6/24/20 the front driver door latch had to be replaced and on 03/21/21 the left rear door latch had to be replaced. Presently the right rear door latch is not operating and the vehicle has been scheduled for service on 7/9/21.. When these locks fail you are unable to open the doors unless you can reach the lock to pull up. In an emergency such as a crash or fire this failure can be fatal. It appears that there is a design flaw or defect with these locks. Review of internet blogs reveal this may be a common unreported problem that needs immediate attention. In the event there are emergent circumstances requiring the removal of a child or elderly this may be tragic.

First instance was in mid December 2020. While driving down the highway the power steering suddenly went out, showing errors "Steering Assist Fault, Service Required" , "Hill Start Assist Not Available" , and "Service AdvanceTrac". Pulled over and turned off the car for a few minutes, when restarted it appeared to work fine. Second instance was in mid May 2021. Similar circumstances to the first instance: happened while driving, same errors, started working after restarting the car. After this second instance we took the car to the dealership for servicing. They replaced the Hub Bearings, but said there were no additional errors for the vehicle. The third instance was June 24th 2021. This time the errors showed up upon startup, and did not resolve upon restarting the vehicle. Took the vehicle to the dealer, and they determined that we would need to replace the entire steering gear assembly, at a significant cost.

The contact owns a 2016 Ford Explorer. The contact stated that the vehicle steering wheel failed when reversing out of the garage, the contact was unable to turn the steering wheel. The contact stated that the electrical service light illuminated. The vehicle was taken to an independent mechanic to have a diagnostic performed. The failure code for the steering power assist module was detected. The vehicle was not repaired. The manufacturer was contacted. The failure mileage 70,000.

The trim to the lining of my window on the right side flew off on the highway

The electric power steering went out. On the way to get my 3 month old son from daycare, I was merging onto the highway next to a semi and a warning came on letting me know there was a steering issue. After picking my son up from daycare, I started my vehicle again and it said power steering failure. I could hardly drive the vehicle and did not feel comfortable since my son was with me. I have since taken it to our local Ford dealer and the module must be replaced.

Air bag light came on randomly one day, diagnostics indicated it was an issue with the wiring harness under the rear passenger second-row seating. This area is inaccessible so accidental disconnection is unlikely. I was told that the airbags will not deploy in the event of an accident when the airbag light is on. This certainly was the case for me as the airbag light was on at the time I was in an accident with contact to my driver's side front bumper and the airbag did not deploy. My grievance is that this is a common issue that Ford is aware of and no recall has been put in place to fix it. It is unacceptable for a manufacturer to be aware of a problem and not fix it especially as it is costly to the consumer. Quoted $1,000+ for repair. Most importantly, it is a safety issue.

Driving down Interstate and steering started to get sticky. Steering wheel would grab, be difficult to turn, then release. Suddenly the 'traction control' light on the dashboard flashed and then within 2-3 minutes the 'Loss of Steering' dashboard message flashed and the steering wheel froze. Fortunately we were on a flat/straight stretch of highway or this could have been catastrophic. This could easily result in a fatal crash. We had the vehicle towed to nearest Ford dealership and they diagnosed that the 'Steering gear seized internally' and the vehicle was repaired at a cost exceeding $2000.00. Tow Truck Operator communicated they have never seen a steering column completely freeze like this one did. I have the service invoice on file.

The rack and pinion steering had to be replaced in my 2016 Ford Explorer Limited. I had a difficult time controlling the steering and was fearful with my 4 kids in the car but made it home. I had it replaced and had to take a loan out to cover the $2500 price tag. The car has mainly highway miles on at 109,000. I am hoping to have this reimbursed by Ford because what I am looking up this is a MAJOR problem with many Ford vehicles.

I have a 2016 Ford Explorer Limited. It has 109,000 miles, mostly highway miles on it. The rack and pinion steering needed to be replaced and it was a $2500 bill. It has happened in countless Ford Explorers from my research. This should be a recall bc it not only is a HUGE expense on cars that are not that old but what a scary safety concern. Thankfully I was able to control my car and park it before an accident happened. Please consider issuing a recall so this HUGE expense isn't the burden of a Ford customer when this should not happen to such a new model. Thank you.

The contact's girlfriend owns a 2016 Ford Explorer. The contact stated after placing groceries inside the vehicle, the contact heard a chime as the liftgate independently started closing, almost striking him on the head. The contact also stated while driving at various speeds, the vehicle would stall or surge upon depression of the accelerator pedal, with the service engine warning light illuminated. The contact also mentioned that the side-view mirrors would independently adjust while driving at various speeds. The contact stated that he manually adjusted the mirrors to correct his driving visibility. The manufacturer was notified of the failure. The contact was informed that the VIN was not under recall. The contact was then transferred to NHTSA for assistance. The vehicle was not repaired. The failure mileage was approximately 57,000.

As I was driving in the highway the steer assist fault warning came on and the steering wheel locked. I was not able to turn the wheel without force. I pulled over and turned vehicle off to see if it was a malfunction, but the stabilitrack and steer assist light remained on and steering wheel was still very hard to move.

The contact owns a 2016 Ford Explorer. The contact stated while driving at 10 MPH, various warning lights illuminated as the steering became difficult to maneuver. The vehicle collided with the curb and then stalled. The vehicle was restarted with all warning lights and audio warnings. The contact was able to drive without the power steering to a friend's residence. The vehicle was not taken to the dealer or independent mechanic for diagnosis or repairs. The contact called the dealer who told him that the failure was related to the rack and pinion and a diagnosis appointment was scheduled. The manufacturer was notified and a case was opened. The failure mileage was approximately 80,000.

The contact owns a 2016 Ford Explorer. The contact received a notification for NHTSA Campaign Number: 19V435000 (SUSPENSION) however, the part to do the recall repair was unavailable. The dealer was notified about the recall however, the contact was informed that the part was not yet available. The manufacturer was made aware of the issue and referred the contact to NHTSA. The contact stated that the manufacturer had exceeded a reasonable amount of time for the repair. The contact had not experienced a failure. Parts distribution disconnect.

Our Ford Explorer lost power in the rear gear position. It also had trouble shifting from certain gears to the next. We took it into the shop when we lost full reverse. The transmission transfer case had blew out a piece of the casing. This left a gaping hole in the case, exposing a gear in the transfer case. This also allowed fluid to drain from transmission. The mechanic said this should never happen on a 76,803 mile car, let alone on a part such as the transmission. This was the second one her did in a two week period. This not only put our family out of a car, it posed a huge safety concerning not being able to move the vehicle. I would hate for this to happen to any owner who is not automotive educated. I was luck I was driving and could get us to move.

The recall has been put out and the dealership is claiming that the fix of gluing the roof rack covers back on is not sufficient and that a new fix needs to be made. The fix is not available to me and I cannot use the vehicle for work with an open recall. I understand that recalls happen, but the fix should be available immediately upon publishing them.

The transmission is constantly slipping. While driving up or down any steeper grades, the RPMs are so high we have to adjust speed to get the transmission to shift properly as to not blow the engine. The suv surges and shifts hard while going only 15 to 20 mph on regular pavement. This has all been happening since we purchased the vehicle (in 2018 @ 27,000 miles). We took in right away and they did replace the transfer case. Since then we’ve taken it to two different Ford dealerships in the area and they state there is nothing wrong. We were told ‘sorry it’s not like we can drive it up a hill to see what the issue is and it’s just not bad enough to warrant replacing the transmission at this time’ We’ve had to swerve to the side of the highway to avoid rear end collisions due to poor shifting and reduced speeds. It’s not trustworthy to travel and at our first chance we’re dumping it for a Chevy. Ford knows there’s an issue with their transmissions, but they push you off until you’re outside of your warranty to tell you to replace the transmission. We helped our elderly mom purchase a Ford and her transmission went out with the same issues and she had to purchase another vehicle as well due to being put off outside of her warranty (by three days - WOW Ford!). ‘It’s not bad enough’ - we’ll it’s not going to get better!!

THE VEHICLE WAS PURCHASED IN 2020 AND SO FAR I HAVE HAD TO REPLACE THE A PILLAR TRIM 3 TIMES.ONCE ON THE PASSENGER SIDE AND TWICE ON THE DRIVERS SIDE. COSTING OVER $100 EACH TIME JUST FOR THE PARTS.THE TRIM HAS COME OFF TWICE WHILE AT HIGHWAY SPEED, 60 MPH, CAUSING A LOUD NOISE AND FLYING DEBRIS. THE THIRD TIME THE TRIM CAME OFF AT A SLOW SPEED OFF 35 MPH AND ACTUALLY BROKE IN HALF. I ATTACHED A PHOTO OF THE TRIM PIECE. I BELIEVE THE CAUSE MAY BE THE PLASTIC CLIPS THAT HOLD THE TRIM IN PLACE.

MY HUSBAND WAS DRIVING TO WORK AND LOST DRIVE POWER AND THE UNDERNEATH OF THE SUV WAS ON FIRE, MY HUSBAND PULLED OVER AD CALLED 911. THE DEALER STATED THE PTU CRACKED FROM PRESSURE LEAKING ALL THE OIL ONTO THE EXHAUST. ALSO STATED ALL OF MY TIRES WERE GOOD .. SO WE ARE UNSURE WHERE THE PRESSURE CAME FROM>

VEHICLE DISPLAYS AIR BAG WARNING LIGHT. DEALERSHIP STATED IT IS DUE TO ELECTRICAL CONNECTION UNDER REAR SEAT. COST TO REPAIR $700-1000. WHILE AIR BAG LIGHT IS ON AIR BAGS WILL NOT DEPLOY. A INTERNET SEARCH YIELDED OVER 250 REPORTED CASES OF THIS EXACT ISSUE. DUE TO THE AIR BAGS NOT FUNCTIONING, THE COST OF THE REPAIR, AND THE FREQUENCY OF THIS VERY SPECIFIC BREAK, AND THE QUANTITY OF REPORTS,I QUESTION WHY FORD HAS NOT RECALLED THIS SAFETY ISSUE.

HEARD NOISES WHEN I TURN MY STEERING WHEEL. I WAS TOLD I NEED TO HAVE MY RACK AND PINION STEERING REPLACE-EST COST MID 2K. STARTING TO RESEARCH ONLINE AND I SEE THAT THIS IS A COMMON PROBLEM WITH POTENTIAL SEVERE CONSEQUENCES IF NOT FIXED. WHY HASN'T THIS BEEN RECALLED??? ALSO WE HAD TO REPLACE THE STRUTS. THE CAR DOES NOT HAVE 50K MILES YET. I DO HAVE THE REPAIR FOR THE STRUTS. HAVE NOT REPAIRED THE RACK AND PINION YET.

WHILE DRIVING DOWN THE HIGHWAY AT APPROXIMATELY 75 MPH, THE DRIVER'S WINDSHIELD SIDE TRIM MOLDING DETACHED FROM THE VEHICLE. THIS MOLDING IMPACTED THE SIDE OF THE VEHICLE, AND BECAME FOD ON THE HIGHWAY. IN REVIEW, ONLY HALF OF THE MOLDING DETACHED FROM THE VEHICLE, WITH HALF REMAINING IN PLACE.

RADIO SPARKING AND SMOKING PLUS PEELING AND BUBBLES INSIDE THE HOOD PAINT

AIR BAG LIGHT ON DASH. CAUSED BY DTC B141B. FOUND TSB RELATED TO CONNECTORS UNDER REAR SEAT MP 130. CAR WAS STATIONARY.

THE 2ND ROW AIRBAG LIGHT CAME ON, AND FORD TOLD ME IT WAS A SHORTAGE IN THE WIRES AND IT WASN'T COVERED UNDER THE MANUFACTURERS WARRANTY. THEY STATED THAT SINCE THE AIRBAG LIGHT WAS ON, THE SHORT IN THE WIRING WOULD STOP THE AIRBAG FROM DEPLOYING, WHICH IN TURN IS A SAFETY ISSUE.

ON MULTIPLE OCCASIONS TRANSMISSION WAS SLIPPING WHICH LED TO AN EVENTUAL COMPLETE FAILURE. EXPLORER WAS ON CA HIGHWAY 76 GOING WESTBOUND WHEN TRANSMISSION FAILED. DRIVER WA FORCED TO DODGE TRAFFIC AND COAST TO AN EMERGENCY STOP AT THE RIGHT SIDE OF THE HIGHWAY. EXPLORER HAD TO BE TOWED.

MY AIRBAG LIGHT CAME ON AND THE FORD DEALER WARNED ME THAT THE AIRBAGS WOULD NOT DEPLOY UNTIL I GOT THE ISSUE FIXED. THIS IS A KNOWN ISSUE BY FORD, AS THEY HAVE ISSUED TSB IT. MY EXPLORER SPORT IS 4 MONTHS OVER THE 5 YEAR/60,000 MILE POWER TRAIN WARRANTY, SO I CONTACTED ASSURANT SOLUTIONS BECAUSE I BOUGHT A 72 MONTH/75,000 MILE EXTENDED WARRANTY THROUGH USAA ON 1/6/2016. THIS WAS MY FIRST CLAIM AND THEY DENIED THE CLAIM BECAUSE THEY SAID THAT 'SAFETY RESTRAINT SYSTEMS' WAS AN 'EXCLUDED ITEM'! WHAT'S INFURIATING IS THAT THEY COVER ELECTRICAL ASSEMBLY, INTERIOR ELECTRONICS AND POWER TRAIN ELECTRONICS, BUT NOT 'SAFETY' ELECTRICAL COMPONENTS!! I RAISED CANE WITH THE GENERAL MANAGER OF THE FORD DEALERSHIP AND THEY WENT BACK TO FORD FOR A 'GOODWILL' WARRANTY COVERAGE AND THEY AGREED TO PAY FOR ALL BUT $261 OF THE REPAIR. WHILE I SINCERELY APPRECIATE THE GOODWILL OFFER, FORD LOST ANY FUTURE BUSINESS FROM ME FOR NOT PROACTIVELY OFFERING THE GOODWILL COVERAGE FROM THE START BEFORE I HAD TO PURSUE OTHER OPTIONS. SHAME ON FORD!! IT DOESN'T RISE TO THE LEVEL OF A FULL RECALL, BUT IT IS A KNOWN DEFECT WITH A CRITICAL SAFETY FEATURE, SO THEY SHOULD HAVE COVERED IT FROM THE START WHEN PRESENTED WITH THE AIR BAG LIGHT COMING ON! *TR

DRIVING ON HIGHWAY, WINDSHIELD TRIM ON DRIVERS SIDE BROKE OFF. ONCE STATIONARY, INSPECTED WHERE THE TRIM WAS AND IT'S COMPLETELY GONE & APPEARS THAT THE CLIPS HOLDING IT THERE ARE BROKEN AND SOME GONE. PASSENGERS SIDE TRIM IS WARPED AND APPEARS LOOSE. ALSO, DRIVERS DOORS TRIM IS NOW PARTLY DETACHED FROM DOOR

I TOUCHED THE STEERING WHEEL BOTTOMS FOR AND WHEN I TRUN THE STEERING WHEEL I HERE A POPING SOUND. I'M SACAR IT MAY LOCK AND THEN CRASH. WHILE IN MENTION. CITY AND HIGHWAYS.

MY EXPLORER STARTED HAVING POPPING NOISES WHEN TURNING LEFT OR RIGHT. IT IS BAD ENOUGH TO GIVE SIGNIFICANT FEEDBACK IN THE STEERING WHEEL AND VIBRATIONS THROUGHOUT THE FRONT PASSENGER AREA. WHEN I JACK UP THE FRONT END UNLOADING THE WHEELS, THERE IS NO NOISE OR POPPING. WITH FULL WEIGHT ON THE WHEELS, WHEN THE WHEEL IS TURNED SLIGHTLY LEFT AND RIGHT AND GET SIGNIFICANT POPPING AND CRACKING FEEDBACK VIA THE TIE RODS, THE NOISE HAS PROGRESSED INTO THE STEERING WHEEL FREEZING IN PLACE WHILE DRIVING THE VEHICLE. NOT BEING ABLE TO CONTROL THE CAR IS A MAJOR LIFE SAFETY ISSUE IF NOT ADDRESSED THIS HAS THE POTENTIAL TO CAUSE MAJOR INJURIES OR DEATH. IF IT HAS NOT ALREADY. THE DEALER IS AWARE OF THE ISSUES AND I FIND COUNTLESS ONLINE INSTANCES OF THIS MECHANICAL DEFECT.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT AT START-UP, THE DRIVER'S SIDE FRONT SEAT INDEPENDENTLY ADJUSTED, TRAPPING THE CONTACT UP AGAINST THE STEERING WHEEL. THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER WALKER FORD (17556 US HWY 19 N, CLEARWATER, FL 33764, (727) 265-3992) BUT WAS NOT YET DIAGNOSED. THE VEHICLE WAS NOT YET REPAIRED. THE MANUFACTURER WAS INFORMED OF FAILURE. THE CONTACT WAS STILL AWAITING A RESPONSE. THE FAILURE MILEAGE WAS APPROXIMATELY 23,000. THE CONSUMER STATED THE DEALER WAS NOTIFIED AND SUGGESTED THE CONSUMER INADVERTENTLY CHANGED THE SEAT SETTINGS. THE CONSUMER WAS UNABLE TO REPLICATE THE FAILURE AND DENIED CHANGING THE SETTINGS.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE HAVING A ROUTINE OIL CHANGE AT WALDORF FORD (2440 CRAIN HWY, WALDORF, MD 20601, (888) 709-3528) THE TECHNICIAN INFORMED THE CONTACT THAT THE ENGINE BLOCK WAS LEAKING AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. A FEW DAYS LATER A BYSTANDER INFORMED THE CONTACT THAT THERE WAS WATER IN THE PASSENGER'S SIDE REAR BRAKE LAMP AND THAT THE BRAKE LAMP FAILED TO ILLUMINATE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT MENTIONED NHTSA CAMPAIGN NUMBER: 15V605000 (FUEL SYSTEM, GASOLINE) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA TO FILE A COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 85,000.

THE CAR LOOSE THE POWER AND DON'T GO OVER 20 MILES AN HOUR . RPM GOES OVER 5000 CAR SPEED DON'T CHANGE MAKE NOISE YOU CAN'T GO UP THE HAVE THE POWER TO GO ONLY 20 MILES TO 23 MILES AN HOUR

I WAS STATIONARY IN A PARKING LOT AND STARTED THE VEHICLE TO FIND MESSAGES STEERING ASSIST FAULT SERVICE REQUIRED, HILL START ASSIST NOT AVAILABLE, SERVICE ADVANCE TRAC, AND TERRAIN MANAGEMENT SYSTEM FAULT ALL DISPLAYED ON THE INSTRUMENT CLUSTER. THERE WAS NO POWER STEERING ASSISTANCE AND THE STEERING WHEEL WAS INCREDIBLY HARD TO TURN. IN THE DAYS LEADING UP TO THE FAILURE I NOTICED ON A FEW OCCASIONS THE STEERING WHEEL WOULD NOT CENTER AFTER EXITING A 90 DEGREE TURN AND I WOULD HAVE TO PROVIDE INPUT TO STRAIGHTEN THE WHEELS. THE ELECTRIC POWER STEERING RACK HAS FAILED AND THERE ARE NOT EVEN ANY PARTS AVAILABLE FOR THIS, NOR DOES IT APPEAR FORD HAS ACKNOWLEDGE THEY HAVE A WIDESPREAD PROBLEM..

WENT TO THE BEACH THIS PAST SATURDAY AND AS I WAS PULLING INTO THE TURNING LANE FOR THE STATE PARK AND ALARM WENT OFF SAYING DRIVE ASSIST CONTROL FAILURE, AND NUMEROUS THINGS THAT NO LONGER WORK, SINCE THEN THERE HAS BEEN NO POWER STEERING AND IT WAS A MIRACLE WE GOT IT HOME WHICH WAS AN HOUR AND A HALF AWAY, HAD THIS HAPPENED WHILE GOING FASTER THEN I COULD OF LOST CONTROL OF THE VEHICLE, AND I WAS GOING ABOUT 10 MPH WHEN IT ALARMED. THE PICTURES SHOW WAS ALERTS EVERY TIME THE VEHICLE IS STARTED NOW. THIS MORNING THE STEERING WHEEL WAS NEAR IMPOSSIBLE TO MOVE SO MY GIRLFRIEND WHO DRIVES THE EXPLORER HAS TO USE THE BACK UP CAR THAT CAN'T HOLD ALL OF OUR KIDS.

I RECEIVED THE RECALL NOTICE IN OCTOBER 2020 MANUFACTURER RECALL NUMBER20S62 NHTSA RECALL NUMBER20V675. WHEN ATTEMPTING THE SCHEDULE WITH KOONS FORD ANNAPOLIS, I HAVE BEEN TOLD THE PARTS ARE STILL ON BACK ORDER. THIS IS NOW MONTH 5 AND THE RECALL HAS NOT BEEN CORRECTED.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING THERE WAS A STRONG ODOR COMING INTO THE CABIN OF THE VEHICLE CAUSING THE CONTACT AND HER HUSBAND TO BECOME LIGHTHEADED. WHEN THE CONTACT RETURNED TO HER RESIDENCE SHE CHECKED UNDER THE HOOD AND SMELLED AN ABNORMALLY STRONG ODOR COMING FROM UNDERNEATH THE ENGINE. THE CONTACT STATED THE ODOR SMELLED LIKE SULFUR AND ROTTEN EGGS. THE CONTACT TOOK THE VEHICLE TO THE LOCAL DEALER BALISE FORD (1979 BOSTON RD, WILBRAHAM, MA 01095) TO HAVE THE VEHICLE DIAGNOSED HOWEVER, THE DEALER WAS UNABLE TO FIND THE CAUSE OF THE ODOR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 63,000.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE PASSENGER MIDDLE ROW SEAT BELT FAILED TO LATCH CORRECTLY. THE CONTACT SPOKE WITH BREDEMANN FORD (2038 WAUKEGAN RD, GLENVIEW, IL 60025, (847) 510-5585) WHO STATED THAT THE SEAT BUCKLE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE AND FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT UNDER RECALL AND THERE WAS NO WARRANTY ON THE VEHICLE. THE APPROXIMATE FAILURE MILEAGE WAS 33,778.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING 5 MPH, THE VEHICLE MADE AN ABNORMAL NOISE PRIOR TO THE STEERING WHEEL LOCKING UP. THE VEHICLE WAS TURNED OFF AND RESTARTED AND THE STEERING WHEEL UNLOCKED. THE CONTACT STATED A TIRE SENSOR WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO BANNER FORD OF MONROE (6300 FRONTAGE RD, MONROE, LA 71202) WHERE IT WAS DIAGNOSED WITH THE RACK AND PINION NEEDING TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE REPLACEMENT PART WAS DEFECTIVE. THE MANUFACTURER HAD NOT BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 101,509.

AS MY WIFE WAS DRIVING SHE HEARD A POP NOISE, THEN SHE WENT TURN AND THE STEERING LOCKED UP WHICH FORCED HER TO STAY IN HEAD ON TRAFFIC. AFTER FORCING THE WHEEL BACK AND FORTH SHE WAS ABLE TO GET STEERING BACK AND TOOK THE SUV TO A LOCAL SHOP. IT WAS THEN DETERMINED THAT THE STEERING GEAR WAS BAD. THIS HAPPENED WHEN OUR VEHICLE ONLY HAD ROUGHLY 60,000 MILES. THANKFULLY NO ONE HIT HER HEAD ON. THE STEERING GEAR WAS REPLACED.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE WATER PUMP LEAKED FLUID WITHOUT WARNING. THE CONTACT TOOK THE VEHICLE TO STEVENS FORD OF MILFORD (717 BRIDGEPORT AVE, MILFORD, CT 06460) WHERE SHE WAS INFORMED THAT THE VEHICLE NEEDED A NEW WATER PUMP. THE CONTACT DECLINED THE REPAIR. THE CONTACT THEN TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE SHE HAD THE VEHICLE REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 78,000.

THIS VEHICLE ALMOST TOOK MY LIFE THE OTHER DAY. ALMOST JUST AS SCARY IS THE FACT THAT THIS ISSUE IS WIDELY REPORTED ON THESE VEHICLES FROM 2011 ON AND FORD HAS ZERO RECALL FOR IT. I WAS ON THE FREEWAY THE OTHER DAY GOING ABOUT 70MPH WHEN INSIDE OF 10 SECONDS (WHILE ON A BEND IN THE ROAD) MY DASH LIT UP AND MY STEERING LOCKED!!! AT 70 MPH!!! I ALMOST HIT 3 CARS WHILE TRYING TO SLOW DOWN AS I COULD ONLY GO STRAIGHT. WHEN I SAY LOCKED, I MEAN AS IF IT WAS CEMENTED IN PLACE. THE DASH READS 'STEERING LOSS STOP SAFELY', 'SERVICE ADVANCETRAC', 'HILL START ASSIST NOT AVAILABLE'. THIS COULD HAVE LIKED NOT ONLY ME BUT OTHER MOTORISTS THIS DAY. ON TOP OF THE INCREDIBLE CONCERN OF SAFETY, THE 'HEAD IN THE SAND' MENTALITY THAT FORD HAS ON THIS ISSUE IS DISGUSTING, AS THEY'RE ALSO LEAVING OWNERS WITH $5000-$10000 REPAIR BILLS DUE TO THIS ISSUE. THIS WAS THE LAST STRAW WITH FORD, AFTER 20 YEARS, I'M DONE.

VEHICLE STARTED TO MISFIRE AS I WAS DRIVING. IT WOULD GET WORSE EVERY TIME I WAS IDLE AT STOP LIGHTS. HAD TO PULL OVER TO ASSESS THE SITUATION AND I SHORTLY SCHEDULED A SERVICE APPOINTMENT WITH A FORD DEALERSHIP. FORD TECHS SAID IT WAS THE SPARK PLUGS AND COILS. HAD ALL 6 SPARK PLUGS & COILS REPLACED BUT THE ISSUE CONTINUED. STILL NO RESOLUTION AS OF TODAY. VEHICLE ONLY HAS 47K MILES.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT UPON MAKING A SHARP TURN FROM LEFT TO RIGHT AT A LOW RATE OF SPEED, AN ABNORMAL CLANKING SOUND WOULD EMIT FROM THE UNDERCARRIAGE OF THE VEHICLE. THE CONTACT HAD TAKEN THE VEHICLE TO BALISE FORD OF CAPE COD (90 HIGH SCHOOL RD EXT, HYANNIS, MA 02601) WHERE THEY INFORMED HIM THAT THE VEHICLE HAD A BLOWN SHOCK. THE SECOND TIME, THE CONTACT WAS INFORMED THAT HE NEEDED A FULL STEERING RACK REPLACEMENT. THE MANUFACTURER HAD YET TO BE NOTIFIED OF THE FAILURE. THE VEHICLE HAD YET TO BE REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 61,000. THE VIN WAS UNAVAILABLE.

THE HOOD OF THE VEHICLE IS RUSTING ALONG THE FRONT EDGE. IT STARTED WITH A SMALL AREA AT FIRST A YEAR AGO BY BUBBLING UP FROM UNDERNEATH. NOW THERE ARE SEVERAL VISIBLE AREAS ALONG THE FRONT EDGE OF THE HOOD DOING THE SAME. IT'S A MATTER OF TIME TIL THE RUST BREAKS THRU THE PAINT. 5 YEARS OLD AND I LIVE IN MD. MILD WINTERS. SHOULDN'T HAPPEN.

WHILE TRAVELING AT APPROXIMATELY 70 MPH THE PASSENGER SIDE WINDSHIELD PILLAR MOLDING DEPARTED THE VEHICLE. WHILE RESEARCHING PART NUMBERS AND REPAIRS ONLINE I HAVE NOTICED THIS APPEARS TO BE A COMMON PROBLEM FOR EXPLORERS FROM 2011- 2018. ALSO SEEMS SOMEWHAT RELATED TO THE CURRENT RECALL FOR EXPLORER ROOF RACKS THAT USE SOME OF THE SAME MOUNTING HARDWARE. PARTS SEPARATING FROM VEHICLES AT HIGHWAY SPEEDS CREATES HIGH RISK OF INCIDENTS.

I'M EXPERIENCING LIMP MODE. WHILE DRIVING AT ANY SPEED THE TRUCK LOSES POWER AND CUTS BACK ALMOST LIKE I PUT IT IN PARK WHILE DRIVING. THE WRENCH AND ENGINE LIGHTS ARE ON.

94000 MILES THE TRANSFER CASE BURST AND WHEN 70000 MILES CHARGING CYCLE DOES NOT WORK , THE VEHICLE SUDDENLY STOPS.

EXHAUST FUMES IN THE CABIN. STATED SLOWLY AND PROGRESSIVE GOT WORSE. HEAVY FUMES AND NOT SAFELY DRIVABLE, FORD REPAIR SAID IT WAS THE PTU UNIT LEAKING ALLOWING EXHAUST FUMES IN THE CABIN THROUGH THE AIR FLOW SYSTEM. FORD SAID THE PTU WOULD HAVE TO BE REPLACED- $2,400. THE VEHICLE ONLY HAS 58,740 MILES. DEFINITELY A SAFETY AND HEALTH HAZARD. THIS HAPPENS WHEN VEHICLE IS RUNNING AND AFTER RUNNING AND PARKED IN GARAGE FILLS GARAGE WITH NOXIOUS ODOR OF EXHAUST SMELL.

WIFE WAS SHOPPING IN ANOTHER CITY AND STEERING LOCKED UP WHEN SHE STARTED IT AFTER BEING PARKED IN A LOT ,WARNING SIGNALS CAME ON . TURNED EXPLORER OFF AND RESTARTED CAR AND DROVE FINE AND DROVE HOME 50 MILES . WENT TO HOCKEY GAME AT AN ARENA , CAME OUT AND STARTED CAR AND STEERING WAS HARD TO STEER ( NO POWER STEERING ) BUT MANAGED TO DRIVE HOME 2 MILES AND PUT IN GARAGE . LOOKED FOR POWER STEERING RESEVOUR AND THERE WAS NONE UNDER HOOD THINKING LOW ON FLUID . LOOKED IN OWNERS MANUAL AND SAW -- ALL ELECTRONIC ! DROVE IT TO DEALERSHIP NEXT DAY ( WEEKEND ) AND PARKED IT EVEN THOUGH IT WAS HARD TO STEER . GOOGLED THIS PROBLEM AND SAW ALL THE SAME PROBLEMS THAT OTHERS HAD WITH THIS STEERING GEAR ! WENT TO DEALER MONDAY MORNING AND THEY CHECKED IT OUT AND CALLED ME TO TELL ME IT WAS THE STEERING RACK THAT NEEDED TO BE REPLACED AT A COST OF APPROXIMATELY $ 2500 AND PART HAD TO COME OUT OF DETROIT AND WOULD TAKE A FEW DAYS TO GET HERE AND THEN REPAIR IT . CALLED ME YESTERDAY AND CAR WAS DONE ( $ 2395.91 ) WHY NO RECALLS ???

TL* THE CONTACT OWNS 2016 FORD EXPLORER. THE CONTACT STATED UPON ENTERING THE VEHICLE, THE FRONT DRIVER'S SIDE SEAT BELT FAILED TO LATCH SECURELY. THE CONTACT CALLED TOWN AND COUNTRY FORD (7800 E LLOYD EXPY, EVANSVILLE, IN 47715) HOWEVER, THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. THE CONTACT WAS INFORMED THAT THE VIN WAS NOT UNDER RECALL. THE MANUFACTURE WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILLAGE WAS 45,000.

FORD DESIGNED THE HEADLIGHTS IN THE 2016 FORD EXPLORER SO THAT THE LED LOW BEAM IS BUILT INTO THE HOUSING. SO YOU EITHER HAVE TO REPLACE THE VERY EXPENSIVE HOUSING (1,000) WHEN YOUR LOW BEAM GOES OUT OR DRIVE WITH LESS VISIBILITY. MOST PEOPLE DO NOT HAVE $1,000 JUST LAYING AROUND.

YOU CAN SMELL EXHAUST IN THE CABIN. IT SEEMS TO BE WORSE THE HIGHER THE HEATER IS TURNED UP. IT IS IRRITATING TO THE EYES. FORD DENIES THIS BEING A PROBLEM BASED ON OUR VIN.

I LOST MY STEERING COMPLETELY AND HAD TO TAKE MY VEHICLE INTO A SHOP. THE RACK AND PINION FOR THE STEERING OF MY VEHICLE HAS GONE OUT COMPLETELY AT ONLY 80,000 MILES. THIS IS AN EXTREMELY DANGEROUS ISSUE, AS IT COULD HAVE CAUSED A SERIOUS CRASH. WHILE STATIONARY OR MOVING SLOWLY, THE WHEEL IS HARDER TO TURN AND MAKES A LOUD SLIDING/GRINDING SOUND. AT HIGHER SPEEDS, THE STEERING WHEEL GETS "STUCK" AND IS VERY HARD TO GET OUT OF A CERTAIN POSITION. THIS ISSUE CAUSED ME TO ALMOST HIT ONCOMING TRAFFIC. AS COMMON AS THIS ISSUE IS AT AN AVERAGE OF 52,000 MILES ON THESE EXPLORERS, IT SHOULD BE A RECALL! THE REPAIR IS AT AN ESTIMATED $3,000 TO FIX. NOW I AM OUT OF A VEHICLE UNTIL I CAN COME UP WITH THAT KIND OF FUNDING, WHILE STILL OWING TONS OF MONEY ON IT. NOT ONLY IS THIS A HUGE FINANCIAL NIGHTMARE, BUT IT IS EXTREMELY UNSAFE!

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE AIR BAGS WARNING LIGHT REMAINED ILLUMINATED ON THE INSTRUMENTAL PANEL. THE CONTACT TOOK THE VEHICLE TO KOONS FORD OF ANNAPOLIS (2540 RIVA ROAD, ANNAPOLIS, MD 21401, (410-224-2100) TO HAVE A DIAGNOSTIC TEST PERFORMED. THE CONTACT WAS INFORMED THAT THE AIR BAGS ELECTRICAL CONNECTOR LOCATED UNDERNEATH THE DRIVER'S FRONT SEAT WAS CORRODED AND NEEDED TO BE REPLACED. THE DEALER INFORMED THE CONTACT OF MANUFACTURER COMMUNICATIONS NUMBER: 16-0001 AND PROVIDED AN ESTIMATE FOR THE COST OF THE REPAIR. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 93,000.

I WAS DRIVING ON THE HIGHWAY AND WHEN I BEGAN TO TURN OFF THE EXIT I BEGAN HEARING A LOUD GRINDING SOUND COMING FROM MY STEERING COLUMN. IT WAS ALSO EXTREMELY DIFFICULT TO TURN THE WHEEL. IAM GRATEFUL THAT MY YOUNG CHILDREN WERE NOT WITH ME AT THE TIME BECAUSE THE GRINDING WAS SUPER LOUND AND I WAS ABOSULTELY TERRIFIED THAT I WAS GOING TO CRASH. I IMMEDIATELY TOOK THE TRUCK TO MY LOCAL MECHANIC WHERE HE SAID THAT I SHOULD NOT BE DRIVING THR TRUCK AT ALL BECAUSE I COULD DEFINITELY CRASH AN KILL MYSELF OR ANY OTHERS AROUND ME. ALSO THAT IT IS GOING TO COST $2500.00 TO FIX THE PROBLEM. I JUST PURCHASE THIS TRUCK FROM AUTOFAIR FORD IN JULY 2020 FOR 20K AND 6 MONTHS LATER AM FORCED TO DUMP 2.5K INTO IT WHEN MONEY IS TIGHT AND MY FAMILY IS STRUGGLING AS IT IS...I AM EXTREMELY UPSET THAT THIS HAPPENED AND TO LEARN THAT THIS HAS HAPPENED TO THOUSANDS OF PEOPLE, YET THERE IS NO RECALL FOR THIS ISSUE. AOMETHING SHOULD BE DONT TO HELP ME AND MY FAMILY BY FORD MOTOR COMPANY THIS IS NOT ACCEPTABLE TO BE GOING BROKE BECAUSE OF THIS ISSUE AND THE CAR IS JUST 5 YEARS OLD.

PAINT BUBBLING AND PEELING AROUND FRONT EDGE OF HOOD SHOWING RUST UNDERNEATH. VEHICLE IS GARAGE KEPT AND CLEANED REGULARLY.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING, THE REAR GLASS EXPLODED WITHOUT AN IMPACT. NEITHER THE DEALER NOR THE MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 90,000.

2016 FORD EXPLORER SMELLS LIKE CARBON MONOXIDE INSIDE OF THE VEHICLE WHEN DRIVING ,UNABLE TO DRIVE DUE TO BEING OVERCOME WITH CARBON MONOXIDE.

MY DRIVER SIDE AIRBAG LIGHT IS ON MY DASH I HAVE PLUGGED IN AND UNPLUGGED ALL OF THE SEATBELTS RESET THE AIRBAG LIGHT AND IT STAYS OFF FOR A WHILE. THIS IS DEFINITELY A SAFETY ISSUE I UNDERSTAND IT IS EITHER A SENSOR OR THEY ARE HAVING PROBLEMS WITH THE WIRING HARNESS THIS SHOULD BE ADDRESSED IN A RECALL. THE FRONT PASSENGER SIDE SEAT WARMER/COOLER DOES NOT WORK, NOT SURE IF THAT ISSUE IS PART OF THE AIRBAG LIGHT PROBLEM.

WE ARE DRIVING BACK FROM ZION NATIONAL PARK THEN IN THE FREEWAY SUDDENLY I LOST POWER LUCKILY IT WAS ON A DOWN HILL. I WENT ON THE SIDE OF THE ROAD THEN THEN COUPLE I STARTED RIGHT BACK. NOW AM AFRAID DRIVING IT FAR AWAY. FROM TIME TO TIME WHEN UPHILL IT JERK A BIT AND IT FEELS LIKE LOOSING POWER.

TOOK A QUICK LOOK UP TOP AND MY SUNROOF WAS CLOSED CORRECTLY. I OPENED THE SUNROOF AND POURED SOME WATER INTO THE CHANNEL AND WATER SEEMS TO DRAIN DOWN THE HOLES CORRECTLY. I ALSO CLOSED THE ROOF ALL THE WAY AND SPRAYED IT WITH A GARDEN HOSE, AND DIDNT SEE ANY LEAKING. I CANT SEE WHERE AND WHY WATER WOULD BE LEAKING OUT OF THE OVERHEAD CONSOLE. DID A QUICK SEARCH ON YOUTUBE AND FOUND SOMEONE ELSE HAD THIS PROBLEM, BUT COULDNT FIND A SOLUTION

DURING ACCELERATION CAR SMELLS LIKE ROTTEN EGGS ALL WINDOWS NEED TO BE OPEN TO VENT CAR AND ALL PASSENGERS GET NAUSEOUS. DEALER TRIED TWICE TO FIX PROBLEM BUT WITH NO SUCCESS.ITS GETTING IMPOSSIBLE TO DRIVE THE CAR ON HIGHWAY.FORD NEEDS TO DO SOMETHING ASAP.

I PURCHASED A 2016 EXPLORER LIMITED FROM A FORD DEALER AND NOTICED IT WAS LOW ON COOLANT, WAS TOLD IT WOULD BE FILLED AND OF COURSE IT WASN'T, I FILLED IT MYSELF. A WEEK LATER IT WAS LOW AGAIN, TOOK IT TO A CHEVY DEALER AND WAS TOLD THE WATER PUMP IS LEAKING. I CONTACTED THE SELLING DEALER AND LEFT A VOICEMAIL AND NO ONE RETURNED MY CALL. I CALLED BACK A COUPLE WEEKS LATER AND WAS TOLD IT ISN'T COVERED UNDER THEIR 30 DAY/1000 MILE WARRANTY. I CONTACTED FORD AND WAS TOLD NO ASSISTANCE BECAUSE I'M NOT THE ORIGINAL OWNER, SHOULD THAT MATTER WITH 69500 MILES??? I WAS TOLD TO CALL A LOCAL DEALER MAYBE THEY CAN HELP ME. THE WATER PUMP ON THIS VEHICLE IS MOUNTED INTERNALLY AND DRIVEN BY THE TIMING CHAIN AND COST ABOUT 1500.00 TO REPLACE. SO FAR AFTER A USED PURCHASE I'LL HAVE $25,000 INTO A VEHICLE THEY MAY TURN INTO A BRICK. I HAVE BOUGHT AND LEASED SEVERAL NEW FORD VEHICLES AND THIS IS HOW THEY TREAT CUSTOMERS, INCLUDING HAVING RETIRED FAMILY MEMBERS.

BROKEN CLOCK SPRING CAUSING DISABLING OF AIRBAG PROTECTION. COST TO REPAIR $541.10

DRIVING 45MPH SUDDENLY LOST STEERING CONTROL, WAS ABLE TO DECELERATE AND GET OFF THE ROAD, THEN SLOWLY GET HOME. AFTER THIS IT SEEMED TO WORK FINE. HOWEVER, EVERY DAY, A LOUD POPPING CREAKING SOUND THAT YOU CAN EVEN FEEL IS COMING FROM THE ELECTRIC POWER-ASSIST STEERING. ESPECIALLY NOTICEABLE WHEN PULLING IN OR OUT OF A PARKING LOT/DRIVEWAY/GARAGE. LOCAL SHOP SAYS IT WILL COST ABOUT $2500 TO REPLACE THE ELECTRIC POWER-ASSIST STEERING RACK AND PINION, AND IT MUST THEN BE PROGRAMMED TO THE VEHICLE. THIS EXPLORER HAS 78,000 MILES ON IT. THANKS.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING THE CONTACT TURNED ON THE HEAT IN THE VEHICLE AND SMELT AN DISTINCT ODOR COMING FROM THE VEHICLE. THE ODOR WAS STRONG THE CONTACT HAD TO ROLL DOWN THE WINDOW IN THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THE FAILURE AS A CARBON MONOXIDE LEAKAGE. THE VEHICLE WAS REPAIRED BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 66,000.

AIRBAG LIGHT HAS BEEN COMING ON INTERMITTENTLY FOR OVER 1 YEAR. DIAGNOSTIC TEST DETERMINED THERE IS A FAULTY CONNECTION TO THE 2ND ROW INFLATABLE SEATBELT SENSOR. FORD ISSUED A SERVICE BULLETIN TO REPLACE THE WIRE HARNESS PIG TAIL CONNECTION. WHEN THE AIR BAG LIGHT IS ILLUMINATED DUE TO THIS FAULTY CONNECTION, ALL OF THE AIR BAGS IN THE VEHICLE ARE DEACTIVATED. THIS IS EXTREMELY DANGEROUS, AND MY FAMILY HAS BEEN DRIVING THE CAR IN THIS CONDITION FOR OVER A YEAR. UPON FURTHER RESEARCH, NUMEROUS CASES EXIST REPORTING THE SAME ISSUE. PLEASE ADDRESS THIS SAFETY ISSUE.

DRIVING DOWN THE ROAD AND THE AIR BAG LIGHT COMES ON AND NOW IT WONT GO OFF. IT STAYS ON 24/7. THIS IS AN ISSUE IN MANY 2016 FORD EXPLORERS AND IT HAS YET TO BE RECALLED. THIS IS A SAFETY ISSUE.

I TOOK MY 2016 FORD EXPLORER XLT ON DEC 29TH 2020 TO GET A OIL CHANGE ETC. THEY HAD THE VEHICLE ALL DAY EVEN THOUGH I TOOK IT IN AT 7AM. I PICK IT UP A 4:45 PM THEN DRIVE IT HOME BECAUSE I WORK FROM HOME I DID NOT DRIVE IT AGAIN UNTIL SATURDAY JAN 9TH 2021, WHILE DRIVING IT THAT MORNING I REALIZED THAT THE STEERING WHEEL WAS HARD TO STEER AND THE TRUCK WOULD MAKE NOISES WHEN I TURN THE STEERING IN EITHER DIRECTION. I TOOK IT IN TO THE DEALERSHIP THAT MORNING AND ASKED THE SERVICE CONSULTANT TO TAKE A LOOK AT IT. HE TOLD ME WHILE MY FATHER WAS ON THE PHONE THAT HE BELIEVES IT THE RACK AND PINION AND HE CAN'T TAKE IT BECAUSE THEY ARE BUSY AND IT'S OKAY FOR ME TO DRIVE IT. I ALSO TOLD HIM AT THAT TIME I AM SUPPOSED TO DRIVE OUT OF TOWN AND I WON'T BE BACK FOR AWHILE SO IF THERE IS A PROBLEM I RATHER LEAVE IT SO IT CAN BE FIXED. I HAVE DAMAGED ON MY C5 VERTEBRAE SO I CAN FEEL THE HARDNESS IN THE STEERING. HE ASSURED OR DISMISSED ME BUT HE SAID IT'S FINE. A FEW HOURS LATER THE STEERING WHEEL SEIZED UP AND THE DASHBOARD STARTED MAKING NOISE AND THE WARNING LIGHTS AND MESSAGES STARTED TO DISPLAYING. IT ALMOST KILLED BOTH MY MOTHER AND I ON THE HIGHWAY. IF YOU KNOW NYC HIGHWAY YOU KNOW THERE IS NO SHOULDERS. WHEN I PULLED OF THE ROAD THE STEERING WHEEL LOCKED UP AND I COULD NOT MOVE IT. I HAD TO PAY FOR THE TRUCK TO BE TOWED AND A UBER FOR MYSELF BACK TO THE DEALERSHIP AND THEN PAID FOR ME TO GET HOME. NOW THEY ARE TELLING ME THAT I HAVE TO PAY $2719.81 FOR THE RACK AND PINION REPAIR AND THE ALSO PAY FOR THE STRUT BEARING TO BE REPAIRED WHICH THEY HAVEN'T GIVEN ME THE PRICE FOR IT BECAUSE "IT WAS TOO MUCH TO GIVE ME BOTH PRICE AT ONCE." OH BY THE WAY, THIS IS THE SAME SERVICE CONSULTANT THAT TOLD ME IT WAS FINE FOR ME TO DRIVE AND ALMOST KILLED 2 GENERATION OF MY FAMILY AT THE SAME TIME. I AM PISSED!! NOW I SEE OTHER CUSTOMERS COMPLAINING ABOUT THE SAME ISSUE ON THERE SUV!!

CAR WENT IN FOR RECALL NHTSA #20V675 AND DEALER INSPECTED VEHICLE AND INFORMED US, IT HAS FAILED INSPECTION AND WILL REQUIRE REPLACEMENT. THEY HAVE PARTS QUOTED AT 4-6 WEEKS OUT AND WE ASKED ABOUT A RENTAL VEHICLE AND WERE INFORMED THAT IT WOULD NOT BE COVERED. WE ASKED IF THE VEHICLE WAS SAFE TO DRIVE AND THEY WILL NOT STATE IT IS SAFE TO DRIVE, SO THEREFORE WE CANNOT DRIVE IT. CONTACTED FORD CUSTOMER SERVICE AND WERE INFORMED OUR RENTAL REQUEST WAS DENIED AND THEY WILL NOT SAY THE CAR IS SAFE TO DRIVE. WE CANNOT BE WITHOUT A CAR FOR 6 WEEKS AND CANNOT AFFORD A RENTAL FOR THAT AMOUNT OF TIME. FORD SHOULD COVER RENTAL WHEN PARTS ARE NOT AVAILABLE.

2016 FORD EXPLORER. CONSUMER WRITES IN REGARD TO BRAKE FAILURE WHILE DRIVING. *AS THE CONSUMER STATED AS A RESULT OF THE CONTINUOUS FAILURE, THE VEHICLE WAS TRADED IN. *JS

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V675000 (SUSPENSION) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CONTACTED BEAU TOWNSEND FORD (1020 W. NATIONAL RD, VANDALIA, OH 45377, (937) 898-5841) TO SCHEDULE AN APPOINTMENT AND THE DEALER CONTACTED THE CONTACT BACK TO INFORMED HIM THAT THERE WERE NO PARTS AVAILABLE FOR THE RECALL REPAIR. THE CONTACT CONTACTED THE MANUFACTURER BUT THERE WAS NO RESPONSE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

TL* THE CONTACT OWNED A 2016 FORD EXPLORER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V435000 (SUSPENSION). THE VEHICLE TAKEN LOCAL DEALER KEVIN'S ROYAL FORD OF COOPERSTOWN (5069 NY-28, COOPERSTOWN, NY 13326:(607) 547-9924) AND HAD THE RECALL COMPLETED. THE CONTACT STATED WHILE DRIVING 45 MPH, WHEN THE VEHICLE'S TOE LINK DETACHED AND CRASHED INTO A GUARD RAIL AND DROVE INTO A DITCH. ALL 5 AIR BAGS DEPLOYED. THE CONTACT DID NOT SUSTAINED ANY INJURIES OR SEEK ANY MEDICATION ATTENTION. A POLICE REPORT WAS FILED. THE VEHICLE WAS NOT DRIVABLE. THE INSURANCE COMPANY DEEMED THE VEHICLE A LOSS. THE VEHICLE WAS TOWED TO A JUNKYARD. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V675000(SUSPENSION) ON NOVEMBER OF 2020 AFTER THE ACCIDENT. THE MANUFACTURER HAD BEEN INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 42,300. *JS

WENT TO VISIT FAMILY ON CHRISTMAS MORNING AND WHILE DRIVING POWER ASSIST WENT OUT AND POPPED UP THE DISPLAY WARNINGS. DROVE IT ANOTHER 8 MILES TO DESTINATION. VEHICLE SAT FOR ABOUT 3 HOURS IN THE DRIVEWAY. 30 DEGREE WEATHER. WENT TO LEAVE AND AS I PULLED ONTO THE MAIN ROAD THE STEERING LOCKED AND WARNING MESSAGE LOSS OF STEERING BRAKE SAFELY. I COULD JERK THE WHEEL HARD TO GET IT TO SLIGHTLY MOVE ENOUGH TO GET BACK IN THE DRIVEWAY. JUST HIT 100K MILES. HAD TO HAVE IT TOWED BACK HOME.

MY 2016 FORD EXPLORER XLT TURBO 4WD IS HAVING POWER STEERING PROBLEMS, THE TRUCK ONLY HAS 65,000 MILES AND IT'S HARD TO TURN THE WHEEL AND IT MAKES A GRINDING RUBBING SOUND WHEN TURN THE WHEEL LEFT OR RIGHT. IT MAKES THAT NOISE WHILE DRIVING OR PARKED.

USING A PEDAL COMMANDER PC18 BLUETOOTH "THROTTLE ENHANCER" IN AN EMERGENCY VEHICLE EQUIPPED WITH A VHF MOBILE TWO-WAY RADIO. THE RADIO TRANSMITS AT 50W AND IS INSTALLED BY A PROFESSIONAL EMERGENCY VEHICLE UPFITTER PER MANUFACTURERS INSTRUCTIONS. WHEN TRANSMITTING IN THE 156MHZ RANGE THE PEDAL COMMAND CONSISTENTLY AND UNEXPECTEDLY CAUSES THE VEHICLE TO BEGIN ACCELERATING WHEN IN DRIVE, AND INCREASING THE RPM OF THE ENGINE IN PARK. THE ACCELERATION CONTINUES AS LONG AS THE USER IS TRANSMITTING ON THE TWO-WAY RADIO. AS SOON AS THE TRANSMISSING ENDS THE VEHICLE GOES BACK TO IDLE OR RPMS CONSISTENT WITH THE PEDAL POSITION. THESE SYMPTOMS GO AWAY AS SOON AS THE PC18 IS REMOVED. THIS ISSUE WAS ALSO EXPERIENCED BY OTHER USERS WITH PC18 AND RADIOS THAT TRANSMIT IN THE MID 150MHZ RANGE.

THE STEERING WHEEL AT TIMES WHEN EVEN MAKING A SLIGHT TURN POPS BACK AND SHAKES. RESTRICTING THE TURN THE WIPERS HAVE NOW MULTIPLE TIMES IN RAIN STOPPED IN THE UPRIGHT POSITIONS CAUSING A GRAVE DRIVING HAZARD

I FIRST NOTICED THE PROBLEM LAST WINTER, WHEN WE WOULD DRIVE OUR EXPLORER IN THE SNOW THE CAR WOULD PULL IN RANDOM DIRECTIONS, IT GOT TO THE POINT WHERE I WAS SCARED TO DRIVE THE CAR IN FEET I WOULD BE PULLED INTO ON COMING TRAFFIC. I TOOK IT TO A MECHANIC AND THEY COULDN'T FIND ANYTHING WRONG OTHER THAN MY REAR SHOCKS WERE BAD, SO I REPLACED THEM. THEN OVER THE SUMMER I NOTICED WHEN I TURN GOING AT SLOW SPEEDS THE CAR WOULD MAKE A LOUD POP AND SOMETIMES THE STEERING WOULD GET STUCK WHEN IT POPED, SO I DID SOME RESEARCH A THOUGH MAYBE IT WAS MY TOE LINKS. SO I JUST REPLACED THEM AND THIS CAR IS STILL TERRIFYING TO DRIVE IN THE SNOW. I HAVE SEEN THAT A CONCERNING NUMBER OF PEOPLE HAVE HAD THIS SAME ISSUE AND THEY END UP REPLACING THEIR RACK AND PINION AND IT COSTS THOUSANDS OF DOLLARS.

ELECTRONIC POWER STEERING HAS FAILED WHILE VEHICLE WAS IN MOTION TURNING ON A HIGHWAY. IT WAS IMPOSSIBLE TO TURN THE VEHICLE OFF THE ROADWAY DUE TO LOSS OF POWER STEERING.

POWER STEERING BEGAN TO GO WHEN I WAS DRIVING ON A HIGHWAY, MAKING ME FEEL LIKE I WAS LOSING CONTROL. WAS ABLE TO GET CAR HOME AND ENDED UP COMPLETELY LOCKING UP NEEDING TO BE TOWED FROM MY DRIVEWAY. I NEED TO HAVE STEERING RACK REPLACED FOR OVER $1800 JUST FOR THE PART ON A VEHICLE WITH ONLY 80,000 MILES ON IT.

WHILE OPERATING VEHICLE AT HIGH SPEEDS THE ADVANCETRAC LIGHT, TRACTION CONTROL LIGHT, AND NO STEERING ASSIST LIGHT CAME ON. BEFORE I COULD GET OFF THE INTERSTATE I LOST MOST OF MY STEERING. LUCKILY IT WAS AT NIGHT AND NOT TO MANY ON THE INTERSTATE. IT WAS AN EXTREMELY DANGEROUS SITUATION FOR MYSELF AND MY FAMILY. VERY LUCKY WE DIDN'T GET IN A SERIOUS ACCIDENT. IT WAS WORSE THAN LOOSING POWER STEERING WITH A HYDRAULIC POWER SYSTEM. THERE WAS NO CONTROL AVAILABLE WHILE TRYING TO GET OVER.

I WAS DRIVING TO WORK AND MY CAR MADE A SCREECHY SOUND ONCE I GOT ON THE HIGHWAY AND WENT 45 OR OVER THE STEERING WHEEL STARTED TO SHAKE. IN A WAY IT FELT THE STEERING WHEEL OR THE PART THAT HOLDS THE FRONT TIRES WAS LOOSE. IT FELT LIKE IF I WENT ANY FASTER I'D LOSE CONTROL OF THE CAR.

THERE IS AN SRS AIRBAG WARNING LIGHT ON THE DASHBOARD THAT USED TO INTERMITTENTLY DISPLAY. NOW IT IS ON CONSISTENTLY WHEN THE VEHICLE IS DRIVEN. IT IS DUE TO A CIRCUIT FAILURE OR A BROKEN CORD LEADING TO THE DRIVER SIDE MIDDLE ROW SEATBELT AIRBAG. DIRECTLY FROM SITE: HTTPS://FORD.OEMDTC.COM/1203/AIR-BAG-WARNING-LIGHT-ILLUMINATED-WITH-DTC-B141B-B141C-2014-2016-FORD-EXPLORER TSB 16-0001 AIR BAG WARNING LIGHT ILLUMINATED WITH DIAGNOSTIC TROUBLE CODE (DTC) B141B AND/OR B141C THIS IS NOT NORMAL WEAR AND TEAR BUT A SAFETY ITEM DESIGN BY FORD THAT HAS FAILED IN THE VEHICLE. FORD DEALERSHIP CLAIMS THAT THIS IS NOT WARRANTY FAILURE. BUT SOUNDS LIKE AN ELECTRICAL AND SAFETY ISSUE TO ME...WHICH SHOULD BE COVERED UNDER WARRANTY. THE TRUTH TO THE MATTER IS...FORD DOES NOT CARE THAT A POTENTIALLY HIGH RISK PROBLEM HAS BEEN IDENTIFIED AS A FAILURE ON THE COMPANY'S END BUT THEY DON'T CARE ENOUGH TO DO ANYTHING ABOUT IT. WELL..OTHER THAN CHARGE THE CUSTOMER CLOSE TO $1000 OUT OF POCKET TO FIX FOR A POOR DESIGN ON FORD'S END. THE FORD DEALERSHIP SERVICE DEPARTMENT DOES NOT KNOW HOW THIS SAFETY FEATURE BROKE. IF WE WERE TO GET IN AN ACCIDENT WHILE THE AIRBAG IS IN THIS STATE, IT WOULD NOT DEPLOY AND THE LIVES OF ALL PASSENGERS IN JEOPARDY!

WHENEVER PUTTING THE VEHICLE INTO REVERSE THERE WILL BE A LOUD POP AND WILL SLAM INTO GEAR. SIMILARLY WILL HAPPEN WHEN SHIFTED INTO DRIVE. THEN WHEN CHANGING GEARS FROM SECOND TO THIRD THE VEHICLE WILL HESITATE SWITCHING GEARS AND THE RPM WILL GO INTO THE 5000 RPM. WILL HAPPEN USUALLY WHEN SHIFTING AGAIN INTO A HIGHER GEAR. USUALLY CAN DRIVE AROUND FIVE TO TEN MILES AND WILL SORT ITSELF OUT. HOWEVER IF YOU ARE ENTERING TRAFFIC ESPECIALLY A BUSY ROAD SYSTEM THIS MAY NOT ALLOW YOU TO ACCELERATE TO A SAFE SPEED SINCE THE GEARS NOT SHIFTING WILL CAUSE THE VEHICLE TO STALL AND NOT ACCELERATE.

I STARTED HEARING A GRINDING NOISE WHEN TURNING THE VEHICLE IN EITHER DIRECTION IN REVERSE LAST WEEK. I TOOK A LITTLE TRIP ON DEC. 5 2020, GOING UP TO THE MOUNTAINS. IT GOT WORSE WHILE STEERING MY VEHICLE ON A MOUNTAIN ROAD. I MADE AN APPOINTMENT ON DECEMBER 7 TO THE LOCAL DEALER. MY WIFE WAS DRIVING AT 50 MPH WHEN THE STEERING STARTED TO LOCK UP AND ALMOST CAUSED A COLLISION.THAT'S WHEN WE DECIDED IT IS A SAFETY ISSUE TO DRIVE THIS VEHICLE SO WE TOOK IT TO THE DEALER ASAP AND WAS HANDED A REPAIR COST OF 2620.00 TO REPAIR STEERING GEAR ASSEMBLY . THE VEHICLE HAD ONLY 47,700 MILES ON MY 2016 FORD EXPLORE XLT. IT IS NOW AT THE LOCAL FORD DEALER ON DECEMBER 9, 2020 AWAITING COMPLETION OF REPAIR AS VEHICLE IS NOT DRIVE-ABLE UNTIL REPAIRED. MY WIFE WAS ON THE HIGHWAY DRIVING WHEN SHE ENCOUNTERED ERRATIC BEHAVIOR FROM THE STEERING WHEEL GOING 50MPH. MY PARTS TOTAL FOR REPAIR IS 1,840.44 WITH LABOR TOTAL IS 2,620.00 WITH PARTS.

I RECEIVED A RECALL NOTICE FROM FORD ON THURSDAY. EVERYTIME I CALL TO MAKE A SERVICE APPOINT, I TOLD RECALL COMPUTERS ARE DOWN.

I TOOK MY VEHICLE IN FOR AN AIRBAG LIGHT AND WAS TOLD THAT THE WIRE ASSEMBLY LOCATED UNDER THE REAR SEAT WAS DAMAGED/FAULTY. THIS SEEMS TO BE A VERY COMMON ISSUE (SEE LINKS BELOW) THAT REQUIRED ME TO REPLACE THE WIRING AND WAS NOT COVERED UNDER WARRANTY BUT IS A SAFETY ITEM THAT IS WELL DOCUMENTED BY OTHERS IN ONLINE FORUMS. HTTPS://FORD.OEMDTC.COM/1203/AIR-BAG-WARNING-LIGHT-ILLUMINATED-WITH-DTC-B141B-B141C-2014-2016-FORD-EXPLORER?FBCLID=IWAR1IAMT7GHXQIAJF_Q3ETH7XLFE011S14V7P3JBMQQF1BY4XP1GP55U5F-E HTTPS://WWW.CARPROBLEMZOO.COM/FORD/EXPLORER/AIR-BAG-LIGHT-ON-PROBLEMS.PHP?FBCLID=IWAR32W-NNT2R2ESUV-5JM3H5ULS1FW4OQUHGPXWVRW5DLBBVOTZ4ED5OR69M

THE VEHICLE WITHOUT WARNING , JUST SHUTS OFF. EVEN WHILE GOING 65 MPH ON A HIGHWAY. IF YOUR LUCKY, YOU CAN COAST OFF THE HIGHWAY BEFORE YOU ARE HIT . FORD REFUSED TO FIX EVEN THOUGH UNDER WARRANTY. SO I HAD TO SELL IT SO I WOULDN'T BE KILLED. HUNDREDS IF NOT THOUSANDS HAVE COMPLAINED ABOUT THE SAME THING.

48K MILES PLATINUM EDITION , STEERING WHEEL BEGAN STICKING. RECENTLY STARTED PULLING HARD TO THE RIGHT AT TIMES. HAD IT LOOKED AT AND IT LOOKS LIKE AS WITH MANY MANY OTHERS LIKE IT, THE THE RACK AND PINION NEEDS TO REPLACED. FORD SHOULD BE FORCED TO RECALL THE CARS AND FIX THE PROBLEM. THERE ARE LITERALLY HUNDREDS OF PEOPLE WITH THE SAME PROBLEM. WHEN IS THE NHTSA GOING TO STEP UP AND DO SOMETHING? AFTER PEOPLE START DYING?

UPON STARTING MY CAR FOR THE THIRD TIME THAT DAY MY AIR BAG LIGHT CAME ON AND DOES NOT GO OFF. I ALSO HAVE A PROBLEM WITH IT OCCASIONALLY NOT REGISTERING MY DRIVERS SEATBELT AS BUCKLED OR UNBUCKLED.

S AIR BAG LIGHT IS ON, CHECK AND ADVISE SRS AIRBAG LIGHT IS ON. MANUFACTURER AND DEALERSHIP ARE AWARE OF THE ISSUE AND HAVE A TSB FOR THE ISSUE BUT ARE NOT COVERING UNDER VEHICLE WARRANTY OR RECALL. INSTEAD THEY ARE CHARGING FOR TROUBLE SHOOTING TO LOOK UP THE CODE AND THEN OFFERING TO LOOK INTO REPLACING PARTS TO GET THE SYSTEM WORKING AGAIN UNDER THE ALREADY ISSUED TSB FOR THE FAULTY SAFETY SYSTEM. THIS IS THE DESCRIPTION PROVIDED: VERIFIED CONCERN. RAN EEC TEST, FOUND B141C STORED IN RCM, SECOND ROW INFLATOR CONTROL SEAT BELTS. RAN OASIS, TSB 16-0001 APPLIES HOWEVER NOT COVERED UNDER ACTIVE CONTRACTS CPO POWERTRAIN.

ON SEVERAL OCCASIONS WHEN I GO TO START THE VEHICLE I GET A MESSAGE ON THE LEFT SIDE OF THE DASH CLUSTER THAT SAYS " STEERING ASSIST FAULT FAILURE, SEEK SERVICE." THE VEHICLE WON'T START. AFTER I KEEP PRESSING THE START BUTTON IF WILL START. I CARRIED IT TO THE DEALER ( PARADISE FORD IN COCOA, FL) AND THEY SAID THERE WERE NO CODES IN THE SYSTEM BUT DID SAY THERE WERE A LOT OF PROBLEMS WITH THE STEERING FAILURE ON THAT MODEL AND WOULD COST AROUND $2,500.00 TO REPAIR OUT OF MY POCKET. THE VEHICLE ONLY HAS A LITTLE OVER 5,000 MILES ON IT AS OF 11/29/20.

MY AIRBAGS LIGHT IS ON AND NONE WILL DEPLOY IN THE EVENT OF AN ACCIDENT AND IS NOT COVERED BY ANY WARRANTY. UNACCEPTABLE AND VERY DANGEROUS MANY OWNERS ARE REPORTING THIS ISSUE. HTTPS://WWW-ODI.NHTSA.DOT.GOV/VEHICLECOMPLAINT/

WHEN ACCELERATING AN ODOR LIKE BURNT HAIR OR ELECTRICAL ENTERS THE CABIN. FORD DID PERFORM RECALL WORK BUT THE ODOR STILL ENTERS THE CABIN.

WHEN BACKING OUT OF MY DRIVEWAY AND TURNING SLOWLY THERE IS A POPING NOISE AND MY STEERING WHEEL LOCKED UP MULTIPLE TIMES. BEFORE THIS I SPENT 1000 BUCKS TO GET THE WIRING HARNESS FOR AIR BAGS REPLACED. NONE OF THEM WORK FORD WOULD NOT COVER IT BECAUSE THERE IS NOT A RECALL.

WHEN I GO TO TURN, IT CONTINUES TO POP. THE TIE RODS HAVE BEEN REPLACED ALONG WITH RACK AND PINION BUT YOU COULD BE STOPPED AND APPLYING BRAKE AND TURN WHEEL AND IT POPS.

MY WATER PUMP HAS GONE OUT AND APPARENTLY THIS HAS NOT BEEN THE ONLY ONE.

ON AUGUST 20, 2020, MY VEHICLE HAD LAST BEEN DRIVEN AROUND 12 NOON. IT SAT IN THE DRIVEWAY WITH ALL OF US HOME. MY SON WENT TO GET IN THE VEHICLE AROUND 6:30 PM. SMOKE POURED OUT, THE SEAT WAS SMOLDERING AND FLAMES CAME UP. WE COULDN'T PUT THE FIRE OUT WITH EXTINGUISHER. FIRE DEPARTMENT PUT HOSE ON SEAT. FIREMEN STATED THEY SEE THIS OFTEN WITH HEATED/AIRCONDITIONED SEATS THAT MALFUNCTION AND BURN UP OR CAUSE FIRE. FIREMEN STATED THEY COULD TELL THE WAY IT LOOKED "LIKE ALL THE OTHER HEATED /AIR CONDITIONED SEATS THAT IGNITE THAT THEY SEE OFTEN". INSURANCE COMPANY SAYS CAR IS TOTALED SINCE HOSE WAS PUT ON IT. FORD WILL NOT WORK WITH ME. NO ONE LEFT ANYTHING BURNING IN THE SEAT OR SMOKED IN THE CAR. I BELIEVE THE CAR HEATED/AIR CONDITIONED SEAT MALFUNCTIONED AND FORD SHOULD HELP. I HAD PURCHASED BUMPER TO BUMPER WARRANTY FROM DEALERSHIP. WARRANTY COMPANY SAYS IF A CAR CATCHES FIRE, WARRANTY IS VOIDED, EVEN IF CAR MALFUNCTIONED CAUSING THE FIRE. INSURANCE COMPANY IS TRYING TO PAY AS LEAST AMOUNT AS POSSIBLE. THIS WAS A WELL CARED FOR, VERY NICE CAR. I BELIEVE IT MALFUNCTIONED. FORD MOTOR COMPANY SENT ME A LETTER SAYING THEY HAD THE DEALERSHIP TAKE PICTURES, AND THEY FEEL IT HAD SOMETHING LEFT BURNING ON THE SEAT. NO ONE LEFT ANYTHING BURNING ON THE SEAT. IN THE LETTER FORD MOTOR COMPANY SENT ME BY EMAIL, THEY STATE THEY INSPECTED THE CAR. THEY NEVER CAME TO SEE THE CAR IN PERSON. THEY ONLY HAD THE SERVICE STAFF TAKE PICTURES. THE CAR WAS SITTING IN THE DRIVEWAY ALL AFTERNOON. I ALSO BACKED OUT OF THE DRIVEWAY IN MY SUBARU AT 5:00 PM AND DID NOT SMELL OR SEE SMOKE AS I LEFT.. THE PASSENGER SEAT THAT IGNITED ITSELF HAD A STACK OF BUSINESS PAPERS AND SOME SOCCER GEAR THAT COULD HAVE OVERHEATED IF THE SEAT WAS MALFUNCTIONING TOO. THE SEAT IGNITED BY ITSELF. AS A CONSUMER I DESERVE TO BE ASSISTED. I WOULD LIKE THE CAR REPAIRED OR REPLACED W/SIMILAR CAR.*DT CONSUMER STATED VEHICLE WAS TOTALED AND SETTLEMENT WAS OFFERED BY THE INSURANCE COMPANY. VEHICLE WAS TOWED TO THE DEALERSHIP. *JB

TL* THE CONTACT OWNS A 2016 FORD EXPLORER EQUIPPED WITH HANKOOK TIRES, TIRE LINE: VENTUS S1 NOBLE 2, TIRE SIZE: 255/50/R20, DOT NUMBER: 5MNC 1A H 0716. THE CONTACT BECAME AWARE OF TREAD SEPARATION ON ALL FOUR TIRES. THE CONTACT STATED THAT THE FAILURE WAS MORE SEVERE ON THE TWO FRONT TIRES. THE VEHICLE WAS NOT TAKEN TO HAVE THE TIRES REPLACED. THE CONTACT ALSO STATED THAT THE TIRES FAILED TO MAINTAIN THE PROPER TIRE PRESSURE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 16,132.

RANDOMLY ONE OF THE CAPTAIN CHAIRS SEAT BELTS NO LONGER BUCKLES. IT'S A AIRBAG SEATBELT WITH A DIFFERENT TYPE OF LATCH. WE HAVE NUMEROUS PROBLEMS WITH THESE TYPE OF BUCKLES SINCE WE BOUGH THE VEHICLE. THEY HAD TO REPLACE THE WHOLE HOUSING UNIT ON THE OTHER SIDE WITHIN THE FIRST 6 MONTHS BECAUSE IT JUST FELL APART.

WITHIN 10 DAYS OF BUYING IT BRAND NEW I'VE HAD ELECTRICAL PROBLEMS. REPLACED BACK UP SCREEN WITHIN THOSE 10 DAYS EVEN THOUGH THEY DIDN'T FIND ANYTHING WRONG. STILL CONTINUES. MULTIPLE ISSUES WITH THE POWER TRAIN. NOW I'VE BEEN OUT OF A CAR FOR 2 WEEKS BECAUSE I MIGHT NEED A NEW TRANSMISSION AT 65,000 NO LONGER UNDER WARRANTY. HOW CAN I PAY $38,000 AND IT GOES BAD INSTANTLY? NO HELP FROM FORD OR DEALER. MY GEARS ARE STALLING AND NOT SHIFTING CORRECTLY OR PICKING UP SPEED. I DRIVE LIKE AN OLD LADY AND TAKE CARE OF THIS CAR LIKE IT'S BRAND NEW. I WILL NEVER BUY A FORD AGAIN AND WILL TELL ANYONE WHO WILL LISTEN NOT TO DO THE SAME.

POWER STEERING LOCKED UP , WELL ITS ELECTRIC STEERING .AND THE WARRING LIGHTS CAME ON TERRAIN ASSIST AND HILL ASSIST DISABLED, SERVICE ADVANCE TRAC ,STEERING LOSS , I WAS TRAVELING ON THE FREEWAY DOING ABOUT 70 MILES AN HOUR WHEN THIS HAPPED I ALMOST LOSS CONTROL OF THE VEHICLE . THERE ARE SO MANY COMPLAINTS ABOUT THIS PROBLEM WITH THE FORD EXPLORE STEERING ISSUSE .

WHILE MOVING THE STEERING WHEEL THERE IS A WEIRD CLUNK/POP NOISE AND FEELS A BIT LOOSE. SO THIS IS CONCERNING 66,000 MILES ON MY VEHICLE. ALSO THE FRONT SUSPENSION IS VERY ROUGH AND I HAVE TAKEN VERY GOOD CARE. DEALERSHIP WAS NOT SURE WHAT IT WAS BUT STATED IT WAS SAFE

WHILE DRIVING 52MPH, CRUISE CONTROL SET, CLEAR WEATHER, RURAL ROAD, TRAVELING STRAIGHT - NO INCLINE OR DOWNHILL...THE VEHICLE SUDDENLY DOWNSHIFTED TO 2ND OR 1ST GEAR - THUS DECELERATING RAPIDLY. AFTER A MOMENT, IT WENT BACK TO BEING ABLE TO ACCELERATE AND MAINTAIN NORMALLY. 2016 EXPLORER SPORT WITH 44K MILES...I'VE HAD IT FOR ABOUT A MONTH.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE VEHICLE WAS PARKED INSIDE HIS GARAGE WHEN HE STARTED TO SMELL A HEAVY EXHAUST ODOR INSIDE AND OUTSIDE OF THE VEHICLE. THE CONTACT STATED NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO DORSCH FORD LINCOLN KIA (2641 EATON RD, GREEN BAY, WI 54311, (920) 469-3000) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED COST ME $3,000 TO FIX BY CONSUMER'S MECHANIC. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 107,000.*DT*JB

WHILE I WAS DRIVING I STARTED TO GET A STRONG SMELL OF ROTTEN EGGS/SULFUR THAT FILLED THE CABIN. IT GOT SO STRONG THAT I HAD TO ROLL DOWN THE WINDOWS TO AIR IT OUT AND IT STARTED TO GIVE ME A HEADACHE. IT HAPPENED AGAIN WHILE DRIVING BACK TO MY HOME THAT SAME DAY. THE SMELL GOT SO STRONG IT STARTED TO MAKE ME DIZZY, NAUSEOUS AND GAVE ME A HEADACHE.

AIRBAG WARNING LIGHT ILLUMINATED ON VEHICLE. CHECKED ALL WIRES UNDER THE SEAT AND NONE ARE LOOSE OR DAMAGED. SEARCHED TOPIC ONLINE AND APPEARS TO BE A KNOWN ISSUE. FORD ISSUED A SERVICE BULLETIN FOR THE REPAIRS BUT WILL NOT COVER UNDER WARRANTY OR ISSUE RECALL. THIS IS A SAFETY ISSUE AS THE AIRBAGS WILL NOT DEPLOY WHEN THIS LIGHT IS ILLUMINATED.

THE STEERING WHEEL LOCKED WHILE WE WERE DRIVING IN THE CAR. WE TURNED LEFT INTO THE GROCERY STORE AND THEN BACK RIGHT TO ENTER A PARKING SPOT AND THE STEERING LOCKED AND WE ALMOST RAN INTO A PARKED CAR. LUCKILY WE SLAMMED ON THE BRAKES IN TIME TO AVOID AN ACCIDENT. WE HAD TO CRANK THE STEERING WHEEL ALL THE WAY TO THE RIGHT TO ALLOW IT TO "RELEASE" AND GIVE US SOME STEERING BACK...BUT AFTER THAT THE STEERING NOW CLICKS WHILE YOU TURN LEFT OR RIGHT BADLY. WE TOOK IT INTO OUR DEALER...THEY SAID IT IS THE STEERING GEAR MOTOR. THE CAR WAS IN THE SAME DEALERSHIP 1 WEEK PRIOR TO THIS GETTING AN OIL CHANGE AND NO SIGNS OF MALFUNCTION OR WEAR/TEAR...WITHOUT WARNING THE STEERING LOCKED UP ON US...VERY FRIGHTENING...OUR CAR IS 4 YEARS OLD AND ONLY HAS 16,000 MILES ON IT. AND THEY CANNOT EXPLAIN EXACTLY WHY IT HAPPENED. SO I AM UNSURE OF IF/WHEN IT HAPPENS AGAIN.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE SECOND-ROW MIDDLE SEAT FAILED TO UNLATCH AS DESIGNED. THE CONTACT STATED THAT HIS CHILD WAS CONFINED IN THE SEAT WHILE STRAPPED INTO THE SEAT BELT. THE CONTACT TOOK THE VEHICLE TO VAN DRUNEN FORD (3233 183RD ST, HOMEWOOD, IL 60430) AND WAS INFORMED THAT THERE WERE NO RECALLS ON THE VEHICLE AND WAS PROVIDED AN ESTIMATE FOR THE REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,600.

SOUNDED LIKE A POPPING OR CLUNK TYPE NOISE WHEN I TURNED THE WHEEL TO THE RIGHT FOR A WHILE THEN IT STARTED TO MAKE NOISE WHEN TURN THE WHEEL EITHER WAY. LOSING CONTROL DRIVING. READ ON THE NEWS, 1.2 MILLION EXPLORER RECALLED FOR THE STEERING ASSEMBLY RECALLED FOR SAME ISSUE BUT WHEN I CALL FORD THEY SAID THIS VIN WAS NOT PART OF RECALL. VERY DISAPPOINTED.

THE FIRST TIME MY STEERING GOT STIFF ON 09/13/2019 WHILE TRYING TO MAKE A LEFT TURN ON A CITY STREET. IN THE PROCESS OF MAKING THE LEFT TURN MY STEERING WHEEL GOT STIFF, AND THE STEERING FAULT HILL START AND TRAC LIGHT WENT ON. I WAS UNABLE TO CONTROL THE STEERING WHEEL WHICH CAUSE ME TO GET UP ONTO THE SIDE WALK AND ALMOST HITTING A TREE. I HAD TO SLAM ON MY BREAKS IN ORDER TO AVOID THE ACCIDENT. MY KIDS BODY JERK BACK AND FORTH REALLY HARD. I TURN MY CAR OFF AND BACK ON, AND THE STEERING WHEEL WAS WAS NO LONGER STIFF AND WORKING. I WAS ABLE TO DRIVE HOME. THE SECOND TIME STEERING WHEEL GOT STIFF WAS ON 10/05/2019. WHILE ON THE CURVE OF A RAMP TO GET OFF THE FREEWAY THE STEERING WHEEL GOT STIFF AGAIN AND THE STEERING FAULT, HILL START AND TRAC LIGHTS WENT ON AS WELL. ONCE AGAIN I HAD TO SLAM ON THE BREAKS IN OR. I DER TO AVOID HITTING THE RAILS, AS I WAS NOT ABLE TO CONTROL THE STEERING WHEEL. I TRY TURNING MY CAR OFF AND BACK ON AGAIN TO SEE IF MY STEERING WHEEL WOULD WORK AGAIN, BUT IT STILL DID NOT WORK. I HAD TO CALL MY HUSBAND TO COME PICK ME UP. I TOOK THE CAR TO THE DEALER AND I WAS TOLD THAT THEY H.AD TO REPLACE THE WHOLE POWER STEERING EQUIPMENT WHICH COST ME A TOTAL OF $2350.39

TWO SEPARATE FAILURE WITHIN A FOUR DAY TIME SPAN. COMPANY SOLD ME THE VEHIXAL SAID IT WAS A TIE ROD AND FIXED THE RIGHT PASSENGER REAR WHEEL. THE VEHICAL WAS REAL EASED TO ME TODAY WITH THE UNDERSTANDING THAT THE REAR SUSPENSION WAS FULLY REPAIRED. I HAD A HIGH SPEED ACCIDENT AFTER THE LEFT REAR TIR ROD BROKE AT A SPEED OF 80 MPH. DUE TO THE SUSPENSION BREAKAGE, THE CAR WENT OFF THE INTERSTATE AT HIGH SPEED. THE REAR END SUSPENSION HAD COMPLETE FAILURE AND THE AUTO DEALERSHIP RELEASED THE VEHICLE TO ME WITH THE FULL WITH ASSURANCE THE ISSUE WAS FIXED. THIS WAS A VERY SERIOUS INCIDENT WITH A POTENTIAL DEADLY OUTCOME.

POWER STEERING FAILED COMPLETELY ON MY 2016 FORD EXPLORER WHILE DRIVING. DASHBOARD LIT UP WITH A STEERING ASSIST FAULT, AND THEN HILL ASSIST FAULT. STEERING THE VEHICLE TO SAFETY WAS VERY CHALLEGING. I WAS TURNING AT A LEFT TURN LIGHT AND ALMOST CRASHED INTO ANOTHER VEHICLE BECAUSE I COULD NOT STEER THE CAR. LOOKED IT UP ONLINE AND HAVE FOUND NUMEROUS OTHER ACCOUNTS OF THE SAME ISSUE WITH NO REPSONSE OR RECALL FROM FORD.

WHILE DRIVING THE TRACTION CONTROL AND ABS LIGHTS COME ON. SYSTEM HAS STABILITY CONTROL WARNING. WHILE DRIVING THIS CAUSES BRAKES TO LOCK UP. MY WIFE ALMOST CRASHED DUE TO THE BRAKES LOCKING. ONCE YOU TURN OFF THE CAR IT WILL RESET AND EVERYTHING APPEARS NORMAL UNTIL IT HAPPENS AGAIN. UNFORTUNATELY THIS INCIDENT DOES NOT STORE ANY CODES IN THE SYSTEM. WE HAVE HAD THE 2016 EXPOLORER IN THE SHOP MULTIPLE TIMES AND THE DEALERSHIPS HAVE DONE NOTHING TO FIX THE ISSUE. BECAUSE THERE ARE NO CODES THEY ARE DOING NOTHING. THEY DO NOT RESEARCH THE ISSUE NOR HAVE THEY TRIED TO FIX ANYTHING. THERE ARE MULTIPLE COMPLAINTS ABOUT THIS AND A PROCEDURE NEEDS TO BE ESTABLISHED TO DIAGNOSE AND FIX THE PROBLEM. THIS IS A SERIOUS SAFETY ISSUE AND NEEDS TO BE ADDRESSED BY FORD BEFORE SOMEONE DIES. MY WIFE WILL NO LONGER DRIVE THIS VEHICLE BECAUSE SHE FEEL UNSAFE.

MY TIRE VALVE CORRODED AFTER 3 YEARS WITH THE CAR. WHICH CAUSED DAMAGE TO THE TIRE AND THE TIRE PRESSURE SENSOR. THE POWER STEERING WENT AT 67000 MILES. IT STOPPED WORKING COMPLETELY WHILE DRIVING, EXTREMELY SCARY. THE SERVICE DEPARTMENT AT THE DEALERSHIP SAID IT IS JUST SOMETHING THAT HAPPENS. $2400 FIX ON A 4 YEAR OLD CAR WITH 67000 MILES AND COULD HAVE CAUSED AN ACCIDENT.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING, THE VEHICLE SURGED BETWEEN GEARS AND DECELERATED BEFORE OPERATING AS DESIGNED. THE CONTACT ALSO STATED THAT AFTER THE VEHICLE REVERSED OUT OF THE DRIVEWAY AND SHIFTED INTO DRIVE, AN ABNORMAL CLUNKING NOISE WAS HEARD UNDERNEATH THE VEHICLE. THE CONTACT STATED THAT THE FAILURES WERE NOTICED DURING A TEST DRIVE PRIOR TO PURCHASING THE VEHICLE HOWEVER, THE TECHNICIAN AT THE GRIECO FORD OF RAYNHAM LOCATED AT 1651 NEW STATE HWY, RAYNHAM, MA, 02767, INFORMED THE CONTACT THAT THERE WAS NO PROBLEM WITH THE VEHICLE. THE CONTACT STATED THAT THE FAILURE RECURRED AFTER THE VEHICLE WAS PURCHASED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE WAS NOT DIAGNOSED NOR REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 45,000.

I HAD THE REAR TOE LINKS REPLACED DUE TO A SAFETY RECALL DECEMBER 2, 2019. ON 09/27/20, I WAS RETURNING HOME AFTER DROPPING MY KIDS OFF TRAVELING 70 MPH ON A HIGHWAY, WHEN THE RECAL PART I HAD REPLACED LESS THAN A YEAR AGO BREAK. THIS CAUSED ME TO LOSE CONTROL AND HAVE AN ACCIDENT. I NOTIFIED FORD OF THIS 09/28/20 AND I WAS INFORMED THAT THE RECAL WAS COMPLETED, NOTHING THEY COULD DO. I INFORMED THEM THE PART BROKE AT THE WELD WHICH IS A DEFECTIVE PART. AGAIN, I WAS TOLD OT THEIR PROBLEM. THIS HAS CAUSED MY VEHICLE TO TO BE TOWED , DAMAGE TO THE REAR BUMPER AND MYSELF BUYING A NEW PART OUT OF POCKET TO GET VEHICLE ON ROAD AGAIN TO GO TO WORK. THIS IS ALSO ANY OTHER PROBLEMS THAT IT MAY HAVE CAUSED DUE TO STRESS ON VEHICLE, LIKE OTHER TOE LINK, TIRES, BRAKES, OTHER SUSPENSION PARTS. ENCLOSED IS PART AND PART NUMBER THAT WAS THE RECAL PART REPLACED BY A FORD DEALERSHIP AND DAMAGE TO VEHICLE. I WAS LUCKY I DID NOT HIT THE OTHER VEHICLES AROUND ME, HIT HEAD ON WITH CENTER DIVIDER OR GUARDRAIL, ROLL THE VEHICLE OR HAVE SERIOUS INJURY.

STEERING WOULD LOCK UP AND YOU WOULD HAVE TO FORCE THE STEERING BACK TO DRIVE ABILITY. THE RACK AND PINION WAS WORN OUT, IN MY OPINION PREMATURELY. THIS HAPPENED WHILE THE VEHICLE WAS IN MOTION. THE FIRST TIME IT WAS NOTICE WAS ON HIGHWAY DRIVING IN A CONSTRUCTION ZONE. THE STEERING WOULD CATCH WHEN TURNING LEFT OR RIGHT AND YOU WOULD HAVE TO FORCE THE WHEEL TO STRAIGHTEN OUT THE VEHICLE.

STEERING WHEEL IS STIFF AND MAKES NOISE WHEN TURNING.

EVEN UNDER WARRANTY THERE WERE SPORADIC TIMES THE FRONT SUSPENSION/STEERING WOULD MAKE A LOAD THUMP NOISE. THIS USUALLY HAPPENED WHEN BACKING OUT OF THE DRIVEWAY AND SOMETIMES WHEN PULLING OUT OF A PARKING SPACE. THE DEALER COULD NEVER DUPLICATE THE NOISE SO THEY FOUND NOTHING WRONG WITH IT. NOW AT 48K MILES AND OUT OF WARRANTY THE SOUND HAPPENS MUCH MORE OFTEN. MY WIFE SAID ONCE THE STEERING APPEARED TO MOMENTARILY LOCK UP AND HAD TO PULL THE STEERING WHEEL PRETTY HARD TO FREE IT UP. I FOUND SEVERAL OTHER INTERNET SITES STATING THAT THE STEERING SYSTEM IS NEEDING REPLACED ON MANY EXPLORERS WITH RELATIVELY LOW MILES AT A COST TO THE OWNERS OF OVER $2000.

POWER LOCKS GET STUCK ON EITHER LOCK OR UNLOCKED NOT ALLOWING ME TO EITHER LOCK OR UNLOCK THE CAR DOOR ON DRIVER AND BACK PASSENGER DOOR. PLASTIC STRIPPING PANELS ON FRONT DRIVER AND PASSENGER DOORS ARE COMING OFF AND THE PANELS CONNECTED TO THE WINDSHIELD ON BOTH SIDES. POWER SEATS DO NOT HOLD THE MEMORY OF WHERE IT WAS LEFT. THE SEAT GOES ALL THE WAY UP TO THE STEERING WHEEL WHEN MEMORY BUTTONS ARE PRESSED OR IF THE KEYLESS CODE ON THE DOOR IS USED TO UNLOCKED THE CAR. KEYLESS ENTRY WILL UNLOCK WITHOUT TO CODE BEING TYPED IN CORRECTLY. USING THE FIRST THREE NUMBERS CAN UNLOCK THE DOOR. ALL OF THESE THINGS HAPPEN WILL THE CAR IS STATIONARY.

WHEN TURNING RIGHT AT A SLOW SPEED, HEAVY KNOCKING/THUMPING NOISE AND STEERING WAS JERKY. VEHICLE HAS 33,400 MILES. HAD IT REPAIRED AT THE FORD DEALERSHIP YESTERDAY AND THEY REPLACED THE RACK AND PINION AT A COST OF $1800. SINCE I READ THIS SEEMS TO BE A COMMON PROBLEM I ASKED IF THIS ISSUE HAS BEEN RECALLED AND WAS INFORMED IT WAS NOT.

PER FORD WEBSITE, I WAS TOLD THAT MY SYNC SOFTWARE NEED AN UPGRADE WHEN I TYPED IN THE VIN, THEN I FOLLOW THE INSTRUCTION ON WEBSITE BUT THE PROGRAM I DOWNLOADED MESSED UP MY APIM MODULE ON MY CAR AND RADIO, GPS, AND OTHER FUNCTION AE NOT WORKING. SO I TOOK MY SUV TO THE DEALER AND THEY SAID IT WILL COST ME $1050 TO FIX THE ISSUE.

STARTED HAVING ISSUES WITH THE STEERING AT 39,500 MILES. SOUNDED LIKE A POPPING OR CLUNK TYPE NOISE WHEN I TURNED THE WHEEL TO THE RIGHT. I TOOK IT TO FORD DEALERSHIP WHO INDICATED THE WHOLE STEERING ASSEMBLY NEEDED TO BE REPLACED. THIS CAR WAS BUILT AT THE CHICAGO PLANT LIKE ALL THE OTHER EXPLORERS THAT NEEDED THE STEERING ASSEMBLY REPLACED. FORD INDICATED THIS VIN WAS NOT PART OF RECALL.

I HAVE A 2016 FORD EXPLORER WITH 94,000 MILES. WE NOTICED THAT THE AC WAS BLOWING HOT AIR SO WE TOOK THE CAR IN FOR A REPAIR ON 9/8/2020. THE DEALERSHIP CALLED US BACK TO INFORM US THAT THE WATER PUMP HAD FAILED WHICH CAUSED ANTIFREEZE TO LEAK INTO AND ON THE AC COMPRESSOR CAUSING IT TO FAIL. WE WERE QUOTED A PRICE OF $2600.00 FOR THE REPAIR THE WATER PUMP. I WAS ALSO TOLD THAT MANY POLICE CRUISERS WITH THE SAME MOTOR ARE HAVING THE SAME ISSUE. FORD RECOMMENDS THAT THE WATER PUMP BE REPLACED AT 150000 MILES' THE MILES ON THE SUV ARE HIGHWAY MILES.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING 70 MPH, THE STEERING WHEEL FAILED. THE DRIVER KEPT THE STEERING WHEEL UNDER CONTROL AND MOVE INTO THE SLOW LANE WHILE CONTINUING TO DRIVE. THE CONTACT STATED THAT THE STEERING SYSTEM FAILURE WARNING LIGHT ILLUMINATED ON THE INSTRUMENTAL PANEL WHEN THE FAILURE OCCURRED. THE VEHICLE WAS TOWED TO LEWIS J C FORD (9505 ABERCORN STREET SAVANNAH, GEORGIA, 31406, (912)-210-5677) TO BE DIAGNOSED. THE MECHANIC LOCATED THE FAILURE AT THE STEERING WHEEL RACK AND PINION. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 65,000.*DT*JB

INITIAL ISSUES WAS AN ISSUES ACCELERATING. WHEN ACCELERATING TO 3000 RPM, THE RPMS WOULD SUDDENLY DROP BACK TO 2 AND THE CAR WOULD LURCH. STARTED EXPERIENCING ISSUES WHEN SLOWLY DECELERATING LIKE GEARS WOULD NOT ENGAGE CORRECTLY. WHEN STARTING THE CAR AND SHIFTING INTO DRIVE, THE CAR LURCHED FORWARD WITH A GRIND AND THE WRENCH DASH LIGHT CAME ON.

STEERING STARTED MAKING A GRINDING NOISE TURNING LEFT OR RIGHT. INTERMITTENT SEVERE PULLING TO THE LEFT OR TURNING FROM LEFT TO RIGHT. HAPPENS AT LOW OR HIGH SPEED. STARTED ABOUT 58K MILES. CAR IS UNSAFE AND UN-DRIVABLE IN THIS CONDITION. ADVISED THE RACK AND PINION IS BAD AND NEEDS TO BE REPLACED AT APPROX $2000.

STARTED DRIVING AND RECEIVED A WARNING ON THE SCREEN SAYING "STEERING FAULT SERVICE NOW". LOTS POWER STEERING CONTROL. THANKFULLY WAS AT A LOW SPEED AND COULD STOP SAFELY BEFORE LEAVING OUR NEIGHBORHOOD. PUT VEHICLE IN PARK, POWERED OFF, POWERED BACK ON, AND WAS ABLE TO DRIVE AGAIN. VEHICLE HAS 56K MILES ON IT.

WHILE MAKING TURNS EITHER AT SLOW SPEEDS OR AT A COMPLETE STOP, THE STEERING MAKES POPPING SOUNDS. STEERING WHEEL ALSO LOCKS FOR HALF A SECOND. TOOK VEHICLE TO A SHOP AND WAS ADVISED IT WAS THE RACK AND PINION ON THE FRONT RIGHT TIRE AREA. THE VEHICLE IS A 2016 AND HAS 41K MILES. THIS ISSUE BEGAN MANIFESTING APPROXIMATELY TWO WEEKS PRIOR. ESTIMATED COST TO REPAIR IS $2500. ACCORDING TO VEHICLE FORUMS THIS IS A COMMON ISSUE WITH THIS VEHICLE MAKE AND MODEL.

MY WIFE WAS DRIVING DOWN THE ROAD WHEN THE STEERING QUIT. IT WAS PULLING FROM SIDE TO SIDE AND SHE ALMOST LOST CONTROL. STEERING FAILURE ALARMS WERE CONTINUING TO GO OFF. SHE WAS ABLE TO GET THE VEHICLE OFF THE ROADWAY AND AVOID A CRASH.

NOT LONG AFTER PURCHASING THE VEHICLE FROM A DEALERSHIP I WAS DRIVING DOWN THE HIGHWAY WITH MY FAMILY WHEN THE DRIVER WINDSHIELD PILLAR MOLD FLYS OFF MY VEHICLE AND INTO TRAFFIC BEHIND ME. A FEW WEEKS OR SO LATER THE SAME THING HAPPENED TO THE PASSENGER SIDE. I WAS LOOKING ONLINE FOR PARTS AND NOTICED MANY PEOPLE COMPLAINING ABOUT THIS ISSUE.

THE ENTIRE AIR CONDITIONING SYSTEM HAS CORROSION AND RUSTED COMPLETELY OUT. THIS VEHICLE IS ONLY 4 YEARS OLD. IT SHOULD NOT BE RUSTED BEYOND REPAIR. THIS ENTIRE SYSTEM IS VERY COSTLY. THERE IS A LEAK AT THE REAR EVAPORATOR HOUSING CONNECTION.

POWER STEERING WENT ON A 2016 FORD EXPLORER XLT WITH 57001 MILES ON IT. CHARGED FOR STEERING RACK/BOX REPLACEMENT PLUS OTHER ASTRONOMICAL FEES ASSOCIATED WITH IT OUT OF POCKET. THE VEHICLE IS SUPPOSED TO BE A FAMILY CAR. IT IS UNSAFE AND HASN'T BEEN THE SAME SINCE. CAR JUST GAVE OUT ON HIGHWAY WITH CHILDREN IN CAR. THE CAR STARTED TO ACTIVELY SWAY ALL OVER THE ROAD WITHOUT WARNING. NO CONTROL. HAD TO PULL OVER. CALLED FOR ASSISTANCE AND THAN RESTARTED THE CAR TO HAVE NO POWER STEERING WHAT SO EVER. IT WAS WORSE THAN TRYING TO DRIVE A HEAVY DUTY TRUCK. AS A FEMALE, I COULD NOT EVEN TURN THE STEERING WHEEL. NO CODES CAME UP PRIOR; UNTIL THE RESTART OF THE CAR. ???? DEALER TOOK WEEK TO GET IT IN PLUS A DAY FOR PART AND THOUSANDS OUT OF MY POCKET DURING A WORLD WIDE PANDEMIC. WITH MASSIVE AMOUNTS OF PEOPLE COMPLAINING ABOUT THIS ISSUE WHY HASN'T IT BEEN RECALLED? THIS IS INCREDIBLY DANGEROUS.

THE VEHICLE WAS IN MOTION ON A STATE HIGHWAY WHEN THE FOLLOWING WARNING MESSAGES WERE DISPLAYED STEERING ASSIST FAULT SERVICE REQUIRED, HILL START ASSIST NOT AVAILABLE, SERVICE ADVANCE TRAC, TERRAIN MANAGEMENT SYSTEM FAULT. AT THIS POINT I HAD COMPLETE LOSS OF POWER STEERING. I WAS ABLE TO PULL TO THE SIDE OF THE ROAD SAFELY AND HAD TO HAVE TOWED TO THE FORD DEALER IN MY TOWN WHICH IS WAS 2 HOURS AWAY. FORD DEALERSHIP DIAGNOSED THE PROBLEM AS POWER STEERING CONTROL MODULE.WHICH IS INTEGRAL WITH THE RACK AND PINION ASSEMBLY. COST OF REPAIR IS 2400.00 OF COURSE I HAVE A LIFETIME WARRANTY ON MOST PARTS INCLUDING FUEL PUMP, ENGINE ,TRANSMISSION BUT RACK AND PINION NOT CONSIDERED UNDER THIS WARRANTY. *TR

TL* THE CONTACT OWNS A 2016 FORD EXPLORER EQUIP WITH HANKOOK VENTUS S1 NOBLE 2; TIRE SIZE: 255/50R20-108H AND THE DOT NUMBER: 5MNC 1A H0118. THE CONTACT STATED THAT WHILE INSPECTING THE TIRES, IT WAS DISCOVERED THAT THE TIRES HAD EXPERIENCED CRACKING AND GUDGES ON THE INSIDE AND OUTSIDE OF THE TIRES. THE FAILURE WAS PRESENT ON ALL FOUR TIRES. THE CONTACT ALSO INDICATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SHAKE AND VIBRATE. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER AUTONATION FORD LOCATED AT 7700 BLANDING BLVD, JACKSONVILLE, FL 32244 WHO REPLACED ALL FOUR TIRES WITH THE SAME BRAND SIZE AND MODEL TIRES BUT APPROXIMATELY 13,000 MILES LATER THE SAME FAILURE HAD OCCURRED. THE CONTACT WAS UNABLE TO REACH OUT TO THE MANUFACTURER IN REFERENCE TO THE FAILURES. THE VEHICLE FAILURE MILEAGE WAS 18,000 AND THE FAILURE TIRE MILEAGE WAS NOT AVAILABLE. THE VIN WAS NOT AVAILABLE.

I WAS DRIVING HOME FROM DROPPING MY DAUGHTER OFF AT DAYCARE AND I LOST THE POWER STEERING ON MY VEHICLE WHILE THE VEHICLE WAS IN MOTION AND I WAS DRIVING A STEADY SPEED DOWN A STRAIGHT ROAD. MY DAUGHTER WAS NO LONGER IN THE CAR WITH ME AS THIS COULD HAVE RESULTED IN AN ACCIDENT BUT THANKFULLY SHE WAS NOT AND I WAS ABLE TO PULL OFF THE ROAD WITH A LOT OF EFFORT INVOLVED. MY CAR HAD TO BE TOWED TO THE FORD SHOP AND I HAD TO HAVE MY POWER STEERING CORE CHANGED. $2500. THIS CAR ONLY HAS 37,000 MILES AND IS A 2016 FORD EXPLORER. QUITE FRUSTRATING, DISAPPOINTING AND EXPENSIVE. THERE NEEDS TO BE A RECALL WITH THIS PROBLEM BECAUSE I AM NOT THE ONLY ONE THIS HAS HAPPENED TOO.

NOTICED PROBLEM WITH STEERING. WHEN I CHANGED LANES THE VEHICLE CONTINUED IN THAT DIRECTION UNTIL I CORRECTED IT. THIS HAPPENED SEVERAL TIMES WHILE DRIVING HOME FROM WORK SO I WENT STRAIGHT TO MATT BOWERS FORD IN METAIRIE. I WAS TOLD THE STEERING GEAR NEEDED TO BE REPLACED, THE MODULE REPROGRAMMED AND AN ALIGNMENT. I'VE SEEN QUITE A FEW RECALLS CONCERNING THIS BUT WAS NOT TOLD THAT MY VHEICLE VIN WAS NOT AFFECTED. I NOW SEE MANY PEOPLE ARE COMPLAINING OF THE SAME PROBLEMS. THIS SHOULD BE LOOKED AT CAREFULLY BEFORE SOMEONE GETS HURT.

THE VEHICLE WAS IN MOTION ON A STATE HIGHWAY WHEN THE FOLLOWING WARNING MESSAGES WERE DISPLAYED STEERING ASSIST FAULT SERVICE REQUIRED, HILL START ASSIST NOT AVAILABLE, SERVICE ADVANCE TRAC, TERRAIN MANAGEMENT SYSTEM FAULT. AT THIS POINT I HAD COMPLETE LOSS OF POWER STEERING. I WAS ABLE TO PULL TO THE SIDE OF THE ROAD SAFELY AND HAD TO HAVE TOWED. LOCAL FORD DEALERSHIP DIAGNOSED THE PROBLEM AS POWER STEERING CONTROL MODULE.WHICH IS INTEGRAL WITH THE RACK AND PINION ASSEMBLY.

I WAS TURNING INTO A GAS STATION AND THE POWER STEERING WENT OUT WITH NO PREVIOUS WARNINGS OR ISSUES.

BROKEN TOE LINK. FORD REFUSING TO RECOGNIZE IT AS A FAILURE UNDER FORD RECALL 19S17. THEY SAY IT WAS REPAIRED UNDER FORD RECALL 17S11. REAR DRIVER SIDE TOE LINK BROKE 7/25/20 WHEN GOING OVER A RAILROAD GRADE CROSSING. OEM REPLACEMENT PART PURCHASED FROM FORD DEALER BROKE 8/24/20 TURNING GENTLY TO THE LEFT. ATTACHED PICTURE IS THE ORIGINAL LINK THAT BROKE 7/25/20. REPLACEMENT PART BOUGHT THROUGH FORD DEALER BROKE IN APPROXIMATELY THE SAME AREA.

LOSS OF STEERING WHILE DRIVING. NEARLY CAUSED A 4 CAR COLLISION. STEERING WHEEL LOCKED WHILE DRIVING 57 MPH. WAS BARELY ABLE TO SLOW DOWN AND PULL OFF TO THE SIDE. THIS HAS HAPPENED MULTIPLE TIMES, HOWEVER AFTER THIS LAST TIME, THE STEERING WHEEL IS PERMANENTLY LOCKED. STEERING LOSS LIGHT CAME ON AFTERWARDS.

WHILE DRIVING ON TRIPS OVER 30 MINUTES I EXPERIENCE HEADACHES, NAUSEOUS AND FATIGUE. I HAVE AN APPOINTMENT WITH FORD DEALER ON AUGUST 27, 2020

I OWN A 2016 FORD EXPLORER WHICH HAS 78,146 MILES AND WHILE DRIVING THE ENGINE LIGHT CAME ON AND THE VEHICLE STALLED WITHOUT WARNING. I HAD TO PUT MY CAR IN NEUTRAL AND COAST TO THE SIDE OF THE ROAD WITH MY CHILDREN IN THE CAR. I JUST PURCHASED THIS VEHICLE FROM EVERETT FORD IN BENTON, ARKANSAS LESS THAN A YEAR AGO AND HAVE HAD NORMAL ROUTINE MAINTENANCE COMPLETED ACCORDING THE THE OWNERS MANUAL. AFTER HAVING A MECHANIC TAKE A LOOK IT IS A RESULT OF A FAULTY WATER PUMP IN WHICH I WAS QUOTED $2500-$3500 FOR A REPLACEMENT IN ADDITION THE ENGINE WOULD BE SEVERAL THOUSAND. THE PROBLEM IS THAT THE WATER PUMP IS INSIDE THE ENGINE AND SO WHEN THE WATER PUMP FAILS IT DESTROYS THE ENGINE WITHOUT WARNING BY MIXING THE COOLANT WITH THE ENGINE OIL. AFTER LOOKING INTO THIS FURTHER THE DEALERSHIP AND THE MANUFACTURER WERE AWARE OF THIS MECHANICAL DEFECT AND THE THOUSANDS OF CUSTOMERS THAT WERE AFFECTED BUT CONTINUE TO ADVERTISE 'BUILT FORD TOUGH'TO DRIVE SALES AND DID NOT WARN CUSTOMERS OR MAKE THEM AWARE. THIS IS A SAFETY CONCERN FOR ALL OWNERS OF THE FORD DURATEC V6 ENGINE AND THERE SHOULD BE A FORCED RECALL BY THE NATIONAL HIGHWAY SAFETY ADMINISTRATION. DO NOT WAIT FOR THERE TO BE DEATHS FROM THIS MECHANICAL DEFECT BEFORE TAKING ACTION. FORD SHOULD TAKE RESPONSIBILITY. I AM A LOYAL CUSTOMER OF FORD BUT WILL BE GETTING RID OF MY VEHICLE AND MAKING SURE ALL FORD OWNERS ARE AWARE AND YOU CANNOT TRUST FORD WHEN THEY ARE AWARE OF A SAFETY RELATED MECHANICAL FAILURE AND THEY ARE NOT TAKING RESPONSIBILITY OR EVEN NOTIFYING ITS LOYAL CUSTOMERS!

THERE IS AN AIRBAG WARNING LIGHT ON THE DASHBOARD. IT IS DUE TO A CIRCUIT FAILURE OR A BROKEN CORD LEADING TO THE DRIVER SIDE MIDDLE ROW SEATBELT AIRBAG. THIS IS NOT NORMAL WEAR AND TEAR BUT A SAFETY ITEM DESIGN BY FORD THAT HAS FAILED IN THE VEHICLE. THE FORD DEALERSHIP SERVICE DEPARTMENT DOES NOT KNOW HOW THIS SAFETY FEATURE BROKE. IF WE WERE TO GET IN AN ACCIDENT WHILE THE AIRBAG IS IN THIS STATE, IT WOULD NOT DEPLOY AND PUT MY PASSENGERS LIFE IN MORE JEOPARDY.

STEERING WAS GETTING DIFFICULT WHILE MAKING TURNS. TOOK IT TO A FORD DEALER AND WAS TOLD THE RACK & PINION NEED TO BE REPLACED FOR $2,560 AND IT IS UNSAFE TO DRIVE. FORD IS NOT COVERING THIS ISSUE EVEN THOUGH IT IS A FAULTY PART ON THEIR END AND SHOULD BE THEIR RESPONSIBILITY.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE THE ENGINE COOLANT OVER TEMPERATURE MESSAGE WAS DISPLAYED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT A FLUID LEAK WAS PRESENT BEHIND THE WATER PUMP. THE VEHICLE WAS NOT REPAIRED. THE LOCAL DEALER MCGOVERN FORD LOCATED AT 1212 WESTFORD ST, LOWELL, MA 01851 AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 16V183000 (ENGINE, ENGINE COOLING). THE CONTACT STATED THAT THE VEHICLE HAD EXPERIENCED THE SAME FAILURE LISTED IN THE RECALL. THE FAILURE MILEAGE WAS 99,000.

I WAS DRIVING ON THE HIGHWAY 65 IN HAM LAKE, MN SEVERAL WEEKS AGO WHEN I SUDDENLY LOST CONTROL OF THE STEERING. THE VEHICLE LUNGED TO THE LEFT TOWARDS THE DITCH. I WAS ABLE TO FISHTAIL IT BACK ONTO THE ROAD, ALMOST ROLLED THE VEHICLE AND BARELY KEPT IT UNDER CONTROL. I GOT OVER TO THE RIGHT SHOULDER AND CALL THE ANOKA COUNTY SHERIFF FOR ASSISTANCE. A DEPUTY ASSISTED BUT I DON'T BELIEVE A FORMAL POLICE REPORT WAS FILED. THIS WAS SUNDAY JULY 19TH. WE WERE ABLE TO GET TO LOCAL MECHANIC WHO LOOKED AT IT THE FOLLOW DAY AND DETERMINED THAT THE TOE CONTROL LINK HAD BROKEN. THEY REPAIRED IT WITH A NEW PART FROM THE LOCAL FORD DEALERSHIP AND THE VEHICLE SEEMED FINE. LAST NIGHT THE NEW PART THAT THEY INSTALLED BROKE AS WELL. I LOOKED ONLINE AND SEE THAT THERE IS A RECALL FOR THIS EXACT PART, THE TOE CONTROL LINK ON 2011-2017 FORD EXPLORERS. I CHECKED THE VIN ON THE NTSB WEBSITE BUT IT INDICATES THAT OUR CAR IS NOT INCLUDED IN THE RECALL. WE HAD BROUGHT THE CAR INTO METROPOLITAN FORD IN EDEN PRAIRIE EARLIER IN THE YEAR FOR OTHER RECALL ISSUES. HAD THE RECALL BEEN COMPREHENSIVE, THIS WOULD HAVE BEEN CAUGHT AND FIXED. AT 65 MPH, MY DAUGHTER AND I SHOULD HAVE BOTH BEEN KILLED IN THE ORIGINAL INCIDENT. IT HAD BEEN SEVERAL WEEKS SINCE THE (NEAR) ACCIDENT AND WE ARE STILL SHAKEN UP BY IT. FORTUNATELY, LAST NIGHT'S INCIDENT WAS AT MUCH SLOWER SPEED. I AM FEARFUL THAT THERE ARE OTHER FAMILIES WHOSE LIVES IN DANGER AS WELL. I HAVE A PHOTO THAT I TOOK OF THE CURRENT (SECOND) BREAK THAT OCCURRED THAT IS ATTACHED.

I INITIALLY HAD 'STEERING FAULT' ALERT A FEW MONTHS AGO. JUST TODAY A 'TERRAIN MAINTENANCE FAULT' ALERT CAME UP WITH A FEW ALERTS ICONS ON THE DASHBOARD. THE STEERING FROZE TO THE POINT I COULD ONLY MOVE THE STEERING WHEEL AN INCH WHILE MUSCLING IT TO A STOP. APPARENTLY, ACCORDING TO THE DEALERSHIP, THIS IS A KNOW ISSUE. THEY HAD ME RESTART THE SUV AND THAT TEMPORARILY SOLVED THE ISSUE, BUT IT COULD HAPPEN AGAIN AT ANYTIME. THE DEALERSHIP SAID, IF THE ISSUE ISN'T OCCURRING WHEN I BRING THE SUV IN THEY CAN'T SPECIFICALLY DIAGNOSE THE PROBLEM, BUT MORE THAN LIKELY THE STEERING GEAR NEEDS TO BE REPLACE FOR ~$2K. AS I AM READING OTHERS, THIS IS AN ONGOING ISSUE THAT COULD PUT DRIVERS IN DANGER AND HAVE FOR OTHERS. I WAS IN MARSHFIELD, MA WHEN THIS HAPPENED, DRIVING 30 MPH APPROXIMATELY 2PM ON PLAIN STREET.

PASSENGER SIDE WINDSHIELD TRIM MOLDING FLEW OFF WHILE DRIVING. DRIVER SIDE DOOR TRIM PANEL LOOSE.

THE FLUIDITY OF THE STEERING IS DETERIORATING. WHEN TURNING THE WHEEL RIGHT OR LEFT THERE IS A GRINDING SOUND OF METAL ON METAL. INTERMITTENTLY I HAVE TO WRESTLE WITH THE STEERING WHEEL WHEN ACCELERATING THROUGH A TURN WHICH IS A MAJOR SAFETY CONCERN I HAVE AS I TYPICALLY AM TRAVELING WITH TWO YOUNG CHILDREN. THE PROBLEM HAS ARISEN IN THE PAST THREE MONTHS AND THE MECHANIC I UTILIZE, WHO DOES NOT REPAIR STEERING RACKS, REPORTED THAT THE COST OF ADDRESSING THE ISSUE COULD EXCEED $1000. THIS PROBLEM SHOULD NOT BE ASSOCIATED WITH A 2016 MODEL THAT JUST WENT OVER 50,000 MILES AND IS NOT SUBJECTED TO ROUGH, EXTENDED DRIVING BUT RATHER MOST DAYS ARE A 28 MILE ROUND TRIP FOR WORK.

THIS CAR HAS EXTREMELY BAD SWAY IN THE REAR END, IT CANNOT BE DRIVEN OVER 40 MPH OR YOU WILL LOSE TOTAL CONTROL OF THE VEHICLE

49000 MILES, ELECTRONIC STEERING IS STARTING TO GO OUT. WHEN DRIVING MODERATE SPEEDS CAR MAKES LOUD AUDIBLE NOISES ESPECIALLY WHEN TURNING THE WHEEL. RACK AND PINION WILL NEED TO BE REPLACED. FORD TOLD ME IT WAS 100% SAFE TO DRIVE. TOOK TO INDEPENDENT MECHANIC WHO SAID THE EXACT OPPOSITE AND SHOULD BE REPLACED BEFORE IT GOES OUT HEAVEN FORBID AT HIGH SPEEDS.FAMILY OF 4 YOUNG KIDS, THIS IS SUPPOSED TO BE A SAFE, FAMILY CAR. FORD IS PUTTING A LOT OF FAMILIES AT RISK NOT RECALLING THIS. THIS CAR ONLY HAS 49K MILES. THEY ARE LOSING LOTS OF RETURN CUSTOMERS BY NOT HANDLING A SAFETY ISSUE PROPERLY. I HOPE NO DEATHS HAVE TO HAPPEN TO BRING MORE SEVERITY TO THIS PRESSING ISSUE. IF YOU HEAR A CLICK WHEN STEERING, GET THE CAR INSPECTED ASAP! CLICKING OCCURS WHEN STATIONARY AND IS MORE INTENSE WHEN DRIVING. IT COULD GO OUT AT ANY MOMENT.

OUR 2016 FORD EXPLORER WITH ONLY 50K MILES STARTED TO HAVE VERY STICKY STEERING AND IT WOULD MAKE SOME CLUNKING NOISES WHEN TURNING. THIS PROGRESSIVELY GOT WORSE WHILE MY PREGNANT WIFE USED THE SUV AS A DAILY DRIVE UNTIL ONE DAY SHE SAID SHE NEARLY LOST CONTROL OF THE FORD AND HAD TO SWERVE OFF THE ROAD TO AVOID HITTING ONCOMING TRAFFIC. WE TOOK THE VEHICLE INTO HAROLD ZEIGLER FORD IN LOWELL, MI AND THEY SAID THAT THE ELECTRONIC STEERING GEAR HAD GONE BAD AND NEEDED TO BE REPLACED. THAT MEANS REPLACING THE ENTIRE STEERING ASSEMBLY WHICH IS A $2,200+ REPAIR. THAT IS WAY TO SERIOUS OF A REPAIR TO HAPPEN SO OFTEN AND THIS EARLY. BASED ON THE MANY SIMILAR ISSUES I HAVE READ ABOUT REGARDING THIS ISSUE AND THE FACT THAT FORD ALREADY HAD A SIMILAR RECALL FOR EARLIER YEARS OF THE EXPLORER, THIS NEEDS TO BE RECALLED. SOMEONE WILL GET HURT AND FORD IS JUST TRYING TO SAVE MONEY BY NOT ADDRESSING IT. THE WORST PART IS THAT THERE SEEMS TO BE NO GUARANTEE THAT IT WON'T HAPPEN AGAIN IN 50K MORE MILES.

EXHAUST IS GETTING INTO THE CAB OF VEHICLE WHEN UNDER MODERATE ACCELERATION TO PASS VEHICLES AND WHEN THE WINDOW OR WINDOWS ARE OPEN IT IS EVEN WORSE.

WHILE DRIVING AT 75 MPH THE VEHICLE EXPERIENCED A LOSS OF POWER STEERING, THE WHEEL JERKED AND I ALMOST RAN OFF THE ROAD. THEN THE STEERING MADE GRINDING NOISES. THE DEALERSHIP WANTS $1500 FOR THE PART AND JUST AS MUCH OR MORE FOR THE LABOR, NOT COVERED UNDER WARRANTY AND THE VEHICLE ONLY HAS APPROXIMATELY 77000 MILES ON IT.

THE RACK & PINION MOTOR FAILED ON THIS VEHICLE AFTER ONLY APPROXIMATELY 40,000 MILES. IN THIS INSTANCE IT DID NOT CAUSE AN ACCIDENT. HOWEVER, I UNDERSTAND THAT THESE MOTORS ARE FAILING AT A RELATIVELY HIGH RATE AND STEERING COULD LOCK UP IN THESE VEHICLES WHILE DRIVING.

THIS TRUCK HAS HAD ISSUES SINCE I BOUGHT IT LIKE 5 MONTHS AGO FROM CARMAX WITHIN THAT TIME I REALLY ONLY HAD IT A MONTH REST OF TIME IT HAS BEEN IN THE SHOP I BOUGHT WITH 26K MILES FROM CARMAX ALREADY HAD REBUILT ENGINE BREAKS ROADERS STILL HAVE ENGINE ISSUES NOW TODAY BELT BROKE AND NEEDS TO BE TOWED I SHOULD NOT HAVE TO HAVE DO MANY ISSUES WITH A NEW TRUCK NOT MENTION IF YOU DO NOT SHUT THE TRUNK HARD IT WILL DRAIN THE BATTERY SINCE IT KEEPS THE LIGHTS ON IN THE TRUCK ALREADY HAD TO REPLACE THE BATTERY. THIS TRUCK HAS BEEN A LEMON SINCE DAY ONE AND SHOULD HAVE NEVER BEEN SOLD I FEEL THIS TRUCK IS NOT RELIABLE AND UNSAFE AT TIMES. NOT WORTH THE 26000 I PAID FOR IT. PLUS THE SENSORS GO OFF FOR NO REASON AND NOTHING IS AROUND.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT AT START-UP OR WHILE DRIVING AND ATTEMPTING TO TURN IN EITHER DIRECTION, THERE WAS AN ABNORMAL KNOCKING SOUND COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO BOZARD FORD LINCOLN (540 OUTLET MALL BLVD, ST. AUGUSTINE, FL 32084, (904) 824-1641) TO BE DIAGNOSED. THE STRUT TOWER AND STEERING GEAR NEEDED TO REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED HOWEVER, NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE 78,105.

I HAVE A 2016 FORD EXPLORER PLATINUM AND I TOOK THE CAR INTO THE FORD DEALERSHIP WITH AROUND 40-45,000 MILES BC THE AIRBAG LIGHT HAD CAME ON. TURNS OUT I WOULD HAVE TO PAY OUT OF POCKET FOR THE FIX BC ITS NOT A RECALL EVEN WITH IT BEING STILL UNDER WARRANTY. AS I HAVE LOOKED MORE AND MORE INTO THIS IT REALLY NEEDS TO BE ONE. BECAUSE ITS OUT NOW, ALL MY AIRBAGS WILL NOT DEPLOY IF SOMETHING WAS TO HAPPEN I HAVE 3 KIDS (NIGHTMARE TO THINK IF SOMETHING DID). I HAVE SEEN 100'S WITH THE SAME PROBLEM. ITS A MATTER OF TIME BEFORE SOMEONE SUES FORD WITH THIS MANY COMPLAINTS ON JUST THIS ALONE. WHEN PEOPLE ASK ME ABOUT GETTING A FORD I TURN THEM AWAY AND SHOW THEM HOW MUCH I HAVE SPENT ON REPAIRS AND ETC. AND THEY ALL END UP WITH SOMETHING ELSE. THIS NEEDS TO BE FIXED.!!

PLASTIC ROOF RACK TOP CAPS ARE POORLY AFFIXED AND CAME LOOSE ON HIGHWAY AND BLEW OFF THE VEHICLE. THIS PRESENTS HAZARDOUS ROAD CONDITIONS FOR DRIVERS AND PEDESTRIANS. AFTER THE INCIDENT, I RESEARCHED AND FOUND THAT THIS IS A WELL DOCUMENTED ISSUE WITH THIS GENERATION OF FORD EXPLORER.

OUR 2016 FORD EXPLORER WITH 44K MILES IS MAKING KNOCKING SOUNDS WHILE TURNING. THE SOUND WAS INTERMITTENT AT TIMES SO NOT ALL TURNS MADE THE KNOCKING SOUND.WE HAD IT LOOKED AT BY A MECHANIC AND HE SAID THE RACK AND PINION STEERING IS GOING OUT. HE EXPLAINED IN MORE DETAIL, BUT THE GIST OF IT IS A REPAIR COST OF $2K ON A VEHICLE THAT'S NOT PAID OFF AND EXTREME HAZARD TO DRIVE. THIS IS A CRITICAL CONCERN FOR MANY FORD EXPLORER OWNERS THAT HAVE REPORTED THE SAME ISSUE. PLEASE INVESTIGATE.

STEERING FAULT LIGHT CAME ON TWICE IN TWO DAYS, BOTH INSTANCES HAPPENED AFTER TAKING OFF FROM A STOPLIGHT. TOOK THE VEHICLE IN THE DEALERSHIP WHERE THEY READ THE CODES AND IT CAME BACK THE STEERING ASSEMBLY WAS FAILING. THEY PROCEEDED TO TELL ME THAT THE STEERING COULD GO OUT ANY MINUTE. THE VEHICLE ONLY HAS 57K MILES ON IT BUT OF COURSE ISN'T COVERED UNDER POWER TRAIN WARRANTY. AFTER GOOGLING THE ISSUE, IT SEEMS AS THOUGH THIS IS A VERY COMMON PROBLEM AND THE DEALERSHIP CONVENIENTLY HAD THE A STEERING ASSEMBLY IN STOCK. NOT SURE WHAT THE HOLD UP IS FOR FORD TO ISSUE A RECALL! THIS COULD KILL SOMEONE.

WE OWN A 2016 FORD EXPLORER, AND HAVING MAJOR ISSUE WITH STEERING ASSIST FAULT SERVICE REQUIRED. WHICH MEANS NEW RACK SYSTEM AT $2,100 +. I'VE READ SO MANY OTHER PEOPLE WITH SAME PROBLEM, AND EVEN WITH PAST EXPLORERS WITH RECALLS. WHY HAS FORD NOT RECALLED THIS PROBLEM AS THEY DID WITH PAST EXPLORERS?? IT'S A DEATH TRAP, AND YOU WILL LIKELY WRECK WHEN THIS HAPPENS. I'M THE LUCKY ONE THIS TIME..

AIRBAG WARNING LIGHT INDICATOR CAME ON. FORD DEALERSHIP (SOUND FORD RENTON,WA) PERFORMED $150 DIAGNOSTIC WHICH PRODUCE CODE STORED IN RCM "B141B" FOR 2ND ROW DRIVER SIDE INFLATABLE SEAT BELT DEPLOYMENT CONTROL USING OASIS THE DEALER FOUND TSB 16--0001. THIS SERVICE BULLETIN REPLACES THE CONNECTORS FOR THE LEFT AND RIGHT SECOND ROW SEATING AIRBAG CONTROL AND RE-ROUTES HARNESS. VEHICLE HAS 45,319 MILES (BELOW THE 5YR/60,000 SRS WARRANTY) HOWEVER DEALER CLAIMS REPAIR IS OUT OF POCKET. DEALER ALSO STATED WHEN THE AIRBAG LIGHT IS ON NO AIRBAGS WILL DEPLOY IN EVENT OF ACCIDENT.

WHILE OPERATING THE VEHICLE WE NOTICED OVERTIME A CLICKING NOISE COMING FROM THE FRONT OF THE VEHICLE AS WE DROVE DOWN THE ROAD MAKING TURNS AND BACKING UP OUT OF A PARKING SPACE. WE HAVE READ ABOUT INSTANCES OF PEOPLE EXPERIENCING A PROBLEM DRIVING AND TRYING TO STEER THE CAR AND IT LOCKING PREVENTING STEERING OF THE VEHICLE. THIS HAPPENED TEMPORARILY TO US SO I AM REPORTING IT AS IT CAN BE WORSE DOWN THE ROAD AS A SAFETY HAZARD TO US AND OTHER PEOPLE ON THE ROAD. THE VEHICLE ONLY HAS 40,000 MILES AND SHOULD NOT BE EXPERIENCING THESE TYPES OF ISSUES SO EARLY AND OWNERSHIP. WE DRIVE THE VEHICLE LESS THAN 10000 MILES PER YEAR.

WHILE SITTING AT A STOP LIGHT MULTIPLE WARNING SENSORS WENT OFF AND WE LOST ALL POWER STEERING ONCE WE STARTED TO ACCELERATE THE CAR. WE TOOK THE CAR TO OUR MECHANIC WHO SAID THAT THE ENTIRE RACK AND PINION NEEDED TO BE REPLACED. THIS CAR HAS 53K MILES ON IT. I HAVE TWO SMALL CHILDREN AND HAD THIS HAPPENED ON A BUSY ROAD, IT WOULD HAVE PUT ALL OF US IN EXTREME DANGER. THERE WAS NO PREVIOUS WARNINGS, IT JUST WENT.

THIS IS A POLICE VEHICLE AND WHILE RESPONDING TO AN EMERGENCY CALL, THE STEERING FAULTED WITH A STEERING FAULT WARNING ON THE DASH. THE STEERING WHEEL LOCKED WITH VERY LITTLE CONTROL OF THE VEHICLE. THANKFULLY I WAS ABLE TO PLACE THE VEHICLE IN NEUTRAL AND SHUT DOWN AND RESTART THE VEHICLE AS I WAS ON A STRAIGHT AWAY! THIS RESET THE COMPUTER AND STEERING RETURNED. IT HAS HAPPENED AGAIN SINCE THIS OCCURRED, THIS IS GOING TO KILL SOMEONE!

REAR AIRBAG SEATBELT FEATURE MALFUNCTIONS BY TRIGGERING AIRBAG WARNING LIGHT ON DASH BOARD. OBD DIAGNOSTIC PRODUCES NO ERROR CODES. WARNING LIGHT IS INTERMITTENT AND MOST COMMON AFTER REAR PASSENGERS USE SEAT BELTS.

GETTING VERY HEAVY FUMES OF EXHAUST INSIDE THE CAB. SMELLS LIKE EXHAUST OR THE CATALYTIC CONVERTERS. WHILE IN MOTION AND THEN WHEN GETTING BACK IN THE VEHICLE ANY TIME LATER. DOES NOT MATTER WHERE IT WAS DRIVEN. *TR

THE ENTIRE TRANSMISSION HAS TO BE REPLACED. THE TRANSMISSION STARTED WITH A WEIRD NOISE, SLOW ACCELERATION DESPITE A RACING ENGINE AND THEN TOTAL FAILURE. THE EXPLORER ONLY HAS ABOUT 60,000 MILES.

WHILE DRIVING ON THE HIGHWAY (65 MPH SPEED LIMIT) MY POWER STEERING SUDDENLY STOPPED WORKING. AT THE HIGH SPEEDS I HAD VERY LITTLE CONTROL OF STEERING. I WOULD TURN THE CAR OFF & THE POWER STEERING WOULD COME BACK, THEN A FEW MINUTES LATER WOULD GO OUT AGAIN UNTIL THE POWER STEERING NO LONGER WORKED. HAD TO HAVE IT TAKEN TO THE GARAGE WHERE THEY SAID THE ENTIRE STEERING RACK NEEDS TO BE REPLACED. THIS IS OVER $2100 REPAIR ON A FAIRLY NEW VEHICLE AND SHOULD NEVER HAPPEN. THE GENTLEMAN AT THE GARAGE ALLUDED TO IT BEING A DEFECTIVE PART BUT FORD CUSTOMER SERVICE WILL DO NOTHING ABOUT IT. IT IS 100% ON ME TO GET REPAIRED. IT WAS VERY SCARY & LUCKY NO ACCIDENT OCCURRED WITH THE SUDDEN LOSS OF STEERING ABILITY. IT IS CURRENTLY AT THE GARAGE WAITING FOR THE PART TO BE SHIPPED. *TR

OUR STEERING WHEEL LOCKED UP WHILE TURNING IN AN INTERSECTION. THERE WAS ALSO A KNOCKING NOISE WHEN WE WOULD TURN THE WHEEL TO THE RIGHT. WHEN WE TOOK IT TO THE FORD DEALER THEY SAID THAT THE STEERING GEAR HAD GONE BAD AND WAS MOST LIKELY CAUSED BY A LEAK IN THE POWER TRANSFER UNIT OF POWER TRANSFER FLUID. THE SERVICE TECHNICIAN INDICATED THAT THERE WAS NOTHING THAT WE DID AS DRIVERS TO CAUSE THE PTU TO LEAK. WE HAVE SEEN MANY REPORTS ABOUT THE STEERING GEAR PROBLEMS IN THE YEAR AND MODEL OF OUR VEHICLE. THE COST TO REPAIR THE STEERING GEAR AND THE LEAK WAS OVER $5000.00.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT 30 MPH, THE STEERING WHEEL CEASED WITH THE TRAC CONTROL WARNING LIGHT ILLUMINATED. THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE CONTACT DROVE THE VEHICLE TO HER RESIDENCE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED OR REPAIRED. AN AUTHORIZED DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE HOWEVER, INFORMED THE CONTACT THAT THE VIN WAS NOT SUBJECTED TO A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 81,000.

6/21/20 - STOPPED FOR GAS AFTER DRIVING APPROXIMATELY 150 MILES ON THE INTERSTATE. CRANKED CAR AND STEERING WOULD NOT WORK. DASH NOTICES: STEERING ASSIST FAULT SERVICE REQUIRED; SERVICE ADVANCETRAC; HILL START ASSIST NOT AVAILABLE; TRACTION LIGHT SHOWING OFF. DROVE CAR HOME WITH NO POWER STEERING. CALLED SELLING DEALERSHIP AND WAS TOLD PROBABLY COST AROUND $2000 TO REPAIR. SEARCHED ON LINE AND FOUND HUNDREDS OF COMPLAINTS ABOUT THIS BUT NO RECALL FROM FORD. PURCHASED NEW AND NOW HAS ONLY 61K MILES. RIDICULOUS! *TR

SATURDAY JUNE 20TH 2020 THE HILL ASSIST MESSAGE CAME ON AS DID THE ABS AND TRACTION CONTROL LIGHTS CAME ON. THERE IS NO POWER STEERING AND BOTH AXLES ARE MAKING A CLICKING NOISE. I HAVE LEARNED THAT THIS IS THE RACK AND PINION ELECTRONIC POWER ASSIST SYSTEM. EPAS UNIT HAS FAILED. LUCKILY IT WAS IN MY CUL DE SAC TURNING AROUND AND NOT ON THE FREEWAY. MY WIFE PREDOMINANTLY DRIVES THIS VEHICLE. THE STEERING IS VERY DIFFICULT TO MOVE. THE VEHICLE ONLY HAS 64,000 MILES ON IT. IS THIS A PRIVATE RECALL? I HAVE SPOKEN WITH A COUPLE OF OTHER EXPLORER OWNERS THAT FORD "TOOK CARE OF IT" FOR THEM. I HAVE ORDERED THE PART, BUT IT WILL NOT BE THERE FOR A WEEK. THIS CAR IS WELL TAKEN CARE OF AND IS NORMALLY DRIVEN ON CITY STREETS AND OCCASIONALLY ON THE HIGHWAY. *TR

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING 35 MPH, THE TRACTION CONTROL WARNING LIGHT WAS ILLUMINATED. THE CONTACT STATED THAT RECENTLY WHILE DRIVING AT 75 MPH, WHEN SHE HEARD AN ABNORMAL NOISE AND "TRANSMISSION NOT IN PARK" WARNING MESSAGE WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO MADISON FORD LOCATED AT 2895 S. SEMINOLE TRAIL, MADISON, VA 22727, (540) 948-6806, WHERE THE MECHANIC WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS INFORMED THAT THE THROTTLE BODY NEEDED TO BE REPLACED. THE MANUFACTURER WAS INFORMED OF FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

I STARTED HEARING A KNOCKING IN THE FRONT END AND THE STEERING WAS VERY LOOSE, WHEN I TURNED RIGHT AT FIRST AND ON OCCASION TO THE LEFT MECHANIC SAID IF I HAD GONE MUCH FURTHER IT WOULD HAVE BROKEN ALL THE WAY AND I WOULD HAVE LOST ALL CONTROL OF THE SUV. *TR

I WOULD LIKE TO SHARE MY FORD EXPERIENCE WITH MY 2016 FORD EXPLORER LIMITED EDITION THAT WAS BOUGHT FROM HIGLEY FORD. AT 64,000 MILES... YES 4,000 OVER MY WARRANTY MY COMPUTER MODULE FRIED AND I HAD TO REPLACE THAT... $1500 OUT OF MY POCKET... THEN LAST SUMMER MY AC QUIT WORKING FOLLOWED BY MY DRIVERS SIDE SEAT HEATER AND MIRROR ON MY VISOR... THEN HERE RECENTLY I COULD SMELL SOMETHING LIKE BURNT RUBBER AND FOUND OUT SOME SEAL POPPED OFF SO OIL WAS LEAKING.... WHICH IS IN A SPOT THAT YOU CAN'T GET TO UNLESS YOU TAKE THINGS APART...THEN NOW JUST FOUND OUT MY RACK AND PINION WENT OUT... THE STEERING (PART ALONE COSTS $1500)!!! I WAS TOLD I SHOULD HAVE BOUGHT THE EXTENDED WARRANTY AND THAT WAS ALL I GOT. REALLY!!!!!!! ESPECIALLY THE RACK AND PINION! HOW THE HELL DOES THAT GO OUT...I'M A NIGHT NURSE THAT DRIVES TO WORK AND BACK AND THAT'S ABOUT ALL! I'VE NEVER BEEN IN AN ACCIDENT, IN THE DITCH AND I DON'T TEAR AROUND IN MY CAR. I CAN UNDERSTAND MAYBE A COMPUTER THING HAPPENING BECAUSE WELL... COMPUTERS ARE COMPUTERS... BUT ALL OF THOSE THINGS GOING WRONG WITH 1 VEHICLE! AND IT'S SUPPOSED TO BE A NICE VEHICLE!!! LET ME JUST SAY... I FEEL VERY SCREWED. *TR

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE AIR BAGS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE AIR BAGS WIRING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED THREE TIMES. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED FOR THE MOST RECENT FAILURE. THE FAILURE MILEAGE WAS 52,000. *LN CONSUMER STATED THE FIRST TIME MECHANIC TIGHTENED THE CONNECTORS SECOND TIME THE HARNESS WAS REPLACED AND THE THIRD TIME MECHANIC SAYS HARNESS NEEDED TO BE REPLACED AGAIN AND THE CONSUMER NEEDS TO FOOT THE BILL EVEN THOUGH IT IS WITHIN WARRANTY PERIOD.*JB

I WAS DRIVING MY 2016 FORD EXPLORER ON MY LAST LEFT TURN TO MY HOUSE THE VEHICLE'S POWER STEERING COMPLETELY LOCKED UP I WASN'T ABLE TO STEER MY VEHICLE I HAD TO PUSH THE SUV BACK TO THE HOUSE.THERE WAS 3 LIGHTS CAME ON COME ON THE DASH BOARD WITH THESE MESSAGES.. 1 HILL START ASSIST NOT AVAILABLE..(I DON'T THINK THAT ITS EQUIPPED WITH THIS FUTURE) PRESS THE OK BOTTOM.SECOND LIGHT.. SERVICE ADVANCE TRACK THIRD LIGHT..STEERING ASSIST FAULT SERVICE REQUIRED.CANT DRIVE THE VEHICLE ANY MORE. NOW THERE ARE 203 COMPLAINS JUST ON STEERING MOST ARE ALL ABOUT STEERING WHEEL LOCKING UP.THIS IS SOMETHING WAY SERIOUS MOST OF THIS SUV'S ARE THE WIFE CAR ALWAYS PACK WITH CHILDREN. THE NHTSA AND FORD SHOULD REALLY LOOK N TO THIS JUST BEFORE ONE OF OUR LOVE ONES IS DRIVING ON THE FREEWAY AT 75 MPH AND IT LOCKS ON THEM IT WOULD BE A TERRIBLE ACCIDENT.NOW IF THE NHTSA AND FORD KNOWS ABOUT THIS PROBLEM THEY SHOULD BE HELD RESPONSIBLE FOR LOST AND OR DAMAGE THAT MY OCCUR.IF THIS WAS SOMETHING SMALL AND CHEAP TO FIX THE OWNERS OF THIS SUV WOULD PROBABLY FIX IT BUT WE ARE TALKING ABOUT $2300-$3000 DOLLARS. WE ARE TALKING ABOUT 4 YEAR OLD SUV WITH THIS KIND OF A PROBLEM ITS A $18000 SUV.. ITS IS A PROBLEM THAT FORD WITH NO HESITATION SHOULD BE FIXING....PEOPLE PLEASE UPLOAD YOUR PROBLEMS LET THEM KNOW WE ARE THE CONSUMER THEY ARE WHO THEY ARE BECAUSE WE BUY FROM THEM THEY SHOULD BE MORE RESPONSIBLE. *TR

THE 2016 EXPLORER EXPERIENCED A CLUCKING SOUND AND THE STEERING WOULD HITCH WHILE TURNING AT APPROX 50K MILES. VEHICLE WAS TAKEN TO DEALER BUT DEALER COULD NOT RECREATE. AT 60K MILES THERE WAS A CONSTANT CLUNKING AND STEERING STICKING WHILE TURNING THE WHEEL. VEHICLE WAS RETURNED TO DEALER FOR REVIEW, DEALER CONFIRMED THE RACK AND PINION WAS FAILING AND WAS A MAJOR SAFETY ISSUE. DEALER ALSO CONFIRMED THEY HAVE TO REPLACE MANY RACK AND PINIONS FOR EXPLORERS AND IT IS A PROBLEM BUT HEY CAN ONLY DO WHAT FORD INSTRUCTS. AFTER REVIEW ON THE NHTSA.GOV SITE, THERE ARE OVER 200 COMPLAINTS FOR THE SAME ISSUE WITH THE RACK AND PINION SYSTEM THAT OCCURS FROM 30K TO 60K MILES. THIS IS AN ISSUE THAT IS NOT BEING DEALT WITH BY THE MANUFACTURER AND NEEDS TO BE ADDRESSED SINCE MOST OF THESE VEHICLES ARE NOW HITTING THIS MILEAGE RANGE. *TR

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE POWER STEERING ELECTRONIC CONTROL MODULE FAILED ON SEVERAL OCCASIONS WHILE DRIVING AND ATTEMPTING TO STEER THE VEHICLE IN EITHER DIRECTION. THE VEHICLE WAS TAKEN TO MITCHELL SELIG FORD (801 BLOOMFIELD AVE, WINDSOR, CT 06095, (860)688-3651), WHERE THE POWER STEERING RACK WAS REPLACED AT THE OWNER'S EXPENSE FOR $2,200. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND A CASE WAS FILED. THE FAILURE MILEAGE WAS 81,000.*DT*JB

VERY SOON AFTER ACCELERATING ANYWHERE NEAR FULL THROTTLE WE SMELL A BURNING TYPE EMISSIONS SMELL WITHIN THE CABIN OF THE VEHICLE. IT IS MOST NOTICEABLE IN THE BACKSEATS BUT IS ALARMING ENOUGH TO WHERE WE NEED TO OPEN THE WINDOWS EVERY TIME WE NEED TO ACCELERATE QUICKLY. *TR

AT ABOUT 60,000 THE STEERING STARTED CATCHING. AT ANY SPEED THIS HAPPENED. IT WOULD FEEL LIKE THE TIRES WERE IN A RUT, THEN ALL OF A SUDDEN IT WOULD BREAK FREE, AND THE VEHICLE WOULD SUDDENLY SWERVE OVER ABOUT A FOOT. IT HAS GONE ON TO A GRINDING NOISE. VERY UNNERVING TO DRIVE AT HIGHWAY SPEED! FORD TELLS ME THE STEERING RACK IS BAD, AND SINCE IT'S OUT OF WARRANTY, THEY WILL NOT COVER REPAIRS. I'VE OWNED QUITE A FEW NON-FORD VEHICLES WITH OVER 150,000 MILES AND NEVER HAD A STEERING ISSUE WITH THEM. *TR

/EMPLOYEE STARTED THE CAR TO WARM IT UP AND THE BACK WINDOW EXPLODED. HAD TO HAVE BACK WINDOW REPLACED. VEHICLE HAD BEEN PARKED OVERNIGHT IN HIS DRIVEWAY. *TR

EMPLOYEE WAS DRIVING HOME FROM WORK. HE HAD WARMED UP HIS CAR BEFORE DRIVING ABOUT 10 MINUTES. ALL OF A SUDDEN HIS BACK WINDOW EXPLODED. WEATHER WAS COLDER. FOUND ONLINE THAT THERE WAS A PROBLEM WITH FORD'S WINDOWS HAVING ISSUES WITH WINDOWS GETTING TOO HOT AND THEN POPPING WHEN THE COLD AIR SURROUNDED IT.. *TR

STEERING BECOMES STUCK WHILE MAKING A RIGHT OR LEFT TURN. THIS HAPPENED ON A STOP LIGHT WHILE TURNING. IT ALSO HAS A SLIDING/GRINDING FEEL WHEN TURNING THE WHEEL WHILE IN IDLE. ISSUE SEEMS TO BE A MANUFACTURING PROBLEM WITH FORD VEHICLES THAT HAVE THE ELECTRONIC STEERING WHEEL SYSTEM. *TR

I WENT TO PULL OUT OF MY DRIVEWAY AND MY VEHICLE'S POWER STEERING COMPLETELY LOCKED UP AND I WAS UNABLE TO STEER MY VEHICLE. I MANAGED TO AT LEAST BACK IT STRAIGHT BACK INTO MY DRIVEWAY TO BE OUT OF THE ROAD, AND CALLED THE CLOSEST FORD DEALERSHIP TO ME. I HAD 3 LIGHTS COME ON MY DASH WITH THESE MESSAGES; HILLSTART ASSIST NOT AVAILABLE, SERVICE ADVANCETRAC, AND STEERING ASSIST FAULT SERVICE REQUIRED. MY VEHICLE HAD TO BE TOWED TO THE DEALERSHIP, AND THE ENTIRE POWER STEERING HAS TO BE REPLACED, WHICH THE REPAIR COSTS $2300 TO FIX. IF I WOULD HAVE BEEN MOVING AT A FASTER SPEED THIS COULD HAVE BEEN A MUCH WORSE STORY, BECAUSE WHEN THE STEERING LOCKED UP YOU COULD NOT TURN THE STEERING WHEEL AT ALL. I HAVE FILED A COMPLAINT WITH FORD DIRECTLY, AND THEY HAVE SAID THERE IS NOTHING THEY CAN DO, BUT THIS IS A KNOWN PROBLEM AND A LOT OF OTHERS HAVE HAD THE EXACT SAME ISSUE WITH THEIR VEHICLE. BUT YET THEY REFUSE TO ISSUE A RECALL ON THIS. *TR

THE RACK & PINION STEERING BROKE AND FORD IS REFUSING TO INCLUDE IT IN THE RECALL THEY HAVE ON THIS EXACT PROBLEM. *TR

2016 EXPLORER XLT WITH 70K MILES AND THE POWER STEERING STARTED TO FAIL REQUIRING THE STEERING RACK AND PINION TO BE REPLACED. SYMPTOM INCLUDED STICKING AND UNPREDICTABLE STEERING WHILE STOPPED AND AT ALL DRIVING SPEEDS AND CONDITIONS. *TR

AIRBAG LIGHT COMES ON - WHEN LIGHT IS ON AIRBAGS DO NOT DEPLOY IN CASE OF AN ACCIDENT. TOOK TO DEALER TOLD WIRING HARNESS UNDER BACK SEATS NEED REPLACED, NOT COVERED UNDER WARRANTY. THIS IS AN ISSUE WITH MORE THAN JUST MY VEHICLE. THERE IS A FIX AND SHOULD BE A RECALL. *TR

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT HE HAD HANKOOK TIRES WHEN HE BOUGHT THE VEHICLE NEW. THE TIRE LINE, TIRE SIZE AND DOT NUMBER WERE UNKNOWN. THE TIRES WERE BALD BY THE TIME THE VEHICLE HAD 11,000 MILES. THE DEALER STATED THAT IT WAS NOT THEIR ISSUE AND TO CALL THE TIRE MANUFACTURER. THE TIRE MANUFACTURER DECIDED TO AWARD THE CONTACT WITH A 20% CREDIT TO BUY SOME NEW TIRES. THE NEW TIRES WERE PLACED ON THE VEHICLE AND THEY WERE ALMOST BALD AT 34,000 MILES. THE MANUFACTURER ADVISED THE CONTACT TO RECALL THE DEALER COGSWELL FORD LOCATED AT 1900 E MAIN ST, RUSSELLVILLE, AR 72801 479-968-2665. THE DEALER HAD NOT BEEN RECONTACTED YET. THE CONTACT RESEARCHED AND FOUND THE ISSUE HAD OCCURRED IN MANY FORD EXPLORERS. THE FAILURE MILEAGE WAS 11,000.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT THE STEERING ASSIST, HILL ASSIST AND TRACTION CONTROL WARNING LIGHTS ILLUMINATED. THE CONTACT ALSO STATED THAT THERE WAS AN AUDIBLE SOUND IN THE VEHICLE. THE VEHICLE LOSS POWER STEERING ASSIST AND THE VEHICLE BECAME DIFFICULT TO STEER. THE CONTACT DROVE SLOWLY TO THE RESIDENCE. A DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS INFORMED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT SUBJECTED TO A RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 88,000. *BF CONSUMER STATED STEERING WHEEL WAS STUCK AND COULD NOT TURN AT ALL.*JB

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE PULLED TO THE RIGHT WITH AN ABNORMAL CLUNKING SOUND COMING FROM THE STEERING COLUMN. THE CAUSE OF THE FAILURE WAS NOT YET DETERMINED. THE VEHICLE WAS NOT REPAIRED. FREEDOM FORD (3941 ADMIRAL PEARY HWY, EBENSBERG, PA 15931, (800)215-0042 AND THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 36,000.

AFTER GETTING MY AIRBAG RECALL TAKEN CARE OF I NOTICED THE STEERING STARTED GETTING TIGHT MORE AND MORE AFTER 2 DAYS IT WAS REALLY TIGHT UNTIL IT RAINED AND IT GOT LOOSE AGAIN BUT THE STREET LINE SENSORS AND THE RUMBLE STOPPED WORKING. ONE DAY AFTER THE RAIN DRIED THE WHEEL TIGHTEN UP AGAIN WHERE I CAN BARELY TURN IT. I ASK FORD ABOUT IT AND THEY SAID I HAD TO GET A DIAGNOSTIC FOR $179 TO DETERMINE WHAT WAS WRONG. ALSO HAVE A PROBLEM WITH THE EMISSIONS PASSING BECAUSE THE AIR FILTER SENSOR IS NOT WORKING. TRYING TO GET AN OUTSIDE MECHANIC . FORD IS A RIPOFF.

I WAS DRIVING UP A HILL WHEN THE VEHICLE LURCHED FORWARD AND THEN LOST POWER. I WAS ABLE TO JUST MAKE IT TO THE TOP OF THE HILL. I PULLED OVER PUT IT PARK AND THEN PUT IT IN DRIVE AND WAS ABLE DRIVE HOME. HOWEVER, NOW THE CAR HAS NO REVERSE. A TRANSMISSION REBUILD/REPLACEMENT NEEDED.

STEERING BECAME DIFFICULT FOR TURNING AND REVERSING IN TO MY DRIVEWAY. I WAS DRIVING ON MAJOR HIGHWAY AND ABLE TO FORTUNATELY GET OFF AND RETURN HOME. BUT WHEN I GOT IN MY CAR A FEW DAYS LATER TO TAKE IT TO AUTOSHOP, THE STEERING WHEEL DID NOT MOVE AT ALL AND SO HAD TO HAVE MY CAR TOWED

I GOT INTO MY CAR ONE MORNING AND THE CAR MADE A TERRIBLE SOUND WHEN TURNING THE STEERING WHEEL LEFT TO RIGHT. THE STEERING ALSO WANTS TO STICK WHEN GOING AROUND A TURN. I TOOK IT TO A FORD DEALERSHIP WHERE THE SAID THE RACK AND PINION WAS GOING BAD AND IS COMMON IN MY YEAR OF CAR AND MILEAGE. THEY SAID AT ANY POINT MY CAR STEERING COULD COMPLETELY BE LOST. HOW DANGEROUS ESPECIALLY WHEN DRIVING WITH A TODDLER?!?!

MY FAMILY AND I WERE AT A A GAS STATION ABOUT TO GET ON THE FREEWAY WHEN MY FORD EXPLORER STARTED TO STALL. I PULLED TO THE SIDE AND TURNED IT OFF AND BACK ON. THIS ACTION SEEMED TO FIX THE PROBLEM; HOWEVER, AFTER THAT DAY (4 MONTHS AGO) THE FORD EXPLORER HAS BEEN STALLING EVERY TIME I START IT AND START TO PULL OUT OF MY DRIVE WAY. IT WILL LOSE SPEED WHEN I TRY TO ACCELERATE AND WILL STALL FOR THE FIRST MINUTE OR SO BEFORE RESUMING BACK TO NORMALS I AM NOW AFRAID TO DRIVE THIS VEHICLE WITH MY FAMILY AS IT DOES NOT FEEL SAFE AT ALL. ADDITIONALLY, AFTER STALLING I WILL GET THE WRENCH SYMBOL ON MY DASH.

STEERING MAKES A POPPING SOUND WHILE TURNING THE WHEEL AT SLOWER SPEEDS. THIS IS CONTRIBUTING TO THE STEERING SLIPPING WHILE DRIVING. THE EXPLORER HAS 53000 MILES ON IT. OUT OF POCKET AT A COST OF $2,200 TO $2,500 DOLLARS FOR A PREMATURE FAILURE OF STEERING SYSTEM COMPONENTS. THESE PREMATURE/DEFECTIVE STEERING PROBLEMS CAN LEAD TO DEATHS OR SERIOUS INJURIES WHILE DRIVING.

DRIVERS SEAT ROCKS LIKE IT IS LOOSE

THE STEERING MAKES POPPING AND GRINDING NOISE WHEN TURNING LEFT OR RIGHT. ALSO AT TIMES THE STEERING IS HARD, THERE IS RESISTANCE . I HAVE TO USE TWO HANDS FORCE-ABLY TO TURN. AT FIST I THOUGHT THIS WAS AN ISOLATED INDECENT BUT REALIZE ITS GETTING WORSE OVER TIME. WAS ROUGHLY AROUND 65,000 MILES WHEN I FIRST NOTICED POPPING NOISE.THE VEHICLE HAS APPROXIMATELY 80,165 MILES ON IT. THE MAJORITY IS HIGHWAY MILES.

WHEN SITTING IDLE AND STATIONARY, A STRONG ODOR OF ROTTEN EGGS/EXHAUST ENTER THE CABIN THROUGH THE AIR VENTS. THE CAR CONTINUES TO HAVE A STRONG ODOR AFTER BEING TURNED OFF. THE ODOR WAS SO STRONG OUTSIDE THE VEHICLE THAT WE HAD TO PARK IT FAR AWAY FROM THE HOUSE BECAUSE THE SMELL WAS COMING INTO THE HOUSE THROUGH THE GARAGE. AFTER TAKING THE CAR TO THE FORD DEALERSHIP AND THEM TELLING US IT WAS FIXED, I TRUSTED THAT THE VEHICLE WAS SAFE AND TOOK MY 4 YEAR OLD DAUGHTER TO THE GROCERY STORE. IMMEDIATELY AT THE FIRST STOP LIGHT AND SITTING IN IDLE, THE ODOR WAS RELEASED INTO THE CABIN OF THE CAR- NO DIFFERENT THAN PRIOR TO BEING "FIXED." WE CALLED THE DEALERSHIP AND THEY TOLD US WE HAD TO DRIVE THE SMELL OFF AND PUSH IT THROUGH THE VENTILATION SYSTEM. THE SMELL CONTINUED WITHOUT RELIEF AND I IMMEDIATELY DROVE THE VEHICLE HOME (15 MINUTE DRIVE) WITH THE WINDOWS DOWN DURING AN OHIO WINTER OF 34 DEGREES FAHRENHEIT FOR MY HUSBAND TO RETURN THE VEHICLE TO THE DEALERSHIP. UPON ARRIVING HOME, EVEN WITH THE WINDOWS DOWN I HAD A HEADACHE AND FELT NAUSEOUS. I WOULD HATE TO KNOW WHAT WOULD HAVE HAPPENED IF I CONTINUED TO DRIVE THE VEHICLE AT THE DEALERSHIP'S ADVICE. OUR VEHICLE WAS RETURNED TO US A SECOND TIME AND THE ISSUE WAS STILL UNRESOLVED. AT THIS MOMENT, OUR VEHICLE IS AT OUR LOCAL FORD DEALERSHIP WITH WHAT SEEMS LIKE NO END IN SIGHT. FORD HAS PUT US BACK INTO A FAULTY AND DANGEROUS VEHICLE TWICE NOW AND WE HAVE LITTLE TRUST OR FAITH THAT OUR FORD EXPLORER WILL BE RETURNED TO US AS A SAFE FAMILY CAR. ALSO TO NOTE, WE DID HAVE THE VEHICLE SERVICED FOR RECALL RELATED TO CARBON MONOXIDE.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH, THE VEHICLE LOSS POWER STEERING ASSIST AND THE STEERING BECAME FIRM. NO WARNING LIGHT ILLUMINATED. THE CONTACT DROVE THE VEHICLE TO THE RESIDENCE. THE CONTACT ALSO STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AFTER THE FAILURE RECURRED WITH SEVERAL ADDITIONAL UNKNOWN WARNING LIGHTS ILLUMINATED. THE CONTACT WAS REFERRED TO MOUNTAINEER FORD LOCATED AT (615 EISENHOWER DR, BECKLEY, WV 25801) AND AN UNKNOWN REPAIR WAS PERFORMED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 88,000.

ON FEBRUARY 4, 2020, MY WIFE'S 2016 FORD EXPLORER (VIN# [XXX]) HAD AN ODOMETER READING OF 29,265 MILES WHEN SHE BEGAN TO NOTICE SERIOUS SAFETY CONCERNS AFTER THE STEERING SYSTEM HAD MALFUNCTIONED WHILE TURNING AT INTERSECTIONS, DRIVEWAYS AND PARKING LOTS. DURING ONE INCIDENT, THE STEERING SYSTEM TEMPORARILY LOCKED UP AND MAKE A DISTINCT CLUNKING SOUND; IT ALMOST CAUSED MY WIFE TO HIT ANOTHER CAR DURING A LEFT HAND TURN AT AN INTERSECTION. SHE IS THE PRIMARY DRIVER OF THIS VEHICLE 99% OF THE TIME TO TRANSPORT OUR GRANDCHILDREN WHILE THE REMAINING 1% HAS INVOLVED MY COMMUTE TO WORK. OUR REYNOLDS FORD OF NORMAN DEALERSHIP FAILED TO DUPLICATE THE STEERING MALFUNCTIONS WE EXPERIENCED. THEY ALSO MADE IT KNOWN THAT OUR EXTENDED FIVE-YEAR WARRANTY WOULD NOT COVER ANY REPAIRS RELATED TO THE STEERING SYSTEM. ON MARCH 6, 2020, ACCORDING TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION HTTPS://WWW.NHTSA.GOV/VEHICLE/2016/FORD/EXPLORER/SUV/FWD, THERE WERE SEVEN RECALLS, ONE INVESTIGATION AND 918 COMPLAINTS ON THE 2016 FORD EXPLORER. OF THOSE 918 COMPLAINTS, 189 WERE RELATED TO THE SAME SAFETY RELATED STEERING PROBLEMS EXPERIENCED BY OUR VEHICLE. MANY OF THOSE 189 COMPLAINTS ALSO INDICATED THAT THE VEHICLE OWNERS HAD TO PAY OUT OF POCKET AT A COST OF $2,200 TO $2,500 DOLLARS FOR A PREMATURE FAILURE OF STEERING SYSTEM COMPONENTS. FORD NEEDS TO ACCEPT RESPONSIBLE AND OWN UP TO THEIR PREMATURE/DEFECTIVE STEERING PROBLEMS TO PREVENT DEATHS OR SERIOUS INJURIES. I SHOULD NOT HAVE TO PAY FOR DEFECTIVE/PREMATURE STEERING COMPONENTS. AT THIS POINT, I HAVE ZERO QUALITY AND SAFETY CONFIDENCE WITH MY CURRENT STEERING SYSTEM AND REPLACEMENT PARTS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE RECALLED TOE LINK ON THE REAR SUSPENSION BROKE 3 MONTHS AFTER IT WAS REPLACED AND CAUSE A CRASH WHILE DIVING DOWN THE HIGHWAY, SLOWING FOR A SPEED ZONE FOR A TOWN. INVOLVING BODY DAMAGE. AND THE VEHICLE WAS REPAIRED AND 1 WEEK AFTER GETTING IT BACK FROM THE DEALER THE LINK BROKE FOR A SECOND TIME, WHILE ON A CURVE WITH CRUISE CONTROL ON ROAD CONDITIONS WERE DRY BOTH TIMES.WE HAVE OWNED THE VEHICLE FOR 6 WEEKS TOTAL AND HAVE ONLY BEEN ABLE TO DRIVE FOR 2 OF THEM.

ADVANCETRAC AND STEERING FAULT WARNING LIGHTS CAME ON WHILE DRIVING. STEERING LOCKED UP AND BECAME EXTREMELY DIFFICULT TO SAFELY STEER OFF ROADWAY.

I BOUGHT MY CERTIFIED PREOWNED 2016 FORD EXPLORER ON OCTOBER 22 2019. I HAVE HAD IT FOR 4 MONTHS. YESTERDAY WHILE I WAS DRIVING I NOTICED WHEN SLIGHTLY VEERING TO THE RIGHT THAT THE WHEEL PULLS HARD TOWARDS THE RIGHT AND IT IT HARD TO PULL THE WHEEL BACK TO THE STRAIGHT POSITION. I TESTED THIS ON THE LEFT SIDE AND IT DOES THE SAME JUST NOT AS HARD TO PULL.

ANOTHER 2016 EXPLORER WITH AN AIRBAG MALFUNCTION. OBDII CHECK IS NOT SHOWING ANY FAULTS. I HAVEN'T TAKEN IT TO DEALER YET, BUT I AM ASSUMING IT'S THE SAME OR SIMILAR FAULT TO WHAT OTHERS ARE SEEING ON HERE AND ELSEWHERE.

HELLO TODAY AFTER DRIVING MY 2016 FORD EXPLORER ONLY DOWN THE STREET TO THE STORE IT WAS FINE I PULLED BACK UP AT MY HOUSE AND IT WAS FINE I UNLOADED MY TODDLER AND TOOK HIM INSIDE AND THEN WENT BACK AND TURNED MY SUV BACK ON TO BACK IT INTO MY DRIVEWAY AND IT MADE A REALLY LOUD HUMMING SOUND LIKE A VACUUM OR A HIGH SPEED FAN IT DIDN'T SLOW IT DIDN'T STOP IT ONLY STAYED LOUD I THEN LEFT IT PARKED ON THE STREET AND IT CONTINUED TO MAKE THE SOUND ITS BEEN 2 HOURS AND ITS STILL GOING STRONG NO KEY IN THE IGNITION OR NOTHING AND ITS STILL NO MY HUSBAND IS PULLING FUSES OUT TRYING TO GET IT TO STOP.

AIRBAG LIGHT COMES ON AND STAYS ON FOR WEEKS AT A TIME AND THEN COMES OFF. THIS TENDS TO HAPPEN WHEN IT RAINS.

RUTTEN EGGS SULFUR STRONG SMELL COMING INTO CAB DURING ACCELERATION MAKING IT IMPOSSIBLE TO BREATHE IN THE CAR. WENT TO DEALER FEW TIMES BUT THE PROBLEM STILL THERE. WHEN FORD GOING TO SOLVE THIS PROBLEM?

AIR BAG LIGHT KEEPS COMING ON. RIGHT NOW IT IS AT THE DEALERSHIP, HOPEFULLY TO BE FIXED

SEAT HEAT UNDER DRIVER SEAT KEEPS GOING BAD. ONLY THE SEAT BOTTOM, NOT THE TOP. I NOTICED AS THIS IS THE 3RD TIME IT HAS BEEN IN FOR THIS, THAT WHEN I HAVE THE SEAT IN THE FARTHEST BACK POSITION IT WORKS, BUT WHEN THE SEAT IS MOVED FURTHER IT PULLS ON THE WIRES. I WONDER IF THIS COULD BE CAUSING A SHORT IN THE WIRING, WHICH POTENTIAL COULD BE A FIRE HAZARD.

VEHICLE EMITS A STRONG EXHAUST / SULFUR SMELL WHEN ACCELERATING OR PLACING A LOAD ON THE ENGINE SUCH AS USING A/C OR DRIVING UPHILL.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING AT 5 MPH, MAKING A LEFT TURN THE STEERING WHEEL CEASED WITH THE REMOTE HILL START ASSIST NOT AVAILABLE SERVICE ADVANCE TRAC, POWER STEERING ASSIST WARNING LIGHT ILLUMINATED. THE CONTACT VEER TO THE SHOULDER OF THE ROAD PLACED THE VEHICLE IN PARK TURNED THE VEHICLE OFF AND BACK ON WHICH FAILED TO RESUME NORMAL OPERATION. THE VEHICLE WAS TOWED TO BOMMARITO FORD LOCATED AT (675 DUNN RD, HAZELWOOD, MO 63042, (314) 895-0600 WHERE A DIAGNOSTIC TEST WAS STILL PENDING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 28,000.

THE STEERING MAKES POPPING AND GRINDING NOISE WHEN TURNING LEFT OR RIGHT. HAD VEHICLE INSPECTED AT A TRUSTED GARAGE I USE, THEY SAID THAT THE RACK AND PINION WAS SHOT. THE VEHICLE HAS APPROXIMATELY 53165 MILES ON IT. THE MAJORITY IS HIGHWAY MILES.

WHILE GOING TO BACK OUT OF MY DRIVEWAY, I'M IN REVERSE AND MOVING AND GO TO TURN THE STEERING WHEEL AND IT IS LOCKED AND I GET A "HILL START ASSIST NOT AVAILABLE, SERVICE ADVANCETRAC" NOW MINE YOU THIS CAR IS ONLY 4YRS OLD WITH 25K MILES ON IT. ACCORDING TO ALL THE OTHER COMPLAI TS I'VE READ I'VE GOTTEN OFF EASY IN THE FACT I WAS IN MY OWN DRIVEWAY AND NOT DRIVING ANYWAYS WITH MY CHILDREN IN THE CAR, WHICH IS THE MAIN VEHICLE THEY WOULD BE IN. HAD TOWED TO LOCAL FORD DEALER AND TOLD ITS THE PINION IN THE STEERING COLUMN NOT COVERED UNDER MY 5YR, 60,000 MILES WARRANTY AND WILL COST $2,247 PKUS TAX TO FIX. ABSOLUTELY RIDICULOUS. 4 YEARS OLD BARELY DRIVEN AT 25K MILES TO HAVE THIS CRAZY EXPENSIVE FIX THAT I CANNOT AFFORD! WHERE IS THE RECALL ON THIS KNOWN PROBLEM? ARE WE WAITING FOR SOMEONE TO DIE? IS THAT WHAT IT TAKES? IF IT HAPPENED WHILE TAKING NY KIDS TO SCHOOL WHO KNOWS WHAT COULD HAVE HAPPENED. PLEASE DO THE RIGHT THING.

FOR A FEW MONTHS WHEN I WOULD ACCELERATE FROM A RED LIGHT OR SITTING STILL THE SMELL OF ROTTEN EGGS WOULD COME INTO MY VEHICLE. WITH ME HAVING KIDS I FIGURED IT WAS JUST THEM PASSING GAS, HOWEVER REPEATEDLY IT STARTED HAPPENING & IF THE A/C OR HEATER WAS ON IT WAS WORSE. I TOOK IT TO WORLD FORD IN PENSACOLA ON TUESDAY 02/04/2020, THEY DID NOT GET TO IT UNTIL 02/05/2020 AND THEY INFORMED ME THAT THEY HAD A DIAGNOSIS & THE WAY MY VEHICLE WAS DESIGNED THE AERODYNAMICS WERE ALLOWING THE EXHAUST FUMES TO ENTER THE CABIN. I AM ABSOLUTELY UPSET AT THIS BEING AS THOUGH NOT ONLY MYSELF, BUT MY KIDS, OTHER PASSENGERS, AND THEIR KIDS HAVE BEEN EXPOSED TO CARBON MONOXIDE IN A CLOSED IN AREA. FORD MAKES IT SOUND ACCEPTABLE BY SAYING IT'S COVERED UNDER WARRANTY HOWEVER A MANUFACTURER DEFAULT NEEDS TO BE RECALLED AND FIXED IMMEDIATELY, THIS PROBLEM COULD HAVE BEEN FATAL TO MYSELF, MY FAMILY, AND MY FRIENDS.

PLASTIC MOLDINGS ON THE RIGHT AND LEFT OF THE WINDSHIELD FLY OFF AT HIGHWAY SPEEDS AND THE WEATHERSTRIPPING SPLITS AND BANGS AGAINST THE WINDSHIELD

MY CAR WAS COMPLETELY TOTALED IN AN ACCIDENT ON 10/21/19. I RECEIVED VERY SERIOUS MULTIPLE BRAIN BLEEDS, FACIAL LAC, FACIAL & HEAD FX'S & A SEVERE TBI. MY MOM REC A CONCUSSION, FACIAL LAC CONCUSSION & A FX CLAVICLE. WE STOPPED AT THE STOP SIGN & MOVED TO THE CENTER BETWEEN THE 4 LANES & STOPPED AGAIN & WE WERE HIT BY A LARGE ROLL ON ROLL OFF ROCK CARRYING DUMP TRUCK IN THE MIDDLE OF THE LANES. THE CAR WAS COMPLETELY TOTALED & I WAS IN A COMA & AIRLIFTED TO A TRAUMA CTR APPROX 40 MINS AWAY, BUT I WAS IN RESP ARREST & NOT EXPECTED TO LIVE. IT IS UNKNOWN EXACTLY WHAT CAUSED THE UNSAFE CONDITIONS, HOWEVER I NEVER CROSS STRAIGHT ACROSS THE TRAFFIC & WE HAD BEEN ON A VERY VERY BUMPY INTERSECTION THE FRI BEFORE THE ACC ON MONDAY & THE CAR HAD NOT BEEN DRIVEN SINCE THAT 5 HR TRIP OF EXTREMELY BUMPY ROUGH ROAD CONDITIONS ON INTERSTATE 95 COMING THROUGH PART OF NC, ALL OF SC & PART OF GA.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED THAT UPON STARTUP, THE ENGINE RUMBLED AND VIBRATED WITH THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE CONTACT ALSO STATED THAT AT VARIOUS SPEEDS ON SEVERAL OCCASIONS, THE VEHICLE STALLED WHILE DEPRESSING THE ACCELERATOR PEDAL. THE TAIL PIPE ALSO EMITTED AN EXCESSIVE AMOUNT OF SMOKE WHILE THE VEHICLE WAS BEING DRIVEN. THE VEHICLE WAS TAKEN TO THREE INDEPENDENT MECHANICS TO BE DIAGNOSED. THE CONTACT WAS INFORMED OF AN HEAD GASKET LEAK, A ND ALSO THAT THE SPARK PLUGS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 91,000.

OBEYING SPEED LIMIT DRIVING DOWN THE HIGHWAY ON N127 TOWARDS JACKSON MICHIGAN, GOING PAST AN ON RAMP AND MY PASSENGERS WINDSHIELDS OUTER PILLAR COVER FLEW OFF OUT OF NO WHERE, NO REASON, VERY UNEXPECTED. ALMOST HIT A CAR THAT WAS COMING ONTO THE HIGHWAY ON A ON RAMP. I HAVE FOUND 5 OTHER REPORTS OF EXACTLY SAME THING. MY VEHICLE ONLY HAS 37K MILES ON IT, HAVE ONLY DROVE IT BARELY 3 MONTHS. THIS SHOULD NOT HAVE HAPPENED OR BE HAPPENING TO VEHICLES. OTHER COMPLAINTS I FOUND VEHICLES WERE AT 40K MILES OR 41K MILES. TIMING OF ALL 6 INCIDENTS IS NOT A COINCIDENCE. ALL 2016 FORD EXPLORERS ALL WITHIN LAST 6 MONTHS.

I PURCHASED THIS VEHICLE IN APRIL OF 2019, WITH ABOUT 31K MILES ON THE ODOMETER. IT WAS A RETURNED LEASE. IN JANUARY OF 2020, AT JUST OVER 41K MILES, THE STEERING GEAR FAILED AS I WAS PULLING INTO THE PARKING LOT AT WORK. I HAD NO PROBLEM TURNING THE WHEEL TO THE LEFT, BUT AS SOON AS I TURNED THE WHEEL EVEN SLIGHTLY RIGHT, THERE WAS AN AWFUL CLICKING NOISE, ALMOST LIKE SOMETHING WAS GRINDING IN THE WHEEL WELL. I LIMPED IT OVER TO THE FORD DEALERSHIP A MILE AWAY AND THEY TOLD ME THE STEERING GEAR HAD FAILED. I WAS OUTSIDE OF THE 3 YR/36000 MI WARRANTY, AND APPARENTLY THE 5 YR/60000 MI POWERTRAIN WARRANTY ONLY COVERS THE STEERING HOUSING, NOT THE GEAR ITSELF, SO I WAS ON THE HOOK FOR THE ENTIRE FIX - $2200 AT THIS POINT. THE SERVICE ADVISOR AT FORD SAID IT WASN'T DUE TO ANY NEGLECT OR "OUTSIDE INFLUENCE" - IT JUST FAILED AND THERE'S NOTHING I COULD HAVE DONE TO PREVENT IT. I FIND IT HARD TO BELIEVE THAT SOMETHING SO CATASTROPHIC AND EXPENSIVE SHOULD BE FAILING AT 4 YRS/41K MI. FORD CAN'T ACTUALLY EXPECT PEOPLE TO REPLACE A $2200 PART EVERY 4 YRS/41K MI, RIGHT?! LUCKILY I WAS DOING ABOUT 5 MPH WHEN THE GEAR FAILED - OTHER PEOPLE HAVE BEEN DRIVING AT HIGHWAY SPEEDS, AND THIS ISSUE IS SURELY GOING TO INJURE AND/OR KILL PEOPLE, IF IT HASN'T ALREADY. FORD NEEDS TO RECTIFY THIS ISSUE!!

MY VEHICLE SMELLS LIKE GAS IN THE INSIDE. IT'S LIKE CARBON MONOXIDE COMING INTO THE CABIN AND IT'S MAKING MY FAMILY LIGHTED HEADED. DEALER CAN'T LOOK AT VEHICLE FOR A WEEK OR LONGER. I'M AFRAID I'LL PASS OUT DRIVING HOME FROM WORK. I HAVE SEEN NUMEROUS COMPLAINTS AND THE DEALER IS OVERLOADED WITH THE SAME COMPLAINT SUDDENLY IN CLINTON TOWNSHIP, MI

AIRBAG INDICATOR LIGHT STAYS ON. CHECKED WITH OBD, NO CODES. TOOK TO DEALER AND THEY STATED THAT THEY WOULD NEED TO REMOVE ALL THE SEATS AND REWIRE. RESEARCHED AND FOUND TSB 16-0001WHICH SUPERSEDES TSB 15-0113. THERE ARE NUMEROUS REPORTS OF THIS ISSUE (HTTP://WWW.CARPROBLEMZOO.COM/FORD/EXPLORER/AIR-BAG-LIGHT-ON-PROBLEMS.PHP). EVEN THE SERVICE DEPARTMENT STATED THAT THEY ARE SEEING MANY CUSTOMERS WITH THE SAME ISSUE. THEY ARE QUOTING $1400 TO REPAIR. IN ADDITION THE TSB STATES IT IS ONLY 2.5 HOURS AND PART NUMBER, 14A005. I BELIEVE THE NHTSA SHOULD REQUIRE FORD TO COVER THE COSTS OF THIS ISSUE.

EXHAUST FUMES ENTERING THE CABIN OF VEHICLE NEAR MIDDLE AND REAR SEATS.WHILE DRIVING DOWN HIGHWAY AT 70MPH PASSENGERS TURNED ON AIR FOR THE BACK AND AN ODD SMELL WAS NOTICED. AIR WAS TURNED OFF AT THE BACK. ONCE AT LOCATION READY TO PARK SMELL BEGAN TO GET WORSE. VERY NOTICEABLE INSIDE AND OUTSIDE. ODOR CLUNG TO SKIN. POSSIBLY CO LEAK.

I PURCHASED THIS 2016 FOR EXPLORER LIMITED IN AUGUST OF 2016 WITH 18,000 MILES ON IT. NOW AT JUST BELOW 60,000 MILES IN JANUARY OF 2020, I HAD THE EXPERIENCE OF MY STEERING GEAR GOING OUT WHICH IN TURN COST ME $2200.00. WHO WOULD OF THOUGHT THAT AFTER ONLY 3 YEARS, THE STEERING GEAR WOULD GO BAD IN A PRACTICALLY BRAND NEW VEHICLE? WHILE DRIVING THE VEHICLE, THE STEERING WHEEL WOULD LOCK UP AND I WOULD HAVE TO FORCEFULLY TURN IT TO VEER BACK IN MY LANE ON THE CITY STREETS AS WELL AS ON THE HIGHWAY. IN MICHIGAN, THAT WAS REALLY DANGEROUS ESPECIALLY IN THE SNOWY CONDITIONS. I DON'T UNDERSTAND HOW THERE IS NOT A RECALL ON THE OBVIOUS DEFECTIVE PARTS. THERE IS NO WAY A DRIVER CAN BRAKE THE ELECTRONIC STEERING GEAR.

OUR 2016 FORD EXPLORER SPORT LOST POWER GOING UP A SLIGHT HILL RIGHT BEFORE OUR HOUSE AND BARELY MADE IT HOME. WE IMMEDIATELY CALLED THE DEALERSHIP AND ARRANGED TO BRING IT THE FOLLOWING MORNING. THE DRIVETRAIN IS UNDER WARRANTY FOR 5 YEARS OR 60,000 MILES. OUR VEHICLE IS 4 YEARS OLD WITH SLIGHTLY OVER 60,000 MILES AND WE ALSO PURCHASED THE ADDITIONAL WARRANTY FOR 100,000 MILES. WE HAVE BEEN TOLD BY THE DEALERSHIP THAT WE WILL BE RESPONSIBLE TO PAY FOR THE LABOR OF A TRANSMISSION TEAR DOWN WHICH TAKES 18 HRS AND $2,000 IN LABOR BEFORE WE CAN FIND OUT IF THE WARRANTY WILL COVER THE ISSUE. WE HAVE ALSO HAD ISSUES WITH THE HEATED/COOLED SEATS, THE AIR BAGS, THE PARKING ASSIST, AND STEERING. WE DID NOT SPEND ALL THIS MONEY FOR A NEWER VEHICLE(WAS 2 YRS OLD WHEN PURCHASED) JUST TO HAVE SEVERAL ISSUES THAT WILL END UP COSTING US A RIDICULOUS AMOUNT OF MONEY. THIS IS OUR FAMILY VEHICLE THAT WE DRIVE OUR 3 KIDS AROUND IN. WE SPENT THE EXTRA MONEY TO HAVE SOMETHING RELIABLE AND SAFE THAT WE WOULDN'T HAVE TO SINK MONEY INTO REPAIRS AND ALSO PURCHASED THE ADDITIONAL WARRANTY TO NOT HAVE TO WORRY ABOUT AY REPAIRS. WITH THE AMOUNT OF MONEY WE HAVE SPENT ON THE VEHICLE, WE WERE NOT EXPECTING A BIG OUT OF POCKET COST, ESPECIALLY SINCE WE HAVE THE WARRANTY. WE ARE VERY DISAPPOINTED IN THE VEHICLE AND THE CUSTOMER SERVICE WE HAVE RECEIVED AND WILL NEVER PURCHASE ANOTHER FORD IF THIS IS THE REPUTATION THEY ALLOW THEMSELVES TO HAVE.

WHILE DRIVING 70 MPH ON I81 IN VA THE POWER STEERING ON OUR 2016 FORD EXPLORER WITH LESS THAN 70,000 MILES DIED. THE ONLY WARNING WAS A MESSAGE ON THE DASH SAYING "LANE KEEPING SYST MALFUNCTION" AND "STEERING ASSIST FAULT." AFTER WRESTLING THE CAR TO A SAFE SITE I SHUT IF OFF. UPON RESTARTING THE CAR THE STEERING RETURNED TO NORMAL. WHILE DRIVING TO THE NEAREST FORD DEALER TO HAVE IT CHECKED OUT IF FAILED AGAIN. THE DEALERSHIP PERFORMED PINPOINT TEST B FOR U3000 CODE STORED IN THE PSCM. THEIR RECOMMENDATION WAS REPLACEMENT OF THE ELECTRIC POWER STEERING GEAR ASY (P/N FB5Z3504W) AT A COST OF $2,300. I INQUIRED IF THERE WERE ANY RECALLS OR SAFETY BULLETINS ISSUED REGARDING PREMATURE FAILURE OF THE POWER STEERING IN WHICH THEY INDICATED THERE WASN'T. THIS IS A SAFETY ISSUE, THE CAR IS DIFFICULT TO CONTROL AT HIGH SPEEDS AND ALMOST IMPOSSIBLE TO CONTROL AT SLOW SPEEDS ESPECIALLY IF YOUR MAKING A TURN. WITHOUT STRONG UPPER BODY STRENGTH, YOU CAN EASILY HAVE AN ACCIDENT. BASED ON MY EXPERIENCE WITH THIS ISSUE, I STRONGLY RECOMMEND A SAFETY BULLETIN AND A RECALL BE ISSUED.

I NEVER RECEIVED A RECALL IN THE MAIL. VEHICLE WAS PURCHASED IN JUNE 2019 BUT THE RECALL ENDED IN AUGUST 2019 AND I WOULD LIKE TO HAVE THIS REPAIRED

THE AIR BAG LIGHT IS ON. DEALERSHIP FOUND CODE B141B AND B141C TO SECOND ROW SEAT BELTS AND RECOMMENDED REPLACING PIGTAILS. $431.46 QUOTE FOR PARTS SEEMS EXCESSIVE FOR SOMETHING THAT IS IN A 2016 CAR. THE AIRBAGS WILL NOT DEPLOY UNLESS FIXED. SEEMS UNSAFE UNLESS YOU HAVE ABOUT $600 FOR REPAIRS.

I WAS MERGING TO ENTER THE HIGHWAY WHEN ALL THE SUDDEN I COULDN'T CONTROL THE ACCELERATION AND ALMOST GOT HIT BY ANOTHER CAR. THE CAR WILL NOT RESPOND TO THE GAS PEDAL LIKE IF IT WAS IN THE NEUTRAL POSITION. THIS KEEPS HAPPENING RANDOMLY ESPECIALLY WHEN DRIVING A LOWER SPEEDS AND ONCE YOU TRY TO ACCELERATE THE CAR WOULDN'T RESPOND FOR A BIT AND THEN DOES IT ABRUPTLY. I ALMOST GOT INTO A SECOND ACCIDENT AND IT WAS WHEN I TOOK IT TO THE DEALERSHIP BECAUSE I REFUSE TO DRIVE IT. THEY HAVE MY CAR SINCE ALMOST TWO MONTHS NOW WITHOUT SOLVING THE PROBLEM COMPLETELY BECAUSE IT DOES NOT SHOW UP IN THE COMPUTER DIAGNOSTIC AND THEY DON'T EVEN HAVE A RECALL FOR IT. THIS IS A VERY DANGEROUS PROBLEM AND IT SHOULD OFF BEEN PART OF A RECALL LONG TIME AGO.

MY VEHICLE ONLY HAS A LITTLE OVER 91,000 MILES ON IT. HOWEVER, FOR THE LAST 45,000 MILES, I HAVE NOTICED A JERKING IN THE TRANSMISSION ONCE I REACH ABOVE 40MPH. MY MOTHER HAS A 2017 FORD EXPLORER AND HAD THE SAME ISSUES. SHE HAD THE EXTENDED WARRANTY SO SHE WAS ABLE TO HAVE HERS FIXED BUT HAD TO PAY A DEDUCTIBLE. THIS SHOULD NOT BE A WARRANTY FIX... THIS SHOULD BE A MANUFACTURER FIX AND RECALL. MY MOM WAS TOLD BY THE FORD DEALERSHIP THAT FIXED HER CAR THAT THERE WAS A KNOWN ISSUE WITH THIS PROBLEM WITH DEALING WITH THE TRANSMISSION. SHE WAS ALSO TOLD THAT IF THE ISSUE IS NOT FIXED ON YOUR VEHICLE, IT COULD CAUSE THE TRANSMISSION TO GO OUT AT ANY TIME . THIS IS A SERIOUS SAFETY CONCERN,. I HAVE 4 CHILDREN IN MY VEHICLE AT ALL TIMES, TWO OF THEM BEING UNDER THE AGE OF 3. I DO NOT FEEL SAFE IN MY VEHICLE AND DO NOT FEEL THAT FORD IS DOING THEIR JOB TO ENSURE THAT RECALLS ARE BEING DONE PROPERLY. I SAW 7 RECALLS FOR FORD EXPLORES FOR YEAR 2016 BUT WHEN I SEARCHED MY VIN... NOTHING CAME UP... WHY IS THAT?

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING AT 20-25 MPH, THE VEHICLE WAS JERKED SPORADICALLY. THE CHECK ENGINE AND IGNITION WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO QUIRK FORD (540 SOUTHERN ARTERY, QUINCY, MA 02169 (617) 770-0070) WHERE THE FAILURE WAS UNABLE TO BE DUPLICATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS CONTACTED WHO REFERRED CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 65,000.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. THE CONTACT STATED WHILE DRIVING AT APPROXIMATELY 70 MPH, THE RUBBER SEAL AROUND THE DRIVER'S SIDE WINDOW DETACHED. THE VEHICLE WAS TAKEN TO (COCONUT POINT FORD LOCATED AT 22400 S TAMIAMI TRAIL, ESTERO, FL 33928) FOR A DIAGNOSIS. THE CONTACT WAS INFORMED THE DETACHMENT WAS NOT A SAFETY DEFECT AND THE COST OF THE REPAIR WOULD BE ASSESSED TO THE VEHICLE OWNER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 51,000.

LOSS OF EASE OF STEERING DRIVING IN FRIGID WIND CHILL NIGHT TIME NORTH DAKOTA WEATHER. MY WIFE WAS STRONG ENOUGH TO STRONG ARM STEER AND DRIVE THE VEHICLE THE 40 PLUS MILES HOME. A DEFINITE SAFETY ISSUE- AN INTERNET SEARCH REVEALED NUMEROUS COMPLAINTS AND COMPLETE STEERING FAILURE ON THE ELECTRONIC STEERING APPARATUS INSTALLED ON THIS MAKE AND MODEL. THE REPAIR COSTS COULD AMOUNT TO $3000. THE FACT THAT THESE PROBLEMS AND STEERING APPARATUS FAILURE IS OCCURRING ON LOWER MILEAGE VEHICLES IS VERY CONCERNING. OUR VEHICLE HAS 56,700 ODOMETER MILES. THIS ISSUE IS DEFINITELY A SAFETY ISSUE AND FORD MOTOR COMPANY MUST BE HELD ACCOUNTABLE. THE NEAREST FORD DEALERSHIP IS 75 MILES AWAY FROM OUR RURAL FARM LOCATION- I EXPECT I WILL HAVE TO TRANSPORT OUR VEHICLE TO THE DEALERSHIP FOR REPAIRS.

STRONG SMELL OF NATURAL GAS OR EXHAUST ENTERING THE CABIN. SEEMS TO BE COMING IN THROUGH THE AIR VENTS. AS THAT'S WHERE THE SMELL IS THE MOST INTENSE. IT ALSO GETS WORSE WHEN THE CAR IS STATIONARY. BUT IT IS NOTICEABLE THROUGHOUT THE WHOLE DRIVE. AT THIS POINT EVEN AFTER ONLY TWO DAYS IT'S ALMOST UNBEARABLE TO DRIVE AND THE WHOLE CABIN IS STAINED WITH THE SMELL.

I HAVE A 2016 FORD EXPLORER THAT WAS PURCHASED BRAND NEW 3.5 YEARS AGO. IT HAS 55K MILES ON IT, WHICH ISN'T WHAT I CONSIDER MANY MILES, AND IS DRIVEN BY MY WIFE 90% OF THE TIME TO AND FROM WORK AND WE USE IT FOR LONGER DRIVERS WITH OUR 4 YEAR OLD DAUGHTER. I JUST RECEIVED WORD, AFTER I TOOK THE VEHICLE IN FOR A GRINDING NOISE IN THE STEERING COLUMN, THAT THE STEERING RACK AND GEAR HAS FAILED. I HAVE SEEN OTHERS TALK ABOUT THIS PROBLEM AND IT IS A VERY BIG SAFETY CONCERN IN MY OPINION. IF THIS THING FAILED ON THE HIGHWAY AT A FASTER SPEED AND MY WIFE AND CHILD WERE IN THE CAR AND SHE HAD LIMITED STEERING CONTROL IT COULD HAVE BEEN DISASTROUS AND TRAGIC. I SEE ON CARCOMPLAINTS.COM I AM THE 165TH CASE OF THIS HAPPENING. I WANTED TO MAKE YOU AWARE OF THIS AND HOPEFULLY YOU CAN MAKE THE 3RD RECALL ON THIS VEHICLE HAPPEN IN THE NEAR FUTURE (HAD 2 ALREADY) PLEASE REACH OUT TO ME WITH ANY QUESTIONS.

AT SLOW SPEEDS 20 MPH AND LESS THERE IS SIGNIFICANT NOISE WHEN DRIVING OVER BUMPS OR TRANSITIONS. AT VERY SLOW SPEEDS LESS THAN 5 MPH AND TURNING STEERING WHEEL THE STEERING WILL GET STUCK OR HESITATE AND MAKE A CLUNKING OR POPPING SOUND. SEEMS TO BE STABILIZER BAR RELATED. ITS PROGRESSIVELY GETTING WORSE. I ALSO HAVE AN ENGINE SURGING ISSUE AT SLOWER SPEEDS OF 30 MPH OR LESS.

PROPANE SMELL INTO CABIN OF VEHICLE WHEN VEHICLE IS RUNNING AND HEAT OR AC IS ON. NO MATTER IF IT'S STATIONARY OR IN MOTION, CITY, STREET OR HIGHWAY.

THE REAR WINDSHIELD SPONTANEOUSLY SHATTERED WHILE DRIVING ON 495 SOUTH IN MA. FORTUNATELY NO ONE WAS INJURED AND THE GLASS REMAINED INTACT TO PULL OFF TO SAFETY. WITH THE IMPACT OF THE CAR DOOR OPENING AND CLOSING, PIECES OF GLASS BEGAN TO BREAK AWAY.

THE VEHICLE BEGAN TO OVERHEAT WHEN DRIVING AT AN INCLINE. AS SOON AS THE VEHICLE WAS LEVEL THERE WERE NO OVERHEATING ISSUES. I TOOK THE VEHICLE TO THE DEALERSHIP AND WAS ADVISED THAT THE VEHICLE WAS OVERHEATING DUE TO THE GRILL SHUTTERS BEING STUCK CLOSED AND AS A RESULT THE TRANSMISSION WAS FAILING AND NEEDED A PARTIAL REBUILD. THE VEHICLE WAS STILL ELIGIBLE FOR CERTAIN REPAIRS UNDER THE WARRANTY, MILEAGE 58,120, SO FORD COVERED THE PARTIAL TRANSMISSION REBUILD AS THEY DETERMINED WAS FIT. THE GRILL SHUTTERS MALFUNCTIONING AND BEING STUCK CLOSED WERE NOT COVERED UNDER WARRANTY BUT THE MALFUNCTION WAS A MAJOR CONTRIBUTING FACTOR TO THE TRANSMISSION FAILURE AND OVERHEATING OF THE VEHICLE. REPAIRS WERE COMPLETED IN MAY 2019. IN NOVEMBER 2019 AND APPROX. 2K MILES OUT OF WARRANTY AND JUST SLIGHTLY 2K MORE MILES SINCE THE TRANSMISSION REBUILD AND GRILL SHUTTER REPLACEMENT, THE VEHICLE BEGAN TO OVERHEAT AGAIN. THE OVERHEATING WOULD OCCUR CONSISTENTLY WHEN SITTING IDLE OR IN MOTION ON STREETS AND ON HIGHWAYS. THE VEHICLE WAS TAKEN TO THE FORD DEALERSHIP AGAIN FOR DIAGNOSIS. IT WAS DETERMINED THAT THE HEAD GASKET WAS BLOWN WHICH WAS CAUSING THE VEHICLE TO OVERHEAT. FORD ADVISED THAT DUE TO THE GRILL SHUTTERS BEING STUCK CLOSED THAT ULTIMATELY WAS THE CAUSE OF THE DAMAGE TO THE ENGINE AND THE HEAD GASKET BEING BLOWN. THE MALFUNCTIONING GRILL SHUTTERS ARE A MAJOR ISSUE THAT SHOULD BE FIXED ON FORDS BEHALF SO THAT ADDITIONAL ENGINE DAMAGE DOESN'T OCCUR. FORD IS NOW NOT COVERING THE HEAD GASKET BEING BLOWN/OVERALL ENGINE DAMAGE EVEN THOUGH THIS WAS ULTIMATELY CAUSED BY THE MALFUNCTIONING GRILL SHUTTERS. THE VEHICLE IS NOT DRIVABLE WITHOUT OVERHEATING AND THE OVERHEATING COULD CAUSE A FIRE WHICH COULD BE EXTREMELY DANGEROUS AND IN SOME CASES, FATAL.

WHEN TURNING THE STEERING WHEEL TO THE RIGHT THERE IS A DISTINCT CLUNKING SOUND. I HAVE READ MULTIPLE BLOGS WHERE MANY SIMILAR STORIES ARE BEING TOLD AND IT SEEMS THERE'S A DEFECT IN THE STEERING GEAR EXPIERENCING INTERNAL FAILURE PREMATURLY. OWNERS ARE SAYING THEIR VEHICLES WILL DRIFT IN THE LANE AND THE STEERING BECOMES LOOSE AND UNCONTROLLABLE. FORD DEALERS ARE CHARGING $2,500 TO REPLACE THE PARTS CAUSING THIS EXTREME SAFETY ISSUE. THIS NEEDS TO BE RECALLED AND FIXED NOW, WHO CAN AFFORD SUCH AN EXPENSIVE REPAIR ON SOMETHING THIS CRITICAL. FORD NEEDS TO STEP UP AND TAKE RESPONSIBILITY. WE TOOK OUR VEHICLE IN AT 56,000 AND THEY SAID NOTHING WAS WRONG. AT 68,326 MILES WE TOOK IN AGAIN BECAUSE IT GOT WORSE. THIS HAPPENS WHEN YOU TURN TO THE RIGHT AND I HEAR IT AT SLOW SPEEDS WHEN PARKING OR JUST RIGHT TURNS.

TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHILE DRIVING 45 MPH, THE VEHICLE, JERKED, LOST POWER, AND CAME TO A COMPLETE STOP. THE FAILURES OCCURRED WITHOUT WARNING. THE CONTACT NOTICED AN ODOR COMING FROM THE REAR OF THE VEHICLE. THE CONTACT ATTEMPTED TO DEPRESS THE ACCELERATOR PEDAL, BUT IT FAILED TO ENGAGE. A BYSTANDER HELPED THE CONTACT PUSH THE VEHICLE TO THE SHOULDER OF THE ROAD. THE VEHICLE WAS TOWED TO BYERLY FORD (4041 DIXIE HWY, LOUISVILLE, KY 40216, (502) 448-1661) WHERE IT WAS DIAGNOSED THAT THE TURBO FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE CONTACT WAS INFORMED TO CALL NHTSA TO FILE A COMPLAINT. THE FAILURE MILEAGE WAS APPROXIMATELY 67,000.

EXHAUST OR GAS SMELL IN THE CABIN. ESPECIALLY NOTICEABLE AFTER LONGER DRIVES. SO STRONG YOU CAN SMELL IT IN THE HOUSE AFTER PARKING IN THE GARAGE. TOOK IT TO A FORD DEALER AND WAS TOLD THEY COULDN'T FIND ANYTHING.

WHILE I WAS DRIVING ON THE HIGHWAY GOING NO MORE 70MPH, WHEN THE ENGINE STARTED TO MAKE A WHINING NOISE AND THE TRUCK STARTED BUCKING. THEN THE TRUCK STOPPED ABRUPTLY AS IF SOMEONE HIT THE BRAKE THEN A LOUD POP NOISE. ONCE WE PULLED TO THE SHOULDER, SMOKE CAME THROUGH THE VENT AND FROM UNDER THE HOOD. WITHIN 15 SECOND FIRE SPARKS WAS SHOOTING FROM THE BOTTOM OF THE TRUCK THEN BY THE NEXT 10 SECOND FIRE STARTED SHOOTING FROM UNDER THE HOOD. THE ENTIRE FRONT OF THE TRUCK WAS ENGULFED. NO WARNING, NO CHECK ENGINE LIGHT, NOTHING. I HAVE ALWAYS HAD MY REGULAR MAINTENANCE DONE. LAST ONE DONE 10/2019. NOW I'M OUT OF A VEHICLE WITH NO WARNING FROM FORD. I'VE ONLY HAD THIS TRUCK 9 MONTHS WHICH I PURCHASED WITH AN EXTENDED WARRANTY IN MARCH 2019.

MY 2016 FORD EXPLORER LIMIITED HAS 70K MILES AND IS GARAGE KEPT. AFTER DRIVING IN HEAVY RAIN, I NOTICED WATER IN MY CARGO AREA. WATER IS LEAKING INTO CARGO AREA NEAR THE THIRD ROW'S DRIVERSIDE SEAT BELT. DEALER TOLD ME IT WAS A FACTORY DEFECT WHERE THEY DIDN'T WELD AND INSTEAD USED SEAM SEALER AND NOW THAT SEAM SEALER HAS FAILED. FORD AND THE DEALER REFUSE TO COVER THE COST OF REPAIR. THEY SAID THEY COULD FIX IT WAS WITH A STRONGER TYPE OF SEAM SEALER.

I WENT ON VACATION WITH MY FAMILY FOR A WEEK. WE TOOK MY CAR TO AIRPORT AND PARKED IT FROM 11/8-11/16. I HAD NO PROBLEMS ON THE DRIVE TO THE AIRPORT, BUT WHEN WE CAME HOME, ALMOST IMMEDIATELY, WHILE PULLING OUT OF THE PARKING SPACE (STILL STATIONARY) I HEARD A RUBBING NOSE COMING FROM WHAT SOUNDED LIKE THE STEERING COLUMN. DUE TO MY SON'S ALWAYS BEING IN THE VEHICLE I DIDN'T WANT TO CHANCE ANYTHING SINCE IT SEEMED TO BE STEERING RELATED. I TOOK IT TO A MECHANIC WHO ENDED UP TELLING ME THAT IT WAS MY STEERING RACK. HE ALSO INFORMED ME THAT ON THE YEAR'S BEFORE MINE THEY HAD TO ISSUE A RECALL DUE TO SIMILAR ISSUES AS MINE. I'VE NOTICED THAT THERE ARE A LOT OF PEOPLE WITH THE SAME YEAR AND MODEL THAT STILL HAVE THIS PROBLEM EVEN THOUGH IT ISN'T A RECALL ANYMORE FOR SOME REASON. LUCKILY I CAUGHT MINE BEFORE IT CAUSE A SERIOUS ISSUE, BEING THAT PEOPLE HAVE SAID THIS CAUSES THEIR STEERING TO COMPLETELY LOCK UP.

THERE IS A BURNING SMELL, LIKE EXHAUST, THAT IS COMING INTO THE CABIN OF MY 2016 FORD EXPLORER. FORD SERVICED THE VEHICLE AND SAID THEY REPROGRAMMED THE HVAC SYSTEM, BUT I AM STILL GETTING THE SMELL.

WHEN TURNING THE STEERING WHEEL TO THE RIGHT THERE IS A DISTINCT CLUNKING SOUND. I HAVE READ MULTIPLE BLOGS WHERE MANY SIMILAR STORIES ARE BEING TOLD AND IT SEEMS THERE'S A DEFECT IN THE RACK AND PINION. OWNERS ARE SAYING THEIR VEHICLES WILL DRIFT IN THE LANE AND THE STEERING BECOMES LOOSE AND UNCONTROLLABLE. FORD DEALERS ARE CHARGING AT LEAST $2000.00 TO REPLACE THE PARTS CAUSING THIS EXTREME SAFETY ISSUE. I KNOW OF THE RECALL FOR THE REAR SUSPENSION BUT THIS IS VERY DIFFERENT. THIS NEEDS TO BE RECALLED AND FIXED NOW, WHO CAN AFFORD SUCH AN EXPENSIVE REPAIR ON SOMETHING THIS CRITICAL. FORD NEEDS TO STEP UP AND TAKE RESPONSIBILITY. MY VEHICLE HAS 65,000 MILES. THIS HAPPENS WHEN YOU TURN TO THE RIGHT AND I HEAR IT AT SLOW SPEEDS WHEN PARKING OR JUST RIGHT TURNS.